Transcript
Q U I C K
I N S TA L L
G U I D E
SINGLE WALL MOUNT SYSTEM CONTROL KEYPAD
DS00465D-1 ICS Single QIG.indd 1
3/3/08 11:20:35 AM
Ta b l e o f C o n t e n t s Product Overview - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 2 The IntelliControl ICS Single Keypad is a singlegang, wall-mounted keypad user interface. Eight backlit Master Keys provide Niles’ exclusive “One Touch to Music™”, which turns the system on, selects a source and starts the music. Additional
Getting Started - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 5
Installation - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 8
Operating the Single - - - - - - - - - - - - - - - - - - - - - - - - - - - - 15
backlit Hard Keys provide simple system and source control.
Troubleshooting - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 17
Specifications - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 20
Contact Information - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 21
Warranty - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 22
DS00465D-1 ICS Single QIG.indd 2-Sec1:1
3/3/08 11:20:36 AM
www.nilesaudio.com
PRODUCT OVERVIEW
FEATURES AND BENEFITS Eight Customizable, Backlit Master Keys Provide “One Touch To Music” Each of the 8 backlit Master Keys can be customized to identify the specific source or music genre that will be selected when that button is pressed. The Master Keys turn the zone on, select a source and play your favorite channel or music selection.
Master Keys 8 backlit buttons provide “One Touch to Music”
Six Backlit Hard Keys Provide convenient access to frequently used system controls. Volume up/down, previous/next (track/ station) mute and off keys provide simple system and source control.
Convenient Backlighting for All Keys PREV/NEXT 2 backlit buttons move to Next or Previous / Track or Channel
OFF Backlit button turns zone or system off
13&7
/&95
70-o
70-
0''
.65&
Automatically illuminate when any button is pressed. –VOL/VOL+ 2 backlit buttons adjust volume UP/DOWN
MUTE Backlit button mutes/ un-mutes audio output to zone
Party Mode Party Mode turns on all your enabled “Party Zones,” with the push of a button, from anywhere in your home. Press and hold a Master Key for two seconds to turn on zones enabled for “Party Mode.”
Source/Zone On Indicator Selected Source Master Key illuminates to indicate source selected and Zone On status.
Mute On Indicator Mute button illuminates red to indicate mute on. Red illumination turns off when un-muted. Figure 1: IntelliControl ICS Single Keypad – front view.
2 DS00465D-1 ICS Single QIG.indd Sec1:2-Sec1:3
3 3/3/08 11:20:36 AM
www.nilesaudio.com
FEATURES AND BENEFITS (CONT’D)
GETTING STARTED
Global Off
Unpacking the Box (Contents)
Press and hold the OFF key to turn off all zones from anywhere in the house.
■
1, Single Keypad
■
10, Master Key Caps
Connects to IntelliControl ICS Modular MultiZone Receiver via CAT-5
■
1, Master Key Label Sheet
■
1, User Guide
The IntelliControl ICS Single Keypad connects to the IntelliControl ICS Modular MultiZone Receiver via a CAT-5 data cable terminated with RJ-45 connectors.
■
1, Quick Install Guide
External IR Sensor Input (RJ-45) RJ-45 jack allows connection of an external IR sensor to the keypad for use of an IR remote in a zone or sub-zone
Fits Standard 1-Gang Box
4:45&.
*34&/403
Installs in standard 1-Gang low voltage box.
Color Inserts Additional Decora snap-in color inserts are included to match virtually any room’s wall plate.
System Connects to IntelliControl ICS Modular MultiZone Receiver Communication and Control Switch (RJ45 jack)
IR Sensor Connects to plug-in connector on an IR sensor (RJ45 jack)
Figure 2: IntelliControl ICS Single Keypad – rear view.
4 DS00465D-1 ICS Single QIG.indd Sec1:4-Sec1:5
5 3/3/08 11:20:38 AM
www.nilesaudio.com
GETTING STARTED (CONT’D)
GETTING STARTED (CONT’D)
Locating the MAC ID
Filling Out the GXR2 Installation Worksheet
The Media Access Control Address (MAC ID), tells the IntelliControl ICS Modular MultiZone Receiver which device, in this case an ICS Single Keypad, is sending commands. The IntelliControl ICS Modular MultiZone Receiver then knows which zone to turn on and which source to select for that zone based on the MAC ID it is assigned to.
3).',%
3).',%
3).',% 3).',%
MAC ID Sticker
Figure 3: MAC ID sticker location – Single Keypad – side view..
6 DS00465D-1 ICS Single QIG.indd Sec1:6-Sec1:7
The GXR2 Installation Worksheet, included with the IntelliControl ICS Modular MultiZone Receiver (and available for download at www.nilesaudio. com), provides spaces for placing the MAC ID stickers next to the name of the zone they are located in. Take special care in associating the correct MAC ID sticker with the right zone on the worksheet. Two MAC ID stickers are found on the keypad. Remove one of the stickers and place it next to the zone it is located in on the worksheet. DO NOT REMOVE BOTH STICKERS FROM THE KEYPAD. It may become necessary to reference the keypad sticker for troubleshooting if the system is not performing properly and to be able to make changes in the IntelliFile 3 software.
3).',%
Figure 4: Affixing Mac ID sticker to GXR2 Installation Worksheet.
7 3/3/08 11:20:39 AM
www.nilesaudio.com
INSTALLATION
INSTALLATION (CONT’D)
Installing the Master Key Labels
Basic Installation Diagram
To install the Master Key labels (Figure 5): 1.
J1PE¥
Carefully remove the Master Key keycaps (keycaps DO NOT come installed for the Single Keypad).
2. Place labels from the included label sheet inside the keycap.
UP74:/$*/
$47
*3'MBTIFS
4BUFMMJUF3FDFJWFS
%7%$%1MBZFS
%*(*5"-"6%*0065
015*$"-
3. Place the caps in the appropriate key locations (refer to the GXR2 Installation Worksheet to assure proper position).
$0"9*"-
3
"6%*0065
5.".'.
". "/5&//"
/JMFT"VEJP$PSQPSBUJPO.JBNJ'MPSJEB 64"
'. "/5&//"
Figure 5.
5P6OTXJUDIFE 0VUMFU
'. "/5
". "/5 $"4$"%&"6%*0 065
-
7*%&0 065
$"4$"%&"6%*0 065
3
$0..6/*$"5*0/ $0/530-48*5$)
9. "/5&//"
4*3*64 "/5&//"
$"5 8JSF
4QFBLFS8JSF
;0/&
Step 1: Label Sheet Removal.
;0/&
;0/&
;0/&
Step 2: Insert label in keycap. .BTUFS $IBSHJOH #BTF4UBUJPO
4QFBLFST
4QFBLFST
4QFBLFST 4QFBLFST
13&7
70-o
0''
/&95
70-
.65&
Step 3: Keycap replacement.
8 DS00465D-1 ICS Single QIG.indd Sec1:8-Sec1:9
Figure 6
9 3/3/08 11:20:41 AM
www.nilesaudio.com
INSTALLATION (CONT’D)
INSTALLATION (CONT’D)
Wiring Termination Diagram
Adding an IR Sensor
The IntelliControl ICS Keypads connect to an IntelliControl ICS Modular MultiZone Receiver via CAT-5 cable. For the system to function properly, all runs of CAT-5 must be pulled, in home-runs, from each keypad location to the system head end where the MultiZone Receiver and other system components will be located.
To add an IR sensor to a keypad, use the wiring diagrams and connector detail that follow to adapt an RJ-45 connector from a keypad to the plug-in wire terminals on the IR sensor. /JMFT*3 $POOFDUPS
3+
4UBUVT
The runs of CAT-5 must be terminated with RJ-45 connectors using the T-568A pinout configuration as follows:
%BUB (SPVOE 7%$
3+1MVHT
1JO
5BC %PXO
4UBUVT (SPVOE
H(P#C0CS#3
5"
Pin# 1 2 3 4 5 6 7 8 Note:
Descrip. TX+ TX– RX+ IR Signal IR Ground RX– UI Power UI Ground
7 %BUB
H(P#C0CS#3
5"
Color Code White/Green Green White/Orange Blue White/Blue Orange White/Brown Brown
TX+ = transmit, RX+ = receive, UI = user interface.
Figure 8: Niles IR sensor to ICS keypad IR sensor input. See table below for RJ45 pinout.
Pin # 1 2 3 4 5 6 7 8
Color Code White/Green Green White/Orange Blue White/Blue Orange White/Brown Brown
Connector 12V Data Ground Empty Status Empty Empty Empty
Figure 7: IntelliControl ICS RJ-45 pinout checklist.
10 DS00465D-1 ICS Single QIG.indd Sec1:10-Sec1:11
11 3/3/08 11:20:44 AM
www.nilesaudio.com
INSTALLATION (CONT’D)
INSTALLATION (CONT’D)
Adding an IR Sensor (cont’d)
Keypad Connections
Using a properly configured CAT-5 cable, connect the IR Sensor terminal on the keypad to the plug-in terminal on the IR Sensor as shown.
After all system components have been properly installed, use a properly configured CAT-5 cable and connect the System terminal on the keypad to any of the RJ-45 Communication And Control Hub ports on the IntelliControl ICS Modular MultiZone Receiver as shown.
CAUTION: These connections are different than those used from the keypads to the IntelliControl ICS Modular MultiZone Receiver. Be sure to check wire configuration and connections before powering up the system.
GXR2
Four Pair Twisted Cable 4ZTUFN
*34FOTPS
CAT-5 Cable IR Sensor Terminal
SINGLE
System Terminal
IR Sensor
4ZTUFN
*34FOTPS
4ZTUFN
*34FOTPS
Figure 9: IR Sensor to IntelliControl ICS Single Keypad connections.
SINGLE
SINGLE
Figure 10: Connecting the Single Keypad to IntelliControl ICS Modular Multizone Receiver.
12 DS00465D-1 ICS Single QIG.indd Sec1:12-Sec1:13
13 3/3/08 11:20:46 AM
www.nilesaudio.com
INSTALLATION (CONT’D)
OPERATING THE SINGLE
Using a New Construction Bracket
TURNING ON THE SYSTEM/SELECT A SOURCE
(See Figure 11.)
Press any Master Key to turn on the local zone.(i.e., ).
1.
Connect a properly configured CAT-5 cable to the system terminal on the back of the keypad.
2. Install keypad to low voltage electrical box as shown using included hardware. 3. Finish with appropriate color faceplate. WARNING: Do not mount the keypad, or IR sensor if used, in the same electrical box as 110V AC devices. This is a violation of electrical code in some areas.
Decora style insert
1 Gang Low Voltage Box
iPOD SIRIUS ROCK CLASSICL
PREV
PARTY MODE
Press and hold any of the eight Master Keys for 2 seconds. All zones enabled for Party Mode turn on to the same source ). (i.e.,
XM AM/FM JAZZ BLUES
NEXT
VOL –
VOL +
OFF
MUTE
CHANGING TRACKS
SINGLE
Faceplate Figure 11: Keypad installation.
14 DS00465D-1 ICS Single QIG.indd Sec1:14-Sec1:15
Press the PREV Key for previous track/station. Key Press the NEXT for next track/station.
13&7
/&95
15 3/3/08 11:20:48 AM
www.nilesaudio.com
OPERATING THE SINGLE (CONT’D)
TROUBLESHOOTING
ADJUSTING VOLUME
PROBLEM
Press the VOL– to lower volume.
Key
CONTROL
Press the VOL+ to raise volume.
Key
70-o
70-
Keypad does not control IntelliControl ICS Modular MultiZone Receiver or sources
0''
.65&
TURNING THE ZONE OFF
Press the OFF Key to turn the local zone off
0''
.65&
TURN THE SYSTEMS OFF
Press and hold OFF Key for 2 seconds to turn all zones off
a) Confirm Keypad connections to IntelliControl ICS Modular MultiZone Receiver. b) Confirm configuration of CAT-5 (pinout) cables and RJ-45 connectors.
MUTING
Press the MUTE Key to mute/un-mute zone speakers.
SOLUTION
0''
.65&
c) Verify MAC ID number for this Keypad is properly configured in IntelliFile 3. d) Confirm Modules are in proper card slots in IntelliControl ICS Modular MultiZone Receiver card cage (Check GXR2 Installation Worksheet). e) Check Module connection to header in card cage. f)
Verify IR commands in IntelliFile 3 for Legacy Sources, if used.
g) Confirm IR Flasher is plugged into the IR OUT jack on IM-AUDIO.
16 DS00465D-1 ICS Single QIG.indd Sec1:16-Sec1:17
17 3/3/08 11:20:51 AM
www.nilesaudio.com
TROUBLESHOOTING (CONT’D)
TROUBLESHOOTING (CONT’D)
PROBLEM
PROBLEM
SOLUTION
CONTROL Keypad does not control IntelliControl ICS Modular MultiZone Receiver or sources
h) Confirm that placement of IR Flasher is over the IR eye of the component being controlled.
PROBLEM
SOLUTION
AUDIO No Audio
a) Check connection of L&R Audio OUT from Legacy source to L&R IN on IMAUDIO, if used. b) Check speaker connections.
No Audio in Expansion Zones
SOLUTION
SYNC
a) Check connection of L&R Cascade Audio OUT on Master Chassis to L&R Audio IN on the IM-AUDIO Module on the Slave Chassis.
18 DS00465D-1 ICS Single QIG.indd Sec1:18-Sec1:19
Source out of sync when using 3-30V Sync
a) Check connection between sensing device and IM-AUDIO, if used. b) Confirm trigger voltage of sensing device or switched voltage is turning ON/OFF with volt meter, if used.
Source out of sync when using Video Sync
a) Check connection between source video OUT and Video Sync IN on IM-AUDIO, if used. b) Confirm that video signal from source turns OFF when the source is in ‘standby’, if used.
19 3/3/08 11:20:54 AM
www.nilesaudio.com
SPECIFICATIONS
CUSTOMER SERVICE – TECHNICAL SUPPORT
Master Keys:
8 Programmable, configurable, backlit
Hard Keys:
6, backlit
Agency certifications:
Class 2/SELV covering US,
1-800-BUY-HIFI (289-4434)
Canadian and EU markets
BY PHONE (OUTSIDE USA/CANADA)
Warranty:
Two-year limited
Shipping Weight:
1 lb.
BY PHONE (IN USA/CANADA)
1-305-238-4373 CUSTOMER SERVICE HOURS
8: 00 AM to 5:30 PM ET
DIMENSIONS
TECHNICAL SUPPORT HOURS
Keypad:
1-3/4" W x 4" H x 1-5/8" D
8: 00 AM to 7: 00 PM ET
Depth behind wall:
1-1/8" (based on mounting into 1/2" drywall)
ON THE WEB
w w w.nilesaudio.com EMAIL TECHNICAL SUPPORT
[email protected] EMAIL FOR PRODUCT SUGGESTIONS
[email protected]
Niles offers many accessories. For a complete list please visit: www.nilesaudio.com.
20 DS00465D-1 ICS Single QIG.indd Sec1:20-Sec1:21
21 3/3/08 11:20:55 AM
www.nilesaudio.com
LIMITED WARRANTY
NOTES
Niles Audio Corporation (“NILES”) warrants this IntelliControl ICS product to the original purchaser to be free of manufacturing defects in material and workmanship for a period of two years from date of purchase. This Warranty is subject to the following additional conditions and limitations. The Warranty is void and inapplicable if NILES deems that the product has been used or handled other than in accordance with the instructions provided by the manufacturer, including but not limited to damage caused by accident, mishandling, improper installation, abuse, negligence, or normal wear and tear, or any defect caused by repair to the product by anyone other than NILES or an authorized NILES dealer. To obtain warranty service, take the unit to the nearest authorized NILES dealer, who will test the product and if necessary, forward it to NILES for service. If there are no authorized NILES dealers in your area, you must write to NILES and include your name, address, model and serial number of your unit, along with a brief description of the problem. A factory Return Authorization Number will be sent to you. Do not return any unit without first receiving written authorization and shipping instructions from NILES. If the above conditions are met, the purchaser’s sole remedy shall be to return the product to NILES, in which case NILES will repair or replace, at its sole option, the defective product without charge for parts or labor. NILES will return a unit repaired or replaced under warranty by shipping same by its usual shipping method from the factory (only) at its expense within the United States of America. THERE ARE NO OTHER WARRANTIES, INCLUDINGWITHOUT LIMITATION, EITHER EXPRESS OR IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, WITH RESPECT TO THE PRODUCT.
Repair or replacement as provided under this warranty is the exclusive remedy of the consumer/purchaser. NILES shall not be responsible for any incidental or consequential damages except to the extent provided (or prohibited) by applicable law. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation may not apply to you. This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. For the name of your nearest authorized NILES dealer contact: NILES AUDIO CORPORATION, P.O. BOX 160818 MIAMI, FLORIDA 33116-0818. Please fill in your product information and retain for your records.
Model_________________________ Purchase Date_________________
22 DS00465D-1 ICS Single QIG.indd Sec1:22-Sec1:23
23 3/3/08 11:20:56 AM
www.nilesaudio.com
NOTES
24 DS00465D-1 ICS Single QIG.indd Sec1:24-Sec1:25
NOTES
25 3/3/08 11:20:58 AM
iPOD
XM
SIRIUS
AM/FM
ROCK
JAZZ
CLASSCL
BLUES
13&7
/&95
70-o
70-
0''
.65&
1 - 8 0 0 - B U Y- H I F I – w w w . n i l e s a u d i o . c o m
©2006-2008 Niles Audio Corporation 12331 S.W. 130 Street, Miami, FL 33186. All rights reserved. Niles, the Niles logos, IntelliControl, IntelliFile, and iRemote are registered trademarks of Niles Audio Corporation. One touch to music is a trademark of Niles Audio Corporation. All other trademarks are the property of their respective owners. Niles reserves the right to change specifications, descriptions and prices without notice. The technical and other information contained herein is not intended to set forth all technical and other specifications. Designed and engineered in the USA. DS00465D
DS00465D-1 ICS Single QIG.indd Sec1:26
3/3/08 11:20:58 AM
