Transcript
UCCSS Series UCCSM Series UCCSL Series
iPad®, Chromebook™, Tablet, and Laptop Cart, Single Frame
Mobile, secure, and powered storage for up to 10, 18, 20, 24, 27, 30, 36, or 42 computing devices. The perfect storage solution for tablets, notebooks, and laptops.
Contact Information
Order toll-free in the U.S. or for FREE 24/7 technical support: Call 877-877-BBOX (outside U.S. call 724-746-5500) www.blackbox.com •
[email protected]
Important Safety Information/Electrical Precautions Important Safety Information WARNING! Death or serious injury may occur when children climb on the Cart. The cart can tip over onto the child. WARNING! Avoid uneven loading of equipment onto the cart. Uneven weight distribution could cause the cart to tip when the cart is moving. Ensure devices are distributed evenly within the cart. Excess weight on sides of cart could cause the cart to tip while in motion. • Only adults should move the cart. • Do not leave the cart unattended in areas where children have access. • Do not block the air vent openings. • The Cart can be very heavy when fully loaded with laptops and should be moved about by persons physically able to do so. • T he Cart should only be used for the storage and transport of tablets, laptops, and other similar devices. •M isuse, incorrect operation, or inadequate repair of the Cart will void the warranty. Electrical Precautions DANGER! Failure to observe the following electrical safety precautions can result in fire or death by electric shock. • The power switch must be in the “OFF” position before plugging the Cart into a wall receptacle. • The Cart must ONLY be connected to a 110–120-volt AC, 15-amp power supply. • The Cart must only be used by adults or with adult supervision. • Never pull the Cart by the power cord. • Do not plug the Cart in if the switch, receptacle(s), or power cord has been damaged. All electrical components on this product must be repaired by a qualified electrician. • Do not use an extension cord in conjunction with the Cart.
Page 2
877-877-2269 | blackbox.com
UCCSM20T
Electrical Precautions • Do not use liquids in or around the Cart environment. • Inadequate repair or modifications can create significant hazards to users and is not covered by warranty. • F or your safety, we recommend that a qualified electrician test the circuit you will be plugging the Cart into. The circuit should be checked for ground integrity and appropriate branch circuit protection. • T he Cart ground prong must be present for safe operation. If the plug is damaged or if the ground prong has been removed, it should be replaced by a qualified electrician. • The use of the Cart, including plugging or unplugging laptops, plugging or unplugging the Cart, operating the control switch, and engaging or releasing the directional and locked casters, must be done with adult supervision.
UCCSM20-T
877-877-2269 | blackbox.com
Page 3
FCC and IC RFI Statements/NOM Statement FEDERAL COMMUNICATIONS COMMISSION AND INDUSTRY CANADA RADIO FREQUENCY INTERFERENCE STATEMENTS This equipment generates, uses, and can radiate radio-frequency energy, and if not installed and used properly, that is, in strict accordance with the manufacturer’s instructions, may cause interference to radio communication. It has been tested and found to comply with the limits for a Class A computing device in accordance with the specifications in Subpart B of Part 15 of FCC rules, which are designed to provide reasonable protection against such interference when the equipment is operated in a commercial environment. Operation of this equipment in a residential area is likely to cause interference, in which case the user at his own expense will be required to take whatever measures may be necessary to correct the interference. Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. This digital apparatus does not exceed the Class A limits for radio noise emission from digital apparatus set out in the Radio Interference Regulation of Industry Canada. Le présent appareil numérique n’émet pas de bruits radioélectriques dépassant les limites applicables aux appareils numériques de la classe A prescrites dans le Règlement sur le brouillage radioélectrique publié par Industrie Canada.
Normas Oficiales Mexicanas (NOM) Electrical Safety Statement INSTRUCCIONES DE SEGURIDAD 1. Todas las instrucciones de seguridad y operación deberán ser leídas antes de que el aparato eléctrico sea operado. 2. Las instrucciones de seguridad y operación deberán ser guardadas para referencia futura. 3. Todas las advertencias en el aparato eléctrico y en sus instrucciones de operación deben ser respetadas.
Page 4
877-877-2269 | blackbox.com
UCCSM20T
NOM Statement
4. Todas las instrucciones de operación y uso deben ser seguidas.
5. El aparato eléctrico no deberá ser usado cerca del agua—por ejemplo, cerca de la tina de baño, lavabo, sótano mojado o cerca de una alberca, etc. 6. El aparato eléctrico debe ser usado únicamente con carritos o pedestales que sean recomendados por el fabricante. 7. El aparato eléctrico debe ser montado a la pared o al techo sólo como sea recomendado por el fabricante. 8. Servicio—El usuario no debe intentar dar servicio al equipo eléctrico más allá lo descrito en las instrucciones de operación. Todo otro servicio deberá ser referido a personal de servicio calificado. 9. El aparato eléctrico debe ser situado de tal manera que su posición no interfiera su uso. La colocación del aparato eléctrico sobre una cama, sofá, alfombra o superficie similar puede bloquea la ventilación, no se debe colocar en libreros o gabinetes que impidan el flujo de aire por los orificios de ventilación. 10. El equipo eléctrico deber ser situado fuera del alcance de fuentes de calor como radiadores, registros de calor, estufas u otros aparatos (incluyendo amplificadores) que producen calor. 11. El aparato eléctrico deberá ser connectado a una fuente de poder sólo del tipo descrito en el instructivo de operación, o como se indique en el aparato. 12. Precaución debe ser tomada de tal manera que la tierra fisica y la polarización del equipo no sea eliminada. 13. Los cables de la fuente de poder deben ser guiados de tal manera que no sean pisados ni pellizcados por objetos colocados sobre o contra ellos, poniendo particular atención a los contactos y receptáculos donde salen del aparato. 14. El equipo eléctrico debe ser limpiado únicamente de acuerdo a las recomendaciones del fabricante. 15. En caso de existir, una antena externa deberá ser localizada lejos de las lineas de energia.
UCCSM20-T
877-877-2269 | blackbox.com
Page 5
NOM Statement 16. El cable de corriente deberá ser desconectado del cuando el equipo no sea usado por un largo periodo de tiempo. 17. Cuidado debe ser tomado de tal manera que objectos liquidos no sean derramados sobre la cubierta u orificios de ventilación. 18. Servicio por personal calificado deberá ser provisto cuando:
A: El cable de poder o el contacto ha sido dañado; u
B: Objectos han caído o líquido ha sido derramado dentro del aparato; o
C: El aparato ha sido expuesto a la lluvia; o
D: El aparato parece no operar normalmente o muestra un cambio en su desempeño; o
E: El aparato ha sido tirado o su cubierta ha sido dañada.
Page 6
877-877-2269 | blackbox.com
UCCSM20T
Trademarks Used In This Manual Trademarks Used In This Manual
Black Box and the Double Diamond logo are registered trademarks of BB Technologies, Inc. Any other trademarks mentioned in this manual are acknowledged to be the property of the trademark owners.
UCCSM20-T
877-877-2269 | blackbox.com
Page 7
Table of Contents Table of Contents
1. Specifications ....................................................................................................... 9 2. Overview............................................................................................................ 19 2.1 Introduction........................................................................................ 19 2.2 What‘s Included ................................................................................. 19 2.3 Hardware Description......................................................................... 20 3. Configuration and Setup ................................................................................... 21 3.1 Installing the Handle ........................................................................................ 21 3.2 Routing the Cable .............................................................................. 22 3.3 Fastening the Power Bricks and Routing the Cable.............................. 23 3.4 Installing the Cambrionix PowerPad 15S Units and Power Supplies (UCCSS30H-S and UCCSS30T-S Only)................................................. 25 3.5 HASP Option (UCCSM-10-30H-HASP and UCCSM-10-30T-HASP)....... 26 3.6 Pop-Up Power Port Option (UCCSM-10-30TP or UCCSM-10-30HP).... 26 3.7 Stand-Off Brackets Option (UCCSM-10-30H-SO and UCCSM-12-36H-SO)........................................................................... 26 3.8 Using the Intelligent Charging System (-ILC at end of product code)............................................................. 27 3.9 Basket Distribution System (-BIN1 in product code)............................ 31 4. Using Your iPad, Chromebook, Tablet, and Laptop Cart.................................... 32 4.1 Charging Your Computers ................................................................. 32 4.2 Moving Your iPad, Chromebook, Tablet, and Laptop Cart ............... 32 4.3 Timer Instructions............................................................................................. 34
Page 8
877-877-2269 | blackbox.com
UCCSM20T
Chapter 1: Specifications 1. Specifications Table 1-1. Cart Specifications Part Number
UCCSS20T, UCCSS20H
UCCSM18T, UCCSM18H, UCCSM18H-ILC, UCCSM18T-ILC
UCCSL18T, UCCSL18H, UCCSL18H-ILC, UCCSL18T-ILC
UCCSS30T, UCCSS30H
UCCSM27T, UCCSM27H UCCSM27TILC UCCSM27HILC
Slot Dimensions Height (in.)
13"
13"
13"
8.75"
8.75"
Height (cm)
33.02 cm
33.02 cm
33.02 cm
22.22 cm
22.22 cm
Width (in.)
1.36"
1.53"
1.53"
1.36"
1.53"
Width (cm)
3.45 cm
3.89 cm
3.89 cm
3.45 cm
3.89 cm
Depth (in.)
10"
15"
17"
10"
15"
Depth (cm)
25.4
38.1 cm
43.2 cm
25.4 cm
38.1 cm
30
27
44.3"
44.3"
Device Capacity Number of Devices
20
Height (in.)
44.3"
18
18
External Dimensions (Including Handle)* 44.3"
44.3"
Height (cm)
112.5 cm
112.5 cm
112.5 cm
112.5 cm
112.5 cm
Width (in.)
33.1"
33.1"
33.1"
33.1"
33.1"
Width (cm)
84 cm
84 cm
84 cm
84 cm
84 cm
Depth (in.)
24.8"
24.8"
24.8"
24.8"
24.8"
Depth (cm)
63 cm
63 cm
63 cm
63 cm
63 cm
UCCSS20T
UCCSM18T
UCCSL18T
UCCSS30T
UCCSM27T
Weight (lb.)
134 lb.
140 lb.
146 lb.
146 lb.
155 lb.
Weight (kg)
60.8 kg
63.5 kg
66.2 kg
66.2 kg
70.3 kg
Weight (Cart with Sliding Door)
Weight (Cart with Solid Steel Door) UCCSS20H
UCCSM18H
UCCSL18H
UCCSS30H
UCCSM27H
Weight (lb.)
144 lb.
150 lb.
156 lb.
156 lb.
165 lb.
Weight (kg)
65.3 kg
68 kg
70.8 kg
70.8 kg
74.8 kg
*External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary. ,
UCCSM20-T
877-877-2269 | blackbox.com
Page 9
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCSS-12-36H, UCCSS-12-36T
UCCSM-10-10H, UCCSM-10-20H, UCCSM-10-10T UCCSM-10-20T
Slot Dimensions Height (in.)
8.75"
8.75"
13"
Height (cm)
22.22 cm
22.22 cm
33.02 cm
Width (in.)
1.12"
1.36"
1.36"
Width (cm)
2.84 cm
3.45 cm
3.45 cm
Depth (in.)
15"
13"
13"
Depth (cm)
38.1
33.02 cm
33.02 cm
Device Capacity Number of Devices
36
10
20
External Dimensions (Including Handle)* Height (in.)
44.27"
44.27"
44.27"
Height (cm)
112.4 cm
112.4 cm
112.4 cm
Width (in.)
33.07"
33.07"
33.07"
Width (cm)
83.99 cm
83.99 cm
83.99 cm
Depth (in.)
25.35"
25.35"
25.35"
Depth (cm)
64.39 cm
64.39 cm
64.39 cm
Weight (Cart with Sliding Door) UCCSS-12-36T
UCCSM-10-10T
UCCSM-10-20T
Weight (lb.)
211.5 lb.
193.5 lb.
208.5 lb.
Weight (kg)
95.9 kg
87.8 kg
94.6 kg
Weight (Cart with Solid Steel Door) UCCSS-12-36H
UCCSM-10-10H
UCCSM-10-20H
Weight (lb.)
211.5 lb.
193.5 lb.
208.5 lb.
Weight (kg)
95.9 kg
87.8 kg
94.6 kg
*External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary.
Page 10
877-877-2269 | blackbox.com
UCCSM20T
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCSM-10-30H, UCCSM-10-30T, UCCSM-10-30H-ILC, UCCSM-10-30T-ILC
UCCSM-12-36H, UCCSM-12-36T, UCCSM-12-36H-ILC, UCCSM-12-36T-ILC
UCCSM-12-24H, UCCSM-12-24T, UCCSM-12-24H-ILC, UCCSM-12-24T-ILC
Slot Dimensions Height (in.)
8.75"
8.75"
13"
Height (cm)
22.22 cm
22.22 cm
33 cm
Width (in.)
1.36"
1.1"
1.1"
Width (cm)
3.45 cm
2.8 cm
2.8 cm
Depth (in.)
13"
15"
15"
Depth (cm)
33.02 cm
38.1
38.1
Device Capacity Number of Devices
30
36
24
External Dimensions (Including Handle)* Height (in.)
44.27"
44.27"
44.27"
Height (cm)
112.4 cm
112.4 cm
112.4 cm
Width (in.)
33.07"
33.07"
33.07"
Width (cm)
83.99 cm
83.99 cm
83.99 cm
Depth (in.)
25.35"
25.35"
25.35"
Depth (cm)
64.39 cm
64.39 cm
64.39 cm
Weight (Cart with Sliding Door) UCCSM-10-30T
UCCSM-12-36T
UCCSM-12-24T
Weight (lb.)
223.5 lb.
236.5 lb.
221.1 lb.
Weight (kg)
101.4 kg
107.3 kg
100.3 kg
Weight (Cart with Solid Steel Door) UCCSM-10-30H
UCCSM-12-36H
UCCSM-12-24H
Weight (lb.)
223.5 lb.
236.5 lb.
221.1 lb.
Weight (kg)
101.4 kg
107.3 kg
100.3 kg
*External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary.
UCCSM20-T
877-877-2269 | blackbox.com
Page 11
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCSM-10-30TP, UCCSM-10-30HP
UCCSM-10-30H-HASP, UCCSM-10-30T-HASP
Slot Dimensions Height (in.)
8.75"
8.75"
Height (cm)
22.22 cm
22.22 cm
Width (in.)
1.36"
1.36"
Width (cm)
3.45 cm
3.45 cm
Depth (in.)
13"
13"
Depth (cm)
33.02
33.02
Number of Devices
30
Device Capacity 30
External Dimensions (Including Handle)* Height (in.)
44.27"
44.27"
Height (cm)
112.4 cm
112.4 cm
Width (in.)
33.07"
33.07"
Width (cm)
83.99 cm
83.99 cm
Depth (in.)
25.35"
25.35"
64.39 cm
64.39 cm
Depth (cm)
Weight (Cart with Sliding Door) UCCSM-10-30TP
UCCSM-10-30T-HASP
Weight (lb.)
225.5 lb.
224 lb.
Weight (kg)
102.5 kg
101.8 kg
Weight (Cart with Solid Steel Door) UCCSM-10-30HP
UCCSM-10-30H-HASP
Weight (lb.)
225.5 lb.
224 lb.
Weight (kg)
102.5 kg
101.8 kg
*External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary.
Page 12
877-877-2269 | blackbox.com
UCCSM20T
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCSM-10-30H-SO UCCSM-12-36H-SO
UCCSM-12-36H-14C
Slot Dimensions Height (in.)
8.75"
8.75"
9.75"
Height (cm)
22.22 cm
22.22 cm
24.7
Width (in.)
1.36"
1.12"
1.12"
Width (cm)
3.45 cm
2.85 cm
2.85 cm
Depth (in.)
13"
15"
15"
Depth (cm)
33.02
38.1
38.1
Number of Devices
30
36
36
Device Capacity
External Dimensions (Including Handle)* Height (in.)
44.27"
44.27"
44.27"
Height (cm)
112.4 cm
112.4 cm
112.4 cm
Width (in.)
33.07"
33.07"
33.07"
Width (cm)
83.99 cm
83.99 cm
83.99 cm
Depth (in.)
25.35"
25.35"
25.35"
Depth (cm)
64.39 cm
64.39 cm
64.39 cm
Weight (Cart with Solid Steel Door) UCCSM-10-30H-SO UCCSM-12-36H-SO
UCCSM-12-36H-14C
Weight (lb.)
225 lb.
238 lb.
234.5 lb.
Weight (kg)
102.2 kg
108.2 kg
106.6 kg
*External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary.
UCCSM20-T
877-877-2269 | blackbox.com
Page 13
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCSM-12-36H-15C, UCCSM-12-36T-15C
UCCSS30T-S, UCCSS30H-S
UCCSM-14-42T, UCCSM-14-42H
Slot Dimensions Height (in.)
11.5"
10"
8.75"
Height (cm)
29.21 cm
25.4 cm
22.22"
Width (in.)
1.12"
1.36
0.87"
Width (cm)
2.84 cm
3.45 cm
2.21 cm
Depth (in.)
15"
10"
13"
Depth (cm)
38.1 cm
25.4 cm
33.02 cm
Number of Devices
36
Device Capacity 30
42
External Dimensions (Including Handle)* Height (in.)
44.27"
44.27"
44.27"
Height (cm)
112.4 cm
112.4 cm
112.4 cm
Width (in.)
33.07"
33.07"
33.07"
Width (cm)
83.99 cm
83.99 cm
83.99 cm
Depth (in.)
25.35"
25.35"
25.35"
Depth (cm)
64.39 cm
64.39 cm
64.39 cm
Weight (lb.)
232.5 lb.
216.5 lb.
236.5 lb.
Weight (kg)
105.7 kg
98.4 kg.
107.5 lb.
Weight (Cart with Sliding Door)
Weight (Cart with Solid Steel Door) Weight (lb.)
236.5 lb.
216.5 lb.
236.5 lb.
Weight (kg)
107.5 kg
98.4 kg.
107.5 lb.
*External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary.
Page 14
877-877-2269 | blackbox.com
UCCSM20T
Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number
UCCSM-BIN1-36T, UCCSM-BIN1-36H
UCCSM-BIN1-36H-FCM0, UCCBIN1KIT UCCSM-BIN1-36T-FCM0
Basket Dimensions Height (in.)
5"
5"
5"
Height (cm)
12.7 cm
12.7 cm
12.7 cm
Width (in.)
8.25"
8.25"
8.25"
Width (cm)
20.9 cm
20.9 cm
20.9 cm
Depth (in.)
10.875"
10.875"
10.875"
Depth (cm)
27.6 cm
27.6 cm
27.6 cm
Number of Baskets
6
6
1
Device Capacity Number of Devices
36
36
6
Maximum Device Size HxWxD
8"H x 1"W x 9"D 9"H x 1"W x 9"D (20.3 x 2.5 x 22.8 cm) (22.8 x 2.5 x 22.8 cm)
External Dimensions (Including Handle)*
1"W x 9"D (2.5 x 22.8 cm) Height depends on cart Basket Dimensions
Height (in.)
44.27"
44.27"
5"
Height (cm)
112.4 cm
112.4 cm
12.7
Width (in.)
33.07"
33.07"
8.25"
Width (cm)
83.99 cm
83.99 cm
20.9
Depth (in.)
25.35"
25.35"
10.875"
Depth (cm)
64.39 cm
64.39 cm
27.6
Weight (Cart with Sliding Door)
Max. Basket Weight Loaded
Weight (lb.)
210 lb.
210 lb.
25 lb.
Weight (kg)
95.4 kg
95.4 kg
11.4 kg
Weight (Cart with Solid Steel Door) Weight (lb.)
210 lb.
210 lb.
25 lb.
Weight (kg)
95.4 kg
95.4 kg
11.4 kg
UCCSM20-T
877-877-2269 | blackbox.com
Page 15
Chapter 1: Specifications Table 1-2. Power Strip Specifications Part Number
Automated Power Controller
Included Power Strips
UCCSM18T, UCCSM18H
(1) 4-outlet, 4-bank automated power controller with ”alwayson outlet,” 15-minute increments, 100–125 V, 50–60 Hz, 15 amp max.
(2) 12-outlet, 15 A max.
UCCSL18T, UCCSL18H UCCSS20T, UCCSS20H
(2) 12-outlet, 15 A max. (2) 12-outlet, 15 A max.
UCCSS30T, UCCSS30H,
(3) 12-outlet, 15 A max.
UCCSM27T, UCCSM27H
(3) 12-outlet, 15 A max.
UCCSS-12-36T, UCCSS-12-36H
(3) 12-outlet, 15 A max.
UCCSM-10-10T UCCSM-10-10H
(1) 12-outlet, 15 A max.
UCCSM-10-20T, UCCSM-10-20H
(2) 12-outlet, 15 A max.
UCCSM-10-30T, UCCSM-10-30H, UCCSM-10-30TP, UCCSM-10-30HP, UCCSM-10-30H-HASP, UCCSM-10-30T-HASP, UCCSM-10-30H-SO
(3) 12-outlet, 15 A max.
UCCSM-12-36T, UCCSM-12-36H, UCCSM-12-36H-SO, UCCSM-12-36H-14C, UCCSM-12-36H-15C, UCCSM-12-36T-15C, UCCSM-BIN1-36T, UCCSM-BIN-36T-FCM0, UCCSM-BIN1-36H, UCCSM-BIN1-36H-FCM0
(3) 12-outlet, 15 A max.
UCCSS30T-S, UCCSS30H-S
(2) Cambrionix Power Pad 15S units and power supplies
Page 16
877-877-2269 | blackbox.com
UCCSM20T
Chapter 1: Specifications Table 1-2 (continued). Power Strip Specifications Part Number
Automated Power Controller
Included Power Strips
UCCSM-12-24T, UCCSM-12-24H
(1) 4-outlet, 4-bank automated power controller with ”alwayson outlet,” 15-minute increments, 100–125 V, 50–60 Hz, 15 amp max.
(2) 12-outlet, 15 A max.
UCCSM-14-42T, UCCSM-14-42H
(4) 12-outlet, 15 A max.
Table 1-3. Charging Units included with Carts. Part Number
Intelligent Charging System
Included Power Strips
UCCSM18T-ILC, UCCSM18H-ILC
(1) Intelligent Charging System Unit (SDILCU4)
(2) 12-outlet, 15 A max.
UCCSL18T-ILC, UCCSL18H-ILC
(2) 12-outlet, 15 A max.
UCCSM27T-ILC, UCCSM27H-ILC
(3) 12-outlet, 15 A max.
UCCSM-10-30T-ILC, UCCSM-10-30H-ILC
(3) 12-outlet, 15 A max.
UCCSM-12-36T-ILC, UCCSM-12-36H-ILC
(3) 12-outlet, 15 A max.
UCCSM-12-24T-ILC, UCCSM-12-24H-ILC
(2) 12-outlet, 15 A max.
UCCSM20-T
877-877-2269 | blackbox.com
Page 17
Chapter 1: Specifications Table 1-3. Accessories Specifications Part Number
Accessory
Specs
UCCSHELFS
Small device shelf
Number of Slots: 10; Slot Dimensions: 1.32"W x 10"D
UCCSHELFM
Medium device shelf
Number of Slots: 9; Slot Dimensions: 1.52"W x 15"D
UCCSHELFL
Large device shelf
Number of Slots: 9; Slot Dimensions: 1.52"W x 17"D
UCCSHELF
Storage shelf
Height: 2U
UCC-PPM
Pop-up power module
Recesses into top laminate of cart, 2-outlet, 110–125 V
UCCDRAWER-2U
2U Accessory Drawer
Height: 3.5"H (2U); Cable Access: 1.75"D; Weight: 15 lb. (6.8 kg)
UCCDRAWER-3U
3U Accessory Drawer
Height: 5.25"H (3U); Cable Access: 1.75"D; Weight: 18 lb. (8.2 kg)
UCCDIVIDER-S
PVC-coated divider for small shelves
—
UCCDIVIDER-ML
PVC-coated divider for medium and large shelves
—
UCCLINER-S-10
Shelf liner for UCC small 10-slot shelves
—
UCCLINER-S-12
Shelf liner for UCC small 12-slot shelves
—
UCCLINER-M
Shelf liner for UCC medium 9-slot shelves
—
UCCLINER-M-10
Shelf liner for UCC medium 10-slot shelves
—
UCCLINER-M-12
Shelf liner for UCC medium 12-slot shelves
—
UCCLINER-L
Shelf liner for UCC large shelves
—
UCCBIN1KIT
6-Device Charging Cart Basket Kit for Deluxe, Basic, and 30-Device Standard Carts
Page 18
Dimensions: 5"H x 8.25"W x 10.875"D (12.7 x 20.9 x 27.6 cm);
877-877-2269 | blackbox.com
UCCSM20T
Chapter 2: Overview 2. Overview 2.1 Introduction The iPad®, Chromebook®, Tablet, and Laptop Cart is designed to store, charge, and transport tablets, e-readers, laptops, netbooks, and other similar devices. Units are available with capacities for 10, 18, 20, 24, 27, 30, 36, or 42 separate storage slots. Each unit plugs into a typical 120-volt 15-amp outlet. Carts are available with sliding or solid-steel doors. Syncing and intelligent charging carts are also available. Please read these operating instructions carefully. They contain important advice concerning the use and safety of your cart. This Cart must only be used for its intended purpose in accordance with these operating instructions.
2.2 What‘s Included • iPad, Chromebook, Tablet, and Laptop Cart with 10-, 18-, 20-, 24-, 27-, 30-, 36-, or 42-device capacity; assembled • (4) casters (installed), including: (2) locking swivel casters and (2) non-locking fixed casters • (1) Automated Power Controller or Intelligent Charging System Unit (installed) • Power Strips (installed): See the power strips specifications in Table 1-2 on the previous page. • Cart handle with mounting hardware (to be installed by user) • (1) user‘s manual • (2) sets of keys
UCCSM20-T
877-877-2269 | blackbox.com
Page 19
Chapter 2: Overview 2.3 Hardware Description Cable Grommet or Pop-Up Power Module
Ventilation
Laminate Top
Handle and Power Cord Wrap Removable Rear Door
Cable Access
Sliding Door Non-Locking Casters
Locking SwivelCasters
Figure 2-1. Front and back of cart with sliding door.
Cable Grommet or Pop-Up Power Module
Ventilation
Laminate Top Handle and Power Cord Wrap
Removable Rear Door
Solid Steel Door
Non-Locking Casters
Cable Access
Locking SwivelCasters
Figure 2-2. Front and back of cart with solid steel door.
Page 20
877-877-2269 | blackbox.com
UCCSM20T
Chapter 3: Configuration and Setup 3. Configuration and Setup Remove and discard all packaging materials and then lock the lockable casters. Open and inspect the Cart to verify all doors, locks, and casters are working properly. Do not plug the Cart into a wall outlet until all configurations and setup are complete.
3.1 Installing the Handle The handle/cord wrap installs on the side of the cart with the locking swivel casters. NOTE: The casters swivel on one side of the Cart and are fixed on the other. Consider maneuverability options before installing the handle. Step 1: Locate the side of the cart with the locking swivel casters. Step 2. Place the handle so that the holes in the brackets are aligned with the threaded holes in the side panels. Phillips-head screws
Handle
Phillips-head screws
Figure 3-1. Handle assembly. Step 3. Using a Phillips-head screwdriver, tighten four of the Phillips-head screws into the threaded holes.
UCCSM20-T
877-877-2269 | blackbox.com
Page 21
Chapter 3: Configuration and Setup 3.2 Routing the Cable (UCCSS20T, UCCSS20H, UCCSS30T, UCCSS30H) 1. A t the back of the cart, loosen the two screws on the cable manager, pull up on the top section of the cable manager, and place the device side of the charging cable into one of the slots. (See Figure 3-2.)
Cable manager
Loosen screws on cable manager and pull up
Route cable to the front of the cart
Power Strip Wrap excess cable around cable wrap
Charger
Figure 3-2. Small shelf routing instructions. 2. Replace the top section of the cable manager and tighten the screws. 3. R oute the device side of the charging cable to the front of the cart and repeat step 1 for the front cable manager. 4. Wrap any excess cable around the cable wrap on the back of the shelf. 5. Plug the charger power plug into the power strip located below the shelf.
Page 22
877-877-2269 | blackbox.com
UCCSM20T
Chapter 3: Configuration and Setup Loosen screws on cable manager and pull up
Cable manager
Route cable to the front of the cart
Figure 3-3. Routing the cable. 3.3 Fastening the Power Bricks and Routing the Cable (UCCSM18T, UCCSM18H, UCCSM27T, UCCSM27H, UCCSL18T, UCCSL18H) 1. A ttach the wrapped cord and power brick to the back of the shelf using the hook and loop strap. Keep some extra cable unwrapped to plug into the power strip. (See Figure 3-4.) 2. Loosen the two screws on the cable manager, pull up on the top section of the cable manager, and place the device side of the charging cable into one of the slots. 3. Replace the top section of the cable manager and tighten the screws. 4. R oute the device side of the charging cable to the front of the cart and repeat step 2 for the front cable manager (see Figure 3-3). UCCSM20-T
877-877-2269 | blackbox.com
Page 23
Chapter 3: Configuration and Setup 5. Plug the charger power plug into the power strip located below the shelf. Route cable to the front of the cart
Loosen screws on cable manager and pull up
Cable manager
Power block and cord
Power strip
Figure 3-4. Fastening the power brick and routing the cable.
Page 24
877-877-2269 | blackbox.com
UCCSM20T
Chapter 3: Configuration and Setup 3.4 Installing the Cambrionix PowerPad 15S Syncing Units (UCCSS30H-S and UCCSS30T-S Only) Charge and sync up to 10 devices per locker or 30 devices per cart at the same time. The USB charge and sync device works with nearly all e-learning devices — including Chromebook computers, iPad devices, mobile phones, e-readers, 3D glasses, and other tablets. The synchronization is achieved through a terminal interface (in the 16th USB port) which also allows you to control, monitor, and update the USB charge and sync device with the latest firmware. It is perfect for schools, businesses, and other organizations that require numerous devices to be charged and synced at the same time.
Figure 3-5. USB charge and sync device installed in Syncing Cart (UCCSS30HS or UCCSS30T-S).
UCCSM20-T
877-877-2269 | blackbox.com
Page 25
Chapter 3: Configuration and Setup 3.5 HASP Option (UCCSM-10-30H-HASP and UCCSM-10-30T-HASP) A HASP lock option is available on the UCCSM-10-30H-HASP and UCCSM-10-30T-HASP carts.
Hasp for optional padlock
Figure 3-6. HASP lock option on the UCCSM-10-30H-HASP. 3.6 Pop-Up Power Port Option (UCCSM-10---SM-10-30HP Only) A popup power port is available for maximum safety.
Figure 3-7. Popup power port.
3.7 Standoff Brackets Option UCCSM-10-30H-SO and UCCSM-12-36H-SO carts use standoff brackets to create a shelf using the power strips in the back. This ensures that power adapters don't fall.
Page 26
877-877-2269 | blackbox.com
UCCSM20T
Chapter 3: Configuration and Setup 3.8 Using the Intelligent Charging System (-ILC at end of product code) The Intelligent Charging System Module arrives installed in your cabinet. 3.8.1 Display Tour Power Icon
Charge Button
AUX Button
Charging USB Port Manage Button Port LEDs
LED Display
Reset Button
Figure 3-8. Front of SDILCU4. Back
Power Connector
Auxiliary Outlet
Charging Ports
Figure 3-9. Back of SDILCU4.
UCCSM20-T
877-877-2269 | blackbox.com
Page 27
Chapter 3: Configuration and Setup 3.8.2 To Begin Charging • Connect to Power • Select Charging Mode (Choose from Charge Mode or Manage Mode.)
CHARGE MODE: Best used if all devices are powered off and connected at the same time. Power is discontinued when batteries reach full charge to conserve energy.
MANAGE MODE: Best used if all or some devices are left on or are returned at different times. Charging continues until it is manually stopped.
NOTE: The charging system should always be in MANAGE mode in order to charge iPads and devices that remain in sleep mode.
Page 28
877-877-2269 | blackbox.com
UCCSM20T
Chapter 3: Configuration and Setup 3.8.3 Basic Functions
Charge Button Pressing the CHARGE button will start charge mode. This is best used when all devices are powered down and returned to the cart at the same time. Charging will automatically stop when all batteries are 100% charged. You can also stop charging at any time by pressing the CHARGE button a second time.
Manage Button Pressing MANAGE button will start manage mode and turn on the auxiliary power. This mode will continuously monitor and distribute power until manually stopped. This mode is best used if some of the devices may be left on when connected or if devices are connected at different times. Press the button again to stop manage mode.
Auxiliary Power Button Controls power to any peripherals that are plugged into the AUX power strip in the back of the cart. If the AUX devices must be operational during charging then the system must be in manage mode. Be aware that this may lengthen charging time.
UCCSM20-T
877-877-2269 | blackbox.com
Page 29
Chapter 3: Configuration and Setup
Charging Port LEDs Indicates which sections of the cart are active. The charging unit controls this automatically, ensuring that all devices inside are charged in the fastest, most efficient way possible. When all four quadrant LEDs are solid green, charging is complete.
Power Icon Indicates when the cart is connected to power and is ready.
Reset Button The Intelligent Charging System is protected with its own circuit breaker. If it encounters misuse such as plugging in unsupported devices or if there is a power surge, the circuit will trip and the reset button will pop out. To reset the cart simply press it back in. Please first ensure that everything is plugged in properly and that only supported devices are connected before resetting.
Page 30
877-877-2269 | blackbox.com
UCCSM20T
Chapter 3: Configuration and Setup 3.9 Basket Distribution System UCC carts with baskets (UCCBIN1KIT) instead of slots include: • UCCSM-BIN1-36T • UCCSM-BIN1-36H • UCCSM-BIN1-36T-FCM0 • UCCSM-BIN1-36T-FCM0 The baskets can also be ordered separately: • UCCBIN1KIT Figures 3-10 through 3-12 show the UCCBIN1KIT basket.
Baskets installed in cart.
Basket, side view.
Basket, top view. UCCSM20-T
877-877-2269 | blackbox.com
Page 31
Chapter 4: Using Your iPad, Chromebook, Tablet, and Laptop Cart 4. Using Your iPad, Chromebook, Tablet, and Laptop Cart 4.1 Charging Your Computers • After the devices have been loaded into the Cart, plug the power cord of the Cart into a suitable receptacle. • Locate the internal power switches on the timer and power strips of the Cart and push the switches to the ON position.
4.2 Moving Your iPad, Chromebook, Tablet, and Laptop Cart • Turn the timer power switch to the off position. • Remove the Cart plug from the wall receptacle and wrap the cord around the cord wrap or handle. • Close and secure sliding or solid-steel doors. • Your Cart comes equipped with two fixed casters and two locking swivel casters. Unlock the casters before moving the Cart to a new location. • When you reach your desired destination, lock the casters to prevent the cart from moving and plug the Cart into a wall receptacle.
Page 32
877-877-2269 | blackbox.com
UCCSM20T
Chapter 4: Using Your iPad, Chromebook, Tablet, and Laptop Cart
Timer
Power cord
Cable access ports
To wall outlet
Figure 4-1. Plug the cart into the wall.
UCCSM20-T
877-877-2269 | blackbox.com
Page 33
Chapter 4: Using Your iPad, Chromebook, Tablet, and Laptop Cart 4.3 Timer Instructions Before using your timer: • For your safety, we recommend that a qualified electrician test the circuit you will plug the cart into. The circuit should be checked for ground integrity and appropriate branch circuit protection. • The cart’s ground prong must be present for safe operation. If the plug is damaged or if the ground prong has been removed, it should be replaced by a qualified electrician. • Using the cart, including plugging it in or unplugging it, plugging in or unplugging the laptop(s) or other electrical equipment, or operating the control switch must be done with adult supervision. The timer comes preset from the factory to alternate power between the power strips at 15-minute intervals. All power strips cannot charge simultaneously. By plugging the cart power cord into an approved outlet and flipping the red switches located on the timer and power strips, the cart will begin charging. To end power, turn the red switch on the timer off and unplug the cart from the wall outlet.
Page 34
877-877-2269 | blackbox.com
UCCSM20T
NOTES
UCCSM20-T
877-877-2269 | blackbox.com
Page 35
Black Box Tech Support: FREE! Live. 24/7.
Tech support the way it should be.
Great tech support is just 60 seconds away at 724-746-5500 or blackbox.com.
About Black Box Black Box Network Services is your source for an extensive range of networking and infrastructure products. You’ll find everything from cabinets and racks and power and surge protection products to media converters and Ethernet switches all supported by free, live 24/7 Tech support available in 60 seconds or less. © Copyright 2016. Black Box Corporation. All rights reserved. UCCSM20T, version 5
877-877-2269 | blackbox.com
