Gto752 - Minjja

Transcript

GTO752 2 CHANNEL POWER AMPLIFIER SERVICE MANUAL JBL Consumer Products 250 Crossways Park Dr. Woodbury, New York 11797 Released 2007 Discontinued XXXX Rev1 1/2008 GTO752 - CONTENTS SPECIFICATIONS ………………………………………..1 PACKING……………………………………………..…....2 CONTROL/INSTALLATION DRAWINGS………………3 CONTROL/INSTALLATION INSTRUCTIONS………....4 BASIC TROUBLESHOOTING……………………………5 EXPLODED VIEW/PARTS LIST…….….….…………....6 AMPLIFIER BLOCK DIAGRAM…………………….……7 ELECTRICAL PARTS LIST ..……….……….…….…….8 P.C.B. DRAWINGS….………………………..…….……11 IC/TRANSISTOR PINOUTS..………………..….….…..13 SCHEMATICS……………..……………….………..…...14 GTO 752 Specifications Output Power: (14.4V supply) Signal-to-noise ratio: Dynamic power: Frequency response: THD+N 1KHz LPF=22KHz Channel Separation Input Impedance Maximum input signal: Maximum sensitivity: Hi-Pass, Low Pass X-over Limits Bass Boost @ 50Hz DC Offset Output regulation: Idle Current @ 4 ohms Max Current Draw Remote Operating Voltages Turn-on delay time Circuit Protection Operating voltage range Dimensions: Fuses: 75W RMS x 2 channels @ 4 ohms; ≤1% THD + N 110W RMS x 2 channels @ 2 ohms; ≤1% THD + N 200W RMS x 1 channel (bridged) @ 4 ohms; ≤1% THD + N 90dBA (reference 1W into 4 ohms) 108dBA (reference rated power into 4 ohms) 130W @ 2 ohms 10Hz – 100kHz (–3dB) ≤0.07% (rated power @ 4 ohms) ≥45db (full rated power) >20K ohms 6.0V 100mV 40Hz – 450Hz ±20% 0-6dB <30mV .03dB @ 4 ohms 0.5A <30A @ 2 ohms both channels driven ON 5V OFF 4V 2-3 sec Temperature (80±5C), Short circuit (8-16V) 12 1/4 x 10 3/8 x 2 1/8” (310 x 263 x 53mm) 30A JBL continually strives to update and improve existing products, as well as create new ones. The specifications and details in this and related JBL publications are therefore subject to change without notice. 1 GTO752 2 GTO752 4x 1x 1x 10-3/8" 263mm 12-1/4" 310mm 0 1 5 6 34 B A 2-1/8" 53mm 2 7 8 9 A C B C D E A B C 3 GTO752 GTO752 CAR AUDIO POWER AMPLIFIER OWNER’S MANUAL Installation Warnings and Tips • Disconnect the negative (–) lead from your vehicle’s battery. • At the installation sites, locate and make a note of all fuel lines, hydraulic brake lines, vacuum lines and electrical wiring. Use extreme caution when cutting or drilling in and around these areas. • Choose a safe mounting location away from moisture. • Make sure there is sufficient air circulation at the mounting location for the amplifier to cool itself. • Mount the amplifier, using the supplied hardware. Specifications • 75W RMS x 2 channels @ 4 ohms and ≤1% THD + N* • 110W RMS x 2 channels @ 2 ohms and ≤1% THD + N* • THD + N: 0.07% (rated power @ 4 ohms) • Signal-to-noise ratio: 90dBA (reference 1W into 4 ohms)* • Signal-to-noise ratio: 108dBA (reference rated power into 4 ohms) • Frequency response: 10Hz – 100kHz (–3dB) • Max power: 220 watts * CEA-2006A-compliant 0 Speaker Output Connectors • Connect the speakers to these terminals, observing proper polarity. • Two-channel operation: Connect the left speaker to the L+ and L– terminals and the right speaker to the R+ and R– terminals. • One-channel (bridged) operation: Connect the single speaker to the R+ and L– terminals. • Minimum speaker impedance for 2-channel operation is 2 ohms. Minimum speaker impedance for 1-channel (bridged) operation is 4 ohms. 1 Fuses • Replace only with the same type and rating. 2 Power Input Connectors • +12V: Connect to the positive terminal of the vehicle’s battery. 10 AWG wire is recommended. Install an appropriate fuse holder and fuse (30A minimum) within 18 inches of the battery. Make sure the wire is not damaged or pinched during installation. Install protective grommets when routing wires through the firewall or other sheet metal. • GND: Connect to the vehicle’s chassis. Refer to the picture below. Factory Bolt Ring Connector Ground Wire Note: Remove any paint below ring connector. Star Washer • REM: Connect to the “Remote Out” lead from the source unit or to a source of switched 12V+ (ACC). 3 Aux Output Connectors (RCA) • Nonfiltered pass-through output. Connect to the input of an additional amplifier. 4 Input Connectors (RCA) • Connect to the RCA outputs from the source unit or signal processor. 5 Input-Level Control • Used to match the input level of the amplifier to the output level of the source unit. • See B for the adjustment procedure. 6 Front Crossover-Frequency Control • 12dB/octave crossover, variable from 32Hz to 320Hz. • See C for the adjustment procedure. 7 Crossover-Filter Selector • LPF: Select for subwoofer(s). • FLAT: Select for full-range speakers when no subwoofer will be used in the system. • HPF: Select for midrange speakers or full-range speakers when a subwoofer is used in the system. 8 Bass-Boost Control • Set the Bass-Boost control according to your preference, being careful not to apply enough boost to damage your speaker(s). 9 Power On LED • Illuminated when the amplifier is on. A Protect LED • Illuminated under any of the following fault conditions: battery over/under voltage, short circuit in speaker wires, amplifier is too hot, amplifier’s output circuit has failed (DC voltage is present in the amplifier’s output). B Setting Input Level A Turn Input-Level control counterclockwise to 6V (minimum). B With a dynamic music track playing, turn the head unit’s volume control to the 3/4 position. C Turn Input-Level control clockwise until the music is so loud that it no longer sounds clear (distortion is present in the output). D Turn Input-Level control counterclockwise gradually, just until the music sounds clear, once again. E Input level is now adjusted correctly. C Setting the Crossover A Crossover setting for 5" or larger full-range speakers when no subwoofer is included in the system. B Crossover setting for midrange and/or full-range speakers when a subwoofer is included in the system. C Crossover setting for subwoofers. Note: Acceptable frequency ranges are indicated in gray. This product is designed for mobile applications and is not intended for connection to the mains. A valid serial number is required for warranty coverage. Features, specifications and appearance are subject to change without notice. 4 GTO752 Amplifier Troubleshooting Guide 1. Status LED on Amplifier not Lit - Head Unit (Source) Turned ON Verify: A. Remote turn-on wire from source to amplifier has proper voltage B. Power (B+) connections at amplifier, terminal blocks, and battery are secure C. Ground (GND) connections at amplifier and vehicle chassis are secure D. Battery B+ fuse (if used) is OK E. Amplifier fuse is OK F. B+ at battery and B+ at amplifier has proper voltage 2. Status LED’s Lit, No Output from Speakers in Normal Operating Condition Verify: A. RCA cables from amplifier to source are securely connected B. Volume adjustment on amplifier is correctly adjusted C. Source is ON and playing 3. Engine Noise From Speaker(s) Turn source OFF, Disconnect RCA cables at amplifier. If noise stops, check equipment & cables leading to amplifier. Verify: A. RCA cables are of good quality with no breakage to internal shields B. RCA cables from source to amplifier are not run alongside any power cables 4. Amplifier Output Distorted Music Verify: A. Source output music to amplifier is not distorted B. Source output sensitivity is correctly adjusted 5. Amplifier Shuts Down, Green LED.s are Lit - Amplifier is in Thermal Protection Mode Verify: A. Amplifier is mounted with adequate air circulation around heatsinks or vents B. Amplifier is not mounted under carpet or sealed enclosure C. Speakers meet correct impedance for application (mono or stereo hookup) 6. Amplifier Does Not Turn ON, and Red LED is Lit Amplifier (and not Connected to a Shorted Speaker) Verify: A. Speaker crossover (if used) is not defective 5 GTO752 EXPLODED VIEW Part Number Part Number Trans. Clamp Trans. Clamp Trans. Clamp 1380-0206-00 RCA Cap (Red) RCA Cap (Wht) Front Plate Standoff 6 1 2 3 4 5 6 GTO752 BLOCK DIAGRAM D D INPUT L 3 10 OP 32 320 100K 10 50 100K OP AMP 4 ohm/2 ohm speaker 2 1 A MODE HP/FLAT/LP VARIABLE LPF/HPF BASS BOOST VARIABLE 32Hz-320Hz/12dB 0dB-6dB/50Hz MODE HP/FLAT/LP BASS BOOST C VARIABLE LPF/HPF 32Hz-320Hz/12dB 10 32 320 100K FRONT L BTL-4ohm speaker 10 50 C MAIN AMP FRONT R VARIABLE 0dB-6dB/50Hz 100K OP AMP 4 ohm/2 ohm speaker 3 OP MAIN AMP A INPUT R 2 1 AUX OUT L OP B B +15V AUX OUT R +VCC OP power supply Battery -VCC -15V A A 7 1 2 3 4 5 6 GTO752 GTO752 Electrical Parts List Description Part Number Qty Reference Designator 4 2 2 2 1 R25B R25C R46 R20 R19 R20B R20C R16C R16B R15C R15B R14C R14B R13B R13C R4B R3C R4C R3B R38 R39 R40 R41 R12B R12C R24C R23C R24B R23B R227 R226 R119A R17C R17B R2C R2B R1C R1B R120A R111 R106 R28C R27B R27C R28B R18C R18B R9C R9B R8B R8C R118A R117A R116A R115A R19C R19B R2 R32 R37 R113A R108A R107A R104A R101A R100A R50 R36 R11C R11B R10C R10B R7C R7B R6C R6B R5C R5B R110A R103A R1 R4D R34 R106A R114A R56B R56C R222 R221 R323 R320 R52 R55 R43 R217 R216 R112A R105A R102A R109A R127 R128 R231 R241 R101 R100 R204 R201 R316 R315 R314 R313 R312 R211 R209 R208 R207 R205 R203 R202 R200 R229 R224 R230 R210 R26C R26B R22C R22B R63 R62 VR200 1 VR100A 1 1 VR101 R45 MAIN PCB Resistors 0702-34R7-02 0702-3220-02 0702-2221-02 0702-1220-02 0702-1470-02 0702-1101-02 0702-1821-02 Resistor Resistor Resistor Resistor Resistor Resistor Resistor 1/2W 4.7Ω ±5% 1/2W 22Ω ±5% 1/4W 220Ω ±5% 1/8W 22Ω ±5% 1/8W 47Ω ±5% 1/8W 100Ω ±5% 1/8W 820Ω ±5% 2 3 2 8 4 6 4 0702-1102-02 Resistor 1/8W 1KΩ ±5% 16 0703-1332-03 Resistor 1/8W 3.3KΩ ±1% 2 0702-1562-02 Resistor 1/8W 5.6KΩ ±5% 10 0702-1472-02 Resistor 1/8W 4.7KΩ ±5% 3 0702-1103-02 Resistor 1/8W 10KΩ ±5% 22 0702-1473-02 0702-1563-02 0702-1104-02 0702-1221-02 0702-1682-02 0702-1273-02 0703-1301-03 0702-1223-02 0703-1223-03 Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor 1/8W 47KΩ ±5% 1/8W 56KΩ ±5% 1/8W 100KΩ ±5% 1/8W 220Ω ±5% 1/8W 6.8KΩ ±5% 1/8W 27KΩ ±5% 1/8W 300Ω ±1% 1/8W 22KΩ ±5% 1/8W 22KΩ ±1% 3 6 5 2 2 2 2 2 2 0703-1103-03 Resistor 1/8W 10KΩ ±1% 13 0703-1472-03 0703-1562-03 0705-50R1-06 0704-6271-02 1204-2030-01 Resistor Resistor Resistor Resistor potentiometer 1204-5031-18 1204-5021-06 0703-2392-03 1/8W 4.7KΩ ±1% 1/8W 5.6KΩ ±1% 5W 0.1Ω*2 ±5% 26*5*18MM 2W 270Ω ±5% B20K KQ L=15 ±15% (INPUT LEVEL) A50K R0971G2B W=5 KQ柄 L=15MM potentiometer T=7.5MM M=1MM (FREQ) potentiometer B5K KQ L=15 ±10% 1,1" (BASS BOOST) Resistor METAL MF 1/4W 3.9KΩ ±1% Capacitors 06D212274001 Cap electro 220UF/25V ±20% 8*16 105℃ 2 06D212266010 Cap electro 22uF/50V ±20% 5*11 105℃ 06D212264103 06D213375101 06D214765000 06D211074100 06D202264109 06D211066109 06D211056001 06D212285106 06D213384003 06D321037200 06D321047200 06D321027200 06D321247000 06D325637000 Cap electro Cap electro Cap electro Cap electro Cap electro Cap electro Cap electro Cap electro Cap electro Capacitor Capacitor Capacitor Capacitor Capacitor 220uF/25V ±20% 8*12 105℃ 330UF/35V ±20% Ф8*14MM 105℃ 47UF/35V ±20% 5*11 105℃ 100uF/25V ±20% 6.3*11 105℃ 22uF/25V ±20% 5*12 105℃ 10uF/50V ±20% 5*11 105℃ 1UF/50V ±20% 5*11 105℃ 2200UF/35V ±20% 16*26MM 105℃ 3300UF/25Vφ 18*26MM ±20% 105℃ 103/100V ±5% 104/100V ±5% 102/100V ±5% 124/100V ±5% 563/100V ±5% 8 C216 C217 C15 C200 C201 C206 C211 C212 C11C C11B C12C 11 C12B C207 2 C42 C41 2 C32 C31 2 C55 C38 4 C37 C7C C7B C40 1 C18 2 C1C C1B 2 C9C C9B 2 C58 C59 1 C17 2 C7 C6 6 2C 1C C8C C8B C10B C10C 1 C29 2 C131 C106 2 C130 C107 GTO752 Part Number Description Qty 4 4 4 Reference Designator MAIN PCB 06D328237200 06D232207000 06D231007001 Capacitor porcelin Cap porcelin Cap 823/100V ±5% 22pF/100V ±20% 10PF/100V ±20% 105℃ 06D231017000 porcelin Cap 100pF/100V ±20% 06D233917000 06D234717001 Capacitor porcelin Cap 391/100V ±20% 470PF/100V ±20% 06D231047000 porcelin Cap 0.1uF/100V ±20% 06D211076001 Cap electro 100UF/50V ±20% 8*12 105℃ 5mm C104A C105A C102A C103A C101A C100A C109A C108A C227 C226 C215 C214 C225 C222 C221 C220 C219 C218 C3C C3B C2C C2B 14 C223 C224 C103A C103B 4 C5C C4C C5B C4B 2 C6C C6B C9 C208 C205 C203 C202 C48 C47 C39 C14 C8 C56 17 C57 3C 4C C30 C28 C209 1 C10A Semiconductors 04WY-51AV104 04WY-15BV204 04PT-4148-04 04ZL-5401-06 03N2-8050-01 5.1V DO-35 0.5W 15V DO-35 1W 1N4148 GSS 200MA 75V DO-35 1N5401 DO-201AD 2SC8050 NPN TO-92 2SA1015 150MA 60V 400MW PNP TOTransistor 92 2SC1815GR 150MA 60V 400MW NPN Transistor TO-92 Transistor 2N5401 PNP TO-92 Transistor 2SB647 1A 120V 0.9W PNP TO-92 Transistor 2N5551 NPN TO-92 Transistor MPSA13 0.5A 30V NPN TO-92 Transistor 2SD667AC 1A 120V 0.9W NPN TO-92 Transistor 2SA1023 TO-92 PNP Transistor TIP35CW NPN T0-247 Transistor TIP36CW PNP T0-247 diode FR104 1A 400V 52MM MOS Transistor HFP50N06 TO-220 Rectifier UF1602CT AKA 16/200V TO-220 Rectifier MUR1620CTA KAD 16A/200V TO-220 LED red with red light Φ3MM 2P (PROTECT) LED Φ3.0MM blue with blue light (POWER) IC NJM4558 SIP-8 Dual Op-Amp 1 2 10 1 2 ZD2 ZD6 ZD4 D21 D15 D14 D11 D2C D2B D2 D1C D1B D1 D7 Q8C Q8B 4 Q9C Q10C Q9B Q10B 2 2 2 2 2 1 2 2 5 4 1 1 1 1 8 Q4C Q4B Q12C Q12B Q11C Q11B Q3C Q3B Q5C Q5B Q19 Q6C Q6B Q13C Q13B D9 D8 D6 D5 D3 Q14 Q16 Q15 Q13 D10 D12 LED1 LED2 U103 U302 U202 U201 U200 U100 U102 U101 1501-0300-02 1501-0400-01 1601-303G-00 1401-0004-00 1001-0003-10 1005-5R00-10 1380-0206-00 terminal terminal fuse fuse holder inductor toroidal inductor tem switch 1 1 1 1 2 1 1 CN1 CN3 F1 for F1 L6 L4 L1 attach to heat sink 3000-GTO7-01 Transformer 1 T1 1404-0020-04 1501-0209-00 RCA JACKS Molex socket 1 2 RCA200 CN4 CN5 1333-0204-00 slide switch PL-L0002-000 sheet GND 03P1-1015-01 03N1-1815-01 03P1-5401-01 03P1-B647-01 03N1-5551-01 03N1-SA13-01 03N1-667A-01 03P1-1023-01 03N1-35CW-26 03P1-36CW-26 04GS-R104-00 03D1-50N6-24 2202-1602-05 2202-1620-05 2000-0017-00 2004-0014-00 01JR-4558-02 diode schottky diode schottky diode diode Transistor 10 Q23 Q22 Q7C Q7B Q5 Q4 Q2C Q2B Q1C Q1B Miscellaneous BTS3-24 POWER BTS4-23 SPEAKER 30A/32V DC BXS-09 φ11 φ0.8 5uH Φ23 Φ1.2*3 7T 80℃ KSD301 φ376:13 L1=L2 0.8*8*6TS L3=L4 0.8*5*13TS AV4-8.4-38 QUAD Pitch 2.54MM 2PIN SSH-23D04-2P3T L:9MM (LPF/FLAT/HPF) GND-3 1 SW100 1 JK1 2PIN UL1007 AWG26 L=35mm 2.54 5mm 5*10*10MM 35° black Alum. Bar with Insulated paper 1 2 1 for MPSA13 14.0x7.0x30.0 Miscellaneous 2100-0069-02 JD-E00020515 PL-A0051-000 wire insulator 9 GTO752 Description Part Number Qty Reference Designator MAIN PCB PL-A0050-000 PL-A0049-000 PWM PCB Alum. Bar with Insulated paper Alum. Bar with Insulated paper 2 1 14.0x7.0x40.0 14.0x7.0x60.0 SMD 220Ω 1/8W ±1% 0805 SMD 100Ω 1/8W ±1% 0805 SMD 1KΩ 1/8W ±1% 0805 SMD 3KΩ 1/8W ±1% 0805 SMD 4.7KΩ 1/8W ±1% 0805 SMD 6.8KΩ 1/8W ±1% 0805 SMD 5.6KΩ 1/8W ±1% 0805 SMD 10K 1/8W ±1% 0805 SMD 11KΩ 1/8W ±1% 0805 SMD 12KΩ 1/8W ±1% 0805 SMD 15KΩ 1/8W ±1% 0805 SMD 18KΩ 1/8W ±1% 0805 SMD 22KΩ 1/8W ±1% 0805 SMD 33KΩ 1/8W ±1% 0805 SMD 330KΩ 1/8W ±1% 0805 SMD 100KΩ 1/8W ±1% 0805 SMD 1KΩ 1/4W ±5% 1206 1 1 6 1 1 2 1 2 1 1 1 1 2 1 1 3 8 R17 R10 R31 R30 R29 R28 R26 R15 R13 R11 R5 R51 R14 R1 R23 R27 R24 R53 R7 R18 R9 R65 R3 R25 R12 R4 R1 R2 R3 R4 R5 R6 R7 R8 Cap electro Cap electro Cap electro Cap electro SMD Capacitor SMD Capacitor 1uF/25V ±20% 4*7 105C 100UF/25V 6.3*7mm 5mm ±20% 105C 220UF/16V ±20% 8*7 105C 5MM 47UF/25V ±20% 6*7 105C black 5mm SMD 1000pF/50V 0805 NPO ±5% SMD 0.1uF/50V 0805 X7R ±10% 1 1 1 2 1 2 C3 C27 C22 C1 C20 C26 C4 C25 diode schottky diode schottky diode Transistor Transistor Transistor IC Transistor SMD 3.9V DO-213AA 0.5W SMD 15V 1/2W ±2% DO-213AA SMD 1N4148 DO-213AA SMD 2SA1015 SOT-23 PNP 2SB649A 1.5A 180V 20W PNP TO-126 SMD 2SC1815 SOT-23 NPN SMD TL494C SO-16 PWM 2SA1015 150MA 60V 400MW PNP TO-92 1 1 6 1 1 4 1 2 ZD2 ZD1 D4 D1 D20 D3 D2 D13 Q10 Q6 Q3 Q2 Q7 Q1 U1 Q9 Q8 PITCH 2.54mm 4PIN 90° 2 CN2 CN1 Resistors 0701-2221-03 0701-2101-03 0701-2102-03 0701-2302-03 0701-2472-03 0701-2682-03 0701-2562-03 0701-2103-03 0701-2113-03 0701-2123-03 0701-2153-03 0701-2183-03 0701-2223-03 0701-2333-03 0701-2334-03 0701-2104-03 0701-3102-02 SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor SMD resistor resistor Capacitors 06D211054104 06D211074101 06D212273001 06D214764103 06S321026000 06S121046000 Semiconductors 04WY-39AV101 04WY-15BV-01 04PT-4148-01 03P1-1015-04 03P1-B649-07 03N1-1815-04 01TI-L494-09 03P1-1015-01 Miscellaneous 1501-0409-02 socket LED PCB 2100-0067-02 2100-0068-02 2005-0009-00 06S121046000 2PIN UL1007 AWG26 L=70mm 5mm high temperature 105Cwire 2PIN UL1007 AWG26 L=210mm 2.54 wire 5mm,high temperature105Cwire guide light LED 2*3*4mm、 SMD Capacitor SMD 0.1uF/50V 0805 X7R ±10% wire 10 2 1 8 1 LED1 LED2 LED3 LED4 LED5 LED6 LED7 LED8 C1 GTO752 11 GTO752 12 GTO752 13 1 2 3 4 5 6 7 8 GTO752 R1 1K R2 1K R3 1K R4 1K R5 1K R6 1K R7 1K R8 1K CN4 CON2.54*2 R1 10K 2 RT1 80℃ 2 1 2 2 D PRO D11 IN4148 R34 47K V- +12 MUTE MUTE C18 1 R37 4.7K D1 IN4148 22uF/25VNP CN4 CON2.54*2 1 D 1 AC Q19 A1023 C15 22uF/50V CN5 CN5 CON2.54*2 CON2.54*2 LED1 LED2 LED3 LED4LED5 LED6 LED7 LED8 LED LED LED LED LED LED LED LED D3 FR104 R43 100K R4D 10K C9 R45 3.9K1/4W 104P ZD2 R36 5.1V 10K C8 104P CN6 +12V C17 +12 +12V C28 104/P CON4 C R19 22R/0.5W L1A 1 IN5401 C39 104P Q13 CET50N60 PRO Q14 CET50N60 CON4 C14 104P T1 R39 100 4.7K CA1 CA2 NC NC FR104 FR104 Q15 CET50N60 D6 3 7 2 6 Q16 CET50N60 FR104 FR104 R41 100 TRANC-1 8 Q23 4148 104/P D8 C55 47U/50V R52 100K R55 C48 104P 270/2W V- B 1 R46 22/0.5W C58 2200U/35V 2 L4A 1MH D10 U1620 DC 4148 1 L6A -VCC 3C 104P 4C 104P C32 330U/35V C29 102/M D15 1C 2C CL104 CL104 2 1MH CH1OUT +VCC C59 2200U/35V AC C40 100U/25V Q4 C1815 R32 4.7K C10A 100U50V C41 220U/25V R63 C56 104P D12 U1620R CH2OUT 100K C1815 Q5 C1815 4148 C47 104P C42 220U/25V ZD6 15V1W C31 330U/35V PRO 4148 C1815 V+ R62 C57 270/2W ZD4 104P 15V1W C38 47U/50V D14 D21 Q22 CH2OUT SPEAKER OUT C10 NC D9 C7 103/M D2 C30 D5 R20 22R/0.5W PRO CH1OUT 5 4 LED1 PRO R2 B 4 3 2 1 C R40 100 CN7 1 2 3 4 5 5 CN3 D7 1 E2 E1 PRO LED PRO 6 C6 103/M R38 100 R50 10K 6 PGND REM +12V 3 2 1 5UH C19 NC 4 3 2 1 W3300U/25V GND 12V DC12V REM 2 CN3 CN1 F1C 30A C37 100U DESCRIPTON A A ECN NO DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: POWER 14 1 2 3 4 PRODUCT MODE: JBL GTO752 5 6 SCALE: 1:1 DRAWN BY: DATA: UNIT: MM CHECKED BY: DATA: SIZE: A4 APPROVED BY: REV: PV 7 DATA: 8 GTO752 1 2 3 C4 104 R7 18K D20 D1 4148 4148 ZD1 15V D Q1 C1815 C1 47/25V CN1 CON4 R10 100 R8 NC R1 10K ZD2 3V9 4 Q2 C1815 R14 5K6 R13 3K R11 4.7K R25 +12V Q6 B649 C2 NC D REM DC12V 12V GND 1 2 3 4 +12 100k D2 R4 100K R65 33K D13 4148 R51 6K8 OP1 8 GND 7 6 C R29 1K Q8 A1015R31 1K D3 4148 B C25 104 R27 11K C26 R9 102/M 22K C27 100/25V CN2 CON4 R12 100K 1 2 3 4 PRO +12 R15 1K ECN NO A C R30 1K R28 1K E1 E2 9 10 11 VCC OP2 12 13 CON 5 FED 3 2 - + C20 47/16V B Q9 A1015 U1 TL494 TL494CN R R24 12K DT R23 10K 4 R3 1 R17 220R 220/16V 22K 330K R18 D4 4148 C22 Q3 C1815 - + PRO 4148 14 R5 6K8 REF Q10 A1015 C 1K R26 15 R53 15K 16 C3 1U/50V E2 E1 PRO LED PRO Q7 C1815 DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: POWER1 15 1 2 3 SCALE: 1:1 DRAWN BY: DATA: UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: JBL GTO752 REV: PV 4 A GTO752 1 2 3 4 +VCC 2 +VCC D D R1B 1K R3B 47R C4B 391/100V 1 Q4B 2N5401 Q5B D667 PRO Q6B TIP35C PRO R5B 10K R12B 100R MUTE C C1B W10U/50V Q2B C1815 V- C2B 100/100V R24B 820R CH1SG MUTE R6B 10K R7B 10K Q8B S8050 R27B 1K C6B 471 R13B 22R R9B 5K6 C12B 22U R16B 22R R22B 0.10/5W Q3B A13 R28B 1K V+ Q9B A1015 C Q10B A1015 CH1OUT CH1OUT R56B DC R25B 4.7/0.5W 56K R19B 5K6 3 C11B 22U R15B 22R C7B 100U/25V R8B 5K6 C9B 1U/50V 1 R20B 220R 1/4W R17B 1K R14B 22R Q7B C1815 2 R18B 3K3 C8B CL104 CH1SG Q1B C1815 R23B 820R C10B CL104 R10B 10K C3B 100/100V R11B 10K D1B 4148 Q11B 2N5551 Q12B B647 Q13B TIP36C C5B 391/100V B R2B 1K D2B 4148 B R4B 47R -VCC -VCC R26B 5K6 ECN NO A DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: 16 1 2 3 SCALE: 1:1 DRAWN BY: DATA: AMP-1CH UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: JBL GTO752 REV: 1.0 4 A GTO752 1 2 3 4 +VCC +VCC D D R1C 1K R3C 47R C4C 391/100V Q4C 2N5401 Q5C D667 PRO Q6C TIP35C PRO R5C 10K R12C 100R MUTE C C1C W10U/50V Q2C C1815 V- C2C 100/100V R24C 820R CH2SG MUTE R6C 10K R7C 10K Q8C S8050 R27C 1K C6C 471 R13C 22R R9C 5K6 C12C 22U R16C 22R R22C 0.10/5W Q3C A13 R28C 1K V+ Q9C A1015 C Q10C A1015 CH2OUT CH2OUT R56C DC R25C 4.7/0.5W 56K R19C 5K6 3 C11C 22U R15C 22R C7C 100U/25V R8C 5K6 C9C 1U/50V 1 R20C 220R 1/4W R17C 1K R14C 22R Q7C C1815 2 R18C 3K3 C8C CL104 CH2SG Q1C C1815 R23C 820R C10C CL104 R10C 10K C3C 100/100V R11C 10K D1C 4148 Q11C 2N5551 Q12C B647 Q13C TIP36C C5C 391/100V B R2C 1K D2C 4148 B R4C 47R -VCC -VCC R26C 5K6 ECN NO A DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: 17 1 2 3 SCALE: 1:1 DRAWN BY: DATA: AMP-2CH UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: JBL GTO752 REV: PV 4 A GTO752 1 2 10K R224 4K7 2 U201A NJM4558 3 C214 CC10P U202A NJM4558 3 1 6 2 7 R314 10K R202 10K C219 100P FR R208 10K R231 300R 10K U201B C215 CC10P 8 7 NJM4558 5 8 C100A 22P R100 22K C R211 10K CH1 R216 100K R-OUT C223 100/P C224 100/P D C130A 100/P 56K R230 R241 4K7 300R U302A R3153 10K 1 -V 5 R227 C212 1K W22U/50V Output L-OUT 7 U200B NJM4558 +V NJM4558 R316 10K 4 -V 6 7 56K CH2 2 6 R323 FL R217 100K C130B 100/P VR200B B20K R103A 10K C C102A CL823 C103A CL823 SW100AA R105A 220R LPF 1 U100A 2 R100A 10K 3 U202B NJM4558 6 FL R101A 10K CH1 R320 FR 7 1 1 VR100AA R115A A50K 3 5.6K2 U101A 7 VR100AC A50K 1 R116A 9 5.6K2 2 U103A 2 R119A 1K 3 1 HPF 4 CH1SG 2 1 C108A 22P R104A 10K 3 4558 4558 -V C106 124 4558 C107 563 1 R102A 6.8K FLAT3 U102A 3 4558 8 220U/25NP C221 100 P 5 C222 100P +V C207 R205 W22U/50V 10K +V R229 4K7 6 6 R204 22K R221 56K R209 -V 5 3 R222 56K R203 10K FL CH2-in U302B V+ NJM4558 VR200A B20K C227 10P 4 5 C206 W22U/50V CH1 1 C220 100P INPUT C217 3 R226 C211 1K W22U/50V Output 2 4 C201 W22U/50V 2 C225 100P 5 U200A NJM4558 1 3 V- 1 R210 4K7 8 C216 R313 10K R312 10K 4 R207 4 220U/25VNP D 6 8 R201 22K R200 10K 2 1 5 8 CH1-in FR 4 4 C200 W22U/50V INPUT 3 C218 100P R106 1K R106A 47K VR101A 2 C202 104P C203 10P C205 104P C208 104P V+ C209 104P 3 B5K LED2 LED R127 27K R101 22K R110A 10K C104A CL823 R108A 10K C105A CL823 SW100AB 10 VR100AD 7 A50K R118A 125.6K6 U102B -V 4558 +V B +V +V U103B R120A 1K 6 C109A 22P R113A 10K 5 11 CH2SG C1314558 -V 124 C130 R114A 563 47K 4 8 R109A 6.8K 8 4558 5 7 7 4558 +V R112A 6 220R HPF 8 5 +V FLAT7 4 -V U101B 5 5 CH2 8 CH2 VR100AB R117A U100B 5.6K6 4 7 A50K 6 R107A 6 10K 4 4 LPF 5 -V R111 1K 8 C101A 22P 4 B VR101B 5 R128 ECN NO 6 27K A B5K DESCRIPTON A APPROVED DW GNO: DATA PART NO: PART NAME: 18 1 2 3 4 SCALE: 1:1 DRAWN BY: PRE UNIT: MM CHECKED BY: DATA: 2007/07/17 DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: JBL GTO752 REV: 1.0 5 zeng xin hua 6