Transcript
HCD-XGV11AV SERVICE MANUAL
E Model
Ver 1.0 2003.05
• HCD-XGV11AV is the Amplifier, CD player, tape deck and tuner section in LBT-XGV11AV. Model Name Using Similar Mechanism
HCD-XGV6/XGV8/XGV10AV
CD
CD Mechanism Type
CDM37B-30BD62
Section
Base Unit Name
BU-30BD62
Optical Pick-up Name
A-MAX.3
TAPE
Model Name Using Similar Mechanism
NEW
Section
Tape Mechanism Type
CWM43RR23
SPECIFICATIONS Amplifier section Front speaker: The following measured at AC 120, 220, 240 V 50 Hz DIN power output (rated): 150 + 150 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 200 + 200 watts (6 ohms at 1 kHz, 10% THD) Center speaker: DIN power output (rated): 35 watts (8 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 50 watts (8 ohms at 1 kHz, 10% THD) Surround speaker: DIN power output (rated): 35 + 35 watts (8 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 50 + 50 watts (8 ohms at 1 kHz, 10% THD)
GAME INPUT VIDEO (phono jack): MD (VIDEO) IN (phono jacks):
Inputs PHONO IN (phono jacks):
CENTER SPEAKER:
sensitivity 3 mV, impedance 47 kilohms MIC-1/MIC-2 (phone jacks): sensitivity 1 mV, impedance 10 kilohms GAME INPUT AUDIO (phono jacks): sensitivity 250 mV, impedance 47 kilohms
1Vp-p, 75 ohms sensitivity 450 mV (250 mV), impedance 47 kilohms
DVD INPUT FRONT, REAR, CENTER, WOOFER (phono jacks): sensitivity 450 mV, impedance 47 kilohms DVD VIDEO INPUT (phono jack): 1Vp-p, 75 ohms Outputs PHONES (stereo phone jack): MD (VIDEO) OUT (phono jacks): VIDEO OUT (phono jack): SUB WOOFER OUT (phono jack): FRONT SPEAKER:
accepts headphones of 8 ohms or more voltage 250 mV, impedance 1 kilohm max. output level 1Vp-p, load impedance 75 ohms voltage 1 V, impedance 1 kilohm accepts impedance of 6 to 16 ohms accepts impedance of 8 to 16 ohms — Continued on next page —
COMPONENT Hi-Fi STEREO SYSTEM
9-877-430-01
Sony Corporation
2003E02-1 © 2003.05
Home Audio Company Published by Sony Engineering Corporation
HCD-XGV11AV
SURROUND SPEAKER: CD player section System Laser
Frequency response Signal-to-noise ratio Dynamic range Video color system format
accepts impedance of 8 to 16 ohms
Compact disc digital audio system Semiconductor laser (λ=795 nm) Emission duration: continuous 2 Hz – 20 kHz (±0.5 dB) More than 90 dB More than 90 dB NTSC, PAL
Tape deck section Recording system Frequency response
4-track 2-channel, stereo 40 – 13,000 Hz (±3 dB), using Sony TYPE I cassettes
Tuner section FM stereo, FM/AM superheterodyne tuner FM tuner section Tuning range: 87.5 – 108.0 MHz (50 kHz step) Antenna FM lead antenna Antenna terminals 75 ohms unbalanced Intermediate frequency 10.7 MHz AM tuner section Tuning range:
Antenna Antenna terminals Intermediate frequency General Power requirements
Power consumption Dimensions (w/h/d) Mass
530 – 1,710 kHz (with the tuning interval set at 10 kHz) 531 – 1,602 kHz (with the tuning interval set at 9 kHz) AM loop antenna External antenna terminal 450 kHz
Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of soldering iron around 270˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior.
120 V, 220 V or 230 – 240 V AC, 50/60 Hz Adjustable with voltage selector 230 watts Approx. 355 x 425 x 451 mm Approx. 15.4 kg
Design and specifications are subject to change without notice.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
2
HCD-XGV11AV
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT
TABLE OF CONTENTS 1. SERVICING NOTE ·························································· 4
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care.
2. GENERAL ·········································································· 5
NOTES ON LASER DIODE EMISSION CHECK
7. DIAGRAMS
The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. LASER DIODE AND FOCUS SEARCH OPERATION CHECK Carry out the “S curve check” in “CD section adjustment” and check that the S curve waveforms is output three times.
3. DISASSEMBLY ································································ 7 4. TEST MODE ···································································· 16 5. MECHANICAL ADJUSTMENTS ····························· 18 6. ELECTRICAL ADJUSTMENTS ······························· 18 7-1. Circuit Board Location ······················································ 22 7-2. Block Diagram – CD Servo Section – ······························· 24 Block Diagram – Tuner/Tape Deck Section – ··················· 25 Block Diagram – Main Section – ······································ 26 Block Diagram – Display/Key Control/Power Supply Section – ·········· 27 7-3. Printed Wiring Board – BD Section – ······························· 28 7-4. Schematic Diagram – BD Section – ·································· 29 7-5. Printed Wiring Board – Video Section – ··························· 30 7-6. Schematic Diagram – Video Section – ······························ 31 7-7. Printed Wiring Board – Motor LED Section – ·················· 32 7-8. Schematic Diagram –Motor LED Section – ······················ 32 7-9. Schematic Diagram – Main (1/4) Section – ······················ 33 7-10. Schematic Diagram – Main (2/4) Section – ······················ 34 7-11. Schematic Diagram – Main (3/4) Section – ······················ 35 7-12. Schematic Diagram – Main (4/4) Section – ······················ 36 7-13.Printed Wiring Board – Main Section – ····························· 37 7-14. Printed Wiring Board – CD-L, CD-R Section – ················ 38 7-15. Schematic Diagram – CD-L, CD-R Section – ··················· 39 7-16. Printed Wiring Board – TC-A, TC-B Section – ················ 40 7-17. Schematic Diagram – TC-A, TC-B Section – ··················· 41 7-18.Printed Wiring Board – Panel VR, Key Section – ············· 42 7-19. Schematic Diagram – Panel VR, Key Section – ················ 43 7-20.Printed Wiring Board – Panel FL Section – ······················· 44 7-21. Schematic Diagram – Panel FL Section – ························· 45 7-22. Printed Wiring Board – Power Amp Section – ·················· 46 7-23. Schematic Diagram – Power Amp Section – ····················· 47 7-24. Printed Wiring Board – Sub Amp Section – ····················· 48 7-25. Schematic Diagram – Sub Amp Section – ························· 49 7-26. Printed Wiring Board – Prologic Section – ······················· 50 7-27. Schematic Diagram – Prologic Section – ·························· 51 7-28. Printed Wiring Board – Mic Section – ······························ 52 7-29. Schematic Diagram – Mic Section – ································· 52 7-30. Printed Wiring Board – Power Supply Section – ·············· 53 7-31. Schematic Diagram – Power Supply Section – ················· 53 7-32. IC Pin Function Description ············································· 54 7-33. IC Block Diagram ····························································· 60
8. EXPLODED VIEWS 8-1. 8-2. 8-3. 8-4. 8-5. 8-6.
Case,Back Panel Section ··················································· 63 Front Panel Section-1 ························································ 64 Front Panel Section-2 ························································ 65 Chassis Section ·································································· 66 CD Mechanism Deck Section (CDM-30BD62) ················ 67 Base Unit Section (BU-30BD62) ······································ 68
9. ELECTRICAL PARTS LIST ······································· 69
3
HCD-XGV11AV
SECTION 1 SERVICING NOTE
JIG FOR CHECKING PROLOGIC BOARD The special jig (J-2501-216-A) is useful for checking the PROLOGIC board. CN201 PROLOGIC board MAIN board
CN152
CN202
Jig (J-2501-216-A)
CN151
SERVICE POSITION FOR BD BOARD AND OPTICAL PICK-UP BLOCK
BD board
5
3 Bottom plate 2
4 BU fitting screw
Optical pick-up block 1 Two screws (+BVTP 3 x 8)
4
HCD-XGV11AV
SECTION 2 GENERAL
This section is extracted from instruction manual.
Main unit ALPHABETICAL ORDER E–L
A–D
ALBUM +/– qh CD SYNC qf Deck A ws Deck B w; Direct equalizer eh SALSA/REGGAE/TANGO/ MOVIE/GAME/SAMBA/ ROCK/JAZZ/DANCE/POP DIRECTION wk DISC 1 – 5 r; DISC SKIP r; Disc tray wd DISPLAY 2 Display window 7 DVD 5.1CH es
M–R
ECHO LEVEL wj EDIT wf EFFECT el ENTER ej FM MODE qs FUNCTION qa GAME ea GAME INPUT AUDIO L/R jacks qk GAME INPUT VIDEO jack qk GAME MIXING e; ILLUMINATION 4 KARAOKE/MPX eg
S –Z
MEMORY qs MIC-1/MIC-2 jacks wg MIC LEVEL wh P FILE ek PHONES jack qg PLAY MODE wf Power illuminator 5 PRO LOGIC ef PUSH OPEN wd Remote sensor 3 REPEAT wf
SLEEP 9 SURROUND ed TIMER SELECT 8 TUNER ENTER qs TUNER/BAND qs TUNING MODE qs TUNING +/– qs VOLUME control 6 X-GROOVE ql
BUTTON DESCRIPTIONS
?/1 (power) 1 c/CLOCK SET 0 X (pause) qd h/H (play) qd wl x (stop) qd wl .m/M> (rewind/fast forward) qd wl z REC qf
./> (go back/go forward) qj M/m/ (go back/go forward) es CD N (play) ed KEY CONTROL #/2 wl RETURN O qj TAPE A nN (play) qg TAPE B nN (play) 7 TV ?/1 ws
ek ej eh eg
ws wd wf wg
6
ef
7
ed es
wh wj
ea e;
wk
8 9
wl
V
qa
B
b v
6
V
0
B
b v
HCD-XGV11AV
SECTION 3 DISASSEMBLY • The equipment can be removed using the following procedure.
Set
Case
Front panel section
Tape mechanism deck PANEL FL board, GAME board, TC-A board, TUNER board, TC-B board KEY board PANEL VR board HEADPHONE board, MIC VR board, MIC board, ALBUM board FRONT INPUT board
Sub panel CD ASSY, CD-L board, DOOR SW board, CD-R board Back panel, DC fan, MAIN board, PROLOGIC board VIDEO board CD mechanism deck (CDM37B-30BD62)
Base unit-1 (BU-30BD62)
Base unit-2 (BU-30BD62)
BD board
Disc table Note : Follow the disassembly procedure in the numerical order given.
3-1. CASE
3 Five screws (BVTT 3x6) 8 Case
7
1 Three screws (CASE3 TP2) 4 Two screws (BVTP 3x8)
5 6
6 5
2 Three screws (CASE3 TP2)
7
HCD-XGV11AV
3-2. FRONT PANEL SECTION 4 Connector (CN903) 3 Connector (CN311) 5 Connector (CN722) 8 Screw (BVTP 3x8) 9 Lugs
1 Flat type wire (CN371) 2 Flat type wire (CN431) 6 Connector (CN801) 0 Screw (BVTP 3x8) qa Lug 7 Connector (CN806) qd Screw (BVTP 3x8) qg Claw qh Front panel section qs Connector (B deck) qf Four screws (BVTP 3x8)
3-3. TAPE MECHANISM DECK 1 Flat type wire (13 core)
2 Two screws (BVTP 2.6x8)
3 Two screws (BVTP 2.6x8) 4
5 Tape mechanism deck
Front panel
8
HCD-XGV11AV
3-4. PANEL FL BOARD, GAME BOARD, TC-A BOARD, TUNER BOARD, TC-B BOARD qa Five screws (BVTP 2.6x8)
qs Four screws (BVTP 2.6x8)
qk PANEL FL board
7 Flat type wire (CN601) 8 Screw (BVTP 2.6x8)
w; GAME board 1 Screw (BVTP 2.6x8) 9 Bracket (MAIN)
qh Two claws
2 Bracket (TA)
ws TC-A board
0 Four screws (BVTP 2.6x8)
qj qd Four screws (BVTP 2.6x8)
qf Four screws (BVTP 2.6x8)
5 Connector (CN700)
wf TUNER board qg Four screws (BVTP 2.6x8)
wd Three claws
ql Two claws
wh TC-B board wa Three claws 6 Connector (CN600) 3 Screw (BVTP 2.6x8)
4 Bracket (TA) wg Three claws
Front panel
3-5. KEY BOARD
1 Three screws (BVTP 2.6x8) 7
6 Three claws
2 OPERATION PANEL ASSY
4 Cursor
Front panel 3 Flat type wire (CN801)
8 KEY board
5 Five screws (BVTP 2.6x8)
9
HCD-XGV11AV
3-6. HEADPHONE BOARD, MIC VR BOARD, MIC BOARD, ALBUM BOARD
7 MIC VR board 5 Three screws (BVTP 2.6x8) 6 Knob (MIC)
4 Connector (CN812) 8 Two screws (BVTP 2.6x8)
0 MIC board 9 Screw (BVTP 2.6x8)
1 Tow screws (BVTP 2.6x8)
2 Bracket HP PWB qa Tow screws (BVTP 2.6x8) 3 HEADPHONE board
qs ALBUM board
Front panel
3-7. PANEL VR BOARD
5 Six screws (BVTP 2.6x8)
3 Flat type wire (CN601)
4 Flat type wire (CN801)
6
2 Nut (Supplied with S700)
1 Volume knob
Front panel
10
7 PANEL VR board
HCD-XGV11AV
3-8. FRONT INPUT BOARD
Front panel
FRONT INPUT board
J500 1 Five screws (BVTP 2.6x8)
4 FRONT INPUT board 3
2 Bumper ASSY
3-9. SUB PANEL CD ASSY, CD-L BOARD, DOOR SW BOARD, CD-R BOARD Front panel
5 Five claws
3 Connector (CN700) 1 Five screws (BVTP 2.6x8) 7
8 Sub panel CD ASSY qf DOOR SW board 6 qd Froating screw (DIA.12)
4 Connector (CN600)
qs CD-L board
2 Four screws (BVTP 2.6x8) qk CD-R board
0 BRACKET (S/P) (L)
qh BRACKET (S/P) (R) qa Four screws (BVTP 2.6x8) 9 Screw (BVTP 2.6x8)
qg Screw (BVTP 2.6x8) qj Four screws (BVTP 2.6x8)
11
HCD-XGV11AV
3-10. VIDEO BOARD
2
7VIDEO board 5Connector (CN301)
Bracket (PWB) 3Flat type wire (CN101)
1Two screws (BVTP 3 X 8)
6Two screws (BVTP 3 X 8)
4Flat type wire (CN201)
3-11. BACK PANEL, DC FAN, MAIN BOARD, PROLOGIC BOARD
1 Flat type wire (CN441) 2 Eight screws (BVTP 3 X 8)
7 Back panel
3 Four screws (BVTP 3 X 8)
9 Two screws (BVTP 3 X 8)
qd Connector (CN102)
w; PROLOGIC board 5 Four screws (BVTP 3 X 8)
0 DC FAN (M901)
4 Three screws (BVTP 3 X 8) qf Connector (CN721)
qa Flat type wire (CN401) 6 ql
qk Two connectors (CN151, 152)
qg Two screws (BVTP 3 X 8)
8 Connector (CN961)
qh Two connectors (CN901, 902)
qsConnector (CN441) qj MAIN board
12
HCD-XGV11AV
3-12. CD MECHANISM DECK (CDM37B-30BD62) 6Two screws (BVTP 3 X 8)
1Flat type wire (CN401) 4Three screws (BVTP 3 X 8) 3Four screws (BVTP 3 X 8) 7
Wire holder 8 2Connector (CN411)
7 5Two screws (BVTP 3 X 8)
9Remove two cables from wire holder.
0 Five screws (BVTP3 × 8)
qa CD mechanism deck (CDM37B-30BD62)
13
HCD-XGV11AV
3-13. BASE UNIT-1 (BU-30BD62)
3 Base unit (BU-30BD62)
2 Boss 1 BU fitting screw
3-14. BASE UNIT-2 (BU-30BD62)
6Base unit (BU-30BD62) 1Two floating screws (DIA.12)
2Two screws (BVTP 2.6 X 8)
3Two stoppers (BU)
4Two coil springs (insulator)
5Two coil springs (insulator)
Holder (BU30) assy
14
HCD-XGV11AV
3-15. BD BOARD BU-30BD62
3Flat type wire (CN102) 4BD board
1Remove the two solders.
2Remove the two solders.
3-16. DISC TABLE Note: When the disc table is installed, adjust the positions of roller cam and mark B as shown in the figure, then set to the groove of disc table. A
Cam (holder) 3Step screw
Roller cam 1Screw (BVTP 3 × 8)
4Disc table
2Bracket (BU)
Chassis
A
15
HCD-XGV11AV
SECTION 4 TEST MODE
[MC Cold Reset] • The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Turn the power ON or set to the DEMO mode. 2. Press three buttons of x (TC-B) , TUNER ENTER , and \/1 simultaneously. 3. The set is reset, and displays “COLD RESET”, then becomes DEMO mode. [Change-over the AM Tuning Interval] • The AM tuning interval can be changed over 9 kHz or 10 kHz. Procedure: 1. Press the \/1 button to turn the power ON. 2. Select the function “TUNER”, and press the TUNER/BAND button to select the BAND “AM”. 3. Press the \/1 button to turn the power OFF. 4. Press the ENTER and \/1 buttons simultaneously, and the display on the fluorescent indicator tube changes to “AM 9 K STEP” or “AM 10 K STEP”, and thus the tuning interval is changed over. [CD Ship Mode] (No memory clear) • This mode moves the optical pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair. Procedure: 1. Press the \/1 button to turn the power ON. 2. Press the EDIT and \/1 buttons simultaneously. 3. A message “LOCK” is displayed on the fluorescent indicator tube, and the CD delivery mode is set. [LED and Fluorescent Indicator Tube All Lit, Key Check Mode] Procedure: 1. Press three buttons of x (TC-B) , TUNER ENTER ,and DISC 2 simultaneously. 2. LEDs and fluorescent indicator tube are all turned on. 3. Press the DISC 1 button, the MODE and DESTINATION are displayed fluorescent indicator tube. 4. Each time the DISC 1 button is pressed, the MC/GC category version is displayed in the following order. NR
MC
GC
CD
CDDM
TC
TM
TA
ST
BDB
CDMA BDA
CDMB
5. Press the DISC 2 button, and the key check mode is acti-vated. 6. In the key check mode, the fluorescent indicator tube displays “K 0 J0 V0”. Each time a button is pressed, “K” value in-creases to “K69”call the button is pressed. However, once a button is pressed, it is no longer taken into account. “V” value increases like 1, 2, 3 ... if turn the VOLUME dial clockwise (“+” direction), or it decreases like 0, 9, 8 ... if turn the VOLUME dial counterclockwise (“–” direction). 7. To release from this mode, press three buttons in the same manner as step 1, or disconnect the power cord.
[Sled Servo Mode] (CD service mode) • This mode can run the CD sled motor freely. Use this mode, for instance, when cleaning the pick-up. Procedure: 1. Select the function “CD”. 2. Press three buttons x (TC-B) , TUNER ENTER , and DISC 5 simultaneously. 3. The Sled Servo mode is selected, if “CD” is blanking on the fluorescent indicator tube. 4. With the CD in stop status, press M button in CD section to move the pick-up to outside track, or m button to inside track. 5. To exit from this mode, press \/1 button turn to the power OFF. Note: • Always move the pick-up to most inside track when exiting from this mode. Otherwise, a disc will not be unloaded. • Do not run the sled motor excessively, otherwise the gear can be chipped. [Change-over of FUNCTION Name] • The FUNCTION name of external input terminal can be changed over to VIDEO or MD. With the FUNCTION selected to “MD”, about 5dB mute is applied to the input gain. Procedure: 1. Press \/1 button to turn the power OFF. 2. Press \/1 button together with FUNCTION button for several seconds, and the power is turned on, the display of fluorescent indicator tube changes to “MD” or “VIDEO” instantaneously, and thus the FUNCTION is changed over. [Aging Mode] This mode can be used for operation check of tape deck section. Tape deck section work in parallel. • If an error occurred: The aging operation stops and display then status. • If no error occurs: The aging operation continues repeatedly. Procedure: 1. Load the tapes into the decks A and B respectively. 2. Press the FUNCTION button to select the function “CD”. 3. Press the PLAY MODE button to set the “ALL DISCS” mode, and press the REPEAT button to “REPEAT” off. 4. Press three buttons of x (TC-B) , TUNER ENTER ,and DISC 4 simultaneously. 5. The aging mode is activated, if the indicator of disc tray number on the fluorescent indicator tube is blinking. 6. To release from the aging mode, press the \/1 button to turn the power OFF and operate the cold reset. (Refer to the “MC Cold Reset”) 1. Display at the Aging Mode • Display operating state of tape deck section alternately. • If an error occurred, stop display. [Changeover the color system] The color system can be changed over PAL, NTSC or AUTO. Procedure: The color system can be changed over PAL, NTSC or AUTO by pressing \/1 button while pressing followings and indication on display changes to “COLOR PAL”, “COLOR NTSC” or “COLOR AUTO”. PAL NTSC AUTO
16
: REGGAE + \/1 : MOVIE + \/1 : TANGO + \/1
HCD-XGV11AV
2.Tape Dec k Section • The sequence during the aging mode is following as below. • If an error occurred, stop display that step.
3. CD Section • The sequence during the aging mode is following as below. • If an error occurred, stop display that step.
Aging mode sequence (Tape deck section):
Aging mode sequence (CD section):
Rewind the tape A “TAPE A AG-1”
Tray Turn
Shut off FWD the tape A “TAPE A AG-2”
DISC 1 chucking
2 minutes TOC Read Fast forward the tape A “TAPE A AG-3” Shut off or 20 seconds RVS the tape A “TAPE A AG-4”
Track 1 Play 2 seconds
2 minutes Last Track Play Rewind the tape A “TAPE A AG-5” 2 seconds Shut off FWD the tape B “TAPE B AG-2”
Tray Tun
2 minutes Fast forward the tape B “TAPE B AG-3”
DISC 4 Chucking
Shut off or 20 seconds RVS the tape B “TAPE B AG-4” 2 minutes Rewind the tape B “TAPE B AG-5”
TOC Read
Track 1 Play 2 seconds
Shut off Last Track play Note: “TAPE * AG- * ” is display of each step.
[VACS ON/OFF] • The volume control by VACS is turned ON/OFF. Procedure: 1. Press the \/1 button to turn the power ON. 2. Press the PLAY MODE and \/1 buttons simultaneously. 3. The reaction display appears when switcing ON/OFF.
17
HCD-XGV11AV SECTION 5 MECHANICAL ADJUSTMENTS Precaution 1. Clean the following parts with a denatured alcohol-moistened swab: record/playback heads pinch rollers erase head rubber belts capstan 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. Torque Measurement Mode
Torque Meter
FWD CQ-102C FWD back tension
FF/REW
18
CQ-201B
Meter Reading 2.9~6.9 mN•m (30 to 70 g•cm) (0.42 – 0.97 oz•inch) 0.19~0.59 mN•m (2 to 6 g•cm) (0.03 – 0.08 oz•inch) 7.8~16.7 mN•m (80 to 170 g•cm) (1.11 – 2.36 oz • inch)
SECTION 6 ELECTRICAL ADJUSTMENTS DECK SECTION
0 dB = 0.775 V
Precaution 1. Demagnetize the record/playback head with a head demagnetizer. 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjust. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed for both L-CH and R-CH. 7. Switches and controls should be set as follows unless otherwise specified. 8. Set to the test mode. (1) Press the \/1 button to turn the power ON. (2) Select the function “TAPE A or B”. (3) Press the button of x (TC-B) , ENTER ,and DISC 3 simultaneously, to set the tape deck test mode and displays “TEST MODE” on the fluorescent indicator tube. (4) To release from the test mode, press the \/1 button. • Test Tape Tape P-4-A100 WS-48B
Signal 10 kHz, – 10 dB 3kHz, 0dB
Used for Azimuth Adjustment Tape Speed Adjustment
HCD-XGV11AV
Record/Playback Head Azimuth Adjustment DECK A DECK B Note: Perform this adjustments for both decks Procedure: 1. Mode: Playback (FWD) test tape P-4-A100 (10 kHz, – 10 dB)
Adjustment Location: Playback Head (Deck A). Record/Playback/Erase Head (Deck B).
MAIN board MD (VIDEO) OUT jack (J701) L-CH, R-CH level meter set
+
2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1dB of peak.
within 1dB
L-CH peak
within 1dB
Output level
Screw position
R-CH peak
forward
Tape Speed Adjustment DECK B Procedure: Mode: Playback test tape WS-48B (3 kHz, 0dB)
MAIN board MD (VIDEO) OUT jack (J701) L-CH, R-CH frequency counter set
L-CH peak
Screw position
R-CH peak
3. Mode: Playback test tape P-4-A100 (10 kHz, – 10 dB) L-CH
MAIN board MD (VIDEO) OUT jack (J701) L-CH oscilloscope
V
set
H
reverse
+ –
1. Insert the WS-48B into the deck B. 2. Press the H button on the deck B. 3. Adjust the tape speed adjustment control inside motor so that frequency counter reads 3,000 ± 90Hz. Sample value of wow and flutter W.RMS (JIS) less than 0.3% WS-48B Adjustment Location: Tape speed Adjustment
R-CH R-CH waveform of oscilloscope
in phase 45 ° good
90 ° 135 ° 180 ° wrong
Tape speed adjustment control inside motor
4. Repeat step 1 to 3 in playback (REV) mode. 5. After the adjustments, apply suitable locking compound to the pats adjusted.
19
HCD-XGV11AV
Note: Clear RF signal waveform means that the shape “◊” can be clearly distinguished at the center of the waveform.
CD SECTION Note : 1. CD Block is basically designed to operate without adjustment. Therefore, check each item in order given. 2. Use LUV-P01 (4-999-032-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10MΩ impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks. S-Curve Check
VOLT/DIV : 200mV TIME/DIV : 500ns
level : 1.45 ± 0.3Vp-p
E-F Balance (1 Track jump) Check Oscilloscope
BD board
oscilloscope BD board
TP(FE) TP(DVC)
TP(TE) TP(DVC)
Procedure : 1. Connect oscilloscope to TP (FE). 2. Connect between TP (FE) and TP (DVC ( 1.65 V)) by lead wire. 3. Press the \/1 button to turn the power ON. 4. Load a disc (LUV-P01) and actuate the focus search. (In consequence of open and close the disc tray, actuate the focus search) 5. Confirm that the oscilloscope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within 2 ±0.5 Vp-p.
Procedure: 1. Connect oscilloscope to TP (TE) and TP (DVC) board. 2. Press the \/1 button to turn the power ON. 3. Load a disc (LUV-P01) and playback the number nine track. 4. Press the bB button. (Becomes the 1track jump mode.) 5. Confirm that the level B and A (DC voltage) on the oscilloscope waveform. center of waveform
S-curve waveform
B
symmetry
A (DC voltage)
0V
A within 2 ±0.5Vp-p B
6. After check, remove the lead wire connected in step 2. Note : • Try to measure several times to make sure than the ratio of A : B or B : A is more than 10 : 7. • Take sweep time as long as possible and light up the brightness to obtain best waveform.
B=1.3 ± 0.6Vp-p
symmetry
Specified level: A × 100=less than – 22% B
Checking Location: [BD BOARD] (SIDE B)
RF Level Check oscilloscope BD board TP(RFDC) TP(RFAC)
Procedure : 1. Connect oscilloscope to TP (RFDC) and TP (RFAC). 2. Press the \/1 button to turn the power ON. 3. Load a disc (LUV-P01) and playback. 4. Confirm that oscilloscope waveform is clear and check RF signal level is correct or not.
20
DVC
SE FE
TE RFDC RFAC DVC
HCD-XGV11AV
VIDEO SECTION Note :
1. VIDEO board is basically designed to operate without adjustment. Therefore, check each item in order given. 2. Use HLV-402 (8-909-870-00) unless otherwise indicated. 3. Use an oscilloscope with more than 10MΩ impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks. Video Level Check (VIDEO BOARD) Purpose This adjustment is made to satisfy the NTSC standard, and if not adjusted correctly, the brightness will be too large or small.
Oscilloscope 75 Ω
set
J721 VIDEO OUTPUT
Procedure: 1. Connect oscilloscope to VIDEO output. 2. Load a disc HLV-402 (8-909-870-00) playback. 3. Check that the video level is 1.0 ± 0.1 Vp-p.
1.0 ± 0.1 Vp-p
(WHITE 100%)
21
HCD-XGV11AV SECTION 7 DIAGRAMS 7-1. CIRCUIT BOARD LOCATION
TRANS board
SUB TRANS board TUNER PACK (FM/AM TUNER UNIT)
PANEL FL board
Five screws (BVTT 3x6) SUB AMP board
PROLOGIC board GAME board MAIN board TC-A board
PA board
CD-L board
TUNER board
ALBUM board
TC-B board HEADPHONE board CD-R board FRONT INPUT board
KEY board
PANEL VR board SENSOR board
MIC board
MIC VR board DOOR SW board VIDEO board
BD board
MOTOR board LED board
22
HCD-XGV11AV
r WAVEFORMS
Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. f : internal component. • • 2 : nonflammable resistor. • 5 : fusible resistor. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. • • • • •
•
•
• •
C : panel designation. A : B+ Line. B : B– Line. H : adjustment for repair. Voltages and waveforms are dc with respect to ground under no-signal conditions. BD board section and VIDEO board section. no mark: CD PLAY Other board section no mark: TUNER (FM/AM) ( ): TAPE PLAY < >: TAPE REC [ ]: CD PLAY Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. F : TUNER (FM/AM) E : TAPE PLAY (DECK A) d : TAPE PLAY (DECK B) G : RECORD J : CD PLAY N : MIC INPUT g : VIDEO
1 IC501 qa
– BD BOARD –
1 IC103 qg (RFAC)
1 IC505 150 (XTAO)
(XC-OUT)
2.5 Vp-p
3.0Vp-p
C Q
These are omitted.
VOL/DIV : 1V AC TIME/DIV : 10 µsec
2 IC501 qd (X-OUT)
Q C
1.2 Vp-p
33.8688 MHz
32KHz
B E
B
– VIDEO BOARD –
– MAIN BOARD –
Note on Printed Wiring Boards: • X : parts extracted from the component side. • : Pattern from the side which enables seeing. (The other layers´ Patterns are not indicated.) • Indication of transistor.
VOL/DIV : 1V AC TIME/DIV : 20nsec
2 IC505 207 (CLKB)
2 IC103 qh (FE) 2.8 Vp-p
2.0Vp-p
E
VOL/DIV : 0.2V AC TIME/DIV : 0.5µsec
0.15 Vp-p
These are omitted. 16MHz
Q B
C
E
VOL/DIV : 1V AC TIME/DIV : 50nsec
3 CN321 2
27 MHz
VOL/DIV : 1V AC TIME/DIV : 20nsec
3 IC505 173 (RFAC)
VOL/DIV : 0.2V AC TIME/DIV : 0.2msec
3 IC103 qk (TE)
TAPE REC only
These are omitted.
24Vp-p
18 µsec
0.8 Vp-p
VOL/DIV : 10V AC TIME/DIV : 5 µsec
4 CN321 3
VOL/DIV : 0.2V AC TIME/DIV : 0.5 µsec
4 IC505 6 (EPSIG)
TAPE REC only 36Vp-p
18 µsec
VOL/DIV : 10V AC TIME/DIV : 5 µsec
0.8 Vp-p
H
VOL/DIV : 0.5V AC TIME/DIV : 20 µsec
5 Q301 E – PANEL FL BOARD –
1 IC601 is
VOL/DIV : 0.5V AC TIME/DIV : 20 µsec 3.0Vp-p
4MHz
6 IC307 6 (VOUT)
VOL/DIV : 1V AC TIME/DIV : 0.2 µsec H
23
23
0.8 Vp-p
H
(X OUT)
1.0 Vp-p
VOL/DIV : 0.5V AC TIME/DIV : 20 µsec
0.7 Vp-p
VOL/DIV : 1V AC TIME/DIV : 0.2msec
HCD-XGV11AV 7-2. BLOCK DIAGRAMS – CD SERVO SECTION –
RF AMP, FOCUS/TRACKING ERROR AMP
Q102
IC103 +2.5V +4.5V
6
PD2
7
C 8 D I-V AMP
9
RFC
13 VCC
PD1
B
26
A
RF SUMMING AMP
B
AC_SUM
EQ_IN 4
3
I1-6
E
11
I5-10
10
: VIDEO
RF EQ RFAC 15 AMP
173 RFAC
RFDCO 28 RFDCI 29
160 RFDC
DC AMP
∑ A-D
D
A+5V (SW)
FE 16 FEI 17
F
164
6 VCC
E
TE
TRACKING ERROR AMP
E I-V AMP
OPTICAL PICK-UP BLOCK (A-MAX.3)
VDC
18
AUDDTO0 201
2
AUDLRCK 204 AUDBCK 203
3
FE
F I-V AMP
VDC BUFFER
162
TE
163
SE
1
DATA CLK
14
LAT
GPIO11 26
MCLK
AUDXCLKO 205 SW
13 14 15
D/A CONVERTOR
IC504
DATA DAC LRCK
LPF
5 VDD
I/F
BLK
IC102 LOUT
DAC ROUT
7
5
7
8
3
1
CD-L
A
To MAIN SECTION (Page 26)
R-CM
16
206 CLKA
12
VIDEO AMP
X502 27MHz
LASER DIODE LD DRIVE Q101
LD
1
LD
APC LD AMP
PD
APC PD AMP
IC307 207 CLKB
2 149 XTAI
LD
PD
+3.3V REG Q581
C
FOCUS ERROR AMP
F
: CD PLAY (ANALOG)
CONTROL
VCC A
• R-ch is omitted due to same as L-ch. • Signal Path
22 VCC
VCC
CPSIG 6
Y
LPF Q302
3
X501 33.8688MHz
PD
2
OUT
IN
B
6 5
VCD-VIDEO
To MAIN SECTION (Page 26)
STB
26
138 SRDR
IN3-
IN2-
IN1+ COIL DRIVE
IN1-
STBY
140 TFDR
31
141 TRDR
35
142 FFDR
34
143 FRDR
DRDAT0 I DRDAT15 DRADR0 I DRADR10 GPIO0 GPIO1 GPIO2 GPIO3 GPIO4 GPIO5
13 14 15 16 18 19
24 DE
IC201
D+5V (SW)
1
+3.3V REG
IC202
BU UP/DW SW 48 S201 (UP SWITCH)
A0-A16 DQ0-DQ7 13-15, 7-21 LED-DISK 47
24
24
TABLE MOTOR DRIVER
IC501 (1/4)
34-37, 39-45
81
D201 (DISC No.)
LED DRIVE Q201
SYSTEM CONTROLLER (CD MECHANISM CONTROL)
49-56, 59-66
SYS RST
IC202
ROM
2-12,23, 25-31
DISC TABLE SENSOR
TBL-SENS 49
IC508
16 17 18 20 38 15 39
23-26, 2,4,5,7,8,10,11,13, 29-34 42,44,45,47,48,50,51,53 A0-A9
SDRAM
DQ0-DQ15
IC507
IC201 Q412
MTR-CTRL1 44
1
MTR-CTR2 45
35 36 37 32 19 40 43 SI
28 GPIO12
LD 10
SI SO SCK SRQ SOK SCS
AO5
CLK 11
29 GPIO13
74 78 77 70 76 72 68 73
NVOEL DRDQM1 DRDQM0 DRCK DRBS DRRAS DRCAS DRWEL
RST
4
30 GPIO14
DATA
AO3
RST
IC506
DI 12
CLK
6
AO6
DATA DECODERR, D/A CONVERTOR
3
AO4
(
9
+2.5V REG
33
135 SSTP 5
3
CSIA 7
8
RST
(
S101 (LIMIT) ON: when the optical pick-up is inner position.
32
V-MUTE
137 SFDR
SQ-CLK
VC
27
IN2+ COIL DRIVE
VO1VO1+
165
IN3+
RST
47
VREF 22
+3.3V
SRQ
52
VO2+
CE
CD-DATA XLT CD-CLK SQ-DATA SCOR HOLD XRST
55
VO2-
MOTOR DRIVE
161
SO SCK SOK SCS
F-
56
VO3-
+2.5V
133 MDP
23
0-7
F+ FOCUS COIL
2
VO3+
IN4
8-15
T-
1
MOTOR DRIVE
RIPPLE FILTER Q201
Q370
IC505
VO4+ VO4-
+4.5V (IC103)
0-15
T+ TRACKING COIL
M
10
CD-DSP, DIGITAL SERVO, MPEG DECODER, DAC
189 XTSL
WE CAS RAS BA0 CLK LDQM UDQM
M102 SLED MOTOR
M
5
24 GPIO9
RST
M101 SPINDLE MOTOR
RFDC
IC102
FE
TE
FOCUS/TRACKING COIL DRIVE, SPINDLE/SLED MOTOR DRIVE
LD-ON
150 XTAO
9 Q411
OUT2
IN2 IN1
MOTOR DRIVE
OUT1
3
M 7
M201 (TABLE)
HCD-XGV11AV –TUNER/TAPE DECK SECTION – HPF Q341,342,344
+
R-CH
AMS DETECT Q343
DECK-A 32 PB HEAD
AIN 1
70
TAI1
A 28
B
R-CH
34
120
BIN 1
PB-OUT1
27
PB-L
26
C
To MAIN SECTION (Page 26)
D
To MAIN SECTION (Page 26)
EQ OUT 1
DECK-B
REC/PB HEAD
IC301 ALC1 MUTE ON/OFF
EQ
REC MUTE ON/OFF
R-CH
REC-OUT
ALC ON/OFF
21
NORM/HIGH
Q323,325
A/B
R-CH
DECK A/B SELECT PB/REC EQUALIZER AMP
SWITCH Q321,322,327
13
12
11
15
14
T331 BIAS OSC Q331
TC A+9V Q334,335
ERASE HEAD
TC BLOCK REC(REW) REC(FWD) B-PHOTO A-PHOTO B-MODE A-MODE B-HALF A-HALF
Q383,384 A TRIG DRIVE
A-SOL
REC-L
23
SYSTEM CONTROL (CD MECHANISM CONTROL)
IC501(2/4) 53 58 61 68
AMS-IN TC-MUTE REC-MUTE ALC
67 65 50 46
PB-A/B BIAS REC-B REC-A
90 89 57 56 91 70 69 51
B-SHUT A-SHUT B-PLAY SW A-PLAY SW B-HALF A-HALF TC-RELAY A-TRIG
Q381,382 B TRIG DRIVE Q385,386
B-SOL
52 B-TRIG
CAP MOTOR DRIVE
CAP M+
55 CAPM-CTRL
CN371 FM/AM TUNER UNIT ST-L ST-LOUT FM ANT
FM 75Ω
FM ANT
AM ANT AM
ANTENNA
ST-ROUT ST-MUTE STEREO TUNED
OUT(ST-DIN) IN(ST-DOUT) AM ANT ST-CLK ST-CE
R-CH
E
To MAIN SECTION (Page 26)
ST-MUTE STEREO TUNED
21 ST-MUTE 2 STEREO 3 TUNED
ST-DIN ST-DOUT ST-CLK ST-CE
25 23 27 22
ST-DIN ST-DOUT ST-CLK ST-CE
• R-ch is omitted due to same as L-ch. • SIGNAL PATH : TUNER (FM/AM) : PLAYBACK (DECK A) : PLAYBACK (DECK B) : RECORD
25
25
HCD-XGV11AV – MAIN SECTION –
J801 MIC 1
+5V REG. Q884
VC (+5V)
RV802 MIC LEVEL MIC AMP
REC-L
MIC OUT
ECHO MIXING
+
IC850(1/2)
A+9V
VC(+5V)
To TUNER/TAPE DECK SECTION (Page 25)
D
IC850 (2/2) VC(+5V)
L MD OUT
J802 MIC 2
MUTE Q701
R-CH
PB-L
INC1 5 INB1 4 INA1 3 IND1 6
ST-L
To TUNER/TAPE DECK SECTION (Page 25)
FUNCTION SELECT SWITCH
MUTE Q401 PHONO EQ AMP
L
X0 12 X1 14 X2 15 X3 11
IC601 R-CH
R
7
INPUT SELECT SWITCH
RECB1
+ SURROUND OR DPL BUFFER
R-CH X
C A B
INEX1
IC181
Q809, 810
J701 (1/2) PHONO IN
IC111
MID/ BASS & TREBLE
F OUT2
14
L+R
+
VOLUME CONTROL
19
21
+ SPEANA
SUR1
F
24
OUT1 18 FAN MOTOR B+
CPU INTERFACE
COMMAND
R-CH
13 42
15
VL IN1
22
To DISPLAY/KEY CONTROL/POWER SUPPLY SECTION (Page 27)
R-CH Q115
D405
D803
+
R-CH
R
+5V REG
A 10
Q611
J500
TM401 FRONT SPEAKER IMPEDANCE USE 6 – 16Ω
+
EQIC-DAT 80 EQIC-CLK 81
8 VSS
D406
–1
R-CH
16 VDD
M
16 17
Q166,167 A+10V
M901 (FAN)
FAN MOTOR DRIVE Q961, 962
L MD IN
J701 (2/2)
Q805,806 LEVEL SHIFT
BB-B1
E
RV801 ECHO LEVEL
C A B
BB-A1
C
IC851
CD-L
+
8
CLK
A
INPUT SELECT SWITCH, GRAPHIC EQUALIZER CONTROL, ELECTRICAL VOLUME
DATA
To CD SERVO SECTION (Page 24) To TUNER/TAPE DECK SECTION (Page 25)
2
DIGTAL LPF1 ECHO LPF2 8 OUT IN
MIC
1
SWOUT
R
R-CH
L
B 9
–
–2
R-CH
+ R
AUDIO R
Q181
R-CH
GAME INPUT
Q182
AUDIO-OUT 1
VIDEO INPUT SELECT
71 AU-SEL0 72 AU-SEL1 5 CD-MUTE
IC191 VIDEO
VIDEO
A B C
R-CH
18 V-SELA 100 V-SELB 76 VIDEO-MUTE
2 3 5
POWER AMP 18
Q802,803 LEVEL SHIFT
SYSTEM CONTROLLER (CD MECHANISM CONTROL)
VCD-VIDEO
B
11
STANDBY SWITCH Q803, 804, 834
R-CH
IC501 (3/4) To CD SERVO SECTION (Page 24)
IC801 12
MUTE Q114
LINE-MUTE 82 R-CH
VD-OUT 6db (75Ω)
10
VIDEO OUT
LOGIC
IN4 8 IN3 6 IN2 4 1 IN1 MUTE
J721 DVD INPUT
–
TEMP DET 97
L
TH831
TEMPERATURE DETECT SWITCH Q842, 843
MUTE Q805,855
TEMPERATURE DETECT SWITCH Q831, 832
STK-MUTE 83 HP-MUTE 86
DELAY Q833
XC-OUT 11 PRO-LOGIC SOUND CONTROL
FRONT
XC-IN 10
72
27
+
26
1
+
R
LT-IN
2
2 C-IN
SUB WOOFER OUT
79
4
RY401
PROTECT SWITCH Q431 Q923
: CD PLAY : TAPE PLAY : RECORD : MIC INPUT : VIDEO
3 OUT RELAY DRIVE Q401, 402
74
HP-IN 95 D410
3
SL 11
10
SL VOL
VOL OUT SL
MUTE Q281
C 5
MUTE Q271 4
C
VOL
VOL OUT C
SR 15
SR 16
IC101(1/2)
5 OVER LOAD DETECT Q101, 151, 181
D811 14
3
6
TM402
POWER AMP MUTE Q731
VR SW IN 80
VOL
POWER AMP
LEVEL SHIFT Q804, 807, 808
9
1 SW-IN
2 VP
PROTECT 88
10
R-CH 76
AC DET
R-CH
1
REAR
CENTER
77 PL-LAT 78 PL-DAT 79 PL-CLK
• R-ch is omitted due to same as L-ch. • SIGNAL PATH : TUNER (FM/AM)
To DISPLAY/KEY CONTROL/POWER SUPPLY SECTION (Page 27)
REAR-RELAY 85
(L-R) (L+R)
SL-IN 77
G
1 OCP
FRONT-RELAY 87
CONTROL CENTER MODE
L
D401
+
X-IN 15 REQ 24 DATA 22 SCK 23
A/D, D/A LOGIC
VCA DVD INPUT
X502 16MHz
L
L-IN
40 42
OVER LOAD DETECT Q801, 851
R-CH
IC912
X-OUT 13
IC201
R
PRPTECTPR
X501 32.768KHz
J711 L
J891 PHONES
R-CH
15
IC101(2/2)
+
18 RY403
SURROUND SPEAKER IMPEDANCE USE 8 – 16Ω R
– REAR
+ 1
L
2
–
RELAY DRIVE Q403, 407
17 VOL OUT SW
RY402
+ –
CENTER
J731 SUB WOOFER OUT
26
26
HCD-XGV11AV – DISPLAY/KEY CONTROL/POWER SUPPLY SECTION – To MAIN SECTION (Page 26)
F IC603
48 VKK BPF-F01 BPF-F02 BPF-F03 BPF-F04 BPF-F05
FLUORESCENT INDICATOR TUBE FL601
18 – 22,24 – 41 43,44 SEG-1 – SEG-25
VF(-35V)
BAND-PASS FILTER
IC601
GRID DRIVE Q608, Q609
1 8
GR-16 GR-9
70 71 72 73 74
ALL BAND 75
16 15 14 13 12
11
NFF02 INF03 NFF04 INF05 F06
DET
B.P.F.
SUB POWER TRANSFORMER T901
SPEANA
VF VF
FLUORESCENT INDICATOR TUBE DRIVER, KEY CONTROL
LINE IN
+3.9V REGULATOR
EVER +3.9V SYSTEM CONTROLLER (IC501) , SIRCS (IC602) B+
RECT D902 – 905
IC901
4 POWER TRANSFORMER T951
REC LEVEL
REC IN
DET
TO FLUORESCENT INDICATOR TUBE (FL601)
6
VF VF F963
16,14 – 12 10,9,7-2 GR-2 ,GR-4-GR8 GR9-GR15
+VL –VL
LED SELB 55
POWER AMP (IC101,IC801), PROTECT CIRCUIT
LED SELA 80 LED DRIVER
IC701 15 GR-3 17 GR-1
64 – 69
16 DATA 17 CLK 18 STB
D503, 501 D701, 703, 705, D707, 709, 711, 713 D801, 803, 805, 807, D809, 811, 813 D901, 903, 905, D600(R)
+VH
RECT D831
VF(–35V) FL DRIVER (IC601)
–35V REGULATOR Q903, 908
AC IN R952 AC7V
+10V D502, 504, D702, 704, 706, 708, 710, 712, 714 D802, 804, 806, 808, 810, 812, 814 D906, 904 D600(G)
-10V
RECT D841 – 844
R951 AC7V RY901 R953 AC12V
+15V
RECT D833 – 836
AC12V
AC DET
G To MAIN SECTION (Page 26)
IC501 (4/4)
D601
41 OTM-RESET
I2C-DAT 60 I2C-CLK 61
CD A+5V(SW) CD D+5V(SW) D+5V (SW) (CD SENSOR SECTION B+)
30 IIC-DATA 29 IIC-CLK
+5V REGULATOR
IC921
B+ SWITCH Q921, 922
D-SW 52 CD-POWER 38
S700 LID (CD) OPEN/CLOSE
57 VOL A
XOUT
XIN
56 VOL B
82
83
+3.9V REGULATOR
D+3.9V
IC922
LED 3.9V
75 LED-STBY 74 KEY-POWER 73 KEY-DISPLAY
LED DRIVE Q601
–VEE +9V REGULATOR
A+9V
X601 4MHz
IC931
ST +9V (FM/AM TUNER UNIT B+) D602
S617
S618 DISPLAY
TC+9V D961-965 FAN MOTOR B+
REMOTE CONTROL RECEIVER (SIRCS) 1
4
TC M+9V (TC MOTOR SECTION B+)
SIRCS
IC602 EVER +3.9V
1
RESET SIGNAL GENERATOR
IC801
3
CD M+7V (CD MOTOR SECTION B+)
20 AC-CUT RESET SWITCH Q801
VOLTAGE SELECTOR S901
CN901 B+ SWITCH Q602-603
D853
RESET 77
ROTARY ENCODER S700
F961
F962
SYSTEM CONTROLLER CD MECHANISM CONTROL
S700 VOLUME
F964
–VH
LED +3.9V
KEY 0 – KEY 5
LED DAT 78 LED SCK 76 LED LATCH 79
P1 – P20
S701-709, 505-508 S612, 501-504 S910-915, 601-607 S613-616, 901-909 S801-805, 800, 806, 807 S701, 809-817
KEY NETWORK
B+ SWITCH Q604, 605
20-29,1-7,9-11
GRID DRIVE Q606,Q607
RECT D832
D911-913
STBY-RELAY 84 12 RESET
D+5V D915
27
27
+12V REGULATOR Q911, 918, D914, 916
POWER ON/OFF RELAY DRIVE Q901
HCD-XGV11AV 7-3. PRINTED WIRING BOARD – BD SECTION – • See page 22 for Circuit Boards Location.
3
2
1
4
5
6
8
7
BD BOARD (SIDE B) BD BOARD
M101 SPINDLE MOTOR
(SIDE A) –
M
C163
+
C164
C166
Q102
C165 C103
B
R176 E
1
IC102
C151
C153
28
R152
R179
R151
A
29
56
R109
R236
C182
C107
R103 R102 C102 R105
SE
FE
TE
C120
R235 R114
30
C109
16
RFAC R121
RFDC
CN101
C
R112
C112
R111
R229
R227
R118
R113
R117
C104
DVC
R120
D101
C101
R104
C108 C213 C111 R228
IC103
V
DVC
15
VIDEO BOARD (Page 30)
C117
R126
C110
Q101
C115 R125 E
R122
C113
1-684-174-
R124
C114
R123
C119
R234 CN102
C118
D
1
R231
+
12 (12) OPTICAL PICK-UP BLOCK (A-MAX.3)
E
–
M M102 SLED MOTOR
1-684-174-
12 (12)
• Semiconductor
Location Ref. No.
28
28
Location
D101
C-6
IC102 IC103
B-7 C-6
Q101 Q102
D-5 B-5
HCD-XGV11AV 7-4. SCHEMATIC DIAGRAM – BD SECTION –
CN101 28P R234 0 R231 1k
C213 0
R103 100k
R227 100k
D101 1SS355TE-1
C102 0.1
R102 15k
C101 470p
C112 47 C109 0.1 4V
C115 47 6.3V
C117 0.1
CN102 16P
R126 33k
R105 1k Q102 UN2111-TX SWITCH
C104 0.0033
R125 33k
R112 0
R111 120k
C119 1
C120 47 4V
IC103 CXA2581N-T4 RF AMP
R120 120k
C107 33p
C118 1
R114 47k R109 120k
R117 47k Q101 2SB710A-RT LD DRIVE
C110 0.1 R104 15k
R229 2.2k
R113 2.7k
C114 0.001 C111 47 4V
C108 0.1
R118 0
C103 470p
R228 470k
R122 100k
R235 1k
C113 100 4V
R124 10 R123 10
C166 0.1 C182 100 10V
IC102 AN41020A FOCUS/TRACKING COIL DRIVE, SPINDLE/SLED MOTOR DRIVE C153 0.1
C165 10 16V
R152 4.7k R151 100k
R179 10k
R176 0
M102
C151 0.022 C164 0.1
R236 1k
C163 100 10V M101
29
29
HCD-XGV11AV 7-5. PRINTED WIRING BOARD – VIDEO SECTION – • See page 22 for Circuit Boards Location.
W
(SIDE A)
VIDEO BOARD
5
MAIN BOARD (Page 37)
6
(SIDE B)
VIDEO BOARD
CN301
C366
EP200
C364
Q370
IC307 16
17
C253
E
B1
R375
C576
C361
C365
A1
B
8
7
R376
A
4
IC506
FL502
C567
C360
C571
8
7
14
1
R561 C574
3
2
1
FB360
C561
IC507 C566
IC508 C575
55 54
1
CN201
IC202
3
4
1
EP202
R115 C115
X502
5
8
IC102
A
1-687-869-
C254 FB251
R532 R534
C224 C255
C257
• Semiconductor
FB503
C208
Location
C221
1 2
IC201
3
1-687-869-
MAIN BOARD (Page 37)
30
Ref. No.
C203
C116
11 (11)
30
C222
R201
C205
C547 FL503
R508 R507 R506 R505 R504 R503
E
C206
C201
1
C223
FB502
L102
C210
C533
C535 C542 R546
C550
R550 R547
R522
C504
R513 C321 R321
R157 R158 C155
C204
R544
FL504
C259
R102
R152 R114
19
9
C156 R159
C114
C258
C214
IC504
8
C154
FL201
F
16
1
C104
C597
C106
C211
C581
R109 R108 C105 R107
R554
R202 C209
C545
FB504
C207
E
C596 C552
C541
Q581
C582
R552 C543
C548 C546
R531
R541 R542 R543
C322
C583
C584
R545
L321
C323
R582 R581
R516
C501
C525 1 C538
C212
R558 C551 R517
R551
C503
R555 R556 R557
2
C502 R502
218 C540 C544
5
163 FB501
C524
10
1
C570
162 FB252
R510
R559 C549
R322
15
X501
R537 C523
R538
R509
R323
E Q301
R533
C522
C202 FB201
R512 R511
20
E
C521
IC505 C338
V
C510
Q201
JW203
28 27 25
BD BOARD (Page 28)
C513 C505
109
D
C511
FL501
R548 C536
108
CN101
FB561
C572
1
32
R549 C539 C537 C534
EP201
C
C213
C573
11 (11)
Location
IC102 IC201 IC202 IC307 IC504 IC505 IC506 IC507 IC508
F-4 F-8 F-2 B-6 E-6 D-3 B-8 C-7 C-3
Q201 Q301 Q370 Q581
E-8 D-6 A-6 E-5
HCD-XGV11AV 7-6. SCHEMATIC DIAGRAM – VIDEO SECTION – • See page 54 for IC Pin Function.
C596 10 16V
1887SO SCK
C259 100 6.3V
SRQ
8
R102 100
C105 0.0047
6
C581 0.1 IC504 PCM1748E/2 K D/A CONVERTER
R582 470
R109 1.5k
R108 1.5k
C584 0.1
C597 10 16V
C104 22 6.3V
205
SOK
C202 0.1 25V F
C213 C203 22 100 6.3V 6.3V
C205 0.1
C204 0.1
C207 0.1
C550 8p CH
R551 1.6k
3
5
6
165
162
163
164
165
C539 0.47 173
R543 470k
R541 0
R542 0
R545 1k
C535 0.068 R546 180k
C544 R552 0.47 820
C537 100p CH
R548 680k R550 10k
201
R554 10
204
203
205
C547 1 50V C548 0.1
R544 1M
C525 1 50V
R517 2.7k
C206 0.1
C208 0.1
C551 0.1
R516 4.7k
FB201 0UH
X502 27MHz R559 470
C542 0.1
C540 0.1
R534 0
R502 3.3k
IC202 BA033FP-E2 +3.3V REG
162
C501 10 16V C503 0.1
FL201 0UH
160
C524 0.1 F
R533 33k C210 0.1 25V F
C214 22 6.3V
C212 0.1
C211 100 6.3V
COUT
R503 100
R561 1k
R532 4.7k
1887SI
C566 100 C561 6.3V 0.1
C574 0.1
C567 0.1
9
6
R538 10k 1/10W
R537 0
R504 100
1887SO SCK
R505 100
SRQ
R506 100
SOK
R507 100
SCS
R508 100
C522 7p CH
143
28 29
R513 10k
30
3
142
C504 0.1 25V
5
X501 33.8688MHz C523 7p CH
IC201 µPC2925T-E 1 +2.5V REG
C552 1 50V
R556 10
FB504 0UH
C549 8p CH
R558 1M
C502 0.1
R557 10
C222 10 16V
R555 10
C545 1 50V
C536 150p CH
C570 0.0033
C224 0.1
R547 10k
R549 100k
FL504 0UH C543 470p CH
C546 0.1
C223 100 6.3V
R201 100
C533 0.1
FB502 0UH
FB503 0UH FL503 0UH
C221 10 16V
C538 100 6.3V
C534 470p CH
C541 0.01
Q201 2SD999-T1CLCK RIPPLE FILTER
FB561 0UH
173
163
C255 0.1 FB251 0UH
FB501 0UH
C209 22 6.3V
JW203 0
C254 0.1
FB252 0UH
SCS
C201 22 6.3V
160
164
142
135
143
141
9
C257 68 10V C583 0.1
140
R107 10k
CN101 28P
138
R581 100 C106 1200p
5 7
203
204
Q581 2SC4154TP1EF +3.3V REG
R157 10k
137
IC102(2/2) NJM2100M(TE2) LPF
C115 0.1 R115 2.2k
C156 1200p
C154 22 6.3V
133
R114 2.2k
3
R158 1.5k
R202 100
1
R159 1.5k
26
C114 22 6.3V
2
29
C116 100 6.3V
L102 2.2µH
1887SI
4
30
C258 0.1 25V F
C155 0.0047
IC102(1/2) NJM2100M(TE2) LPF
R152 100
C582 10 16V
201
CN201 19P
141 140
IC505 IC506 BU2507FV-E 2 DATA DECODER, D/A CONVERTER
26
R509 100
CXD1887R
138
CD-DSP,
137
DIGITAL SERVO, 28
R510 100
29
R511 100
30
R512 100
CN301 3P
R531 100k 135
MPEG DECODER,DAC
133
R375 75
FL502 0UH
FL501 0UH
C575 100 6.3V
C361 0.1
C521 0.1
IC507 VG3612816B T-7L SDRAM
34
C365 100 6.3V
35
49
66
50
65
51
64
C366 100 6.3V
C360 100 6.3V
36 37
FB360 0UH
39 40
65
45
64
66
62
54
61
55
60
56
59
63
77
62
73
78
41
43
68
70
40
44
72
60 74
36
59
44 45
R376 10k
C572 0.1 50 51 52 53
Q370 DTC114EUA-T106 INVERTER
54
76 44 45
43
34
56
34
42
49
55
35
41
50
54
36
40
51
53
37
39
35
43
49
61
39
IC307 BD7600FV-E2 VIDEO AMP
42
C505 0.1
42
37
41
C364 10 16V
C576 100 6.3V
C573 0.1
63
53
R323 470 78
77
74
76
73
72
70
68
66
65
62
64
63
61
60
59
56
52 55
IC508 MR27V401E-0F3MAZ 060 ROM
52
C338 0.1
C571 0.1
C513 0.001
C511 0.1
C322 15p CH
C253 0
R522 10k
C510 0.1
Q301 2SA1602TP1EF LPF
R322 0 R321 220
31
31
C321 22p CH
L321 10µH
C323 10p CH
HCD-XGV11AV 7-7. PRINTED WIRING BOARD – MOTOR LED SECTION – • See page 22 for Circuit Boards Location.
7-8.SCHEMATIC DIAGRAM – MOTOR LED SECTION –
LED BOARD SENSOR BOARD
4.8
TABLE MOTOR DRIVER
4.8
TRAY
MOTOR BOARD
B B
MAIN BOARD (Page 37)
MAIN BOARD(3/4) (Page 35)
DISC TABLE SENSOR
4.8 LED DRIVE
32
32
4.8
HCD-XGV11AV 7-9. SCHEMATIC DIAGRAM – MAIN (1/4) SECTION –
IC111 M61529FP+T60G INPUT SELECT SWITCH, GRAPHIC EQUALIZER CONTROL,ELECTRICAL VOLUME
R604 1k
C136 10 50V
R119 470
R654 1k
C651 330p
C655 0.0047 PET
C656 0.0015 PET
R655 560k
R656 47k
R132 33k
80
C134 0.01
R135 0
C135 47 16V
PL A+9V
R115 15k Q611 2SC2603 V REF
Q115 2SC2603 SWITCH
R118 10k R122 2.2k
6
R652 1k
R651 1k
5
C653 100p
IC601(2/2) NJM4558M
R657 1k
C657 0.033
L-CH SIG
R125 10k
R612 1k
Q114 2SC3623TP MUTE R124 10k
C613 47 16V
SIG AGND
C611 47 16V
C612 0.01
R614 1k
C181 0.1
R707 1M
C139 10 50V
R611 1k
R174 10k
Q164 2SC3623TP MUTE
R613 330
R179 10k R-CH SIG
J701 6P
R140 100k
IC181 MC14052BFEL FUNCTION SELECT SWITCH
C174 2.2 50V
R141 100k
7
C658 10 50V
C124 2.2 50V
R127 150
R658 100k
R653 47k
C137 3300p C121 10 50V
C133 10 50V
C654 2.2 50V C652 100p
C111 10 50V
R120 0
C604 2.2 50V
R112 10k
C606 0.0015 PET
C118 10 50V
R111 2.2k
C119 0.033 C120 4700p
C605 0.0047 PET
C115 10 50V
R606 47k
C112 10 50V
R605 560k
C132 100 16V
C114 10 50V
C610 100 16V
C113 10 50V
1
C123 0.33
R609 220 1/10W
C116 0.022
R603 47k
C609 0.01
2
C601 330p
C602 100p
C607 0.033
C117 0.022
R602 1k
R601 1k
R607 1k
R608 100k
C608 10 50V
8 3
C110 10 50V
C603 100p
C122 0.33
IC601(1/2) NJM4558M
R172 2.2k
Q166 DTA124ESA AMP
L IN
R757 1M
C752 220p Q701 2SC3623TP MUTE
C772 0.1
C183 0.1
C168 10 50V
R177 150
C171 10 50V
R169 470
Q167 2SC2603 AMP
DBFB
R176 22k
+9V DSC AGND
C172 0.33
R136 0
C173 0.33
V GND
R161 2.2k
CN152 10P
C714 10 50
Q751 2SC3623TP MUTE
78 79
81
R755 10k CN722 5P EH-S
C764 10 50
R721 75
R756 2.2k
C753 10 50V
R706 2.2k
C703 10 50V
77
PL AGND
C774 0.1 C722 1000 10V
R715 6.2k
R716 10k
C713 220p
R765 1k
R766 10k
C763 220p
C193 0.1
C731 10/50
D191 1SS355
D192 1SS355
R732 1k
R733 100k R731 10k
C732 220p
C733 0.1
Q731 2SC3623
33
33
TA-MUTE
C762 220p
MC1
R764 10k
SPE-SIG
R763 6.2k
C192 10 50V C191 0.01
ST-R
C712 220p
CD-R
R714 10k
RECOUT-MUTE
R713 6.2k
CN151 10P
ST-L
C761 220p
CD-L
C711 220p
R762 10k
SW-MUTE
R712 10k
R761 8.2k
TCPB-R
R711 8.2k
18
J711 6P
D161 1SS355
C724 470p
D162 1SS355
AC-MUTE
C723 1 50
R723 75
R734 1k
AU D+5V JACK GND
R722 47
R724 10k
C775 0.1
AU DGND
IC191 BA7615N VIDEO INPUT SELECT
TCREC-R
J721 2P
C721 1 50V
TCPB-L
JR723 0
C776 0.1
R170 0
R705 10k
C773 0.1
J731 1P
C161 10 50V
TCREC-L
CN721 2P
Q181 DTC124ESA INV.
R143 10k
C169 0.033 C170 4700p
C182 0.1
R162 10k
R754 100k
C167 0.022
R704 100k
R753 1k
R142 10k
MIC/PTY-SIG
R
R703 1k
76
L OUT
Q165 2SC2603 SWITCH
R168 10k
Q182 DTC124ESA INV.
220p
C166 0.022
C702
C754 10 50V
C160 10 50V
C751 220p
C165 10 50V
C701 220p
R751 R752 1k 100k
C164 10 50V
MD(VIDEO)
R701 R702 100k 1k
R165 15k
72
R
R182 10k
71
L IN
R181 10k
C162 10 50V
C771 0.1
C163 10 50V
C704 10 50V
R
100
PHONO
HCD-XGV11AV 7-10. SCHEMATIC DIAGRAM – MAIN(2/4) SECTION –
R477 4.7k
MIC/PTY-SIG TCREC-R
JR353 0
R338 10k
C352 10 50V JR351 0
R352 4.7k C353 0.1 MF
R347 220k
R348 470
C345 47p
Q344 2SC2785TPHFE Q342 2SC2785TPHFE
R349 220k
Q341,342,344 HPF
R361 10k
R363 JR
C346 0.1 50V D384 1SS355 R350 470
D383 1SS355
MIC-IN
Q343 DTC124ESA AMS DETECT
C347 0.1 50V
53
R355 47k
R354 2.2k
R342 1k
R346 10k
C356 2.2 50V
C355 1 50V TP351
TP352
C351 0.01 PET
IC301 HA12237F DECK A/B SELECT PB/REC EQUALIZER AMP
C348 100 16V
R345 470k
C344 1 50V
C343 47p Q341 2SC2785TPHFE
C354 10 50V
R351 3.3k
R339 10k
R343 470k
C342 0.033
R341 1M
R358 10k
JR360 0
TCPB-R
C366 0.001
R365 2.2k
TCPB-L
R340 3.3k
C341 2.2 50V
R364 22k
TCREC-L
R344 10k
JW422
C357 47 16V
TP303 R308 22k
C312 10 50V
C311 100 16V
R309 1M
C310 10 50V
CN311 3P EH
TAPE A
C358 390p
HEAD
C308 390p
C313 10 50V L301 100µ
61
R311 4.7k
58 67
TP304
68
C307 47 16V
R301 3.3k
TP301
C359 390p C309 390p TAPE B
C301 0.01 PET
JR303 0
HEAD
C303 0.1 MF
C305 1 50V
C304 10 50V
R302 4.7k C302 10 50V
JR301 0
R310 10k Q323-326 SWITCH
R304 2.2k
TP302
CN321 8P EH
C306 2.2 50V
TC+9V
R305 47k
JR350 0 C322 0.001
R315 2.2k
R314 22k
Q322 2SA1175
B1 B2 D+3.3V
R323 10k
Q324 2SC2785TPHFE
Q323 2SC2785TPHFE
Q385,386 CAP MOTOR DRIVE
R320 10k
Q386 DTC124ESA
55
R326 10k
C319 2200p
Q321 DTC124ESA
R390 3.3k
CN371 13P
R388 3.3k
R378 10k
Q327 C321 DTC124ESA 47 16V
R375 10k Q383,384
C320 2200p
Q335 2SB1116 SWITCH
Q331 2SC2001 BIAS OSC T331
R336 270
R337 10k
C338 47 16V
R331 22k
R333 10k
C331 0.015
Q383 2SB1116
R330 22k
C333 0.0047 C332 0.0047
R385 2.2k
R371 10k
D382 1SS355
TC MOTOR +9V
TC AGND
TAPE MECHANISM DECK
70
56
R372 10k R381 680
Q334 DTC124ESA SWITCH
TC DGND
90 46
89
65
R334 10
34
C382 0.0047
Q384 DTC124ESA
52
Q381 2SB1116
34
R377 10k R386 2.2k
R384 680
50 57 91
DRIVE
R335 22k
C334 0.022 100V
R374 10k
A TRIG 51
TC MGND
Q321,322,327 SWITCH
Q385 2SB1068
PARTY AGND
R322 4.7k
R389 3.3k
R387 47k
69
PARTY DGND
R321 4.7k
R324 0
TC BIAS GND
Q326 2SC2785TPHFE
Q325 2SC2785TPHFE
R383 2.2k
Q382 DTC124ESA Q381,382
C381 0.0047
R382 2.2k
D381 1SS355
B TRIG DRIVE
HCD-XGV11AV 7-11. SCHEMATIC DIAGRAM – MAIN (3/4) SECTION – • See page 57 for IC Pin Function.
TUNER PACK
MC1
CD-R
CD-L
ST-R
SPE-SIG
ST-L
AC-MUTE
TA-MUTE
CN402 4P
CN801
27
25
23
3
22
2
21
CN441 11P
RECOUT-MUTE
SW-MUTE
NC
MC2 VF1 VF2 VFDP LED 3.9V
FB562 0µH
73
74
75
BPF+9V
R572 15k
D 3.9V
C406 100p R404 1k
R571 15k
R402 33k C405 100p
51
95
52
53
R552 10k
R557 100
R556 100 55
57
56
58
61
65
69
67
70
68
C563 47 16V
R570 100
71
72
R573 100
41 30
C562 0.1
29
4
R549 10k
TP563
R574 100
R575 100
R580 100
R563 10k
76
80
B1
PANEL GND CN431 19P FFC-S
D431 1SS355
C431 0.1
81
R581 100
83
R583 100
84
R584 100
85
R585 100
86
R586 100
50
82
87
R587 100
88
R588 100
45 44
R543 100 R551 10k
R591 100
R593 680
43
R540 47k 41 R541 100 40
IC501 M30620MCN-A214FP SYSTEN COMTROL
91
38
R537 100 37 95
R599 10k
R536 100 36 R595 100
R596 1.5k
97
Q804,807,808 LEVEL SHIFT
D811 1SS355TE-1
75
46
R547 100
R590 100
90
74
47
R589 100 89
73
48
D810 EC10DS2-TE
R592 4.7k R594 4.7k
R582 10k R597 47k R598 47k
49
R548 100
R535 100 35
R600 10k
34 33
R533 100
32
C401 0.1
R532 100
100
R401 4.7k
R615 100
Q804 DTA124ESA
Q807 DTC124ESATP
R534 100
R405 10k C414 0.1
R811 10k
R406 10k
Q401 2SC3623TP MUTE
CN401 19P
C403 10 50V
JR404 0 C402 1000 6.3V
C407 220p
R407 0 R408 0
Q402 2SC3623TP MUTE
C408 1000 6.3V FB403 0µH
C516 0.1
Q802 DTC124ESA
Q810 DTA124ESA
R813 10k
R814 22k
R812 3.3k R810 100k
R808 100k
C806 2.2 50V
R816 100k
R815 22k
R518 100
29 27
25
22
23
30
19
C410 470 10V
Q809,810 LEVEL SHIFT
C804 1000 6.3
CN411 9P CT-S
D803 1SS355 Q411 DTC124ESA INV.
D801 1SS355
R806 10k
R807 1k
19
FB516 0µH
Q809 DTC124ESA
82
JR414
33
R531 10k
21
Q803 DTA124ESA Q802,803 LEVEL SHIFT
R530 100
R529 100
R527 100
R525 100
R522 100
R523 100
R519 100
R521 100
R517 10k
C512 0.1
R509 10k
R513 0 X502 16MHz
3
2
Q805 DTA124ESA
37
32
R410 0
D802 1SS355
Q801 2SC2603 RESET SWITCH
R803 4.7k
R805 47k
R804 47k
C803 0.1 MF
D804 1SS355 IC801 M62703SL RESET SIGNAL GENERATOR
C802 0.1 MF
D807 1SS355
R801 220
49
D805 1SS355 R802 4.7k
R412 15k
R413 10k
D806 1SS355
R414 10k
45
C801 10 50 47
D808 1SS355
48
D815 1SS355
D809 EC10DS2
44
D+3.3V
35
M GND
D+5V UNSW
CD D+5V SW
CD A+5V SW
CD AGND
EVER+3.9V
MC DGND
ST +9V
ST AGND
-VEE
35
M +7V
Q412 DTC124ESA INV.
TC+9V
CD DGND
Q806 DTC124ESA
C416 2200p
36
40
R516 10k
18
Q805,806 LEVEL SHIFT
C415 2200p
43 35
34
C510 C511 18p 22p
4
B2
X501 32.768kHz
R505 10k
R504 100
R501 10k
R503 100
C807 4.7 16V
Q808 DTC124ESATP
C598 0.1
R502 100
C599 47 16V
R511 330k
R403 10k C404 10 50V FB599 0µH
R809 100k
FB402 0µH
HCD-XGV11AV 7-12. SCHEMATIC DIAGRAM – MAIN (4/4) SECTION –
IC921 µPC7805AHF +5V REG
Q921 2SB734-3 B+ SWITCH
CD A+5V SW CD D+5V SW
R922 2.2k
CD DGND 38
C924 1000 6.3V
CD AGND M +7V
R921 10k R923 2.2k
M GND
Q922 DTC124ESA INV.
C922 0.1
MIC-IN
C921 2200 16V
R924 2.2k
CN903 3P
MC DGND EVER+3.9V
D+5V UNSW
ST AGND
IC912 IC RT8H015C-T12
IC931 M5F7809L +10V REG
IC922 µPC3504AHF +3.9V REG
C928 2.2 50V TC MOTOR +9V
ST +9V
PARTY AGND
-VEE
C902 0.1
C903 C925 470 0.1 16V
C926 470 6.3V
C913 47 16V
TC DGND
C901 0.01 25V
TC BIAS GND
TC+9V
C929 47 25
C930 100 16V
Q923 2SC2603 SWITCH
TC MGND
C927 100 16V
PARTY DGND TC AGND
PL A+9V
EP901
L-CH SIG SIG AGND
PL AGND
D913 EC10DS2
R-CH SIG
D912 EC10DS2
+9V
DBFB
D911 EC10DS2
AU DGND
DSC AGND
AU D+5V
V GND
JACK GND
Q911 2SD2012 +9V REG
BPF+9V D 3.9V
D915 UDZS TE-17 5.1B
R911 100
C915 100 16V
Q918 2SC2603 +9V REG
LED 3.9V VFDP VF2
D916 UDZS5.1B
C914 100 16V
VF1
D914 UDZS 5.1B 88
C961 0.1
FAN
R963 2.2k R961 4.7k
Q962 2SB1116 Q961 2SC2603
R962 18k
CN901 13P
36
CN902 13P
36
84
97
86
87
D965 D964 D963 D962 D961 EC10DS2 EC10DS2 EC10DS2 EC10DS2 EC10DS2
Q961,962 FAN MOTOR DRIVE
83
MC2
M901
85
CN961 EH-S 3P
R912 2.2k C912 470 10V
PANEL GND
C911 470 25V
HCD-XGV11AV 7-13. PRINTED WIRING BOARD – MAIN SECTION – • See page 22 for Circuit Boards Location.
REAR
L
R FRONT
J711
CN402
R341
R338
R339
JR301
RV301
C301
C308
• Semiconductor
JW25
Location
C358
TAPE A HEAD
JW22 JW436
JW422
JW433
MIC BOARD (Page 52)
R461 R751
C604 C608
C651
L OUT
37
CN903
IN
JW415
JW538 CN441 R606 R607 C658
C771
R
VIDEO BOARD (Page 30)
R658
C657
5 8 JW536 R657 R653 R656 C656 C652 R655 R652 C655 C653
C772
MD (VIDEO)
1
PROLOGIC BOARD (Page 50)
C609
R701
J731 SUB WOFER OUT
4
JR16
R651
R754
JW412
C606
C602
R702
R752
U
C607 JW416
IC601 C603
R602
TUNER PACK
R603
C754 C751
R605
C601
C704
R601
JW981
JW884
R604
JW428
JW429
CN321
C334 JW871 C753
C701
R705
R704
E C732
TAPE B HEAD
JW414
R609
Q326
Q324
JW446 JW444
Q701
E E Q751
C612
JW448 JW413 JW447
E
R654
R731
R733
R734
JW982 C733
Q611
JW453 JW452
R753
JW500 JW510
R755
R611
R614 E
JW419
R756
JW504 R706
JW506
R757 R707
C703
R612
R613
C610
Q323 Q325 JR501
E
E
C613
C605 R608
C321
JW430 JW431
E
JW872
JW870
JW508
JW883 JW885
E R320 Q327 E E
T331
JW505 JW503
IC181
R782
Q321
JW445
JW304
JW308 JW48
JW47 JW309
JR44
R336 C332 C331
JW515
JW6
JW514
JW46 R181
E
R321
JW423
JW513 JW397
JW396 JW394
C307
C359 C309
C611
R322
E
C319
Q335
E C333 R331
FRONT INPUT BOARD (Page 38)
37
JR350
C357
C352
R333 C320
E
Q331
C183
C181
R326 R323
R335
R337
C338
R324
R330 Q334
JW305
C182
Q182 E
JW28 JW27
C353 R351
JR353 R352
C351
Q322
C702 R703
JW879 JW878 JW877 JW880
R182
R302
CN311
R343
R310
C322 R315
JW32 JW31
R354
RV351
30 31 C312
JR351
JW157
JW42
1 40
C302
R306
R371 JR24 JW36
JW37
R382
C382 R381
Q381
R375
C354
JR40
JW41
JR303 R301
C303
20 21
C355
R365 C366
JW421
JW307
JW45 JW44 JW43 JW361 C722 R724
R344 R340
D382 D381
JR30
JW3 JW38
R311
R308
R358
R556 JW141
JW148
R355
JW34
C776
J721
W
DVD INPUT
C381 R383
R384 R389 JW13
JW15 JW14
R575
R572
R574
JW151 JW150 JW149 JW146 JW145 JW144
JW152
R563
JW138
R581
R583
R571
R570 R573
CLP5
JW303
JW306
C731
C R
R309 11 10
R305 R304
JW291 JW294
Q731
VIDEO OUT
C305
C310
L301
C752
VIDEO
C304
R477
1
JR723
R723
JW140 JW139
R594
JW562 JW561 JW49
JW567
JW568
JW569
JW570 JW360
JW387
C306
JW290
JW302
E
C724
C348
JW158
Q181
C143
JR13
R763
IC191 R722
C774 C761 JW385 R762 R761
D192
1
10
R350 R349 R348 R347 R342 C341
Q341
C470
5
1
Q342 E
E
D383
R314 C313
JR360
R334
CN722
M901 FAN L
JW16
R599 R590
R504 FB599 JW169 JW168 JW167
JW183
JW185 JW572 JW873
JW881 JW882
JW340 JW359
JW358 JW388 C773
JW332
JW89 JW143
R513 C516 JW173 JW174
JW166
JW104 R532
JW106
JW264 JW263 JW354
R170 JW357
JW980
JW353
JW389
D191
C343 C342
D384
C347
JW40 C356
JW299
JW391 C723
E
R361
R557
JW161 JW162
C344
JR406
C311
JW555
JW131
JW350 C711
JW55 JW56 JW58 JW60 JW59 JW57
JR26 C345
JW289 CN152 10
C192
R721
R378
R377
JW71
JW52 JW295 JW296 JW297 JW73 JW298
JW279
JW278
JW277
JW276
JW275 JW265
JW563 JW333 JR23
JW347 JW348 JW380
JW383
1
CN721 2 1
JW12 JW384 C714
C762 R764
C721
D815
R372
Q344 E
R345 R346 C346 Q343
JW94
JR3
C191
R374
JW30 R364
JW165
R522
R509
C511 C510
R511 X501
D804
D802
R505
R803
R802 D808
R805
JW189 JW188 JW187 JW186
JW70 JW579 JW191 JW190
JW271 JW274
JW273
JW269 R142 R140 R141
R765
WOOFER
PRO LOGIC BOARD (Page 50)
FB562
D807 C803
D806
C801 R814
Q809
Q810
JW267
JW266 JW270 JW268 JW377
JW378
C763 C712 R766 R714
C764
R711 R712
R716 R715
CENTER
T
JW172 JW171 JW170
R549
JW560
C775
3
JW381
R713
E C961 CN961
E
CN151 10
C165
C713
Q962 Q961
R962
JW156
JW116 Q807 Q808
Q806 R815
JW192 C406
C166
C170
R161 JW344
JW114
CLP4
K
R536
JW310
C168
C124 E
R961 R963
J
R548
R120
C162
1
Q165
R122
E Q166
R162 C167
R165
R125
JW341
R179
R168
EP901
D965
JW337
C164
C139
Q167 E
C160
C171
JR18
R176
R111
C169
C172 JW343
R172
JR17
D964
JW336
R169
C173
JW345
JW342
C174
I
R543
JR25
JW88
C562
50 51
CN371
JR12
JW87
R579
JW300
R136 C161
42 C163 R143
22 R127
JR22 Q164 E
C135
C110 C137 R135
Q115 E
R177
E
C123
JW339
R115 R119
R582
R577 C563
JW8
E
JW74 JW75
R578
Q383 E
R386
R388
JW76 R588 JW110 JW82 JR8 JW83 R587 JW84 R585 JW85 R586 81 R584 JW86 R580
JW11 R385
JW9
JW17
R589
JW319
JW588
1
JW346
D162 D161 R124 JW583
D962
Q114
C122
C598
JW77 JW78 JW79
JR2
R390
Q384
JW301
C132 R132
C136
IC111
21 C120
C930 R118
R174 JR19
C929
R597
IC501
JW328
C111 C121
C118
R593 R592 R596 JR10
1 100
R547
JW329 JW330
R112
3 1 4 6
E
C133
C113
C134
Q923 IC912
C117
C112
C115
JW559
C927 JW259
C116 C119
JW288
JW620
C114
IC931
JR42 C928
D963
R403 JW260
JW284 JW282
3
1 JW254
C903
JW250
C902
JW251 JW252 JW253
JW261 JW262
JW258
JW281
JW272
C901
JW248 JW249
JW379
CN901
C926
R502
31
JR333
1
3
JW255
D961
JW137
R591 R598
CN431
E
E
Q382 E
D809 JW67
80
R541
JW178 JW177
JW225 JW224
JW223
JR414 JW229
JW256
H
JW246 JW247
IC922
JW286
R537
R540
JW136
JR4
R529 30
R530
C925
JW226 JW227 JW228
JW280
JW134 JW135
JW242 JW243 JW244 JW245
1
F
JW257
JW133 JW408
JW66
C599
Q385
Q386 R387 E
D810
JW64
R595
R517
R533
JW409
JW241
C922
C921
JR45
JW142 JW132 JW410
JW238 JW240
IC921
3
JW222 JR46
JW610
JW553
JW221
JR35
R527
JW237 Q922 E
X502
R521
14
PANEL FL BOARD (Page 44)
1
C924
JW218
G
JW193
JW211
Q921
JW100 JW101 C512
R806
C807
JW236 JW239
R924
R921
R519
D
13
30
JW220
F
R404
C414 D911
E
PA BOARD (Page 46)
JW234 JW235
D916 R912
JW219
R812
JW127 JW128 JW129 JW130
R501
FB516
12
IC
CN902
D912
D913
C913
JR32
R503
C431
JW62 JW63
JR11 R600
JR5
R518
JW126
JW233
E
D915
R813
JW232
Q918
D914
JW124 JW125
E Q801
JR47 C804
E
D801 JR6
D803
R531
R911
D
E
R410
R804
JW65
R615
E
R516
E
E E JW117
E
JW122 JW123
R523 R525
Q911
C911
D805
JW118
JW217
Q165
JW230 JW231
R922 R923
R913
R801
Q804 Q805
R816 JW120
C912
PA BOARD (Page 46)
G
R811
JW109 R535
JR323
R406
1
E E E JW119 JR7 R810
Q802
JW182 JW181 JW180 JW179
JW216 JW215
JR324
Q402 E
3
11
D431
1
C802
R808 R809
D811
FB402 E Q401
JW204
C914
C915
JW194 C404
C403
R414
JR322
C408
JW113 JW115
10 TAPE MECHANISM DECK
CN801 2
IC801
C806
Q803
R807
JW406 C416
R405
R413
R407 R408
C405 R402 R401
Q411
C415
E
FB403
C407
E
JR404
JW214 JW213 JW212
R412
E
C
C401
C402
Q412
JW208
18 CN401 C410
1
JW201
JW202 JW203 JW205 JW206 JW207
JR1
C409
9
HEADPHONE BOARD (Page 38)
H
JW112
JW197
CLP2 JW200
8
7
VIDEO BOARD (Page 30)
JW198 JW199
B4
6
A
CN411
B
5
R534
MOTOR BOARD (Page 32)
B
MAIN BOARD
A
4
JW176 JW175
3
2
1
PHONO IN
J701
C654
1-687-261-
11 (11)
Ref. No.
Location
Ref. No.
Location
D161 D162 D191 D192 D381 D382 D383 D384 D431 D801 D802 D803 D804 D805 D806 D807 D808 D809 D810 D811 D815 D911 D912 D913 D914 D915 D916 D961 D962 D963 D964 D965
H-3 H-3 I-7 I-8 B-11 B-11 C-12 C-12 A-10 B-7 C-7 B-7 C-7 B-6 B-6 B-7 B-7 B-10 B-9 B-5 C-10 D-4 D-4 D-4 D-3 D-2 D-3 H-2 H-2 I-2 I-2 I-2
IC111 IC181 IC191 IC301 IC501 IC601 IC801 IC912 IC921 IC922 IC931
H-5 I-9 I-7 D-12 C-8 I-13 B-7 H-3 E-4 E-4 G-3
Q114 Q115 Q164 Q165
H-3 H-3 H-3 I-3
Q166 Q167 Q181 Q182 Q321 Q322 Q323 Q324 Q325 Q326 Q327 Q331 Q334 Q335 Q341 Q342 Q343 Q344 Q381 Q382 Q383 Q384 Q385 Q386 Q401 Q402 Q411 Q412 Q611 Q701 Q731 Q751 Q801 Q802 Q803 Q804 Q805 Q806 Q807 Q808 Q809 Q810 Q911 Q918 Q921 Q922 Q923 Q961 Q962
I-3 I-3 I-8 J-8 G-11 G-10 G-11 G-12 G-11 G-11 G-11 G-10 G-10 G-10 C-13 B-13 C-12 B-12 B-12 B-10 B-12 B-10 B-10 B-10 C-3 B-4 B-3 B-2 G-13 J-10 J-9 J-10 B-7 B-7 B-6 B-6 B-6 B-6 B-6 B-6 C-6 B-6 D-3 D-3 D-4 D-4 H-3 J-4 J-4
HCD-XGV11AV 7-14. PRINTED WIRING BOARD – CD-L, CD-R SECTION – • See page 22 for Circuit Boards Location. 3
2
1
4
5
6
8
7
9
10
ALBUM BOARD A
DOOR SW BOARD
I
H
S700 (DOOR SW)
MAIN BOARD (Page 37)
C700
PA BOARD (Page 46)
R606
NO702 1 2
S606 ALBUM -
1-687-267-
HEADPHONE BOARD
11 (11)
NO607 1 2
CD–R BOARD 1
21
M
NO891 JW891 C893
1-687-258-
11 (11)
NO606
NO701
R603
2 1
TC-B BOARD (Page 40)
CN600
R602 R601
R604
PHONES
>
S603
x
NO892 R891 C891 C892
J891
S600
S604
CLP891
1-687-268-
JW701
R600
5
B
S602
K
R605
M S605
NX
C
D600
R608
S601
>
R607
1-687-266-
C
FRONT INPUT BOARD
11 (11)
MAIN BOARD (Page 37) J500
D
6
R523
C501
R
1
R525
R521
C502
C504
AUDIO
JW501 L
R522
CD–L BOARD
GAME INPUT
TC-A BOARD (Page 40)
S701 REPEAT
R703
R524
C505
C503 S707 DISC 4
DISC 2
R706
J
S702 PLAY MODE
R704
F
R700
S705 2 1
VIDEO
S709
DISC 1
CN700
DISK SKIP
R705
S703 DEDIT
R707
S704
R702
R701
E
S706 DISC 3
1-687-264S708
DISC 5
1-687-265-
11 (11)
38
38
S607 ALBUM +
11 (11)
11 (11)
HCD-XGV11AV 7-15. SCHEMATIC DIAGRAM – CD-L, CD-R SECTION –
MAIN BOARD (3/4) (Page 35) R606 68k
TC - B BOARD (Page 41)
CN607 2P S607
ALBUM –
R891 100
NO892 5P
PA BOARD (Page 47)
S606
J891 PHONES
C892 1000p
C891 1000p
ALBUM +
NO891
CN600 6P CN606 2P NO701
R605 33k R604 22k
S605
R603 15k
S604
R602 10k
S603
R601 6.8k
S602
R607 22 D600 SML79423C ORG/GREEN
R600 4.7k
S601
C893 JW
N0702
C700 10000p
S700
R608 22
S600
NO500 6P SCN
MAIN BOARD (1/4) (Page 33)
C501 1000p
R523 47k
R525 1k
J500
R521 47k
C502 1000p
R AUDIO L
R522 1k
C503 1 50V
R707 33k
R706 22k
R705 15k
R704 10k
R703 6.8k
R702 4.7k
R701 3.3k
C504 JW
CN700 2P
R700 2.2k
EPT500
S709
S708
S707
S706
S705
S704
S703
S702
S701
VIDEO
TC - A BOARD (Page 41)
39
39
C505 100p R524 75
GAME INPUT
HCD-XGV11AV 7-16. PRINTED WIRING BOARD – TC-A, TC-B SECTION – • See page 22 for Circuit Boards Location. 3
2
1
4
5
6
8
7
9
TUNER BOARD
S914
S901
S907
S910
TUNING MODE FM MODE
R915
D906
R912
D905
>M R911
S906
1
ENTER
h
X
1-687-257-
11 (11)
1
NO604
S902
S905
10
D901
R901
R914 D903
L
TUNING–
JW643
NO902
9
S909
JW904
9
S908
R919
1
PANL FL BOARD (Page 44)
NX901
R913
S913
R903
R904
R910
R916
JW905 JW901 JW900
R918
z REC
B
R917
R920
K
TUNING+
1
S911
S912
S915
JW902
6
S903 R905
h CD–R BOARD (Page 38)
S904 MEMORY
R906
D904
x
M>
CD SYNC
R909 R908 R907
TC–B BOARD
A
TUNER/BAND
1-687-254-
11 (11)
2 1
J
NO901
C
GAME BOARD S502
GAME
GAME MIXING
TC–A BOARD B
D502
R505
S501
R502
NX501
R508
S508
>M
CD–L BOARD (Page 38)
R507 R504
R501
S507
S504
1
7 D504
x
S503
6 1
R511
S505
NO504
DIRECTION
R506
M
R510
R509
1 NO603
PANEL FL BOARD (Page 44)
JW501
6
R503
NO501
D
E
S506
M>
D501 D503
1-687-255-
11 (11)
B 1-687-256-
11 (11) • Semiconductor Location Ref. No. D501 D502 D503 D504 D901 D903 D904 D905 D906
40
40
Location E-3 D-6 E-6 E-2 B-8 B-4 A-4 B-3 B-2
HCD-XGV11AV 7-17. SCHEMATIC DIAGRAM – TC-A, TC-B SECTION –
R901 68 D901 SEL5423E-TP15 GREEN
R501 68
D501 SEL5423E-TP15 GREEN
R904 3.3k
R903 2.2k
NX604 10P
S901
R906 6.8k
R905 4.7k S903
S902
R907 10k
S904
R908 15k S906
S905
R909 22k S907
R511 68 D504 SEL5423E-TP15 GREEN
PANEL FL BOARD (Page 45)
S502
R502 1k
NX603 7P
S501
NO901 9P
PANEL FL BOARD (Page 45) NO501 6P
NX901 9P
NX501 6P D903 SEL5423E-TP15 GREEN
R914 22
D905 SEL5923A-TP15 YELLOW
R913 100
R912 68
D904 SEL5423E-TP15 GREEN
R911 68 D906 SEL5223S-TP15 RED
NO902 6P
R504 22
R503 100 D502 SEL5423E-TP15 GREEN
R508 1.5k
R510 1.5k
D503 SEL5423E-TP15 GREEN
R507 1.5k
R506 1k
R920 3.3k
CD - R BOARD (Page 39) R505 680
S915
R509 1.5k
NO504 2P S508
S507
S506
S505
S504
R919 2.2k
S503
CD - L BOARD (Page 39)
41
41
R918 1.5k S914
R917 1.5k
R916 1k
S913
S912
R915 680 S911
R910 33k S910
S909
S908
HCD-XGV11AV 7-18. PRINTED WIRING BOARD – PANEL VR, KEY SECTION – • See page 22 for Circuit Boards Location. 4
5
6
8
7
D708 (VU8)
L701
JW723
JW715
R702
R711
JW701 R703 R704
JW713
JW714
JW716
R706
(VU5) D704
C701
D713 (VU13)
R720
(VU3)
S700 VOLUME
30
R709
IC701
D702
1
JW719 D714
2
3
(VU2) R708
C705
16
JW706
JW718
JW705
C706 C707 C708
R701
D703 JW704
(VU12)
R721
C703
JW703 R710
JW709 JW708 JW707
R719 JW720 JW721
C704
C702
D712
X–GROOVE
CN701
JW710
R707
D705
(VU4)
R718
S701
R705
JW725
(VU11)
JW702
(VU6) R712
D711 R717 R716
Ref. No.
R713 R715
(VU10)
B
• Semiconductor Location
D706
D710 CN702
PAMEL FL BOARD (Page 44)
(VU7)
JW712
(VU9)
10
D707
JW722 JW717
D709
C
9
N
PANEL VR BOARD R714
A
3
2
1
D701
(VU14)
1
15
(VU1)
1-687-252-
11 (11)
Location
D701 D702 D703 D704 D705 D706 D707 D708 D709 D710 D711 D712 D713 D714 D801 D802 D803 D804 D805 D806 D807 D808 D809 D810 D811 D812 D813 D814
C-7 C-7 C-7 B-7 B-7 A-7 A-7 A-4 B-3 B-3 B-3 C-3 C-3 C-3 F-4 E-4 F-5 E-5 F-6 E-6 F-7 E-7 F-8 E-7 E-10 E-9 E-10 F-10
IC701
C-8
D
F
DVD 5.1ch
SALSA
S816 R836
JW800
JW803
R832
R801
R802 R830
R828
R817
R833
R816
R831
R815
R829
R814 R803
SURROUND
D811
R818 R819
D809
D807
S814
D812
S813
S812
D805
D803
R826
D801 R804
R824
JW801
R805
S811
S810
S809
R820
JW809
D814
S817
R835
D810
D808
R837
REGGAE
D806
R813 R827
JW806
R808
R806 R809
S806 P.FILE
R810
R811
S800 ENTER
R825
JW805
S807 EFFECT
TANGO
D804
D802 JW804
E
MOVIE
CN801 JW802
R807
GAME
R834
KEY BOARD
D813
S815 S805
S804
S801
S802
S803
KARAOKE/MPX POP
DANCE
42
JAZZ
42
ROCK
SANBA
PRO LOGIC
11 (11)
1-687-253-
HCD-XGV11AV 7-19. SCHEMATIC DIAGRAM – PANEL VR, KEY SECTION –
PANEl FL BOARD (Page 45)
R806 3.3k
R809 10k
R808 6.8k
R807 4.7k
CN702 13P
P4
P3
P2
P1
DATA
CLK
R705 1k
P5
C708 10000p
P6
S700
STB
CN701 19P CN801 13P
R802 1k
R801 680
S804
S803
S802
S801
R810 15k
R805 2.2k
R804 1.5k
R803 1.5k
R811 22k
S807
S806
S805 S800
C706 0.1
DANCE
R706 1k
JAZZ P10
JW725 MT
R707 680 L701 10µ C703 1000p
P8
D706 SEL5223A-TP15 D704 SEL5223S-TP15
D702 SEL5223S-TP15
D710 SEL5223A-TP15
D708 SEL5223A-TP15
P7
P11
P11
P12
P12
P13
P13
S811
S810
S809
S817
S816
S815
S814
S813
S812
KARAOKE/MPX
D714 SEL5223A-TP15 D712 SEL5223A-TP15
D802 SEL5423E-TP15 GREEN
D804 SEL5423E-TP15 GREEN
D806 SEL5423E-TP15 GREEN
D810 SEL5423E-TP15 GREEN
D808 SEL5423E-TP15 GREEN
43
D812 SEL5223S-TP15 RED
R836 100
D814 SEL5923A-TP15
D813 SEL5923A-TP15
R837 100
R834 47
P12
P11
R832 47
R835 47
P13
R833 47
D811 SEL5223S-TP15 RED
D809 SEL5423E-TP15 GREEN
D807 SEL5423E-TP15 GREEN
JAZZ
D805 SEL5423E-TP15 GREEN
DANCE
D803 SEL5423E-TP15 GREEN
R831 47
R830 47
P7
P10
43
R829 47
R828 47
R826 47
R824 47
P20
P19
P18
P17
P16
P15
P14
IC701 NJU 3719L LED DRIVER
R827 47
P8
R720 68
R825 47
P9
R718 68
D801 SEL5423E-TP15 GREEN
R721 68
D713 SEL5223A-TP15
D711 SEL5223A-TP15
R719 68
R716 68
R714 68
R712 68
R710 68
R717 68
D709 SEL223A-TP15
R715 68
D707 SEL5223A-TP15
R713 68
D705 SEL5223A-TP15
R711 68
D703 SEL5223S-TP15
R709 68
D701 SEL5223S-TP15
R704 100
R702 100 R703 100 P20
P19
P18
P17
P16
P15
P14
P13
P12
R820 10k
R819 6.8k
R818 4.7k
R817 3.3k
R816 2.2k
KARAOKE/MPX
R708 68
P11
R815 1.5k
R814 1.5k
R813 1k
DATA
CLK
P9
P8
P1
P2
P3
P4
P5
P6
P7
P8
P9
P10
STB
C705 10000p
C702 1000p C701 1000p
R701 10k
C704 47 16V
P9
P7
S701
POP
P10
POP
C707 10000p
HCD-XGV11AV 7-20. PRINTED WIRING BOARD – PANEL FL SECTION – • See page 22 for Circuit Boards Location.
3
2
1
D
A
PANEL FL BOARD
4
5
6
8
7
9
10
11
12
13
14
MAIN BOARD (Page 37)
JW632
C606
IC602
C604
JW620
D602
R691
JW606
R692
ILLUMINATION
Q602
E Q603
E
R690 R688
R685 R683
CN601 JW609
R622 R623
E Q605
L604
R647
R689
R686
Q604
R684
R681
JW601 JW621
R600
JW625
JW624 JW623 JW622
C605
JW628
X601
S617
R621
S612
JW605
JW627 JW655 JW626
JW656 JW641 JW657
R696 R697
JW631
JW640 JW639 JW638 JW637 JW636
JW634 JW633
R695
D601
R619
Q601
R634
C601
FB601
L601
C603
JW619
R612 R613 R614 R615 R616 R617
R665 R601
R666
JW616
JW617
R604 R603 R602
JW629 C617
C618
R605 R607 R606
E
JW618
C607
R611 R610
JW645
R658
R659
R656
R618
C608
R638
C624
JW653
JW642
R608
R633 CN604
C620
C619
JW654
D
E
100
C625
R640
L603
S618 DISPLAY
R620
C614
JW658 R637
E Q609
1
80 81
JW608 JW607
L605
CLOCK SET C615
R657
R655 R639
S613
50 51
R609
JW635
JW651 CN602
R630 R629
18
01
10
E Q608
6 IC
IC603 S614 TIMER SELECT
FUNCTION
1
9
1
3 2
Q606
31 30
R631
C622
C
C623 Q607
JW615
JW644
R668
JW614
R667
R625
R624
R627
R626
R635
R628
C616
JW650 R632
JW613
R643
JW612
SLEEP
JW649
S616
JW610
S615
JW648
B
JW611
C602
FL601
L602
JW647
E
JW603 JW604
JW602 CN603
1-687-251E
L
N
TUNER BOARD (Page 40)
PANEL VR BOARD (Page 42)
11 (11)
M GAME BOARD (Page 40)
• Semiconductor
Location
44
44
Ref. No.
Location
D601 D602
D-5 C-13
IC601 IC602 IC603
C-8 B-11 C-5
Q601 Q602 Q603 Q604 Q605 Q606 Q607 Q608 Q609
B-13 D-11 D-11 D-12 D-12 B-10 B-9 C-9 C-10
HCD-XGV11AV 7-21. SCHEMATIC DIAGRAM – PANEL FL SECTION –
• See page 59 for IC Pin Function.
44
43
40
39
41
38
37
34
36
35
33
30
32
31
29
28
27
26
24
22
25
21
19
18
20
16
12
14
13
10
9
7
5
6
4
2
3
FL601
C623 1 50V R667 100k
R666 100k
R665 100k
Q606 DTC114TLTL2
3
4
R668 100k
2
5
6
9
7
12
10
13
14
16
18
19
21
20
22
24
25
28
26
27
30
29
R601 100k
Q606-609 GRID DRIVE
Q607 DTC114TLTL2 Q608 DTC114TLTL2
Q609 DTC114TLTL2
C622 1 50V
31 32
35
JW JW JW JW JW
36
R659 R658 R657 R656 R655
74
75
73
C625 10 50V
R640 100k
L603 47µ
R639 10k
37
72
34
71
70
33
38 39 40
C620 10000p 16V C619 10 16V
IC601
41
CN604
L602 JW
MB90M407APF-G-125-BND FLUORESCENT INDICATOR TUBE DRIVER,
43
KEY CONTROL
44
C606 4.7 50V
FB601 JW
C605 10000p
IC603 BA3830F
L601 JW
P1 P2 P3 P4
R602 10k 66
R619 22k
C608 0.1
D601 1SS133T-77
80 R697 100
77
R695 100
79 R696 100
78
76
75
R635 47k
C614 10 16V
C616 3300p 16V
R628 C615 10 33k 50
CN602 19P
R631 1k
R632 1.5k
77
60
61
R629 470 R630 680
IC602 NJL74H400A
R633 1.5k
CN603 7P
C601 1000p S613
64
R623 470
S614
S616
S615
C602 47 16V
R643 47
R622 680
CN601 19P
69 79
R688 47k Q605 2SB1116-TP-LK
R647 470
R683 47k Q603 2SB1116-TP-LK
78 76
R600 470
L604 JW
R690 1k
L605 JW
P2
R691 470
Q601 DTC124ESA-TP LED DRIVE
R685 1k
JW601 MT
P1
JW602 MT
P3 P4
45
R692 470 S618
R634 330
Q602-605 +B SWITCH
Q602 2SC2603TP-EF
Q604 2SC2603TP-EF
57
D602 SEL5223S-TP15 RED I/
R681 47k
R684 1k
R689 1k
56
68
R686 47k
R608 470
R637 220
80
55
R616 15k
R617 15k
R615 15k
R614 15k
R613 15k
C607 0.1
R612 15k
R607 10k
R609 10k
S612
52
67
74
73
71
72
69
68
70
67
66
65
64 61
60 57
56
52
65 R621 470
R618 100
R610 100
R611 100
R606 10k 55
R604 10k
R605 100
C617 0.1
X601 4MHz
R627 22k
C618 0.1
R625 330k
R620 1M
R638 680
C603 10000p
R626 47k
C604 47 16V
R624 330k
R603 10k
45
S617 I/ C624 47 16V
HCD-XGV11AV 7-22. PRINTED WIRING BOARD – POWER AMP SECTION – • See page 22 for Circuit Boards Location.
22
TH831
CN804
D409
JW469
R423
C409
E
CN803
E
C401
D406 R407
D405
C408
C416 JW404 JW403
C414
JW406
RY401
L404
R406
JW820
JW821
R409
D407 R408
R418 R419
JW467
R416 R417
R422
C406
D408
R450 JW471 R424
JW470 C407 R420 R421
L406
L403
Q402 R447 R401 R446
D402
C410 C411
C415
C412
C413
1-687-269G
+
-
CENTER SPEAKER (IMPEDANCE USE 8–16Ω)
-
+ L
-
+ R
SURROUND SPEAKER (IMPEDANCE USE 8–16Ω)
-
+ L
TM402
46
TM401
-
+ R
FRONT SPEAKER (IMPEDANCE USE 8–16Ω)
46
F
MAIN BOARD (Page 37)
01 WH0
JW410 J
C852 R852 R802 C802 C801 R801 JW819
E
F
1
Q401
IC801
C813
R429
R808 R898
R833
R803
C857R810
R857
C851
JW405
R807
C854 E Q842 R837 E R853 Q843 C804
13
R851
E
C807
R832
R843 R842
R835
R831
R838 Q834 C832
G
MAIN BOARD (Page 37)
1
Q831 E E Q832
C833
C803 R820
C862
13
JW827
1
JW440
R866
Q801
Location
C814
C831
C811
C861
D801
E
• Semiconductor
E Q833 D804
R860 JW514 JW513 R804
D852
JW476
JW472
R859
D851
JW450 Q803 E R817 Q851 Q804 E E R444 JW452 R815 JW451 JW474 R821 R814 JW493 JW458 C809 R403 R402 JW454 JW477 JW459 JW473 R432 JW489 JW455 JW460 D403 D404 JW456 R827 Q403 E JW461 R431 JW519 D803 R823 R806 R822 R425 R824 Q407 C815 E R858 R888 R828 D802 RY403 C810 JW475
R863 R813
D401
R812 C812
EPT801
R825
C853 JW414
JW816
R819 R816
R809 R834 R836
JW810
9
D410
1 CN805
D805
C847
JW448
C850
JW818
RY402
D
C830
R811
Q431
R442
CN904
JW815
R862
1E
C891
R861 C808
4
JW481
JW413
S
Q901 E
R443
SUB TRANS BOARD (Page 53)
R902
D903
R889
JW441
D905 D902
JW429
R805 JW807
D904
R439
R901
JW430 JW433 R839 JW432 JW434
C842
C892
JW700
11
CN806
C864
R840 R880 R818 Q805 JW426 E R868 JW424 Q855 R855 E C895
NO701
3
1
JW509
HEADPHONE BOARD (Page 38)
R867
D841
C841
C859
C858
JW427
R916
C906
D833
JW447 JW446 JW445 JW444 JW443
JW999
D843 D842
D834
3
C894
D831
JW701
I
D844
8
7
SUB AMP BOARD (Page 48)
C845
JW442
D906
JW479 JW480 JW478
C902 C909
R864
1
+
– JW483
B
C863
C844
JW485
C848
JW482
C903
D835
6
O
R
D836
C849
1
NO702
Q908 EPT802
C904
D853
TRANS BOARD (Page 53)
R865
R915 E
JW506
R905
JW505
IC901
R906 JW486
R903 R904 D912 R907
C905
E
5
TRANS BOARD (Page 53)
Q
Q903
C
4
PA BOARD
D911
A
3
2
1
11 (11)
Ref. No.
Location
D401 D402 D403 D404 D405 D406 D407 D408 D409 D410 D801 D802 D803 D804 D805 D831 D833 D834 D835 D836 D841 D842 D843 D844 D851 D852 D853 D902 D903 D904 D905 D911 D912
C-5 E-6 D-2 D-3 F-7 F-7 F-5 F-5 E-4 C-5 C-5 D-5 D-4 C-6 D-6 B-3 A-4 A-4 A-4 A-4 A-5 A-6 A-6 A-5 C-5 D-4 A-3 C-2 C-2 B-2 B-2 B-2 A-2
IC801 IC901
D-5 B-2
Q401 Q402 Q403 Q407 Q431 Q801 Q803 Q804 Q805 Q831 Q832 Q833 Q834 Q842 Q843 Q851 Q855 Q901 Q903 Q908
E-7 E-7 D-3 D-3 C-2 C-5 C-4 C-4 B-6 C-6 C-6 C-6 C-6 D-6 D-6 C-5 B-6 C-2 A-2 B-2
HCD-XGV11AV 7-23. SCHEMATIC DIAGRAM – POWER AMP SECTION –
D406 1SS133T-77
R868 220
IC801
STK412-150 POWER AMP
JW821
D405 1SS133T-77
R818 220
Q401,402 FRONT SPEAKER PROTECT RELAY DRIVE
TM401 +
R406 47k
RY401 24V
R407 47k
–
Q805 2SC2878AB MUTE Q855 2SC2878AB MUTE 1
3
R832 100k
EPT801
R853 470 C853 220p
C844 0.1 100V
R839 100k
C894 0.1 100V
C892 3300 110V
R889 100k
R842 330 R857 100 1/4W
R815 22k
C414 0.01 C410 0.1
L403 AIR COIL
C861 0.047 PE
C862 0.047 PE
Q851 2SC1841
L404 AIR COIL
RY403 24V
R419 4.7
R859 10 1/2W
C408 0.1 R423 10 1/2W
R418 4.7
R431 56k D404 1SS133T-77
–
SURROUND
+
(IMPEDANCE USE 8–16Ω) R
JW403 –
CENTER
+
R421 4.7
R432 47k
TM402 L
SPEAKER
C409 0.1
L405 AIR COIL
R420 4.7
–
SPEAKER (IMPEDANCE USE 8–16Ω)
R422 10 1/2W
R442 33k
C406 0.1
R443 27k
C407 0.1
R444 68k C830 10 50
JW404
JW489
R403 JW
Q833 DTA124ESA DELAY
C415 0.01
C411 0.1
+
D403 1SS133T-77 Q407 DTC124ESA
2
R863 100k
R424 10 1/2W
R417 4.7
R425 47k
R817 47k
C412 0.01
C416 0.01
R402 180 2W
R816 10k
C810 47 100V
C833 10 50
D831 D5SBA204101 C842 3300 100V
R450 47k
R819 68k
Q801 C811 2SC1841 0.047 PE R813 100k
R861 1k
C831 10 50
R833 22k
JW827
R408 82k
Q804 2SC1841
Q832 2SC2603
R860 47k
3
R851 1k
R831 100k
R843 100k
Q831 DTC124ESA R838 10k
RY402 24V
D802 RD18ESB1
C814 1000p
C854 22 50V R852 47k
C851 10 100V
R805 3.9k 1W
R821 33k
R862 15k
C852 470p
R806 3.9k 1W
C809 0.1 100V TF
C857 22 100
C813 0.01
2
C808 0.1 100V TF
D801 R812 1SS133T-77 15k
C804 22 50V
R809 10 1/2W C812 0.047 PE
D851 1SS133T-77
R803 470
Q403 DTA124ESA
C815 0.47 50V
Q803,804 STANDBY SWITCH
Q803 2SA988
C807 R807 100 22 100 1/4W
Q834 2SC1841 STANDBY SWITCH
R802 47k
R828 1M
R409 47k
C401 4.7 50
R416 4.7
Q801,851 OVER LOAD DETECT
C802 470p
NO702
R814 2.2k
D804 1SS133T-77
R810 47k
R858 0.1/5W
C803 220p
R447 47k
D409 1SS133T-77
R827 D803 1SS133T-77 100k
R811 1k
R888 0.1/5W
R804 33k
R808 0.1/5W
JW819
R898 0.1/5W
R801 1k
R837 D805 10k 1SS133T-77
1
Q402 2SC1841
R823 22k
D852 RD18ESB1
R824 1.2k C801 10 100V
C413 0.01
R446 10k
R880 56
D407 1SS133T-77
R822 22k R820 1
R
D402 1SS133T-77
R429 47k
R855 680 2W
JW467
R840 56
D408 1SS133T-77
C895 4.7 100V
–
R401 390 1W
Q401 DTA124ESA
FRONT SPEAKER (IMPEDANCE USE 6–16Ω)
+
JW820
C850 R825 4.7 100V 680 2W
L
R836 1k
R834 10k
Q431 2SC2603-EF PROTECT SWITCH
CN805 9P
R835 47k
TH831
D401 1SS133T-77 Q842 2SC2603
D400 JW
Q843 DTC124ESA
JW815
D410 1SS133T-77
Q831,832,842,843 TEMPERATURE DETECT SWITCH
JW807
JW701
JW810
JW816
C841 3300 50V
NO701
JW818
C891 3300 50V
C848 0.1
CN904
C909 0.1
R439 4.7k
R902 100k
R866 10k
R867 2.2k
D904 10EDB40-TA2B5
D905 10EDB40-TA2B5
D903 10EDB40-TA2B5
C903 100 16
C906 2200 25
C902 0.1
D902 10EDB40-TA2B5
1
C864 100 25V
R906 100
5
6
2
1
2
R905 10k
R907 100 D912 MTZJ-7-77-5.6
CN806 3P AMP CN804 13P BTB
CN803 13P BTB
47
47
C905 100 50
Q908 2SA1115TP-EF
D911 MTZJ-T-77-33A
3
R903 10k R915 22 Q903 2SB1375
C904 10 50 Q903,908 -35V REG
R904 1k
3
D842 10EDB40-TA2B5
IC901 µPC3504AHF +5V REG
C863 2.2 50V
2
EPT802
D841 10EDB40-TA2B5
R901 10k
6
R865 22k
3
C859 0.1
D844 10EDB40-TA2B5
5
1
C858 0.1
R864 D853 4.7k D843 1SS133T-77 10EDB40-TA2B5
C845 2200 25
6
C849 0.1
D834 10EDB40-TA2B5
3
D833 10EDB40-TA2B5
Q901 2SC2603 POWER ON/OFF RELAY DRIVE
D835 10EDB40-TA2B5
1
D836 10EDB40-TA2B5
2
C847 0.1
R916 470 2W
HCD-XGV11AV 7-24.PRINTED WIRING BOARD – SUB AMP SECTION – • See page 22 for Circuit Boards Location.
3
2
1
4
5
6
SUB AMP BOARD
A
JW131 JW101
R128
R163
R162
Q151 JW136 JW137
C188
C106
JW115
JW133 R159
JW120
C158
JW140
D151 JW125
JW118
JW111
C159
D191
R189
R107
C157
JW106
R193 R192
R109 JW134
C104
BCE
D101
JW122
C109
C107
R113
R157 C101
R112
JW121
JW110
JW139
E
C105
C108
R103
R138
Q101
1
Q181
R111
R110
C103
R160
R120 JW116
C154
R153 C153
JW105 R151
C151
CN102
C
C152
R168 R191
4
R101 C113 R102 C102
P
R152
PROLOGIC BOARD (Page 50)
R190
R188
B
R108
R161
JW138
C184
C181
1
IC101 R158
R183 C183 C182 R182 R181
18
JW119 CN101
C189
1
9
D
O
48
PA BOARD (Page 46)
48
1-687-262-
11 (11)
• Semiconductor
Location Ref. No.
Location
D101 D151 D191
B-5 C-3 C-3
IC101
A-4
Q101 Q151 Q181
B-4 B-4 C-2
HCD-XGV11AV 7-25. SCHEMATIC DIAGRAM – SUB AMP SECTION –
IC101
– 29.0
30.4
– 32.6
– 30.4
POWER AMP
R188 0.22 2W
R168 0.22 2W
R111 1k
R138 0.22 5W
R108 0.22 5W
R158 0.22 5W
R128 0.22 5W
C101 R101 1 1k 50
R130 10k
C103 220p
R109 10 1/2W
CN102 4P
R110 47k
R103 330
PROLOGIC BOARD (Page 51)
R161 1k 1/4W
C102 680p
C152 680p
R120 1 1/4W
R102 47k C104 47 50V
R152 47k
15.4 D101 1SS133T
R107 100 1/4W
C113 10000p
Q101 2SC1841
C157 100 50V
R153 270
C107 100 50V
C106 0.1 TF
D151 1SS133T
C105 0.1 TF
R163 100k
15.4
R162 15k
Q151 2SC1841
R191 1k
C159 0.068 PE C158 0.068 PE R159 10 1/2W
C183 220p
R181 1k
R182 47k
CN101 9P
C109 0.068 PE
R113 100k
R151 1k
C182 680p
Q101,181,501 OVER LOAD DETECT
PA BOARD (Page 47)
R160 47k
C181 1 50
C108 0.068 PE
JW115
C154 47 50V
C153 220p C151 1 50
R157 100 1/4W
R112 15k
R183 330 C184 47 50
R190 47k R192 15k
15.4 D191 1SS133T
49
49
Q181 2SC1841
R193 100k
R189 10 1/2W C188 0.068 PE C189 0.068 PE
HCD-XGV11AV 7-26.PRINTED WIRING BOARD – PROLOGIC SECTION – • See page 22 for Circuit Boards Location.
3
2
1
4
5
6
PROLOGIC BOARD C216
JW202
JW201
R201 FL201 C262
C219
R291 D201
R292
C234
C233
R206
R207
R293
C292
C291
JW200
JW208
C261
R212
JW206
C260
1
MAIN BOARD (Page 37)
CN203
C247
4
JW210
1
C250
C256
C257
C259
JW214 JW215
C241
JW216 C251
P
JW217 CN202
L201
R211
C240
JW212 C239
C253
C255 JW207
R217
C246
R216
C244 C243 C245
C238
R208
R205 R209
C258
JW218
64 65
C248 C249
C229
C235
D
R283 R273
R271
JW205
C242
C232
C203 C202
R210
C231
C
R272 E Q271
C237
U
R294
JW213
JW211
C225
C201
C224
C236
C252 C227
Q281 E
C205
C230
C228
R282
JW209
1 80
R204
C226
C206
C204
10
R281
C222
C223
C207
IC201 40 41
JW219
B
CN201
C208 C209
C221
JW204
C211
25 24
C220
Q291 E
C210
C214
C218
C212
C213
C215
A
R202
R203
C217
C264
1
• Semiconductor
Location 10
1-684-074-
T
SUB AMP BOARD (Page 48)
11 (11)
MAIN BOARD (Page 37)
E
50
50
Ref. No.
Location
D201
A-4
IC201
B-3
Q271 Q281 Q291
B-4 B-4 A-5
HCD-XGV11AV 7-27. SCHEMATIC DIAGRAM – PROLOGIC SECTION –
R205 47k C244 0.01
0.1
50V
50V
0.047
0.047
0.22
0.22
4.7
4.7
0.22
0.22 330k 0.68 0.047
5600p
C237
C236
C234
C233
C232
C231
C230
C229 R204 C228 C227
C226
C235 0.022 C240
680p
C245 0.01
0.022
R210 75k
C243
C239 0.1
C247 0.01
C248 0.01
C238 0.1
R207 75k
C241
R208 47k
680p
R209 150k
C242 0.1
C246
R206 150k
C225 1 50V
C250 6800p
R211 100k C253 220 16V
C249 47 16V
C251
4.7
R212
100k
50V
C224
1000p
C223
4700p
C222
0.1
C221
0.22
C220
0.22
C219
0.1
CN202 10P
C252 220 16
C255
10
50V
C256
10
50V
C257
10
50V
C218
1000p
C258
10
50V
C217
4700p
C259
10
50V
C260
10
50V
C216
1
C261
10
50V
CN201 10P
50V
IC201 M62464FP PRO-LOGIC SOUND CONTROL
77 79 C215 0.1
50V
50V
50V
50V
50V
50V
0.47
0.47
0.47
0.47
0.47
0.1
C208
C209
C210
C211
C212
C213
R281 2.2k R282 100k
100
100
470
R201
R202
R203
78
79
77
78
C262 10 50V
C214 0.1
C264 1000p
R291 2.2k R292 100k
D201 1SS355
R272 100k
0.47
0.1 C206
R271 2.2k
C207
0.1 C205
L201 100µH
50V
C202 10 50V
0.47
50V
R217 10k
C204
C201 10 50V
0.47
R216 10k
C203
FL201
C292 0.01
C291 0.01 Q291 2SC3623A MUTE
Q281 2SC3623A MUTE
R294 1k
R293 10k
R283 10k
Q271 2SC3623A MUTE
R273 10k
51
51
CN203 4P EH
HCD-XGV11AV 7-29. SCHEMATIC DIAGRAM – MIC SECTION –
7-28.PRINTED WIRING BOARD – MIC SECTION – • See page 22 for Circuit Boards Location. 1
3
2
4
5
6
7
MAIN BOARD (Page 37)
A
IC850(1/2) NJM14558L MIC AMP
E R850 1k
C837
C831
R874
C828
R859 R860
R862
R875
C825
C826
C834
5
C900
1-687-263-
D
R810 JW
FL801 FILTER CERAMIC
C822 1000 16V
R874 10k
11 (11)
R867 2.2k NO802
R855 10k Q884 2SC2785 V REF
R856 390k R876 1k
C837 10 50V
C820 0.22 50V
C824 2.2 50V
R878 1k C838 10 50V
C819 47p
R857 100 C817 2.2 50V
R879 1k
IC850(2/2) NJM14558L ECHO MIXING 6
C818 47p
C865 2.2 50V
7 5
8
R877 330
R858 22k
R811 100k
E
MIC VR BOARD C831 6800p
NO801
5
R859 22k
1
C829 0.47 50V
C830 0.47 50V
R860 22k C828 0.068
C827 1000p
C832 0.15
RV801 MIC LEVEL
F RV802 ECHO LEVEL
IC851 M65850P DIGITAL ECHO
R865 47k
R875 100
R861 120k
G D801 MTZJ-5.1B C823 47 16V
52
52
C826 47 16V
C833 1000p
R863 22k
11 (11)
R862 22k
C835 0.068
1-687-259-
MIC-1
LEVEL
C821 47 16V
R864
C835
R857
C865
C824
J802 C801 10000p
R807 10k
C900 0.1
1
JW818
R810
JW815
C802 R806
R850
J801 MIC–2
C819
R855
C804
R808
R854
CN812
R853 C817
R856
R809 1k
NO811
C878
C810
R806 10k
C803 1 50V
MIC
8
14
R861 C822
C
C805 1000p
R852 100k
R853 1k
LEVEL
IC851
D801
2
7
1
R863
C803
RV801 50k
MIC-2 4
C810 330p
ECHO
J801
1
R854 47k
CN812 5P
C802 47p
R808 1k
C830
NO811 JW812
C833
R878
R867 C818
IC850 8
1
C821
R876
C823
R807 R809
C805 R852 C806
JW816
JW817
C801
1
CLP804 C829
R879 4
RV802 50k
R858
FL801 R811
J802 MIC–1
R877
R866
MIC BOARD
C838
C832
C820
R865
B
C827
JW800 Q884
NO803
CN801 5P
NO802
E
C804 0.47 50V
C806 47p
3
C834 6800p
R864 22k
C878 1 50V
C825 22000p R866 15k
HCD-XGV11AV 7-30. SCHEMATIC DIAGRAM – POWER SUPPLY SECTION – • See page 22 for Circuit Boards Location. 3
2
1
7-31.SCHEMATIC DIAGRAM – POWER SUPPLY SECTION – 4
5
S901 VOLTAGE SELECTOR 230-240V t 220V t 120V
SUB TRANS BOARD
MT901
R953 0.1
JW950
A
T901 SUB TRANSFORMER
T951 POWER TRANSFORMER
1/2W
R951 0.33
CN952 EH
RY901
B
CN901
JW944
JW941
R952 0.33
D832 RBV1306
LP901 CN902 1
C834 0.1 100
4
CN905 VH-4P
F961 T8.0AL 250V
F963 T8.0AL 250V
F951 T8.0AL 250V
JW971
D901
LP903 4 NO903
1
S C
JW946 JW949
PA BOARD (Page 46)
11 (11)
1-687-271-
C963 10000p
CN951 VH-3P
AC IN F962 T8.0AL 250V
TRANS BOARD LP961
F964 T8.0AL 250V
C893 0.1 100 C961 10000p
1 CN905
4
CN902 VH-4P D901 1SS133T-77
NO903
T951 POWER TRANSFORMER
T901
SUB TRANSFORMER
CN901 2P AMP
E C961
C963
F961
JW980
F962
JW979 F964
JW977
C834
JW978
JW973
CN952
1
F963
+
JW984 JW975 JW985 JW983 JW982 11 JW981
R H
JW986
PA BOARD (Page 46)
– JW702 LP963
JW976 JW974
R952
R953
R951
C893
JW972 JW960
JW706
F
G
RY901 STB RELAY 9V
D832 CN951
1
1
1-687-270-
Q
11 (11) PA BOARD (Page 46)
53
53
JW941
D
JW971
F951
JW965
JW949 VOLTAGE SELECTOR
S901
HCD-XGV11AV 7-32. IC PIN FUNCTIONS • IC505 CXD1887R CD-DSP, DIGITAL SERVO, MPEG DECODER, DAC (VIDEO board) Pin No.
Pin Name
I/O
Pin No.
Description
Pin Name
I/O
Description
1
VB
O
Not used (Connected to ground with capacitor)
74
NVOEL
O
Out enable signal output to memory
2
IREF
O
Reference current output of DAC
75
LVS4
—
Ground
3
VRF
I
Reference voltage input of DAC
76
DRBS
O
Bank select address output to memory
4
VG
O
Not used (Connected to VDD with capacitor)
77
DRDQM0
O
Lower byte mask of memory
5
XCPSIG
O
Not used (Connected to ground)
78
DRDQM1
O
Upper byte mask of memory
6
CPSIG
O
Video composite/component (Y) signal output
79
IV55
—
Ground
7
NC
O
Video chroma (C) signal output (Not used )
80
NC
—
Not used (open)
8
NC
—
Connected to +2.5 V
81
SYSRST
9
V_AVS
—
Ground
82
IRDIN
10
IVD1
—
Power supply (+3.3V)
83
NC
I
System reset signal input
I
Not used (Connected to ground)
—
Not used (open)
11
I2C_CLK
I/O
Not used (open)
84
VDD1
—
Power supply (+2.5V)
12
I2C_DATA
I/O
Not used (open)
85
V16M
I/O
Not used (open)
13
GPIO0
I
Serial data input from M30620
86
DOUT
O
Digital audio data output (Not used)
14
GPIO1
O
Serial data output to M30620
87
L_CDLRCK
I
D/A interface, L/R clock input
15
GPIO2
I
Serial clock input from M30620
88
LRCK
O
D/A interface, L/R clock output
16
GPIO3
I
Data request signal input
89
VSS1
—
Ground
17
LVD1
—
Power supply (+2.5V)
90
L_CDDATA
I
Serial data input from D/A interface
18
GPIO4
O
Ok signal output to M30620
91
PCMD
O
Serial data output to D/A interface
19
GPIO5
I
Chip select signal input from M30620
92
L_CDBCK
I
Bit clock input (2’s COMP) from D/A interface
20
GPIO6
I
Not used (open)
93
BCK
O
Bit clock output (2’s COMP) to D/A interface
21
GPIO7
O
Not used (open)
94
EMPH
O
Not used (open)
22
LVS1
—
Ground
95
L_SQSO
I
SubQ 80bit and PCM peak level data input
23
GPIO8
O
Not used (open)
96
SQSO
O
SubQ 80bit and PCM peak level data output
24
GPIO9
O
Clock select signal output
97
VDD2
—
Power supply (+2.5V)
25
GPIO10
O
Not used (open)
98
L_SQCK
O
SQSO read out clock output
26
GPIO11
O
Latch signal output to PCM1748
99
SQCK
I
SQSO read out clock input
27
LVD2
—
Power supply (+2.5V)
100
SBSO
O
Not used (open)
28
GPIO12
O
Data load signal output to BU2507FV
101
EXCK
I
Not used (Connected to ground)
29
GPIO13
O
Serial data output to BU2507FV
102
DATA
I
Serial data input from CPU
30
GPIO14
O
Serial data clock output from BU2507FV
103
L_DATA
O
Serial data output to CPU
31
IVS1
—
Ground
104
VSS2
—
Ground
32
LVS2
—
Ground
105
L_CDXRST
I
33
IVD2
—
Power supply (+3.3V)
106
XRST
O
System reset signal output (L:reset)
DRADR0 to 3
O
Address output to memory
107
MUTE
I
Not used (Connected to ground)
LVD3
—
Power supply (+2.5V)
108
L_XLAT
O
Latch signal output to CPU
DRADR4 to 10
O
Address output to memory
109
XLAT
I
Latch signal input from CPU
46
LVS3
—
Ground
110
L_DCLK
O
Serial data clock output
47
IVS3
—
Ground
111
CLOK
I
Serial data clock input
48
IVD3
—
Power supply (+3.3V)
112
L_SENS
I
SENS signal input
DRDAT0 to 7
I/O
Data input/output to memory
113
SENS
O
SENS signal output
34 to 37 38 39 to 45
49 to 56
System reset signal input (L:reset)
57
IVS3
—
Ground
114
L_SCLK
O
SENS serial data read clock output
58
IVD4
—
Power supply (+3.3V)
115
SCLK
I
SENS serial data read clock input
GRDAT8 to 15
I/O
Data and input/output to memory
116
VDD3
—
Power supply (+2.5V)
IVS4
—
Ground
117
ATSK
I/O
Not used (Connected to ground)
59 to 66 67 68
DRCAS
O
CAS signal output to memory
118
XUGF
O
Not used (open)
69
LVD4
—
Power supply (+2.5V)
119
XPCK
O
Not used (open)
70
DRCK
O
Clock output to memory
120
L_GFS
I
GPS signal input
71
IVD5
—
Power supply (+3.3V)
121
GFS
O
GPS signal output
72
DRRAS
O
RAS signal output
122
VSS3
—
Ground
73
DRWEL
O
Write enable signal output to memory
54
54
HCD-XGV11AV
Pin No.
Pin Name
Description
I/O
123
L_CDC2PO
I
C2PO signal input
124
C2PO
O
C2PO signal output
125
L_SCOR
I
Sub code sink (S0 or S1) detect signal input
126
SCOR
O
Sub code sink (S0 or S1) detect signal output
127
COUT
I/O
Not used (open)
128
VDD4
—
Power supply (+2.5V)
129
MIRR
I/O
Not used (open)
130
DFCT
I/O
Not used (open)
131
L_FOK
I/O
Focus OK signal input/output
132
FOK
I/O
Focus OK signal input/output
133
MDP
O
Servo control signal output of spindle motor
134
VSS4
—
Ground
135
SSTOP
I
Inner position of optical pick-up signal input
136
FSTO
O
Not used (open)
137
SFDR
O
Sled motor control signal output
138
SRDR
O
Sled motor control signal output
139
VDD5
—
Power supply (+2.5V)
140
TFDR
O
Tracking coil control signal output
141
TRDR
O
Tracking coil control signal output
142
FFDR
O
Focus coil control signal output
143
FRDR
O
Focus coil control signal output
144
VSS5
—
Ground
145
WFCK
O
Not used (open)
146
WDCK
O
Not used (open)
147
ASYE
I
148
VDD6
—
149
XTAI
I
Crystal oscillator input (33.8688MHz)
150
XTAO
O
Crystal oscillator output (33.8688MHz)
151
VSS6
—
152
TES1
I
Not used (Connected to ground)
153
TEST
I
Not used (Connected to ground)
154
NC
155
NC
—
Not used (Connected to ground)
156
AVD0
—
Power supply (+2.5V)
157
IGEN
I
158
AVS0
—
Ground
159
ADIO
O
Not used (open)
160
RFDC
I
RF signal input
161
CE
I
center servo analog signal input
162
TE
I
Tracking error signal input
163
SE
I
Sled error signal input
164
FE
I
Focus error sigunal input
165
VC
I
Center voltage signal input
166
VPCO
O
EFM PLL charge pump output
167
VCTL
I
EFM PLL charge pump input
168
FILO
O
Master PLL filter output
169
FILI
I
Master PLL filter input
170
PCO
O
Master PLL change pump output
171
CLTV
I
VCO1 control signal input
—
Not used (Connected to +2.5V) Power supply (+2.5V)
Ground
Not used (open)
OP AMP current constant setting input
55
HCD-XGV11AV
Pin No.
56
Pin Name
Discription
I/O
172
AVS1
—
Ground
173
RFAC
I
EFM (RF) signal input
174
BIAS
I
Current source input
175
ASYI
I
Comparator voltage input
176
ASYO
O
EFM full swing signal output (L:VSS, H:VDD)
177
AVD1
—
Power supply (+2.5V)
178
VDD7
—
Power supply (+2.5V)
179
SOUT
O
Not used (open)
180
SOCK
O
Not used (open)
181
XOLT
O
Not used (open)
182
C4M
O
Not used (open)
183
LOCK
I/O
Not used (open)
184
VSS7
—
Ground
185
MD2
I
Not used (Connected to ground)
186
SCSY
I
Not used (Connected to ground)
187
PWMI
I
Not used (Connected to ground)
188
VDD8
—
Power supply (+2.5V)
189
XTSL
I
190
VSS8
—
X’tal frequency select input (L:16.9344MHz, H:33.8688MHz)
191
PVS2
—
192
LPFI
I
193
LPFO
I
194
PVD2
—
Power supply (+2.5V)
195
NC
—
Not used (open)
196
NC
—
Not used (open)
197
PVD1
—
Power supply (+2.5V)
198
PVS1
—
Ground
199
TRODE0
I
Not used (Connected to ground)
200
AUDDTI
I
Not used (Connected to ground)
201
AUDDTO0
O
Audio serial data output to PCM1748
202
AUDDTO1
O
Digital audio data output (Not used)
203
AUDBCK
O
Audio serial data bit clock output to PCM1748
204
AUDLRCK
O
Audio serial data L/R clock output to PCM1748
205
AUDXCLKO
O
Audio serial clock output to PCM1748
206
CLKA
I
Crystal oscillator input (27MHz)
207
CLKB
O
Crystal oscillator output (27MHz)
208
VDD9
—
Power supply (+2.5V)
209
THRCLK
I
Not used (open)
210
TESTEN
I
Not used (Connected to ground)
Ground Ground PLL2 filter terminal PLL2 filter terminal
211
TCLK
I
Not used (Connected to ground)
212
TMODE1
I
Not used (Connected to ground) Not used (open)
213
TRST
I
214
VSS9
—
215
NC
—
Ground
216
V_AVD
—
Power supply (+2.5V)
Ground
HCD-XGV11AV
• IC501 M30620MCN-A21FP SYSTEM CONTOL (MAIN Board) Pin No.
Pin Name
Description
I/O
1
AUDIO-OUT
O
MD output mute signal output
2
STEREO
I
Stereo signal input
3
TUNED
I
Tuned signal input
4
SIRCS
I
SIRCS input
5
CD-MUTE
O
CD mute signal output
6
PARTY-DATA
—
Not used (open)
7
PARTY-CLK
—
Not used (open)
8
BYTE
I
Not used (connected to ground)
9
CNVSS
—
10
XC-IN
I
Sub clock input
Not used (Connected to ground with resistor)
11
XC-OUT
O
Sub clock output
12
RESET
I
System reset input
13
X-OUT
O
Main system clock output (16MHz)
14
VSS
—
Ground
15
X-IN
I
16
VCC
—
17
NMI
I
Not used (Pull up with resistor)
18
V-SELA
I
Video input select signal output.
19
SCOR
O
Chip select signal output to CXD1887R
20
AC-CUT
I
AC cut check signal input
21
ST-MUTE
O
Tuner mute signal output
22
ST-CE
O
Tuner chip enable signal output
23
ST-DOUT
O
Tuner data output
24
BU-PWM3
O
BU PWM 3 (for CD-RW) signal output
25
ST-DIN
I
Tuner data input
26
BU-PWM2
O
BU PWM 2 (for CD-RW) signal output
27
ST-CLK
O
Tuner clock signal output
28
BU-PWM1
O
BU PWM 1 (for CD-RW) signal output
29
IIC-CLK
I
IIC serial data clock input
30
IIC-DATA
I
IIC serial data input
31
–
32
SQ-DATA
I
OK signal input from CXD1887R
33
SQ-CLK
O
Video mute signal output to BD7600FV
34
SENS
I
Not used (open)
35
CD-DATA
O
Serial data output to CXD1887R
36
XLT
I
Serial data input from CXD1887R
37
CD-CLK
O
Serial clock output to CXD1887R
38
CD-POWER
O
CD power on/off signal output
39
CLK-OUT
O
Not used (open)
40
LD-ON
O
Laser diode control signal output
41
OTM-RESET
O
Other micom reset
42
PARTY-TEMPO
—
Not used (open)
43
XRST
O
Reset signal output to AN41020A
44
MTR-CTRL1
O
CD motor control 1 output
45
MTR-CTRL2
O
CD motor control 2 output
46
REC-A
I
Record tab switch for SIDE-A signal input
47
LED-DISC
O
DISC LED on/off signal output
48
BU UP/DW SW
I
BU up switch signal input
49
TBL-SENS
I
Table sensor signal input
50
REC-B
I
Record tab switch for SIDE-B signal input
—
Main system clock input (16MHz) Power supply (+3.3V)
(Not used) (Not used) (Not used)
Not used (open)
57
HCD-XGV11AV
Pin No.
58
Pin Name
Discription
I/O
51
A-TRG
O
TCM-A trigger output
52
B-TRG
O
TCM-B Trigger output
53
AMS-IN
I
AMS signal input
54
ML-BUSY2
O
Not used (Connected to ground)
55
CAPM-CTRL
O
Capstan motor REV/FWD/STOP control signal output
56
A-PLAY SW
I
TCM-A play switch input
57
B-PLAY SW
I
TCM-B play switch input
58
TC-MUTE
O
TC line mute signal output
59
ML-WR
O
Not used
60
ML-RESET
O
Not used
61
REC-MUTE
O
REC mute signal output
62
VCC
—
Power supply (+3.3V)
63
SOFT-TEST
O
Not used (open)
64
VSS
—
Ground
65
BIAS
O
Bias on/off signal output
66
ML-MUTE
O
Not used
67
PB-A/B
O
TC A/B select signal output
68
ALC
O
ALC signal output
69
TC-RELAY
O
TC relay control signal output
70
A-HALF
I
A deck half detection signal input
71
AU-SEL0
O
Audio input select A signal output
72
AU-SEL1
O
Audio input select B signal output
73
KEY-DISPLAY
I
DISPLAY key signal input
74
KEY-POWER
I
POWER key signal input
75
LED-STBY
O
Standby LED driver signal output
76
VIDEO-MUTE
O
Video input select signal output
77
PL-LAT
O
Prologic sound control LAT signal
78
PL-DAT
O
Prologic sound control data
79
PL-CLK
O
Prologic sound control clock
80
EQIC-DAT
O
Serial data output to Audio EQIC (M61529 )
81
EQIC-CLK
O
Serial data clock output to Audio EQIC (M61529 )
82
LINE-MUTE
O
TA LINE mute signal output
83
STK-MUTE
O
Mute signal output to power IC
84
STBY-RELAY
O
Standby relay driver signal output
85
REAR-RELAY
O
Rear speaker relay driver signal output
86
HP-MUTE
O
Headphone mute signal output
87
FRONT-RELAY
O
Front speaker relay driver signal output and woofer mute signal
88
PROTECT
I
Speaker protection signal input
89
A-SHUT
I
TCM-A reel pulse input
90
B-SHUT
I
TCM-B reel pulse input
91
B-HALF
I
B deck half detection input
92
MODEL-IN
I
Model input
93
DEST-IN
I
Destination input
94
MIC-IN
O
Not used
95
HP-IN
I
Headphone detect input
96
AVSS
—
97
TEMP OUT
98
VREF
I
99
AVCC
—
100
V-SELB
I
I
Ground Temperature detect signal input Reference voltage input Power supply (+3.3V) Video input select signal output
HCD-XGV11AV
• IC601 MB90M407APF-G-125-BND DISPLAY CONTROL (PANEL FL Board) Pin Name
Pin No.
1 to 10
Description
I/O
GR-16 to GR-7
O
FLD grid output
VSS-IO
—
Ground
12 to 17
GR-6 to GR-1
O
FLD grid output
18 to 22
SEG-1 to SEG-5
O
FLD segment output
VDD-FIP
—
Power supply (+3.3V)
SEG-6 to SEG-23
O
FLD segment output
VSS-IO
—
Ground
SEG-24, SEG-25
O
FLD segment output
11
23 24 to 41 42 43,44 45 to 47
NO USE
O
Not used (open)
48
VKK
—
Power supply (-35V)
49
MD0
I
Not used (pull up with resistor)
50
MD1/VDD-VFT
I
Not used (pull up with resistor)
51
MD2
I
Not used (pull down with resistor)
52
D-SW
I
CD lid open/close detect signal input
53
NO USE
O
Not used (open)
54
SOFT TEST
O
Not used (open)
55
LED SELB
O
LED group B select signal output
56
VOL A
I
Volume encoder signal A input
57
VOL B
I
Volume encoder signal B input
58
NO USE
I
Not used (open)
59
NO USE
I
Not used (open)
60
I2C-DATA
O
IIC serial data output
61
I2C-CLOCK
O
IIC clock signal output
62
AVCC
—
Power supply (+3.3V)
63
AVSS
—
Ground
64 to 69
KEY0 to KEY5
I
Key input (A/D port)
70
BPF1-F02
I
Spectrum analyzer BPF signal input
71
BPF2-F03
I
Spectrum analyzer BPF signal input
72
BPF3-F04
I
Spectrum analyzer BPF signal input
73
BPF4-F05
I
Spectrum analyzer BPF signal input
74
BPF5-F06
I
Spectrum analyzer BPF signal input
75
ALL BAND
I
L+R signal input
76
LED-SCK
O
Serial clock output to LED driver
77
RESET
I
Reset input
78
LED-DAT
O
Serial data output to LED driver
79
LED-LATCH
O
Latch signal output to LED driver
80
LED-SELA
O
LED group A select signal output
81
VSS-CPU
—
Ground
82
XOUT
O
Crystal oscillator output (4MHz)
83
XIN
I
Crystal oscillator input (4MHz)
84
VCC-CPU
—
Power supply (+3.3V)
85 to 100 NO USED
O
Not used (open)
59
HCD-XGV11AV
7-33. IC BLOCK DIAGRAMS IC103
CXA2581N-T4 (BD BOARD)
30 DC_OFST RW/ROM APC
LD 1
29 RFDCI PD 2
DVCC VC
28 RFDCO
DVC VCC VC
27 VC EQ_IN 3
AC_SUM 4
AC SUM
EQ
26 RFC 25 VFC 24 BST
AC VCA
23 RFG
EQ ON/OFF
GND 5
VCC VOFST
22 VCC
RW/ROM B C
A 6 B 7
A
C 8
D
VCC
20 CE VC VC
VOFST
D 9
VC
RW/ROM
RW/ROM
F 10
21 CEI
19 TE_BAL DVCC RW/ROM
gm
18 TE E 11 SW 12
gm APC-OFF(Hi-Z) RW/ROM (H/L)
DVCC 13
RW/ROM AVC
DVC VOFST
DVC
17 FEI DVCC
VC DVC 14 RFAC 15
60
DVC
DVC
16 FE
HCD-XGV11AV
AN41020A (BD BOARD)
PVCC/2
RESET CIRCUIT
DIRECTION DET
IC102
VO3+ VO3PGND2
VO2VO2+ PGND1 PGND1 PVCC/2
PGND2 DIRECTION DET
VO4+ NC NC STBY NC
VO1NC NC PVCC/2(NC) NC VO1+
VO4-
NC DIRECTION DET
NC PVCC2 PVCC2 NC(BC4) NC
PVCC1 PVCC1 NC(BC2) NC NC(BC1)
NC(BC3)
NC(VPUMP1)
DIRECTION DET
NC(VPUMP2) NC(CT) NC(SW) NC(FB)
NC(VDD) OP+ OP-
NC
OP.O
VREF
IN1+
IN4
IN1OPO1(NC)
IN4R OPO3(NC)
IN2+
IN3-
IN2-
IN3+
OPO2(NC) SGND
SVCC
IC201 TA8409S (MOTOR BOARD)
VREF BLOCK
STANDBY BLOCK
HEAT CUT OFF BLOCK 1 IN2
2 VCC
3 OUT2
4 NC
5 GND
6 VS
7 OUT1
8 VREF
9 IN1
61
HCD-XGV11AV
IC191 BA7615N (MAIN BOARD (1/4))
VCC
CLOCK
REF
OP2IN
OP2OUT
LPF2IN
LPF2OUT
IC851 M65850P (MIC/GUITAR BOARD)
14
13
12
11
10
9
8
MUTE 75Ω
6db LOGIC
OSCILLATOR
D/A
LPF2
1/2 VCC DO1
CLOCK 10
9
MAIN RESET CONTROL D1 DO0
VOUT
8 IN4
VCC
7
GND
6
5 C
4
IN3
B
3
IN2
2 A
IN1
1
AUTO RESET
MO
20KBIT SRAM
MI
A/D
IC504
2
3
4
5
6
7
OP1OUT
OP1IN
CC1
CC2
GND
LPF1IN
1
LPF1OUT
LPF1
PCM1748E/2K (VIDEO BOARD)
System Clock BCK 1 DATA 2 LRCK 3
Serial Input I/F
DGND 4 VDD 5 VCC 6
System Clock Manager
16 MCLK
Function Control I/F
15 LAT 14 CLK 13 DATA
Zero Detect
12 DZFL 11 DZFR
8x Oversampling Digital Filter with Function Controller
Power Supply
Enhanced Multi-Level Deita-Sigma Modurator
DAC
Output Amp and Low-Pass Filter
LOUT 7
DAC
Output Amp and Low-Pass Filter 10 VCOM
ROUT 8
9 AGND
IC603 BA3830F (PANEL FL BOARD)
R02
1
REFERENCE CURRENT
R01
2
REFERENCE CURRENT
LINE NF
3
LINE IN
4
– +
RESET
BAND PASS FILTER DET
REC NF
5
REC IN
6
RESET C BIAS C GND
7 8 9
– +
18 RESET
17 16 15 14 13 12
F01 F02 F03 F04 F05 F06
11 REC LEVEL 10 VCC
62
HCD-XGV11AV
SECTION 8 EXPLODED VIEWS NOTE: • -XX, -X mean standardized parts, so they may have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied.
•
Hardware (# mark) list and accessories are given in the last of this parts list.
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
8-1. CASE, BACK PANEL SECTION not supplied
3 #3
4
#1 #2 #1 #1 #1
5 #1 #1
#1
2
not supplied
#1 #1
a #1
2
not supplied
M901
a Chassis section #1
Front panel section #1
1
Ref. No. 1 2 3 4 5
Part No.
Description
4-948-236-01 3-363-099-01 4-237-661-11 1-693-603-41 1-769-945-11
CUSHION (107) SCREW (CASE 3 TP2) CASE TUNER (FM/AM) WIRE (FLAT TYPE) (11 CORE)
Remarks
Ref. No. M901 #1 #2 #3
Part No.
Description
1-763-072-11 7-685-646-79 7-685-872-09 7-685-871-01
FAN, DC SCREW +BVTP 3X8 TYPE2 N-S SCREW +BVTT 3X8 (S) SCREW +BVTT 3X6 (S)
Remarks
63
HCD-XGV11AV
8-2. FRONT PANEL SECTION-1 51 63 51
51
51
not supplied
51
62
not supplied
66 not supplied
51
64
65
61
51
59
FL601
51
67
64
51
51
51
60
56
not supplied
not supplied
57
55
51 51
68
not supplied not supplied
51 71 72 54
51
53 52 51 51
Ref. No.
not supplied
not supplied
51
69
51
Part No.
Description
51 52 53 54 55
4-951-620-01 1-687-266-11 1-687-265-11 4-227-899-01 X-4955-802-A
SCREW (2.6X8), +BVTP CD-R BOARD CD-L BOARD SCREW (DIA. 12), FROATING SUB PANEL CD ASSY
56 57 59 60 61
4-040-472-01 4-224-104-01 4-244-859-01 4-237-635-03 1-687-256-11
LATCH, D.C. DAMPER SPRING CD LID KNOB (MIC) TC-A BOARD
62
1-687-255-11 GAME BOARD
64
70
Remarks
Ref. No.
Part No.
Description
Remarks
63 64 65 66
A-4732-065-A 4-949-935-41 4-225-511-01 A-4732-037-A
MIC BOARD, COMPLETE CUSHION (FL) HOLDER FL TUBE PANEL FL BOARD, COMPLETE
67 68 69 70 71
1-773-114-11 A-4732-036-A 1-687-264-11 X-4955-344-1 1-687-267-11
WIRE (FLAT TYPE) (19 CORE) (150mm) TUNER/TC-B BOARD, COMPLETE FRONT INPUT BOARD BUMPER ASSY DOOR SW BOARD
72 FL601
1-687-268-11 ALBUM BOARD 1-518-794-11 INDICATOR TUBE, FLUORESCENT
HCD-XGV11AV 8-3. FRONT PANEL SECTION-2 111 106 112 110 not supplied
118
106
109
118
119 117 115
106
114
121 not supplied
108
116 113 106
128
120
106 122 123
121 106
124 not supplied
107 106
106
127
not supplied
supplied with S700
126
103 105
131
104 102
130 129
132 101 125
106
Ref. No.
Part No.
Description
Remarks
101 102 103 104 105
X-4955-192-1 4-243-981-01 4-248-245-01 4-243-975-01 4-244-858-01
LID (TC) ASSY BUTTON (EJECT B) SPRING (TC-EJECT), COMPRESSION BUTTON (EJECT A) KNOB VOLUME
106 107 108 109 110
4-951-620-01 A-4732-084-A X-4955-335-1 X-4955-457-1 A-4732-062-A
SCREW (2.6X8), +BVTP KEY BOARD, COMPLETE OPERATION PANEL ASSY WINDOW (FL) ASSY PANEL VR BOARD, COMPLETE (including MIC VR BOARD)
111 112 113 114 115
1-773-108-11 1-769-977-11 4-226-883-01 4-226-880-01 4-226-882-01
WIRE (FLAT TYPE) (19 CORE) (100mm) WIRE (FLAT TYPE) (13 CORE) (150mm) COVER (EJECT) LEVER (EJECT-A) LEVER (EJECT-C)
116
4-226-881-01 LEVER (EJECT-B)
Ref. No.
Part No.
Description
117 118 119 120
4-226-889-01 4-959-229-11 4-243-969-01 4-243-970-01
SPRING (LEVER), TENSION COIL DETENT, CASSETTE HOLDER (TC L) HOLDER (TC R)
121 122 123 124 125
4-224-104-01 4-243-971-02 4-243-977-02 4-227-899-01 X-4955-330-1
DAMPER SPRING (TC L), TORSION SPRING (TC R), TORSION SCREW (DIA. 12), FROATING FRONT PANEL ASSY
126 127 128 129 130
1-769-986-11 1-796-487-31 4-244-861-01 4-243-608-01 4-243-609-01
WIRE (FLAT TYPE) (13 CORE) (270mm) DECK, MECHANICAL (CWM43RR23) CURSOR BELT (BR) BELT (AF)
131 132
4-243-610-01 BELT (AL) 4-248-244-01 SPRING (TC LID)
Remarks
65
HCD-XGV11AV
8-4. CHASSIS SECTION not supplied #2
154
not supplied
#5
#5
158 #1 F951
157 #1
#2
T951
not supplied F961
#1
#4
156
F962 #1
F963
162
155
F964
153 159 #4
160
b
b #1
not supplied #1 #1
#1
#1
CDM37B-30BD62
161
not supplied
163
not supplied
151
not supplied
Ref. No.
Part No.
Description
151 153 154 * 155 0 156
1-925-122-81 A-4732-086-A 1-687-270-11 3-703-244-00 1-777-071-53
WIRE (FLAT TYPE) (28 CORE) PA BOARD, COMPLETE TRANS BOARD BUSHING (2104), CORD CORD, POWER
157 158 * 159 160 161
A-4732-075-A 1-687-271-11 4-988-533-01 A-4732-088-A X-494-122-81
SUB AMP BOARD, COMPLETE SUB TRANS BOARD HOLDER, PWB MAIN BOARD, COMPLETE FOOT (F22125H-M)
162 163
66
A-4732-081-A PROLOGIC BOARD, COMPLETE A-4747-196-A VIDEO BOARD, COMPLETE
Remarks
Ref. No. 164
#1
#1
Part No.
164
#1
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Description
0F951 0 F961 0 F962 0 F963 0 F964
1-532-506-31 1-533-949-31 1-533-949-31 1-532-506-31 1-532-506-31
0 T951
1-439-875-11 TRANSFORMER, POWER
#1 #2 #4 #5
Remarks
1-925-122-71 WIRE (FLAT TYPE) (19 CORE)
7-685-646-79 7-685-872-09 7-685-650-79 7-685-881-09
FUSE (T6.3A/250V) FUSE, CYLINDRICAL (TIME LUG) (T8.0A/250V) FUSE, CYLINDRICAL (TIME LUG) (T8.0A/250V) FUSE (T6.3A/250V) FUSE (T6.3A/250V)
SCREW +BVTP 3X8 TYPE2 N-S SCREW +BVTT 3X8 (S) SCREW +BVTP 3X16 TYPE2 IT-3 SCREW +BVTT 4X8 (S)
HCD-XGV11AV
8-5. CD MECHANISM DECK SECTION (CDM37B-30BD62) 501 501 509 505 #1
504
507 511 506
510 501
517 502 508 510
503
510 512 M201
502
518
520 518
519 520 516
519
BU-30BD62
520
514
513
#1
520 522
521
521
524
515 #1
#1
#1
523
Ref. No. 501 502 503 504 505
Part No. 4-987-976-01 4-944-490-01 A-4660-978-A 4-978-421-01 4-978-425-01
Description SCREW, STEP BELT (TIMING) GEAR (PULLEY) ASSY GEAR (MID) ROLLER (CAM)
506 507 508 509 510
4-978-420-01 4-237-981-02 X-4953-307-1 4-238-261-03 X-4947-960-1
CAM (HOLDER) PULLEY (B) (30), CHUCKING PULLEY (A) ASSY, CHUCKING TABLE, DISK ROLLER ASSY
* 511
4-978-583-01 4-238-260-02 A-4673-765-A 4-978-426-01
BRACKET (BU) CHASSIS MOTOR BOARD, COMPLETE INDICATOR (NO.)
512 * 513 514
Remarks
Ref. No. * 515
Part No. Description 1-659-059-13 LED BOARD
* 516 517 518 519 520
1-659-058-13 4-228-414-01 4-951-620-01 4-231-151-01 4-231-451-11
SENSOR BOARD BRACKET (YOKE) SCREW (2.6X8), +BVTP STOPPER (BU) INSULATOR (BU-30)
521 522 523 524
4-227-045-11 4-227-899-01 4-998-716-01 X-4954-451-1
SPRING (INSULATOR), COIL SCREW (DIA. 12), FROATING SCREW, BU FITTING HOLDER (BU30) ASSY
M201 #1
A-4660-977-A MOTOR ASSY 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
Remarks
67
HCD-XGV11AV
8-6. BASE UNIT SECTION (BU-30BD62) 551
554
555
553
552
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Ref. No.
Part No.
0 551 552 553
A-4735-189-A OP ASSY (A-MAX.3) A-4728-371-A BD BOARD, COMPLETE 4-233-832-01 GEAR (LB)
68
Description
Remarks
Ref. No. 554 555
Part No.
Description
4-233-831-01 GEAR (LA) 1-782-817-11 WIRE (FLAT TYPE) (16 CORE)
Remarks
NOTE: Ref. No. Part No. Description • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • CAPACITORS: uF: µF • RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable Ref. No.
HCD-XGV11AV
SECTION 9 ELECTRICAL PARTS LIST • •
Remarks Ref. No. COILS uH: µH SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD...
Part No.
ALBUM Description
BD Remarks
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board name.
Part No. Description 1-687-268-11 ALBUM BOARD
Remarks
Ref. No.
Part No.
Description < DIODE >
Remarks
*********** D101
8-719-988-61 DIODE 1SS355TE-17
< RESISTOR > < IC > R606
1-249-439-11 CARBON
68K
5%
1/4W IC102 IC103
< SWITCH > S606 S607
8-759-713-70 IC AN41020A 8-752-089-74 IC CXA2581N-T4
1-762-875-21 SWITCH, KEYBOARD (ALBUM +) 1-762-875-21 SWITCH, KEYBOARD (ALBUM -)
< TRANSISTOR >
******************************************************
Q101 Q102
8-729-049-31 TRANSISTOR 2SB710A-RTX 8-729-424-08 TRANSISTOR UN2111-TX
A-4728-371-A BD BOARD, COMPLETE
*****************
< RESISTOR >
< CAPACITOR > C101 C102 C103 C104 C107
1-164-315-11 1-107-826-11 1-164-315-11 1-162-967-11 1-162-921-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
470PF 0.1uF 470PF 0.0033uF 33PF
C108 C109 C110 C111 C112
1-164-360-11 1-164-360-11 1-107-826-11 1-126-607-11 1-126-607-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP
0.1uF 0.1uF 0.1uF 47uF 47uF
C113 C114 C115 C117 C118
1-126-209-11 1-162-964-11 1-126-205-11 1-164-360-11 1-115-156-11
ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP
100uF 0.001uF 47uF 0.1uF 1uF
C119 C120 C151 C153 C163
1-115-156-11 1-126-607-11 1-164-227-11 1-164-360-11 1-128-995-21
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP
1uF 47uF 0.022uF 0.1uF 100uF
C164 C165 C166 C182 C213
1-164-360-11 1-124-779-00 1-164-360-11 1-128-995-21 1-216-864-11
CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP METAL CHIP
0.1uF 10uF 0.1uF 100uF 0
5% 10% 5% 10% 5%
50V 16V 50V 50V 50V
10% 20% 20%
16V 16V 16V 4V 4V
20% 10% 20%
20% 10% 20%
20% 20% 5%
< CONNECTOR >
4V 50V 6.3V 16V 10V 10V 4V 25V 16V 10V 16V 16V 16V 10V 1/10W
R102 R103 R104 R105 R109
1-216-835-11 1-216-845-11 1-216-835-11 1-216-821-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
15K 100K 15K 1K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R111 R112 R113 R114 R117
1-216-846-11 1-216-864-11 1-216-826-11 1-216-841-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
120K 0 2.7K 47K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R118 R120 R122 R123 R124
1-216-864-11 1-216-846-11 1-216-845-11 1-216-797-11 1-216-797-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 120K 100K 10 10
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R125 R126 R151 R152 R176
1-216-839-11 1-216-839-11 1-216-845-11 1-216-829-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
33K 33K 100K 4.7K 0
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R179 R227 R228 R229 R231
1-216-833-11 1-216-845-11 1-216-853-11 1-216-825-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 100K 470K 2.2K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R234 R235 R236
1-216-864-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-821-11 METAL CHIP
0 1K 1K
5% 5% 5%
1/10W 1/10W 1/10W
****************************************************** CN101 CN102
1-784-877-21 CONNECTOR,FFC(LIF(NON-ZIF))28P 1-794-424-11 CONNECTOR, FCC/FPC 16P
69
HCD-XGV11AV CD-L Ref. No.
CD-R
DOOR SW
FRONT INPUT
GAME
Remarks
Part No.
Part No. Description 1-687-265-11 CD-L BOARD
Ref. No.
HEADPHONE
KEY
Description < SWITCH >
Remarks
********** S700
* CN700
1-570-953-11 SWITCH, PUSH (1 KEY) (DOOR SW)
******************************************************
< CONNECTOR > 1-564-718-11 PIN, CONNECTOR (SMALL TYPE) 2P
1-687-264-11 FRONT INPUT BOARD
**************** < RESISTOR > < CAPACITOR > R700 R701 R702 R703 R704
1-249-421-11 1-247-843-11 1-249-425-11 1-249-427-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
2.2K 3.3K 4.7K 6.8K 10K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W F 1/4W
R705 R706 R707
1-249-431-11 CARBON 1-249-433-11 CARBON 1-249-435-11 CARBON
15K 22K 33K
5% 5% 5%
1/4W 1/4W 1/4W
C501 C502 C503 C505
1-162-294-31 1-162-294-31 1-115-871-11 1-162-282-31
CERAMIC CERAMIC ELECT CERAMIC
0.001uF 0.001uF 1uF 100PF
10% 10% 20% 10%
50V 50V 50V 50V
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W F
< JACK > J500
1-815-310-11 JACK 3P (GAME INPUT)
< SWITCH >
< RESISTOR >
S701 S702 S703 S704 S705
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (REPEAT) SWITCH, KEYBOARD (PLAY MODE) SWITCH, KEYBOARD (EDIT) SWITCH, KEYBOARD (DISC1) SWITCH, KEYBOARD (DISC2)
S706 S707 S708 S709
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (DISC3) SWITCH, KEYBOARD (DISC4) SWITCH, KEYBOARD (DISC5) SWITCH, KEYBOARD (DISC SKIP)
R521 R522 R523 R524 R525
1-249-437-11 1-249-417-11 1-249-437-11 1-247-804-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
47K 1K 47K 75 1K
****************************************************** 1-687-255-11 GAME BOARD
**********
****************************************************** 1-687-266-11 CD-R BOARD
< DIODE > D501 D504
********** < CONNECTOR > CN600
< RESISTOR >
1-785-332-11 PIN, CONNECTOR (LIGHT ANGLE)6P
R501 R502 R511
< DIODE > D600
8-719-058-03 DIODE SEL5423E-TP15 (GAME MIXING) 8-719-058-03 DIODE SEL5423E-TP15 (GAME)
8-719-056-13 DIODE SML79423C-TP15 (u)
1-249-403-11 CARBON 1-249-417-11 CARBON 1-249-403-11 CARBON
68 1K 68
5% 5% 5%
1/4W F 1/4W F 1/4W F
< SWITCH > S501 S502
< RESISTOR > R600 R601 R602 R603 R604
1-249-425-11 1-249-427-11 1-249-429-11 1-249-431-11 1-249-433-11
CARBON CARBON CARBON CARBON CARBON
4.7K 6.8K 10K 15K 22K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W 1/4W
R605 R607 R608
1-249-435-11 CARBON 1-249-397-11 CARBON 1-249-397-11 CARBON
33K 22 22
5% 5% 5%
1/4W 1/4W F 1/4W F
1-762-875-21 SWITCH, KEYBOARD (GAME) 1-762-875-21 SWITCH, KEYBOARD (GAME MIXING)
****************************************************** HEADPHONE BOARD
*************** < CAPACITOR > C891 C892
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
0.001uF 0.001uF
10% 10%
50V 50V
< JACK >
< SWITCH > S600 S601 S602 S603 S604
1-162-294-31 CERAMIC 1-162-294-31 CERAMIC
J891
SWITCH, KEYBOARD (>) SWITCH, KEYBOARD (.) SWITCH, KEYBOARD (m) SWITCH, KEYBOARD (M) SWITCH, KEYBOARD (x)
1-770-226-11 JACK (LARGE TYPE) (PHONES) < RESISTOR >
R891
1-247-807-31 CARBON
100
5%
1/4W
****************************************************** S605
1-762-875-21 SWITCH, KEYBOARD (u)
******************************************************
A-4732-084-A KEY BOARD, COMPLETE
******************* 1-687-267-11 DOOR SW BOARD
*************
< CONNECTOR >
< CAPACITOR > C700
70
1-162-306-11 CERAMIC
CN801 0.01uF
30%
16V
1-563-616-11 CONNECTOR, FLEXIBLE 13P
HCD-XGV11AV KEY Ref. No.
Part No.
Description < DIODE >
Remarks
D801 D802 D803 D804 D805
8-719-058-03 8-719-058-03 8-719-058-03 8-719-058-03 8-719-058-03
DIODE DIODE DIODE DIODE DIODE
SEL5423E-TP15 (POP) SEL5423E-TP15 (GAME) SEL5423E-TP15 (DANCE) SEL5423E-TP15 (MOVIE) SEL5423E-TP15 (JAZZ)
D806 D807 D808 D809 D810
8-719-058-03 8-719-058-03 8-719-058-03 8-719-058-03 8-719-058-03
DIODE DIODE DIODE DIODE DIODE
SEL5423E-TP15 (TANGO) SEL5423E-TP15 (ROCK) SEL5423E-TP15 (REGGAE) SEL5423E-TP15 (SAMBA) SEL5423E-TP15 (SALSA)
D811 D812 D813 D814
8-719-058-04 8-719-058-04 8-719-057-97 8-719-057-97
DIODE DIODE DIODE DIODE
SEL5223S-TP15 (SURROUND) SEL5223S-TP15 (KARAOKE/MPX) SEL5923A-TP15 (PRO LOGIC) SEL5923A-TP15 (DVD 5.1ch)
Ref. No. S811 S812 S813 S814 S815 S816 S817
Part No. 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
LED
MAIN
Description Remarks SWITCH, KEYBOARD (TANGO) SWITCH, KEYBOARD (REGGAE) SWITCH, KEYBOARD (SALSA) SWITCH, KEYBOARD (SURROUND) SWITCH, KEYBOARD (KARAOKE/MPX)
1-762-875-21 SWITCH, KEYBOARD (PRO LOGIC) 1-762-875-21 SWITCH, KEYBOARD (DVD5.1ch)
****************************************************** *
1-659-059-13 LED BOARD
********* < DIODE > D201
8-719-032-98 DIODE SEL5820A-TP15 (DISC No.) < TRANSISTOR >
< RESISTOR >
Q201
R801 R802 R803 R804 R805
1-249-415-11 1-249-417-11 1-249-419-11 1-249-419-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
680 1K 1.5K 1.5K 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F F F F
R806 R807 R808 R809 R810
1-247-843-11 1-249-425-11 1-249-427-11 1-249-429-11 1-249-431-11
CARBON CARBON CARBON CARBON CARBON
3.3K 4.7K 6.8K 10K 15K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W F 1/4W 1/4W
R811 R813 R814 R815 R816
1-249-433-11 1-249-417-11 1-249-419-11 1-249-419-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
22K 1K 1.5K 1.5K 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R817 R818 R819 R820 R824
1-247-843-11 1-249-425-11 1-249-427-11 1-249-429-11 1-249-401-11
CARBON CARBON CARBON CARBON CARBON
3.3K 4.7K 6.8K 10K 47
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W F 1/4W 1/4W F
R825 R826 R827 R828 R829
1-249-401-11 1-249-401-11 1-249-401-11 1-249-401-11 1-249-401-11
CARBON CARBON CARBON CARBON CARBON
47 47 47 47 47
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F F F F
R830 R831 R832 R833 R835
1-249-401-11 1-249-401-11 1-249-401-11 1-249-401-11 1-249-401-11
CARBON CARBON CARBON CARBON CARBON
47 47 47 47 47
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F F F F
R836 R837
1-247-807-31 CARBON 1-247-807-31 CARBON
100 100
5% 5%
1/4W 1/4W
8-729-119-78 TRANSISTOR 2SC2785TP-HFE < RESISTOR >
R201 R202 R203
1-249-433-11 CARBON 1-249-411-11 CARBON 1-249-437-11 CARBON
22K 330 47K
5% 5% 5%
1/4W 1/4W 1/4W
****************************************************** A-4732-088-A MAIN BOARD, COMPLETE
******************* 4-229-123-01 4-875-327-31 4-948-236-01 7-685-646-79
F F F F
HEAT SINK, V.OUT HEAT SINK CUSHION (107) SCREW +BVTP 3X8 TYPE2 N-S < CAPACITOR >
C110 C111 C112 C113 C114
1-126-795-11 1-126-795-11 1-126-795-11 1-126-795-11 1-126-795-11
ELECT ELECT ELECT ELECT ELECT
10uF 10uF 10uF 10uF 10uF
20% 20% 20% 20% 20%
50V 50V 50V 50V 50V
C115 C116 C117 C118 C119
1-126-795-11 1-130-487-00 1-130-487-00 1-126-795-11 1-130-489-00
ELECT MYLAR MYLAR ELECT MYLAR
10uF 0.022uF 0.022uF 10uF 0.033uF
20% 5% 5% 20% 5%
50V 50V 50V 50V 50V
C120 C121 C122 C123 C124
1-130-479-00 1-126-795-11 1-136-171-00 1-136-171-00 1-126-961-11
MYLAR ELECT FILM FILM ELECT
0.0047uF 10uF 0.33uF 0.33uF 2.2uF
5% 20% 5% 5% 20%
50V 50V 50V 50V 50V
1-126-933-11 1-126-795-11 1-162-974-11 1-124-589-11 1-126-795-11
ELECT ELECT CERAMIC CHIP ELECT ELECT
100uF 10uF 0.01uF 47uF 10uF
20% 20%
< SWITCH >
C132 C133 C134 C135 C136
20% 20%
16V 50V 50V 16V 50V
S800 S801 S802 S803 S804
1-786-528-11 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, ROTARY (ENTER) SWITCH, KEYBOARD (SAMBA) SWITCH, KEYBOARD (ROCK) SWITCH, KEYBOARD (JAZZ) SWITCH, KEYBOARD (DANCE)
C137 C139 C160 C161 C162
1-162-967-11 1-126-964-11 1-126-795-11 1-126-795-11 1-126-795-11
CERAMIC CHIP ELECT ELECT ELECT ELECT
0.0033uF 10uF 10uF 10uF 10uF
10% 20% 20% 20% 20%
50V 50V 50V 50V 50V
S805 S806 S807 S809 S810
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (POP) SWITCH, KEYBOARD (P.FILE) SWITCH, KEYBOARD (EFFECT) SWITCH, KEYBOARD (GAME) SWITCH, KEYBOARD (MOVIE)
C163 C164 C165 C166 C167
1-126-795-11 1-126-795-11 1-126-795-11 1-130-487-00 1-130-487-00
ELECT ELECT ELECT MYLAR MYLAR
10uF 10uF 10uF 0.022uF 0.022uF
20% 20% 20% 5% 5%
50V 50V 50V 50V 50V
71
HCD-XGV11AV MAIN Ref. No. C168 C169 C170 C171 C172
Part No. 1-126-795-11 1-130-489-00 1-130-479-00 1-126-795-11 1-136-171-00
Description ELECT MYLAR MYLAR ELECT FILM
10uF 0.033uF 0.0047uF 10uF 0.33uF
20% 5% 5% 20% 5%
C173 C174 C181 C182 C183
1-136-171-00 1-126-961-11 1-164-156-11 1-164-156-11 1-164-156-11
FILM ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.33uF 2.2uF 0.1uF 0.1uF 0.1uF
5% 20%
C191 C192 C193 C301 C302
1-162-974-11 1-126-964-11 1-164-156-11 1-130-483-00 1-126-964-11
CERAMIC CHIP ELECT CERAMIC CHIP MYLAR ELECT
0.01uF 10uF 0.1uF 0.01uF 10uF
C303 C304 C305 C306 C307
1-136-165-00 1-126-964-11 1-126-960-11 1-126-961-11 1-126-947-11
FILM ELECT ELECT ELECT ELECT
C308 C309 C310 C311 C312
1-164-392-11 1-164-392-11 1-126-964-11 1-126-933-11 1-126-964-11
C313 C319 C320 C321 C322
Remarks 50V 50V 50V 50V 50V 50V 50V 25V 25V 25V
5% 20%
50V 50V 25V 50V 50V
0.1uF 10uF 1uF 2.2uF 47uF
5% 20% 20% 20% 20%
50V 50V 50V 50V 16V
CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT
390PF 390PF 10uF 100uF 10uF
10% 10% 20% 20% 20%
50V 50V 50V 16V 50V
1-126-964-11 1-162-966-11 1-162-966-11 1-126-947-11 1-130-471-00
ELECT CERAMIC CHIP CERAMIC CHIP ELECT MYLAR
10uF 0.0022uF 0.0022uF 47uF 0.001uF
20% 10% 10% 20% 5%
50V 50V 50V 16V 50V
C331 C332 C333 C334 C338
1-137-350-11 1-130-479-00 1-130-479-00 1-137-395-91 1-126-947-11
MYLAR MYLAR MYLAR MYLAR ELECT
0.015uF 0.0047uF 0.0047uF 0.022uF 47uF
5% 5% 5% 5% 20%
50V 50V 50V 100V 16V
C341 C342 C343 C344 C345
1-126-961-11 1-130-489-00 1-162-949-11 1-126-960-11 1-162-949-11
ELECT MYLAR CERAMIC CHIP ELECT CERAMIC CHIP
2.2uF 0.033uF 47PF 1uF 47PF
20% 5% 5% 20% 5%
50V 50V 50V 50V 50V
C346 C347 C348 C351 C352
1-126-956-91 1-126-956-91 1-126-933-11 1-130-483-00 1-126-964-11
ELECT ELECT ELECT MYLAR ELECT
0.1uF 0.1uF 100uF 0.01uF 10uF
20% 20% 20% 5% 20%
50V 50V 16V 50V 50V
C353 C354 C355 C356 C357
1-136-165-00 1-126-964-11 1-126-960-11 1-126-961-11 1-126-947-11
FILM ELECT ELECT ELECT ELECT
0.1uF 10uF 1uF 2.2uF 47uF
5% 20% 20% 20% 20%
50V 50V 50V 50V 16V
C358 C359 C366 C381 C382
1-164-392-11 1-164-392-11 1-130-471-00 1-162-968-11 1-162-968-11
CERAMIC CHIP CERAMIC CHIP MYLAR CERAMIC CHIP CERAMIC CHIP
390PF 390PF 0.001uF 0.0047uF 0.0047uF
10% 10% 5% 10% 10%
50V 50V 50V 50V 50V
C401 C402 C403 C404 C405
1-164-156-11 1-126-916-11 1-126-964-11 1-126-964-11 1-162-953-11
CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP
0.1uF 1000uF 10uF 10uF 100PF
20% 20% 20% 5%
25V 6.3V 50V 50V 50V
C406
1-162-953-11 CERAMIC CHIP
100PF
5%
50V
72
20%
Ref. No. C407 C408 C410 C414
Part No. 1-164-156-11 1-126-916-11 1-126-935-11 1-164-156-11
Description CERAMIC CHIP ELECT ELECT CERAMIC CHIP
0.1uF 1000uF 470uF 0.1uF
C415 C416 C431 C510 C511
1-162-966-11 1-162-966-11 1-164-156-11 1-162-918-11 1-162-945-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.0022uF 0.0022uF 0.1uF 18PF 22PF
C512 C516 C562 C563 C598
1-164-156-11 1-164-156-11 1-164-156-11 1-126-947-11 1-164-156-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 0.1uF 0.1uF 47uF 0.1uF
C599 C601 C602 C603 C604
1-126-947-11 1-162-961-11 1-162-953-11 1-162-953-11 1-126-961-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
47uF 330PF 100PF 100PF 2.2uF
20% 10% 5% 5% 20%
16V 50V 50V 50V 50V
C605 C606 C607 C608 C609
1-130-479-00 1-130-473-00 1-136-159-00 1-126-964-11 1-162-974-11
MYLAR MYLAR FILM ELECT CERAMIC CHIP
0.0047uF 0.0015uF 0.033uF 10uF 0.01uF
5% 5% 5% 20%
50V 50V 50V 50V 50V
C610 C611 C612 C613 C651
1-126-933-11 1-126-947-11 1-162-974-11 1-126-947-11 1-162-961-11
ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP
100uF 47uF 0.01uF 47uF 330PF
20% 20% 20% 10%
16V 16V 50V 16V 50V
C652 C653 C654 C655 C656
1-162-953-11 1-162-953-11 1-126-961-11 1-130-479-00 1-130-473-00
CERAMIC CHIP CERAMIC CHIP ELECT MYLAR MYLAR
100PF 100PF 2.2uF 0.0047uF 0.0015uF
5% 5% 20% 5% 5%
50V 50V 50V 50V 50V
C657 C658 C701 C702 C703
1-136-159-00 1-126-964-11 1-162-960-11 1-162-960-11 1-126-964-11
FILM ELECT CERAMIC CHIP CERAMIC CHIP ELECT
0.033uF 10uF 220PF 220PF 10uF
5% 20% 10% 10% 20%
50V 50V 50V 50V 50V
C704 C711 C712 C713 C714
1-126-964-11 1-162-960-11 1-162-960-11 1-162-960-11 1-126-964-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
10uF 220PF 220PF 220PF 10uF
20% 10% 10% 10% 20%
50V 50V 50V 50V 50V
C721 C722 C723 C724 C731
1-126-960-11 1-126-926-11 1-109-889-11 1-162-962-11 1-126-964-11
ELECT ELECT ELECT CERAMIC CHIP ELECT
1uF 1000uF 1uF 470PF 10uF
20% 20% 20% 10% 20%
50V 10V 50V 50V 50V
C732 C733 C751 C752 C753
1-162-960-11 1-164-156-11 1-162-960-11 1-162-960-11 1-126-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
220PF 0.1uF 220PF 220PF 10uF
10% 10% 10% 20%
50V 25V 50V 50V 50V
C754 C761 C762 C763 C764
1-126-964-11 1-162-960-11 1-162-960-11 1-162-960-11 1-126-964-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
10uF 220PF 220PF 220PF 10uF
20% 10% 10% 10% 20%
50V 50V 50V 50V 50V
C771 C772
1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP
0.1uF 0.1uF
20% 20%
10% 10% 5% 5%
20%
Remarks 25V 6.3V 10V 25V 50V 50V 25V 50V 50V 25V 25V 25V 16V 25V
25V 25V
HCD-XGV11AV MAIN Ref. No. C773 C774 C775
Part No. 1-164-156-11 1-164-156-11 1-164-156-11
Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF
Remarks 25V 25V 25V
C776 C801 C802 C803 C804
1-164-156-11 1-126-964-11 1-136-165-00 1-136-165-00 1-126-916-11
CERAMIC CHIP ELECT FILM FILM ELECT
0.1uF 10uF 0.1uF 0.1uF 1000uF
C806 C807 C901 C902 C903
1-109-953-11 1-126-963-11 1-111-235-61 1-164-156-11 1-126-935-11
ELECT ELECT ELECT CERAMIC CHIP ELECT
2.2uF 4.7uF 10000uF 0.1uF 470uF
20% 10% 20% 20%
50V 20V 25V 25V 16V
C911 C912 C913 C914 C915
1-126-941-11 1-126-935-11 1-126-947-11 1-126-933-11 1-126-933-11
ELECT ELECT ELECT ELECT ELECT
470uF 470uF 47uF 100uF 100uF
20% 20% 20% 20% 20%
25V 16V 16V 16V 16V
C921 C922 C924 C925 C926
1-126-768-11 1-164-156-11 1-126-917-11 1-164-156-11 1-126-935-11
ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT
2200uF 0.1uF 3300uF 0.1uF 470uF
20%
16V 25V 6.3V 25V 6.3V
C927 C928 C929 C930 C961
1-126-933-11 1-126-961-11 1-126-947-11 1-126-933-11 1-164-156-11
ELECT ELECT ELECT ELECT CERAMIC CHIP
100uF 2.2uF 47uF 100uF 0.1uF
20% 20% 20% 20%
20% 5% 5% 20%
25V 50V 50V 50V 6.3V
Ref. No. D807 D808 D809 D810 D811
Part No. 8-719-988-61 8-719-988-61 8-719-210-33 8-719-210-33 8-719-988-61
Description DIODE 1SS355TE-17 DIODE 1SS355TE-17 DIODE EC10DS2 DIODE EC10DS2 DIODE 1SS355TE-17
D815 D911 D912 D913 D914
8-719-988-61 8-719-210-33 8-719-210-33 8-719-210-33 8-719-069-54
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 EC10DS2 EC10DS2 EC10DS2 UDZSTE-175.1B
D915 D916 D961 D962 D963
8-719-069-54 8-719-069-54 8-719-210-33 8-719-210-33 8-719-210-33
DIODE DIODE DIODE DIODE DIODE
UDZSTE-175.1B UDZSTE-175.1B EC10DS2 EC10DS2 EC10DS2
D964 D965
8-719-210-33 DIODE EC10DS2 8-719-210-33 DIODE EC10DS2
Remarks
< FERRITE BEAD >
20% 20%
< CONNECTOR > CN151 CN152 CN321 CN371 CN401
1-770-863-11 1-770-863-11 1-691-770-11 1-784-774-11 1-784-780-11
CONNECTOR, BOARD TO BOARD 10P CONNECTOR, BOARD TO BOARD 10P PLUG (MICRO CONNECTOR) 8P CONNECTOR, FFC 13P CONNECTOR, FFC 19P
CN411 CN431 CN441 CN721 * CN801
1-785-321-11 1-784-780-11 1-568-830-11 1-564-505-11 1-564-704-11
PIN, CONNECTOR (STRAIGHT) 9P CONNECTOR, FFC 19P CONNECTOR, FFC 11P PLUG, CONNECTOR 2P PIN, CONNECTOR (SMALL TYPE) 2P
CN901 CN902 CN903 CN961
1-778-982-21 1-778-982-21 1-785-315-11 1-564-506-11
CONNECTOR, BOARD TO BOARD 13P CONNECTOR, BOARD TO BOARD 13P PIN, CONNECTOR (STRAIGHT) 3P PLUG, CONNECTOR 3P
16V 50V 25V 16V 25V
FB402 FB403 FB516 FB562 FB599
1-414-772-11 1-414-772-11 1-414-772-11 1-414-772-11 1-414-772-11
FERRITE FERRITE FERRITE FERRITE FERRITE
0UH 0UH 0UH 0UH 0UH
< IC > IC111 IC181 IC191 IC301 IC501
6-703-650-01 8-759-009-06 8-759-571-53 6-702-130-01 6-802-674-01
IC IC IC IC IC
M61529FP-T60G MC14052BFEL BA7615N HA12237F M30620MCN-A21FP
IC601 IC801 IC912 IC921 IC922
8-759-100-96 8-759-532-64 6-703-610-01 8-759-039-69 6-701-760-01
IC IC IC IC IC
NJM4558M-TE2 M62703SL-TP RT8H015C-T112-1 uPC7805AHF uPC3504AHF
IC931
8-759-701-59 IC TA7809S < JACK >
J701 J711 J721 J731
1-774-411-11 1-779-599-11 1-518-043-11 1-770-377-31
JACK, PIN 6P (PHONO/MD(VIDEO)) JACK, PIN 6P (DVD INPUT) JACK, PIN 2P (VIDEO OUT/DVD INPUT) JACK, PIN 1P (SUB WOOFER OUT) < JUMPER RESISTOR >
< DIODE > D161 D162 D191 D192 D381
8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17
D382 D383 D384 D431 D801
8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17
D802 D803 D804 D805 D806
8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61 8-719-988-61
DIODE DIODE DIODE DIODE DIODE
1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17 1SS355TE-17
JR1 JR2 JR3 JR4 JR5
1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR6 JR7 JR8 JR10 JR11
1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-296-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR12 JR13 JR14 JR16 JR17
1-216-295-91 1-216-296-11 1-216-295-91 1-216-295-91 1-216-296-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
JR18
1-216-296-11 SHORT CHIP
0
73
HCD-XGV11AV MAIN Ref. No. JR19 JR22 JR23 JR24
Part No. 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91
Description SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0
Remarks
Ref. No. Q344 Q381 Q382 Q383
Part No. 8-729-119-78 8-729-140-04 8-729-029-86 8-729-140-04
Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2785-HFE 2SB1116A-L DTC124ESA 2SB1116A-L
JR25 JR26 JR29 JR30 JR32
1-216-295-91 1-216-296-11 1-216-295-91 1-216-296-11 1-216-295-91
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
Q384 Q385 Q386 Q401 Q402
8-729-029-86 8-729-116-59 8-729-029-86 8-729-141-30 8-729-141-30
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC124ESA 2SB1068TP DTC124ESA 2SC3623A-LK 2SC3623A-LK
JR35 JR36 JR39 JR40 JR42
1-216-296-11 1-216-296-11 1-216-295-91 1-216-295-91 1-216-296-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
Q411 Q412 Q611 Q701 Q731
8-729-029-86 8-729-029-86 8-729-620-05 8-729-141-30 8-729-141-30
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC124ESA DTC124ESA 2SC2603-EF 2SC3623A-LK 2SC3623A-LK
JR44 JR45 JR46 JR47 JR301
1-216-295-91 1-216-296-11 1-216-296-11 1-216-295-91 1-216-295-91
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
Q751 Q801 Q802 Q803 Q804
8-729-141-30 8-729-620-05 8-729-029-86 8-729-029-40 8-729-029-40
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC3623A-LK 2SC2603-EF DTC124ESA DTA124ESA DTA124ESA
JR303 JR322 JR323 JR324 JR325
1-216-295-91 1-216-296-11 1-216-295-91 1-216-296-11 1-216-295-91
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
Q805 Q806 Q807 Q808 Q809
8-729-029-40 8-729-029-86 8-729-029-86 8-729-029-86 8-729-029-86
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTA124ESA DTC124ESA DTC124ESA DTC124ESA DTC124ESA
JR333 JR350 JR351 JR353 JR360
1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
Q810 Q911 Q918 Q921 Q922
8-729-029-40 8-729-209-15 8-729-620-05 8-729-140-97 8-729-029-86
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTA124ESA 2SD2012 2SC2603-EF 2SB734-34 DTC124ESA
JR404 JR405 JR406 JR407 JR414
1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
Q923 Q961 Q962
8-729-620-05 TRANSISTOR 2SC2603-EF 8-729-620-05 TRANSISTOR 2SC2603-EF 8-729-140-04 TRANSISTOR 2SB1116A-L
JR723
1-216-295-91 SHORT CHIP
0
R111 R112 R115 R118 R119
1-216-825-11 1-216-833-11 1-216-835-11 1-216-833-11 1-216-817-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 10K 15K 10K 470
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R120 R122 R124 R125 R127
1-216-295-91 1-216-825-11 1-216-833-11 1-216-833-11 1-216-811-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 2.2K 10K 10K 150
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R132 R135 R136 R140 R141
1-216-839-11 1-216-295-91 1-216-295-91 1-216-845-11 1-216-845-11
METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP
33K 0 0 100K 100K
5%
1/10W
5% 5%
1/10W 1/10W
R142 R143 R161 R162 R165
1-216-833-11 1-216-833-11 1-216-825-11 1-216-833-11 1-216-835-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 2.2K 10K 15K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R168 R169 R170 R172 R174
1-216-833-11 1-216-817-11 1-216-295-91 1-216-825-11 1-216-833-11
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
10K 470 0 2.2K 10K
5% 5%
1/10W 1/10W
5% 5%
1/10W 1/10W
R176 R177
1-216-837-11 METAL CHIP 1-216-811-11 METAL CHIP
22K 150
5% 5%
1/10W 1/10W
< COIL > L301
1-412-032-11 INDUCTOR CHIP 100uH < TRANSISTOR >
Q114 Q115 Q164 Q165 Q166
8-729-141-30 8-729-620-05 8-729-141-30 8-729-620-05 8-729-029-40
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC3623A-LK 2SC2603-EF 2SC3623A-LK 2SC2603-EF DTA124ESA
Q167 Q181 Q182 Q321 Q322
8-729-620-05 8-729-029-86 8-729-029-86 8-729-029-86 8-729-119-76
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2603-EF DTC124ESA DTC124ESA DTC124ESA 2SA1175-HFE
Q323 Q324 Q325 Q326 Q327
8-729-119-78 8-729-119-78 8-729-119-78 8-729-119-78 8-729-029-86
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2785-HFE 2SC2785-HFE 2SC2785-HFE 2SC2785-HFE DTC124ESA
Q331 Q334 Q335 Q341 Q342
8-729-142-46 8-729-029-86 8-729-140-04 8-729-119-78 8-729-119-78
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2001-LK DTC124ESA 2SB1116A-L 2SC2785-HFE 2SC2785-HFE
Q343
8-729-029-86 TRANSISTOR DTC124ESA
74
Remarks
< RESISTOR >
HCD-XGV11AV MAIN Ref. No. R179 R181 R182
Part No. 1-216-833-11 1-216-833-11 1-216-833-11
Description METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K
5% 5% 5%
Remarks 1/10W 1/10W 1/10W
R301 R302 R304 R305 R308
1-216-827-11 1-216-829-11 1-216-825-11 1-216-841-11 1-216-837-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.3K 4.7K 2.2K 47K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R309 R310 R311 R314 R315
1-216-857-11 1-216-833-11 1-216-829-11 1-216-837-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1M 10K 4.7K 22K 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R320 R321 R322 R323 R324
1-216-833-11 1-216-829-11 1-216-829-11 1-216-833-11 1-216-295-91
METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
10K 4.7K 4.7K 10K 0
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R326 R330 R331 R333 R334
1-216-833-11 1-216-837-11 1-216-837-11 1-216-833-11 1-216-797-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 22K 22K 10K 10
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R335 R336 R337 R338 R339
1-216-837-11 1-216-814-11 1-216-833-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 270 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R340 R341 R342 R343 R344
1-216-827-11 1-216-857-11 1-216-821-11 1-216-853-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
3.3K 1M 1K 470K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R345 R346 R347 R348 R349
1-216-853-11 1-216-833-11 1-216-849-11 1-216-817-11 1-216-849-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470K 10K 220K 470 220K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R350 R351 R352 R354 R355
1-216-817-11 1-216-827-11 1-216-829-11 1-216-825-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 3.3K 4.7K 2.2K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R358 R361 R364 R365 R371
1-216-833-11 1-216-833-11 1-216-837-11 1-216-825-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 22K 2.2K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R372 R374 R375 R377 R378
1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R381 R382 R383 R384 R385
1-216-819-11 1-216-825-11 1-216-825-11 1-216-819-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
680 2.2K 2.2K 680 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R386 R387 R388
1-216-825-11 METAL CHIP 1-216-841-11 METAL CHIP 1-216-827-11 METAL CHIP
2.2K 47K 3.3K
5% 5% 5%
1/10W 1/10W 1/10W
Ref. No. R389 R390
Part No. Description 1-216-827-11 METAL CHIP 1-216-827-11 METAL CHIP
3.3K 3.3K
5% 5%
Remarks 1/10W 1/10W
R401 R402 R403 R404 R405
1-216-829-11 1-216-833-11 1-216-833-11 1-216-829-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 10K 10K 4.7K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R406 R407 R408 R410 R412
1-216-833-11 1-216-295-91 1-216-295-91 1-216-295-91 1-216-835-11
METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP METAL CHIP
10K 0 0 0 15K
5%
1/10W
5%
1/10W
R413 R414 R477 R501 R502
1-216-833-11 1-216-833-11 1-216-829-11 1-216-833-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 4.7K 10K 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R503 R504 R505 R509 R511
1-216-809-11 1-216-809-11 1-216-833-11 1-216-833-11 1-216-851-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 10K 10K 330K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R513 R516 R517 R518 R519
1-216-295-91 1-216-833-11 1-216-833-11 1-216-809-11 1-216-809-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 10K 10K 100 100
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R521 R522 R523 R525 R527
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R529 R530 R531 R532 R533
1-216-809-11 1-216-809-11 1-216-833-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 10K 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R534 R535 R536 R537 R540
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R541 R543 R547 R548 R549
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R551 R552 R556 R563 R549
1-216-833-11 1-216-833-11 1-216-809-11 1-216-809-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 100 100 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R570 R571 R572 R573 R574
1-216-809-11 1-216-835-11 1-216-835-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 15K 15K 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R575 R577 R578 R579
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
75
HCD-XGV11AV MAIN Ref. No. R580
MIC Part No. Description 1-216-809-11 METAL CHIP
100
5%
Remarks 1/10W
R581 R582 R583 R584 R585
1-216-809-11 1-216-833-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 10K 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R586 R587 R588 R589 R590
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R591 R592 R593 R594 R595
1-216-809-11 1-216-819-11 1-216-829-11 1-216-829-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 680 4.7K 4.7K 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R596 R597 R598 R599 R600
1-216-295-91 1-216-841-11 1-216-841-11 1-216-833-11 1-216-833-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 47K 47K 10K 10K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R601 R602 R603 R604 R605
1-216-821-11 1-216-821-11 1-216-841-11 1-216-821-11 1-216-854-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 1K 47K 1K 560K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R606 R607 R608 R609 R611
1-216-841-11 1-216-821-11 1-216-845-11 1-216-813-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
47K 1K 100K 220 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R612 R613 R614 R615 R651
1-216-821-11 1-216-815-11 1-216-821-11 1-216-809-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 330 1K 100 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R652 R653 R654 R655 R656
1-216-821-11 1-216-841-11 1-216-821-11 1-216-854-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 47K 1K 560K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R657 R658 R701 R702 R703
1-216-821-11 1-216-845-11 1-216-821-11 1-216-845-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 100K 1K 100K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R704 R705 R706 R707 R711
1-216-845-11 1-216-833-11 1-216-825-11 1-216-857-11 1-216-832-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 10K 2.2K 1M 8.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R712 R713 R714 R715 R716
1-216-833-11 1-218-866-11 1-216-833-11 1-218-866-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 6.2K 10K 6.2K 10K
5% 0.5% 5% 0.5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R721 R722 R723 R724 R731
1-218-285-11 1-216-805-11 1-218-285-11 1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
75 47 75 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
Ref. No. R732 R733 R734 R751 R752
Part No. 1-216-821-11 1-216-845-11 1-216-821-11 1-216-821-11 1-216-845-11
Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 100K 1K 1K 100K
5% 5% 5% 5% 5%
Remarks 1/10W 1/10W 1/10W 1/10W 1/10W
R753 R754 R755 R756 R757
1-216-821-11 1-216-845-11 1-216-833-11 1-216-825-11 1-216-857-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 100K 10K 2.2K 1M
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R761 R762 R763 R764 R765
1-216-832-11 1-216-833-11 1-218-866-11 1-216-833-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
8.2K 10K 6.2K 10K 1K
5% 5% 0.5% 5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R766 R801 R802 R803 R804
1-216-833-11 1-216-813-11 1-216-829-11 1-216-829-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 220 4.7K 4.7K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R805 R806 R807 R808 R809
1-216-841-11 1-216-833-11 1-216-821-11 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
47K 10K 1K 100K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R810 R811 R812 R813 R814
1-216-845-11 1-216-833-11 1-216-827-11 1-216-833-11 1-216-837-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 10K 3.3K 10K 22K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R815 R816 R911 R912 R921
1-216-837-11 1-216-845-11 1-215-863-11 1-216-825-11 1-216-833-11
METAL CHIP METAL CHIP METAL OXIDE METAL CHIP METAL CHIP
22K 100K 100 2.2K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1W 1/10W 1/10W
R922 R923 R924 R961 R962
1-216-825-11 1-216-825-11 1-216-825-11 1-216-829-11 1-216-836-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 2.2K 2.2K 4.7K 18K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R963
1-216-825-11 METAL CHIP
2.2K
5%
1/10W
< TRANSFORMER > T331
1-437-220-11 TRANSFORMER, BIAS OSCILLATION < VIBRATOR >
X501 X502
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) 1-781-107-21 VIBRATOR, SERAMIC (16MHz)
****************************************************** A-4732-065-A MIC BOARD, COMPLETE
*******************
76
< CAPACITOR > C801 C802 C803 C804 C805
1-162-306-11 1-162-306-11 1-126-960-11 1-126-959-11 1-162-294-31
CERAMIC CERAMIC ELECT ELECT CERAMIC
C806 C810
1-162-215-31 CERAMIC 1-162-288-31 CERAMIC
0.01uF 0.01uF 1uF 0.47uF 0.001uF
30% 30% 20% 20% 10%
16V 16V 50V 50V 50V
47PF 330PF
5% 10%
50V 50V
HCD-XGV11AV MIC Ref. No. C817 C818 C819
Part No. 1-126-961-11 1-162-215-31 1-162-215-31
Description ELECT CERAMIC CERAMIC
2.2uF 47PF 47PF
20% 5% 5%
Remarks 50V 50V 50V
C820 C821 C822 C823 C824
1-126-957-11 1-126-947-11 1-126-767-11 1-126-947-11 1-126-961-11
ELECT ELECT ELECT ELECT ELECT
0.22uF 47uF 1000uF 47uF 2.2uF
20% 20% 20% 20% 20%
50V 16V 16V 16V 50V
C825 C826 C827 C828 C829
1-161-494-00 1-126-947-11 1-162-294-31 1-136-495-11 1-126-959-11
CERAMIC ELECT CERAMIC FILM ELECT
0.022uF 47uF 0.001uF 0.068uF 0.47uF
20% 10% 5% 20%
25V 16V 50V 50V 50V
C830 C831 C832 C833 C834
1-126-959-11 1-162-305-11 1-136-167-00 1-162-294-31 1-162-305-11
ELECT CERAMIC FILM CERAMIC CERAMIC
0.47uF 0.0068uF 0.15uF 0.001uF 0.0068uF
20% 30% 5% 10% 30%
50V 16V 50V 50V 16V
C835 C837 C838 C865 C878
1-136-495-11 1-126-964-11 1-126-964-11 1-126-961-11 1-126-960-11
FILM ELECT ELECT ELECT ELECT
0.068uF 10uF 10uF 2.2uF 1uF
5% 20% 20% 20% 20%
50V 50V 50V 50V 50V
C900
1-164-159-11 CERAMIC
Ref. No. R859 R860
MOTOR
PA
Part No. Description 1-249-433-11 CARBON 1-249-433-11 CARBON
22K 22K
5% 5%
Remarks 1/4W 1/4W
R861 R862 R863 R864 R865
1-247-881-00 1-249-433-11 1-249-433-11 1-249-433-11 1-249-437-11
CARBON CARBON CARBON CARBON CARBON
120K 22K 22K 22K 47K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R866 R867 R874 R875 R876
1-249-431-11 1-249-421-11 1-249-429-11 1-247-807-31 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
15K 2.2K 10K 100 1K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W F
R877 R878 R879
1-249-411-11 CARBON 1-249-417-11 CARBON 1-249-417-11 CARBON
330 1K 1K
5% 5% 5%
1/4W 1/4W F 1/4W F
****************************************************** *
A-4673-765-A MOTOR BOARD, COMPLETE
*********************
0.1uF
50V
*
4-980-385-01 HOLDER (SW) < CAPACITOR > C201 C202 C203
1-126-964-11 ELECT 1-164-159-21 CERAMIC 1-126-964-11 ELECT
10uF 0.1uF 10uF
20% 20%
50V 50V 50V
5% 5%
1/4W F 1/4W F
< CONNECTOR > < CONNECTOR > CN812
1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P
* CN201
1-568-947-11 PIN, CONNECTOR 9P
< DIODE > < IC > D801
8-719-109-85 DIODE RD5.1ESB2 IC201
8-759-365-94 IC TA8409S
< FILTER > < COIL > FL801
1-424-228-11 FILTER, NOISE L201
1-408-117-00 INDUCTOR
10uH
< IC > < RESISTOR > IC850 IC851
8-759-505-55 IC NJM4558L 8-759-450-96 IC M65850P
R205 R206
1-249-427-11 CARBON 1-249-425-11 CARBON
6.8K 4.7K
< JACK > < SWITCH > J801 J802
1-770-226-11 JACK (LARGE TYPE) (MIC-2) 1-770-226-11 JACK (LARGE TYPE) (MIC-1)
S201
1-762-587-11 SWITCH, PUSH (1 KEY) (UP)
****************************************************** < TRANSISTOR > A-4732-086-A PA BOARD, COMPLETE Q884
******************
8-729-119-78 TRANSISTOR 2SC2785-HFE
4-875-327-31 HEAT SINK 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< RESISTOR > R806 R807 R808 R809 R811
1-249-429-11 1-249-429-11 1-249-417-11 1-249-417-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
10K 10K 1K 1K 100K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W
R850 R852 R853 R854 R855
1-249-417-11 1-249-441-11 1-249-417-11 1-249-437-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
1K 100K 1K 47K 10K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W 1/4W
R856 R857 R858
1-247-893-11 CARBON 1-247-807-31 CARBON 1-249-433-11 CARBON
390K 100 22K
5% 5% 5%
1/4W 1/4W 1/4W
< CAPACITOR > C401 C406 C407 C408 C409
1-126-963-11 1-164-159-11 1-164-159-11 1-164-159-11 1-164-159-11
ELECT CERAMIC CERAMIC CERAMIC CERAMIC
4.7uF 0.1uF 0.1uF 0.1uF 0.1uF
C410 C411 C412 C413 C414
1-164-159-11 1-164-159-11 1-162-306-11 1-162-306-11 1-162-306-11
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
0.1uF 0.1uF 0.01uF 0.01uF 0.01uF
20%
30% 30% 30%
50V 50V 50V 50V 50V 50V 50V 16V 16V 16V
77
HCD-XGV11AV PA Ref. No. C415 C416 C801 C802 C803
Part No. 1-162-306-11 1-162-306-11 1-128-582-11 1-162-290-31 1-162-286-31
Description CERAMIC CERAMIC ELECT CERAMIC CERAMIC
0.01uF 0.01uF 10uF 470PF 220PF
30% 30% 20% 10% 10%
C804 C807 C808 C809 C810
1-126-965-91 1-128-560-11 1-137-749-11 1-137-749-11 1-128-562-11
ELECT ELECT MYLAR MYLAR ELECT
22uF 22uF 0.1uF 0.1uF 47uF
20% 20%
C811 C812 C813 C814 C815
1-130-491-00 1-130-491-00 1-162-306-11 1-162-294-31 1-126-959-11
MYLAR MYLAR CERAMIC CERAMIC ELECT
C830 C831 C833 C841 C842
1-107-714-11 1-126-964-11 1-126-964-11 1-127-811-11 1-127-815-11
C844 C845 C847 C848 C849
Ref. No. D406 D407 D408 D409 D410
Part No. 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33
Description DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE 1SS133T-77 DIODE 1SS133T-77
20%
50V 100V 100V 100V 100V
D801 D802 D803 D804 D805
8-719-991-33 8-719-110-48 8-719-991-33 8-719-991-33 8-719-991-33
DIODE DIODE DIODE DIODE DIODE
1SS133T-77 RD18ESB1 1SS133T-77 1SS133T-77 1SS133T-77
0.047uF 0.047uF 0.01uF 0.001uF 0.47uF
5% 5% 30% 10% 20%
50V 50V 16V 50V 50V
D831 D833 D834 D835 D836
8-719-510-68 6-500-522-11 6-500-522-11 6-500-522-11 6-500-522-11
DIODE DIODE DIODE DIODE DIODE
D5SBA204101 10EDB40-TA2B5 10EDB40-TA2B5 10EDB40-TA2B5 10EDB40-TA2B5
ELECT ELECT ELECT ELECT ELECT
10uF 10uF 10uF 3300uF 3300uF
20% 20% 20% 20% 20%
50V 50V 50V 50V 100V
D841 D842 D843 D844 D851
6-500-522-11 6-500-522-11 6-500-522-11 6-500-522-11 8-719-991-33
DIODE DIODE DIODE DIODE DIODE
10EDB40-TA2B5 10EDB40-TA2B5 10EDB40-TA2B5 10EDB40-TA2B5 1SS133T-77
1-137-749-11 1-126-943-11 1-164-159-11 1-164-159-11 1-164-159-11
MYLAR ELECT CERAMIC CERAMIC CERAMIC
0.1uF 2200uF 0.1uF 0.1uF 0.1uF
100V 25V 50V 50V 50V
D852 D853 D902 D903 D904
8-719-110-48 8-719-991-33 6-500-522-11 6-500-522-11 6-500-522-11
DIODE DIODE DIODE DIODE DIODE
RD18ESB1 1SS133T-77 10EDB40-TA2B5 10EDB40-TA2B5 10EDB40-TA2B5
C850 C851 C852 C853 C854
1-107-721-11 1-128-582-11 1-162-290-31 1-162-286-31 1-126-965-91
ELECT ELECT CERAMIC CERAMIC ELECT
4.7uF 10uF 470PF 220PF 22uF
20% 20% 10% 10% 20%
100V 100V 50V 50V 50V
D905 D911 D912
6-500-522-11 DIODE 10EDB40-TA2B5 8-719-983-86 DIODE MTZJ-T-72-33A 8-719-109-89 DIODE RD5.6ESB2
C857 C858 C859 C861 C862
1-128-560-11 1-164-159-11 1-164-159-11 1-130-491-00 1-130-491-00
ELECT CERAMIC CERAMIC MYLAR MYLAR
22uF 0.1uF 0.1uF 0.047uF 0.047uF
20%
100V 50V 50V 50V 50V
IC801 IC901
C863 C864 C891 C892 C894
1-126-961-11 1-104-665-11 1-127-811-11 1-127-815-11 1-137-749-11
ELECT ELECT ELECT ELECT MYLAR
2.2uF 100uF 3300uF 3300uF 0.1uF
20% 20% 20% 20%
50V 25V 50V 100V 100V
C895 C902 C903 C904 C905
1-107-721-11 1-164-159-11 1-126-933-11 1-126-964-11 1-126-968-11
ELECT CERAMIC ELECT ELECT ELECT
4.7uF 0.1uF 100uF 10uF 100uF
20%
100V 50V 16V 50V 50V
C906 C909
1-126-943-11 ELECT 1-164-159-11 CERAMIC
2200uF 0.1uF
20%
20%
5% 5%
20% 20% 20%
< CONNECTOR > CN803 CN804 * CN806 CN904
1-778-981-21 1-778-981-21 1-564-705-11 1-785-316-11
CONNECTOR, BOARD TO BOARD 13P CONNECTOR, BOARD TO BOARD 13P PIN, CONNECTOR (SMALL TYPE) 3P PIN, CONNECTOR (STRAIGHT) 4P
Remarks 16V 16V 100V 50V 50V
25V 50V
< IC > 8-749-017-06 IC STK412-150 6-701-760-01 IC uPC3504AHF < COIL > L403 L404 L405
1-422-009-13 COIL, AIR-CORE 1-422-009-13 COIL, AIR-CORE 1-422-009-13 COIL, AIR-CORE < TRANSISTOR >
Q401 Q402 Q403 Q407 Q431
8-729-029-40 8-729-140-84 8-729-029-40 8-729-029-86 8-729-620-05
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTA124ESA 2SC1841-PAFAEA DTA124ESA DTC124ESA 2SC2603-EF
Q801 Q803 Q804 Q805 Q831
8-729-140-84 8-729-140-82 8-729-140-84 8-729-231-55 8-729-029-86
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC1841-PAFAEA 2SA988-PAFAEA 2SC1841-PAFAEA 2SC2878-AB DTC124ESA
Q832 Q833 Q834 Q842 Q843
8-729-620-05 8-729-029-40 8-729-140-84 8-729-620-05 8-729-029-86
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2603-EF DTA124ESA 2SC1841-PAFAEA 2SC2603-EF DTC124ESA
Q851 Q855 Q901 Q903 Q908
8-729-140-84 8-729-231-55 8-729-620-05 8-729-209-60 8-729-119-76
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC1841-PAFAEA 2SC2878-AB 2SC2603-EF 2SB1375 2SA1175-HFE
< DIODE > D401 D402 D403 D404 D405
78
8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33
DIODE DIODE DIODE DIODE DIODE
1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77
Remarks
HCD-XGV11AV PA Ref. No.
Part No.
Description < RESISTOR >
Remarks
0 R401 0 R402 R406 R407 R408
1-216-430-11 1-216-452-11 1-249-437-11 1-249-437-11 1-249-440-11
METAL OXIDE METAL OXIDE CARBON CARBON CARBON
390 180 47K 47K 82K
5% 5% 5% 5% 5%
1W 2W 1/4W 1/4W 1/4W
R409 R416 R417 R418 R419
1-249-437-11 1-249-389-11 1-249-389-11 1-249-389-11 1-249-389-11
CARBON CARBON CARBON CARBON CARBON
47K 4.7 4.7 4.7 4.7
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R420 R421 R422 R423 R424
1-249-389-11 1-249-389-11 1-260-076-11 1-260-076-11 1-260-076-11
CARBON CARBON CARBON CARBON CARBON
4.7 4.7 10 10 10
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/2W 1/2W 1/2W
R425 R429 R431 R432 R439
1-249-437-11 1-249-437-11 1-249-438-11 1-249-437-11 1-249-425-11
CARBON CARBON CARBON CARBON CARBON
47K 47K 56K 47K 4.7K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W F
R442 R443 R444 R446 R447
1-249-435-11 1-249-434-11 1-249-439-11 1-249-429-11 1-249-437-11
CARBON CARBON CARBON CARBON CARBON
33K 27K 68K 10K 47K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R450 R801 R802 R803 R804
1-249-437-11 1-249-417-11 1-249-437-11 1-249-413-11 1-249-435-11
CARBON CARBON CARBON CARBON CARBON
47K 1K 47K 470 33K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W F 1/4W
R805 R806 0 R807 0 R808 R809
1-216-436-00 1-216-436-00 1-212-881-11 1-219-718-11 1-260-076-11
METAL OXIDE METAL OXIDE FUSIBLE METAL CARBON
3.9K 3.9K 100 0.1 10
5% 5% 5% 10% 5%
1W 1W 1/4W 5W 1/2W
R810 R811 R812 R813 R814
1-249-437-11 1-249-417-11 1-249-431-11 1-249-441-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
47K 1K 15K 100K 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W F
R815 R816 R817 R818 R819
1-249-433-11 1-249-429-11 1-249-437-11 1-249-409-11 1-249-439-11
CARBON CARBON CARBON CARBON CARBON
22K 10K 47K 220 68K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W
0 R820 R821 R822 R823 R824
1-217-637-00 1-249-435-11 1-249-433-11 1-249-433-11 1-249-416-11
FUSIBLE CARBON CARBON CARBON CARBON
1 33K 22K 22K 820
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W F
R825 R827 R828 R831 R832
1-215-891-11 1-249-441-11 1-247-903-00 1-249-441-11 1-249-441-11
METAL OXIDE CARBON CARBON CARBON CARBON
680 100K 1M 100K 100K
5% 5% 5% 5% 5%
2W 1/4W 1/4W 1/4W 1/4W
R833 R834 R835 R836 R837
1-249-433-11 1-249-429-11 1-249-437-11 1-249-417-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
22K 10K 47K 1K 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W
R838
1-249-429-11 CARBON
10K
5%
1/4W
F F F F
PANEL FL
Ref. No. R839 R840 R842 R843
Part No. 1-249-441-11 1-249-402-11 1-249-411-11 1-249-441-11
Description CARBON CARBON CARBON CARBON
100K 56 330 100K
5% 5% 5% 5%
Remarks 1/4W 1/4W F 1/4W 1/4W
R851 R852 R853 R855 0 R857
1-249-417-11 1-249-437-11 1-249-413-11 1-215-891-11 1-212-881-11
CARBON CARBON CARBON METAL OXIDE FUSIBLE
1K 47K 470 680 100
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 2W 1/4W
0 R858 R859 R860 R861 R862
1-219-718-11 1-260-076-11 1-249-437-11 1-249-417-11 1-249-431-11
METAL CARBON CARBON CARBON CARBON
0.1 10 47K 1K 15K
10% 5% 5% 5% 5%
5W 1/2W 1/4W 1/4W F 1/4W
R863 R864 R865 R866 R867
1-249-441-11 1-249-425-11 1-249-433-11 1-249-429-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
100K 4.7K 22K 10K 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W F
R868 R880 0 R888 R889 0 R898
1-249-409-11 1-249-402-11 1-219-718-11 1-249-441-11 1-219-718-11
CARBON CARBON METAL CARBON METAL
220 56 0.1 100K 0.1
5% 5% 10% 5% 10%
1/4W F 1/4W F 5W 1/4W 5W
R901 R902 R903 R904 R905
1-249-429-11 1-249-441-11 1-249-429-11 1-249-417-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
10K 100K 10K 1K 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W
R906 R907 R915 0 R916
1-247-807-31 1-247-807-31 1-249-397-11 1-215-915-11
CARBON CARBON CARBON METAL OXIDE
100 100 22 470
5% 5% 5% 5%
1/4W 1/4W 1/4W F 3W
< RELAY > RY401 RY402 RY403
1-515-920-11 RELAY 1-515-920-11 RELAY (24V) 1-515-920-11 RELAY (24V) < THERMISTOR >
TH831
1-807-796-11 THERMISTOR < TERMINAL >
TM401 TM402
1-537-925-62 TERMINAL BOARD (FRONT SPEAKER) 1-537-510-31 TERMINAL BOARD (SPEAKER) (6P) (SURROUND/CENTER SPEAKER)
****************************************************** A-4732-037-A PANEL FL BOARD, COMPLETE
********************** 4-225-511-01 HOLDER FL TUBE 4-949-935-41 CUSHION (FL) < CAPACITOR > C601 C602 C603 C604 C605
1-162-294-31 1-126-947-11 1-162-306-11 1-126-947-11 1-162-306-11
CERAMIC ELECT CERAMIC ELECT CERAMIC
0.001uF 47uF 0.01uF 47uF 0.01uF
10% 20% 30% 20% 30%
50V 16V 16V 16V 16V
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
79
HCD-XGV11AV PANEL FL Ref. No. C606 C607 C608 C614 C615
Part No. 1-126-963-11 1-164-159-11 1-164-159-11 1-126-157-11 1-126-964-11
Description ELECT CERAMIC CERAMIC ELECT ELECT
4.7uF 0.1uF 0.1uF 10uF 10uF
C616 C617 C618 C619 C620
1-162-303-11 1-164-159-11 1-164-159-11 1-126-157-11 1-162-306-11
CERAMIC CERAMIC CERAMIC ELECT CERAMIC
0.0033uF 30% 0.1uF 0.1uF 10uF 20% 0.01uF 30%
16V 50V 50V 16V 16V
C622 C623 C624 C625
1-126-960-11 1-126-960-11 1-126-947-11 1-126-964-11
ELECT ELECT ELECT ELECT
1uF 1uF 47uF 10uF
50V 50V 16V 50V
20%
20% 20%
20% 20% 20% 20%
Remarks 50V 50V 50V 16V 50V
< CONNECTOR > CN601 CN602
1-784-741-11 CONNECTOR, FFC 19P 1-784-780-11 CONNECTOR, FFC 19P < DIODE >
D601 D602
8-719-991-33 DIODE 1SS133T-77 8-719-058-04 DIODE SEL5223S-TP15 (=/1) < FLUORESCENT INDICATOR TUBE >
FL601
1-518-794-11 INDICATOR TUBE, FLUORESCENT < IC >
IC601 IC602 IC603
6-802-683-01 IC MB90M407APF-G-125-BND 8-759-826-34 IC NJL74H400A 8-759-083-77 IC BA3830F < COIL >
L603
1-410-517-11 INDUCTOR
47uH
< TRANSISTOR > Q601 Q602 Q603 Q604 Q605
8-729-029-86 8-729-620-05 8-729-140-04 8-729-620-05 8-729-140-04
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC124ESA 2SC2603-EF 2SB1116A-L 2SC2603-EF 2SB1116A-L
Q606 Q607 Q608 Q609
8-729-047-58 8-729-047-58 8-729-047-58 8-729-047-58
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC114TLTL2 DTC114TLTL2 DTC114TLTL2 DTC114TLTL2
< RESISTOR > R600 R601 R602 R603 R604
1-249-413-11 1-249-441-11 1-249-429-11 1-249-429-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
470 100K 10K 10K 10K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R605 R606 R607 R608 R609
1-247-807-31 1-249-429-11 1-249-429-11 1-249-413-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
100 10K 10K 470 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W
R610 R611 R612
1-247-807-31 CARBON 1-247-807-31 CARBON 1-249-431-11 CARBON
100 100 15K
5% 5% 5%
1/4W 1/4W 1/4W
Ref. No. R613 R614
Part No. Description 1-249-431-11 CARBON 1-249-431-11 CARBON
15K 15K
5% 5%
Remarks 1/4W 1/4W
R615 R616 R617 R618 R619
1-249-431-11 1-249-431-11 1-249-431-11 1-247-807-31 1-249-433-11
CARBON CARBON CARBON CARBON CARBON
15K 15K 15K 100 22K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R620 R621 R622 R623 R624
1-247-903-00 1-249-413-11 1-249-415-11 1-249-413-11 1-247-891-00
CARBON CARBON CARBON CARBON CARBON
1M 470 680 470 330K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W F 1/4W F 1/4W
R625 R626 R627 R628 R629
1-247-891-00 1-249-437-11 1-249-433-11 1-249-435-11 1-249-413-11
CARBON CARBON CARBON CARBON CARBON
330K 47K 22K 33K 470
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W F
R630 R631 R632 R633 R634
1-249-415-11 1-249-417-11 1-249-419-11 1-249-419-11 1-249-411-11
CARBON CARBON CARBON CARBON CARBON
680 1K 1.5K 1.5K 330
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R635 R637 R638 R639 R640
1-249-437-11 1-249-409-11 1-249-415-11 1-249-429-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
47K 220 680 10K 100K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W F 1/4W 1/4W
R643 R647 R665 R666 R667
1-249-401-11 1-249-413-11 1-249-441-11 1-249-441-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
47 470 100K 100K 100K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W 1/4W
R668 R681 R683 R684 R685
1-249-441-11 1-249-437-11 1-249-437-11 1-249-417-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
100K 47K 47K 1K 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W F
R686 R688 R689 R690 R691
1-249-437-11 1-249-437-11 1-249-417-11 1-249-417-11 1-249-413-11
CARBON CARBON CARBON CARBON CARBON
47K 47K 1K 1K 470
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W F
R692 R695 R696 R697
1-249-413-11 1-247-807-31 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON
470 100 100 100
5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W
F F F F
< SWITCH > S612 S613 S614 S615 S616
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (ILLUMINATION) SWITCH, KEYBOARD (c CLOCK SET) SWITCH, KEYBOARD (TIMER SELECT) SWITCH, KEYBOARD (SLEEP) SWITCH, KEYBOARD (FUNCTION)
S617 S618
1-762-875-21 SWITCH, KEYBOARD (=/1) 1-762-875-21 SWITCH, KEYBOARD (DISPLAY) < VIBRATOR >
80
X601
1-795-737-21 VIBRATOR, CERAMIC (4MHz)
******************************************************
HCD-XGV11AV PANEL VR Ref. No.
Part No. Description Remarks A-4732-062-A PANEL VR BOARD, COMPLETE (including MIC VR BOARD)
Ref. No. R721
Part No. Description 1-249-403-11 CARBON
************************
1-162-294-31 1-162-294-31 1-162-294-31 1-126-947-11 1-162-306-11
CERAMIC CERAMIC CERAMIC ELECT CERAMIC
RV801 RV802
C706 C707 C708
1-164-159-11 CERAMIC 1-162-306-11 CERAMIC 1-162-306-11 CERAMIC
0.001uF 0.001uF 0.001uF 47uF 0.01uF
68
5%
Remarks 1/4W F
< RELAY >
< CAPACITOR > C701 C702 C703 C704 C705
PROLOGIC
10% 10% 10% 20% 30%
50V 50V 50V 16V 16V
30% 30%
50V 16V 16V
1-225-739-11 RES, VAR CARBON 50K (MIC LEVEL) 1-225-739-11 RES, VAR CARBON 50K (ECHO LEVEL) < SWITCH >
S700 S701
1-473-392-11 ENCODER, ROTARY (VOLUME) 1-762-875-21 SWITCH, KEYBOARD (X-GROOVE)
****************************************************** 0.1uF 0.01uF 0.01uF
A-4732-081-A PROLOGIC BOARD, COMPLETE
**********************
< CONNECTOR > CN701 CN702
< CAPACITOR >
1-784-741-11 CONNECTOR, FFC 19P 1-563-616-11 CONNECTOR, FLEXIBLE 13P < DIODE >
D701 D702 D703 D704 D705
8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04
DIODE DIODE DIODE DIODE DIODE
SEL5223S-TP15 (VU 1) SEL5223S-TP15 (VU 2) SEL5223S-TP15 (VU 3) SEL5223S-TP15 (VU 4) SEL5223S-TP15 (VU 5)
D706 D707 D708 D709 D710
8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04
DIODE DIODE DIODE DIODE DIODE
SEL5223S-TP15 (VU 6) SEL5223S-TP15 (VU 7) SEL5223S-TP15 (VU 8) SEL5223S-TP15 (VU 9) SEL5223S-TP15 (VU 10)
D711 D712 D713 D714
8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04
DIODE DIODE DIODE DIODE
SEL5223S-TP15 (VU 11) SEL5223S-TP15 (VU 12) SEL5223S-TP15 (VU 13) SEL5223S-TP15 (VU 14)
< IC > IC701
8-759-373-50 IC NJU3719L < COIL >
L701
1-410-509-11 INDUCTOR
10uH
< RESISTOR > R701 R702 R703 R704 R705
1-249-429-11 1-247-807-31 1-247-807-31 1-247-807-31 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
10K 100 100 100 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W F
R706 R707 R708 R709 R710
1-249-417-11 1-249-415-11 1-249-403-11 1-249-403-11 1-249-403-11
CARBON CARBON CARBON CARBON CARBON
1K 680 68 68 68
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F F F F
R711 R712 R713 R714 R715
1-249-403-11 1-249-403-11 1-249-403-11 1-249-403-11 1-249-403-11
CARBON CARBON CARBON CARBON CARBON
68 68 68 68 68
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F F F F
R716 R717 R718 R719 R720
1-249-403-11 1-249-403-11 1-249-403-11 1-249-403-11 1-249-403-11
CARBON CARBON CARBON CARBON CARBON
68 68 68 68 68
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F F F F
C201 C202 C203 C204 C205
1-126-795-11 1-126-795-11 1-115-870-11 1-126-959-11 1-136-165-00
ELECT ELECT ELECT ELECT FILM
10uF 10uF 0.47uF 0.47uF 0.1uF
20% 20% 20% 20% 5%
50V 50V 50V 50V 50V
C206 C207 C208 C209 C210
1-136-165-00 1-126-959-11 1-126-959-11 1-126-959-11 1-126-959-11
FILM ELECT ELECT ELECT ELECT
0.1uF 0.47uF 0.47uF 0.47uF 0.47uF
5% 20% 20% 20% 20%
50V 50V 50V 50V 50V
C211 C212 C213 C214 C215
1-126-959-11 1-126-959-11 1-136-165-00 1-164-156-11 1-164-156-11
ELECT ELECT FILM CERAMIC CHIP CERAMIC CHIP
0.47uF 0.47uF 0.1uF 0.1uF 0.1uF
20% 20% 5%
50V 50V 50V 25V 25V
C216 C217 C218 C219 C220
1-126-960-11 1-130-479-00 1-130-471-00 1-136-165-00 1-136-169-00
ELECT MYLAR MYLAR FILM FILM
1uF 0.0047uF 0.001uF 0.1uF 0.22uF
20% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C221 C222 C223 C224 C225
1-136-169-00 1-136-165-00 1-130-479-00 1-130-471-00 1-115-871-11
FILM FILM MYLAR MYLAR ELECT
0.22uF 0.1uF 0.0047uF 0.001uF 1uF
5% 5% 5% 5% 20%
50V 50V 50V 50V 50V
C226 C227 C228 C229 C230
1-130-480-00 1-136-161-00 1-136-175-00 1-136-169-00 1-136-169-00
MYLAR FILM FILM FILM FILM
0.0056uF 0.047uF 0.68uF 0.22uF 0.22uF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C231 C232 C233 C234 C235
1-126-963-11 1-126-963-11 1-136-169-00 1-136-169-00 1-136-165-00
ELECT ELECT FILM FILM FILM
4.7uF 4.7uF 0.22uF 0.22uF 0.1uF
20% 20% 5% 5% 5%
50V 50V 50V 50V 50V
C236 C237 C238 C239 C240
1-136-161-00 1-136-161-00 1-136-165-00 1-136-165-00 1-136-157-00
FILM FILM FILM FILM FILM
0.047uF 0.047uF 0.1uF 0.1uF 0.022uF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C241 C242 C243 C244 C245
1-136-157-00 1-136-165-00 1-130-469-00 1-136-153-00 1-136-153-00
FILM FILM MYLAR FILM FILM
0.022uF 0.1uF 680PF 0.01uF 0.01uF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C246
1-130-469-00 MYLAR
680PF
5%
50V
81
HCD-XGV11AV PROLOGIC
SENSOR
SUB AMP
Ref. No. C247 C248 C249 C250
Part No. 1-136-153-00 1-136-153-00 1-126-947-11 1-130-481-00
Description FILM FILM ELECT MYLAR
0.01uF 0.01uF 47uF 0.0068uF
5% 5% 20% 5%
Remarks 50V 50V 16V 50V
C251 C252 C253 C255 C256
1-126-963-11 1-126-934-11 1-126-934-11 1-126-964-11 1-126-964-11
ELECT ELECT ELECT ELECT ELECT
4.7uF 220uF 220uF 10uF 10uF
20% 20% 20% 20% 20%
50V 16V 16V 50V 50V
C257 C258 C259 C260 C261
1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11
ELECT ELECT ELECT ELECT ELECT
10uF 10uF 10uF 10uF 10uF
20% 20% 20% 20% 20%
50V 50V 50V 50V 50V
C262 C264 C291 C292
1-126-964-11 1-162-964-11 1-162-974-11 1-162-974-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
10uF 0.001uF 0.01uF 0.01uF
20% 10%
50V 50V 50V 50V
Ref. No. R283 R291 R292 R293 R294
Part No. Description 1-216-833-11 METAL CHIP
10K
5%
Remarks 1/10W
1-216-825-11 1-216-845-11 1-216-833-11 1-216-821-11
2.2K 100K 10K 1K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
****************************************************** *
1-659-058-13 SENSOR BOARD
************ < IC > IC202
8-749-924-18 PHOTO INTERRUPTER RPI-1391 < RESISTOR >
R207
1-249-416-11 CARBON
820
5%
1/4W F
****************************************************** A-4732-075-A SUB AMP BOARD, COMPLETE
********************** < CONNECTOR > < CAPACITOR > CN201 CN202
1-766-797-11 CONNECTOR, BOARD TO BOARD 10P 1-766-797-11 CONNECTOR, BOARD TO BOARD 10P < DIODE >
D201
8-719-988-61 DIODE 1SS355TE-17 < FLUORESCENT INDICATOR TUBE >
FL201
1-233-289-21 FILTER, EMI (SMD) < IC >
IC201
8-759-571-51 IC M62464FP < COIL >
L201
1-412-032-11 INDUCTOR CHIP 100uH < TRANSISTOR >
Q271 Q281 Q291
8-729-141-30 TRANSISTOR 2SC3623A-LK 8-729-141-30 TRANSISTOR 2SC3623A-LK 8-729-141-30 TRANSISTOR 2SC3623A-LK < RESISTOR >
R201 R202 R203 R204 R205
1-216-809-11 1-216-809-11 1-216-817-11 1-216-851-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 470 330K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R206 R207 R208 R209 R210
1-216-847-11 1-218-892-11 1-216-841-11 1-216-847-11 1-218-892-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
150K 75K 47K 150K 75K
5% 0.5% 5% 5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R211 R212 R216 R217 R271
1-216-845-11 1-216-845-11 1-216-833-11 1-216-833-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 10K 10K 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R272 R273 R281 R282
1-216-845-11 1-216-833-11 1-216-825-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 10K 2.2K 100K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
C101 C102 C103 C104 C105
1-126-960-11 1-162-292-31 1-162-286-31 1-126-967-11 1-136-165-00
ELECT CERAMIC CERAMIC ELECT MYLAR
1uF 680PF 220PF 47uF 0.1uF
20% 10% 10% 20% 5%
50V 50V 50V 50V 50V
C106 C107 C108 C109 C113
1-136-165-00 1-126-968-11 1-136-495-11 1-136-495-11 1-162-306-11
MYLAR ELECT FILM FILM CERAMIC
0.1uF 100uF 0.068uF 0.068uF 0.01uF
5% 20% 5% 5% 30%
50V 50V 50V 50V 16V
C151 C152 C153 C154 C157
1-126-960-11 1-162-292-31 1-162-286-31 1-126-967-11 1-126-968-11
ELECT CERAMIC CERAMIC ELECT ELECT
1uF 680PF 220PF 47uF 100uF
20% 10% 10% 20% 20%
50V 50V 50V 50V 50V
C158 C159 C181 C182 C183
1-136-495-11 1-136-495-11 1-126-960-11 1-162-292-31 1-162-286-31
FILM FILM ELECT CERAMIC CERAMIC
0.068uF 0.068uF 1uF 680PF 220PF
5% 5% 20% 10% 10%
50V 50V 50V 50V 50V
C184 C188 C189
1-126-967-11 ELECT 1-136-495-11 FILM 1-136-495-11 FILM
47uF 0.068uF 0.068uF
20% 5% 5%
50V 50V 50V
< CONNECTOR > CN101 CN102
1-691-771-11 PLUG (MICRO CONNECTOR) 9P 1-691-766-11 PLUG (MICRO CONNECTOR) 4P < DIODE >
D101 D151 D191
8-719-991-33 DIODE 1SS133T-77 8-719-991-33 DIODE 1SS133T-77 8-719-991-33 DIODE 1SS133T-77 < IC >
IC101
8-749-017-20 IC STK443-070 < TRANSISTOR >
82
Q101 Q151 Q181
8-729-140-84 TRANSISTOR 2SC1841-PAFAEA 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
HCD-XGV11AV SUB AMP
SUB TRANS
Ref. No.
Part No.
Description < RESISTOR >
Remarks
R101 R102 R103 0 R107 0 R108
1-249-417-11 1-249-437-11 1-249-411-11 1-212-881-11 1-220-755-11
CARBON CARBON CARBON FUSIBLE METAL
1K 47K 330 100 0.22
5% 5% 5% 5% 10%
1/4W F 1/4W 1/4W 1/4W 2W
R109 R110 R111 R112 R113
1-260-076-11 1-249-437-11 1-249-417-11 1-249-431-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
10 47K 1K 15K 100K
5% 5% 5% 5% 5%
1/2W 1/4W 1/4W F 1/4W 1/4W
0 R120 0 R128 R130 0 R138 R151
1-217-637-00 1-220-755-11 1-249-429-11 1-220-755-11 1-249-417-11
FUSIBLE METAL CARBON METAL CARBON
1 0.22 10K 0.22 1K
5% 10% 5% 10% 5%
1/4W 2W 1/4W 2W 1/4W F
R152 R153 0 R157 0 R158 R159
1-249-437-11 1-249-410-11 1-212-881-11 1-220-755-11 1-260-076-11
CARBON CARBON FUSIBLE METAL CARBON
47K 270 100 0.22 10
5% 5% 5% 10% 5%
1/4W 1/4W F 1/4W 2W 1/2W
R160 R161 R162 R163 0 R168
1-249-437-11 1-249-417-11 1-249-431-11 1-249-441-11 1-220-755-11
CARBON CARBON CARBON CARBON METAL
47K 1K 15K 100K 0.22
5% 5% 5% 5% 10%
1/4W 1/4W F 1/4W 1/4W 2W
R181 R182 R183 0 R188 R189
1-249-417-11 1-249-437-11 1-249-411-11 1-220-755-11 1-260-076-11
CARBON CARBON CARBON METAL CARBON
1K 47K 330 0.22 10
5% 5% 5% 10% 5%
1/4W F 1/4W 1/4W 2W 1/2W
R190 R191 R192 R193
1-249-437-11 1-249-417-11 1-249-431-11 1-249-441-11
CARBON CARBON CARBON CARBON
47K 1K 15K 100K
5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W
Ref. No.
TC-A
TRANS
TUNER/TC-B
Part No. Description 1-687-256-11 TC-A BOARD
Remarks
********* < DIODE > D502 D503
8-719-058-03 DIODE SEL5423E-TP15 (h) 8-719-058-03 DIODE SEL5423E-TP15 (H) < RESISTOR >
R503 R504 R505 R506 R507
1-247-807-31 1-249-397-11 1-249-415-11 1-249-417-11 1-249-419-11
CARBON CARBON CARBON CARBON CARBON
100 22 680 1K 1.5K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R508 R509 R510
1-249-419-11 CARBON 1-249-419-11 CARBON 1-249-419-11 CARBON
1.5K 1.5K 1.5K
5% 5% 5%
1/4W F 1/4W F 1/4W F
F F F F
< SWITCH > S503 S504 S505 S506 S507
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (h) SWITCH, KEYBOARD (H) SWITCH, KEYBOARD (x) SWITCH, KEYBOARD (.m) SWITCH, KEYBOARD (M>)
S508
1-762-875-21 SWITCH, KEYBOARD (DIRECTION)
****************************************************** 1-687-270-11 TRANS BOARD
*********** 1-533-217-31 HOLDER, FUSE 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S < CAPACITOR >
******************************************************
C834 C893 C961 C963
1-137-749-11 1-137-749-11 1-162-306-11 1-162-306-11
MYLAR MYLAR CERAMIC CERAMIC
0.1uF 0.1uF 0.01uF 0.01uF
30% 30%
100V 100V 16V 16V
< CONNECTOR >
1-687-271-11 SUB TRANS BOARD
*************** < CONNECTOR > CN901 CN902
* CN951 * CN952
1-564-321-00 PIN, CONNECTOR(3.96MM PITCH)2P 1-568-106-11 PIN, CONNECTOR(3.96MM PITCH)4P
1-564-214-11 PIN, CONNECTOR(3.96MM PITCH)3P 1-564-526-11 PLUG, CONNECTOR 11P < DIODE >
D832
8-719-066-42 DIODE RBV1306
< DIODE > < RESISTOR > D901
8-719-991-33 DIODE 1SS133T-77 < RELAY >
0 RY901
1-755-467-11 RELAY (POWER)
0 R951 0 R952 0 R953
1-219-122-11 FUSEBLE 1-219-122-11 FUSEBLE 1-219-591-11 FUSEBLE
0.33 0.33 0.1
1/4W 1/4W 1/2W
******************************************************
< SWITCH >
A-4732-036-A TUNER/TC-B BOARD, COMPLETE
************************ 0 S901
1-786-055-21 SELECTOR, VOLTAGE (VOLTAGE SELECTOR) < DIODE > < TRANSFORMER >
0 T901
1-437-674-11 TRANSFORMER, POWER
******************************************************
D901 D903 D904
8-719-058-03 DIODE SEL5423E-TP15 (TUNER/BAND) 8-719-058-03 DIODE SEL5423E-TP15 (h) 8-719-058-03 DIODE SEL5423E-TP15 (H) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
83
HCD-XGV11AV TUNER/TC-B Ref. No. D905 D906
VIDEO
Part No. Description 8-719-057-97 DIODE SEL5923A-TP15 (X) 8-719-058-04 DIODE SEL5223S-TP15 (zREC)
Remarks
< RESISTOR >
Ref. No. C208 C209 C210 C211
Part No. 1-164-156-11 1-124-778-00 1-164-156-11 1-126-206-11
Description CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP
0.1uF 22uF 0.1uF 100uF
1-164-156-11 1-124-778-00 1-124-778-00 1-124-779-00 1-124-779-00
CERAMIC CHIP ELECT CHIP ELECT CHIP ELECT CHIP ELECT CHIP
0.1uF 22uF 22uF 10uF 10uF
20%
Remarks 25V 6.3V 25V 6.3V
20% 20% 20% 20%
25V 6.3V 6.3V 16V 16V
20%
R901 R903 R904 R905 R906
1-249-403-11 1-249-421-11 1-247-843-11 1-249-425-11 1-249-427-11
CARBON CARBON CARBON CARBON CARBON
68 2.2K 3.3K 4.7K 6.8K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F
C212 C213 C214 C221 C222
R907 R908 R909 R910 R911
1-249-429-11 1-249-431-11 1-249-433-11 1-249-435-11 1-249-403-11
CARBON CARBON CARBON CARBON CARBON
10K 15K 22K 33K 68
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W F
C223 C224 C253 C254 C255
1-126-206-11 1-164-156-11 1-216-864-11 1-164-156-11 1-164-156-11
ELECT CHIP CERAMIC CHIP METAL CHIP CERAMIC CHIP CERAMIC CHIP
100uF 0.1uF 0 0.1uF 0.1uF
20%
R912 R913 R914 R915 R916
1-249-403-11 1-247-807-31 1-249-397-11 1-249-415-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
68 100 22 680 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
C257 C258 C259 C321 C322
1-128-065-11 1-164-156-11 1-126-206-11 1-162-919-11 1-162-917-11
ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP
68uF 0.1uF 100uF 22PF 15PF
20%
R917 R918 R919 R920
1-249-419-11 1-249-419-11 1-249-421-11 1-247-843-11
CARBON CARBON CARBON CARBON
1.5K 1.5K 2.2K 3.3K
5% 5% 5% 5%
1/4W F 1/4W F 1/4W F 1/4W
C323 C338 C360 C361 C364
1-162-915-11 1-164-156-11 1-126-206-11 1-164-156-11 1-124-779-00
CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP
10PF 0.1uF 100uF 0.1uF 10uF
C365 C366 C501 C502 C503
1-126-206-11 1-126-206-11 1-124-779-00 1-164-156-11 1-164-156-11
ELECT CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP
100uF 100uF 10uF 0.1uF 0.1uF
C504 C505 C510 C511 C513
1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-162-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 0.1uF 0.001uF
C521 C522 C523 C524 C525
1-164-156-11 1-162-912-11 1-162-912-11 1-164-156-11 1-126-193-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0.1uF 7PF 7PF 0.1uF 1uF
20%
25V 50V 50V 25V 50V
C533 C534 C535 C536 C537
1-164-156-11 1-164-315-11 1-110-563-11 1-164-217-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 470PF 0.068uF 150PF 100PF
5% 10% 5% 5%
25V 50V 16V 50V 50V
C538 C539 C540 C541 C542
1-126-206-11 1-117-863-11 1-164-156-11 1-162-974-11 1-164-156-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100uF 0.47uF 0.1uF 0.01uF 0.1uF
20% 10%
6.3V 6.3V 25V 50V 25V
C543 C544 C545 C546 C547
1-164-315-11 1-117-863-11 1-126-193-11 1-164-156-11 1-126-193-11
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT
470PF 0.47uF 1uF 0.1uF 1uF
5% 10% 20%
50V 6.3V 50V 25V 50V
C548 C549 C550 C551 C552
1-164-156-11 1-162-913-11 1-162-913-11 1-164-156-11 1-126-193-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0.1uF 8PF 8PF 0.1uF 1uF
25V 0.50PF 50V 0.50PF 50V 25V 20% 50V
C561 C566
1-164-156-11 CERAMIC CHIP 1-126-206-11 ELECT CHIP
0.1uF 100uF
20%
F F
F F F F
5%
20% 5% 5% 0.5PF 20% 20%
6.3V 25V 1/10W 25V 25V 10V 25V 6.3V 50V 50V 50V 25V 6.3V 25V 16V
< SWITCH > S901 S902 S903 S904 S905
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (TUNER/BAND) SWITCH, KEYBOARD (TUNING -) SWITCH, KEYBOARD (TUNING +) SWITCH, KEYBOARD (MEMORY) SWITCH, KEYBOARD (FM MODE)
S906 S907 S908 S909 S910
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (ENTER) SWITCH, KEYBOARD (TUNING MODE) SWITCH, KEYBOARD (h) SWITCH, KEYBOARD (H) SWITCH, KEYBOARD (X)
S911 S912 S913 S914 S915
1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (x) SWITCH, KEYBOARD (M>) SWITCH, KEYBOARD (.m) SWITCH, KEYBOARD (z REC) SWITCH, KEYBOARD (CD SYNC)
****************************************************** A-4748-118-A VIDEO BOARD, COMPLETE
********************
20% 20% 20%
10%
0.5PF 0.5PF
6.3V 6.3V 16V 25V 25V 25V 25V 25V 25V 50V
< CAPACITOR > C104 C105 C106 C114 C115
1-124-778-00 1-162-968-11 1-164-670-11 1-124-778-00 1-164-156-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
22uF 0.0047uF 1200PF 22uF 0.1uF
20% 10% 5% 20%
6.3V 50V 16V 6.3V 25V
C116 C154 C155 C156 C201
1-126-206-11 1-124-778-00 1-162-968-11 1-164-670-11 1-124-778-00
ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP
100uF 22uF 0.0047uF 1200PF 22uF
20% 20% 10% 5% 20%
6.3V 6.3V 50V 16V 6.3V
C202 C203 C204 C205 C206
1-164-156-11 1-126-206-11 1-164-156-11 1-164-156-11 1-164-156-11
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 100uF 0.1uF 0.1uF 0.1uF
C207
1-164-156-11 CERAMIC CHIP
0.1uF
84
20%
25V 6.3V 25V 25V 25V 25V
20%
25V 6.3V
HCD-XGV11AV VIDEO Ref. No. C567 C570 C571
Part No. 1-164-156-11 1-162-967-11 1-164-156-11
Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.0033uF 10% 0.1uF
Remarks 25V 50V 25V
C572 C573 C574 C575 C576
1-164-156-11 1-164-156-11 1-164-156-11 1-126-206-11 1-126-206-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP
0.1uF 0.1uF 0.1uF 100uF 100uF
25V 25V 25V 6.3V 6.3V
Part No.
Description < RESISTOR >
R102 R107 R108 R109 R114
1-216-809-11 1-216-833-11 1-216-823-11 1-216-823-11 1-216-825-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 10K 1.5K 1.5K 2.2K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R115 R152 R157 R158 R159
1-216-825-11 1-216-809-11 1-216-833-11 1-216-823-11 1-216-823-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 100 10K 1.5K 1.5K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C581 C582 C583 C584 C596
1-164-156-11 1-124-779-00 1-164-156-11 1-164-156-11 1-124-779-00
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP
0.1uF 10uF 0.1uF 0.1uF 10uF
R201 R202 R321 R322 R323
1-216-809-11 1-216-809-11 1-216-813-11 1-216-864-11 1-216-817-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 220 0 470
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
C597
1-124-779-00 ELECT CHIP
< FERRITE BEAD >
R375 R376 R502 R503 R504
1-211-990-11 1-216-833-11 1-216-827-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
75 10K 3.3K 100 100
0.5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
10uF
20% 20%
20%
25V 16V 25V 25V 16V
20%
16V
20%
< CONNECTOR > CN101 CN201 CN301
1-784-327-21 CONNECTOR, FFC/FPC 28P 1-778-874-11 CONNECTOR,FFC(LIF(NON-ZIF))19P 1-794-509-11 PIN, CONNECTOR (PC BOARD) (3P)
Ref. No.
Remarks
FB201 FB251 FB252 FB360 FB501
1-469-869-21 1-469-869-21 1-469-869-21 1-469-869-21 1-469-869-21
FERRITE FERRITE FERRITE FERRITE FERRITE
0uH 0uH 0uH 0uH 0uH
R505 R506 R507 R508 R509
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
FB502 FB503 FB504 FB561
1-469-869-21 1-469-869-21 1-469-869-21 1-469-869-21
FERRITE FERRITE FERRITE FERRITE
0uH 0uH 0uH 0uH
R510 R511 R512 R513 R516
1-216-809-11 1-216-809-11 1-216-809-11 1-216-833-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 10K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R517 R522 R531 R532 R533
1-216-826-11 1-216-833-11 1-216-845-11 1-216-829-11 1-216-839-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.7K 10K 100K 4.7K 33K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R534 R537 R538 R541 R542
1-216-864-11 1-216-864-11 1-216-833-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
0 0 10K 0 0
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R543 R544 R545 R546 R547
1-216-853-11 1-216-857-11 1-216-821-11 1-216-848-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470K 1M 1K 180K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R548 R549 R550 R551 R552
1-216-855-11 1-216-845-11 1-216-833-11 1-218-852-11 1-216-820-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
680K 100K 10K 1.6K 820
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R554 R555 R556 R557 R558
1-216-797-11 1-216-797-11 1-216-797-11 1-216-797-11 1-216-857-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10 10 10 10 1M
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R559 R561 R581 R582
1-216-817-11 1-216-821-11 1-216-809-11 1-216-817-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 1K 100 470
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
< FILTER > FL201 FL501 FL502 FL503 FL504
1-234-177-21 1-234-177-21 1-234-177-21 1-234-177-21 1-234-177-21
FERRITE FERRITE FERRITE FERRITE FERRITE
0uH 0uH 0uH 0uH 0uH
< IC > IC102 IC201 IC202 IC307 IC504
8-759-701-40 6-700-399-01 8-759-460-72 6-702-001-01 8-759-825-13
IC IC IC IC IC
NJM2100M(TE2) uPC2925T-E1 BA033FP-E2 BD7600FV-E2 PCM1748E/2K
IC505 IC506 IC507 IC508
8-752-417-93 6-702-000-01 6-702-571-01 6-803-237-01
IC IC IC IC
CXD1887R BU2507FV-E2 VG3612816BT-7L MR27V401E-0F3MAZ060
< JUMPER WIRE > JW203
1-216-864-11 METAL CHIP
0
5%
< COIL > L102 L321
1-410-373-31 INDUCTOR 2.2uH 1-410-381-11 INDUCTOR CHIP 10uH
1/10W
< TRANSISTOR > Q201 Q301 Q370 Q581
8-729-140-75 8-729-602-36 8-729-028-96 8-729-602-21
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SD999-CLCK 2SA1602-F DTC114EUA-T106 2SC4154-F
85
HCD-XGV11AV VIDEO Ref. No.
X501 X502
Part No.
Description < VIBRATOR >
Remarks
Ref. No.
Part No.
Description
1-767-518-11 VIBRATOR, CRYSTAL (33.8688MMHz) 1-767-519-11 VIBRATOR, CRYSTAL (27MHz)
****************************************************** MISCELLANEOUS
************* 0 4 5 67 111
1-569-008-22 1-693-603-41 1-769-945-11 1-773-114-11 1-773-108-11
ADAPTOR, CONVERSION 2P TUNER (FM/AM) WIRE (FLAT TYPE) (11 CORE) WIRE (FLAT TYPE) (19 CORE) (150mm) WIRE (FLAT TYPE) (19 CORE) (100mm)
112 126 127 151 0 156
1-769-977-11 1-769-986-11 1-796-487-31 1-925-122-81 1-777-071-53
WIRE (FLAT TYPE) (13 CORE) (150mm) WIRE (FLAT TYPE) (13 CORE) (270mm) DECK, MECHANICAL (CWM43RR23) WIRE (FLAT TYPE) (28 CORE) CORD, POWER
164 0 551 555 0 F951 0 F961
1-925-122-71 A-4735-189-A 1-782-817-11 1-532-506-31 1-533-949-31
WIRE (FLAT TYPE) (19 CORE) OP ASSY (A-MAX.3) WIRE (FLAT TYPE) (16 CORE) FUSE (T6.3A/250V) FUSE, CYLINDRICAL (TIME LUG) (T8.0A/250V)
0 F962 0 F963 0 F964 FL601 M201
1-533-949-31 1-532-506-31 1-532-506-31 1-518-794-11 A-4660-977-A
FUSE, CYLINDRICAL (TIME LUG) (T8.0A/250V) FUSE (T6.3A/250V) FUSE (T6.3A/250V) INDICATOR TUBE, FLUORESCENT MOTOR ASSY
M901 0 T951
1-763-072-11 FAN, DC 1-439-875-11 TRANSFORMER, POWER
86
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Remarks
HCD-XGV11AV
MEMO
87
HCD-XGV11AV
REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver.
Date
1.0
2003.05
Description of Revision New
