96041000301

Transcript

TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 SCHEMATIC 02928-194276_Regulated-Tex BATTERY SOLENOID STARTER M RED A RED FUSE AMMETER (OPTIONAL) BLACK ELECTRIC CLUTCH WHITE S WHITE M B BLACK WHITE A1 G L GRAY A2 RED CLUTCH/BRAKE (PEDAL UP) RED BLACK BLACK PTO SWITCH (DISENGAGED) REVERSE SWITCH (NOT IN REVERSE) BLACK BLACK 2 BLACK 3 BLACK BLACK BLACK BLACK 1 6 SEAT SWITCH (NOT OCCUPIED) GRAY BLACK /WHITE JUNCTION CONNECTOR SHORTING CONNECTOR CHASSIS HARNESS SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES) IGNITION UNIT (OPTIONAL) HOUR METER BLACK BLUE BLACK FUEL LINE 12V POWER OUTLET (IF SO EQUIPPED) BLUE CHARGING SYSTEM OUTPUT 15 AMP DC @ 36 RPM FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) REGULATOR ORANGE RED STATOR 28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED) BROWN BLACK LIGHT SWITCH HEADLIGHTS 3 6 2 1 6 3 5 5 2 4 4 1 IGNITION SWITCH POSITION CIRCUIT OFF RUN/OVERRIDE M+G+A1 B+A1 RUN START B+A1 B + S + A1 “MAKE” L+A2 02928 CHASSIS HARNESS CONNECTOR (MATING SIDE) DASH HARNESS CONNECTOR (MATING SIDE) 25 WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 ELECTRICAL 22 90 21 41 24 43 42 40 27 33 30 25 34 46 2 27 50 1 26 91 99 16 100 8 71 tter Ba 28 y_ 29 55 28 194276D 26 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 ELECTRICAL KEY NO. 1 2 8 16 21 22 24 25 26 27 28 29 30 33 34 40 41 42 43 46 50 55 59 71 90 91 99 100 PART NO. 532 14 49-27 874 76 04-12 532 18 64-91 532 17 61-38 532 18 37-59 532 00 41-52 532 40 02-53 532 19 88-93 532 17 51-58 873 51 04-00 532 14 54-91 532 40 15-45 532 19 33-50 532 14 04-01 532 11 07-12 532 40 11-04 817 72 04-08 532 13 15-63 532 19 25-07 532 19 81-38 532 17 46-51 817 49 05-12 532 40 03-03 532 19 42-76 532 18 04-49 532 19 02-70 817 67 04-12 819 09 14-16 DESCRIPTION Battery Bolt Hex Hd 1/4-20 unc x 3/4 Battery Box Switch Interlock Harness Socket Light Bulb, Light # 1156 Cable Battery Cable Starter Fuse Nut Keps Hex 1/4-20 unc Cable Ground 21" Blk 6 Ga. Switch Seat Switch Ignition Key Ignition Molded Generic Switch Light/Reset Harness Ignition Dash Screw Thd Cut 1/4-20 x 1/2 Cover Terminal Red Solenoid Gauge Hourmeter Switch PTO Screw Thdrol 5/16-18 x 3/4 Outlet 12-Volt Harness Ignition Cover Terminal Battery Strap Battery Screw Hexwsh Thdrol 1/4-20 x 3/4 Washer 9/32 x 7/8 x 16 Ga. NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 27 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 CHASSIS                                                                          CHASSIS TEX? GT HUSQ 28 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 CHASSIS KEY NO. PART NO. DESCRIPTION 5 14 15 18 25 34 36 37 52 58 68 99 130 137 150 152 161 162 165 175 176 177 178 180 181 182 183 532 40 18-23 532 40 18-24 532 19 89-07 532 40 48-21 532 19 89-06 532 19 61-25 817 06 05-12 532 40 18-25 873 68 05-00 532 19 43-14 817 49 05-08 532 40 66-42 532 19 16-11 532 40 47-42 532 19 85-12 532 19 95-35 532 40 18-26 532 14 24-32 532 19 68-26 532 19 63-04 532 40 07-76 532 19 52-27 532 19 97-82 532 40 15-59 532 40 30-25 532 19 47-87 874 78 05-20 Dash Hood Lens LH Grille Lens RH Plate Engine Screw 5/16-18 x 3/4 Fender Nut Lock 5/16-18 Bracket Fender Screw 5/16-18 x 1/2 Rod Bypass Asm. Screw 10 x 3/4 Single Lead Hex Bumper Hood Duct Heat Hood Shield Browning/Debris Console Fuel Window Screw Hex Wsh Hi-Lo 1/4 x 1/2 Bracket Support Tank Crossmember Screw 10-24 x 5/8 Rnd Qdrx Bushing Steering Cargo Asm. Net Chassis Bushing Mtg. Fender Crgo. Dash Lower Bolt 5/16-18 x 1-1/4 KEY NO. PART NO. DESCRIPTION 189 194 195 196 199 202 203 204 205 206 207 208 209 210 211 212 213 214 217 218 221 228 235 236 817 00 05-12 873 90 05-00 532 40 41-37 532 40 02-99 532 19 82-59 532 40 30-48 532 40 30-76 532 19 89-04 532 40 17-09 532 40 17-11 532 19 71-98 532 19 71-99 532 19 91-30 532 19 91-31 532 19 91-32 532 19 91-33 874 76 05-12 532 19 91-45 532 15 65-24 532 19 63-95 532 19 89-09 532 19 51-61 532 40 61-29 873 93 05-00 Screw 5/16-18 x 3/4 Nut Lock Hex Flange 5/16-18 Plug Hole Dash Lower 12V Console Asm. Deck Lift Plate Deck Lift Vent Side Hood RH Vent Side Hood LH Vent Asm Hood Top Skirt Hood Side RH Skirt Hood Side LH Bezel RH Bezel LH Insert Hex Top RH Insert Hex Top LH Insert Hex Bottom RH Insert Hex Bottom LH Bolt Hex Hd 5/16-18 unc x 3/4 Clip Retainer Rod Pivot Hood Stop Reflector LH Stud Fastner Spacer Fender Nut Lock 5/16-18 unc NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 29 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 DRIVE 74 56 220 221 70 213 74 206 125 207 26 209 92 171 197 196 125 221 184 42 125 35 80 64 160 167 203 160 170 188 185 52 51 186 189 214 153 208 49 187 159 161 50 211 29 51 190 15 215 159 211 166 51 116 116 17 2 205 37 162 162 183 169 2 169 222 163 52 33 210 148 15 37 205 1 33 183 drive-tex_9-husq-hydro 30 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 DRIVE KEY NO. PART NO. 1 ------ 2 15 17 26 29 33 35 37 42 49 50 51 52 56 64 70 74 80 92 116 125 143 159 160 161 162 163 166 167 169 532 12 35-83 819 13 13-16 532 19 72-96 532 19 96-79 532 19 94-67 812 00 00-01 532 19 95-91 532 12 17-49 532 12 48-72 872 11 06-14 532 19 43-27 873 90 06-00 532 19 43-26 532 14 02-18 532 19 78-65 532 40 05-30 532 14 24-32 532 40 05-07 874 76 05-20 873 90 05-00 817 00 05-12 817 49 05-08 876 02 04-12 532 16 94-84 532 19 54-03 532 19 57-85 532 19 90-00 532 19 72-90 532 19 62-11 874 49 05-60 DESCRIPTION Transaxle, Hydro HG0510 (Order Parts from Transaxle Manufacturer) Key 1/4 x 2.5 Washer 13/32 x 13/16 x 16 Ga. Spring, Brake Spring Return Cruise Rod, Brake Ring E Rod, Brake, Park Washer Cover, Foot Pedal Bolt Pulley Idler Flat Lock Nut 3/8-16 Idler V-Groove 910" Offset V-Belt, Drive Shaft Asm. Pedal Brake Control Control Asm. Screw 1/4 x 1/2 Bracket Strap Torque Bolt Fin Hex 5/16-18 unc x 1.25 Nut Lock Hex Flange 5/16-18 Screw 5/16-18 x 3/4 Screw Thdrol 5/16-18 x 1/2 Pin Cotter 1/8 x 3/4 Retainer Clip Spring, Return, Clutch Spacer Transaxle Rod Pedal Control Nut Push .625 Latch Brake Parking Bolt Hex Flghd 5/16-18 x 3.75 KEY NO. PART NO. DESCRIPTION 170 171 183 184 185 186 187 188 189 190 196 197 203 205 206 207 208 209 210 211 213 214 215 216 218 219 220 221 222 532 19 43-22 872 11 06-16 532 13 70-57 532 40 31-18 872 11 06-20 532 19 43-21 819 13 32-10 532 19 43-23 532 19 43-17 532 19 43-18 817 00 06-16 532 19 58-04 819 11 11-16 532 12 17-48 532 19 78-67 532 19 78-68 532 19 78-69 532 19 95-92 532 19 78-60 532 12 01-83 532 40 31-19 532 40 17-22 532 40 17-23 532 19 61-31 874 78 05-20 532 19 57-80 532 19 89-08 532 40 31-87 819 21 20-10 Keeper Belt Centerspan Bolt Spacer Split Handle Parking Brake Bolt Rdhd Sqnk 3/8-16 x 2-1/2 Spacer Retainer Washer Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Screw 3/8-16 x 1 Bracket Clutch Anti-Rotation Washer 11/32 x 11/16 x 16 Ga. Washer Bracket Mount Latch Cruise Latch Control Cruise Gear Sector Control Cruise Rod Control Cruise Rocker Asm. Pedal Control Bearing Nylon Knob Control Cruise Pedal Forward Pedal Reverse Bracket Pulley Idler Bolt Fin Hex 5/16-18 unc x 1-1/4 Spacer Fender Reflector RH Retainer Spring Clip Handle Washer 21/32 x 1-1/4 x 10 Ga. NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 31 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 STEERING ASSEMBLY 26 45 51 1 21 63 19 16 60 57 63 9 61 8 7 66 67 2 59 98 7 6 4 35 58 64 67 28 13 15 22 6 14 5 69 68 62 13 14 15 53 8 70 steering-tex_4-husq 13 KEY NO. PART NO. DESCRIPTION 1 2 4 5 6 7 8 9 13 14 15 16 19 21 22 26 28 35 45 532 19 36-51 532 19 59-68 532 19 47-43 532 19 47-44 532 12 49-31 532 12 17-48 812 00 00-29 532 12 12-32 532 12 17-49 810 04 06-00 873 54 06-00 532 19 47-46 532 19 47-29 532 18 67-37 532 19 48-45 532 19 36-52 817 00 06-12 532 19 47-32 819 18 38-12 Wheel, Steering Axle Asm., Front Spindle Asm., LH Spindle Asm., RH Bearing, Race Thrust Harden Washer 25/32 x 1-5/8 x 16 Ga. Ring, Klip #T5304-75 Cap, Spindle Washer 25/32 x 1-1/4 x 16 Ga. Washer, Lock Hvy Hlcl Spr 3/8 Nut, Crown Lock 3/8-24 unf Shaft Steering Plate Steering Adapter, Wheel Steering Bushing, Strg. Blk Insert, Wheel Steering Screw 3/8-16 x 3/4 Gear, Sector Plate Washer 9/16 x 2-3/8 x 12 Ga. KEY NO. PART NO. 51 53 873 94 08-00 Nut Hex Jam Toplock 1/2-20 unf 532 18 89-67 Washer Hardened .793 x 1.637 x .060 532 19 72-46 Bracket Upstop 532 19 47-47 Bolt Shoulder Sector Pivot CFM 532 19 47-48 Washer Thrust Sector Steering 873 97 10-00 Nut Flange Lock 5/8-11 532 19 47-40 Draglink LH 532 19 47-41 Draglink, RH 817 00 05-12 Screw 5/16-18 x 3/4 532 19 98-49 Retainer Clip Spring Steering 871 02 07-48 Bolt Hex Fghd 7/16-14 x 3 Serr 532 19 47-37 Bushing PM Front Axle 873 90 07-00 Nut Lock Flange 7/16-14 Gr. 5 532 19 91-62 Washer 1.5 x .505 x .118 532 19 61-97 Bracket Deck Susp. Front 57 58 59 60 61 62 63 64 66 67 68 69 70 DESCRIPTION NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 32 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 ENGINE 1 21 20 87 81 82 22 18 84 62 45 15 69 37 12 28 37 11 70 31 71 95 41 42 85 2 9 29 90 SPARK ARRESTER KIT engine-tex_15-kohl KEY NO. 1 2 9 11 12 15 18 20 21 22 28 29 31 37 41 42 45 62 69 70 PART NO. -----532 14 97-23 532 19 43-19 532 18 05-05 532 19 43-38 532 19 34-99 532 19 42-67 532 18 29-37 532 19 16-11 532 19 15-96 532 14 21-58 532 13 71-80 532 14 50-06 532 12 34-87 532 12 61-97 810 04 07-00 873 51 04-00 532 14 66-29 ---------532 14 66-99 KEY NO. 71 81 82 84 85 87 90 95 -- DESCRIPTION Engine Kohl Model No. SV710 Muffler Keeper Belt Engine Clutch Electric Pulley Engine Tank Fuel 4.0 Cap Asm Control Throttle Screw 10 x 3/4 Single Lead Hex Control Choke Fuel Line Spark Arrester Kit Clip Push-In Clamp Hose Washer 1-1/2 OD x 15/32 ID x .250 Washer Lock 7/16 Nut Keps Hex 1/4-20 unc Shield Heat Muffler Gasket (Order part from Eng. Mfg.) Tube Exhaust LH PART NO. 532 14 67-00 532 14 84-56 532 18 16-54 817 06 06-20 532 17 39-37 532 19 82-39 817 00 06-16 532 19 23-34 532 18 74-95 DESCRIPTION Tube Exhaust RH Tube Drain Oil Easy Plug Drain Oil Easy Screw 3/8-16 x 1-1/4 Bolt Hex 7/16-20 x 4 x Gr. 5-1.5 Bolt 5/16-18 unc x 1 w/Sems Screw 3/8-16 x 1 Screw Socket Head 5/16-18 x .75 Bushing NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton 1-800-233-3723 Kohler Co. 1-800-544-2444 Tecumseh Products 1-800-558-5402 Honda Engines 1-800-426-7701 Kawasaki 1-949-460-5688 33 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 SEAT ASSEMBLY 1 8 8 7 7 41 40 10 21 6 37 5 44 37 2 43 21 3 seat-tex_5-husq KEY NO. PART NO. DESCRIPTION 1 2 3 5 6 7 8 10 21 532 19 75-26 532 18 01-66 532 14 06-75 532 14 50-06 873 80 06-00 532 12 41-81 532 17 18-77 532 19 69-77 532 17 18-52 Seat Bracket Pivot Fender Strap, Asm Fender Clip, Push In, Hinged Nut, Lock W/Ins. 3/8-16 unc Spring, Seat Cprsn Bolt 5/16-18 uncx 3/4 w/Sems Pan, Seat Bolt, Shoulder 5/16-18 KEY NO. PART NO. DESCRIPTION 37 40 41 43 44 873 80 05-00 532 19 76-61 532 19 82-00 874 76 06-12 819 13 38-12 Nut, Lock 5/16-18 unc Handle Slide Seat Spring Latch Seat Bolt 3/8-16 x 3/4 Washer 13/32 x 2-3/8 x 12 Ga. NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 34 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 DECALS 16 13 2 16 1 14 14 3 12 8 9 11 11 7 5 6 4 10 KEY NO. 1 2 3 4 5 6 7 8 9 10 PART NO. 532 40 03-89 532 40 21-28 532 19 63-57 532 19 68-41 532 14 08-37 532 17 83-02 532 16 88-69 532 16 03-96 532 14 50-05 532 15 97-37 DESCRIPTION Decal, Warning Syms. CE Decal, Hood Insert Decal, Warning Deflect Cutfinger Decal, Warning Eng. Syms. Decal, Saddle Brake Parking Decal, Oper Cruise Sym. Decal, Tick Mark Decal, Mower Sch. Decal, Battery Dnge/Poison Decal, Brake/Clutch Sym WHEELS AND TIRES 1 2 11 3 4 7 10 5 6 9 8 KEY NO. 11 12 13 14 16 ------ PART NO. 532 15 97-36 532 18 21-66 532 40 44-84 532 40 55-20 532 40 33-78 532 16 25-98 532 16 69-60 532 40 17-71 532 40 37-73 532 41 01-91 DESCRIPTION Decal, Chassis Hot Muffler Decal, Cutfinger CE Decal, Steering Whl Decal, Panel Side Decal, Hood Logo Decal, Drawbar Load Limit Decal, Bypass Pad, Footrest, LH Pad, Footrest, RH Manual, Owner's (Eng) KEY NO. 1 2 3 4 5 6 7 8 9 10 11 -- PART NO. 532 05 91-92 532 06 51-39 532 13 83-36 532 00 81-34 532 10 62-22 532 00 02-78 532 00 90-40 532 17 50-39 532 12 20-82 532 00 71-54 532 13 83-37 532 14 43-34 DESCRIPTION Cap, Valve, Tire Stem, Valve Rim Assembly, Front Tube, Front (Service Item Only) Tire, Front Fitting, Grease (Front Wheel Only) Bearing, Flange (Front Wheel Only) Cap, Axle (Front Wheel Only) Tire, Rear Tube, Rear (Service Item Only) Rim Assembly, Rear Sealant, Tire (10 oz. Tube) NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm wheel_art_1-vgt 35 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 MOWER DECK 40 145 59 57 55 68 56 34 190 33 40 116 117 32 36 31 30 118 119 1 21 21 118 119 117 188 69 189 19 21 116 62 6 23 21 189 188 24 6 19 25 16 26 20 15 29 27 115 14 115 13 11 8 116 113 111 21 42_D_elec-Tex_5 2 117 21 119 118 112 2 118 119 113 36 117 116 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 MOWER DECK KEY NO. PART NO. 1 2 6 8 11 532 40 29-99 872 14 05-06 532 19 51-86 532 19 30-03 532 13 89-71 13 14 15 16 19 20 21 23 24 25 26 27 28 29 30 31 32 33 34 36 40 45 55 532 19 28-72 532 18 72-81 532 11 04-85 532 17 44-93 532 19 65-39 532 15 97-70 873 68 05-00 532 19 25-57 532 10 53-04 532 19 70-26 532 11 04-52 532 40 30-04 819 11 10-16 532 13 14-91 532 17 39-84 532 18 76-90 532 17 34-36 532 40 02-34 872 11 06-12 532 19 61-06 873 90 06-00 532 17 79-68 532 19 72-49 DESCRIPTION Mower Deck Assembly, 42" Bolt Rdhd Sqnk 5/16-18 unc x 3/4 Arm Susp. Rear Bolt/Washer Asm 7/16-20 unf Blade Mower 42” Hi-Lift (for bagging and discharging) Shaft Assembly, Mandrel Housing, Mandrel Bearing, Ball, Mandrel Stripper, Mandrel Deck Bolt, Shoulder Baffle, Vortex Nut Bracket, Deflector Mower 42" Cap, Sleeve 80 x 112 Blk Mower Spring, Torsion, Deflector Nut, Push Phos & Oil Shield, Deflector 42" Blk Washer 11/32 x 5/8 x 16 Ga. Rod, Hinge 42" 6 75 W/G Screw Thdrol Washer, Spacer Mower Vented Pulley, Mandrel Nut, Toplock Bolt Carr SH 3/8-16 x 1-1/2 Gr.5 Pulley, Idler, Flat Nut Lock 3/8-16 Pulley Idler Glat Arm, Idler KEY NO. PART NO. 56 57 59 61 62 68 69 111 112 113 115 116 117 118 119 145 188 189 190 -- 532 19 90-92 817 00 06-16 532 14 10-43 532 17 48-82 872 11 06-16 532 14 49-59 872 14 05-05 532 17 92-92 532 17 92-93 817 00 05-10 872 11 05-05 532 19 34-06 532 17 48-73 873 90 06-00 819 13 20-12 532 17 34-37 532 19 51-61 873 90 05-00 532 19 72-51 532 19 28-70 -- DESCRIPTION Spacer, Retainer Screw 3/8-16 x 1 Guard TUV Idler Spring Ext Elect. Clutch Bolt Rdhd Sqnk 3/8-16 unc x 2 V-Belt, 42" Mower Bolt, Carriage 5/16-18 x 5/8 Bracket Wh Gauge RH Bracket Wh Gauge LH Screw 5/16-18 Nut Crownlock Bolt, Shoulder Wheel, Gauge Nut Centerlock 3/8-16 Washer 13/32 x 1-1/4 x 12 Ga. Pulley Idler Flat Stud Fastner W/D Anti-Rotation Nut Lock Hex Flange 5/16-18 Spring Mower Drive Mandrel Assembly (Includes Housing Shaft and Shaft Hardware Only - Pulley Not Included) 532 40 12-28 Replacement Mower, Complete (Std. deck Order separately gauge wheel componants Key Nos. 116119) NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 37 TRACTOR - MODEL NO. YTH2042XP(96041000301), PRODUCT NO. 960 41 00-03 MOWER LIFT 7 87 87 90 98 89 3 10 88 97 2 97 91 lift-tex_4 KEY NO. PART NO. DESCRIPTION 2 3 7 10 87 88 89 532 19 52-23 532 19 52-30 532 19 64-92 532 19 63-14 532 19 42-09 532 19 53-04 819 19 19-12 Shaft Asm., Lift Lever Asm., Lift Rh Grip, Lever Spring Torsion Pin Cotter 7/16 Bow Tie Lock Spring Lift Assist Washer Clear Zinc KEY NO. PART NO. DESCRIPTION 90 91 97 98 532 19 42-08 532 19 51-81 817 06 06-12 532 19 52-70 Pin Cotter 5/16 Bow Tie Lock Link Lift Susp Mower Rear Screw 3/8-16 x .75 Smgml Tap/R.Z Link Lift Susp. Front Mower NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 38