Preview only show first 10 pages with watermark. For full document please download

Electrical Wiring (evolution-v)

   EMBED

Share

Transcript

C-1 ELECTRICAL WIRING (EVOLUTION-V) CONTENTS WIRING HARNESS CONFIGURATION DIAGRAMS . . . . . . . . . . . . . . . . . . . . . . . . . 2 ROOM LAMP AND LUGGAGE COMPARTMENT LAMP . . . . . . . . . . . . . . . . 36 ENGINE COMPARTMENT . . . . . . . . . . . . . . . . 2 TURN-SIGNAL LAMP AND HAZARD LAMP . . . . . . . . . . . . . . . . . . . . . . . 38 DASH PANEL . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 FLOOR, ROOF, AND SEAT . . . . . . . . . . . . 10 LUGGAGE COMPARTMENT . . . . . . . . . . . . 12 SINGLE PART INSTALLATION POSITION . . . . . . . . . . . . . . . . . . . . . . . . . 13 RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 ECU . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 SOLENOID VALVE . . . . . . . . . . . . . . . . . . . . . 16 CHECK CONNECTOR AND SPARE CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 17 FUSIBLE LINK AND FUSE . . . . . . . . . . . . . 17 GROUND CABLE . . . . . . . . . . . . . . . . . . . . . . 18 GROUND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 STOP LAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 41 BACK-UP LAMP . . . . . . . . . . . . . . . . . . . . . . . 42 OIL PRESSURE WARNING LAMP . . . . . . 43 CENTRAL DOOR LOCKING SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44 HEATER AND MANUAL AIR CONDITIONER . . . . . . . . . . . . . . . . . . . . 48 FULLY AUTOMATIC AIR CONDITIONER 54 WINDSHIELD WIPER AND WASHER . . . . . . . . . . . . . . 61 REAR WIPER AND WASHER . . . . . . . . . . 62 DEFOGGER AND DOOR MIRROR HEATER . . . . . . 64 CENTRALIZED JUNCTION . . . . . . . . . . . . . 19 DEFOGGER AND DOOR MIRROR HEATER . . . . . . 66 POWER DISTRIBUTION SYSTEM . . . . . . 20 SPARE CONNECTOR FOR RADIO . . . . . 68 STARTING SYSTEM . . . . . . . . . . . . . . . . . . . 25 RADIO <4-SPEAKER, 6-SPEAKER> . . . . 70 IGNITION SYSTEM . . . . . . . . . . . . . . . . . . . . 26 ANTI-LOCK BRAKE SYSTEM (ABS) . . . . 74 CHARGING SYSTEM . . . . . . . . . . . . . . . . . . 27 ACTIVE YAW CONTROL SYSTEM (AYC) 80 ENGINE CONTROL SYSTEM . . . . . . . . . . . 28 INTERCOOLER WATER SPRAY SYSTEM 86 CIRCUIT DIAGRAM . . . . . . . . . . . . . . . . 19 COOLING SYSTEM . . . . . . . . . . . . . . . . . . . . 34 WIRING HARNESS CONFIGURATION DIAGRAMS – Engine Compartment C-2 WIRING HARNESS CONFIGURATION DIAGRAMS ENGINE COMPARTMENT Ground cable Connector symbol A A-01 (2-B) A-03 (1-B) A-04 (1) A-05 (4-GR) A-09 (1-B) A-10 (1) A-12 (2-B) A-16 (4-B) A-18 (6-B) A-19 (3-B) –01 thru –50 Brake fluid level switch Noise condenser Alternator Alternator Starter Starter Fuel pressure solenoid valve Throttle position sensor Idle speed control servo Vehicle speed sensor A-20 (4-B) A-21 (8-B) A-22 (2-B) A-23 (2-B) A-25 (7-B) A-26 (2-B) A-28 (8-B) Windshield wiper motor Hydraulic unit Hydraulic unit Waste gate solenoid valve Air flow sensor Front speed sensor (LH) Control harness and front harness combination WIRING HARNESS CONFIGURATION DIAGRAMS – Engine Compartment A-29 (2-B) A-33 (1) A-34 (1) A-35 (2-BR) A-38 (2-B) A-39 (1-B) Front harness and battery harness combination Horn (LH) Horn (LH) Outside air temperature sensor Engine coolant temperature sensor Engine coolant temperature gauge unit A-45 (1) A-46 (1) A-47 (2-G) A-48 (2) A-49 (2-BR) A-50 (2-B) C-3 Horn (RH) Horn (RH) Rear washer motor Windshield washer motor Dual pressure switch Front speed sensor (RH) WIRING HARNESS CONFIGURATION DIAGRAMS – Engine Compartment C-4 Ground cable Connector symbol A A-51 (3-B) A-52 (1-B) A-53 (2-B) A-54 (2-B) A-55 (2-B) A-56 (2-B) A-63 (4-B) A-72 (2-B) A-73 (1-L) A-74 (1-B) A-76 (6) A-77 (5) –51 thru –131 Crank angle sensor Oil pressure switch Injector (No.1) Injector (No.2) Injector (No.3) Injector (No.4) O2 sensor Back-up lamp switch Engine speed detection connector Fuel pump check connector Valve relay Motor relay A-78 (2-GR) A-80X (5) A-82X (5) A-84X (5) A-86X (4) A-88 (6-B) A-89 (2-BR) A-90 (3-B) A-91 (2) A-92 (2-B) Side turn signal lamp (LH) Horn relay Radiator fan relay (LO) Headlamp relay Alternator relay Control harness and battery harness combination Front turn signal lamp (LH) Headlamp (LH) Position lamp (LH) Fog lamp (LH) WIRING HARNESS CONFIGURATION DIAGRAMS – Engine Compartment A-94 (4-GR) A-96 (2-GR) A-97 (3-B) A-99 (2-B) A-101 (1) A-102 (1) A-103 (2-B) A-104 (2) A-105 (3-B) A-106 (1-B) A-107 (2-BR) A-110 (3-GR) A-111 (3-GR) Radiator fan motor Knock sensor Camshaft position sensor Condenser fan motor Power steering oil pressure switch Spare connector for fog lamp Fog lamp (RH) Position lamp (RH) Headlamp (RH) A/C compressor assembly Front turn signal lamp (RH) Ignition coil 1 Ignition coil 2 A-112X (4) A-113X (4) A-114X (4) A-116X (4) A-117 (2-GR) A-123 (5-B) A-124 (6-B) A-125 (2-B) A-126 (5-B) A-127 (2-B) A-128 (2-GR) A-129 (2-B) A-131 (1-B) C-5 Radiator fan relay (HI) Condenser fan relay (LO) Condenser fan relay (HI) A/C compressor relay Side turn signal lamp (RH) Fuel pump relay No.2 Fuel pump resistor Resistor (for injector) AYC relay Secondary air control solenoid valve Condenser fan motor Water spray motor Noise condenser WIRING HARNESS CONFIGURATION DIAGRAMS – Dash Panel C-6 DASH PANEL Connector symbol B B-01 (2-R) B-02 (2) B-03 (2-B) B-04 (20-B) B-05 (16-B) B-06 (6) B-07 (8) B-08 (25) –01 thru –37 Passenger seat air bag module (squib) Heater water temperature sensor Air thermo sensor A/C-ECU A/C-ECU Air outlet change-over damper motor and potentiometer Blower switch Meter and gauge B-09 (25) B-10 (22) B-11X (8) B-13X (5) B-15 (20) B-16 (6) B-17 (14) B-18 (19) B-19 (22) Meter and gauge Body harness and front door harness (RH) combination Rear intermittent wiper relay Power window relay Front harness and body harness combination Front harness and body harness combination Front harness and body harness combination Jumper connector (1) Body harness and instrument panel harness combination WIRING HARNESS CONFIGURATION DIAGRAMS – Dash Panel C-7 Interior relay box B-21 (2) B-22 (16-B) B-24 (26-Y) B-25 (22-Y) B-26 (2-B) B-27 (4) B-28 (4) B-30 (14) B-31 (1) B-32 (19-B) B-33 (2) Stop lamp switch Diagnosis connector ABS-ECU ABS-ECU Diode (for ABS circuit) Engine control relay Fuel pump relay Radio or spare connector for radio Glass antenna amplifier Jumper connector (5) Blower motor B-34 (4) B-35 (22) B-36 (2) B-37 (4) Blower high speed relay Body harness and front door harness (LH) combination Inside and outside air change-over damper motor Power transistor or resistor WIRING HARNESS CONFIGURATION DIAGRAMS – Dash Panel C-8 Connector symbol –38 B B-38 (2) B-39 (6) B-40 (3) B-41 (8) B-42 (2) B-43 (6-B) thru –65 and –94 thru –99 Sunlight sensor Air mix damper motor and potentiometer Automatic compressor ECU A/C switch Blower switch illumination lamp Defogger switch B-44 (6) B-45 (2-B) B-46 (2) B-48 (14) B-49 (14) B-50 (14-L) B-51 (21-Y) B-52 (16-B) Body harness and roof harness combination Diode (for keyless entry system circuit) Spare connector for fog lamp switch Jumper connector (2) Jumper connector (3) Jumper connector (4) SRS-ECU Control harness and body harness combination WIRING HARNESS CONFIGURATION DIAGRAMS – Dash Panel C-9 Interior relay box B-59 (26-Y) B-60 (16-Y) B-61 (12-Y) B-62 (22-Y) B-63 (2) B-64 (13) Engine-ECU Engine-ECU Engine-ECU Engine-ECU Blower motor Control harness and body harness combination B-65 (16-B) B-94 (13) B-95 (26) B-96 (16) B-99 (12) Control harness and body harness combination Control harness and body harness combination AYC-ECU AYC-ECU Diagnosis connector WIRING HARNESS CONFIGURATION DIAGRAMS – Floor, Roof, and Seat C-10 FLOOR, ROOF, AND SEAT Connector symbol D D-01 (20) D-02 (2) D-03 (2) D-04 (10) D-05 (6) D-06 (22) D-07 (6) D-08 (8) Receiver Seat belt switch Front door switch (RH) Body harness and fuel harness combination Body harness and rear door harness (RH) combination Body harness and rear harness combination Sunroof switch Room lamp D-09 (1) D-10 (18) D-11 (2-GR) D-12 (8) D-13 (3-B) D-14 (2-B) D-16 (6) D-17 (2) D-18 (6) Map lamp Sunroof ECU Room lamp Sunroof motor Fuel gauge unit (sub) Rear speed sensor (LH) Body harness and rear door harness (LH) combination Front door switch (LH) Fuel gauge unit (main) WIRING HARNESS CONFIGURATION DIAGRAMS – Floor, Roof, and Seat D-19 (2-B) D-20 (3-B) D-21 (1-B) D-27 (2) Rear speed sensor (RH) Acceleration sensor Parking brake switch Body harness and rear harness combination D-31 (2) D-32 (3-B) Water spray switch Acceleration sensor (lateral) C-11 WIRING HARNESS CONFIGURATION DIAGRAMS – Luggage Compartment C-12 LUGGAGE COMPARTMENT Connector symbol F Glass antenna amplifier F-01 (1-B) F-02 (1-B) F-03 (2) F-04 (3) F-05 (2) F-06 (2) F-08 (2-B) F-09 (1-B) F-10 (1-B) F-11 (3) F-12 (1-B) F-13 (2) F-15 (6) F-16 (2-GR) F-17 (1-B) Defogger (–) Defogger (–) Choke coil Choke coil Luggage compartment lamp Vacant connector or high mounted stop lamp (installed on rear shelf) Rear speaker (RH) Defogger (+) Defogger (+) Rear wiper motor Rear door switch (RH) High mounted stop lamp (installed on rear spoiler) Rear combination lamp (RH) Licence plate lamp (RH) Luggage compartment lamp switch F-18 (2-GR) F-20 (6) F-23 (2-B) F-24 (1) F-25 (1) F-26 (1-B) F-27 (3-B) F-28 (2-B) F-29 (2-B) F-30 (8-B) F-31 (2-B) F-32 (2-B) F-33 (6) Licence plate lamp (LH) Rear combination lamp (LH) Rear speaker (LH) Glass antenna Glass antenna Rear door switch (LH) Proportioning valve Direction valve (LH) Direction valve (RH) Rear harness and AYC harness combination Accumulator pressure switch AYC motor CD changer C-13 SINGLE PART INSTALLATION POSITION – Relay SINGLE PART INSTALLATION POSITION RELAY Name Symbol Name Symbol AYC relay B Fuel pump relay No.2 B Condenser fan motor relay (HI) A Radiator fan motor relay (HI) A Condenser fan motor relay (LO) A Radiator fan motor relay (LO) C A Condenser fan motor relay (HI) Condenser fan motor relay (LO) B Radiator fan motor relay (HI) C Fuel pump relay No.2 AYC relay Radiator fan motor relay (LO) C-14 SINGLE PART INSTALLATION POSITION – ECU / Sensor ECU SENSOR Name Symbol Name Symbol Acceleration sensor (lateral) I Knock sensor B Acceleration sensor (longitudinal) I Outside air temperature sensor F Air flow sensor D O2 sensor E Camshaft position sensor G Steering angle sensor (lateral) H Crank angle sensor A Throttle position sensor C Engine coolant temperature sensor G SINGLE PART INSTALLATION POSITION – Sensor A B Knock sensor Crank angle sensor C D Throttle position sensor E Air flow sensor F Outside air temperature sensor O2 sensor G H Camshaft position sensor I Acceleration sensor (longitudinal) Acceleration sensor (lateral) Engine coolant temperature sensor Steering angle sensor C-15 C-16 SINGLE PART INSTALLATION POSITION – Solenoid Valve SOLENOID VALVE Name Symbol Name Symbol Direction valve D Secondary air control solenoid valve A Fuel pressure solenoid valve B Waste gate solenoid valve C Proportioning valve D A B Fuel pressure solenoid valve Intake manifold stay Secondary air control solenoid valve C D Waste gate solenoid valve Rear combination lamp (RH) Direction valve Proportioning valve SINGLE PART INSTALLATION POSITION – Check Connector and Spare Connector / Fusible Link and Fuse CHECK CONNECTOR AND SPARE CONNECTOR Fuel pump check connector Engine speed check connector FUSIBLE LINK AND FUSE Fusible link Fusible link C-17 C-18 SINGLE PART INSTALLATION POSITION – Ground Cable / Ground GROUND CABLE GROUND CIRCUIT DIAGRAM – Centralized Junction C-19 CIRCUIT DIAGRAM CENTRALIZED JUNCTION CENTRALIZED RELAY Connector No. Name Connector No. Name A-82X Radiator fan motor relay (LO) A-113X Condenser fan motor relay (LO) A-112X Radiator fan motor relay (HI) A-114X Condenser fan motor relay (HI) Relay box in engine compartment (A/C relay box) C-20 CIRCUIT DIAGRAM – Power Distribution System POWER DISTRIBUTION SYSTEM FUSIBLE LINK (RELAY BOX IN ENGINE COMPARTMENT) BATTERY CHARGING SYSTEM STARTING SYSTEM FUSIBLE LINK (DIRECTLY CONNECTED TO BATTERY) ANTILOCK BRAKE SYSTEM ACTIVE YAW CONTROL SYSTEM • HEATER AND MANUAL AIR CONDITIONER • FULLY AUTOMATIC AIR CONDITIONER • COOLING SYSTEM DEDICATED FUSE (RELAY BOX IN ENGINE COMPARTMENT) DEDICATED FUSE (A/C RELAY BOX IN ENGINE COMPARTMENT) • HEATER AND MANUAL AIR CONDITIONER • FULLY AUTOMATIC AIR CONDITIONER • COOLING SYSTEM • HEATER AND MANUAL AIR CONDITIONER • FULLY AUTOMATIC AIR CONDITIONER CIRCUIT DIAGRAM – Power Distribution System CHARGING SYSTEM HEADLAMP RELAY • HEATER AND MANUAL AIR CONDITIONER • FULLY AUTOMATIC AIR CONDITIONER • COOLING SYSTEM • POWER WINDOW • POWER SEAT C-21 • ENGINE CONTROL SYSTEM HEADLAMP HEADLAMP FOG LAMP • CLOCK AND MULTI-DISPLAY • SUNROOF • CIGARETTE LIGHTER AND ASHTRAY ILLUMINATION LAMP • METER AND GAUGE • TURN SIGNAL LAMP AND HAZARD LAMP • TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP, AND LIGHTING MONITOR BUZZER • DEFOGGER AND DOOR MIRROR HEATER • ELECTRIC RETRACTABLE REMOTE CONTROLLED MIRROR • HEATER • HEATER AND MANUAL AIR CONDITIONER • FOG LAMP • FOOT LAMP • FULLY AUTOMATIC AIR CONDITIONER • RADIO • SPARE CONNECTOR FOR RADIO SPARE CONNECTOR FOR FOG LAMP TURN SIGNAL LAMP AND HAZARD LAMP • ACTIVE YAW CONTROL SYSTEM • ANTILOCK BRAKE SYSTEM • STOP LAMP C-22 CIRCUIT DIAGRAM – Power Distribution System POWER DISTRIBUTION SYSTEM (CONTINUED) FUSIBLE LINK IGNITION SWITCH • ENGINE CONTROL SYSTEM • STARTING SYSTEM MULTIPURPOSE FUSE • ENGINE CONTROL SYSTEM • CHARGING SYSTEM • IGNITION SYSTEM • SRS AIR BAG • ENGINE CONTROL SYSTEM • BACK-UP LAMP • HEATER AND MANUAL AIR CONDITIONER • FULLY AUTOMATIC AIR CONDITIONER • COOLING SYSTEM TURN SIGNAL LAMP AND HAZARD LAMP • • • • • • • • • • • • • • • • • • • • • • • • • ACTIVE YAW CONTROL SYSTEM ANTILOCK BRAKE SYSTEM INTERCOOLER WATER SPRAY SYSTEM DEFOGGER AND DOOR MIRROR HEATER TENSION REDUCER SEAT BELT POWER WINDOW HEATER HEATER AND MANUAL AIR CONDITIONER FULLY AUTOMATIC AIR CONDITIONER SRS AIR BAG ACTIVE YAW CONTROL SYSTEM ANTILOCK BRAKE SYSTEM IGNITION KEY CYLINDER ILLUMINATION LAMP IGNITION KEY REMINDER BUZZER ENGINE CONTROL SYSTEM OIL PRESSURE WARNING LAMP SUNROOF METER AND GAUGE CHARGING SYSTEM CENTRAL DOOR LOCKING SYSTEM TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP, AND LIGHTING MONITOR BUZZER FUEL WARNING LAMP BRAKE WARNING LAMP RADIO SPARE CONNECTOR FOR RADIO CIRCUIT DIAGRAM – Power Distribution System MULTIPURPOSE FUSE DEDICATED FUSE (RELAY BOX IN ENGINE COMPARTMENT) • WINDSHIELD WIPER, WASHER • REAR WIPER, WASHER • CLOCK AND MULTI-DISPLAY • CENTRAL DOOR LOCKING SYSTEM (VEHICLES • CIGARETTE LIGHTWITH KEYLESS ER AND ASHTRAY ENTRY SYSTEM) ILLUMINATION LAMP • ELECTRIC RETRACT- • RADIO • SPARE CONNECABLE REMOTE TOR FOR RADIO CONTROLLED DOOR MIRROR • ELECTRICALLY REMOTE CONTROLLED DOOR MIRROR C-23 HORN C-24 CIRCUIT DIAGRAM – Power Distribution System POWER DISTRIBUTION SYSTEM (CONTINUED) FUSIBLE LINK MULTIPURPOSE FUSE CENTRAL DOOR LOCKING SYSTEM • • • • • • • • • • • • • • • • • HEATER • HEATER AND MANUAL AIR CONDITIONER • FULLY AUTOMATIC AIR CONDITIONER SRS AIR BAG ACTIVE YAW CONTROL SYSTEM ANTILOCK BRAKE SYSTEM IGNITION KEY CYLINDER ILLUMINATION LAMP IGNITION KEY REMINDER BUZZER ENGINE CONTROL SYSTEM CLOCK AND MULTI-DISPLAY METER AND GAUGE CENTRAL DOOR LOCKING SYSTEM TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP, AND LIGHTING MONITOR BUZZER DEFOGGER AND DOOR MIRROR HEATER BACK-UP LAMP AND REVERSE (R) POSITION BUZZER FULLY AUTOMATIC AIR CONDITIONER RADIO SPARE CONNECTOR FOR RADIO ROOM LAMP AND LUGGAGE COMPARTMENT LAMP DEDICATED FUSE (INSTALLED IN JUNCTION BLOCK) DEFOGGER AND DOOR MIRROR HEATER SUNROOF CIRCUIT DIAGRAM – Starting System STARTING SYSTEM BATTERY IGNITION SWITCH (ST) ENGINE CONTROL SYSTEM STARTER C-25 C-26 CIRCUIT DIAGRAM – Ignition System IGNITION SYSTEM IGNITION SWITCH (IG1) ENGINE CONTROL SYSTEM NOISE CONDENSER NOISE CONDENSER IGNITION COIL 1 IGNITION COIL 2 INPUT SIGNAL • • • • • • • • • IDLE SWITCH IGNITION SWITCH (ST) CAM POSITION SENSOR INTAKE AIR TEMPERATURE SENSOR CRANK ANGLE SENSOR VEHICLE SPEED SENSOR ENGINE COOLANT TEMPERATURE SENSOR BAROMETRIC PRESSURE SENSOR KNOCK SENSOR SPARK PLUG ENGINE-ECU METER AND GAUGE ENGINE SPEED DETECTION CONNECTOR C-27 CIRCUIT DIAGRAM – Charging System CHARGING SYSTEM FUSIBLE LINK FUSIBLE LINK • TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP, AND LIGHTING MONITOR BUZZER • POWER SUPPLY • FOG LAMP • HEADLAMP ENGINE CONTROL UNIT IGNITION SWITCH (IG1) COMBINATION METER ALTERNATOR RELAY ALTERNATOR STATOR COIL FIELD COIL IC VOLTAGE REGULATOR C-28 CIRCUIT DIAGRAM – Engine Control System ENGINE CONTROL SYSTEM FUSIBLE LINK FUSIBLE LINK IGNITION SWITCH (IG1) VACANT TERMINAL COMBINATION METER ENGINE CONTROL RELAY ACTIVE YAW CONTROL SYSTEM ANTI-LOCK BRAKE SYSTEM ENGINE-ECU POWER SUPPLY BACK-UP POWER SUPPLY C-29 CIRCUIT DIAGRAM – Engine Control System FUEL PUMP RELAY NO.2 FUEL PUMP RESISTOR IGNITION SYSTEM FUEL PUMP RELAY FUEL PUMP C-30 CIRCUIT DIAGRAM – Engine Control System ENGINE CONTROL SYSTEM (CONTINUED) ENGINE CONTROL RELAY CRANK ANGLE SENSOR CAMSHAFT POSITION SENSOR IDLE SPEED CONTROL SERVO ENGINEECU IDLE SWITCH O2 SENSOR THROTTLE POSITION SENSOR FRONT VIEW FRONT VIEW CIRCUIT DIAGRAM – Engine Control System RESISTOR (FOR INJECTOR) INJECTOR INJECTOR INJECTOR INJECTOR MULTI-PURPOSE FUSE DIAGNOSIS CONNECTOR • CENTRAL DOOR LOCKING SYSTEM • FULLY AUTOMATIC AIR CONDITIONER DIAGNOSIS CONNECTOR C-31 C-32 CIRCUIT DIAGRAM – Engine Control System ENGINE CONTROL SYSTEM (CONTINUED) THROTTLE POSITION SENSOR ENGINE COOLANT TEMPERATURE SENSOR IDLE SPEED CONTROL SERVO ENGINE-ECU CHARGING SYSTEM AIR FLOW SENSOR INTAKE AIR TEMPERATURE SENSOR BAROMETRIC PRESSURE SENSOR ENGINE-ECU • METER AND GAUGE • RADIO VEHICLE SPEED SENSOR KNOCK SENSOR POWER STEERING OIL PRESSURE SWITCH C-33 CIRCUIT DIAGRAM – Engine Control System IDLE SPEED CONTROL SERVO IGNITION SWITCH (ST) STARTING SYSTEM FUEL PRESSURE SOLENOID VALVE WASTE GATE SOLENOID VALVE SECONDARY AIR CONTROL SOLENOID VALVE METER AND GAUGE • AIR AIR CONDITIONER CONDITIONER • COOLING SYSTEM IGNITION SYSTEM ENGINE SPEED DETECTION CONNECTOR C-34 CIRCUIT DIAGRAM – Cooling System COOLING SYSTEM IGNITION SWITCH (IG2) FUSIBLE LINK RADIATOR FAN MOTOR RELAY (HI) RADIATOR FAN MOTOR RELAY (LO) INPUT SIGNAL A/C SWITCH IDLE SWITCH CRANK ANGLE SENSOR VEHICLE SPEED SENSOR ENGINE COOLANT TEMPERATURE SENSOR • THROTTLE POSITION SENSOR RADIATOR FAN MOTOR • • • • • ENGINE-ECU CIRCUIT DIAGRAM – Cooling System C-35 FUSIBLE LINK DEDICATED FUSE CONDENSER FAN MOTOR RELAY (HI) • HEATER AND MANUAL AIR CONDITIONER • FULLY AUTOMATIC AIR CONDITIONER DEDICATED FUSE CONDENSER FAN MOTOR RELAY (LO) CONDENSER FAN MOTOR C-36 CIRCUIT DIAGRAM – Room Lamp and Luggage Compartment Lamp ROOM LAMP AND LUGGAGE COMPARTMENT LAMP FUSIBLE LINK VEHICLES WITHOUT SUNROOF VEHICLES WITH SUNROOF VEHICLES WITH MAP LAMP ROOM LAMP ROOM LAMP COMBINATION METER MAP LAMP DEFOGGER VEHICLES WITHOUT KEYLESS ENTRY SYSTEM VEHICLES WITH KEYLESS ENTRY SYSTEM LUGGAGE COMPARTMENT LAMP DIODE CENTRAL DOOR LOCKING SYSTEM FRONT DOOR SWITCH REAR DOOR SWITCH LUGGAGE COMPARTMENT LAMP SWITCH C-37 NOTES C-38 CIRCUIT DIAGRAM – Turn-signal Lamp and Hazard Lamp TURN-SIGNAL LAMP AND HAZARD LAMP FUSIBLE LINK IGNITION SWITCH (IG1) BATTERY • CHARGING SYSTEM • HEADLAMP DEDICATED FUSE DEDICATED FUSE FOG LAMP COLUMN SWITCH (LIGHTING SWITCH) HAZARD SWITCH TURN SIGNAL AND HAZARD FLASHER UNIT NOTE : • CLOCK AND MULTIDISPLAY • CIGARETTE LIGHTER AND ASHTRAY ILLUMINATION LAMP • ELECTRIC RETRACTABLE REMOTE CONTROLLED DOOR MIRROR • FOG LAMP CIRCUIT DIAGRAM – Turn-signal Lamp and Hazard Lamp TURN SIGNAL AND HAZARD FLASHER UNIT C-39 HAZARD SWITCH SIDE TURN SIGNAL LAMP FRONT TURN SIGNAL LAMP SIDE TURN SIGNAL LAMP C-40 CIRCUIT DIAGRAM – Turn-signal Lamp and Hazard Lamp TURN-SIGNAL LAMP AND HAZARD LAMP (CONTINUED) TURN SIGNAL AND HAZARD FLASHER UNIT HAZARD SWITCH COLUMN SWITCH (TURN SIGNAL LAMP SWITCH) REAR COMBINATION LAMP (TURN: RH) REAR COMBINATION LAMP (TURN: LH) COMBINATION METER C-41 CIRCUIT DIAGRAM – Stop Lamp STOP LAMP BATTERY DEDICATED FUSE STOP LAMP SWITCH INSTALLED ON REAR SPOILER ANTI-LOCK BRAKE SYSTEM INSTALLED ON REAR SHELF VACANT CONNECTOR (SOME MODELS) HIGH MOUNTED STOP LAMP REAR COMBINATION LAMP (STOP: (STOP: RH) LH) HIGH MOUNTED STOP LAMP C-42 CIRCUIT DIAGRAM – Back-up Lamp BACK-UP LAMP IGNITION SWITCH (IG1) BACK-UP LAMP SWITCH REAR COMBINATION LAMP (BACK-UP: LH) REAR COMBINATION LAMP (BACK-UP: RH) CIRCUIT DIAGRAM – Oil Pressure Warning Lamp OIL PRESSURE WARNING LAMP IGNITION SWITCH (IG1) COMBINATION METER CHARGING SYSTEM C-43 C-44 CIRCUIT DIAGRAM – Central Door Locking System CENTRAL DOOR LOCKING SYSTEM FUSIBLE LINK IGNITION SWITCH (IG1) RECEIVER KEY REMINDER SWITCH DOOR LOCK ACTUATOR (FRONT: RH) CIRCUIT DIAGRAM – DOOR LOCK ACTUATOR (FRONT: LH) Central Door Locking System DOOR LOCK ACTUATOR (REAR: RH) C-45 DOOR LOCK ACTUATOR (REAR: LH) C-46 CIRCUIT DIAGRAM – Central Door Locking System CENTRAL DOOR LOCKING SYSTEM (CONTINUED) MULTI-PURPOSE FUSE VEHICLES WITHOUT SUNROOF VEHICLES WITH SUNROOF VEHICLES WITH MAP LAMP ROOM LAMP ROOM LAMP MAP LAMP DIODE SUNROOF FRONT DOOR SWITCH REAR DOOR SWITCH FRONT VIEW COMBINATION METER CIRCUIT DIAGRAM – Central Door Locking System C-47 IGNITION SWITCH (ACC) MULTI-PURPOSE FUSE RADIO RECEIVER RECEIVING ANTENNA • ANTI-LOCK BRAKE SYSTEM • ENGINE CONTROL SYSTEM • FULLY AUTOMATIC AIR CONDITIONER DIAGNOSIS CONNECTOR CONTROL CIRCUIT TRANSMITTER C-48 CIRCUIT DIAGRAM – Heater and Manual Air Conditioner HEATER AND MANUAL AIR CONDITIONER FUSIBLE LINK FUSIBLE LINK IGNITION SWITCH (IG2) • CHARGING SYSTEM • POWER SUPPLY • HEADLAMP DEDICATED FUSE BLOWER MOTOR RELAY FOG LAMP BLOWER MOTOR COLUMN SWITCH (LIGHTING SWITCH) RESISTOR BLOWER SWITCH CIRCUIT DIAGRAM – Heater and Manual Air Conditioner BLOWER SWITCH COLUMN SWITCH A/C SWITCH HEATER CONTROL PANEL ILLUMINATION LAMP AUTOMATIC COMPRESSOR ECU BLOWER SWITCH C-49 C-50 CIRCUIT DIAGRAM – Heater and Manual Air Conditioner HEATER AND MANUAL AIR CONDITIONER (CONTINUED) IGNITION SWITCH (IG2) FUSIBLE LINK RADIATOR FAN MOTOR RELAY (LO) RADIATOR FAN MOTOR RELAY (HI) INPUT SIGNAL RADIATOR FAN MOTOR • • • • • A/C SWITCH IDLE SWITCH CRANK ANGLE SENSOR VEHICLE SPEED SENSOR ENGINE COOLANT TEMPERATURE SENSOR • THROTTLE POSITION SENSOR ENGINE-ECU CIRCUIT DIAGRAM – Heater and Manual Air Conditioner FUSIBLE LINK DEDICATED FUSE CONDENSER FAN MOTOR RELAY (HI) DEDICATED FUSE CONDENSER FAN MOTOR RELAY (LO) CONDENSER FAN MOTOR C-51 C-52 CIRCUIT DIAGRAM – Heater and Manual Air Conditioner HEATER AND MANUAL AIR CONDITIONER (CONTINUED) AUTOMATIC COMPRESSOR ECU DUAL PRESSURE SWITCH FUSIBLE LINK DEDICATED FUSE A/C COMPRESSOR RELAY REFRIGERANT TEMPERATURE SWITCH ENGINE-ECU A/C COMPRESSOR AND MAGNETIC CLUTCH C-53 NOTES C-54 CIRCUIT DIAGRAM – Fully Automatic Air Conditioner FULLY AUTOMATIC AIR CONDITIONER FUSIBLE LINK IGNITION SWITCH (IG2) BLOWER MOTOR RELAY BLOWER MOTOR BLOWER HIGH SPEED RELAY BACK-UP POWER SUPPLY POWER TRANSISTOR DRIVE CIRCUIT POWER SUPPLY CIRCUIT DIAGRAM – Fully Automatic Air Conditioner BLOWER MOTOR FUSIBLE LINK • CHARGING SYSTEM • POWER SUPPLY • HEADLAMP DEDICATED FUSE POWER TRANSISTOR FOG LAMP COLUMN SWITCH (LIGHTING SWITCH) POWER TRANSISTOR DRIVE CIRCUIT AIR MIX DAMPER POTENTIOMETER C-55 BLOWER HIGH SPEED RELAY C-56 CIRCUIT DIAGRAM – Fully Automatic Air Conditioner FULLY AUTOMATIC AIR CONDITIONER (CONTINUED) AIR OUTLET CHANGEOVER POTENTIOMETER DEDICATED IC AIR OUTLET CHANGEOVER DAMPER MOTOR AIR THERMO SENSOR DEDICATED IC AIR MIX DAMPER MOTOR HEATER WATER TEMPERATURE SENSOR DEDICATED IC INSIDE AND OUTSIDE AIR CHANGEOVER DAMPER MOTOR FRONT VIEW C-57 CIRCUIT DIAGRAM – Fully Automatic Air Conditioner OUTSIDE AIR TEMPERATURE SENSOR SUNLIGHT SENSOR DEFOGGER FUSIBLE LINK • ANTI-LOCK BRAKE SYSTEM • ENGINE CONTROL SYSTEM • CENTRAL DOOR LOCKING SYSTEM DIAGNOSIS CONNECTOR C-58 CIRCUIT DIAGRAM – Fully Automatic Air Conditioner FULLY AUTOMATIC AIR CONDITIONER (CONTINUED) IGNITION SWITCH (IG2) FUSIBLE LINK RADIATOR FAN MOTOR RELAY (LO) RADIATOR FAN MOTOR RELAY (HI) INPUT SIGNAL A/C SWITCH IDLE SWITCH CRANK ANGLE SENSOR VEHICLE SPEED SENSOR ENGINE COOLANT TEMPERATURE SENSOR • THROTTLE POSITION SENSOR RADIATOR FAN MOTOR • • • • • ENGINE-ECU C-59 CIRCUIT DIAGRAM – Fully Automatic Air Conditioner FUSIBLE LINK DEDICATED FUSE CONDENSER FAN MOTOR RELAY (HI) DEDICATED FUSE CONDENSER FAN MOTOR RELAY (LO) CONDENSER FAN MOTOR C-60 CIRCUIT DIAGRAM – Fully Automatic Air Conditioner FULLY AUTOMATIC AIR CONDITIONER (CONTINUED) DEDICATED FUSE DUAL PRESSURE SWITCH DEDICATED FUSE A/C COMPRESSOR RELAY REFRIGERANT TEMPERATURE SWITCH ENGINE-ECU A/C COMPRESSOR AND MAGNETIC CLUTCH CIRCUIT DIAGRAM – Windshield Wiper and Washer WINDSHIELD WIPER AND WASHER IGNITION SWITCH (ACC) COLUMN SWITCH INTERMITTENT WIPER RELAY IN CASE OF OPERATION INTERVAL FIXED TYPE INTERMITTENT WIPER VARIABLE INTERMITTENT WIPER CONTROL SWITCH WINDSHIELD WASHER SWITCH WINDSHIELD WIPER SWITCH WINDSHIELD WASHER MOTOR WINDSHIELD WIPER MOTOR CIRCUIT BREAKER C-61 C-62 CIRCUIT DIAGRAM – Rear Wiper and Washer REAR WIPER AND WASHER IGNITION SWITCH (ACC) WINDSHIELD WIPER AND WASHER COLUMN SWITCH REAR INTERMITTENT WIPER RELAY REAR WASHER MOTOR REAR WIPER MOTOR C-63 NOTES C-64 CIRCUIT DIAGRAM – Defogger and Door Mirror Heater DEFOGGER AND DOOR MIRROR HEATER FUSIBLE LINK IGNITION SWITCH (IG2) FUSIBLE LINK • CHARGING SYSTEM • POWER SUPPLY • HEADLAMP DEDICATED FUSE DEFOGGER RELAY FOG LAMP COLUMN SWITCH (LIGHTING SWITCH) DEFOGGER SWITCH VEHICLES WITHOUT GLASS ANTENNA DEFOGGER VEHICLES WITH GLASS ANTENNA CIRCUIT DIAGRAM – Defogger and Door Mirror Heater C-65 DEFOGGER RELAY ROOM LAMP AND LUGGAGE COMPARTMENT LAMP VEHICLES WITH GLASS ANTENNA VEHICLES WITH DIVERSITY ANTENNA DOOR MIRROR PRINTED HEATER WIRE PRINTED HEATER WIRE CHOKE COIL DEFOGGER C-66 CIRCUIT DIAGRAM – Defogger and Door Mirror Heater DEFOGGER AND DOOR MIRROR HEATER IGNITION SWITCH (IG2) FUSIBLE LINK DEFOGGER RELAY VEHICLES WITHOUT GLASS ANTENNA DEFOGGER VEHICLES WITH GLASS ANTENNA CIRCUIT DIAGRAM – Defogger and Door Mirror Heater C-67 DEFOGGER RELAY ROOM LAMP AND LUGGAGE COMPARTMENT LAMP VEHICLES WITH GLASS ANTENNA CHOKE COIL DOOR MIRROR PRINTED HEATER WIRE PRINTED HEATER WIRE VEHICLES WITH DIVERSITY ANTENNA DEFOGGER C-68 CIRCUIT DIAGRAM – Spare Connector for Radio SPARE CONNECTOR FOR RADIO IGNITION SWITCH (ACC) FUSIBLE LINK FUSIBLE LINK • CHARGING SYSTEM • POWER SUPPLY • HEADLAMP DEDICATED FUSE CENTRAL DOOR LOCKING SYSTEM FOG LAMP COLUMN SWITCH (LIGHTING SWITCH) SPARE CONNECTOR FOR RADIO SPARE CONNECTOR FOR REAR SPEAKER C-69 CIRCUIT DIAGRAM – Spare Connector for Radio IGNITION SWITCH (IG1) REAR WINDOW GLASS ANTENNA POLE ANTENNA GLASS ANTENNA AMPLIFIER ANTENNA FEEDER LINE ANTENNA FEEDER LINE • SUNROOF • SEAT BELT WARNING LAMP METER AND GAUGE ENGINE CONTROL SYSTEM VEHICLE SPEED SENSOR SPARE CONNECTOR FOR DOOR SPEAKER C-70 CIRCUIT DIAGRAM – Radio <4-speaker, 6-speaker> RADIO <4-SPEAKER, 6-SPEAKER> FUSIBLE LINK IGNITION SWITCH (ACC) FUSIBLE LINK POLE ANTENNA • CHARGING SYSTEM • POWER SUPPLY • HEADLAMP DEDICATED FUSE CENTRAL DOOR LOCKING SYSTEM ANTENNA FEEDER LINE FOG LAMP COLUMN SWITCH (LIGHTING SWITCH) RADIO AND TAPE PLAYER REAR SPEAKAER CIRCUIT DIAGRAM – Radio <4-speaker, 6-speaker> REAR WINDOW GLASS ANTENNA REAR WINDOW GLASS ANTENNA GLASS ANTENNA AMPLIFIER ANTENNA FEEDER LINE TWEETER (LH) DOOR SPEAKER (LH) DOOR SPEAKER (RH) TWEETER (RH) C-71 C-72 CIRCUIT DIAGRAM – Radio <4-speaker, 6-speaker> RADIO <4-SPEAKER, 6-SPEAKER> (CONTINUED) (MULTI-PURPOSE FUSE) IGNITION SWITCH (IG1) (MULTI-PURPOSE FUSE) CD CHANGER DIN CABLE • SUNROOF • SEAT BELT WARNING LAMP RADIO AND TAPE PLAYER METER AND GAUGE VEHICLE SPEED SENSOR ENGINE CONTROL SYSTEM C-73 NOTES C-74 CIRCUIT DIAGRAM – Anti-lock Brake System (ABS) ANTI-LOCK BRAKE SYSTEM (ABS) BATTERY FUSIBLE LINK DEDICATED FUSE STOP LAMP SWITCH STOP LAMP ENGINE CONTROL SYSTEM BACK-UP POWER SUPPLY CIRCUIT DIAGRAM – Anti-lock Brake System (ABS) IGNITION SWITCH (IG2) • ACTIVE YAW CONTROL SYSTEM • INTERCOOLER WATER SPRAY SYSTEM ACCELERATION SENSOR (LATERAL) C-75 C-76 CIRCUIT DIAGRAM – Anti-lock Brake System (ABS) ANTI-LOCK BRAKE SYSTEM (ABS) (CONTINUED) MULTI-PURPOSE FUSE FUSIBLE LINK IGNITION SWITCH (IG1) VALVE RELAY COMBINATION METER MOTOR RELAY DIODE ACTIVE YAW CONTROL SYSTEM CIRCUIT DIAGRAM – Anti-lock Brake System (ABS) C-77 ACCELERATION SENSOR (LATERAL) ACCELERATION SENSOR (LONGITUDINAL) ACTIVE YAW CONTROL SYSTEM FRONT SPEED SENSOR REAR SPEED SENSOR C-78 CIRCUIT DIAGRAM – Anti-lock Brake System (ABS) ANTI-LOCK BRAKE SYSTEM (ABS) (CONTINUED) MOTOR RELAY VALVE RELAY HYDRAULIC UNIT INLET VALVE FRONT (LH) FRONT (RH) REAR (LH) REAR (RH) OUTLET FRONT FRONT VALVE (LH) (RH) REAR (LH) REAR (RH) MULTI-PURPOSE FUSE • CENTRAL DOOR LOCKING SYSTEM • FULLY AUTOMATIC AIR CONDITIONER FRONT VIEW DIAGNOSIS CONNECTOR C-79 NOTES C-80 CIRCUIT DIAGRAM – Active Yaw Control System (AYC) ACTIVE YAW CONTROL SYSTEM (AYC) IGNITION SWITCH (IG2) FUSIBLE LINK INTERCOOLER WATER SPRAY SYSTEM ACCELERATION SENSOR (LONGITUDINAL) ACCELERATION SENSOR (LATERAL) ENGINE CONTROL SYSTEM ANTI-LOCK BRAKE SYSTEM BACK-UP POWER SUPPLY CIRCUIT DIAGRAM – Active Yaw Control System (AYC) IGNITION SWITCH (IG1) BATTERY ENGINE-ECU DEDICATED FUSE • SUNROOF • SEAT BELT WARNING LAMP • METER AND GAUGE • RADIO COMBINATION METER STOP LAMP SWITCH ENGINE CONTROL SYSTEM THROTTLE POSITION SENSOR STOP LAMP C-81 C-82 CIRCUIT DIAGRAM – Active Yaw Control System (AYC) ACTIVE YAW CONTROL SYSTEM (AYC) (CONTINUED) MOTOR RELAY (ABS) FRONT SPEED SENSOR ANTI-LOCK BRAKE SYSTEM FRONT VIEW REAR SPEED SENSOR CIRCUIT DIAGRAM – Active Yaw Control System (AYC) FRONT SPEED SENSOR C-83 REAR SPEED SENSOR (MULTI-PURPOSE FUSE STEERING ANGLE SENSOR ) C-84 CIRCUIT DIAGRAM – Active Yaw Control System (AYC) ACTIVE YAW CONTROL SYSTEM (AYC) (CONTINUED) FUSIBLE LINK AYC RELAY PROPORTIONING VALVE AYC MOTOR FRONT VIEW DIRECTION VALVE CIRCUIT DIAGRAM – Active Yaw Control System (AYC) C-85 MULTI-PURPOSE FUSE • • CENTRAL DOOR LOCKING SYSTEM FULLY AUTOMATIC AIR CONDITIONER ACCUMULATOR PRESSURE SWITCH DIAGNOSIS CONNECTOR C-86 CIRCUIT DIAGRAM – Intercooler Water Spray System INTERCOOLER WATER SPRAY SYSTEM IGNITION SWITCH (IG2) VEHICLES WITHOUT ABS AND AYC VEHICLES WITH ABS OR AYC • ACTIVE YAW CONTROL SYSTEM • ANTI-LOCK BRAKE SYSTEM WATER SPRAY SWITCH WATER SPRAY MOTOR HY807002-538