4113c100

Transcript

COMPOSITE WIRING DIAGRAM 230/208/60-1 Y1 Yellow O/B O Blue W2 W2 RED BLACK GREEN PINK RED/WHITE BROWN/WHITE BROWN BLUE GRAY YELLOW ORANGE Circuit Breaker 28 5 RED/WHITE COM BLACK/WHITE Brown/White Purple G Orange G Orange Y1 Yellow 1 2 O/B W2 Blue Brown R Red/White C Black/White L Pink 3 4 Y1 Yellow O/B Blue R Red/White C Black/White 8 L Pink 9 Temp. and Humidity Controller Part #8403-060 5 6 7 10 11 2 3 4 5 6 7 8 9 10 11 12 PLUG #1 12 Red 24VAC Red Black Black Yellow Brown Analog Out Yellow Orange Green 1 2 3 4 5 6 Brown Orange "D" THERMOSTAT OPTION Green 4115-100 39 33 18 Check Light CO2 Controller Part #8403-056 "H" THERMOSTAT OPTION 4115-101 35 36 PURPLE 27 12 PIN VENT PLUG 12 11 10 9 8 7 6 5 4 3 2 1 BLUE Optional High Speed Solenoid 1 BLUE BLACK/WHITE 48 RED Low Voltage Brown W2 35 36 27 Factory Field 1 FOR ANTIFREEZE LOOP APPLICATIONS, CHANGE LOW PRESSURE SWITCH TO YELLOW LEADS ON YELLOW WIRES COMING OFF OF COMPRESSOR CONTROL MODULE "LPC" TERMINALS 2 FOR 208V OPERATION, MOVE THIS RED WIRE TO 208V TRANSFORMER TAP 3 REMOVE JUMPER WHEN CS2000 ENERGY MONITOR IS INSTALLED 4 REMOVE WIRE FROM TERMINAL Y2 AND TAPE OFF WHEN LOWER FULL LOAD CFM DESIRED 1 39 21 Capacitor RED High Voltage PLUG #2 1 39 PINK BLACK 32 230/208 VOLT PACKAGE UNIT DIAGRAM 4115-102 4 5 3 2 BLACK/ WHITE 30 Purple A PLUG #2 31 240V C Red/Yellow Y2 Brown/White 39 C Y LPC LPC BLACK/WHITE ORANGE 2 T2 CC ALR R 1 27 BROWN GREEN HPC 38 208V "X" THERMOSTAT OPTION A BLACK/WHITE YELLOW/RED 19 RED YELLOW 15 Transformer Y2 39 RED/WHITE R Green Red/Yellow T1 48 27 6 PIN CO2 PLUG Orange 33 RED/ WHITE 38 RED/WHITE BLACK/WHITE 4 5 6 Yellow Brown W1/E LOW VOLTAGE STRIP 38 1 2 3 Red Black Yellow Brown Orange Green Black W1/E 12 37 L2 BLUE/WHITE Terminal Strip Red Temp. and Humidity Controller Part #8403-060 L1 RED/WHITE 24VAC Analog Out 31 10 2 4 10 CO2 Controller Part #8403-056 BLOWER VENT RELAY Compressor Control Module 24 YELLOW BLACK/ WHITE 10 1 3 14 32 BLACK/WHITE Pink 34 PINK 34 RED/WHITE L 10 PURPLE L 10 BROWN Black/White BLACK/WHITE C 10 ORANGE BROWN/ WHITE Ground 4 Terminal 29 27 10 BLACK/WHITE C BROWN YELLOW Red/White 4 YELLOW BROWN/WHITE 7 8 9 10 11 12 O1 Y Y1 C R 4 5 6 R Brown PURPLE ORANGE RED RED/YELLOW BLUE 5 CAPACITOR CHART MODEL CAPACITOR QW2S 35/370 QW3S 40/370 QW4S 45/370 QW5S 80/370 Reversing Valve YELLOW Y1 L1 YELLOW Orange YELLOW G RED G YELLOW Brown/White BLACK/ WHITE BLUE A PURPLE/WHITE A 12 PIN PLUG FOR THERMOSTAT 10 BLACK/WHITE Purple BLUE C Y2 3 4 5 RED NC Y2 Terminal Block #1 ("A" Ctrl. Opt. Only) L2 230/208-60-1 POWER SOURCE 11 5 PIN PLUG FOR INDOOR BLOWER MOTOR BLACK NO Red/Yellow 3 O1 Y Y1 C Compressor Contactor C E 14 12 15 3 1 10 6 9 13 2 BLACK/W NC PWR W1/E 16 PIN PLUG FOR INDOOR BLOWER MOTOR 10 1 2 3 NO HVAC Low Voltage Terminal Strip PURPLE AREA OCCUPIED Temp. and Humidity Controller Part #8403-060 RED/WHITE Optional CS2000A Energy Monitor (Use With "A" Thermostat Only) YELLOW R S RED C Hi Pressure Control Low Pressure Control Low Pressure Control BLACK Compressor 4113-100 99 ! Wire Identification numbers for Bard use only. DANGER *ELECTRICAL SHOCK HAZARD *DISCONNECT POWER BEFORE SERVICING. ! WARNING USE COPPER CONDUCTORS ONLY SUITABLE FOR AT LEAST 75° C. Bard Mfg. Co. Bryan, Ohio 4113C100