Transcript
INSTALLATION, OPERATION AND MAINTENANCE MANUAL Warning Please read carefully before proceeding with installation. Your failure to follow any attached instructions or operating parameters may lead to the product’s failure. Save manual for future reference
Model: UC1-HC
Premier, Inc. Phone: 800-752-5582 Manual #: 299112
8716 W Ludlow Drive Suite #1 www.PremierH2o.com
Peoria, AZ 85381 Fax: 623-866-5666 Manual Date: 09/25/2013
Thank you for your purchase of a state of the art Premier Water Treatment system.
UC1-HC Water Treatment System: Premier UC1-HC water treatment system contains a heavy duty sediment, cyst and chlorine reducing filter block. The UC1-HC water filtration helps protect small appliances and provides clean, clear, great tasting water with a higher flow and gallon rating than other similar systems.
System Maintenance Just because you can not taste it, does not mean that it is not there. Many contaminants in the drinking water are undetectable to the taste. Additionally, over time if you do not replace the filter elements, other bad tastes and odors will be apparent in your drinking water. This is why it is important to change your filters at the recommended intervals as indicated in this system manual. When replacing any of the filter elements, pay special attention to any cleaning instructions. Should you have any further questions please refer to our web site at www.PremierH2o.com or call our customer service department at 1-800-752-5582.
2
Table of Contents Service Record....................................................................................................................................... 3 Operational Parameters......................................................................................................................... 4 Contents of Under Counter System....................................................................................................... 4 Tools Recommended For Installation..................................................................................................... 4 Part Number List / Flow Diagram........................................................................................................... 4 Blue Tube Connection to Cold Water Angle Stop Valve......................................................................... 5 Blue Tube Connection TO Faucet Supply Hose .................................................................................... 5 Mount the Filtration System ................................................................................................................... 6 Connect the Blue Tube to the Filtration System .................................................................................... 6 Start-up Instructions .............................................................................................................................. 6 Changing The Filter Cartridge ............................................................................................................... 7 Performance Data Sheet ....................................................................................................................... 8 Warranty Registration ....................................................................................................................... 9-10 Removing chlorine from your shower....................................................................................................11 Limited Warranty ................................................................................................................................. 12
System Information
Service Record Filter Replacement Date
Model Number:
_____________
Serial Number:
_____________
Date of Purchase: _____________
3
Date of Install:
_____________
Installed by:
_____________
Operational Parameters Installation must comply with state and local plumbing regulations. Water supply line to the system must be from the cold water supply line.
Operating Temperatures: Operating Pressure: Flow Rate:
Maximum 100°F (37.8°C)
Minimum 40°F (4.4°C)
Maximum 100 psi (689 kpa)
Minimum 25 psi (172 kpa)
1.5 GPM @ 60 psi
Contents of Under Counter System √ 1 UC1-HC Unit
√ 1 Parts Bag
If any of the items are missing, please contact Premier prior to installing.
Tools Recommended For Installation √ Phillips bit for electric drill √ 1/2" Open End Wrench
√ Sharp Knife or Scisors √ Electric Drill
Part Number List / Flow Diagram Counter Top UC1-HC Blue Tubing
Blue Tubing
COLD
4
Item Part #
Description
1 2 3 4 5 6 7 8 9
3/8” BRASS INSERT 3/8” DELRIN SLEEVE 3/8” BRASS NUT 3/8” BLUE TUBING 3/8” QC UNION 3/8” QC STEM ADAPTER SYSTEM BRACKET SYSTEM LID 15” HC CARBON FILTER
231026 231020 231002 140012 125159 225008 137084 304132 500168
Blue Tube Connection To Cold Water Angle Stop Valve Caution: Water supply line to the system must be from the cold water supply line only. Hot water will severely damage your system.
Verify contents prior to installation: ( 1 ) - Brass Nut ( 1 ) - Brass Insert
( 1 ) - Plastic Delrin Sleeve ( 1 ) - 3/8” Blue Tube
( 1 ) - 3/8” x 3/8” QC Union ( 1 ) - 3/8” QC Stem Adapter
Step 1
Turn off the cold water supply to the faucet by turning the angle stop valve completely off. Open cold water sink faucet to relieve pressure.
Step 2
Place a small container under the cold water angle stop valve to catch any runoff water. Disconnect the cold water faucet supply hose from the cold water angle stop valve.
Step 3
Locate the blue 3/8” tube in the parts bag. Remove a brass nut, plastic delrin sleeve and brass insert from the parts bag. To assemble, place the brass nut on the blue tube first (Open end out), then the sleeve and then push the brass insert all the way into the end of the tube. (See Picture)
WARNING: Step 4
Do not use Teflon tape. Insert the assembled blue tube into the open fitting of the cold water angle stop valve and use an adjustable wrench to tighten the brass nut securely.
Blue Tube Connection To Faucet Supply Hose Step 5
Locate the threaded 3/8” male stem adapter fitting in the parts bag. Thread the stem adapter on to the supply hose attached to the faucet and tighten with an adjustable wrench.
Faucet Supply Hose
3/8” Adapter
Step 6
Step 7
Locate the 3/8”x3/8” Quick Connect union in the parts bag. Push the union on to the 3/8” stem adapter fitting attached to the faucet hose until fully seated. Connect the open end of the 3/8” blue tube to the open end of the 3/8”x3/8” Quick connect union fitting by pushing the tube into the adapter until fully seated.
5
3/8” Union
3/8” Blue Tube
Mount the Filtration System Step 8
Determine best location for the filtration system to be mounted and spliced into the 3/8” blue tubing. Using the mounting holes on the bracket, mark the location for the mounting screws on the cabinet wall under the sink (Make sure to leave enough room to remove the filter during filter changes, approximately 2” below filter). In the parts bag, locate the two self tapping screws. Using an electric drill with a Phillips bit, screw them into the cabinet at the marked location. Hang the system on the screws using the mounting holes in the bracket
Connect the Blue Tube to the Filtration System Step 9
After mounting the system, determine where and cut the 3/8” blue tubing into two parts in order to connect it to the filtration system.
IN
OUT
Step 10 Connect the 3/8” blue tube coming from the angle stop valve into the left side of the filtration system (IN), by pushing the tubing firmly into the quick connect fitting. Connect the 3/8” blue tube coming from the faucet supply hose into the right side of the filtration system (OUT), by pushing the tubing firmly into the quick connect fitting.
Congratulations! You have completed the installation of your new water filtration system. Please Follow the Startup Instructions.
Start up Instructions Step 1
Turn on water supply at cold water angle stop. Turn cold water faucet handle to the open position to start the flow of water through the unit. Run 5 gallons of water through the unit in order to flush out the normal black carbon fines (it will “sputter” until the air is purged out) from the unit. Initially, the water may appear cloudy which is due to tiny air bubbles and it will clear up shortly. Close the faucet when finished.
Step 2
Check for leaks. If you have any leaks, shut off the water supply to your system, tighten any fittings and restart unit. (Check frequently over the next 24 hours to ensure no leaks are present)
6
Filter Change Premier recommends changing the filter element once every 1 year. However filter life may vary depending on local water conditions and water use. Use Premier’s replacement cartridge only. Other filters may look the same, but only filters by Premier are manufactured to fit your UC1-HC filter unit in order to ensure proper reduction of water contaminants. Carbon Block Cyst Filter: Part# 500168
(A) Turn off incoming water supply to the filtration unit. (B) Open the cold water faucet handle to relieve the water pressure. (B) Remove filter from lid by turning it to the left, then pulling the filter down out of the lid. Discard of old filter. (C) Remove plastic wrapping and cap from new filter. (D) To install new filter cartridge, with the filter label facing approximately 45 degrees to the left, push the filter into the lid and twist it to the right until the filter locks in and the label on filter is facing the front. (H) Follow start-up procedure on page 6.
7
To Loosen
To Tighten
Performance Data Sheet
Premier Inc. 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381
UC1-HC
GENERAL USE CONDITIONS: 1: System to be used with municipal or well water sources treated and tested on regular basis to insure bacteriological safe quality. DO NOT use with water that is micro biologically unsafe or of unknown quality without adequate disinfection before or after the system. Systems certified for cyst reduction may be used on disinfected waters that may contain filterable cysts. 2: Operating Temperature: 3: Operating Water Pressure: 4: Maximum flow Rate: 5: Rated Capacity (Chlorine):
Maximum 100o F (38o C) Maximum 100-psi (689kpa) 1.5 gpm (5.7 lpm) 10000 Gallons (37,854 liters)
Minimum 40o F (4.4o C) Minimum 25-psi (172kpa)
RECOMMENDED REPLACEMENT PARTS AND CHANGE INTERVAL: Note: Depending on incoming feed water conditions replacement time frame may vary. Description UC1-HC
Part Number 303016
Change time Frame 12 Months or 10000 gallons of water
California Proposition 65 Warning WARNING: this product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. (Installer: California law requires that this warning be given to the consumer). For more information: www.wattsind.com/prop65
8
WARRANTY REGISTRATION Thank you for selecting Premier for your water filtration needs.
4 Ways to Register 1. On-line at www.PremierH2o.com
Register your product on-line and receive a 5% discount on your next on-line order, Plus receive reduced shipping.
2. Call in your information 1-800-752-5582
Call and we will enter your registration information for you.
3. Fax in your information Fax this form directly to us.
623-866-5666
4. Mail in the information. Please complete the form below. Mail to: Premier 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381
Registering will insure you receive Premier
FREE Filter Reminder Notice
Premier Inc. is concerned for the safety of your personal information. Premier collects personal information when you register with Premier. This information is stored in our data base and we do not rent, sell, or share personal information with other people or nonaffiliated companies. We reserve the right to send you certain types of communications such as direct mail, email, or by telephone relating to our products or products that you have purchased. We limit access to your personal information to those employees who will directly provide you with services or products in order to do their jobs. We want to offer you four ways to communicate with us. 1.Online, 2.Fax, 3.Telephone, and 4. Mail the form below. By registering your product you will receive the full benefit of our warranty. Premier will also send you a semiannual filter change reminder beginning six months from date of installation. To insure the highest quality of your water, filters should be replaced every 6 months. If you have any questions or comments please give us a call at 1-800-752-5582 M-F 8:00am -5:00pm MST.
First Name:_________________________ Last Name:____________________________ Address: ________________________________________ City: ____________________ State: _______________________________________ Zip Code: ___________________ Country:
USA
CANADA
MEXICO
OTHER ____________
Phone # ______-__________ -__________
Email Address: ______________________
Date of Purchase: ___________________
Date of Install: _______________________
Installed By:
SELF
Plumbing Professional
Model Number: _______________________ Premier, Inc. Phone: 800-752-5582
Where Purchased: ____________ Serial Number: ____ - __________ XXXXX XXXXXX
8716 W Ludlow Drive Suite #1 www.PremierH2o.com 9
Peoria, AZ 85381 Fax: 623-866-5666
WARRANTY REGISTRATION Please Fill out and keep for your Records First Name:_________________________ Last Name:____________________________ Address: ________________________________________ City: ____________________ State: _______________________________________ Zip Code: ___________________ Country:
USA
CANADA
MEXICO
OTHER ____________
Phone # ______-__________ -__________
Email Address: ______________________
Date of Purchase: ___________________
Date of Install: _______________________
Installed By:
SELF
Plumbing Professional
Model Number: _______________________
Where Purchased: ____________ Serial Number: ____ - __________ XXXXXX XXXXX -
Iowa Department of Public Health - Sales in Iowa require this to be completed, signed and returned. These signatures will be retained on file for two years.
Insert into envelope and return to Premier Premier 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381
10
Removing chlorine from your shower Special Chlorgon & KDF media – More effective then carbon medias with hot water applications in the removal of the following. √ √ √ √
√ Iron oxide (rust water) Free Chlorine (CL-) Combined Chlorine (Sodium Hypochlorite) √ Dirt, sediment √ Odors Hydrogen Sulfide (Rotten egg smell) Plus, its pH balanced.
Deluxe Shower Handle with Built in Filter Replacement filters 2PK 5-Way Massaging Spray 72” Reinforced Hose High Strength Bracket Triple Plated Finish Reversible Filter Cartridge (Model HHC) Cartridge Life Rating: 3 months Part No. 107070 WHITE *$38.95 Part No. 107091 CHROME *$44.95 Part No. 107075 *$15.95/pk Part No. 107092 GOLD *$44.95 Shower Falls Deluxe Shower Handle with Built in Filter Curved Ergonomic Shower Handle Replacement filters 2PK Filter Handle Extension Dual Swivel Adjustment Ultra Deluxe 5 Way Massaging Spray 72” Reinforced Hose Chrome Plated Brass Bracket & Swivel Ball Extension Triple Plated Finish Reversible Filter Cartridge (Model HHC) Cartridge Life Rating: 3 months Part No. 107075 *$15.95/pk Part No. 107095 CHROME *$55.95 All-In-One reversible High-Flow Filter Deluxe 5-Way Massaging Spray Soft-Touch Adjustment Pads Anti-Scaling Spray Nozzle High Strength Housing Triple Plated Finish Cartridge Life Rating: 6 months Part No. 107098 White/Chrome *$39.95
Replacement filter
Part No. 107080 *$13.95/ea
*All prices subject to change without notice. 11
8716 W Ludlow Drive Suite #1 Peoria, AZ 85381
Limited Warranty
What your Warranty Covers: If any part of your Premier UC1-HC is defective in workmanship (excluding replaceable filters ), return unit after obtaining a return authorization (see below), within 3 years of original retail purchase, Premier will repair or, at Premier’s option, replace the system at no charge. How to obtain Warranty Service: For warranty service, call 1-800-752-5582 for a return authorization number. Then, ship your unit to our factory, freight and insurance prepaid, with proof of date of original purchase. Please include a note stating the problem. Premier will repair it, or replace it, and ship it back to you prepaid. What this warranty does not cover: This warranty does not cover defects resulting from improper installation, (contrary to Premier’S printed instructions), from abuse, misuse, misapplication, improper maintenance, neglect, alteration, accidents, casualties, fire, flood, freezing, environmental factors, water pressure spikes or other such acts of God. This warranty will be void if defects occur due to failure to observe the following conditions: 1. The UC1-HC System must be hooked up to a potable municipal or well cold water supply. 2. The pH of the water must not be lower than 5 or higher than 10. 3. The incoming water pressure must be between 25 and 100 pounds per square inch. 4. Incoming water to the Counter Top cannot exceed 100 degrees F (38 degrees C.) This warranty does not cover any equipment that is relocated from the site of its original installation.
This warranty doe not cover any charges incurred due to professional installation.
This warranty does not cover any equipment that is installed or used outside the United States of America and Canada. LIMITATIONS AND EXCLUSIONS: Premier WILL NOT BE RESPONSIBLE FOR ANY IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. Premier WILL NOT BE RESPONSIBLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES, INCLUDING TRAVEL EXPENSE, TELEPHONE CHARGES, LOSS OF REVENUE, LOSS OF TIME, INCONVENIENCE, LOSS OF USE OF THE EQUIPMENT, AND DAMAGE CAUSED BY THIS EQUIPMENT AND ITS FAILURE TO FUNCTION PROPERLY. THIS WARRANTY SETS FORTH ALL OF PREMIER’S RESPONSIBILITIES REGARDING THIS EQUIPMENT. OTHER CONDITIONS: If Premier PREMIER chooses to replace the equipment, Premier may replace it with reconditioned equipment. Parts used in repairing or replacing the equipment will be warranted for 90 days from the date the equipment is returned to you or for the remainder of the original warranty period, whichever is longer. This warranty is not assignable or transferable. YOUR RIGHTS UNDER STATE LAW: Some states do not allow limitations on how long an implied warranty lasts, and some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitations or exclusions may not apply. This warranty gives you specific legal rights, and you may have other legal rights which vary from state to state.
