Hcd-hp7

Transcript

http://www.xiaoyu163.com HCD-HP7 892498299 376315150 QQSERVICE MANUAL US Model Canadian Model AEP Model UK Model E Model Australian Model Ver 1.1 2003. 11 TEL TEL Model Name Using Similar Mechanism CD Section CD Mechanism Type CDM69CH-K6BD71C Base Unit Name BU-K6BD71C Optical Pick-up Name KSM-213D Model Name Using Similar Mechanism HCD-EP515 CMAL1Z234A SPECIFICATIONS Main unit AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION: Other models: The following measured at AC 120, 127, 220, 240 V 50/60 Hz DIN power output (rated): 60 + 60 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 60 + 60 watts (6 ohms at 1 kHz, 10% THD) With 6 ohm loads, both channels driven, from 120 – 10,000 Hz: rated 60 watts per channel minimum RMS power, with no more than 10% total harmonic distortion from 250 milliwatts to rated output. Inputs MD IN (phono jacks): 9-877-349-02 2003K16-1 © 2003.11 Laser Frequency response Wavelength Signal-to-noise ratio Dynamic range Compact disc and digital audio system Semiconductor laser (λ=780 nm) Emission duration: continuous 2 Hz – 20 kHz (±0.5 dB) 780 – 790 nm More than 90 dB More than 90 dB Sensitivity 250 mV, impedance 47 kilohms Amplifier section North American model: Continuous RMS power output (reference): 60 + 60 watts (6 ohms at 1 kHz, 10% THD) Total harmonic distortion less than 0.7% (6 ohms at 1 kHz, 30 W) European and Russian models: DIN power output (rated): 60 + 60 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 60 + 60 watts (6 ohms at 1 kHz, 10% THD) Music power output (reference): 120 + 120 watts (6 ohms at 1 kHz, 10% THD) www CD player section System Outputs PHONES (stereo minijack): accepts headphones of 8 ohms or more OPTICAL CD DIGITAL OUT (Supported sampling frequency: 44.1 kHz) SPEAKER: accepts impedance of 6 to 16 ohms. Tape deck section Recording system Frequency response x aoy u163. com 4-track 2-channel, stereo 50 – 13,000 Hz (±3 dB), using Sony TYPE I cassettes MICRO HI-FI COMPONENT SYSTEM .Sony Corporation i Home Audio Company Published by Sony Engineering Corporation http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 Tape Transport Mechanism Type QQ QQ TAPE Section NEW 13942296513 13942296513 HCD-HP7 is the Amplifier, CD player, Tape Deck and Tuner section in CMT-HP7. http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 General Power requirements North American model: 120 V AC, 60 Hz European and Russian models: 230 V AC, 50/60 Hz Australian model: 230 – 240 V AC, 50/60 Hz Mexican model: 120 V AC, 60 Hz Other models: 120 V, 220 V or 230 – 240 V AC, 50/60 Hz Adjustable with voltage selector Power consumption European and Russian models: 100 watts 0.35 watts (at the Power Saving Mode) Other models: 100 watts Approx. 199 252 400 mm Mass Approx. 7.0 kg Supplied accessories: Remote Commander (1) Batteries (2) AM loop antenna (1) FM lead antenna (1) Speaker pads (8) Design and specifications are subject to change without notice. xiaoy u163. com COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. . ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPÉMENTS PUBLIÉS PAR SONY. 2 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www SAFETY-RELATED COMPONENT WARNING!! QQ QQ QQ 376315150 892498299 TEL 13942296513 13942296513 13942296513 Dimensions (w/h/d) TEL TEL Tuner section FM stereo, FM/AM superheterodyne tuner FM tuner section Tuning range Russian model: 65.0 – 74.0 MHz (There is no stereo effect) 87.5 – 108.0 MHz Other models: 87.5 – 108.0 MHz Antenna FM lead antenna Antenna terminals 75 ohms unbalanced Intermediate frequency 10.7 MHz AM tuner section Tuning range Pan-American model: 530 – 1,710 kHz (with the tuning interval set at 10 kHz) 531 – 1,710 kHz (with the tuning interval set at 9 kHz) European, Russian, Middle Eastern models: 531 – 1,602 kHz (with the tuning interval set at 9 kHz) Other models: 530 – 1,710 kHz (with the tuning interval set at 10 kHz) 531 – 1,602 kHz (with the tuning interval set at 9 kHz) Antenna AM loop antenna Antenna terminals External antenna terminal Intermediate frequency 450 kHz http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 QQ 376315150 892498299 TABLE OF CONTENTS 1. SERVICING NOTES ······················································· 4 6. MECHANICAL ADJUSTMENTS ····························· 23 2. GENERAL ·········································································· 6 7. ELECTRICAL ADJUSTMENTS ······························· 24 3. DISASSEMBLY 8. DIAGRAMS ······································································ 26 QQ 376315150 892498299 10.ELECTRICAL PARTS LIST ······································· 55 5. TEST MODE ···································································· 22 www . xiaoy u163. com 3 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 9-1. Case, Top Panel Section ·············································· 44 9-2. Front Panel Section ····················································· 45 9-3. Chassis Section-1 ························································ 46 9-4. Chassis Section-2 ························································ 47 9-5. CD Mechanism Section-1 (CDM69CH-K6BD71C) ··· 48 9-6. CD Mechanism Section-2 (CDM69CH-K6BD71C) ··· 49 9-7. CD Mechanism Section-3 (CDM69CH-K6BD71C) ··· 50 9-8. CD Mechanism Section-4 (CDM69CH-K6BD71C) ··· 51 9-9. CD Mechanism Section-5 (CDM69CH-K6BD71C) ··· 52 9-10. CD Mechanism Section-6 (CDM69CH-K6BD71C) ··· 53 9-11. Optical Pick-up Section (KSM-213D) ························ 54 QQ QQ 4-1. How to Install the Cam (Eject Lock) ···························· 18 4-2. How to Install the Cam (GEAR) ··································· 18 4-3. How to Install the Gear (MODE C) ······························ 19 4-4. How to Install the Gear (MODE CAM) ······················· 19 4-5. How to Install the Rotary Encoder (S702), Gear (STOCKER COMMUNICATION) ····················· 20 4-6. How to Install the Stocker Assy ···································· 20 9. EXPLODED VIEWS 13942296513 13942296513 4. ASSEMBLY 8-1. Block Diagram ···························································· 28 8-2. Printed Wiring Boards — BD Board — ······················ 29 8-3. Schematic Diagram — BD Board — ·························· 30 8-4. Printed Wiring Boards — Changer Section — ··········· 31 8-5. Schematic Diagram — Changer Section — ················ 32 8-6. Printed Wiring Boards — Main Section — ················· 33 8-7. Schematic Diagram — Main Section — ····················· 34 8-8. Printed Wiring Boards — Front Section — ················ 35 8-9. Schematic Diagram — Front Section — ····················· 36 8-10. Printed Wiring Boards — PWR AMP/Power Section — ································· 37 8-11. Schematic Diagram — PWR AMP/Power Section — ································· 38 8-12. IC Block Diagrams ······················································ 39 8-13. IC Pin Function Description ······································· 42 TEL TEL 3-1. Case (Side-L)(Side-R), Tape Mechanism Deck (CMAL1Z234A) ······················ 9 3-2. Front Panel Section ······················································· 9 3-3. Panel Board ································································· 10 3-4. Back Panel Section ······················································ 10 3-5. MAIN Board ······························································· 11 3-6. PWR AMP Board, Power Transformer ······················· 11 3-7. CD Mechanism Deck (CDM69CH-K6BD71C) ·········· 12 3-8. Base Unit Section ························································ 12 3-9. Base Unit (BU-K6BD71C) ········································· 13 3-10. BD Board ····································································· 13 3-12. SW Board, Bracket (Top) Assy ··································· 14 3-13. CONNECTOR Board ·················································· 15 3-14. Motor (Stocker) Assy (Stocker)(M761) ······················ 15 3-15. Motor (Roller) Assy (Roller)(M781) ··························· 16 3-16. Motor (Mode) Assy (Mode)(M771) ···························· 16 3-17. Rubber Roller (Slider) Assy ········································ 17 3-18. Timing Belt (Front/Rear) ············································· 17 3-19. Cam (Gear) ·································································· 18 3-20. SENSOR Board ··························································· 18 http://www.xiaoyu163.com HCD-HP7 SECTION 1 SERVICING NOTES QQ 376315150 892498299 Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270 ˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. 0.15 µF 1.5 k Ω AC voltmeter (0.75 V) Earth Ground Fig. A. Using an AC voltmeter to check AC leakage. www . The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. QQ 376315150 892498299 NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. LASER DIODE AND FOCUS SEARCH OPERATION CHECK Carry out the “S curve check” in “CD section adjustment” and check that the S curve waveforms is output three times. UNLEADED SOLDER Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size) : LEAD FREE MARK Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40 ˚C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350 ˚C . Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder. xiaoy u163. com 4 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 To Exposed Metal Parts on Set NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT QQ QQ TEL 13942296513 Laser component in this product is capable of emitting radiation exceeding the limit for Class 1. 13942296513 13942296513 LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes.). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A) This appliance is classified as a CLASS 1 LASER product. This label is located on the rear exterior. TEL TEL SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 Service Position of the Tape Cassette Mechanism Deck TEL TEL 13942296513 13942296513 QQ 376315150 892498299 376315150 892498299 376315150 892498299 Service Position of the CD Mechanism Deck QQ QQ TEL 13942296513 Connect jig (extension cable J-2501-248-A) to the MAIN board (CN302) and CONNECTOR board (CN701). www xiaoy u163. com Connect jig (extension cable J-2501-011-B) to the MAIN board (CN301) and BD board (CN710). . 5 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 SECTION 2 GENERAL QQ 376315150 892498299 This section is extracted from instruction manual. List of button locations and reference pages Main unit BUTTON DESCRIPTIONS ALPHABETICAL ORDER . xiaoy u163. com 6 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513 ?/1 (power) 1 (7, 8, 14, 20, 21, 29) m/M (rewind/fast forward) qa (10, 16) ./> (go back/go forward) qa (8, 10, 11, 16, 20, 21) x (stop) 5 (10, 16, 17, 21, 29) X (pause) 5 (10, 16) CD N (play) 5 (10, 12) TAPE nN (play) 5 (16, 17, 21) DISC 1 Z – DISC 5 Z (eject) qg (9, 10) 13942296513 CD SYNC 9 (17) DIMMER ql (23) DISC 1 – 5 qs (9, 10, 11, 29) Disc slot qf DISPLAY 6 (15, 22, 23, 29) Display window 3 FUNCTION w; (9, 11, 16, 17, 25) GROOVE qj (18) 13942296513 P–Z PHONES jack qd PLAY MODE 7 (9, 11, 16, 17, 21) PRESET EQ qk (18) PRESET/ALBUM +/– wa (10, 11, 13, 14) REC PAUSE/START 0 (17) Remote sensor 2 REPEAT 8 (11) Tape deck 4 TUNER/BAND 5 (13, 14, 17) TUNING +/– qa (13, 14) VOLUME qh (20) TEL TEL A–G http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 Remote control BUTTON DESCRIPTIONS ALPHABETICAL ORDER I–Z ILLUMINATION*2 qg PLAY MODE w; (9, 11, 16, 17, 21) PRESET EQ qj (18) PRESET +/– 5 (13, 14) REPEAT/FM MODE wa (11, 14) SLEEP 1 (20) SURROUND qa (19) TAPE A/B*3 9 (16, 17) TUNER BAND qk (13, 14, 17) TUNER MEMORY 8 (13) TUNING +/– 5 (13, 14) VOL +/– qs (20) ?/1 (power) 4 (7, 8, 20, 21, 29) m/M (rewind/fast forward) 5 (10, 16) ./> (go back/go forward) 5 (8, 10, 11, 16, 20, 21) x (stop) 5 (10, 16, 17, 21, 29) X (pause) 5 (10, 16) N (play) 5 (10, 12, 16) *1 *2 *3 This button is used to switch to MD function. This button cannot be used in this system. This button is used to switch to TAPE function. TEL TEL A–G ALBUM +/– qf (10, 11) CD ql (9, 11, 17) CLEAR 5 (12) CLOCK/TIMER SELECT 2 (21, 22) CLOCK/TIMER SET 3 (8, 20, 21) DISPLAY 6 (15, 22, 23, 29) D. SKIP 7 (10, 11) ENTER qh (8, 11, 13, 20, 21) GAME (MD)*1 q; (17, 25) GROOVE qd (18) 13942296513 13942296513 12 3 4 QQ 376315150 892498299 6 376315150 892498299 376315150 892498299 wa QQ QQ TEL 13942296513 5 7 w; ql qk qj qh 8 9 q; qa qs qg qd qf Setting the clock Use buttons on the remote for the operation. 1 2 3 4 5 6 Press ?/1 to turn on the system. Press CLOCK/TIMER SET. Press ./> repeatedly to set the hour. Press ENTER. Press ./> repeatedly to set the minute. Press ENTER. The clock starts working. To adjust the clock 1 Press CLOCK/TIMER SET. 2 Press ./> to select “CLOCK SET”, www then press ENTER. xiaoy u163. com 3 Do the same procedures as step 3 to 6 above. Note . The clock settings are canceled when you disconnect the power cord or if a power failure occurs. 7 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 SECTION 3 DISASSEMBLY QQ 376315150 892498299 • This set can be disassembled in the order shown below. SET CASE (SIDE-L) (SIDE-R), TAPE MECHANISM DECK (CMAL1Z234A)) BACK PANEL SECTION FRONT PANEL SECTION TEL TEL MAIN BOARD PANEL BOARD CD MECHANISM DECK (CDM69CH-K6BD71C) SW BOARD, BRACKET (TOP) ASSY BASE UNIT (BU-K6BD71C) MOTOR (ROLLER) ASSY (ROLLER) (M781) BD BOARD CONNECTOR BOARD QQ 376315150 892498299 RUBBER ROLLER (SLIDER) ASSY MOTOR (MODE) ASSY (MODE) (M771) TIMING BELT (FRONT/REAR) CAM (GEAR) SENSOR BOARD www . xiaoy u163. com 8 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 MOTOR (STOCKER) ASSY (STOCKER) (M761) QQ QQ BASE UNIT SECTION 13942296513 13942296513 PWR AMP BOARD, POWER TRANSFORMER http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 Note: Follow the disassembly procedure in the numerical order given. 3-1. Case (Side-L)(Side-R), Tape Mechanism Deck (CMAL1Z234A) 8 top panel section 5 two screws (BVTP3× 16) 4 four screws (case3 TP2) 7 two screws (BVTP3× 16) qd tape mechanism deck (CMAL1Z234A) qs shield plate (case) TEL TEL 9 connector (6p) 13942296513 13942296513 qa four screws (BVTP2.6× 8) q; wire (flat type) 8p 2 two screws (BVTP3× 16) 6 case (side-L) QQ QQ 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 1 four screws (case3 TP2) 3 case (side-R) 3-2. Front Panel Section 2 wire (flat type) 9p (CN303) 6 front panel section www 4 wire (flat type) 37p (CN402) 1 screw (BVTP3× 8) . xiaoy u163. com 3 connector (CN305) 5 two screws (BVTP3× 8) 9 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 3-3. Panel Board 4 PANEL board 3 six claws 2 ten screws (BVTP2.6× 8) TEL TEL 13942296513 13942296513 1 knob (VOL) 6 connector (CN908) 8 back panel section 2 four screws (BVTP3× 10) 4 connector (CN503) 3 two screws (BVTP3× 8) 5 connector (CN905) 7 connector (CN904) www . 1 wire (flat type) 11p (CN101) xiaoy u163. com 10 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 3-4. Back Panel Section QQ 376315150 892498299 QQ QQ TEL 13942296513 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 3-5. MAIN Board 5 wire (flat type) 9p (CN303) 4 wire (flat type) 37p (CN402) 3 connector (CN404) 1 connector (CN907) 9 MAIN board TEL TEL 2 two screws (BVTP3× 8) 13942296513 13942296513 8 connector (CN305) 7 wire (flat type) 27p (CN302) 6 wire (flat type) 19p (CN301) 5 four screws (BVTT4× 8) QQ 376315150 892498299 1 connector (CN902) 2 screw (BVTP3× 8) 376315150 892498299 376315150 892498299 3-6. PWR AMP Board, Power Transformer QQ QQ TEL 13942296513 3 four screws (BVTP3× 8) 6 power transformer 4 PWR AMP board www . xiaoy u163. com 11 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 3-7. CD Mechanism Deck (CDM69CH-K6BD71C) 1 two screws (BVTP3× 8) 3 blacket (TR) 2 two screws (BVTP3× 8) 4 four screws (BVTP3 × 8) 5 wire (flat type) 27p (CN701) 2 screw (DIA. 12) 3 boss 1 floating screw (+PTPWHM2.6) www . xiaoy u163. com 4 boss 7 base unit section 6 boss 5 boss 12 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 3-8. Base Unit Section QQ QQ QQ 376315150 892498299 TEL 13942296513 13942296513 13942296513 6 wire (flat type) 19p (CN710) TEL TEL 7 CD mechanism deck (CDM69CH-K6BD71C) http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 3-9. Base Unit (BU-K6BD71C) 3 floating screw (+PTPWHM2.6) q; base unit (BU-K6BD71C) 8 insulator (213) 4 floating screw (+PTPWHM2.6) 2 floating screw (+PTPWHM2.6) 7 insulator (213) 9 insulator (213) TEL TEL 1 floating screw (+PTPWHM2.6) 5 6 insulator (213) 13942296513 13942296513 QQ QQ 3-10. BD Board 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 2 Remove the solder (four portions). 3 wire (flat type) (16core) www xiaoy u163. com 4 BD board . 1 screw (BVTP2.6 × 8) 13 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 QQ 376315150 892498299 3-12. SW Board, Bracket (Top) Assy 4 SW (3) board 3 SW (2) board 5 SW (4) board 1 four screws (BTP2.6 × 6) 6 six screws (BVTP2.6 × 8) 2 SW (1) board TEL TEL 7 bracket (top) assy 13942296513 13942296513 . xiaoy u163. com 14 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 3-13. CONNECTOR Board TEL TEL – bottom view – CONNECTOR board 13942296513 13942296513 4 connector (CN710) 3 5 connector (CN702) 6 connector (CN703) 2 four screws (BVTP2.6 × 8) 7 CONNECTOR board 3-14. Motor (Stocker) Assy (Stocker)(M761) QQ 376315150 892498299 3 two screws (BVTP2.6 × 8) 376315150 892498299 376315150 892498299 TEL 13942296513 QQ QQ 1 Remove five solders. 4 2 Remove two solders 5 STOCKER MOTOR board 6 motor (stocker) assy (stocker) (M761) www xiaoy u163. com 1 belt (mode) . 15 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 3-15. Motor (Roller) Assy (Roller)(M781) 3 two screws 2 Remove two solders. 4 ROLLER MOTOR board 5 motor (roller) assy (roller)(M781) TEL TEL 1 Remove five solders of rotary encoder. 3 two screws (BVTP2.6 × 8) 4 MODE MOTOR board 6 motor (mode) assy (mode) (M771) MODE MOTOR board 2 Remove two solders of motor (M771) www xiaoy u163. com 5 belt (mode V) . 16 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 3-16. Motor (Mode) Assy (Mode)(M771) QQ 376315150 892498299 QQ QQ TEL 13942296513 13942296513 13942296513 1 belt (roller V) http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 3-17. Rubber Roller (Slider) Assy 8 step screw 5 step screw 9 tension spring (slider 2) 0 rubber roller (slider 1) assy 1 step screw 6 tension spring (base slider 4) 2 rubber roller (slider S) assy qa rubber roller (slider 2) assy 3 tension spring (base slider 5) qs step screw 7 rubber roller (slider 1) assy 4 rubber roller (slider 5) assy qf screw (BVTP2.6 × 8) TEL TEL qd rubber roller (slider 4) assy 13942296513 13942296513 qg sub chassis QQ 376315150 892498299 376315150 892498299 376315150 892498299 3-18. Timing Belt (Front/Rear) QQ QQ TEL 13942296513 3 slider (mode cam) assy 7 two gears (center) 8 timing belt (rear) When install three timing belts, its pass under each claws. timing belt (rear) 5 two gears (center) 9 timing belt (rear) claw 6 timing belt (front) timing belt (rear) claw claw claw 4 gear (timing) timing belt (front) www xiaoy u163. com 2 gear (mode cam) : Note . Note: Refer to assembly (Section 4) 1 screw (PTPWH2.6 × 8) 17 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 3-19. Cam (Gear) qf cam (gear) : Note 6 gear (mode 5) qd screw 5 screw (PTPWH2.6 × 8) qs gear(mode cam) 3 screw (PTPWH2.6 × 8) 2 pulley (mode deceleration) 0 gear (mode C) :Note Note: Refer to assembly (Section 4). 9 screw (PTPWH2.6 × 8) 8 gear (mode D) 7 screw (PTPWH2.6 × 8) ql harness qk claw q; cam (eject lock) : Note 9 screw (PTPWH2.6 × 8) qh two claws qd gear (eject lock) 8 shaft (shutter) qs cam (BU U/D) 7 compression spring (shutter) wa SENSOR board w; screw (BVTP2.6 × 8) qg screw (PTPWH2.6 × 8) 6 gear (mode A) 5 base (shutter) block www qj rotary encoder (S771) qf gear (mode B) xiaoy u163. com qa screw (PTPWH2.6 × 8) 3 screw (BVTP2.6 × 8) . 1 screw (PTPWH2.6 × 8) Note: Refer to assembly (Section 4). 4 two screws (BVTP2.6 × 8) 2 lever shutter (A) 18 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 QQ QQ TEL 13942296513 3-20. SENSOR Board 1 screw(PTPWH2.6 × 8) 13942296513 13942296513 qa screw (PTPWH2.6 × 8) TEL TEL 4 gear (mode 5) http://www.xiaoyu163.com HCD-HP7 SECTION 4 ASSEMBLY QQ 376315150 892498299 • This set can be assembled in the order shown below. 4-1. How to Install the Cam (Eject Lock) 1 Rotate the cam (BU U/D) fully in the direction of arrow. 2 Engage the gear (eject lock) and the gear of the cam (eject lock) aligning the mark with the center of the gear (eject lock). cam (BU U/D) TEL TEL mark 13942296513 13942296513 gear (eject lock) cam (eject lock) – bottom view • front – How to Install the Cam (Gear) QQ 376315150 892498299 376315150 892498299 376315150 892498299 4-2. QQ QQ TEL 13942296513 1 Check that the cam (BU U/D) can not be rotated in the direction of arrow. 2 Align the mark on the cam (gear) with the boss as shown in the figure and install the cam (gear). cam (gear) boss cam (BU U/D) mark www xiaoy u163. com – bottom view • front – . 19 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 4-3. How to Install the Gear (Mode C) 1 Align the mark on the rotary encoder (S771) with the projection of the assy. 2 Check that the cam (BU U/D) can not be rotated in the direction of arrow. 3 Install the gear (mode C) rotary encoder (S771) cam (BU U/D) gear (mode C) TEL TEL chassis projection – bottom view • front – 1 Slide the shaft in the direction of arrow. 2 Align mark A on the gear (mode cam) with mark B on the slider (mode cam) assy, then install the gear (mode cam). 3 Check that mark C on the gear (mode cam) is in alignment with mark D on the cam (gear). shaft mark A slider (mode cam) assy gear (mode cam) mark D mark B mark C cam (gear) www . xiaoy u163. com – bottom view • front – 20 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 How to Install the Gear (Mode Cam) QQ QQ 4-4. QQ 376315150 892498299 TEL 13942296513 13942296513 13942296513 mark http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 4-5. How to Install the Rotary Encoder (S702), Gear (Stocker Communication) 4 gear (stocker communication) 5 screw (PTPWH2.6 × 8) 3 screw (PWH2 × 6) Engage the rotary encoder (S702) and the gear (stocker communication) as shown below in the figure. 7 two screws (PTPWH2.6 × 8) 1 rotary encoder (S702) 6 two gears (stocker communication) rotary encoder (S702) TEL TEL 13942296513 13942296513 2 five solders gear (stocker communication) How to Install the Stocker Assy boss 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 4-6. QQ QQ CONNECTOR board – rear – Install the stocker assy fitting three bosses into the each groove of cam (stocker U/D) then fix by rotating the cams in the direction of arrow. 3 three screws (PTPWH2.6 × 8) 2 three cams (stocker U/D) boss cam (stocker U/D) To install three cams (stocker U/D), align each groove of the cam (stocker U/D) with each f mark on the chassis as shown in the figure. www rotary encoder (S702) hole screw . xiaoy u163. com 1 Position the hole on the gear (stocker communication) on the screw of the rotary encoder (S702). gear (stocker communication) – rear – 21 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 SECTION 5 TEST MODE QQ 376315150 892498299 * All fluorecent segments, LEDs, keys, volume and headphone detection are tested. Procedure: 1. Press the ?/1 button to turn the set on. 2. To enter the test mode, press three buttons DISPLAY , x and DISC 3 simultaneously. All segments and LEDs are turned on. 3. Press the x and PRESET EQ buttons simultaneously. In this key code display mode, the fluorecent indicator displays “KEY 0 0 0”. Each time a button is pressed, the key code is displayed. 4. Press the x and PRESET EQ buttons simultaneously. In this key count mode, the fluorecent indicator displays “KEYCNT 0 1”. Each time a button is pressed, “KEYCNT 0 X” value increases. However, once a button is pressed, it is no longer taken into account. 5. Press the x and PRESET EQ buttons simultaneously. When a headphone jack is not inserted, “ H_P RELEASE” is displayed. When a headphone jack is inserted, “ H_P IN” is displayed. 6. When the VOLUME knob is not rotated, “VOLUME FLAT” is displayed. The message “VOLUME UP” is displayed, when the VOLUME knob is rotated clockwise. The message “VOLUME DOWN” is displayed, when the VOLUME knob is rotated counterclockwise. 7. To exit from this mode, press three buttons DISPLAY , x and DISC 3 simultaneously. [CD Ship Mode] TEL 13942296513 * This mode moves the optical pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair. Procedure: 1. Press the ?/1 button to turn the set on. 2. Press the N (CD) button and the ?/1 button simultaneously. 3. After the message “STANDBY” blinks, “LOCK” is displayed on the fluorescent indicator tube, and the CD ship mode is set. [Disc Tray Lock] [Cold Reset] * The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Press three buttons DISPLAY , x and DISC 1 simultaneously. 2. The fluorescent indicator tube displays the message “COLD RESET” and the set is reset. [Version and Destination Display Mode] * The version or destination is displayed. Procedure: 1. Press the ?/1 button to turn the set on. 2. To enter the test mode, press the three buttons DISPLAY , x and DISC 2 simultaneously. 3. The model and destination is displayed. Example : “HP717 U” 4. Press the x and PRESET EQ buttons simultaneously. 5. The version is displayed. Example : “V1.09:2003:02.04” 6. To exit from this mode, press the three buttons DISPLAY , x and DISC 2 simultaneously, or press the ?/1 button to turn the set off. www . * This mode is used to check the function of the amplifier. Procedure: 1. Press the ?/1 button to turn the set on. 2. To enter the test mode, press the three buttons DISPLAY , x and DISC 4 simultaneously. 3. The message “VOLUME MIN”, “VOLUME 16” or “VOLUME MAX” is displayed , when turning the VOLUME knob clockwise or conterclockwise. 4. Each time the DIMMER button is pressed, the message “GEQ MAX” or “GEQ MIN” is displayed. The function of the equalizer is set to maximum or minimum. 5. The message “GEQ FLAT” is displayed, when pressing the PRESET EQ button. The function of the equalizer is set to flat. 6. Each time the GROOVE button is pressed, the message “VACS OFF” or “VACS ON” is displayed. 7. Automatic recording/playback : Press the REC button when a tape is inserted, recording is started and the input source function is selected to “MD” automatically. 8. When the . button is pressed, tape is rewound , stops at around the record-starting position and playback is started automatically. 9. To exit from this mode, press the ?/1 button to turn the set off. QQ 376315150 892498299 xiaoy u163. com 22 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 [MC Test Mode] QQ QQ The disc tray lock function for the antitheft of an demonstration disc in the store is equipped. Setting Procedure: 1. Press the ?/1 button to turn the set on. 2. Press two buttons of x and Z (DISC 1) simultaneously for five seconds. 3. The message “LOCKED” is displayed and the tray is locked. Releasing Procedure: 1. Press two buttons of x and Z (DISC 1) simultaneously for five seconds again. 2. The message “UNLOCKED” is displayed and the tray is unlocked. Note : When “LOCKED” is displayed, the tray lock is not released by turning power on/off with the ?/1 button. 13942296513 [Panel Test Mode] * Either the 9 kHz step or 10 kHz step can be selected for the AM channel step. Procedure: 1. Set the function to AM. 2. Press the ?/1 button to turn off the main power. 3. While depressing the TUNER/BAND button, press the ?/1 button to turn on the main power. 4. Either the message “MW 9k STEP” or “MW10k STEP” appears, and thus the channel step is changed over. TEL [AM Channel Step 9 kHz/10kHz Selection Mode] http://www.xiaoyu163.com HCD-HP7 SECTION 6 MECHANICAL ADJUSTMENTS QQ 376315150 892498299 • TAPE MECHANISM DECK SECTION [AMP Test Mode] Precaution 1. Clean the following parts with a denatured alcohol-moistened swab: record/playback heads pinch rollers erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. Torque Measurement Mode Torque meter [CD Service Mode] . FWD back tension CQ-102C REV CQ-102RC REV back tension CQ-102RC 2.94 – 7.84 mN • m (30 to 79 g • cm) (0.42 – 1.11 oz • inch) 0.15 – 0.6 mN • m 2 to 6 g • cm (0.03 – 0.08 oz • inch) 2.94 – 7.84 mN • m (30 to 79 g • cm) (0.42 – 1.11 oz • inch) 0.15 – 0.6 mN • m 2 to 6 g • cm (0.03 – 0.08 oz • inch) 6.86 – 17.64 mN • m (70 to 179 g • cm) (0.98 – 2.49 oz • inch) 9.8 mN • m more (100 • cm or more) (1.4 oz • inch or more) 9.8 mN • m more (100 • cm or more) (1.4 oz • inch or more) QQ 376315150 892498299 FF/REV CQ-201B FWD tension CQ-403A REV tension CQ-403R 376315150 892498299 376315150 892498299 www CQ-102C QQ QQ TEL 13942296513 FWD Meter reading 13942296513 13942296513 * This mode can run the CD sled motor freely. Use this mode, for instance, when cleaning the pickup. Procedure: 1. Press ?/1 button to turn the set on. 2. Set the function to CD. 3. Press three buttons DISPLAY , x and DISC 5 simultaneously. 4. The CD service mode is selected. 5. Press > button to move the pickup to outside track, or press . button to inside track. 6. To exit from this mode, perform as follows: 1) Move the pickup to the most inside track. 2) Perform the Cold Reset. Note: Do not run the sled motor excessively, otherwise the gear can be chipped. TEL TEL Procedure: 1 Press the ?/1 button to turn the set on. 2. To enter the test mode, press the three buttons x , PRESET EQ and DISC 4 simultaneously. 3. The message “AMP TEST IN” is displayed. 4. Press the x and PRESET EQ buttons simultaneously. The VACS status and IC parameters are displayed. Example : “D: S: +4. 0. +2” 5. DBFB ON/OFF Function : Press the GROOVE button, “DBFB ON” or “DBFB OFF” is displayed. 6. SURROUND ON/OFF Function : Press the PRESET EQ button, “SURROUND ON” or “SURROUND OFF” is displayed. 7. To exit from this mode, press three buttons x , PRESET EQ and DISC 4 simultaneously. Note: Perform the Cold Reset to initialize the equalizer parameters. xiaoy u163. com 23 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 SECTION 7 ELECTRICAL ADJUSTMENTS QQ 376315150 892498299 DECK SECTION 3. 0 dB=0.775 V Note: Confirm each contents of this section first of all. If the results are not satisfied, do the adjustment. 1. 2. 3. 4. 5. 6. Signal Used for P-4-A63J 10 kHz, –10 dB Azimuth Adjustment Record/Playback Head Azimuth Adjustment Procedure: 1. Mode: Playback waveform of oscilloscope in phase 45 ° good 4. 5. 90 ° 135 ° 180 ° wrong Repeat step 1 to 3 in playback (REV) mode. After the adjustments, apply suitable locking compound to the pats adjusted. + – adjustment screw QQ 376315150 892498299 Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1dB of peak. within 1 dB L-CH peak within 1 dB Output level Screw position R-CH peak www L-CH peak . R-CH peak Screw position xiaoy u163. com 24 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 2. R-CH Adjustment Location : Record/Playback/Erase Head PWR AMP board SPEAKER terminals (JK501) L-CH, R-CH level meter set R-CH QQ QQ test tape P-4-A63J (10 kHz, –10 dB) H 13942296513 13942296513 Tape V set TEL TEL • Test Tape PWR AMP board SPEAKER terminals (JK501) L-CH oscilloscope test tape P-4-A63J (10 kHz, –10 dB) L-CH Demagnetize the record/playback head with a head demagnetizer. Do not use a magnetized screwdriver for the adjustments. After the adjustments, apply suitable locking compound to the parts adjust. The adjustments should be performed with the rated power supply voltage unless otherwise noted. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) The adjustments should be performed for both L-CH and RCH. Switches and controls should be set as follows unless otherwise specified. 7. Mode: Playback http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 CD SECTION Checking Location: Note: 1. CD Block is basically constructed to operate without adjustment. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10 MΩ impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks. 5. Check the focus bias check when optical block is replaced. – BD BOARD (Conductor Side) – Focus Bias Check 14 1 IC722 oscilloscope (DC range) 15 28 TP (RF) TP (VC) CN710 TP(RF) + – 80 61 1 13942296513 IC721 TP(VC) 20 21 40 41 IC803 s 13942296513 QQ 376315150 892498299 VOLT/DIV: 200 mV TIME/DIV: 500 ns 376315150 892498299 376315150 892498299 TEL 13942296513 QQ QQ Procedure : 1. Connect oscilloscope to TP (RF) and TP (VC) on the BD board. 2. Press the ?/1 button to turn the power on. 3. Put disc (YEDS-18) in and press the N (CD) button to playback. 4. Confirm that oscilloscope waveform is as shown in the figure below. (eye pattern) A good eye pattern means that the diamond shape ( ) in the center of the waveform can be clearly distinguished. 60 level: 1.0 ± 0.2 Vp-p www . xiaoy u163. com 25 http://www.xiaoyu163.com TEL TEL BD board http://www.xiaoyu163.com HCD-HP7 SECTION 8 DIAGRAMS QQ 376315150 892498299 • Circuit Boards Location SUB TRANS board SENSOR (FAN) board PWR TRANS board PWR AMP board TEL TEL 13942296513 13942296513 MAIN board 376315150 892498299 ROLLER MOTOR board STOCKER MOTOR board SW (4) board ST ENCODER board SW (3) board SW (2) board SW (1) board CONNECTOR board BD board www xiaoy u163. com SENSOR board . MODE MOTOR board 26 http://www.xiaoyu163.com 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 QQ QQ PANEL board http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) For schematic diagrams. Note: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. f : internal component. • • 2 : nonflammable resistor. • 1 : fusible resistor. • C : panel designation. For printed wiring boards. Note: • X • Y f • • : parts extracted from the component side. : parts extracted from the conductor side. : internal component. : Pattern from the side which enables seeing. Caution: Pattern face side: (Conductor Side) Parts face side: (Component Side) 8 9 2 4 9 8 2 9 9 • Waveforms – BD Board – – PANEL Board – 1 IC721 4 (RF) – MAIN Board – 7 Q207 collector(REC Mode) 5 IC601 qd (XT2) (CD Play Mode) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated. 1.3 Vp-p 200 mV/DIV, 400 ns/DIV 2 IC721 qd (FE) 3.4Vp-p 1V/DIV, 10 µs/DIV 30.5 µs 13 µs 5V/DIV, 4 µs/DIV 12 Vp-p 6 IC601 qh (CF2) (CD Play Mode) • Indication of transistor C . 3Vp-p 1V/DIV, 40 ns/DIV 125 ns 3 IC721 qg (TE) (CD Play Mode) Q B C E 150 mVp-p These are omitted. 100 mV/DIV, 1 ms/DIV 4 IC721 rk (XOUT) (CD Play Mode) Q B C E 1 3 9 4 2 2 9 6 5 1 3 www 180 mVp-p 100 mV/DIV, 1 ms/DIV These are omitted. QQ 3 7 6 3 1 5 1 5 0 4 Vp-p 59 ns 1 V/DIV, 20 ns/DIV 8 9 2 4 9 8 2 9 9 C B E These are omitted. x ia o y u 1 6 3 27 27 http://www.xiaoyu163.com . c o m 376315150 892498299 376315150 892498299 TEL These are omitted. QQ QQ • A : B+ Line. • B : B– Line. • V oltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. ∗ : Impossible to measure • V oltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • W aveforms are taken with a oscilloscope. • W aveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. • Circled numbers refer to waveforms. • Signal path. F : TUNER J : CD L : MD E : PB (TAPE) a : REC (TAPE) c : DIGITAL OUT • A bbreviation AUS : Australian model. CND : Canadian model. E2 : 120 V AC area in E model. E3 : 220-240 V AC area in E model. KR : Korean model. MX : Mexican model. RU : Russian model. TH : Thai model. TW : Taiwan model. Q B E 13942296513 13942296513 Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce por tant le numéro spécifié. TEL TEL Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 8-1. Block Diagram QQ 3 7 6 3 1 5 1 5 0 L MD IN 37 IND2 R-CH R 40 INA2 11 DBFB Q301 REF 1 +10V VACS Q609,610 SA OUT 19 VM+10V D417 L SYSTEM CONTROLLER IC601 (1/2) CLOCK 22 L-CH AM DATA 21 RY501 Q306,307 MUTE CONT SYS MUTE 1 23 VACS R-CH R-CH PROTECT DETECT Q507,508 12 35 RECB2 TUNER PACK JK601 PHONES 4 MUTE Q304 38 INC2 FM R CH 3 10 OUT2 25 39 INB2 8 9 2 4 9 8 2 9 9 POWER AMP IC501 SOUND PROCESSOR IC301 JK301 OVER LOAD DETECTOR Q503 MUTE Q501 PROTECT CONT Q509 D505 PROTECT SWITCH Q510 PROTECT SWITCH Q513 JK501 SPEAKER RELAY DRIVE Q512 R CH R 7 MCLK D OUT 96 DI D IN 95 DO CLK 97 CLK CE +VCC TH501 9 CE TUNED OVER HEAT DETECTOR Q504,506 D509 75 STEREO Q514,515 D507 FAN SWITCH Q505 74 TUNED STEREO PROTECT SWITCH Q511 FAN DRIVE FAN • RCH is omitted due to same as L-ch. • Signal Path MUTE +4V +3.3V AEP/UK RDATA MODEL RCLK PROTECTOR 82 2 DATA 29 CLK RF AMP, FOCUS/TRACKING ERROR AMP IC721 DETECTOR VCC +5V 11 VREF 8 FIN 2 B 7 FIN 1 X601 32.768kHz 12 XT1 P1 13 XT2 P22 C 99 DI DO 64 E F Q701 LD DRIVER LD 9 TIN 1 DI 63 98 DO 10 TIN 2 CL 62 100 CLK CE 61 5 CE 80 LDD 73 COMDOUT T+ TRACKING COIL T KEY2 24 FUNCTION KEY DISC3 LED 88 1 3 9 4 2 2 9 6 5 1 3 FOIN 10 ASDFIN 57 2 ADDATA ASDACK 56 3 ADBCK ASLRCK 55 4 ADLRCK 21 FDO 11 VO2(+) LRSY 58 1 LRSY C2F 52 5 C2FIN TIN 20 20 TDO 17 VO3(-) SRAM IO1-16 DISC4 LED 87 DISC5 LED 86 TW:Taiwan model. FAN+B D405-408 IC403 1 VCC+10V +10V 3 REG LED607-611 Q412 PWR LED 93 CE 16MOUT 54 7 CKIN LCAS MP3RES 26 78 RESB UCAS XIN 49 SLIN 25 VOLUME ENCODER +1.8V REG AVDD FIL1 EVER+3.3V Q601 +3.3V RESET 11 REMOTE CONTROL RECEIVER 22 SPDO IC603 RESET SWITCH 3 RESET D901-904 25 CONT4 T902 SUB TRANS IC602 D620 5 1 +4V REG 1 AC IN EVER+10V D624 D413 Q410 28 REMCON IN D414 VM+10V I/O EXPANDER IC302 1 VO1(-) 7 80 VR ENC B RM601 2 VO1(+) SPIN 3 8 9 2 4 9 8 2 9 9 S902 VOLTAGE SELECTOR D622 PWR DOWN 27 79 VR ENC A DVDD1,3,4,6 XOUT 48 E2, E3, TW D907 VR601 DVDD2,5 X701 16.9344MHz 23 SLDO 27 VO4(-) 3 7 6 3 1 5 1 5 0 -VFL REG -VFL FIL2 WE 26 VO4(+) QQ LED614 A0-8 9 CKOUT FSX/16MIN 50 18 VO3(+) MUTE FUNCTION KEY E2:120V AC area in E model. E3:220-240V AC area in E model. 3 DISC2 LED 91 TEL M KEY1 25 DISC1 LED 92 IC802 12 VO2(-) M +4V REG 1 +4V S601-610 10 SYNC IC803 M702 (SPINDLE) • Abbreviation 6 CE CE 76 80 DATACK F SYNC 66 DATACK 59 D410 D401-404 S614-622 79 DATAIN DATA 60 : REC (TAPE) D412 +10V 3 REG 1 IC402 FUNCTION KEY CL 75 RAS M701 (SLED) VM+10V S627-636 COMDIN 74 75 79 LDS -VCC IC401 RY901 RELAY DRIVE Q411 POWER CONTROL POWER RELAY 94 DI1 26 S701 (LIMIT) 70 LIMIT SW LATCH 4 PB/REC EQ AMP IC201 DECK 21 REC OUT(L) R-CH 12 P8 MUTE Q209 PB OUT(L) 26 34 PB IN(L) REC/PB HEAD 18 TCM 19 P5 20 P4 REC MUTE ON/OFF 15 MUTE ON/OFF 14 P10 10 7 FIN OUT1 4 P11 9 9 RIN OUT2 2 VM+10V M Q408,409 PLAY R REC F REC PACK END 2 G 7 FIN OUT1 4 9 RIN OUT2 2 4 M M781 (ROLLER) S711 (DISC INSERT(8/12cm)) CDM SW1-A 71 IC721 STOCKER MOTOR DRIVE Q211 SWITCH Q206 www 1 CDM ELVE 20 S713 (DISC IN (8/12cm)) 22 P2 MOTOR DRIVE P14 6 7 FIN OUT1 4 P15 5 9 RIN OUT2 2 CDM SW2-A 70 S714 (DISC IN (8cm)) M CDM SW2-B 69 M761 (STOCKER) S715 (DISC OUT) CDM SW3 73 24 P0 S718 (STOCKING) CDM SW4 68 23 P1 . m S711 (ON : When disc insert) S713 (ON : Play position) S714 CDM SW5-A 67 P7 17 x ia o y u 1 6 3 28 28 http://www.xiaoyu163.com c o CDM SW5-B 66 S718 OFF: In the Midst disc is moving between play position and stocker S717 In the midst disc is moving between play position and stocker ON : disc is play position side OFF : disc is stocker side S716 ON : The moment disc in/out from stocker . CDM D SENSOR 81 S716 (STOCKER IN/OUT) Q731 LEVEL SHIFT IC751 DISC INSERT DETECT SENSOR ON : Play position (8cm disc only) S715 (ON : When disc out from play position) S717 (DISC POSITION) P6 18 T SOL DRIVE SW401 TAPE OPEN/CLOSE M771 (MODE) 21 P3 Q406,407 SOL M 3 P12 8 P13 7 BIAS Q212 DECK MOTOR S702 ROTARY ENCODER (STOCKER POSITION) IC711 ROLLER MOTOR DRIVE A/B 13 Q205 G 3 CDM SLDE 21 IC701 MODE MOTOR DRIVE Q208 MECHA BLOCK 1 2 83 TAPE END 4 R-CH Q201 Q203 CDM SLDE1 22 19 TCM1 11 P9 ALC(L) 23 BIAS OSC Q207 S771 ROTARY ENCODER (MODE) 8 CE REC IN(L) 24 L201 BIAS ERASE HEAD SYSTEM CONTROLLER IC601 (2/2) CLK 3 376315150 892498299 376315150 892498299 F 30 : DIGITAL OUT : PB (TAPE) QQ QQ F+ FOCUS COIL 41 +VCC POWER AMP KEY0 26 MP3 DECODER IC801 SLED/SPINDLE MOTOR DRIVE, FOCUS/TRACKING COIL DRIVE IC722 G1 G12 : MD FIL1 50 . 52 4 RESET RES 66 VR 45 . 47 77 CD WRQ WRQ 65 GND PD FIL2 65 76 CD DRF DRF 67 T901 MAIN TRANS D501 42 LCHO 42 D : CD FLOURESCENT INDICATOR TUBE 13942296513 13942296513 A 15 CF1 16 CF2 CD DIGITAL OUT (OPTICAL) DOUT 39 VC RES601 8MHz PH301 TEL TEL OPTICAL PICK-UP BLOCK (KSM-213D) : TUNER FLD601 http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 QQ 3 7 6 3 1 5 1 5 0 8-2. Printed Wiring Boards — BD Board — • See page 26 for Circuit Boards Location. 1 2 3 4 • : Uses unleaded solder. 5 8 9 2 4 9 8 2 9 9 6 7 8 9 10 11 + BD BOARD A (COMPONENT SIDE) BD BOARD (CONDUCTOR SIDE) M M702 (SPINDLE) • Semiconductor Location S701 (LIMIT IN) B Ref. No. – C E + 14 8 R860 C860 D 21 22 28 M701 (SLED) 8 9 2 4 9 8 2 9 9 – TP (RF) IC721 IC801 A TP (VC) FB806 FB804 R806 R807 R762 C761 TP TP (FE) (TE) C817 FB803 R761 R747 R746 FB805 E M 3 7 6 3 1 5 1 5 0 15 11 1-688-077- (11) 5 3 www . 4 IC803 IC802 F B-7 x ia o y u 1 6 3 29 29 http://www.xiaoyu163.com . c o m 11 1-688-077- (11) MAIN BOARD CN312 (Page 33) 376315150 892498299 376315150 892498299 QQ 1 3 9 4 2 2 9 6 5 1 3 Q701 1 IC722 TEL E-8 C-9 E-3 F-3 F-9 QQ QQ C 7 Location IC721 IC722 IC801 IC802 IC803 13942296513 13942296513 B TEL TEL OPTICAL PICK-UP BLOCK (KSM-213D) http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 8-3. Schematic Diagram — BD Board — • See page 39, 40 for IC Block Diagrams. • See page 27 for Waveforms. QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 R732 IC803 R731 R722 R721 R834 C753 R725 R719 R726 C754 C807 C844 R720 Q701 R729 C744 R718 C708 C742 R716 C746 R717 C709 C743 R707 C804 C741 C704 C705 C802 C806 C859 R730 R860 C858 R728 C856 (KSM-213D) C803 C857 C805 C860 C843 S701 C703 R727 R833 C710 IC B/D R708 R709 C823 R823 CN708 C824 R824 C712 C713 R702 C825 R825 R711 TP R826 R827 R828 R703 FB808 R704 C830 C829 R705 R701 C731 R829 R706 FB807 TP R765 C716 R745 C715 TP C717 TP IC721 R713 FB701 IC B/D FB801 C831 C734 FB802 X701 C811 IC801 C735 C718 C810 C733 C720 1 3 9 4 2 2 9 6 5 1 3 C721 C729 R738 C701 R715 R818 3 7 6 3 1 5 1 5 0 R714 8 9 2 4 9 8 2 9 9 R817 R820 R819 R747 C816 R746 C815 376315150 892498299 C814 R760 R740 R761 C761 R741 C702 R739 C756 R762 C813 C722 FB761 C706 C837 C707 R804 R803 C834 R805 C835 M701 CN710 IC802 R807 FB708 IC722 FB707 R801 R744 (Page 34) M702 www x ia o y u 1 6 3 C747 . R802 FB806 FB803 FB805 R806 FB804 376315150 892498299 QQ C732 C812 QQ QQ C719 TEL 13942296513 13942296513 C714 C817 C711 R832 TEL TEL C723 C748 30 30 http://www.xiaoyu163.com . c o m http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 8-4. Printed Wiring Boards — Changer Section — • See page 26 for Circuit Boards Location. 1 2 3 • : Uses unleaded solder. 4 5 8 9 2 4 9 8 2 9 9 6 7 9 8 A • Semiconductor Ref. No. B IC751 IC701 QQ 3 7 6 3 1 5 1 5 0 IC701 IC711 IC721 IC751 C-4 D-4 C-4 C-2 Q731 B-5 8 9 2 4 9 8 2 9 9 IC721 IC711 D S718 (STOCKING) OFF: In the Midst disc is moving between play position and stocker S717 (DISC POSITION) In the midst disc is moving between play position and stocker ON : disc is play position side OFF : disc is stocker side E S716 (STOCKER IN/OUT) ON:The moment disc in/out from stocker www . x ia o y u 1 6 3 31 31 http://www.xiaoyu163.com . c o m 376315150 892498299 376315150 892498299 1 3 9 4 2 2 9 6 5 1 3 C-4 C-4 C-4 QQ QQ C TEL Location D701 D711 D721 13942296513 13942296513 TO MAIN BOARD CN302 (Page 33) TEL TEL Location http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 8-5. Schematic Diagram — Changer Section — • See page 41 for IC Block Diagrams. CN751 3P 1 DIODE IC751 CN702 3P 1 D SENSE R731 100 DIODE D SENSE GND IC751 RPR-220 8 9 2 4 9 8 2 9 9 R733 10k GND 3 CN701 27P R734 12k 3 3.2 R732 1k GND RIN VCC FIN OUT1 VM OUT2 RNF VREF DISC INSERT DETECT SENSOR D+3.3V M+12V Q731 RT1N141 M+12V LEVEL MGND MODE MOTOR DRIVE SHIFT MGND D.SENSOR IC701 BA6956AN C754 0.1 C711 10 50V C758 0.1 R701 680 SW2A SW2-A C756 0.1 SW2B SW2-B C751 0.1 SW5B SW5-B SW5A SW5-A C752 0.1 MTR RL 2 C781 0.01 MD NEG RIN GND VCC FIN 2 VM 2 RNF VREF - OUT1 ROL NEG MTR RL 1 MTR RL 1 (ROLLER) MD POS CN703 2P 1 OUT2 M781 MTR RL 2 ROL POS ROLLER MOTOR TEL MAIN BOARD CN302 (Page 34) ELV POS 13942296513 ELV NEG SW4 GND RIN VCC FIN VM RNF OUT1 SW4 VREF 13942296513 DRIVE OUT2 TEL CN781 2P 1 + SW3 SW1-A C755 0.1 R702 100 D701 MTZJ-T-77-4.7B SW3 SW1 IC711 BA6956AN C753 0.1 STOCKER MOTOR P02 SLD E1 R712 100 DRIVE SLD E2 IC721 BA6956AN + M761 (STOCKER) CN761 2P 1 MTR ST 2 CN704 2P 1 MTR ST 2 C761 R722 0.01 100 SLD E3 C765 0.1 R711 680 D711 MTZJ-T-77-5.6B ELV E0 ELV E1 C764 0.1 ELV E2 C763 0.1 MTR ST 1 MTR ST 1 SLD E0 ELV E3 2 R721 680 CN711 2P 1 GND QQ CN705 2P 1 GND SW1 S711 SW1 2 2 CN721 3P 1 1 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 SW1 (DISC INSERT(8/12cm)) (ON:WHEN DISC INSERT) GND S713 CN706 3P GND SW2-A SW2-A SW2A SW2-B SW2-B SW2B (DISC IN(8/12cm)) 3 (ON:PLAY POSITION) 3 S714 (DISC IN(8cm)) (ON:PLAY POSITION(8cm DISC ONLY)) S771 ROTARY ENCODER (MODE) CN731 2P 1 GND CN707 2P 1 SW3 S715 SW3 2 CN710 7P 1 E1 C769 0.1 GND SW3 E2 C768 0.1 C767 0.1 E3 C766 0.1 E4 E1 E2 GND 2 (DISC OUT) CN771 7P 1 GND E3 (ON:WHEN DISC OUT FROM PLAY POSITION) E4 MTR MD 1 MTR MD 1 MTR MD 2 MTR MD 2 CN741 4P 1 GND S716 (STOCKER IN/OUT) CN708 4P 1 C771 0.01 GND SW5-B SW5-B SW5B SW5-A SW5-A SW5A SW4 SW4 SW4 7 + M771 - ON:THE MOMENT DISC IN/OUT FROM STOCKER www 4 4 S717 (DISC POSITION) IN THE MIDST DISC IS MOVING BETWEEN PLAY POSITION AND STOCKER x ia o y u 1 6 3 ON:DISC IS PLAY POSITION SIDE OFF:DISC IS STOCKER SIDE . S718 (STOCKING) OFF:IN THE MIDST DISC IS MOVING BETWEEN PLAY POSITION AND STOCKER 32 32 http://www.xiaoyu163.com 7 . c o No mark : CD(STOP) m (MODE) 376315150 892498299 376315150 892498299 1 3 9 4 2 2 9 6 5 1 3 S702 ROTARY ENCODER (STOCKER POSITION) QQ QQ D721 MTZJ-T-77-3.6A TEL C762 0.1 2 http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 8-6. Printed Wiring Boards — Main Section — • See page 26 for Circuit Boards Location. 1 2 • 3 : Uses unleaded solder. 8 9 2 4 9 8 2 9 9 • Semiconductor Location 4 5 6 7 Ref. No. 8 A 1 2 3 4 5 6 7 8 (AEP,UK) E (TAPE OPEN/CLOSE) (AEP,UK) 36 30 E E 9 PH301 E IC201 E E CD DIGITALL OUT (OPTICAL) C347 E E 10 1 3 9 4 2 2 9 6 5 1 3 E E E E E IC403 2 1 1 E 2 1 1 8 2 3 3 7 6 3 1 5 1 5 0 C422 IC402 1 E 3 E 8 9 2 4 9 8 2 9 9 IC201 IC301 IC302 IC401 IC402 IC403 C-3 B-4 D-3 C-5 C-5 C-4 L PH301 C-8 G Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q208 Q209 Q210 Q211 Q212 Q301 Q302 Q304 Q305 Q306 Q307 Q406 Q407 Q408 Q409 Q410 Q411 Q412 B-3 B-3 B-3 B-3 B-3 C-2 C-2 C-2 C-3 C-3 E-4 C-2 C-4 B-4 C-6 C-6 B-5 C-5 C-2 C-2 C-2 C-2 B-7 B-7 C-7 IC401 1 3 8 R 9 MD IN C423 18 19 2 7 1 E QQ E D TO PWR TRANS BOARD CN907 (Page 37) IC302 1 D E TO PANEL BOARD CN603 (Page 35) 1 4 2 1 20 10 13 26 27 E 12 1-689-244TO CONNECTOR BOARD CN701 (Page 31) www . B TO BD BOARD CN710 (Page 29) A TO PANEL BOARD CN602 (Page 35) TO PWR AMP BOARD CN501 (Page 37) C x ia o y u 1 6 3 33 33 http://www.xiaoyu163.com . c o (CHASSIS) F m 12 376315150 892498299 376315150 892498299 TEL E E QQ QQ C IC301 4 5 1 TO PANEL BOARD CN601 (Page 35) E B-7 B-7 B-5 D-4 D-4 D-4 D-4 E-4 D-5 E-3 D-7 D-7 D-7 D-7 D-7 C-7 D-7 C-7 D-2 D-7 D-1 E-7 C-7 B-7 C-7 C-6 E-6 13942296513 13942296513 37 (EXCEPT AEP,UK) * E E E B 11P : EXCEPT AEP,UK E Location TEL TEL *CN101 15P : AEP,UK D101 D102 D301 D302 D303 D304 D305 D306 D307 D309 D401 D402 D403 D404 D405 D406 D407 D408 D409 D410 D411 D412 D413 D414 D415 D416 D417 http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 8-7. Schematic Diagram — Main Section — • See page 41 for IC Block Diagrams. • See page 27 for Waveforms. 8 9 2 4 9 8 2 9 9 B TO CONNECTOR BOARD CN701 (Page 32) 27P MAIN BOARD ANTENNA FM75Ω COAXIAL AM * CN101 15P:AEP,UK 11P:EXCEPT AEP,UK 3.3 3.2 0 3.3 0 3.2 0 0 IC302 0.01 0.01 I/O EXPANDER 0 AEP,UK 3.3 AEP,UK * R101,102 47K:AEP,UK 100K:EXCEPT AEP,UK 3.3 * 19P 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 3.2 1000P 1K C TO PANEL BOARD CN602 (Page 36) A TO BD BOARD CN710 (Page 30 ) DBFB 1K 470P 4.3 4.6 JK301 0.0027 L 0 0 0 0 4.6 4.7 0.082 0 4.7 4.6 4.6 4.6 0.047 4.6 0.022 4.6 4.6 4.6 4.6 4.7 4.6 4.6 4.6 4.7 4.7 0.047 R 0.022 MD IN 4.6 4.7 4.7 +10V REG 2SD1306NETL Q304,305 MUTE Q306,307 MUTE CONT 15.6 10 Q406,407 T SOL DRIIVE 10 4.7K 0 10 C420 0.1 0.0022 1000 0 PH301 CD DIGITAL OUT (OPTICAL) 0.7 0.7 TA7810S 0.047 TOTX141 8 9 2 4 9 8 2 9 9 0.2 3 7 6 3 1 5 1 5 0 0.1 3.9 0 4.2 0 0.1 9.2 4.6 4.7 4.6 DBFB 9.2 QQ 1 3 9 4 2 2 9 6 5 1 IC403 3 0.0027(M) 9.9 9.9 0.082 4.7 4.6 4.6 4.6 4.6 0.022 4.6 0.047 0.7 0.1 10 3.0 0 3.7 0.5 3.7 HEAD (REC/PB/ERASE) UPC3504AHF 0 9.2 10 IC402 +4V REG 4 RELAY DRIVE 9.2 9.2 C423 0.1u C422 0.1u 7.5 PB/REC EQ AMP 10 8.4 IC401 2.5 0 10 0 0 REC/PB R-CH TA7810S MUTE IC201 0 0.1 0 1.3 L-CH 16.6 3.7 3.8 3.7 0.6 0.6 3.0 0.015 MUTE 0 Q408,409 MOTOR DRIVE 0 +10V REG 0.7 10 0 0 EH POWER CONTROL 0.6 ERASE 0.6 3.8 0.047 TAPE MECHANISM DECK SWITCH 0 0.7 0 0.7 0 0.6 3.0 0.015 0.5 0.7 3.0 0 0.7 0 3.8 3.7 0 3.7 0 0 0.0022 Q201-204 SWITCH 0 0 8P 7 0.0022 9.9 9.9 0.0022 0 SWITCH 9.9 25V 0 9.2 16V 9.9 BIAS OSC SWITCH 0 0 0.015 0.015 0.015 SWITCH 0 -VFL REG BIAS 1/2W -27 UDZSTE1727B www 9.9 0.0047 -37.5 0.7 -26.5 0 0 0 0 1/2W UDZSTE175.6B x ia o y u 1 6 3 37P 9P . G TO PWR TRANS BOARD CN907 (Page 38) E TO PANEL BOARD CN601 (Page 36) 34 34 http://www.xiaoyu163.com c o 13P . F TO PWR AMP BOARD CN501 (Page 38) m 4P D TO PANEL BOARD CN603 (Page 36) No mark:FM 376315150 892498299 376315150 892498299 TEL 0.022 4.6 4.6 4.6 4.6 4.6 4.7 SOUND PROCESSOR 2SD1306NETL QQ QQ 4.6 4.6 IC301 13942296513 13942296513 4.7 TEL TEL 0.022 3.3 9P http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 8-8. Printed Wiring Boards — Front Section — • See page 26 for Circuit Boards Location. 1 2 C PANEL BOARD A • : Uses unleaded solder. 3 8 9 2 4 9 8 2 9 9 4 5 6 7 TO MAIN BOARD CN303 (Page 33) • Semiconductor Location (EXCEPT AEP,UK,RU) Ref. No. (AEP,UK,RU) S635 S636 DIMMER S633 GROOVE S634 45 S614 RM601 + 1 S601 DISC1 S621 S622 41 S610 DISC1 - PRESET/ALBUM 3 C S609 DISC2 S602 DISC2 S615 (EXCEPT AEP,UK,RU) (AEP,UK,RU) 30 1 3 9 4 2 2 9 6 5 1 3 IC601 VOLUME 3 7 6 3 1 5 1 5 0 S603 DISC3 20 (TH) S608 DISC3 8 9 2 4 9 8 2 9 9 (US,CND,E2, KR,MX,AUS) S617 (US,CND,AEP,UK,RU) D QQ S616 E (KR,AUS) FLASH R/W 3 10 1 IC603 S604 DISC4 E S607 DISC4 S618 IC601 IC602 IC603 C-2 F-4 D-4 LED607 LED608 LED609 LED610 LED611 LED614 B-5 C-5 C-5 D-5 E-5 B-2 Q601 Q609 Q610 E-3 D-5 D-5 RM601 B-2 S620 5 S619 1 TUNING TUNING + - S606 DISC5 S629 S630 REPEAT PLAY MODE E S631 CD SYNC S628 DISPLAY S605 DISC5 S632 REC(PAUSE/START) E 4 5 3 1 IC602 F www (E2,E3,KR,TW, TH,MX,AUS) 1-689-249TO MAIN BOARD CN402 (Page 33) . E TO MAIN BOARD CN305 (Page 33) D x ia o y u 1 6 3 35 35 http://www.xiaoyu163.com (CHASSIS) . c o m 376315150 892498299 376315150 892498299 TEL (FLUORESCENT INDICATOR TUBE) TUNER/BAND D-1 D-1 D-1 D-1 D-4 C-5 D-4 E-3 E-4 F-3 E-4 D-4 E-4 E-3 F-4 QQ QQ D606 D607 D608 D609 D615 D616 D617 D619 D620 D621 D622 D623 D624 D625 D626 PRESET EQ 13942296513 13942296513 B FUNCTION Location TEL TEL S627 http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 8-9. Schematic Diagram — Front Section — • See page 40 for IC Block Diagrams. • See page 27 for Waveforms. TO MAIN BOARD CN303 (Page34 ) 8 9 2 4 9 8 2 9 9 C PANEL BOARD (FLUORESCENT INDICATOR TUBE) 0 PHONES 0 D 0 0 TO MAIN BOARD CN305 (Page34 ) -24 US,CND,E2, KR,MX,AUS -26.5 TH -26.4 -16.5 @ @ KR,AUS -16.5 -19 US,CND,AEP, UK,RU -19 -16.5 -19 -26.4 -26.4 -26.4 -21.5 0 0 0 0 0 3.3 3.3 3.4 0 3.2 3.8 -26.4 3.3 -24 3.2 -24 0.7 -19 3.3 0 0.7 VOLUME -11.7 0.7 0.7 IC601 -14.1 SYSTEM CONTROLLER -26.4 -14.5 -25 3.3 0.7 -25 LC876796B-51K7-E 0.7 -25 2.7 -25 -25 QQ 3 7 6 3 1 5 1 5 0 TO MAIN BOARD CN402 (Page34 ) -25 3.3 -25 37P EXCEPT AEP,UK,RU 0 AEP,UK,RU 3.3 -25 3.5 3.3 0.3 2.8 3.3 -25 1.9 2.4 8 9 2 4 9 8 2 9 9 -25 22P 3.3 1.4 0 0 0 0 0 3.3 18P AEP,UK,RU I/ EXCEPT AEP,UK,RU 0 1.5 3.3 0 1.5 1.7 3.2 0.4 3.3 E -25 2.9 0 -25 6 3.3 0 IC603 IC602 RESET +4V REG 3.5 0 3.4 4 1.3 8.4 8.4 0.01 I/ 0.022 25V 0 E2,E3,KR,TW, TH,MX,AUS 3.3 www . C607 100U 10V R685 220 1/8W R684 220 1/8W RESET SWITCH 3.3 x ia o y u 1 6 3 36 36 http://www.xiaoyu163.com RM601 3.3 . c o m No mark:FM 376315150 892498299 376315150 892498299 1 3 9 4 2 2 9 6 5 1 3 5 1.7 0 QQ QQ 3.2 TEL 13942296513 13942296513 ENCODER,ROTARY 3.4 3.4 VACS TEL TEL 0.4 0 5.9 1 3.4 @ @ @ @ @ @ @ @ VACS 5.2 -24 5.9 -19 9.6 http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 • 8-10. Printed Wiring Boards — PWR AMP/Power Section — • See page 26 for Circuit Boards Location. 1 2 3 : Uses unleaded solder. 4 PWR TRANS BOARD SUB TRANS BOARD T901 POWER TRANSFORMER (MAIN) A 8 69 2 4 97 8 2 9 9 5 (US,CND) 4 3 2 1 (E2,E3,TW) * CN906 4P : E2,E3,TW (E2,E3,TW) * CN905 4P : E2,E3,TW 3 2P : EXCEPT E2,E3,TW 2 4 * (AUS) (AEP,UK,RU,KR,TH) 2P : EXCEPT E2,E3,TW * (E2,E3,TW) S902 4 4 VOLTAGE SELECTOR 120V 3 (US,CND,E2,E3, TW,MX) (EXCEPT E2,E3,TW) 220V 3 2 B • Semiconductor 2 Location (E2,E3,TW) (EXCEPT E2,E3,TW) 7 5 (EXCEPT E2,E3,TW) (E2,E3,TW) (E2,E3,TW) T902 POWER TRANSFORMER (SUB) 14 13 12 11 10 9 8 7 6 1 5 2 3 Ref. No. 1 (EXCEPT E2,E3,TW) (E2,E3,TW) 4 (EXCEPT E2,E3,TW,MX) 9 1 1 4 3 (MX) 1-689-250- 1 (CHASSIS) (EXCEPT E2,E3,TW,MX) QQ 1 3 9 4 2 2 9 6 5 1 3 G 3 7 6 3 1 5 1 5 0 8 1 1 (CHASSIS) 12 2 3 D 1 4 4 E E E E 1 E F 3 1 2 TO MAIN BOARD CN404 (Page 33) E E E E E E IC501 2 1 E E 3 5 4 6 R551 E SENSOR (FAN)BOARD C530 E C532 E R550 1 C529 2 C531 F 12 C527 www 12 C528 12 1-689-248- 1-689-245- . x ia o y u 1 6 3 L SPEAKER R (IMPEADANCE USE 6-16 ) 37 37 http://www.xiaoyu163.com . c o 12 IC501 F-2 Q501 Q502 Q503 Q504 Q505 Q506 Q507 Q508 Q509 Q510 Q511 Q512 Q513 Q514 Q515 E-2 E-2 E-1 E-3 F-3 E-3 E-4 E-4 D-3 D-4 D-3 E-4 E-4 E-3 E-3 8 9 2 4 9 8 2 9 9 (E2,E3,TW,MX) 6 3 PWR AMP BOARD D-2 E-2 E-1 E-2 E-4 E-4 F-4 F-4 E-4 C-6 C-6 D-6 D-6 D-7 B-2 m 1-689-246- 12 376315150 892498299 376315150 892498299 TEL TO MAIN BOARD CN401 (Page 33) AC IN D501 D502 D503 D504 D505 D506 D507 D508 D509 D901 D902 D903 D904 D905 D907 QQ QQ C Location 13942296513 13942296513 6 1 TEL TEL 230-240V http://www.xiaoyu163.com HCD-HP7 QQ 3 7 6 3 1 5 1 5 0 8-11. Schematic Diagram — PWR AMP/Power Section — • See page 41 for IC Block Diagrams. 8 9 2 4 9 8 2 9 9 FAN SPEAKER IMPEADANCE USE 6-16Ω 3P - 14.3 C516 0.22U + - + C528 0.1U 4P 0 JR502 4P PWR TRANS BOARD C531 14.4 C532 (TO CHASSIS) PROTECT C527 CONT 0.1U FAN DRIVE C530 0 PROTECT SWITCH 0 10 0 9.9 PROTECT SWITCH 0 G RELAY DRIVE 0.4 0.2 2.2 * 13P 9P 0.9 PROTECT SWITCH 0.2 0.8 US,CND TO MAIN BOARD CN401 (Page 34 ) * IC501 QQ JR504 3 7 6 3 1 5SUB1TRANS5 BOARD 0 8 9 2 4 9 8 2 9 9 E2,E3,TW S902 VOLTAGE SELECTOR * JR505 120V E2,E3,TW 220P 220P 220V 230-240V * 3.5P * 10K 1K 3.5P 0 0 9.7 MUTE 2SC3143S 2.7 3.2 47K R521 10 1/2W C524 0.1U C523 0.1U C526 0.1U C525 0.1U * * 1000U 16V Q502,503 OVER LOAD DETECTOR 9.7 0 39.4 220P 2SC3143S 0 R520 10 1/2W * POWER TRANSFORMER (SUB) 47K * US/CND AEP/UK/RU AUX E2/E3/TW MX KR/TH JW901 JW902 56K PWR AMP BOARD 0.7 9.6 Q504,506 OVER HEAT DETECTOR JW903 JW904 0 0 JW905 0 JW906 JW907 0.6 JW908 JW909 JW910 FAN SWITCH JW911 No mark:FM JW912 2P JW913 2P JW914 JW915 SENSOR (FAN) BOARD . JW912 * * * 1K www * * * * *CN905 4P:E2,E3,TW 2P:EXCEPT E2,E3,TW -40.7 40.7 0 0 0 0 39.4 0 0 0 0.6 0 0 1 3 9 4 2 2 9 6 5 1 3 * x ia o y u 1 6 3 38 38 http://www.xiaoyu163.com JW916 . c o m * 376315150 892498299 376315150 892498299 TEL POWER AMP QQ QQ *CN906 4P:E2,E3,TW 2P:EXCEPT E2,E3,TW 13942296513 13942296513 F TO MAIN BOARD CN404 (Page 34 ) TEL TEL 0 3.3 C529 9.9 JW911 * 3.9 POWER TRANSFORMER (MAIN) Q507,508 PROTECT DETECT 4.7K R551 R548 100 4.7K FAN DRIVE R550 JR503 R549 100 15.1 0.22U http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 8-12. IC Block Diagrams — BD Board — VSS VDD5 DRF RES WRQ DO DI CL CE 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 FIN2 MIX + – TIN1 RF DRF BH LPF + – TBAL + – TBAL LPF SW + – LPF + – + – MONI CONT – + VREF RAM DEFECT TRACK JUMP LDD LDS APC SERVO PROCESSOR A/D ADAVDD ADAVSS AUTO ADJUST TDO JITTER DETECT SLCO 1 SLCIST 2 EFMIN 3 RF 4 5 6 FIN1 7 FIN2 8 TIN1 9 TIN2 10 VREF 11 REFI 12 FE 13 TEC 14 TE 15 RFMON 16 JITTC 17 ADAVDD 18 ADAVSS 19 TDO 20 SLICE LEVEL CONTROL SW D/A FDO SPDO SLDO GPDAC QQ 376315150 892498299 DRF DRF RUPTURE DEFECT PDO1 PDO2 FR PLL PCKIST VCEC VVDD VVSS FRAME SYNC DETECT,PROTECT,INSERT, EFM DECODE CLV,CAV CONTROL SBCK/FG FSEQ V/P SUBCODE DECODE CRC 16MOUT XVSS XIN XOUT XVDD CLOCK GENERATOR WRQ CL CE DI DO MONITOR SIGNAL SELECTOR MONI1-5 RAM COMMAND INTERFACE EFLG C2F FSX/16MIN ERROR CORRECTION AUDIO CD CONT1-3 SBCK/CONT6 CONT4,5 DATA DATACK LRSY ASDFIN ASDACK ASLRCK 16MOUT EFLG C2F XVSS FSX/16MIN XIN XOUT XVDD RVDD RCHO RVSS LVSS LCHO LVDD GENERAL PURPOSE PORTS INTERPOLATION MUTE 8FS DIGITAL FILTER ATTENUATION DEEMPHASIS EXTERNAL AUDIO IN ASDFIN ASDACK ASLRCK SERIAL OUT DATA DATACK LRSY AUDIO OUT 1BIT DAC LPF xiaoy u163. com FDO SPDO SLDO GPDAC CONT4 CONT5 SBCK/CONT6 SBCK/FG DEFECT V/P FSEQ MONI1 MONI2 MONI3 MONI4 MONI5 VDD(3.3V) DOUT TEST . 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 FDO SPDO SLDO GPDAC CONT4 CONT5 SBCK/CONT6 SBCK/FG DEFECT V/P FSEQ MONI1 MONI2 MONI3 MONI4 MONI5 VSS www LVDD LVSS LCHO RCHO RVDD RVSS 39 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 SLCO SLCIST EFMIN RF RFVDD RFVSS FIN1 FIN2 TIN1 TIN2 VREF REFI FE TEC TE RFMON JITTC ADAVDD ADAVSS TDO S/H 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 QQ QQ JITTC DATA DATACK LRSY ASDFIN ASDACK ASLRCK 16MOUT EFLG C2F XVSS FSX/16MIN XIN XOUT XVDD RVDD RCHO RVSS LVSS LCHO LVDD 13942296513 13942296513 RFMON LEVEL SET REFI PH AGC EQ TEL TEL TIN2 TEC + – TE FE LDD LDS FIN1 WRQ DO DI CL CE FR VVDD PCKIST VVSS PDO2 PDO1 CONT1 CONT2 CONT3 80 79 FR VVDD PCKIST VVSS PDO2 PDO1 CONT1 CONT2 CONT3 LDD LDS IC721 LC78646E-E http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 WEB RASB 50-46 CASLB 51 CASUB 52 OEB MADRS8 MADRS12 DVDD4 60-53 VSS MADRS7 MADRS0 IC801 LC78684E-E 45 44 43 42 41 13 DVDD5 61 3 VSS 62 16 DATA-I/F STREQ 63 STCK 64 40 33 DRAM-I/F STDAT 65 MDATA15 MDATA8 MP3 DECODER FSYNC 66 TEL TEL CRCF 67 DVDD6 68 CDROM DECODER 13942296513 VSS 69 32 VSS WOK 70 31 DVDD3 MUX CNTOK 71 OVF 72 CMDOUT 73 AUDIO-I/F 3 CMDIN 74 CPU-I/F SYSTEM CLOCK GENERATOR CL 75 CE 76 4 3 4 MDATA7 MDATA0 3 RESB 78 DATACK 80 CKIN VSS 13 14 15 18 19 20 AVSS TEST1 12 VCOC C2FIN 11 VPDO ADLRCK 10 16 17 AVDD ADBCK 9 VPRFR 8 SBCK 7 SFSY 6 SBSY 5 PW 4 DVDD1 3 TEST2 2 CKOUT 1 ADDATA 21 DVDD2 LRSY 376315150 892498299 22 VSS DATAIN 79 5 VO — PANEL Board — IC602 MM1574A VIN 1 BIAS GND 2 DRIVER REFERENCE www CURRENT LIMITTER xiaoy u163. com THERMAL SHUTDOWN 4 CONT 3 . 40 http://www.xiaoyu163.com NOISE 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 QQ QQ INTB 77 30 23 VCO + PLL 13942296513 CD-DA SHOCKPROOF (COMPRESSED OR UNCOMPRESSED) http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 — MAIN Board — IC201 HA12237F TEL TEL 13942296513 QQ PRE DRIVER CH1 376315150 892498299 PRE DRIVER CH2 BIAS CIRCUIT CH2 OUT(+) CH2 OUT(-) +PRE SUB GND CH1 IN CH1 NF 12 13 14 CH2 NF CH2 IN 5 6 7 8 9 10 11 ST-BY 3 4 CH1 OUT(+) CH1 OUT(-) 2 +VCC SUB 1 — CONNECTOR Board — IC701, 711, 721 BA6956AN xiaoy u163. com 1 2 3 4 5 6 7 8 9 OUT1 VM VCC FIN GND RIN . CONTROL LOGIC RNF www TSD OUT2 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 -VCC QQ IC501 STK403-070S VREF 13942296513 — PWR AMP Board — 41 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 8-13. IC Pin Function Description • IC601 LC876796B-51K7-E (SYSTEM CONTROLLER)(PANEL B0ARD) Pin Name I/O 1 SYS MUTE O System muting signal output 2 BU1924 DATA I RDS data input from the tuner 3 CD POWER O Not used (open) 4 LC87646 RESET O Reset signal output to the RF amplifier (IC721) 5 LC87646 CE O Chip enable signal output to the RF amplifier (IC721) 6 LC87684 CE O Chip enable signal output to the MP3 decoder (IC801) 7 M61529 CLK O Clock output to the sound processor (IC301) 8 PT8300 CE O Chip enable signal output to the I/O expander (IC302) 9 LC72121 CE O Chip enable signal output to the tuner 10 LC87684 SYNC I MP3 frame sync signal input from the MP3 decoder (IC801) TEL 11 RESET I Reset signal input 12 XT1 I Resonator terminal (32.768kHz) 13 XT2 O Resonator terminal (32.768kHz) 13942296513 14 VSS1 — Ground terminal 15 CF 1 I Resonator terminal (8MHz) 16 CF 2 O Resonator terminal (8MHz) 17 VDD1 — Power supply terminal 18 TCM I Switch detection signal input from the tape deck 19 TCM1 I Switch detection signal input from the tape deck 20 CDM ELVE-3,2,1 I Sensor signal input from the CD changer QQ 21 I Sensor signal input from the CD changer CDM SLDE-1,0 I Sensor signal input from the CD changer 23 VACS I VACS signal input 24 KEY 2 I Key signal input from the S614 to 622 25 KEY 1 I Key signal input from the S601 to 610 26 KEY 0 I Key signal input from the S627 to 636 27 POWER DOWN I Power down detection signal input from the IC603 28 REMCON IN I Remote control signal input from the remote sensor (RM601) 29 BU1924 CLK I RDS clock input from the tuner 30 to 41 G12 to G1 O Grid signal output to the fluorescent indicator tube 42 to 45 P1 to P4 O Segment output to the fluorescent indicator tube 46 VDD3 — Power supply terminal 47 to 50 P5 to P8 O Segment output to the fluorescent indicator tube 51 VPP — Power supply terminal (negative) 52 to 65 P9 to P22 O Segment output to the fluorescent indicator tube 66 CDM SW5-B I Stocker in/out switch signal input from the CD changer 67 CDM SW5-A I Disc position switch signal input from the CD changer 68 CDM SW4 I Stocking switch signal input from the CD changer 69 CDMSW2-B I Disc in (8cm) switch signal input from the CD changer 70 CDM SW2-A I Disc in (play) switch signal input from the CD changer 71 CDMSW1-A I Disc insert switch signal input from the CD changer 72 VDD4 — 73 CDM SW3 I www 74 TUNER TUNED I 75 TUNER STEREO I 76 CD DRF I 77 CD WRQ 78 CD MUTE 79 VR ENCODER A . I O I Power supply terminal Disc out switch signal input from the CD changer xiaoy u163. com Tuner tuned status signal input from the tuner Stereo/mono signal input from the tuner DRF signal input from the RF amplifier (IC721) Subcode Q output standby signal input from the RF amplifier (IC721) Not used (open) Volume signal input from the rotary encoder (VR601) 42 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 22 QQ SLDE-3,2 13942296513 CDM ELVE-0/ Description TEL Pin No. http://www.xiaoyu163.com HCD-HP7 I/O VR ENCODER B I Volume signal input from the rotary encoder (VR601) 81 CDM D.SENSOR I Disc detection signal input 82 PROTECTOR I Protection signal input from the power amplifier circuit 83 TAPE END I Tape end detection signal input from the tape deck 84 MODE SW IN I Mode setting signal input 85 LINE MUTE O Line muting signal output 86 DISC5 LED O Disc LED control signal output 87 DISC4 LED O Disc LED control signal output 88 DISC3 LED O Disc LED control signal output 89 VSS2 — Ground terminal 90 VDD2 — Power supply terminal 91 DISC2 LED O Disc LED control signal output 92 DISC1 LED O Disc LED control signal output 13942296513 93 POWER LED O Power LED control signal output 94 POWER RELAY O Power relay on/off control signal output O Data output to the tuner, the sound processor (IC301) and the I/O expander (IC302) I Data input from the tuner O Clock output to the tuner and the I/O expander (IC302) QQ Description 98 O Serial command data output to the RF amplifier (IC721) and the MP3 decoder (IC801) 13942296513 Pin Name 80 TEL Pin No. TEL QQ 376315150 892498299 LC72121/M61529/ 95 96 97 PT8300 DO LC72121 DI LC72121/PT8300 CLK DO 99 100 LC87646/LC78684 DI LC87646/LC78684 www CLK . QQ 376315150 892498299 I Serial command data input from the RF amplifier (IC721) and the MP3 decoder (IC801) O Serial command clock output to the RF amplifier (IC721) and the MP3 decoder (IC801) 376315150 892498299 376315150 892498299 TEL 13942296513 QQ LC87646/LC78684 xiaoy u163. com 43 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 SECTION 9 EXPLODED VIEWS QQ 376315150 892498299 NOTE: • -XX, -X mean standardized parts, so they may have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Abbreviation AUS : Australian model. CND: Canadian model. E2 : 120 V AC area in E model. E3 : 220-240 V AC area in E model. KR : Korean model. MX : Mexican model. RU : Russian model. TH : Thai model. TW : Taiwan model. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. 9-1. Case, Top Panel Section 4 8 9 #2 3 TEL TEL 10 14 5 13942296513 13942296513 14 1 #2 2 6 11 6 7 12 6 #2 #1 6 not supplied 1 13 #1 chassis section 1 front panel section #1 Ref. No. 1 1 2 2 3 4 5 6 7 8 Part No. Description 3-363-099-71 3-363-099-81 4-246-394-01 4-246-394-11 4-246-395-01 SCREW (CASE 3 TP2)(EXCEPT KR) SCREW (CASE 3 TP2)(KR) CASE (SIDE-L)(US) CASE (SIDE-L)(EXCEPT US) LID (TC) 4-246-396-01 4-232-195-01 4-951-620-01 4-231-776-01 4-246-390-01 WINDOW (TC) SPRING (LID) SCREW (2.6X8), +BVTP SPRING, CASSETTE DETENT PANEL (L), SUB TOP www . Remark Ref. No. Part No. Description 9 9 10 11 12 4-246-389-01 4-246-389-11 4-246-391-01 1-827-392-11 1-796-351-41 PANEL, TOP (US) PANEL, TOP (EXCEPT US) PANEL (R), SUB TOP WIRE (FLAT TYPE)(8 CORE) MECHANISM, SINGLE CASSETTE 13 13 14 #1 #2 4-246-393-01 4-246-393-11 4-246-403-01 7-685-646-79 7-685-650-79 CASE (SIDE-R)(US) CASE (SIDE-R)(EXCEPT US) SPACER SCREW +BVTP 3X8 TYPE2 IT-3 SCREW +BVTP 3X16 TYPE2 IT-3 xiaoy u163. com 44 http://www.xiaoyu163.com Remark 376315150 892498299 376315150 892498299 TEL 13942296513 QQ QQ QQ 376315150 892498299 1 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 9-2. Front Panel Section 63 60 59 58 64 65 55 61 57 56 TEL TEL 66 62 13942296513 13942296513 54 66 55 57 QQ QQ 66 53 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 67 68 52 69 70 Ref. No. 51 Part No. Description Part No. Description 51 52 53 54 55 4-225-252-01 4-246-397-01 4-246-384-01 4-246-385-01 4-246-382-01 CUSHION (FOOT) EMBLEM (5CD) KNOB (VOL) RING (VOL) BUTTON (FUNCTION) 63 64 64 64 64 1-769-920-11 A-4734-337-A A-4734-349-A A-4734-360-A A-4747-533-A WIRE (FLAT TYPE)(9 CORE) PANEL BOARD, COMPLETE (US,CND) PANEL BOARD, COMPLETE (AEP,UK,RU) PANEL BOARD, COMPLETE (E3,TW) PANEL BOARD, COMPLETE (MX,E2) 56 56 56 57 58 4-246-374-01 4-246-374-11 4-246-374-21 4-246-383-01 4-246-379-01 PANEL, FRONT (US) PANEL, FRONT (AEP,UK) PANEL, FRONT (EXCEPT US,AEP,UK) BUTTON (PRESET) BUTTON (POWER) 64 64 65 66 67 A-4747-535-A A-4747-545-A 1-827-395-11 4-951-620-01 4-246-388-01 PANEL BOARD, COMPLETE (KR,AUS) PANEL BOARD, COMPLETE (TH) WIRE (FLAT TYPE)(37 CORE) SCREW (2.6X8), +BVTP BUTTON (EJECT) INDICATOR (POWER) BUTTON (PLAY) WINDOW (DISPLAY) BUTTON (DISPLAY) 68 69 70 4-246-387-01 INDICATOR (DISC) 4-246-386-01 BUTTON (DISC) 4-246-375-01 PANEL, SUB www 59 60 61 62 4-246-378-01 4-246-381-01 4-246-376-01 4-246-380-01 . Remark Ref. No. Remark xiaoy u163. com 45 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 QQ 376315150 892498299 9-3. Chassis Section-1 not supplied 103 #3 101 #1 #1 #3 #1 #1 T901 #4 not supplied 105 #5 #5 #1 102 F904 F905 F903 F901 104 #1 13942296513 13942296513 107 #1 106 109 #1 chassis section Ref. No. Part No. Description Ref. No. Part No. 101 102 102 103 104 1-689-250-11 A-4734-342-A A-4747-550-A 1-689-248-12 1-689-246-12 PWR TRANS BOARD PWR AMP BOARD, COMPLETE (EXCEPT TH) PWR AMP BOARD, COMPLETE (TH) SENSOR (FAN) BOARD SUB TRANS BOARD Remark 0 F902 105 106 107 107 107 1-787-025-11 4-225-252-01 1-693-625-11 1-693-626-11 1-693-627-11 DC FAN CUSHION (FOOT) TUNER (FM/AM)(US,CND) TUNER (FM/AM)(AEP,UK) TUNER (FM/AM)(RU) 0 F904 1-533-473-11 FUSE, GLASS TUBE (DIA. 5)(T6.3AL/250V) (EXCEPT US,CND,MX) 1-533-451-11 FUSE, GLASS TUBE (DIA. 5)(T3.15AL/125V) (US,CND,MX) 1-533-470-11 FUSE, GLASS TUBE (DIA. 5)(T3.15AL/250V) (EXCEPT US,CND,MX) 1-533-451-11 FUSE, GLASS TUBE (DIA. 5)(T3.15AL/125V) (US,CND,MX) 1-533-470-11 FUSE, GLASS TUBE (DIA. 5)(T3.15AL/250V) (EXCEPT US,CND,MX) 107 107 108 108 109 1-693-628-11 1-693-629-11 1-769-946-11 1-773-009-11 A-4734-344-A TUNER (FM/AM)(E2,E3,TW,TH,MX,AUS) TUNER (FM/AM)(KR) WIRE (FLAT TYPE)(11 CORE)(EXCEPT AEP,UK) WIRE (FLAT TYPE)(15 CORE)(AEP,UK) MAIN BOARD, COMPLETE (EXCEPT AEP,UK,TH) 0 F903 0 F903 0 F904 0 F905 109 109 0 F901 A-4734-354-A MAIN BOARD, COMPLETE (AEP,UK) A-4747-553-A MAIN BOARD, COMPLETE (TH) 1-533-454-11 FUSE, GLASS TUBE (DIA. 5)(T6.3AL/125V) (US,CND,MX) 1-533-473-11 FUSE, GLASS TUBE (DIA. 5)(T6.3AL/250V) (EXCEPT US,CND,MX) 1-533-454-11 FUSE, GLASS TUBE (DIA. 5)(T6.3AL/125V) (US,CND,MX) www 0 F901 0 F902 . 0 T901 0 T901 0 T901 #1 #3 #4 #5 #8 Description Remark 1-533-471-11 FUSE, GLASS TUBE (DIA. 5)(T4AL/250V) (E2,E3,TW) 1-439-827-11 TRANSFORMER, POWER (E2,E3,KR,TW,TH,AUS) 1-439-828-11 TRANSFORMER, POWER (US,CND,MX) 1-439-829-11 TRANSFORMER, POWER (AEP,UK,RU) 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 7-685-881-09 7-682-552-09 7-684-023-04 7-685-647-79 SCREW +BVTT 4X8 (S) SCREW +B 3X16 N 3, TYPE 2 SCREW +BVTP 3X10 TYPE2 IT-3 xiaoy u163. com The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 46 http://www.xiaoyu163.com Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. 376315150 892498299 376315150 892498299 QQ 376315150 892498299 QQ QQ 108 TEL 13942296513 TEL TEL #8 F902 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 9-4. Chassis Section-2 151 152 not supplied #1 153 not supplied TEL TEL 13942296513 13942296513 #1 #1 CD mechanism deck section-1 155 QQ QQ 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 156 157 not supplied 157 Ref. No. Part No. Description 0 151 0 151 0 151 0 151 0 151 1-690-608-11 1-769-079-22 1-783-531-11 1-783-532-11 1-791-901-12 CORD, POWER (AUS) CORD, POWER (KR) CORD, POWER (US,CND) CORD, POWER (AEP,UK,RU,TW) CORD, POWER (E2,E3,MX) 0 151 152 1-824-818-11 CORD, POWER (WITH CONNECTOR) (TH) 3-703-571-11 BUSHING (S)(4516), CORD (E2,E3,MX) www . Remark Ref. No. Part No. Description * 152 153 155 156 157 3-703-244-00 4-988-533-01 1-827-390-11 1-827-393-11 3-378-109-12 BUSHING (2104), CORD (EXCEPT E2,E3,MX) HOLDER, PWB WIRE (FLAT TYPE)(27 CORE) WIRE (FLAT TYPE)(19 CORE) CUSHION, SARANET xiaoy u163. com #1 Remark 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. 47 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 9-5. CD Mechanism Section-1 (CDM69CH-K6BD71C) not supplied 304 302 #4 S702 303 TEL TEL 301 #4 M761 306 13942296513 13942296513 not supplied 312 not supplied 308 309 CD mechanism deck section-2 307 302 310 #4 Ref. No. Part No. Description 301 302 303 304 306 1-686-725-12 4-951-620-01 4-239-690-01 4-239-618-01 4-239-687-01 STOCKER MOTOR BOARD SCREW (2.6X8), +BVTP CAM (STOCKER U/D) SCREW (+PWH,2X6), STEP TAPPING GEAR (STOCKER COMMUNICATION) 307 308 A-4731-113-A CONNECTOR BOARD, COMPLETE 4-239-689-01 GEAR (STOCKER DECELERATION) www . Remark Ref. No. Part No. Description 309 310 312 M761 S702 4-239-698-01 4-211-237-01 4-986-156-01 A-4735-953-A 1-477-299-11 PULLEY (STOCKER) BELT (MODE) PULLEY, MOTOR MOTOR ASSY (STOCKER) ENCODER, ROTARY (STOCKER POSITION) #4 7-685-902-21 SCREW +PTPWH 2.6X8 (TYPE2) xiaoy u163. com 48 http://www.xiaoyu163.com Remark 376315150 892498299 376315150 892498299 302 QQ QQ QQ 376315150 892498299 TEL 13942296513 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 9-6. CD Mechanism Section-2 (CDM69CH-K6BD71C) 352 353 354 355 #5 355 351 TEL TEL 13942296513 13942296513 CD mechanism deck section-3 357 QQ QQ QQ 376315150 892498299 376315150 892498299 376315150 892498299 TEL 13942296513 CD mechanism deck section-4 356 optical pick-up section Ref. No. 351 352 353 354 Part No. Description 1-686-727-12 1-686-728-12 1-686-729-12 1-686-730-12 SW (1) BOARD SW (2) BOARD SW (3) BOARD SW (4) BOARD www . Remark Ref. No. 355 356 357 #5 Part No. Description 4-951-620-01 4-985-672-01 4-227-899-01 7-685-533-14 SCREW (2.6X8), +BVTP SCREW (+PTPWHM2.6), FLOATING SCREW (DIA. 12), FROATING SCREW +BTP 2.6X6 TYPE2 N-S Remark xiaoy u163. com 49 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 9-7. CD Mechanism Section-3 (CDM69CH-K6BD71C) 407 not supplied 406 not supplied not supplied 405 409 421 413 not supplied 411 409 408 413 13942296513 13942296513 415 402 412 not supplied 405 414 416 376315150 892498299 404 418 403 404 419 402 402 422 418 423 418 402 417 418 402 401 Ref. No. Part No. Description Part No. Description 401 402 403 404 405 X-4955-448-1 4-992-069-01 4-239-648-01 4-239-646-01 4-239-641-01 PULLEY(A)(KSM213)ASSY,CHUCKING SCREW (+PTPWH)(M2)(DIA. 7) PARASOL (ROLLER) ROLLER (ROLLER) SPRING (1.2), TENSION 413 414 415 416 417 4-243-291-01 4-240-039-01 4-239-702-01 4-985-672-01 4-243-713-01 SPRING, TORSION LEVER (DISC STOPPER) ROLLER (DISC STOPPER) SCREW (+PTPWHM2.6), FLOATING LEVER (LIFTER) 406 407 408 409 411 4-239-642-01 4-239-679-01 4-243-703-01 4-239-649-01 4-244-035-01 SPRING (3), TENSION COIL SPRING (5), TENSION COIL YOKE (213) PARASOL (STOCKER) ROLLER (STOCKER), RUBBER 418 419 420 421 422 4-239-647-01 4-243-916-01 4-241-599-01 4-239-643-01 1-471-244-11 PARASOL (MAIN) ROLLER (S), RUBBER LEVER (SUPPORT) SPRING (4), TENSION COIL MAGNET 412 4-239-640-01 PINION (SLIDER) 423 4-244-032-01 ROLLER, RUBBER www . Remark Ref. No. xiaoy u163. com 50 http://www.xiaoyu163.com Remark 376315150 892498299 QQ 376315150 892498299 not supplied QQ QQ 415 TEL 13942296513 TEL TEL 420 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 9-8. CD Mechanism Section-4 (CDM69CH-K6BD71C) #6 457 #6 457 467 454 457 454 458 457 453 456 455 455 #6 457 457 452 456 454 451 463 461 464 453 not supplied 465 475 457 461 452 461 466 451 461 457 460 466 QQ QQ 456 455 13942296513 13942296513 455 456 458 470 471 462 #6 469 468 452 457 458 453 456 #6 TEL TEL 458 470 #6 455 472 TEL 13942296513 453 473 not supplied 376315150 892498299 376315150 892498299 QQ 376315150 892498299 454 474 452 M781 451 CD mechanism deck section-5 Ref. No. Part No. Description Part No. Description 451 452 453 454 455 X-4954-626-1 4-239-666-01 4-239-668-01 4-239-652-01 4-239-669-01 LEVER (ROLLER) ASSY GEAR LEVER (CENTER) SCREW (ROLLER), STEP GEAR (ROLLER COMMUNICATION) 465 466 467 468 469 4-240-041-01 4-951-620-01 4-243-916-01 4-244-035-01 4-241-209-01 SPRING (SLIDER 2), TENSION SCREW (2.6X8), +BVTP ROLLER (S), RUBBER ROLLER (STOCKER), RUBBER SHEET, ADHESIVE 456 457 458 460 461 4-239-667-01 4-239-647-01 4-244-032-01 X-4954-622-1 4-239-670-01 GEAR (ROLLER CENTER) PARASOL (MAIN) ROLLER, RUBBER BASE (SLIDER 2) ASSY GEAR (ROLLER 5 COMMUNICATION) 470 471 472 473 474 4-239-649-01 4-239-671-01 X-4954-627-1 1-686-726-12 4-986-156-01 PARASOL (STOCKER) GEAR (ROLLER 5 CENTER) BASE (SLIDER 5) ASSY ROLLER MOTOR BOARD PULLEY, MOTOR 462 463 464 X-4954-624-A LEVER (SLIDER 4) ASSY 4-992-069-01 SCREW (+PTPWH)(M2)(DIA. 7) 4-240-981-01 SPRING (BASE SLIDER 5),TENSION 475 M781 #6 4-244-162-01 SPRING (SLIDER 4),TENSION A-4735-953-A MOTOR ASSY (ROLLER) 7-623-921-01 RING, RETAINING, CAPSTAN www . Remark Ref. No. Remark xiaoy u163. com 51 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 9-9. CD Mechanism Section-5 (CDM69CH-K6BD71C) 504 503 505 TEL TEL 503 13942296513 13942296513 505 502 501 CD mechanism sdeck ection-6 507 509 508 Ref. No. 501 502 503 504 505 Part No. Description 4-240-020-01 4-239-708-02 4-239-697-01 X-4955-15701 4-239-706-02 GEAR (TIMING) BELT (FRONT), TIMING GEAR (CENTER) SLIDER (MODE CAM V) ASSY BELT (REAR), TIMING www . Remark Ref. No. 506 507 508 509 #4 #4 Part No. Description 4-239-699-01 4-247-349-02 4-227-899-01 4-239-686-01 7-685-902-21 PULLEY BELT (ROLLER V) SCREW (DIA. 12), FROATING GEAR (ROLLER DECELERATION) SCREW +PTPWH 2.6X8 (TYPE2) xiaoy u163. com 52 http://www.xiaoyu163.com Remark 376315150 892498299 376315150 892498299 506 QQ QQ QQ 376315150 892498299 TEL 13942296513 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 9-10. CD Mechanism Section-6 (CDM69CH-K6BD71C) 563 575 M771 not supplied 565 not supplied 576 551 #4 TEL TEL #4 13942296513 13942296513 554 #4 #4 553 558 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 not supplied 555 QQ QQ 569 #4 564 555 560 570 557 #4 572 562 563 559 552 567 563 563 #4 #4 S771 561 571 566 #4 #4 Ref. No. Part No. Description Part No. Description 551 552 553 554 555 4-239-693-02 1-686-723-12 4-239-696-01 4-239-695-02 4-240-019-01 CAM (GEAR) SENSOR BOARD GEAR (EJECT LOCK) CAM (EJECT LOCK) GEAR (MODE 5) 565 566 567 569 570 4-239-694-01 4-241-731-01 4-241-732-01 4-241-734-01 4-241-735-01 GEAR (MODE CAM) SHUTTER (A), LEVER SHUTTER (B), LEVER SHAFT (SHUTTER) SPRING (SHUTTER), COMPRESSION 557 558 559 560 561 4-243-682-01 4-239-683-01 4-243-702-01 4-243-683-01 4-239-618-01 GEAR (MODE C) PULLEY (MODE DECELERATION) BELT (MODE V) GEAR (MODE D) SCREW (+PWH,2X6), STEP TAPPING 571 572 575 576 M771 4-227-899-01 4-243-680-01 1-686-724-12 4-986-156-01 A-4735-953-A SCREW (DIA. 12), FROATING GEAR (MODE A) MODE MOTOR BOARD PULLEY, MOTOR MOTOR ASSY (MODE) 562 563 564 4-243-681-01 GEAR (MODE B) 4-951-620-01 SCREW (2.6X8), +BVTP 4-239-692-02 CAM (BU U/D) S771 #4 1-477-300-11 ENCODER, ROTARY (MODE) 7-685-902-21 SCREW +PTPWH 2.6X8 (TYPE2) www . Remark Ref. No. Remark xiaoy u163. com 53 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 QQ 376315150 892498299 9-11. Optical Pick-up Section (KSM-213D) 604 603 607 608 604 TEL TEL 603 604 603 13942296513 13942296513 604 603 601 QQ 376315150 892498299 #7 601 601 not supplied 601 Ref. No. 601 602 603 Part No. Description Remark 4-229-806-01 SPRING (213), COMPRESSION A-4747-707-A BD BOARD, COMPLETE 4-227-679-01 INSULATOR (213) www . Ref. No. Part No. Description Remark 604 0 607 #7 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING A-4735-357-A BASE ASSY, OP (KSM-213D) 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S xiaoy u163. com The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 54 http://www.xiaoyu163.com Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. 376315150 892498299 376315150 892498299 TEL 13942296513 QQ QQ 602 http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 SECTION 10 ELECTRICAL PARTS LIST QQ 376315150 892498299 NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • CAPACITORS: uF: µF • COILS uH: µH • Accessories are given in the last of this parts list. Ref. No. Part No. • • • RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... Abbreviation AUS : Australian model. CND: Canadian model. E2 : 120 V AC area in E model. E3 : 220-240 V AC area in E model. KR : Korean model. Description Remarks CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP 0.1uF 100uF 0.1uF 47uF 0.001uF C706 C707 C708 C709 C710 1-164-156-11 1-126-392-11 1-164-156-11 1-126-392-11 1-165-176-11 CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP 0.1uF 100uF 0.1uF 100uF 0.047uF C711 C712 C713 C714 C715 1-164-156-11 1-162-949-11 1-162-968-11 1-164-156-11 1-126-401-21 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP 0.1uF 47PF 5% 0.0047uF 10% 0.1uF 1uF 20% C716 C717 C718 C719 C720 1-162-964-11 1-162-968-11 1-115-156-11 1-162-968-11 1-162-953-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001uF 0.0047uF 1uF 0.0047uF 100PF C721 C722 C723 C729 C731 1-164-156-11 1-164-156-11 1-126-392-11 1-128-360-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP 0.1uF 0.1uF 100uF 220uF 0.1uF C732 C733 C734 C735 C741 1-162-970-11 1-162-970-11 1-162-917-11 1-162-918-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 0.01uF 15PF 18PF 0.1uF C742 C743 C744 C746 C747 1-164-156-11 1-165-176-11 1-125-837-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.047uF 1uF 0.1uF 0.1uF C748 C753 C754 C756 C761 1-128-360-11 1-162-949-11 1-162-949-11 1-162-949-11 1-162-941-11 ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 220uF 47PF 47PF 47PF 10PF TEL 13942296513 www . 20% 20% 10% 20% 20% 10% 10% 10% 10% 5% 20% 20% 10% 10% 5% 5% 10% 10% 25V 6.3V 25V 6.3V 50V 25V 6.3V 25V 6.3V 16V The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. Part No. Description Remarks C802 C803 C804 C805 C806 1-164-156-11 1-162-970-11 1-162-945-11 1-126-392-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP 0.1uF 0.01uF 22PF 100uF 0.1uF C807 C810 C811 C812 C813 1-126-392-11 1-164-156-11 1-164-156-11 1-115-156-11 1-164-156-11 ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100uF 0.1uF 0.1uF 1uF 0.1uF 20% 6.3V 25V 25V 10V 25V C814 C815 C816 C817 C823 1-126-392-11 1-128-360-11 1-164-156-11 1-164-156-11 1-162-949-11 ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100uF 220uF 0.1uF 0.1uF 47PF 20% 20% 5% 6.3V 10V 25V 25V 50V C824 C825 C829 C830 C831 1-162-949-11 1-162-949-11 1-162-949-11 1-162-945-11 1-162-945-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 47PF 47PF 47PF 22PF 22PF 5% 5% 5% 5% 5% 50V 50V 50V 50V 50V C834 C835 C837 C843 C844 1-128-360-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 220uF 0.1uF 0.1uF 0.1uF 0.1uF 20% 10V 25V 25V 25V 25V C856 C857 C858 C859 C860 1-115-156-11 1-162-945-11 1-162-945-11 1-162-945-11 1-162-953-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 1uF 22PF 22PF 22PF 100PF 10% 5% 20% 25V 25V 50V 6.3V 25V QQ 376315150 892498299 25V 50V 50V 25V 50V 50V 50V 10V 50V 50V 25V 25V 6.3V 10V 25V 25V 25V 50V 50V 25V 25V 16V 6.3V 25V 25V 5% 5% 5% 5% 376315150 892498299 376315150 892498299 1-164-156-11 1-126-392-11 1-164-156-11 1-126-391-11 1-162-964-11 When indicating parts by reference number, please include the board name. QQ QQ C701 C702 C703 C704 C705 : Mexican model. : Russian model. : Thai model. : Taiwan model. 13942296513 13942296513 < CAPACITOR > MX RU TH TW TEL TEL A-4747-707-A BD BOARD, COMPLETE ******************* Ref. No. BD 10V 50V 50V 50V 50V < CONNECTOR > CN708 CN710 1-817-244-11 CONNECTOR, FFC 16P 1-778-874-11 CONNECTOR, FFC (LIF(NON-ZIF)) 19P < FERRITE BEAD > FB701 FB707 FB708 FB761 FB801 1-550-907-21 1-550-907-21 1-550-907-21 1-550-907-21 1-550-907-21 BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) FB802 FB803 FB804 1-550-907-21 BEAD, FERRITE (CHIP) 1-550-907-21 BEAD, FERRITE (CHIP) 1-550-907-21 BEAD, FERRITE (CHIP) xiaoy u163. com 20% 5% 5% 5% 0.5PF 10V 50V 50V 50V 50V 55 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 QQ 376315150 892498299 BD Ref. No. FB805 FB806 FB807 FB808 CONNECTOR Part No. Description 1-550-907-21 1-550-907-21 1-550-907-21 1-550-907-21 BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) Remarks < IC > IC721 IC722 IC801 IC802 IC803 6-701-796-01 6-704-220-01 6-704-008-01 6-704-009-01 6-704-007-01 IC IC IC IC IC LC78646E-E BA5836FP LC78684E-E LC32V4265CT-25-MPB-E MM1571J < TRANSISTOR > Q701 Ref. No. Part No. Description Remarks 100 100 100 5% 5% 5% 1/10W 1/10W 1/10W R806 R807 R817 R818 R819 1-216-809-11 1-216-809-11 1-216-827-11 1-216-811-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 3.3K 150 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R820 R823 R824 R825 R826 1-216-821-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 100 100 100 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R827 R828 R829 R832 R833 1-216-809-11 1-216-809-11 1-216-809-11 1-216-825-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 100 2.2K 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R834 R860 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 100 100 5% 5% 1/10W 1/10W 8-729-054-57 TRANSISTOR KTN2907AS-RTK < RESISTOR > METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 15K 15K 15K 15K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R706 R707 R708 R709 R711 1-216-841-11 1-216-797-11 1-216-833-11 1-216-838-11 1-216-815-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 10 10K 27K 330 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R713 R714 R715 R716 R717 1-216-821-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 100 100 100 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R718 R719 R720 R721 R722 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 100 100 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R725 R726 R727 R728 R729 1-216-819-11 1-216-819-11 1-216-809-11 1-216-841-11 1-216-834-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 680 100 47K 12K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R730 R731 R732 R738 R739 1-216-822-11 1-216-825-11 1-216-864-11 1-218-867-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1.2K 2.2K 0 6.8K 0 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R740 R741 R744 R745 R746 1-218-867-11 1-216-864-11 1-216-845-11 1-216-809-11 1-216-803-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 6.8K 0 100K 100 33 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R747 R760 R761 R762 R765 1-216-803-11 1-216-809-11 1-216-821-11 1-216-825-11 1-216-857-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 33 100 1K 2.2K 1M 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R801 R802 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP . 100 100 5% 5% 1/10W 1/10W TEL 13942296513 www < SWITCH > S701 1-771-853-11 SWITCH, DETECTION (LIMIT IN) < VIBRATOR > X701 1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHz) ************************************************************ QQ 376315150 892498299 A-4731-113-A CONNECTOR BOARD,COMPLETE *************************** < CAPACITOR > C711 C751 C752 C753 C754 1-126-795-11 1-164-159-21 1-164-159-21 1-164-159-21 1-164-159-21 ELECT CERAMIC CERAMIC CERAMIC CERAMIC 10uF 0.1uF 0.1uF 0.1uF 0.1uF 20.00% 50V 50V 50V 50V 50V C755 C756 C758 C761 C762 1-164-159-21 1-164-159-21 1-164-159-21 1-162-306-11 1-164-159-21 CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC 0.1uF 0.1uF 0.1uF 0.01uF 0.1uF 50V 50V 50V 30.00% 16V 50V C763 C764 C765 C766 C767 1-164-159-21 1-164-159-21 1-164-159-21 1-164-159-21 1-164-159-21 CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF C768 C769 C771 C781 1-164-159-21 1-164-159-21 1-162-306-11 1-162-306-11 CERAMIC CERAMIC CERAMIC CERAMIC 0.1uF 0.1uF 0.01uF 0.01uF 50V 50V 50V 50V 50V 50V 50V 30.00% 16V 30.00% 16V < CONNECTOR > xiaoy u163. com CN701 CN702 CN703 * CN710 1-779-564-21 1-785-329-11 1-785-328-11 1-506-486-11 56 http://www.xiaoyu163.com CONNECTOR,FFC (LIF (NON-ZIF)) 27P PIN,CONNECTOR (LIGHT ANGLE) 3P PIN,CONNECTOR (LIGHT ANGRE) 2P PIN,CONNECTOR 7P 376315150 892498299 376315150 892498299 1-216-841-11 1-216-835-11 1-216-835-11 1-216-835-11 1-216-835-11 QQ QQ R701 R702 R703 R704 R705 13942296513 13942296513 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP TEL TEL R803 R804 R805 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 CONNECTOR Ref. No. Part No. Description Remarks < DIODE > D701 D711 D721 8-719-921-40 DIODE MTZJ-T-77-4.7B 8-719-109-89 DIODE MTZJ-T-77-5.6B 8-719-982-03 DIODE MTZJ-T-77-3.6A < IC > IC701 IC711 IC721 8-759-598-69 IC BA6956AN 8-759-598-69 IC BA6956AN 8-759-598-69 IC BA6956AN < TRANSISTOR > Q731 8-729-029-66 TRANSISTOR Remarks C226 C227 C228 C229 C235 1-126-963-11 1-128-551-11 1-162-966-11 1-162-966-11 1-130-479-00 ELECT ELECT CERAMIC CHIP CERAMIC CHIP MYLAR 4.7uF 22uF 0.0022uF 0.0022uF 0.0047uF 20.00% 20.00% 10% 10% 5% 50V 25V 50V 50V 50V C236 C237 C238 C239 C240 1-130-485-00 1-130-485-00 1-130-485-00 1-126-963-11 1-126-964-11 MYLAR MYLAR MYLAR ELECT ELECT 0.015uF 0.015uF 0.015uF 4.7uF 10uF 5% 5% 5% 20.00% 20.00% 50V 50V 50V 50V 50V C301 C302 C303 C304 C305 1-126-964-11 1-126-964-11 1-104-665-11 1-104-665-11 1-126-964-11 ELECT ELECT ELECT ELECT ELECT 10uF 10uF 100uF 100uF 10uF 20.00% 20.00% 20.00% 20.00% 20.00% 50V 50V 10V 10V 50V 680 100 680 100 680 5% 5% 5% 5% 5% 1/4W F 1/4W 1/4W F 1/4W 1/4W F C306 C308 C309 C310 C311 1-126-964-11 1-109-953-11 1-126-964-11 1-126-964-11 1-126-964-11 ELECT ELECT ELECT ELECT ELECT 10uF 2.2uF 10uF 10uF 10uF 20.00% 20.00% 20.00% 20.00% 20.00% 50V 50V 50V 50V 50V R722 1-247-807-31 CARBON 100 5% 1/4W R731 1-247-807-31 CARBON 100 5% 1/4W R732 1-249-417-11 CARBON 1K 5% 1/4W F R733 1-249-429-11 CARBON 10K 5% 1/4W R734 1-249-430-11 CARBON 12K 5% 1/4W ************************************************************ C312 C313 C314 C316 C317 1-126-964-11 1-126-964-11 1-126-964-11 1-162-962-11 1-126-964-11 ELECT ELECT ELECT CERAMIC CHIP ELECT 10uF 10uF 10uF 470PF 10uF 20.00% 20.00% 20.00% 10% 20.00% 50V 50V 50V 50V 50V A-4734-344-A MAIN BOARD,COMPLETE (EXCEPT AEP,UK,TH) A-4734-354-A MAIN BOARD,COMPLETE (AEP,UK) A-4747-553-A MAIN BOARD,COMPLETE (TH) ********************* C318 C319 C320 C321 C322 1-126-964-11 1-136-161-00 1-136-157-00 1-136-157-00 1-126-916-11 ELECT FILM FILM FILM ELECT 10uF 0.047uF 0.022uF 0.022uF 1000uF 20.00% 5.00% 5.00% 5.00% 20.00% 50V 50V 50V 50V 6.3V C323 C324 C325 C326 C327 1-136-157-00 1-136-157-00 1-136-161-00 1-136-161-00 1-130-476-00 FILM FILM FILM FILM MYLAR 0.022uF 0.022uF 0.047uF 0.047uF 0.0027uF 5.00% 5.00% 5.00% 5.00% 5% 50V 50V 50V 50V 50V C328 C329 C330 C331 C332 1-130-476-00 1-126-964-11 1-126-964-11 1-136-165-00 1-136-165-00 MYLAR ELECT ELECT FILM FILM 0.0027uF 10uF 10uF 0.1uF 0.1uF 5% 20.00% 20.00% 5.00% 5.00% 50V 50V 50V 50V 50V C333 C334 C338 C340 C341 1-136-164-00 1-136-164-00 1-164-227-11 1-162-960-11 1-162-960-11 FILM FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.082uF 0.082uF 0.022uF 220PF 220PF 5.00% 5.00% 10% 10% 10% 50V 50V 25V 50V 50V C342 C343 C344 C345 C346 1-126-964-11 1-162-953-11 1-164-156-11 1-162-953-11 1-162-964-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10uF 100PF 0.1uF 100PF 0.001uF 20.00% 50V 5% 50V 25V 5% 50V 10% 50V 10uF 10uF 10uF 10uF 0.001uF 20.00% 20.00% 20.00% 20.00% 10% QQ 376315150 892498299 TEL 13942296513 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 376315150 892498299 376315150 892498299 20.00% 50V 20.00% 16V QQ QQ 4.7uF 100uF 13942296513 13942296513 CARBON CARBON CARBON CARBON CARBON Description 1-126-963-11 ELECT 1-126-933-11 ELECT TEL TEL 1-249-415-11 1-247-807-31 1-249-415-11 1-247-807-31 1-249-415-11 Part No. C224 C225 RT1N141S-TP < RESISTOR > R701 R702 R711 R712 R721 Ref. No. MAIN < CAPACITOR > C101 1-162-970-11 CERAMIC CHIP 0.01uF C102 1-162-970-11 CERAMIC CHIP 0.01uF C201 C202 C203 1-162-964-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 1-126-947-11 ELECT 0.001uF 0.001uF 47uF 25V (AEP,UK) 10% 25V (AEP,UK) 10% 50V 10% 50V 20.00% 16V C204 C205 C206 C207 C208 1-126-947-11 1-126-960-11 1-130-485-00 1-130-485-00 1-126-960-11 ELECT ELECT MYLAR MYLAR ELECT 47uF 1uF 0.015uF 0.015uF 1uF 20.00% 20.00% 5% 5% 20.00% 16V 50V 50V 50V 50V C209 C210 C211 C212 C213 1-126-960-11 1-126-961-11 1-126-961-11 1-126-960-11 1-126-960-11 ELECT ELECT ELECT ELECT ELECT 1uF 2.2uF 2.2uF 1uF 1uF 20.00% 20.00% 20.00% 20.00% 20.00% 50V 50V 50V 50V 50V C214 C215 C216 C217 C218 1-126-959-11 1-126-959-11 1-126-961-11 1-126-961-11 1-165-176-11 ELECT ELECT ELECT ELECT CERAMIC CHIP 0.47uF 0.47uF 2.2uF 2.2uF 0.047uF 20.00% 20.00% 20.00% 20.00% 10.00% 50V 50V 50V 50V 16V C219 C220 C221 1-165-176-11 CERAMIC CHIP 1-162-966-11 CERAMIC CHIP 1-162-966-11 CERAMIC CHIP www . 10% xiaoy u163. com 0.047uF 10.00% 16V 0.0022uF 10% 50V 0.0022uF 10% 50V C347 C348 C349 C350 C351 1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11 1-162-964-11 ELECT ELECT ELECT ELECT CERAMIC CHIP 50V 50V 50V 50V 50V 57 http://www.xiaoyu163.com http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 MAIN Ref. No. 10% 10% 10% 10% 10% 50V 50V 50V 50V 50V Remarks C357 C358 C359 C361 C362 1-126-933-11 1-162-960-11 1-162-960-11 1-162-960-11 1-162-960-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100uF 220PF 220PF 220PF 220PF 20.00% 10% 10% 10% 10% 16V 50V 50V 50V 50V C366 C367 C368 C369 C401 1-164-156-11 1-162-960-11 1-162-960-11 1-164-156-11 1-136-165-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM 0.1uF 220PF 220PF 0.1uF 0.1uF 25V 50V 50V 25V 5.00% 50V C402 C403 C404 C405 C406 1-136-165-00 1-136-165-00 1-136-165-00 1-126-768-11 1-126-943-11 FILM FILM FILM ELECT ELECT 0.1uF 0.1uF 0.1uF 2200uF 2200uF 5.00% 5.00% 5.00% 20.00% 20.00% 50V 50V 50V 16V 25V C407 C411 C412 C413 C414 1-126-964-11 1-126-767-11 1-126-943-11 1-126-935-11 1-126-947-11 ELECT ELECT ELECT ELECT ELECT 10uF 1000uF 2200uF 470uF 47uF 20.00% 20.00% 20.00% 20.00% 20.00% 50V 16V 25V 16V 10V C415 C416 C417 C418 C419 1-126-767-11 1-126-935-11 1-126-964-11 1-126-948-11 1-126-959-11 ELECT ELECT ELECT ELECT ELECT 1000uF 470uF 10uF 100uF 0.47uF 20.00% 20.00% 20.00% 20.00% 20.00% 16V 16V 50V 35V 50V C420 C422 C423 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 10% 10% Ref. No. Part No. Description Remarks D403 D404 D405 6-500-522-21 DIODE 10EDB40-TB3 6-500-522-21 DIODE 10EDB40-TB3 6-500-522-21 DIODE 10EDB40-TB3 D406 D407 D408 D409 D410 6-500-522-21 6-500-522-21 6-500-522-21 8-719-988-61 6-500-522-21 DIODE 10EDB40-TB3 DIODE 10EDB40-TB3 DIODE 10EDB40-TB3 DIODE 1SS355TE-17 DIODE 10EDB40-TB3 D411 D412 D413 D414 D415 8-719-988-61 6-500-522-21 8-719-988-61 8-719-988-61 8-719-083-70 DIODE 1SS355TE-17 DIODE 10EDB40-TB3 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE UDZSTE-1727B D416 D417 8-719-069-55 DIODE UDZSTE-175.6B 8-719-988-61 DIODE 1SS355TE-17 < EARTH TERMINAL > * EP401 1-537-738-21 TERMINAL,EARTH < FERRITE BEAD > TEL 13942296513 0.1uF 0.1uF 0.1uF FB301 1-550-907-21 FERRITE 0uH < IC > IC201 IC301 IC302 IC401 IC402 6-702-130-01 6-703-650-11 8-759-828-32 8-759-231-57 6-701-760-01 IC HA12237F IC M61529FP-D60G IC PT8300 IC TA7810S IC uPC3504AHF IC403 8-759-231-57 IC TA7810S QQ 376315150 892498299 25V 25V 25V < JACK > JK301 1-793-987-11 JACK,PIN 2P (MD IN) < CONNECTOR > < JUMPER RESISTOR > CN101 CN101 CN301 CN302 CN303 1-784-733-11 1-784-737-11 1-784-780-11 1-779-564-11 1-568-828-11 CONNECTOR,FFC 11P (EXCEPT AEP,UK) CONNECTOR,FFC 15P (AEP,UK) CONNECTOR,FFC 19P CONNECTOR,FFC (LIF (NON-ZIF)) 27P CONNECTOR,FFC 9P * CN305 CN402 CN403 CN404 1-564-706-11 1-784-798-11 1-691-040-31 1-778-982-21 PIN,CONNECTOR (SMALL TYPE) 4P CONNECTOR,FFC 37P CONNECTOR,FFC 8P CONNECTOR,BOARD TO BOARD 13P JR101 JR102 JR201 JR202 JR203 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W < DIODE > JR204 JR301 JR302 JR303 JR304 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W D101 D102 D301 D302 D303 8-719-988-61 8-719-988-61 8-719-988-61 6-500-522-21 6-500-522-21 DIODE 1SS355TE-17 (AEP,UK) DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 10EDB40-TB3 DIODE 10EDB40-TB3 JR305 JR306 JR310 JR401 JR402 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W D304 D305 D306 D307 D309 6-500-522-21 6-500-522-21 8-719-988-61 8-719-988-61 8-719-988-61 DIODE 10EDB40-TB3 DIODE 10EDB40-TB3 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 JR403 JR404 JR405 JR406 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W D401 D402 6-500-522-21 DIODE 10EDB40-TB3 6-500-522-21 DIODE 10EDB40-TB3 www . xiaoy u163. com < COIL > L201 1-424-849-11 COIL,OSCILLATION (BIAS) 58 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 0.001uF 470PF 470PF 470PF 470PF QQ QQ CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 13942296513 13942296513 Description 1-162-964-11 1-162-962-11 1-162-962-11 1-162-962-11 1-162-962-11 TEL TEL Part No. C352 C353 C354 C355 C356 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 MAIN Ref. No. L301 Part No. Description 1-410-521-11 INDUCTOR Remarks 100uH < IC > PH301 8-749-019-25 IC TOTX141 (CD DIGITAL OUT (OPTICAL)) < TRANSISTOR > 2SC3052F-T1-LF 2SC3052F-T1-LF 2SC3052F-T1-LF 2SC3052F-T1-LF 2SA1235F Q206 Q207 Q208 Q209 Q210 8-729-120-28 8-729-142-46 8-729-140-04 8-729-120-28 8-729-120-28 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3052F-T1-LF 2SC2001TP-LK 2SB1116-TP-LK 2SC3052F-T1-LF 2SC3052F-T1-LF Q211 Q212 Q301 Q302 Q304 8-729-120-28 8-729-120-28 8-729-120-28 8-729-120-28 8-729-052-79 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3052F-T1-LF 2SC3052F-T1-LF 2SC3052F-T1-LF 2SC3052F-T1-LF 2SD1306NETL Q305 Q306 Q307 Q406 Q407 8-729-052-79 6-550-289-01 8-729-120-28 8-729-140-04 8-729-120-28 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SD1306NETL 2SA1235F 2SC3052F-T1-LF 2SB1116-TP-LK 2SC3052F-T1-LF 8-729-140-04 8-729-120-28 6-550-289-01 8-729-120-28 8-729-048-52 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SB1116-TP-LK 2SC3052F-T1-LF 2SA1235F 2SC3052F-T1-LF 2SA1932 (TP) R101 1-216-845-11 METAL CHIP 100K R101 1-216-841-11 METAL CHIP 47K R102 1-216-845-11 METAL CHIP 100K R102 1-216-841-11 METAL CHIP 47K R103 1-216-813-11 METAL CHIP 220 R104 1-216-829-11 METAL CHIP 4.7K 5% R201 R202 R203 R204 1-216-829-11 1-216-829-11 1-216-832-11 1-216-832-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 4.7K 8.2K 8.2K 5% 5% 5% 5% 1/10W (AEP,UK) 1/10W 1/10W 1/10W 1/10W R207 R208 R209 R210 R211 1-216-833-11 1-216-833-11 1-216-825-11 1-216-825-11 1-216-824-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 10K 2.2K 2.2K 1.8K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R212 R213 R216 R217 R218 1-216-824-11 1-216-837-11 1-216-833-11 1-216-833-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1.8K 22K 10K 10K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W . 5% 5% 5% 5% 5% Remarks 1/10W 1/10W 1/10W 1/10W 1/10W R224 R225 R226 R227 R228 1-218-867-11 1-218-867-11 1-216-833-11 1-216-833-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 6.8K 6.8K 10K 10K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R229 R230 R231 R232 R233 1-216-815-11 1-216-797-11 1-216-838-11 1-216-829-11 1-216-837-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 330 10 27K 4.7K 22K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R234 R235 R236 R237 R238 1-216-837-11 1-216-829-11 1-216-833-11 1-216-829-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 4.7K 10K 4.7K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R239 R240 R241 R242 R243 1-216-833-11 1-216-833-11 1-216-825-11 1-216-825-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 10K 2.2K 2.2K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R244 R245 R246 R247 R301 1-216-833-11 1-216-829-11 1-216-833-11 1-216-833-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 4.7K 10K 10K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R302 R303 R304 R305 R306 1-216-829-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 4.7K 4.7K 4.7K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R307 R308 R309 R310 R311 1-216-833-11 1-216-833-11 1-216-833-11 1-216-825-11 1-216-825-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 10K 10K 2.2K 2.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R312 R313 R314 R315 R316 1-216-833-11 1-216-833-11 1-216-829-11 1-216-829-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 10K 4.7K 4.7K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R317 R318 R319 R321 R322 1-216-833-11 1-216-841-11 1-216-841-11 1-216-821-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 47K 47K 1K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R323 R324 R325 R326 R327 1-216-833-11 1-216-821-11 1-216-829-11 1-216-829-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 1K 4.7K 4.7K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R328 R329 R330 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-833-11 METAL CHIP 100 100 10K 5% 5% 5% 1/10W 1/10W 1/10W QQ 376315150 892498299 < RESISTOR > www 220 1K 47K 47K 47K 5% 1/10W (EXCEPT AEP,UK) 5% 1/10W (AEP,UK) 5% 1/10W (EXCEPT AEP,UK) 5% 1/10W (AEP,UK) 5% 1/10W (AEP,UK) xiaoy u163. com 59 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 Q408 Q409 Q410 Q411 Q412 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP QQ QQ TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR Description 1-216-813-11 1-216-821-11 1-216-841-11 1-216-841-11 1-216-841-11 13942296513 13942296513 8-729-120-28 8-729-120-28 8-729-120-28 8-729-120-28 6-550-289-01 Part No. R219 R220 R221 R222 R223 TEL TEL Q201 Q202 Q203 Q204 Q205 Ref. No. http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 MAIN Ref. No. MODE MOTOR Part No. PANEL Description Remarks 1/10W 1/10W R345 R346 R347 R348 R349 1-216-837-11 1-216-837-11 1-216-829-11 1-216-829-11 1-216-837-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 22K 4.7K 4.7K 22K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R350 R351 R352 R353 R354 1-216-837-11 1-216-837-11 1-216-829-11 1-216-829-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 22K 4.7K 4.7K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R356 R357 R359 R360 R361 1-216-837-11 1-216-845-11 1-216-825-11 1-216-825-11 1-216-825-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 100K 2.2K 2.2K 2.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R362 R363 R364 R365 R367 1-216-825-11 1-216-825-11 1-216-845-11 1-216-845-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 2.2K 2.2K 100K 100K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R368 R375 R376 R377 R378 1-216-829-11 1-216-837-11 1-216-829-11 1-216-837-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 22K 4.7K 22K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R379 R380 R381 R382 R383 1-218-717-11 1-218-717-11 1-216-837-11 1-218-717-11 1-218-717-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 11K 11K 22K 11K 11K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R384 R385 R389 R390 R391 1-216-837-11 1-216-829-11 1-216-829-11 1-216-837-11 1-218-717-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 4.7K 4.7K 22K 11K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R392 R393 R404 R405 R406 1-218-717-11 1-216-837-11 1-216-821-11 1-216-198-91 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP 11K 22K 1K 1K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/8W 1/10W R407 R408 R409 R410 R411 1-216-198-91 1-216-829-11 1-216-837-11 1-216-829-11 1-215-891-11 RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE 1K 4.7K 22K 4.7K 680 5% 5% 5% 5% 5% 1/8W 1/10W 1/10W 1/10W 2W R412 R413 R414 R415 R416 1-215-891-11 1-216-837-11 1-216-829-11 1-216-837-11 1-216-829-11 METAL OXIDE METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 22K 4.7K 22K 4.7K 5% 5% 5% 5% 5% 2W 1/10W 1/10W 1/10W 1/10W TEL 13942296513 www R417 R418 R419 R420 R421 1-216-837-11 1-216-829-11 1-216-837-11 1-216-829-11 1-216-837-11 Part No. Description R427 R428 R429 R430 R431 1-218-717-11 1-218-717-11 1-216-837-11 1-218-717-11 1-218-717-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 11K 11K 22K 11K 11K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W Remarks R432 R433 R435 R436 R438 1-216-837-11 1-216-841-11 1-216-806-11 1-216-806-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 47K 56 56 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R439 R440 R441 R444 R445 1-216-829-11 1-216-833-11 1-216-821-11 1-216-829-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 10K 1K 4.7K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R446 R447 R448 R449 R450 1-216-829-11 1-216-829-11 1-216-833-11 1-216-821-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 4.7K 10K 1K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R451 R452 R453 R454 R455 1-260-087-21 1-260-087-21 1-216-837-11 1-216-837-11 1-216-829-11 CARBON CARBON METAL CHIP METAL CHIP METAL CHIP 100 100 22K 22K 4.7K 5% 5% 5% 5% 5% 1/2W 1/2W 1/10W 1/10W 1/10W R456 R457 1-216-845-11 METAL CHIP 1-216-857-11 METAL CHIP 100K 1M 5% 5% 1/10W 1/10W QQ 376315150 892498299 < SWITCH > SW401 1-771-264-11 SWITCH,PUSH (DETECTION)(1 KEY) (TAPE OPEN/CLOSE) ************************************************************* 1-686-724-12 MODE MOTOR BOARD ****************** ************************************************************* A-4734-337-A A-4734-349-A A-4734-360-A A-4747-533-A A-4747-535-A PANEL BOARD,COMPLETE (US,CND) PANEL BOARD,COMPLETE (AEP,UK,RU) PANEL BOARD,COMPLETE (E3,TW) PANEL BOARD,COMPLETE (MX,E2) PANEL BOARD,COMPLETE (KR,AUS) A-4747-545-A PANEL BOARD,COMPLETE (TH) ********************** 4-238-614-01 FL HOLDER (R) < CAPACITOR > C601 C602 C603 C604 C605 1-126-964-11 1-126-964-11 1-126-947-11 1-126-964-11 1-164-156-11 ELECT ELECT ELECT ELECT CERAMIC CHIP 10uF 10uF 47uF 10uF 0.1uF 20.00% 20.00% 20.00% 20.00% C606 C607 C611 C612 C614 1-128-551-11 1-124-584-00 1-126-916-11 1-115-156-11 1-164-227-11 ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP 22uF 100uF 1000uF 1uF 0.022uF 20.00% 25V 20% 10V 20.00% 6.3V 10V 10% 25V C616 1-115-156-11 CERAMIC CHIP xiaoy u163. com METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP . Ref. No. 22K 4.7K 22K 4.7K 22K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 60 http://www.xiaoyu163.com 1uF 50V 50V 10V 50V 25V 10V 376315150 892498299 376315150 892498299 5% 5% QQ QQ 4.7K 22K 13942296513 13942296513 1-216-829-11 METAL CHIP 1-216-837-11 METAL CHIP TEL TEL R343 R344 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 PANEL Ref. No. CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 330PF 0.1uF 22uF 0.1uF 50V 25V 20.00% 25V 25V Remarks C621 C622 C635 C636 C637 1-164-156-11 1-164-156-11 1-162-918-11 1-162-919-11 1-124-257-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.1uF 0.1uF 18PF 22PF 2.2uF 25V 25V 5.00% 50V 5% 50V 20% 50V C639 C640 C641 C642 C643 1-119-772-91 1-162-970-11 1-162-970-11 1-164-227-11 1-115-156-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 47uF 0.01uF 0.01uF 0.022uF 1uF 20.00% 10% 10% 10% 35V 25V 25V 25V 10V C646 C647 C648 C649 C650 1-162-970-11 1-164-156-11 1-124-257-00 1-124-234-00 1-162-964-11 CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP 0.01uF 0.1uF 2.2uF 22uF 0.001uF 10% 25V 25V 50V 16V 50V Ref. No. Part No. Description Remarks < JUMPER RESISTOR > 10% JR605 1-216-864-11 METAL CHIP 0 JR606 1-216-864-11 METAL CHIP 0 JR607 1-216-864-11 METAL CHIP 0 5% 1/10W (EXCEPT AEP,UK,RU) 5% 1/10W (EXCEPT AEP,UK,RU) 5% 1/10W < DIODE > LED607 LED608 LED609 LED610 LED611 6-500-414-01 6-500-414-01 6-500-414-01 6-500-414-01 6-500-414-01 DIODE HL-30105Q2AT (DISC 1) DIODE HL-30105Q2AT (DISC 2) DIODE HL-30105Q2AT (DISC 3) DIODE HL-30105Q2AT (DISC 4) DIODE HL-30105Q2AT (DISC 5) LED614 6-500-415-01 DIODE HL-30105Q2IT (@/1) 20% 20% 10% < TRANSISTOR > Q601 Q609 Q610 8-729-120-28 TRANSISTOR 8-729-120-28 TRANSISTOR 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF 2SC3052F-T1-LF 2SC3052F-T1-LF < CONNECTOR > < RESISTOR > CN601 CN602 1-784-759-11 CONNECTOR,FFC 37P 1-784-731-11 CONNECTOR,FFC 9P < DIODE > DIODE 1SS355TE-17 (TH) DIODE 1SS355TE-17 (KR,AUS) DIODE 1SS355TE-17 (US,CND,E2,KR,MX,AUS) DIODE 1SS355TE-17 (US,CND,AEP,UK,RU) DIODE 1SS355TE-17 D616 D617 D619 D620 D621 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 D622 D623 D624 D625 D626 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-083-61 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE UDZSTE-1711B (E2,E3,KR,TW,TH,MX,AUS) METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 4.7K 180K 2.2K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W QQ 376315150 892498299 TEL 13942296513 R036 R037 R053 R054 R055 1-216-825-11 1-216-817-11 1-216-841-11 1-216-841-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 2.2K 470 47K 47K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R056 R057 R058 R059 R060 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 47K 47K 47K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R061 R062 R063 R064 R065 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 47K 47K 47K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R066 R067 R068 R069 R070 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 47K 47K 47K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R071 R072 R073 R074 R075 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 47K 47K 47K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R076 R077 R078 R079 R080 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 47K 47K 47K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R081 R082 1-216-841-11 METAL CHIP 1-216-841-11 METAL CHIP 47K 47K 5% 5% 1/10W 1/10W < FERRITE BEAD > FB601 FB602 FB603 FB604 FB605 1-412-473-21 1-550-907-21 1-550-907-21 1-550-907-21 1-550-907-21 INDUCTOR FERRITE FERRITE FERRITE FERRITE 0uH 0uH 0uH 0uH 0uH < FLUORESCENT INDICATOR TUBE > FLD601 1-518-923-11 INDICATOR TUBE,FLUORESCENT < IC > www IC601 IC602 IC603 JK601 xiaoy u163. com 6-803-002-01 IC LC876796B-51K7-E 6-704-045-01 IC MM1574A 8-759-533-04 IC M62703ML-E1 . < JACK > 1-691-293-21 JACK (PHONES) 61 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 1-216-809-11 1-216-829-11 1-216-848-11 1-216-825-11 1-216-841-11 QQ QQ D606 D607 D608 D609 D615 R030 R031 R032 R034 R035 13942296513 13942296513 Description 1-162-961-11 1-164-156-11 1-128-551-11 1-164-156-11 TEL TEL Part No. C617 C618 C619 C620 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 PANEL Ref. No. Part No. Description Remarks 1/10W 1/10W 1/10W R086 R087 R088 R089 R090 1-216-841-11 1-216-820-11 1-216-820-11 1-216-827-11 1-216-827-11 47K 820 820 3.3K 3.3K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R602 1-216-809-11 METAL CHIP 100 5% R604 R605 R606 R607 1-216-833-11 1-216-833-11 1-216-829-11 1-216-833-11 10K 10K 4.7K 10K 5% 5% 5% 5% 1/10W (AEP,UK,RU) 1/10W 1/10W 1/10W 1/10W R608 1-216-809-11 METAL CHIP 100 5% R609 R610 R611 R612 1-216-833-11 1-216-835-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 15K 100 100 5% 5% 5% 5% 1/10W (AEP,UK,RU) 1/10W 1/10W 1/10W 1/10W R613 R614 R615 R616 R617 1-216-821-11 1-216-821-11 1-216-821-11 1-216-833-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 1K 1K 10K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R623 R624 R625 R626 R627 1-216-198-91 1-216-835-11 1-216-817-11 1-216-819-11 1-216-821-11 RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 15K 470 680 1K 5% 5% 5% 5% 5% 1/8W 1/10W 1/10W 1/10W 1/10W R628 R629 R630 R631 R632 1-216-823-11 1-216-823-11 1-216-825-11 1-216-827-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1.5K 1.5K 2.2K 3.3K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R633 R634 R635 R636 R637 1-218-867-11 1-216-198-91 1-216-198-91 1-216-198-91 1-216-198-91 METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 6.8K 1K 1K 1K 1K 5% 5% 5% 5% 5% 1/10W 1/8W 1/8W 1/8W 1/8W R638 R639 R640 R641 R642 1-216-835-11 1-216-817-11 1-216-819-11 1-216-821-11 1-216-823-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 15K 470 680 1K 1.5K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R643 R644 R645 R646 R647 1-216-823-11 1-216-825-11 1-216-827-11 1-216-849-11 1-220-397-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP 1.5K 2.2K 3.3K 220K 4.7M 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R648 R649 R650 R651 R652 1-216-819-11 1-216-198-91 1-216-198-91 1-216-833-11 1-216-809-11 METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP 680 1K 1K 10K 100 5% 5% 5% 5% 5% 1/10W 1/8W 1/8W 1/10W 1/10W R653 R654 R655 1-216-805-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-841-11 METAL CHIP 47 10K 47K 5% 5% 5% 1/10W 1/10W 1/10W METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP TEL 13942296513 Ref. No. Part No. Description Remarks R656 R657 1-216-841-11 METAL CHIP 1-216-829-11 METAL CHIP 47K 4.7K 5% 5% 1/10W 1/10W R658 R659 R660 R661 R662 1-216-833-11 1-216-833-11 1-216-198-91 1-216-817-11 1-216-819-11 METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP 10K 10K 1K 470 680 5% 5% 5% 5% 5% 1/10W 1/10W 1/8W 1/10W 1/10W R663 R664 R665 R666 R667 1-216-821-11 1-216-823-11 1-216-809-11 1-216-841-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 1.5K 100 47K 220 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R668 R669 R670 R671 R672 1-216-809-11 1-216-823-11 1-216-198-91 1-216-825-11 1-216-827-11 METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP 100 1.5K 1K 2.2K 3.3K 5% 5% 5% 5% 5% 1/10W 1/10W 1/8W 1/10W 1/10W R673 R674 R675 R676 R677 1-216-829-11 1-216-829-11 1-218-867-11 1-216-821-11 1-216-851-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 4.7K 6.8K 1K 330K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R678 R679 R680 R681 R682 1-216-833-11 1-216-198-91 1-216-809-11 1-216-833-11 1-216-845-11 METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP 10K 1K 100 10K 100K 5% 5% 5% 5% 5% 1/10W 1/8W 1/10W 1/10W 1/10W R683 R684 R685 R686 R687 1-216-833-11 1-216-182-00 1-216-182-00 1-218-867-11 1-216-833-11 METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP 10K 220 220 6.8K 10K 5% 5% 5% 5% 5% 1/10W 1/8W 1/8W 1/10W 1/10W R688 R689 R690 R691 R692 1-216-809-11 1-216-833-11 1-216-809-11 1-216-821-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 10K 100 1K 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R693 R694 R695 R696 R697 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 100 100 100 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R698 1-216-809-11 METAL CHIP 100 5% 1/10W QQ 376315150 892498299 < VIBRATOR > RES601 1-579-125-11 VIBRATOR,CERAMIC (8.0MHz) < IC > RM601 www . 6-600-174-01 IC RPM7240-H4 (g) < SWITCH > xiaoy u163. com S601 S602 S603 S604 S605 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 62 http://www.xiaoyu163.com SWITCH,TACT (DISC 1) SWITCH,TACT (DISC 2) SWITCH,TACT (DISC 3) SWITCH,TACT (DISC 4) SWITCH,TACT (DISC 5) 376315150 892498299 376315150 892498299 5% 5% 5% QQ QQ 47K 47K 47K 13942296513 13942296513 1-216-841-11 METAL CHIP 1-216-841-11 METAL CHIP 1-216-841-11 METAL CHIP TEL TEL R083 R084 R085 http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 PANEL Ref. No. SWITCH,TACT (DISC 5 Z) SWITCH,TACT (DISC 4 Z) SWITCH,TACT (DISC 3 Z) SWITCH,TACT (DISC 2 Z) SWITCH,TACT (DISC 1 Z) Remarks S614 S615 S616 S617 S618 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 SWITCH,TACT (TAPE Y) SWITCH,TACT (TUNER/BAND) SWITCH,TACT (CD) SWITCH,TACT (B) SWITCH,TACT (x) S619 S620 S621 S622 S627 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 SWITCH,TACT (TUNING +) SWITCH,TACT (TUNING -) SWITCH,TACT (PRESET/ALBUM-) SWITCH,TACT (PRESET/ALBUM+) SWITCH,TACT (^/1) S628 S629 S630 S631 S632 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 SWITCH,TACT (DISPLAY) SWITCH,TACT (PLAY MODE) SWITCH,TACT (REPEAT) SWITCH,TACT (CD SYNC) SWITCH,TACT (REC (PAUSE/START)) S633 S634 S635 S636 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 SWITCH,TACT (GROOVE) SWITCH,TACT (PRESET EQ) SWITCH,TACT (DIMMER) SWITCH,TACT (FUNCTION) Ref. No. Part No. Description C524 C525 C526 C527 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF Remarks 25V 25V 25V 25V C528 C529 C530 C531 C532 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 25V 25V 25V 25V 25V C541 C542 C543 C544 1-136-165-00 1-128-550-11 1-136-165-00 1-128-550-11 FILM ELECT FILM ELECT 0.1uF 2200uF 0.1uF 2200uF 5.00% 20.00% 5.00% 20.00% 50V 50V 50V 50V < CONNECTOR > CN501 CN503 * CN504 1-778-982-21 CONNECTOR,BOARD TO BOARD 13P 1-564-506-11 PLUG,CONNECTOR 3P 1-564-704-11 PIN,CONNECTOR (SMALL TYPE) 2P 13942296513 13942296513 Description 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 1-762-196-21 TEL TEL Part No. S606 S607 S608 S609 S610 PWR AMP < DIODE > DIODE D5SBA204101 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 D506 D507 D508 D509 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE 1SS355TE-17 < VARIABLE RESISTOR > VR601 1-477-194-11 ENCODER,ROTARY (12 TYPE)(VOLUME) QQ 376315150 892498299 TEL 13942296513 < VIBRATOR > X601 1-760-252-12 VIBRATOR,CRYSTAL (32.768kHz) ************************************************************ < EARTH TERMINAL > * EP501 1-537-738-21 TERMINAL,EARTH A-4734-342-A PWR AMP BOARD,COMPLETE (EXCEPT TH) A-4747-550-A PWR AMP BOARD,COMPLETE (TH) ************************* 0 FR501 0 FR502 < CAPACITOR > C501 C502 C503 C504 C505 1-126-964-11 1-126-964-11 1-162-964-11 1-162-964-11 1-162-960-11 ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10uF 10uF 0.001uF 0.001uF 220PF 20.00% 20.00% 10% 10% 10% 50V 50V 50V 50V 50V C506 C507 C508 C509 C510 1-162-960-11 1-126-964-11 1-126-964-11 1-126-966-11 1-164-156-11 CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP 220PF 10uF 10uF 33uF 0.1uF 10% 20.00% 20.00% 20.00% 50V 50V 50V 16V 25V C511 C513 C514 C515 C516 1-126-963-11 1-104-665-11 1-126-963-11 1-165-128-11 1-165-128-11 ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP 4.7uF 100uF 4.7uF 0.22uF 0.22uF 20.00% 50V 20.00% 10V 20.00% 50V 16V 16V C517 C518 C520 C521 C522 1-162-960-11 1-126-961-11 1-126-968-11 1-165-183-91 1-165-183-91 CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP 220PF 2.2uF 100uF 3.5PF 3.5PF 10% 20.00% 20.00% 0.25PF 0.25PF C523 1-164-156-11 CERAMIC CHIP www . < FUSIBLE > 50V 50V 50V 50V 50V 1-202-972-61 FUSIBLE 1-212-881-11 FUSIBLE 25V 5% 5% 1/4W 1/4W < IC > IC501 6-600-089-01 IC STK403-070 < TERMINAL BOARD > JK501 1-694-884-11 TERMINAL BOARD (4P)(SPEAKER) < JUMPER RESISTOR > JR501 JR502 JR503 JR504 JR505 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W < COIL > L501 L502 1-422-009-13 COIL,AIR-CORE 1-422-009-13 COIL,AIR-CORE xiaoy u163. com 0.1uF 1 100 The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. 63 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 8-719-510-68 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 QQ QQ D501 D502 D503 D504 D505 http://www.xiaoyu163.com HCD-HP7 PWR AMP PWR TRANS ROLLER MOTOR SENSOR SENSOR (FAN) ST ENCODER QQ 376315150 892498299 Ref. No. Part No. Description Remarks < TRANSISTOR > 8-729-120-28 6-550-646-01 6-550-646-01 8-729-120-28 8-729-120-28 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3052F-T1-LF 2SC3143K4/K5-TB 2SC3143K4/K5-TB 2SC3052F-T1-LF 2SC3052F-T1-LF Q506 Q507 Q508 Q509 Q510 8-729-900-36 8-729-120-28 8-729-120-28 6-550-289-01 8-729-120-28 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR BA1F4M-TP 2SC3052F-T1-LF 2SC3052F-T1-LF 2SA1235F 2SC3052F-T1-LF Q511 Q512 Q513 Q514 Q515 8-729-120-28 8-729-120-28 8-729-120-28 8-729-120-28 8-729-140-04 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3052F-T1-LF 2SC3052F-T1-LF 2SC3052F-T1-LF 2SC3052F-T1-LF 2SB1116-TP-LK Part No. Description R546 R547 R548 R549 R550 1-216-839-11 1-216-833-11 1-216-174-00 1-216-174-00 1-260-076-21 METAL CHIP METAL CHIP RES-CHIP RES-CHIP CARBON R551 1-260-076-21 CARBON Remarks 33K 10K 100 100 10 5% 5% 5% 5% 5% 1/10W 1/10W 1/8W 1/8W 1/2W 10 5% 1/2W < RELAY > RY501 1-755-373-11 RELAY ************************************************************ 1-689-250-11 PWR TRANS BOARD ***************** < CAPACITOR > C902 C903 1-164-159-21 CERAMIC 1-126-969-11 ELECT 0.1uF 220uF 50V 20.00% 50V 13942296513 13942296513 < RESISTOR > < CONNECTOR > METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 1K 56K 56K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R508 R509 R510 R511 R512 1-216-821-11 1-216-833-11 1-216-839-11 1-216-821-11 1-216-842-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 10K 33K 1K 56K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R513 R514 R515 R516 R517 1-216-842-11 1-216-821-11 1-216-821-11 1-216-835-11 1-216-835-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 56K 1K 1K 15K 15K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R518 R519 R520 R521 R522 R523 1-216-841-11 1-216-841-11 1-260-076-21 1-260-076-21 1-217-151-00 1-217-151-00 METAL CHIP METAL CHIP CARBON CARBON METAL METAL 47K 47K 10 10 0.22 0.22 5% 5% 5% 5% 10% 10% 1/10W 1/10W 1/2W 1/2W 2W 2W R524 R525 R526 R527 R528 1-216-162-00 1-216-854-11 1-216-813-11 1-216-841-11 1-216-845-11 RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 33 560K 220 47K 100K 5% 5% 5% 5% 5% 1/8W 1/10W 1/10W 1/10W 1/10W R529 R530 R531 R532 R533 1-216-842-11 1-216-845-11 1-216-829-11 1-216-829-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 56K 100K 4.7K 4.7K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R534 R535 R536 R537 R538 1-216-841-11 1-216-830-11 1-216-825-11 1-216-829-11 1-216-829-11 METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP 47K 5.6K 2.2K 4.7K 4.7K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R539 R540 R543 R544 R545 1-216-829-11 1-216-833-11 1-216-837-11 1-216-842-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 10K 22K 56K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W * CN902 * CN904 * CN907 1-564-519-11 PLUG,CONNECTOR 4P 1-564-719-11 PIN,CONNECTOR (SMALL TYPE) 3P 1-564-524-11 PLUG,CONNECTOR 9P < DIODE > TEL 13942296513 www . D907 6-500-522-21 DIODE 10EDB40-TB3 < FUSIBLE > QQ 376315150 892498299 0 FR903 1-217-639-00 FUSIBLE 2.2 5% 3.3M 20% 1/4W < RESISTOR > 0 R901 1-219-237-91 SOLID 1/2W (US,CND) ************************************************************ 1-686-726-12 ROLLER MOTOR BOARD ******************** ************************************************************ 1-686-723-12 SENSOR BOARD ************* < IC > IC751 8-749-017-45 SENSOR,PHONT RPR-220C1N (DISC INSERT DETECT SENSOR) ************************************************************ 1-689-248-12 SENSOR (FAN) BOARD ****************** < THERMISTOR > TH501 1-807-796-11 THERMISTOR ************************************************************ ST ENCODER BOARD ***************** ************************************************************ xiaoy u163. com The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 64 http://www.xiaoyu163.com Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. 376315150 892498299 376315150 892498299 1-216-821-11 1-216-821-11 1-216-842-11 1-216-842-11 1-216-821-11 QQ QQ R501 R502 R503 R504 R507 TEL TEL Q501 Q502 Q503 Q504 Q505 Ref. No. http://www.xiaoyu163.com HCD-HP7 Ver 1.1 2003.11 QQ 376315150 892498299 STOCKER MOTOR Ref. No. Part No. SUB TURANS Description Remarks 1-686-725-12 STOCKER MOTOR BOARD ********************* ************************************************************ SW (1) Ref. No. SW (2) Part No. 1000uF 20.00% 16V < CONNECTOR > 0 CN905 0 CN905 1-564-321-21 PIN,CONNECTOR (3.96mm PITCH) 2P (EXCEPT E2,E3,TW) 1-568-106-11 PIN,CONNECTOR (3.96mm PITCH) 4P (E2,E3,TW) 1-564-321-00 PIN,CONNECTOR (3.96mm PITCH) 2P < DIODE > 6-500-522-21 6-500-522-21 6-500-522-21 6-500-522-21 8-719-988-61 DIODE 10EDB40-TB3 DIODE 10EDB40-TB3 DIODE 10EDB40-TB3 DIODE 10EDB40-TB3 DIODE 1SS355TE-17 < RELAY > 0 RY901 1-755-276-11 RELAY,POWER 0 S902 107 107 107 107 107 1-693-625-11 1-693-626-11 1-693-627-11 1-693-628-11 1-693-629-11 TUNER (FM/AM)(US,CND) TUNER (FM/AM)(AEP,UK) TUNER (FM/AM)(RU) TUNER (FM/AM)(E2,E3,TW,TH,MX,AUS) TUNER (FM/AM)(KR) 108 108 0 151 0 151 0 151 1-769-946-11 1-773-009-11 1-690-608-11 1-769-079-22 1-783-531-11 WIRE (FLAT TYPE)(11 CORE)(EXCEPT AEP,UK) WIRE (FLAT TYPE)(15 CORE)(AEP,UK) CORD,POWER (AUS) CORD,POWER (KR) CORD,POWER (US,CND) 0 151 0 151 0 151 155 156 1-783-532-11 1-791-901-12 1-824-818-11 1-827-390-11 1-827-393-11 CORD,POWER (AEP,UK,RU,TW) CORD,POWER (E2,E3,MX) CORD,POWER (WITH CONNECTOR)(TH) WIRE (FLAT TYPE)(27 CORE) WIRE (FLAT TYPE)(19 CORE) 422 0 607 608 0 F901 1-471-244-11 A-4735-357-A 1-823-859-11 1-533-454-11 QQ 376315150 892498299 1-786-055-21 SELECTOR,VOLTAGE (VOLTAGE SELECTOR) (E2,E3,TW) 0 F901 < TRANSFORMER > 0 T902 0 T902 1-439-830-11 TRANSFORMER,POWER (US,CND,MX) 1-439-832-11 TRANSFORMER,POWER (E2,E3,KR,TW,TH,AUS) 0 T902 1-439-831-11 TRANSFORMER,POWER (AEP,UK,RU) ************************************************************ 0 F902 0 F902 0 F903 1-686-727-12 SW (1) BOARD ************ 0 F903 0 F904 < SWITCH > S711 1-786-382-11 SWITCH,PUSH (1 KEY)(DISC INSERT (8/12cm)) ************************************************************ S713 1-786-382-11 SWITCH,PUSH (1 KEY)(DISC IN (8/12cm)) S714 1-786-382-11 SWITCH,PUSH (1 KEY)(DISC IN (8cm)) ************************************************************ 1-686-729-12 SW (3) BOARD ************ S715 1-786-382-11 SWITCH,PUSH (1 KEY)(DISC OUT) ************************************************************ . M761 M771 M781 S702 S771 0 T901 0 T901 1-533-454-11 FUSE,GLASS TUBE (DIA. 5)(T6.3AL/125V) (US,CND,MX) 1-533-473-11 FUSE,GLASS TUBE (DIA. 5)(T6.3AL/250V) (EXCEPT US,CND,MX) 1-533-451-11 FUSE,GLASS TUBE (DIA. 5)(T3.15AL/125V) (US,CND,MX) 1-533-470-11 FUSE,GLASS TUBE (DIA. 5)(T3.15AL/250V) (EXCEPT US,CND,MX) 1-533-451-11 FUSE,GLASS TUBE (DIA. 5)(T3.15AL/125V) (US,CND,MX) 1-533-470-11 FUSE,GLASS TUBE (DIA. 5)(T3.15AL/250V) (EXCEPT US,CND,MX) 1-533-471-11 FUSE,GLASS TUBE (DIA. 5)(T4AL/250V) (E2,E3,TW) A-4735-953-A MOTOR ASSY (STOCKER) A-4735-953-A MOTOR ASSY (MODE) A-4735-953-A 1-477-299-11 1-477-300-11 1-439-827-11 MOTOR ASSY (ROLLER) ENCODER,ROTARY (STOCKER POSITION) ENCODER,ROTARY (MODE) TRANSFORMER,POWER (E2,E3,KR,TW,TH,AUS) 1-439-828-11 TRANSFORMER,POWER (US,CND,MX) xiaoy u163. com 0 T901 1-439-829-11 TRANSFORMER,POWER (AEP,UK,RU) ************************************************************ 1-686-730-12 SW (4) BOARD ************ S716 0 F904 0 F905 1-686-728-12 SW (2) BOARD ************ www MAGNET BASE ASSY, OP (KSM-213D) WIRE (FLAT TYPE)(16 CORE) FUSE,GLASS TUBE (DIA. 5)(T6.3AL/125V) (US,CND,MX) 1-533-473-11 FUSE,GLASS TUBE (DIA. 5)(T6.3AL/250V) (EXCEPT US,CND,MX) 1-786-382-11 SWITCH,PUSH (1 KEY)(STOCKER IN/OUT) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. 65 http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 WIRE (FLAT TYPE)(8 CORE) MECHANISM,SINGLE CASSETTE WIRE (FLAT TYPE)(9 CORE) WIRE (FLAT TYPE)(37 CORE) DC FAN QQ QQ < SWITCH > 1-827-392-11 1-796-351-41 1-769-920-11 1-827-395-11 1-787-025-11 13942296513 13942296513 D901 D902 D903 D904 D905 11 12 63 65 105 TEL TEL 0 CN908 Remarks MISCELLANEOUS ************** < CAPACITOR > 1-126-767-11 ELECT Description SW (4) S717 1-786-382-11 SWITCH,PUSH (1 KEY)(DISC POSITION) S718 1-786-382-11 SWITCH,PUSH (1 KEY)(STOCKING) ************************************************************ 1-689-246-12 SUB TRANS BOARD **************** C901 SW (3) http://www.xiaoyu163.com HCD-HP7 QQ 376315150 892498299 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2003.06 New 1.1 2003.11 Correction of BD BOARD (SPM-03112) Deletion of 3-11. Optical Pick-up (KSS-213D) in DISASSEMBLY. Addition of Description for Ref. No. F901, F902, F903, F904 and F905. (SPM-03061) TEL TEL Change of Part No. for Ref. No. 607 (KSM-213D) 13942296513 13942296513 . xiaoy u163. com http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513