2220 Interconnect Drawing Cp Integrated Motor

Transcript

CP2220 Interconnect Drawing IMCB enclosure mounted to lens mount NOTE: All part numbers subject to change J53 P5 J99 P5 P53 P99 J94 P94 P39 J39 P36 -12 05 O 86-01 -11 R 123 6-0 1 002 RED BLUE GREEN Fan 5 Fan 6 Fan 7 Fan 8 Light Engine Quick Disconnect Board (LEQD) 001-111257-xx P6A1 J6A1 J13 P13 Christie Serial Protocol P6A2 J6A2 Security Ring 001-111277-02 SPB2 LID P11 J11 Light Engine Quick Disconnect 2 2 Main Power Run PIB Status Link Decryptor ICP IMB Status Status Status PCB LEDB 001-111180-01 J11 F F PIB RS-232 ICP RS-232 001-111520-01 J80 LD (Optional) A1J1 A1J1 A1J2 A1J2 A1J3 A1J3 ASSY PIB 000-101341-05 Image Media Block ICP 000-101342-05 J8 J4 J5 J6 J7 ETH DVI-D A DVI-D B 292 A 292 B Fan 2 Cardcage Exhaust Fans Security Lock Interlock Switch 016-100966-01 F F M SCCI J10 GPIO 3D Security Ring Reset 001-111169-02 J12 A3J1 A3J1 J3 P31 J1 J1 4 J2A2 P2A2 001-111138-01 J2A1 P2A1 J2 P30 001-111170-01 NOTE: Fans 1,2,5-8 P/N# 001-110827-02 Fan 1 001-111173-01 001-111137-01 -12 05 O 87-01 -11 R 123 6-0 1 -12 05 O 86-01 -11 R 123 6-0 1 002 J9 P9 Ballast COM J8 P8 LVPS 002-120535-xx 001-111129-01 Blue Satellite 001-111253-02 Backplane 001-111469-xx 4 30 AMP AC Line Filter 016-101834-01 Green Satellite 001-111252-02 10 Comms Optional Intake Fans (2) 4 Red Satellite 001-111252-02 002 001-111176-01 Cardcage Intake Fans (2) Standby Power LVPS Input connects to either: AC Power Relay or UPS Input Plug. NEVER connect both!! Default connection is to AC Line Filter (in production). Heatsink Blue DMD 001 Blue DMD Temp J7 P7 Standby Supply (+24V) 002-120509-01 Heatsink GREEN DMD P12 J12 J14 P14 Spare (5..0) CAT-5E: 4 Ethernet Heatsink Red DMD 001 Green DMD Temp 001-111140-01 GND GND 001-111128-02 001-111123-01 L 001-110854-01 Red DMD Temp 4 +24V_stdby, GND N LAD Fan Prism Temp J1 PLUG 001-111122-02 Quick Disconnect Panel Fan 4 PIBUP P18 J18 GPIO P101 J101 001-111127-01 4 MALM/GPIO DMD Cooling System 4 Temp Sens 1-4 AC_OK (Collector), DC_OK (Collector), Enable Logic ‘1’, +5V Housekeeping Voltage, SCL,SDA, A (2..0), GND (thick wire) LED 001-111198-01 001-111139-04 4 10 001-111126-03 +12V +12V LI (Neutral) L2 (Line) 001-111375-01 Pump J2 001-111123-02 J34 P34B MCB2 9 +12V, GND 16 Pump 001-111179-01 J100 P5 P100 001-111133-01 +12V DC Power Module (Dual) GND 001-111350-01 Fan 3 J10 P10 001-111135-01 X-Axis Sensor 001-111171-01 2 9 +24V, GND 001-111136-01 +12V GND X-Axis Focus Motor 001-111242-01 GND 002-120508-01 LVPS with Built in Fan 0 1 M 6 J1 8 1 LMP_EN, RS-232 Tx, RS-232 Rx, +5V, RTNx2 001-111171-01 11 2 J1 4 001-111141-02 001-111351-03 J1 AC Power Relay 016-101691-01 30 AMP, DPST 6 1 EVB (EnVironmental Board) 001-111059-xx Temp Sens 5-8 Power P32 J32 001-111171-01 002-120453-01 11 Fan2 Y Y-Axis Sensor +24V J94 P94 J93 P93 J43 P43 J31 P5 Lamp Exhaust Temp 2 5 Y-Axis Stepper Motor 001 001-111337-02 +24V 4 Fan1 Filtered Air Intake Temp +24V DC Power Module (Single) 5 M RAD Fan In-Line Connector (LMP_EN +5V, RTN) 6 001-111171-01 Focus 3 J34 P34A MCB1 P71 3 Zoom Sensor 001-111178-01 2 1 Integrator Temp 0.22uF Capacitor Y-Axis Motor J92 P92 J42 P42 SPB-2 Boundary +24V + 3kW Ballast Control 002-100228-xx or 002-120526-xx N L +24V STBY Ballast Harness 001-100549-01 A GND 4mm Bonding Grounding Stud Lamp Door Zoom 001-111171-01 P40 J40 Extractor Lamp Blower P36 J36 P35 J35 J71 P5 - 2uF Startup Capacitor 001-100417-01 5 Fire Alarm B Terminal Block 34-002030-01P 001-100438-02 X-Axis Sensor 4 M P35 J35 +24V STBY Igniter 002-100100-01 or 002-120580-1 001-111330-01 4 Z-Axis Z-Axis Sensor Motor J44 P44 001-111326-xx 001-100029-02 P31 001-100550-02 001-100605-01 5 001-100550-02 Light Sensor Module (LSM) 001-100229-01 5 Removable Lenses (Zoom) X Radiator 001-111637-02 001-100417-01 X-Axis Sensor Lamp Blower (AC) 001-100247-01 Y-Axis Sensor 001-111171-01 4 Zoom Focus Motor J41 P41 4 Xenon Lamp Focus Sensor J91 P91 001-111326-xx 5 J42 P42 5 M X-Axis Stepper Motor Integrated Motor Control Board (IMCB) 001-111426-xx Y-Axis Sensor 001-100417-01 J91 P91 4 Z-Axis Sensor J41 P41 001-111326-xx X-Axis X-Axis Y-axis Sensor Motor Sensor Y-Axis Stepper Motor Focus Sensor M AC Blowers for Lamp Compartment Integrated Motor Control Board (IMCB) 001-111426-xx 001-111171-01 J92 P92 M GPIO M 4 Focus Stepper Motor J43 P43 4 DC Motor 001-111171-01 J93 P93 M J99 P99 J44 P44 001-100646-01 J53 P5 P53 Zoom Sensor Z-Axis Stepper Motor Douser DC GPIO Motor USB1 USB2 Security Lock Interlock Switch 016-100966-01 Emergency Start Marriage 1uF Capacitor L 001-111738-01 (Used with 002-120526-01) 001-110896-01 N L Ballast Input (field wireable) 020-100439-05 Rev. 1 (09-2012) E N RFI M4 Stud 016-102108-01 (field wireable) M5 Stud for Earth 001-100653-01 G Receptacle w/ Filter 15 Amp: 016-100006-02 AC/UPS Input 120-240 VAC F M 001-120506-01 or 002-120576-01 Auxiliary Blanking Plate Panel Motorized Auxiliary Lens Mount (MALM) 001-100410-xx (OPTIONAL) Page 1 of 1