Transcript
FRYMASTER HLZ 18/HLZ 22 Heated Landing Zone
HLZ 18/ HLZ 22 Heated Landing Zone
Interior Parts ➤ NOTE: Burger Bumpers are not used on units built after 10/98.
ITEM NO.
PART NO.
1
807-0979 Transformer, 208v/240v/12v
2A
807-2945 Air Heater, 208v Only
2B
807-3011 Air Heater, 240v Only
3
900-8073 Shield, HLZ Heater
4
807-3036 Air RTD Probe
5
900-8086 Bracket, RTD/Thermocouple
6
823-2741 Delivery Air Back W/A
7
807-3043 Air Thermocouple
8A
806-9238 HLZ 22 Plate, Heater with RTD
DESCRIPTION
8B
806-9239 HLZ 18 Plate, Heater with RTD and Thermocouple, 208/240V (22" x 12")
224
PART NO.
9
806-9146 Plug Assembly, Computer
10
826-1508 Relay, Solid State Service Kit
11
807-3021 Relay, Latching
12
807-2953 Blower, 208v/240v
13
807-2820 Fuse Block
14
807-2819 Fuse, 20A
15
DESCRIPTION
807-3020 Cord Set, Twist Lock, HLZ 811-0511 RTV#108 Silicone Rubber 816-0418 Gasket, HLZ Plate/Cowl 810-1724 Filter Screen 811-0953 Acrylic Tape, Double-Sided 806-9247 Computer Assembly, HLZ
and Thermocouple, 208v/240v (22" x 15.5")
ITEM NO.
823-2745 Cowl Assembly 809-0448 Cowl Tinnerman Clips 823-2742 Front Delivery Air W/A 807-2972 Lug, Grounding 14 GA 816-0410 Pad, HLZ Leg
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
Universal Holding Cabinet (UHC)
Universal Holding Cabinet (UHC)
Universal Holding Cabinet ITEM NO.
PART NO.
DESCRIPTION
1
806-8162SP
Bottom Pan Assembly
ITEM NO.
PART NO.
DESCRIPTION
2
806-7904
Pan Base
13
816-0265
Bushing .75 ID Snap-In (4 qty.)
3
See pg 108
Slot Assembly (4 qty.)
14
4
910-4876
Cabinet Side, 4-Slot Unit (2 qty.)
4
106-0266
Cabinet Side, 2-Slot Unit (2 qty.)
5
900-4880SP
Inner Panel, 4-Slot Unit (2 qty.)
5
900-9453
6
910-4875
6 7
910-4876
Cabinet Side, 4-Slot Unit (2 qty.)
106-0266
Cabinet Side, 2-Slot Unit (2 qty.)
15
See pg 106
Shelf Assembly
16
807-3238
Power Cord Strain Relief
Inner Panel, 2-Slot Unit
17
823-2375
Rear Fascia
Vertical Support, 4-Slot Unit (4 qty.)
18
807-2473
Pin & Sleeve Power Cord, 12-1/2'
910-9451
Vertical Support, 2-Slot Unit (4 qty.)
18
807-2474
Twist Lock Power Cord, 12-1/2'
807-2444E
Display Driver (4 qty.)
19
902-4882
Right Bracket (2 qty.)
8
816-0267
Driver Board Cover, 4-Slot Unit
19
902-4882
Left Bracket (2 qty.)
8
816-0506
Driver Board Cover, 2-Slot Unit
20
816-0262
VHB Tape, 3.75 x 1" (4 qty.)
807-2448
Driver Board AC/Data Harness, 4-Slot Unit
21
806-7906
Top Cap Assembly
807-3413
Driver Board AC Harness, 2-Slot Unit
22
210-0047
Cord Support Bracket
807-3414
Driver Board Data Harness, 2-Slot Unit
900-5217
Air Flow Closure
806-0618
Button Hanger (8 qty.)
900-5218
Full Baffle
9
806-0256
Button Hanger Nut (8 qty.)
901-5219
Left Baffle
10
807-3308
On/Off Switch
902-5219
Right Baffle
11
806-8654SP
Front Fascia
826-1288
Leg Kit (4 qty.)
12
900-4946
Slide Bracket (2 qty.)
809-0428
Leg Plate Mounting Screws (16 qty.)
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
225
FRYMASTER Universal Holding Cabinet (UHC)
5 14
15
6 9
7
16
1
2
12
4
13
3
11
226
Domestic Component Shelf
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
8
809-0094
Screw, 6-32 x 3/8 (2 qty.)
DESCRIPTION
9
826-1366
Nut, Hex Keps (2 qty.)
1
807-0263
Connector, Terminal (2 qty.)
10
809-0250
#6-32
2
807-2443
Motherboard
11
809-0360
Screw, #8 x 3/4 (4 qty.)
826-1529
Alarm Buzzer Kit
12
809-0580
Circuit Board Stand Off (5 qty.)
3
807-2460
Transformer
13
809-0607
Screw, #8 x 2 (4 qty.)
4
807-2665
Exhaust Blower (2 qty.)
14
809-0675
Screw, 4-40 x 1/2 (2 qty.)
5
807-2812
Terminal Block
15
812-1306
Metal Oxide Varistor
6
807-2819
Fuse, 20 Amp (2 qty.)
16
900-5511
Equipment Shelf
7
807-2820
Fuse Block
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
3
Universal Holding Cabinet (UHC)
2
1
C.E. Components ITEM NO.
PART NO.
DESCRIPTION
1
807-2767
Bead Shield, CE Only
2
807-2766
Power Line Filter, CE Only
3
807-2769
Power Transformer, CE Only
2
3
1
Pre-1997 Components ITEM NO.
PART NO.
DESCRIPTION
1
807-2278
20-Amp Fuse (2 qty.)
2
807-2447
Fuse Holder
3
807-2462
Terminal Block (2 qty.)
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
227
FRYMASTER Universal Holding Cabinet (UHC) 228
1
4
11
10
3
8 2
7 9 6
5
Slot Assembly
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
6
809-0610
Washer, #8 (4 qty.)
DESCRIPTION
7
809-0612
Screw, #8-32 x 3/16 (8 qty.)
1
807-2880
Heater Plate (Includes RTD) (2 qty.)
8
810-1286
Spacer (2 qty.)
1
807-2906
Heater Plate CSA (2 qty.)
9
816-0239
Slot Bezel (2 qty.)
2
807-3309
Front Slot Display Pre 9703
10
900-5109
Display Bracket (2 qty.)
3
807-3310
Rear Slot Display
11
4
809-0593
Screw, Set #6 x 1/2 (8 qty.)
5
809-0609
Screw, Set #8 x 3/8 Phillips (8 qty.)
900-5234
Bezel Support Bracket (2 qty.)
816-0243
Insulation
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
VT Series Vertical Toaster
VT Series Vertical Toaster
Cabinetry Components
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
4
823-2759
Component Box
DESCRIPTION
5
824-0767
Pan, Holding
1
823-2758
Panel, Back
6
900-8173
Panel Bottom
2
910-8602
Panel, Side
7
816-0406
Seal, Base
3
810-1662
Knob, Compression
8
823-2738
Feeder, Bun
Adjustment (Silver Face)
9
823-2746
Cover
Knob, Compression
10
810-1683
Handle
3
810-1692
Adjustment (Blue Face)
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
229
FRYMASTER VT Series Vertical Toaster 230
Component Box
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
7
810-1670
Chain, Drive
DESCRIPTION
8
810-1690
Sprocket, Idler
1
807-3040
Cordset, Pin and Sleeve
9
810-1728
Sprocket, Roller
807-3119
Cordset, Standard Twist and Lock
10
807-3196
Heater, Cartridge
807-3198
Cordset, Hooded Twist and Lock
11
806-9296
Computer
2
807-3021
Relay, 30A, 12VDC
12
806-9542
Switch, Cover Interlock
3
807-0979
Transformer, 208/240VAC - 12VAC
13
807-2813
Motor, 208/240VAC Drive
4
807-3131
Relay, 5A, Solid State
14
5
807-2751
Relay, 50A, 208/240VAC
6
810-1629
Sprocket, Drive
807-2937
Heater, Adhesive-Backed Holding Tray
807-3132
Probe, Holding Tray Heater
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER VT Series Vertical Toaster
Dual Belt Conveyor Assembly
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
11
810-1699
Washer, Wave
DESCRIPTION
12
809-0647
Retainer, E-Ring Clip
1
816-0389
Belt, Dual Conveyor
13
806-9318
Roller, Drive
2
809-0723
Retainer, Cotter Pin
14
810-1525
Bushing, .375 x .500
3
810-1718
Shaft, Idler Roller
15
810-1672
Spring Pressure Plate
4
810-1729
Retainer, Hairpin Clip
16
823-2720
Pressure Plate, Crown
5
806-9200
Roller, Idler
17
823-2719
Pressure Plate, Heel
6
823-2798
Cover, Spring
18
823-2723
Short (Heel Compression)
7
810-1661
Spring, Roller Extension
8
910-8580
Latch, Conveyor Stabilizing
19
823-2722
9
810-1738
Washer, Shoulder
10
809-0132
Screw, Conveyor Stabilizing Latch
NO ONE WORKS HARDER TO KEEP YOU COOKING.
Cam Assembly Long (Crown Compression) Cam Assembly
❘
WHALEY FOODSERVICE REPAIRS
231
FRYMASTER VT Series Vertical Toaster Cooking Conveyor Assembly
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
10
810-1525
Bushing, .375 x .500
DESCRIPTION
11
910-8246
Crumb Shield, Upper
1
816-0379
Belt, Cooking Conveyor
12
910-8166
Crumb Shield, Lower
Platen Assembly
2
232
13
910-8245
Brace, Lower Tray
3
810-1658
Platen
14
823-2764
Tray, Platen
4
910-8327
Retainer, Heater Probe
15
810-1661
Spring, Roller Extension
5
807-3066
Probe, Heater
16
823-2726
Slide, Weld Assembly
6
807-3037
Thermostat, High-Limit
17
816-0403
Insulation, Platen
7
809-0647
Retainer, E-Ring Clip
18
810-1736
Plug, Probe Access Opening
8
806-9195
Roller, Idler
9
806-9199
Roller, Drive
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
GF14/GF40 Gas Fryer
GF14/GF40 Gas Fryer
GF14 Burner Assembly
ITEM NO.
PART NO.
ITEM NO.
PART NO.
7
810-0703
1
806-3960
DESCRIPTION Burner and Control Assembly,
806-3961
Burner and Control Assembly,
8
810-0426
823-1023
Burner Manifold Only
3
807-1603
Honeywell Gas Valve,
3
807-1604
3
807-0115
MV Natural Gas, Series AE
8
810-0427
807-0755
Pilot Burner, ITT262A38, LP Gas, without Pilot Generator
8
810-0615
Pilot Burner, ITT262A38, Nat., with Pilot Generator, Series AE
8
810-0616
Honeywell Gas Valve,
Pilot Burner, ITT262A38, LP, with Pilot Generator, Series AE
MV LP Gas, Series AE
9
900-1032
Pilot Mounting Bracket
Unitrol Gas Valve,
10
809-0092
Screw, Pilot Burner Mounting
MV, LP Gas, Prior to Series AE 3
Pilot Burner, ITT262A38, Natural Gas, without Pilot Generator
LP Gas, Series AE 2
Pilot Tubing 19-1/2" (7.68 cm), Gas Valve to Pilot
Natural Gas, Series AE 1
DESCRIPTION
809-0115
Screw, Pilot Mounting Bracket to Manifold
Unitrol Gas Valve,
11
910-1082
Flame Deflector Bracket, Sides
MV, Natural Gas, Prior to Series AE
12
810-0496
Burner Orifice, #52 (1.65 mm), Natural Gas
810-0109
Knob, Gas Valve, Prior to Series AE
12
810-0134
Burner Orifice, #58 (1.07 mm), LP Gas
807-0347
Wire Terminal for Pilot Magnet Pin,
13
810-0149
Pilot Orifice, TJ.024, Natural Gas
Prior to Series AE
13
810-0148
Pilot Orifice, TJ.013, LP Gas
4
813-0154
Plug, Pressure Test Port, 1/8 NPT
14
809-0256
Burner Mounting Nut
5
810-0691
Vent Tube, 1/8" (3.17 mm)
15
806-3605
Ceramic Target & Deflector Bracket,
6
810-0617-1 Pilot Generator (Thermopile), Series AE with Honeywell Valve
16
910-1465
Deflector Bracket, Rear Only
Pilot Generator (Thermopile), Prior to
17
810-0424
Ceramic Target, Rear
Series AE with Unitrol Valve
18
806-3962
Burner Gas Line, Front to Back
19
809-0043
Clamp, Burner Gas Line
810-0617
NO ONE WORKS HARDER TO KEEP YOU COOKING.
Rear Only
❘
WHALEY FOODSERVICE REPAIRS
233
FRYMASTER GF14/GF40 Gas Fryer Fry Pot Assembly
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
5
806-4006
Combustion Chamber Front
DESCRIPTION
1
806-3958
Fry Pot Assembly Complete, SS,
6
806-4145
Drain Valve, 1-1/4" (31.7 mm)
Combustion Chamber, Flue,
7
810-0662
Drain Valve Handle
and Insulation
8
900-1090
Pilot Hole Cover
Fry Pot Assembly Complete,
9
8261177
Thermostat, Hi-Limit
CR Steel, Combustion Chamber,
9
8071692
Thermostat
Flue, and Insulation
10
813-0343
Thermostat Bulb Adapter Fitting
812-0142
Cabinet Rear Insulation
11
813-0156
Pipe Plug
826-0934
Fry Pot Insulation Kit, Complete
1
3
806-3959
823-1024
with Insulation
Flue Assembly and Rear Combustion Chamber
4
806-4005
Combustion Chamber Side with Insulation, Left or Right
234
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
H50 Series Gas Fryer
H50 Series Gas Fryer
Burner Ignition System Components and Associated Hardware
ITEM NO.
PART NO.
DESCRIPTION
10
—
Orifice
812-1137 1.95 mm Propane/Butane (G30, G31)
ITEM NO.
PART NO.
DESCRIPTION
1
8071006
Ignition Module, Full and Dual Vat
(0-4999',0-1524 M) (CE) 810-1221 2.00 mm Propane/Butane
(Original Design, with Fuse) 2
8073366
(0-4999', 0-1524 M) (Japan)
Ignition Module, Full Vat
810-0386 2.10 mm Propane/Butane
(New Design, without Fuse) 3
8073365
(0-4999', 0-1524 M)
Ignition Module, Dual Vat
810-0413 2.16 mm Propane/Butane (G30, G31)
(New Design, without Fuse) 4
(5000-6999', 1525-2133 M)
Ignition Cable (with Two 90° Connectors,
812-1028 2.20 mm Propane/Butane (G30, G31)
used with Item 1 Only)
(7000-10,999', 2134-3352 M)
807-1878 19" Long
812-1134 3.10 mm Natural Gas (G20, G25)
807-1200 27" Long 5
0-4999', 0-1524 M) (Japan)
807-3367 Ignition Cable (with One 90° Connector,
810-0403 3.40 mm Natural Gas (G20, G25)
Used with Items 2 and 3 Only) 6
806-6085 Wiring Assembly, Igniter
7
806-6084 Wiring Assembly Ignition Module
8
807-2263 Switch, Air Pressure (Use 807-2262 in
(0-4999', 0-1524 M) 810-0437 3.60 mm Natural Gas (G20, G25) (5000-6999', 1525-2133 M) 812-1144 3.65 mm Natural Gas (G20, G25)
Units with 100 VAC Power Supply) 9
(7000-8999', 2134-2743 M)
Igniter and Gasket Kit
812-1145 3.70 mm Natural Gas (G20, G25)
826-0981 Natural Gas (G20, G25)
(9000-10,999', 2744-3352 M)
826-0982 Propane/Butane (G30, G31)
810-0642 5.95 mm Manufactured Gas
826-1002 Manufactured Gas
(0-4999', 0-1524 M) 826-1196 Conversion Kit, Natural Gas (G20, G25) to Propane/Butane (G30, G31) 826-1197
Conversion Kit, Propane/Butane (G30, G31) to Natural Gas (G20, G25)
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
235
FRYMASTER H50 Series Gas Fryer Component Box Assemblies and Associated Component Parts
ITEM NO.
PART NO.
9
816-0217 Paper, Insulating (Items 9, 10, 11, 12
10
810-1164 Block, Terminal (See Item 9)
11
809-0354 Screw, 4-40 x 3/4"
Not Used on Hong Kong Units)
ITEM NO.
PART NO.
1
806-9849 Box Assembly, One-Piece Component
2
807-1006 Ignition Module, Full or Dual Vat
DESCRIPTION
(Fuse-Protected) 807-2971 Ignition Module, Full or Dual Vat
Slotted Round Head (See Item 9) 12
809-0237 Nut, 4-40 Keps Hex (See Item 9)
13
807-1241 Spacer, Interface Board
(Fuse-Protected) (Australian Units Only)
(.151" ID x 5/8")
3
807-3366 Ignition Module, Full Vat (Unfused)
14
809-0250 Nut, 6-32 Keps Hex
4
807-3365 Ignition Module, Dual Vat (Unfused)
15
807-0037 Tab, Push-On Terminal
5
807-0833 Relay, 12v 5 Amp Latch
16
809-0446 Spacer, Ignition Module (.260" ID x 1/2")
6
806-3398 Interface Board (Single Fuse-Protected)
17
809-0441 Screw, #7 x 1/4"
(Use with 807-1006 Only) 7
Slotted Washer Hex Head
106-0386 Interface Board (Double Fuse-Protected)
806-3660 Sound Device (for Units with KFC1
(Use with 807-3365 or 807-3366) 806-4973 Interface Board (Used with 240v
Computers, use Speaker 807-1617) 807-1359 Mount, Tie-Wrap
Manufactured Gas Units Only) 8
236
DESCRIPTION
(Used on CE Units Only)
807-1926 Bushing, .875 Diameter Split
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
➤ NOTE: All insulation and gaskets can be ordered in a single kit, P/N 826-0929
H50 Series Gas Fryer
FRYPOT ASSEMBLY, FULL VAT (806-3875SP, 806-3876SP, 806-3884SP, 806-4787SP, 806-4789SP, 806-5391)
Full Vat Fry Pot Assembly, with Power Shower, Component Parts
ITEM NO.
PART NO.
DESCRIPTION
21
812-1029
Insulation, Combustion Chamber Side
22
900-4452
23
812-0706
(for Left and Right)
ITEM NO.
PART NO.
DESCRIPTION
1
823-0969
Plenum, Full Vat (Non-CE Units)
1
823-1048
Plenum, Full Vat (CE Units)
2
816-0057
Gasket, Plenum Chamber
3
900-1049
Retainer, Plenum Chamber Gasket
Retainer, Combustion Chamber Side Insulation (for Left and Right) Insulation, Upper Burner Rail (for Left and Right)
823-1777SP
Burner Rail, Left
4
810-0500
Spacer, 1/4" x 15/16" Long
24
823-17771SP Burner Rail, Right
5
823-11691
Combustion Chamber Outer Front, Left
25a
826-1072
25b
826-1073 812-0357
6
812-0661
Insulation, Combustion Chamber, Outer
7
823-1169
Combustion Chamber Outer Front, Right
Burner, Natural or Propane Gas (for Left or Right) Burner, Manufactured Gas
8
900-1031
Retainer, Sight Glass, 3/4"
9
812-0356
Insulation, Sight Glass Gasket
25c
10
814-0048
Sight Glass
26a
Fry Pot Assembly, Full Vat, with Three Holes
11
826-1340
Spacer, 1/4" x 1-3/16" Long
26b
Fry Pot Assembly, Full Vat, with Four Holes
12
900-1210
Retainer, Lower Front Insulation, Left
27
812-0355
Insulation, Lower Rear
13
900-1211
Retainer, Lower Front Insulation, Right
28
900-1223
Back, Combustion Chamber, Right
14
812-0457
Insulation, Lower Front
29
900-1222
Back, Combustion Chamber, Left
15
900-3742
Retainer, Upper Front Insulation
30
900-1221
Retainer, Rear Insulation and
812-0353
Insulation, Upper Front
824-0157
Retainer, Left Front Seal Insulation
31
810-0406
16
(for Left or Right) Insulation, Burner
Combustion Chamber Back Spacer, 1/4" x 1.625" Long
17
824-0158
Retainer, Right Front Seal Insulation
32
930-0818
Bracket, Flue to Fry Pot Connection
18
812-0404
Insulation, Front Seal (for Left and Right)
33
806-5859SP
Flue Assembly, Full Vat
19
900-1515
Brace, Upper Oil Zone Insulation
20
812-0993
Insulation, Upper Oil Zone
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
237
FRYMASTER H50 Series Gas Fryer Dual Vat Fry Pot with Power Shower Component Parts
PART NO.
DESCRIPTION
19
812-1029
Insulation, Combustion Chamber Side
20
900-4452
21
812-0706
(for Left and Right)
ITEM NO.
PART NO.
DESCRIPTION
1
823-0970
Plenum, Dual Vat (Non-CE Units)
1
823-2181
Plenum, Dual Vat (CE Units)
2
816-0057
Gasket, Plenum Chamber
3
900-1049
Retainer, Plenum Chamber Gasket
Retainer, Combustion Chamber Side Insulation (for Left and Right) Insulation, Upper Burner Rail (for Left and Right)
823-2822SP
Burner Rail, Left
4
810-0500
Spacer, 1/4" x 15/16" Long
22
823-2823SP
Burner Rail, Right
5
823-0968
Combustion Chamber Outer Front
23a
826-1072
Burner, Natural or Propane Gas
6
812-0456
Insulation, Combustion Chamber, Outer
7
900-1031
Retainer, Sight Glass, 3/4"
23b
826-1073
8
812-0356
Insulation, Sight Glass Gasket
9
814-0048
Sight Glass
23c
812-0357
10
810-0476
Spacer, 1/4" x 1-3/16" Long
24a
11
823-0983
Retainer, Lower Front Insulation
12
812-0456
Insulation, Lower Front
13
930-3628
Retainer, Upper Front Insulation
812-0352
Insulation, Upper Front
25
812-0354
Insulation, Lower Rear
824-0159
Retainer, Left Front Seal Insulation
26
930-0789
Back, Combustion Chamber
27
900-0914
14
238
ITEM NO.
(for Left or Right) Burner, Manufactured Gas (for Left or Right)
Please Call
Insulation, Burner Fry Pot Assembly, Dual Vat, with Three Holes
24b
Please Call
Fry Pot Assembly, Dual Vat, with Four Holes
15
824-0160
Retainer, Right Front Seal Insulation
16
812-0404
Insulation, Front Seal (for Left and Right)
17
900-1515
Brace, Upper Oil Zone Insulation
28
810-0406
Spacer, 1/4" x 1.625" Long
18
812-0993
Insulation, Upper Oil Zone
29
930-0818
Bracket, Flue to Fry Pot Connection
30
806-5860SP
Flue Assembly, Dual Vat
Retainer, Rear Insulation and Combustion Chamber Back
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
MJ45E Series Fryer
MJ45E Series Fryer
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
DESCRIPTION
1
910-6545 Flue Cap, 1 Fryer
5
823-0588 Top Cap, 4 Fryers
1
910-9132 Flue Cap, 2 Fryers
6
806-4732 Computer or Controller
1
910-9133 Flue Cap, 3 Fryers
2
803-0028 Basket Hanger for Non-Basket Lift Fryers
6
806-4733 Computer of Controller
6
806-4734 Computer of Controller
6
806-5018 Computer or Controller
7
809-0449 Screw, Computer or
Mounting Frame, 1 Fryer
809-0015 Nut Retainer for Basket Hanger Screws 3
809-0171 Basket Hanger Screw
Mounting Frame, 2 Fryers
807-0154 Power Cord Set
Mounting Frame, 3 Fryers
4
806-1370 Fry Pot Complete (Combustion Chamber,
4
823-0359 Fry Pot Only
5
910-3544 Top Cap, 1 Fryer
Controller Mounting Frame
5
823-0586 Top Cap, 2 Fryers
(Series AD)
5
823-0587 Top Cap, 3 Fryers
Flue, and Insulation)
Mounting Frame, 4 Fryers
809-0177 Tinnerman Clip, Computer or Controller Mounting Frame Screw
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
239
FRYMASTER MJ45E Series Fryer
(cont.)
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
13
807-0046
Melt Switch for Fryers with Melt Cycle
14
810-0333
8
PART NO. 806-4827
DESCRIPTION Control Panel Assembly, without Melt, 2 15-Minute Deihl
15
Mechanical Timers 8 8
806-4829 806-4831
8 8 8
806-4832 806-4833 806-4834 806-4835
910-3672
Handle, Door for Universal Doors Only
809-0266
Screw for Door Handle and Door Edge
Control Panel Assembly, with Melt,
16
806-1961SP
Door Assembly, Universal, Painted
2 15-Minute Deihl Mechanical Timers
16
806-1962SP
Door Assembly, Universal,
Control Panel Assembly, without Melt,
Stainless Steel
2 15-Minute Paragon Timers 120v 8
Control Panel Assembly, with Melt,
810-0066
Magnetic Door Catch
900-0048-1
Door Striker Plate
2 15-Minute Paragon Timers 120v
17
810-0357
Caster, 5" with Brake
Control Panel Assembly, with Melt,
18
900-0734-1
Door Hinge Bracket
2 5-Minute Paragon Timers 120v
19
809-0216
Door Hinge Pin
Control Panel Assembly, without Melt,
810-0275
Door Hinge Pin Spring
2 5-Minute Paragon Timers 120v
810-0274
Door Hinge Pin Keeper
Control Panel Assembly, without Melt,
20
901-9323
5 15-Minute Paragon Timer 120v 8
806-4836
Control Panel Assembly, with Melt,
806-4837
Control Panel Assembly, with Melt,
20
902-9323
806-4838
Control Panel Assembly, without Melt,
20
911-9323
806-4841
Control Panel Assembly, with Melt,
20
912-9323
8
806-4842 806-4864
Cabinet Side, SS, Right, without Holes
20
901-9324
No Timer 8
Cabinet Side, SS, Left, without Holes
2 18-Minute Deltrol Timers 240v 8
Cabinet Side, CRS, Right, without Holes
2 18-Minute Deltrol Timers 240v 8
Cabinet Side, CRS, Left, without Holes
5 15-Minute Paragon Timer 120v 8
Hole Plug, Back for Fryers without Melt Cycle
Cabinet Side, CRS, Left, with Holes
Control Panel Assembly without Melt,
20
902-9324
Cabinet Side, CRS, Right, with Holes
No Timer
20
911-9324
Cabinet Side, SS, Left, with Holes
Control Panel Assembly without Melt
20
912-9324
Cabinet Side, SS, Right, with Holes
(Military)
900-0889
Cabinet Side, Hole Cover, CRS (3 qty.)
9
806-3705
Computer, Single or Multi-product
900-0890
Cabinet Side, Hole Cover, CRS
9
806-4353
Computer, Basket Lift Timer
910-0889
Cabinet Side, Hole Cover, SS (3 qty.)
9
806-3559
Solid-State Electronic Controller
910-0890
Cabinet Side, Hole Cover, SS (1 qty.)
with Thermostat Knob
809-0359
Screw, Hole Cover (16 qty.)
9
806-2071
Computer or Controller Wire Harness
21
810-0356
Caster, 5" without Brake
9
806-3797
Digital Controller
22
810-0334
Knob with Skirt
10
807-1525
Indicator Light
23
806-0168
Thermostat Dial Plate
11
807-1404
Switch, Power On/Off
12
940-0176
24v Lamp, Red
240
Insert Clip, Switch Hole Control Panel
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER MJ45E Series Fryer
Burner
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
12
810-0353
Unitrol Gas Valve, 24v,
DESCRIPTION
1
806-1677
Burner and Control Assembly, Nat. Gas
13
810-0109
1
806-1678
Burner and Control Assembly, LP
14
817-0112
Operator Assembly, 24v
1
806-1646
Burner and Control Assembly,
15
810-0187
Regulator, Nat. Gas, 3.5" W.C. (0.86 kPa)
Nat. Gas (England and Germany) Gas Valve Knob
Nat. Gas (England and Germany)
15
817-0098
Regulator, LP Gas, 8.25" W.C. (2.05 kPa)
809-0170
Burner Mounting Screw
16
810-0691
Vent Tube 1/8" (3.17 mm)
2
814-0034
Ceramic Target, Side Targets Only
17
810-0617
Pilot Generator Cartridge (Thermopile)
3
806-0225
Deflector Assembly, Side Deflectors Only
17
807-0699
Thermocouple, 20" (50.8 cm)
4
823-1496
Burner Manifold Only
5
813-0154
Pressure Test Port Plug
18
810-0149
Pilot Orifice, ITT TJ024, Nat. Gas
6
813-0205
Compression Fitting, 3/4TB OD X 1/2PP
18
810-0148
Pilot Orifice, ITT TJ013, LP
Use with 940-0747-1 & 2
18
810-0126
Pilot Orifice, Robertshaw,
Use with 940-0747-1 & 2
19
810-0426
Pilot Burner, ITT 262A38, Nat. Gas
940-0747-1 Curved Input Gas Tube, 5/8" for Batteried
19
810-0427
Pilot Burner, ITT 262A38, LP
19
810-0154
Pilot Burner, Robertshaw, 3CH6,
Fryers w/o Manual Shut-Off Valve
20
910-0226
Deflector Bracket
Pilot Tubing, Gas Valve to Pilot Burner
21
806-3606
Deflector Assembly, Wide Rear Only
(Series AH)
22
810-0424
Ceramic Target, Wide Rear Only
Pilot Tubing, Gas Valve to Pressure Switch,
23
810-0315
Burner Orifice, #53 (1.45 mm) Nat. Gas
.25 X 8.75 (Prior to Series AH)
23
810-0340
Burner Orifice, #65 (0.86 mm) LP
Pilot Tuning, Pressure Switch to Pilot,
23
810-0330
7 8
813-0206
Compression Fitting, 3/4TB OD X 3/4PP
Fryers w/Manual Shut-Off Valve 9 10
(England and Germany)
.018 (England and Germany)
940-0747-2 Curved Input Gas Tube, 5/8" for Batteried 810-0705 810-0700 810-0704
Nat. Gas (England and Germany)
.25 X 19.50 (Prior to Series AH) 11
810-0239
Manual Gas Shut-Off Valve
12
807-0428
Unitrol Gas Valve, 24v, Nat. Gas
12
807-0757
Unitrol Gas Valve, 24v, LP
Burner Orifice, #54 (1.40 mm) Nat. Gas (England and Germany)
24
NO ONE WORKS HARDER TO KEEP YOU COOKING.
823-0574
❘
Burner Suspended Heat Shield
WHALEY FOODSERVICE REPAIRS
241
FRYMASTER MJ45E Series Fryer Fry Pot
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
9
823-1363
Drain Valve, 1-1/4" x 1"
DESCRIPTION
1
806-1370
Fry Pot Complete (Combustion Chamber,
10
810-05831 Drain Valve Handle without Lock Pin
Flue and Insulation)
11
806-3865
Fry Pot Complete, Hardee’s Only
without Lock Pin, with Filter Magic 806-4791
Safety Drain Switch Box Filter Magic
807-0027
Safety Drain Switch
806-0861
Fry Pot Insulation Kit for Whole Fry Pot
12
900-1101
Safety Drain Switch Box Cover
2
806-1092
Flue Assembly
13
900-1090
Pilot Hole Cover
3
806-1096
Rear Combustion Chamber Baffle
14
806-0178
Assembly (Must be Ordered with 806-1092) 4
806-1097
Fry Pot Baffle Pot Side, Fits Left or Right
15
807-0280
Hi-Limit Wire Adapter
5
806-1095
Fry Pot Baffle Pot Front
16
806-0183
Operating Thermostat
6
809-0173
Tinnerman Clip Nut
7
806-4145
Drain Valve, 1-1/4" (37 mm) with Lock
(MJ45E Standard Only) 806-4206
Pin, without Filter Magic 8
242
Hi-Limit Thermostat with Adapter Wire 435˚F (224˚C)
810-0662
Temperature Sensing Probe, Minco (MJ45E with Computer Only)
Drain Valve Handle with Lock Pin
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER MJ45E Series Fryer
Thermostat Related Parts
ITEM NO.
PART NO.
ITEM NO.
PART NO.
9
802-0045
DESCRIPTION
1
806-0168
Thermostat Dial Plate
10
810-0334
Knob with Skirt
2
809-0104
Screw, Thermostat Shaft Stop Plate
11
807-0280
Hi-Limit Thermostat Adapter
809-0237
Nut, Thermostat Shaft Stop Plate
3
806-0066
Thermostat Shaft Stop Plate
12
826-1177
Hi-Limit Thermostat
4
810-0729
Thermostat Flexible Extension Shaft
13
806-0183
Operating Thermostat
810-0008
Thermostat Flexible Extension Shaft
14
900-1579
Thermostat Dial Lock Plate
(Prior to Series AH)
15
809-0177
5
810-0009
6
809-0111
7
810-0364
Wire Assembly
16
809-0103
810-0276
Screw for Thermostat Dial Lock Plate
17
for Filter Magic Fryers (Prior to Series AH) 8
Tinnerman Clip Nut for Thermostat Dial Lock Plate
Thermostat Stop Screw Solid Adapter Shaft 3-1/2" Long
Caution Label, Thermostat Adjustment Warning
Adapter for Flexible Extension Shaft (Prior to Series AH)
DESCRIPTION
900-0031
Plug Button
807-0123
Heyco Bushing for 900-0031
Solid Adapter Shaft 2-1/2" Long
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
243
FRYMASTER TCF Gas Fryer
TCF Gas Fryer
244
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
DESCRIPTION
1
806-4535
Wand, Filter Hose
10
813-0010
Compression Fitting, 1/2"
2
810-0675
Orifice, 44 Nat (5 Per Fryer)
11
810-0680
T-handle, Oil Return
2
810-0710
Orifice, 54 LP (5 Per Fryer)
12
910-7107
Oil Return Linkage
3
823-1514
Elbow, Drain Switch
13
900-4208
Gas Line, Long
4
810-0583
Drain Valve, 1-1/4" Gemini
14
823-1516
Drain Handle
5
813-0380
Drain Nipple
15
810-0239
Shut-Off Valve
6
900-1419
Drain Switch Mounting Bracket
16
900-1457
Gas Line, Short
7
807-0027
Microswitch
17
813-0205
Compression Fitting, 3/4"
8
900-1420
Drain Switch Cover
18
806-4548
Computer (for 2-Battery Unit
9
810-0786
Gas Valve, Nat.
9
810-0787
Gas Valve, LP
19
810-0487
or Left Side of 3-Battery Unit)
(800) 877-2662 ❘
Male Quick Disconnect Fitting
WWW.WHALEYFOODSERVICE.COM
FRYMASTER TCF Gas Fryer
Component Box and Transformer Box
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
15
806-4545
Component Box Assembly, Left
DESCRIPTION
16
807-1312
Ignition Module
1
806-4575
Transformer Box Assembly
17
900-4206
Mounting Plate, Left
2
807-1322
Terminal Block, 12-Pin
18
807-1035
Relay, 24v
3
807-0154
Cord Set, Filter
19
810-0678
Grommet
4
807-0154
Cord Set, Fryer
20
900-4207
Mounting Plate, Right
5
807-0067
Terminal Block, 8-Pin
21
806-4549
Interface Board
6
900-4230
Cover, Transformer Box
22
7
807-1319
Elbow
8
807-0855
Transformer, 12v
9
807-0800
Transformer, 24v
10
807-0012
Relay, Filter Pump
25
807-1313
Hi-Limit Thermostat
11
806-4358
Resistor
810-0708
Hi-Limit Spring
12
810-0045
Bushing
807-0910
Fuse, 3-Amp
13
812-0829
Plastic Conduit
807-1321
Fuse Holder
14
807-1321
Fuse Holder
806-4546
Component Box, Right
806-4908
Component Box, Right w/o Rear Flush
23
807-1315
Ignition Cable
24
807-0833
Heat Relay
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
245
FRYMASTER TCF Gas Fryer 246
Fry Pot and Related Parts List
ITEM NO.
PART NO.
ITEM NO.
PART NO.
14
806-5006SP
DESCRIPTION
1
823-1566
Fry Pot
2
809-0459
Washer Head Bolt
3
823-1562
Burner Basket
4
809-0071
Hex Nut 1/4-20
5
900-1428
6
DESCRIPTION Temperature Probe Assembly, Left or Right
15
807-1313
Hi-Limit Thermostat
810-0708
Hi-Limit Thermostat Spring
16
809-0442
Nut, SS 1/4-20
17
910-1573
Probe Retainer
Manifold Bracket
18
823-1505
Diffuser
823-1561
Manifold
19
900-4197
Heat Shield
7
809-0439
Bolt, All Thread 1/4-20
20
823-1531
Crossover Tube
8
810-0167
Spring Dowel Pin
21
807-1311
Igniter Assembly, Nat.
9
900-1438
Air Shutter
22
807-1553
Igniter Assembly, LP
10
812-0837
Burner, Right
23
807-1310
Flame Sensor
11
812-0836
Burner, Center
12
812-0835
Burner, Left
13
823-1670
Flue
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER TCF Gas Fryer
Inner Filter Pan Assembly
ITEM NO.
PART NO.
ITEM NO.
PART NO.
14
809-0185 Flat Washer, #10
15
807-1367 Washer, Flat Non-Conductive
1
810-0006 Caster
16
810-0695 Contact, Heater Pan
2
809-0417 Lock Nut
17
807-1270 Washer, Shoulder Insert
3
809-0256 Keps Lock Nut
18
809-0020 Nut, Cap 10-24
4
823-1475 Filter Pan Base
19
824-0312 Housing, Tube and Heater
5
806-4486 Outer Pan Assembly
20
806-4373 Pan Heater
5
823-1466 Outer Pan Only
21
823-1686 Filter Paper Screen
6
809-0024 Screw 10-24 X 3/8"
22
823-1713 Inner Filter Pan Only
7
810-0180 Handle
23
823-16841 Filter Paper Hold-Down Ring
8
809-0422 Screw, Shoulder 10-32
24
810-0180 Handle, Filter Pan
9
823-1501 Filter Pan Cover
25
806-4854 Inner Pan Assembly
10
813-0411 Pipe Plug
26
816-0117 O-Ring Filter Pan
11
809-0053 Nut 10-32
27
823-1491 Crumb Screen
12
809-0184 Lock Washer
13
807-0037 Terminal Tab
DESCRIPTION
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
DESCRIPTION
WHALEY FOODSERVICE REPAIRS
247
FRYMASTER 47 Series Gas Fryer
47 Series Gas Fryer
Accessories
248
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
803-0099
Basket, Full
DESCRIPTION
810-0357
Caster, 5", w/Brake
1
803-0022
Basket, Twin
810-0356
Caster, 5", w/o Brake
2
803-0028
Basket Hanger (for Non-Basket Lift Fryers)
810-0378
Caster, Rigid
3
803-0132
Basket Support Rack
806-5518
Fry Pot Cover
4
812-1226
Drain Extension Pipe
806-5043
Kit, 1-Leg
(for Use on Units w/o
806-3811
Kit, 4-Leg
Built-in Filtration Systems)
809-0171
Screw, Basket Hanger
5
803-0209
Fry Pot Cleanout Brush
6
803-0197
Fry Pot Cleanout Rod (Fryer’s Friend)
(for use w/803-0028)
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER 47 Series Gas Fryer
Burner Manifold Assemblies and Component Parts
ITEM NO.
PART NO.
6
910-2025 Bracket, Target Retaining
ITEM NO.
DESCRIPTION
7
810-0989 Burner Manifold, Full Vat
DESCRIPTION
8
810-0987 Burner Manifold, Dual Vat, Left
806-5927 Burner Manifold Assembly,
9
810-0988 Burner Manifold, Dual Vat, Right
10
910-2022 Bracket, Manifold Mounting, Full Vat
11
910-2024 Bracket, Manifold Mounting, Dual Vat, Rear
12
910-2023 Bracket, Manifold Mounting, Dual Vat, Front
PART NO.
Full Vat, Complete 806-5928 Burner Manifold Assembly, Dual Vat, Complete 806-7949 Burner Manifold Sub-Assembly
826-1357 Orifice, Burner Manifold,
(Target Assembly) 1
911-2029 Support, Target, Left End
2
814-0034 Ceramics, #R-590 Radiants
3
910-2031 Support, Target, Back Plate
4
910-2027 Standoff, Target
5
912-2029 Support, Target, Right End
NO ONE WORKS HARDER TO KEEP YOU COOKING.
Natural Gas (Drill #53, 1.45 mm) 826-1387 Orifice, Burner Manifold, LP Gas (Drill #65, 0.86 mm) 809-0500 Screw, 410 SS, #10 x 1/2, Hex Washer Head
❘
WHALEY FOODSERVICE REPAIRS
249
FRYMASTER 47 Series Gas Fryer Burner Ignition System Components ITEM NO. 1
PART NO.
ITEM NO.
PART NO.
3
Igniter Assembly, Honeywell (for Use w/Electronic Ignition Systems)
DESCRIPTION
807-1707 Natural Gas
Pilot Assembly w/Thermopile
807-1708 Propane Gas
(for Use w/Non-CE Pilot Ignition Systems)
4
807-1928 Electrode, Flame Sensor
810-0615 Natural Gas
2
DESCRIPTION
(for Use w/Electronic Ignition Systems)
810-0616 Propane Gas
806-5830 Ignition Cable (Spark Plug Wire)
810-0617 Thermopile
826-1511 Igniter Kit, Optional Piezo
Pilot Assembly w/o Thermopile
810-1001 Trigger
(for Use w/CE Pilot Ignition Systems)
807-1906 Electrode Assembly
812-1286 Natural Gas 812-1287 Propane Gas 812-1284 Thermocouple
250
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER 47 Series Gas Fryer
Gas Valve Assemblies and Connection Components ITEM NO. 1
PART NO.
ITEM NO.
807-0757, 810-0786, 810-0787)
DESCRIPTION
Vent Tube, Gas Valve
Valve Assembly
810-1166 For Use w/CE Gas Valves 807-2091
(for Use w/CE Pilot Ignition Systems)
and 807-2127 810-0691 For Use w/Non-CE Gas Valves 807-0428,
807-2127 Propane Gas
807-0757, 810-0786, 810-0787
Valve Assembly
Hose, Flexible, Gas
(for Use w/Non-CE
810-0084 3/4" (19.05 mm) ID, 48 inches
Electronic Ignition Systems)
(1.2 m) long
810-0786 Natural Gas
810-0085 1" (25.4 mm) ID, 48 inches
810-0787 Propane Gas 3
DESCRIPTION
806-0236 Capacitor, .002 F (for Use w/807-0428,
807-2091 Natural Gas 2
PART NO.
(1.2 m) long
Valve Assembly
Quick Disconnect Fitting, Female
(for Use w/Non-CE Pilot Ignition Systems)
810-0072 3/4" (19.05 mm)
807-0428 Natural Gas
810-0073 1" (25.4 mm)
807-0757 Propane Gas (Full Vat Units)
Quick Disconnect Fitting, Male
807-2922 Propane Gas (Split Vat Units)
810-0070 3/4" (19.05 mm) 810-0074 1" (25.4 mm)
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
251
FRYMASTER 47 Series Gas Fryer
1 5
4
7
3
2
6
Component Box/Shield Component Parts COMMON COMPONENTS
ITEM NO.
PART NO.
1
806-2071 Cable Assembly, 15-Pin,
SPACER, ALUMINUM (FOR USE WITH INTERFACE BOARD)
ITEM NO.
DESCRIPTION
809-0349 4mm x 6mm
DESCRIPTION Computer to Interface Board
PART NO.
807-1241 5/8" Unthreaded TERMINAL BLOCK, SCREWLESS
807-1978 Cable Assembly, Transformer Box to Interface Board 806-5830SP Cable Assembly, Ignition (Spark Plug Wire)
ITEM NO.
PART NO.
5
810-1164 2-Wire
DESCRIPTION
810-1168 3-Wire INTERFACE BOARDS
6
ITEM NO.
PART NO.
TRANSFORMER, V/F, DUAL VOLTAGE
2
806-3398 Fryers w/Electronic Ignition
3
806-5857 Fryers w/o Electronic Ignition
4
807-1006 Module, Ignition,
DESCRIPTION
4-Second Delay, Honeywell
806-1661 Timer, Melt Cycle, 24v, 60hz
ITEM NO.
PART NO.
7
807-2176 100-120v
7
DESCRIPTION
807-1999 208-240v 806-5879 Wire Assembly, Ignition Module 806-3660 Sound Device, High Output
252
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER 47 Series Gas Fryer
Control Assemblies and Component Parts
THERMOSTAT ASSEMBLY, HIGH LIMIT
ITEM NO.
PART NO.
COMMON COMPONENTS
2
806-7550 For Use on CE Units
3
826-1177 For Use on Non-CE Units
ITEM NO. 1
PART NO.
DESCRIPTION
4
DESCRIPTION
Timer, Basket Lift, Electric 807-0103 120v, 60 hz, 5-Minute
806-4206 Probe, Temperature Control
807-0104 120v, 60 hz, 15-Minute
(Not for Use with Thermostat Controllers)
807-0401 240v, 50/60 hz, 18-Minute
810-0625 Probe Guard 5
810-0585 Timer, Basket Lift, Mechanical, 15-Minute
6
810-1287 Knob, Mechanical Timer
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
253
FRYMASTER 47 Series Gas Fryer Thermostat Controller Components
ITEM NO.
PART NO.
ITEM NO.
PART NO.
8
807-2197 Switch, Rocker, Melt Cycle I/O,
1
806-0183 Thermostat, Operating
DESCRIPTION
w/24v Lamp, Amber (CE) 9
807-0046 Switch, Rocker, Melt Cycle On/Off,
(for Use with Thermostat Controller Only)
254
2
810-0999 Shaft, Flexible
3
809-0157 Set Screw
4
809-0050 Nut, Hex
5
826-1361 Stop Screw
6
810-0276 Adapter, Shaft End
7
810-0334 Knob, Thermostat
DESCRIPTION
w/24v Lamp, Amber (Non-CE) 10
807-2196 Switch, Rocker, Fryer I/O, w/24v Lamp, Green (CE)
11
807-1404 Switch, Rocker, Fryer On/Off, w/24v Lamp, Red (Non-CE)
12
807-1525 Light, 24v, White
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER 47 Series Gas Fryer
Filtration Systems and Component Parts FILTER BASE ASSEMBLY
ITEM NO.
PART NO.
ITEM NO.
PART NO.
3
900-7470 Support, Filter Motor
4
823-2289 Support, Filter Pan
5
901-7650 Frame, Base, Left Side
DESCRIPTION
DESCRIPTION
6
902-7650 Frame, Base, Right Side
806-5954 Base Assembly, Complete
7
810-0019 Handle
1
900-1953 Bracket, Filter Pan Lock
8
810-0006 Caster, Swivel, Rokite #127-2
2
900-7469 Support, Filter Motor Angle
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
255
FRYMASTER 47 Series Gas Fryer
Filter Pump and Motor Assemblies ITEM NO.
PART NO.
DESCRIPTION
900-7558 Cover, Motor 816-0093 Gasket, Pump/Motor 810-1159 Flexline, Steel, 7-1/2" Oil Return (Pump to Filter Pan Outlet) 1
813-0376 Fitting, Oil Return Hose
2
807-1968 Pump, Viking, 5 GPM
3
900-1958 Support, Oil Return
4
813-0062 Elbow, 1/2", 90º
Filter Pan Assembly
5
813-0165 Elbow, 1/2", 90º Street
6
813-0265 Nipple, 1/2" x 3.0"
ITEM NO.
7
806-6728 Pump Wiring Assembly
8
806-6714 100VAC Pump/Motor Assembly
(for Use with Rubber Hose Only)
PART NO.
DESCRIPTION
806-5618 Pan Assembly, Complete
w/Fittings, Complete
(Less Crumb Screen Pan)
806-6120 Pump and Motor Only
824-0430 Pan, Crumb Screen (Must Be Ordered as a Separate Item) 803-0170 Paper, Filter, 100 Sheet Pack 1
823-2027 Cover
2
810-1408 Hold Down Ring
3
810-1223 Screen
4
823-1979 Pan
5
810-1387 Retainer, Check Valve
6
900-5448 Strain Plate, Check Valve
7
810-0946 Spring, Check Valve
8
810-0948 Ball, Check Valve
9
810-1388 Tube, Check Valve
10
816-0181 O-Ring, Check Valve
11
809-0422 Screw, Shoulder
807-1984 Motor Only 9
806-6715 115VAC Pump/Motor Assembly, w/Fittings, Complete 806-6034 Pump and Motor Only 807-1969 Motor Only
10
806-6716 208VAC Pump/Motor Assembly, w/Fittings, Complete 806-6121 Pump and Motor Only 807-1985 Motor Only
11
806-6717 230VAC Pump/Motor Assembly, w/Fittings, Complete 806-6119 Pump and Motor Only 807-1983 Motor Only
12
806-6718 250VAC Pump/Motor Assembly, w/Fittings, Complete 806-6118 Pump and Motor Only 807-1982 Motor Only 807-2172 Wiring Harness, Controller to Filter
256
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
Filter Magic II
Filter Magic II
Filter Magic II
ITEM NO.
PART NO.
5
823-1732 Screen, Filter Pan
6
816-0117 O-Ring, Inner Pan Fitting
DESCRIPTION
ITEM NO.
PART NO.
1
806-4338 Pan, Outer (Complete)
7
806-4373 Pan Heater
2
806-5282 Pan, Inner
8
803-0002 Filter Powder
3
810-0180 Handle, Inner Pan
9
803-0154 Filter Paper
809-0024 Screw, Handle
10
823-1362 Crumb Screen
4
DESCRIPTION
823-17331 Filter Paper Hold-Down Ring
ONE-STOP SHOP
Don’t see what you need? We will find it!
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
257
FRYMASTER Filter Magic II Filter Magic II
258
ITEM NO.
PART NO.
10
807-1270 Insulator Shoulder
11
809-0020 Nut, Cap 10-24
DESCRIPTION
ITEM NO.
PART NO.
1
810-0006 Caster, 2" Swivel
12
809-0184 Lock Washer, #10
2
810-0005 Caster, 2" Rigid
13
809-0185 Flat Washer #10
3
809-0256 Keps Lock Nut
14
824-0291 Cover, Suction Tube
4
823-1360 Pan, Only
15
807-0037 Terminal Tab
5
910-1350 Clamp, Suction Tube
16
806-4373 Pan Heater
813-0411 Pipe Plug
17
809-0071 Base Mount Nut
6
809-0361 Screw Drill
18
809-0189 Washer, Flat 1/4"
7
809-0053 Nut 10-32
19
823-1361 Base, Outer Pan
8
807-1367 Insulator Filter Contacts
9
810-0695 Contactor Pan Heater
DESCRIPTION
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
FRYMASTER
Footprint II
Footprint II
Footprint II
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
7
809-0422
Pan Cover Hinge Screw
DESCRIPTION
8
824-0246
Cover, Suction Tube
1
806-4370SP
Outer Pan Assembly
9
816-0117
O-Ring, Inner Pan Fitting
2
810-0180
Handle, Outer Pan Cover
10
806-4373
Pan Heater
809-0024
Screw, Handle
11
810-0695
Contactor Pan Heater
3
823-1397
Cover, Outer Pan
12
807-1367
Insulator Filter Contacts
4
806-4771
Inner Pan Assembly
13
807-1270
Insulator Shoulder
5
823-16631
Filter Paper Hold-Down Ring
14
910-4240
Drip Pan
6
823-1664
Screen, Filter Pan
15
823-1423
Crumb Screen
803-0002
Filter Powder
803-0153
Filter Paper, High Performance
NO ONE WORKS HARDER TO KEEP YOU COOKING.
❘
WHALEY FOODSERVICE REPAIRS
259
FRYMASTER Footprint II 260
Footprint II
ITEM NO.
PART NO.
DESCRIPTION
ITEM NO.
PART NO.
11
809-0053
Nut 10-32
DESCRIPTION
12
809-0184
Washer, Lock #10
1
810-0006
Caster, 2" Swivel
13
807-0037
Terminal Tab
2
809-0256
Keps Lock Nut
14
809-0185
Flat Washer #10
3
809-0417
Lock Nut
15
807-1367
Washer, Flat Non-Conductive
4
823-1376
Base Assembly, Outer Pan
16
810-0695
Contact Pan
5
823-1377
Filter Pan Assembly
17
807-1270
Washer Shoulder Insert
6
809-0024
Screw 10-24 x 3/8"
18
809-0020
Nut, Cap 10-24
7
810-0180
Handle
19
824-0312
Housing, Tube and Heater
8
809-0422
Screw, Shoulder, 10-32
20
806-4373
Pan Heater
9
823-1397
Cover
10
813-0411
Pipe Plug
(800) 877-2662 ❘
WWW.WHALEYFOODSERVICE.COM
