Transcript
IPL, 124L (AUST,NZ), 2010-08, 545 10 34-50
124L (AUST,NZ) Spare parts Ersatzteile Pièces détachées Reserve onderdelen Repuestos Reservdelar
Parts List No.
PARTS LIST
Replaces
Date
10/09/09
MODEL
R
545103450
124L (AUST/NZ)
NOTE : Illustration may differ from actual model due to design changes.
545103450 - 8/28/09
Page:
1
WARNING
8
2 3
4
5 6
All repairs, adjustments and maintenance not described in the Operator’s Manual must be performed by Qualified Service Personnel.
7
11
10
9
12
13 14
21 22
19 20
16 17
15
23
18
Ref.
Part No.
1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18.
545125301 545062002 530016448 530016449 530016454 545066001 545067001 545030601 530015820 530150076 545081878 530059185 530016152 545007507 545081704 530052285 530015814 530015820
Description
Assy-Cable/Wire Harness Housing-Throttle (RH) Screw Screw Spring-Trigger Trigger Housing-Throttle (LH) Switch Bolt Handle-Assist Kit-Driveshaft (Incl. 14,19,20,22,23) Clamp-Handle Wingnut Flexshaft 57” Kit-Shield (Incl. 16,17) Limiter-Line Screw Bolt
= New Part Number For This IPL
Ref.
19. 20. 21. 22. 23.
Part No.
530016014 530015775 530016152 545150701 530096099
Description
Screw Screw Wingnut Bracket-Shield Gearbox 1”
Not Shown 545059101
Decal-Warning
= Refer to the Service Reference Indicated for more information.(Located at the END of the IPL)
1
Parts List No.
MODEL
R
545103450
PARTS LIST
Replaces
Date
10/09/09
124L (AUST/NZ)
NOTE : Illustration may differ from actual model due to design changes.
545103450 - 8/28/09
Page:
2
1 2 4 18
3
16
5
17
66 65
6
19
15
7
64
8
9
63 62
20
25
26
24
61
23
21 22
10
27
60
14
67
13
28
12 11
29 30
31
59 58 57
Gasket Kit 56
55 54
53 52 51
32 33
50
40
49 44
39
34 35
41
45
42 43
38 37
46
36
Ref.
Part No.
1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21.
530150253 530016101 530057844 530058709 545008086 530035596 545008084 530016400 952030249 545008084 545008084
22. 23. 24.
530057851 530016448 545029901
530095646 530069599 530023877 530150350 545008084 530059780 545180870
Description
Filter Nut - Carb. Screw Lever - Choke Bulb - Purge Kit-Carb. Gasket (Incl 7,63) Adaptor - Carb. Foam - Gasket (kit) Bolt Plug - Spark (RCJ-6Y) Seal - Cylinder (kit) Seal - Crankshaft (kit) Washer Assy - Starter Cup Coupling - Starter Assy - Fuel Filter Kit - Fuel Line (Incl. 17) Fitting - Fuel Line Assy - Cap w/ret.(Incl. 19) O-Ring - Fuel Cap (kit) Isolator - Fuel Tank Kit - Fuel Tank (Incl. 15,16,17,18,19,20) Shroud - Rear Screw Kit - Rope
= New Part Number For This IPL
Ref.
Part No.
25. 26. 27. 28. 29. 30. 31.
530150318 530016426 545029603 545029801 545029701 530016468 545106301
32. 33. 34. 35. 36. 37. 38.
530058982 530015241 530150440 530016449 545104901 545030501 574031501
39. 40. 41. 42. 43. 44. 45. 46.
545008084 530015897 530039224 530039227 530016456 530016463 530094189 530016469
Description
Handle - Starter Screw Starter Hsg. w/eyelet Kit - Starter Spring Kit - Starter Pulley Screw Assy-Starter Hsg.(Incl. 24,25,27,28,29,30) Bolt - Muffler Screw Shield - Heat Screw Guard - Muffler Kit - Spark (Incl. 33) Kit - Muffler (Incl. 32,33,37,39) Gasket-Paper Met.(kit) Screw Module Assy - Leadwire Screw Washer Washer - Clutch Screw
Ref.
Part No.
47. 48. 49. 50. 51. 52. 53. 54. 55. 56. 57. 58. 59. 60.
530016470 530015768 530016456 545017501 530150039 545050405 530057852 530039242
61. 62. 63. 64 65. 66. 67.
545008084 530015897
545013401 530015162 530019283
545084601 530057846 530059796 545008084
47
48
Description
Screw Nut Screw Assy - Fan Housing Assy - Clutch Drum Kit - Clutch Assy. Spacer Flywheel Crankcase - cast Bearing Crankshaft - Assy Retainer - Piston Pin Ring - Piston Kit - Cyl./Piston (Incl. 60,61) Seal - adaptor (kit) Screw Kit - Carb. (Incl. 3,4,5) Airbox Cover - Air Box Assy - Knob Kit - Gasket (Incl. 5,7,10,11,19,39,61)
= Refer to the Service Reference Indicated for more information.(Located at the END of the IPL)
Parts List No.
545103450
PARTS LIST
Replaces
Date
10/09/09
545103450 - 8/28/09
MODEL
R
NOTE : Illustration may differ from actual model due to design changes.
Service Reference Note : Due to product improvements, your unit may have a different carburetor. Please refer to the serial number on your unit and order the parts below. Serial Number - 2007-087N and lower, please use the following parts: Page 2, Ref.# 63 - 545030401 Kit - Carburetor
Serial Number - 2007-088N thru 2007-333N, please use the following parts: Page 2, Ref.# 63 - 545006060 Kit - Carburetor
Serial Number - 2007-334N and higher, please use the following parts: Page 2, Ref.# 63 - 545081850 Kit - Carburetor
Service Reference Note : Due to product improvements, your unit may have a different starter system. Please refer to the serial number on your unit and order the parts below.
15
Serial Number - 2008-009N and lower, please use the following parts: Ref.# 12,13,14,15 - 545180844 Kit - Starter System 14
13
12
14 13 12
Serial Number - 2008-010N and higher, please use the following parts: Page 2, Ref.# 12 - 530015828 Washer Page 2, Ref.# 13 - 545102303 Assy - Starter Cup Page 2, Ref.# 14 - 545099201 Coupling - Starter
124L (AUST/NZ) Page:
3
Parts List No.
PARTS LIST
Replaces
Date
10/09/09
MODEL
R
545103450 545103450 - 8/28/09
NOTE : Illustration may differ from actual model due to design changes.
124L (AUST/NZ) Page:
4
Service Reference Note : Due to product improvements, your unit may have a different piston, cylinder & crankcase. Please refer to the serial number on your unit and order the parts below. Serial Number - 2008-365N and lower, please use the following parts: Ref.# 9,55,60 - 545003378 Kit - Cyl., Piston, Crankcase Ref.# 57 - 545030001 Kit - Crankshaft
9
60
55
57
10
60
55
57
Serial Number - 2009-001N and higher, please use the following parts: Page 2, Ref.# 10 - 545008084 Seal - Cylinder (kit) Page 2, Ref.# 55 - 545195601 Crankcase Page 2, Ref.# 57 - 545220101 Assy-Crankshaft Page 2, Ref.# 60 - 545008082 Kit - Cylinder / Piston
