Transcript
SW-4000M-PMCL SW-8000M-PMCL
4096 pixels 8192 pixels
200 kHz 100 kHz
Sweep Series
CMOS Monochrome Line Scan Cameras
With M-42x1 mount
Monochrome CMOS Line Scan Camera Resolution: 4096 pixels in a line (SW-4000M-PMCL) 8192 pixels in a line (SW-8000M-PMCL) Scan rate: 200,000 lines per second - 200 kHz (SW-4000M-PMCL) 100,000 lines per second - 100 kHz (SW-8000M-PMCL) Sensor scanning width: 30.72 mm Video signal output: 8-bit or 10-bit via Mini Camera Link Interface: Power over Mini Camera Link JAI SDK and GenICam compliant F-mount and M-42x1 mount
www.jai.com
W W W. S T E M M E R- I M A G I N G . C O M
Specifications for Sweep SW-4000M-PMCL and SW-8000M-PMCL Dimensions
Specifications
Responsivity
Gamma LUT Auto Level Control (ALC)
Interface Operating temperature Storage temperature Humidity Vibration Shock Regulations Power and power consumption
Pin no. M-42x1 mount
DC12～24 V+/-10%
GND
6
I
RxD in
7
O
TxD out
O
TTL Out1
GND
10
I
TTL In1
11
POo
DC(+12V) in
DC12～24 V+/-10%
GND
12-pin connector
Mini-CL interface 13
Mini-CL interface Pin no.
Pin no.
Attribute
Signal
Power In
DC(+12V) in
Name
Remarks
1,14
2(-),15(+) GND
RESERVED
5
GND
14
Pin no.
In/Out
Name
2(-),15(+)
O
TxOUT0
Power 1,14
DC12～24 V+/-10%
3(-),16(+)
4
1
26
In/Out
GND
O
TxOUT0 3(-),16(+)
O
4(-),17(+) TxOUT1 5(-),18(+)
Power
Note
Note
DC in
DC in Data output
Data output
O
TxOUT1
O
TxOUT2
O
TxClk
CL Clock
6
I
4(-),17(+) RxD in
O
TxOUT2 6(-),19(+)
O
TxOUT3
Data output
7
O
TxD out
5(-),18(+) GND
O
7(+),20(-)
I
SerTC (RxD)
8(-),21(+)
O
LVDS serial control (CC1 only)
TTL Out1 6(-),19(+)
O
9(-),22(+) TxOUT3
I
O
Manual/Auto (Digital All: 0dB ~ +24dB (x1~x16) 1-Step = x0.01) 9 Step 1.0 ~ 0.45 256 point Exposure time (Exposure auto): 4µs~1s Digital All (Gain auto): 0dB ~ +24dB(x1~x16) 1STEP = x0.01 Power over Mini Camera Link NB: Running Power over Camera Link requires 2 cables -5°C to +45°C -25°C to +60°C 20 - 80% non-condensing 10G (20 Hz to 200 Hz XYZ direction) 80G CE (EN 61000-6-2, EN 61000-6-3), FCC part 15 class B PoCL or 12pin (12V to 24V DC + 10%). 435 mA/ 5.22W max. (full frame @ 12V) NB: Running Power over Camera Link requires 2 lines
I
11
POo
TTL In1
7(+),20(-)
TxClk
10(+),23(-)
Trigger input (CC1 only) Data output
CC1 (Trigger)
(CC1 only)
SerTC (RxD) 11,24
8(-),21(+)
O
12,25
SerTFG (TxD)
NC serial control LVDS NC(CC1 only)
9(-),22(+)
I
CC1 (Trigger)
Trigger input (CC1 only)
10(+),23(-)
CC1 (Reserved)
(CC1 only)
11,24
NC
DC12～24 V+/-10%
GND
Spectral Response 12,25
13,26
GND
Shield
NC
SW-4000M-PMCL
SW-4000 Sensitivity
13,26
1.00
CL Clock
SerTFG (TxD)
CC1 (Reserved)
I
DC(+12V) in
12
GND
Shield
0.90
Mode A (small well)
0.80 0.70
Mode B (large well)
0.60 0.50
A B
0.40 0.30 0.20 0.10 0.00 400
M-42x1 mount Metric screw thred
42 mm
RESERVED
12
9
16 mm
4
DC In / Trigger
8
44 mm
DC(+12V) in GND
9 Connector pin-out
3
46.5 mm
Power In
8
1
Diameter:
Remarks
3 5
2
Flange Back Distance:
Signal GND
2
10
F-Mount Bayonet
Attribute
1
Flat shading
Mount type:
Lens mounts
DIGITAL I/O -1
12-pin connector
Line start Off: Line period -3.08µs Timed: 4µs to 15.148ms Trigger Width: 4µs~
Shading correction Gain
DC IN / TRIG
8-bit or 10-bit via Mini Camera Link connector GPIO in/out via 12-pin connector
Trigger mode Exposure mode (Exposure time)
POWER/TRIG
DIGITAL I/O -2
53 DN/(nJ/cm2) (Mode-B, Large well) (@10bits, gain= 1x, λ = 650nm) SW-8000M: 23 DN/(nJ/cm2) (@10bits, gain= 1x, λ = 650nm) 60 dB @10bit (Typical) 31.875 to 85MHz adjustable
S/N ratio Pixel clock Video signal output Inputs/Outputs
DC In / Trigger
500
600
SW-8000M-PMCL
700 wavelength (nm)
800
900
1000
SW-8000 Sensitivity
0.50 0.45 0.40
62 x 62 x 53 mm (w/o projection part) 320 g
Ordering Information SW-4000M-PMCL SW-8000M-PMCL
0.35 0.30 Sensitivity
Dimensions (H x W x L ) Weight
0.25 SW-8000
0.20
CMOS Monochrome Line Scan Camera (4096 pixels) CMOS Monochrome Line Scan Camera (8192 pixels)
0.15 0.10 0.05 0.00 400
500
600
700 wavelength (nm)
800
900
1000
JAI A·S cannot be held responsible for any technical or typographical errors and reserves the right to make changes to products and documentation without prior notification.
Cell size
F-mount
Company and product names mentioned in this datasheet are trademarks or registered trademarks of their respective owners. K-JAIO88-11/2016 ∙ Subject to technical change without notice. No liability is accepted for errors which may be contained in this document.
Sensor scanning width
CMOS line scan sensor JAI custom made sensor (APS-C) SW-4000M: 4096 pixels horizontal SW-8000M: 8192 pixels horizontal SW-4000M: 200 kHz (Full Camera Link 8-bit config.) SW-8000M: 100 kHz (Full Camera Link 8-bit config.) SW-4000M: 30.72 mm (Mode-A, Small well) 30.72 mm (Mode-B, Large well) SW-8000M: 30.72 mm SW-4000M: 7.5 um (H) x 7.5 um (V) (Mode-A, Small well) 7.5 um (H) x 10.5 um (V) (Mode-B, Large well) SW-8000M: 3.75 um (H) x 5.78 um (V) SW-4000M: 58 DN/(nJ/cm2) (Mode-A, Small well) (@10bits, gain= 1x, λ = 650nm)
Sensitivity
Scanning system Sensors type Sensor resolution (effective pixels) Scan rate (max)
Spectral response without lens Asia Pacific Phone +81 45 440 0154 Fax +81 45 440 0166
Americas Phone (Toll-Free) 1 800 445 5444 Phone +1 408 383 0300 June 2016 v2
Europe, Middle East & Africa Phone +45 4457 8888 Fax +45 4491 8880
Visit our web site on www.jai.com
Imaging is our passion. www.stemmer-imaging.com
STEMMER IMAGI NG Head Office Gutenbergstraße 9 - 13, D-82178 Puchheim Phone: +49 89 80902-0,
[email protected]
