Glyn - Sanken Ipm Brochure 03/2014

Transcript

IPM Brochure Inverter Power Modules for Variable Speed Motor Applications IPM Overview Mains Supply Filter Status LED Rectifier Inrush current limiting Sanken IPM Sanken Intelligent Power Modules combine all the necessary power components required for efficient running of three phase electric motors in a complete and compact module. DC Link SMPS Voltage sense Current sense SMPS Motor Speed Sensor Interface Voltage sense Control Interface External control Debug Interface Motor Control IC INVERTER PCB The latest addition of trench-type IGBTs with outstanding conduction and switching performance, makes Sanken’s IPMs the ideal choice for modern energy efficient products. VCC HIN2 HIN3 LIN1 High Side Driver UV Detect HV Level Shift HIN1 Logic Low Side Driver UV Detect Delay Matching LIN2 LIN3 O.C.P COM FO To Low Side Emitter RCIN Application Areas Glossary of terms UVLO OCP OCL TD TSD TM FO 3 shunt Boot Diode STP 7.5VReg By combining three IGBT or MOSFET half bridge circuits, high-side & low-side drivers and adding protection / timing features, Sanken IPMs are simple to integrate and require only a few external components. Under-voltage lock-out Over-current protection Over-current limiter Over-temperature detection output Thermal shutdown Temperature monitor output Fault output Output of each emitter/source Built-in bootstrap diodes Short-circuit protection Built-in regulator output of 7.5V Air Con Central Heating Domestic Appliance Industrial Page 2 Expansion / Evolution / Eco-Solutions Inverter Power Modules SX SMA 1.5A to 2.5A 1.0A to 2.5A 105W 200W 3.3V Logic Compatible Yes Option Under voltage protection Yes Yes Over Current protection Yes Option Temperature shutdown protection Yes Option 3-shunt outputs No Option Integrated boot strap diodes Yes Yes SMD SIP Output current (cont., Tc=25degC) Approx. inverter output power (max) Package Picture of the package Typical application Circulation pump for central heating system; Fan for air conditioner; Fan for fridge; Drainage pump for dishwasher; Dosage and drainage pumps for washing machine. Page 3 Power Electronics for Next "E" Stage Fan, Fan for air conditioner; Circulation pump for dishwasher SLA SIM SCM 2A to 5A 2A to 5A 5A to 30A 365W 410W 3,100W Option Yes Yes Yes Yes Yes Option Yes Yes Option Yes Option Option Yes Yes Option Yes Yes SIP DIP DIP Central Heating Fan and Pump, Fan for air conditioner, Pump for dishwasher, Compressor for fridge, Dryer, Kitchen Hood Fan, Fan for air conditioner, Pump for dishwasher, Compressor for fridge Compressor for fridge and air conditioner, Fan for air conditioner, Washing Machine, Door / Gate opener, Industrial Pumps Page 4 Expansion / Evolution / Eco-Solutions SX Range High density multichip module packages using Sanken’s advanced bonding technology Functions & Features  Built-in bootstrap diodes with limit resistors  Built-in TSD (Thermal Shutdown) function  Built-in OCP (Overcurrent Protection) function  Built-in OCL (Overcurrent Limiter) function  Built-in UVLO (Under voltage Lock-Out protection) function  Output of fault signal during operation of protection circuit SOP-27 Lead-frame: 1890  Built-in 7.5 V, 35 mA regulated output  CMOS compatible inputs (3.3V & 5.0V)  Highly integrated motor driver IC with small SMD package dimensions of 22 mm x 11.4 mm x 2.1 mm 500V MOSFET SX68003MH Active 2.5A 500V MOSFET 2.4Ω Active – In Mass Production 4Ω ■ ■ ■ ■ ■ - ■ ■ ■ ■ ■ ■ - ■ ■ ■ ■ ■ ■ - ■ - - ■ - ■ - ■ - ■ - ■ - ■ - CS – Customer Samples (contact for latest status) Page 5 Power Electronics for Next "E" Stage Low Noise 1.5A 7.5V Reg Active STP SX68002MH Boot Diode MOSFET 1.5Ω Heatsink Pad 250V 3 shunt 2A TSD Active TD SX68001MH Power switch OCL Breakdown voltage OCP Output Current UVLO Status 5V logic Device Name Features 3.3V logic RDS(on) Max [Ω] / Vsat (Typ) [V]  SX6800xMH series motor drivers require fewer external components, and allow PCB designs that are simpler and smaller for embedded motor controller boards SMA Range High density multichip module packages using Sanken’s advanced bonding technology Functions & Features Lead-frame: 2452  Built-in bootstrap diodes with limit resistors  Built-in TD (Thermal Detection) or TSD (Thermal Shutdown) function  Built-in OCP (Overcurrent Protection) function (SMA685xMZ/X series)  Built-in OCL (Overcurrent Limiter) function (SMA685xMZ/X series)  Built-in UVLO (Under voltage Lock-Out protection) function  Output of fault signal during operation of protection circuit  Built-in 7.5 V, 35 mA regulated output (SMA682xMZ and SMA685xMZ/X series) Lead-frame: 2451  CMOS compatible inputs (3.3V & 5V, 5V for SMA686xMZ series)  Highly integrated motor driver IC with small SIP (SMA 24pin) package dimensions of 31 mm x 10.4 mm x 4.0 mm 500V MOSFET SMA6823MH Active 2.5A 500V MOSFET 2.4Ω SMA6852MZ Active 1.5A 500V MOSFET SMA6853MX Active 2.5A 500V MOSFET 2.4Ω SMA6854MZ Active 1.5A 600V MOSFET 3.5Ω SMA6860MZ Active 1A 500V MOSFET 1.8Ω SMA6861MZ Active 2A 250V MOSFET 1.5Ω SMA6862MZ Active 1.5A 500V MOSFET SMA6863MZ Active 2.5A 500V MOSFET 2.4Ω SMA6864MZ Active 2.5A 250V MOSFET 0.5Ω SMA6865MZ Active 2.5A 500V MOSFET 1.7Ω Active – In Mass Production 4Ω 4Ω 4Ω Low Noise 1.5A 7.5V Reg Active STP SMA6822MH Boot Diode MOSFET 1.5Ω Heatsink Pad 250V 3 shunt 2A TSD Active TD SMA6821MH Power switch OCL Breakdown voltage OCP Output Current UVLO Status 5V logic Device Name Features 3.3V logic RDS(on) Max [Ω] / Vsat (Typ) [V]  SMA68 series motor drivers require fewer external components, and allow PCB designs that are simpler and smaller for embedded motor controller boards ■ ■ ■ ■ ■ ■ - ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ - ■ ■ ■ ■ ■ ■ ■ ■ ■ - - ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ - ■ ■ ■ ■ ■ ■ - - CS – Customer Samples (contact for latest status) Page 6 Expansion / Evolution / Eco-Solutions SLA Range High density multichip module packages using Sanken’s advanced bonding technology Functions & Features SLA 23 3A 600V IGBT 1.75V SLA6845MZ Active 3A 600V IGBT 1.75V SLA6866MZ Active 2A 250V MOSFET 1.5Ω SLA6868MZ Active 2.5A 500V MOSFET 2.4Ω SLA6870MZ Active 3A 500V MOSFET 1.7Ω Active – In Mass Production ■ ■ ■ - ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ - ■ ■ ■ ■ - ■ ■ ■ ■ ■ ■ ■ ■ ■ - - - - - ■ - - - - - - - CS – Customer Samples (contact for latest status) Page 7 Power Electronics for Next "E" Stage Low Noise Active 7.5V Reg SLA6816MZ STP 1.75V Boot Diode IGBT Heatsink Pad 600V Features 3 shunt 5A 2178 TSD CS 2175 Lead-frames TD SLA6806M 2171 OCL Power switch SLA 24 OCP Breakdown voltage 2153 UVLO Output Current 2152 Lead-frames 5V logic Status 2151 (underlined parts only) 3.3V logic Device Name RDS(on) Max [Ω] / Vsat (Typ) [V]  Built-in bootstrap diodes with limit resistors (SLA686/7xMZ series)  Built-in TD (Thermal Detection, SLA6845MZ) or TSD (Thermal Shutdown, SLA686/7xMZ series) function  Built-in OCP (Overcurrent Protection) function (SLA68x6M(Z) and SLA686/7xMZ series)  Built-in OCL (Overcurrent Limiter) function (SLA686/7xMZ series)  Built-in UVLO (Under voltage Lock-Out protection) function  Output of fault signal during operation of protection circuit  CMOS compatible inputs (3.3V and 5V, 5V for SLA686/7xMZ series)  Highly integrated motor driver IC with small SIP (SLA 24-pin) package (SLA 23-pin for SLA68x6M(Z)) dimensions of 31 mm x 16 mm x 4.8 mm with heat sink tab  SLA68 series motor drivers require fewer external components, and allow PCB designs that are simpler and smaller for embedded motor controller boards SIM Range Ideal for mid-size motor applications, allows reduction of external component count Functions & Features  Built-in bootstrap diodes with limit resistors  Built-in TSD (Thermal Shutdown) function  Built-in OCP (Overcurrent Protection) function  Built-in OCL (Overcurrent Limiter) function  Built-in UVLO (Under voltage Lock-Out protection) function  Output of fault signal during operation of protection circuit  CMOS compatible inputs (3.3V & 5.0V)  Highly integrated motor driver IC with small DIP package dimensions of 36 mm x 14.6 mm x 4.0 mm  Isolation rating of 1,500 Vrms/min, UL recognised: UL1557 file E118037  SIM680xxM series includes low noise versions  SIM680xxM series motor drivers require fewer external components, and allow PCB designs that are simpler and smaller for embedded motor controller boards 500V MOSFET 2.4Ω SIM6813M Active 3A 500V MOSFET 1.7Ω SIM6852M Active 2.5A 500V MOSFET 2.4Ω SIM6853M Active 3A 500V MOSFET 1.7Ω SIM6816M CS 2A 500V MOSFET SIM6817M CS 2.5A 500V MOSFET 2.4Ω SIM6821M CS 2A 600V MOSFET 3.5Ω SIM6822M Active 5A 600V IGBT 1.75V SIM6862M Active 5A 600V IGBT 1.75V SIM6827M Active 5A 600V IGBT 1.75V Active – In Mass Production 4Ω ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ - ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ - ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ ■ - - - - - - - - - ■ - ■ - - ■ - ■ - - - ■ - - - ■ - - - - - - - ■ - - - - ■ Low Noise 2.5A 7.5V Reg Active RCIN Pin SIM6812M STP 4Ω Boot Diode MOSFET Heatsink Pad 500V 3 shunt 2A TSD Active TD SIM6811M OCL Power switch OCP Breakdown voltage UVLO Output Current 5V logic Status Features 3.3V logic Device Name RDS(on) Max [Ω] / Vsat (Typ) [V] SOP-40 Lead-frame: 2971 CS – Customer Samples (contact for latest status) Page 8 Expansion / Evolution / Eco-Solutions SCM Range Expand the capacity to 30A in a small robust package with Trench IGBT Functions & Features  Built-in bootstrap diodes with limit resistors Heat-sink Pad  Built-in TSD (Thermal Shutdown) function Lead-frame:  Built-in OCP (Overcurrent Protection) function 2552  Built-in STP (Shoot Through Protection)  CMOS compatible inputs (3.3V & 5.0V) function  Highly integrated motor driver IC with small  Built-in UVLO (Under voltage Lock-Out DIP package dimensions of 47 mm x 19.0 mm protection) function x 4.4 mm  Output of fault signal during operation of  Isolation rating of 2,000 Vrms/min, UL protection circuit recognised: UL1557 file E118037  SCM125/6xM(F) series are low noise versions  SCM124/5/6xM(F) series motor drivers Fully Moulded require fewer external components, and allow Lead-frame: PCB designs that are simpler and smaller for 2551 embedded motor controller boards 5V logic UVLO OCP OCP Filter TSD Active 10A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ Low Noise 3.3V logic SCM1241M STP Power Switch Boot Diode Breakdown Voltage Bootstrap Resistor Output Current Heatsink Pad Status 3 Shunt Device Name RDS(on) Max [] Vsat (typ) [V] Features ■ - 22Ω ■ ■ - SCM1242M CS 15A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ - 22Ω ■ ■ ■ SCM1242MF Active 15A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ ■ 22Ω ■ ■ ■ SCM1243M Active 15A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ - 22Ω ■ ■ - SCM1243MF Active 15A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ ■ 22Ω ■ ■ - SCM1245MF Active 20A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ ■ 22Ω ■ ■ - SCM1246MF Active 30A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ ■ 22Ω ■ ■ - SCM1248M Active 5A 500V MOSFET 0.8Ω ■ ■ ■ ■ 1500nS ■ ■ - 22Ω ■ ■ - SCM1250M Active 10A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ - 22Ω ■ ■ ■ SCM1251M CS 10A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ - 22Ω ■ ■ ■ SCM1253MF CS 15A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ ■ 22Ω ■ ■ ■ SCM1255MF CS 20A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ ■ 22Ω ■ ■ ■ SCM1256MF Active 30A 600V IGBT 1.7V ■ ■ ■ ■ 1500nS ■ ■ ■ 22Ω ■ ■ ■ SCM1261M CS 10A 600V IGBT 1.7V ■ ■ ■ ■ 540nS ■ ■ - 22Ω ■ ■ ■ SCM1262MF CS 15A 600V IGBT 1.7V ■ ■ ■ ■ 540nS ■ ■ ■ 210Ω ■ ■ ■ SCM1263MF CS 15A 600V IGBT 1.7V ■ ■ ■ ■ 540nS ■ ■ - 22Ω ■ ■ ■ SCM1263MF CS 15A 600V IGBT 1.7V ■ ■ ■ ■ 540nS ■ ■ ■ 22Ω ■ ■ ■ SCM1264MF CS 20A 600V IGBT 1.7V ■ ■ ■ ■ 540nS ■ ■ ■ 210Ω ■ ■ ■ SCM1265MF Active 20A 600V IGBT 1.7V ■ ■ ■ ■ 540nS ■ ■ ■ 22Ω ■ ■ ■ SCM1266MF CS 30A 600V IGBT 1.7V ■ ■ ■ ■ 540nS ■ ■ ■ 22Ω ■ ■ ■ SCM1267MF CS 30A 600V IGBT 1.7V ■ ■ ■ ■ 540nS ■ ■ ■ 210Ω ■ ■ ■ Active – In Mass Production CS – Customer Samples (contact for latest status) Page 9 Power Electronics for Next "E" Stage Sanken Electric Co., Ltd. Headquarters: Saitama-ken, Japan Net Sales: €1,181m, 47% Japan, 35% Asia, 10% NA, 8% Europe Established: 1946 Group Companies: 8 Japan, 12 Asia, 2 US, 2 Europe Employees: 10,427 Listed on Tokyo and Osaka Stock Exchanges Page 10 Expansion / Evolution / Eco-Solutions Internationales GLYN Netzwerk GLYN Norway GLYN Sweden Germany Head Office GLYN Denmark GLYN U.K. GLYN Poland GLYN Benelux GLYN GmbH & Co. KG GLYN Germany GLYN Austria & Czech Republic GLYN Switzerland Am Wörtzgarten 8 D-65510 Idstein www.glyn.de GLYN Australia GLYN Hungary GLYN Bulgaria GLYN New Zealand Tel.: +49 6126 590-222 [email protected] Nettetal Tel.: +49 2157 124-222 [email protected] Norderstedt Tel.: +49 40 3204699-0 [email protected] Pforzheim Tel.: +49 7231 42441-00 [email protected] Unterhaching Tel.: +49 89 3216 4957-0 [email protected] Australia GLYN Ltd. Tel.: +61 2 8850-0320 www.glyn.com.au [email protected] Bulgaria Cooperation Partner Universal 98 Ltd. Tel.: +359 2 8708009 www.uni98-bg.com [email protected] New Zealand GLYN Ltd. Tel.: +64 9 441-9050 www.glyn.co.nz [email protected] Sweden GLYN GmbH & Co. KG (Germany) Tel.: +46 293 300-84 www.glyn.se [email protected] Austria & Czech Republic GLYN GmbH & Co. KG (Germany) Tel.: +43 2236 311112-0 www.glyn.at [email protected] Denmark GLYN GmbH & Co. KG (Germany) Tel.: +45 7020 1633 www.glyn-nordic.dk [email protected] Norway Link Electronics AS Tel.: +47 6988-9899 www.linknordic.com [email protected] Switzerland GLYN GmbH & Co. KG (Germany) Tel.: +41 44 944 55-00 www.glyn.ch [email protected] Benelux GLYN GmbH & Co. KG (Germany, via Nettetal) Tel.: +31 6 10930497 www.glyn.com [email protected] Hungary GLYN GmbH & Co. KG (Germany) Tel.: +36 1 204 9571 www.glyn.hu [email protected] Poland GLYN GmbH & Co. KG (Germany) Tel.: +48 71 7828-758 www.glyn.pl [email protected] U.K. Cooperation Partner First Byte Micro Ltd. U.K. Head Office Tel.: +44 1277 634200 www.firstbytemicro.com sales@firstbytemicro.com © 2014-01 by GLYN GmbH & Co. KG Achtung! Mit dieser Übersicht präsentieren wir Ihnen nur einen Auszug aus unserer Produktpalette. In einigen europäischen Ländern wurden mit diversen Herstellern spezielle bzw. einschränkende Vereinbarungen getroffen.