Transcript
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) DECALS
7
11
16
4
4
3
10
20
9 1
8 6
12 5 2
14
KEY NO. 1 2 3 4 5 6 7 8 9 10 11
PART NO. 193939 186503 176273 189289 189288 170563 194984 179128 172740 157140 172743
13
DESCRIPTION Decal Oper Decal Dash Decal Hood LH Decal Side Panel Logo Decal Eng. HP Decal Warning, Keep Hand Away Decal Replacement Parts Decal Deck "B" 42" Decal Fender Logo Decal Fender Danger E/F Decal Ins Strg Whl
WHEELS AND TIRES 1 2
5,8 4,10
7 3,9 6
11
KEY NO.
PART NO.
DESCRIPTION
12 13 14 16 20 ------
173587 173589 160396 176272 145005 166960 184310X428 184311X428 195018 195019
Decal Fend Reflector Rh Decal Fend Reflector Lh Decal V-Belt Schematic Decal Hood Rh Decal Bat Dan/Psn Decal By Pass Lt Hydro Pad Footrest LH Pad Footrest RH Manual Operator's E&F Manual Parts E&F
KEY NO. 1 2 3 4 5 6 7 8 9 10 11 --
PART NO. 59192 65139 106222X 59904 106732X421 278H 9040H 106108X421 138468 7152J 104757X421 144334
DESCRIPTION Cap Valve Tire Stem Valve Tire F T 15 x 6 0 - 6 Service Tube Front (Service Item Only) Rim Asm 6" front Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel nly) Rim Asm 8" rear Service Tire R T 20 x 8-8 Service Tube Rear (Service Item Only) Cap Axle Blk 1 50 x 1 00 Sealant, Tire (10 oz. Tube)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
2
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) SCHEMATIC BATTERY SOLENOID A
RED
RED
AMMETER (OPTIONAL)
M
RED
FUSE
STARTER
PTO (DISENGAGED)
WHITE
B S M G A1 L A2
WHITE
IGNITION SWITCH
BLACK
CLUTCH / BRAKE (PEDAL UP) GRAY
BLACK
SEAT SWITCH (NOT OCCUPIED) BLACK
BLACK
GRAY
REVERSE SWITCH BLACK
SHORTING CONNECTOR NOT IN REVERSE BLACK
ELECTRIC CLUTCH BLACK RED
BLACK / WHITE
IGNITION UNIT
BLUE
FUEL SHUT-OFF SOLENOID
FUEL LINE
HOUR METER
BLACK
(OPTIONAL)
BLUE
RED
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES)
CHARGING SYSTEM OUTPUT 9 AMP DC @ 3600 RPM
28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
(IF SO EQUIPPED)
REGULATOR
ALTERNATOR
ORANGE
LIGHT SW BLACK
BROWN
BLACK
IGNITION SWITCH POSITION
CIRCUIT
OFF RUN/OVERRIDE
M+G+A1 B+A1
RUN START
B+A1 B + S + A1
“MAKE”
L+A2 02834
NOTE HEADLIGHTS YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE NON-REMOVABLE REMOVABLE BATTERY, BUT HAVE THEIR CONNECTIONS CONNECTIONS OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE WIRING INSULATED CLIPS SPEED. AT IDLE THE LIGHTS NOTE: IF WIRING INSULATED CLIPS WILL DIM. AS THE ENGINE IS WERE REMOVED FOR SERVICING OF SPEEDED UP, THE LIGHTS UNIT, THEY SHOULD BE REPLACED WILL BECOME THEIR BRIGHTEST. TO PROPERLY SECURE YOUR WIRING.
3
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) ELECTRICAL 22
79
21
41
24 42 43
40 26
27
27
25
34
16 33 30
92
94
50 48
93
52 29
10 11
55
27
193389ROS
12 2
28
1 8
12
4
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) ELECTRICAL
KEY NO. 1 2 8 10 11 12 16 21 22 24 25 26 27 28 29 30 33 34 40 41 42 43 48 50 52 55 79 92 93 94
PART NO. 144927 74760412 7603J 145211 150109 145769 176138 175688 4152J 8860R 146148 175158 73510400 145491 192749 193350 140401 110712X 193389 17720408 131563 178861 140844 174653 141940 17490508 175242 193465 192540 191834
DESCRIPTION Battery Bolt Hex Hd 1/4-20 unc x 3/4 Tray Battery Bolt Battery Front 1/4-20 x 7.5 Holddown Battery Nut Push Nylon 1/4 Switch Interlock Harness Socket Light Bulb, Light # 1156 Cable Battery Cable Battery 6 Ga. Red w/16 wire Fuse Nut Keps Hex 1/4-20 unc Cable Ground 21" Blk 6 Ga. Switch Seat Switch Ign Key Ign Molded Generic Switch Light/Reset Harness Ign Bolt Fin Hex 1/4-20 unc x 1/2 Cover Terminal Red Solenoid Adaptor Ameter Switch PTO Protection Loop Screw Thdrol 5/16-18 x 1/2 Socket Asm Bulb Twistlock Harness Pigtail Reverse Switch Screw Plastite 10-14 x 2.0 Module Revers ROS
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
5
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) CHASSIS
17
29 278
10
217
161
10
278
30
28 90
278
159
31
9
209
54 58
209
155
213
54
214
158
278 11
209
20
64
59
209
209
209
209
144
26 209 142
60
1
26
154
143
209 144 26 60
142 2
278
26
145
37
13
37
209 14
74 38 206
209
38
chassis-stealth.stlt_27
6
14
209
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) CHASSIS
KEY NO.
PART NO.
DESCRIPTION
1 2 9 10 11 13 14 17 20 26 28 29 30 31 37 38 54 58 59 60 64 74 90 142 143 144 145 154 155 158 159 161 206 209 213 214 217 278
174619 176554 193635X428 72140608 167203 188702X010 17490608 175260X428 162026 73800600 175289X428 161840 192395X428 139976 17490508 175710 192512 175351 187495 72140606 174997 73680600 124346X 175702 186689 175582 156524 161897 161900 162037 191120X428 164655 170165 17000612 169848X428 169847X428 179132X428 191611
Chassis Drawbar Dash Bolt Carriage 3/8-16 x 1 Panel Dash Lh Panel Dash Rh Screw Thdrol 3/8-16 x 1/2 Hood Plate Battery Nut Lock Hex W/Ins 3/8-16 unc Grille Lens Bar Fender Footrest Bracket Fender Screw Thdrol 6/16-18 x 1/2 TYT Bracket Asm Pivot Mower Rear Screw WSHD Hex 10-32 x 5/8 Duct Air Bushing Bolt RDHD Sqnk 3/8-16 unc x 3/4 Dash Lower STLT Nut Crownlock 3/8-16 unc Nut Self Thd Wsh - HD 1/4 Zinc Plate Reinforcement STLT Bracket Swaybar Chassis Bracket Footrest Step-thru Rod Pivot Chassis/Hood Bracket Dash RH Bracket Dash LH Bracket Parking Brake Cupholder Bumper Hood Bolt Shoulder 5/16-18 Screw Hexwsh Thdr 3/8-16 x 3/4 Skirt Grille LH Skirt Grille RH Console Fuel Window Screw 10 x 3/4 Single Lead-Hex
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
7
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) DRIVE
57 120
23
89
254
63
66 59
69
161
197 169
159 158
56
61
9
162 198 83
81
112 21
65 17
41
14
150
64
168
163
202
50
48
38 10
82 165 156
27
166
35
32
49
39
8
151 51
47 62
30
120
34
36
52
52 16
36 35
37
32 95
53
28
30
26 16 29
16 77
25
22
19 24
27
199
200 263
26 26
263
71
15 77 96
1
74
55
84
75
78
73
16
76 drive-hydro.stlt_73
26
8
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) DRIVE
KEY NO.
PART NO.
1
------
8 9 10 14 15 16 17 19 21 22 23 24 25 26 27 28 29 30 32 34 35 36 37 38 39 41 47 48 49 50 51 52 53 55 56 57 59 61 62
192502 180505 76020416 10040400 74490544 73800500 126197X 73800600 106933 169498 190736 73350600 106888X 19131316 76020412 175765 71673 169592 74760512 175578 120183X 19211616 1572H 179114 72110622 175556 127783 154407 123205X 72110612 73680600 73680500 105710X 105709X 17060620 140294 169691 17120614 123533
DESCRIPTION
KEY NO.
Transaxle Hydro Gear 314-0510 (Order Parts From Transaxle Manufacturer) Rod Shift Clutch Ogura Pin Cotter 1/8 x 1 CAD Washer Lock Hvy Helical Bolt, Hex FLGHD 5/16-18 Gr. 5 Nut Lock Hex W/Ins 5/16-18 unc Washer Nut Lock Hex W/Wsh 3/8-16 unc Knob Rod, Brake Hydro Bracket Anti Rotation Nut Spring, Brake Rod Washer Pin Cotter 1/8 x 3/4 CAD. Rod, Parking Brake Cap, Parking Brake Bracket, Transaxle Bolt Hex Hd 5/16-18 unc x 3/4 Shaft, Foot Pedal Bearing, Nylon Washer Pin, Roll Pulley, Composite Bolt Rdhd 3/8-16 unc x 2-3/4 Gr. 5 Keeper, Belt Idler Pulley, Idler, V-Groove Bellcrank Clutch Grnd Drv STL Retainer, Belt Bolt Carr Sh 3/8-16 x 1-1/2 Gr. 5 Nut Crownlock 3/8-16 unc Nut Crownlock 5/16-18 unc Link, Clutch Spring, Return, Clutch Screw 3/8-16 x 1-1/4 V-Belt, Ground Drive Keeper, Center Span Screw 3/8-16 x .875 Cover, Pedal
63 174607 Pulley, Engine 64 173937 Bolt Hex 7/16-20 x 4 x Gr. 5-1.5 Thr 65 10040700 Washer 66 154778 Keeper Belt Engine 69 142432 Screw Hex Wsh Hi-Lo 1/4 x 1/2 unc 71 169183 Strap Torque Lh Hydro 73 169182 Strap Torque Rh Hydro 74 137057 Spacer, Axle 75 121749X Washer 25/32 x 1-1/4 x 16 Ga. 76 12000001 E-Ring 77 123583X Key, Square 78 121748X Washer 25/32 x 1-5/8 x 16 Ga. 81 165596 Shaft Asm. Cross Hydro 82 165711 Spring Torsion T/A 83 19171216 Washer 17/32 x 3/4 x 16 Ga. 84 169594 Link Transaxle 89 192387X428 Console, Shift 95 170201 Control Asm Bypass Hydro 96 4497H Retainer Spring 1" Zinc/Cad 112 19091210 Washer 9/32 x 3/4 x 10 Ga. 120 73900600 Nut Lock Flg 3/8-16 unc 150 175456 Spacer Retainer 151 19133210 Washer 13/32 x 2 x 10 Ga. 156 166002 Washer Srrted 5/16 ID x 1.125 158 165589 Bracket Shift Mount 159 183900 Hub Shift 161 72140406 Bolt Rdhd Sqnk 1/4-20 x 3/4 Gr. 5 162 73680400 Nut Crownlock 1/4-20 unc 163 74780416 Bolt Hex Fin 1/4-20 unc x 1 Gr. 5 165 165623 Bracket Pivot Lever 166 17490510 Screw 5/16-18 x 5/8 168 165492 Bolt Shoulder 5/16-18 x .561 169 165580 Plate Fastening Lt 197 169613 Nyliner Snap-In 5/8" ID 198 169593 Washer Nyl 7/8 ID x .105 199 169612 Bolt Shoulder 5/16-18 unc 200 72140508 Bolt Rdhd Sqnk 5/16-18 unc x 1 202 72110614 Bolt Carr Sh 3/8-16 x 1-3/4 Gr. 5 254 17000616 Screw 3/8-16 x 1 263 17000612 Thdrol Screw 3/8-16 x 3/4 NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
9
PART NO.
DESCRIPTION
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) STEERING ASSEMBLY
38 12 39
1
41 42 37
37 36
88
91 43
71
29
67
67
68
46
67
8
13
6 65
17
46
2
8 6
87 5
87
3
32 11
68 82
29
5
4
26
43
40 43 29 15
10
28
95 8
30
steering_stealth_prem_12
10
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) STEERING ASSEMBLY
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 8 10 11 12 13 15 17 26 28 29 30 32 36 37 38 39 40 41 42 43 46 65 67 71 68 82 87 88 91 95
186094X428 184706 169840 169839 6266H 121748X 12000029 175121 10040600 73940800 136518 145212 177883 126847X 19131416 17000612 76020412 192757 155105 152927 186095X428 19183812 73540600 186737 163888X428 121749X 121232X 160367 72110618 175146 169827 169835 173966 175118 175553 188967
Wheel Steering Axle Asm Cast Iron LT Spindle Asm LH Spindle Asm RH Bearing Race Thrust Harden Washer 25/32 x 1-5/8 x 16 Ga. Ring Klip #t5304-75 Link Drag Washer Lock Hvy Hlcl Spr 3/8 Nut Hex Jam Toplock 1/2-20 unf Spacer Brg Axle Front Nut Hex Flange Lock Shaft Asm Steering Bushing Link Drag Washer 13/32 x 7/8 x 16 Ga. Screw 3/8-16 x .75 Pin Cotter 1/8 x 3/4 Rod Tie Bushing Strg Screw Insert Cap Strg Wh Washer 9/16 ID x 2-3/8 OD x 12 Ga. Crownlock nut Adaptor Wheel Strg Boot Steering Dash Washer 25/32 x 1 1/4 x 16 Ga. Cap Spindle Fr Top Blk Spacer Brace Axle Bolt RDHD SQNK 3/8-16 x 2 1/4 Steering Asm Axle, Brace Bracket Susp Chassis Front Washer Flat .781 x 1-1/2 x .14 Bolt Shoulder 7/16-20 unc Clip Steering Washer Harden .739 x 1.637 x 060
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
11
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) SEAT ASSEMBLY 1 18
8 8
9 14
9
7
7
10
5 6 22 21
2 24 5 16
25
15 11 4 13 17
3
12
seat_lt.knob_2
KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12
PART NO. 188720 140551 71110616 19131610 145006 73800600 124181X 17000616 19131614 182493 166369 174648
DESCRIPTION Seat Bracket Pivot Seat 8 720 Bolt Fin Hex 3/8-16 unc x 1 Washer 13/32 x 1 x 10 Ga. Clip Push-In Nut Hex w/Ins. 3/8-16 unc Spring Seat Cprsn 2 250 Blk Zi Screw 3/8-16 x 1.5 Smgml Washer 13/32 x 1 x 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch
KEY NO.
PART NO.
DESCRIPTION
13 14 15 16 17 18 21 22 24 25
121248X 72050412 134300 121250X 123976X 124238X 171852 73800500 19171912 127018X
Bushing Snap Blk Nyl 50 Id Bolt Rdhd Sqnk 1/4-20 x 1-1/2 Spacer Split 28 x 96 Spring Cprsn Nut Lock 1/4 Lge Flg Gr. 5 Zinc Cap Spring Seat Bolt Shoulder 5/16-18 unc Nut Hex Lock W/Ins 5/16-18 Washer 17/32 x 1-3/16 x 12 Ga. Bolt Shoulder 5/16-18 x 62
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
12
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) ENGINE 2
3 72
1
62
81
13
4
78 38 14
32
78
31
33
37
112 41
33 45
29
23
OPTIONAL EQUIPMENT Spark Arrester KEY NO. 1 3 4 2 13 14 23 29 31 32 33 37 38 41 45
PART NO.
engine-bs.1cyl_53
DESCRIPTION
176636X428 Control, Throttle/Choke ------Engine Briggs Model 31P777 (Order Parts from Engine Mfg.) 137352 Muffler 191611 Screw 10 x 3/4 Single Lead Hex 165291 Muffler Gasket 148456 Tube Oil Drain 169837 Shield, Browning/Debris Guard 137180 Arrester, Spark 179022 Tank, Fuel 179124X428 Cap Gauge, Fuel 123487X Clamp, Hose Blk 8543R Line, Fuel 181654 Plug Drain Oil Easy 139277 Stem Tank Fuel 17000612 Screw Hex Wsh Thdrol 3/8-16 x 3/4
KEY NO.
PART NO.
DESCRIPTION
62 72 78 81 112
10010500 71070512 17060620 73510400 3645J
Washer Split Screw Hex Hd Cap 5/16-18 x 3/4 Screw 3/8-16 x 1-1/4 Nut Keps Hex 1/4-20 unc Bushing
NOTE:
All component dimensions given in U.S. inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton 1-800-233-3723 Kohler Co. 1-800-544-2444 Tecumseh Products 1-800-558-5402 Honda Engines 1-800-426-7701 Kawasaki 1-949-460-5688
13
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) MOWER DECK 68 40 36 40 143 144
159 46
45 150
40 145
44
184 59
56 55
132 91
148
182 54
146 33 32 31
94
183 95
30 34
132 21 21
1
2 21
116
21
113 111 21
23
2 117
25 26
2
119
118 130
16
92
15 14
131 129
3 4
5
24
20 18
28
27
29
92 149
61
18 13
21 6
11 19
21
10 9
112
2 8
42_D_elec-t-path_stlt_4
118 119 113
14
117 116
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) MOWER DECK
KEY NO.
PART NO.
1 2 3 4 5 6 8 9 10
165892X421 72140506 138017 165460 4939M 178024 850857 10030600 140296
11
138971
--
134149
--
139775
Blade Mulching 42” Premium (For better wear when mulching)
13 14 15 16 18 19 20 21 23 24 25 26 27 28 29 30 31 32 33 34 36 40 44 45 46 54
137645 128774 110485X 174493 72140505 132827 159770 73680500 177563 105304X 123713X 110452X 130968X428 19111016 131491 173984 187690 173436 178342 72110612 173438 73900600 140088 4497H 137729 178515
Shaft Assembly, Mandrel, Vented Housing, Mandrel, Vented Bearing, Ball, Mandrel Stripper, Mandrel Deck Bolt, Carriage 5/16-18 x 5/8 Bolt, Shoulder Baffle, Vortex Nut Bracket, Deflector Mower 42" Cap, Sleeve 80 x 112 Blk Mower Spring, Torsion, Deflector 2 52 Nut, Push Phos & Oil Shield, Deflector 42" Blk Washer 11/32 x 5/8 x 16 Ga. Rod, Hinge 42" 6 75 W/G Screw Thdrol Washer, Spacer Mower Vented Pulley, Mandrel Nut, Toplock Bolt Carr SH 3/8-16 x 1-1/2 Gr.5 Pulley, Idler, Flat Nut Lock 3/8-16 Guard, Mandrel, LH Retainer Screw, Thdrol 1/4-20 x 5/8 T Washer, Hardened
DESCRIPTION Mower Deck Assembly, 42" Bolt Bracket Asm Fr. Sway Bar 3/42 Bracket Asm Deck 42" Sway Bar Retainer Spring Bar Sway Deck Bolt 3/8-24 x 1.25 Gr. 8 patched Washer, Lock Washer, Hardened (The following Blades are available) Blade Mower 42” Hi-Lift (for bagging and discharging) Blade, Mulching 42” Std (for mulching mowers only)
KEY NO.
PART NO.
55 56 59 61 68 91 92 94 95 111 112 113 116 117 118 119 129 130 131 132 143 144 145 146 148 149 150 159 182 183 184 --
155046 122052X 141043 174882 174 883 180532 73800600 132264 180533 179292 179293 17000510 4898H 188606 73930600 19121414 19131312 74780616 72140608 17000612 157109 173441 173437 173443 169022 165898 19091210 72140614 179126 163552 19131410 130794
--
176207
DESCRIPTION Arm, Idler Spacer, Retainer Guard TUV Idler Spring Ext Elect. Clutch V-Belt, 42" Mower Bracket Roller Nose LH Nut Lock Hex w/Ins 3/8-16 unc Roller Nose Bracket Roller Nose RH Bracket Wheel Gauge LH Bracket Wheel Gauge RH Screw 5/16-18 Bolt, Shoulder Wheel, Gauge Nut Centerlock 3/8-16 Washer 3/8 x 7/8 x 14 Ga. Washer 13/32 x 13/16 x 12 Ga. Bolt Fin HEx 3/8-16 unc x 1 Gr. 5 Bolt RDHD SQNK 3/8-16 unc x 1 Screw Hexwsh Thdr 3/8-16 x 3/4 Bracket Arm Idler 42" Keeper Belt 42" Clutch Cable Pulley Idler Flat Bolt Carriage Idler Spring Return Idler Retainer Spring Yellow Washer 9/32 x 3/4 x 10 Ga. Bolt Rdhd Sqn 3/8-16 unc x 1-3/4 Rod Roller Nose Retainer Spring Washer 13/32 x 7/8 x 10 Ga. Mandrel Assembly (Includes Housing Shaft and Shaft Hardware Only - Pulley Not Included) Replacement Mower, Complete (Std. deck Order separately muklcher cover, and gauge wheel componants Key Nos. 101-106 and 116-119)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
15
TRACTOR - - MODEL NUMBER DB185H42YT (96012003000) MOWER LIFT 7 41
5
37 38 40 36
1
3
13 4
6
2
11
6
5 4
12 13 19 20
13 31 32 13
15
19
20
31 32
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 11 12 13 15 16 17
184432 159476 188822 12000002 19211621 120183X 175830 139865 139866 4939M 173288 73350800 175689
Plunger Asm. Shaft Asm Lift RH w/Inf Pin Groove 2" E Ring #5133-62 Washer 21/32 x 1 x 21 Ga. Bearing Nylon Blk 629 Id Grip Handle Link Lift LH Fixed Length Link Lift RH Fixed Length Retainer Spring Link Front Nut Jam Hex 1/2-13 unc Trunnion
20
17 18 20 16
15 lift-rh.1pc.stlt_9
KEY NO. 18 19 20 31 32 36 37 38 40 41
PART NO. 73800800 139868 163552 169865 73540600 155097 123935X 17060516 19112410 155098
DESCRIPTION Nut Lock W/Wsh 1/2-13 unc Arm Suspension Rear Retainer Spring Bearing Pvt Lift Nut Crownlock 3/8 - 24 Pointer Height Indicator Plug Hole Blk 1.485/1.515 Dia. Screw 5/16-18 x 1 Washer 11/32 x 1-1/2 10 Ga. Indicator Height STLT
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
16
