Transcript
http://www.xiaoyu163.com
HCD-GNX600 QQ 376315150 892498299 SERVICE MANUAL
E Model Australian Model
Ver.1.0 2006.04
TEL
TEL
Model Name Using Similar Mechanism CD Section
CD Mechanism Type
CDM74KFS-F1BD81A
Base Unit Name
BU-F1BD81A
Optical Pick-up Name
KSM-215DCP/C2NP
Model Name Using Similar Mechanism
HCD-GNX800
Tape Transport Mechanism Type
SPECIFICATIONS
Amplifier section The following are measured at 120 V, 220 V, 240 V AC, 50/60 Hz Front speakers DIN power output (rated)
Disc player section System
130 + 130 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference) 160 + 160 watts(6 ohms at 1 kHz, 10% THD) Sub woofer Continuous RMS power output (reference) 200 watts (4 ohms at 100 Hz, 10% THD) TV (AUDIO) IN (phono jack) voltage 250 mV, impedance 47 kiloohms MIC (phone jack) sensitivity 1 mV, impedance 10 kiloohms
Laser
Outputs PHONES (stereo mini jack)
Tape deck section Recording system Frequency response
accepts headphones of 8 ohms or more FRONT SPEAKER/SUB WOOFER OUT Use only the supplied speaker
www 9-887-199-01 2006D02-1 © 2006.04
CWN42FF601
Laser Output
Frequency response Wave length Signal-to-noise ratio Dynamic range
Compact disc and digital audio system Semiconductor laser (λ=780 nm) Emission duration: continuous Max. 44.6 µW* * This output is the value measured at a distance of 200 mm from the objective lens surface on the Optical Pick-up Block with 7 mm aperture. 2 Hz – 20 kHz (±0.5 dB) 780 – 790 nm More than 90 dB More than 90 dB
4-track 2-channel stereo 50 – 13,000 Hz (±3 dB), using Sony TYPE I tape – Continued on next page –
x aoy u163. com
MINI HI-FI COMPONENT SYSTEM
.Sony Corporation i
Home Audio Division Published by Sony Techno Create Corporation
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
Section
QQ
QQ
TAPE
HCD-GNX800
13942296513
13942296513
• HCD-GNX600 is the Amplifier, CD player, tape deck and tuner section in MHC-GNX600.
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
Power consumption Dimensions (w/h/d) (Approx.) Mass (Approx.) Supplied accessories:
Design and specifications are subject to change without notice.
This appliance is classified as a CLASS 1 LASER product. This label is located on the rear exterior.
Unleaded solder Boards requiring use of unleaded solder are printed with the lead free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.)
QQ 376315150 892498299 : LEAD FREE MARK Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40°C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350°C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder.
SAFETY-RELATED COMPONENT WARNING!!
www
.
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
xiaoy u163. com
2 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
QQ
QQ
230 – 240 V AC, 50/60 Hz 220 V AC, 50/60 Hz 120 V or 220 – 240 V AC, 50/60 Hz Adjustable with voltage selector 110 watts 280 × 326 × 385.5 mm 6.3 kg Remote Commander (1) Batteries (2) AM loop antenna (1) FM lead antenna (1) Front speaker pads (8) Sub woofer pads (4)
Flexible Circuit Board Repairing • Keep the temperature of soldering iron around 270˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering.
13942296513
13942296513
General Power requirements Australian model: Argentina model: Other models:
Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat.
TEL
TEL
Tuner section FM stereo, FM/AM superheterodyne tuner FM tuner section Tuning range 87.5 – 108.0 MHz Antenna FM lead antenna Antenna terminals 75 ohm unbalanced Intermediate frequency 10.7 MHz AM tuner section Tuning range Latin American models: 530 – 1,710 kHz (with the interval set at 10 kHz) 531 – 1,710 kHz (with the interval set at 9 kHz) Other models: 531 – 1,602 kHz (with the interval set at 9 kHz) 530 – 1,710 kHz (with the interval set at 10 kHz) Antenna AM loop antenna Antenna terminals External antenna terminal Intermediate frequency 450 kHz
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 TABLE OF CONTENTS
1.
SERVICING NOTES ................................................ 4
2.
GENERAL Locating the Controls ...................................................... 5 Setting the Clock ............................................................. 6
24 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
Disassembly Flow ........................................................... Side Case, Top Case ........................................................ Loading Panel .................................................................. Front Panel Assy .............................................................. Tuner Pack ....................................................................... Tape Mechanism Deck, MIC Board ................................ PANEL Board, IR Board, VOL Board ............................ CD Mechanism Deck ...................................................... Back Panel, DC FAN (M891) ......................................... MAIN Board, ADC Board ............................................... POWER Board, SPEAKER Board .................................. SMASTER Board ............................................................ DRIVER Board, SW Board ............................................. CD Board, Optical Pick-up ............................................. SENSOR Board ............................................................... MOTOR (TB) Board ....................................................... MOTOR (LD) Board .......................................................
4.
TEST MODE .............................................................. 16
5.
MECHANICAL ADJUSTMENTS ....................... 20
7-18. 7-19. 7-20. 7-21. 7-22. 7-23. 7-24. 7-25. 7-26.
6.
ELECTRICAL ADJUSTMENTS
8.
EXPLODED VIEWS
8-1. 8-2. 8-3. 8-4. 8-5.
Case (Top), Back Panel Section ...................................... Front Panel Section ......................................................... Chassis Section ................................................................ CD Mechanism Deck Section-1 ...................................... CD Mechanism Deck Section-2 .....................................
9.
ELECTRICAL PARTS LIST ................................ 66
TEL 13942296513
7 8 8 9 9 10 10 11 11 12 12 13 13 14 14 15 15
QQ 376315150 892498299
Deck section .................................................................... 20 CD Section ...................................................................... 21
www
.
7-17.
41 42 43 44 45 46 47 48 49 50 54
61 62 63 64 65
xiaoy u163. com 3 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
DISASSEMBLY
3-1. 3-2. 3-3. 3-4. 3-5. 3-6. 3-7. 3-8. 3-9. 3-10. 3-11. 3-12. 3-13. 3-14. 3-15. 3-16. 3-17.
QQ
QQ
3.
13942296513
13942296513
DIAGRAMS .................................................................... Block Diagram – CD Section – ...................................... Block Diagram – Tape/Tuner Section – ......................... Block Diagram – Main Section – ................................... Block Diagram – AMP Section – ................................... Block Diagram – Display/Power Section – .................... Printed Wiring Board – CD Board – .............................. Schematic Diagram – CD Board – ................................. Printed Wiring Boards – CD Mechanism Sectiom – ...... Schematic Diagram – CD Mechanism Section – ........... Printed Wiring Board – MAIN Board – ......................... Schematic Diagram – MAIN Board (1/3) – ................... Schematic Diagram – MAIN Board (2/3) – ................... Schematic Diagram – MAIN Board (3/3) – ................... Printed Wiring Board – PANEL Section – ..................... Schematic Diagram – PANEL Section – ......................... Printed Wiring Boards – MIC,VOL and SPEAKER Boards – ............................ Schematic Diagram – MIC,VOL and SPEAKER Boards – ............................ Printed Wiring Board – ADC Board – ............................ Schematic Diagram – ADC Board – .............................. Printed Wiring Board – SMASTER Board (Side A)– ... Printed Wiring Board – SMASTER Board (Side B)– .... Schematic Diagram – SMASTER Board (1/2)– ............ Schematic Diagram – SMASTER Board (2/2)– ............ Printed Wiring Boards – Power Board – ........................ Schematic Diagram – Power Board – ............................ IC Pin Function Description ............................................
TEL
TEL
7. 7-1. 7-2. 7-3. 7-4. 7-5. 7-6. 7-7. 7-8. 7-9. 7-10. 7-11. 7-12. 7-13. 7-14. 7-15. 7-16.
http://www.xiaoyu163.com
HCD-GNX600
SECTION 1 SERVICING NOTES
QQ 376315150 892498299 NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT
• MODEL IDENTIFICATION – Back Panel –
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care.
NOTES ON LASER DIODE EMISSION CHECK
TEL
TEL
The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
Carry out the “S curve check” in “CD section adjustment” and check that the S curve waveform is output several times.
.
QQ 376315150 892498299 • Abbreviation AR : Argentina model AUS : Australian model E2 : 120 V AC Area in E model E3 : 240 V AC Area in E model E51 : Chilean and Peruvian model
xiaoy u163. com
4 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
PART No. 2-658-970-0[] 2-658-970-2[] 2-658-970-3[] 2-658-970-4[] 2-658-970-5[]
QQ
QQ
TEL 13942296513
MODEL E2 model AUS model E3 model E51 model AR model
13942296513
13942296513
PART No.
LASER DIODE AND FOCUS SEARCH OPERATION CHECK
http://www.xiaoyu163.com
HCD-GNX600
SECTION 2 GENERAL
QQ 376315150 892498299 This section is extracted from instruction manual.
LOCATING THE CONTROLS
ALPHABETICAL ORDER
SYMBOLS
M-R
MASTER VOLUME ws
A-D
ALBUM + qk ALBUM – ql CD es CD SYNC 8 Deck A wh Deck B qh DIRECTION wg DISC 1 ~ 3 qa DISC SKIP/EX-CHANGE qs Disc tray 6 DISPLAY 3 Display 5 E-L
S-Z
SUB WOOFER ON/OFF ed TAPE A/B e; Tape lid qh, wh TUNER/BAND ea TV wl
TEL
TEL
13942296513
13942296513
ECHO LEVEL wa EQ BAND/MEMORY 4 GROOVE w; ILLUMINATION/ SUB WOOFER LEVEL 2
MIC 1/2 (jack) wf MIC 1/2 LEVEL wd MP3 BOOSTER 7 PHONES (jack) qj POWER ILLUMINATOR wk PRESET EQ wj REC PAUSE/START 9
?/1 (power) ef Z OPEN/CLOSE q; N (play) qd . OPERATION DIAL > (forward/go backward) 1 M (fast forward) qk m (rewind) ql X (pause) qf x (stop) qg PUSH Z (Eject A) wh PUSH Z (Eject B) qh
Top Panel
QQ
QQ
QQ 376315150 8192498299
376315150 892498299
376315150 892498299
TEL 13942296513 Front Panel
23456789
ef ed es ea e; wl wk wj wh
www
q; qa qs qd qf qg qh
xiaoy u163. com qj
.
wg wf wdwswaw;qlqk
5 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
This section is extracted from instruction manual.
QQ 376315150 892498299 Remote control TAPE wd TUNER/BAND 7 TUNER MEMORY wg TUNING MODE 5 VOLUME +/– qg
ALPHABETICAL ORDER A–E
1
2
3
The + button has a tactile dot.* SYMBOLS
wh
F–Z
13942296513
FM MODE 6 FUNCTION 8 PLAY MODE 5 REPEAT 6 SLEEP 1
wg wf wd ws wa w;
4 5 6 7 8 9 q; qa
ql qk
qs
qj
qd
qh
qf
* Use the tactile dot as a reference when operating the system.
qg
376315150 892498299
Use buttons on the remote for the operation. Press ?/1 to turn on the system.
2
Press CLOCK/TIMER SET.
“CLOCK” appears in the display. Then, the hour indication flashes in the display.
3 4
Press –. or >+ repeatedly to set the hour. Press ENTER.
The minute indication flashes in the display.
5 6
Press –. or >+ repeatedly to set the minute. Press ENTER.
The clock starts functioning.
To adjust the clock
1 Press CLOCK/TIMER SET. “SET” appears in the display, then “PLAY SET” flashes in the display.
2 Press –. or >+ repeatedly to select “CLOCK SET”, then press ENTER. The hour indication flashes in the display.
3 Do the same procedures as step 3 to 6 above.
www
xiaoy u163. com Notes
The clock settings are canceled when you disconnect the power cord or if a power failure occurs. You cannot set the clock in Power Saving Mode
.
6 http://www.xiaoyu163.com
376315150 892498299
QQ 376315150 892498299
TEL 13942296513 1
QQ
QQ
Setting the clock
13942296513
?/1 (power) 3 x (stop) qa 29, 31) X (pause) ql N (play) w; –. (go backward) ws >+ (go forward) wa m (rewind) q; M (fast forward) 9
TEL
TEL
ALBUM + qf ALBUM – qh CD wf CLEAR qk CLOCK/TIMER SELECT 2 CLOCK/TIMER SET 4 DISC SKIP qd DISPLAY wh ENTER qs EQ qj
http://www.xiaoyu163.com
HCD-GNX600
SECTION 3 DISASSEMBLY
QQ 376315150 892498299 • This set can be disassembled in the order shown below.
3-1. DISASSEMBLY FLOW SET
3-2.SIDE CASE, TOP CASE (Page 8)
3-3.LOADING PANEL (Page 8)
TEL
TEL
3-4.FRONT PANEL ASSY (Page 9)
3-6.TAPE MECHANISM DECK, MIC BOARD (Page 10)
3-11.POWER BOARD, SPEAKER BOARD (Page 12)
3-13.DRIVER BOARD, SW BOARD (Page 13)
3-15.SENSOR BOARD (Page 14)
3-14.CD BOARD, OPTICAL PIC-UP (Page 14)
3-16.MOTOR (TB) BOARD (Page 15)
3-12.SMASTER BOARD, (Page 13)
www
.
3-17.MOTOR (LD) BOARD (Page 15)
xiaoy u163. com 7 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
3-9.BACK PANEL, DC FAN (M981) (Page 11)
3-10. MAIN BOARD, ADC BOARD (Page 12)
3-7.PANEL BOARD, IR BOARD, VOL BOARD (Page 10)
QQ
QQ
TEL 13942296513 3-8.CD MECHANISM DECK (Page 11)
13942296513
13942296513
3-5.TUNER PACK (Page 9)
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
Note: Follow the disassembly procedure in the numerical order given.
3-2. SIDE CASE, TOP CASE
qf case (top)
7 screw (case 3 TP2) (3×12)
qs two screws (+BVTP 3×8) 8 screw (+BVTP 3×8) qa two tapping screws
9 qd
0 case (side-L)
TEL
TEL
3 screw (+BVTP 3×8)
2 screw (case 3 TP2) (3×12)
4
1 screw (case 3 TP2) (3×8)
3-3. LOADING PANEL
4 loading panel
CD mechanism deck (CDM74KFS-F1BD81A) 1 Turn the pulley to the arrow direction.
Pulley 3
Front side
2 Pull out disc tray.
www
.
xiaoy u163. com
8 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
5 case (side-R)
QQ
QQ
QQ 376315150 892498299
TEL 13942296513
13942296513
13942296513
6 screw (case 3 TP2) (3×8)
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 3-4. FRONT PANEL ASSY
q; connector (CN503)
8 connector (CN131)
7 connector (CN121) 6 wire (flat type) (CN509) 5 wire (flat type) (CN201)
9 connector (CN205)
TEL
TEL
3 tapping screw
13942296513
13942296513
2 tapping screw
4 front panel assy
QQ
QQ
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
1 four screws (+BVTP 3×8)
3-5. TUNER PACK 3 tuner pack
2 wire (flat type) (CN1)
1 two screws (+BVTT 3×6)
www
.
xiaoy u163. com 9 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
3-6. TAPE MECHANISM DECK, MIC BOARD
2 tape mechanism deck
1 six screws (+BVTP2.6)
lug
front panel
6 holder (TC-L) 8 four screws (+BVTP2.6)
TEL
TEL
5 holder (TC-R)
9 bracket (pivot)
0
qs bracket (TC) qd MIC board
4 splring (L) qa three screws (+BVTP3×8) 3 spring (R)
5 PANEL board
1 eighteen screws (+BVTP2.6)
6 IR board
7 four screws (+BVTP2.6) 2
4 connector (CN1452)
9 knob jog assy
3 wire (flat type) (CN1402)
0 VOL board
8 accessory nut
www
7 knob (vol)
.
xiaoy u163. com front panel
10 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
3-7. PANEL BOARD, IR BOARD, VOL BOARD
QQ
QQ
QQ 376315150 892498299
TEL 13942296513
13942296513
13942296513
7 three mic knobs
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 3-8. CD MECHANISM DECK
1 CD mechanism deck
2 wire (flat type) (CN351)
3 wire (flat type) (CN701)
TEL
TEL
13942296513
13942296513
QQ
QQ
MAIN board
3-9. BACK PANEL, DC FAN (M891)
4 screw (+BVTP 3×8)
5 two screws (+BVTP 3×8)
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
6 back panel
1 screw (+BVTP 3×8) 7 two screws (+BVTP 3×8)
9 connector (CN580) 8 DC fan (M891)
2 three screws (+BVTP 3×8) 3 three screws (+BVTP 3×8)
www
.
xiaoy u163. com 11 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
3-10. MAIN BOARD, ADC BOARD
2 connector (CN501)
3 two screws (+BVTT 3×6) 1 wire (flat type) (CN105) 7 connector (CN590)
TEL
TEL 8 board to board connector (CN381,CN01)
8 bracket (support top)
7 three screws (+BVTP 3×8)
qs bracket (support pwb) ql bracket (SMPS -B5)
qj bracket (SMPS 5ch) qd two tapping screws
qk three screws (+BVTP 3×8) q; bracket (support front)
qa tapping screw 4 connector (CNP1100)
9 two screws (+BVTP 3×8)
qf bracket (trans 5ch) qg screw (+BVTP 3×8)
2 three screws (+BVTT 3×6)
wa two screws (+BVTP 3×8)
1 screw (+BVTT 3×6)
w; POWER board qh three screws (+BVTP 3×8)
3 ws SPEAKER board
www
xiaoy u163. com
5 connector (CN1101)
.
6 connector (CN1200)
12 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
3-11. POWER BOARD, SPEAKER BOARD
QQ
QQ
4 two screws (+BVTP 3×8)
5 shield plate (TC MAIN)
13942296513
13942296513
6 MAIN board 9 ADC board
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 3-12. SMASTER BOARD
1 two screws (+BVTT 3×6)
2 heat sink (SMAS) 4 three screws (+BVTT 3×6)
3 two screws (+BVTT 3×6)
5 SMASTER board
TEL
TEL
13942296513
13942296513
3-13. DRIVER BOARD, SW BOARD
QQ
QQ
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
1 three screws (+BVTP 3×10)
2 cover (CDM)
3 two screws (+BTTP (M2.6))
6 DRIVER board
5 connector (CN703) 7 screw (+BTTP (M2.6))
8 SW board
4 wire (flat type) (CN702)
www
.
xiaoy u163. com 13 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
3-14. CD BOARD, OPTICAL PICK-UP
1 floating screw (+PTPWH M2.6)
2 holder (213) ASSY
5 two insulators
9
4 two coil springs (insulator)
8 two insulators
13942296513
6 two floating screws (+PTPWH M2.6)
qs wire (flat type) (CN101) qd CD board
q; screw (+BVTP 2.6 (3CR))
1 floating screw (+PTPWH M2.6) 2 tray
8 screw (+BTTP (M2.6)) 3 belt (table) 0 SENSOR board 4 floating screw (+PTPWH M2.6) 5 pulley (table)
6 floating screw (+PTPWH M2.6)
9 connector (CN731)
7 gear (geneva)
www
.
xiaoy u163. com
14 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
3-15. SENSOR BOARD
QQ
QQ
qa Remove the four solderings of motor.
13942296513
3 two floating screws (+PTPWH M2.6)
7 two coil springs (insulator)
TEL
TEL
qf optical pick-up (KSM-215DCP/C2NP)
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 3-16. MOTOR (TB) BOARD
2 stopper
4
TEL
TEL
1 stopper 7 table motor assy (M741)
13942296513
13942296513
3 wire (flat type) 5 core (CN742) 8 MOTOR (TB) board 6 Remove the two solderings of motor.
QQ
QQ
5 two screws (+BTTP (M2.6))
3-17. MOTOR (LD) BOARD
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
2 two screws (+BTTP (M2.6)) 4 Remove the two solderings of motor. 3 MOTOR (LD) board
5 loading motor assy (M751)
www
xiaoy u163. com 1 belt (loading)
.
15 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
SECTION 4 TEST MODE
QQ 376315150 892498299
[PANEL TEST MODE] • This mode is used to check the fluorescent indicator tube, LEDs, buttons, MASTER VOLUME knob, model, destination, software version and VACS level.
* Tape function 1. When a tape is inserted in Deck B and recording is started, the function is changed to TV automatically. When [CD SYNC] button is pressed during recording in function, ALC (Automatic Logic Control) is turned on. 2. During recording, press m button will stop the recording and the function is changed to TAPE B and rewind the tape in Deck B until the recording start position and playback of the tape in Deck B is started. If the [REC PAUSE/ START] button is pressed for a pause and pressed again to resume recording during recording time, when the tape is rewind, the tape will be rewind until the position where the pause is applied. * To release from Common Test mode. 1. To release this mode, press ?/1 button. 2. The cold reset is enforced at the same time.
[COLD RESET] • The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Press ?/1 button to turn on the set. 2. Press x button, [ILLUMINATION/SUB WOOFER LEVEL] button, and ?/1 button simultaneously. 3. The message “COLD RESET” appears on the fluorescent indicator tube. then, the fluorescent indicator tube becomes blank for a while, and the set is reset.
xiaoy u163. com
16 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
.
QQ 376315150 892498299
QQ
QQ
www
* Check of Amplifier 1. Press [EQ BAND/MEMORY] button repeatedly until a message “GEQ MAX” appears on the fluorescent indicator tube. GEQ increases to its maximum. 2. Press [EQ BAND/MEMORY] button repeatedly until a message “GEQ MIN” appears on the fluorescent indicator tube. GEQ decreases to its minimum. 3. Press [EQ BAND/MEMORY] button repeatedly until a message “GEQ FLAT” appears on the fluorescent indicator tube. GEQ is set to flat. 4. When the [MASTER VOLUME] knob is turned clockwise even slightly, the sound volume increases to its maximum and a message “VOLUME MAX” appears on the fluorescent indicator tube. 5. When the [MASTER VOLUME] knob is turned counterclockwise even slightly, the sound volume decreases to its minimum and a message “VOLUME MIN” appears on the fluorescent indicator tube.
13942296513
13942296513
TEL 13942296513
Procedure: * To enter Common Test Mode 1. Press x button, [ILLUMINATION] button and [DISC 3] button simultaneously. 2. The CD ring indicators and line below CD ring indicator flash synchronously on the fluorescent indicator tube. The function is changed to TV.
TEL
TEL
Procedure: 1. Press x button, [ILLUMINATION] button and [DISC 2] button simultaneously. 2. All LEDs and segments in fluorescent indicator tube are lighted up. All LEDs are lighted up in red color except the SUB WOOFER ON/OFF LED (green). 3. When you want to enter to the software version display mode, press [DISC 1] button. The model infomation is displayed. Press [DISC 1] button again to view destination infomation. 4. Each time [DISC 1] button is pressed, the display changes from MC version, SYS version, UI version, CD version, CDDM version, CDMA version, CDMB version, BDA version, BDB version, ST version, TA version, TM version, TC version in this order, and returns to the model version display. 5. When [DISC 3] button is pressed while the version numbers are being displayed except model and destination, the date of the software creation appear. When [DISC 3] button is pressed again, the display returns to the software version display. When [DISC 1] button is pressed while the date of the software creation is being displayed, the date of the software creation is displayed in the same order of software version display. 6. Press [DISC 2] button, the key check mode is activated. 7. In the key check mode, the fluorescent indicator tube displays “K 0 V0”. Turn the [OPERATION DIAL] clockwise, “K” value increases by one. Turn the [OPERATION DIAL] counterclockwise, “K” value increases by one. Each time a button is pressed, “K” value increases. Press other buttons on main unit to check whether the button is detected. However, once a button has been pressed, it is no longer taken into account. “V” value increases in the manner of 0,1, 2, 3 ... if [MASTER VOLUME] knob is turned clockwise, or it decreases in the manner of 0, 9, 8, 7 ... if [MASTER VOLUME] knob is turned counter-clockwise. 8. When [DISC 3] button is pressed after all LEDs and segments in fluorescent indicator tube light up, the fluorescent indicator tube displays “VACS A”. A is VACS level which is trigger by signal level. 9. When [DISC SKIP/EX-CHANGE] button is pressed after all LEDs and segments in fluorescent indicator tube light up, alternate segments in fluorescent indicator tube would light up. If you press [DISC SKIP/EX-CHANGE] button again, another half of alternate segments in fluorescent indicator tube would light up. When [DISC SKIP/EX-CHANGE] button is pressed again, all segments lights off. Press [DISC SKIP/EX-CHANGE] button again would cause all segments lights up. 10. To release from this mode, press three buttons in the same manner as step 1, or disconnect the power plug.
[COMMON TEST MODE] • This mode is used to check operations of the respective sections of Amplifier and Tape.
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 [VACS ON/OFF] • This mode is used to switch ON and OFF the VACS (Variable Attenuation Control System). Procedure: 1. Press ?/1 button to turn on the set. 2. Press x button and [DIRECTION] button and [DISC 1] button simultaneously. The message “VACS OFF” or “VACS ON” appears on the fluorescent indicator tube. [TUNER STEP CHANGE] • The step interval of AM channels can be toggled between 9 kHz and 10 kHz.
Aging mode sequence: Start (from disc 1)
[CD SERVICE MODE] • This mode let you move the CD sled motor freely. Use this mode when you want to clean the optical pick-up.
button and Z OPEN/CLOSE button simultaneously. 4. The CD service mode is activated. The message “SERVICE MODE” appears on the fluorescent indicator tube. 5. With the CD in stop status, press M button to move the
376315150 892498299 TOC reading
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
QQ
Procedure: 1. Press ?/1 button to turn on the set. 2. Select CD function. 3. Press x button, [ILLUMINATION/SUB WOOFER LEVEL]
Disc chucking
Play first track for 2 seconds
Play last track for 2 seconds
optical pick-up to outside track, or press m button to move to inside track. The message “SLED OUT” or “SLED IN” appears on the fluorescent indicator tube. 6. To turn on or off the laser, press [GROOVE] button. The message “LD ON” or “LD OFF” appears on the fluorescent indicator tube. 7. To release from this mode, press ?/1 button.
EX-CHANGE open/close
Open the disc tray
Disc skip
Close the disk tray
Change to the next disc
www
.
xiaoy u163. com 17 http://www.xiaoyu163.com
13942296513
13942296513
Procedure: 1. Press ?/1 button to turn on the set. 2. Select CD function. 3. Load three discs on the disc tray. 4. Press [PLAY MODE] button on the remote repeatedly to select the “ALL DISCS” mode, and press the [REPEAT] button on the remote repeatedly to select “REPEAT OFF” mode. 5. Press x button, [ILLUMINATION/SUB WOOFER LEVEL] button, and[DISC SKIP/EX-CHANGE] button simultaneously.The CD ring indicator and line below CD ring indicator turn on afternately to indicate aging mode. 6. Aging operation is started. 7. To release from this mode, press ?/1 button or disconnect the power plug.
TEL
TEL
Procedure: 1. Press ?/1 button to turn on the set. 2. Press [TUNER/BAND] button repeatedly to select the “AM”. 3. Press ?/1 button to turn off the set. 4. Press [ILLUMINATION/SUB WOOFER LEVEL] button and ?/1 button simultaneously. The system will turn on automatically. The message “AM 9K STEP” or AM 10K STEP” appears on the fluorescent indicator tube and thus the channel step is changed.
[CD AGING MODE] This mode can be used for operation check of CD section. • If an error occurs, the aging operation would stops and the status is displayed. • If there were no error occurs, the aging operation would continue repeatedly.
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
• Display when an error occurred (CD Error Code Mode) Procedure: 1. Press x button, [ILLUMINATION/SUB WOOFER LEVEL] button and [DISC 1] button simultaneously to enter the error code display mode. 2. The fluorescent indicator tube displays the number of total error. 3. Each time m or M button is pressed, display change as below. Display of total error M >
m
Display of Mechanical errors
direction M
m
Display of no disc errors
direction
.
direction
1) Display of total error
Display
(Rotate . > knob in the direction of either to display next error) $$: Error type 01: Focus error 02: GFS error 03: Setup error %%: Not used &&: 00: No disc judgment without chucking retry. 01: No disc judgment after chucking retry. ##: The state when judged as no disc 01: Stop 02: Setup 03: TOC reading 04: Access 05: Playback 06: Pause 07: Manual search (Play) 08: Manual search (Pause)
Display
M*$$%%&&##00
M*: The number of mechanical error (“00” is latest one) (Rotate . > knob in the direction of either to display next error) $$: Not used %%: Loading related error (Second figure is not used) D: Stop by the problem other than mechanical problem while closing. E: Stop by the problem other than mechanical problem while opening. C: Stop by the problem other than mechanical problem while chucking up. F: Stop by the problem other than mechanical problem while chucking down. &&: Emerging error 01: Stop while chucking up. 02: Stop while chucking up. 03: Time-out of EX-CHANGE open. 05: Time-out of EX-CHANGE close. ##: Not used
Procedure: 1. Press ?/1 button to turn on the set. 2. Select CD function. 3. Press x button, [CD] button and [DISC 1] button simultaneously to enter the CD repeat 5 limit off mode and the fluorescent indicator tube displays “LIMIT OFF”. 4. To release from this mode, operate the cold reset. (Refer to the “COLD RESET”)
[CD SHIP MODE (WITH MEMORY CLEAR)] • This mode moves the optical pick-up to the position durable to vibration and clears all data including preset data stored in the RAM to initial conditions. Use this mode when returning the set to the customer after repair. Procedure: 1. Press ?/1 button to turn on the set. 2. Select CD function. 3. Press x button, [DIRECTION] button and ?/1 button simultaneously. The set will turn off automatically. 4. After the “STANDBY” blinking display finishes, a message “MECHA LOCK” is displayed on the fluorescent indicator tube and the CD ship mode is set.
xiaoy u163. com
18 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
2) Display of mechanical errors
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
EM**: The number of mechanical errors. ED**: The number of no disc errors after chucking the disc.
.
D*: The number of no disc error (“00” is latest one)
[CD REPEAT 5 LIMIT OFF MODE] • The number of repeat for CD playback is 5 times when the repeat mode is “REPEAT ALL”. This mode enables CD to repeat playback for limitless times.
EM**ED**
www
D*$$%%&&##00
13942296513
13942296513
4. To clear the error record, operate the cold reset. (Refer to the “COLD RESET”) 5. To release from this mode, press the ?/1 button or disconnect the power plug.
Display
TEL
TEL
>
.
direction
3) Display of no disc errors
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 [CD SHIP MODE (WITHOUT MEMORY CLEAR)] • This mode moves the optical pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair.
Procedure: 1. Press ?/1 button to turn on the set. 2. Select CD function. 3. Press [CD] button and ?/1 button simultaneously. The set will turn off automatically. 4. After the “STANDBY” blinking display finishes, a message “MECHA LOCK” is displayed on the fluorescent indicator tube and the CD ship mode is set.
[TCM OFFLINE MODE] • This mode prevents set from power off automatically when TCM is not connected. Therefore, measurements can be done even when TCM is not connected during production. • Procedure: 1. When the set in turned off, press [EQ BAND/MEMORY] button, [TAPE A/B] button and ?/1 button simultaneously. The set will turn on automatically. 2. The message “TCM OFFLINE” will be displayed on the fluorescent indicator tube.
QQ
QQ
QQ 376315150 892498299
376315150 892498299
376315150 892498299
TEL 13942296513
3. Press x button and Z OPEN/CLOSE button simultaneously and hold down until “LOCKED” or “UNLOCKED” displayed on the fluorescent indicator tube (around 5 seconds).
4. Press x button and ?/1 button simultaneously. The set will turn on automatically. 5. The message “CD POWER ON” or “CD POWER OFF” will be displayed on the fluorescent indicator tube.
www
.
xiaoy u163. com 19 http://www.xiaoyu163.com
13942296513
13942296513
Procedure: 1. Press ?/1 button to turn on the set. 2. Select CD function. 3. Press ?/1 button to turn off the set.
Procedure: 1. Press ?/1 button to turn on the set. 2. Select CD function.
TEL
TEL
[CD POWER MANAGE] • This mode let you switch on or off power supply to the BU during TUNER function. • When CD POWER is set to OFF, the power supply to the BU is cut off during TUNER function. It will increase the time taken to access CD when function change from TUNER to CD but it will improve tuner reception. • When CD POWER is set to ON, the power supply to the BU is not cut off during TUNER function. It will reduce the time taken to access CD when function change from TUNER to CD but it will decrease tuner reception performance.
[CD TRAY LOCK MODE] • This mode let you lock the disc tray. When this mode is activated, the disc tray will not open when Z OPEN/CLOSE button or [DISC SKIP/EX-CHANGE] button is pressed. The message “LOCKED” will be displayed on the fluorescent indicator tube.
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 SECTION 5 MECHANICAL ADJUSTMENTS
Precaution 1. Clean the following parts with a denatured alcohol-moistened swab: record/playback heads pinch rollers erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. Torque Measurement
FWD
Torque meter
CQ-102C
CQ-102C
FF/REW
CQ-201B
2.9 mN • m to 6.9 mN • m 30 to 70 g • cm (0.42 – 0.97 oz • inch) 0.15 mN • m to 0.59 mN • m 1.6 to 6 g • cm (0.022 – 0.08 oz • inch) 4.8 mN • m to 16.7 mN • m 49 to 170 g • cm (0.69 – 2.36 oz • inch)
0 dB=0.775 V
1. Demagnetize the record/playback head with a head demagnetizer. 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjust. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed for both L-CH and RCH. 7. Switches and controls should be set as follows unless otherwise specified. • Test Tape Tape P-4-A100
Signal 10 kHz, –10 dB
Used for Azimuth Adjustment
RECORD/PLAYBACK HEAD AZIMUTH ADJUSTMENT
DECK A
DECK B
QQ 376315150 892498299 test tape P-4-A100 (10 kHz, –10 dB)
MAIN board CN121 Pin 3 (L-CH) Pin 1 (R-CH) level meter set
+ – MAIN board CN121 Pin 2 (GND)
www
.
xiaoy u163. com
20 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
Procedure: 1. Mode: Playback
QQ
QQ
Note: Perform this adjustments for both decks
13942296513
13942296513
FWD back tension
Meter reading
DECK SECTION
TEL
TEL
Mode
SECTION 6 ELECTRICAL ADJUSTMENTS
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1dB of peak.
within 1dB
Output level
Screw position
Note:
1. CD Block is basically designed to operate without adjustment. Therefore, check each item in order given. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10MΩ impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks.
within 1dB
L-CH peak
CD SECTION
S-curve Check Connection:
R-CH peak L-CH peak
Screw position
R-CH peak
oscilloscope CD board
MAIN board CN121 set
oscilloscope pin 2 V
H
R
R-CH pin 1 waveform of oscilloscope
in phase 45 ° good
90 ° 135 ° 180 ° wrong
QQ 376315150 892498299 S-curve waveform
symmetry
A
4. After the adjustments, apply suitable locking compound to the pats adjusted. Adjustment Location: Playback Head (Deck A). Record/Playback Head (Deck B).
within 2.4 ± 1 Vp-p
B
Note: • Try to measure several times to make sure than the ratio of A : B or B : A is more than 10 : 7. • Take sweep time as long as possible and light up the brightness to obtain best waveform. Checking Location: CD board (SIDE B) (See page 23.)
www
.
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
Procedure: 1. Connect an oscilloscope to test point JPO102 (FE1) and TP 117(VC) on the CD board. 2. Turn the power on. 3. Put the disc (YEDS-18) in and turned power switch on again and actuate the focus search. (actuate the focus search when disc table is moving in and out) 4. Check the oscilloscope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within 2.4 ± 1 Vp-p.
pin 3 L
+ –
13942296513
13942296513
test tape P-4-A100 (10 kHz, –10 dB) L-CH
JPO102 (FE1) TP117 (VC)
TEL
TEL
3. Mode: Playback
xiaoy u163. com
azimuth screw
21 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 E-F Balance Check Connection:
RFAC Level Check Connection:
oscilloscope
oscilloscope
CD board
CD board TP124 (RFAC) TP117 (VC)
JPO103 (TE1) TP117 (VC)
+ –
Procedure: 1. Connect an oscilloscope to test point TP124 (RFAC) and TP 117(VC) on the CD board. 2. Turn the power on. 3. Put the disc (YEDS-18) in to playback the number five track. 4. Confirm that oscilloscope waveform is clear and check RFAC signal level is correct or not. A clear RFAC signal waveform means that the shape “◊” can be clearly distinguished at the center of the waveform.
RFAC signal waveform
level: 0.9 ± 0.4 Vp-p
Center of the waveform
Traverse Waveform
QQ 376315150 892498299 level: 1.0 ± 0.5 Vp-p
8. Press the . button. The message “TRAVERSE” is displayed. (The tracking servo and sledding servo are turned ON) Confirm the C (DC voltage) is almost equal to the A (DC voltage) is step 5. 9. To exit from this mode, perform as follows. 1) Move the optical pick-up to the most inside track. 2) Press three buttons of x , [CLEAR], and [DISPLAY] simultaneously. (cold reset) Notes:
• Always move the optical pick-up to most inside track when exiting from this mode. Otherwise, a disc will not be unloaded. • Do not run the sled motor excessively, otherwise the gear can be chipped.
Traverse Waveform
0V
www
xiaoy u163. com Tracking servo Sled servo OFF
.
Tracking servo Sled servo ON
Checking Location: CD board (SIDE B) (See page 23.)
22 http://www.xiaoyu163.com
C (DC voltage)
376315150 892498299
376315150 892498299
TEL 13942296513
A (DC voltage)
0V
QQ
QQ
B
Checking Location: CD board (SIDE B) (See page 23.)
13942296513
13942296513
VOLT/DIV: 200 mV TIME/DIV: 500 ns
Procedure: 1. Connect an oscilloscpe to test point TPO103 (TE1) and TP117 (VC) on the CD board. 2. Turn the power on. 3. Select the function “CD”. 4. Press three buttons of [ENTER], M , and [SURRUUND MODE] simultaneously to set the CD service mode. 5. Put the disc (YEDS-18) in to playback the number five track. 6. Press the . button. The message “TRAVERSE” is displayed. (The tracking servo and the sledding servo are turned OFF) 7. Check the level B of the oscilliscope's waveform and the A (DC voltage) of the center of the Traverse waveform. Confirm the following : A/B x 100 = less than ± 22%
TEL
TEL
Note:
+ –
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 Checking Location:
– CD BOARD (SIDE B) –
TEL
TEL
13942296513
13942296513
TP117 (VC) JPO103 (TE1)
IC101 JPO102 (FE1)
QQ
QQ
QQ 376315150 892498299
376315150 892498299
376315150 892498299
TEL 13942296513
TP124 (RFAC)
www
.
xiaoy u163. com 23 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 SECTION 7 DIAGRAMS
For schematic diagrams. Note: • All capacitors are in µF unless otherwise noted. (p: pF) 50 V or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • % : indicates tolerance. • f : internal component. • 2 : nonflammable resistor. • 5 : fusible resistor. Note: The components identified by mark 0 or dotted line with mark ! are critical for safety. Replace only with part number specified.
TEL
(The other layers' patterns are not indicated.) Caution: Parts face side: (Side A) Pattern face side: (Side B)
Parts on the parts face side seen from the parts face are indicated. Parts on the pattern face side seen from the pattern face are indicated.
• Indication of transistor.
C Q
These are omitted.
B E
Q B C
E These are omitted.
Q C
E These are omitted.
• Abbreviation AR : Argentina model AUS : Australian model E2 : 120V AC Area in E model E3 : 240V AC Area in E model E51 : Chilean and Peruvian model
www
.
xiaoy u163. com
24 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
376315150 892498299
QQ
QQ
QQ
B
13942296513
13942296513
TEL 13942296513
Note: • X : parts extracted from the component side. : Pattern from the side which enables seeing. •
TEL
C : panel designation. A : B+ Line. B : B– Line. H : adjustment for repair. Voltages and waveforms are dc with respect to ground under no-signal conditions. CD board no mark: CD PLAY Other boards no mark: TUNER (FM/AM) ( ) : CD PLAY < > : TAPE PLAY [ ] : TAPE REC * : Impossible to measure • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. • Signal path. F : AUDIO f : TUNER (FM/AM) E : TAPE PLAY (DECK A) d : TAPE PLAY (DECK B) G : RECORD J : CD PLAY N : MIC INPUT • • • • •
Note on Printed Wiring Boards:
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
• WAVEFORMS
– CD BOARD –
– MAIN BOARD –
1 IC101 wa TEI
HCD-GNX600
• CIRCUIT BOARDS LOCATION
– SMASTER BOARD –
1 IC401 qa XC-OUT
1 IC800 2 SENSOR board CD board
0.8 Vp-p
2.7 Vp-p
SW board
0.15 Vp-p
MOTOR (LD) board 30.5 µsec
1V/DIV, 10 µsec/DIV
0.2V/DIV, 0.2 msec/DIV
2 IC101 wd FEI
TUNER pack
20.3 nsec 0.5V/DIV, 20 nsec/DIV
POWER board
DRIVER board
2 IC401 qd X-OUT
SPEAKER board
13942296513
13942296513
0.4 Vp-p
TEL
TEL 3.3 Vp-p
MOTOR (TB) board
PANEL board
– ADC BOARD – IR board
1 IC03 1
2 µsec 1V/DIV, 1 µsec/DIV
0.1V/DIV, 1 msec/DIV
3 IC101 ra RFAC
3 T101 5
MAIN board
4 Vp-p
TAPE REC only
VOL board
SMASTER board
81.3 nsec
10.5 µsec
0.2V/DIV, 0.5 µsec/DIV
QQ
3 7 6 3 1 5 1 5 0
50V/DIV, 10 µsec/DIV
4 T101 4
MIC board
8 9 2 4 9 8 2 9 9
TAPE REC only
82 Vp-p
10.5 µsec 50V/DIV, 10 µsec/DIV
www
.
x
i
a o y u 1 6 3
HCD-GNX600
25 25 http://www.xiaoyu163.com
.
c o
m
ADC board
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
2V/DIV, 50 nsec/DIV
QQ
QQ
T E L
67 Vp-p
0.9 ± 0.4 Vp-p
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
7-1. BLOCK DIAGRAM
8 9 2 4 9 8 2 9 9
– CD SECTION –
CD-L
AOUT1 81
AOUT2 86
OPTICAL PICK-UP BLOCK (KSM-215DCP/C2NP)
R-CH
IC101
CD MUTE Q237,287
RF AMP, DSP, DAC
MAIN SECTION (Page 28)
A
CD MUTE DRIVE Q307, 308
DETECTOR VCC
+3.3V
IC301
VC
25 VC
MP3 DECODER
IC303
A
26 A
PCMD1 61
11 SDO0
VDD 55
B
27 B
LRCKI 62
16 LRCKIA
VDD 21
C
28 C
LRCK 63
19 SFSY/LRCK1B
D
29 D
PCMD 65
14 SDI0
E
19 E
BCK 66
F
20 F
BCK1 60
5
REG
1
+3.3V
VDDM 40
15 BCKIA 18 SBSY/BCK1B
MIDIO 6 78 XTAI XTACN 95 XRST 100
37 PD
IC251
DATA 102
SL/SP MOTOR DRIVER
XLAT 104 CLOCK 105
F
TRACKING COIL
T
T E L
CH1RIN 5 13 CH1OUT-R
SCOR 115
11 TFDR
DATA
SRMSTB 41
CH2FIN 6
22 MP3 RST
SCOR SENS
SENS
CLOCK
SCOR
XLT
QQ
XTACN
2 CD-DATA
34 CD MUTE
MUTE DATA
CH3FIN 23
9 SFDR
16 CH4OUT-F CH3RIN 22
RESET 12 IIC-DATA 30 IIC-CLK 29
SYSTEM CONTROL
10 SRDR
8 9 2 4 9 8 2 9 9 E-3 ROTARY E-2 ENCODER E-1
S751 (OPEN)
17 CH3OUT-F M102 M (SLED)
TBL ADDRESS SENS
S711
33 31 32 9
15 CH4OUT-R
M+9V
INVERTER
28 XTACN
14 FRDR
M741 (TABLE)
IC401 (1/5)
3 7 6 3 1 5 1 5 0
1 XRST
M
IC731
82 CD-CLK 3 XLAT
M751 (TABLE LOADING)
OUT1 4 OUT2 2
Q731
21 SENS
XRST
13 FFDR
E-3 43 OPEN SW 41
19 SCOR
DATA
12 TRDR
9 RIN 7 FIN
E-2 44
6 MP3 DATA IN
XLT
IC712
M
TABLE MOTOR DRIVER
TBL_SENS 42 E-1 45
23 MP3 CS
MP3 RST
14 CH1OUT-F CH2RIN 7
M101 M (SPINDLE)
24 MP3 LP
MP3 CS
CLOCK
1 3 9 4 2 2 9 6 5 1 3
TM-R 47 TM-F 46
NO401 OPIN+ 2
6 MDP
18 CH3OUT-R MUTE 20
IIC-CLK
4
IIC-DATA
100 XRST VMUTE
S101 (LIMIT)
3
7 SSTP
CN402 2 TXD1
MUTE DATA
3
CDG RST
6
CDG DET
7
CNVSS
8 9
RTS1 CLK1
ON BOARD PROGRAM
RXD1 CN VSS RESET
• R-CH is omitted due to same as L-CH. • SIGNAL PATH
www
.
x
i
a o y u 1 6 3
HCD-GNX600
26
26 http://www.xiaoyu163.com
.
c o
m
: CD
376315150 892498299
376315150 892498299
T+
11 CH2OUT-R
SENS 107
RESET 2
7 MP3 CLK 5 MP3 DATA OUT
OUT1 4 OUT2 2
QQ
QQ
FOCUS COIL
OUT 12 CH2OUT-F VREF 26 CH1FIN 4
MICS 4
XRST
7 FIN
CNVSS
F+
XTACN
MP3 LP
9 RIN
LM-F 48
CDG DET
PD VR
MILP 5
MP3 DATA
LM-R 49
25 MP3 ACK
CNVSS
X171 16.9MHz
MP3 CLK
26 MP3 REQ
VMUTE
77 XTAO
MP3 ACK
CDG DET
MIACK 8 MICK 7
27 MP3 STB
MP3 REQ
13942296513
13942296513
GND
PO11/BUCK/AD14 36
CDG RST
STANBY 3
36 LD
VMUTE
LD DRIVER
TABLE LOADING MOTOR DRIVER
MP3 STB
CDG RST
LD
TEL
TEL
IC701
Q10
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 7-2. BLOCK DIAGRAM
HCD-GNX600
8 9 2 4 9 8 2 9 9
– TAPE/TUNER SECTION –
DECK-A
75
L – CH
PB HEAD
AIN1 A
R – CH
EQ OUT1
R-CH
76 SWITCH DRIVE Q110, 111
Q166
DECK-B
79
78
B
TAI1
PB OUT1
TC-PB-L
80
R-CH
MUTE Q103
1 R-CH
IC101(1/2) Q154, 155
R – CH
L R
TEST CONNECTOR
MUTE DRIVE Q303, 304
DECK A/B SELECT, PB/REC EQUALIZER AMP
Q109
3
MAIN SECTION (Page 28)
CN111
BIN1
L – CH REC/PB HEAD
C
SWITCH DRIVE Q107, 108
R-CH C174, L104
TEL
17
REC IN1
EQ
REC-OUT-L
15
D
MAIN SECTION (Page 28)
MUTE Q175
13942296513
13942296513
R-CH
REC-OUT1
TEL
BIAS TRAP
R-CH
T101 ERASE HEAD
BIAS+9V
BIAS OSC Q101
TC REC MUTE DRIVE Q301, 302
Q113,114
REC(FWD)
QQ
1 3 9 4 2 2 9 6 5 1 3
B SHUT A SHUT
3 7 6 3 1 5 1 5 0
90 B SHUT 89 A SHUT
91 B-HALF 63 A-HALF
BHALF AHALF
IC403(1/2)
ATRGM+
A TRIG DRIVE Q122, 123
17 A-TRIG
BTRGM+
B TRIG DRIVE Q118, 119
19 B-TRIG
CAP M+
CAP MOTOR DRIVE Q120, 121
SIGNAL IN/OUT CONTROL TC-MUTE 5
18 CAPM-CNT
CN101 21 TC-RELAY FM/AM TUNER UNIT
FM ANT
LATCH 4
70 IO-EXP-LAT
CLK 3
69 IO-EXP-CLK
RESET 2
68 IO-EXP-RST
DI1 26
66 IO-EXP-DATA-OUT
7 REC-MUTE ST-L
ST-L FM 75 COAXIAL
ST-R
R-CH
E
MAIN SECTION (Page 28)
20 REC BIAS
40 TUNED
TUNED AM ANT
AM
www AM ANT
ANTENNA
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
T E L
IC401(2/5)
SYSTEM CONTROL (CD/TAPE MECHANISM CONTROL)
QQ
QQ
TAPE MECHANISM DECK
ST-DIN ST-DOUT ST-CLK ST-CE
.
x
i
a o y u 1 6 3
HCD-GNX600
27 27 http://www.xiaoyu163.com
.
c o
m
39 37 38 36
ST-DOUT ST-DIN ST-CLK ST-CE
• R-CH is omitted due to same as L-CH. • SIGNAL PATH : TUNER (FM/AM) : PLAYBACK (DECK A) : PLAYBACK (DECK B) : RECORD
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
7-3. BLOCK DIAGRAM
8 9 2 4 9 8 2 9 9
– MAIN SECTION –
IC1400
DIGTAL ECHO
AD IN
ALC
J1450(1/3) MIC 2
15
J1400(1/3) MIC 1
16
23
25
DA OUT
MC1P
+ ALC
IC1401
ECHO VOL
MIC VOL PRE LPF
+
ADPCM ENCODE
ADC
DELAY
ADPCM DECODE
DAC
POST LPF
S/H
MIC AMP
+
POOUT
29
3
MIC OUT
7
J1400(3/3)
MIC VOL
MC2P
5
6
J1450(3/3)
VOL3
VOL2
VOL1
VOLUME CONTROL
7
RV1401 MIC 2 LEVEL
RV1402 ECHO LEVEL
TEL
TEL
J1400(2/3)
13942296513
REC-OUT-L
TAPE/TUNER SECTION (Page 27)
14
MIC
59
D
J501 L
A
TAPE/TUNER SECTION (Page 27)
C
TAPE/TUNER SECTION (Page 27)
E
QQ
1 3 9 4 2 2 9 6 5 1 3
CD-L
TC-PB-L
R-CH
4
INPUT SELECT SWITCH
3 7 6 3 1 5 1 5 0
+
24
28
FRONT-L
+
1
+
SURROUND ST-L
8 9 2 4 9 8 2 9 9
TONE 23
3
31
R-CH
35
COMMAND
SW
29
37
R-CH
AMP SECTION (Page 29)
FRONT-R
L+R
CLK
MCU INTERFACE
B
30
R-CH
DATA
CD SECTION (Page 26)
R-CH
34
53
J506 L+R D+4V
3 2
D-LIGHT SYNC OUT
• R-CH is omitted due to same as L-CH. • SIGNAL PATH
x
88 VACS IN
.
84 M61537-CLK
www
83 M61537-DATA
1
i
a o y u 1 6 3 IC401(3/5)
SYSTEM CONTROL
HCD-GNX600
28
m
: AUDIO
28 http://www.xiaoyu163.com
.
c o
: TUNER (FM/AM)
: CD : TAPE PLAY : RECORD : MIC
376315150 892498299
376315150 892498299
T E L
R
5
QQ
QQ
AUDIO IN
IC101(2/2) INPUT SELECT SWITCH, GRAPHIC EQUALIZER CONTROL, ELECTRICAL VOLUME
13942296513
RV1400 MIC 1 LEVEL
J1450(2/3)
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 7-4. BLOCK DIAGRAM
HCD-GNX600
8 9 2 4 9 8 2 9 9
– AMP SECTION –
IC650
IC600
POWER DRIVER
STREAM PROCESSOR
IC12
A/D CONVERTER
• Signal Path
DOUT_2
DOUT 12
: AUDIO 2 RIN
BCK
BCK 11 15 SCKI
PDWN 7
31 DATA
OUTR1
6
36 XFSIIN 30 BCK 29 LRCK
OUTR2
4
21 22 23 27 18 19
6 PWM-A 5 RESET
OUTA
SCDT SCSHIFT SCLATCH INIT NSPMUTE SOFTMUTE
27
LPF
(+)
LPF
(–)
SUB WOOFER
28 30
4
DC DETECT Q865, 866
FSOCKO 37 FS0I 38
XFS0IN 48
A/D CONVERTER
BCK
15 SCKI
DOUT1 XFSIIN BCK1 LRCK1
PDWN 7
OUTR1
36 XFSIIN 30 BCK 29 LRCK
OUTR2
OUTL2
5
6 PWM-A
L
5 RESET
LPF
(+)
LPF
(–)
R
28 OUTA
L
9
27
30
2
XFSIIN
4
IC403 (2/2)
43
39
FRONT SPEAKER
IC530 POWER DRIVER
IC800
6 PWM-A OUTA
OSC
14 PWM-B
QQ
OUTB
28 30
X800 49.152MHz
(+)
LPF
(–)
L
25
3 7 6 3 1 5 1 5 0 5 RESET
LPF
8 9 2 4 9 8 2 9 9
27
4
DC DETECT Q850, 851
IC880
SIGNAL IN/OUT CONTROL ADC-RESET 22 SM-NSP-MUTING 9 SM-INIT 12 SM-SOFT-MUTING 10
NSPMUTE INIT SOFTMUTE
5
7
3
1
J1401 PHONES HP MUTE Q1450,1451
HP MUTE Q1400,1401
FAN CTRL 24
M891 DC FAN MUTE SWITCH Q486
IC401 (4/5) SYSTEM CONTROL SM-DATA SM-CLK SM-LATCH-1 SM-LATCH-2
78 77 76 79
SCDT SCSHIFT SCLATCH1 SCLATCH2
SM RESET 65 PROTECT DETECT Q840
SM-SD 72
HP-MUTE 86 HP-DET 85
www
.
x
i
a o y u 1 6 3
HCD-GNX600
29 29 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
DC DETECT Q855, 856
QQ
QQ
IC802 3
4
SCDT SCSHIFT XFS0OUT 14 SCLATCH FSOCKO 37 INIT FS0I 38 NSPMUTE SOFTMUTE XFS0IN 48 HPOUTR2
X001 12.288MHz
21 22 23 27 18 19
HPOUTL2
SCDT SCSHIFT SCLATCH 1 INIT NSPMUTE SOFTMUTE
7
6
R
4
CLOCK GENERATOR
2
14 PWM-B OUTB
6
OUTL1 11
IC03 1
25
R 31 DATA
SD
LRCK 10 BCK 11
FEED BACK SWITCH Q101
IC550 POWER DRIVER
LRCK
13942296513
13942296513
FEED BACK SWITCH Q151
IC500 STREAM PROCESSOR
2 RIN
TEL
TEL
FRONT-R
DOUT_1
DOUT 12
1 LIN
SD
FRONT-L
T E L
14 PWM-B OUTB
SW
25
IC11
SW
B
SCDT SCSHIFT SCLATCH2 INIT NSPMUTE SOFTMUTE
LRCK
LRCK 10
MAIN SECTION (Page 28)
XFSIIN BCK1 LRCK1
TM1500
SW
SD
DOUT2
.
c o
m
UNREG +12V
FAN DRIVE Q580,582, Q584,585
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
7-5. BLOCK DIAGRAM
8 9 2 4 9 8 2 9 9
– DISPLAY/ POWER SECTION –
E2, E3, E51
M+9V
DR17-35
LED+9V
D563 D562 D561
1G, 12G-16G
2-6,18
FL1300 FLUORESCENT INDICATOR TUBE
16–38
P1 – 20
BUFFER Q1311-1316
IC551
M+7V
7-13,15-17
2G-11G F1
F2
AC IN
+44V
+9V REG
IC552
2
+9V REG
7 C
D1114
IC1102 +12V REG
VIN 6
1
D1119
4 VCC
BIAS A+9V
DR5-14
D1112 SMASTER G+12V
3 FB
IC1101
ST A+9V
IC1300
VOLTAGE DETECT
D594
40 VFDP
IC01
A+5V
D1118
IC1100 POWER SWITCHING CONVERTER
PHOTO COUPLER PC1100
+5V REG
51 52 48 49 +1.8V
IC810
IC02
+1.8V REG
+3.3V REG
FL-DRIVER-CS FL-DRIVER-RESET FL-DRIVER-CLK FL-DRIVER-DATA
MAIN ON/OFF SWITCH Q1100, 1101
MAIN ON/OFF 100 S1302,1306,1307, 1309-1328,1331 AD-KEY-1 | AD-KEY-3
Q1304 Q1308
E2, E3, E51
D506
50-52
LED-ILLUMINATION-1 | LED-ILLUMINATION-3
D+4V
+4V REG
D1212
+8V REG Q1205, 1206
EVER +4V
+B SWITCH Q561
CD-POWER 35 ROTARY ENCODER S1305
IC562
+3.3V REG Q560
D1310-1312
3 7 6 3 1 5 1 5 0 +4V REG Q1203, 1204
8 9 2 4 9 8 2 9 9
T1200 SUB POWER TRANSFORMER
5 D
D1213
4 VCC
54 VOL-A
D1207
2 F/B
55 VOL-B
IC401 (5/5)
1 Z/C
D394
SYSTEM CONTROL D+3.3V(2)
EVER +4V
D1204 D395
IC1201 LED DRIVE Q1309
61 SW-LED
VOLTAGE DETECT
D393
S1301
D1313 SUB WOOFER ON/OFF
EVER +3.3V
Q1200
D396 PHOTO COUPLER PC1200
D1304 POWER-KEY 74 56 STBY-LED DISPLAY-KEY 73 S1300 DISPLAY
IC1301
4 SIRCS
REMOTE CONTROL RECEIVER
www X402 5MHz
X401 32.768kHz
15 X-IN 13 X-OUT
.
10 XC-IN
11 XC-OUT
IC1200
D1211
x
i
RESET SWITCH Q213
IC402
a o y u 1 6 3 RESET 12
1
LEVEL DETECT
2
AC-CUT 20
HCD-GNX600
30
30 http://www.xiaoyu163.com
.
c o
m
PRIMARY SWITCHING, MAIN CONVERTER
376315150 892498299
376315150 892498299
QQ
1 3 9 4 2 2 9 6 5 1 3
LED DRIVE Q1305-1307
FL+4V
+3.3V
MASTER VOLUME
AR,AUS
QQ
QQ
T E L
PHOTO COUPLER PC1101
D+3.3V(1)
53 LED-CTRL
D1307-1309
D1102
PHOTO COUPLER PC1102
Q1310
Q1303
C1113
Q1102
94,95,97
LED+9V
D1101
13942296513
13942296513
60 59 58 57
C1112
TEL
TEL
CSb RSTb SCK SI
LED +9V
OSC Q1300
220-240V
D1100
FL DRIVER RECT D1300-1303
120V
DR0-4,15 AUDIO A+9V
T1300 DC/DC CONVERTER
T1100 MAIN POWER D1103 TRANSFORMER
SW1100
VOLTAGE SELECTOR
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 • See page 25 for Circuit Boards Location.
7-6. PRINTED WIRING BOARD – CD BOARD –
3
2
1
4
HCD-GNX600
8 9 2 4 9 8 2 9 9
: Uses unleaded solder.
5
6
8
7
9
10
A
CD BOARD (SIDE A)
CD BOARD (SIDE B) M
M101 (SPINDLE)
C302
IC303 S101 (LIMIT)
C305
1
4
5
C311 R306 C212
C123
OPTICAL PICK-UP BLOCK (KSM-215DCP)
R133 R131 C131
TP124 (RFAC)
R132
C122
R406
C143 R142 C141 C142
C185 C186
MAIN BOARD (Page 35)
27 R204
R151
CN101
C133
1-860-502-
13 (13)
R161
R111
C111
A R182
R412 R112
C162 C181
C115
IC101
CN201
R410
R408 C213
C211 R163 C194
C163
R181
R307 R411
8 9 2 4 9 8 2 9 9
R407
C124
R10 R13
C11
C17
1
R401
C161 C16 Q10 E
R121 C134
C18 R11 R12
C10
C112
C15
C125
E
R409
C114 C113 R113 R114
C14
C196
C151
48
R303
JPO103 (TE1)
C195
C317 R305 R402
49 33
3 7 6 3 1 5 1 5 0 TP117 (VC)
JPO102 (FE1)
C171
R171
X171
C209
C203
R173
C174
R165
C182
C172
R172
32
C310 C251
QQ
R191
IC301
R252 R251
FB301
C201
C309
C116
C210 R162
14
R301 64
376315150 892498299
376315150 892498299
R201
C320 8
7
1
M102 (SLED)
M
QQ
QQ
D
1
16
C307
R253
C258 C259
1 3 9 4 2 2 9 6 5 1 3 C183
C313
17
C318
R205
R404
IC251 R353
C308
T E L
R419 R403
C306
R352
C312
C184
15
21
22
C132 R143 R141
R354 R405
R302 C314
28
C257
13942296513
13942296513
R351
C260
R313 C315 C316
C
C252
C255
C303
TEL
TEL
B
3
R203
1-860-502-
13 (13)
F
www
.
x
i
a o y u 1 6 3
HCD-GNX600
31 31 http://www.xiaoyu163.com
.
c o
m
• Semiconductor Location Ref. No.
Location
IC101 IC251 IC301 IC303
D-8 C-6 C-8 B-8
Q10
E-4
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0 • See page 51 and 52 for IC Block Diagrams. • See page 25 for Waveforms.
7-7. SCHEMATIC DIAGRAM – CD BOARD –
8 9 2 4 9 8 2 9 9
• See page 54 for IC Pin Function Description
CN101 16P
C151 100 10V
R351 100
R302 10k
R303 100k
C310 0.1
R121 15k
C131 100p
JPO10 APC
MP3 CLK MP3 DATA
R419 100
MP3 LP
R403 100
MP3 CS
C18 0.001
TP121 RFDCO
R353 100 C318 0.01
R111 1k
TP301
R161 100
C317 0.01
C303 0.1
TP117 VC
RF AMP, DSP, DAC
X171 16.9MHz
R171 470 R172 1M C195 0.1
R181 100 C185 470p
1 3 9 4 2 2 9 6 5 1 3
C186 470p
C181 0.1
C182 0.1
QQ
C183 22 6.3V C184 22 6.3V
R182 100
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
S101
TP167 LOCK
TP178 FOK TP166 DFCT
C305 220 4V
TP165 MIRR
TP160 WDCK TP162 COUT
TP146 C2PO
TP153 GFS
TP144 XUGF
TP147 XPCK
R191 0
C163 0.1
R165 0
TP145 WFCK
TP142
TP148 SBSO TP149 EXCK
C194 0.1
R252 22k R251 10k
JPO004 MDP C251 0.0068
R163 100
R162 47k
C258 0.1
C259 0.1
C196 0.1
C210 0.1
CN201 27P
R253 10k
IC251 BA5947FM-E2
MP3 ACK
MP3 ACK
R201 0
MP3 CLK
MP3 CLK
MP3 DATA
MP3 DATA
C203 100 10V
MP3 LP
MP3 LP
C201 100 10V
MP3 CS
MP3 CS
C209 0.01 MAIN BOARD (1/3) CN351 (Page 36)
R205 0
R411 100 M101 (SPINDLE)
R410 100 R409 100 R408 100
C257 0.1
R407 100
CD-DATA
R406 100
BD-RST
C213 22p
R412 100 C212 22p
www
C260 220 10V
C211 220p
R204 0
.
x
i
a o y u 1 6 3
HCD-GNX600
32
32 http://www.xiaoyu163.com
.
c o
C255 0.1
C252 0.1
m
M102 (SLED)
376315150 892498299
376315150 892498299
C302 0.1
R173 0
C116 100 10V C115 0.1
C171 22p
C314 47 4V
R114 15k
C112 470p C113 0.0033 C114 470p
QQ
QQ
FB301 BLM21B272S
JPO103 TEI IC101 CXD3059AR
C162 0.1
C320 0
C172 27p
T E L
C111 0.0033
R112 15k JPO102 FEI R113 1k
R313 C315 220 0.1
13942296513
13942296513
R354 100
C161 0.1
C174 0.1 C312 0.1
OPTICAL PICK-UP BLOCK (KSM-215DCP)
R352 100
C313 0.1
IC303 BH15FB1WG
C14 0.1
C123 0.1
R132 10k
R305 100k
R306 0
Q10 2SA2119K
R11 0
C122 0.1
R301 100k
C311 0.1
R13 1 R10 3.3
MP3 ACK
R405 100
R402 100
C316 0.0022
C16 1
C306 0.1
R404 100
R401 100
TP124 RFAC
C17 220 4V
TEL
TEL
MP3 DECODER
R133 180k
R141 4.7k
TP303 IC301 TC94A34FG-002
C309 0.1
C141 0.1 R142 1k
R151 0
C133 0.01 R131 1M
C143 0.1
TP302
C308 47 4V
R12 100k
C132 0.47 R143 3.3k
R203 0
C125 0.1
C134 0.1
C10 10
C142 0.0015
TP304
C124 330p
C307 0.1
C11 10
C15 0.1
R307 10k
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 7-8. PRINTED WIRING BOARDS – CD MECHANISM SECTION –
• See page 25 for Circuit Boards Location.
3
2
1
HCD-GNX600
8 9 2 4 9 8 2 9 9
: Uses unleaded solder.
4
5
SENSOR BOARD
6
7
A CN731
G
DRIVER BOARD
C731
C715 R701
4
JW703 JW702
JW704
R731
1-687-669-
(12)
JW701
R712
R711
D701
R702
9
1
1 CN704
CN751
8 9 2 4 9 8 2 9 129
1 CN703
JW714
C752 JW712 C741 R721
3 7 6 3 1 5IC701 1 5 0
D711
2 1
9
JW713
2
R723
C751
C737 C736 C735
1-687-134-
12 (12)
1
R713
QQ
C
IC712
1-866-201-
12 (12)
MOTOR(LD) BOARD D 1
2
CN721
S711 ROTARY ENCODER • Semiconductor Location
M
Ref. No.
E
www
M751 (TABLE LOADING)
.
x
i
a o y u 1 6 3 1-687-133-
12 (12)
HCD-GNX600
33 33 http://www.xiaoyu163.com
.
c o
m
Location
D701 D711
C-5 C-5
IC701 IC712 IC731
C-5 B-5 B-2
Q731
B-4
376315150 892498299
376315150 892498299
1 3 M9 4 2 2 9 6 5 1 3
R722
CN742
JW708 JW709
QQ
QQ
M741 (TABLE)
CN702
R735
JW710
R734
CN741
T E L
CN701
R736
R732
3
1
JW707 JW706 JW705
R733
MOTOR(TB) BOARD
S751 (OPEN)
13942296513
13942296513
12 1-687-132- (12)
B
JW711
CN705
2 1
SW BOARD
TEL
TEL
IC731
R751
Q731 E
MAIN BOARD CN511 (Page 35)
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
• See page 51 for IC Block Diagrams.
7-9. SCHEMATIC DIAGRAM – CD MECHANISM SECTION –
IC701 BA6956AN
13942296513
13942296513
M751 (TABLE LOADING)
C751 0.01
CN704 2P
TEL
TEL
CN721 2P
R702 100 R701 470
D701 MTZJ-T-77-5.1A
IC712 BA6956AN
IC731 RPI-576 CN742 5P
M741 (TABLE)
CN731 3P
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
C741 0.01
CN702 5P
R711 1k
CN741 3P
D711 MTZJ-T-77-3.6B
R712 4.7k
C715 100 16V
R713 22k
R736 390
CN703 4P
MAIN BOARD (1/3) CN405 (Page 36)
E1 E2 E3
R731 100
CN711 4P
www
R733 1k
.
x
R734 12k
R732 10k Q731 DTC114ESA INVERTER
i
CN701 13P
R723 4.7k
a o y u 1 6 3
HCD-GNX600
34
34 http://www.xiaoyu163.com
R722 4.7k
R721 4.7k C731 10 50V
C737 0.1
.
C736 0.1
c o C735 0.1
m
R751 4.7k
C752 0.1
CN705 2P S751 (OPEN) CN751 2P
376315150 892498299
376315150 892498299
QQ
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
.
D
JW165
JW166
JW164
JW163
JW186
JW183
JW185
C527
JW188
R531
C537
C523
JW182
FB506
R563
JW194 JW201 JW202 JW203
1
JW385
.
JW399
JW253
R575
R506
2 1
m 9
c o
E
1-868-829POWER BOARD CN1200 (Page 49)
3
J506 D-LIGHT SYNC OUT
D101 D102 D104 D213 D214 D215 D216 D230 D231 D232 D393 D394 D395 D396 D486 D506 D561 D562 D563 D580 D581 D582 D583 D586 D594
E-3 E-2 E-2 C-6 C-5 C-6 C-5 D-6 D-5 D-6 C-6 B-5 C-5 C-6 D-6 B-4 F-11 F-11 F-11 G-12 G-12 G-11 G-12 C-11 G-10
IC101 IC401 IC402 IC403 IC551 IC552 IC562
G-5 C-4 C-5 E-3 G-11 G-11 D-11
Q101 Q103 Q104 Q105 Q106 Q107 Q108 Q109
H-5 G-3 H-2 H-3 G-2 H-3 H-3 H-3
R508
JW391
CN590
1
4 5
R509 JW382 FB514 CLP02
JW592
M891 DC FAN
CN580
JW247
C550
EP501
JW257
JW256
JW262
35 35 http://www.xiaoyu163.com
JW250
JW255 JW254
JW264
JR261
HCD-GNX600
C571
D581
JW249
JW263
JW258 JW388
FB513 C581
3
JW244 JW245 JW246
C582
ADC BOARD CN01 (Page 43)
D580
Q582 E E R578 E Q580 Q584 R576 R583 3 C580 E Q585 1 JW248
JW243
JW265
JW226
R525
C521
IC552
C556
D583
C583
R577
JW242
C555
C553
JW259 JW260
JR550
D582
R580 R579
C552
JW241 JW239
C267
JW266 JW267
FB555
JW205 JW204
JW210
JW215 JW214 JW213 JW212 JW211
JW238
JR037
3
JW252
JR126
R294
JW231
JW155
JW381 JW219 JW218 JW217 JW216
JW220
JW299 JW298
JR036
JW371
D594
JW240
JW261
JW269 JW268
JW270
JW276 JW395
JW271
JW167
C535 JW162
JW161
JW159
JW153 JW379
JW152
JW147
JW146
JW355
JW145
JW321
R200
C197
IC551
1
JW236 JW237
R246
a o y u 1 6 3 JR057
D561
C551
JW234
JW288
JW277
JW332
JW329
JW274
JW273
JW233
L
C520
D562
JW232
JW287
R267
R
C531
FB505
JW230
Q287
Location
Ref. No. Q110 Q111 Q112 Q113 Q114 Q118 Q119 Q120 Q121 Q122 Q123 Q125 Q151 Q153 Q154 Q155 Q166 Q175 Q213 Q237 Q287 Q301 Q302 Q303 Q304 Q307 Q308 Q486 Q560 Q561 Q580 Q582 Q584 Q585
8 9 2 4 9 8 2 9 9
R574
D563
JW286
JW281 JW279 JW280 JW278
Ref. No.
J501 AUDIO IN
R524
R245
JR267
• Semiconductor Location
C570
JW228
CLP04
R296
JW289
JW282
Q114
JW221
JW222 JW223
JW235
C105
C133
JW199
JR381
JW227
R295
JW315 JW317 JW318
JW333
JW335
JW181
JW102 JW103 JW104
JW100
JW101
JW098
JW099
JW095 JW096 JW097
JW093
JW094
JW089 JW126
JR020
JW127
JW124
JW128
R488
JW307
JW377 JW372
C166 R133 C198
R155
R192
JW331 JW396 JW330
JW336 JW338
JW378
JW295 JW294
JW291 JW290
JW316
JR029
IC562
NO012
JW224
JW314
CN381
R149
i
JW090 JW091 JW092
JW087 JW088
JW086 JR049
JW125
JW085
JW084
JW082 JW376
JW326
R191 C192 JW272
C194
JW337 JW339
Q308
L105
R169 C165 R156 C160
JW324 JW325 C188
C193
R106 C114 R109 R119 C115
C191 C116
JW313
JW328
3
1
E CLP05
JR555
x
E
JW296
JW312
JW285 JW283
JW195 JW196
Q237
E Q151
C567
Q561
JW200
JW386
E
JW293 R244 JW292 E
JW310
JW394 JW380
R146
R116
C109 C108 C111 R108
JW358
C110
JW340 JR042
Q113
C189
R560
C288
C238
JW311
R157
C190 R193
Q101
C164
C568
BC E
JW398
JW300
JW297
JR043
JW190 C566
3 7 6 3 1 5 1 5 0
JW301
C154
JW320 JW319
C163
Q307 JR028 E
E
R167
JW369
C185
R168
R158 R166 C162
C161
C187
R194
R105
R148
E C142
C112
JW076
JW075
JW073
JW072 D396 D393 JW081
JW079
JW080
JW370
R162
R152
R153
R199 C184
C135
C159
JW275 JW374
C308
E
JW375
C158
C150
B502
D586
JW160
JW229
JW158 JW157 JW156
QQ
JW308
C153
C157
C113
R195 R118 R150
C147
Q302
JR047
C301 R301
R176
T101
C307 JW341 R311 R310
E Q301 E
R312
C302
L104
Q304
C141 R144 R145 Q112 BCE
C140
C126 C138
C148
JW284
JW390 JW189
JW044
Q560
JW384
JW309
R190 C186
C522
R532
CLP01
JR046
JW123
JR176
JW334
C585
JW364
C120 JW363 R111 R102
C130 R138
JR032 R304
C176 R175 R142 R308
R141 R140
R126 JW342
E Q125
R117
Q303 E JW346
R305
C151
C171 JW366
C534
JW171 JW170 C547 JW169 JW168
FB507
R582 JW187
JW173
26 JW172
CN351
JW121 JW122
C177
JW357 JW327
JW050
C106
R101
C195
R584 R590 C303 R302 R592 R585 E Q175 E R303 R147
R591
C139
R586 JW344 C200
JW362 JR059 C173 JW361 FB101 JW359 R113
C123 JR056
JW347
R164
R160 C168
JW110
JW323
IC101
C104
C304
C125
R593
www
E
Q153
R161
JW149 JW150 JW151
JW303 JW304 JW305
JR022 R139
R151
2
B501 JW502
C539
R581
JW198
JW306
3
1
C122
R189
JW352 JW351 Q108 E Q109 E
R587
JW345
C121 R112
JW356
8 CN131
R188
R163
E
CN111
27
1
JW118 JW119 JW120 JW129
JW148
JW068
(FOR CHECK)
C180
JW365
R159 R110 C134
C107
R143 JW343
R125 R127 C179 C178 C199 R177
R114
E
C172
C101
JW354
Q107 C124
L103
C103
C136 JW367
FB104
Q155 R122
H
1
FB151
JR055
CLP03 Q154 E Q104 E Q105 E R173 R123 E
R172
TAPE B HEAD
FB102
Q103
C170 C169
R198
JR030 JR027 C137
R103
JW049 E
E
Q106
E
JR019
JR017
NO013
JW322
R209
E Q486
JR153 JW302 JW142 JR152 JW143 JW144 R483
JR481
R207 R205
JW141
JW112 JW113 JW114 JW115 JW116 JW117
JR044
JR026
JR018 R484
R482
JR014
JW111
1 CN205
R486 5
D486 C486
JR015
R227
R231
JW133 JW130
D232
R230
JR033
R128
G
C132
CN121 FB103 1 FB152 3 C156 FB153 JW360 C118 R165 C119
Q111
JW077
JW069
JW066
D216
JR050 R215 D231
JW131
JW132 R385
R490
D230 C230
JR016
JR228
JW067
R424 JW064 JW065 JW063 JW058
R489 JW055JW056 JW057
R394 R395
JW052 JW053 C416 JW054
D214 C213 R214 R216
R412
C410
JW033
JR487
JW035 JW034
C202
C204
R497
JW083
JW107 JW108 JW109
JW179 JW178 JW177 FB512 JW174
FB509 JW175 FB510
JW209 JW208
R338
JW061 JW062
JW353
JR021
R397 R478
JW019
JR008
R491 R225
R407
JW106
JW180
JW207 JW206
R448 R447 R446 R445 R444 R443 R442 JW036
R306 R406
JW134 JW383 JW136 JW137 JW138 JW139 JW140
D101
R494
R485 JR013
CN105
JW368
JW051
Q110
Q166 R174 R124
J
R495
R476
C228
JW078
C175 C174
TAPE A HEAD
E
I
R479
D213
CLP06
R131
JR031
F
R404
R492
JW032
C214
C216 R405 R403 R402 R401 R500
R493
JW031
D215
1 3 9 4 2 2 9 6 5 1 3
R120 R129 JW046 JR012 JR011 R115 JW047 R104 R107 R121
JW048
C SMASTER BOARD CN500 (Page 45)
JW042 JW135
IC402
JW045
CLP07
T E L
JW041
R393
4 5
C215
JW176 FB508
C536
JW501 CN406
JR024 C538
C526
C546
JW105
JR048
JW500
11 (11)
Location F-3 G-3 I-4 I-4 I-4 D-2 D-2 D-2 D-2 E-3 D-2 I-3 G-6 F-5 G-2 H-2 G-2 I-3 C-5 G-8 F-9 H-4 I-4 H-4 H-4 H-4 I-4 D-7 C-11 D-10 G-11 G-12 G-12 G-12
376315150 892498299
376315150 892498299
TAPE MECHANISM DECK
R130
E
JW030
R477
TUNER PACK
A
QQ
QQ
CN101
C201
IC403
C414 3 1
JW037
Q122
JR004
R202
JW039 JW038
ECB
R220 R221 R222 R224
Q120
D102 E B C
JW043
R374
R372
Q123 E
R184
R212 R210
ECB
E
R196 R197 C145
Q118
C496
R422
D395 E
Q213
80 81
JW027 JW028 JR480 JW475
R474
C412
JR051
C498
JR006 JR005 R204 JR009 JW029 JR007 R203 C203
R182
D104 C144 R179
R178
R473
Q121
X401
IC401
C462
D394
C411 R309
100
C464
R373
R181
R180 R183
JW017 R226 JW018 E
Q119
51
JW060 JW059
JR318
50
R465
C226
D
X402
R413 R411
JW040
JR467
R419
JW074
13
13942296513
13942296513
R463 JW016
JW251
JW389
R420
R432 JW025 JW026
31 30
R450 R451
R186
C
R428
R423
12
TEL
TEL
PANEL BOARD CN1402 (Page 39)
R456 R457 R458 R460
R421
R433
R459 R461 R455 JW012 R453 JW471 JW013 R452 JW014
F
JW004 JW005 JW006 JW007
R472 JW015
JW008
B
CD BOARD CN201 (Page 31)
11
R439 R435
R337 R425
C499
JW009 R355 R354 JW010 JW011 R454 R431 R329
JW003
CN201 NO011
R437
10
CN405
JW373
R436
9
MIC BOARD NO1401 (Page 41)
B
C504
R340 D506 R440
R417
JW002 R330
1
JW020 JW022 JW021 R438 JW023 R430 R429
JW001
NO401 4
JW070 JW071
JR002 R341 JW024 R441
(FOR CHECK)
R427 R426
(FOR CHECK)
R449
CN402
JR003
MAIN BOARD
JR001
8
7
DRIVER BOARD CN701 (Page 33)
G
A
8 9 2 4 9 8 2 9 9
: Uses unleaded solder.
6
JW393
5
C554
4
JW193 JW192 JW191
• See page 25 for Circuit Boards Location.
3
2
1
JW184
QQ 3 7 6 3 1 5 1 5 0 7-10. PRINTED WIRING BOARD – MAIN BOARD –
HCD-GNX600
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
7-11. SCHEMATIC DIAGRAM – MAIN BOARD (1/3) –
CD BOARD CN201 (Page 32)
CN351 27P
R581 10k R531 10k
R582 3.3k 40
JW390 ST-R
39
ST-L R532 3.3k
38
37
36
27
C539 0.1
CN205 5P
35
26
25
D562 10EDB40 D561 10EDB40 7
C523 220p
C535 3300 10V D563 10EDB40
5
24
FB506 0uH
FB507 0uH C522 220p 23
FB508 0uH C526 0.1
22
C546 220p 19
21
82
C527 220p 3
2
C547 220p
FB509 0uH 1
28
C504 1000 10V
C534 0.1
DRIVER BOARD CN701 (Page 34)
MIC BOARD NO1401 (Page 42)
IC562 TA7804LS
JR176 0
D506 1SS355W
MIC
C537 0.1
C536 0.1
JR126 0
Q560 RT1P137P-TP-1 BD +3.3V REG
IC562 +4V REG
41
C238 10 50V R294 2.2k
R244 2.2k
NO401 4P
C567 0.1
C568 1000 6.3V
R560 2.7k
Q561 DTC114EKA B+ SWITCH
1 3 9 4 2 2 9 6 5 1 3 Q287 2SC3661 MUTING
Q237 2SC3661 MUTING
CN402 10P
(FOR CHECK)
R486 2.2k
D486 1SS355W
31 34
R246 10k
R296 10k
86 C486 470 16V
33 32 9 12
C520 10 50V
TV/SAT-L
R563 1k
R488 2.2k
C521 220p
QQ
CD-R
CD-L
R525 100k
TV/SAT-R
JR550 0
Q486 DTC114EKA HP MUTING
R574 1k
C570 10 50V
R509 4.7k
L+R_LIGHTING
I/O 24
IC551
D582 1SS355W
+9V REG
8 9 2 4 9 8 2 9 9
R
J506
R506 10
FB514 0uH
R583 3.3k
R579 3.3k
Q584 DTC114EKA BUFFER
R577 100k
0uH
Q585 2SD2525
R580 3.3k
M891 DC FAN
D581 UDZ6.2B
C581 0.1 CN580 3P
C580 0.1
Q582 2SC2412
R578 4.7k
D-LIGHT SYNC OUT
Q580 2SC2412 R267 0
C552 470 10V
C267 10 50V
C555 0.1
C583 4.7 50V
C551 1 50V
D583 UDZ6.8B
R576 47k Q580,582,585 FAN MOTOR DRIVE
D580 1SS355W
I/O 22
JW226 D594 10EDB40
J501 AUDIO IN
FB555 0
FB513
IC551 TA7809LS
ADC BOARD CN01 (Page 44)
L
R575 100k
R508 5.6k
JR267 0
C531 0.1
3 7 6 3 1 5 1 5 0 C571 220p
85
CN381 17P
FB505 0
R524 1k
C550 6800 16V
CN590 9P JW391
IC552 TA7809LS
JR261 0
IC552
C582 6800 16V
+9V REG
JW592 POWER BOARD CN1200 (Page 50)
JW385
MAIN BOARD (3/3) (Page 38)
C556 0.1
JR555 0
C553 1 50V EP501
MAIN BOARD (2/3) (Page 37)
HCD-GNX600
36
36 http://www.xiaoyu163.com
.
EVER+4V
D+4V GND
a o y u 1 6 3 FAN DET
i
F
x
M+9V BD MGND
.
FL+4V
100
E D+3.3V G
GND AUDIO+9V FRONT-R FRONT-L B A VRSW CD MUTE
www
C554 470 10V
c o
m
376315150 892498299
376315150 892498299
T E L
R295 47k
R245 47k
29 30
C566 1 50V
QQ
QQ
(FOR CHECK)
D586 10EDB40
C288 10 50V
13942296513
13942296513
49 48 47 46 45 44 43 42
TEL
TEL
CN405 13P
C538 0.1
FB512 0uH
FB510 0uH
CN406 9P
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 • See page 25 for Waveforms.
7-12. SCHEMATIC DIAGRAM – MAIN BOARD (2/3) –
HCD-GNX600
8 9 2 4 9 8 2 9 9
• See page 57 for IC Pin Function Description
R182 3.3k
Q121 DTC114EKA
I/O 18
5 R406 100
R407 100
C410 22p X401 32.768kHz
R183 3.3k
R413 0
R184 3.3k
R417 10k
D102 1SS355W
JR318 0
R181 680
R411 330k
R430 R429 R428 R427 R426 R425 R424 R423 R422 R421 R420 R419
100 100 100 100 100 100 100 100 100 100 1k 100
Q120,121 CAP MOTOR DRIVE
C412 0.1 C411 22p
R306 4.7k
C416 3300 6.3V
100 100 100 100 100
I/O 19
R412 100k
Q120 2SB1132-T100-QR
3 2 1
9
7
R309 10k
R330 10k
C414 0.1
R405 R404 R403 R402 R401
Q119 DTC114EKA
X402 5MHz
R329 10k
R179 2.2k
R180 2.2k
12
30 29 28 27 26 25 24 23 22 21 20 19
R178 Q118 680 2SB1132-T100-QR
C144 0.0047
D104 1SS355W
4
Q118,119 B TRIG DRIVE
C499 0.1
C498 0.1
Q122 2SB1132-T100-QR R197 680
C145 0.0047
R196 2.2k
R186 2.2k
Q123 DTC114EKA
CN101 11P R104 47k
R337 10k R338 10k R340 10k R341 10k
38 39 40 41 42 43 44 45 46 47 48 49
R107 4.7k R120 4.7k
R115 10k
R435 R436 R437 R438 R439 R440 R441 R442 R443 R444 R445 R446 R447 R448 R449
91 90
R121 3.3k
100 100 100 100 100 100 100 100 100 100 100 100 100 100 100
100
R493 IC401 M30622MGP-A22FPU0
91 90 89
R491 100 R490 100 R489 100
IC401
*2 R393 *1
R492 0
R497 220
97
R397 3.3k
R495 220
95
R395 3.3k R394 3.3k D230 1SS355W
R494 220
680 1K 4.7K
JR487 0
R484 R483
100 100
84 83
82
79
100 100 100 100
R472 100 R473 100 R474 100
R374 10k R476 R477 R478 R479
R372 10k R373 10k
R463 100
R355 10k
78 77 76
JR480 0
JW475 0
I/O 9 I/O 10 I/O 12
R205 100 R207 100
C203 100p C202 0.01
R209 100
20
12
I/O 12
I/O 9 I/O 10
I/O 7
I/O 5
D
R203 100
R210 100
C204 100p
34D
R204 100
D396 1SS355W
D395 1SS355W
76 77 78 79
72
63
C464 0.1
R202 100
DBFB FEEDBACK VACSIN GND VP
R215 1k D214 1SS355W
R212 100
D215 1SS355W
IC402 IC PST3629NR
C201 100p
IC402 LEVEL DETECT
IC403 BH2210FV
R216 220
D216 1SS355W
C216 0.1
IC403 SIGNAL IN/OUT CONTROL
Q213 DTC124EKA RESET SWITCH
HCD-GNX600
37 37 http://www.xiaoyu163.com
C215 10 50V
FAN DET
m C214 0.1
D+4V
c o
C213 0.1
EVER+4V
.
GND
a o y u 1 6 3 MAIN BOARD (1/3) (Page 36)
D213 1SS355W
I/O 22 I/O 21 I/O 20 I/O 19 I/O 18 I/O 17
R222 100 I/O 24
C226 100p
F
i
G
D+3.3V
x
BD MGND M+9V
FL+4V
.
R226 100
R214 0
E
R224 100 C228 100p
R221 100 R220 100
JR228 0
www
SMASTER BOARD(1/2) CN500 (Page 47)
65 72
D394 1SS355W
73 74 JW471 0
59 60 61
R354 10k
R465 100
100 100 100 100 100 180 100 100 100 100 100 R451 R452 R453 R454 R455 R456 R457 R458 R459 R460 R461 51
50
C462 100 10V
59 60 73 74 61
C230 2.2 50V
D393 1SS355W
65
PANEL BOARD CN1402 (Page 40)
53 54 55
50 51
CN105 19P
8 9 2 4 9 8 2 9 9
JR381 0
JR467 0
JW135
94 95 97 4
3 7 6 3 1 5 1 5 0
R231 47k
D232 1SS355W
MAIN BOARD (3/3) (Page 38)
376315150 892498299
376315150 892498299
CN201 25P
R482 100
R230 100 R227 0
R225 33k
QQ
1 3 9 4 2 2 9 6 5 1 3 53 54 55
86 85
R385 10k
QQ
QQ
T E L
63 89
330 E3 1.5K AUS 4.7K E2,E51,AR
D231 1SS355W
R450 100
R129 4.7k
AR E2,E51 E3,AUS
R485 100
R128 22k
R130 47k R131 3.3k
94
*2 R493
*1 R393
SYSTEM CONTROL
13942296513
13942296513
I/O 17
R431 100 R432 100 R433 100
31 32 33 34 35 36 37
Q122,123 A TRIG DRIVE
TEL
TEL
D101 1SS355W
C496 10 50V
R500 100
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
7-13. SCHEMATIC DIAGRAM – MAIN BOARD (3/3)– • See page 25 for Waveforms.
C198 2.2 50V
FB153 0
C123 220p
R126 4.7k
R176 4.7k
C178 0.01
L103 27mH
R127 5.6k
C124 120p
C200 0.0022 C125 330p
R147 33
C585 0.1
R142 10k
C119 10 50V
R101 180
R592 100k R586 5.6k
R593 100k Q113 RT1P137P-TP-1 SWITCH
C140 47 35V
www
R118 15k
C103 10 50V
C195 1 50V
L105 100uH Q301,302 TC REC MUTING Q301 DTA124EKA
R149 4.7k
C302 2.2 50V
.
x
R303 100k
C304 2.2 50V
R302 22k
i
Q303,304 TC MUTING
Q307 DTA124EKA
Q304 DTC114EKA C303 2.2 50V
C301 2.2 50V
R146 10
Q303 DTA124EKA
Q302 DTC114EKA R301 10k
Q114 DTC114EKA SWITCH
C161 0.033
C158 0.027
R195 1M
R150 47k
R117 2.2k
C148 2.2 50V
C113 10 50V
R304 15k
C308 2.2 50V
R305 68k
R116 10k
R108 2.2k
C116 4.7 50V
Q101 2SC2412 SWITCH
R105 47k
C194 10 50V C187 100 10V C188 0.1
C112 0.0047
A+4.5V
Q307,308 CD MUTING
R310 15k R312 470k R311 68k
a o y u 1 6 3
HCD-GNX600
38
CD MUTE
8 9 2 4 9 8 2 9 9
Q308 DTC114EKA C307 2.2 50V
R308 470k
C191 0.18
C192 1 50V
83 84
C111 0.033 C109 0.027
C110 10 50V
I/O 7
C139 0.01
R144 47 C141 0.01 C142 0.0068
R138 47k
C104 10 50V
R189 0
R194 4.7k
R106 5.6k R109 18k
R584 5.6k
I/O 21
C138 0.0047
C101 10 50V
R191 470
R119 470
C114 0.68
Q125 2SC3661 REC MUTING
C179 0.01
R145 10k
C115 0.56
R111 1k
R192 470 C189 220p
C193 0.18
C121 1 50V
C147 0.0047
R587 10k
R193 4.7k
C122 10 50V
Q103 2SC3661 MUTING
R113 10k
R585 10k
I/O 20
T101
R103 10k
C166 4.7 50V
3 7 6 3 1 5 1 5 0
C135 100p R110 330k C120 R102 0.01 2.2k
C130 0.0056
TC-L
Q175 2SC3661 REC MUTING
R148 47k R143 3.3k
QQ
C134 100p
R112 10k
Q109 DTC114EKA BUFFER
R591 10k
Q112 2SD596T1 BIAS OSC
C190 220p
ST-L
R590 C199 10k 0.0022
C175 330p
C176 0.001
C136 100 16V
R169 470
C165 0.56
R160 330k C185 100p
C118 470p
Q108 DTC114EKA SWITCH DRIVE
R177 5.6k
C174 120p
R125 27k C126 0.001
R140 10k
R122 2.2k
C171 1 R153 50V 10k
R133 1M C133 1 50V
R156 5.6k
C164 0.68
C132 100 16V
R123 2.2k
L104 27mH
R175 27k
R141 10k
R173 2.2k
Q105 2SC3661 SWITCH Q104 2SC3661 SWITCH
R114 0
C168 C170 R152 470p R151 0.01 2.2k 180
R155 47k
Q151 2SC2412 SWITCH
38 http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
R172 2.2k
Q155 2SC3661 SWITCH
R164 0
C172 10 50V
1 3 9 4 2 2 9 6 5 1 3
Q154 2SC3661 SWITCH
R157 18k
C184 100p
Q111 DTC114EKA SWITCHI DRIVE
C163 10 50V
QQ
QQ
FB104 0uH
C169 10 50V
R199 0uH
Q107 2SA812 SWITCH DRIVE
FB151 0
T E L
R124 2.2k
Q106 2SC3661 MUTING
R162 10k
C162 0.0047
34D
FB102 0uH
C137 470 16V
IC101 INPUT SELECT SWITCH, PB/REC EQUALIZER AMP, GRAPHIC EQUALIZER CONTROL, ELECTRICAL VOLUME
TV/SAT-L
C173 220p
R159 0uH
R168 15k
R190 10k
R139 0
C151 10 50V
I/O 5
CN131 8P
Q110 DTA114EKA MUTING SWITCH
C186 0.068
IC101 M61537FP-RFOG
R166 10k
C108 0.027
Q166 2SC3661 MUTING R174 2.2k
C154 10 50V
R158 2.2k C159 0.027
C180 0.0056 R161 1k
FB101 0
C177 0.47
C153 10 50V
TC-R
R165 0uH
C156 680p
FB152 0uH
R188 47k
R167 2.2k
C157 0.1
R198 0uH
C105 10 50V
C150 10 50V
C107 0.1
C106 680p
FB103 0
R200 47k
13942296513
13942296513
CN121 3P
C160 10 50V
TEL
TEL
R163 10k
C197 0.0047
Q153 2SC3661 MUTING
VRSW FRONT-L
B A FRONT-R L+R_LIGHTING
TC-R
MIC
TC-L
ST-R CD-R TV/SAT-R
(FOR CHECK)
CD-L
CN111 3P
MAIN BOARD (1/3) (Page 36)
VP VACSIN DBFB FEEDBACK D
GND
MAIN BOARD (2/3) (Page 37)
GND AUDIO+9V
HCD-GNX600
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 7-14. PRINTED WIRING BOARDS – PANEL SECTION – 3
2
1
• See page 25 for Circuit Boards Location. 4
PANEL BOARD
10
JW1368
JW1347 JW1348 C1301
VOL BOARD NO1402 (Page 41)
D1304
C1357
JW1300 JW1329
JW1345
R1330
S1300 DISPLAY
S1322 TUNER/ BAND
3 7 6 3 1 5 1 5 0
R1305
D1302
R1301
D1305
T1300 JW1308
S1321
S1309 TAPE A/B
I PD-PANEL-01_HCDGNX600etc.eps
CN1403 3
1
C1308
R1306
S1326
JW1301
ILLUMINATION/ SUB WOOFER LEVEL
IR BOARD
S1310 X
R1331
ALBUM + M
S1307 TV
IC1301 1
3
11 1-868-934- (11)
S1317 x
S1325 S1320
ALBUM M
F
DIRECTION
R1325
1-868-830-
www
.
x
i
a o y u 1 6 3
HCD-GNX600
39 39 http://www.xiaoyu163.com
.
c o
m
11 (11)
Location
D1300 D1301 D1302 D1303 D1304 D1305 D1306 D1313 D1314
D-7 D-7 D-7 D-7 A-10 D-7 B-10 B-10 B-4
IC1300 IC1301
B-5 E-7
Q1300 Q1303 Q1304 Q1305 Q1306 Q1307 Q1308 Q1309 Q1310 Q1311 Q1312 Q1313 Q1314 Q1315 Q1316
C-8 C-5 C-6 C-6 C-6 D-6 C-5 B-10 C-5 B-8 B-7 B-7 B-7 B-6 A-6
8 9 2 4 9 8 2 9 9
R1303
D1300
Ref. No.
JW1307
R1304 JW1350 JW1353
D1301
L1300 D1303
Q1300 1 5 2 3 R1300 JW1349
B
JW1371
R1356
C1316
JW1346
JW1378 Q1306 E C1300 Q1305 JW1366 JW1367 JW1364 C1302 E Q1307 JW1365
• Semiconductor Location
R1317
S1311
CD
JW1309
R1332
JW1370
R1327 R1326
S1323
JW1305 JW1306
Q1304
QQ
CN1452
R1313
JW1304
JW1380 JW1379
C1304
JW1374 JW1375 JW1384 JW1377 JW1376
JW1372
SUB WOOFER ON/OFF
R1311 Q1309
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
JW1358 JW1361 JW1362
S1302
JW1303
E
1
C1306
R1345 Q1308 Q1310 E E JW1363
S1327 REC PAUSE START
D1313
JW1334 JW1335
JW1360 JW1359 JW1357
R1346
B C E
E
R1328
D1306
QQ
QQ
S1312 DISC SKIP EX-CHANGE
S1324 CD SYNC JW1369
F
R1314
R1347 R1348
JW1352
S1313 DISC 3
Q1303 E C B
Q1311
R1308 JW1322
CN1453
JW1383 JW1392 JW1395 JW1393 JW1394
Q1312
3
R1321 JW1388
C
JW1351
R1322
S1314 DISC 2
E
Q1314 Q1313 E E
Q1315 E
S1301
JW1302
13942296513
13942296513
JW1354 JW1355 JW1356 JW1390 JW1391
C1310 R1307 52 1 R1353 C1314 C1315 R1355
14 13
R1302
JW1387
JW1386
CN1402
E
9
TEL
TEL
R1323
R1352
IC1300
JW1342
C1305
R1324
C1312 C1313 R1351
D1314
B
JW1344 JW1343
S1315 DISC 2
39 40
R1361 JW1331 JW1333
C1307
27 26
C1311
JR1305 R1318 R1320 R1319
8
7
C1317 JW1310 C1318 JW1320 JW1311 C1319 JW1336 R1360 JW1312 C1320 JW1313 C1321 JW1382 JW1337 R1359 JW1314 C1322 JW1315 C1323 JW1316 C1324 JW1338 JW1317 C1325 JW1318 C1326 R1358 JW1321 C1327 JW1339 R1357 JW1319 C1328 JW1340 JW1323 C1329 JW1324 C1330 JW1341 JW1328 C1331 C1309 JW1330
FL1300 FLUORESCENT Q1316 JW1381 INDICATOR TUBE E
Z OPEN/CLOSE
T E L
6
1
S1316
D
8 9 2 4 9 8 2 9 9
: Uses unleaded solder.
5
A
MAIN BOARD CN201 (Page 35)
HCD-GNX600
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
7-15. SCHEMATIC DIAGRAM – PANEL SECTION –
L1300 47uH R1300 3.3k IC1301 RPM7240-H9 C1300 22 50V
IC1301 REMOTE CONTROL RECEIVER
T1300 (DC/DC CONVERTER)
Q1300(1/2) CPH5504 OSC 1
D1305 RD6.2FM
C1302 0.01 C1304 220 50V
D1301 1SS355WTE-17
R1301 22k R1302 22k
D1302 1SS355WTE-17
C1301 0.022
5
D1300 1SS355WTE-17
4 3
C1306 0.01
FL1300 FLUORESCENT DISPLAY TUBE
R1305 2.2k 1W
R1304 100 R1303 100
D1303 1SS355WTE-17 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29
2
C1357 0.1
CN1403 3P
CN1453 3P
C1309 47 16V
D1306 R1314 1SS355WTE-17 0
R1313 270 D1313 SELU5420E-STP15
C1305 10 50V
C1311 10 16V C1310 100p
CN1402 25P JR1305 0
MAIN BOARD(2/3) CN201 (Page 37)
R1351 100 R1352 100
S1301 I/
R1355 100
DISPLAY CONTROL
33
34 35 36
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
C1314 0.001
R1361 4.7k
C1315 0.001
D1304 SELU5223C-STP15 I/
JW1322
R1308 1k
JW1300
Q1303 2SB1132-P LED DRIVER
R1311 2.2k
Q1311 DTC143TKA FL DRIVER
R1348 1k
SUB WOOFER ON/OFF
45
Q1310 DTC114EKA LED CONTROL
Q1308 DTC114EKA LED DRIVER
R1347 470
S1302 CN1452 11P
R1346 1k
46
48 R1345 100
Q1304 2SB1132-P LED DRIVER
R1324 330
S1315
S1316
Q1312 DTC143TKA FL DRIVER R1323 470
www
R1332 680
.
x
DIRECTION
a o y u 1 6 3
Q1306 DTC123JKA-T146 LED DRIVER
i
HCD-GNX600
40
40 http://www.xiaoyu163.com
R1318 4.7k
S1310
S1309
.
S1322
S1323
ILLUMINATION/ SUB WOOFER LEVEL R1328 1k
S1324
R1330 330
R1331 470
S1321
S1320
Q1307 DTC123JKA-T146 LED DRIVER
R1319 2.2k
DISC SKIP EX-CHANGE
LED2 LED1
Q1305 DTC123JKA-T146 LED DRIVER
S1311
S1312
S1313
S1314
R1320 1.5k
R1321 1k
R1322 680
Q1315 DTC143TKA FL DRIVER
Q1314 DTC143TKA FL DRIVER
Q1313 DTC143TKA FL DRIVER
OPEN/CLOSE
VOL BOARD NO1402 (Page 42)
R1360 4.7k
R1359 4.7k
R1358 4.7k
R1357 4.7k
R1356 4.7k
44
43 42 41 40 39 38 37
S1300
QQ
IC1300
R1307 4.7k
Q1316 DTC143TKA FL DRIVER
c o
S1327
R1327 680
S1326
R1326 470
m
S1325
R1325 330
S1317
R1317 10k
S1307
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
C1312 0.001
47
QQ
T E L
C1313 0.001
R1353 100
IC1300 NJU3427FA2
QQ
22 23 24 25 26 27 28 29
D1314 1SS355WTE-17
13942296513
13942296513
Q1309 DTC123JKA-T146 LED DRIVER
SUB WOOFER ON/OFF
10 11 12 13 14 15 16 17 18 19 20 21
C1308 0.001
C1316 C1317 C1318 C1319 C1320 C1321 C1322 C1323 C1324 C1325 C1326 C1327 C1328 C1329 C1330 C1331
100p 100p 100p 100p 100p 100p 100p 100p 100p 100p 100p 100p 100p 100p 100p 100p
C1307 0.1
TEL
TEL
R1306 47
33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48
Q1300(2/2) CPH5504 OSC
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 7-16. PRINTED WIRING BOARDS – MIC, VOL and SPEAKER BOARDS – 3
2
1
8 9 2 4 9 8 2 9 9
• See page 25 for Circuit Boards Location.
4
5
6
: Uses unleaded solder.
8
7
J1450 MIC 2
J1400 MIC 1
A
HCD-GNX600
RV1400 MIC 1 LEVEL
RV1401 MIC 2 LEVEL
9
10
11
RV1402 ECHO LEVEL
C1405 JW1413 JW1415 R1425
C1415
Q1451
NO1401
1
5 R1441
1
M
S1318
JW1396 C1334
JW1431
JW1399 JW1427
PL1700
JW1530
CN1600
JW1500
JW1520 C1532
• Semiconductor Location
S1328
EP1500
EP1501
11 1-869-011- (11)
PRESET EQ
D1307 (LED 1)
x
Ref. No. C1522
C1512
C1612
TM1500 +
.
JW1510
C1502
1-868-832-
www
2
C1602
R1365 R1366 R1367
R1364 R1362
D1310 (LED 6) R1371 R1372 R1373
SMASTER BOARD NO680 (Page 45)
SMASTER BOARD NO580 (Page 45)
JW1521
LP1701
S1306 > OPERATION DIAL >
R1363
D1308 (LED 2)
R1336 R1337 R1334
S1305 MASTER VOLUME
R1374 R1375 R1376
S1331 GROOVE
G
JW1398
JW1610
R1333 R1335
JW1397
PL1300
L
PL1500
1
JR1301
F
8 9 2 4 9 8 2 9 9 CN1500
D1309 (LED 3)
EQ BAND/MEMORY
D1311 (LED 5)
SMASTER BOARD CN503 (Page 45)
JR1302
D1312 (LED 4)
JW1600
JR1300
SPEAKER BOARD
R1368 R1369 R1370
S1319 MP3 BOOSTER
11 (11)
3 7 6 3 1 5 1 5 0
JW1389
R1377
R1379
R1329
R1378
NO1402 11
J
1-868-831-
i
11 (11)
-
+
-
SUB WOOFER
HCD-GNX600
41 41 http://www.xiaoyu163.com
.
c o
Location
D1307 D1308 D1309 D1310 D1311 D1312 D1400
G-3 F-4 E-3 G-2 F-2 E-2 B-6
IC1400 IC1401
C-4 C-5
Q1400 Q1401 Q1450 Q1451
C-8 C-8 C-8 C-8
+
-
L
a o y u 1 6 3
376315150 892498299
376315150 892498299
VOL BOARD
E
QQ B
1 3 9 4 2 2 9 6 5 1 3 I
MAIN BOARD CN205 (Page 35)
E
QQ
QQ
T E L
PANEL BOARD CN1452 (Page 39)
Q1401
C1424 R1436 C1437 JW1439 C1436 C1486 JR1483 NO1404 R1435 JR1433 R1485 1 3 R1483 R1482
PL1400
D
R1443 R1442
E
R1486
JW1440 JW1423
EPT1400
PL1402
Q1400
JR1403
R1492
E
R1422
JW1412 C1404
C1479
Q1450
EPT1403
R1433 R1432 R1434
C1468 R1476
E
C1487
R1440
JW1418 JW1419 JW1420 JW1421
JW1424
R1477
IC1401
JW1438 JW1425
R1493
R1484
JW1432
C1459
C1429 R1427 R1426 JW1417 C1433 C1418 R1439 JW1400 R1431 C1434 R1437
R1424
C1435
R1412 R1415 C1427
R1414 JR1427 C1419
R1406
C1430
JW1414
C1460
JW1410
R1438 C1413 R1413
JW1409
C1416
30
C1406
16
C1412
IC1400
C1458
JW1402
1
15
R1457
JW1429
C1401
C1403
R1405 JW1416
13942296513
13942296513
C1409
R1407
R1409
JW1437
C
C1461
C1410 JW1401
R1410 C1411
EPT1402
JW1404
JW1411
R1401
TEL
TEL
R1411
R1418
JW1407 JW1408
R1461 R1460 R1459
R1404
D1400
C1408
MIC BOARD
R1403
R1416
JW1405
JR1417 JW1403
C1400
B
R1417 C1407 R1402
JW1430
J1401 PHONES
R FRONT SPEAKER
m
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0 R1417 10k
R1418 1k C1407 47 16V
C1406 47 16V C1409 1 50V
R1461 10k
R1416 10k
RV1400 50k MIC 1 LEVEL
RV1402 50k ECHO LEVEL
S1331
RV1401 50k
R1403 100
JR1417 0
MIC 2 LEVEL
R1401 4.7k
R1402 100
R1336 4.7k
S1328
R1335 2.2k
R1334 1.5k PL1300
C1408 4.7 50V
R1337 10k
S1318 S1305
TEL
PANEL BOARD CN1452 (Page 40)
MASTER VOLUME
D1307 SELU5223C-STP15
IC1400
C1461 0.01
R1363 1k
DIGITAL ECHO
R1366 1k
J1400
R1372 1k
R1405 330
R1413 6.8k C1427 1 0.5%
R1457 1.5k
D1310 SELU5223C-STP15
QQ
C1419 0.0047
1 3 9 4 2 2 9 6 5 1 3
R1410 1k
R1411 10k
C1459 1 50V
R1414 12k
R1438 0
R1415 15k
JR1427 0
D1311 SELU5223C-STP15
R1367 1k R1368 1k R1370 1k R1371 1k R1373 1k R1374 1k
3 7 6 3 1 5 1 5 0 R1375 1k
D1312 SELU5223C-STP15
R1378 1k
8 9 2 4 9 8 2 9 9
R1376 1k R1377 1k
R1379 1k R1431 0
C1416 22 50V
IC1401
IC1401(1/2) NJM4565M-D
R1439 2.2k
MIC AMP
R1424 0
IC1401(2/2) NJM4565M-D
R1425 10k R1426 C1418 56k 390p
R1427 22k
R1477 15k
C1429 0.1 50V
C1468 0.001
C1430 0.1 50V
C1435 220 10V
C1479 4.7 50V
R1476 22k
C1434 10 50V
R1434 10
C1437 0.01
EPT1402
R1436 4.7k
R1422 0
Q1401 2SC3661 MUTING
C1424 0.1
EPT1403
JW1510
C1487 0.01
R1442 1k
.
x
JR1483 0
i
R1485 10
JW1530
C1522 1000p
FRONT SPEAKER L
C1532 1000p
R1493 1k Q1450 2SC3661 MUTING
EP1500 SMASTER BOARD(1/2) CN503 (Page 47)
a o y u 1 6 3 R1484 10
C1512 1000p
NO1404 3P
R1492 1k Q1451 2SC3661 MUTING
R
JW1520
R1443 1k JR1401 0
R1486 4.7k
C1502 1000p
JW1500
SMASTER BOARD(2/2) NO580 (Page 48)
R1432 10
J1401
www
C1612 1000p
SMASTER BOARD(2/2) NO680 (Page 48)
R1433 10 Q1400 2SC3661 MUTING
TM1500 SUB WOOFER
JW1610
C1436 0.0047 R1435 10
C1602 1000p
JW1600
CN1600 2P
CN1500 4P
JR1433 0
EPT1400
MAIN BOARD(1/3) CN205 (Page 36)
R1437 100k C1433 47p
R1440 2.7k
C1401 0.1
C1415 0.1
NO1401 5P
R1441 0
JW1400
R1482 10
R1483 10
C1486 0.0047
HCD-GNX600
42
42 http://www.xiaoyu163.com
.
EP1501
c o
m
376315150 892498299
376315150 892498299
T E L
R1412 3.9k
C1460 1 50V
R1369 1k
R1406 330
R1365 1k
QQ
QQ
C1411 0.01
D1309 SELU5223C-STP15
C1413 0.0012
R1362 1k R1364 1k
D1308 SELU5223C-STP15 C1458 4.7 50V
13942296513
13942296513
IC1400 TC9488FG
JR1302 0
TEL
C1403 68p
R1404 100
R1459 10k
R1409 10k
NO1402 11P
R1333 1k
C1334 0.1
D1400 UDZSTE-175.1B
JR1301 0
J1450
R1329 1.5k
C1404 47 35V
C1405 0.01
C1412 0.1
C1400 0.1
S1319
S1306
R1407 1.5k
C1410 1 50V
R1460 1k
8 9 2 4 9 8 2 9 9
• See page 51 for IC Block Diagrams.
7-17. SCHEMATIC DIAGRAM – MIC, VOL and SPEAKER BOARDS –
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 7-18. PRINTED WIRING BOARD – ADC BOARD –
• See page 25 for Circuit Boards Location.
8 9 2 4 9 8 2 9 9
: Uses unleaded solder.
3
2
1
HCD-GNX600
H ADC BOARD (SIDE A)
4
5
SMASTER BOARD CN501 (Page 45)
EP02
C32
R57
LP01
C62
C81
C61
JR21
C41
C93 R59
C66 C63
R32
C70
C65
C64
D52
C60
C22
B
C59
C56
C67
R58
13942296513
CN01
QQ
1 3 9 4 2 2 9 6 5 1 3
ADC BOARD (SIDE B)
D
3 7 6 3 1 5 1 5 0
MAIN BOARD CN381 (Page 35)
8 9 2 4 9 8 2 9 9
1-868-834- 11 (11)
C L0 1
1 R25
JR51
.
R36
x
C54
R63
R60
C68
IC12
IC11
a o y u 1 6 3
R55
i
R65
www
IC03
R50
C28 C29
R31
R52
E R29
C26 R38
R41
D
Q08 R53
L02
3 FL01
R28
Q07
L03
R40
1 C23
E R27
IC02
IC01
FL02
3
JR52
HCD-GNX600
43 43 http://www.xiaoyu163.com
.
c o
m
1-868-834- 11 (11)
• Semiconductor Location Ref. No.
376315150 892498299
376315150 892498299
T E L
QQ
QQ
C20
X001
13942296513
D51
C58
C55
C27
C24
R67 R64 C51
C90
C57
C50
D12 C40 D11 C42
1
10
D61
C53
TEL
TEL
C25
D14
NO05
D13
C91
EP01
A
Location
D11 D12 D13 D14 D51 D52 D61
A-2 A-2 A-1 A-1 B-3 B-2 B-4
IC01 IC02 IC03 IC11 IC12
C-2 D-1 D-2 D-2 D-4
Q07 Q08
C-2 D-3
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
7-19. SCHEMATIC DIAGRAM – ADC BOARD –
8 9 2 4 9 8 2 9 9
• See page 53 for IC Block Diagrams.
JR21 0
CN01 17P
D61 C93 1SS355TE-17 1000p C63 10 50V C64 0.1 C65 10 50V C67 100 C66 0.1 10V
R63 100
C70 1 50V
C41 0.1
R25 2.2k R27 100k
C32 0.01
EP02
R65 0 R28 1k
Q07 2SC5938 MUTING
IC12 PCM1803DBR
R29 2.2k
IC12
R32 1k
Q08 2SC5938 MUTING
A/D CONVERTER
NO05 10P R57 0 R58 0 R59 0
IC01 uPC2905T-E1
IC01
1 3 9 4 2 2 9 6 5 1 3 C20 0.1 50V
C22 100 10V
QQ
C60 1 50V
IC02
C59 1 50V
+3.3V REG C24 100 10V
C40 0.1
C25 0.01
D14 1SS355TE-17
R40 1k
R38 0
D13 1SS355TE-17
R41 1M
EP1
C55 C56 C57 C58
C90 0.001
C28 10p
X001 12.288MHz
IC03 TC7WU04F (TE12R)
D51 1SS355TE-17
R52 100
C91 0.001
C29 10p
8 9 2 4 9 8 2 9 9
D52 1SS355TE-17
R53 100
C23 0.1
C61 0.1
3 7 6 3 1 5 1 5 0
IC02 uPC2933T-E2
L01 1uH
C62 10 50V
10 50V 0.1 10 50V 0.1
C54 0.1
C53 100 10V
R55 0
IC11 PCM1803DBR
IC11 A/D CONVERTER
IC03 CLOCK GENERATOR
C51 10 50V
R36 0
www
JR52 0
C26 0.1
.
x
C27 4.7 50V
i
JR51 56
a o y u 1 6 3 L02 FL01 0uH 10uH
HCD-GNX600
44
44 http://www.xiaoyu163.com
C50 0.1
.
R50 0
m
R64 0
c o
SMASTER BOARD(1/2) CN501 (Page 47)
C42 0.1
D11 1SS355TE-17 D12 1SS355TE-17
376315150 892498299
376315150 892498299
T E L
L03 10uH
R67 0
QQ
QQ
FL02 0uH
+15V REG
R60 0
13942296513
13942296513
R31 100k
C68 0.1
TEL
TEL
MAIN BOARD(1/3) CN381 (Page 36)
C81 0.01
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 7-20. PRINTED WIRING BOARD – SMASTER BOARD (SIDE A) –
• See page 25 for Circuit Boards Location.
3
2
1
L
SMASTER BOARD (SIDE A)
8 9 2 4 9 8 2 9 9
: Uses unleaded solder.
4
SPEAKER BOARD CN1500 (Page 41)
HCD-GNX600
5
6
SPEAKER BOARD CN1600 (Page 41)
M
8
7
A
C549
R841
R840
R691
R591
R583
C668
CN502
C580
L581
C538
C565
D553
L691
C545
D533
D554
QQ
C665
C658
D653
D534
POWER BOARD CN1101 (Page 49)
C690
C694
1 3 9 4 2 2 9 6 5 1 3
C558
K
L690
C584
L590
L591
C879
Q840
C692
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9 C886
D654
EP886
R662
R668
C653
R884
C881
C892
1 C805
R612 10
R602
CN501
C883
.
R892
FB881
x
1
3
J
CN503
i
MIC BOARD NO1404 (Page 41)
a o y u 1 6 3 C
MAIN BOARD CN105 (Page 35)
45 45 http://www.xiaoyu163.com
. H
3
1
R510 R886
R811
C611
C607
5 4 IC810
C609
C604
C509
C606
C612
L802
C610
C810
R512 CN500
Ref. No.
EP882
C651 R650
C608
R502 C887
C891
www R895
C889
C655
C667
D881
R530
R669
C656
C533
C512 C511
C507 C510
L801
R894
C888
R667
R548
R549
R547
C547
C531
C535
C504
C802
D883 D882 C872
C804
C800
HCD-GNX600
R542
C508
C506
F
R550
C551
C803
EP881
C536
C553
C890
E
C567
• Semiconductor Location
C811 C871 D880
C555
R562
R568
C556
R569
R567
D
376315150 892498299
376315150 892498299
D896
C548
C587
R865 R860 R866 R861 R867 R862
QQ
QQ
T E L D895
C592
C590
C594
C
C586
13942296513
13942296513
R820
C569
C876 R822
C593
C691 C693
EP884
E
D820
R823
R821
R855 R852
1
2
C830
TEL
TEL
B
R868
R859
C591 C585
D890 C568
1
4
NO680
R851
L580
D891
EP885
R856
C669
NO580
C840
R858 R857 R850
c o
ADC BOARD NO05 (Page 43)
m
EP880
1-868-959-
11 (11)
Location
D533 D534 D553 D554 D653 D654 D820 D880 D881 D882 D883 D890 D891 D895 D896
D-2 D-3 D-1 D-2 D-4 D-4 B-1 E-8 E-8 E-1 E-1 B-1 B-1 D-1 D-1
IC810
E-8
Q840
B-6
http://www.xiaoyu163.com
8 9 2 4 9 8 2 9 9
: Uses unleaded solder.
5
6
R581 C583 C582
Q856 C855
Q850
Q865
Q851
C695
Q855
LP801
E E
E E C850
E E
C877 D889 D888
Q866
C865
C697 C696 R693
SMASTER BOARD (SIDE B)
A
8
7
C597
C581
C595
LP800
R593
QQ 3 7 6 3 1 5 1 5 0
7-21. PRINTED WIRING BOARD – SMASTER BOARD (SIDE B) – • See page 25 for Circuit Boards Location. 3 4 2 1
C596
HCD-GNX600
TEL
TEL
B
13942296513
13942296513
www
.
x
R553 R552
R893
C882
HCD-GNX600
46 http://www.xiaoyu163.com
c o
R888
R887
IC880
C884 R883
m
R891 R889
C880
R885
R880
C505
R503 R505 R506 R507
FL800 R511 R509 R881
X800
R890
R523
C521
R524
R526
R529
R516 R517 R519 R520 R521 R500 R501
IC500
.
Ref. No. D535 D536 D555 D556 D655 D656 D884 D885 D888 D889 D892 D893
C520
C557
C513
a o y u 1 6 3 46
D555
D556
C523
C524 R559
IC550
R882
i
• Semiconductor Location
C576
C522 C532 R551 C552 C534 R531 C554 C527 C526 R558 R541 C525 R561 C529 R535 FB801 R555 R802 R801 R515 R800 FB800 4 3 L800 5 1 C801 IC800
C878
D893
C605
R609 R610
C564
C537
8 9 2 4 9 8 2 9 9
C577
R533
C528
R655
IC530
R532
C579 C621 R560
R661
D535
D536
C578
C620
C544
R657
R653
R652
R624
R623
C626
C575 C574
IC600
R603 R605 R606 R607
R617 R616
R807
R806 R805 R804
E
R809
C613
4
R615
R619 R620 R621 R600 R601
C809
5
FL810
1 3
FL801
C806
IC802
C657
C652 R651 C654
C629 D885 D884
C873
C622 R658
IC650
D892
D
C623
C664
3 7 6 3 1 5 1 5 0
D655
C677 C676
R557
QQ
D656
1 3 9 4 2 2 9 6 5 1 3
11 1-868-959- (11) C885
Location C-7 C-6 C-8 C-7 C-5 C-4 D-1 D-1 A-1 A-1 E-5 E-5
IC500 IC530 IC550 IC600 IC650 IC800 IC802 IC880
E-7 D-6 D-7 E-5 D-5 E-7 E-3 E-8
Q850 Q851 Q855 Q856 Q865 Q866
A-6 A-6 A-6 A-6 A-6 A-5
376315150 892498299
376315150 892498299
T E L
QQ
QQ
C
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
• See page 53 for IC Block Diagrams.
R804 0
DATA_2
R805 0 R806 0 R807 0
LRCK_1 BCK_1 DATA_1
ADC BOARD NO05 (Page 44)
SCDT SCSHIFT SCLATCH_2
NSPMUTE SOFTMUTE
R612 10k
R619 1k R620 1k R621 1k
SCDT SCSHIFT SCLATCH_2
C612 0.1 C613 0.1
OVF(SW)
OVF INIT FL801 0uH
INVERTER C809 0.1
R809 0
INIT
LRCK_1 BCK_1 DATA_2
IC600 CXD9843AR
R605 470 R606 470 R607 470
LRCK_2 BCK_2 DATA_2
R624 0
IC600
2
C605 0.1 L802 0
R609 0
C610 0.1
C604 0.1 SCDT SCSHIFT SCLATCH_1
C878 0.1 D892 1SS355TE D893 1SS355TE
1 3 9 4 2 2 9 6 5 1 3
NSPMUTE SOFTMUTE SCDT SCSHIFT SCLATCH_1
INIT
C606 0.1
QQ
R516 R517 R519 R520 R521
NSPMUTE SOFTMUTE SCDT SCSHIFT SCLATCH_1
C607 0.1
C608 0.1
3 7 6 3 1 5 1 5 0
100 100 1k 1k 1k
8 9 2 4 9 8 2 9 9
R512 10k
R515 0
C810 100 10V
C513 0.1 C512 0.1
IC810 NJM2870F18
OVF
IC810
OVF
C811 0.01
R501 0
C504 0.1 R811 100k
INIT C805 100 10V
FL810 0uH
LRCK_1 BCK_1 DATA_1
INIT
IC B/D
R500 0
R502 10k
+1.8V REG
R529 0
R503 100 R505 470 R506 470 R507 470
LRCK_1 BCK_1 DATA_1
IC500 CXD9843AR
D882 0
D883 0
C883 470 10V
C882 100p
C889 C888 100 0.1 16V
XFSIIN R880 22k
R882 22k R883 22k
C509 100 10V
C881 100p
R884 22k
IC880 NJM4580V R895 22k
IC880 C892 100p
R892 0 C887 470 10V
.
R891 33k
x
C885 100p
R894 2.2k
R889 22k R890 22k
i
C891 0.1
FB800 0
L800 0
FL800 0uH
a o y u 1 6 3 R887 22k
C884 100p
DBFB F/B
R888 22k
HCD-GNX600
47 47 http://www.xiaoyu163.com
.
IC800
C507 0.1
c o
C506 0.1
m
C803 0.001
OSC
C508 0.1
R511 0
C890 100 16V
HP AMP FB881 0
R510 0
R893 2.7k
IC800 MC74VHC1GU04DFT1
C510 0.1
R881 22k
R886 0
www
6
C511 0.1
R509 0
C880 100p
EP881
MIC BOARD NO1404 (Page 42)
5
R523 0
STREAM PROCESSOR C505 0.1
R885 33k
CN503 3P
4
R524 0
IC500
C806 0.01 C872 0
3
R526 0
C800 22 25V
R800 1M C801 0.01
R801 100
C804 10p
L801 1uH
X800 49.152MHz
C802 5p 7
FB801 0
R802 0
9 8
SMASTER BOARD (2/2) (Page48)
376315150 892498299
376315150 892498299
OVF /RST /SD /OTW NSPMUTE SOFTMUTE
T E L
C609 100 10V
R610 0
QQ
QQ
MAIN BOARD(2/3) CN105 (Page 37)
R623 0
C611 0.1
XFSIIN
OVF(SW) SCLATCH_2 FAN DET DBFB F/B
1
STREAM PROCESSOR
CN500 19P
13942296513
13942296513
XFSIIN
EP884
R603 100
TEL
TEL
IC802
R602 10k
EP882
IC B/D
R601 0
OVF
EP880
R615 0
R600 0
IC802 MC74VHC1GU04DFT1
C877 0 D888 0 D889 0
CN501 10P
BUS1
R616 100 R617 100
C873 0 D884 0 D885 0
NSPMUTE SOFTMUTE
C871 0 D880 0 D881 0
7-22. SCHEMATIC DIAGRAM – SMASTER BOARD (1/2) –
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
7-23. SCHEMATIC DIAGRAM – SMASTER BOARD (2/2) –
NC680 2P
FAN DET C830 10 50V
R857 100k
C855 R856 10 100k
Q856 2SA1602 DC DETECT
R868 47k
R855 100k
C693 0.0022
C696 0.0022
R850 100k
C695 0.22
C591 0.22
C595 0.22
C580 1
C584 1
C590 1 63V
C594 1 63V
D891 0
C677 1
IC650 CXD9879M
C578 0.001
D654 P6SMB62AT3
C621 0.001
R668 1.5
C664 0.1
C620 0.001
R657 4.7
D655 EC10UA20
C667 0.033
R658 4.7
D656 EC10UA20
C622 0.001
D653 P6SMB62AT3
1 3 9 4 2 2 9 6 5 1 3 R667 1.5
C656 0.033
C579 0.001
C547 0.033
C657 0.1
R560 4.7
C544 0.1
R548 1.5
C538 120 63V C574 1
R547 1.5
QQ C525 0.001
C537 0.1
IC530 CXD9879M
C524 0.001
R559 4.7
C565 120 63V
POWER BOARD CN1101 (Page 50)
C558 120 63V
3 7 6 3 1 5 1 5 0 C577 1
C522 0.001
R558 4.7
C523 0.001 C567 0.033
C536 0.033 IC550 CXD9879M
IC650
IC530
IC550
POWER DRIVER
POWER DRIVER
POWER DRIVER
R568 1.5
8 9 2 4 9 8 2 9 9
C576 1
C557 0.1 R557 C521 4.7 0.001
C564 0.1
C520 0.001
R820 22k
C556 0.033
R567 1.5
/SD Q840 2SC1623 PROTECT DETECT
BUS1
.
i
SMASTER BOARD (1/2) (Page 47)
HCD-GNX600
48
48 http://www.xiaoyu163.com
C553 22 25V
R562 10
C555 0.1
C552 0.1 C526 470p
R561 10
R555 33k
R551 100 R552 1k R553 100
R569 3.3
.
m 8 9
7
c o 5
R542 10
a o y u 1 6 3 4
x
C551 0.1
C529 0.001
R549 3.3
3
www
R550 10
6
C528 0.001
C629 0.001
C527 470p
R541 10
C531 0.1
C535 0.1 C532 0.1
R535 33k
R530 10
C554 0.1
C533 22 25V
100 1k 100
C655 0.1 R662 10
R531 R532 R533
R661 10
R669 3.3
2
/OTW /SD /RST
C652 0.1 C626 470p
C653 22 25V
1
EP886
C651 0.1
R651 100 R652 1k R653 100
R650 10
C534 0.1
C654 0.1
R655 33k
C879 0 D895 0 D896 0
CN502 6P
C886 470 16V
C569 2200 63V
C568 0.1 100V
D535 EC10UA20
C545 120 63V C575 1
D533 P6SMB62AT3
C658 120 63V C676 1
R821 1.5k
D820 1SS355TE-17
C549 2200 63V
C548 0.1
L591 10uH
L590 10uH
376315150 892498299
376315150 892498299
C623 0.001
C665 120 63V
C669 2200 63V
R823 22k
EP885 C876 0
L581 10uH
L580 10uH
R822 22k
QQ
QQ
T E L
R840 100k
C585 0.22
D536 EC10UA20 D534 P6SMB62AT3
C668 0.1
C840 2.2 16V
C581 0.22
D890 0 L691 10uH
L690 10uH
Q865 2SA1602 DC DETECT
C597 0.0022
C586 0.0022
Q851 2SA1602 DC DETECT
Q866 2SA1602 DC DETECT
C593 0.0022
SPEAKER BOARD CN1500 (Page 42)
C596 0.0022
R591 R593 2.7 2.7
C583 0.0022
Q850 2SA1602 DC DETECT
C694 1
C592 0.0022
R581 R583 C587 2.7 0.0022 2.7
13942296513
13942296513
C690 1
C582 0.0022
TEL
TEL
C691 0.22
R841 0
R851 100k
C850 10
D555 EC10UA20
R865 100k
C697 0.0022
R691 R693 2.7 2.7
D553 P6SMB62AT3
C692 0.0022
D554 P6SMB62AT3
R866 100k
R852 100k
D556 EC10UA20
C865 10
NO580 4P
Q855 2SA1602 DC DETECT
R867 100k
SPEAKER BOARD CN1600 (Page 42)
R859 47k
R858 47k
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 7-24. PRINTED WIRING BOARD – POWER BOARD – 2
1
• See page 25 for Circuit Boards Location.
3
4
HCD-GNX600
8 9 2 4 9 8 2 9 9
: Uses unleaded solder.
5
6
8
7
POWER BOARD
9
10
EP1105
C1149
A
L1102
D1116 R1136
JW1129
R1135
JW1145
R1118
JR1107
R1140 R1126 R1145
D1110
C1148
• Semiconductor Location
JW1139
JW1106
JR1101
R1225
R1226 S JW1132
EP1200
JW1131
S Q1206
i
HCD-GNX600
49 49 http://www.xiaoyu163.com
R1144
JW1184
CN1101 JW1120
1
C1221
c o
MAIN BOARD CN590 (Page 35)
R1231
7
m
CN1200
.
SMASTER BOARD CN502 (Page 45)
E
R1223
a o y u 1 6 3
K
C1139
JW1134
PC1102
x
C1137
EP1106
JW1146
IC1201
JW1135
C1219
R1217
E Q1203
R1227
JW1142
R1218 C1212 K E C A
R1131
R1130 E R1229 Q1205 Q1204
R1224
JW1122 JW1121
C1136
R1129
JW1130
R1220
JW1143
A K
L1201 C1216
R1219
C1214
C E
R1216
R1221
C1210 D1202
PC1200
D1212 JW1144
EP1104
JW1123
E
R1230 C1217
D1213
R1128 D1115
C1218
L1200
R1232
C1213
JW1173
E
C1222
JW1147
IC1200
JW1136 R1228
R1139
JW1124
C1135
Q1101
Q1100
D1206
Ref. No. D1100 D1101 D1102 D1103 D1106 D1107 D1108 D1109 D1110 D1111 D1112 D1113 D1114 D1115 D1116 D1117 D1118 D1119 D1120 D1122 D1200 D1202 D1203 D1204 D1205 D1206 D1207 D1208 D1211 D1212 D1213 D1214 D1215
8 9 2 4 9 8 2 9 9 C1138
D1215
EP1103
JW1125
JW1127
L1100
JW1185
T1200 SUB POWER TRANSFORMER
JW1137
JW1138
D1200
C1200
JW1133
JW1156
JW1101
JW1104
JR1103
C111 5
C1209
R1138
JW1128
3 7 6 3 1 5 1 5 0
D1211
FH1101
F1100
QQ
R1215
1
JW1126
C1121
D1208 R1208 R1207
R1214
C1126
R1132 C1129 R1133
R1201
JW1148
D1214
C1202
D1203
C1203
R1203
AC IN
.
JW1161
D1204
R1212 R1211 C1208 C1207 R1209 JW1159 R1210
R1137 2
R1113
JW1158
R1120
VD1100
C1101
JW1162
R1200
JW1157
FH1100
C1134
C1125
T1100 MAIN POWER TRANSFORMER
D1205
C1206
JW1111
JW1112
JW1110
JW1109
EP1100
D1118
(EXCEPT AUS)
JW1163
www
D1109 C1122 R1115 R1114
C1112 JW1160
JW1166 JW1165
(AUS)
G
JW1141 JW1140
JW1152 D1101
0 11 C1
JW1164
CNP1100
C1140
1-868-958-
11 (11)
Location C-2 C-3 C-2 A-4 B-4 A-5 B-6 B-6 B-6 B-6 B-6 A-7 A-8 E-8 A-6 C-9 E-4 D-5 B-7 A-6 E-5 F-5 F-4 D-4 D-4 E-5 E-4 E-4 F-4 F-6 F-7 D-5 F-8
376315150 892498299
376315150 892498299
Q1200 E
R1202 D1207
F
C1127 C1124
QQ
QQ
R1234 R1233
C1109 JW1178
R1 10 0
JR1106 R1123
R1103
1 3 9 4 2 2 9 6 5 1 3
LF1100
1
5
C1123
R1124
JR1105
D1119
(EXCEPT AUS)
R1122
2
4
D1117
C1107
LF1101
IC1102
D1114
13942296513
13942296513
JW1170 JW1169
C1118
TH1100
JW1168 JW1167
E
R1117 A C D1120 E K PC1101 R1146 R1121
JW1149
D1102
D1100
T E L
D1108
D1113
IC1101 C1116 C1130
C1117
C
D
R1142
R1109
(E2, E3, E51)
EP1102
JW1150
C1120
R1106
120V
R1110
R1108
D1106
D1112
C1119
C1147
TEL
TEL
SW1100 VOLTAGE SELECTOR 220-240V
2
4
JW1155
B
1
JW1154
(E2, E3, E51)
3
5 6
A
K
R1105
JW1179
C1113
JW1103 JW1100
7
JW1176
IC1100
D1103
E D1122 Q1102 R1141 R1112 PC1100 R1111 R1116 D1111 A C E K
D1107
(AR,AUS)
JW1151
EP1101
C1131 R1127
IC1100 IC1101 IC1102 IC1200 IC1201
A-5 B-7 A-5 E-4 G-6
Q1100 Q1101 Q1102 Q1200 Q1203 Q1204 Q1205 Q1206
E-8 E-8 A-5 D-4 F-8 F-8 E-8 G-8
http://www.xiaoyu163.com
HCD-GNX600
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
7-25. SCHEMATIC DIAGRAM – POWER BOARD –
C1101 0.22 275V
JW1112
TH1100
JW1111 LF1100
LF1101 C1107 0.22 275V
AUS
C1110 330p 125V
VOLTAGE SELECTOR
EP1102
* C1112
120V
D1100 D5SBA60F01
390/450V AR,AUS 680/220V E2,E3,E51
220-240V
* AR,AUS
C1113 680 220V
IC1100 MR5060
D1106 EG01CV1
R1108 0.33 1W
D1214 MTZJ-4.7C
D1108 MTZJ-T-72-22D R1111 R1112 47k 27k
D1107 MTZJ-T-72-22D C1119 0.1
C1123 0.01 D1113 630V FCH20A20
R1105 100k 3W
R1116 0
D1122 HRU0103ATRF
D1109 MTZJ-T-72-22D
Q1102 2SC2713 SWITCH
R1126 R1127 47k 0
QQ
C1148 0.0027
D1115 UDZSTE-17 Q1100 5.1B 2SC2713 MAIN ON/OFF SWITCHI
EP1103
R1117 3.3k 0.5%
VOLTAGE DET
C1138 C1139 0.1 470 16V
R1135 0
R1132 10k
C1140 0.1
R1144 10k
R1139 10k
R1128 1.8k 0.5%
C1134 820 25V
D1116 RK36LF-B3
R1131 10k
D1117 MTZJ-72-22D-T
R1136 0
L1102 100uH
C1129 0.1
C1219 0.1
3 7 6 3 1 5 1 5 0 Q1101 2SC2713 MAIN ON/OFF SWITCHI
C1218 0.1
D1215 MTZJ-T-72-22D
R1138 470k
R1137 470k
C1212 330p 125V
R1203 10
PC1102 TLP421F(D4-GR)
R1223 10k
D1202 D1NL20U-TR
IC1200 MR1722
R1201 2.2 1/2W R1200 100k 2W
R1202 33k
PRIMARY SWITCHING, MAIN CONVERTER
D1203 MTZJ-T-72-22D
R1233 10k
D1204 D1NL20U-TR
www
R1208 12k C1206 47p
D1206 MTZJ-T-72-22D
D1207 D1NL20U-TR2
R1209 2.2k
x R1234 47k
.
D1205 MTZJ-T-72-22D
D1208 UDZSTE-1711B R1212 10k R1211 1k
C1209 100 25V C1210 22 50V
R1217 47k
T1200 SUB POWER TRANSFORMER
C1213 470 10V
IC1201 TA76L431S
R1216 220
VOLTAGE DET
a o y u 1 6 3
HCD-GNX600
50
50 http://www.xiaoyu163.com
.
R1231 330 1W
R1227 100k R1228 330
R1225 100
R1219 2.2k 0.5% C1222 10 50V
R1224 68k
Q1204 2SC2713 +4V REG
Q1205 2SC2713 +8V REG
EP1200
R1215 1k
C1207 1000p
Q1203 RSR25P03 +4V REG
R1226 1M
R1220 220 0.5%
R1221 3.9k 0.5%
PC1200 TLP421F(D4-GR)
i
C1214 0.1
R1218 6.8k 0.5%
C1216 2200 16V
D1211 R1214 1 D1NL20U-TR2
C1208 0.0068
R1210 15k Q1200 2SC2713 SWITCH
D1213 RK36LF-B3
JR1108 0
R1207 4.7k
C1203 0.1
L1200 10uH
JW1173
D1200 ERA22-08KF
C1202 100p 2kV
L1201
D1212 SF5S6
C1200 3300p 500V
Q1206 RSR25P03 +8V REG
c o
m
R1229 10k R1232 10k
C1221 470 16V
C1217 0.1
R1230 1k
R1141 6.8k
CN1200 7P
8 9 2 4 9 8 2 9 9
R1133 10k
PC1101 TLP421F(D4-GR)
R1115 4.7k
C1149 33 25V
SMASTER BOARD(2/2) CN502 (Page 48)
MAIN BOARD(1/3) CN590 (Page 36)
376315150 892498299
376315150 892498299
R1114 22k C1122 0.0033
CN1101 6P
+12V REG
IC1101 TA76L431S
R1140 1k
1 3 9 4 2 2 9 6 5 1 3 C1121 220 35V
R1129 6.8k 0.5%
C1135 C1136 C1137 0.1 470 470 100V 63V 63V
IC1102 SI-8120JF
QQ
QQ
D1110 D1NL20U-TR2
R1124 56k 0.5%
C1131 470p
D1120 UDZSTE-17 5.1B
JR1103 0
PC1100 TLP421F(D4-GR)
R1130 6.8k 0.5%
C1147 22 63V
R1146 6.8k 0.5%
JR1105 0
D1111 UDZSTE-1716B
C1120 68p
C1127 1200 35V
C1116 10
R1142 47k
D1118 10EDB60-TA2B5
C1126 1200 63V
D1112 D1NL20U-TR2
C1130 0.0022
R1123 3.9k 0.5%
JW1184
R1145 100
R1113 D1119 4.7 D1NL20U-TR2
R1122 2.2k 0.5%
R1121 6.8k 0.5%
D1114 SF20NC15M
C1124 C1125 0.1 1200 63V 100V
R1110 15k
T E L
JW1101
13942296513
13942296513
R1109 0.05 5W
L1100 10uH JR1101 0
D1103 SARS03 (TO-220)
JW1179
JW1106
R1118 1 2W
TEL
TEL
R1106 100k 3W
POWER SWITCHING CONVERTER
JW1104
T1100 C1117 MAIN POWER TRANSFORMER 0.0033 400V
E2,E3,E51
C1118 820p
C1115 220p 125V JW1185
D1101 R1103 R4KLB-LF015-303 0.1 1W D1102 R4KLB-LF015-303
C1112
JW1109 JW1110 EXCEPT AUS
JW1178
E2,E3,E51
SW1100
JW1103
R1120 3.3M CNP1100 1/2W 2P
C1109 330p 125V
JW1100
AC IN
VD1100
F1100 T6.3AL/250V
EXCEPT AUS
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 • IC Block Diagrams – DRIVER Board –
IC701, 712 BA6956AN
TSD
RNF
OUT1
6
7
8
9 RIN
OUT2
5
GND
4
FIN
3
VCC
2
VM
1 VREF
CONTROL LOGIC
– MIC Board – TEL
VSS
POOUT
TEST
NC
VOLST
DA OUT
NC
ADIN
PRIN
MCO
VSA
NC
ALC1
MC2N
MC2P
29
28
27
26
25
24
23
22
21
20
19
18
17
16
VREF
13942296513
ALC VREF VREF POST LPF
ADPCM ENCODE
11
12
13
ALC1
NC
NC
10
9
VDA
8
VREF
7
VRO
6
VOL3 (SDA)
VOL1 (CS)
ALC
VOL2 (SCL)
5
NC
4
OSCR
OSCC
VDD
3
376315150 892498299
14
15
– CD Board –
50k
Pre Vcc
100k
PIN3
F
R
CH3OUTR
CH3OUTF
CH4OUTF
CH4OUTR
22
POWVCC
23
MUTE
24
GND
25 10k
GND
CH3RIN
26
CH3FIN
27
CH4IN
OUTVREF
28
CH4CAPA
DPOUT
IC251 BA5947FM-E2
21
20
19
18
17
16
15
50k
R
POW
D
D
D
D
VCC 50k (ch3, 4)
MUTE
INTER FACE F
INTER FACE F
50k
50k
50k
LEVEL SHIFT 6.5k Vref PIN26
POW VCC (ch1, 2)
D
D
D
D
8
9
10
11
12
13
14
CH2OUTR
CH2OUTF
CH1OUTR
CH1OUTF
7
POWVCC
6
CNF4
xiaoy u163. com 5
GND
CH1FIN
.
50k
R
GND
SW
4
CH2RIN
3
POW VCC
F INTER FACE R F
CH2FIN
2
Vref
CH1RIN
www 1
F
R
SW
19k
10k POW VCC
OPIN+
376315150 892498299
2
VREF
VREF
VOLUME CONTROL
OSC 1
QQ 376315150 892498299
ADC
MC1P
DELAY DRAM
QQ
QQ
TEL 13942296513 ADPCM DECODE
MC1N
S/H
DAC
PREVCC
13942296513
30
OPIN-
TEL
IC1400 TC9488FG
51 http://www.xiaoyu163.com
52
53
54
55
56
57
58
59
60
61
62
63
64
VSS
VDD
CKO/PO13/AD16
VDDX
XO
XI
VSSX
TEST
MIMD
VSSP
VCOI
PO07/AD7 46 Bus Switch
PO05/AD5 48
VC0
Instruction Decoder
AD9 44
AD10 43 MCU. I/F
MZ ALU A3
AY
round & limit
A2
AX
QQ 376315150 892498299 A1
round & limit
MAC
MY
52
http://www.xiaoyu163.com Audio I/F
DIT
Sub code I/F
1Mbit SRAM
PIO4/FI1/BUS0/IO4 PIO3/IO3
PIO1/SDI3/IO1 PIO0/SDI2/IO0 VSS CKI/CLOCK/IRQ/FIO
VDD TXO SFSY/LRCKIB SBSY/BCKIB SDI1/DATA
PIO2/IO2
PIO5/FI2/BUS1/IO5
26
A0
MX
Y-Bus
X-Bus
C-Pointer register
SRAM I/F
27
Program Control
VDDM 40 Y-Pointer register
PO11/BUCK/AD14 36
register XO • X1 • X2 Y0 • Y1 • Y2
X-Pointer register
PO08/AD11 39
CROM 4k word
TEL 13942296513
CRAM 4k word
28
PRAM
POM
SRMSTB 41 ERAM 2k word
PIO6/FI3/BUS2/IO7
29 25 24 23 22 21 20 19 18 17
CS/RAS/SDO2 33
14 SDI0
13 LRCKO
12 BCKO
11 SDO0
10 VSS
9 VDDT
8 MIACK
VDDT 42 7 MICK
6 MIDIO
5 MILP
AD8 45
4 MICS
3 STANBY
PO06/AD6 47
2 RESET
Timing Generator
1 VDDP
376315150 892498299
xiaoy u163. com
51
AD0/PO00
YRAM 4k word
PIO7/BUS3/IO7
30
QQ
XRAM 4k word
WE/SDO1
31
13942296513
376315150 892498299
.
50
AD1/PO01
PO10/CCE/AD13 37 Address Calc. 2sets
General In/Output Port
32
TEL
QQ
49
AD2/PO02
13942296513
www SRAM/ DRAM I/F
SDO3/OE 35
AD3/PO03
TEL
PO9/AD12 38 CDP Cont I/F
AD15/CAS/PD12 34
AD4/PO04
HCD-GNX600 http://www.xiaoyu163.com
– CD Board –
IC301 TC94A34FG-002
QQ 376315150 892498299 16 LRCKIA
15 BCKIA
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 – ADC Board –
IC11,12 PCM1803DBR
DELTA-SIGMA MODULATOR
L IN 1
20 MODE 1
R IN 2
x1/64, x1/128 DECIMATION FILTER WITH HIGH-PASS FILTER
V_REF_1 3 REFERENCE
V_REF_2 4
MODE/ FORMAT CONTROL
19 MODE 0 18 FMT 1 17 FMT 0
SERIAL INTERFACE
DELTA-SIGMA MODULATOR
16 TEST
VCC 5 POWER SUPPLY
15 SCKI
CLOCK AND TIMING CONTROL
AGND 6
TEL
12 DOUT
BYPASS 8
13942296513
LRCK 10
– SMASTER Board –
QQ
INIT
SFLAG
LRCK
MCKSEL
BCK
DATA
BFVSS
BFVDD
TEST
XFSIIN
DVDD
376315150 892498299
36 35 34 33 32 31 30 29 28 27 26 25
SAMPLING RATE CONVERTER
FSOCKO 37 FSOI 38
CLOCK GENERATOR (PRIMARY CLOCK SYSTTEM)
HPOUTR2 39
S
P
DF1
DF2
HPVSSR 40 HPOUTR1 41 HPVDDR 42
PWM
∆ ∑ CONVERTER
HPOUTL2 43
LINER INTERPOLATOR
GAIN CONTROL
FILTER & LOW CUT FILTER
HPVSSL 44 24 OVF FLAGR
HPOUTL1 45
23 SCLATCH
HPVDDL 46
SERIAL CONTROL
XVDD 47
22 SCSHIFT 21 SCDT
XFSOIN 48
20 PGMUTE CLOCK GENERATOR (SECONDARY CLOCK SYSTEM)
INIT/MUTE
19 SOFTMUTE 18 NSPMUTE 17 DVSS 16 DVDD 15 XOVDD 14 XFSOOUT
.
5
6
7
8
9 10 11 12
VSSL
OUTL2
4
VSSR
3
VDDR
2
OUTR1
VDDL
xiaoy u163. com OUTL1 VSSL
www
1
VSSR
13 XOVSS
OUTR2
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
XVSS
QQ
IC500,600 CXD9843AR
VSUBC
13942296513
11 BCK
FSYNC 9
OVF FLAGL
TEL
14 VDD 13 DGND
PDWN 7
53 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
7-26. IC Pin Function Descriptions
• IC101 CXD3059AR (RF AMP,DSP,DAC) (CD BOARD) Pin No.
Pin Name
I/O
Description
1
MIRR
I/O
Not used (Open)
2
DFCT
I/O
Not used (Open)
3
FOK
I/O
Not used (Open)
4
VSS
–
Ground terminal
5
LOCK
I/O
Not used (Open)
6
MDP
O
Spindle motor servo control signal output
I
Disc innermost detection signal input
IOVSS1
–
Ground terminal
9
SFDR
O
Sled drive signal output
10
SRDR
O
Sled drive signal output
O
Tracking drive signal output
O
Tracking drive signal output
13
FFDR
O
Focus drive signal output
14
FRDR
O
Focus drive signal output
15
IOVDD1
–
Power supply terminal (+3.3V)
16
AVDD0
–
Power supply terminal (+3.3V)
17
AVSS0
–
Ground terminal
18
NC
–
Not used (Open)
19
E
I
E signal input
QQ
20
F
I
F signal input
TEI
I
Tracking error signal input
22
TEO
O
Tracking error signal output
23
FEI
I
Focus error signal input
24
FEO
O
Focus error signal output
25
VC
O
Center voltage output from RF amplifier block
26
A
I
A signal input
27
B
I
B signal input
28
C
I
C signal input
29
D
I
D signal input
376315150 892498299
TEL 13942296513
30
NC
–
Not used (Open)
31
AVDD4
–
Power supply terminal (+3.3V)
32
RFDCO
O
RFDC signal output (Open)
33
PDSENS
I
Reference voltage terminal
34
AC_SUM
O
RFAC summing amplifier signal output
35
EG_IN
I
Equalizer circuit signal input
36
LD
O
APC LD drive signal output
37
PD
I
APC PD signal input
38
NC
–
Not used (Open)
39
RFC
I
Equalizer cut-off frequency adjustment terminal
40
AVSS4
–
Ground terminal
41
RFACO
O
RFAC signal output
42
RFACI
www
43
AVDD3
44
BIAS
45
ASYI
46
ASYO
47
VPCO
48
VCTL
.
I
RFAC signal input or EFM signal input
–
Power supply terminal (+3.3V)
I
Asymmetry circuit constant current input
I
Asymmetry comparator voltage input
O
EFM full-swing signal output
xiaoy u163. com O
Not used (Open)
I
Wide-band EFM PLL VCO2 control voltage input
54 http://www.xiaoyu163.com
376315150 892498299
QQ 376315150 892498299
21
QQ
TFDR TRDR
13942296513
11 12
TEL
SSTP
8
13942296513
TEL
7
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 Pin No.
Pin Name
I/O
Description
49
AVSS3
–
Ground terminal
50
CLTV
I
Multiplier VCO1 control voltage input
51
FILO
O
Master PLL (slave = digital PLL) filter signal output
52
FILI
I
Master PLL filter signal input
53
PCO
O
Master PLL charge pump signal output
–
Power supply terminal (+3.3V)
DDVROUT
O
DC/DC converter output (+2.5V)
56
DDVRSEN
I
DC/DC converter output voltage monitor signal input
57
AVSS5
–
Ground terminal
58
DDCR
I
DC/DC converter reset signal input
59
NC
–
Not used (Open)
60
BCKI
I
D/A interface bit clock input
61
PCMDI
I
D/A interface serial data input
62
LRCKl
I
D/A interface LR clock input
63
LRCK
O
D/A interface LR clock output f = Fs
VSS
–
Ground terminal
65
PCMD
O
D/A interface serial data output
66
BCK
O
D/A interface bit clock output
67
VDD
–
Power supply terminal (+2.5V)
68
EMPH
O
High when the playback disc has emphasis, low it has not
69
EMPHI
I
High when de-emphasis is ON, low when input OFF
70
IOVDD2
–
Power supply terminal (+3.3V)
QQ 376315150 892498299
71
DOUT
O
Digital Out signal output
72
TEST
I
Test terminal (Connected to ground)
73
TEST1
I
Test terminal (Connected to ground)
74
IOVSS2
–
Ground terminal
75
NC
–
Not used (Open)
76
XVSS
–
Ground terminal
77
XTAO
O
Crystal oscillation circuit signal output
78
XTAI
I
Crystal oscillation circuit signal input
79
XVDD
–
Power supply terminal (+2.5V)
80
AVDD1
–
Power supply terminal (+3.3V)
81
AOUT1
O
L-ch analog signal output
82
VREFL
O
L-ch reference voltage output
83
AVSS1
–
Ground terminal
84
AVSS2
–
Ground terminal
85
VREFR
O
R-ch reference voltage output
86
AOUT2
O
R-ch analog signal output
87
AVDD2
–
Power supply terminal (+3.3V)
88
NC
–
Not used (Open)
89
IOVDD0
–
Power supply terminal (+3.3V)
90
RMUT
O
Not used (Open)
91
LMUT
O
Not used (Open)
92
NC
–
Not used (Open)
93
XTSL
I
Crystal selection signal input (Pull down)
94
IOVSS0
–
Ground terminal
95
XTACN
I
Oscillation circuit control signal input (“H”: self-oscillation, “L”: oscillation stop)
SQSO
O
Not used (Open)
SQCK
I
SQSO readout clock input (Connected to +VDD(+3.3V))
SBSO
O
Not used (Open)
www 96 97 98
.
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
64
13942296513
13942296513
AVDD5
55
TEL
TEL
54
xiaoy u163. com
55 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 I/O
Description
99
EXCK
I
Not used (Open)
100
XRST
I
System reset signal input from M30622MEP
101
SYSM
I
Muting signal input (Connected to ground)
102
DATA
I
Serial data input from M30622MEP
103
VSS
–
Ground terminal
104
XLAT
I
Latch signal input from M30622MEP
105
CLOCK
I
Serial data transfer clock input from M30622MEP
106
VDD
–
Power supply terminal (+2.5V)
107
SENS
O
SENS output to M30622MEP
108
SCLK
I
SENS serial data readout clock input (Connected to +VDD(+3.3v))
109
ATSK
I/O
Not used (Open)
110
WFCK
O
Not used (Open)
TEL
Pin Name
TEL
Pin No.
O
Not used (Open)
XPCK
O
Not used (Open)
113
GFS
O
Not used (Open)
114
C2PO
O
Not used (Open)
115
SCOR
O
High output when the sub code sync, S0 or S1, is detected
116
VDD
–
Power supply terminal (+2.5V)
117
C4M
O
Not used (Open)
118
WDCK
O
Not used (Open)
119
COUT
I/O
Not used (Open)
120
NC
–
Not used (Open)
www
.
QQ 376315150 892498299
xiaoy u163. com
56 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
XUGF
13942296513
13942296513
111 112
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 • IC401 M30622MGP-A22FPU0 SYSTEM CONTROL (MAIN BOARD) Pin No.
Pin Name
I/O
Description
1
BD-RST
O
Reset signal output to the digital signal processor ( “L”:reset)
2
CD-DATA-OUT
O
Serial data output to the digital signal processor
3
XLAT
O
Serial data latch pulse output to the digital signal processor
4
SIRCS
I
Remote control signal input
5
MP3-DATA-OUT
O
Serial data output signal to MP3 decoder IC
6
MP3-DATA-IN
I
Serial data input signal from MP3 decoder IC
7
MP3-CLK
O
Serial data transfer clock signal to MP3 decoder IC
8
BYTE
-
Ground terminal
9
CNVSS
-
Ground terminal
XC-IN
I
Sub system clock input terminal (32.768kHz)
11
XC-OUT
O
Sub system clock output terminal (32.768kHz)
12
RESET
I
System reset signal input from the reset signal IC (“L”: reset) After the power supply
X-OUT
O
Main system clock output terminal (5MHz)
rises, “L” is input for several hundreds msec and then change to “H”.
SCOR
I
Subcode sync (S0+S1) detection signal input from the digital signal processor
QQ
20
AC-CUT
I
“C off detection signal input from the reset signal IC (“L”: AC cut detected)
VSS
-
Ground terminal
15
X-IN
I
Main system clock input terminal (5MHz)
16
VCC
-
Power supply terminal (+3.3V)
17
NMI
I
Non-maskable interrupt input terminal (Pull to +3.3V)
18
NO-USE
I
Unused port (Pull to ground)
QQ 376315150 892498299
21
SENS
I
Internal status detection monitor input from the digital signal processor
22
MP3-RST
O
Reset signal output to MP3 decoder IC
23
MP3-CS
O
Chip select output signal to MP3 decoder IC (“L”:enable)
24
MP3-LP
O
Latch output signal to MP3 decoder IC (“L”:enable)
25
MP3-ACK
I
Acknowledgement input signal from MP3 decoder IC (“L”:acknowledged)
26
MP3-REQ
I
Request signal from MP3 decoder IC
27
MP3-STB
O
Standby mode signal output to MP3 decoder IC (“L”:standby mode)
28
XTACN
O
29
IIC-CLK
I/O
Clock signal for IIC communcation between the microcomputer and the IIC checker
30
IIC-DATA
I/O
Data signal for IIC communcation between the microcomputer and the IIC checker
31
VMUTE
O
CDG video signal muting on/off control signal output (“H”: muting on)
32
CDG-DET
I
CDG disc detection signal input from CDG decoder (“H”: CDG disc detected)
BD DSP oscillation on/off control signal output (“H”:on)
33
CDG-RST
O
Reset signal output to the CDG decoder (“L”:reset)
34
CD-MUTE
O
CD analog signal muting on/off control signal output (“H”:muting on)
35
CD-POWER
O
Power on/off control signal output to BU section (“H”:power on)
36
ST-CE
O
PLL chip enable signal output to the tuner unit
37
ST-DOUT/MC-DIN
I
PLL serial data input from the tuner unit
38
ST-CLK
O
PLL serial data transfer clock signal output to the tuner unit
39
ST-DIN/MC-DOUT
O
PLL serial data output to the tuner unit
40
TUNED
I
Tuning detection signal input from the tuner unit (“L”:tuned)
41
OPEN-SW
I
Eject detection signal input from the CD mechanism deck
42
TBL-SENSE
I
Disc tray position detection signal input from the CD mechanism deck
43
E-3
I
Disc tray status detection signal input from the CD mechanism deck
44
E-2
I
Disc tray status detection signal input from the CD mechanism deck
www 45 46 47
.
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
19
14
13942296513
13942296513
13
xiaoy u163. com
E-1
I
Disc tray status detection signal input from the CD mechanism deck
TM-F
O
Turning motor control signal output to the CD mechanism deck
TM-R
O
Turning motor control signal output to the CD mechanism deck
57 http://www.xiaoyu163.com
TEL
TEL
10
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 Pin No.
Pin Name
I/O
Description
48
LM-F
O
Loading motor control signal output to the CD mechanism deck
49
LM-R
O
Loading motor control signal output to the CD mechanism deck
50
LED-ILLUMINATION-1
O
Dynamic LED drive signal output to the ILLUMINATION 1st indicator and 2nd
indicator 51
LED-ILLUMINATION-2
O
Dynamic LED drive signal output to the ILLUMINATION 3rd indicator and 4th
52
LED-ILLUMINATION-3
O
53
LED-CTRL
O
Dynamic LED drive select signal output
54
VOL-A
I
Jog dial pulse input from the VOLUME rotary encoder (A phase input)
indicator Dynamic LED drive signal output to the ILLUMINATION 5th indicator and 6h indicator
Jog dial pulse input from the VOLUME rotary encoder (B phase input)
O
LED drive signal output of POWER indicator (“H”:LED is turned on)
57
FL-DRIVER-DATA
O
Serial data output signal to FL Driver, NJU3427
58
FL-DRIVER-CLK
O
Serial data clock signal to FL Driver, NJU3427
59
FL-DRIVER-RESET
O
Serial data reset signal to FL Driver, NJU3427
60
FL-DRIVER-CS
O
Serial data chip select signal to FL Driver, NJU3427
SW-LED
O
LED drive signal output of SUB WOOFER ON indicator (“H”:LED on)
67
NO-USE
I
Unused port (Pull to ground)
IO-EXP-RST
O
Reset signal output to the I/O expander, BH2210V
62
VCC
-
Power supply terminal (+3.3V)
63
A-HALF
I
Deck A cassette detection signal input terminal (“H”:cassette detected)
64
VSS
-
Ground terminal
65
SM-RESET
O
Reset signal output to the S-Master Power IC
66
IO-EXP-DATA-OUT
O
Serial data output signal to IO expander, BH2210V
69
IO-EXP-CLK
O
Serial data latch signal to I/O expander, BH2210V
376315150 892498299
70
IO-EXP-LAT
O
Serial data clock signal to I/O expander, BH2210V
71
NO-USE
I
Unused port (Pull to ground)
QQ 376315150 892498299
TEL 13942296513
72
SM-SD
I
Shutdown (protector) detection signal from the S-Master Power IC
73
DISPLAY-KEY
I
DISPLAY key press detection signal (Interrupt input)
74
POWER-KEY
I
POWER key press detection signal (Interrupt input)
75
NO-USE
I
Unused port (Pull to ground)
76
SM-LATCH-1
O
Serial data latch pulse output to the S-Master Processor IC (Front channel)
77
SM-CLK
O
Serial data transfer clock signal to the S-Master Processor IC
78
SM-DATA
O
Serial data output signal to the S-Master Processor IC
79
SM-LATCH-2
O
Serial data latch pulse output to the S-Master Processor IC (Sub woofer channel)
80
NO-USE
I
Unused port (Pull to ground)
81
NO-USE
I
Unused port (Pull to ground)
82
CD-CLK
O
Serial data transfer clock signal output to the digital signal processor
83
M61537-DATA
O
Serial data output to audio signal processor, M61537FP
84
M61537-CLK
O
Serial data transfer clock signal output to audio signal processor, M61537FP
85
HP DET
I
Headphone connection detection signal input “H”: headphone connected
86
HP-MUTE
O
Headphone muting on/off control signal (“L”: muting on)
87
NO-USE
I
Unused port (Pull to ground)
88
VACS-IN
I
VACS level detection signal (A/D input)
89
A-SHUT
I
Shut off detection signal input from deck A side reel pulse detector (A/D input)
90
B-SHUT
I
Shut off detection signal input from deck B side reel pulse detector (A/D input)
I
Deck B cassette detection and forward side recording tab detection signal input
www
91
B-HALF
xiaoy u163. com terminal (A/D input)
92
MODEL-IN
93
DEST-IN
94
AD-KEY-3
95
AD-KEY-2
.
I
Model setting terminal (A/D input)
I
Destination setting terminal (A/D input)
I
Key input terminal (A/D input)
I
Key input terminal (A/D input)
58 http://www.xiaoyu163.com
376315150 892498299
QQ
68
QQ
61
13942296513
I
STBY-LED
13942296513
VOL-B
56
TEL
TEL
55
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 Pin No.
Pin Name
I/O
96
AVSS
-
Ground terminal (for A/D conversion)
Description
97
AD-KEY-1
I
Key input terminal (A/D input)
98
VREF
I
A/D Converter reference voltage input terminal (+3.3V)
99
AVCC
-
Power supply terminal (+3.3V) (for A/D conversion)
100
MAIN ON/OFF
O
Main power on/off control signal output (“H”:power on)
TEL
TEL
13942296513
13942296513
.
QQ 376315150 892498299
376315150 892498299
376315150 892498299
www
QQ
QQ
TEL 13942296513
xiaoy u163. com 59 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
• IC403 BH2210FV-E2 (SIGNAL IN/OUT CONTROL) (MAIN BOARD) Pin No.
Pin Name
I/O
Description
1
CTLIO
I
Input/output mode select port (Fixed at "H")
2
RESET
I
Reset signal input
3
CLK
I
Serial data clock input
4
LATCH
I
Serial data latch input
5
TC-MUTE
O
Tape playback muting on/off control signal output ( "H":muting on)
6
NO-USE
O
Not used (Open)
7
REC-MUTE
O
Recording muting on/off control signal output ("H":muting on)
8
NO-USE
O
Not used (Open)
9
SM-NSP-MUTING
O
S-Master Processor IC PWM 50% duty muting on/off control signal output ("L":muting on) Not used (Open)
12
SM-INIT
O
Initialization signal output to the S-Master Processor IC
13942296513
13
LATCHO
O
Serial data latch output signal (Not used) (Open)
14
CLKO
O
Serial data clock output signal (Not used) (Open)
15
DO1
O
Serial data output signal 1 (Not used) (Open)
16
DI2
I
Serial data input signal 2 (Not used) (Open)
17
A-TRIG
O
Deck A side trigger plunger drive signal output ("H":plunger on)
18
CAPM-CNT
O
Capstan motor drive signal output
19
B-TRIG
O
Deck B side trigger plunger drive signal output ("H":plunger on)
REC-BIAS
O
Recording bias on/off control signal output ("H":bias on)
21
TC-RELAY
O
Recording/playback selection signal output ("H":recording "L":playback)
376315150 892498299
22
ADC-RESET
O
Power down control signal to Analog to Digital converter, PCM1803 ("L": Power down)
23
NO-USE
O
Not used (Open)
24
FAN-CTRL
O
Fan driving signal output ("L": Fan on)
25
DO2
O
Serial data output signal 2 (Not used) (Open)
26
DI1
I
Serial data input signal 1
27
VSS
-
Ground terminal
28
VDD
-
Power supply terminal (+3.3V)
TEL 13942296513
www
.
QQ 376315150 892498299
xiaoy u163. com
60 http://www.xiaoyu163.com
376315150 892498299
QQ
20
QQ
S-Master Processor IC Soft muting on/off control signal output ("L":muting on)
O
13942296513
O
NO-USE
TEL
SM-SOFT-MUTING
11
TEL
10
http://www.xiaoyu163.com
HCD-GNX600
SECTION 8 EXPLODED VIEWS
QQ 376315150 892498299 NOTE: • -XX, -X mean standardized parts, so they may have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied.
8-1.
• •
Hardware (# mark) list and accessories are given in the last of this parts list. Abbreviation AR : Argentina model AUS : Australian model E2 : 120V AC Area in E model E3 : 240V AC Area in E model E51 : Chilean and Peruvian model
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
CASE (TOP), BACK PANEL SECTION 3
#1
#1
5
4
6 TEL
TEL
2
#1
7
13942296513
13942296513
1
not supplied
13 8
6
not supplied
#1
#1 #1
not supplied
#1 not supplied
376315150 892498299
376315150 892498299
QQ 376315150 892498299 10
6
#1
QQ
QQ
TEL 13942296513
#1
#1
not supplied
M891
11 #1 #1
3 12 9 2
Ref. No. 1 2 3 4 5
Part No.
Description
2-658-345-01 3-363-099-02 3-363-099-32 2-680-202-01 2-670-216-01
PANEL, LOADING SCREW (CASE 3 TP2) SCREW (CASE 3 TP2) CASE (SIDE-L) CASE (TOP)
www 6 7 8
Remarks
Part No.
Description
9 10
2-680-201-01 CASE (SIDE-R) 1-775-250-11 WIRE (FLAT TYPE) (27 CORE)
11 12 13 M891 #1
1-829-030-11 1-827-720-11 3-378-109-12 1-763-372-11 7-685-646-79
Remarks
WIRE (FLAT TYPE) (25 CORE) WIRE (FLAT TYPE) (11 CORE) CUSHION, SARANET FAN, DC SCREW +BVTP 3X8 TYPE2 IT-3
xiaoy u163. com
3-703-136-12 SCREW, TAPPING 1-693-702-11 TUNER (FM/AM) (TM10SE) 2-630-050-01 +BVTT 3X6 (SUMITITE)
.
Ref. No.
61 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
8-2.
FRONT PANEL SECTION
65
63
65
not supplied
62
65
not supplied
61 75 60
TEL
TEL
76
74
59
64
73
57
72 71
55
66
supplied with S1305
53
54
13942296513
13942296513
58
59
65
70 56 65
69
QQ 376315150 892498299 not supplied
68
67
51 #1
Ref. No.
Part No.
Description
51 52 53 54 55
2-658-356-01 2-658-355-01 2-669-613-01 2-590-671-01 X-2103-595-1
HOLDER (TC-R) HOLDER (TC-L) DETENT SPRING KNOB (VOL) KNOB JOG ASSY
56 57 58 59 60
4-238-628-03 2-658-350-01 4-231-841-01 4-224-104-41 4-231-825-01
MIC KNOB WINDOW (FL) SPRING (HEART CAM-B) DAMPER CAM (B), HEART
61 62 63 64
2-658-343-01 X-2103-443-1 A-1167-711-A 2-658-347-01
PANEL, FRONT BUTTON (FUNCTION) ASSY PANEL BOARD, COMPLETE BUTTON (DISC)
www
.
Remarks
Ref. No. 65
Part No. Description 3-087-053-01 +BVTP2.6 (3CR)
66 67 68 69 70
1-417-656-11 A-1167-713-A 4-225-252-01 2-658-367-01 4-231-836-01
MECHA DECK (CWN42FF601) MIC BOARD, COMPLETE CUSHION (FOOT) SPRING (L) SPRING (HEART CAM-A)
71 72 73 74 75
2-658-368-01 4-231-824-01 2-659-548-01 2-658-354-01 2-658-349-01
SPRING (R) CAM (A), HEART BUTTON (EQ2) BUTTON (EQ) BUTTON (DISPLAY)
xiaoy u163. com 76 #1
2-658-348-01 BUTTON (REC) 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
62 http://www.xiaoyu163.com
Remarks
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
53
52
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 8-3.
CHASSIS SECTION
101
not supplied
not supplied
#1
104 101
101 102
108
not supplied
107 #1
#1
101
106 105
TEL
TEL
102 not supplied
13942296513
13942296513
#1 #1 F1100
101 103
not supplied
#1 not supplied
101
111
QQ
QQ
not supplied
111
109 110 not supplied
Ref. No.
Part No.
Description
101 102 103 103 103
2-630-050-01 3-703-136-12 A-1167-594-A A-1183-818-A A-1183-905-A
+BVTT 3X6 (SUMITITE) SCREW, TAPPING POWER BOARD, COMPLETE (E2, E3, E51) POWER BOARD, COMPLETE (AUS) POWER BOARD, COMPLETE (AR)
104 105 106 107 * 107
2-597-972-31 A-1164-113-A 1-500-497-11 3-703-244-00 3-703-571-12
SHEET, RADIATION SMASTER BOARD, COMPLETE FILTER, CLAMP (FERRITE CORE) BUSHING (2104), CORD (E51, AR, AUS) BUSHING (S) (4516), CORD (E2, E3)
0 108 0 108
1-783-941-12 CORD, POWER (AR) 1-827-226-31 CORD, POWER (E2, E3)
www
.
Remarks
Ref. No.
Part No.
0 108 0 108 109
1-829-259-11 CORD, POWER (AUS) 1-830-188-11 CORD, POWER (E51) A-1164-115-A ADC BOARD, COMPLETE
110 110 110 110 110 111 0 F1100 #1
A-1159-545-A A-1183-586-A A-1183-591-A A-1183-596-A A-1183-599-A
Description
#1
Remarks
MAIN BOARD, COMPLETE (E2) MAIN BOARD, COMPLETE (AUS) MAIN BOARD, COMPLETE (E3) MAIN BOARD, COMPLETE (E51) MAIN BOARD, COMPLETE (AR)
4-225-252-01 CUSHION (FOOT) 1-532-506-33 FUSE (T6.3AL/250V) 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
xiaoy u163. com 63 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
101
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
8-4. CD MECHANISM DECK SECTION-1 156
162
158
151 156
157
157
161
164 164 165
160
155
TEL
TEL
156
163
159
158
13942296513
13942296513
155
M741
152 154
166 CD mechanism deck section-2
151
Ref. No. 151 152 153 154 155
Part No. 4-218-253-62 1-832-798-21 1-687-134-12 4-243-815-11 4-245-571-02
Description SCREW (M2.6), +BTTP CABLE, FLEXIBLE FLAT (5 CORE) MOTOR (TB) BOARD TABLE (LOADING) GEAR (STOPPER)
156 157 158 159
4-985-672-01 4-245-570-01 4-245-572-01 1-687-132-12
SCREW (+PTPWH M2.6), FLOATING GEAR (JOINT) BUSHING (GEAR) SENSOR BOARD
www
.
Remarks
Ref. No. 160
Part No. Description 4-243-820-01 GEAR (TABLE)
161 162 163 164 165
4-243-819-01 4-243-816-11 4-243-823-11 4-218-252-61 4-243-821-01
GEAR (GENEVA) TRAY BELT (TABLE) SCREW (+PTPWH M2.6), FLOATING PULLEY (TABLE)
166 M741
3-231-598-01 SHEET (BA) A-1108-965-A MOTOR ASSY, TABLE (TABLE)
xiaoy u163. com
64 http://www.xiaoyu163.com
Remarks
376315150 892498299
376315150 892498299
153
QQ
QQ
QQ 376315150 892498299
TEL 13942296513
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 8-5.
CD MECHANISM DECK SECTION-2
212
205
213
205 216 214
211
217
205 215
210
219
231
220
S711
202 TEL
TEL
208 205 223 222
222
M751
230
223
223 222 223 205 205
207 203 218 202
QQ
QQ
206
13942296513
13942296513
222 229
205
205
201
202
204
226
228
not supplied
232
Ref. No. 201 202 203 204 205
Part No. A-1103-756-B 4-218-253-52 1-687-669-12 4-244-034-11 4-985-672-01
Description DRIVER BOARD, COMPLETE SCREW (M2.6), +BTTP SW BOARD BELT (LOADING) SCREW (+PTPWH M2.6), FLOATING
206 207 208 210 211
4-225-844-01 4-224-613-11 1-687-133-12 4-244-108-01 4-224-609-01
GEAR (LOADING A) GEAR (SHAFT) MOTOR (LD) BOARD GEAR, SWING GEAR (LOADING C)
212 213 214 215 216
4-224-608-01 3-016-533-11 4-224-611-01 4-224-606-01 4-243-818-01
COLLAR, SWING WASHER (FR), STOPPER GEAR (LOADING B) GEAR (RV) GEAR (U/D)
www
.
Remarks
Ref. No. 217 218 219 220 222
Part No. 4-243-822-02 X-2102-809-1 4-231-189-01 X-2055-190-1 4-227-549-11
Description LEVER (LIFTER) PULLEY (KH) ASSY PULLEY (B), CHUCKING HOLDER (213) ASSY INSULATOR
223 226 228 0 229 230
4-227-045-31 1-832-404-21 A-4751-431-A 8-820-244-01 1-471-035-21
SPRING (INSULATOR), COIL CABLE, FLEXIBLE FLAT (16 CORE) CD BOARD, COMPLETE OPTICAL PICK-UP KSM-215DCP/C2NP MAGNET ASSY
4-243-817-22 3-087-053-01 A-1108-966-A 1-477-680-12
CHASSIS +BVTP2.6 (3CR) MOTOR ASSY, LOADING (LOADING) ENCODER, ROTARY
231 232 M751 S711
Remarks
xiaoy u163. com
65 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
http://www.xiaoyu163.com
HCD-GNX600
SECTION 9
QQ 376315150 892498299 ADC
ELECTRICAL PARTS LIST
• •
•
COILS uH: µH SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... Abbreviation AR : Argentina model AUS : Australian model E2 : 120V AC Area in E model E3 : 240V AC Area in E model E51 : Chilean and Peruvian model
Remarks
Ref. No.
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
When indicating parts by reference number, please include the board.
Part No.
Description
Remarks
< CONNECTOR > CN01
13942296513
13942296513
A-1164-115-A ADC BOARD, COMPLETE *******************
1-766-720-41 CONNECTOR, BOARD TO BOARD 17P
< CAPACITOR > < DIODE > ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 100uF 0.1uF 100uF 0.01uF
20% 20% 10% 20% 10%
50V 10V 16V 10V 16V
C26 C27 C28 C29 C32
1-107-826-11 1-126-963-11 1-162-915-11 1-162-915-11 1-107-726-91
CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 4.7uF 10PF 10PF 0.01uF
10% 20% 0.5PF 0.5PF 10%
16V 50V 50V 50V 16V
C40 C41 C42 C50 C51
1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-126-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0.1uF 0.1uF 0.1uF 0.1uF 10uF
20%
25V 25V 25V 25V 50V
C53 C54 C55 C56 C57
1-104-658-91 1-164-156-11 1-126-964-11 1-164-156-11 1-126-964-11
ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT
100uF 0.1uF 10uF 0.1uF 10uF
C58 C59 C60 C61 C62
1-164-156-11 1-126-960-11 1-126-960-11 1-164-156-11 1-126-964-11
CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT
0.1uF 1uF 1uF 0.1uF 10uF
C63 C64 C65 C66 C67
1-126-964-11 1-164-156-11 1-126-964-11 1-164-156-11 1-104-658-91
ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT
10uF 0.1uF 10uF 0.1uF 100uF
C68 C70 C81 C90 C91
1-164-156-11 1-126-960-11 1-107-726-91 1-162-964-11 1-162-964-11
CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
C93
1-162-964-11 CERAMIC CHIP
TEL 13942296513
.
20% 20% 20%
20% 20% 20%
10V 25V 50V 25V 50V 25V 50V 50V 25V 50V
D11 D12 D13 D14 D51
8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61
D52 D61
8-719-988-61 DIODE 1SS355TE-17 8-719-988-61 DIODE 1SS355TE-17
< EARTH TERMINAL >
EP01 EP02
1-537-738-21 TERMINAL, GROUND 1-537-738-21 TERMINAL, GROUND < FILTER >
FL01 FL02
1-234-177-21 FILTER, CHIP EMI 1-234-177-21 FILTER, CHIP EMI < IC >
IC01 IC02 IC03 IC11 IC12
8-759-473-95 8-759-583-47 8-759-387-77 6-707-608-01 6-707-608-01
IC IC IC IC IC
uPC2905T-E1 uPC2933T-E2 TC7WU04F (TE12R) PCM1803DBR PCM1803DBR
< JUMPER RESISTOR > JR21 JR51 JR52
20%
0.1uF 1uF 0.01uF 0.001uF 0.001uF
20% 10% 10% 10%
25V 50V 16V 50V 50V
L01 L02 L03
0.001uF
10%
50V
Q07 Q08
20%
1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17
QQ 376315150 892498299
50V 25V 50V 25V 10V
20%
DIODE DIODE DIODE DIODE DIODE
1-216-864-11 SHORT CHIP 1-216-806-11 METAL CHIP 1-216-864-11 SHORT CHIP
0 56 0
5%
< COIL > 1-412-939-11 INDUCTOR 1-412-951-11 INDUCTOR 1-412-951-11 INDUCTOR
1uH 10uH 10uH
xiaoy u163. com < TRANSISTOR >
6-550-889-01 TRANSISTOR 2SC5938-T112-1B 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
66 http://www.xiaoyu163.com
1/10W
376315150 892498299
376315150 892498299
1-126-956-91 1-104-658-91 1-107-826-11 1-104-658-91 1-107-726-91
QQ
QQ
C20 C22 C23 C24 C25
www
TEL
TEL
NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • CAPACITORS: uF: µF • RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable Ref. No. Part No. Description
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 ADC
Ref. No.
Part No.
Description
Remarks
Ref. No.
Part No.
Description
CD
Remarks
C151
1-128-995-21 ELECT CHIP
100uF
20%
10V
C161 C162 C163 C171 C172
1-164-360-11 1-164-360-11 1-164-360-11 1-162-919-11 1-162-920-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 22PF 27PF
5% 5%
16V 16V 16V 50V 50V
C174 C181 C182 C183 C184
1-164-360-11 1-164-360-11 1-164-360-11 1-124-778-00 1-124-778-00
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP
0.1uF 0.1uF 0.1uF 22uF 22uF
20% 20%
16V 16V 16V 6.3V 6.3V
C185 C186 C194 C195 C196
1-164-315-11 1-164-315-11 1-164-360-11 1-164-360-11 1-164-360-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
470PF 470PF 0.1uF 0.1uF 0.1uF
5% 5%
50V 50V 16V 16V 16V
C201 C203 C209 C210 C211
1-128-995-21 1-128-995-21 1-162-970-11 1-107-826-11 1-164-230-11
ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100uF 100uF 0.01uF 0.1uF 220PF
20% 20% 10% 10% 5%
10V 10V 25V 16V 50V
C212 C213 C251 C252 C255
1-162-919-11 1-162-919-11 1-162-969-11 1-164-360-11 1-164-360-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
22PF 5% 22PF 5% 0.0068uF 10% 0.1uF 0.1uF
50V 50V 25V 16V 16V
< RESISTOR >
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 100K 1K 2.2K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R32 R36 R38 R40 R41
1-216-821-11 1-216-864-11 1-216-864-11 1-216-821-11 1-216-857-11
METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP
1K 0 0 1K 1M
5%
1/10W
5% 5%
1/10W 1/10W
R50 R52 R53 R55 R57
1-216-864-11 1-216-809-11 1-216-809-11 1-216-864-11 1-216-864-11
SHORT CHIP METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP
0 100 100 0 0
R58 R59 R60 R63 R64
1-216-864-11 1-216-864-11 1-216-864-11 1-216-809-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP METAL CHIP SHORT CHIP
0 0 0 100 0
R65 R67
1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP
5% 5%
5%
1/10W 1/10W
1/10W
0 0
A-4751-431-A CD BOARD, COMPLETE ******************* < CAPACITOR >
C10 C11 C14 C15 C16
1-165-989-11 1-165-989-11 1-164-360-11 1-164-360-11 1-115-156-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
10uF 10uF 0.1uF 0.1uF 1uF
10% 10%
C17 C18 C111 C112 C113
1-126-246-11 1-162-964-11 1-162-967-11 1-164-315-11 1-162-967-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
220uF 0.001uF 0.0033uF 470PF 0.0033uF
20% 10% 10% 5% 10%
4V 50V 50V 50V 50V
C114 C115 C116 C122 C123
1-164-315-11 1-164-360-11 1-128-995-21 1-107-826-11 1-107-826-11
CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP
470PF 0.1uF 100uF 0.1uF 0.1uF
5%
50V 16V 10V 16V 16V
C124 C125 C131 C132 C133
1-162-959-11 1-164-360-11 1-162-927-11 1-117-863-11 1-162-970-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
330PF 0.1uF 100PF 0.47uF 0.01uF
5% 5% 10% 10%
50V 16V 50V 6.3V 25V
C134 C141 C142 C143
1-164-360-11 1-107-826-11 1-162-965-11 1-164-360-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 10% 0.0015uF 10% 0.1uF
16V 16V 50V 16V
20% 10% 10%
6.3V 6.3V 16V 16V 10V
C257 C258 C259 C260 C302
1-164-360-11 1-164-360-11 1-164-360-11 1-128-394-11 1-164-360-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 220uF 0.1uF
C303 C305 C306 C307 C308
1-164-360-11 1-126-246-11 1-164-360-11 1-164-360-11 1-126-208-21
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP
0.1uF 220uF 0.1uF 0.1uF 47uF
C309 C310 C311 C312 C313
1-164-360-11 1-164-360-11 1-164-360-11 1-164-360-11 1-164-360-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
C314 C315 C316 C317 C318
1-126-208-21 1-107-826-11 1-162-966-11 1-162-970-11 1-162-970-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
47uF 0.1uF 0.0022uF 0.01uF 0.01uF
C320
1-216-864-11 SHORT CHIP
20%
20%
20%
16V 16V 16V 10V 16V
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
X001 1-795-843-11 VIBRATOR, CRYSTAL (12.288MHz) ************************************************************
www
QQ
QQ
< VIBRATOR >
13942296513
13942296513
1-216-825-11 1-216-845-11 1-216-821-11 1-216-825-11 1-216-845-11
TEL
TEL
R25 R27 R28 R29 R31
16V 4V 16V 16V 4V 16V 16V 16V 16V 16V
20% 10% 10% 10% 10%
4V 16V 50V 25V 25V
0
< CONNECTOR > CN101 CN201
1-770-425-51 CONNECTOR, FFC/FPC 16P 1-818-350-51 CONNECTOR, FFC (LIF (NON-ZIF)) 27P
xiaoy u163. com
< FERRITE BEAD >
.
FB301
1-500-445-21 FERRITE, EMI (SMD) (2012)
67 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 CD
DRIVER
Ref. No.
Part No.
Description
Remarks
< IC >
IC101 IC251 IC301 IC303
8-752-425-12 6-705-808-01 6-705-365-01 6-705-807-01
IC IC IC IC
CXD3059AR BA5947FM-E2 TC94A34FG-002 BH15FB1WG
< TRANSISTOR > Q10
6-551-120-01 TRANSISTOR 2SA2119K < RESISTOR > 5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
R112 R113 R114 R121 R131
1-216-835-11 1-216-821-11 1-216-835-11 1-216-835-11 1-216-857-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
15K 1K 15K 15K 1M
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R132 R133 R141 R142 R143
1-216-833-11 1-216-848-11 1-216-829-11 1-216-821-11 1-216-827-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 180K 4.7K 1K 3.3K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R151 R161 R162 R163 R165
1-216-864-11 1-216-809-11 1-216-841-11 1-216-809-11 1-216-864-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
0 100 47K 100 0
5% 5% 5%
TEL 13942296513
1/10W 1/10W 1/10W
R171 R172 R173 R181 R182
1-216-817-11 1-216-857-11 1-216-295-91 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
470 1M 0 100 100
R191 R201 R203 R204 R205
1-216-864-11 1-500-445-21 1-216-864-11 1-500-445-21 1-216-864-11
SHORT CHIP 0 FERRITE, EMI (SMD) (2012) SHORT CHIP 0 FERRITE, EMI (SMD) (2012) SHORT CHIP 0
R251 R252 R253 R301 R302
1-216-833-11 1-216-837-11 1-216-833-11 1-216-845-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 22K 10K 100K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R303 R305 R306 R307 R313
1-216-845-11 1-216-845-11 1-216-864-11 1-216-833-11 1-216-813-11
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
100K 100K 0 10K 220
5% 5%
1/10W 1/10W
5% 5%
1/10W 1/10W
R351 R352 R353 R354 R401
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R402
1-216-809-11 METAL CHIP
.
100
5%
1/10W
5% 5%
1/10W 1/10W
5% 5%
1/10W 1/10W
100 100 100 100
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
Remarks
R407 R408 R409 R410 R411
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R412 R419 R502
1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-864-11 SHORT CHIP
100 100 0
5% 5%
1/10W 1/10W
< SWITCH > S101
1-771-853-11 SWITCH, DETECTION (LIMIT) < VIBRATOR >
X171 1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHz) ************************************************************ A-1103-756-B DRIVER BOARD, COMPLETE ********************** < CAPACITOR > C715 C731 C735 C736 C737
1-126-933-11 1-126-964-11 1-164-159-21 1-164-159-21 1-164-159-21
ELECT ELECT CERAMIC CERAMIC CERAMIC
100uF 10uF 0.1uF 0.1uF 0.1uF
20% 20%
C741 C751 C752
1-162-306-11 CERAMIC 1-162-306-11 CERAMIC 1-164-159-21 CERAMIC
0.01uF 0.01uF 0.1uF
20% 20%
16V 50V 50V 50V 50V
QQ 376315150 892498299 16V 16V 50V
< CONNECTOR > CN701 CN702 * CN703 CN704
1-784-735-11 1-784-766-11 1-564-720-11 1-785-328-11
CONNECTOR, FFC 13P CONNECTOR, FFC 5P PIN, CONNECTOR (SMALL TYPE) 4P PIN, CONNECTOR (LIGHT ANGRE) 2P < DIODE >
D701 D711
8-719-921-42 DIODE MTZJ-5.1A 8-719-109-69 DIODE RD3.6ESB2 < IC >
IC701 IC712
8-759-598-69 IC BA6956AN 8-759-598-69 IC BA6956AN < TRANSISTOR >
Q731
8-729-029-66 TRANSISTOR DTC114ESA < RESISTOR >
www
R701 R702 R711 R712 R713
1-249-413-11 1-247-807-31 1-249-417-11 1-249-425-11 1-249-433-11
CARBON CARBON CARBON CARBON CARBON
470 100 1K 4.7K 22K
xiaoy u163. com
68 http://www.xiaoyu163.com
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
376315150 892498299
376315150 892498299
3.3 0 100K 1 1K
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
QQ
QQ
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
Description
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
13942296513
13942296513
1-216-791-11 1-216-864-11 1-216-845-11 1-218-446-11 1-216-821-11
Part No.
R403 R404 R405 R406
TEL
TEL
R10 R11 R12 R13 R111
Ref. No.
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 DRIVER
Ref. No. R721 R722 R723 R731 R732
Part No.
Description
1-249-425-11 1-249-425-11 1-249-425-11 1-247-807-31 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
Remarks
4.7K 4.7K 4.7K 100 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R733 1-249-417-11 CARBON 1K 5% 1/4W R734 1-249-430-11 CARBON 12K 5% 1/4W R736 1-249-412-11 CARBON 390 5% 1/4W R751 1-249-425-11 CARBON 4.7K 5% 1/4W ************************************************************ IR BOARD ******** < CAPACITOR > 1-115-416-11 CERAMIC CHIP
0.001uF
5%
MAIN
120PF 330PF 0.001uF 0.0056uF 100uF
5% 5% 10% 10% 20%
50V 50V 50V 25V 16V
Remarks
C133 C134 C135 C136 C137
1-126-960-11 1-162-927-11 1-162-927-11 1-126-933-11 1-126-935-11
ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT
1uF 100PF 100PF 100uF 470uF
20% 5% 5% 20% 20%
50V 50V 50V 16V 16V
C138 C139 C140 C141 C142
1-162-968-11 1-137-150-11 1-126-947-11 1-162-970-11 1-130-481-00
CERAMIC CHIP FILM ELECT CERAMIC CHIP MYLAR
0.0047uF 0.01uF 47uF 0.01uF 0.0068uF
10% 5% 20% 10% 5%
50V 100V 35V 25V 50V
C144 C145 C147 C148 C150
1-162-968-11 1-162-968-11 1-162-968-11 1-126-961-11 1-126-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT
0.0047uF 0.0047uF 0.0047uF 2.2uF 10uF
10% 10% 10% 20% 20%
50V 50V 50V 50V 50V
C151 C153 C154 C156 C157
1-126-964-11 1-126-964-11 1-126-964-11 1-115-412-11 1-136-497-81
ELECT ELECT ELECT CERAMIC CHIP FILM
10uF 10uF 10uF 680PF 0.1uF
20% 20% 20% 5% 5%
50V 50V 50V 25V 50V
C158 C159 C160 C161 C162
1-104-700-11 1-104-700-11 1-126-964-11 1-100-436-91 1-162-968-11
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
0.027uF 0.027uF 10uF 0.033uF 0.0047uF
10% 10% 20% 10% 10%
16V 16V 50V 25V 50V
C163 C164 C165 C166 C168
1-126-964-11 1-137-196-11 1-137-195-11 1-126-963-11 1-162-962-11
ELECT FILM FILM ELECT CERAMIC CHIP
10uF 0.68uF 0.56uF 4.7uF 470PF
20% 5% 5% 20% 10%
50V 50V 50V 50V 50V
C169 C170 C171 C172 C173
1-126-964-11 1-162-970-11 1-126-960-11 1-126-964-11 1-162-957-11
ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP
10uF 0.01uF 1uF 10uF 220PF
20% 10% 20% 20% 5%
50V 25V 50V 50V 50V
C174 C175 C176 C177 C178
1-162-928-11 1-162-959-11 1-162-964-11 1-137-194-81 1-162-970-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM CERAMIC CHIP
120PF 330PF 0.001uF 0.47uF 0.01uF
5% 5% 10% 5% 10%
50V 50V 50V 50V 25V
C179 C180 C184 C185 C186
1-162-970-11 1-164-172-11 1-162-927-11 1-162-927-11 1-110-563-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.01uF 0.0056uF 100PF 100PF 0.068uF
10% 10% 5% 5% 10%
25V 25V 50V 50V 16V
C187 C188 C189 C190 C191
1-104-658-91 1-163-077-00 1-162-957-11 1-162-957-11 1-137-189-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM
100uF 0.1uF 220PF 220PF 0.18uF
20% 10% 5% 5% 5%
10V 25V 50V 50V 50V
C192 C193
1-126-960-11 ELECT 1-137-189-11 FILM
1uF 0.18uF
20% 5%
50V 50V
25V
< CONNECTOR > CN1403 1-816-423-11 SOCKET, CONNECTOR 3P < IC > IC1301
6-600-309-01 IC RPM7240-H9 ( g ) < RESISTOR >
R1306 1-216-805-11 METAL CHIP 47 5% 1/10W ************************************************************
TEL 13942296513 A-1159-545-A A-1183-586-A A-1183-591-A A-1183-596-A A-1183-599-A
MAIN BOARD, COMPLETE (E2) MAIN BOARD, COMPLETE (AUS) MAIN BOARD, COMPLETE (E3) MAIN BOARD, COMPLETE (E51) MAIN BOARD, COMPLETE (AR) ********************
QQ 376315150 892498299
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
376315150 892498299
376315150 892498299
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
QQ
QQ
Description
1-162-928-11 1-162-959-11 1-162-964-11 1-164-172-11 1-126-933-11
13942296513
13942296513
Part No.
C124 C125 C126 C130 C132
< CAPACITOR > C101 C103 C104 C105 C106
1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11 1-115-412-11
ELECT ELECT ELECT ELECT CERAMIC CHIP
10uF 10uF 10uF 10uF 680PF
20% 20% 20% 20% 5%
50V 50V 50V 50V 25V
C107 C108 C109 C110 C111
1-136-497-81 1-104-700-11 1-104-700-11 1-126-964-11 1-100-436-91
FILM CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 0.027uF 0.027uF 10uF 0.033uF
5% 10% 10% 20% 10%
50V 16V 16V 50V 25V
C112 C113 C114 C115 C116
1-162-968-11 1-126-964-11 1-137-196-11 1-137-195-11 1-126-963-11
CERAMIC CHIP ELECT FILM FILM ELECT
0.0047uF 10uF 0.68uF 0.56uF 4.7uF
10% 20% 5% 5% 20%
50V 50V 50V 50V 50V
C118 C119 C120 C121 C122 C123
1-162-962-11 1-126-964-11 1-162-970-11 1-126-960-11 1-126-964-11 1-162-957-11
CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP
470PF 10uF 0.01uF 1uF 10uF 220PF
10% 20% 10% 20% 20% 5%
50V 50V 25V 50V 50V 50V
www
.
xiaoy u163. com
69 http://www.xiaoyu163.com
TEL
TEL
C1308
Ref. No.
IR
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 MAIN
Ref. No.
20% 20% 10% 20%
50V 50V 50V 50V
Remarks
C199 C200 C201 C202 C203
1-162-966-11 1-162-966-11 1-162-953-11 1-162-970-11 1-162-953-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.0022uF 0.0022uF 100PF 0.01uF 100PF
10% 10% 5% 10% 5%
50V 50V 50V 25V 50V
C204 C213 C214 C215 C216
1-162-953-11 1-136-497-81 1-136-497-81 1-126-964-11 1-136-497-81
CERAMIC CHIP FILM FILM ELECT FILM
100PF 0.1uF 0.1uF 10uF 0.1uF
5% 5% 5% 20% 5%
50V 50V 50V 50V 50V
C226 C228 C230 C238 C267
1-162-953-11 1-162-953-11 1-126-961-11 1-126-964-11 1-126-964-11
CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT
100PF 100PF 2.2uF 10uF 10uF
5% 5% 20% 20% 20%
50V 50V 50V 50V 50V
C288 C301 C302 C303 C304
1-126-964-11 1-126-961-11 1-126-961-11 1-126-961-11 1-126-961-11
ELECT ELECT ELECT ELECT ELECT
10uF 2.2uF 2.2uF 2.2uF 2.2uF
20% 20% 20% 20% 20%
50V 50V 50V 50V 50V
C307 C308 C410 C411 C412
1-126-961-11 1-126-961-11 1-162-919-11 1-162-919-11 1-164-156-11
ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
2.2uF 2.2uF 22PF 22PF 0.1uF
20% 20% 5% 5%
50V 50V 50V 50V 25V
C414 C416 C462 C464 C486
1-164-156-11 1-126-917-11 1-104-658-91 1-164-156-11 1-126-935-11
CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT
0.1uF 3300uF 100uF 0.1uF 470uF
C496 C498 C499 C504 C520
1-126-964-11 1-164-156-11 1-164-156-11 1-126-926-11 1-126-964-11
ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT
10uF 0.1uF 0.1uF 1000uF 10uF
20%
C521 C522 C523 C526 C527
1-162-960-11 1-162-960-11 1-162-960-11 1-164-156-11 1-162-960-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
220PF 220PF 220PF 0.1uF 220PF
10% 10% 10%
C531 C534 C535 C536 C537
1-164-156-11 1-164-156-11 1-126-928-11 1-164-156-11 1-164-156-11
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 3300uF 0.1uF 0.1uF
C538 C539 C546 C547 C550
1-164-156-11 1-164-156-11 1-162-960-11 1-162-960-11 1-128-547-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0.1uF 0.1uF 220PF 220PF 6800uF
10% 10% 20%
25V 25V 50V 50V 16V
C551 C552 C553
1-126-960-11 ELECT 1-126-925-91 ELECT 1-126-960-11 ELECT
1uF 470uF 1uF
20% 20% 20%
50V 10V 50V
TEL 13942296513
www
.
20% 20% 20%
20% 20%
10%
20%
25V 6.3V 10V 25V 16V 50V 25V 25V 10V 50V 50V 50V 50V 25V 50V 25V 25V 10V 25V 25V
Ref. No.
Part No.
Description
Remarks
C554 C555
1-126-925-91 ELECT 1-107-826-11 CERAMIC CHIP
470uF 0.1uF
20% 10%
10V 16V
C556 C566 C567 C568 C570
1-107-826-11 1-126-960-11 1-107-826-11 1-126-916-11 1-126-964-11
CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT
0.1uF 1uF 0.1uF 1000uF 10uF
10% 20% 10% 20% 20%
16V 50V 16V 6.3V 50V
C571 C580 C581 C582 C583
1-162-960-11 1-164-156-11 1-164-156-11 1-128-547-11 1-126-963-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT
220PF 0.1uF 0.1uF 6800uF 4.7uF
10%
50V 25V 25V 16V 50V
C585
1-164-156-11 CERAMIC CHIP
20% 20%
0.1uF
25V
< CONNECTOR > CN101 CN105 * CN111 CN121 * CN131
1-568-830-11 1-784-780-11 1-568-449-11 1-564-705-11 1-564-710-11
CONNECTOR, FFC 11P CONNECTOR, FFC 19P HOUSING, CONNECTOR (PC BOARD) 3P PIN, CONNECTOR (SMALL TYPE) 3P PIN, CONNECTOR (SMALL TYPE) 8P
CN201 CN205 CN351 * CN381 CN402
1-784-786-11 1-785-317-11 1-779-295-11 1-766-718-21 1-785-336-11
CONNECTOR, FFC 25P PIN, CONNECTOR (STRAIGHT) 5P CONNECTOR, FFC (LIF (NON-ZIF)) 27P CONNECTOR, BOARD TO BOARD 17P PIN, CONNECTOR (LIGHT ANGLE) 10P
CN405 CN406 CN580 * CN590
1-784-774-11 1-568-828-11 1-564-506-11 1-564-512-11
CONNECTOR, FFC 13P CONNECTOR, FFC 9P PLUG, CONNECTOR 3P PLUG, CONNECTOR 9P
QQ 376315150 892498299 < DIODE > D101 D102 D104 D213 D214
6-501-193-01 6-501-193-01 6-501-193-01 6-501-193-01 6-501-193-01
DIODE DIODE DIODE DIODE DIODE
1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17
D215 D216 D230 D231 D232
6-501-193-01 6-501-193-01 6-501-193-01 6-501-193-01 6-501-193-01
DIODE DIODE DIODE DIODE DIODE
1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17
D393 D394 D395 D396 D486
6-501-193-01 6-501-193-01 6-501-193-01 6-501-193-01 6-501-193-01
DIODE DIODE DIODE DIODE DIODE
1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17
D506 D561 D562 D563 D580
6-501-193-01 6-500-522-21 6-500-522-21 6-500-522-21 6-501-193-01
DIODE DIODE DIODE DIODE DIODE
1SS355WTE-17 10EDB40-TB3 10EDB40-TB3 10EDB40-TB3 1SS355WTE-17
D581 D582 D583 D586 D594
8-719-069-56 6-501-193-01 8-719-978-33 6-500-522-21 6-500-522-21
DIODE DIODE DIODE DIODE DIODE
UDZSTE-176.2B 1SS355WTE-17 DTZ-TT11-6.8B 10EDB40-TB3 10EDB40-TB3
xiaoy u163. com
70 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
10uF 1uF 0.0047uF 2.2uF
QQ
QQ
ELECT ELECT CERAMIC CHIP ELECT
13942296513
13942296513
Description
1-126-964-11 1-126-960-11 1-162-968-11 1-126-961-11
TEL
TEL
Part No.
C194 C195 C197 C198
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 MAIN
Ref. No.
Part No.
Description
Remarks
< FERRITE BEAD >
SHORT CHIP 0 FERRITE, EMI (SMD) (1608) SHORT CHIP 0 FERRITE, EMI (SMD) (1608) SHORT CHIP 0
FB152 FB153 FB505 FB506 FB507
1-469-125-21 1-216-864-11 1-216-864-11 1-500-283-11 1-500-283-11
FERRITE, EMI (SMD) (1608) SHORT CHIP 0 SHORT CHIP 0 INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD
FB508 FB509 FB510 FB512 FB513
1-500-283-11 1-500-283-11 1-500-283-11 1-500-283-11 1-414-235-22
INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD
FB514 FB555
1-414-235-22 INDUCTOR, FERRITE BEAD 1-216-864-11 SHORT CHIP 0 < IC > 6-705-667-01 6-806-204-01 6-701-680-01 6-707-095-01 6-703-550-01
IC IC IC IC IC
M61537FP-RF0G M30622MGP-A22FPU0 PST3629NR BH2210FV-E2 TA7809LS
IC552 IC562
6-703-550-01 IC TA7809LS 6-703-546-01 IC TA7804LS
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR036 JR037 JR042 JR043 JR044
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR046 JR047 JR048 JR049 JR050
1-216-864-11 1-216-864-11 1-216-296-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR051 JR055 JR056 JR057 JR059
1-216-864-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR126 JR152 JR153 JR176 JR228
1-216-864-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
< JACK >
JR261 JR267 JR318 JR381 JR467
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
1-815-045-11 JACK, PIN 2P (AUDIO IN) 1-820-048-11 CONNECTOR (LIGHTING) (D-LIGHT SYNC OUT) < JUMPER RESISTOR >
JR480 JR481 JR487 JR550 JR555
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR001 JR002 JR003 JR004 JR005
1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR006 JR007 JR008 JR009 JR011
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
L103 L104 L105
JR012 JR013 JR014 JR015 JR016
1-216-864-11 1-216-296-11 1-216-296-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
Q101 Q103 Q104 Q105 Q106
8-729-901-81 8-729-802-80 8-729-802-80 8-729-802-80 8-729-802-80
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2412K-T-146-R 2SC3661 2SC3661 2SC3661 2SC3661
JR017 JR018 JR019 JR020 JR021
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-296-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
Q107 Q108 Q109 Q110 Q111
8-729-216-22 8-729-027-43 8-729-027-43 8-729-027-23 8-729-027-43
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SA1162-G DTC114EKA-T146 DTC114EKA-T146 DTA114EKA-T146 DTC114EKA-T146
JR022 JR024 JR026
1-216-864-11 SHORT CHIP 1-216-296-11 SHORT CHIP 1-216-864-11 SHORT CHIP
0 0 0
Q112 Q113 Q114
8-729-141-75 TRANSISTOR 2SD596DV345 6-550-185-01 TRANSISTOR RT1P137P-TP-1 8-729-027-43 TRANSISTOR DTC114EKA-T146
www
.
376315150 892498299
376315150 892498299
JR029 JR030 JR031 JR032 JR033
QQ 376315150 892498299
TEL 13942296513 J501 J506
Remarks
0 0
QQ
QQ
IC101 IC401 IC402 IC403 IC551
Description
1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP
13942296513
13942296513
1-216-864-11 1-469-125-21 1-216-864-11 1-469-125-21 1-216-864-11
Part No.
JR027 JR028
TEL
TEL
FB101 FB102 FB103 FB104 FB151
Ref. No.
< COIL > 1-410-780-11 INDUCTOR 1-410-780-11 INDUCTOR 1-414-189-31 INDUCTOR
27mH 27mH 100uH
< TRANSISTOR >
xiaoy u163. com
71 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 MAIN
Ref. No.
Part No.
Description
Remarks
Ref. No.
Part No.
Description
Remarks
4.7K 5.6K
5% 5%
1/10W 1/10W
Q120 Q121 Q122 Q123 Q125
8-729-903-46 8-729-027-43 8-729-903-46 8-729-027-43 8-729-802-80
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SB1132-P DTC114EKA-T146 2SB1132-P DTC114EKA-T146 2SC3661
R128 R129 R130 R131 R133
1-216-837-11 1-216-829-11 1-216-841-11 1-216-827-11 1-216-857-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 4.7K 47K 3.3K 1M
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
Q151 Q153 Q154 Q155 Q166
8-729-901-81 8-729-802-80 8-729-802-80 8-729-802-80 8-729-802-80
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2412K-T-146-R 2SC3661 2SC3661 2SC3661 2SC3661
R138 R139 R140 R141 R142
1-216-841-11 1-216-864-11 1-216-833-11 1-216-833-11 1-216-833-11
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
47K 0 10K 10K 10K
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
Q175 Q213 Q237 Q287 Q301
8-729-802-80 8-729-901-00 8-729-802-80 8-729-802-80 8-729-027-31
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC3661 DTC124EK 2SC3661 2SC3661 DTA124EKA-T146
R143 R144 R145 R146 R147
1-216-827-11 1-216-805-11 1-216-833-11 1-216-797-11 1-216-803-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.3K 47 10K 10 33
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
Q302 Q303 Q304 Q307 Q308
8-729-027-43 8-729-027-31 8-729-027-43 8-729-027-31 8-729-027-43
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC114EKA-T146 DTA124EKA-T146 DTC114EKA-T146 DTA124EKA-T146 DTC114EKA-T146
R148 R149 R150 R151 R152
1-216-841-11 1-216-829-11 1-216-841-11 1-216-812-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
47K 4.7K 47K 180 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
Q486 Q560 Q561 Q580 Q582
8-729-027-43 6-550-185-01 8-729-027-43 8-729-901-81 8-729-901-81
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC114EKA-T146 RT1P137P-TP-1 DTC114EKA-T146 2SC2412K-T-146-R 2SC2412K-T-146-R
R153 R155 R156 R157 R158
1-216-833-11 1-216-841-11 1-216-830-11 1-216-836-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 47K 5.6K 18K 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
Q584 Q585
8-729-027-43 TRANSISTOR DTC114EKA-T146 8-729-026-68 TRANSISTOR 2SD2525 (TP)
R159 R160 R161 R162 R163
1-469-125-21 1-216-851-11 1-216-821-11 1-216-833-11 1-216-833-11
FERRITE, EMI (SMD) (1608) METAL CHIP 330K METAL CHIP 1K METAL CHIP 10K METAL CHIP 10K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R164 R165 R166 R167 R168
1-216-864-11 1-469-125-21 1-216-833-11 1-216-825-11 1-216-835-11
SHORT CHIP 0 FERRITE, EMI (SMD) (1608) METAL CHIP 10K 5% METAL CHIP 2.2K 5% METAL CHIP 15K 5%
1/10W 1/10W 1/10W
R169 R172 R173 R174 R175
1-216-817-11 1-216-825-11 1-216-825-11 1-216-825-11 1-216-838-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 2.2K 2.2K 2.2K 27K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R176 R177 R178 R179 R180
1-216-829-11 1-216-830-11 1-216-819-11 1-216-825-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 5.6K 680 2.2K 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R181 R182 R183 R184 R186
1-216-819-11 1-216-827-11 1-216-827-11 1-216-827-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
680 3.3K 3.3K 3.3K 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
QQ 376315150 892498299
TEL 13942296513 < RESISTOR >
R101 R102 R103 R104 R105
1-216-812-11 1-216-825-11 1-216-833-11 1-216-841-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
180 2.2K 10K 47K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R106 R107 R108 R109 R110
1-216-830-11 1-216-829-11 1-216-825-11 1-216-836-11 1-216-851-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
5.6K 4.7K 2.2K 18K 330K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R111 R112 R113 R114 R115
1-216-821-11 1-216-833-11 1-216-833-11 1-216-864-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP METAL CHIP
1K 10K 10K 0 10K
5% 5% 5%
1/10W 1/10W 1/10W
5%
1/10W
R116 R117 R118 R119 R120
1-216-833-11 1-216-825-11 1-216-835-11 1-216-817-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 2.2K 15K 470 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R121 R122 R123 R124 R125
1-216-827-11 1-216-825-11 1-216-825-11 1-216-825-11 1-216-838-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.3K 2.2K 2.2K 2.2K 27K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
www
.
xiaoy u163. com R188 R189 R190 R191 R192
1-216-841-11 1-216-864-11 1-216-833-11 1-216-817-11 1-216-817-11
72 http://www.xiaoyu163.com
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
47K 0 10K 470 470
376315150 892498299
376315150 892498299
1-216-829-11 METAL CHIP 1-216-830-11 METAL CHIP
QQ
QQ
R126 R127
13942296513
13942296513
8-729-903-46 TRANSISTOR 2SB1132-P 8-729-027-43 TRANSISTOR DTC114EKA-T146
TEL
TEL
Q118 Q119
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 MAIN
Ref. No.
Part No.
Description
Remarks
4.7K 4.7K 1M 2.2K 680
1-469-125-21 1-469-125-21 1-216-841-11 1-216-809-11 1-216-809-11
FERRITE, EMI (SMD) (1608) FERRITE, EMI (SMD) (1608) METAL CHIP 47K 5% METAL CHIP 100 5% METAL CHIP 100 5%
1/10W 1/10W 1/10W
R204 R205 R207 R209 R210
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R212 R214 R215 R216 R220
1-216-809-11 1-216-864-11 1-216-821-11 1-216-813-11 1-216-809-11
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
100 0 1K 220 100
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
R221 R222 R224 R225 R226
1-216-809-11 1-216-809-11 1-216-809-11 1-216-839-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 33K 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R227 R230 R231 R244 R245
1-216-864-11 1-216-809-11 1-216-841-11 1-216-825-11 1-216-841-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 100 47K 2.2K 47K
5% 5% 5% 5%
R246 R267 R294 R295 R296
1-216-833-11 1-216-864-11 1-216-825-11 1-216-841-11 1-216-833-11
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
10K 0 2.2K 47K 10K
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
R301 R302 R303 R304 R305
1-216-833-11 1-216-837-11 1-216-845-11 1-216-835-11 1-216-843-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 22K 100K 15K 68K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R306 R308 R309 R310 R311
1-216-829-11 1-216-853-11 1-216-833-11 1-216-835-11 1-216-843-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 470K 10K 15K 68K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R312 R329 R330 R337 R338
1-216-853-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R340 R341 R354 R355 R372
1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R373
1-216-833-11 METAL CHIP
10K
5%
1/10W
www
.
1/10W 1/10W 1/10W 1/10W 1/10W
5% 5% 5%
1/10W 1/10W 1/10W (AR) 1/10W (E2, E51)
R393
1-216-821-11 METAL CHIP
1K
5%
R393
1-216-829-11 METAL CHIP
4.7K
5%
R394 R395 R397 R401
1-216-827-11 1-216-827-11 1-216-827-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.3K 3.3K 3.3K 100
5% 5% 5% 5%
1/10W (E3, AUS) 1/10W 1/10W 1/10W 1/10W
R402 R403 R404 R405 R406
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R407 R411 R412 R413 R417
1-216-809-11 1-216-851-11 1-216-845-11 1-216-864-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP METAL CHIP
100 330K 100K 0 10K
5% 5% 5%
1/10W 1/10W 1/10W
5%
1/10W
R419 R420 R421 R422 R423
1-216-809-11 1-216-821-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 1K 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
QQ 376315150 892498299 1/10W 1/10W 1/10W 1/10W
R424 R425 R426 R427 R428
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R429 R430 R431 R432 R433
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R435 R436 R437 R438 R439
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R440 R441 R442 R443 R444
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R445 R446 R447 R448 R449
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R450 R451 R452 R453 R454
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
xiaoy u163. com
73 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
R198 R199 R200 R202 R203
TEL 13942296513
5% 5% 5% 5% 5%
Remarks
10K 10K 680
QQ
QQ
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
Description
1-216-833-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-819-11 METAL CHIP
13942296513
13942296513
1-216-829-11 1-216-829-11 1-216-857-11 1-216-825-11 1-216-819-11
Part No.
R374 R385 R393
TEL
TEL
R193 R194 R195 R196 R197
Ref. No.
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 MAIN
Ref. No.
MIC
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
Remarks
R460 R461 R463 R465 R472
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R473 R474 R476 R477 R478
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R479 R482 R483 R484 R485
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R486 R488 R489 R490 R491
1-216-825-11 1-216-825-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 2.2K 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R492 R493
1-216-864-11 SHORT CHIP 1-216-815-11 METAL CHIP
0 330
5%
R493
1-216-823-11 METAL CHIP
1.5K
R493
1-216-829-11 METAL CHIP
4.7K
R494
1-216-813-11 METAL CHIP
220
1/10W (E3) 5% 1/10W (AUS) 5% 1/10W (E2, E51, AR) 5% 1/10W
R495 R497 R500 0 R506 R508
1-216-813-11 1-216-813-11 1-216-809-11 1-219-153-11 1-216-830-11
METAL CHIP METAL CHIP METAL CHIP FUSIBLE METAL CHIP
220 220 100 10 5.6K
5% 5% 5% 5% 5%
R509 R524 R525 R531 R532
1-216-829-11 1-216-821-11 1-216-845-11 1-216-833-11 1-216-827-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 1K 100K 10K 3.3K
R560 R563 R574 R575 R576
1-216-826-11 1-216-821-11 1-216-821-11 1-216-845-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
R577 R578 R579 R580 R581
1-216-845-11 1-216-829-11 1-216-827-11 1-216-827-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
www 1-216-827-11 1-216-827-11 1-216-830-11 1-216-833-11 1-216-830-11
R587 R590 R591 R592 R593
Part No.
Description
1-216-833-11 1-216-833-11 1-216-833-11 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
Remarks
10K 10K 10K 100K 100K
.
1/10W 1/10W 1/10W 1/10W 1/10W
< TRANSFORMER > T101
1-433-372-11 TRANSFORMER, BIAS OSCILLATION < VIBRATOR >
X401 1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz) X402 1-795-058-21 VIBRATOR, CERAMIC (5MHz) ************************************************************ A-1167-713-A MIC BOARD, COMPLETE ******************** < CAPACITOR > 1-107-826-11 1-100-597-91 1-109-864-91 1-119-772-11 1-162-970-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 0.1uF 68PF 47uF 0.01uF
10% 10% 2% 20% 10%
16V 25V 50V 35V 25V
C1406 C1407 C1408 C1409 C1410
1-124-589-11 1-124-589-11 1-126-163-11 1-126-160-11 1-126-160-11
ELECT ELECT ELECT ELECT ELECT
47uF 47uF 4.7uF 1uF 1uF
20% 20% 20% 20% 20%
16V 16V 50V 50V 50V
C1411 C1412 C1413 C1415 C1416
1-162-970-11 1-107-826-11 1-164-730-11 1-100-597-91 1-128-131-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0.01uF 0.1uF 0.0012uF 0.1uF 22uF
10% 10% 10% 10% 20%
25V 16V 50V 25V 50V
1/10W 1/10W 1/10W 1/4W 1/10W
C1418 C1419 C1424 C1427 C1429
1-164-392-11 1-162-968-11 1-100-597-91 1-165-908-11 1-124-463-00
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
390PF 0.0047uF 0.1uF 1uF 0.1uF
5% 10% 10% 10% 20%
50V 50V 25V 10V 50V
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C1430 C1433 C1434 C1435 C1436
1-124-463-00 1-162-923-11 1-124-261-00 1-126-176-11 1-162-968-11
ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP
0.1uF 47PF 10uF 220uF 0.0047uF
20% 5% 20% 20% 10%
50V 50V 50V 10V 50V
2.7K 1K 1K 100K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C1437 C1458 C1459 C1460 C1461
1-162-970-11 1-126-163-11 1-126-160-11 1-126-160-11 1-162-970-11
CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP
0.01uF 4.7uF 1uF 1uF 0.01uF
10% 20% 20% 20% 10%
25V 50V 50V 50V 25V
100K 4.7K 3.3K 3.3K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C1468 C1479 C1486 C1487
1-115-416-11 1-126-163-11 1-162-968-11 1-162-970-11
CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
0.001uF 4.7uF 0.0047uF 0.01uF
5% 20% 10% 10%
25V 50V 50V 25V
QQ 376315150 892498299
< DIODE >
xiaoy u163. com
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
5% 5% 5% 5% 5%
C1400 C1401 C1403 C1404 C1405
TEL 13942296513
R582 R583 R584 R585 R586
Ref. No.
3.3K 3.3K 5.6K 10K 5.6K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
D1400
8-719-069-54 DIODE UDZSTE-175.1B
74 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
100 180 100 100 100
QQ
QQ
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
13942296513
13942296513
Description
1-216-809-11 1-216-812-11 1-216-809-11 1-216-809-11 1-216-809-11
TEL
TEL
Part No.
R455 R456 R457 R458 R459
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 MIC
Ref. No.
Part No.
Description
Remarks
< IC >
IC1400 IC1401
6-709-116-01 IC TC9488FG 8-759-710-97 IC NJM4565M-D < JACK >
J1400 J1401 J1450
1-817-629-11 JACK (LARGE TYPE) (MIC 1) 1-794-702-11 JACK, HEADPHONE (PHONES) 1-817-629-11 JACK (LARGE TYPE) (MIC 2) < JUMPER RESISTOR > 1-216-864-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR1483 1-216-864-11 SHORT CHIP
0
Part No.
MOTOR(TB)
Description
PANEL
Remarks
R1441 R1442 R1443
1-216-864-11 SHORT CHIP 1-216-821-11 METAL CHIP 1-216-821-11 METAL CHIP
0 1K 1K
5% 5%
1/10W 1/10W
R1457 R1459 R1460 R1461 R1476
1-216-823-11 1-216-833-11 1-216-821-11 1-216-833-11 1-216-837-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1.5K 10K 1K 10K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1477 R1482 R1483 R1484 R1485
1-216-835-11 1-216-797-11 1-216-797-11 1-216-797-11 1-216-797-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
15K 10 10 10 10
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1486 R1492 R1493
1-216-829-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-821-11 METAL CHIP
4.7K 1K 1K
5% 5% 5%
1/10W 1/10W 1/10W
Q1400 Q1401 Q1450 Q1451
8-729-802-80 8-729-802-80 8-729-802-80 8-729-802-80
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
RV1400 1-223-983-11 RES, VAR, CARBON 50K (MIC 1 LEVEL) RV1401 1-223-983-11 RES, VAR, CARBON 50K (MIC 2 LEVEL) RV1402 1-223-983-11 RES, VAR, CARBON 50K (ECHO LEVEL) ************************************************************
2SC3661 2SC3661 2SC3661 2SC3661
1-687-133-12 MOTOR (LD) BOARD *****************
< RESISTOR > METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 100 100 100 330
5% 5% 5% 5% 5%
R1406 R1407 R1409 R1410 R1411
1-216-815-11 1-216-823-11 1-216-833-11 1-216-821-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
330 1.5K 10K 1K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1412 R1413 R1414 R1415 R1416
1-216-828-11 1-218-867-11 1-216-834-11 1-216-835-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.9K 6.8K 12K 15K 10K
5% 0.5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1417 R1418 R1422 R1424 R1425
1-216-833-11 1-216-821-11 1-216-864-11 1-216-864-11 1-216-833-11
METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP
10K 1K 0 0 10K
5% 5%
1/10W 1/10W
5%
1/10W
R1426 R1427 R1431 R1432 R1433
1-216-842-11 1-216-837-11 1-216-864-11 1-216-797-11 1-216-797-11
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
56K 22K 0 10 10
5% 5%
1/10W 1/10W
5% 5%
1/10W 1/10W
R1434 R1435 R1436 R1437 R1438
1-216-797-11 1-216-797-11 1-216-829-11 1-216-845-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
10 10 4.7K 100K 0
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R1439 R1440
1-216-825-11 METAL CHIP 1-216-826-11 METAL CHIP
2.2K 2.7K
5% 5%
1/10W 1/10W
TEL 13942296513
www
.
1/10W 1/10W 1/10W 1/10W 1/10W
************************************************************
QQ 376315150 892498299 1-687-134-12 MOTOR (TB) BOARD **************** < CONNECTOR >
CN742 1-784-727-11 CONNECTOR, FFC 5P ************************************************************ A-1167-711-A PANEL BOARD, COMPLETE ********************** < CAPACITOR > C1300 C1301 C1302 C1304 C1305
1-128-131-11 1-162-995-11 1-162-974-11 1-126-969-11 1-124-261-00
ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT
22uF 0.022uF 0.01uF 220uF 10uF
C1306 C1307 C1309 C1310 C1311
1-162-974-11 1-107-826-11 1-124-589-11 1-162-927-11 1-126-157-11
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT
C1312 C1313 C1314 C1315 C1316
1-115-416-11 1-115-416-11 1-115-416-11 1-115-416-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
xiaoy u163. com C1317 C1318 C1319 C1320 C1321
1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
20%
20% 20%
50V 50V 50V 50V 50V
0.01uF 0.1uF 47uF 100PF 10uF
10% 20% 5% 20%
50V 16V 16V 50V 16V
0.001uF 0.001uF 0.001uF 0.001uF 100PF
5% 5% 5% 5% 5%
25V 25V 25V 25V 50V
100PF 100PF 100PF 100PF 100PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
75 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1-216-829-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-815-11
QQ
QQ
R1401 R1402 R1403 R1404 R1405
13942296513
13942296513
< VARIABLE RESISTOR > < TRANSISTOR >
TEL
TEL
JR1401 JR1403 JR1417 JR1427 JR1433
Ref. No.
MOTOR(LD)
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 PANEL
Ref. No.
Part No.
Description
Remarks
C1322 C1323 C1324 C1325 C1326
1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100PF 100PF 100PF 100PF 100PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C1327 C1328 C1329 C1330 C1331
1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100PF 100PF 100PF 100PF 100PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C1357
1-107-826-11 CERAMIC CHIP
0.1uF
10%
16V
Description
Remarks
< RESISTOR >
R1305 R1307 R1308 R1311 R1313
1-215-871-11 1-216-829-11 1-216-821-11 1-216-825-11 1-216-814-11
METAL OXIDE METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 4.7K 1K 2.2K 270
5% 5% 5% 5% 5%
1W 1/10W 1/10W 1/10W 1/10W
< DIODE >
R1314 R1317 R1318 R1319 R1320
1-216-864-11 1-216-833-11 1-216-829-11 1-216-825-11 1-216-823-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 10K 4.7K 2.2K 1.5K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
DIODE DIODE DIODE DIODE DIODE
R1321 R1322 R1323 R1324 R1325
1-216-821-11 1-216-819-11 1-216-817-11 1-216-815-11 1-216-815-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 680 470 330 330
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1326 R1327 R1328 R1330 R1331
1-216-817-11 1-216-819-11 1-216-821-11 1-216-815-11 1-216-817-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 680 1K 330 470
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1332 R1345 R1346 R1347 R1348
1-216-819-11 1-216-809-11 1-216-821-11 1-216-817-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
680 100 1K 470 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1351 R1352 R1353 R1355 R1356
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1357 R1358 R1359 R1360 R1361
1-216-829-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 4.7K 4.7K 4.7K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
TEL 13942296513 QQ 376315150 892498299
6-501-193-01 6-501-193-01 6-501-193-01 6-501-193-01 6-500-809-01
1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 SELU5223C-STP15 ( ^/1 )
D1305 D1306 D1313
8-719-059-18 DIODE RD6.2FM-T1 6-501-193-01 DIODE 1SS355WTE-17 6-501-228-01 DIODE SELU5420E-STP15 (SUB WOOFER ON/OFF) 6-501-193-01 DIODE 1SS355WTE-17
TEL 13942296513 < FLUORESCENT INDICATOR >
FL1300 1-519-859-11 VACUUM FLUORESCENT DISPLAYS < IC > 6-709-115-11 IC NJU3427FA2 < JUMPER RESISTOR > JR1305 1-216-864-11 SHORT CHIP
0
< COIL > 1-410-671-31 INDUCTOR
47uH
< TRANSISTOR > Q1300 Q1303 Q1304 Q1305 Q1306
6-550-065-01 8-729-903-46 8-729-903-46 8-729-027-50 8-729-027-50
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
CPH5504-TL-E 2SB1132-P 2SB1132-P DTC123JKA-T146 DTC123JKA-T146
Q1307 Q1308 Q1309 Q1310 Q1311
8-729-027-50 8-729-027-43 8-729-027-50 8-729-027-43 8-729-027-56
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC123JKA-T146 DTC114EKA-T146 DTC123JKA-T146 DTC114EKA-T146 DTC143TKA-T146
Q1312 Q1313 Q1314
8-729-027-56 TRANSISTOR DTC143TKA-T146 8-729-027-56 TRANSISTOR DTC143TKA-T146 8-729-027-56 TRANSISTOR DTC143TKA-T146
www
.
QQ 376315150 892498299
< SWITCH > S1300 S1301 S1302 S1307 S1309
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (DISPLAY) SWITCH, KEYBOARD ( ^/1 ) SWITCH, KEYBOARD (SUB WOOFER ON/OFF) SWITCH, KEYBOARD (TV) SWITCH, KEYBOARD (TAPE A/B)
S1310 S1311 S1312 S1313 S1314
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (X) SWITCH, KEYBOARD (B) SWITCH, KEYBOARD (DISC SKIP, EX-CHANGE) SWITCH, KEYBOARD (DISC 3) SWITCH, KEYBOARD (DISC 2)
S1315
1-762-875-21 SWITCH, KEYBOARD (DISC 1)
xiaoy u163. com
76 http://www.xiaoyu163.com
376315150 892498299
1/10W 1/10W 1/10W 1/10W 1/10W
QQ
5% 5% 5% 5% 5%
13942296513
3.3K 22K 22K 100 100
TEL
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
D1300 D1301 D1302 D1303 D1304
L1300
Part No.
8-729-027-56 TRANSISTOR DTC143TKA-T146 8-729-027-56 TRANSISTOR DTC143TKA-T146
1-216-827-11 1-216-837-11 1-216-837-11 1-216-809-11 1-216-809-11
CN1402 1-784-747-11 CONNECTOR, FFC 25P CN1452 1-785-337-11 PIN, CONNECTOR (LIGHT ANGLE) 11P CN1453 1-818-282-11 PIN, CONNECTOR (FOR PWB) 3P
IC1300
Q1315 Q1316
R1300 R1301 R1302 R1303 R1304
< CONNECTOR >
D1314
Ref. No.
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 Ref. No.
Part No.
Description
S1316 S1317 S1320 S1321
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD ( Z OPEN/CLOSE) SWITCH, KEYBOARD (x) SWITCH, KEYBOARD (DIRECTION) SWITCH, KEYBOARD (ILLUMINATION/SUB WOOFER LEVEL)
Remarks
S1322 S1323 S1324 S1325 S1326
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (TUNER/BAND) SWITCH, KEYBOARD (CD) SWITCH, KEYBOARD (CD SYNC) SWITCH, KEYBOARD (ALBUM- m) SWITCH, KEYBOARD (ALBUM+ M)
S1327
1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START) < TRANSFORMER >
1-162-979-11 CERAMIC CHIP
0.0027uF 10%
50V
C1149 C1200 0 C1202 0 C1203 0 C1206
1-104-663-11 1-165-136-11 1-107-444-11 1-100-566-91 1-162-923-11
ELECT CERAMIC CERAMIC CERAMIC CHIP CERAMIC CHIP
33uF 3300PF 100PF 0.1uF 47PF
20% 10% 5% 10% 5%
25V 500V 2KV 25V 50V
0 C1207 0 C1208 0 C1209 0 C1210 0 C1212
1-162-964-11 1-162-969-11 1-104-665-11 1-126-965-11 1-112-868-11
CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC
0.001uF 0.0068uF 100uF 22uF 330PF
10% 10% 20% 20% 10%
50V 25V 25V 50V 125V
C1213 C1214 C1216 C1217 C1218
1-135-372-11 1-100-566-91 1-128-951-21 1-100-566-91 1-100-566-91
ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
470uF 0.1uF 2200uF 0.1uF 0.1uF
20% 10% 20% 10% 10%
10V 25V 16V 25V 25V
C1219 C1221 C1222
1-100-566-91 CERAMIC CHIP 1-126-935-11 ELECT 1-126-964-11 ELECT
0.1uF 470uF 10uF
10% 20% 20%
25V 16V 50V
Ref. No.
C1148
Part No.
< CAPACITOR > MYLAR MYLAR CERAMIC CERAMIC ELECT (BLOCK)
0.22uF 0.22uF 330PF 330PF 390uF
10 10 10% 10% 20%
0 C1112
1-114-206-11 ELECT (BLOCK)
680uF
20%
0 C1113
1-114-206-11 ELECT (BLOCK)
0 C1115 C1116 0 C1117
1-112-867-11 CERAMIC 1-117-370-11 CERAMIC CHIP 1-112-335-91 FILM
0 C1118 0 C1119 0 C1120 0 C1121 0 C1122
1-112-841-11 1-100-566-91 1-162-925-11 1-126-949-11 1-162-967-11
CAP, METALIZED PP FILM CERAMIC CHIP 0.1uF CERAMIC CHIP 68PF ELECT 220uF CERAMIC CHIP 0.0033uF
820PF 10% 5% 20% 10%
25V 50V 35V 50V
C1123 C1124 C1125 C1126 C1127
1-136-203-11 1-100-623-91 1-165-761-21 1-165-761-21 1-165-744-11
MYLAR CERAMIC CHIP ELECT ELECT ELECT
0.01uF 0.1uF 1200uF 1200uF 1200uF
5% 10% 20% 20% 20%
630V 100V 63V 63V 35V
C1129 C1130 C1131 C1134 C1135
1-100-566-91 1-162-966-11 1-164-362-11 1-131-976-11 1-128-555-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT
0.1uF 0.0022uF 470PF 820uF 470uF
10% 10% 5% 20% 20%
25V 50V 50V 25V 63V
C1136 C1137 C1138 C1139 C1140
1-128-555-11 1-100-623-91 1-126-935-11 1-100-566-91 1-115-339-11
ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
470uF 0.1uF 470uF 0.1uF 0.1uF
20% 10% 20% 10% 10%
63V 100V 16V 25V 50V
C1147
1-128-551-11 ELECT
22uF
20%
63V
TEL 13942296513
275V 275V 125V 125V 450V (AR,AUS)
< DIODE >
QQ 376315150 892498299
220V (E2, E3, E51) 680uF 20% 220V (E2, E3, E51) 220PF 10% 125V 10uF 10V 0.0033uF 5% 400V
0 D1100 0 D1101 0 D1102 0 D1103 0 D1106
8-719-082-57 6-501-496-01 6-501-496-01 6-500-241-01 8-719-030-33
DIODE DIODE DIODE DIODE DIODE
D5SBA60F01 R4KLB-LF015-303 (E2, E3, E51) R4KLB-LF015-303 (E2, E3, E51) SARS03 EG01CV1
0 D1107 0 D1108 0 D1109 0 D1110 0 D1111
8-719-947-79 8-719-947-79 8-719-947-79 8-719-063-74 8-719-083-52
DIODE DIODE DIODE DIODE DIODE
MTZJ-T-72-22D MTZJ-T-72-22D MTZJ-T-72-22D D1NL20U-TR2 UDZSTE-1716B
0 D1112 D1113 D1114 D1115 D1116
8-719-063-74 6-501-398-01 6-501-411-01 8-719-069-54 8-719-080-53
DIODE DIODE DIODE DIODE DIODE
D1NL20U-TR2 FCH20A20 SF20NC15M UDZSTE-175.1B RK36LF-B3
D1117 0 D1118 0 D1119 D1120 D1122
8-719-947-79 6-500-593-41 8-719-063-74 8-719-069-54 8-719-071-94
DIODE DIODE DIODE DIODE DIODE
MTZJ-T-72-22D 10EDB60-TA2B5 D1NL20U-TR2 UDZSTE-175.1B HRU0103ATRF
0 D1200 0 D1202 0 D1203 0 D1204 0 D1205
6-500-849-01 8-719-063-74 8-719-947-79 8-719-063-74 8-719-947-79
DIODE DIODE DIODE DIODE DIODE
ERA22-08KFLB D1NL20U-TR2 MTZJ-T-72-22D D1NL20U-TR2 MTZJ-T-72-22D
0 D1206 0 D1207 0 D1208 0 D1211 D1212
8-719-947-79 8-719-063-74 8-719-083-61 8-719-063-74 6-501-412-01
DIODE DIODE DIODE DIODE DIODE
MTZJ-T-72-22D D1NL20U-TR2 UDZSTE-1711B D1NL20U-TR2 SF5S6
376315150 892498299
376315150 892498299
1-165-529-11 1-165-529-11 1-112-868-11 1-112-868-11 1-112-529-11
* CN1101 1-564-243-11 PIN, CONNECTOR (3.96mm PITCH) 6P * CN1200 1-564-510-11 PLUG, CONNECTOR 7P CNP1100 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
QQ
QQ
0 C1101 0 C1107 0 C1109 0 C1110 0 C1112
.
Remarks
< CONNECTOR >
1-533-313-11 FUSE HOLDER
www
Description
13942296513
13942296513
A-1167-594-A POWER BOARD, COMPLETE (E2, E3, E51) A-1183-818-A POWER BOARD, COMPLETE (AUS) A-1183-905-A POWER BOARD, COMPLETE (AR) *********************
POWER
TEL
TEL
T1300 1-443-894-11 DC/DC CONVERTER TRANSFORMER ************************************************************
PANEL
xiaoy u163. com
77 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 POWER
Ref. No.
D1213
Part No.
Description
Remarks
Ref. No.
Part No.
Description
Remarks
< RESISTOR >
8-719-080-53 DIODE RK36LF-B3
10% 5% 5% 5%
1W 3W 3W 1W
TERMINAL, EARTH TERMINAL, EARTH TERMINAL, EARTH TERMINAL, EARTH TERMINAL, EARTH
0 R1109 0 R1110 0 R1111 0 R1112 0 R1113
1-243-665-11 1-216-835-11 1-216-838-11 1-216-841-11 1-249-389-11
METAL METAL CHIP METAL CHIP METAL CHIP CARBON
0.05 15K 27K 47K 4.7
5% 5% 5% 5% 5%
5W 1/10W 1/10W 1/10W 1/4W
* EP1105 1-537-738-21 TERMINAL, EARTH * EP1106 1-537-738-21 TERMINAL, EARTH * EP1200 1-537-738-21 TERMINAL, EARTH
1-216-837-11 1-216-829-11 1-216-864-11 1-218-859-11 1-246-097-31
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL OXIDE
22K 4.7K 0 3.3K 1
5% 5%
1/10W 1/10W
< IC >
0 R1114 0 R1115 0 R1116 R1117 0 R1118
0.5% 5%
1/10W 2W
IC IC IC IC IC
0 R1120 R1121 R1122 R1123 R1124
1-219-769-11 1-218-867-11 1-218-855-11 1-218-861-11 1-218-889-11
METAL METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.3M 6.8K 2.2K 3.9K 56K
5% 0.5% 0.5% 0.5% 0.5%
1/2W 1/10W 1/10W 1/10W 1/10W
R1126 R1127 R1128 R1129 R1130
1-216-864-11 1-216-841-11 1-218-853-11 1-218-867-11 1-218-867-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 47K 1.8K 6.8K 6.8K
5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W
R1131 R1132 R1133 R1135 R1136
1-216-833-11 1-216-833-11 1-216-833-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP
10K 10K 10K 0 0
5% 5% 5%
1/10W 1/10W 1/10W
0 R1137 0 R1138 R1139 R1140 0 R1141
1-247-895-00 1-247-895-00 1-216-833-11 1-216-821-11 1-216-831-11
CARBON CARBON METAL CHIP METAL CHIP METAL CHIP
470K 470K 10K 1K 6.8K
5% 5% 5% 5% 5%
1/4W 1/4W 1/10W 1/10W 1/10W
0 R1142 R1144 R1145 R1146 0 R1200
1-216-841-11 1-216-833-11 1-216-809-11 1-218-867-11 1-215-904-61
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE
47K 10K 100 6.8K 100K
5% 5% 5% 0.5% 5%
1/10W 1/10W 1/10W 1/10W 2W
0 R1201 0 R1202 0 R1203 0 R1207 0 R1208
1-249-478-11 1-216-839-11 1-249-393-11 1-216-829-11 1-216-834-11
CARBON METAL CHIP CARBON METAL CHIP METAL CHIP
2.2 33K 10 4.7K 12K
5% 5% 5% 5% 5%
1/2W 1/10W 1/4W 1/10W 1/10W
0 R1209 0 R1210 0 R1211 R1212 0 R1214
1-216-825-11 1-216-835-11 1-216-821-11 1-216-833-11 1-249-381-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON
2.2K 15K 1K 10K 1
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/4W
R1215 R1216 R1217 R1218 R1219
1-216-821-11 1-216-813-11 1-216-841-11 1-218-867-11 1-218-855-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 220 47K 6.8K 2.2K
5% 5% 5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1220
1-218-831-11 METAL CHIP
220
0.5%
1/10W
* * * * *
EP1100 EP1101 EP1102 EP1103 EP1104
TEL 13942296513
0 IC1100 IC1101 IC1102 0 IC1200 IC1201
1-537-738-21 1-537-738-21 1-537-738-21 1-537-738-21 1-537-738-21
6-709-168-01 6-707-743-01 6-701-021-01 6-707-962-01 6-707-743-01
MR5060 TA76L431S (TPE6, Q) SI-8120JF MR1722 TA76L431S (TPE6, Q)
< JUMPER RESISTOR >
QQ
JR1101 JR1103 JR1105 JR1106 JR1107
1-216-864-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11
376315150 892498299
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
0 JR1108 1-216-296-11 SHORT CHIP
0
TEL 13942296513 < COIL >
L1100 L1102 L1200 L1201
1-457-058-21 1-456-545-11 1-410-470-11 1-456-545-11
COIL, CHOKE INDUCTOR INDUCTOR INDUCTOR
10uH 100uH 10uH 100uH
QQ 376315150 892498299
< LINE FILTER > 0 LF1100 1-457-268-11 LINE FILTER COIL (AUS) 0 LF1101 1-457-268-11 LINE FILTER COIL < PHOTO COUPLER > 0 PC1100 0 PC1101 0 PC1102 0 PC1200
6-600-438-01 6-600-438-01 6-600-438-01 6-600-438-01
IC IC IC IC
TLP421F (D4-GR) TLP421F (D4-GR) TLP421F (D4-GR) TLP421F (D4-GR)
< TRANSISTOR > Q1100 Q1101 0 Q1102 0 Q1200 Q1203 Q1204 Q1205 Q1206
8-729-271-31 8-729-271-31 8-729-271-31 8-729-271-31 6-551-460-01
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2713-G 2SC2713-G 2SC2713-G 2SC2713-G RSR25P03TL
8-729-271-31 TRANSISTOR 2SC2713-G 8-729-271-31 TRANSISTOR 2SC2713-G 6-551-460-01 TRANSISTOR RSR25P03TL
www
.
xiaoy u163. com
78 http://www.xiaoyu163.com
376315150 892498299
0.1 100K 100K 0.33
QQ
FUSIBLE METAL OXIDE METAL OXIDE METAL OXIDE
13942296513
1-220-886-11 1-215-929-11 1-215-929-11 1-216-343-00
8-719-921-40 DIODE MTZJ-4.7C 8-719-947-79 DIODE MTZJ-T-72-22D
TEL
< EARTH TERMINAL >
0 R1103 0 R1105 0 R1106 0 R1108
0 D1214 D1215
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 POWER
Ref. No.
Part No.
Description
R1221 0 R1223 0 R1224 R1225
1-218-861-11 1-216-833-11 1-216-843-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.9K 10K 68K 100
0.5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
Remarks
R1226 R1227 R1228 R1229 R1230
1-216-857-11 1-216-845-11 1-216-815-11 1-216-833-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1M 100K 330 10K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
0 R1231 R1232 R1233 R1234
1-215-866-11 1-216-833-11 1-216-833-11 1-216-841-11
METAL OXIDE METAL CHIP METAL CHIP METAL CHIP
330 10K 10K 47K
5% 5% 5% 5%
1W 1/10W 1/10W 1/10W
0 SW1100 1-762-753-11 SWITCH, VOLTAGE SELECTION (VOLTAGE SELECTOR) (E2,E3,E51)
0 T1100 0 T1200
1-443-893-11 POWER TRANSFORMER 1-443-895-11 POWER TRANSFORMER < THERMISTOR >
0 TH1100 1-805-841-21 THERMISTOR, NTC 3.0
Description
Remarks
0.001uF
10%
50V
C525 C526 C527 C528
1-162-964-11 1-162-962-11 1-162-962-11 1-162-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.001uF 470PF 470PF 0.001uF
10% 10% 10% 10%
50V 50V 50V 50V
C529 C531 C532 C533 C534
1-162-964-11 1-107-826-11 1-107-826-11 1-104-662-91 1-107-826-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.001uF 0.1uF 0.1uF 22uF 0.1uF
10% 10% 10% 20% 10%
50V 16V 16V 25V 16V
C535 C536 C537 C538 C544
1-107-826-11 1-100-436-91 1-100-623-91 1-114-119-31 1-100-623-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 0.033uF 0.1uF 120uF 0.1uF
10% 10% 10% 20% 10%
16V 25V 100V 63V 100V
C545 C547 C548 C549 C551
1-114-119-31 1-100-436-91 1-100-623-91 1-135-632-51 1-107-826-11
ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
120uF 0.033uF 0.1uF 2200uF 0.1uF
20% 10% 10% 20% 10%
63V 25V 100V 63V 16V
C552 C553 C554 C555 C556
1-107-826-11 1-124-248-00 1-107-826-11 1-107-826-11 1-100-436-91
CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 22uF 0.1uF 0.1uF 0.033uF
10% 20% 10% 10% 10%
16V 25V 16V 16V 25V
C557 C558 C564 C565 C567
1-100-623-91 1-114-119-31 1-100-623-91 1-114-119-31 1-100-436-91
CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 120uF 0.1uF 120uF 0.033uF
10% 20% 10% 20% 10%
100V 63V 100V 63V 25V
C568 C569 C574 C575 C576
1-100-623-91 1-135-632-51 1-114-160-91 1-114-160-91 1-114-160-91
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC
0.1uF 2200uF 1uF 1uF 1uF
10% 20% 10% 10% 10%
100V 63V 100V 100V 100V
C577 C578 C579 C580 C581
1-114-160-91 1-162-964-11 1-162-964-11 1-135-618-11 1-125-898-91
CHIP CERAMIC CERAMIC CHIP CERAMIC CHIP MYLAR CERAMIC CHIP
1uF 0.001uF 0.001uF 1uF 0.22uF
10% 10% 10% 5% 10%
100V 50V 50V 63V 50V
C582 C583 C584 C585 C586
1-162-966-11 1-162-966-11 1-135-618-11 1-125-898-91 1-162-966-11
CERAMIC CHIP CERAMIC CHIP MYLAR CERAMIC CHIP CERAMIC CHIP
0.0022uF 0.0022uF 1uF 0.22uF 0.0022uF
10% 10% 5% 10% 10%
50V 50V 63V 50V 50V
C587 C590 C591 C592 C593
1-162-966-11 1-135-618-11 1-125-898-91 1-162-966-11 1-162-966-11
CERAMIC CHIP MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.0022uF 1uF 0.22uF 0.0022uF 0.0022uF
10% 5% 10% 10% 10%
50V 63V 50V 50V 50V
C594 C595 C596 C597 C604
1-135-618-11 1-125-898-91 1-162-966-11 1-162-966-11 1-107-826-11
MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 0.22uF 0.0022uF 0.0022uF 0.1uF
5% 10% 10% 10% 10%
63V 50V 50V 50V 16V
C605
1-107-826-11 CERAMIC CHIP
0.1uF
10%
16V
< VARISTOR >
QQ 376315150 892498299
TEL 13942296513
0 VD1100 1-805-482-11 VARISTOR ************************************************************ 1-687-132-12 SENSOR BOARD ************
< CONNECTOR > CN731
1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P < IC >
IC731 6-600-022-01 IC RPI-576 ************************************************************ A-1164-113-A SMASTER BOARD, COMPLETE *********************** < CAPACITOR > C504 C505 C506 C507 C508
1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
10% 10% 10% 10% 10%
16V 16V 16V 16V 16V
C509 C510 C511 C512 C513
1-104-658-91 1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100uF 0.1uF 0.1uF 0.1uF 0.1uF
20% 10% 10% 10% 10%
10V 16V 16V 16V 16V
C520 C521 C522 C523
1-162-964-11 1-162-964-11 1-162-964-11 1-162-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.001uF 0.001uF 0.001uF 0.001uF
10% 10% 10% 10%
50V 50V 50V 50V
www
.
xiaoy u163. com
79 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1-162-964-11 CERAMIC CHIP
QQ
QQ
C524
13942296513
13942296513
< TRANSFORMER >
Part No.
SMASTER
TEL
TEL
< SWITCH >
Ref. No.
SENSOR
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 SMASTER
Ref. No.
10% 10% 10% 20% 10% 10% 10% 10%
16V 16V 16V 10V 16V 16V 16V 16V
Remarks
C620 C621 C622 C623 C626
1-162-964-11 1-162-964-11 1-162-964-11 1-162-964-11 1-162-962-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.001uF 0.001uF 0.001uF 0.001uF 470PF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C629 C651 C652 C653 C654
1-162-964-11 1-107-826-11 1-107-826-11 1-104-662-91 1-107-826-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.001uF 0.1uF 0.1uF 22uF 0.1uF
10% 10% 10% 20% 10%
50V 16V 16V 25V 16V
C655 C656 C657 C658 C664
1-107-826-11 1-100-436-91 1-100-623-91 1-114-119-31 1-100-623-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 0.033uF 0.1uF 120uF 0.1uF
10% 10% 10% 20% 10%
16V 25V 100V 63V 100V
C665 C667 C668 C669 C676
1-114-119-31 1-100-436-91 1-100-623-91 1-135-632-51 1-114-160-91
ELECT CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC
120uF 0.033uF 0.1uF 2200uF 1uF
20% 10% 10% 20% 10%
63V 25V 100V 63V 100V
C677 C690 C691 C692 C693
1-114-160-91 1-135-618-11 1-125-898-91 1-162-966-11 1-162-966-11
CHIP CERAMIC MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 1uF 0.22uF 0.0022uF 0.0022uF
10% 5% 10% 10% 10%
100V 63V 50V 50V 50V
C694 C695 C696 C697 C800
1-135-618-11 1-125-898-91 1-162-966-11 1-162-966-11 1-124-248-00
MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
1uF 0.22uF 0.0022uF 0.0022uF 22uF
5% 10% 10% 10% 20%
C801 C802 C803 C804 C805
1-162-970-11 1-162-910-11 1-162-964-11 1-162-915-11 1-104-658-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0.01uF 5PF 0.001uF 10PF 100uF
C806 C809 C810 C811 C830
1-162-970-11 1-107-826-11 1-104-658-91 1-162-970-11 1-126-964-11
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT
0.01uF 0.1uF 100uF 0.01uF 10uF
C840 C850 C855 C865 C871
1-164-337-11 1-117-370-11 1-117-370-11 1-117-370-11 1-216-864-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP SHORT CHIP
2.2uF 10uF 10uF 10uF 0
www 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-107-826-11
Description
Remarks
C879 C880 C881 C882 C883
1-216-864-11 1-162-927-11 1-162-927-11 1-162-927-11 1-126-925-91
SHORT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0 100PF 100PF 100PF 470uF
5% 5% 5% 20%
50V 50V 50V 10V
C884 C885 C886 C887 C888
1-162-927-11 1-162-927-11 1-126-935-11 1-126-925-91 1-119-774-11
CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT
100PF 100PF 470uF 470uF 100uF
5% 5% 20% 20% 20%
50V 50V 16V 10V 16V
C889 C890 C891 C892
1-107-826-11 1-119-774-11 1-107-826-11 1-162-927-11
CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
0.1uF 100uF 0.1uF 100PF
10% 20% 10% 5%
16V 16V 16V 50V
< CONNECTOR > CN500 * CN501 * CN502 CN503
1-784-780-11 1-564-712-11 1-564-243-11 1-564-705-11
CONNECTOR, FFC 19P PIN, CONNECTOR (SMALL TYPE) 10P PIN, CONNECTOR (3.96mm PITCH) 6P PIN, CONNECTOR (SMALL TYPE) 3P < DIODE >
6-501-484-01 6-501-484-01 6-501-485-01 6-501-485-01 6-501-484-01
DIODE DIODE DIODE DIODE DIODE
P6SMB62AT3 P6SMB62AT3 EC10UA20 EC10UA20 P6SMB62AT3
D554 D555 D556 D653 D654
6-501-484-01 6-501-485-01 6-501-485-01 6-501-484-01 6-501-484-01
DIODE DIODE DIODE DIODE DIODE
P6SMB62AT3 EC10UA20 EC10UA20 P6SMB62AT3 P6SMB62AT3
63V 50V 50V 50V 25V
D655 D656 D820 D880 D881
6-501-485-01 6-501-485-01 8-719-988-61 1-216-295-91 1-216-295-91
DIODE EC10UA20 DIODE EC10UA20 DIODE 1SS355TE-17 SHORT CHIP 0 SHORT CHIP 0
10% 0.25PF 10% 0.5PF 20%
25V 50V 50V 50V 10V
D882 D883 D884 D885 D888
1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
10% 10% 20% 10% 20%
25V 16V 10V 25V 50V
D889 D890 D891 D892 D893
1-216-295-91 1-216-295-91 1-216-295-91 8-719-988-61 8-719-988-61
SHORT CHIP 0 SHORT CHIP 0 SHORT CHIP 0 DIODE 1SS355TE-17 DIODE 1SS355TE-17
16V 10V 10V 10V
D895 D896
1-216-295-91 SHORT CHIP 1-216-295-91 SHORT CHIP
QQ 376315150 892498299
0 0 0 0 0
0 0
< EARTH TERMINAL > EP880 EP881 EP882 EP884 EP885
1-537-738-21 1-537-738-21 1-537-738-21 1-537-738-21 1-537-738-21
TERMINAL, GROUND TERMINAL, GROUND TERMINAL, GROUND TERMINAL, GROUND TERMINAL, GROUND
xiaoy u163. com
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP CERAMIC CHIP
.
Part No.
D533 D534 D535 D536 D553
TEL 13942296513
C872 C873 C876 C877 C878
Ref. No.
0 0 0 0 0.1uF
10%
16V
80 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
0.1uF 0.1uF 0.1uF 100uF 0.1uF 0.1uF 0.1uF 0.1uF
QQ
QQ
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
13942296513
13942296513
Description
1-107-826-11 1-107-826-11 1-107-826-11 1-104-658-91 1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11
TEL
TEL
Part No.
C606 C607 C608 C609 C610 C611 C612 C613
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 SMASTER
Ref. No.
EP886
Part No.
Description
Remarks
1-537-738-21 TERMINAL, GROUND
Ref. No.
Part No.
Description
Remarks
R517 R519
1-216-809-11 METAL CHIP 1-216-821-11 METAL CHIP
100 1K
5% 5%
1/10W 1/10W
R520 R521 R523 R524 R526
1-216-821-11 1-216-821-11 1-216-864-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP
1K 1K 0 0 0
5% 5%
1/10W 1/10W
R529 R530 R531 R532 R533
1-216-864-11 1-216-797-11 1-216-809-11 1-216-821-11 1-216-809-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 10 100 1K 100
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R535 R541 R542 R547 R548
1-216-839-11 1-216-797-11 1-216-797-11 1-219-107-91 1-219-107-91
METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP
33K 10 10 1.5 1.5
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/8W 1/8W
R549 R550 R551 R552 R553
1-216-791-11 1-216-797-11 1-216-809-11 1-216-821-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.3 10 100 1K 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R555 R557 R558 R559 R560
1-216-839-11 1-216-142-00 1-216-142-00 1-216-142-00 1-216-142-00
METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP
33K 4.7 4.7 4.7 4.7
5% 5% 5% 5% 5%
1/10W 1/8W 1/8W 1/8W 1/8W
R561 R562 R567 R568 R569
1-216-797-11 1-216-797-11 1-219-107-91 1-219-107-91 1-216-791-11
METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP
10 10 1.5 1.5 3.3
5% 5% 5% 5% 5%
1/10W 1/10W 1/8W 1/8W 1/10W
R581 R583 R591 R593 R600
1-216-790-11 1-216-790-11 1-216-790-11 1-216-790-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
2.7 2.7 2.7 2.7 0
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R601 R602 R603 R605 R606
1-216-864-11 1-216-833-11 1-216-809-11 1-216-817-11 1-216-817-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 10K 100 470 470
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R607 R609 R610 R612 R615
1-216-817-11 1-216-864-11 1-216-864-11 1-216-833-11 1-216-864-11
METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP SHORT CHIP
470 0 0 10K 0
5%
1/10W
5%
1/10W
R616 R617 R619 R620 R621
1-216-809-11 1-216-809-11 1-216-821-11 1-216-821-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 1K 1K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
0 0 10 100 1K
5% 5% 5%
1/10W 1/10W 1/10W
< FERRITE BEAD >
FB800 FB801 FB881
1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP 1-216-295-91 SHORT CHIP
0 0 0
< FILTER > FL800 FL801 FL810
1-234-177-21 FILTER, CHIP EMI 1-234-177-21 FILTER, CHIP EMI 1-234-177-21 FILTER, CHIP EMI < IC > IC IC IC IC IC
CXD9843AR CXD9879M CXD9879M CXD9843AR CXD9879M
IC800 IC802 IC810 IC880
6-701-189-01 6-701-189-01 6-700-263-01 8-759-422-21
IC IC IC IC
MC74VHC1GU04DFT1 MC74VHC1GU04DFT1 NJM2870F18 (TE2) NJM4580V (TE2)
< COIL > CHOKE COIL CHOKE COIL CHOKE COIL CHOKE COIL CHOKE COIL
10uH 10uH 10uH 10uH 10uH
L691 L800 L801 L802
1-457-237-11 1-216-295-91 1-412-939-11 1-216-295-91
CHOKE COIL SHORT CHIP INDUCTOR SHORT CHIP
10uH 0 1uH 0
QQ 376315150 892498299
TEL 13942296513 < TRANSISTOR > Q840 Q850 Q851 Q855 Q856
8-729-120-28 8-729-602-36 8-729-602-36 8-729-602-36 8-729-602-36
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC1623-L5L6 2SA1602-F 2SA1602-F 2SA1602-F 2SA1602-F
Q865 Q866
8-729-602-36 TRANSISTOR 2SA1602-F 8-729-602-36 TRANSISTOR 2SA1602-F < RESISTOR >
R500 R501 R502 R503 R505
1-216-864-11 1-216-864-11 1-216-833-11 1-216-809-11 1-216-817-11
SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
0 0 10K 100 470
R506 R507 R509 R510 R511
1-216-817-11 1-216-817-11 1-216-864-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP
R512 R515 R516
1-216-833-11 METAL CHIP 1-216-864-11 SHORT CHIP 1-216-809-11 METAL CHIP
www
.
5% 5% 5%
1/10W 1/10W 1/10W
470 470 0 0 0
5% 5%
1/10W 1/10W
10K 0 100
5%
1/10W
5%
1/10W
xiaoy u163. com R623 R624 R650 R651 R652
1-216-864-11 1-216-864-11 1-216-797-11 1-216-809-11 1-216-821-11
SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
81 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1-457-237-11 1-457-237-11 1-457-237-11 1-457-237-11 1-457-237-11
QQ
QQ
L580 L581 L590 L591 L690
13942296513
13942296513
6-707-939-01 6-709-087-01 6-709-087-01 6-707-939-01 6-709-087-01
TEL
TEL
IC500 IC530 IC550 IC600 IC650
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 SMASTER
Ref. No.
SPEAKER
Part No.
SW
VOL
Description
Remarks
Ref. No.
Part No.
Description
Remarks
< VIBRATOR >
5% 5% 5% 5% 5%
1/10W 1/10W 1/8W 1/8W 1/10W
R662 R667 R668 R669 R691
1-216-797-11 1-219-107-91 1-219-107-91 1-216-791-11 1-216-790-11
METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP
10 1.5 1.5 3.3 2.7
5% 5% 5% 5% 5%
1/10W 1/8W 1/8W 1/10W 1/10W
R693 R800 R801 R802 R804
1-216-790-11 1-216-857-11 1-216-809-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP
2.7 1M 100 0 0
5% 5% 5%
1/10W 1/10W 1/10W
R805 R806 R807 R809 R811
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-845-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP METAL CHIP
0 0 0 0 100K
5%
1/10W
R820 R821 R822 R823 R840
1-216-837-11 1-216-823-11 1-216-837-11 1-216-837-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 1.5K 22K 22K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R841 R850 R851 R852 R855
1-216-864-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 100K 100K 100K 100K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R856 R857 R858 R859 R865
1-216-845-11 1-216-845-11 1-216-841-11 1-216-841-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 47K 47K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R866 R867 R868 R880 R881
1-216-845-11 1-216-845-11 1-216-841-11 1-216-837-11 1-216-837-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 47K 22K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R882 R883 R884 R885 R886
1-216-837-11 1-216-837-11 1-216-837-11 1-216-839-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
22K 22K 22K 33K 0
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R887 R888 R889 R890 R891
1-216-837-11 1-216-837-11 1-216-837-11 1-216-837-11 1-216-839-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 22K 22K 22K 33K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R892 R893 R894 R895
1-216-864-11 1-216-826-11 1-216-825-11 1-216-837-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
0 2.7K 2.2K 22K
5% 5% 5%
1/10W 1/10W 1/10W
X800 1-795-660-21 QUARTZ CRYSTAL UNIT (49.152MHz) ************************************************************ SPEAKER BOARD ************* < CAPACITOR > C1502 C1512 C1522 C1532 C1602
1-162-964-11 1-162-964-11 1-162-964-11 1-162-964-11 1-162-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.001uF 0.001uF 0.001uF 0.001uF 0.001uF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C1612
1-162-964-11 CERAMIC CHIP
0.001uF
10%
50V
< CONNECTOR > * CN1500 1-564-241-11 PIN, CONNECTOR (3.96mm PITCH) 4P CN1600 1-564-320-00 PIN, CONNECTOR (3.96mm PITCH) 2P
TEL 13942296513
www
< EARTH TERMINAL > * EP1500 1-537-738-21 TERMINAL, EARTH * EP1501 1-537-738-21 TERMINAL, EARTH < TERMINAL > TM1500 1-820-057-11 CONNECTOR (SPEAKER) 3P (SUB WOOFER, FRONT SPEAKER) ************************************************************
QQ 376315150 892498299 1-687-669-12 SW BOARD ********
< SWITCH > S751 1-786-514-31 SWITCH, LEVER (SLIDE) (OPEN) ************************************************************ VOL BOARD ********* < CAPACITOR > C1334
1-164-360-11 CERAMIC CHIP
0.1uF
16V
< DIODE > D1307 D1308 D1309 D1310 D1311
6-500-809-01 6-500-809-01 6-500-809-01 6-500-809-01 6-500-809-01
DIODE DIODE DIODE DIODE DIODE
SELU5223C-STP15 (LED 1) SELU5223C-STP15 (LED 2) SELU5223C-STP15 (LED 3) SELU5223C-STP15 (LED 6) SELU5223C-STP15 (LED 5)
D1312
6-500-809-01 DIODE SELU5223C-STP15 (LED 4) < JUMPER RESISTOR >
JR1300 1-216-864-11 SHORT CHIP JR1301 1-216-864-11 SHORT CHIP JR1302 1-216-864-11 SHORT CHIP
0 0 0
xiaoy u163. com < RESISTOR >
.
R1329
1-216-823-11 METAL CHIP
82 http://www.xiaoyu163.com
1.5K
5%
1/10W
376315150 892498299
376315150 892498299
100 33K 4.7 4.7 10
QQ
QQ
METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP
13942296513
13942296513
1-216-809-11 1-216-839-11 1-216-142-00 1-216-142-00 1-216-797-11
TEL
TEL
R653 R655 R657 R658 R661
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299 VOL
Ref. No.
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 1.5K 2.2K 4.7K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
Remarks
R1337 R1362 R1363 R1364 R1365
1-216-833-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 1K 1K 1K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1366 R1367 R1368 R1369 R1370
1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 1K 1K 1K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1371 R1372 R1373 R1374 R1375
1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 1K 1K 1K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R1376 R1377 R1378 R1379
1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 1K 1K 1K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
13942296513
13942296513
Description
1-216-821-11 1-216-823-11 1-216-825-11 1-216-829-11
TEL
TEL
Part No.
R1333 R1334 R1335 R1336
< SWITCH >
QQ 376315150 892498299
TEL 13942296513 S1306 S1318 S1319 S1328
376315150 892498299
376315150 892498299
1-418-725-41 ENCODER, ROTARY (12 TYPE) (MASTER VOLUME) 1-786-289-11 SWITCH, DETECTION (OPERATION DIAL) 1-762-875-21 SWITCH, KEYBOARD (EQ BAND/MEMORY) 1-762-875-21 SWITCH, KEYBOARD (MP3 BOOSTER) 1-762-875-21 SWITCH, KEYBOARD (PRESET EQ)
QQ
QQ
S1305
S1331 1-762-875-21 SWITCH, KEYBOARD (GROOVE) ************************************************************ MISCELLANEOUS ************** 7 10 11 12 66
1-693-702-11 1-775-250-11 1-829-030-11 1-827-720-11 1-417-656-11
TUNER (FM/AM) (TM10SE) WIRE (FLAT TYPE) (27 CORE) WIRE (FLAT TYPE) (25 CORE) WIRE (FLAT TYPE) (11 CORE) MECHA DECK (CWN42FF601)
106 0 108 0 108 0 108 0 108
1-500-497-11 1-783-941-12 1-827-226-31 1-829-259-11 1-830-188-11
FILTER, CLAMP (FERRITE CORE) CORD, POWER (AR) CORD, POWER (E2, E3) CORD, POWER (AUS) CORD, POWER (E51)
152 226 0 229 230 0 F1100
1-832-798-21 1-832-404-21 8-820-244-01 1-471-035-21 1-532-506-33
CABLE, FLEXIBLE FLAT (5 CORE) CABLE, FLEXIBLE FLAT (16 CORE) OPTICAL PICK-UP KSM-215DCP/C2NP MAGNET ASSY FUSE (T6.3AL/250V)
M741 M751 M891 S711
A-1108-965-A A-1108-966-A 1-763-372-11 1-477-680-12
MOTOR ASSY, TABLE (TABLE) MOTOR ASSY, LOADING (LOADING) FAN, DC ENCODER, ROTARY
www
.
xiaoy u163. com 83 http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-GNX600
QQ 376315150 892498299
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver.
Date
1.0
2006.04
Description of Revision New
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
