Transcript
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 DECALS
2
12
7
6
15
8
8
9
14
1
5 4
11
11
3
10
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10
408948 426688 408820 170563 408949 411658 423398 408794 172740 160396
Decal, Fenser SD LH Decal, Replacement Decal, Engine HP Decal, Warning Decal, Fender SD RH Decal, Fender Warning (E&F) Decal, Ins Str Wh Decal, Side Panel Decal, Fender Decal, V-Belt Sch.
WHEELS & TIRES 1 2
5,8 4,10
7 3,9 6
11
wheel_1
2
KEY NO.
PART NO.
DESCRIPTION
11 12 14 15 ------
402436 186163 186164 145005 404102 193226X428 193227X428 426557 426558
Decal, Dash Lower Decal, Hood RH Decal, Hood LH Decal, Caution, Battery Decal, Spark Arrester Pad Footrest LH Pad Footrest RH Manual, Operator's, English & French Manual, Parts, English & French
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 --
59192 65139 106222X 59904 106732X421 278H 9040H 106108X421 420531 7152J 104757X421 144334
Cap, Tire Valve Stem, Valve Tire, Front Tube, Front (Service item only) Rim Assembly, 6" Front Fitting, Grease (Front wheel only) Bearing, Flange (Front wheel only) Rim Assembly, 8" Rear Tire, Rear Tube, Rear (Service item only) Cap, Hub Axle Sealant, Tire (10 oz. Tube)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 SCHEMATIC SCH11
BATTERY RED
SOLENOID
M
FUSE
AMMETER (OPTIONAL)
BLACK
WHITE
S B G
STARTER
RED
A
WHITE
M A1
L
A2
ATTACHMENT CLUTCH (CLUTCH OFF) BLACK
CLUTCH/BRAKE (PEDAL UP)
GRAY
REVERSE SWITCH (NOT IN REVERSE)
BLACK BLACK
BLACK
2
BLACK
3
BLACK BLACK
SEAT SWITCH (NOT OCCUPIED)
BLACK BLACK
1 6
GRAY
SHORTING CONNECTOR
CHASSIS HARNESS
IGNITION UNIT
(OPTIONAL)
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES)
HOUR METER
BLUE
BLACK
NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST.
BLACK /WHITE
JUNCTION CONNECTOR
BLACK
FUEL LINE
12V POWER OUTLET (OPTIONAL)
BLUE
FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED)
CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM
28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
RED
LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 RPM DIODE
ALTERNATOR
ORANGE
LIGHT SWITCH
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF) BROWN
BLACK
HEADLIGHTS
IGNITION SWITCH POSITION
CIRCUIT
OFF RUN/OVERRIDE
M+G+A1 B+A1
RUN START
B+A1 B + S + A1
“MAKE”
L+A2
3
6
6
3
2
5
5
2
1
4
4
1
CHASSIS HARNESS CONNECTOR (MATING SIDE)
DASH HARNESS CONNECTOR (MATING SIDE)
3
WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.
NON-REMOVABLE CONNECTIONS
REMOVABLE CONNECTIONS
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 ELECTRICAL T02K 22
With 12V Outlet Option
33 30
79
103
21 87
59
34
With Service Minder Option
27 43 42
46
41
40
26
25
16
71
90
2
94 29
28
55
92 93
4
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 ELECTRICAL
KEY NO.
PART NO.
DESCRIPTION
1 2 8 16 21 22 25 26 27 28 29 30 33 34 40 41 42 43 55 71 79 87 90 92 93 94
163465 74760412 193228 176138 183759 4152J 421894 175158 73510400 198885 192749 193350 411935 110712X 401098 17720408 131563 192507 17060512 400449 175242 197802 400725 196615 192540 191834
Battery Bolt Hex Hd 1/4-20 unc x 3/4 Box Battery Switch Interlock Harness Asm Light w/4152j Bulb Light #1156 Cable Starter Fuse 20 AMP Nut Keps Hex 1/4-20 unc Cable Ground 22" Black Switch Seat Switch Ign Key/Chain Switch Light/Reset Harness Ign Dash Bolt Blk Fin Hex 1/4-20 x 1/2 Cover Terminal Red Solenoid Screw 5/16-18 x 3/4 Harness IGN Chassis Socket Asm. Bulb Twistlock Switch Interlock Clutch Cable Cover Terminal Battery Harness Pigtail Screw Plastite 10-14 x 2.0 Module Reverse ROS
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
5
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 CHASSIS
15 208
25
18
207
14
186
137 5 176
137
151
176 176 177 175
36 196
130
182
176
194
37
181
150
159
194
180 236
235
235
152
236 287
217
228
181
138
194
159
162 189
68
159
228
58
183
2
189
159
189 159
159 Chassis-tex_ELITE-SV PRO_11_r3
6
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 CHASSIS
KEY NO.
PART NO.
DESCRIPTION
2 5 14 15 18 25 36 37 58 68 130 137 138 150 151 152 159 162 175 176 177 180 181 182 183 186 189 194 196 207 208 217 228 235 236 287
412282 197783X428 183393X428 183834X599 183395X428 183835X599 17060512 414872X428 412280 17490508 416358 184921 193224X428 184322 407807 194329 17000612 142432 193243 400776 195228 194260 193102X428 193057 74780520 183829X428 17000512 73900500 414581 183833 183832 409167 195161 406129 73930500 17600406
Drawbar Lower Dash Hood Lens Grille LH Grille Lens Grille RH Screw 5/16-18 x 3/4 Fender Drawbar Upper Screw Thdrol 5/16-18 x 1/2 Screw #10 x 0.750 Bumper Hood Cupholder Duct Heat Hood Bracket Pivot Shield Browning/Debris Screw Hexwsh Thdrol 3/8-16 x 3/4 Screw Hex Wsh Hi-Lo 1/4 x 1/2 Crossmember Screw 10-24 x 5/8 Wshd Qdrx Bushing Steering Chassis Bushing Mtg. Fender Crgo. Dash Lower Bolt Fin Hex 5/16-18 x 1-1/4 Insert Grille Screw 5/16-18 x 3/4 Nut Lock Hex Flange 5/16-18 Console Asm. Deck Lift Bezel Grille RH Bezel Grille LH Rod Pivot Hood Stud Fastener Spacer Fender Nut Center Lock 5/16-18 Screw 1/4-20 x 3/8
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
7
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 DRIVE
70 185 56
74
221
184
35
172
125
160
172
42 125
167
160
186 189
49
203
187
188
64
50
190
51
161 139
155
202
52
140
165
61 141 158
116
2
157
51 166
192 23 176
134
174 233 232
192 193
166 17
15
26 2
183 37 33
drive-tex_peerless_fender_28
73
29
175 22
1
125
178
116
73
195
205
8
159
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 DRIVE
KEY NO.
PART NO.
DESCRIPTION
1 2 15 17 22 23 26 29 33 35 37 42 49 50 51 52 56 61 64 70 73 74 116 125 134 139 140 141 155 157 158 159
-----123583X 19131316 197297 197660 171674 197455 197267 12000001 197722 121749X 8883R 72110614 194327 73900600 194326 194346 123666X 196200 193225X428 74490544 142432 73900500 17000512 197857 74550412 10040400 19091210 12000028 105701X 194352 76020412
Transaxle, Peerless 206-565 Key Square Washer 13/32 x 13/16 x 16 Ga. Spring, Brake Rod Shift Knob Spring Brake RTN Rod, Brake Ring E Rod, Brake, Park Washer 25/32 x 1-1/4 x 16 Ga. Cover, Foot Pedal Bolt Pulley Idler Flat Lock Nut 3/8-16 Idler V-Groove V-Belt, Drive Pulley Transaxle Shaft Asm. Pedal Brake Control Console Bolt 5/16-18 Gr. 5 Screw 1/4 x 1/2 Nut Lock Hex Flange 5/16-18 Screw 5/16-18 x 3/4 Arm Shift Bolt 1/4-20 unf Gr. 8 w/Patch Washer Lock Hvy Helical 1/4 Washer 9/32 x 3/4 x 10 Ga. Ring Retainer Washer Plate Shf Keeper T/A Pin Cotter 1/8 x 3/4
KEY NO.
PART NO.
DESCRIPTION
160 161 165 166 167 172 174 175 176 178 183 184 185 186 187 188 189 190 192 193 195 202 203 205 221 232 233
169484 105709X 196212 197290 405257 197657 197289 197858 196214 197456 137057 198403X505 72110622 194321 19133210 194323 194317 194318 150360 17060512 197332 197859 19111116 121748X 403187 74780716 405296
Retainer Clip Spring, Return, Clutch Busing Shaft Brake Hand Control Nut Push .625 Latch Brake Parking Strap Torque LH Nut Push Shaft Asm Shift Arm Clevis Rod Shift Spring Shift Spacer, Axle Handle Parking Brake Bolt Spacer Retainer Washer Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Nut Lock Center 1/4-28 Screw 5/16-18 x 3/4 Bracket Brake Rod Link Shift Washer 11/32 x 11/16 x 16 Ga. Washer 25/32 x 1-5/8 x 16 Ga. Retainer Spring Clip Handle Bolt 7/16-14 x 1 Gr. 5 Washer Serrated
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
9
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 STEERING
26
72 33 45 1
54 20 21
63
71
19
60
16
9 57
63
61
8
7
74 57
2
55
67 78
59
4
58
13
54
98 7
74
6 35 64
66
65
74
67
28
6
14
5
15
22
55 74
62 50
13 14 15
69 68
53 8
65 50 13 70
steering-tex_STDHRS_7
10
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 STEERING
KEY NO.
PART NO.
DESCRIPTION
1 2 4 5 6 7 8 9 13 14 15 16 19 20 21 22 26 28 33 35 45 50 53
414803X428 418168 403087 403088 6266H 121748X 12000029 121232X 121749X 10040600 73540600 408220 194729 198375X428 186737 194845 414854X428 17000612 10040500 194732 19113812 73900600 188967
Wheel, Steering Axle Asm., Front Spindle Asm., LH Spindle Asm., RH Washer Thrust 0.75 x 1.23 Washer 25/32 x 1-5/8 x 16 Ga. Ring, Clip #T5304-75 Cap, Spindle Washer 25/32 x 1-1/4 x 16 Ga. Washer Lock 3/8 Nut, Crown Lock 3/8-24 unf Shaft Steering Plate Steering Boot, Steering Adapter, Wheel Steering Bushing, Strg. Blk Insert, Wheel Steering Screw 3/8-16 x 3/4 Washer Lock 5/16 Gear, Sector Plate Washer 11/32 x 2-3/8 x 12 Ga. Nut Lock Flg 3/8-16 unc Washer Hardened .793 x 1.637 x .060
KEY NO.
PART NO.
DESCRIPTION
54 55 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 74 78
74760636 414736 407465 194747 194748 73971000 194740 194741 17000512 199849 194734 71020748 194737 73900700 199162 196197 196075 74780572 3366R 57079
Bolt Hex HS 3/8-16 unc x 2-1/4 Spacer Brace Axle Bracket Upstop Bolt Shoulder Sector Pivot CFM Washer Thrust Sector Steering Nut Flange Lock 5/8-11 Draglink, LH Draglink, RH Screw 5/16-18 x 3/4 Retainer Clip Spring Steering Brace Axle Front Bolt Hex Fghd 7/16-14 x 3 Serr Bushing PM Front Axle Nut Lock Flange 7/16-14 Gr. 5 Washer 1.5 x .505 x .118 Bracket Deck Susp. Front Shaft Ext. Steering Bolt 5/16-18 x 4.5 Gr. 5 Bearing Col. Strg. Washer Thrust
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
11
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 ENGINE
1
21
20
45
79 84 97
18
82 81
96
15
37 69 28
12
37
114
28
42 85
90
9
109 111
29
OPTIONAL EQUIPMENT Spark Arrester engine-tex_BS_12
12
2
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 ENGINE
KEY NO.
PART NO.
DESCRIPTION
1 2 9 12 15 18 20 21 28 29 37 42 45 69 79 81 82 84 85 90 96 97 109 111 114
-----137352 194319 401985 420721 414113 176636X421 416358 401137 137180 123487X 10040700 73510400 165291 192334 148456 181654 17060620 173937 17000616 19091416 17670412 414114 414119 414116
Engine B&S Model No. 31N707 Muffler Keeper Belt Engine Pulley Engine Tank Fuel 1.50 Cap Asm Control Throttle/Choke Screw #10 x 0.750 Fuel Line Spark Arrester Kit Clamp Hose Washer Lock 7/16 Nut Keps Hex 1/4-20 unc Gasket Screw Socket Hd 5/16-18 x .75 Tube Drain Oil Easy Plug Drain Oil Screw 3/8-16 x 1-1/4 Bolt Hex 7/16-20 x 4 x Gr. 5-1.5 Screw 3/8-16 x 1.0 Washer 9/32 x 7/8 x 16 Ga. Screw 1/4-20 x 3/4 Canister Carbon Filter Asm. Purge Line Cradle Canister Carbon
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton 1-800-233-3723 Engine Power Rating Information The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J11940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J1995 (Revision 2002-5). Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual “on-site” or net horsepower). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine.
13
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 MOWER DECK
67
195 40
57
122
42
145 59
43 30
60
56
57
55
56 64 113
195
63 147
40
113 36
47 192
46
123
68
30 3833
34
32 31
208 144
30 21 23
21
24 25
69
26
21
189
27
29 113
62 189
188
6
15
19
14
20 69
13
69
11 8
14
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 MOWER DECK
KEY NO.
PART NO.
1 6 7 8 --
199911 195186 416358 193003 139775
11 -13 14 15 19 20 21 23 24 25 26 27 29 30 31 32 33 34 36 37 38 40 42 43 46
DESCRIPTION
Mower Housing Arm Suspension Screw #10 x 0.750 BOS Thread Bolt/Washer Asm 7/16-20 unf Blade, 42" Mulching Premium (For better wear when mulching) 138971 Blade, 42" Hi-Lift (For bagging or discharge) 134149 Blade, 42" Mulching Std (For mulching mowers only) 192872 Shaft Assembly, Mandrel 187281 Housing, Mandrel 110485X Bearing, Ball, Mandrel 196539 Bolt, Shoulder 159770 Baffle, Vortex 73680500 Nut, Crownlock 5/16-18 unc 192557 Bracket, Deflector 105304X Cap, Sleeve 197026 Spring, Torsion, Deflector 110452X Nut, Push 193108X428 Shield, Deflector 131491 Rod, Hinge 173984 Screw Thdrol Rolling Wsh Hd 187690 Washer, Spacer 197473 Pulley, Mandrel 400234 Nut, Toplock, Flanged 72110612 Bolt Carr Sh. 3/8-16 x 1-1/2 Gr. 5 197379 Pulley, Idler 4.50 RAW 19131316 Washer 13/32 x 13/16 x 16 Ga. 199189 Keeper Belt LH Mandrel 73900600 Nut, Lock Flg. 3/8-16 unc 197256 Spring Torsion Retainer 198410 Spring Torsion Brake 137729 Screw Thd Roll 1/4-20 x 5/8
KEY NO.
PART NO.
47 55 56 57 59 60 62 63 64 67 68 69 70 113 122 123 144 145 147 152 188 189 192 195 208 --
197250 197249 199092 17000616 141043 197261 72110616 199477 199790 198398X421 197253 72140505 198332 17000510 197258 197259 199204 193197 401971 408714 195161 73900500 197260 17000612 17670608 192870
--
415241
DESCRIPTION Bracket Clutch Cable Arm, Idler Spacer, Retainer Screw Hexwsh Thd 3/8-16 x 1 Guard, Tuv Idler (94) Arm Brake Mower Bolt Rdhd Sqnk 3/8-16 unc x 2 Arm Brake Mower Linkage Brake Handle, Clutch Cable V-Belt Bolt Rdhd Sqnk 5/16-18 x 5/8 Clutch Asm. Manual Screw 5/16-18 Keeper Belt Eng. LH Keeper Belt Eng. RH Keeper Belt Pulley Idler Primary Spring Return Cable Clutch Manual w/Spr. Stud Fastener Nut Lock Hex Flange Bracket Brake Stand LH Screw Hexwsh Thdr 3/8-16 x 3/4 Screw THDROL 3/8-16 x 1/2 Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/washer and blade bolt/washers not included) Replacement Mower, Complete
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
15
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 MOWER LIFT
87
7
90
98
113
10 3 97
100 2
88
97
91
87
91
89
87
lift-tex_17
KEY NO.
PART NO.
DESCRIPTION
2 3 7 10 87 88 89 90
195223 195231 196492X421 196314 194209 410710 19191912 194208
Shaft Asm., Lift Lever Asm., Lift RH Grip, Lever Spring Torsion Pin Cotter 7/16 Bow Tie Lock Spring Lift Assist Washer Clear Zinc Pin Cotter 5/16 Bow Tie Lock
KEY NO.
PART NO.
DESCRIPTION
91 97 98 100 113
195181 17000612 195270 73930600 19171912
Link Lift Susp Mower Rear Screw 3/8-16 x .75 Link Lift Susp. Front Mower Nut Lock 3/8-16 unc Washer 17/32 x 1-3/16 x 12 Ga.
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
16
REPAIR PARTS
TRACTOR - MODEL NUMBER PB18542LT (96042008900), PRODUCT NO. 960 42 00-89 SEAT
1
8 8 7
8 7 8
10
14
42 19
16
6
21
37 5
15
6
37
12
21 13
2
17 3 seat-tex_knob_1 KEY NO.
PART NO.
DESCRIPTION
1 2 3 5 6 7 8 10 12 13
197514 180166 140675 145006 73800600 124181X 171877 199180 199370 121248X
Seat Bracket Pivot Fender Strap, Asm Fender Clip Push-In Hinged Nut, Lock w/Ins. 3/8-16 unc Spring, Seat Cprsn Bolt 5/16-18 unc x 3/4 w/Sems Pan, Seat Bracket Seat Bushing Snap
KEY NO.
PART NO.
DESCRIPTION
14 15 16 17 19 21 37 42
72050412 134300 123740X 123976X 199372 171852 73800500 199371
Bolt RDHD SHT NK 1/4-20 x 1-1/2 Spacer Split 28 x .96 Spring CRPSN Plate SW 1.310 Nut Lock 1/4 Knob Seat Bolt, Shoulder 5/16-18 Nut, Lock 5/16-18 unc Washer Cup
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
17
