Transcript
TRACTOR -- MODEL NUMBER AG17542STB SCHEMATIC
RED
BLACK
BATTERY
RED
A
RED
M
FUSE
AMMETER (OPTIONAL)
STARTER BLACK
WHITE
SOLENOID RED
B
S
G
BLACK
L
M
CLUTCH / BRAKE (PEDAL UP)
A1 A2
WHITE
SEAT SWITCH (NOT OCCUPIED)
IGNITION SWITCH
WHITE
BLACK
BLACK
BLACK BLACK
HOUR METER
ATT'MENT CLUTCH (CLUTCH OFF)
GROUNDING CONNECTOR
(OPTIONAL)
SPARK PLUG GAP (2 PLUGS ON TWIN CYL. ENGINES)
IGNITION UNIT
BLACK
BLUE
FUEL LINE
CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM
FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) ORANGE
BLACK
28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
RED LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 RPM
DIODE
ALTERNATOR
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)
NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST.
BLACK
BROWN
HEADLIGHTS
NON-REMOVABLE CONNECTIONS
IGNITION SWITCH POSITION
CIRCUIT
OFF M+G+A1 RUN/LIGHT B+A1 RUN START
B+A1 B + S + A1
“MAKE” NONE A2+L NONE NONE
WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 02363
31
REMOVABLE CONNECTIONS
REPAIR PARTS TRACTOR -- MODEL NUMBER AG17542STB ELECTRICAL 22
21
42
24
41
43 27
27 40
26
27
27
25 16
16
33 30
D.C.
AM PE
52 RE
S
45
29 28
8
27
90
2 1
32
TRACTOR -- MODEL NUMBER AG17542STB ELECTRICAL
KEY PART NO. NO.
DESCRIPTION
1 2 8 16 21 22 24 25 26 27 28 29 30 33 40 41 42 43 45 52 90
Battery 12 Volt 25 Amp Bolt Hex Hd 1/4-20 unc x 3/4 Box Battery Switch Interlock Push -In Harness Asm Light W/4152J Bulb Light #1156 Cable Battery 6 Ga. 11”red Cable Battery 6 Ga. w/16 wire,red Fuse 20 AMP Nut Keps Hex 1/4-20 unc Cable Ground 6 Ga. 12” black Switch Plunger Nc Gray Switch Ign Key Ign Harness Ign Bolt Blk Fin Hex 1/4-20 x 1/2 Cover Terminal Red Solenoid Ammeter Protection Wire Loop Cover Terminal
163465 74760412 176689 176138 183759 4152J 4799J 146147 175158 73510400 4207J 121305X 175566 140401 179720 71110408 131563 178861 121433X 141940 180449
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
33
TRACTOR -- MODEL NUMBER AG17542STB CHASSIS AND ENCLOSURES
29
212
17 28
30
24
39
18
24 166
26
25
25
26
5
31
5
209
209 9
11
208
209 208
207
64
26
35 209
209 1
13
33 142
10
37
145 37
209 35 209
142
2
35
208 34
205 206
209
26
38
38
205
34
Chassis-Elite_Basic_2
TRACTOR -- MODEL NUMBER AG17542STB CHASSIS AND ENCLOSURES
KEY PART NO. NO.
DESCRIPTION
1 2 5 9 10 11 13 17 18 24 25 26 28 29 30 31 33 34 35 37 38 39 64 142 145 166 205 206 207 208 209 212 ---
Chassis Drawbar Bumper Hood/Dash Dash Bolt Carriage 3/8-16 x 1 Panel Dash Lh Panel Dash Rh Hood Bumper Hood Bolt Fin Hex 3/8-16 x 1 Gr. 5 Washer 13/32 x 13/16 x 12 Ga. Nut Lock Hex W/Ins 3/8-16 unc Grille Lens Fender Footrest STLT Pnt Bracket Support Fender Footrest Pnt Lh Footrest Pnt Rh Bolt Rdhd Sht Sqnk 3/8-16 x 3/4 Screw Thdrol 6/16-18 x 1/2 TYT Bracket Asm. Pivot Mower Rear Bracket Pivot Dash Lower STLT Plate Reinforcement STLT Rod Pivot Chassis/Hood Screw HWHD Hi-Lo #13-16 x 5/8 Screw Thdrol 3/8-16 x 1-1/4 Bolt Shoulder 5/16-18 Screw Thdrol 5/16-18 x 1/2 Screw Thdrol 3/8-16 x 1/2 Screw Hex Wsh Thdr. 3/8-16 x 3/4 Insert Lens Reflect Plug Btn Blk .359 Plug Dome
174619 176554 155272 187846X012 72140608 174996 179174X010 183394X428 126938X 74780616 19131312 73800600 183826 183824X599 169468X505 136619 179716X505 179717X505 72110606 17490508 175710 174714 154798 175702 156524 171875 17490608 170165 17670508 17670608 17000612 183823 5479J 187801
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
35
TRACTOR -- MODEL NUMBER AG17542STB GROUND DRIVE
57 120
89
69 63 197
81
212
59 84 198 161
70 66
159 158
61
65
162 21
85
112
169
10
13 14
83
41
18 4
8
80
51
82
165
5
11
156
166
6
79 30
32
32
170
30 52
48 27
151 51
49 47
6 62
6
77
150
39
18
16 52
50
38
113
3
85
202
168
163
112
55
64
56 14
116
35 36
120
37 34
25
26 15
77 96 26
1
19
28
24
36
35 53
2 74
78
29
76
75
22
26
27 drive-fender_49
36
TRACTOR -- MODEL NUMBER AG17542STB GROUND DRIVE
KEY PART NO. NO. 1
------
2 3 4 5 6 8 10 11 13 14 15 16 18 19 21 22 24 25 26 27 28 29 30 32 34 35 36 37 38 39 41 47 48 49 50 51 52 53 55 56 57 59 61
146682 123666X 12000028 121520X 17000512 165619 76020416 105701X 74550412 10040400 74490544 73800500 74780616 73800600 106933X 130804 73350600 106888X 19131316 76020412 175765 71673 174973 74760512 175578 120183X 19211616 1572H 179114 72110622 175556 127783 154407 123205X 72110612 73680600 73680500 105710X 105709X 17060620 130801 169691 17120614
DESCRIPTION Transaxle Peerless (206-545C) (Order parts from transaxle manu facturer) Spring Return Brake T/a Zinc Pulley Transaxle 18" tires Ring Retainer # 5100-62 Strap Torque 30 Degrees Screw 5/16-18 X 3/4 Rod Shift Fender Adjust Lt Pin Cotter 1/8 X 1 Cad Washer Plate Shf 388 Sq Hole Bolt 1/4-28 Unf Gr. 8 W/Patch Washer Lock Hvy Helical Bolt Hex FLGHD 5/16-18 Gr. 5 Nut Lock Hex w/ins 5/16-18 Bolt, Fin Hex 3/8-16 unc x 1 Gr. 5 Nut Lock 3/8-16 Unc Knob Rod Brake Blk Zinc 26 840 Nut Hex Jam 3/8-16 unc Spring Rod Brake 2 00 Zinc Washer 13/32 x 13/16 x 16 Ga. Pin Cotter 1/8 x 3/4 Cad Rod Brake Parking LT/YT Cap Brake Parking Bracket Mtg Transaxle Bolt Hex Hd 5/16-18 unc x 3/4 Shaft Asm Pedal Foot Bearing Nylon Blk 629 Id Washer 21/32 x 1 x 16 Ga. Pin Roll 3/16 X 1" Pulley Composite Flat Bolt RDHD 3/8-16 unc x 2-3/4 Gr. 5 Keeper Belt Flat Idler Pulley Idler V Groove Plastic Bellcrank Asm Retainer Belt Style Spring Bolt Carr. Sh. 3/8-16 x 1-1/2 Gr. 5 Nut Crownlock 3/8-16 unc Nut Crownlock 5/16-18 unc Link Clutch Spring Return Clutch 6 75 Screw 3/8-16 x 1-1/4 V-Belt Ground Drive 95 25 Keeper Belt Span Ctr Screw 3/8-16 x .875
37
KEY PART NO. NO.
DESCRIPTION
62 63 64 65 66 69 70 74 75 76 77 78 79 80 81 82 83 84 85 89 96 112 113 116 120 150 151 156 158 159 161 162 163 165 166 168 169 170 197 198 202 212
Cover Pedal Blk Round Engine Pulley Bolt Hex Washer Lock Hvy Hlcl Spr 7/16 Keeper Belt Engine Foolproof Screw Hex wsh HiLo 1/4 x 1/2 unc Guide Belt Mower Drive RH Spacer Axle Washer 25/32 x 1 1/4 x 16 Ga. E-ring #5133-75 Key Square 2 0 x 1845/ 1865 Washer 25/32 x 1-5/8 x 16 Ga. Key Woodruff #9 3/16 x 3/4 Arm Shift Shaft Asm Cross Tapered PMST/20 Spring Torsion T/a Washer 17/32 x 3/4 x 16 Ga. Link Transaxle PMST/18" Zinc Nut Lock Center 1/4 - 28 FNTHD Console Shift STLT Retainer Spring 1" Washer 9/32 x 3/4 x 10 Ga. Strap Torque LT Bolt Rdhd Sq Neck 3/8-16 x 1 Nut Lock Flg. 3/8-16 unc Spacer Retainer Washer 13/32 x 2 x 10 Washer Srrted 5/16ID x 1.125 Bracket Shift Mount Hub Tapered Flange Shift Lt Bolt Rdhd Sqnk 1/4-20 x 3/4 Nut Crownlock 1/4-20 unc Bolt Hex Fin 1/4-20 unc x 1 Gr. 5 Bracket Pivot Lever Screw 5/16-18 x 5/8 Bolt Shoulder 5/16-18 x .561 Plate Fastening Keeper Belt Transaxle Gear Nyliner Snap-In Washer Nyliner Bolt RdHd 3/8-16 unc x 1-3/4 Gr. 5 Nut Hexflange Lock
8883R 175410 173937 10040700 154778 142432 134683 137057 121749X 12000001 123583X 121748X 2228M 131486 165594 123782X 19171216 166228 150360 169372X428 4497H 19091210 127285X 72140608 73900600 175456 19133210 166002 165589 183900 72140406 73680400 74780416 165623 17490510 165492 165580 187414 169613 169593 72110614 145212
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
TRACTOR -- MODEL NUMBER AG17542STB STEERING
38 12 39
1
41
42 37 37 36
44 51
54
88
91 43
71
68
29
67
67
46 8
47
6 9
17
67
13 65
46
2
8
7
6
9 5
9 47 7
3 68
32 11
82
29
9 5
26
4 43
15
40 15
43
29
28 15
10
steering_pl.lt_46
38
30
95
8
TRACTOR -- MODEL NUMBER AG17542STB STEERING
KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 12 13 15 17 26 28 29 30 32 36 37 38 39 40 41 42 43 44 46 47 51 54 65 67 68 71 82 88 91 95
Wheel Steering Auto Black Axle Asm Front Spindle Asm Lh Spindle Asm Rh Bearing Race Thrust Harden Washer 25/32 x 1 5/8 x 16 Ga. Washer 27/32 x 1 1/4 x 16 Ga. Ring Klip #t5304-75 Bearing Col Strg Blk Link Drag Extended Lockwasher Nut Hex Jam Toplock 1/2-20 unf Spacer Bearing Axle Front Hex Flange Lock Shaft Asm Strg Bushing Rod Tie Blk Lt Washer 13/32 x 7/8 x 16 Ga. Screw 3/8-16 x 3/4 Pin Rod Tie Wire Form 19 75 Mech Bushing Strg 5/8 Id Dash Screw TT #10-32 x 5 x 3/8 Flange Insert Cap Strg Washer 9/16 ID x 2-3/8 OD 12 Gr. Nut Crownlock Adaptor Wheel Strg .760 Boot Dash Steering Washer 25/32 x 1 1/4 x 16 Ga. Extension Steering Cap Spindle Fr Top Blk Fitting Grease Nut Crownlock 1/4-28 Bolt Hex 1/4-28 unf x 1-1/4 Gr. 8 Spacer Brace Axle Bolt Rdhd Sq 3/8-16 unc x 2-1/4 Brace Axle Steering Asm Bracket Susp Chassis Front Bolt Shoulder 7/16-20 Clip Steering Washer Hardened
140044X428 175131 169840 169839 6266H 121748X 19272016 12000029 3366R 175121 10040600 73940800 136518 145212 180641 126847X 19131416 17000612 76020412 130465 155099 152927 140045X428 19183812 73540600 186737 145054X428 121749X 180640 121232X 183226 73540400 71130420 160367 72110618 169827 175146 169835 175118 175553 188967
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
39
TRACTOR -- MODEL NUMBER AG17542STB ENGINE 3
2
72 1
81
13
4
78 38 14
32
78 44 46 45 33 23
37
31 33
40
29
OPTIONAL EQUIPMENT Spark Arrester engine-bs.1cyl_49
KEY PART NO. NO. 1 2 3
170551 17720408 ------
4 13 14 23 29 31 32 33 37 38 40
137352 165291 148456 169837 137180 184900 140527 123487X 137040 181654 124028X
DESCRIPTION Control Throttle /Choke Flag Screw Hex Thd Cut 1/4-20 x 1/2 Engine Briggs Model 31C707 (Order Parts From Engine Manufacturer) Muffler Exhaust B&S Lt Gasket 1 313 Id Tin Plated Tube Drain Oil Easy Shield Browning/Debris Guard Arrestor Spark Tank Fuel 1 25 Fr Cap Asm Fuel W/sym Vented Clamp Hose Blk Line Fuel 20” Plug Drain Oil Easy Bushing Snap Nyl Blk Fuel Line
KEY PART NO. NO.
DESCRIPTION
44 45 46 72 78 81
Screw Hexwsh Thdrol 1/4-20 x 3/4 Screw Hex Wsh Thdrol 3/8-16 Washer 9/32 X 7/8 X 16 Ga. Screw Socket Head 5/16-18 x 1 Screw Thdrol 3/8-16 x 1-1/4 Nut Keps Hex 1/4-20 unc
17670412 17000612 19091416 183906 17060620 73510400
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton 1-800-233-3723 Kohler Co. 1-800-544-2444 Tecumseh Products 1-800-558-5402 Honda Engines 1-800-426-7701 Kawasaki 1-800-460-5688
40
TRACTOR -- MODEL NUMBER AG17542STB SEAT ASSEMBLY
1
8 8
9 14
9
7
7
10
5 6 22 21
2 24 5 26 16 25 15 23
4 13 17 seat_lt.bolt_1 KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 12 13 14
Seat Bracket Pnt Pivot Seat (blk) Bolt Washer 13/32 x 1 x 10 Ga. Clip Push-In Hinged Nut Spring Seat Cprsn 2 250 Blk Zi Screw 3/8-16 x 1.5 Washer 13/32 x 1 x 14 Ga. Pan Pnt Seat (blk ) Bracket Pnt Mounting Switch Bushing Snap Blk Nyl 50 Id Bolt Rdhd Sht Nk 1/4-20 x 1-1/2
175389 140551 188978 189116 184774 73800600 124181X 17000616 19131614 182493 121246X 121248X 72050412
3
12
KEY PART NO. NO.
DESCRIPTION
15 16 17 21 22 23 24 25 26
Spacer Split 28 x 96 Yel Zinc Spring Cprsn 1 27 Blk Pnt Nut Lock 1/4 Lge Flg Gr. 5 Zinc Bolt Shoulder 5/16-18 unc Blkz-2A Nut Bolt Hex Black Washer 17/32 x 1-3/16 x 12 Ga. Bolt Shoulder 5/16-18 x 62 Lockwasher
134300 121250X 123976X 171852 73800500 71110814 19171912 127018X 10040800
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
41
TRACTOR -- MODEL NUMBER AG17542STB DECALS
16
11
3 10
9 20 1 8
6 4
4
5
14
KEY PART NO. NO.
DESCRIPTION
KEY PART NO. NO.
DESCRIPTION
1 3 4 5 6 7 8 9
Decal Oper Decal Hood LH Decal Chassis Decal HP Engine Decal Deck "B" 42" Decal Side Panel Decal Warning Mult-Language Decal Fender Logo
10 11 14 16 20 ----
Decal Fender Danger E/F Decal Ins Strg Whl Decal V-Belt Schematic Decal Hood Rh Decal Bat Dan/Psn Decal Handle Lft Height Adjust Manual Owner's (English) Manual Owner's (Span)
156368 189824 189830 184774 179128 188980 170563 186209
WHEELS AND TIRES 1 2
5,8
7
4,10
3,9 6
11
157141 186232 160396 189823 145005 138311 191878 191879
KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 --
Cap Valve Tire Stem Valve Tire F Ts 15 X 6 0 - 6 Service Tube Front (Service Item Only) Rim Asm 6" front Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) Rim Asm 8" rear Service Tire R Ts 18x9.5-8 Service Tube Rear (Service Item Only) Cap Axle 1 50 X 1 00 Sealant, Tire ( 10 oz. Tube)
59192 65139 106222X 59904 106732X624 278H 9040H 106108X624 106268X 7152J 104757X428 144334
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
42
TRACTOR -- MODEL NUMBER AG17542STB LIFT ASSEMBLY 7 8
5
1
3
13
2
4
6
6
11
5 4
12 13 19 20
31 32 13
19
159461 159476 178981 12000002 19211621 120183X 109413X 124526X 139865 139866 4939M
DESCRIPTION
20
20
31 32
KEY PART NO. NO. 1 2 3 4 5 6 7 8 11 12 13
15
17 18 20 16
15 lift-rh.1piece_3
KEY PART NO. NO.
DESCRIPTION
15 16 17 18 19 20 31 32
Link Front Nut Jam Hex 1/2-13 unc Trunnion Blk Zinc Nut Lock w/Wsh 1/2-13 unc Arm Suspension Rear Retainer Spring Bearing Pvt Lift Nut Crownlock 3/8-24
Wire Asm Inner/Sprg w/Plunger Shaft Asm Lift Pin Groove E Ring #5133-62 Washer 21/32 x 1 x 21 Ga. Bearing Nylon Grip Handle Button Plunger Link Lift Lh Link Lift Rh Retainer Spring
173288 73350800 175689 73800800 139868 163552 169865 73540600
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
43
TRACTOR -- MODEL NUMBER AG17542STB MOWER DECK 67 158
od m
152
_7
185
42 _c lu tc h_
68 40 36 40
113 111
116 120 117
143
21 2
144
159 46
45 150
40
119
145
118 44
184 59
56 53 52 55 48 147
54 142
148
146 33 32 31
21 112
2
30
118 34
21
117
119
120 116
21 113
1 147
2 21
142
21 23
24 25 26
2 16 15 14
20 18
3 4 5
18
149 13
6
11 19
42_deck_man-t-path_3
21
10 9
8
44
28 29
27
TRACTOR -- MODEL NUMBER AG17542STB MOWER DECK
KEY PART NO. NO. 1 2 3 4 5 6 8 9 10
165892 72140506 138017 165460 4939M 178024 850857 10030600 140296
11
134149
--
139775
--
138971
13 14 15 16 18 19 20 21 23 24 25 26 27 28 29 30 31 32 33 34 36 37 40 44
137645 128774 110485X 174493 72140505 132827 159770 73680500 177563 105304X 123713X 110452X 130968X428 19111016 131491 173984 187690 153535 178342 72110612 131494 19131316 73900600 140088
KEY PART NO. NO.
DESCRIPTION Mower Deck Assembly, 42" Bolt Bracket Asm Fr. Sway Bar 3/42 Bracket Asm Deck 42" Sway Bar Retainer Spring Bar Sway Deck Bolt 3/8-24 x 25 Gr. 8 patched Washer, Lock Washer, Hardened (The following blades are available) Blade, 42" Mulching Std (For mulching mowers only) Blade, 42" Mulching Premium (For better wear when mulching Blade, 42" Hi-Lift (For bagging or discharging) Shaft Assembly, Mandrel, Vented Housing, Mandrel, Vented Bearing, Ball, Mandrel Stripper, Mandrel Deck Bolt, Carriage 5/16-18 x 5/8 Bolt, Shoulder Baffle, Vortex Nut Bracket, Deflector Mower 42" Cap, Sleeve 80 x 112 Blk Mower Spring, Torsion, Deflector 2 52 Nut, Push Phos & Oil Shield, Deflector 42" Blk Washer 11/32 x 5/8 x 16 Ga. Rod, Hinge 42" 6 75 W/G Screw Thdrol Washer Head Washer, Spacer Mower Vented Pulley, Mandrel Nut, Toplock 9/16 Flange Bolt Pulley, Idler, Flat Washer 13/32 x 13/16 x 16 Ga. Nut Guard, Mandrel, LH
45
45 46 48 52 53 54 55 56 59 67 68 111 112 113 116 117 118 119 120 142 143 144 145 146 147 148 149 150 152 158 159 184 185 --
4497H 137729 133944 139888 184907 178515 155046 165723 141043 106932X 144959 179292 179293 17000510 4898H 105455X 73930600 19121414 19171512 165890 157109 158634 165888 171977 131335 169022 165898 19091210 169676 17720408 72140614 19131410 188234 130794
DESCRIPTION
Retainer Screw, Thdrol 1/4-20 x 5/8 T Washer, Hardened Bolt, Shoulder 5/16-18 unc Arm Assembly, Pad, Brake Washer, Hardened Arm, Idler Spacer, Retainer Guard TUV Idler Knob V-Belt, 42" Mower Bracket Wheel Gauge LH Bracket Wheel Gauge RH Bolt 5/16-18 Bolt Shoulder Wheel Gauge Nut Centerlock 3/8-16 Washer 3/8 x 7/8 x 14 Ga. Washer 17/32 x 15/16 x 12 Ga. Arm Spring Brake Mower Bracket Arm Idler 42" Keeper Belt 42" Clutch Cable Pulley Idler Flat Bolt Carriage Idler Spring Extension Spring Return Idler Retainer Spring Yellow Washer 9/32 x 3/4 x 10 Ga. Clutch Cable 42" Screw Hex Thd Cut 1/4-20 x 1/2 Bolt Rdhd Sqn 3/8-16 unc x 1-3/4 Washer 13/32 x 7/8 x 10 Ga. Head Asm Cable Clutch Mandrel Assembly (Includes Housing, Shaft and Shaft Hard ware Only-Pulley Not Included) -171491 Replacement Mower, Complete (Std. deck order separately gauge wheel components key nos. 116119) NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
