Transcript
TRACTOR -- MODEL NUMBER 271150 SCHEMATIC
RED
BLACK
BATTERY
RED
A
RED
FUSE
AMMETER (OPTIONAL)
M STARTER BLACK
WHITE
SOLENOID RED
B
S
G
BLACK
L
M
CLUTCH / BRAKE (PEDAL UP)
A1 A2
WHITE
SEAT SWITCH (NOT OCCUPIED)
IGNITION SWITCH
WHITE
BLACK
BLACK
BLACK BLACK
HOUR METER
ATT'MENT CLUTCH (CLUTCH OFF)
GROUNDING CONNECTOR
(OPTIONAL)
BLUE
SPARK PLUG GAP (2 PLUGS ON TWIN CYL. ENGINES)
IGNITION UNIT
BLACK
FUEL LINE
CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM
FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED)
28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
RED LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 RPM
ORANGE
BLACK
DIODE
ALTERNATOR
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)
NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST.
BLACK
BROWN
HEADLIGHTS
NON-REMOVABLE CONNECTIONS
IGNITION SWITCH POSITION
CIRCUIT
OFF M+G+A1 RUN/LIGHT B+A1 RUN START
B+A1 B + S + A1
REMOVABLE CONNECTIONS
“MAKE” NONE A2+L NONE NONE
WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.
29
REPAIR PARTS TRACTOR -- MODEL NUMBER 271150 ELECTRICAL 22
21
42 24
41
43 27
27 40
26
27
27
25 16
16
33
30
48
52
29 28
8
27
90
2 1
30
TRACTOR -- MODEL NUMBER 271150 ELECTRICAL
KEY PART NO. NO.
DESCRIPTION
1 2 8 16 21 22 24 25 26 27 28 29 30 33 40 41 42 43 48 52 90
Battery Bolt, Hex Head 1/4-20 unc x 3/4 Box Battery Fender Switch, Interlock Harness, Light Socket (Includes 4152J) Bulb, Light Cable, Battery, 6 Gauge, Red, 11" Cable, Battery, 6 Gauge, Red, W/16 Wire Fuse Nut Keps Hex 1/4-20 UNC Cable, Ground, 6 Gauge, Black, 12" Switch, Plunger Switch, Ignition Key, Ignition Harness, Ignition Bolt, Hex Head, Fin. 1/4-20 x 1/2 Cover, Terminal, Red Solenoid Adaptor Ammeter Rectangular Protection Wire Loop Cover Terminal Battery
163465 74760412 176689 176138 175685 4152J 4799J 146147 175158 73510400 4207J 121305X 175566 140401 179720 71110408 131563 178861 140844 141940 180449
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
31
TRACTOR -- MODEL NUMBER 271150 CHASSIS AND ENCLOSURES
212
17
30
24 29
18 24
26
25 26
25
12
5
53 5
31 209
51
52
209
55
57
9
11
208
28
15 209
209
8
54
209
6 26
1
16
13
3
35
145
37 33
37
10
3
35
2
205
34 26
38 206
208
3 205
38
32
TRACTOR -- MODEL NUMBER 271150 CHASSIS AND ENCLOSURES
KEY PART NO. NO.
DESCRIPTION
1 2 3 5 6 8 9 10 11 12 13 15 16 17 18 24 25 26 28 29 30 31 33 34 35 37 38 51 52 53 54 55 57 145 205 206 208 209 212 --
Chassis Drawbar Screw 3/8-16 x 3/4 Bumper Hood/Dash Saddle Slkscr Flt LT Clip Retainer Slide-On Dash Bolt Rdhd Sqnk 3/8-16unc X 1 Panel Dash LH Clip Tinnerman Grille P/L Panel Slkscr Dash RH Screw Mach TRHD 5/16-18 unc x 3/4 Nut Keps 5/16-18 Unc Hood Asm Bumper Hood Bolt Fin Hex 3/8-16 unc x 1 Gr. 5 Washer 13/32 X 13/16 x 12 Ga Nut Hex Lock W/Ins. 3/8-16 Unc Grille/Lens Asm Lens Headlight Bar Clear Fender Bracket Fender Repl 109873x Footrest Pnt Lh Footrest Pnt Rh Bolt Rdhd Sht Sqnk 3/8-16 x 3/4 Screw Thdrol 5/16-18 x 1/2 Bracket Asm Pivot Mower Rear Nut Lock Hex w/Ins 1/4-20 Washer 9/32 x 7/8 x 16 Ga. Bracket, Grille LH Screw Bracket, Grille RH Bolt Hex 1/4-20 x 3/4 Rod Pivot Chassis/Hood Screw Thdrol 3/8-16 x 1/2 Bolt Shoulder 5/16-18 Screw thdrol 3/8-16 x 1/2 Screw Hex Wsh Thdrol 3/8-16 Insert Lens Reflective Plug Button Blk 359 Dia Choke
174620 176554 17060612 155272 174643X014 155138 168347X011 72140608 174996 145660 172105X010 74180512 73510500 159639X417 184921 74780616 19131312 73680600 179777 150209X599 169465X417 136619 179716X417 179717X417 72110606 17490508 175710 73800400 19091416 144697 161464 144696 74780412 156524 17490608 170165 17670608 17000612 156494 5479J
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
33
TRACTOR -- MODEL NUMBER 271150 GROUND DRIVE
57
51
63
21 8
212
59
12
70
66
116
7 61
10
65
12
13
56
55
64
14 112 18 113 16
41
11 30
170
32
6
38
48
6
6
47 62
3
77
49
30 52
4
35 79
26
120 37
36
250
34
25
19
28
24
36
77 96 26
74 78
1
35 53
2
15
151 51
27
39 32 250
150
5 18
52
202
50
51
76
29
75
34
22
26
27
TRACTOR -- MODEL NUMBER 271150 GROUND DRIVE
KEY PART NO. NO. 1
------
2 3 4 5 6 7 8 10 11 12 13 14 15 16 18 19 21 22 24 25 26 27 28 29 30 32 34 35 36 37 38 39 41 47
146682 123666X 12000028 121520X 17000512 162240 131679 76020416 105701X 19151216 74550412 10040400 74490544 73800500 74780616 73800600 106933X 130804 73350600 106888X 19131316 76020412 175765 71673 174973 74760512 175578 120183X 19211616 1572H 179114 74760648 175556 127783
DESCRIPTION Transaxle Dana D4360-139 (Order parts from transaxle Manufacturer) Spring Return Brake T/a Zinc Pulley Transaxle 18/20" tires Ring Retainer # 5100-62 Strap Torque 30 Degrees Screw 5/16-18 x 3/4 Bracket Saddle Shift T/a Rod Shf Sdl LY/YT Str Blk Pin Cotter 1/8 x 1 Cad Washer Plate 388 Sq Hole Washer 15/32 x 3/4 x 16ga Bolt 1/4-28unf Gr8 W/Patch Washer Lock Hvy Helical 1/4 Bolt Hex Flghd 5/16-18 x Gr. 5 Nut 5/16-18 Bolt Fin Hex 3/8-16 UNC x 1 Gr. 5 Nut Lock Hex W/Ins. 3/8-16 Unc Knob Rd 1/2-13 Plstc Thds Rod Brake Blk Zinc 26 840 Nut Hex Jam 3/8-16 Unc Spring Rod Brake 2 00 Zinc Washer 13/32 x 13/16 x 16 Ga. Pin Cotter 1/8 x 3/4 Cad Rod Brake Parking Lt/Yt Cap Brake Parking Bracket Mtg Transaxle Bolt Hex Hd 5/16-18unc x 3/4 Shaft Asm Pedal Foot Nibbed Bearing Nylon Blk 629 Id Washer 21/32 x 1 x 16 Ga Pin Roll 3/16 x 1" Pulley Composite Flat Bolt Fin Hex 3/8-16 UNC x 3 Gr. 5 Keeper Belt Idler Pulley Idler V Groove Plastic
KEY PART NO. NO.
DESCRIPTION
48 49 50 51 52 53 55 56 57 59 61 62 63 64 65 66 70 74 75 76 77 78 79 96 112 113 116 120 150 151 170 202 212
Bellcrank Asm. Clutch Retainer Belt Style Spring Bolt 3/8-16 x 1-1/2 Gr. 5 Nut Crownlock 3/8-16 UNC Nut Crown Lock 5/16-18 Link Clutch 7 66 Spring Return Clutch 6 75 Screw 3/8-16 x 1-1/4 V-Belt Gd Drive 9530 Keeper Belt Centerspan Screw 3/8-16 x .875 Cover Pedal Blk Round Pulley Eng Cl Cable Bolt Hex 7/16-20 x 4 Gr 5 Washer Lock Hlcl Spr 7/16 Keeper Belt Engine FP Guide Belt Mower Drive RH Spacer Axle Washer 25/32 x 1-1/4 x16 Ga E-ring #5133-75 Key Square 2 0 x 1845/ 1865 Washer 25/32 x1-5/8 x 16 Ga Key Woodruff #9 3/16 x 3/4 Retainer Spring 1 Washer 9/32 x 3/4 x 10 Ga Strap Torque LH LT Bolt 3/8-16 x 1 Nut Lock Flg 3/8-16 Spacer Retainer Washer 13/32 x 2 x 10 Ga. Keeper Belt Transaxle Gear Bolt Carr. Sh 3/8-16 x 1-3/4 Gr. 5 Nut Hex Flange Lock
154407 123205X 72110612 73680600 73680500 105710X 105709X 17060620 160855 169691 17120614 8883R 175410 71170764 10040700 154778 134683 109502X 121749X 12000001 123583X 121748X 2228M 4497H 19091210 127285X 72140608 73900600 175456 19133210 178394 72110614 145212
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
35
TRACTOR -- MODEL NUMBER 271150 STEERING
38 12 39
1
41
42 37 37 36
44 51
54
88
91 43
71
68
67
67
29 46 8
47
6 9
17
67 13 65
46
85
2
8 7
85
6 9
9 5
47 7
3
32
9 5
68
11
82
29
26
4 43
15
40 15
43
29
28 15
10 30
36
6 8
TRACTOR -- MODEL NUMBER 271150 STEERING
KEY PART NO. NO.
DESCRIPTION
1 140044X428 Steering Wheel 2 175131 Axle Assembly 3 169840 Spindle Assembly, L.H. 4 169839 Spindle Assembly, R.H. 5 6266H Bearing, Race, Thrust, Hardened 6 121748X Washer 25/32 x 1-5/8 x 16 Gauge 7 19272016 Washer 27/32 x 1-1/4 x 16 Gauge 8 12000029 Ring, Klip 9 3366R Bearing, Steering Column 10 175121 Draglink 11 10040600 Washer, Lock 12 73940800 Nut Hex Jam Toplock 1/2-20 13 136518 Spacer Bearing Axle Front 15 145212 Hexflange Lock 17 180641 Shaft Assembly, Steering 26 126847X Bushing, Link, Drag 28 19131416 Washer 13/32 x 7/8 x 16 Gauge 29 17060612 Screw, 3/8-16 x 3/4 30 76020412 Pin 32 130465 Rod, Tie 36 155099 Bushing, Steering 37 152927 Screw 38 140045X428 Cap, Steering Wheel 39 19183812 Washer 9/16 x 2-3/8 40 7810H Gripco Nut 41 100711L Adaptor, Steering Wheel 42 145054X428 Boot, Steering 43 121749X Washer 25/32 x 1-1/4 x 16 Gauge 44 180640 Shaft Extension Steering 46 121232X Cap, Spindle 47 183226 Fitting, Grease 51 73540400 Nut 1/4-28 54 71130420 Bolt Hex 1/4-28 x 1-1/4 63 74780616 Bolt Fin Hex 3/8-16 x 1-1/4 65 160367 Spacer Brace Axle 67 72140618 Bolt, Rdhd Sq 3/8-16 UNC x 2-1/4 68 169827 Axle, Brace 71 175146 Steering Asm 82 169835 Bracket Susp Chassis Front 85 133835 Fastener Christmas Tree 88 175118 Shoulder Bolt 91 175553 Clip Steering NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
37
TRACTOR -- MODEL NUMBER 271150 ENGINE
3
2
72 1
81
13
78 38 32
14
16 44
78
46
33 37
31
40
33 45
29
23
OPTIONAL EQUIPMENT Spark Arrester
38
4
TRACTOR -- MODEL NUMBER 271150 ENGINE
KEY PART NO. NO. 1 2 3
170551 17720408 ------
4 13 14 16 23 29 31 32 33 37 38 40 44 45 46 72 78 81
137348 165291 148456 11050600 169837 137180 184900 140527 123487X 137040 181654 124028X 17670412 17000612 19091416 183906 17060620 73510400
DESCRIPTION Control Th/ch Screw Hex Thd Cut 1/4-20 x 1/2 Engine Briggs Model 28R707-1147-E1 (Order parts from Engine Manufacturer) Muffler Gasket Eng 1 313 Id Tin Plated Tube Drain Oil Easy Washer Lock Ext Tooth 3/8 Shield Browning Kit Spark Arrestor (Flat Scrn) Tank Fuel Front 1 25 Cap Asm Fuel Clamp Hose Blk Line Fuel 20" Plug Drain Oil Easy Bushing Snap Nyl Blk Fuel Line Screw Hexwsh Thdrol 1/4-20 x 3/4 Screw Hex Wsh Thdrol 3/8-16 Washer 9/32 x 7/8 x 16 ga Screw Socket Head 5/16-18 x 1 Screw 3/8-16 x 1-1/4 Nut Keps Hex 1/4-20 UNC
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
39
TRACTOR -- MODEL NUMBER 271150 SEAT ASSEMBLY 1
8 8
9 14
9
7
7
10
5 6 22 21
2 24 5
16 25 15 11 4 13 17 KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 12
Seat Bracket Pvt St Bolt Fin Hex 3/8-16unc x 1 Washer Flat 13/32 x1 x10 Ga Clip Push-In Hinged Locknut Hex W/Wsh 3/8-16 Spring Seat Cprsn 2 250 Blk Screw 3/8-16 x 1 Washer 13/32 x 1 x 14 Ga Pan Seat Knob Seat Adj. Wingnut Bracket Mounting Switch
127427 140551 71110616 19131610 145006 73800600 124181X 17000616 19131614 182493 166369 121246X
3
12 KEY PART NO. NO.
DESCRIPTION
13 14 15 16 17 21 22 24 25
Bushing Snap Blk Nyl 50 Id Bolt Rdhd Sht 1/4-20x1-1/2 Spacer Split 28x 96 Yel Zinc Spring Cprsn 1 27 Blk Pnt Nut Lock 1/4 Lge Flg Gr 5 Bolt Shld 5/16-18 Unc Nut Lock Hex W/Ins 5/16-18 Washer 17/32 x1-3/16x12 Ga Bolt Shoulder 5/16-18 x 62
121248X 72050412 134300 121250X 123976X 171852 73800500 19171912 127018X
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
40
TRACTOR -- MODEL NUMBER 271150 DECALS 6 3 4
3
1
7
1
11 8
5
13
2
15 12 KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 8
Decal Lower Dash Decal Engine Decal Hood Decal Fender Decal Battery Danger Decal Replacement Decal Steering Decal, Oper sdl P/L Gear
177109 176394 171828 171829 145005 186216 171830 156867
KEY PART NO. NO.
---
185514 185515
1 2 3 4 5 6 7
1 5,8 4,10
7 3,9 6
156439 181249 146046 136832 138311
KEY PART NO. NO.
WHEELS AND TIRES
2
11 12 13 15 --
8 9 10 11 --
11
DESCRIPTION Decal Fender Dnger Decal, Clutch/Brake Eng Decal V-Belt Dr Sch tractor Decal V-Belt sch Decal Handle Lft Height Adjust (Lift Handle) Owner’s Manual, English Owner’s Manual, Spanish
DESCRIPTION
59192 65139 106222X 59904 106732X624 278H 9040H
Cap Valve Tire Stem Valve Tire F Ts 15 X 6 0 - 6 Service Tube Front (Service Item Only) Rim Asm 6"front Service Fitting Grease (Front Wheel Only) Bearing Flange (front Wheel Only) 106108X624 Rim Asm 8"rear Service 124635X Tire Rear 7152J Tube Rear (Service Item Only) 104757X428 Cap Axle Blk 1 50 X 1 00 144334 Sealant, Tire ( 10 oz. Tube)
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
41
TRACTOR -- MODEL NUMBER 271150 LIFT ASSEMBLY
7 8
5
1
3
13 2
4 6
6
11
5 4
12 13 19 20
13
15 31 32 13
19
20
17 18 20 16
20 15
31 32
42
TRACTOR -- MODEL NUMBER 271150 LIFT ASSEMBLY
KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 8 11 12 13 15 16 17 18 19 20 31 32
Wire Asm Inner W/plunger Shaft Asm Lift Pin Groove 1 500 Zinc E Ring #5133-62 Washer Pltd 21/32 X 1 X 21ga Bearing Nylon Blk 629 Id Grip Handle Fluted Blk Button Plunger Red Link Lift LH Link Lift RH Retainer Spring Link Front Nut Jam Hex 1/2-13 Unc Trunnion Blk Zinc Nut Lock w/Wsh 1/2-13 UNC Arm Suspension Rear Retainer Spring Zinc Bearing Pvt Lift Nut Crownlock 3/8-24
159460 159471 105767X 12000002 19211621 120183X 125631X 122365X 139865 139866 4939M 173288 73350800 175689 73800800 139868 163552 169865 73540600
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
43
TRACTOR -- MODEL NUMBER 271150 MOWER DECK
40
146
89
42
157
68
148
107
67
38
108
158
36
156 153
151
89
155
56
152
36 153 154
69
33 32
55
31 40 54
150 2
123
45 113
21
110
122 53 30
1
21 88
109
87 89
24
25
28 26
97 96 21 2 86
2
21
2
23 15
16
29
14
3 5
27
13
4
6
11
19 21
10 9 8
149
44
TRACTOR -- MODEL NUMBER 271150 MOWER DECK
KEY PART NO. NO. 1 2 3 4 5 6 8 9 10 11 11 11 13 14 15 16 19 21 23 24 25 26 27 28 29 30 31 32 33 36 40 45 53
KEY PART NO. NO.
DESCRIPTION
170280 72140506 138017 169970
Mower Housing Assembly Bolt, Carriage 5/16-18 x 3/4 Bracket Asm. Fram Sway Bar Bracket, Asm. Deck Sway Bar 4939M Retainer, Spring 178024 Bar Sway Deck 850857 Bolt, Hex 3/8-24 x 1-1/4 Gr 8 10030600 Washer, Lock, Hlcl Sprg 3/8 140296 Washer, Hard Blade Mower Vented (The following blades are available) 134148 Blade, 38" Mulching Std (For mulching mowers only) 139774 Blade, 38" Mulching Premium (For better wear when mulching) 138497 Blade, 38" Hi-Lift (For Bagging and discharging) 137645 Shaft and Bearing Assembly (Includes Key Number 15) 128774 Mandrel Housing, Vented 110485X Ball Bearing, Mandrel 174493 Stripper, Mower, Vented 132827 Bolt, Shoulder 73680500 Nut, Crownlock 5/16-18 137607 Bracket, Mower Deflector 105304X Cap, Sleeve 123713X Spring, Deflector 110452X Nut, Push 106736X428 Shield, Deflector 19111016 Washer 11/32 x 3/4 x 16 Ga 106735X Rod, Hinge 173984 Screw, Thdro 129963 Washer, Spacer 153532 Pulley, Mandrel 178342 Nut, Flangelock 9/16 131494 Pulley, Idler, Flat 73680600 Nut Crownlock 3/8-16 4497H Retainer, Spring 130840 Brake Assembly
45
54 55 56 67 68 69 86 87 88 89 96 97 107 108 109 110 113 122 123 146 148 149 150 151 152 153 154 155 156 157 158
178515 133840 165723 149846 144200 76020312 7631J 128772 19111216 19131612 74930620 73930600 133502 133503 74760640 142587 17060512 131289 169971 165891 169022 165898 19091216 169670 172758 169674 169675 169671 169672 169669 17720408
--
130794
--
171665
DESCRIPTION Washer Hardened Idler Arm Assembly Spacer, Retainer Knob Belt Pin, Cotter 3/32 x 3/4 Runner, LH Runner, RH Washer 11/32 x 3/4 x 16 Ga Washer 13/32 x 1 x 12 Ga Bolt 3/8-16 x 1-1/4 Nut Centerlock 3/8-16 Spacer, Retainer Stiffener, Idler Arm Bolt, Hex Head 3/8-16 x2-1/2 Upstop Deck Front 38" Screw 5/16-18 x 3/4 Rod, Brake, LH Rod, Brake, RH Bolt Carriage Idler Spring Return Idler Retainer Spring Yellow Zinc Washer 9/32 x 3/4 x 16 Ga. Bracket Clutch Cable Clutch 38 In Washer Flat 3/8” Type B Spring Retainer Spring Retention Lever Spacer Rod Clutch Screw Hex Thd Cut 1/4-20 x 1/2 Mandrel Assembly (Includes Housing, Shaft and Shaft Hardware Only-Pulley Not Included) Replacement Mower, Complete
NOTE: All component dimensions given in U. S. inches 1 inch = 25.4 mm
