Transcript
Carefree®
CFR-12V29-S10
S P E C I F I C AT I O N S C F R - 1 2 V 2 9 - S 1 0 Nominal Open Circuit Voltage ............................12.7V Nominal Working Voltage .................................. 11.9V Nominal Capacity at 77°F (25°C) Voltage readings are per cell 20 Hour Rate (1.45 amps to 1.75 volts)........ 29.0 ampere hours 10 Hour Rate (2.70 amps to 1.75 volts)........ 27.0 ampere hours 5 Hour Rate (4.80 amps to 1.75 volts)........ 24.0 ampere hours 1 Hour Rate (17.00 amps to 1.6 volts)........ 17.0 ampere hours 1/2 Hour Rate (24.90 amps to 1.6 volts)........ 12.4 ampere hours Max. Physical Size: Length .................................... 6.51 inches (165mm) Width ...................................... 4.91 inches (125mm) Height...................................... 7.39 inches (188mm) Weight ............................................ 21.2 lbs (10.0kg) Energy Density (20 Hour Rate) ........................ 1.47 watt hrs/cu in (20 Hour Rate) .......................... 16.4 watt hrs/lbs
P RO D U C T S C H E M AT I C
Operating Temperature Range Discharge ...... -60°F to +165°F (-50°C to +74°C) Charge .............. 0°F to +120°F (-18°C to +49°C)
6.51 ( 165.4 )
Recharging Methods: Float Charging: Constant Potential Source of 13.7 to 13.9 volts continuously. Routine Charging: Constant Potential Source of 14.7 to 15.1 volts with a charging current of 10.0 ampere maximum.
+
-
Terminal: Cable assembly with TEW-105 (#12 AWG) tinned copper wire; black - negative, red - positive; 23 inches long from edge of battery to end of connector; AMP connector housing 770017-1 and 2 AMP sockets 770004-3
4.91 ( 124.7 )
Case Material: Polycarbonate Flame Class: UL94 V-O exceeds oxygen index 28
+
Float Life Expectancy: 8+ years at 77°F (25°C) Two Year Full Warranty at average battery temperature of 77°F (25°C) or less
7.39 ( 187.7 )
Above data are average values which can be obtained within 3 charge/discharge cycles. These are not minimum values.
MAINTENANCE-FREE RECHARGEABLE BATTERIES
Carefree®
CFR-12V29-S10
Charge Voltage per Cell vs. Temperature 2.7 Deep Cyclic Charging 2.6
The charging of Carefree batteries is best accomplished in a temperature range of 60°F
2.5
VOLTS PER CELL
Charging vs Temperature
to 90°F. Charging within this temperature range requires no temperature compensation. For applications over a wider temperature range, charging voltage must be changed as a
Shallow Cyclic Charging
Float Charging
2.4
2.3
function of temperature. (see chart at right) 2.2
Capacity vs Temperature
10 50
0 32
-10 -14
-20 -4
20 68
50 (oC) 122 (oF)
40 104
30 86
AMBIENT TEMPERATURE
The efficiency of the lead-acid system decreases as the temperature decreases and increases
Capacity as Affected by Temperature
as temperature increases from room temperature (77°) as illustrated. These four curves
@ VARIOUS RATES OF DISCHARGE
shown are based on discharges at the 20 hour, 5 hour, 11/2 hour and 1 hour rates.
110 100
High temperature increases the rate of self-discharge of all battery systems but even in this respect, the lead-calcium battery is perhaps least affected. In general, the rate of self-discharge can be expected to double for each 20°F rise in temperature above 70°F. Battery Operating Conditions & Cautions
20 hr.
90
PERCENTAGE OF FULL CAPACITY
Self-Discharge Characteristics
80
5 hr.
70 60
11/2 hr. 1 hr.
50 40 30 20 10
Battery contains toxic material (lead) and corrosive fluid (sulfuric acid) • Charging can
0
produce explosive gases • Do not charge in gas tight enclosures • Charge battery in a
-40 -40
-20 -29
20 -7
0 -18
120 140 ( F) o 49 60 ( C)
DISCHARGE CURVE
fire • Keep batteries and chargers away from children • Charge battery as soon as possible
13.0
BATTERY VOLTAGE (V)
Installation Care
o
100 38
Typical Voltage Characteristic (77°F)
controlled charger • Do not short-circuit battery terminals, as this can cause an explosion or
or incinerate • MUST BE RECYCLED OR DISPOSED OF PROPERLY
80 27
60 16
TEMPERATURE
well-ventilated area away from sparks, flames or smoking • Use approved voltage
after use • Do not store battery in discharged state • Do not puncture, disassemble, mutilate
40 4
12.0 11.0 4.80A 2.70A 1.45A 10.0 24.90A 17.00A
9.0 8.0
All CAREFREE batteries are carefully assembled and with proper charging will provide
0
1
2
3
5
10
excellent service. When placing the battery into service it must be inspected to make sure
and eyes. If contact is made with a damaged battery, immediately wash the contacted area with water for at least 5 minutes. When installing the battery in equipment, ventilation must be provided. Toward the end of charge and under overcharge conditions, hydrogen and oxygen gas can be generated. If this gas is allowed to accumulate in the enclosure and a spark is introduced, an explosion could result. The specifications on this sheet may be changed by EaglePicher without notice. EaglePicher™ is a trademark of and Keeper® is a registered trademark of EaglePicher Corporation.
Carefree® 3220 Industrial Drive • Joplin, MO 64801 Tel: 1-800-201-0215 • Fax: 417-626-2078 E-mail:
[email protected] • Web site: www.epcompower.com Copyright ©2006 EaglePicher Corporation
2
3
5
10
20 30
hrs.
Typical Self-Discharge Characteristics PERCENTAGE OF NOMINAL CAPACITY (AMPERE HOURS)
corrosion of adjacent components. Any sulfuric acid can cause severe burns to the skin
60
DISCHARGE TIME
that the battery has not been damaged by rough handling. If the unit has been damaged, there is a possibility of a loss of a small amount of sulfuric acid electrolyte and possible
20 30
min.
100
80
60
o
o
40
40o F 4C
o
o
100o F 38 C
60o F 16 C
80o F 27 C
20
0
2
4
6
8
10
STORAGE TIME - MONTHS
12
14
