Gto3501 - Minjja

Transcript

GTO3501 1 CHANNEL POWER AMPLIFIER SERVICE MANUAL JBL Consumer Products 250 Crossways Park Dr. Woodbury, New York 11797 Released 2007 Discontinued XXXX Rev1 1/2008 GTO3501 - CONTENTS SPECIFICATIONS ………………………………………..1 PACKING……………………………………………..…....2 CONTROL/INSTALLATION DRAWINGS………………3 CONTROL/INSTALLATION INSTRUCTIONS………....4 BASIC TROUBLESHOOTING………….........................5 EXPLODED VIEW/PARTS LIST…….….….…………....6 AMPLIFIER BLOCK DIAGRAM…………………….……7 ELECTRICAL PARTS LIST ..……….……….…….…….8 P.C.B. DRAWINGS….………………………....…...……12 IC/TRANSISTOR PINOUTS..……………….…...….…..14 SCHEMATICS……………..……………….………..…...15 GTO 3501 Specifications Output Power: (14.4V supply) Signal-to-noise ratio: Dynamic power: Frequency response: THD+N 1KHz LPF=22KHz Input Impedance Maximum input signal: Maximum sensitivity: Bass Boost @ 50Hz DC Offset Output regulation: Idle Current @ 4 ohms Max Current Draw Remote Operating Voltages Turn-on delay time Circuit Protection Operating voltage range Dimensions: Fuses: 225W RMS x 1 channels @ 4 ohms; ≤1% THD + N 360W RMS x 1 channels @ 2 ohms; ≤1% THD + N 85dBA (reference 1W into 4 ohms) 104dBA (reference rated power into 4 ohms) 350W @ 2 ohms 20Hz – 330Hz (–3dB) ≤0.04% (rated power @ 4 ohms) >20K ohms 6.0V 100mV 0-12dB <30mV .03dB @ 4 ohms 0.8A <45A @ 2 ohms ON 5V OFF 4V 2-3 sec Temperature (90±5C), Short circuit (8-16V) 12 1/4 x 10 3/8 x 2 1/8” (310 x 263 x 53mm) (2) x 30A JBL continually strives to update and improve existing products, as well as create new ones. The specifications and details in this and related JBL publications are therefore subject to change without notice. 1 GTO3501 Item 1 2 3 4 5 6 7 8 9 Part Number Description CH3923221133 BZL311105120 GTO3501 Outer Carton Packing Foam Amplifier Plastic bag Plastic bag Owner’s manual Accessory kit consisting of: Mounting Screws 30A Fuse Remote Level control Phone cable 4PIN Black L=6M, 6P4C Visit www.jbl.com LS1AA0404501 1601-303G-00 REMOTE GTO AMP 2100-0009-04 2 Qty 1 2 1 1 1 1 4 2 1 1 GTO3501 4x 2x 2x 1x 1x 1x 10-3/8" 263mm 0 1 2 12-1/4" 310mm 2-1/8" 53mm D ±ÈÀý 1.000 34 5 6 B A 8 9 A 1" 25mm 7 A B C B C 1-5/8" 40mm D A 8 3 GTO3501 GTO3501 CAR AUDIO SUBWOOFER AMPLIFIER OWNER’S MANUAL Installation Warnings and Tips: • Disconnect the negative (–) lead from your vehicle’s battery. • At the installation sites, locate and make a note of all fuel lines, hydraulic brake lines, vacuum lines and electrical wiring. Use extreme caution when cutting or drilling in and around these areas. • Choose a safe mounting location away from moisture. • Make sure there is sufficient air circulation at the mounting location for the amplifier to cool itself. • Mount the amplifier, using the supplied hardware. Specifications • 225W RMS x 1 channel @ 4 ohms and ≤1% THD + N* • 360W RMS x 1 channel @ 2 ohms and ≤1% THD + N* • THD + N: 0.04% (rated power @ 4 ohms) • Signal-to-noise ratio: 85dBA (reference 1W into 4 ohms)* • Signal-to-noise ratio: 104dBA (reference rated power into 4 ohms) • Frequency response: 20Hz – 330Hz (–3dB) • Max power: 360 watts * CEA-2006A-compliant 0 Speaker Output Connectors • Connect the subwoofer to these terminals, observing proper polarity. Either + or – terminal may be used. Minimum total impedance is 2 ohms. 1 Fuses • Replace only with the same type and rating. 2 Power Input Connectors • +12V: Connect to the positive terminal of the vehicle’s battery. 8 AWG wire is recommended. Install an appropriate fuse holder and fuse (60A minimum) within 18 inches of the battery. Make sure the wire is not damaged or pinched during installation. Install protective grommets when routing wires through the firewall or other sheet metal. • GND: Connect to the vehicle’s chassis. Refer to the picture below. Factory Bolt Ring Connector Ground Wire Note: Remove any paint below ring connector. Star Washer • REM: Connect to the “Remote Out” lead from the source unit or to a source of switched 12V+ (ACC). 3 Aux Output Connectors (RCA) • Nonfiltered pass-through output. Connect to the input of an additional amplifier. 4 Input Connectors (RCA) • Connect to the RCA outputs from the source unit or signal processor. 5 Input-Level Control • Used to match the input level of the amplifier to the output level of the source unit. • See B for the adjustment procedure. 6 Low-Pass Filter Frequency Control • 12dB/octave low-pass filter, variable from 32Hz to 320Hz. • See C for the adjustment procedure. 4 7 DBO (Dynamic Bass Optimization) Variable Subsonic High-Pass Filter With Variable Boost (Q) • For woofers in tuned (vented) enclosures, set the Frequency control to a value 10Hz below the enclosure’s resonance (tuned) frequency. • For woofers in sealed boxes, set the control to any value you prefer between 30Hz and 50Hz. • Set the Boost control according to your preference, being careful not to apply enough boost to damage your woofer(s). A DBO High-Pass Filter Frequency control, variable between 10Hz and 100Hz. See above for appropriate settings. B DBO Boost control provides up to 12dB of boost slightly above the highpass filter’s frequency. See above for appropriate settings. 8 Remote Level Control (RLC) Connector • Connect the Remote Level Control (RLC) here, using the supplied RJ-11 cable. 9 Power On LED • Illuminated when the amplifier is on. A Protect LED • Illuminated under any of the following fault conditions: battery over/under voltage, short circuit in speaker wires, amplifier is too hot, amplifier’s output circuit has failed (DC voltage is present in the amplifier’s output). B Setting Input Level A Turn Input Level control counterclockwise to 6V (minimim). B With a dynamic music track playing, turn the head unit’s volume control to the 3/4 position. C Turn Input Level control clockwise until the bass output is proportionate to the output of the high-frequency speakers, according to your preference. D Input level is now adjusted correctly. C Setting the Crossover A Crossover setting for subwoofers. Note: Acceptable frequency ranges are indicated in gray. D Remote Level Control The Remote Level Control, if installed, will allow you to adjust the level of bass while seated in the listening position. GTO3501 Amplifier Troubleshooting Guide 1. Status LED on Amplifier not Lit - Head Unit (Source) Turned ON Verify: A. Remote turn-on wire from source to amplifier has proper voltage B. Power (B+) connections at amplifier, terminal blocks, and battery are secure C. Ground (GND) connections at amplifier and vehicle chassis are secure D. Battery B+ fuse (if used) is OK E. Amplifier fuse is OK F. B+ at battery and B+ at amplifier has proper voltage 2. Status LED’s Lit, No Output from Speakers in Normal Operating Condition Verify: A. RCA cables from amplifier to source are securely connected B. Volume adjustment on amplifier is correctly adjusted C. Source is ON and playing 3. Engine Noise From Speaker(s) Turn source OFF, Disconnect RCA cables at amplifier. If noise stops, check equipment & cables leading to amplifier. Verify: A. RCA cables are of good quality with no breakage to internal shields B. RCA cables from source to amplifier are not run alongside any power cables 4. Amplifier Output Distorted Music Verify: A. Source output music to amplifier is not distorted B. Source output sensitivity is correctly adjusted 5. Amplifier Shuts Down, Green LED’s are Lit - Amplifier is in Thermal Protection Mode Verify: A. Amplifier is mounted with adequate air circulation around heatsinks or vents B. Amplifier is not mounted under carpet or sealed enclosure C. Speakers meet correct impedance for application (mono or stereo hookup) 6. Amplifier Does Not Turn ON, and Red LED is Lit Amplifier (and not Connected to a Shorted Speaker) Verify: A. Speaker crossover (if used) is not defective 5 GTO3501 Part Number Part Number Trans. Clamp Trans. Clamp 1380-0003-00 RCA CAP (Red) RCA CAP (Wht) Front Plate Standoff 6 1 2 3 4 GTO3501 D D BALANCED INPUT UNIT OP MODEL FREQ VARIABLE LP 11HZ--320HZ/12dB BALANCED INPUT UNIT C MAIN AMP FRONTL 2ohm/4ohm C GAIN CONTROL OP BASS BOOST VARIABLE 0dB--12dB/20HZ~100HZ OP 11 25 320 11 20HZ~100HZ 320 OP AMP SPEAKER AUX OUT L OP B B +V AUX OUT R + +VCC Battery POWER SUPPLY OP -VCC - -V A A 7 1 2 3 4 GTO3501 GTO3501 Electrical Parts List Description Part Number Qty Reference Designator MAIN PCB Resistors 0702-34R7-02 0702-4220-02 0702-3101-02 0702-24R7-02 0702-2472-02 0702-3271-02 07301220XK01 0702-1680-02 0702-1101-02 0702-1201-02 0702-1221-02 0702-1471-02 0702-1821-02 0702-1102-02 0702-1431-02 0702-1152-02 0702-1182-02 0702-1302-02 0702-1222-02 0702-1332-02 0702-1472-02 0702-1512-02 0702-1562-02 0702-1682-02 0702-1752-02 Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor 1/2W 4.7Ω ±5% 1W 22Ω ±5% 1/2W 100Ω ±5% 1/4W 4.7Ω ±5% 1/4W 4.7KΩ ±5% 1/2W 270Ω ±5% 1/8W 22Ω ±1% 1/8W 68Ω ±5% 1/8W 100Ω ±5% 1/8W 200Ω ±5% 1/8W 220Ω ±5% 1/8W 470Ω ±5% 1/8W 820Ω ±5% 1/8W 1KΩ ±5% 1/8W 430Ω ±5% 1/8W 1.5KΩ ±5% 1/8W 1.8KΩ ±5% 1/8W 3KΩ ±5% 1/8W 2.2KΩ ±5% 1/8W 3.3KΩ ±5% 1/8W 4.7KΩ ±5% 1/8W 5.1KΩ ±5% 1/8W 5.6KΩ ±5% 1/8W 6.8KΩ ±5% 1/8W 7.5KΩ ±5% 0702-1103-02 Resistor 1/8W 10KΩ ±5% 0702-1153-02 0702-1203-02 0702-1223-02 0702-1243-02 0702-1333-02 Resistor Resistor Resistor Resistor Resistor 1/8W 15KΩ ±5% 1/8W 20KΩ ±5% 1/8W 22KΩ ±5% 1/8W 24KΩ ±5% 1/8W 33KΩ ±5% 0702-1473-02 Resistor 1/8W 47KΩ ±5% 0702-1563-02 0702-1474-02 0702-1104-02 0705-515X-07 0704-6202-02 0702-1205-02 1204-5011-01 1204-5031-30 1204-2041-03 1204-5031-34 Resistor Resistor Resistor Resistor Resistor Resistor potentiometer potentiometer potentiometer potentiometer 3 3 2 6 1 2 5 2 7 1 3 1 1 8 1 6 2 1 2 1 4 1 2 3 1 1/8W 56KΩ ±5% 1/8W 470KΩ ±5% 1/8W 100KΩ ±5% 5W 0.15Ω ±5% 2W 2KΩ ±5% 1/8W 2MΩ ±5% B500 KQ L=15 ±15% BOOST B50K ±15% R0971G INPUT LEVEL A2K/A200K KQ A2K,A200K HP FREQ C50K KQ L=15 ±15% LP FREQ R242 R37 R36 R142 R141 R140 R223 R222 R231 R229 R228 R227 R226 R225 R122 R221 R220 R213 R212 R211 R210 R112 R203 R202 R42 R138 R137 R136 R134 R133 R132 R45 R207 R131 R129 R240 R38 R201 R200 R113 R33 R32 R31 R30 R25 R49 R253 R252 R250 R249 R241 R238 R48 R41 R159 R204 R217 R120 R205 R110 R109 R26 R39 R15 R9 R216 R215 R214 R50 R121 R103 R102 R101 R100 R62 R27 9 R21 R117 2 R256 R239 3 R119 R18 R17 4 R208 R106 R7 R1 2 R209 R40 1 R118 R29 R28 R24 R23 R13 R12 R11 R10 R8 13 R6 R5 R4 R3 3 R150 R235 R14 1 R206 4 R2 R54 R53 R218 6 R260 R259 R237 R234 R233 R236 2 R108A R107A 1 R44 1 VR4 1 VR1 1 VR3 1 VR2 2.2UF/50V ±20% 5*11 105C 100UF/16V±20% 5*11 105C black 100uF/25V ±20% 6.3*11 105C black 220uF/25V ±20% 8*12 105C black 22uF/25V ±20% 5*11 105C black 470uF/35V ±20% 10*17 105C 47UF/35V ±20% 5*11 105C 47uF/16V ±20% 5*11 105C black 1 3 1 2 1 2 2 1 Capacitors 06D212256301 06D211073116 06D211074100 06D212264103 06D212264102 06D214775117 06D214765000 06D214763109 CAP,Electro CAP,Electro CAP,Electro CAP,Electro CAP,Electro CAP,Electro CAP,Electro CAP,Electro 8 C208 C104 C138 C137 C148 C209 C139 C103 C8 C134 C133 C36 C35 C102 GTO3501 Description Part Number Qty Reference Designator 2200UF/35V Φ16*26MM ±20% 105C 3300UF/63V ±20% 30*25 105C 22uF/50V ±20% 5*11 105C 220UF/25V ±20% 8*16 105C 184/63V ±5% 684/63V ±5% 473/100V ±5% green 104/100V ±5% green 22pF/100V ±20% green 56PF/100V ±20% 220pF/100V ±20% 2 2 8 3 1 1 1 3 2 2 1 MAIN PCB 06D212285101 06D213389001 06D212266010 06D212274001 06D341849400 06D346849400 06D324737200 06D321047200 06D232207000 06D235607000 06D232217000 CAP,Electro CAP,Electro CAP,Electro CAP,Electro MET Capacitor MET Capacitor Capacitor Capacitor porcelin cap Capacitor porcelin cap 06D231017000 porcelin cap 100pF/100V ±20% 9 06D234717001 06D234737001 06D236817000 porcelin cap Capacitor porcelin cap 470PF/100V ±20% 473/100V ±20% 680pF/100V ±20% 1 1 2 06D231047000 porcelin cap 0.1uF/100V ±20% 18 06D321027200 06D321037200 Capacitor Capacitor 102/100V ±5% green 103/100V ±5% 1 2 C124 C122 C145 C144 C4 C5 C7 C9 C10 C13 C14 C204 C1 C2 C207 C3 C47 C24 C46 C211 C206 C44 C42 C202 C201 C38 C21 C20 C19 C18 C16 C15 C23 C48 C49 C37 C205 C203 C200 C101 C121 C120 C118 C117 C115 C114 C100 C32 C30 C1B C1A C129 C128 C130 C131 C146 C147 C142 C127 C126 1N4148 GSS 200MA 75V DO-35 1N4004 DO-41 MIC6A4 8.2V DO-35 0.5W FR104 1A 400V KTB817 PNP TO-3P 2N5551 NPN TO-92 2N5401 PNP TO-92 2SA1015 150MA 60V 400MW PNP TO92 2SB649A 1.5A 180V 20W PNP TO-126 2SD669A NPN TO-126 2SB647 1A 120V 0.9W PNP TO-92 7 1 1 1 4 3 4 2 D100 D202 D208 D205 D204 D201 D200 D111 D106 DZ100 D107 D108 D109 D110 Q215,Q220,Q222 Q212 Q211 Q210 Q1 Q215 Q214 2 Q108 Q107 2 3 1 6 3 1 1 1 1 6 1 1 4 1 1 1 Q217 Q218 Q213 Q201 Q202 Q200 Q122 Q209 Q208 Q102 Q101 Q100 Q204-Q206 U100 U101 Q216 Q207 Q113 Q114 Q115 Q116 Q117 Q118 LED100 LED101 U1 U2 U3 U4 R43 D114 D115 1 1 2 1 2 1 L1A Semiconductors 04PT-4148-04 04ZL-4004-03 04GS-C6A4-00 04WY-82AV104 04GS-R104-00 03P1-B817-13 03N1-5551-01 03P1-5401-01 03P1-1015-01 diode diode diode diode schottky diode Transistor Transistor Transistor Transistor 03P1-B649-07 Transistor 03N1-669A-07 Transistor 03P1-B647-01 Transistor 2SC1815GR 150MA 60V 400MW NPN TO-92 03N1-1815-01 Transistor 03N1-1047-13 Transistor KTD1047 NPN TO-3P 01FA-7815-04 +15v Regulator KA7815E TO-220 FAIRCHILD 01FA-7915-04 neg15v Regulator KA7915 TO-220 FAIRCHILD 03N1-667A-01 Transistor 2SD667AC 1A 120V 0.9W NPN TO-92 03N1-8050-01 Transistor 8050D NPN TO-92 03T1-Z48N-02 MOS Transistor IRFZ48N TO-220 2004-0014-00 LED Φ3.0MM blue with blue light 2000-0017-00 LED red with red light Φ3MM 2P 01JR-4560-01 Dual Op-amp NJM4560D -8 2601-0202-00 OptoTransistor LCR-0202 2202-1602-05 Rectifier UF1602CT AKA 16/200V TO-220 2202-1620-05 Rectifier MUR1620CTA KAD 16A/200V TO-220 Miscellaneous 1005-5R04-10 1380-0003-00 1601-303G-00 1404-0020-04 1501-0209-00 1413-0001-00 toroidal inductor temp switch fuse socket socket phone socket 5UH φ23 φ1.0*5 90C KSD-301 30A/32V DC AV4-8.4-38 Pitch 2.54MM 2PIN 6P4C RJ11 HPCB-3021-6P4C black 9 F100 RCA1 CN104 CN105 JK1 GTO3501 Description Part Number Qty Reference Designator MAIN PCB 1501-0300-02 1501-0400-01 terminal terminal 3000-GT00-01 transformer 1401-0008-00 PL-L0002-000 fuse holder sheet ground 2100-0083-02 wire BTS3-24 BTS4-23 Φ40 4:15:8 F1=F2=Φ0.8*12*4TS S1=S2=Φ0.8*6*15TS S3=S4=Φ0.8*1*8TS 2PIN BXS2-09 GND-3 2PIN P=2.54MM 1007# 26AWG L=85MM (A2501TOP-2)5MM 105C Alum. Bar with Insulated paper Alum. Bar with Insulated paper 1 1 SMD 220Ω 1/8W ±1% 0805 SMD 100Ω 1/8W ±1% 0805 SMD 1KΩ 1/8W ±1% 0805 SMD 3KΩ 1/8W ±1% 0805 SMD 4.7KΩ 1/8W ±1% 0805 SMD 6.8KΩ 1/8W ±1% 0805 SMD 5.6KΩ 1/8W ±1% 0805 SMD 10K 1/8W ±1% 0805 SMD 11KΩ 1/8W ±1% 0805 SMD 12KΩ 1/8W ±1% 0805 SMD 15KΩ 1/8W ±1% 0805 SMD 18KΩ 1/8W ±1% 0805 SMD 22KΩ 1/8W ±1% 0805 SMD 33KΩ 1/8W ±1% 0805 SMD 330KΩ 1/8W ±1% 0805 SMD 100KΩ 1/8W ±1% 0805 1 L102 1 1 1 tem switch 2 2 14.0x7.0x64.0 14.0*7.0*64.0 1 1 6 1 1 2 1 2 1 1 1 1 2 1 1 3 R17 R10 R31 R30 R29 R28 R26 R15 R13 R11 R5 R51 R14 R1 R23 R27 R24 R53 R7 R18 R9 R65 R3 R25 R12 R4 CAP,Electro 1uF/25V ±20% 4*7 105C CAP,Electro 100UF/25V 6.3*7mm 5mm ±20% 105C CAP,Electro 220UF/16V ±20% 8*7 105C 5MM CAP,Electro 47UF/25V ±20% 6*7 105C 5mm SMD Capacitor SMD 1000pF/50V 0805 NPO ±5% SMD Capacitor SMD 0.1uF/50V 0805 X7R ±10% 1 1 1 2 1 2 C3 C27 C22 C1 C20 C26 C4 C25 diode schottky diode schottky diode Transistor Transistor Transistor IC PWM SMD 3.9V DO-213AA 0.5W SMD 15V 1/2W ±2% DO-213AA SMD 1N4148 DO-213AA SMD 2SA1015 SOT-23 PNP 2SB649A 1.5A 180V 20W PNP TO-126 SMD 2SC1815 SOT-23 NPN SMD TL494C SO-16 2SA1015 150MA 60V 400MW PNP TO92 1 1 6 1 1 4 1 ZD2 ZD1 D4 D1 D20 D3 D2 D13 Q10 Q6 Q3 Q2 Q7 Q1 U1 2 Q9 Q8 PITCH 2.54mm 4PIN 90° 2 CN2 CN1 PL-A0054-000 PL-A0056-000 PWM PCB Resistors 0701-2221-03 0701-2101-03 0701-2102-03 0701-2302-03 0701-2472-03 0701-2682-03 0701-2562-03 0701-2103-03 0701-2113-03 0701-2123-03 0701-2153-03 0701-2183-03 0701-2223-03 0701-2333-03 0701-2334-03 0701-2104-03 SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor SMD Resistor Capacitors 06D211054104 06D211074101 06D212273001 06D214764103 06S321026000 06S121046000 Semiconductors 04WY-39AV101 04WY-15BV-01 04PT-4148-01 03P1-1015-04 03P1-B649-07 03N1-1815-04 01TI-L494-09 03P1-1015-01 Transistor Miscellaneous 1501-0409-02 socket 10 GTO3501 Description Part Number Qty Reference Designator LED PCB 0701-3102-02 2100-0067-02 2100-0068-02 Resistor wire wire 2005-0009-00 LED 06S121046000 SMD 1KΩ 1/4W ±5% 1206 2PIN UL1007 AWG26 L=70mm 105℃ 2PIN UL1007 AWG26 L=210mm 105℃ 8 2 1 LED 2*3*4mm、 8 SMD Capacitor SMD 0.1uF/50V 0805 X7R ±10% 1 11 R1 R2 R3 R4 R5 R6 R7 R8 LED1 LED2 LED3 LED4 LED5 LED6 LED7 LED8 C1 GTO3501 12 GTO3501 13 GTO3501 14 GTO3501 1 2 3 C4 104 R7 18K D20 D1 4148 4148 ZD1 15V D CN1 CON4 R10 100 R1 10K Q1 C1815 4 R13 3K R11 4.7K REM DC12V 12V GND 1 2 3 4 +12V Q6 B649 D ZD2 3V9 Q2 C1815 R14 C1 47/25V 7K5 C2 10/25V R25 +12 100k D2 9 C R30 1K R28 1K E1 E2 OP1 R29 1K Q8 A1015 R31 1K 8 GND 7 R 6 5 C DT 10 11 VCC OP2 12 13 14 FED 3 - + 1 Q9 A1015 U1 TL494 TL494CN 330K 220/16V R17 220R R24 12K 4 R23 10K R3 22K 2 R18 CON + D4 4148 C22 Q3 C1815 REF R5 6K8 PRO 4148 15 Q10 A1015 C 1K R26 - R53 15K 16 C3 1U/50V D3 C20 47/16V B R4 100K R65 33K 4148 D13 4148 B C25 104 R51 6K8 R27 11K C26 102/M R9 22K C27 100/25V CN2 CON4 R12 100K 1 2 3 4 PRO +12 R15 1K REV A DESCRIPTON Place DATA REV DESCRIPTON E2 E1 PRO LED PRO Q7 C1815 Place APPROVED DW GNO: DATA PART NO: PART NAME: 1 2 15 3 JUNPING.LI SCALE: 1:1 DRAWN BY: UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: JBL GTO-3501 REV: MV1 POWER 4 DATA: 2007.12.05 A 1 2 3 4 5 6 7 8 GTO3501 D D +VCC R202 68R R200 1K C200 CC681/100V Q200 B647 Q201 D669 Q202 D669 Q206 KTD1047 Q204 KTD1047 Q205 KTD1047 D204 4148 D202 4148 C201 D200 CC56P/100V 4148 R204 2K2 R207 C204 R208 C205 220R W22U/50V 22K CC473 LIN Q211 5551 Q212 5551 R227 4.7R0.25W D201 4148 R217 2.2K R210 22R R226 4.7R0.25W Q213 D669 R211 22R C148 R159 100U/25V 3K R222 100R/0.5W R236 0.15R/5W C206 CL104 Q122 C1815 R249 1K5 R233 0.15R/5W R234 0.15R/5W C207 NP220U/26V R250 1K5 R218 100K Q209 C1815 R215 6.8K R235 56K R150 56K -V1 R205 4.7K C208 2.2U/50V Q208 C1815 C R238 1K5 R214 6.8K Q207 S8050 PRO Q210 5551 R220 270R/0.5W R206 470K C R225 4.7R0.25W CN200 1 2 3 4 MUTE +V1 R240 470R C211 CL104 R209 24K R216 6.8K C209 220U/25V R212 22R R242 4.7R/0.5W R223 100R/0.5W R213 22R R252 1K5 R259 0.15R/5W R253 1K5 R260 R237 0.15R/5W 0.15R/5W R241 1K5 B Q214 5401 Q215 5401 R221 270R/0.5W C202 CC56P/100V R228 4.7R0.25W R256 15K R239 15K D205 4148 D208 4148 B R231 4.7R0.25W R229 4.7R0.25W Q216 D667 Q217 B649 R201 1K R203 68R Q218 B649 Q219 KTB817 Q220 KTB817 Q222 KTB817 C203 CC681/100V -VCC A A REV DESCRIPTON MV MV D1047 B817 DATA Place Q204 Q205 Q206 Q219 Q220 Q222 REV DESCRIPTON 2007.07.19 MV1 KTD1047 KTB817 2007.07.19 MV1 Place APPROVED Q204 Q205 Q206 Q219 Q220 Q222 DW GNO: DATA 2007.12.05 PART NO: 2007.12.05 PART NAME: AMP PRODUCT MODE: 1 2 3 4 16 JBL GTO3501 5 6 SCALE: 1:1 DRAWN BY: UNIT: SIZE: MM A4 CHECKED BY: APPROVED BY: REV: MV1 7 DATA: JUNPING.LI DATA: DATA: 8 2007.12.05 GTO3501 1 2 C4 W22U/50V 1 INPUT C19 R5 U1A NJR4560 2 C15 CC101 CC101 47K R17 R62 10K 5 6 U2A R30 NJR4560 1K 2 1 20K 4 CC101 1 3 3 2 CH1-INPUT R1 22K R3 47K 3 C23 D D C5 W22U/50V R4 C18 47K CC101 R6 47K R OUT C1 NP/220U/25V R37 4R7 +15V +V1 JK1 RJ-11 REM R12 47K C10 W22U/50V -15V U1B NJR4560 6 7 R18 20K R10 C21 47K CC101 R11 47K 8 -V1 5 -15V 4 R38 820R R39 C38 R13 47K R25 1K C32 CC104 5K1 CC221 Q1 5551 R21 10K CC22P R23 47K R40 24K C R43 4 -15V 104/MET 5 7 R27 10K 3 1 2R29 47K L OUT R28 47K C44 CC22P C47 684/MET 6 3 R49 430R -15V C24 473/MET C3 184/MET R14 56K VR3A A2K2 U4A NJR4560 VR3B A200K 5 C8 1 LIN 2 22U/16V 3 1 VR2A C50K 3 7 CH2-OUT U3A NJR4560 3 R9 5K6 4 8 C14 R33 W22U/50V 1K 6 VR2B C50K VR4A R2 100K B500 2 1 +15V 4 R54 100K 4 R50 7K5 U4B NJR4560 6 R53 100K R42 100 C49 CC101 B 8 +15V C48 CC101 C46 5 U3B NJR4560 CH1-OUT +15V 6R2447K R OUT 7 4 B R41 1K8 LC202 1 R32 C13 W22U/50V 1K 3 R44 2M R15 5K6 +15V C36 47U C37 R31 CC471 1K REM C42 R26 4K7 8 C9 W22U/50V 3 4 R36 4R7 -15V 6 VR1B B50K +15V L OUT C2 NP/220U/25V U2B NJR4560 5 4 8 C +15V 7 5 2 3 +15V 2 C16 CC101 6 CH2-INPUT R7 22K 1 2 R45 200 5 5 INPUT C35 47U C30 CC104 6 R8 47K CC101 4 C7 W22U/50V C20 1 R48 1K8 A A REV DESCRIPTON Place DATA REV DESCRIPTON Place APPROVED DATA DW GNO: PART NO: PART NAME: INPUT PRODUCT MODE: 1 2 3 17 JBL GTO3501 4 5 SCALE: 1:1 DRAWN BY: UNIT: MM CHECKED BY: SIZE: A4 APPROVED BY: REV: MV1 JUNPING.LI DATA: DATA: DATA: 6 2007.12.05 1 2 3 4 5 6 7 8 GTO3501 Q101 C1815 D CN4 CON2.54*2 1 R110 4.7K C102 47u/16V D R102 10K RT1 90℃ Q108 R120 A1015 3.3K Q107 A1015 R103 10K C104 100U/16V 2 C101 104 R112 22R R106 22K R4 1K MUTE R109 4.7K R119 20K R101 10K Q100 C1815 R7 1K R8 1K R9 1K R10 R11 1K 1K 2 1 -V R118 33K R100 10K R6 1K R113 1K C1815 Q102 C100 CC104 R5 1K CN5 CON2.54*2 LED1 LED2 LED3 LED4 LED5 LED6 LED7 LED8 LED LED LED LED LED LED LED LED DZ100 C103 D100 22U/25V 1N4148 8V2 CN100 3 CN102 4 D111 1N4004 1 C105 220U/25V 2 CN104 2 2 5UH D106 4 6A10 1 2 1 20A F100A 3 4 3 F100B 20A 1 REM 2 1 +12V C POWER C114 C115 CC104 CC104 C130 C133 CL104 470U/35V 1 D108 FR204 U100 L7815 Vin R133 100R R134 100R R129 2 1 R121 10K D109 FR204 10 6 3 Q114 IRF48N Q116 IRF48N Q118 IRF48N C127 CL103 Vin C131 C134 CL104 470U/35V U101 Vout 3 -V1 L7915 7 8 B 4 +VCC R136 100R PRO 1 -V C117 CC104 C118 CC104 D110 FR204 2 R131 220R CN105 80C C129 CC104 8 C126 CL103 Q117 IRF48N LED101 RED 3 4 PRO B Q115 IRF48N R137 100R R138 100R R141 22R/ 1/2W 9 TRANC-2 F40 F1=F2=F0.8*12 4TS S1=S2=F0.8*8 15TS S3=S4=F0.8*1 8TS 2 D114 MUR1620CT C144 3300U/63V 2 CN103 CON4P-1 3 Q113 IRF48N +V1 C138 100U/16V 5 R142 22R/ 1/2W 1 L102 1 220R 1 C128 CC104 R140 22R/ 1/2W 3 C137 100U/16V 2 R132 100R Vout 2 D107 FR204 GND 3 1 PGND 3 GND 3 2 C1A CC104 C1B CC104 2 2 L1A C124 2200U/35V C 1 C122 2200U/35V 1 R107A C146 2K/2W CL104 C120 CC104 LED100 BLU R117 10K D115 MUR1620CTR C145 3300U/63V R122 4K7/0.25W C142 CL102 +15V R108A C147 2K/2W CL104 C121 CC104 -VCC A A REV DESCRIPTON Place DATA REV DESCRIPTON Place APPROVED DW GNO: DATA PART NO: PART NAME: POWER PRODUCT MODE: 1 2 3 4 18 JBL GTO3501 5 6 SCALE: 1:1 DRAWN BY: UNIT: MM CHECKED BY: DATA: SIZE: A4 APPROVED BY: DATA: REV: MV1 7 DATA: JUNPING.LI 8 2007.12.05