Transcript
TRACTOR - - MODEL NUMBER CO185H42STA SCHEMATIC
BLACK
RED
BATTERY
SOLENOID RED
RED
A AMMETER (OPTIONAL)
STARTER
WHITE
C
WHITE
M
RED
FUSE
BLACK
G
RED WHITE
S
BLACK
M
G A2
A1
RED
IGNITION SWITCH
BLACK
ELECTRIC CLUTCH
H
B
A
E
CLUTCH / BRAKE (PEDAL UP) RED
DIODE SEAT SWITCH (NOT OCCUPIED)
D
ORANGE
BROWN
BLACK
L
F
BLACK
B
PTO (DISENGAGED)
BLACK
GROUNDING CONNECTOR HOUR METER
BLUE
BLACK
(OPTIONAL)
FUEL LINE
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES)
RED
IGNITION UNIT CHARGING SYSTEM OUTPUT 9 AMP DC @ 3600 RPM
FUEL SHUT-OFF SOLENOID
28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
REGULATOR
RED
ALTERNATOR
BROWN
REMOVABLE CONNECTIONS
BLACK
PTO SWITCH POSITION
CIRCUIT
OFF ON
C + G, B + H C + F, B + E, A + D
HEADLIGHTS
NON-REMOVABLE CONNECTIONS IGNITION SWITCH POSITION
CIRCUIT
OFF M + G + A1 ON + LIGHTS B + A1 ON START
B + A1 B + S + A1
“MAKE” NONE L + A2 NONE NONE
02781
G F C
WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.
29
H
E D A
B
REPAIR PARTS TRACTOR - - MODEL NUMBER CO185H42STA ELECTRICAL 22
79
21
41
24 42
80
43 40
27
26
27
27
25
16 33 30
50 D.C.
89 AM
PE
RE
46
S
29
45 10 11
55
28
27
12 2 1 8
12
30
TRACTOR - - MODEL NUMBER CO185H42STA ELECTRICAL
KEY PART NO. NO.
DESCRIPTION
1 2 8 10 11 12 16 21 22 24 25 26 27 28 29 30 33 40 41 42 43 45 46 50 55 79 80 89
Battery Bolt, Hex 1/4-20 x 3/4 Tray, Battery Bolt, Btr Front 1/4-20 x 7-1/2 Holddown Battery Front Mount Nut, Push Nylon Battery Front 1/4 Switch Interlock Harness, Light Light Bulb Cable, Starter Cable, Battery Fuse Nut Keps Hex 1/4-20 Unc Cable, Ground Switch, Seat Switch, Ignition Key, Molded Harness, Ignition Screw Thd Cut 1/4-20 x 1/2 Cover, Terminal Solenoid Ammeter Hourmeter Switch, PTO Screw Thdrol 5/16-18 x 1/2 Socket Asm bulb Twistlock Harness Clutch EVX Bracket Snap-In
163465 74760412 7603J 145211 150109 145769 176138 175688 4152J 8860R 146148 175158 73510400 145491 121305X 175566 140401 188031 17720408 131563 178861 122822X 169635 174653 17490508 175242 146685 169639
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
31
TRACTOR - - MODEL NUMBER CO185H42STA CHASSIS AND ENCLOSURES
17
29 166
10
217
161
10
166
30
28 90
166
159
31
9
209
54 58
209
155
213
54
214
158
166 11
209
20
64
59
209
209
209
209
144
26 209 142
60
1
26
154
143
209 144 26 60
142 2
166
26
145
37
13
37
209 14
74 38 206
209
38
chassis-stealth.stlt_27
32
14
209
TRACTOR - - MODEL NUMBER CO185H42STA CHASSIS AND ENCLOSURES
KEY PART NO. NO.
DESCRIPTION
1 2 9 10 11 13 14 17 20 26 28 29 30 31 37 38 54 58 59 60 64 74 90 142 143 144 145 154 155 158 159 161 166 206 209 213 214 217
Chassis Drawbar Dash Bolt RDHD SQNK 3/8-16 x 1 Panel, Dash, LH Panel, Dash, RH Screw Thdrol 3/8-16 x 1/2 Hood Assembly Plate Battery Locknut, Hex, with Insert 3/8-16 unc Grille Lens, Bar Fender/Footrest Bracket, Fender/Support Screw, Thdrol. 5/16-18 x 1/2 TYT Bracket Asm Pivot Mower Rear Screw Hex Wshd 8-18 x 7/8 Duct Hood Bushing 1.375 OD Bolt Rdhd Sqnk 3/8-16 unc x 3/4 Dash Lower Nut Crownlock 3/8-16 unc Nut Self Thrd Wshd 1/4 Zinc Plate Reinforcement Bracket Swaybar Chassis Bracket Footrest Rod Pivot Chassis/Hood Bracket Dash Rh Bracket Dash Lh Parking Brake Bkrt Cupholder Bumper Extrusion .600 x 3.50 Screw 10 x 3/4 Single Lead-Hex Bolt Shoulder 5/16-18 Screw Hexwsh Thdr 3/8-16 x 3/4 Skirt Grille LH Skirt Grille RH Console Fuel Window
174619 176554 161566X428 72140608 167203 188702X010 17490608 175260X428 162026 73800600 175289X428 161840 188572X428 139976 17490508 175710 161464 175351 187495 72140606 174997 73680600 124346X 175702 186689 175582 156524 161897 161900 162037 179950X428 164655 191611 170165 17000612 169848X428 169847X428 179132X428
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
33
TRACTOR - - MODEL NUMBER CO185H42STA GROUND DRIVE
57
120
89
63 33
144
66
69
59
197
161 169
159 158
56
61
9
162 198
81 21
112
14
82 165 156
166
48 27
35
47
62
120
34
36
52
52
36 35
37
32
16 95
53
28
30
26 16 29
16 77
25
22
19 24
84
96
77 1
74
75
78
73 76
26
34
27
263
71
15
55
199
200
263
26 26
151 51
49
39
8
30
150
20
168
163
202
50
65
41
83
38
10
32
52 23
16 drive-hydro.stlt_69
TRACTOR - - MODEL NUMBER CO185H42STA GROUND DRIVE
KEY PART NO. NO. 1
---
8 9 10 14 15 16 17 19 20
165866 160889 76020416 10040400 74490544 73800500 126197X 73800600 150280
21 22 23 24 25 26 27 28 29 30 32 33 34 35 36 37 38 39 41 47 48 49 50 51 52 53 55 56 57 59 61
106933X 169498 171258 73350600 106888X 19131316 76020412 175765 71673 169592 74760512 72140506 175578 120183X 19211616 1572H 179114 72110622 175556 127783 154407 123205X 72110612 73680600 73680500 105710X 105709X 17060620 140294 169691 17120614
DESCRIPTION Transaxle, HydroGear, Model Number 314-0510 (Order parts from transaxle manufacturer) Rod Shift Fend. Clutch Electric Pin Cotter 1/8 x 1 Washer Lock Hvy 1/4 Bolt Hex Flghd 5/16-18 Gr. 5 Nut Lock Hex W/Ins. 5/16-18 unc Washer 1-1/2 x 15/32 x .250 Nut Lock Hex W/Wsh 3/8-16 unc Bolt Hex 7/16-20 x 4-1/4 5 Ga. 1.38 Knob Rod, Brake Bracket Asm Anti-Rotation Nut, Hex Jam 3/8-16 unc Spring, Brake Rod Washer Pin Cotter 1/8 x 3/4 CAD. Rod, Parking Brake Knob Brake Parking Bracket, Transaxle Bolt Hex Hd 5/16-18 unc x 3/4 bolt Rdhd Sqnk 5/16-18 unc x 3/4 Shaft, Foot Pedal Bearing, Nylon Washer Pin, Roll Pulley, Composite Bolt Rdhd 3/8-16 unc x 2-3/4 Gr. 5 Keeper, Belt Idler Flat Pulley, Idler, V-Groove Bellcrank Clutch Grnd Drw Stl Retainer, Belt Bolt Nut Crownlock 3/8-16 unc Nut, Crownlock 5/16-18 unc Link, Clutch Spring, Return, Clutch Screw 3/8-16 x 1-1/4 V-Belt, Ground Drive Keeper, Center Span Screw 3/8-16 x .875
KEY PART NO. NO.
DESCRIPTION
62 63 65 66 69 71 73 74 75 76 77 78 81 82 83 84 89 95 96 112 120 144 150 151 156 158 159 161 162 163 165 166 168 169 197 198 199 200 202 254 263
Cover, Pedal Pulley, Engine Washer Keeper Belt Engine Screw Hex Wsh H-Lo 1/4-1/2 unc Strap Torque LH Strap Torque RH Spacer, Axle Washer 25/32 x 1-1/4 x 16 Ga. E-Ring Key, Square Washer 25/32 x 1-5/8 x 16 Ga. Shaft Assy. Cross Taper Spring Torsion Washer 17/32 x 3/4 x 16 Ga. Link Transaxle Console, Shift Rod Bypass Retainer Spring 1" Zinc/Cad Washer 9/32 x 3/4 x 10 Ga. Nut Lock Flg 3/8-16 unc Washer 11/32 x 5/8 x 16 Ga. Spacer Retainer Washer 13/32 x 2 x 10 Ga. Washer 5/16 ID x 1.0 x .125 Bracket Shift Mount Hub Shift Bolt Rdhd Sqnk 1/4-20 x 3/4 Gr. 5 Nut Crownlock 1/4-20 unc Bolt Hex Fin 1/4-20 unc x 1 Gr. 5 Bracket Pivot Lever Screw 5/16-18 x 5/8 Bolt Shoulder 5/16-18 x .561 Plate Fastener Cross Shf. Nyliner Snap-in 5/8 ID Washer Nyl 7/8 ID x .105" Bolt Shoulder 5/16-18 unc Bolt Rdhd Sqnk 5/16-18 unc x 1 Bolt Carr Sh 3/8-16 x 1-3/4 Gr. 5 Screw 3/8-16 x 1 Screw 3/8-16 x .75
123533X 175414 10040700 154778 142432 169183 169182 137057 121749X 12000001 123583X 121748X 165596 165711 19171216 169594 188309X428 170201 4497H 19091210 73900600 19111016 175456 19133210 166002 165589 183900 72140406 73680400 74780416 165623 17490510 165492 165580 169613 169593 169612 72140508 72110614 17000616 17000612
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
35
TRACTOR - - MODEL NUMBER CO185H42STA STEERING ASSEMBLY
38 12 39
1
73 41 42 37
37 36
88
91 43
71
29
67
67
68
46
67
8
13
6 65
17
46
2
8 6
87 5
87
3 32 68 82
29
5
11 4 43 40 43 33
29 15
10
95
8
34 35
steering_stealth_prem_3
36
TRACTOR - - MODEL NUMBER CO185H42STA STEERING ASSEMBLY
KEY PART NO. NO. 1 2 3 4 5 6 8 10 11 12 13 15 17 29 32 33 34 35 36 37 38 39 40 41 42 43 46 65 67 68 71 73 82 87 88 91 95
159944X428 184706 169840 169839 6266H 121748X 12000029 175121 10040600 73940800 136518 145212 177883 17000612 171888 19111216 10040500 73540500 155105 152927 159946X428 19182411 73540600 159945 163888X428 121749X 184946X505 160367 72110618 169827 175146 160135X428 169835 173966 175118 175553 188967
DESCRIPTION Wheel Steering Axle Asm Spindle Asm LH Spindle Asm RH Bearing Race Thrust Harden Washer 25/32 x 1-5/8 x 16 Ga. Ring Klip #t5304-75 Link Drag Washer Lock Hvy Hlcl Spr 3/8 Nut Hex Jam Toplock 1/2-20 unf Spacer Bearing Axle Front Nut Hex Flange Lock Shaft Asm. Steering Screw 3/8-16 x 3/4 Rod Tie Washer 11/32 x 3/4 x 16 Ga. Washer Lock Hlcl Spr 5/16 Crownlock Nut 5/16-24 unf Bushing Strg Screw Insert Cap Strg Wh Washer 9/16 ID x 1-1/2 OD 11Ga. Nut Crownlock 3/8-24 Adaptor Wheel Strg Boot Steering Washer 25/32 1 1/4 x 16 Ga. Cap Spindle Spacer Brace Axle Bolt, Rdhd Sq 3/8-16 unc x 2-1/4 Axle, Brace Steering Asm. Extension Steering Stealth Bracket Susp. Chassis Front Washer Flat .781 x 1-1/2 x .15 Bolt Shoulder 7/16-20 unc Clip Steering Washer Harden .793 x 1.637 x .060
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
37
TRACTOR - - MODEL NUMBER CO185H42STA ENGINE 3
2
72 1
81
13
4
78 38 14
32
78
31
33
37 112
41
33 45
29
23
OPTIONAL EQUIPMENT Spark Arrester KEY PART NO. NO. 1 2 3 4 13 14 23 29 31 32 33
engine-bs.1cyl_51
KEY PART NO. NO.
DESCRIPTION
176636X428 Control Throttle 171875 Screw Hwhd Hi-Lo #13-16 x 3/4 - - - - - - - - Engine, Briggs Model 31P777 (Order parts for Engine Manufac turer) 137352 Muffler Asm Twin Lo-Tone 165291 Muffler Gasket 148456 Tube Drain oil 169837 Shield Heat 137180 Kit Spark Arrestor (Flat Scrn) 179022 Tank Fuel 179124X428 Cap Asm Fuel 123487X Clamp Hose Black
37 38 41 45
8543R 181654 139277 17000612
72 78 81 112
183906 17060620 73510400 3645J
DESCRIPTION Line Fuel Plug Drain Oil Easy Stem Tank Fuel Screw Hexwsh Thdr 3/8-16 x 3/4 Screw 5/16-18 x 1 Screw 3/8-16 x 1-1/4 Nut Keps Hex 1/4-20 unc Bushing
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
38
TRACTOR - - MODEL NUMBER CO185H42STA SEAT ASSEMBLY 1 18
8 8
9 14
9
7
7
10
5 6 22 21
2 24 5 16
25
15 11 4 13 17
3
12
seat_lt.knob_2
KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 12
Seat Bracket Pivot Seat Bolt Fin Hex 3/8-16 unc x 1 Washer 13/32 x 1 x 10 Ga Clip Push-In Nut Hex w/Ins. 3/8-16 unc Spring Seat Cprsn Screw 3/8-16 x 1-1/2 Washer 13/32 x 1 x 14 Ga. Pan Seat Knob Seat Adj. Wingnut Bracket Mounting Switch
189022 140551 71110616 19131610 145006 73800600 124181X 17000616 19131614 182493 166369 121246X
KEY PART NO. NO.
DESCRIPTION
13 14 15 16 17 18 21 22 24 25
Bushing Snap Blk Nyl 50 Id Bolt Rdhd Sqnk 1/4-20 x 1-1/2 Spacer Split 28x .88 Zinc Spring Cprsn Plate 1.310 Ga Nut Lock 1/4 Lge Flg Gr. 5 Zinc Cap Spring Seat Bolt Shoulder 5/16-18 unc Nut Hex Lock W/Ins 5/16-18 Washer 17/32 x 1-3/16 x 12 Ga. Bolt Shoulder 5/16-18 x 62
121248X 72050412 121249X 123740X 123976X 124238X 171852 73800500 19171912 127018X
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
39
TRACTOR - - MODEL NUMBER CO185H42STA DECALS 11
9
16
5
3
21
21
4
11
10
18
20
15
23 1 14 8
KEY PART NO. NO.
DESCRIPTION
KEY PART NO. NO.
DESCRIPTION
1 3 4 5 8 9 10 11 14 15
Reflector, LH Decal, Hood RH Decal, Hood LH Decal, Fender Decal, Deck, Caution Decal, Replacement Hood Decal, Fender, Danger Decal, Panel, Dash Decal, V-Belt, Schematic Decal, Reflector, RH
16 18 20 21 23 ------
Decal, Steering Wheel Decal, Fender Opr. Decal, Battery Decal, Hood, Side Panel Decal, Engine Pad, Footrest, ST/LT, LH Pad, Footrest, ST/LT, RH Decal By-Pass Manual, Owner's, English Manual, Owner's, Spanish
187407 176272 176273 172740 179128 189342 157141 191648 160396 187408
KEY PART NO. NO.
WHEELS & TIRES 1 2
1 2 3 4 5 6 7
5,8
7
172743 156811 145004 189289 189288 184310X428 184311X428 166960 191641 191642
4,10
3,9 6
11
8 9 10 11 --
DESCRIPTION
59192 65139 106222X 59904 106732X421 278H 9040H
Cap Valve Tire Stem Valve Tire F Ts 15 x 6 0 - 6 Service Tube Front (Service Item Only) Rim Asm 6"front Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) 106108X421 Rim Asm 8"rear Service 122082X Tire R Ts 20 x 10-8 C Service 7152J Tube Rear (Service Item Only) 104757X428 Cap Axle Blk 1 50 x 1 00 144334 Sealant, Tire ( 10 oz. Tube)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
wheel_1
40
TRACTOR - - MODEL NUMBER CO185H42STA LIFT ASSEMBLY 7 41
37 5
38 40
3 1
36 13
4 6
6
11
5
2
4
12
13 19 13 20
15
16
17 18
20
20
31 32
19 15
13
31 32
KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 11 12 13 15 16 17
Plunger Assembly Shaft Assembly, Lift Pin, Groove E-Ring Washer 21/32 x 1 x 21 Ga. Bearing, Nylon Grip, Handle, Fluted Link, Lift, L.H. Link, Lift, R.H. Retainer Spring Link Front Sus. Nut Hex Jam 1/2-13 unc Trunnion Front Susp.
179504 159476 188822 12000002 19211621 120183X 175830 139865 139866 4939M 173288 73350800 175689
20
lift-rh.1piece_24
KEY PART NO. NO.
DESCRIPTION
18 19 20 31 32 36 37 38 40 41
Nut Lock w/Wsh 1/2-13 unc Arm Asm. Suspension Mower Retainer Spring Bearing Pivot Lift Nut Crownlock 3/8-24 Pointer Height Indicator Plug Hole Screw 5/16-18 x 1 Washer 11/32 x 1-1/2 x 10 Ga. Indicator Height Stlt
73800800 139868 163552 169865 73540600 155097 123935X 17060516 19112410 155098
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
41
TRACTOR - - MODEL NUMBER CO185H42STA MOWER DECK
68 40 36 40
184
143 45 150
144
159 46
132 91
40
182
145 44
184 59
56 55
54
21
5
134 135
146 33 32 31
94
103
102
104 103 late h_p mulc 42_
101
21
104 106
21
102
116
5 134
139 21
117
119 113
118 2
136
118 119 117
2 21
34
132
105
105
21
136
95
106
30
140
183
148
2
1
116
21 23
24 25
138
26 28
113
29
2
27
16 130
131 129
92
3
20 18
92
61 4
5
15 14
149
18 13
6
11 19
21
10 9
8
42
42_D.elec.t-path.adjwl.stlt_3
TRACTOR - - MODEL NUMBER CO185H42STA MOWER DECK KEY PART NO. NO. 1 2 3 4 5 6 8 9 10 11 --13 14 15 16 18 19 20 21 23 24 25 26 27 28 29 30 31 32 33 34 36 37 40 44 45 46 54 55 56 59 61 68 91
KEY PART NO. NO.
DESCRIPTION
182032 72140506 138017
Mower Housing Bolt Bracket Assembly,Sway Bar, Front 165460 Bracket Sway Bar 38/42” 4939M Retainer Spring 178024 Bar Sway Deck 850857 Bolt, Hex 3/8-24 x 1.25 Gr. 8 10030600 Washer, Lock 140296 Washer, Hardened (The following blades are available) 134149 Blade, 42" Mulching STD (For mulching mowers only) 139775 Blade, 42" Mulching Premium (For better wear when mulching) 138971 Blade, 42" Hi-Lift (For bagging or discharge) 137645 Shaft Assembly, Mandrel, Vented (Incl. Key Number 6) 128774 Housing, Mandrel, Vented 110485X Bearing, Ball, Mandrel 174493 Stripper, Mower Deck 72140505 Bolt, Carriage 5/16-18 x 5/8 132827 Bolt, Shoulder 159770 Baffle, Vortex 73680500 Nut, Crownlock 5/16-18 unc 177563 Bracket, Deflector 105304X Cap, Sleeve 123713X Spring, Torsion, Deflector 110452X Nut, Push 130968X428 Shield, Deflector 19111016 Washer 11/32 x 5/8 x 16 Ga. 131491 Rod, Hinge 173984 Screw Thdrol Rolling Wsh Hd 187690 Washer, Spacer 173436 Pulley, Mandrel 178342 Nut, Toplock, Flanged 72110612 Bolt 173438 Pulley, Idler, Flat 19131316 Washer 13/32 x 13/16 x 16 Ga. 73900600 Nut, Lock 3/8-16 unc 140088 Guard, Mandrel, L.H. 4497H Retainer 137729 Screw, Thd. Roll 1/4-20 x 5/8 178515 Washer, Hardened 155046 Arm, Idler 122052X Spacer, Retainer 173442 Guard, Tuv Idler 174882 Spring Ext Elect Clutch 174883 V-Belt 180532 Bracket Roller Nose LH
92 94 95 101 102 103 104 105 106 113 116 117 118 119 129 130 131 132 134 135
73800600 132264 180533 136420 71081010 19061216 10071000 160793 2029J 17060512 4898H 165746 73930600 19121414 19131312 74780616 72140608 17000612 156941 159765
136 138
155986 159763
139
159767
140
159768
143 144 145 146 148 149 150 159 182 183 184 --
157109 173441 173437 173443 169022 165898 19091210 72140614 179126 163552 19131410 130794
--
181542
DESCRIPTION Locknut, Hex W/Wsh 3/8-16 unc Roller Nose Bracket Roller Nose RH Cover Mulching 42" Black Screw Truss Hd Phil10-24 x 5/8 Washer #10 Washer Lock Latch Asm Bagger Nut Weld Screw 5/16-18 Bolt, Shoulder Wheel, Gauge Nut, Crownlock 3/8-1 Washer 13/32 x 7/8 x 14 Ga. Washer 13/32 x 13/16 x 12 Ga. Bolt, Fin Hex 3/8-16 unc x 1Gr. 5 Bolt Rdhd Sqnk 3/8-16 unc x 1 Screw 3/8-16 x 3/4 Pin Head Rivet Bracket Asm. Wheel Gauge Rear LH Bar Adj. Gauge Wheel Bracket Asm. Wheel Gauge Rear RH Bracket Asm. Wheel Gauge Front RH Bracket Asm. Wheel Gauge Front LH Bracket Arm Idler 42” Keeper Belt 42” Clutch Cable Pulley Idler Flat Bolt Carraige Idler Spring Return Idler Retainer Spring Yellow Zinc Washer 9/32 x 3/4 x 10 Ga. Bolt Rdhd Sqn 3/8-16 unc x 1-3/4 Rod Roller Nose Retainer Spring Washer 3/8 Mandrel Assembly (Includes housing, shaft and shaft hardware only-pulley not included) Replacement Mower, Complete (Std. Deck-Order separately mulch cover, gauge wheels and nose roller components key nos. 101 - 106, 5, 116 - 119, 134, 136 and 91, 94, 95, 132, 182, 183).
NOTE: All component dimensions given in U.S.inches 1 inch = 25.4 mm
43
