Transcript
PARTS LIST
2009-2010 Yamaha FZ6R I n s t a l l a t i o n I n s t ru c t i o n s
1 1 1 1 2 1
Juice Box Pro™ USB Cable Top Tune CD-ROM Installation Guide Velcro strip Alcohol swab
THE IGNITION MUST BE TURNED OFF BEFORE INSTALLATION! DOWNLOAD THE TOPTUNE SOFTWARE AND LATEST MAPS FROM OUR WEBSITE:
www.twobros.com
PLEASE READ ALL DIRECTIONS BEFORE STARTING INSTALLATION 401 S. Grand Ave. Santa Ana, CA 92705 (800) 211-2767 www.twobros.com
ITBR001-257
www.twobros.com
2009-2010 Yamaha FZ6R - 1
S electing the M ap Pos ition T he J uice B ox Pro com es loaded with up to ten m aps . U s ing a #1 Phillips s crewdriver, turn the m ap s elect dial to toggle between the loaded m aps . R efer to the m ap pos ition table below for the m aps included in your J uice B ox Pro.
U s ing the R PM R ange Dials T he Low, M id, and High R PM Dials refer to the R PM range, in thirds , of your vehicle. E ach dial allows +/- 10% fuel adjus tm ent on top of what fuel changes are done in the m ap. W ith the dial facing s traight up, there is no additional fuel change. For exam ple, if your vehicle revs to 15,000 R PM : • the low R PM dial w ill adjus t 0-5000 R PM • the m id R PM dial will adjus t 5001-10000 R PM • the high R PM dial will adjus t 10001-15000 R PM
U s ing Top Tune Take your tuning to the next level w ith the Top Tune s oftware. U S B Port High R PM Dial M id R PM Dial Low R PM Dial M ap S elect S tatus Light (Power to U nit) Position 0
Zero map
Position 1
Stock exhaust Stock air filter
2009-2010 Yamaha FZ6R
Position 2
Two Brothers full exhaust Stock air filter
2009-2010 Yamaha FZ6R
Ins talling the Top Tune S oftw are 1 Ins ert the CD provided into your com puter ’s cd-rom drive. T he launch program will run autom atically. If auto-run is dis abled, double-click the M y Com puter icon then double-click the CD drive icon. Double-click T B R Top Tune.exe to m anually s tart the CD. 2 Click Ins tall S oftware and follow the on-s creen ins tructions to ins tall the Top Tune s oftware. T he Top Tune s oftware and m aps will be s tored in C:\Program Files \T B R Top Tune. 3 Click M ap Databas e. A ll m aps w ill autom atically be ins talled to the C:\Program Files \T B R Top Tune\m aps folder. Loading Additional M aps 1 Connect the U S B cable from the com puter to the J uice B ox Pro. Verify the cable is fully s eated in the J uice B ox Pro. 2 R un the Top Tune s oftware by double-clicking the program icon ins talled on your des ktop or on your s tart m enu. 3 Click Open M ap File and s elect a m ap file. 4 Click S end M ap. You can s end the m ap to any of the ten m ap pos itions . A ltering M aps U s ing Top Tune T he values in the m ap repres ent a percentage of fuel change over s tock. A value of 10 in the m ap indicates at that throttle pos ition and R PM range the vehicle will be 10% richer than s tock. If the value is -10, then it would be 10% leaner than s tock. You have the ability to fine tune your fuel curve by altering thes e values . T he Top Tune s oftware allows a value of +250 to -100 in each cell.
ITBR001-257
www.twobros.com
2009-2010 Yamaha FZ6R - 2
1.
Remove the seat.
2. Prop the front of the fuel tank up. Figure A is shown with the fuel tank removed which is not necessary.
Figure A
3. Using the supplied velcro, secure the Juice Box Pro underneath the inner fairing panel as shown in Figure A. Make sure to clean both surfaces with the alcohol swab before attaching.
Juice Box Pro harness
4. Route the Juice Box Pro wiring harness down the left side of the air box and go towards the throttle bodies as shown in Figure B.
Figure B
Juice Box Pro harness
5. Unplug the stock wiring harness from the throttle bodies as shown in Figure C. One connector is a white 4-pin and the other is a clear 6-pin.
Figure C
unplug
unplug
ITBR001-257
www.twobros.com
2009-2010 Yamaha FZ6R - 3
Figure D
6. Attach the connectors from the Juice Box Pro to the stock wiring harness as shown in Figure D.
7. ground wire
Attach the ground wire from the Juice Box Pro to the negative side of the battery as shown in Figure E.
8. Bolt the fuel tank back into place.
Figure E
9. Reinstall the seat.
ITBR001-257
www.twobros.com
2009-2010 Yamaha FZ6R - 4
