Transcript
ILLUSTRATED PARTS LIST MODEL NO. 96011021900 CUSTOMER CATALOG NO. PP25H48 PRODUCT NO. 960 11 02-19
403711 Rev. 2 02.13.06 TR Printed in the U.S.A.
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 DECALS 3 2
9
9
10
8 4
3 14
12 16 13 8 11
5
6 18 12
1 7
17 15 KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 13
PART NO.
KEY NO.
DESCRIPTION
532 40 28-36 532 17 27-43 532 18 61-63 532 17 27-40 532 14 50-05 532 16 88-69 532 19 68-41 532 18 21-66 532 18 90-51 532 18 61-64 532 19 63-57 532 17 83-02 532 19 68-42
14 15 16 17 18 --------
Decal, Engine Decal, Ins. Strg. Whl. Decal, Hood RH Decal, Fender Decal, Btry DNGR/PSN P/L Sym. Decal, Tick Mark Decal, Warning Eng. Sym. Decal, Cutfinger CE Decal, Side Panel Decal, Hood LH Decal, Deflector Warning Sym Decal, Oper. Cruise Sym Decal, Saddle Shift Cutfinger Sym.
KEY NO.
WHEELS & TIRES 1 2
5,8 4,10
7 3,9 6
11
PART NO. 532 40 03-89 532 17 52-91 532 15 97-63 532 15 97-37 532 14 08-37 532 16 69-60 532 16 25-98 532 13 83-11 532 19 17-87 532 19 17-86 532 40 37-10 532 40 37-11 PART NO.
1 2 3 4 5 6
532 05 91-92 532 06 51-39 532 10 62-22 532 05 99-04 532 12 51-21 532 00 02-78
7
532 12 49-59
8 9 10 11 --
532 12 51-22 532 12 20-82 532 12 49-26 532 19 32-68 532 14 43-34
DESCRIPTION Decal, Warning Sym CE Decal, V-Belt Decal, Chassis Hot Muffler Decal, Brake/Clutch Sym Decal, Saddle Brake Parking Decal, By Pass Lt Hydro Decal, Load Limit Decal, Handle Lift Pad Footrest LH Pad Footrest RH Manual, Operator's Manual, Parts DESCRIPTION Cap Valve Tire Stem Valve Tire F Ts 15 x 6 0 - 6 Service Tube Front (Service Item Only) Rim Asm 6" front Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) Rim Asm 8" Rear Service Tire R Ts 20 x 10-8 C Service Tube Rear (Service Item Only) Cap, Hub Axle Tire, Sealant (10 oz. Tube)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
wheel_1
2
TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 SCHEMATIC 03088_197429
BATTERY SOLENOID A
RED
RED
M
RED
AMMETER (OPTIONAL)
FUSE
STARTER
PTO (DISENGAGED)
WHITE
S B M A1 G L A2
WHITE
IGNITION SWITCH
BLACK
CLUTCH / BRAKE (PEDAL UP) GRAY
SEAT SWITCH (NOT OCCUPIED) BLACK
BLACK
GRAY
BLACK
REVERSE SWITCH
SHORTING CONNECTOR NOT IN REVERSE
BLACK
BLACK
ELECTRIC CLUTCH BLACK RED
BLACK / WHITE
IGNITION UNIT HOUR METER
BLUE
FUEL SHUT-OFF SOLENOID
FUEL LINE
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES) BLACK
(OPTIONAL)
BLUE
CHARGING SYSTEM OUTPUT 16 AMP DC @ 3600 RPM
(IF SO EQUIPPED)
28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
RED
REGULATOR ALTERNATOR ORANGE
LIGHT SW BROWN
BLACK
BLACK
IGNITION SWITCH POSITION
CIRCUIT
OFF RUN/OVERRIDE
M+G+A1 B+A1
RUN START
B+A1 B + S + A1
“MAKE”
L+A2 03088
NOTE HEADLIGHTS YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE REMOVABLE NON-REMOVABLE BATTERY, BUT HAVE THEIR CONNECTIONS CONNECTIONS OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WIRING INSULATED CLIPS WILL CHANGE WITH ENGINE NOTE: IF WIRING INSULATED CLIPS SPEED. AT IDLE THE LIGHTS WERE REMOVED FOR SERVICING OF WILL DIM. AS THE ENGINE IS UNIT, THEY SHOULD BE REPLACED SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. TO PROPERLY SECURE YOUR WIRING.
3
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 ELECTRICAL 22
21
90
42 24
41
43
27
40 26
27
27
25 34
16 33
30
50
51
2
27 29
46
1 91 55
28 197429
8
y tter Ba
_27
4
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 ELECTRICAL
KEY NO.
PART NO.
DESCRIPTION
1 2 8 16 21 22 24 25 26 27 28 29 30 33 34 40 41 42 43 46 48 50 51 55 90 91
532 14 49-27 874 76 04-12 532 18 64-91 532 17 61-38 532 18 37-59 532 00 41-52 532 12 47-80 532 14 61-48 532 17 51-58 873 51 04-00 532 14 54-91 532 19 27-49 532 19 33-50 532 14 04-01 532 11 07-12 532 19 74-29 871 11 04-08 532 13 15-63 532 19 25-07 532 19 81-38 532 14 08-44 532 17 46-53 532 14 04-05 817 49 05-08 532 18 04-49 532 19 02-70
Battery Bolt Hex Hd 1/4-20 unc x 3/4 Box Battery Switch Interlock Push-In Harness Asm Light W/4152j Bulb Light #1156 Cable Battery Cable Battery Fuse Nut Keps Hex 1/4-20 unc Cable Ground 21" Blk 6 Ga 90T Switch Seat Switch Ignition Key Ignition Switch Light Harness Ignition Bolt Fin Hex 1/4-20 unc x 1/2 Cover Terminal Solenoid Gauge Hourmeter Adapter Ammeter Switch PTO Ring Retainer PTO Screw Thdrol 5/16-18 x 1/2 Typ Cover Terminal Battery Strap Battery
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
5
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 CHASSIS AND ENCLOSURES 259 264 258
28
263
17 261
10
217
39
18 10 30
58
278
90 31 209
5
159
5 209
11
208
9 209
208
207 64
1
144 209
13
26 60
26
142
143
142 145
37 209
2
37
14
74 209
208
38
38
14
chassis_elite sv_pro_13
6
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 CHASSIS AND ENCLOSURES
KEY NO.
PART NO.
DESCRIPTION
1 2 5 9 10 11 13 14 17 18 26 28 30 31 37 38 39 58 60 64 74 142 143 144 145 159 207 208 209 217 258 259 261 263 264 278
532 17 46-19 532 17 65-54 532 15 52-72 532 40 51-15 872 14 06-08 532 17 49-96 532 17 52-55 817 49 06-08 532 19 45-88 532 18 49-21 873 80 06-00 532 18 38-28 532 19 46-18 532 13 99-76 817 49 05-08 532 17 57-10 532 17 47-14 532 18 93-50 872 14 06-06 532 15 47-98 873 68 06-00 532 17 57-02 532 18 66-89 532 17 55-82 532 15 65-24 532 19 46-22 817 67 05-08 817 67 06-08 817 00 06-12 532 19 46-19 532 18 97-55 532 18 97-54 532 18 97-53 532 18 38-33 532 18 38-32 532 19 16-11
Chassis Stamping Drawbar Bumper Hood/Dash Dash Bolt Rdhd Sqnk 3/8-16 unc x 1 Panel Dash Lh Panel Dash Rh Screw Thdrol 3/8-16 x 1/2 Hood Bumper Hood Nut Lock w/Insert 3/8-16 unc Grille Lens Asm (Includes Key #'s 258, 259, 261, 263, 264) Fender Bracket Screw Thdrol 5/16-18 x 1/2 Bracket Asm Pivot Mower Rear Bracket Pivot Duct Air Bolt RDHD SQNK 3/8-16 x 3/4 Dash Lower Stlt Nut Crownlock 3/8-16 Plate Reinforcement Bracket Swaybar Chassis Bracket Ft Rest Rod Pivot Chassis Hood Cupholder Screw Thdrol 5/16-18 x 1/2 Screw Thdrol 3/8-16 x 1/2 Screw Hexwsh Thdr 3/8-16 c-x 3/4 Consol Fuel Window Lens Grille RH Lens Grille LH Insert Grille Bezel Grille RH Bezel Grille LH Screw 10 x 3/4 Single Lead-Hex
NOTE:
All component dimensions given in U. S. inches 1 inch = 25.4 mm
7
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 DRIVE
57 120
243
89
254 63
66 219 19 59 221 274 61 224
221
69
19
276
214
222 51
221
225 220
96
21
236
218
19 263 241232 242 235
240 233
273 38 272 217 244 35
32 30
62
16
239 33 239
253
6 231
36 35 53
28 26 55
96
19
22
29
27
25 24 77
252
15
52 32
77 1
drive-hydro.stlt_65
120 37
95
241
49
34
36 19
52
39
151 51
47
221
238
48 27
223
237 52
150
20
51 226
202
50
17 65
251 228
223 226 227
234
9 41
229
223
19
56
74
30 75 78
76
8
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 DRIVE
KEY NO.
PART NO.
1
------
6 9 15 16 17 19 20 21 22 24 25 26 27 28 29 30 32 33 34 35 36 37 38 39 41 47 48 49 50 51 52 53 55 56 57 59 61 62 63 65 66 69 74 75 76 77
817 06 05-12 532 17 93-34 874 49 05-44 873 80 05-00 532 12 61-97 873 80 06-00 532 17 39-37 532 18 65-71 532 17 58-96 873 35 06-00 532 19 20-36 819 13 13-16 876 02 04-12 532 17 57-65 532 07 16-73 532 16 95-92 874 76 05-12 872 14 05-06 532 17 55-78 532 12 01-83 819 21 16-16 532 12 49-63 532 17 91-14 872 11 06-22 532 17 55-56 532 12 77-83 532 15 44-07 532 12 32-05 872 11 06-12 873 68 06-00 873 68 05-00 532 19 96-52 532 10 57-09 817 06 06-20 532 14 02-94 532 16 96-91 817 12 06-14 532 12 48-72 532 17 46-07 810 04 07-00 532 15 47-78 532 14 24-32 532 13 70-57 532 12 17-49 812 00 00-01 532 12 35-83
KEY NO.
DESCRIPTION
78 89 95 96 120 150 151 202 214 217 218 219 220 221 222 223 224 225 226 227 228 229 231 232 233 234 235 236 237 238 239 240 241 242 243 244 251 252 253 254 263 272 273 274 276
Transaxle (Order parts from transaxle manufacturer) Hydro Gear Model 347-0510 Screw 5/16-18 x 3/4 Clutch Elec Bolt Hex Flghd 5/16-18 Gr. 5 Nut Lock Hex W/Ins. 5/16-18 unc Washer 1-1/2 OD x 15/32 ID x .250 Nut Lock Hex W/Wsh 3/8-16 unc Bolt Hex 7/16-20 x 4 x Gr. 5-1.5 Knob Custom Control Cruise Rod, Brake Nut, Hex Jam 3/8-16 unc Spring, Brake Rod Washer Pin Cotter 1/8 x 3/4 CAD. Rod, Parking Brake Cap, Brake, Park Bracket, Transaxle Bolt Hex Hd 5/16-18 unc x 3/4 Bolt Rdhd Sqnk 5/16-18 unc x 3/4 Shaft, Foot Pedal Bearing, Nylon Washer Pin, Roll Pulley, Composite, Flat Bolt Rdhd 3/8-16 unc x 2-3/4 Gr. 5 Keeper, Belt Idler Flat Pulley, Idler, V-Groove Bellcrank Clutch Grnd Drw Stl Retainer, Belt Bolt Nut Crownlock 3/8-16 unc Nut, Crownlock 5/16-18 unc Link, Clutch Spring, Return, Clutch Screw 3/8-16 x 1-1/4 V-Belt, Ground Drive Keeper, Center Span Screw 3/8-16 x .875 Cover, Pedal Pulley, Engine Washer Keeper Belt Engine Screw Hex Wsh Hi-Lo 1/4 x 1/2 unc Spacer, Axle Washer 25/32 x 1-1/4 x 16 Ga. E-Ring Key, Square
PART NO. 532 12 17-48 532 19 22-59 532 19 56-31 532 12 47-88 873 90 06-00 532 17 54-56 819 13 32-10 872 11 06-14 532 17 47-35 532 17 94-33 532 17 47-13 532 17 48-39 532 17 47-11 872 14 06-06 873 68 07-00 532 17 48-40 532 17 47-36 532 17 47-12 532 17 49-02 532 17 47-10 532 17 90-32 532 17 64-51 532 40 25-50 532 17 55-70 532 17 48-56 532 17 48-58 532 17 48-57 532 12 89-03 532 17 01-65 532 17 58-07 817 49 05-08 532 17 56-10 873 93 04-00 874 78 04-12 532 19 07-36 817 49 05-10 817 06 05-16 819 13 16-16 532 17 94-22 817 00 06-16 817 00 06-12 817 67 05-08 532 17 96-10 532 17 56-46 532 17 80-62
DESCRIPTION Washer 25/32 x 1-5/8 x 16 Ga. Console, Shift Bypass Asm Retainer Spring 1" Zinc/Cad Nut Lock Flg 3/8-16 unc Spacer Retainer Washer 13/32 x 2 x 10 Ga. Bolt Rdhd 3/8-16 x 1-3/4 Gr. 5 Link Transaxle Pedal Reverse Asm Arm Control Pedal Reverse Bracket Frest Pdl Ctrl. Hyd Bracket Mtg. Pedal Control Bolt Rdhd Sqnk 3/8-16 unc x 3/4 Nut Crownlock 7/16-14 unc Washer Nylon 11/16 ID x .060 Pedal Forward Arm Control Pedal Forward Bolt Pivot Spacer Cam Reverse Pedal LT Bolt Shoulder 5/16-18 Washer Serrated 5/16 x .75 Strap Torque Actuator Cruise Disengage Pawl Control Cruise Lever Control Cruise Sector Control Cruise Bolt Shoulder 3/8-16 unc 1/44 Bolt Shoulder 5/16-18 Arm Mtg. Cruise Sector Screw Thdrol 5/16 x 1/2 Spring Return Cruise Control Nut Centerlock 1/4-20 unc Bolt Fin Hex 1/4-20 unc x .75 Bracket Anti-Rotation Screw 5/16-18 x 5/8 Screw 5/16-18 x 1 Washer 13/32 x 1 x 16 Ga. Washer .3125 x .615 x 16 Ga. Screw 3/8-16 x 1 Screw Hexwsh Thdr 3/8-16 x 3/4 Screw Thdrol 5/16-18 x 1/2 Pad Pedal Reverse Cover Pedal Forward Clip Retainer
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
9
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 STEERING ASSEMBLY 38 97 34 39
1
41
42 37 37 36
44 67
67
68 88
91
46 8 6
43 71
67 13 65 46
2 29
8 6
87 5 17
87 3 32
5
11
68
4 26
29
43
82 40 43 15
28
29
15 15
10
steering_pl.lt_57
10
30
95 8
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 STEERING ASSEMBLY
KEY NO. 1 2 3 4 5 6 8 10 11 13 15 17 26 28 29 30 32 34 36 37 38 39 40 41 42 43 44 46 65 67 68 71 82 87 88 91 95 97
PART NO. 532 19 45-95 532 18 47-06 532 16 98-40 532 16 98-39 532 12 49-31 532 12 17-48 812 00 00-29 532 17 51-21 810 04 06-00 532 13 65-18 532 14 52-12 532 19 07-53 532 12 68-47 819 13 14-16 817 00 06-12 876 02 04-12 532 19 27-57 810 04 05-00 532 15 50-99 532 15 29-27 532 19 46-03 819 11 38-12 873 54 06-00 532 18 67-37 532 16 96-33 532 12 17-49 532 19 07-52 532 12 12-32 532 16 03-67 872 11 06-18 532 16 98-27 532 17 51-46 532 19 99-78 532 17 39-66 532 17 51-18 532 17 55-53 532 18 89-67 874 78 05-64
DESCRIPTION Wheel Steering Axle Casting Iron Lt Spindle Asm LH Spindle Asm RH Washer Thrust .75 x 1.230 Washer 25/32 x 1-5/8 x 16 Ga Ring Klip #t5304-75 Draglink Washer Lock Hvy Hlcl Spr 3/8 Spacer Bearing Axle Front Nut Hex Flange Lock Shaft Strg Bushing Link Drag Washer 13/32 x 7/8 x 16 Ga. Screw 3/8-16 x 3/4 Pin Cotter 1/8 x 3/4 Rod Asm Tie Washer Lock Hvy Hlcl Spr. 5/16 Bushing Strg Screw TT #10-32.5.3/8 Flange Insert Cap Strg Wh Washer 11/32 ID x 2-3/8 OD x 12 Ga. Nut Crownlock 3/8-24 Adaptor Wheel Strg Boot Steering Washer 25/32 x 1 1/4 x 16 Ga. Extension Shaft Steering Cap Spindle Fr Top Blk Spacer Axle Brace Bolt Rdhd Sqnk 3/8-16 unc x 2-1/4 Brace Axle Steering Asm. Bracket Susp Chassis Front Washer Flat .781 x 1-1/2 x .14 Bolt Shoulder 7/16-20 Clip Steering Washer Harden .793 x 1.637 x 060 Bolt 5/16-18 unc x 4"L Gr. 5
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
11
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 ENGINE 8 2
3
1
14 38
13 81 17
17
25
10
6 5
72
32 31
33
37 112 41
45
33 23
29
4
OPTIONAL EQUIPMENT engine-bs.twin_43
Spark Arrester KEY NO. 1 2 3 4 5 6 8 10 13 14 17 23 25
PART NO.
KEY NO.
DESCRIPTION
532 17 07-71 Control Throttle 817 72 04-08 Screw Thd Cut 1/4-20 x 1/2 -------Engine Briggs Model 445777 Order parts from engine manufacturer 532 14 97-23 Muffler Twin Lo-Twin 532 15 99-55 Tube, Manifold Lh 532 16 05-89 Tube, Manifold Rh 532 17 18-77 Bolt 5/16-18 Unc x 3/4 w/Sems 532 16 27-97 Shield Heat Muffler 532 16 39-51 Gasket Muffler 532 14 84-56 Tube Drain Oil Easy 817 06 06-24 Screw, Thdrol 3/8-16 x 1-1/2 Tap/R 532 16 98-37 Shield Brn/Dbr Guard 532 19 17-17 Choke Control
29 31 32 33 37 38 41 45 72 81 112
PART NO. 532 13 71-80 532 17 90-22 532 18 29-02 532 12 34-87 532 14 21-58 532 18 16-54 532 13 92-77 817 00 06-12 532 18 39-06 873 51 04-00 532 12 49-52
DESCRIPTION Kit Spark Arrestor (Flat Scrn) Tank Fuel Cap Asm Fuel Clamp Hose Blk Line Fuel Plug Drain Oil Easy Stem Tank Fuel Screw Hex Wsh Thdrol 3/8-16 Screw Socket Head 5/16-18 x 1 Nut Keps Hex 1/4-20 unc Bushing
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
12
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 SEAT ASSEMBLY 1
14 10
8
9
24
7
5
8
9 7
25
11 16
6
5
22
15
21
2
13 17
12
41
seat_lt.knob_18
KEY NO. 1 2 5 6 7 8 9 10 11 12 13 14
PART NO. 532 18 90-22 532 14 05-51 532 14 50-06 873 80 06-00 532 12 41-81 817 00 06-16 819 13 16-14 532 19 55-30 532 16 63-69 532 17 46-48 532 12 12-48 872 05 04-12
KEY NO.
DESCRIPTION
15 16 17 21 22 24 41 25
Seat Bracket Pivot Clip Push-In Hinged Nut Lock Hex w/Ins. 3/8-16 unc Spring Seat Cprsn 2 250 Blk Zi Screw 3/8-16 x 1 Washer 13/32 x 1 x 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch Bushing Snap Blk Nyl 50 Id Bolt Rdhd Sht Nk 1/4-20 x 1-1/2
PART NO. 532 12 12-49 532 12 37-40 532 12 39-76 532 17 18-52 873 80 05-00 819 17 19-12 532 14 06-75 532 12 70-18
DESCRIPTION Spacer Split 28x 88 Yel Zinc Spring Cprsn 1 310 Blk Pnt Nut Lock 1/4 Lge Flg Gr. 5 Zinc Bolt Shoulder 5/16-18 unc-2A Nut Lock Hx W/Ins 5/16-18 unc Washer 17/32 x 1-3/16 x 12 Ga. Strap Asm. Fender Bolt Shoulder 5/16-18 x .62
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
13
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 MOWER DECK 46
45
49 52
46
49 37
33
45
130
32
33
43 42
31 49
121
42
30 49
30 39
126 98
99
32 47
50 97
30 111
97
50 21
110
4
57
116
31
131
117
21
56 184
133 118
119
100
55 92
54 72 92
3
24 25
21
1
26 29 17
6
28
16
27
5 15 18
19 14
20
13 18 11 48 8 mower_deck.48lowcost_stlt_1
14
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 MOWER DECK
KEY NO.
PART NO.
DESCRIPTION
1 3 4 5 6 8 11 13 14 15 16 17 18 19 20 21 24 25 26 27 28 29 30 31 32 33 37 39 42 43 45 46 47 48
532 18 03-58 532 13 80-17 532 19 42-08 532 12 46-70 532 17 80-24 532 17 43-65 532 18 00-54 532 17 51-47 532 17 43-58 532 11 04-85 532 17 44-93 872 11 06-10 872 14 05-05 532 13 28-27 532 17 43-78 873 68 05-00 532 10 53-04 532 17 81-02 532 11 04-52 532 18 17-07 819 11 10-16 532 13 14-91 532 17 39-84 532 18 76-90 532 17 34-36 532 40 02-34 532 17 79-68 532 17 43-75 532 12 20-52 532 17 43-73 532 18 08-06 532 13 77-29 532 18 08-08 532 17 43-68
Deck Weldment Mower 48 Bracket Asm., Sway Bar Pin Cotter 5/16 Bow Tie Lock Retainer Spring Bar Sway Deck Bolt, 7/16 Asm. Blade Blade Shaft Asm. Mandrel Sealed Housing Mandrel 48" Bearing, Ball, Mandrel Stripper, Mower Bolt Rdhd Sq Neck 3/8-16 x 1.25 Bolt, Carriage 5/16-18 x 5/8 Bolt, Hex Hd, Shoulder 5/16-18 Baffle, Vortex Mower Nut, Crownlock 5/16-18 unc Cap, Sleeve Spring, Torsion Nut, Push Shield, Deflector Mower Washer 11/32 x 5/8 x 16 Ga. Rod, Hinge Screw, Thdroll, Washer Head Washer, Spacer Mower Vented Pulley, Mandrel Nut, Flg. Top Lock Pulley, Idler, Flat Pulley, Idler, Driven Spacer, Retainer Arm, Idler Secondary Cover, Mandrel Deck Screw, Thdroll. 1/4-20 x 5/8 V-Belt, Mower, Secondary V-Belt, Mower, Primary
KEY NO. 49 50 52 54 55 56 57 72 92 97 98 99 100 110 111 116 117 118 119 121 126 130 131 133 184 ---
PART NO. 873 90 06-00 872 11 06-12 532 17 58-20 874 78 06-16 872 14 06-08 532 15 59-86 532 15 69-41 819 13 13-12 873 80 06-00 532 17 85-15 532 17 94-79 532 18 99-93 872 11 06-16 532 17 50-16 532 17 46-10 532 19 34-06 532 17 48-73 873 93 06-00 819 12 14-14 532 17 43-71 532 17 43-72 817 00 06-16 819 13 16-06 872 11 05-06 532 17 39-79 532 17 43-57
DESCRIPTION Nut, Lock 3/8-16 unc Bolt, Carriage 3/8-16 x 1-1/2 Gr. 5 Pulley Idler Flat 46 Pri. Drive Bolt Fin Hex 3/8-16 x 1 Bolt Rdhd Sqnk 3/8-16 x 1 Bar Pnt Adjusting Wheel Gauge Pin Head Rivet Washer 13/32 x 13/16 x 12 Nut Lock Hex w/Ins 3/8-16 Washer Hardened Spring Primary Drive Pulley Idler "V" Bolt RDHD Sqnk 3/8-16 unc x 2 Arm Spring Secondary Arm Spring Fixed Tension Bolt, Shoulder Gauge Wheel Nut, Centerlock 3/8-16 unc Washer 3/8 x 7/8 x 14 Ga. Spring Secondary Drive Arm, Idler, Primary Deck Screw 3/8-16 x 1.0 Washer 13/32 x 1 x 6 Ga. Bolt Rdhd Sqnk 5/16-18 unc x 3/4 Keeper Belt Idler Mandrel Assembly (Includes Housing, Shaft and Shaft Hardware Only-Pulley Not Included) 532 18 63-53 Replacement Mower, Complete (Std Deck)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
15
REPAIR PARTS TRACTOR - MODEL NUMBER PP25H48 (96011021900), PRODUCT NO. 960 11 02-19 MOWER LIFT 29
28
27 25 24 23
7
41
8
5
49
37 38
30 40
1 36
13
50 4
13
3 26
6 2
6 5 4
11
13
12 51
49 52 31
13 51
32 13
32
20
53
49 18
54 16 17 15 13 54
KEY NO. 1 2 3 4 5 6 7 8 11 12 13 15 16 17 18 20 23 24 25 26
PART NO. 532 19 84-17 532 19 80-70 532 18 88-22 812 00 00-02 819 21 16-21 532 12 01-83 532 12 56-31 532 17 07-70 532 17 53-70 532 17 53-71 532 12 46-70 532 17 55-62 873 35 08-00 532 17 56-89 873 80 08-00 532 19 42-09 532 11 08-07 819 13 10-16 532 12 48-74 532 16 94-84
DESCRIPTION Wire Asm Inner/Spring W/Plunger Shaft Asm Lift RH w/Inf Pin Groove E Ring #5133-62 Washer 21/32 x 1 x 21 Ga. Bearing Nylon Blk 629 Id Grip Handle Fluted Blk Button Plunger Link Lift LH Link Lift RH Retainer Spring Plate Asm Susp Front Nut Jam Hex 1/2-13 unc Trunnion Nut Lock w/Wsh 1/2-13 unc Pin Cotter 7/16 Bow Tie Lock Nut Special Washer 13/32 x 5/8 x 16 Ga. Spring Retainer Clip
KEY NO. 27 28 29 30 31 32 36 37 38 40 41 49 50 51 52 53 54
16
PART NO. 532 12 69-71 873 35 06-00 532 13 80-57 532 15 02-33 532 17 62-05 532 17 59-94 532 15 50-97 532 12 39-35 817 06 05-16 819 11 24-10 532 15 50-98 532 14 52-12 532 11 04-52 819 17 14-16 532 17 53-78 532 17 58-02 532 17 55-60
lift-rh.1pc.stlt_13
DESCRIPTION Rod Adj Lift Nut Hex Jam 3/8-16 unc Knob Inf 3/8-16 unc Blk W/sym Trunnion Infin Height Trunnion Nut Lift Link 7/16-20 Indicator Height STLT Plug Hole Blk 1.485/1.515 Dia. Screw 5/16-18 x 1 Washer 11/32 x 1-1/2 10 Ga. Scale Ind. Height Blk. Nut Hex Flange Lock Nut, Push Phos & Oil Washer 17/32 x 7/8 x 16 Ga. Arm Susp. Rear Lh Arm Susp. Rear Rh Pin Flange
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
