Dfwr1225/dfwr1428/ Dfwr1631/dfwr1833 Dual-fold Wheel V-rake

Transcript

DFWR1225/DFWR1428/ DFWR1631/DFWR1833 DUAL-FOLD WHEEL V-RAKE Published 06/11 MATERIAL HANDLING PARTS MANUAL PARTS MANUAL SECTION 22 PARTS ORDERING GUIDE The following instructions are offered to help eliminate needless delay and error in processing purchase orders for the equipment in this section. 1. The Parts Section is prepared in logical sequence and grouping of parts that belong to the basic machine featured in this manual. Part Numbers and Descriptions are given to help locate the parts and quantities required. 2. The Purchase Order must include the name and address of the person or organization ordering the parts, who should be charged, and if possible, the serial number of the machine for which the parts are ordered. 3. The Purchase Order must clearly list the quantity of each part, the complete and correct part number (be sure to include all periods), and the basic name of the part. 4. The Manufacturer reserves the right to substitute parts where applicable. 5. Some parts are unlisted items which are special production items not normally stocked and are subject to special handling. Request a quotation for such parts before sending a Purchase Order. 6. The Manufacturer reserves the right to change prices without prior notice. For maximum safety and to guarantee optimum product reliability, always use genuine BUSH HOG Parts. The use of inferior replacement parts may causepremature or catastrophic failure which could result in serious injury or death.Direct any questions regarding parts to: BUSH HOG 2501 Griffin Ave. Selma, AL 36703 www.bushhog.com Contact Us 800-304-2836 ©2009 Alamo Group Inc. To the Owner/Operator/Dealer All implements with moving parts are potentially hazardous. There is no substitute for a cautious, safe-minded operator who recognizes the potential hazards and follows reasonable safety practices. The manufacturer has designed this implement to be used with all its safety equipment properly attached to minimize the chance of accidents. BEFORE YOU START! Read the safety messages on the implement and shown in your manual. Observe the rules of safety and common sense! WARRANTY INFORMATION: Read and understand the complete Warranty Statement found in this Manual. Fill out the Warranty RegistrationForm in full and return it to within 30 Days. Make certain the Serial Number of the Machine is recorded on theWarranty Card and on the Warranty Form that you retain. LIMITED WARRANTY 2222222222222222222222222222222 Bush Hog warrants to the original purchaser of any new Bush Hog equipment, purchased from an authorized Bush Hog dealer, that the equipment be free from defects in material and workmanship for a period of one (1) year for non-commercial, state and municipalities’ use and ninety (90) days for commercial use from date of retail sale. The obligation of Bush Hog to the purchaser under this warranty is limited to the repair or replacement of defective parts. Replacement or repair parts installed in the equipment covered by this limited warranty are warranted for ninety (90) days from the date of purchase of such part or to the expiration of the applicable new equipment warranty period, whichever occurs later. Warranted parts shall be provided at no cost to the user at an authorized Bush Hog dealer during regular working hours. Bush Hog reserves the right to inspect any equipment or parts which are claimed to have been defective in material or workmanship. DISCLAIMER OF IMPLIED WARRANTIES & CONSEQUENTIAL DAMAGES Bush Hog’s obligation under this limited warranty, to the extent allowed by law, is in lieu of all warranties, implied or expressed, INCLUDING IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE and any liability for incidental and consequential damages with respect to the sale or use of the items warranted. Such incidental and consequential damages shall include but not be limited to: transportation charges other than normal freight charges; cost of installation other than cost approved by Bush Hog; duty; taxes; charges for normal service or adjustment; loss of crops or any other loss of income; rental of substitute equipment, expenses due to loss, damage, detention or delay in the delivery of equipment or parts resulting from acts beyond the control of Bush Hog. THIS LIMITED WARRANTY SHALL NOT APPLY: 1. To vendor items which carry their own warranties, such as engines, tires, and tubes. 2. If the unit has been subjected to misapplication, abuse, misuse, negligence, fire or other accident. 3. If parts not made or supplied by Bush Hog have been used in connection with the unit, if, in the sole judgement of Bush Hog such use affects its performance, stability or reliability. 4. If the unit has been altered or repaired outside of an authorized Bush Hog dealership in a manner which, in the sole judgement of Bush Hog, affects its performance, stability or reliability. 5. To normal maintenance service and normal replacement items such as gearbox lubricant, hydraulic fluid, worn blades, or to normal deterioration of such things as belts and exterior finish due to use or exposure. 6. To expendable or wear items such as teeth, chains, sprockets, belts, springs and any other items that in the company’s sole judgement is a wear item. NO EMPLOYEE OR REPRESENTATIVE OF BUSH HOG IS AUTHORIZED TO CHANGE THIS LIMITED WARRANTY IN ANY WAY OR GRANT ANY OTHER WARRANTY UNLESS SUCH CHANGE IS MADE IN WRITING AND SIGNED BY BUSH HOG’S SERVICE MANAGER, 2501 GRIFFIN AVE., SELMA, ALABAMA 36703. 2222222222222222222222222222222 Record the model number, serial number and date purchased. This information will be helpful to your dealer if parts or service are required. MODEL NUMBER ________________________________ SERIAL NUMBER ________________________________ DATE OF RETAIL SALE ___________________________ MAKE CERTAIN THE WARRANTY HAS BEEN FILED WITH BUSH HOG SELMA, ALABAMA BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 ALPHABETICAL TABLE OF CONTENTS DFWR FOLDING WHEEL RAKES ITEM PAGE NUMBER Articulation - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-5 Articulation - DFWR1428/DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-26, 22-1-27 Center Section - DFWR1428 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-14, 22-1-15 Center Section - DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-22, 22-1-23 Center Section - DFWR1833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-34, 22-1-35 Center Wheel Lift Cylinder (Opt) - DFWR1225/DFWR1428/DFWR1631 . . . . . . . . . . . . .22-1-42 Decals - Bush Hog Marking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-50, 22-1-51 Front Section - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-6, 22-1-7 Front Section - DFWR1428 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-12, 22-1-13 Front Section - DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-20, 22-1-21 Front Section - DFWR1833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-32, 22-1-33 Hydraulic Kit - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-8, 22-1-9 Hydraulic Kit - DFWR1428 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-16, 22-1-17 Hydraulic Kit - DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-24, 22-1-25 Hydraulic Kit - DFWR1833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-36, 22-1-37 Hydraulic Lift - Center Wheel Kit (Opt) - DFWR1225/DFWR1428/DFWR1631 . .22-1-40, 22-1-41 Kit, Hose Conversion (Opt) - All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-39 Light Kit - All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-48, 22-1-49 Ratchet Link Assembly - All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-46, 22-1-47 Rear Hydraulic Kit (Opt) - (To Open One Side Only) - All Models . . . . . . . . . . . . . . . . . . .22-1-43 Rear Hydraulic Opening Kit (Opt) - All Models . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-44, 22-1-45 Rear Section Hydraulic Cylinder Repair Kit - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-4 Rear Section Hydraulic Cylinder Repair Kit - DFWR1428/DFWR1631/DFWR1833 . . . . .22-1-38 Rear Section - DFWR1225 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-2, 22-1-3 Rear Section - DFWR1428 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-10, 22-1-11 Rear Section - DFWR1631 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-18, 22-1-19 Rear Section - DFWR1833 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-30, 22-1-31 Rear Tandem Wheel kit (Opt) - All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22-1-1 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Inside Back Cover Wheel & Arm Assembly - DFWR1428/DFWR1631 . . . . . . . . . . . . . . . . . . . . . . .22-1-28, 22-1-29 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR TANDEM WHEEL KIT (OPTION) MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 3690302 3690303 3690304 3690305 3668438 3668429 00762395 2568438 3630103 3638406 3666801 3666000 700139C DESCRIPTION Wdmt,Tandem Support Wdmt,RH Tandem Wheel Support Wdmt,LH Tandem Wheel Support Wdmt,Support Pin Spacer Washer Capsc, M12-P1.75- 20MM Gr.8.8 90 Dg Grease Zerk, M8 Assy,Tire & Wheel Nut, Spherical Cap Hex, M16x1.5 Seal, Grease 56 X 80 X 8 (Not Shown) Bearing, Inner (Not Shown) Nut, Low Hex M30 X 3.5 (Not Shown) 22-1-1 QTY. 2 1 1 2 4 2 2 2 2 10 4 4 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION MODEL DFWR1225 RIGHT SIDE LEFT SIDE 22-1-2 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION MODEL DFWR1225 REF. NO. PART NO. 1 2 3 4 5 6 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 3660200 3668425 3690219 3667584 3660119 3667594 3667557 3667552 3637521 3668400 3660204 3660205 3660206 3690277 3690276 3660106 3667504 3666800 3666000 3667505 3666001 3668408 70487 3666700 3660107 3667567 3667568 3667569 3637422 3660209 3630226 3637509 3736800 3736000 3637504 3736001 700728C 70477 3736700 3630100 3637520 3667585 3638403 703516W 3630102 3630101 70631C4 3637508 3737507 3637506 3637505 00765676 61368C8 00755954 00755949 DESCRIPTION Wdmt,Outer Crosspiece Nut,Self Locking Ring M30 X1.5 Wdmt,Sliding Support Plate,Drawbar Counter Assy,Ratchet Link Plate,Cylinder Support Plate,Sliding Spacer Plate,Sliding Wheel Fork Bushing Washer Wdmt,Pin Wdmt,RH Rear Wheel Support Wdmt,LH Rear Wheel Support Wdmt,LH 2-Whl Section Wdmt,RH 2-Whl Section Assy,Hub Spindle,Weld-On Seal Bearing,Inner Hub,Wheel Bearing,Outer Nut,Spindle Cotter Pin, M4x40 Cap,Hub Assy,Hub & Spindle Bushing Tube,Main Lift Clamp,Chain Bushing Extension Arm Spring Wdmt,LH Wheel Arm Wdmt,RH Wheel Arm Weld-On Spindle Seal, 25 X 52.. Inner Tapered Bearing Set Wheel Hub Outer Tapered Bearing Set Nut, Low Hex Castle M18x1.5 Cotter Pin, M3.2x32 Hub Cap Assy,Hub & Spindle Arm Bushing Pin Washer Roll Pin, M8 X 50 Assy,LH Wheel Assy,RH Wheel Carr Bolt, M10x1.5x25 Gr.4.6 Tine Clamp Tine,7MM Dia Rim Flange Nut Metric 10MM Self-Locking Capsc, Hex M10x1.5x25 Gr.8.8-Ft Lockwasher M10 Nut Metric 10MM-P1.5 PL QTY. 1 2 4 1 1 1 8 4 8 2 2 1 1 1 1 2 2 2 2 2 2 2 2 2 2 4 2 12 12 6 6 12 12 12 12 12 12 12 12 12 24 2 24 16 6 6 240 120 480 12 12 240 92 72 76 REF. NO. 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 PART NO. 3638406 3630103 3637800 3637600 3667421 3667509 3660382 3660211 3660383 3637523 3668409 3697110 70502 2568408 3638400 61056C8 70093C 9313087 3038445 00762395 3668405 3667586 71554C8 3667587 6W235 2558466 3668407 610915C8 701618C 3660213 3660214 3660215 3668414 3660122 3690220 3668625 701512C 3690221 6W238 700219C 3660216 3668601 708119C8 3660100 700139C 3660384 3667198 3660232 3668415 613510C8 701611C 001465 3667424 3660420 110 70093C 111 61057C8 22-1-3 DESCRIPTION Nut, Spherical Cap Hex M16x1.5 Assy,Tire & Wheel Tire, 205/75 SR15 Rim-15 Spring Rod,Tie Wdmt,Pin Wdmt,RH Support Wdmt,LH Support Cylinder Pin Fitting,Grease M6 X 1 45dg Cylinder,Hydraulic Cotter Pin, M6.3x36 Grease Zerk, M8 Hairpin Cotter, M3 Capscrew, Hex M8x1.25x60 Gr.8.8 Nut, Hex Toplock M8x1.25 Capsc, M16-P2.0 - 40MM Gr.8 Nut,Toplock M16-P2.0 Pl5 Capsc, M12-P1.75- 20MM Gr.8 Washer,Flat 12 X 40 X 4 Plate,Sliding Fscs Metric 8-P1.25 - 16MM Gr.8 Plate,Linking Capsc, M22 X 2.5 X 50 Gr.10.9 Capsc, M16 X 50 Washer,Flat 12 X 36 X 2.5 Capsc, M16-P2 160MM Gr.8.8 Lockwasher, M22 Wdmt,RH Inner Crosspiece Wdmt,LH Inner Crosspiece Wdmt,Pin Stud,Wheel Hub Gr.8.8 Assy,Tie Rod - Complete Wdmt,Tie Rod Tube End,Tie Rod Head Flatwasher, M10 Wdmt,Tie Rod Pin Nut, Hex M22 X 2.5 Nut, High Hex, M12x1.75 Wdmt,Handle Knob Shcs Metric 12 P1.75 100MM Gr.8.8 Assy,Handle Nut,Low Hex M30 X 3.5 Wdmt,Rear Drawbar Cylinder,Hydraulic Wdmt,Pin Yoke,Clevis-Complete Capsc, Hex M8x1.25x30 Gr.8.8-Ft Lockwasher, M8 Grease Fitting,Straight,M6 Spring Kit, Ratchet Link - Complete Nut, Toplock M8x1.25 Capsc, M8-P1.25 X 65MM Gr.8.8 QTY. 20 4 4 4 2 2 2 1 1 4 12 2 8 12 13 20 22 39 57 18 14 8 32 4 2 6 2 8 2 1 1 2 10 2 2 2 8 2 2 2 2 2 2 2 2 1 2 2 12 6 4 2 1 1 4 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION HYDRAULIC CYLINDER REPAIR KIT MODEL DFWR1225 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 3667198 3667173 3667174 3667178 3667177 --------------3667176 3667175 -------------------3667179 22-1-4 DESCRIPTION Cylinder,Hydraulic Rod,Cylinder Tube,Cylinder Locknut,Cylinder M27 X 2 Piston,Cylinder Piston Seal Piston O-Ring Spacer,Cylinder Head,Cylinder Rod Wiper Rod Seal Head O-Ring Kit,Seal QTY. 1 1 1 1 2 1 1 1 1 1 1 1 1 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 ARTICULATION MODEL DFWR1225 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 3660252 3660227 3660228 3660322 3660323 3667518 3610400 3660231 3660232 3668405 00762395 2568408 610716C8 00772648 9313087 3038445 DESCRIPTION Wdmt,Front Drawbar Wdmt.Center Drawbar Wdmt,Rear Drawbar Wdmt,RH Fixed Arm Wdmt,LH Fixed Arm Plate Kit,Hydraulic Cylinder Wdmt,Pin Wdmt,Pin Washer,Flat 12 X 40 X 4 Capsc, M12-P1.75- 20MM Pl5 Grease Zerk, M8 Capsc, M12-P1.75-140MM Pl5 Nut Metric 12MM-P1.75 Gr.8.8 Capsc, M16-P2.0 - 40MM Gr.8.8 Nut,Toplock Metric 16-P2.0 Gr.8.8 22-1-5 QTY. 1 1 1 1 1 4 2 2 2 2 4 4 16 16 15 15 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 FRONT SECTION MODEL DFWR1225 RIGHT SIDE LEFT SIDE 22-1-6 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 FRONT SECTION MODEL DFWR1225 REF. NO. PART NO. DESCRIPTION QTY. 1 3660385 Wdmt,RH 3-Whl Section 1 2 3660386 Wdmt,LH 3-Whl Section 1 3 3660387 Wdmt,RH 1-Whl Section 1 4 3660388 Wdmt,LH 1-Whl Section 1 5 3667570 Tube,Center Lift 2 6 3667571 Tube,Front Lift 2 7 3667198 Cylinder,Hydraulic 2 8 3667567 Bushing 2 9 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 20 10 3660221 Wdmt,RH Hitch Transport Arm 1 11 3660222 Wdmt,LH Hitch Transport Arm 1 12 3637521 Wheel Fork Bushing 4 13 3667516 Plate,Brake Counter 2 14 3630229 Clutch Bushing Weldment 2 15 3660223 Wdmt,Brake 2 16 3637423 Compression Spring 2 17 3660224 Wdmt,Front Wheel Support 2 18 3660225 Wdmt,Pin 2 19 3636003 Bearing,Ball Two Rubber Seals 4 20 3637526 Wheel Spacer 2 21 3637527 Wheel Hub 2 22 3638409 Washer 2 23 700910C Nut, Toplock M22x2.5 Hex 2 24 3660108 Assy,Hub 2 25 3667517 Spacer 4 26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 10 27 3638406 Nut, Spherical Cap Hex M16x1.5 20 28 3637800 Tire, 205/75 SR15 4 29 3637600 Rim-15 4 30 3630103 Assy,Tire & Wheel 4 31 3660267 Wdmt,Tractor Hitch 1 32 3660235 Wdmt,Hitch Pin 1 33 3668624 Stand,Parking 1 34 3638602 Frame Pin 1 22-1-7 REF. NO. PART NO. 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 3667519 3660236 3660237 3660238 3660239 3660252 3660227 3660322 3660323 3667518 3668407 00762395 3638400 00772648 61075C8 3660231 3668405 703519W 3668401 610711C8 61054C8 00755934 00765901 3038445 3668409 00756934 2568408 3660326 3667577 3668430 3668431 3666776 3667572 3668409 00775032 DESCRIPTION Bushing Wdmt,Inner Arm Wdmt,Outer Arm Wdmt,Pin Wdmt,Bushing Wdmt,Front Drawbar Wdmt.Center Drawbar Wdmt,RH Fixed Arm Wdmt,LH Fixed Arm Plate Washer,Flat 12 X 36 X 2.5 Capsc, M12-P1.75- 20MM Gr.5 Hairpin Cotter, M3 Nut Metric 12MM-P1.75 Gr.8.8 Capsc, M12-P1.75-60MM Gr.5 Wdmt,Pin Washer,Flat 12 X 40 X 4 Pin,Roll M8 X 70MM Pl Washer Capsc, M12 P1.75 90MM Gr.5 Capsc, Hex M8x1.25x50 Gr.8.8 Nut Met 8MM-P1.25 Capsc, M16-P2.0 - 45MM Gr.8 Nut,Toplock Metric 16-P2.0 PL5 Grease Fitting Pin,Roll 10 X 80 Grease Zerk, M8 Wdmt,Brake Counter Plate Plug Ring,External Snap Ring,Internal Elastic Bushing,Nylon Bushing Fitting,Grease M6 X 1 45dg Grease Fitting, 8MMx1x45 QTY. 2 2 2 6 2 1 1 1 1 4 5 18 13 23 1 2 14 2 2 2 20 22 39 57 12 2 12 2 1 24 24 24 12 14 2 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL HYDRAULIC KIT MODEL DFWR1225 22-1-8 JUNE, 2011 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 HYDRAULIC KIT MODEL DFWR1225 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 3637102 3638408 3667200 3667201 3667202 3668402 3668403 3668404 3667198 3638404 3637100 3667102 3697114 3667109 613313C8 70092C 3667103 3667105 3667203 3667204 3667106 3667107 3667110 3660246 613317C8 3667108 3667205 3697110 3667111 3667112 3667113 3667114 3667115 ---------------------3667116 3667173 3667174 3667175 3667176 3667177 3667178 -----------------------------------3667179 3667247 3660240 3667521 610716C8 00772648 3668433 DESCRIPTION Male Coupling Tip Copper Washer, 1/2 ID Assy,Hose Assy,Hose Assy,Hose Collar,Double Hose Collar,Hose Collar,Hose Cylinder,Hydraulic Copper Washer, 17 X 22 X 1.4 Hydraulic Fitting Line,Hydraulic Fitting,Hydraulic Line Valve,Lock Capsc, M6-P1-40MM Gr.8.8 Nut Met Tln M6-P1 PL5 Line,Hydraulic Fitting,Hydraulic Assy,Hose Assy,Hose Fitting,Hydraulic Fitting,Hydraulic Tee Divider,Flow Wdmt,Plate Capsc, M6-P1 -60MM Gr.8.8 Fitting,Hydraulic Tee Assy,Hose Cylinder,Hydraulic Rod,Cylinder Tube,Cylinder Head,Cylinder Piston,Cylinder Nut,Cylinder Seal O-Ring Seal Kit,Seal Rod,Cylinder Tube,Cylinder Head,Cylinder Spacer,Cylinder Piston,Cylinder Locknut,Cylinder Seal Seal O - Ring O - Ring Seal Kit,Seal Assy,Hyd. Hose Wdmt,Bushing Plate Plate Capsc, M12-P1.75-140MM Gr.8.8 Nut Metric 12MM-P1.75 Gr.8.8 Collar,Hose 22-1-9 QTY. 3 3 1 1 1 1 7 7 2 23 6 2 4 2 2 4 2 6 2 2 2 1 1 1 2 1 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 1 1 1 4 23 1 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION MODEL DFWR1428 RIGHT SIDE LEFT SIDE 22-1-10 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION MODEL DFWR1428 REF. NO. PART NO. 1 2 3 4 5 6 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 3660200 3668425 3690219 3667584 3660119 3667594 3667557 3667552 3637521 3668400 3660247 3660248 3660249 3690277 3690276 3660106 3667504 3666800 3666000 3667505 3666001 3668408 70487 3666700 3660107 3667567 3667568 3667569 3637422 3660209 3630226 3637509 3736800 3736000 3637504 3736001 700728C 70477 3736700 3630100 3637520 3667585 3638403 703516W 3630102 3630101 70631C4 3637508 3737507 3637506 3637505 00765676 61368C8 00755954 00755949 3638406 3630103 3637800 3637600 DESCRIPTION Wdmt,Outer Crosspiece Nut,Self Locking Ring M30 X1.5 Wdmt,Sliding Support Plate,Drawbar Counter Assy,Ratchet Link Plate,Cylinder Support Plate,Sliding Spacer Plate,Sliding Wheel Fork Bushing Washer Wdmt,Pin Wdmt,RH Rear Wheel Support Wdmt,LH Rear Wheel Support Wdmt,LH 2-Whl Section Wdmt,RH 2-Whl Section Assy,Hub Spindle,Weld-On Seal Bearing,Inner Hub,Wheel Bearing,Outer Nut,Spindle Cotter Pin, M4x40 Cap,Hub Assy,Hub & Spindle Bushing Tube,Main Lift Clamp,Chain Bushing Extension Arm Spring Wdmt,LH Wheel Arm Wdmt,RH Wheel Arm Weld-On Spindle Seal, 25 X 52.. Inner Tapered Bearing Set Wheel Hub Outer Tapered Bearing Set Nut, Low Hex Castle M18x1.5 Cotter Pin, M3.2x32 Hub Cap Assy,Hub & Spindle Arm Bushing Pin Washer Roll Pin, M8 X 50 Assy,LH Wheel Assy,RH Wheel Carr Bolt, M10x1.5x25 Gr.4.6 Tine Clamp Tine,7MM Dia Rim Flange Nut Metric 10MM Self-Locking Capsc, Hex M10x1.5x25 Gr.8.8-Ft Lockwasher M10 Nut Metric 10MM-P1.5 Pl Nut, Spherical Cap Hex M16x1.5 Assy,Tire & Wheel Tire, 205/75 SR15 Rim-15 QTY. 1 2 4 1 1 1 8 4 12 2 2 1 1 1 1 2 2 2 2 2 2 2 2 2 2 4 2 14 14 6 6 14 14 14 14 4 4 4 4 4 8 2 14 14 6 6 280 140 560 14 14 280 114 92 88 20 6 6 6 22-1-11 REF. NO. 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 PART NO. 3667421 3667509 3660382 3660391 3660383 3637523 3668409 3697110 70502 2568408 3638400 61056C8 70093C 9313087 3038445 00762395 3668405 3667586 71554C8 3667587 6W235 2558466 3668407 610915C8 701618C 3660213 3660214 3660215 3668414 3660122 3690220 3668625 701512C 3690221 6W238 700219C 3660216 3668601 708119C8 3660100 700139C 3660313 3667199 3660232 3668415 613510C8 701611C 3660316 3660315 70096C 3660314 61081C8 3660394 3660395 3667573 001465 3667424 3660420 118 70093C 119 61057C8 DESCRIPTION Spring Rod,Tie Wdmt,Pin Wdmt,RH Support Wdmt,LH Support Cylinder Pin Fitting,Grease M6 X 1 45dg Cylinder,Hydraulic Cotter Pin, M6.3x36 Grease Zerk, M8 Hairpin Cotter, M3 Capsc, Hex M8x1.25x60 Gr.8.8 Nut, Toplock M8x1.25 Capsc, M16-P2.0 - 40MM Gr.8.8 Nut,Toplock Metric 16-P2.0 Pl5 Capsc, M12-P1.75- 20MM Gr.8.8 Washer,Flat 12 X 40 X 4 Plate,Sliding Fscs Metric 8-P1.25 - 16MM Plate,Linking Capsc, M22 X 2.5 X 50 Gr.10.9 Capsc, M16 X 50 Washer,Flat 12 X 36 X 2.5 Capsc, M16-P2 160MM Pl5 Lockwasher, M22 Wdmt,RH Inner Crosspiece Wdmt,LH Inner Crosspiece Wdmt,Pin Stud,Wheel Hub Assy,Tie Rod - Complete Wdmt,Tie Rod Tube End,Tie Rod Head Flatwasher, M10 Wdmt,Tie Rod Pin Nut, Hex M22 X 2.5 Nut, High Hex M12x1.75 Wdmt,Handle Knob Shcs Metric 12 P1.75 100MM Gr.8.8 Assy,Handle Nut,Low Hex M30 X 3.5 Wdmt,LH 2-Whl Section Cylinder,Hydraulic Wdmt,Pin Yoke,Clevis-Complete Capsc, Hex M8x1.25x30 Gr.8.8-Ft Lockwasher, M8 Wdmt,LH Reinforcement Tube Wdmt,RH Reinforcement Tube Nut, Toplock M14x2 Wdmt,RH 2-Whl Section Capsc, M14-P2.0 - 45MM Gr.8.8 Wdmt,Drawbar Wdmt,RH 2-Whl Section Tube,Lift Grease Fitting,Straight,M6 Spring Kit,Ratchet Link - Complete Nut, Top Lock M8x1.25 Hex Capsc, M8-P1.25 X 65MM Pl5 QTY. 2 2 2 1 1 4 28 2 8 16 2 20 20 56 78 18 14 1 32 4 2 6 4 8 2 1 1 2 10 2 2 2 8 2 2 2 2 2 2 2 4 1 2 2 14 4 4 1 1 24 1 16 1 1 2 2 1 1 4 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 FRONT SECTION MODEL DFWR1428 RIGHT SIDE LEFT SIDE 22-1-12 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 FRONT SECTION MODEL DFWR1428 REF. NO. PART NO. DESCRIPTION QTY. 3 3660397 Wdmt,RH 3-Whl Section 4 3660398 Wdmt,LH 3-Whl Section 5 3667570 Tube,Center Lift 6 3667574 Tube,Front Lift 7 3668415 Yoke,Clevis-Complete 8 3667567 Bushing 9 703611W Pin,Roll 10MM X 32MM 10 3660329 Wdmt,RH Support Tube 11 3660330 Wdmt,LH Support Tube 12 3637521 Wheel Fork Bushing 13 3667516 Plate,Brake Counter 14 3630229 Clutch Bushing Weldment 15 3660223 Wdmt,Brake 16 3637423 Compression Spring 17 3660224 Wdmt,Front Wheel Support 18 3660225 Wdmt,Pin 19 3636003 Bearing,Ball Two Rubber Seals 20 3637526 Wheel Spacer 21 3637527 Wheel Hub 22 3638409 Washer 23 700910C Nut,Toplock M22x2.5 Hex 24 3660108 Assy,Hub 25 3667517 Spacer 26 61895C8 Capsc,Hex M16x1.5x40 Gr.8.8-Ft 27 3638406 Nut, Spherical Cap Hex M16x1.5 28 3637800 Tire, 205/75 SR15 29 3637600 Rim-15 30 3630103 Assy,Tire & Wheel 31 3660267 Wdmt,Tractor Hitch 32 3660235 Wdmt,Hitch Pin 33 3668624 Stand,Parking 34 3638602 Frame Pin 35 3667519 Bushing 36 3660236 Wdmt,Inner Arm 37 3660237 Wdmt,Outer Arm 38 3660238 Wdmt,Pin 39 3637520 Arm Bushing 1 1 4 2 18 6 2 1 1 12 4 4 4 4 4 4 8 4 4 4 4 4 8 20 20 6 6 6 1 1 1 1 4 2 2 6 36 REF. NO. PART NO. 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 3660252 3660227 3630226 3660209 3638403 3668407 00762395 3638400 00772648 61075C8 3630101 3630102 3667569 3668401 610711C8 61056C8 00755934 00765901 3038445 3668409 00756934 2568408 61368C8 00755954 00755949 703516W 3637422 3660326 3690202 3690203 3667576 3667577 61364C8 61053C10 701512C 3690208 61097C8 00775032 22-1-13 DESCRIPTION QTY. Wdmt,Front Drawbar Wdmt.Center Drawbar Wdmt,RH Wheel Arm Wdmt,LH Wheel Arm Washer Washer,Flat 12 X 36 X 2.5 Capsc, M12-P1.75- 20MM Gr.8.8 Hairpin Cotter, M3 Nut Metric 12MM-P1.75 Gr.8.8 Capsc, M12-P1.75-60MM Gr.8.8 Assy,RH Wheel Assy,LH Wheel Clamp,Chain Bushing Washer Capsc, M12 P1.75 90MM Gr.8.8 Capsc, Hex M8x1.25x60 Gr.8.8 Nut Met 8MM-P1.25 Capsc, M16-P2.0 - 45MM Gr.8.8 Nut,Toplock Metric 16-P2.0 Pl5 Fitting,Grease M6 X 1 45dg Pin,Roll 10 X 80 Grease Zerk, M8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft Lockwasher M10 Nut Metric 10MM-P1.5 Pl Pin,Roll Extension Arm Spring Wdmt,Brake Counter Plate Wdmt,RH Front Tube Support Wdmt,LH Front Tube Support Bushing Plug Capsc, Hex M10x1.5x16 Gr.8.8-Ft Capsc, Hex M8x1.25x45 Gr.10.9 Flatwasher, M10 Wdmt,Extension Capsc, Hex M16x2x80 Gr.8.8 Grease Fitting, 8MMx1x45 1 1 7 7 36 7 18 13 25 1 7 7 14 4 4 28 30 56 78 28 4 16 122 80 76 22 14 4 1 1 2 1 4 2 4 2 2 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 CENTER SECTION MODEL DFWR1428 RIGHT SIDE LEFT SIDE 22-1-14 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 CENTER SECTION MODEL DFWR1428 REF. NO. PART NO. DESCRIPTION 1 3660397 Wdmt,RH 3-Whl Section 2 3660398 Wdmt,LH 3-Whl Section 5 3667570 Tube,Center Lift 6 3667574 Tube,Front Lift 7 3667199 Cylinder,Hydraulic 8 3667567 Bushing 9 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 10 3668430 Ring,External Snap 11 3668431 Ring,Internal Elastic 12 3637521 Wheel Fork Bushing 13 3667516 Plate,Brake Counter 14 3630229 Clutch Bushing Weldment 15 3660223 Wdmt,Brake 16 3637423 Compression Spring 17 3660224 Wdmt,Front Wheel Support 18 3660225 Wdmt,Pin 19 3636003 Bearing,Ball Two Rubber Seals 20 3637526 Wheel Spacer 21 3637527 Wheel Hub 22 3638409 Washer 23 700910C Nut, Toplock M22x2.5 Hex 24 3660108 Assy,Hub 25 3667517 Spacer 26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 27 3638406 Nut, Spherical Cap Hex, M16x1.5 28 3637800 Tire, 205/75 SR15 29 3637600 Rim-15 30 3630103 Assy,Tire & Wheel 31 3660267 Wdmt,Tractor Hitch 32 3660235 Wdmt,Hitch Pin 33 3668624 Stand,Parking 34 3638602 Frame Pin 35 3667519 Bushing 36 3660236 Wdmt,Inner Arm 37 3660237 Wdmt,Outer Arm QTY. REF. NO. PART NO. 1 1 2 2 2 4 16 28 28 12 4 4 4 4 4 4 8 4 4 4 4 4 8 20 20 6 6 6 1 1 1 1 2 2 2 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 65 66 67 68 69 70 72 73 74 3660238 3666776 3660252 3660227 3660322 3660323 3667518 3668407 00762395 3638400 00772648 61075C8 3660231 3668405 3667572 3668401 610711C8 61056C8 00755934 00765901 3038445 3668409 00756934 2568408 3660324 610714C8 3660694 3660325 3660396 61081C8 70096C 00755940 3660326 3667577 00775032 22-1-15 DESCRIPTION Wdmt,Pin Bushing,Nylon Wdmt,Front Drawbar Wdmt.Center Drawbar Wdmt,RH Fixed Arm Wdmt,LH Fixed Arm Plate Washer,Flat 12 X 36 X 2.5 Capsc, M12-P1.75- 20MM Gr.8.8 Hairpin Cotter, M3 Nut Metric 12MM-P1.75 Gr.8.8 Capsc, M12-P1.75-60MM Gr.8.8 Wdmt,Pin Washer,Flat 12 X 40 X 4 Bushing Washer Capsc, M12 P1.75 90MM Gr.8.8 Capsc, Hex M8x1.25x60 Gr.8.8 Nut Met 8MM-P1.25 Capsc, M16-P2.0 - 45MM Gr.8.8 Nut,Toplock Metric 16-P2.0 PL5 Fitting,Grease M6 X 1 45dg Pin,Roll 10 X 80 Grease Zerk, M8 Wdmt,RH Reinforcement Tube Capsc, M14-P2.0 -160MM Gr.8.8 Wdmt,Drawbar Wdmt,LH Reinforcement Tube Wdmt,LH 2-Whl Section Capsc, M14-P2.0 - 45MM PL5 Nut, Toplock M14x2 Hex Washer M14 Wdmt,Brake Counter Plate Plug Grease Fitting, 8MMx1x45 QTY. 6 28 1 1 1 1 4 6 18 13 25 1 2 14 14 4 4 20 20 56 78 28 4 16 1 8 1 1 1 16 24 8 4 1 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL HYDRAULIC KIT MODEL DFWR1428 22-1-16 JUNE, 2011 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 HYDRAULIC KIT MODEL DFWR1428 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 3637102 3638408 3667245 3667246 3667208 3668402 3668403 3668404 3667199 3638404 3637100 3667125 3697114 3667109 613313C8 70092C 3667103 3667105 3667203 3667204 3667106 3667107 3667110 3660246 613317C8 3667108 3667205 3697110 3667111 3667112 3667113 3667114 3667115 ---------------------3667116 3667180 3667181 3667182 3667183 3667184 3667185 -----------------------------------3667186 3667244 3660240 3667521 610718C8 00772648 3668433 DESCRIPTION Male Coupling Tip Copper Washer, 1/2 ID Assy,Hose Assy,Hose Assy,Hose Collar,Double Hose Collar,Hose Collar,Hose Cylinder,Hydraulic Copper Washer, 17 X 22 X 1.4 Hydraulic Fitting Line,Hydraulic Fitting,Hydraulic Line Valve,Lock Capsc, M6-P1-40MM Gr.8.8 Nut Met Tln M6-P1 PL5 Line,Hydraulic Fitting,Hydraulic Assy,Hose Assy,Hose Fitting,Hydraulic Fitting,Hydraulic Tee Divider,Flow Wdmt,Plate Capsc, M6-P1 -60MM Gr.8.8 Fitting,Hydraulic Tee Assy,Hose Cylinder,Hydraulic Rod,Cylinder Tube,Cylinder Head,Cylinder Piston,Cylinder Nut,Cylinder Seal O-Ring Seal Kit,Seal Rod,Cylinder Tube,Cylinder Head,Cylinder Spacer,Cylinder Piston,Cylinder Locknut,Cylinder Seal Seal O - Ring O - Ring Seal Kit,Seal Assy,Hyd. Hose Wdmt,Bushing Plate Plate Capsc, M12-P1.75-160MM PL5 Nut Metric 12MM-P1.75 Gr.10.9 Collar,Hose 22-1-17 QTY. 3 3 1 1 1 1 9 9 2 23 6 2 4 2 5 5 2 6 2 2 2 1 1 1 2 1 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 1 1 1 4 25 2 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION MODEL DFWR1631 RIGHT SIDE LEFT SIDE 22-1-18 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION MODEL DFWR1631 REF. NO. PART NO. 1 2 3 4 5 6 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 3660200 3668425 3690219 3667584 3660119 3667594 3667557 3667552 3637521 3668400 3660247 3660248 3660249 3690277 3690276 3660106 3667504 3666800 3666000 3667505 3666001 3668408 70487 3666700 3660107 3667567 3667568 3667569 3637422 3660209 3630226 3637509 3736800 3736000 3637504 3736001 700728C 70477 3736700 3630100 3637520 3667585 3638403 703516W 3630102 3630101 70631C4 3637508 3737507 3637506 3637505 00765676 61368C8 00755954 00755949 3638406 3630103 3637800 3637600 DESCRIPTION Wdmt,Outer Crosspiece Nut,Self Locking Ring M30 X1.5 Wdmt,Sliding Support Plate,Drawbar Counter Assy,Ratchet Link Plate,Cylinder Support Plate,Sliding Spacer Plate,Sliding Wheel Fork Bushing Washer Wdmt,Pin Wdmt,RH Rear Wheel Support Wdmt,LH Rear Wheel Support Wdmt,LH 2-Whl Section Wdmt,RH 2-Whl Section Assy,Hub Spindle,Weld-On Seal Bearing,Inner Hub,Wheel Bearing,Outer Nut,Spindle Cotter Pin, M4x40 Cap,Hub Assy,Hub & Spindle Bushing Tube,Main Lift Clamp,Chain Bushing Extension Arm Spring Wdmt,LH Wheel Arm Wdmt,RH Wheel Arm Weld-On Spindle Seal, 25 X 52.. Inner Tapered Bearing Set Wheel Hub Outer Tapered Bearing Set Nut, Low Hex Castle M18x1.5 Cotter Pin, M3.2x32 Hub Cap Assy,Hub & Spindle Arm Bushing Pin Washer Roll Pin, M8 X 50 Assy,LH Wheel Assy,RH Wheel Carr Bolt, M10x1.5x25 Gr.4.6 Tine Clamp Tine,7MM Dia Rim Flange Nut Metric 10MM Self-Locking Capsc, Hex M10x1.5x25 Gr.8.8-Ft Lockwasher M10 Nut Metric 10MM-P1.5 Pl Nut, Spherical Cap Hex M16x1.5 Assy,Tire & Wheel Tire, 205/75 SR15 Rim-15 QTY. 1 2 4 1 1 1 8 4 12 2 2 1 1 1 1 2 2 2 2 2 2 2 2 2 2 6 2 16 16 7 7 16 16 16 16 4 4 4 4 4 8 2 16 16 7 7 280 160 640 16 16 320 128 104 100 20 6 6 6 22-1-19 REF. NO. 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 PART NO. 3667421 3667509 3660382 3660391 3660383 3637523 3668409 3697110 70502 2568408 3638400 61056C8 70093C 9313087 3038445 00762395 3668405 3667586 71554C8 3667587 6W235 2558466 3668407 610915C8 701618C 3660213 3660214 3660215 3668414 3660122 3690220 3668625 701512C 3690221 6W238 700219C 3660216 3668601 708119C8 3660100 700139C 3660313 3667199 3660232 3668415 613510C8 701611C 3660316 3660315 70096C 3660314 61081C8 3660394 3660395 3667573 001465 3667424 3660420 118 70093C 119 61057C8 DESCRIPTION Spring Rod,Tie Wdmt,Pin Wdmt,RH Support Wdmt,LH Support Cylinder Pin Fitting,Grease M6 X 1 45dg Cylinder,Hydraulic Cotter Pin, M6.3x36 Grease Zerk, M8 Hairpin Cotter, M3 Capsc, Hex M8x1.25x60 Gr.8.8 Nut, Toplock M8x1.25 Capsc, M16-P2.0 - 40MM Gr.8.8 Nut,Toplock Metric 16-P2.0 Pl5 Capsc, M12-P1.75- 20MM Gr.8.8 Washer,Flat 12 X 40 X 4 Plate,Sliding Fscs Metric 8-P1.25 - 16MM Plate,Linking Capsc, M22 X 2.5 X 50 Gr.10.9 Capsc, M16 X 50 Washer,Flat 12 X 36 X 2.5 Capsc, M16-P2 160MM Pl5 Lockwasher, M22 Wdmt,RH Inner Crosspiece Wdmt,LH Inner Crosspiece Wdmt,Pin Stud,Wheel Hub Assy,Tie Rod - Complete Wdmt,Tie Rod Tube End,Tie Rod Head Flatwasher, M10 Wdmt,Tie Rod Pin Nut, Hex M22 X 2.5 Nut, High Hex M12x1.75 Wdmt,Handle Knob Shcs Metric 12 P1.75 100MM Gr.8.8 Assy,Handle Nut,Low Hex M30 X 3.5 Wdmt,LH 2-Whl Section Cylinder,Hydraulic Wdmt,Pin Yoke,Clevis-Complete Capsc, Hex M8x1.25x30 Gr.8.8-Ft Lockwasher, M8 Wdmt,LH Reinforcement Tube Wdmt,RH Reinforcement Tube Nut, Toplock M14x2 Wdmt,RH 2-Whl Section Capsc, M14-P2.0 - 45MM Gr.8.8 Wdmt,Drawbar Wdmt,RH 2-Whl Section Tube,Lift Grease Fitting,Straight,M6 Spring Kit,Ratchet Link - Complete Nut, Top Lock M8x1.25 Hex Capsc, M8-P1.25 X 65MM Pl5 QTY. 2 2 2 1 1 4 32 2 8 16 2 28 28 64 84 18 14 1 32 4 2 6 4 8 2 1 1 2 10 2 2 2 8 2 2 2 2 2 2 2 4 1 2 2 16 4 4 1 1 24 1 16 1 1 2 2 1 1 4 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 FRONT SECTION MODEL DFWR1631 RIGHT SIDE LEFT SIDE 22-1-20 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 FRONT SECTION MODEL DFWR1631 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 3660399 3690200 3660397 3660398 3667570 3667575 3668415 3667567 703611W 3660329 3660330 3637521 3667516 3630229 3660223 3637423 3660224 3660225 3636003 3637526 3637527 3638409 700910C 3660108 3667517 61895C8 3638406 3637800 3637600 3630103 3660267 3660235 3668624 3638602 3667519 3660236 3660237 DESCRIPTION QTY. Wdmt,RH 1-Whl Section Wdmt,LH 1-Whl Section Wdmt,RH 3-Whl Section Wdmt,LH 3-Whl Section Tube,Center Lift Tube,Front Lift Yoke,Clevis-Complete Bushing Pin,Roll 10MM X 32MM Wdmt,RH Support Tube Wdmt,LH Support Tube Wheel Fork Bushing Plate,Brake Counter Clutch Bushing Weldment Wdmt,Brake Compression Spring Wdmt,Front Wheel Support Wdmt,Pin Bearing,Ball Two Rubber Seals Wheel Spacer Wheel Hub Washer Nut,Toplock M22x2.5 Assy,Hub Spacer Capsc, Hex M16x1.5x40 Gr.8.8-Ft Nut, Spherical Cap Hex M16x1.5 Tire, 205/75 SR15 Rim-15 Assy,Tire & Wheel Wdmt,Tractor Hitch Wdmt,Hitch Pin Stand,Parking Frame Pin Bushing Wdmt,Inner Arm Wdmt,Outer Arm 1 1 1 1 4 2 20 8 2 1 1 12 4 4 4 4 4 4 8 4 4 4 4 4 8 20 20 6 6 6 1 1 1 1 4 2 2 REF. NO. PART NO. 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 74 77 3660238 3637520 3660252 3660227 3630226 3660209 3638403 3668407 00762395 3638400 00772648 61075C8 3630101 3630102 3667569 3668401 610711C8 61056C8 00755934 00765901 3038445 3668409 00756934 2568408 61368C8 00755954 00755949 703516W 3637422 3660326 3690202 3690203 3667576 3667577 61364C8 701512C 00775032 22-1-21 DESCRIPTION QTY. Wdmt,Pin Arm Bushing Wdmt,Front Drawbar Wdmt.Center Drawbar Wdmt,RH Wheel Arm Wdmt,LH Wheel Arm Washer Washer,Flat 12 X 36 X 2.5 Capsc, M12-P1.75- 20MM Gr.8.8 Hairpin Cotter, M3 Nut Metric 12MM-P1.75 Gr.8.8 Capsc, M12-P1.75-60MM Gr.8.8 Assy,RH Wheel Assy,LH Wheel Clamp,Chain Bushing Washer Capsc, M12 P1.75 90MM Gr.8.8 Capsc, Hex M8x1.25x60 Gr.8.8 Nut Met 8MM-P1.25 Capsc, M16-P2.0 - 45MM Gr.8.8 Nut,Toplock Metric 16-P2.0 PL5 Fitting,Grease M6 X 1 45dg Pin,Roll 10 X 80 Grease Zerk, M8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft Lockwasher M10 Nut Metric 10MM-P1.5 Pl Pin,Roll Extension Arm Spring Wdmt,Brake Counter Plate Wdmt,RH Front Tube Support Wdmt,LH Front Tube Support Bushing Plug Capsc, Hex M10x1.5x16 Gr.8.8-Ft Flatwasher, M10 Grease Fitting, 8MMx1x45 6 40 1 1 8 8 36 7 18 13 39 1 8 8 16 4 4 36 34 64 82 32 4 16 136 92 88 22 16 4 1 1 2 1 4 4 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 CENTER SECTION MODEL DFWR1631 RIGHT SIDE LEFT SIDE 22-1-22 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 CENTER SECTION MODEL DFWR1631 REF. NO. PART NO. DESCRIPTION 1 3660397 Wdmt,RH 3-Whl Section 2 3660398 Wdmt,LH 3-Whl Section 3 3660399 Wdmt,RH 1-Whl Section 4 3690200 Wdmt,LH 1-Whl Section 5 3667570 Tube,Center Lift 6 3667575 Tube,Front Lift 7 3667199 Cylinder,Hydraulic 8 3667567 Bushing 9 610716C8 Capsc, M12-P1.75-140MM Gr.8.8 10 3668430 Ring,External Snap 11 3668431 Ring,Internal Elastic 12 3637521 Wheel Fork Bushing 13 3667516 Plate,Brake Counter 14 3630229 Clutch Bushing Weldment 15 3660223 Wdmt,Brake 16 3637423 Compression Spring 17 3660224 Wdmt,Front Wheel Support 18 3660225 Wdmt,Pin 19 3636003 Bearing,Ball Two Rubber Seals 20 3637526 Wheel Spacer 21 3637527 Wheel Hub 22 3638409 Washer 23 700910C Nut, Toplock M22x2.5 Hex 24 3660108 Assy,Hub 25 3667517 Spacer 26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 27 3638406 Nut, Spherical Cap Hex, M16x1.5 28 3637800 Tire, 205/75 SR15 29 3637600 Rim-15 30 3630103 Assy,Tire & Wheel 31 3660267 Wdmt,Tractor Hitch 32 3660235 Wdmt,Hitch Pin 33 3668624 Stand,Parking 34 3638602 Frame Pin 35 3667519 Bushing 36 3660236 Wdmt,Inner Arm 37 3660237 Wdmt,Outer Arm QTY. REF. NO. PART NO. 1 1 1 1 2 2 2 6 24 32 32 12 4 4 4 4 4 4 8 4 4 4 4 4 8 20 20 6 6 6 1 1 1 1 2 2 2 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 3660238 3666776 3660252 3660227 3660322 3660323 3667518 3668407 00762395 3638400 00772648 61075C8 3660231 3668405 3667572 3668401 610711C8 61056C8 00755934 00765901 3038445 3668409 00756934 2568408 3660324 610817C8 610714C8 3660394 3660325 3660396 61081C8 70096C 00755940 3690201 3660326 3667577 00775032 22-1-23 DESCRIPTION QTY. Wdmt,Pin Bushing,Nylon Wdmt,Front Drawbar Wdmt.Center Drawbar Wdmt,RH Fixed Arm Wdmt,LH Fixed Arm Plate Washer,Flat 12 X 36 X 2.5 Capsc, M12-P1.75- 20MM Gr.8.8 Hairpin Cotter, M3 Nut Metric 12MM-P1.75 Gr.8.8 Capsc, M12-P1.75-60MM Gr.8.8 Wdmt,Pin Washer,Flat 12 X 40 X 4 Bushing Washer Capsc, M12 P1.75 90MM Gr.8.8 Capsc, Hex M8x1.25x60 Gr.8.8 Nut Met 8MM-P1.25 Capsc, M16-P2.0 - 45MM Gr.8.8 Nut,Toplock Metric 16-P2.0 PL5 Fitting,Grease M6 X 1 45dg Pin,Roll 10 X 80 Grease Zerk, M8 Wdmt,RH Reinforcement Tube Capsc, M14-P2.0 -160MM Gr.8.8 Capsc, Hex M12x1.75x120 Gr.8.8 Wdmt,Drawbar Wdmt,LH Reinforcement Tube Wdmt,LH 2-Whl Section Capsc, M14-P2.0 - 45MM PL5 Nut, Toplock M14x2 Washer M14 Wdmt,Reinforcement Wdmt,Brake Counter Plate Plug Grease Fitting, 8MMx1x45 6 32 1 1 1 1 6 6 18 13 39 1 2 14 16 4 4 28 28 64 84 32 4 16 1 8 6 1 1 1 16 24 8 2 4 1 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL HYDRAULIC KIT MODEL DFWR1631 22-1-24 JUNE, 2011 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 HYDRAULIC KIT MODEL DFWR1631 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 3637102 3638408 3667245 3667246 3667208 3668402 3668403 3668404 3667199 3638404 3637100 3667125 3697114 3667109 613313C8 70092C 3667103 3667105 3667203 3667204 3667106 3667107 3667110 3660246 613317C8 3667108 3667205 3697110 3667111 3667112 3667113 3667114 3667115 ---------------------3667116 3667180 3667181 3667182 3667183 3667184 3667185 -----------------------------------3667186 3667244 3660240 3667521 610718C8 00772648 3668433 DESCRIPTION Male Coupling Tip Copper Washer, 1/2 ID Assy,Hose Assy,Hose Assy,Hose Collar,Double Hose Collar,Hose Collar,Hose Cylinder,Hydraulic Copper Washer, 17 X 22 X 1.4 Hydraulic Fitting Line,Hydraulic Fitting,Hydraulic Line Valve,Lock Capsc, M6-P1-40MM Gr.8.8 Nut Met Tln M6-P1 PL5 Line,Hydraulic Fitting,Hydraulic Assy,Hose Assy,Hose Fitting,Hydraulic Fitting,Hydraulic Tee Divider,Flow Wdmt,Plate Capsc, M6-P1 -60MM Gr.8.8 Fitting,Hydraulic Tee Assy,Hose Cylinder,Hydraulic Rod,Cylinder Tube,Cylinder Head,Cylinder Piston,Cylinder Nut,Cylinder Seal O-Ring Seal Kit,Seal Rod,Cylinder Tube,Cylinder Head,Cylinder Spacer,Cylinder Piston,Cylinder Locknut,Cylinder Seal Seal O - Ring O - Ring Seal Kit,Seal Assy,Hyd. Hose Wdmt,Bushing Plate Plate Capsc, M12-P1.75-160MM PL5 Nut Metric 12MM-P1.75 Gr.10.9 Collar,Hose 22-1-25 QTY. 3 3 1 1 1 1 9 9 2 23 6 2 4 2 5 5 2 6 2 2 2 1 1 1 2 1 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 1 1 1 4 39 2 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 ARTICULATION MODEL DFWR1428, DFWR1631 RIGHT SIDE LEFT SIDE 22-1-26 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 ARTICULATION MODEL DFWR1428, DFWR1631 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 3660252 3660227 3660393 3660322 3660323 3667518 3610401 3660231 3660232 3668405 00762395 2568408 610716C8 00772648 9313087 3038445 3660394 3660255 3660256 701613C 00762462 61379C8 3668407 3637423 3660223 3630229 3667516 00756934 610711C8 3637521 3660257 3668401 3660224 3667517 61895C8 3638406 3660225 3636003 3637526 3637527 3638409 700910C 3660108 3637600 3637800 3630103 3660395 3660259 DESCRIPTION Wdmt,Front Drawbar Wdmt.Center Drawbar Wdmt,Rear Drawbar Wdmt,RH Fixed Arm Wdmt,LH Fixed Arm Plate Kit,Hydraulic Cylinder Wdmt,Pin Wdmt,Pin Washer,Flat 12 X 40 X 4 Capsc, M12-P1.75- 20MM Gr.8.8 Grease Zerk, M8 Capsc, M12-P1.75-140MM Gr.8.8 Nut Metric 12MM-P1.75 Gr.8.8 Capsc, M16-P2.0 - 40MM PL5 Nut,Toplock Metric 16-P2.0 Gr.8.8 Wdmt,Drawbar Wdmt,RH Reinforcement Tube Wdmt,LH Reinforcement Tube Lockwasher, M12 Capsc, M12-P1.75- 25MM PL5 Capsc, Hex M12x1.75x40 Gr.8.8-Ft Washer,Flat 12 X 36 X 2.5 Compression Spring Wdmt,Brake Clutch Bushing Weldment Plate,Brake Counter Pin, Roll 10 X 80 Capsc, M12 P1.75 90MM PL5 Wheel Fork Bushing Wdmt,Support Tube Washer Wdmt,Front Wheel Support Spacer Capsc, Hex M16x1.5x40 Gr.8.8-Ft Nut, Spherical Cap Hex, M16x1.5 Wdmt,Pin Bearing,Ball Two Rubber Seals Wheel Spacer Wheel Hub Washer Nut, Toplock M22x2.5 Hex Assy,Hub Rim-15 Tire, 205/75 SR15 Assy,Tire & Wheel Wdmt,RH 2-Whl Section Wdmt,LH 2-Whl Section 22-1-27 QTY. 1 1 1 1 1 6 2 2 2 2 4 6 24 34 24 24 1 1 1 8 8 8 2 2 2 2 2 2 2 4 2 2 2 4 10 10 2 4 2 2 2 2 2 2 2 2 1 1 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL WHEEL & ARM ASSEMBLY MODELS DFWR1428, DFWR1631 22-1-28 JUNE, 2011 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 WHEEL & ARM ASSEMBLY MODELS DFWR1428, DFWR1631 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 3660395 3660259 3660260 3660261 2568408 3667524 3667506 3667508 3637422 3668409 3637520 3638403 703516W 3637509 3736800 3736000 3637504 3736001 700728C 70477 3736700 3630100 3660209 3630226 61368C8 00755954 00755949 70631C4 3637508 3737507 3637506 3637505 00765676 3630102 3630101 61054C8 70093C 61379C8 00772648 3638400 9313087 3038445 DESCRIPTION QTY. Wdmt,RH 2-Whl Section 1 Wdmt,LH 2-Whl Section 1 Wdmt,RH Reinforcement Tube 1 Wdmt,LH Reinforcement Tube 1 Grease Zerk, M8 2 Tube,Lift 2 Bushing 2 Clamp,Chain Bushing 4 Extension Arm Spring 4 Fitting,Grease M6 X 1 45dg 4 Arm Bushing 8 Washer 4 Roll Pin, M8 X 50 4 Weld-On Spindle 4 Seal, 25 X 52.. 4 Inner Tapered Bearing Set 4 Wheel Hub 4 Outer Tapered Bearing Set 4 Nut, Low Hex Castle M18x1.5 4 Cotter Pin, M3.2x32 4 Hub Cap 4 Assy,Hub & Spindle 4 Wdmt,LH Wheel Arm 2 Wdmt,RH Wheel Arm 2 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 28 Lockwasher M10 24 Nut Metric 10MM-P1.5 PL 24 Carr Bolt, M10x1.5x25 Gr.4.6 80 Tine Clamp 40 Tine, 7MM Dia. 160 Rim 4 Flange 4 Nut Metric 10MM Self-Locking 80 Assy,LH Wheel 2 Assy,RH Wheel 2 Capsc, Hex M8x1.25x50 Gr.8.8 8 Nut, Toplock M8x1.25 8 Capsc, Hex M12x1.75x40 Gr.8.8-Ft 16 Nut Metric 12MM-P1.75 Gr.10.9 16 Hairpin Cotter, M3 4 Capsc, M16-P2.0 - 40MM Gr.8.8 8 Nut,Toplock Metric 16-P2.0 PL5 8 22-1-29 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION MODEL DFWR1833 RIGHT SIDE LEFT SIDE 22-1-30 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION MODEL DFWR1833 REF. NO. PART NO. 1 2 3 4 5 6 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 3660200 3668425 3667501 3667584 3660119 3667594 3667557 3667552 3637521 3668400 3660247 3660248 3660249 3690277 3690276 3660106 3667504 3666800 3666000 3667505 3666001 3668408 70487 3666700 3660107 3667567 3667568 3667569 3637422 3660209 3630226 3637509 3736800 3736000 3637504 3736001 700728C 70477 3736700 3630100 3637520 3667585 3638403 703516W 3630102 3630101 70631C4 3637508 3737507 3637506 3637505 00765676 61368C8 00755954 00755949 3638406 3630103 3637800 3637600 DESCRIPTION Wdmt,Outer Crosspiece Nut,Self Locking Ring M30 X1.5 Bar, Angle Plate,Drawbar Counter Assy,Ratchet Link Plate,Cylinder Support Plate,Sliding Spacer Plate,Sliding Wheel Fork Bushing Washer Wdmt,Pin Wdmt,RH Rear Wheel Support Wdmt,LH Rear Wheel Support Wdmt,LH 2-Whl Section Wdmt,RH 2-Whl Section Assy,Hub Spindle,Weld-On Seal Bearing,Inner Hub,Wheel Bearing,Outer Nut,Spindle Cotter Pin, M4x40 Cap,Hub Assy,Hub & Spindle Bushing Tube,Main Lift Clamp,Chain Bushing Extension Arm Spring Wdmt,LH Wheel Arm Wdmt,RH Wheel Arm Weld-On Spindle Seal, 25 X 52.. Inner Tapered Bearing Set Wheel Hub Outer Tapered Bearing Set Nut, Low Hex Castle M18x1.5 Cotter Pin, M3.2x32 Hub Cap Assy,Hub & Spindle Arm Bushing Pin Washer Roll Pin, M8 X 50 Assy,LH Wheel Assy,RH Wheel Carr Bolt, M10x1.5x25 Gr.4.6 Tine Clamp Tine,7MM Dia Rim Flange Nut Metric 10MM Self-Locking Capsc, Hex M10x1.5x25 Gr.8.8-Ft Lockwasher M10 Nut Metric 10MM-P1.5 Pl Nut, Spherical Cap Hex M16x1.5 Assy,Tire & Wheel Tire, 205/75 SR15 Rim-15 QTY. 1 2 4 1 1 1 8 4 12 2 2 1 1 1 1 2 2 2 2 2 2 2 2 2 2 4 2 18 18 9 9 18 18 18 18 18 18 18 18 18 36 2 36 18 9 9 360 180 720 18 18 360 134 104 100 30 6 6 6 22-1-31 REF. NO. 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 PART NO. 3667421 3667509 3660382 3660391 3660383 3637523 3668409 3697110 70502 2568408 3638400 61056C8 70093C 00765901 3038445 00762395 3668405 3667586 71554C8 3667587 6W235 2558466 3668407 610915C8 701618C 3660213 3660214 3660215 3668414 3660122 3690220 3668625 701512C 3690221 6W238 700219C 3660216 3668601 708119C8 3660100 700139C 3660393 3667199 3660232 3668415 613510C8 701611C 3660316 3660315 70096C 3660396 61081C8 3660394 3660395 3667573 001465 3667424 3660420 118 70093C 119 61057C8 DESCRIPTION Spring Rod,Tie Wdmt,Pin Wdmt,RH Support Wdmt,LH Support Cylinder Pin Fitting,Grease M6 X 1 45dg Cylinder,Hydraulic Cotter Pin, M6.3x36 Grease Zerk, M8 Hairpin Cotter, M3 Capsc, Hex M8x1.25x60 Gr.8.8 Nut, Toplock M8x1.25 Capsc, M16-P2.0 - 45MM Gr.8.8 Nut,Toplock Metric 16-P2.0 Pl5 Capsc, M12-P1.75- 20MM Gr.8.8 Washer,Flat 12 X 40 X 4 Plate,Sliding Fscs Metric 8-P1.25 - 16MM Plate,Linking Capsc, M22 X 2.5 X 50 Gr.10.9 Capsc, M16 X 50 Washer,Flat 12 X 36 X 2.5 Capsc, M16-P2 160MM Pl5 Lockwasher, M22 Wdmt,RH Inner Crosspiece Wdmt,LH Inner Crosspiece Wdmt,Pin Stud,Wheel Hub Assy,Tie Rod - Complete Wdmt,Tie Rod Tube End,Tie Rod Head Flatwasher, M10 Wdmt,Tie Rod Pin Nut, Hex M22 X 2.5 Nut, High Hex M12x1.75 Wdmt,Handle Knob Shcs Metric 12 P1.75 100MM Gr.8.8 Assy,Handle Nut,Low Hex M30 X 3.5 Wdmt,Rear Drawbar Cylinder,Hydraulic Wdmt,Pin Yoke,Clevis-Complete Capsc, Hex M8x1.25x30 Gr.8.8-Ft Lockwasher, M8 Wdmt,LH Reinforcement Tube Wdmt,RH Reinforcement Tube Nut, Toplock M14x2 Wdmt,LH 2-Whl Section Capsc, M14-P2.0 - 45MM Gr.8.8 Wdmt,Drawbar Wdmt,RH 2-Whl Section Tube,Lift Grease Fitting,Straight,M6 Spring Kit,Ratchet Link - Complete Nut, Top Lock M8x1.25 Hex Capsc, M8-P1.25 X 65MM Pl5 QTY. 2 2 2 1 1 4 36 2 8 16 13 28 30 56 78 18 14 8 32 4 2 6 2 16 2 1 1 2 10 2 2 2 8 2 2 2 2 2 2 2 2 1 2 2 18 4 4 1 1 24 1 16 28 1 4 2 1 1 4 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 FRONT SECTION MODEL DFWR1833 RIGHT SIDE LEFT SIDE 22-1-32 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 FRONT SECTION MODEL DFWR1833 REF. NO. PART NO. DESCRIPTION 3 3690204 Wdmt,RH 2-Whl Section 4 3690205 Wdmt,LH 2-Whl Section 5 3667524 Tube,Lift 6 3667574 Tube,Front Lift 7 3668415 Yoke,Clevis-Complete 8 3667567 Bushing 9 3667533 Bushing 10 3660329 Wdmt,RH Support Tube 11 3660330 Wdmt,LH Support Tube 12 3637521 Wheel Fork Bushing 13 3667516 Plate,Brake Counter 14 3630229 Clutch Bushing Weldment 15 3660223 Wdmt,Brake 16 3637423 Compression Spring 17 3660224 Wdmt,Front Wheel Support 18 3660225 Wdmt,Pin 19 3636003 Bearing,Ball Two Rubber Seals 20 3637526 Wheel Spacer 21 3637527 Wheel Hub 22 3638409 Washer 23 700910C Nut, Toplock M22x2.5 24 3660108 Assy,Hub 25 3667517 Spacer 26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 27 3638406 Nut, Spherical Cap Hex, M16x1.5 28 3637800 Tire, 205/75 SR15 29 3637600 Rim-15 30 3630103 Assy,Tire & Wheel 31 3660267 Wdmt,Tractor Hitch 32 3660235 Wdmt,Hitch Pin 33 3668624 Stand,Parking 34 3638602 Frame Pin 35 3667519 Bushing 36 3660236 Wdmt,Inner Arm 37 3660237 Wdmt,Outer Arm 38 3660238 Wdmt,Pin 39 3637520 Arm Bushing 40 3660252 Wdmt,Front Drawbar 41 3660227 Wdmt.Center Drawbar REF. QTY. NO. 1 1 4 2 18 6 2 1 1 12 4 4 4 4 4 4 8 4 4 4 4 4 8 20 20 6 6 6 1 1 1 1 4 2 2 6 36 1 1 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 22-1-33 PART NO. 3630226 3660209 3638403 3668407 00762395 3638400 00772648 61075C8 3630101 3630102 3667569 3668401 610711C8 61056C8 70093C 00765901 3038445 3668409 00756934 2568408 61368C8 00755954 00755949 703516W 3637422 3660326 61097C8 3690208 3667578 3667577 3690202 3690203 61364C8 61053C10 701512C 00775032 3690207 610716C8 3667518 DESCRIPTION QTY. Wdmt,RH Wheel Arm 18 Wdmt,LH Wheel Arm 18 Washer 36 Washer,Flat 12 X 36 X 2.5 7 Capsc, M12-P1.75- 20MM Gr.8.8 18 Hairpin Cotter, M3 13 Nut Metric 12MM-P1.75 Gr.8.8 45 Capsc, M12-P1.75-60MM Gr.8.8 1 Assy,RH Wheel 9 Assy,LH Wheel 9 Clamp,Chain Bushing 18 Washer 4 Capsc, M12 P1.75 90MM Gr.8.8 4 Capsc, Hex M8x1.25x60 Gr.8.8 28 Nut,Toplock M8x1.25 Hex 30 Capsc, M16-P2.0 - 45MM PL5 56 Nut,Toplock Metric 16-P2.0 Gr.8.8 76 Fitting,Grease M6 X 1 45dg 36 Pin,Roll 10 X 80 2 Grease Zerk, M8 16 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 142 Lockwasher M10 104 Nut Metric 10MM-P1.5 PL 100 Roll Pin, M8 X 50 22 Extension Arm Spring 18 Wdmt,Brake Counter Plate 4 Capsc, Hex M16x2x80 Gr.8.8 2 Wdmt,Extension 2 Bushing 2 Plug 1 Wdmt,RH Front Tube Support 1 Wdmt,LH Front Tube Support 1 Capsc, Hex M10x1.5x16 Gr.8.8-Ft 4 Capsc, Hex M8x1.25x45 Gr.10.9 2 Flatwasher, M10 4 Grease Fitting, 8MMx1x45 4 Wdmt,Reinforcement 2 Capsc, M12-P1.75-140MM Gr.8.8 32 Plate 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 CENTER SECTION MODEL DFWR1833 RIGHT SIDE LEFT SIDE 22-1-34 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 CENTER SECTION MODEL DFWR1833 REF. NO. PART NO. DESCRIPTION QTY. REF. NO. PART NO. 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 3660252 3690206 3660322 3660323 3667518 3668407 00762395 3638400 00772648 00765672 3660231 3668405 3637520 3668401 610711C8 61056C8 70093C 00765901 3038445 3668409 00756934 2568408 3660324 3660325 610714C8 3660393 3660395 3660396 61081C8 70096C 00755940 3638403 703516W 3660326 3668430 3668431 3666776 3667572 3690207 00775032 1 3660397 Wdmt,RH 3-Whl Section 1 2 3660398 Wdmt,LH 3-Whl Section 1 3 3690204 Wdmt,RH 2-Whl Section 1 4 3690205 Wdmt,LH 2-Whl Section 1 5 3667570 Tube,Center Lift 2 6 3667573 Tube,Lift 4 7 3667199 Cylinder,Hydraulic 2 8 3667567 Bushing 6 9 610716C8 Capsc, M12-P1.75-140MM PL5 32 10 3630226 Wdmt,RH Wheel Arm 9 11 3660209 Wdmt,LH Wheel Arm 9 12 3637521 Wheel Fork Bushing 12 13 3667516 Plate,Brake Counter 4 14 3630229 Clutch Bushing Weldment 4 15 3660223 Wdmt,Brake 4 16 3637423 Compression Spring 4 17 3660224 Wdmt,Front Wheel Support 4 18 3660225 Wdmt,Pin 4 19 3636003 Bearing,Ball Two Rubber Seals 8 20 3637526 Wheel Spacer 4 21 3637527 Wheel Hub 4 22 3638409 Washer 4 23 700910C Nut, Toplock M22x2.5 4 24 3660108 Assy,Hub 4 25 3667517 Spacer 8 26 61895C8 Capsc, Hex M16x1.5x40 Gr.8.8-Ft 20 27 3638406 Nut, Spherical Cap Hex, M16x1.5 20 28 3637800 Tire, 205/75 SR15 6 29 3637600 Rim-15 6 30 3630103 Assy,Tire & Wheel 6 31 3660227 Wdmt.Center Drawbar 1 32 3630101 Assy,RH Wheel 9 33 3630102 Assy,LH Wheel 9 34 3637422 Extension Arm Spring 18 35 3668415 Yoke,Clevis-Complete 18 36 61368C8 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 142 37 00755954 Lockwasher M10 104 38 00755949 Nut Metric 10MM-P1.5 PL 100 39 3667569 Clamp,Chain Bushing 18 22-1-35 DESCRIPTION QTY. Wdmt,Front Drawbar Wdmt,Drawbar Wdmt,RH Fixed Arm Wdmt,LH Fixed Arm Plate Washer,Flat 12 X 36 X 2.5 Capsc, M12-P1.75- 20MM PL5 Hairpin Cotter, M3 Nut Metric 12MM-P1.75 Gr.8.8 Capsc, M14-P2.0-35MM Gr.8.8 Wdmt,Pin Washer,Flat 12 X 40 X 4 Arm Bushing Washer Capsc, M12 P1.75 90MM Gr.8.8 Capsc, Hex M8x1.25x60 Gr.8.8 Nut, Toplock M8x1.25 Hex Capsc, M16-P2.0 - 45MM Gr.8.8 Nut,Toplock Metric 16-P2.0 PL5 Fitting,Grease M6 X 1 45dg Pin,Roll 10 X 80 Grease Zerk, M8 Wdmt,RH Reinforcement Tube Wdmt,LH Reinforcement Tube Capsc, Hex M12x1.75x120 Gr.8.8 Wdmt,Rear Drawbar Wdmt,RH 2-Whl Section Wdmt,LH 2-Whl Section Capsc, M14-P2.0 - 45MM PL5 Nut, Toplock M14x2 Hex Washer M14 Washer Roll Pin, M8 X 50 Wdmt,Brake Counter Plate Ring,External Snap Ring,Internal Elastic Bushing,Nylon Bushing Wdmt,Reinforcement Grease Fitting, 8MMx1x45 1 1 1 1 4 7 18 13 45 8 2 2 36 4 4 28 30 56 78 36 4 16 1 1 6 1 1 1 16 24 8 36 22 2 36 36 36 18 2 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL HYDRAULIC KIT MODEL DFWR1833 22-1-36 JUNE, 2011 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 HYDRAULIC KIT MODEL DFWR1833 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 3637102 3638408 3667225 3667226 3667221 3668402 3668403 3668404 3667199 3638404 3637100 3667125 3697114 3667109 613313C8 70092C 3667103 3667105 3667203 3667204 3667106 3667107 3667110 3660246 613317C8 3667108 3667205 3697110 3667111 3667112 3667113 3667114 3667115 ---------------------3667116 3667180 3667181 3667182 3667183 3667184 3667185 -----------------------------------3667186 3667227 3660240 3667521 610718C8 00772648 3668433 DESCRIPTION Male Coupling Tip Copper Washer, 1/2 ID Assy,Hose Assy,Hose Assy,Hose Collar,Double Hose Collar,Hose Collar,Hose Cylinder,Hydraulic Copper Washer, 17 X 22 X 1.4 Hydraulic Fitting Line,Hydraulic Fitting,Hydraulic Line Valve,Lock Capsc, M6-P1-40MM Gr.8.8 Nut Met Tln M6-P1 PL5 Line,Hydraulic Fitting,Hydraulic Assy,Hose Assy,Hose Fitting,Hydraulic Fitting,Hydraulic Tee Divider,Flow Wdmt,Plate Capsc, M6-P1 -60MM Gr.8.8 Fitting,Hydraulic Tee Assy,Hose Cylinder,Hydraulic Rod,Cylinder Tube,Cylinder Head,Cylinder Piston,Cylinder Nut,Cylinder Seal O-Ring Seal Kit,Seal Rod,Cylinder Tube,Cylinder Head,Cylinder Spacer,Cylinder Piston,Cylinder Locknut,Cylinder Seal Seal O - Ring O - Ring Seal Kit,Seal Assy,Hyd. Hose Wdmt,Bushing Plate Plate Capsc, M12-P1.75-160MM PL5 Nut Metric 12MM-P1.75 Gr.10.9 Collar,Hose 22-1-37 QTY. 3 3 1 1 1 1 10 11 2 23 6 2 4 2 2 5 2 6 2 2 2 1 1 1 2 1 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 1 1 1 4 4 2 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR SECTION HYDRAULIC CYLINDER REPAIR KIT MODELS DFWR1428, DFWR1631, DFWR1833 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 3667199 3667180 3667181 3667185 3667184 --------------3667183 3667182 -------------------3667186 22-1-38 DESCRIPTION Cylinder,Hydraulic Rod,Cylinder Tube,Cylinder Locknut,Cylinder M30 X 2 Piston,Cylinder Piston Seal Piston O-Ring Spacer,Cylinder Head,Cylinder Rod Wiper Rod Seal Head O-Ring Kit,Seal QTY. 1 1 1 1 2 1 1 1 1 1 1 1 1 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 KIT, HOSE CONVERSION (OPTION) MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 REF. NO. PART NO. 1 2 3 4 5 6 3638404 3667143 3667248 3668626 3667108 3667247 3667244 3667250 3667242 3667230 3668424 3668424 3668424 707815C8 707815C8 707815C8 3638408 3637102 3690279 3697541 3697542 3697543 00754091 70093C 613314C8 70092C 7 8 9 10 11 12 13 14 15 16 17 18 19 DESCRIPTION Copper Washer, 17 X 22 X 1.4 Fitting,Hydraulic Assy,Hyd. Hose Wrap,Hose Tie Fitting,Hydraulic Tee Assy,Hyd. Hose 3600MM - 141 3/4" (DFWR1225) Assy,Hyd. Hose 6000MM - 238 1/4" (DFWR1428/DFWR1631) Assy,Hyd. Hose 7720MM - 304" (DFWR1833) Assy,Hyd. Hose 4960MM - 195 1/4" (DFWR1225,DFWR1833) Assy,Hyd. Hose 5360MM - 211" (DFWR1428/DFWR1631) Collar,Hose (DFWR1225) Collar,Hose (DFWR1428/DFWR1631) Collar,Hose (DFWR1833) Shcs Metric 6P-1.0 - 90MM PL5 (DFWR1225) Shcs Metric 6P-1.0 - 90MM PL5 (DFWR1428/DFWR1631) Shcs Metric 6P-1.0 - 90MM PL5 (DFWR1833) Copper Washer, 1/2 ID Male Coupling Tip Wdmt,Cylinder Lock Shim,Cylinder Lock - Nylon Shim,Cylinder Lock - Nylon Shim,Cylinder Lock Capsc, M8-P1.25- 70MM 8 Nut, Toplock M8x1.25 Hex Capsc, M6-P1 -45MM PL5 Nut Met Tln M6-P1 PL5 22-1-39 QTY. 2 2 2 10 1 1 1 1 1 1 12 15 20 12 16 20 1 1 2 4 4 2 2 2 2 1 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 HYDRAULIC LIFT CENTER WHEEL KIT (OPTION) MODELS DFWR1225, DFWR1428, DFWR1631 22-1-40 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 HYDRAULIC LIFT CENTER WHEEL KIT (OPTION) MODELS DFWR1225, DFWR1428, DFWR1631 REF. NO. PART NO. 1 3668424 2 707824C8 707815C8 3 3667523 4 00765676 5 3637505 6 3637508 7 3667522 8 70631C4 9 3660103 10 00755949 11 00755954 12 3667599 13 610716C8 14 3667141 15 701513C 16 00772648 17 3668415 18 703415W 19 701615C 20 3668418 21 3660292 22 3668614 23 00772648 24 3667529 25 3668419 26 3638400 27 3666252 28 3660109 29 3736700 30 700728C 31 3736001 32 3637504 33 3736000 DESCRIPTION REF. QTY. NO. Collar,Hose 4 Shcs Metric 6P-1.0 - 125MM Gr.8.8 4 Shcs Metric 6P-1.0 - 60MM Gr.8.8 4 Rim 2 Nut Metric 10MM Self-Locking 40 Flange 2 Tine Clamp 20 Tine,Center Wheel 80 Carr Bolt, M10x1.5x25 Gr.4.6 40 Assy,LH Wheel 1 Nut Metric 10MM-P1.5 PL 12 Lockwasher M10 12 Block,Wheel Support Hitch 1 Capsc, M12-P1.75-140MM Gr.8.8 4 Cylinder,Hydraulic Lift 1 Flatwasher, M12 12 Nut Metric 12MM-P1.75 Gr.8.8 12 Yoke,Clevis-Complete 6 Pin,Roll 6MMx45MM 2 Lockwasher, M16 2 U-Bolt 6 Wdmt,Pulley Bracket 1 Pulley 2 Nut Metric 12MM-P1.75 Gr.8.8 2 Bushing 2 Bolt W/Hole M12 X 70 Gr.8.8 2 Hairpin Cotter, M3 2 Chain 2 Assy,Hub 2 Hub Cap 2 Nut, Low Hex Castle M18x1.5 2 Outer Tapered Bearing Set 2 Wheel Hub 2 Inner Tapered Bearing Set 2 PART NO. 34 3736800 35 70477 36 3660245 37 61368C8 38 3660293 39 701516C 40 61107C8 41 3660294 42 70098C 43 3637520 44 61075C8 45 700219C 46 3638403 47 703516W 48 3667422 49 3667415 50 3667416 51 3660295 52 3690209 53 3660297 54 3660298 55 3660299 56 3660102 57 701613C 58 3668409 59 3667107 60 3667241 61 3667105 62 3638404 63 61377C8 64 00762462 65 3667588 66 3667589 67 708317C8 22-1-41 DESCRIPTION QTY. Seal, 25 X 52.. 2 Cotter Pin, M3.2x32 2 Wdmt,Spindle 2 Capsc, Hex M10x1.5x25 Gr.8.8-Ft 12 Wdmt,Arm 1 Flatwasher M18 PL 2 Capsc, M18-P2.5 100MM Gr.8.8 2 Wdmt,Bracket 1 Nut, Toplock M18x2.5 Hex 2 Arm Bushing 4 Capsc, M12-P1.75-60MM Gr.8.8 2 Nut, High Hex M12x1.75 2 Washer 2 Roll Pin, M8 X 50 2 Spring,Extension 2 Cable,Lift 1 Cable,Lift 1 Wmdt,Arm 1 Wdmt,Bracket 1 Wdmt,Bracket 1 Wdmt,Bracket 1 Wdmt,Pulley Bracket 1 Assy,RH Wheel 1 Lockwasher, M12 4 Fitting,Grease M6 X 1 45dg 2 Fitting,Hydraulic Tee 1 Asy,Hyd. Hose 1 Fitting,Hydraulic 1 Copper Washer, 17 X 22 X 1.4 1 Capsc, Hex M12x1.75x30 Gr.8.8-Ft 2 Capsc, M12-P1.75- 25MM PL5 8 Plate 1 Plate 1 Shcs Metric 16-P2.0 -110MM Gr.8.8 2 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 CENTER WHEEL LIFT CYLINDER (OPTION) MODELS DFWR1225, DFWR1428, DFWR1631 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 3667148 3667149 3667150 3667114 3667115 -------------------------3667142 3667141 DESCRIPTION Rod,Cylinder Tube,Cylinder Head,Cylinder Piston,Cylinder Nut,Cylinder M18 X 1.5 Seal Seal Seal Seal Seal Kit,Seal Cylinder,Hydraulic Lift 22-1-42 QTY. 1 1 1 1 1 1 1 1 1 1 1 1 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR HYDRAULIC KIT (OPTION)-(TO OPEN ONE SIDE ONLY) MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 REF. NO. PART NO. 5 6 8 9 10 12 13 14 15 3637100 3638404 3667144 3697109 3667350 3667593 707820C8 70092C 3667351 DESCRIPTION Fitting,Hydraulic Copper Washer, 17 X 22 X 1.4 Fitting,Hydraulic Fitting,Hydraulic Valve,Ball - Shut Off Plate,Hydraulic Block Shcs, M6-P1.0 - 90MM Nut Met Tln M6-P1 PL5 Valve, Ball (Not Shown) 22-1-43 QTY. 4 12 2 4 4 1 2 2 1 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL REAR HYDRAULIC OPENING KIT (OPTION) MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 22-1-44 JUNE, 2011 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 REAR HYDRAULIC OPENING KIT (OPTION) MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 3667193 3638404 3667169 3697114 3667109 3637100 3667170 3667171 ------------------------------------3667194 3667195 3667196 3667197 3667105 3667236 3667255 3667238 3668424 707820C8 3638408 3667105 3667239 3667240 3667108 3668425 61358C8 701511C 70092C 3660370 3660371 3667110 613317C8 70788C8 3667578 02965816 3038445 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 DESCRIPTION QTY. Cylinder,Hydraulic Copper Washer, 17 X 22 X 1.4 Line,Hydraulic Fitting,Hydraulic Line Valve,Lock Hydraulic Fitting Tube,Cylinder Rod,Cylinder Seal O-Ring O-Ring O-Ring Seal Head,Cylinder Piston,Cylinder Locknut Cylinder Kit,Seal Fitting,Hydraulic Assy,Hose (DFWR1225) Assy,Hose (DFWR1428 & DFWR1631) Assy,Hose (DFWR1833) Collar,Hose Shcs Metric 6P-1.0 - 90MM Gr.8.8 Copper Washer, 1/2 ID Fitting,Hydraulic Assy,Hose Assy,Hose Fitting,Hydraulic Tee Nut,Self Locking Ring M30 X1.5 Capsc, Hex M8x1.25x25 Gr.8.8-Ft Flatwasher, M8 Nut Met Tln M6-P1 PL5 Wdmt,Cylinder Support Wdmt,Hose Support Divider,Flow Capsc, M6-P1 -60MM Gr.8.8 Shcs Metric 6 X 1.0 X 25 Gr.8.8 Bar, Cylinder Capsc, M16-P2.0-70MM Gr.8.8 Nut, Toplock M16-P2.0 PL4 22-1-45 2 21 4 4 2 6 1 2 2 2 2 2 2 2 2 2 2 5 2 2 2 26 14 2 2 2 2 1 1 4 4 2 1 1 1 2 2 1 4 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL RATCHET LINK ASSEMBLY (STANDARD) MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 22-1-46 JUNE, 2011 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 RATCHET LINK ASSEMBLY (STANDARD) MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 REF. NO. PART NO. 1 2 3 4 5 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 3660120 3668700 3667558 3660372 3667423 00755934 70502 3637523 3660378 3667559 3668701 3660375 3667560 3667561 613510C8 3667566 3666775 3667563 70345 70038C 3660379 001465 613510C8 701611C 61383C8 61339C8 613113C8 3667564 70092C 701614C DESCRIPTION Assy,Ratchet Link Cover,Lever Lever,Ratchet Wdmt,Ratchet Tube Spring,Hook Nut Met 8MM-P1.25 Cotter Pin, M6.3x36 Cylinder Pin Wdmt,RH Ratchet Screw Ring,Clamp Cover,Shield Wdmt,RH Locking Tab Plate,Lever Support Plate,Locking Hook Capsc, Hex M8x1.25x30 Gr.8.8-Ft Support,Ratchet Tube Bushing,Nylon Collar,Lock Pin,Roll Nut,Metric TLE Wdmt,LH Ratchet Screw Grease Fitting,Straight,M6 Capsc, Hex M8x1.25x30 Gr.8.8-Ft Lockwasher, M8 Capsc, M14-P2.0 - 25MM Capsc, Hex M6x1x25 Gr.8.8-Ft Hexb Metric Bushing Nut Met TLN M6-P1 PL5 Lockwasher, M14 22-1-47 QTY. 1 1 1 1 1 2 4 2 1 2 2 1 2 1 2 2 2 2 4 3 1 2 2 2 4 1 3 3 1 4 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL LIGHT KIT MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 22-1-48 JUNE, 2011 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 LIGHT KIT MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 9161600 19100BH 9131200 1160806 15918BH 00776031 15608 03200347 1458392 1458398 2467909 3660353 3661600 3668426 3831611 15608 2438621 33105C 370013C 2417903 02816800 2467900 2467910 2467901 2467903 50021775 4140606 44520BH 3661880 DESCRIPTION QTY. Locknut 1/2 Gr C Cp Capsc, 3/8-16 X 3/4 Gr.5 Zp Locknut 3/8 Grc Cp Capsc, 1/4 X 3/4 G5 Z Flatwasher 1/4 Zp Canister, Parts Manual Locknut 1/4 Gr C Cp Emblem, SMV Decal,Red Reflector Decal,Orange Reflector Harness,Main Wiring - 35’ Wdmt,SMV Bracket Bracket,Light Support U-Bolt,1/2-13x3-15/16x5-7/16 Bracket,Light Housing Locknut 1/4 Gr C Cp Spade Bracket,SMV Mounting Hex Jam Nut 1/2-20 Int Tooth Lockwasher 1/2 Assy,8 Ground Wire Nut 1/2 NF Hex Assy,Dual Signal Lamp Harness,Wishbone - 10' Assy,Dual Signal Lamp Holder,7-Way Connector Plug Capsc, M16 X 2P X 60MM Gr 10.9 Phlp Screw Pn Hd 10-24 X 3/4 Locknut #10 Cp Plate,Socket Mount 22-1-49 8 4 4 2 4 1 2 1 2 2 1 1 1 4 2 2 1 4 4 4 4 2 1 1 1 2 2 2 1 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 DECALS - BUSH HOG MARKING MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 FRONT SECTION REAR SECTION 22-1-50 BUSH HOG/MATERIAL HANDLING REPAIR PARTS MANUAL JUNE, 2011 DECALS - BUSH HOG MARKING MODELS DFWR1225, DFWR1428, DFWR1631, DFWR1833 REF. NO. PART NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 18 00725746 999001 00786980 00763977 50058089 5W119 03200347 02962765 52740 3668308 1458392 1458393 1458398 999200 50068845 2458315 00776031 DESCRIPTION Decal, Peligro Decal, Warning - Tractor Weight Decal, Genuine Bush Hog Parts Decal, Important-Notice To Owner Decal, Bush Hog 11.00" Decal, Warning Speed Restriction Emblem, SMV Decal, Multiple Hazard Decal, Warning, Oil Leak Decal, Warning Transport Decal, Red Reflector Decal, Yellow Reflector Decal, Orange Reflector Decal, General Warning - All Unit Decal, Model DFWR Decal, Warning Stored Energy Canister, Parts Manual Note: For item 8, add 2 for model DFWR1631 and 4 for model DFWR1833 22-1-51 QTY. 1 1 1 1 4 1 1 10 5 2 4 6 2 1 2 2 1