Transcript
DCC Series 15 - 25 TON, THREE-PHASE PACKAGED AIR CONDITIONERS UP TO 11 EER
Submittal Data Form Job Name
■ Standard Features • • • • • •
Location Purchaser Order No. Engineer Unit No.
• • • • • • •
Model No. Unit Designation Performance Data Certified By:
R-410A chlorine-free refrigerant High-efficiency scroll compressor Copper tube / aluminum fin coils High- and low-pressure switches High-capacity, steel-cased filter drier Built-in filter rack with standard 2” filters (convertible to 4” filters) Heater kits with single-point entry Crankcase heaters Contactor with lugs 24-volt terminal strip Easy to service Bottom utility entry AHRI Certified; ETL Listed
■ Cabinet Features
• Heavy-gauge, galvanized-steel cabinet with UV-resistant powder-paint finish • Condenser Hail Guards • Full Perimeter Rail • Sloped drain pan
Note: 25-ton models contain two outdoor fans
* Complete warranty details available from your local dealer or at www.daikincomfort.com.
SF-DCC15
www.daikincomfort.com
9/15 Supersedes 8/15
Job Name
Location
Performance Data Cooling Performance Tota Capacity Sensible Capacity Outdoor Design TMP Air Temp entering Evaporator Coil Power Input Required (less blower motor)
Supply Air Blower Performance MBH MBH ºF DB / WB ºF kW
CFM IWG RPM BHP HP kW
Electrical Data
Heating Performance Total Heating Capacity
Total Supply Air Ext. Static Pressure Blower Speed Power Output Required Motor Ratings Power Input Required
kW BTU/h
Power Supply Total Unit Amps Max Overcurrent Device: Fuse Breaker
Amps Amps
Notes
2
www.daikincomfort.com
SF-DCC15
SF-DCC15
www.daikincomfort.com BACK VIEW
133.354
CONDENSATE DRAIN OUTLET THIS SIDE ONLY
35.551
50.750
7.017
ALL DIMENSIONS ARE GIVEN IN INCHES ALL DIMENSIONS AND SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTIFICATION
LIFT SHACKLE HOLES BOTH SIDES AND ENDS
FORK HOLES BOTH SIDES AND CONDENSER END
TOP VIEW
15 AND 20 TON COMERCIAL
DC*180/240***
LEFT END VIEW
88.116
LINE WIRE ENTRANCE
18.579
12.137
8.949
3.058
8.204
TSTAT WIRE ENTRANCE
(if applicable)
DISCONNECT SWITCH LOCATION
Job Name Location
Dimensions — 15 & 20 Tons
3
4
www.daikincomfort.com BACK VIEW
LEFT SHACKLE HOLES BOTH SIDES AND ENDS
FORK HOLES BOTH SIDES AND CONDENSER END
133.354
CONDENSATE DRAN OUTLET THIS SIDE ONLY
ALL DIMENSION GIVEN ARE IN INCHES ALL DIMENSIONS AND SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE.
53.212
TOP VIEW
35.551
7.017
50.750
88.116 LEFT END VIEW
3.058
DC*300*** 25-TON COMMERCIAL
12.125
8.204
TSTAT WIRE ENTRANCE
LINE WIRE ENTRANCE
Job Name Location
Dimensions — 25 Tons
SF-DCC15
Job Name
Location
Accessories List (dimensions and specifications begin on the following page.) Filed-Installed Item #
Fits Model Sizes
FieldInstalled
14" Roof Curb 25% Manual Fresh Air Damper 25% Motorized Fresh Air Damper Burglar Bar Sleeves with Supply and Return Concentric Duct Kit Concentric Duct Kit Concentric Duct Kit Convenience Outlet: Powered Convenience Outlet: Non Powered Disconnect Switch (non-fused) Downflow Economizer Downflow Economizer Electric Heat Kits (75kW not available as factory-installed kit) High-Static Kit (230/460v) High-Static Kit (575v) High-Static Kit (230/460v) High-Static Kit (575v) High-Static Kit (all voltages) Horizontal Discharge Curb — End Discharge
15-25 tons 15-25 tons 15-25 tons 15-25 tons 15 tons 20 tons 25 tons All Models All Models All Models 15-25 tons 15-25 tons All Models 15 tons 15 tons 20 tons 20 tons 25 tons 15-25 tons
√ √ √ √ √ √ √
HZCURB180240SDN
Horizontal Discharge Curb — Side Discharge; duct openings on non-service side
15-25 tons
√
HZCURB180240SDS
Horizontal Discharge Curb — Side Discharge; duct openings on service side
15-25 tons
√
Hurricane Restraint Clips Low-Ambient Kit Low-Ambient Kit Power Exhaust (208/230v) Power Exhaust (460v) Power Exhaust (575v) Smoke Detector Freeze Stat Kit
All Models 15-20 tons 25 tons 15-25 tons 15-25 tons 15-25 tons All Models 25 tons
√ √ √ √ √ √
14CURB180300 D25FD180300 D25MFD180300 DDNBB180240 CDK180 CDK240 CDK300
DDNECNJ180300B
HSKT180 ¹ HSKT180-7 ¹ HSKT240 ¹ HSKT240-7 ¹ HSKT300C HZCURB180240ED
GHRC-1 LAKT03 LAKT05 DPE1803002 DPE1803004 DPE1803007 FSKT02A
Description
FactoryInstalled
√ √ √ √ √ √ √ √ √ √ √
√ √
√ √
√ √2
¹ HSKT High-static kits are for use with standard single-speed belt-drive units only. 2 FSK02A is standard on 2 speed, V, models, and field installed for single speed, B, models.
SF-DCC15
www.daikincomfort.com
5
Job Name
Location
Roof Curb — #14CRB180300 4
3
D
2
1
D
123.5 CURB TOP O.D. 120.25 CURB I.D.
4 17.25
17.25
17.25
S
S/A
R/A
C 61.88
61.88
4
INSULATED PANELS
4 11.25
C
78 CURB TOP O.D.
22.88
22
B
74.75 CURB I.D.
1.63 TYP. B
1.75
1.75
1.38 TYP.
123 CURB BOTTOM O.D.
3
14
77.5 CURB BOTTOM O.D. DRAWN
mikeg
4/28/2010
CHECKED
A
QA
TITLE
A
14CURB180-240
MFG APPROVED SIZE
C
4
3
REV
DWG NO
SCALE
2
SHEET
1
1
OF
1
Specifications • 14-Gauge construction • 1 x 4 Wood Nailer attached to top of the curb • Shipped knocked down with all hardware • Gasket included • Bed-Rail style corners Note: outside duct dimension should be ½” less than opening dimensions above.
6
www.daikincomfort.com
SF-DCC15
Job Name
Location
Manual Fresh Air Damper — #D25FD180300 Motorized Fresh Air Damper — #D25MFD180300
25FD180240 AND 25MFD180240 MANUAL / MOTORIZED FRESH AIR DAMPE
Specifications Manual Damper • Provides up to 25% fresh air • Locking selection knob provides constant opening • Painted to match the unit • Fits 15 - 25 ton package units in all fuels SPECIFICATIONS Motorized D amper • 24 VAC Damper motor with spring return MANUAL DAMPER • Fully assembled and factory wired • PROVIDES UP TO 25% FRESH AIR • Painted to match the unit • LOCKING SELECTION KNOB PROVIDES CONSTANT OPENING • Fits 15 - 25 ton package units in all fuels
MOTORIZED DAMPER • 24VAC DAMPER MOTOR WITH SPRING RETURN • FULLY ASSEMBLED AND FACTORY WIRED FITS ALL 15-20 TON PACKAGE UNITS IN ALL FUELS ALL DAMPERS PAINTED TO MATCH THE UNIT SF-DCC15
www.daikincomfort.com 7 McDANIEL METALS 1318 BUSCHONG HOUSTON TX 77039 281-987-8400 281-987-9494 F
Job Name
Location
Downflow Economizer — #DDNECNJ180300B
Specifications • Fully modulating • Up to 100% fresh air • Integral barometric relief • Hoods painted to match unit • Honeywell economizer control • Single adjustable enthalpy control convertible to dual enthalpy • Adjustable minimum fresh air • Factory wired • Gas/Electric for 15 - 25 ton units
8
www.daikincomfort.com
SF-DCC15
Job Name
Location
Power Exhaust for 208/230v Units — #DPE1803002 Power Exhaust for 460v Units — #DPE1803004 Power Exhaust for 575V Units - #DPE1803007
Specifications • Features propeller-type fans • 208/230V and 460V models available • Used in conjuntion with DNECONHP150 or DNECONGS180240 • Fans engage when economizer freshair dampers are 70% open • Gives up to 100% relief • Integrates into downflow economizer hood
SF-DCC15
www.daikincomfort.com
9
Job Name
Location
Concentric Duct Kits — #CDK180, #CDK240, & #CDK300
Commercial T-Bar Ceiling
Light Commercial T-Bar Ceiling
Hanging Support from the Diffuser Turing Vane to Ensure Proper Airflow
Specifications • All-aluminum diffuser with aluminum return air egg crate • Built-in anti-sweat gasket • Molded fiberglass transition (through five tons) • Built-in hanging supports • Diffuser box constructed of fiberglass duct board (through 7½ tons) or sheet metal
10
Aluminum Egg Crate
www.daikincomfort.com
Molded Fiberglass Transition
SF-DCC15
Job Name
Location
Notes
SF-DCC15
www.daikincomfort.com
11
Job Name
Location
Notes
Our continuing commitment to quality products may mean a change in specifications without notice. © 2015 • • Houston, Texas • Printed in the USA.
12
www.daikincomfort.com
SF-DCC15
