Kenwood-kdc-722-service-manual

Transcript

CD RECEIVER KDC-7024/Y KDC-722 KDC-8023 © 2003-2 PRINTED IN JAPAN B53-0036-00 (N) 3379 SERVICE MANUAL CD mechanism operation description is not in this service manual. Please, refer to service manual X924030-0x (B51-7867-00). CD mechanism extension cord : W05-0935-00 Panel assy (A64-2981-01): KDC-722, (A64-2983-01): KDC-8023 50W 4 KDC-722 only COMPACT DIGITAL AUDIO Escutcheon (B07-3078-01) Panel assy (A64-2995-02): KDC-722/8023 Panel assy (A64-2987-01): KDC-7024/Y 50W 4 COMPACT DIGITAL AUDIO Escutcheon (B07-3078-01) Panel assy (A64-3003-02): KDC-7024/Y Escutcheon (B07-3078-01) Remote controller assy (RC-505) (A70-2040-05) : KDC-722 Mounting hardware assy (J21-9823-03) Remote controller assy (RC-420) (A70-2026-05) : KDC-8023 Plastic cabinet assy (A02-2731-03) Lever (D10-4674-04) x 2 Size AA battery (Not supplied) DC cord (ISO) (E30-4942-05) : KDC-7024/Y Screw set (N99-1723-05) : KDC-722/8023 DC cord (E30-6062-05) : KDC-8023 (E30-6106-05) : KDC-722 Antenna adaptor (T90-0552-05) : KDC-7024/Y Screw set (N99-1734-05) KDC-7024/Y,722,8023 HOW TO THE PANEL MECHANISM ASSEMBLY 1. Fixed the position of operation side (Fixed the horizontal position when the panel opened) q The mounting hardware (281) of operation side is rotation (A) into the stop position with close side. w As figure (B) line is just above and the gear (230) attached to pin. A 281 Rotary to the stop position B 230 This line attached just above Fig. B (This figure from look at B arrow) 284 2. The slider assembly insert to bottom chassis q The bracket for display panel (284) is leave down, insert to the chassis (702). (C) SW C 702 284 w The slider assembly insert to the chassis (702) after that shift (D) direction. e The bracket for display panel (284) is raised (E) direction. r Keep the raising conditions, the slider assembly is shift (F) direction. (Note) Do not bend the knob of chassis detection switch when the slider assembly insert. F SW E D 702 3 KDC-7024/Y,722,8023 BLOCK DIAGRAM AUX IN 8V (X25-966) Q59,60 IC2 TUNER FM AUDIO OUT PRE MUTE PRE OUT (REAR/NF) PRE MUTE PRE OUT (FRONT) AM CD Q102,103 CH AM+B 8V E-VOL & MPX 8V Q104 QUAL BUFFER 8V Q53 BUFFER S-METER SW5V IC4 SW5V SP OUT (FL) IC12 SP OUT (FR) IC1 RDS DECODER POWER IC SP OUT (RL) SP OUT (RR) IC8 CD MUTE DRIVER BU5V BU5V 8V SERVO CD4.7V WIRED REMO/ OPEL DISP I/F Q25,26 P-CON P CON Q23,24 ANT-CON CH u-COM ANT CON Q29 EXT AMP BACK UP EXT.AMP.CON Q30 DIMMER BU5V Q501 DIMMER BU5V TEL MUTE EEP5V TEL MUTE Q33 IC1 ACC DET EEPROM ACC Q32 B.U DET TDF UNIT (X16-208) DISPLAY UNIT (X16-214) Q1,2 IC7 RESET BU5V IC2 LCD DRIVER BU5V IC1 LCD DRIVER WITH KEY MATRIX BU5V BU5V Q6 PANEL SW5V IC13 MOTOR DR IC3 REMOCON IC14 MOTOR DR BU5V SW5V SW14V A8V Q9,34 SERVO SERVO Q11-14 ILL+B IC5 BU5V ROTARY ENCODER SW 14V Q6-8 SW5V SWITCH UNIT (X16-219) SW 5V Q4,5 SERVO PANEL MECHA BU5V Q3 A8V LCD BACK UP CD5.0V KEY KEY MATRIX RESET SW SW REG KEY ILL 3 KDC-7024/Y,722,8023 COMPONENTS DESCRIPTION ● SUB-CIRCUIT UNIT (X16-2080-10) Ref. No. IC1 Application/Function E2PROM Operation/Condition/Compatibility For security ● SUB-CIRCUIT UNIT (X16-2140-10) Ref. No. IC1 Application/Function LCD driver IC2 LCD driver IC3 Remote control sensor Operation/Condition/Compatibility KEY Input Q1 KEY scan start SW Q5, D26 VLCD AVR ON when the base goes “L”. Q6 Remote control sensor power supply SW ON when the base goes “L”. Q11 Dimmer control LCD back light control. OFF when the base goes “L”, ON when the base goes “H”. ● SWITCH UNIT (X16-2190-10) Ref. No. Q1 Application/Function Operation/Condition/Compatibility DSI (Disabled System Indicator) DSI blinks when the base goes “H/L” Q2 KEY illumination SW (GREEN) ON (KEY illumination green) when the base goes “H” Q3 KEY illumination SW (RED) ON (KEY illumination red) when the base goes “H” ● ELECTRIC UNIT (X25-966x-xx) Ref. No. 4 Application/Function IC1 System µ-com IC2 E-vol & N.C. & MPX IC3 Regulator IC for A8V IC4 Power IC IC7 Reset IC IC8 Logic IC for muting IC12 RDS decoder IC Operation/Condition/Compatibility IC13, 14 Motor driver IC for panel mechanism IC15 ROM IC For ROM correction. Q1, 2 B.U.5V AVR While BU is applied, BU5V AVR outputs +5V. Q3 SW5V When Q3’base goes Lo, SW5V outputs +5V. Q4, 5 SW14V When Q5’base goes Hi, SW14V outputs 14V. Q6~8 AUDIO 8V AVR When Q6’base goes Hi, A8V AVR outputs 8.4V. Q9, 34 SERVO+B AVR When Q34’base goes Hi, S+B AVR outputs 7.4V. Q11~14 ILL+B AVR When Q11’base goes Hi, AVR outputs 10.5V. Q23, 24 P-ANT SW When Q23’base goes Hi, P-ANT SW outputs 14V. Q25, 26 P-CON SW When Q26’base goes Hi, P-CON SW outputs 14V. Q27, 28 P-CON protection Protect Q27 by turning on when P-CON output is grounded. Q29 Ex Amp control buffer Q30 Small lamp det SW When Q30’base goes Hi, Q30 is turned on. Q32 BU det When Q32’base gose Hi, Q32 is turned on. Q33 ACC det When Q33’base gose Hi, Q33 is turned on. Q51, 52 Mute driver When a base gose Lo, mute driver is turned on. Q53 Noise buffer Q54 E-vol mute SW When a base gose Hi, mute SW is turned on. KDC-7024/Y,722,8023 COMPONENTS DESCRIPTION Ref. No. Application/Function Operation/Condition/Compatibility Q55, 56 Pre-out mute SW When a base gose Hi, Pre-out is muted. Q59, 60 Pre-out mute SW When a base gose Hi, Pre-out is muted. Q63 E2P 5V SW When Q63’base gose Lo, E2P 5V is out. Q102, 103 AM+B SW When Q102’base gose Hi, AM+B is out. Q104 Composite signal buffer for RDS MICROCOMPUTER’S TERMINAL DESCRIPTION ● SYSTEM MICROCOMPUTER : UPD703030GC015 (X25-966 : IC1) Pin No. Pin Name I/O Module Purpose / Description 1 PLL_DATA I/O Tuner Data output/input with F/E. 2 AM+B I/O Power supply AM+B. 3 (FM+B) O Power supply FM+B (S01 F/E only). 4 V_ILL PAN_E2P DATA I/O To panel V-ILL D/A converter (V-ILL, LCD), E2PROM data. 5 V_ILL PAN_E2P CLK I/O To panel V-ILL D/A converter (V-ILL, LCD), E2PROM clock. 6 EVDD - 7 EVSS - 8 AFS O Tuner Noise detection time constant switching. 9 BEEP O Audio Beep output. 10 REMO I Extra Remote control input (Panel, External display). 11 P_MUTE O Audio Power IC MUTE output. 12 (SVR) O Audio Power IC SVR discharge circuit control. CD CD mechanism data line. 13 IC2_SDA I/O Audio IC2 data line. Extra ROM correction data line. CD CD mechanism clock line. 14 IC2_CLK I/O Audio IC2 clock line. Extra ROM correction clock line. Truth table Processing Operation AM operation : H FM operation : H, Last FM : H (With RDS, RBDS model) FM seek, AF search : L, Receiving : H, Auto 0 : L Power OFF : L, All OFF : L, TEL mute : L Power OFF momentary power dropped : H (5 second) and then L 15 P_STBY O Audio Power IC STBY output. Power IC ON : H, Power IC OFF : L, All OFF : H 16 P_CON I/O Extra Power control. Power ON : H, Power OFF : Hi-Z, All OFF : Hi-Z 17 DIMMER_CONT O To panel Dimmer control (W-LED only). 18 TEST - TYPE2 I Extra Destination select. w w 19 Dimmer : Pulse control, Frequency : 1kHz, Normally : H Connect to GND. NC O Extra NC (MP3 mechanism model). 20 MUTE O Audio Mute output. 21 PRE_MUTEL O Audio PREOUT (L ch) mute. 22 PRE_MUTER O Audio PREOUT (R ch) mute. Output : L ON : OPEN, OFF : L M MUTE L is L : L (CD), Momentary power dropped : L, 2 zone, NAVI interrupt : Fixed H M MUTE R is L : L (CD), Momentary power dropped : L, 2 zone, NAVI interrupt : Fixed H 5 KDC-7024/Y,722,8023 MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. 23 BU_DET 24 ACC_DET 25 SW5V I/O Module Purpose / Description Truth table Processing Operation Backup : L, I Extra Momentary power dropped detection. I Extra ACC detection. With ACC : L, Without ACC : H Power supply 5V power supply. ON : L, OFF : Hi-Z Extra External amplifier control. Refer to external amplifier control. NC (Without EXT_AMP_CONT model) Output : L ON : L, OFF : H I/O EXT_AMP_CONT O NC O 27 DIMMER I Extra Small lamp detection. 28 ANT_CON O Extra Antenna control. 26 6 Pin Name 29 P_ON I/O Power supply 30 ILL_ON I/O Power supply 31 RESET - 32 XT1 No backup, momentary power dropped : H w Tuner ON : H, Other source With RDS last FM : H, Other source with RDBS TI ON last FM : H SW 14V, SW 5V control, AD reference Power ON : H, Power OFF : Hi-Z voltage control output. FL, illumination output. ON : H, OFF : Hi-Z - Sub clock. 32.768kHz Sub clock. 33 XT2 - 34 REGC - 35 X2 - Main clock. 20MHz 36 X1 - Main clock. 20MHz 37 VSS - 38 VDD - Communication request to external slave. Request : L 39 CLKOUT - 40 LX_REQ_M O 32.768kHz Connect to 1µF capacitor. LX 41 LX_MUTE I LX Mute request from external slave. Mute ON : H 42 LX_CON O LX External slave select. ON : H, OFF : L 43 LX_RST O LX Reset output to external slave µ-com. 44 NC O 45 TYPE0 I Extra Destination select. w Normally : L, After system reset : H (400ms or more) and then L NC (Without WMA, MP3 model) Output : L 46 TYPE1 I Extra Destination select. w 47 IC2_TYPE0 I Extra IC2 destination. w Extra IC2 destination. w 48 IC2_TYPE1 I 49 NC O NC Output : L 50 E2P5V I/O Power supply E2PROM, DA converter power supply control. ON : L, OFF : Hi-Z 51 DSI I/O To panel DSI control. ON : L, OFF : Hi-Z 52 L_CE O To panel Chip enable output to LCD driver. 53 L_INH O To panel Inhibit signal output to LCD driver. To panel VOL input. To panel VOL input. 54 VOL A I 55 BVDD - 56 BVSS - 57 VOL B I Normally : H, Reset, momentary power dropped : L 58 M_RST O CD Reset output to CD mechanism. Normally : H, Reset : L (Per mechanism control) 59 M_STOP O CD Stop request to CD mechanism. Stop : L, CD : H I CD DC down switch detection. Chucking : H I/O CD CD mechanism loading/eject switch. Stop, brake : Hi-Z, Loading : L, Eject : H 60 CD_SW3 61 LO/EJ 62 MOSW O CD CD mechanism motor driver switch. 63 FPM MOTOR B O P-mecha FPM mechanism (Slider) control. Loading, eject, brake : H e KDC-7024/Y,722,8023 MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name 64 FPM MOTOR F O P-mecha FPM mechanism (Slider) control. e 65 FPM MOTOR O O P-mecha FPM mechanism (Angle) control. e 66 FPM MOTOR C O P-mecha FPM mechanism (Angle) control. e O_DATA I/O Extra External display data input/output. External display NC (Without external display model) Output : L Extra External display clock input/output. External display NC (Without external display model) Output : L Extra External display chip enable input/output. External display NC (Without external display model) Output : L CD Mute request form CD mechanism. (R ch). ON : L (CD) 67 68 69 I/O NC O O_CLK I/O NC O O_CE I/O NC O 70 M_MUTER I 71 AVDD - 72 AVSS - Module Purpose / Description 73 AVREF - 74 M_MUTEL I CD Mute request form CD mechanism. (L ch). 75 PAN_DET I To panel Panel E2PROM detection. Truth table Processing Operation Connect to P_ON (29 pin). With : L, Without : H TEL mute : 1V or less, NAVI mute : 2.5V or more, PHONE I NC I 77 FPM SW4 I P-mecha 78 FPM SW1 I P-mecha FPM mechanism position detection. e 79 FPM SW2 I P-mecha FPM mechanism position detection. e 80 FPM SW3 I P-mecha FPM mechanism position detection. e 81 FPM PHOUT I P-mecha FPM mechanism position detection. e 82 S_METER I Tuner S-meter detection. Refer to S03 F/E control. 83 NOISE I Tuner FM noise detection. Refer to S03 F/E control. 84 IFC_OUT I Tuner F/E IFC OUT input. With station : 2.5V or more, refer to S03 F/E control. 85 NC (POWER_DET) I Extra Power IC DC offset detection. 03 model not used. Connect to GND. 86 NC O NC (Except J type) Output : L R_CLK I 76 87 Extra ON : L (CD) PHONE detection. J type 1V or less, 2.5V or more : NAVI mute NC (Without TEL-MUTE model) FPM mechanism position detection, Connect to GND. e mechanism detection. 3.75V or more : No mechanism, 1.25V or more : H, Less than 1.25V : L H : 2.2V or more Tuner RDS decoder clock input. NC (Without RDS, RBDS model) Connecto to GND. LX Receive request from external slave. Request : L NC I 88 LX_REQ_S I 89 KEY_REQ I To panel Communication request from LCD driver 90 CD_SW1 I CD Loading switch detection. Loading start power off : L 91 CD_SW2 I CD 12cm disc detection switch. 12cm disc power off : L R_QUAL I Tuner RDS decoder QUAL input. Tuner RDS decoder data input. 92 93 NC I R_DATA I NC (Without RDS, RBDS model) NC I 94 LX_DATA_S I LX 95 LX_DATA_M O LX Data output to external slave. 96 LX_CLK I/O LX Clock input/output with external slave. 97 L_DATAL I To panel Data input from LCD driver. 98 L_DATAS O To panel Data output to LCD driver. L_CLK O To panel Clock output to LCD driver. PLL_CLK I/O Tuner Clock input/output with F/E. 99 100 NC (Without RDS, RBDS model) Connecto to GND. Connecto to GND. Data input from external slave. 7 KDC-7024/Y,722,8023 MICROCOMPUTER’S TERMINAL DESCRIPTION Truth table w Destination port MODEL Destination DISPLAY TYPE2 TYPE1 TYPE0 KDC-X969 K FL 0 0 0 KDC-MP922 K FL 0 0 1 FX-9000 J FL 0 1 0 KDC-PSW9524 E FL 1 0 0 KDC-9023R KDC-X869 M (E) FL 1 0 1 K FL 0 1 1 KDC-8024 E FL - - - KDC-MP822 K LCD - 0 0 KDC-M7024 E LCD - 0 1 FX-5000 J LCD - 1 0 KDC-V7022 K LCD 0 0 0 KDC-X769 K LCD 0 0 1 KDC-722 K LCD 0 1 0 E LCD 0 1 1 M (K) LCD 1 0 0 KDC-7024 KDC-7024Y KDC-8023 Note : When FL model using TYPE2, K & J type (with ANT_CON model) : L, E type (without ANT_CON model) : H Destination(IC2) TYPE0 Market model L L Market model CRSC modiification L H OEM model CRSC modification H L OEM model CRSC and de-emphasis modification H H e FPM MOTOR Slide FPM mechanism operation FPM MOTOR B FPM MOTOR F 0 0 Standby 1 0 Backward operation 0 1 Forward operation 1 1 Brake Angle 8 TYPE1 FPM mechanism operation FPM MOTOR O FPM MOTOR C 0 0 Standby 1 0 Angle open direction 0 1 Angle close direction 1 1 Brake KDC-7024/Y,722,8023 TEST MODE ● How to enter the test mode While pressing and holding the Preset 1 and Preset 3 keys, reset the unit. ● How to exit from the test mode While holding the Preset 6 key, reset the unit. (Note) The test mode cannot be terminated by reset the unit, ACC OFF, power OFF and Panel detached, momentary power down. ● Initial status in the test mode • • • • • • • • • • • • Sources : ALL OFF Display : All segments are lit. Volume : -10 dB (displayed as “30” ) Loudness : OFF CRSC : OFF regardless of the presence of switching function. SYSTEM Q : Flat WOW : All OFF BEEP : When pressing any keys, the buzzer generates a beep at any time. AUX : ON MENU SYSTEM Q : OFF Variable model : Default is white Multifunction : Source dependency (Preset, SCAN, etc.) ● Special display in Tuner mode When any of the following messages is displayed in Tuner mode, the F/E may be abnormal. • “TNE2P NG” : The EEPROM is set to the default (unstable values) because the F/E was shipped without passing through the adjustment process, etc. • “TNCON NG” : Communication with the F/E is not possible. ● Forced switching of K3I • • • • Each press of the Preset 6 key in Tuner mode should switch K3I from AUTO → Forced Wide → Forced Middle → Forced Narrow → AUTO. The initial status is AUTO and the display shows these modes as follows. AUTO : FMA Forced Wide : FMW Forced Middle : FMM Forced Narrow : FMN ● Test mode specifications of the CD receiver • Forced ejection is inhibited in the reset start operation. When the unit is reset while a CD is loaded in it, the CD is not recognized by resetting. • Each press of the Track Up key jumps to the following track numbers: No. 9 → No. 15 → No. 10 → No. 11 → No. 12 → No. 13 → No. 22 → No. 14 → No. 9 (The cycle restarts from here.) • Each press of the Track Down key jumps to the previous track number to the track being played. • When the number of total trucks of the MP3 disc or the WMA disc is less than 9, 1st truck is played. • When the disc media is CD, A short press of the Preset 1 key jumps to the track number 28. • When the model is equipped the CD mechanism assembly adapted for MP3 or MP3/WMA disc, the mechanism name and version number are displayed during the FL model is lower stand and Display mode of LCD model is DNPS. ● Audio-related specifications • Pressing the ✽ key on the remote initiates the audio adjustment mode. • BL/F key on the Fader initials. • Continuous holding of a remote control key is inhibited, and workings are short press of any keys. • Bass, Middle and Treble are adjusted in 3 steps of -8 / 0 / +8 with the Track Up/Down keys (Default value at 0). • Balance is adjusted in 3 steps of L15 / 0 / R15 with the Track Up/Down keys (Default value at 0). • Fader is adjusted in 3 steps of R15 / 0 / F15 with the Track Up/Down keys (Default value at 0). • HPF is adjusted in 2 steps of OFF / 170Hz (or 220Hz) with the Track Up/Down keys (Default value at OFF). • LPF is adjusted in 2 steps of OFF / 120Hz with the Track Up/Down keys (Default value at OFF). • Bass f, Bass Q, Bass EXT, Middle f, Middle Q and Treble f are not dealt with by the audio adjust. • The WOW key pass during the audio adjustment as following steps. Order Mod. Display TruBass FOCUS SRS q OFF OFF OFF SRS WOW OFF w ON OFF OFF SRS TruBass ON e OFF LOW OFF FOCUS LOW r OFF HIGH OFF FOCUS HIGH t OFF OFF ON SRS ON y ON HIGH ON SRS WOW HIGH 9 KDC-7024/Y,722,8023 TEST MODE ● Menu-related specifications ● Panel mechanism • A short press of the Q key initiates the menu mode. • Pressing the DNPP key on the remote initiates the Menu mode. • Continuous holding of a remote control key is inhibited, and workings are short press of any keys. • Contrast is adjusted in 3 steps of 0 / 5 / 10 with the Track Up/Down keys (Default value at 5). • Auto-panel close inhibition when set-in the CD. • The panel operation inhibition at power ON/OFF and ACC ON/OFF. • The panel position changing Eject ← → Last with a short press of the PLAY/PAUSE keys. ● Backup current measurement When the unit is reset while ACC is OFF (i.e. by turning Backup ON), the MUTE terminal goes OFF in 2 seconds in place of 15 second. (The CD mechanism is not activated at this time.) ● Special display when the display is all on Pressing the Preset keys while the power is ALL OFF displays the following information. [PRESET 1] Version display (8 digits, Month/Day/Hour/Minute) (Display) SYS xxxxxxxx : System microcomputer PAN xxxxxxxx : FL model only ● Other specifications • No displays such as “CODE OFF/ON” during Power-ON. • The LINE MUTE inhibition time is one second from 10 seconds when start-up the test mode. • Do not write the security code with the security jig on the test mode. • Do not write the serial with the serial writing jig on the test mode. • OEM display output is not stop if OEM display not connection on the test mode. ● Switching the frequency span (K/M type) While holding the Preset 1 key and Preset 5 key, reset the unit. MEM xxxxxxxx : 4 contrasts FL model only [PRESET 2] Serial number display (8 digits) (Display) SNo xxxxxxxx [PRESET 3] Short press : View power ON time. (The All OFF period is not counted.) 2 seconds long press/hold : Clear power ON time at the power ON time displaying. IC2 TYPE0 IC2 TYPE1 Description (48 pin) Low Low q Trade model (Initial quantify) 2 seconds long press/hold : Clear CD operation Low High w Trade model (CRSC change) time at the CD operation time displaying. High Low e OEM model-ready CRSC change High High Max. 60000 (hours) Short press : Display CD operation time. (Display) CDTim xxxxx [PRESET 5] S03F/E models are response to OEM models option at put in µ-com 2 pin. Its setting are following steps. (47 pin) (Display) PonTim xxxxx [PRESET 4] ● Response to OEM setting (Destination of electronic volume setting) Max. 60000 (hours) Short press : Display CD ejection count. r OEM model-ready CRSC & de-emphasis change 2 seconds long press/hold : Clear CD ejection count at the CD ejection count displaying. (Display) EjeCnt xxxxx [PRESET 6] Max. 60000 (times) Short press : Display Panel open/close count. 2 seconds long press/hold : Clear Panel open/close count at the Panel open/close count. (Display) PnCnt xxxxxx FM key Display ROM collection version. (Display) ROM R xxx AM key Max. 600000 (times) Invalid : “R – – –” Display panel E2PROM condition. (Display) P–ROM OK (Registered code) P–ROM NG (Code is write in error) P–ROM WAIT (Unregistered code) P-ROM NON (Panel security nonfunctional) 10 ● Security-related information 1. Forced Power ON mode (All models) Even when the security (Cord) is approved, resetting the unit while holding the Q and Preset 4 keys makes it possible to turn the power ON for 30 minutes. After 30 minutes have elapsed, it is not possible to return to the previous condition unless the unit is reset again. (Security code is do not clear at this mode. Put the power on fillin.) KDC-7024/Y,722,8023 TEST MODE 2. Method of registration of the security code after EEPROM (F/E) replacement (Code security model) 1) Enter the test mode. (See How to enter the test mode) 2) Press the MENU key to enter the Menu mode. 3) When the message “Security” is displayed, press and hold the Track Up/Down key for 1 second to enter the security registration mode. 4) Enter the code using the FM/AM/Track Up/Track Down keys. FM key : Number up AM key : Number down Track Up key : Cursor right shift Track Down key : Cursor left shift 5) Hold down the Track Up key for at least 3 seconds and the message, “RE-ENTER” appears, so once again enter the code according to Step 4 above. 6) Press and hold the Track Up key for 3 seconds until “APPROVED” is displayed. 7) Exit from the test mode. (See 2. How to exit from the test mode) (Note 1) All Clear is not applicable to the security code of this model. (Note 2) When the F/E changed, need re-inscription because the panel security is clear. 3. Simple way to clear the security code (K type only) 1) During code request mode, press the Track UP key for at least 3 seconds while holding down the AUTO key. (– – – – will disappear) 2) Enter, “KCAR” with the remote controller as described below. • Press the remote controller 5 key twice, and press the Track Up key. (Enters a “K” ) • Press the remote controller 2 key three times, and press the Track Up key. (Enters a “C” ) • Press the remote controller 2 key once, and press the Track Up key. (Enters an “A” ) • Press the remote controller 7 key twice, and press the Track Up key. (Enters an “R” ) 3) Security function is canceled and unit sets to All-Off mode. 4) Code request mode appears if a mistake was made in entering the numbers. 4. How to inscription the panel security code 1) Enter the test mode. 2) Pressing the AM key on all lighting, check the “P-ROM WAIT” display. 3) The NEXT key is long press 2 seconds, writing the code. 4) Display is “P-ROM OK”. 5) Exit from the test mode. (Note) E2PROM connection is NG when display is “P-ROM NG”, so detach the panel and rewrite after the display is “PROM WAIT”. This code can not clear. ● Check the SRAM Output (Hi) to the SRAM_CHECK terminal on 101 pin when SRAM is function properly on the panel of 4 gradation FL models. ● Check the Flash ROM 1) Display to the following effect at ALL OFF by assortment system computer and panel for cover the customization model attach the panel with no Flash ROM. • Customization system computer + Flash ROM panel : All lighting • Non customization system computer + Non Flash ROM panel : All lighting • Customization system computer + Non Flash ROM panel : Panel NG • Non customization system computer + Flash ROM panel : Panel NG 2) Output (Hi) to the FLASHROM_CHECK terminal on 102 pin when Flash ROM is function properly. 3) Flash ROM data is initialized when pressing the AM key long hold at all lighting. Display is “Data Erase ....” in data erasing mode. Do not touch anything this mode. When the data erase completed, display is “Erase OK!!”. If display is “Erase NG!!!!!!”, Flash ROM data unable erase for some kind or another factors. When same effect as pressing the AM key long hold and data erase once again, Flash ROM is defective. 11 A B C D E KDC-7024/Y,722,8023 1 PC BOARD (COMPONENT SIDE VIEW) ELECTRIC UNIT X25-966x-xx (J74-1474-12) CN1 CN2 12 2 11 1 IC4 R56 R31 R55 R32 8 C6 R129 R128 R143 B Q26 L6 C250 D13 C253 C254 R300 C50 R48 EB 22 23 C252 C41 C42 33 34 Q3 4 IC1 X1 C200 R250 L5 50 51 76 75 X25-966x-xx IC R262 R234 R235 R236 R237 R215 R217 R216 R253 R252 R251 R202 C207 C208 8 IC15 R214 D20 R207 1 IC5 5 1 100 L4 RST 1 25 26 R256 X2 R268 R275 R257 R201 C46 TEST 5V C110 1 44 R259 EB 5 D26 D25 R200 C213 R102 R103 14 IC2 R33 1 8 C45 R35 Q57 IC8 16 15 C2 R22 R283 R206 R205 R209 R208 EB Q32 C1 11 R34 Q58 R141 7 EB R36 R24 C131 R139 R138 C132 C49 EB R23 R47 EB Q55 Q56 R140 R45 EB D17 D16 C105 D4 B R21 EB E Q59 R265 R282 R204 R203 R211 R210 C104 D14 12 R218 R219 R220 Q5 B BE R46 Q60 D15 CN3 R260 C102 Q4 C108 C126 E BE 4 C33 BE B E C128 R228 R230 E R125 W1 Q1 Q9 C31 C2 Q25 C109 5 DATA CLK CN4 24 1 C112 1 28 CN6 C111 C700 CN5 15 L2 C113 7 Refer to the schematic diagram for the values of resistors and capacitors. P1 6 12 C34 E I G O D3 C32 Q24 B C7 C8 B Q13 D6 E C256 R127 IC3 3 25 C2 D1 J1 L1 R105 Q8 1 1 BE Q11 24 C100 16 R126 R112 Q12 2 9 BE 2 R43 1 R44 2 1 Q Address 1 4C 2 4C 3 3A 4 2E 8 4B 15 5C 1 3A 3 5B 4 3B 5 3B 8 3A 9 4A 11 2A 12 2A 13 2A 24 2B 25 3D 26 3C 32 4B 55 4B 56 4B 59 3B 60 3F 102 3F 104 4F F G H I J KDC-7024/Y,722,8023 1 SUB-CIRCUIT UNIT X16-2140-10 (J74-1479-02) D12 SWITCH UNIT X16-2190-10 (J74-1484-12) D17 A1 R307 R303 R302 TUN D6 C33 S10 6 S9 73 2 72 W2 D29 C258 D30 25 C257 D31 D13 24 S14 S15 D16 1 R402 CN7 S19 D4 C410 S3 4 D9 3 S12 SCRL D3 L12 S7 D7 S18 D11 S2 SRC BE S17 Q2 D15 Q3 BE 5 D18 ATT S1 S21 D16 1 VOLUME CONTROL D19 D20 EB Q1 D1 1 AUTO D14 D8 S13 4 D2 2 24 144 6 D19 D18 1 X16-2140-10 S6 S11 4 IC3 2 D10 3 D11 D17 X3 S8 L13 R407 Q104 R406 BE C411 R405 R404 S20 RST L11 MENU 2 1 3 AM BE Q102 2 1 FM S4 D5 5 C5 R403 CN3 S5 L7 C255 X16-2190-10 IC Address Q Address 3 6H 1 5J 7 13 K L M N O KDC-7024/Y,722,8023 1 PC BOARD (FOIL SIDE VIEW) ELECTRIC UNIT X25-966x-xx (J74-1474-12) BU C101 R147 R148 D33 D34 D35 D36 GND D40 D39 2 D38 D37 BU R305 R3 R308 D53 R316 C12 C10 R7 R314 C11 R8 R313 C9 R315 B C21 C22 C15 Q53 R301 C412 C413 R133 C130 AGND C13 C14 R9 E B R142 Q33 R278 R277 R267 R274 R248 R246 R245 R273 IF+B R10 C279 C280 16 4 C24 Q54 L C23 R Q30 B E Q51 Q52 R272 R269 IC12 C16 E B 1 9 Q2 R135 R132 C129 R134 R319 R312 R317 R G L R318 R309 R311 AUDIO-OUT C251 D55 C408 8 C407 E B B E R1 R2 VDD C409 C405 GND D52 R130 C3 C71 R61 M1M1+ PLL+B C403 Q103 R310 C401 AM+B D54 C127 Q28 Q27 D50 C4 3 D9 GND 8V B D11 BU D51 E D12 R306 D66 TH1 B E B E C204 C202 C203 R264 C201 R266 D23 D2 C211 R261 R255 R254 R258 R271 R270 R247 6N 2 6 15 1 1 4 X16-2080-10 8 CP1 IC1 5 6 3Q 7 3Q 14 2Q 23 2P 27 2N M2- D65 E2P5V B E D64 D63 D62 Q63 28 2N Q Address Address 29 3P 52 4O 1 6K 30 4P 53 4N 33 4P 54 4N 34 4Q 63 6N 51 4O 103 3L 14 10 C261 C262 IC 7 SERVO+B IC14 6 3Q IC R285 D-GND 1 D60 R324 14 5 R240 R241 SW5V R325 5M M2+ R326 13 R224 R223 CLK R329 4L ESD-GND 5O R330 7 12 4 8V 1 5 SERVO-GND R328 R327 J1 Address 3 DATA R331 2 Q IC13 R332 14 IC R222 R221 6 R239 R238 SUB-CIRCUIT UNIT X16-2080-10 (J74-1476-02) 10 1 R213 R212 C259 C260 X25-966x-xx R281 R322 R323 R321 R320 R231 R229 5 2 IC7 C206 R232 R233 R227 R226 R225 PAN5V D-GND 5V R1 C1 R1 R1 P Q R S T KDC-7024/Y,722,8023 1 SUB-CIRCUIT UNIT X16-2140-10 (J74-1479-02) R6 R60 R70 R4 R5 C68 C67 C69 Q14 C134 E B KI3 1 RED KI1 CN1 KI2 R107 D2 Q7 C107 R104 1 KS1 VOLA 24 ILLGND ILLGND KS2 32 R19 R18 25 Q6 Q2 Q34 51 5 R16 R17 ILL+B GREEN 26 50 IC2 VOLB R10 R6 D5 R3 R9 1 75 Q10 S16 R32 C12 C7 R33 R34 DGND R15 C14 R9 R35 PAN5V VLCD1 6 D2 C28 100 C11 R31 C16 C15 R36 76 E B 4 KI5 RST PAN5V CE R10 ILL+B KI4 DATAS DATAL INH KS3 RST REMO ILL-GND DGND DSI KS4 R5 CLK CN1 CN2 R145 R23 VOLB VOLA E2PDATA R4 R8 CP1 R13 PANDET 28 DSI 1 RED R8 R14 R7 ESDGND D23 D24 D4 GREEN KS1 KI1 KS4 KS3 KS2 B E D3 E2PCLK KI5 D21 E B Q33 D5 D1 E B KI4 KI3 KI2 Q30 R12 R135 R132 C129 R134 LCD R5 R4 C4 R6 E2P5V R133 C130 C135 3 D26 R3 C3 Q5 EB D22 R108 B E 100 R67 C106 E B Q1 Q29 EB CP4 B E R101 R1 C1 R2 C2 R24 C5 R68 C103 R100 R11 R26 CP5 E B VLCD1 C6 76 W100 1 75 R106 R131 D9 D10 D11 R124 D28 R15 D12 ESDGND D21 R1 SW14V 8V R111 C114 R109 R110 2 25 D27 DSI R2 IC1 R144 Q52 DIMMER 26 50 B E E B R7 51 Q23 R142 C26 R41 R42 R53 R51 R52 R54 C27 Q11 EB R146 ILLGND BU SWITCH UNIT X16-2190-10 (J74-1484-12) C13 C29 C21 Q6 EB ILL+B X16-2140-10 IC Refer to the schematic diagram for the values of resistors and capacitors. Q Address 1 Q 2R 5 3R 2 5R 6 6R 3R 11 2R 1 Address IC 7 15 U V W X Y KDC-7024/Y,722,8023 1 PC BOARD (COMPONENT SIDE VIEW) R18 R16 CD PLAYER UNIT X32-5200-00 (J74-1243-02/1245-02) 2 R22 C89 C17 S2 C15 R15 C14 D4 R218 S1 C13 R234 R233 R202 C23 R32 R53 R34 C24 C26 C28 C85 R54 C46 R52 3 C21 R38 C25 C35 R36 R37 CP1 X1 CP2 D3 4 S3 R125 5 C78 R122 S4 C51 8 C41 5 C72 IC6 R118 R107 1 C80 C71 R117 4 C79 C77 R121 R108 R126 6 X32-5200-00 7 16 IC Address 6 5V Refer to the schematic diagram for the values of resistors and capacitors. Z AA AB AC AD KDC-7024/Y,722,8023 1 PC BOARD (FOIL SIDE VIEW) C2 C1 74 R49 SRDATA BCLK Lch 73 R213 DQSY FOD ECS TRD SPDL+ 4 LRCK /MRST 75 R214 IC2 3 76 51 KICK ECM TRV 1 MOTOR BDO OFT C29 CN2 /MSTOP A.+8V S.GND EB Q3 A.GND Rch LOE/LIM 8EJE S.7.5V LDON 100 C55 C8 TVD 12EJE 24 LOS SPDL- /MUTEL LO/EJ 1 50 /MUTER SLED+/LOAD LDCNT 26 EQCNT SLED-/EJECT R40 RFENV R35 RW C33 PON R10 C5 R12 /CLK D.OUT BE Q5 Q2 EB TOFS 16 25 DATA BU.5V C10 C11 C6 R11 C7 C3 VCC GND Q4 E B R47 FCS+ D.GND R9 C4 R46 TRK- B FCS- 1 2 TRCRS C12 LD E Vref IC1 PD Q1 VDET TE R13 D1 TRK+ 16 TBAL FE C19 R19 R17 17 32 VR FBAL /RFDET R5 R3 R6 C GCTL C18 C16 C20 B CN1 GND IOP+ R21 A 1 R20 ARF RF F TE E Vref IOP- CD PLAYER UNIT X32-5200-00 (J74-1243-02/1245-02) DRVMUTE C44 R79 R81 R80 C42 R84 R110 D2 1 14 R101 R82 R102 C67 R103 R104 C68 5 IC4 28 15 R76 C40 R74 R75 R70 C39 R73 R71 6 X32-5200-00 IC Q Address 1 Q 2AB 2 3AA 2 3AC 3 4AB 4 5AB 4 3AA 3AA 5 3AA 1 Address IC Refer to the schematic diagram for the values of resistors and capacitors. 7 17 A B C D E KDC-7024/Y,722,8023 1 CD PLAYER UNIT (X32-5200-00) D5V D5V BU5V BU5V Q4 D.5V SW Q5 A8V 330 IC6 (2/2) 7 MOTOR S.7.5V 3 2 S.GND 1 7 18 X32-5200-00 (1/2) 5 4 S7.5V 3.0V 5 6 4 R122 20K R118 20K R126 20K C72 470P S7.5V R101 3.3K R102 3.3K 3.8V R108 C67 0.1 IC6 LOW PASS (1/2) 3.0V FILTER 0V LO/EJ 4 2 3 330 C68 0.1 C79 2200P Rch 6 C80 2200P G 1 R117 20K R103 5.6K R107 Lch 5 20K R121 20K C71 470P LRCK 6 8 R104 5.6K 3.8V C77 68P 8.0V 29 27 26 VCOF PLLF2 VCOF2 28 2.5V 29 TVD TRV PC R37 C28 470 1 30 32 2.5V 30 31 2.5V 32 ECS ECM 2.5V 33 KICK C51 0.1 R125 BU5V 8 BCLK 7 SRDATA 2.5V R110 200 A8V C78 68P D.GND 34 TRD DOWN & LIMIT SWITCH D.5V SW C55 0.1 AVSS1 OUT L 0V AVDD1 99 100 2.5V A8V 98 5.0V OUT R 97 2.5V HOT AVREF 96 0V 95 5.0V R53 10K BU5V CLK DATA LDCNT 93 94 94 93 87 BU5V 1K RFDET OFT 0.1 LOE/LIM SW 10 BU+5V 9 33 34 35 36 35 2.5V 37 36 FOD C85 D3 S3 22K R46 C46 R54 0.047 100K BU5V 22K R47 A.8V SW 10K BU5V 22K R52 100K VDET 5V 0V 0.1 C35 D5V Q4 22K 5 86 8cm DISC DET SWITCH Q2 TOFS AVDD2 5.0V 100K 8EJE SW 11 to MAIN UNIT 37 BU5V 5.0V 38 0V FCLK IPFLAG CLDCK R38 220K 0V 41 EFM or CK384 40 DVSS2 39 AVSS2 PCK or DSLB 43 NC LDON MSTOP XSUB1 72 XSUB2 73 DVDD2 74 NC 75 NC ∗R214 ∗S4 CLDCK STOUT 0V STLD NC DVSS 5.0V 91 91 AVSS DXM-6010W (TEXT OFF): 5.0V DXM-6110W (TEXT ON): 0V R233 6.2K 5.0V 92 89 MSTOP 12 AVDD3 X2 0V 86 MRST 13 X1 76 87 MUTE L 14 BU5V MUTE R 15 F TBA FBA 91 C21 2.2 10K G Rch CP2 100x4 A8V 4 BU5V 5.0V NC ∗R213 A.GND 17 Rch 16 4.7K Q3 Lch T NC MECHASEL 71 A8V Lch 18 70 NC 5.0V 90 A.+8V 19 0V NC CD SIGNAL PROCESSOR BULT in MI-COM. D2 A.8V SW ∗IC2 RST 93 20 VRE RFENV NC 89 69 BU5V DATA 94 DR 0V 0V 68 CP1 100x2 CLK 21 PLL IRE R234 10K LOS SW 22 1.5V 0.9Vp-p ARF 5.0V 5.0V BU5V X1 16.93MHz S1 0V NRST 0V 12EJE SW 23 TRV 1.5V BCLK 57 LRCK 58 SRDATA 59 SUBC 60 SBCK 61 DQSY 62 DEMPH 63 TX 64 PSEL 65 MSEL 66 SSEL 67 DVDD1 R49 4.7K 3 TVD 5V 0V 5.0V 5.0V S2 ECM DSL 5.0V 0V 2.5V ECS IOSEL 0V D.OUT 24 TOFS 78 NC 79 NC 80 TEST 81 ASEL 82 PON 83 SEARCH 84 EQCNT 85 SW3 86 AMUTE L 87 AMUTE R 88 CD-RW 0V TRD KICK DRVMUE 0V FOD TEST2 100K CN2 56 TEST1 77 S2 : 12cm DISC DET. SWITCH S1 : LOAD DET. SWITCH 55 CSEL 73/74SEL 5.0V C29 0.1 5.0V 89 54 C25 0.015 42 53 47 TRCRS 46 FLAG 45 IPFLAG 44 FCLK SMCK 52 48 50 49 51 0V BU5V STLD SMCK D5V C33 0.1 2 STOUT BU5V 2.5V 0V FLAG TRCRS BDO F G H I J KDC-7024/Y,722,8023 1 D5V R12 6.8K R10 5.6K D5V C8 1 1.5V 0V 0V DPU1 (X92-) 1 2 LD VCC 5.0V PD 3 4 RFOUT 2.5V RFN 5 6 7 C.AGC RFIN 8 9 C.EA ARF 10 3TOUT 12 11 BDO C.BDO C.OFTR 13 OPTICAL PICKUP APC 0.9Vp-p R9 10 F R3 2.7K 28 E 29 C 30 A 31 D 32 B TBAL 26 R6 2.7K 27 FBAL GCTL 25 FEOUT 3.0V 24 C3 2.2 CN1 D5V 4 LD 5 VR 6 PD 4 7 C 27 8 F 6 1 4 32 30 28 27 R21 240K C19 0.1 1 32 9 B 30 10 A 11 E 28 TBAL 12 GND FBAL BDO 92 R22 62K 37 D4 GCTL 17 18 S7.5V 4 5 TRK+ : AN22000AA :∗ : BA5824FP : NJM4580M1 Q1 Q2,5 Q3 Q4 : : : : D1,4 D2 D3 : DAN202U : MA8051-L : DA204U MCH6101 DTC124EUA DTA143XUA 2SA1362(Y) 4.0V 4.0V 0V 8.0V 0V 21 LD/SLED 20 GND 10 19 VCC1 VCC2 11 18 SPDLSLED12 17 SPDL+ SLED+ 13 16 FCSTRK+ 14 15 FCS+ TRK- 4.0V 16 15 EJECT SLED- LOADING & SLED MOTOR 13 FCS+ 14 TRK+ 15 15 TRK- 13 16 FCS- 4 SIGNAL LINE GND LINE B LINE CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakagecurrent or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. 5 TRKX32-5180-00 X32-5180-01 X32-5200-00 X32-5200-01 IC2 R213 R214 S4 MN662774KJ2 NO YES NO MN662774KJ2 NO YES YES MN662773KH2 YES NO NO MN662773KH2 YES NO YES 6 4.0V 4.0V 8.0V FCS+ 4.0V 12 11 S7.5V 4.0V FCS- 14 13 SPDL- DM1 (X92- ) 11 M 12 C41 2.2 +B 14 16 9 0V 5.0V 8 DM2 (X92- ) M 17 MUTE GND LO/EJ GND 7 0V 2.5V 6 33 32 10K C44 0.01 36 22 0V SL. IN SP. IN 2.5V 5 VREF 2.5V 4 C42 1500P R82 22K 4ch BTL DRIVER R80 R79 10K R81 33K R84 10K 2.5V 18 4.0V 23 2.5V 24 2.5V 25 2.5V 2.5V 3 2.5V 2 FC. IN VREF 26 2.5V 28 VCC 27 2.5V TR. IN 1 BIAS S7.5V R76 10K R40 13K C40 0.01 R70 10K IC1 IC2 IC4 IC6 LOAD SLED+ 30 29 R74 12K C39 1500P 8.0V S7.5V R75 33K 35 R71 18K R73 68K 34 S7.5V 3 1 VCC 2 VC 3 GND C20 0.1 FEN 23 21 22 R16 22K D1 6 R5 360 FE 1 IC4 IOP+ 11 0V 0V C18 330P R20 100K 3 2 C16 220P C14 4700P 47 C17 4700P 0V R19 47K 92 15 4 TEN TEOUT R18 3.9K R17 39K 12 BU5V R218 47K 20 TEBPF VDET 19 2.4V VDET TE 11 10 2.5V 0V 2.5V 12 11 2.0V 0V 2 4.0V 0.1V C15 0.047 12 2.5V 0V C10 4700P C13 0.033 19 C11 6800P 1 3 3.7V NRFDET 14 15 16 GND FE 5.0V 3P 10 AVSS1 OUT L 99 100 0V 15 14 13 TBAL 10 FBAL 9 AVDD3 8 AVSS3 7 NC 6 NC 5 LDON 4 VDET 3 RFDET 2 OFT 1 BDO Q1 R13 3.9K C6 A8V AVDD1 FE 2.5V R15 820K NC 5.6K 2.5V C89 2200P TE NC 15 19 RFENV 16 0.1 RF AMPLIFIER ADAPTED for CD-RW IOP- 2.5V 17 R11 0.9Vp-p 2.5V R202 100K NC C7 3.3V 0V VREF NC 100K RF 2.5V OFT R35 22 DRF 0V 0.9Vp-p ARF 21 20 VREF 19 RFENV 18 NC IC1 2.5V 18 23 0V OFTR R34 36K 24 D5V C5 22P RFDET 17 IREF DSLF C24 0.022 4 1.5V D5V 2 BU5V R36 C26 150 1 1.2V 47 25 BU5V PLLF R32 68K VCOF PLLF2 VCOF2 27 26 0V 2.5V C1 1 C12 3300P C2 1 ARF C4 10u6.3 + C23 1000P D5V D5V SPDL+ SPINDLE MOTOR • DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. S7.5V 7 X32-5200-00 (2/2) 19 K L M N O KDC-7024/Y,722,8023 (X25-966X MODEL NAME FX-5000 KDC-MP82 KDC-V702 KDC-722 KDC-8023 KDC-M702 KDC-7024 1 4 8 TP22 R3 4.7 LX-DATA-S LX-REQ-M TP23 R313 4.7K R1 10 TP25 R314 4.7K TP26 R319 100 +B R318 100 TP28 R317 4.7K TP29 R312 100 SW1 SW2 TP79 SCL SDA TP64 D OUT MS CLK TP78 MS DA TP77 AUDIO 8V TP76 Lch TP75 AGND TP74 Rch TP73 MUTE R TP72 MUTE L TP71 M RST TP70 M STOP TP69 TP68 SW4 TP67 TP66 SW3 BU5V TP65 D-GND 5.0V D-GND LO/EJ 5.0V MOSW TP62 TP61 SERVO +B TP63 R322 2.2K 91 90 70 74 58 59 86 60 43 42 41 ∗A 96 2.4V 0V 88 L2 95 94 40 D51 D52 C71 0.01 R61 1K R321 2.2K C3 0.47 TP27 TP14 CN2 R323 2.2K 2.2K 43 D53 GND ∗R320 6 R316 4.7K 15 16 23 24 4 C5 47u6.3 + TP24 12 22 14.4V 0V R111 47K 14.4V R109 Q10 47K IC5 0V 4 5.0V VOS 5 ON/OFF 3 C4 0.47 R315 4.7K 13 14 21 3 LX-DATA-M 20 GND1 LX-REQ-S 11 19 SWOUT 7 18 2 3 69 R2 10 TP19 13 17 1 LX-CLK 10 16 VIIN 6 15 10 TP21 11 12 14 67 TP20 9 10 Lch 13 C110 100u25 + C111 100u25 + LX-CON 2 ∗R308 1K 7 8 AUDIO GND LX-MUTE TP18 12 R110 47K LX-RST 9 ∗R311 470 5 6 Rch 5 ∗R309 470 10 11 C114 0.22 REMO 1 TP16 3 4 5 6 7 8 9 D5 O-CE 4 C113 220u16 + C112 220u16 + 2 3 68 TP17 1 2 O-DATA 2 61 O-CLK 3 1 62 4 D50 ∗R310 470 TP15 2 ∗D55 TP59 ∗D54 CN3 1 CN4 TP60 (X25-966X-XX) EXTERNAL DISPLAY & STEERING REMOTE CORD SERVO GND to CD MECHANISM 1 2 TP13 Q10 2 D66 25 TP89 10 C403 0.01 MOTORMOTOR- 14 MOTOR- 13 MOTOR- SCL DIGGND 12 VDD NC MOTOR- NC 11 MOTOR+ 9 MOTOR+ 8 MOTOR+ 7 AOUT NC SMETER PH-OUT IF1+B 2 6 SW5V 5 SW4 SW4 4 D GND 3 SW1 2 SW2 1 SW3 IF1GND 26 C408 2.2 2 12 13 14 15 22K R404 4.7K C411 330P Q104 4.7K TP84 84 TP85 C412 10P 14 OSCOUT VREF 13 2.4V 4 OSCIN MPX 5.0V 5 OSEL VCC 0V 6 GND EXTRES 7 ARI TM 8 FILOUT FSEL 100 11 0V 10 0V 9 TP87 C413 10P 4.332MHz 12 5.0V 0V L11 4.7uH 18 19 20 TP90 21 22 23 24 IC13 TP91 7.6V L12 4.7uH TP88 1 2 3 64 4 63 5V 0V 0V 5 IC14 NC10 VCC NC2 OUT1 NC8 IN1 IN2 SGND OUT2 PGND 10 7.6V 9 0V or 7.6V 8 7 0V or 7.6V 6 0V 1 2 3 66 4 65 5V 0V 0V 5 NC10 VCC OUT1 NC2 NC8 IN1 OUT2 IN2 SGND PGND 10 9 0V or 7.6V 8 7 6 0V or 7.6 1 7 X25-966x-xx (1/4) TP33 81 2 MOTOR + MOTOR + PH-OUT 7 8 9 10 MOTOR + SW5V 5 6 SW4 TP34 77 3 4 D-GND 2 SW1 TP35 78 79 TP36 TP37 1 SW2 CN6 SW3 1 TP38 TP31 2 MOTOR- MOTOR DRIVER IC for PANEL MECHA 80 IC13,14 CN7 20 15 1 TP86 16 17 5V 0V RDDA T57 2.4V 3 R405 2.2K 16 RDCL MOTOR+ (1K) SW2 PH SW3 6 MOTOR+ SW1 RLED (1K) RPH (100K) P-MOTOR 10 22K QUAL TP30 M 2 15 SDA 1 2 82 M S-MOTOR MOTOR+ R407 2.2K 5V 0V TP83 C405 0.01 1 IFCOUT 1 11 C407 0.01 COM+B PANEL MECHA ASSY 93 AM+B SW Q102 VT ∗IC12 R406 2.2K C262 0.22 OSCGND 9 92 C261 0.22 NC 7 8 RDS DECODER IC 5V 0V Q103 C409 0.01 OSCGND 6 ∗G TP81 TP82 C410 10u16 + OSCGND 5 X3 AM+B 4 L13 4.7uH FM+B TP80 3 C259 0.22 OSCGND 2 R403 22K FMANT AMANT 1 R402 1K RFGND C401 0.01 ∗A1 4 87 L7 C260 0.22 1 5 SWITCHING REGULATOR IC for CD5V 44 3 ANT. IC5 SW for IC5 W2 P Q R S T KDC-7024/Y,722,8023 (X25-966X-XX) UNIT No. 0-01 0-10 0-11 0-12 0-21 2-71 2-72 A B C D E F G A1 YES YES NO NO NO YES NO YES NO YES NO YES NO NO YES YES YES YES YES NO NO YES NO NO NO YES YES YES NO YES YES YES YES YES YES NO YES NO NO NO NO NO NO NO NO NO NO YES YES X86-3730-01 X86-3730-11 X86-3730-11 X86-3730-11 X86-3730-11 X86-3732-70 X86-3732-70 C23, 24 YES NO YES NO YES YES YES C67 C68 NO YES YES YES YES YES YES D54, C127 C129 D15 55 1u6.3 YES YES NO 0.068u16 NO NO NO 0.068u16 NO NO NO 0.068u16 NO NO NO 0.068u16 NO NO NO 0.068u16 YES YES YES 0.068u16 YES YES YES C100 NO YES NO NO NO NO NO 3900u16 2200u16 2200u16 2200u16 2200u16 3900u16 3900u16 D63, 64 NO YES YES YES YES YES YES IC1 Q28 UPD703030GC014 UPD703030GC014 UPD703030GC015 UPD703030GC015 UPD703030GC015 UPD703030GC014 UPD703030GC015 DTA114EUA DTA124EUA DTA124EUA DTA124EUA DTA124EUA DTA124EUA DTA124EUA R203,225-227, 308-311 NO NO NO NO NO YES YES Q63 R134 R135 R146 R147 NO 100K 47K YES YES NO 100K NO YES NO 100K NO YES NO 100K NO YES NO 100K YES YES 47K 22K YES YES 47K 22K YES YES NO NO NO NO YES YES R204 YES NO NO YES NO NO YES R205,252, 253,257 YES YES YES YES YES NO NO R206 NO YES YES NO YES YES NO R258, 320 YES NO NO NO NO NO NO R281 R282 R283 YES YES NO NO NO YES NO NO NO NO NO YES NO NO NO NO YES YES NO NO YES R326-328, 330,331 NO YES YES YES YES YES YES W1 NO NO NO NO NO YES YES 11 11 12 SDA SCL R271 470 13 R270 470 14 REMO IC2 SDA IC2 CLK ∗IC1 R269 4.7K R272 4.7K SYSTEM u-COM R267 47K 76 74 FPM SW4 R231 100K R229 100K 64 R221 1K 63 R220 100 R219 100 R218 2.2K R217 1K R212 1K R285 1K 5V 0V ∗Q63 E2P 5V SW ∗D64 ∗D63 26 27 28 PAN-E2P CLK ESD-GND ESD-GND 25 PAN-DET 24 54 53 52 51 D60 D62 P1 2 X25-966x-xx (2/4) 61 60 58 0V R214 4.7K 62 59 R216 1K R215 4.7K R213 1K 68 67 65 R222 1K 50 75 R332 470 TP40 100 ∗R331 TP41 21 22 23 E2P5V TP43 100 ∗R330 20 DSI TP42 19 NC 18 PAN-E2P DATA 17 RST TP44 TP45 R329 4.7K 16 DIMMER CONT TP46 15 L-CLK TP47 14 L-DATAS TP48 5V VOL A 54 0V 53 L INH 5V 52 0V L CE 51 DSI 70 69 66 R223 1K TP39 L-DATAL TP49 D65 L-CE TP50 22K 22K 4.7K L-INH TP51 TP52 NC 12 13 VOL-B REMO VOL-A R325 4.7K R324 4.7K TP53 TP55 TP54 NC ILL+B ILL+B ILL-GND ILL-GND NC D-GND D-GND PAN5V MOTOR - MOTOR - MOTOR - MOTOR - MOTOR + MOTOR + MOTOR + TP56 TP57 TP32 TP58 81 TP33 TP34 PH-OUT MOTOR + 1 2 3 4 5 6 7 8 9 10 11 5 ∗R327 ∗R328 4.7K CN5 R224 1K C208 0.01 ∗R203 10K ∗R205 10K ∗R204 10K ∗R206 10K 44 42 43 41 ∗R281 47K R202 100K 4 51 31 17 99 52 53 57 54 50 0V or 7.6V 49 48 R209 10K IC2TYPE1 IC2TYPE0 47 R208 10K TYPE1 46 TYPE0 CD MECHA+B 44 5V 0V 0V or 5.0V 45 LX RST LX CON 42 43 41 LX MUTE LX REQ M CLKOUT 40 VDD 39 38 VSS X1 TP119 7 8 9 10 11 12 13 14 15 ∗R227 100 ∗R226 100 ∗R225 100 0V 5.0V 37 36 X2 REGC 3.3V 40 X2 R200 15K X1 20.000MHz 5V 0V C206 1 35 34 C204 1 98 XT1 33 C203 27P 32.768kHz 97 1 27 VSS OUT 2 5.0V R264 2.2K VDD 26 NC D20 3 0V 4 27 IC7 XT2 SW5V 32 ACC DET 26 5V 0V 5V 0V 3.5V 0V 5V 0V 5V 0V 5V 0V C202 R201 22P 10K 25 25 BU DET 5V 0V 5V 0V 31 31 24 5V 0V PRE MUTE R RESET 24 PRE MUTE L 31 23 23 MUTE ILL ON 22 R228 1K 56 BVSS 55 5.0V 5V BVDD 0V 5V 0V 5V 0V P ON 21 21 22 TYPE2 30 20 0 or 5.0V 30 20 RESET IC TEST 0V ANT CON 19 100K R265 10K 5V 0V DIMMER CON 10K ∗R282 ∗R283 18 29 17 28 29 R266 1K 17 5V 0V P CON 28 16 16 P STBY DIMMER 15 EXT AMP CONT R268 33K R207 100K 15 77 R237 2.2K 77 (SVR) 5V 0V 76 R236 2.2K 78 FPM SW2 FPM SW1 R235 2.2K 79 FPM SW3 PH-OUT 5V 0V P MUTE PHONE 78 R241 1K 79 R240 2.2K R234 2.2K 80 R262 1K R261 2.2K S METER 81 82 0-5.0V 80 R239 2.2K 81 R238 2.2K 82 83 83 0-2.0V 84 POWER-DET IFC OUT NOISE 0V 85 86 R CLK CD SW4 87 LX REQ S KEY REQ 88 89 CD SW1 C211 1000P R260 2.2K 84 86 R259 1K 87 ∗R258 2.2K R275 100K 88 R256 100K ∗R257 100K 91 90 R255 2.2K 90 92 R254 2.2K 91 R QUAL CD SW2 93 ∗R253 100K R DATA LX DATA S 92 94 ∗R252 100K 94 93 95 R251 100K 96 R250 100K L5 600 95 96 R248 1K 98 97 R247 100K R246 1K 97 99 98 R278 470 R245 1K 99 5V 0V R232 1K 21 57 75 10 10 5V 70 0V M MUTER 69 O CE 68 O CLK 5V 67 O DATA 0V 66 FPM MOTOR C 65 FPM MOTOR O 64 FPM MOTOR F 5V 63 FPM MOTOR B 0V 62 MOSW 61 0 or 2.5V or 5.0V LO/EJ 60 CD SW3 59 M STOP 5V 58 M RST 0V 57 VOL B 5V 0V BEEP R233 100K R230 1K 74 M MUTEL 5V 5V 0V 73 0V AVREF 0V 72 AVSS 71 5.0V AVDD C207 0.01 R273 2.2K 2.5V or 5.0V 0V 4.6V 0V 5V 0V 5V 0V AFS 5V 0V 5V 0V 5V 0V EVDD EVSS 5V 0V 5V 0V 5V 0V PAN DET 75 100K 9 5V 0V 5V 0V V ILL PAN-E2P CLK 5V 0V ∗R326 8 9 V ILL PAN-E2P DATA E2P5V R274 1K 8 6 7 (FM+B) PAN5V 5.0V 0V 5V 0V 0.6V or 1.6V or 4.2V 50 5 5 AM+B LX DATA M 3 4 4 PLL DATA LX CLK 2 2 5V 0V L DATAL 1 L DATAS R277 470 PLL CLK 5V 0V R279 4.7K 1 100 5V 0V L CLK R280 4.7K 100 82 MODEL NAME FX-5000 KDC-MP822 KDC-V7022 KDC-722 KDC-8023 KDC-M7024 KDC-7024/Y U V W X Y KDC-7024/Y,722,8023 D63-65 : DA204U D66 : IMSA-6801 MA4056-M MA4047-M MA4068(N)-M MA4062(N)-M DAP202U or MA142WA D25-27,50 : RD6.8M(B2) D28,51 : RD6.8MW D52-55,60,62 : MA3062WA : : : : : SIGNAL LINE GND LINE B LINE 43 34 0V or 2.7V or 3.7V OUTRF 1 29 4.2V C22 1 28 4.2V 1 C21 1 C251 0.01 0V 4.2V 4.2V 4.2V 25 24 23 4.2V 20 FREER 4.2V 21 FREEL 4.2V 22 OUTLR TP116 Q54 Q53 OUTRR D23 22K 22K Q51,52 MUTE DRIVER Q60 C213 10 5V 0V 5V 0V 0.01 9 6 20 7 31 23 R133 100K 27 SMALL LAMP DET SW 2 22K 360 47K 47K R307 6.2K R306 10 R138 22K 0V 24 0-4.4V 14.4V 0V 22 C257 1u50 + 20 18 16 14 C34 0.22u50 12 C256 33u16 + 6.8V 0V 14.4V PGND4 10 8 6 OUT4MUTE VCC2 4 0V 2 13 IN1 OUT1+ OUT1SVR OUT2+ PGND1 OUT2- D40 C32 0.22u50 11 6.8V 6.8V 6.8V 6.8V 6.8V 9 7 5 3 VCC1 TAB D39 0V SGND IN4 6.8V C33 0.22u50 15 6.8V IN3 IN2 6.8V D38 17 6.8V OUT3+ ACGND 6.8V 23 6.8V 19 6.8V OUT3- PGND3 25 21 6.8V OUT4+ 5V 0V C255 1u50 + 15 Q30 D37 IC4 FR+ FRRR+ RR- 1 0V STBY PGND2 R145 100K 2 ∗W1 Q27,28 47K 26 13 3 P.ANT SW 28 4 76 Q23,24 P-CON PROTECT ∗Q28 Q27 10K 10K R130 R128 1K 1/2W 10K Q25 P.CON SW 22K R129 1K 1/2W D13 D11 R126 1K 1/2W D9 R125 1K 1/2W Q23 ∗C D12 R131 4.7K 0.01 ∗R135 ∗C129 ∗D15 D14 2.2K R132 560 14 R124 4.7K ∗D Q29 47K ∗R134 EX AMP CONTROL BUFFER R127 22K Q25,26 Q24 C128 0 1u50 D10 ∗C127 R144 47K R143 3.3K 1/2W D17 C134 0.01 R142 18K ACC DET C135 0.01 Q33 X25-966x-xx (3/4) R56 180 R46 HSD D31 C31 0.22u50 C132 1000P 5V 0V 8 VSS R305 4.3K 9 Q32 R141 8.2K 5 24 22 NON-FAD REAR /NON-FAD D33 0.01 L4 4.7uH 11 4 SDA for ROM CORRECTION C200 47u6.3 + C201 3 10K TP118 B.U. DET 12 R140 5V 0V 5 2 5V 0V SCL 5V 0V R139 SDA 6 TP117 4.7K POWER IC D29 13 D16 10K VSS 0V 7 0V 5V 0V 4.7K 15 4 SCL 5V 0V 8 5.0V 5.0V 14 VDD TH1 470 C130 0.022 1 E2 1 C131 1u50 + 3 WC E1 R55 180 Q59 SCL 75 2 C50 3.3u35 + 20 C258 1u50 + IC8 IC15 2 R45 360 R303 22K D30 11 LOGIC IC for MUTING NOISE BUFFER VCC R43 180 22K R302 220 Q53 E0 Q57 RR 360 22K 22 E-VOL MUTE SW 1 4.7K R33 C49 3.3u35 + Q52 D24 Q54 3 Q58 20 22K 57 4 4.7K 22K 59 5.0V R44 180 REAR C45 3.3u35 + Q51 21 L6 4.7uH C250 47u16 + 27 8.4V R34 360 ∗F ∗C24 30 4.2V 26 C46 3.3u35 + RR C13 0.1 R36 ∗C23 C14 0.1 SCL SDA 19 17 18 AFS SMUTE 5V 0V SDA C254 0.1 MPOUT MPIN R300 4.7K 62 4.7K 63 0V 14 64 4.5V 13 65 C253 0.1 4.6V 12 LEVEL 66 OUTLF 5V 0V 0-2.6V FR 360 22K 36 4.2V 37 4.2V 35 ACIN0L ACIN0R SUBL SUBR ACOUTL 38 4.2V 39 4.2V GND MPX R32 180 R22 R35 C252 2.2u50 + 40 4.2V 41 MDL MDR ACOUTR VDD AM 11 60 31 4.2V RR 10 61 CREF E-VOL & N.C. & MPX C10 150P 67 32 4.2V C15 0.1 NV- 8 C9 0.47 ACIN3L 16 68 IC2 83 R7 4.7K 69 ACIN3R QUAL 70 CDCHR- NV+ 9 C11 0.022 ACIN2R 15 74 R8 10K ACIN2L CDCHR+ CDCHL+ 8 33 4.2V C16 0.1 R9 33K ACIN1L CDCHL- 7 Q56 FR 6 6 C12 0.01 ACIN1R 4.2V R301 4.7K 82 5 4.7K R10 33K AUXR 4 4 Q55 FRONT C42 3.3u35 + FR AUXC 3 3 AUXL 42 CDR 44 4.2V 2 2 4.7K ∗E D26 CDL 1 PRE-OUT MUTE SW R31 180 22K C2 0.47u50 + 43 4.2V C1 0.47u50 + Q55-60 D25 58 R21 360 22K C41 3.3u35 + R23 1N5393G-M5 RB160L-40 MA4056(N)-M MA4082(N)-L SFPB-54V MA4110-L 1SR154-400 or S1J D13,20,29-31 : 1SS133 22K D14 D15 D16 D17 D23,24 : : : : : : : R24 D1 D2 D3 D4 D5 D6 D9-12,33-40 Q24,25 Q28 Q29 R47 Q6,30 : DTC114YUA or UN5214 : 2SB1240 :∗ : DTA123JK or KRA105S Q53,55-60,104 : DTC143TUA or UN5216 Q103 : 2SB1188(Q,R) 2SA2057 2SC4081 2SA1576A DTA124EUA or UN5112 : DTC124EUA or UN5212 : DTC144EUA or UN5213 22K Q5,11,54,102 Q23,26 : : : : R48 Q1,8,9,13 Q2,10,14,32-34 Q3,27 Q4,7,12,28,51,52,63 D34 ∗ TDA7411 M5237ML TDA7560 SI-8050JD S-80837CNNB TC74HC02AF TDA7479D LB1930M BR24C01AF-W D35 : : : : : : : : : : D36 IC1 IC2 IC3 IC4 IC5 IC7 IC8 IC12 IC13,14 IC15 W1 NO NO NO NO NO YES YES C126 3.3u35 + -328, 331 O S S S S S S Z AA AB AC AD KDC-7024/Y,722,8023 3 1 9 10 C8 0.47 R6 10 TP6 C6 47u6.3 + C7 0.47 R4 4.7 TP5 R5 10 TP4 3 4 FRONT ∗B 5 6 1 2 NON-F CN1 AUXR 11 12 AUXG 7 8 7 8 7 8 5 6 5 6 3 4 1 2 (E30-6211-05) : KDC-MP822 9 10 RL TP2 RR ∗C67 3 4 5 6 3 4 1 2 1 2 (E30-6212-05) : KDC-V7022 KDC-8023 RR (E30-6213-05) : KDC-722 KDC-M7024 KDC-7024/Y TP1 7 8 0.1 (E30-6215-05) : FX-5000 2 RG TP12 ∗C68 FR FR TP11 0.1 RR 9 10 AUXL TP3 FR 11 12 9 10 5 6 FG REAR 2 TP10 BU TP9 BU L FL R 2 R60 1K D27 3 C70 0.01 7 8 D28 11 12 AUX IN 5 7 11 12 9 10 REAR NON-F 11 9 11 12 REAR NON-F 2 FRONT 4 FRONT 6 REAR NON-F TOP VIEW 12 10 8 REAR CN1 AUX IN 1 AL LINE LINE INE 3 4 NFL TP8 2 C69 0.1 NFR BATT YEL LINE MUTE ILLUMI ORG/WHT BRN EXT. CONT. 15 16 3 2 1 ANT CONT BLK ACC BLK BLU/WHT RED 14 4 BLU/WHT 13 5 BLU 12 6 GRY 11 7 GRY/BLK 10 8 WHT 9 1 WHT/BLK 16 2 RED 15 3 P. CON ANT CONT FRONT R PNK/BLK VIOL GRN/BLK VIOL/BLK GRN YEL ORG/WHT ILLUMI REAR R VIOL BLU GRY 14 GND R ACC ACC L TP100 TP108 4 DC CORD (E30-6061-05) : FX-5000 L1 Q1 D2 FL- C105 100u6.3 + C104 10u16 + ANT CONT 8 9 7 10 GRY/BLK 6 11 GRY 5 12 BLU/WHT 4 13 GRN GRN/BLK VIOL/BLK VIOL PMK/BLK RL+ RLRRRR+ EXT. CONT P CONT D3 100 C103 0.01 R101 WHT WHT/BLK FR+ C102 220u16 + B.U.5V AVR Q2 R102 2.2K R100 22K FRR103 22K SW5V RR- 4 B.U. Q3 FRRR+ 5 DC CORD (E30-6106-05) : KDC-MP822 KDC-V7022 KDC-722 1 16 FL+ TP110 6 FRONT DC CORD (E30-6062-05) : KDC-8023 GND TP109 FR+ 11 12 13 GRY/BLK 7 VIOL/BLK REAR L ILLUMI ORG/WHT VIOL VIOL/BLK GRN/BLK GRN PNK/BLK BLU 10 8 BLU/WHT 9 1 2 15 ILLUM + ∗C100 D1 C101 0.01 3 14 ACC TP106 TP107 TP115 16 2 GND P-CON TP105 R148 10K 4 13 PHONE 2 15 FRONT L TP104 P-ANT TP103 3 14 15 3 EXT CONT FUSE ∗R147 10K 13 14 3 F1 10A TP102 4 5 12 REAR Rch+ TP101 ∗R146 1K 5 FRONT L TP92 RR+ 6 P. CONT FRONT Rch+ 11 12 13 P. CON TP93 4 6 11 REAR Rch- RRFR+ 7 ANT CONT TP94 10 8 FRONT R FR- 9 GRY FRONT Rch- GRY/BLK TP95 WHT 7 10 GRN REAR Lch- GRN/BLK TP96 WHT FRONT Lch- WHT/BLK FAD R -FAD WHT/BLK TP97 8 9 YEL REAR Lch+ BLK FRONT Lch+ TP98 RED J1 TP99 EXT. CONT. REAR L 1 2 NFG REAR R TP7 BLU/WHT 3 14 RED 2 15 BLK 25 1 16 BRN 5 TEL MUTE ORG/WHT YEL 30 22K ILL+B AVR R112 1.5K 10K 6 8 3 5 7 2 4 6 8 1 3 5 7 ACC GND 4 1 P.CON R108 1.5K D4 C106 0.47 ILLUMI B.UP C109 100u10 + 2 A Q34 Q26 B TP111 6 29 R105 15K 1.29V Q7 IC3 OUT IN GND Q6 47K 13.7V AUDIO8V AVR RL- Q5 22K 22K Q6-8 0V Q4 22K 22K REGULATOR IC for A8V DC CORD (E30-4942-05) : KDC-M7024 KDC-7024/Y 22K R106 24K C108 220u10 + C107 1 R104 220 RR+ RRFR+ FRFL+ FLRL+ Q8 TP112 R107 4.3K 1/2W 16 Q9 SERVO+B AVR 47K 10K R129 1K C128 0.1u50 + 10K D13 P-CON PROTECTION ∗Q28 22K Q12 D6 Q27,28 Q11 22K Q14 Q11-14 22K Q13 22K Q4,5 X16CN1 SW14V 47K 2/3 KDC-722/8023/7024/7024Y (1/3) A CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. • DC voltages are as measured with a high impedance voltmeter. X25-966x-xx (4/4) Values may vary slightly due to variations between individual instruments or/and units. 7 23 AE AF AG AH AI KDC-7024/Y,722,8023 1 KS2 KS3 KS4 KS1 DISPLAY UNIT (X16-2140-10) 89 C3 0.1 90 95 CE S91 S92 S93 S96 S95 52 53 51 S51 S52 S53 54 55 S55 S54 58 56 S56 59 57 N.C. N.C. N.C. N.C. 60 61 N.C. N.C. 62 COM8 63 64 66 65 COM6 COM5 COM7 67 68 69 COM2 COM3 COM4 70 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 S73 S88 S87 S86 S85 S84 S83 S82 S8 S80 S79 S78 S77 S76 S75 S89 S90 S1 S2 S3 S4 S5 S6 S7 S25 S24 24 25 S8 S9 S108 S107 S109 52 51 S51 S23 S53 S52 22 23 S10 S11 S111 S110 54 S55 S54 53 S12 S56 55 S112 S13 56 S22 S21 21 S20 S18 S19 S17 18 20 19 S15 S16 S14 S113 S115 S114 58 59 57 S58 S59 S57 S15 S16 17 16 S18 S17 S116 S117 60 61 S61 S60 S14 S118 S62 S63 62 S119 S19 14 15 S13 S12 S11 11 12 13 S21 S20 S22 S121 S122 S120 63 64 65 S65 S66 S64 S10 S9 S8 9 8 10 S23 S25 S24 S124 S27 S126 S123 66 67 68 S68 S67 S6 S7 S69 S70 69 S125 S26 7 6 S127 71 70 S29 72 S72 N.C. S71 S30 73 S28 S31 74 S40 VLCD0 5.0V IC2 S39 LCD DRIVER S38 S37 VLCD1 S36 3.3V S35 VLCD2 S34 1.7V S33 VLCD3 S32 0V S31 VLCD4 S30 5V 0V VSS OSC S29 S28 5V 0V S27 S26 5V 0V 5V 0V S24 S49 S22 S23 24 23 S51 S50 S21 22 S52 21 S18 S20 S19 19 18 20 S53 S55 S54 S17 S16 16 17 S57 S58 S56 S15 S14 S59 15 S13 S12 S10 S11 12 14 13 S61 S60 S62 9 11 S9 DI S25 CL 25 CE S48 INH S72 N.C. ILL-GND ESD-GND ILL-GND ILL+B ILL+B PAN-5V D-GND VOL-A CN2 COM1 KS1 S5 S4 5 2 S32 75 N.C. VLCD S41 10 2.2K VDD 1 11 13 KS2 KS3 KS1 KS1 KS3 21 22 23 24 25 26 27 28 29 30 31 32 KS2 KI1 KI2 KI3 KI4 83 84 KI5 KS4 KS4 KI1 N.C. KI2 KI3 KI4 D-GND RED-SW E2P-5V GREEN-SW E2P-CLK X16-2140-10 (1/2) 11 12 13 14 15 16 17 18 19 20 KI5 21 E2P-DATA 7 24 20 7 8 9 10 DSI 6 N.C. 5 RST 4 PAN-DET R14 4.7 R7 330 3 ESD-GND 1 2 ESD-GND R13 1K R8 330 D1 6 100 5.0V 8.5V 6.7V S1 100 98 99 N.C. S63 99 D3 VOL-B 25 26 D2 D5 97 S42 S64 98 S43 N.C. S8 INH ESD-GND 28 96 N.C. S7 ESD-GND 27 95 S44 8 C11 680P 94 S45 N.C. S65 26 93 S46 5V 0V COM1 S66 C12 0.1 R32 D4 C26 0.01 92 COM2 S6 C27 0.01 C13 0.1 S47 7 D16 COM3 S67 D17 91 S48 6 25 C28 0.01 C14 0.1 N.C. S128 R51 270 5.0V E2P-5V 24 PAN-DET 26 D18 90 S49 COM4 S5 N.C. 22 5 D19 C29 0.01 E2P-DATA 23 E2P-CLK 25 89 R52 270 S50 COM5 5 Q11 88 2.2K R53 4.7K DIMMER 19 21 83 84 87 R36 4.7 R35 100 DSI 21 82 86 DIMMER CONTROL R34 R54 4.7K R33 99 R31 98 L-CLK 18 81 85 C15 0.01 L-DATAS 17 80 COM8 COM6 S68 C16 79 47 S74 COM7 S4 C15 97 78 49 DI 4 C14 76 77 50 48 5V 0V CL S69 INH CP1 470 20 S26 5V 0V S1 C13 L-DATAL 16 RST 20 71 S27 DO 1 C12 R23 1K L-INH 15 S28 S3 C11 13 L-CE 14 S30 5V 0V INH S2 C10 2.2K 2.2K A C9 11 N.C. 12 VOL-B 13 72 5V 0V OSC S29 100 43K 1/3 73 S31 TEST 10 REMO 10 VOL-A 11 X25CN5 KS2 S32 N.C. 9 4 S33 VSS 2 10.2V ILL+B 8 S39 S34 3 ILL+B 7 LCD DRIVER S36 C21 R42 0.01 1.2K R41 D11 1.2K ILL-GND 6 S40 0V D-GND 4 ILL-GND 5 KS4 VLCD4 C16 0.1 REMOTE CONTROL SENSOR POWER SUPPLY SW IC1 S38 S3 C1 93 94 99 99 S41 VLCD3 1.7V 5V 0V Q6 N.C. 2 D-GND 3 92 98 100 10 S42 3 R2 4 2 GND 1 3 R10 1K S43 S35 91 97 97 S45 S44 5V 0V S37 96 98 4.9V 5.0V 1 R6 3.9K S46 VLCD2 3.3V R24 47K INH S47 VLCD1 5.0V S71 PAN-5V R9 100 IC3 S49 5V 0V S70 CN1 10K 10K Q6 R1 43K OUT C7 2.2 VCC 3 GND R15 100K 0V S50 S48 4 C2 0.1 C5 0.1 R3 REMOTE CONTROL SENSOR KS3 75 D26 IC3 C4 0.1 5V 0V 5V 0V S2 Q5 C6 0.01 VLCD AVR R12 750 4.7 2.2K R11 2.2K 84 680P 2.2K 2.2K 83 R5 10K 10K CP5 1K 76 N.C. 77 KI1 78 KI2 5V 79 KI3 0V 80 KI4 81 KI5 82 REMO R67 330 83 RED R68 330 84 GREEN 85 KEY 86 VDD 5.0V 87 VLCD 8.5V 88 VLCD0 6.7V R4 Q1 KEY SCAN START SW 2 R26 1K KS5 74 KI1 KI2 KI3 KI5 D22 KI4 CP4 1K S94 C8 C6 C5 C7 C2 C3 C4 C1 D21 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 S97 S99 S106 S105 S104 S103 S102 S10 S100 S98 S S S S S S S S S S S S S S S32 S31 S30 S29 S27 S28 S26 31 30 29 28 27 26 S42 S41 S44 S47 S45 S46 N.C J1 1 PAN-DET N.C 3 N.C 4 2 SDA 5 VDD 11 N.C 10 N.C 12 N.C 13 N.C 15 TP4 N.C 6 CP1 100 SCL 8 N.C 7 N.C 9 TP3 5.0V IC1 5V 0V 5 6 7 8 SDA SCL WP VCC GND 14 TP1 GND A2 TP2 A0 A1 EEP ROM 4 3 2 0V 1 IC1 IC2 IC3 : LC75808W : LC75878W : RS-171 Q1,6 Q5,11 : DTA114EUA or UN5111 : 2SC4081 D1 D2-5 D11 D16-19 D21,22 D26 : : : : : : C1 C2 S39 C3 32 S38 C4 33 S36 C5 34 S35 C6 35 S37 C8 S33 36 S33 C7 S34 37 S34 C9 S35 38 S98 C11 S36 39 C10 S37 40 S100 C12 S38 41 C13 S39 16 SEG 113 SWITCH UNIT (X16-2080-10) 51 SEG 94 52 SEG 93 MA3062-M DA204U B30-1564-05 B30-1571-05 FTZ6.8E MA3091-M X16-2140-10 (2/2) 72 SEG 73 71 SEG 74 46 COM 3 47 COM 2 SEG 27 99 SEG 26 98 SEG 1 73 SEG 2 74 SEG 3 75 SEG 4 76 SEG 5 77 SEG 6 78 SEG 7 79 SEG 8 80 SEG 9 81 SEG 10 82 SEG 11 83 SEG 12 84 SEG 13 85 SEG 14 86 SEG 15 87 SEG 16 88 SEG 17 89 SEG 18 90 SEG 19 91 SEG 20 92 SEG 21 93 SEG 22 94 SEG 23 95 S73 S74 S75 S76 S77 S78 S79 S80 S81 S82 S83 S84 S85 S86 S87 S88 S89 S90 S91 S92 S93 S94 S95 72 SEG 73 71 SEG 74 70 SEG 75 69 SEG 76 68 SEG 77 67 SEG 78 66 SEG 79 65 SEG 80 64 SEG 81 63 SEG 82 62 SEG 83 61 SEG 84 60 SEG 85 59 SEG 86 58 SEG 87 57 SEG 88 56 SEG 89 55 SEG 90 54 SEG 91 53 SEG 92 52 SEG 93 51 SEG 94 50 SEG 95 49 SEG 96 45 COM 4 SEG 28 100 48 COM 1 44 COM 5 SEG 29 101 SEG 25 97 43 COM 6 SEG 30 102 SEG 24 96 41 COM 8 42 COM 7 40 COM 9 SEG 31 103 39 COM 10 SEG 32 104 38 COM 11 SEG 33 105 SEG 36 108 SEG 35 107 36 COM 13 37 COM 12 SEG 37 109 SEG 34 106 35 COM 14 SEG 38 110 33 COM 16 32 SEG 97 31 SEG 98 30 SEG 99 29 SEG 100 28 SEG 101 27 SEG 102 26 SEG 103 25 SEG 104 24 SEG 105 23 SEG 106 22 SEG 107 21 SEG 108 20 SEG 109 19 SEG 110 18 SEG 111 17 SEG 112 16 SEG 113 15 SEG 114 14 SEG 115 13 SEG 116 12 SEG 117 11 SEG 118 10 SEG 119 9 SEG 120 8 SEG 121 34 COM 15 S96 S97 S98 S99 S100 S101 S102 S103 S104 S105 S106 S107 S108 S109 S110 S111 S112 S113 S114 S115 S116 S117 S118 S119 S7 SEG 39 111 SEG 40 112 SEG 41 113 SEG 42 114 SEG 43 115 SEG 44 116 SEG 45 117 SEG 46 118 SEG 47 119 SEG 48 120 SEG 49 121 SEG 50 122 SEG 51 123 SEG 52 124 SEG 53 125 SEG 54 126 SEG 55 127 SEG 56 128 SEG 57 129 SEG 58 130 SEG 59 131 SEG 60 132 SEG 61 133 SEG 62 134 SEG 63 135 S121 S120 SEG 1 73 SEG 2 74 SEG 3 75 SEG 4 76 SEG 5 77 SEG 6 78 SEG 7 79 SEG 8 80 SEG 9 81 SEG 10 82 SEG 11 83 SEG 12 84 SEG 13 85 SEG 14 86 SEG 15 87 SEG 16 88 SEG 17 89 SEG 18 90 SEG 19 91 SEG 20 92 SEG 21 93 SEG 22 94 SEG 23 95 SEG 24 96 SEG 25 97 SEG 26 98 SEG 27 99 SEG 28 100 SEG 29 101 SEG 30 102 SEG 31 103 SEG 32 104 SEG 33 105 SEG 34 106 SEG 35 107 SEG 36 108 SEG 37 109 SEG 38 110 SEG 39 111 SEG 40 112 SEG 41 113 SEG 42 114 SEG 43 115 SEG 44 116 SEG 45 117 SEG 46 118 SEG 47 119 SEG 48 120 SEG 49 121 SEG 50 122 SEG 51 123 SEG 52 124 SEG 53 125 SEG 54 126 SEG 55 127 SEG 56 128 SEG 57 129 SEG 58 130 SEG 59 131 SEG 60 132 SEG 61 133 SEG 62 134 SEG 63 135 SEG 64 136 SEG 65 137 SEG 66 138 SEG 67 139 SEG 68 140 SEG 69 141 S71 S72 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 S26 S27 S28 S29 S30 S31 S32 S33 S34 S35 S36 S37 S38 S39 S40 S41 S42 S43 S44 S45 S46 S47 S48 S49 S50 S51 S52 S53 S54 S55 S56 S57 S58 S59 S60 S61 S62 S63 S64 S65 S66 S67 S68 S69 S70 AM 70 SEG 75 69 SEG 76 68 SEG 77 67 SEG 78 66 SEG 79 65 SEG 80 64 SEG 81 63 SEG 82 62 SEG 83 61 SEG 84 60 SEG 85 59 SEG 86 58 SEG 87 57 SEG 88 56 SEG 89 55 SEG 90 54 SEG 91 53 SEG 92 SEG 65 137 SEG 64 136 6 SEG 123 5 SEG 124 7 SEG 122 SEG 71 143 SEG 72 144 SEG 70 142 S91 AL 50 SEG 95 49 SEG 96 48 COM 1 47 COM 2 46 COM 3 45 COM 4 44 COM 5 43 COM 6 42 COM 7 41 COM 8 40 COM 9 39 COM 10 38 COM 11 37 COM 12 36 COM 13 35 COM 14 34 COM 15 33 COM 16 32 SEG 97 31 SEG 98 30 SEG 99 29 SEG 100 28 SEG 101 27 SEG 102 26 SEG 103 25 SEG 104 24 SEG 105 23 SEG 106 22 SEG 107 21 SEG 108 20 SEG 109 19 SEG 110 18 SEG 111 42 C14 S40 43 AK C15 S41 44 C16 S42 45 15 SEG 114 S43 46 17 SEG 112 S44 47 13 SEG 116 S45 48 14 SEG 115 S46 49 S6 12 SEG 117 S48 50 S5 11 SEG 118 S47 26 S3 10 SEG 119 S49 27 S4 9 SEG 120 S50 28 S90 8 SEG 121 S26 29 S2 S122 S27 30 S89 S123 S30 31 S1 S124 S28 32 S75 SEG 66 138 S29 33 SEG 68 140 S31 34 SEG 67 139 S32 35 6 SEG 123 S33 36 5 SEG 124 S35 37 7 SEG 122 S34 38 S125 S36 39 4 SEG 125 S38 40 S126 S37 41 SEG 69 141 S39 42 1 SEG 128 S40 44 2 SEG 127 S41 45 3 SEG 126 S42 43 4 SEG 125 S128 S43 46 S127 S44 47 SEG 71 143 SEG 72 144 S45 48 SEG 70 142 S46 50 1 SEG 128 S47 49 2 SEG 127 S48 3 SEG 126 S49 ED1 (SEGMENT) S50 ED1 (COMMON) S51 AJ AN KDC-7024/Y,722,8023 1 S74 S87 S73 S88 2 S84 S86 S85 S83 S80 S82 S79 S81 S77 S78 S76 3 S97 S99 4 S104 S106 S105 S103 S102 S101 S40 S43 5 GND LINE B LINE KDC-722/8023/7024/7024Y (2/3) X16CN1 IC1 : BR24C01AFV-W 3/3 B • DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. 25 6 CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. 7 AO AP AQ AR AS KDC-7024/Y,722,8023 1 SWITCH UNIT (X16-2190-10) R1 510 R10 470 D18 D19 5 R9 510 4 Q ATT S3 S2 S1 3 AUTO S8 S7 - D17 FM S4 R2 510 D20 S5 D16 KS1 2 D15 R8 510 DTA123JK DTC114YUA DTC143TUA UN5111 UN5114 UN5213 UN5214 UN5216 2SA1362 2SA1576A RD6.8M 2SB1188 BR24C01AF-W TC74HC02AF S9 D14 6 - S10 S6 D13 R7 510 D12 KS2 S14 D10 SHIFT D11 2 DISP S13 S12 S11 1 SRC OPEN S18 S17 S16 - R6 510 S15 KS3 D8 D7 R5 330 3 D9 S19 AM D6 R3 330 D1 D2 D3 KI4 M5237ML KI1 D5 KI2 D4 KI5 R4 330 KI3 - 2SC4081 KS4 R18 1K Q3 R17 1K KEY ILLUMINATION SW (RED) DTA114EUA DTA124EUA DTC124EUA DTC144EUA 4 MCH6101 5 1K 4 Q2 R19 KEY ILLUMINATION SW (GREEN) R16 1K 10K 4 S20 5 LB1930M 47K D21 KI5 KI4 KI2 KI3 KI1 KS4 KS3 KS1 5.0V 10.2V KS2 DSI R15 Q1 240 DAN202U 6 5 4 3 2 1 KS1 KI2 KI3 KI4 KI5 RED-SW GREEN-SW RST N.C. DSI KI1 7 N.C. 8 KS4 9 KS3 15 14 13 12 11 10 KS2 VOL-B VOL-A D-GND PAN-5V ILL+B N.C. ILL+B 17 16 ILL-GND 5 24 23 22 21 20 19 18 ESD-GND S21 Q1 X16CN2 Q2,3 2/3 B GND LINE B LINE CN1 TDA7479D DAP202U DA204U DTA114YUA : DTA114YUA or UN5114 : 2SC4081 D1-11,13,15,17 : B30-1605-05 D12,14,16,18,19,21 : B30-1566-05 D20 : DAP202U or MA142WA KDC-722 (3/3) KDC-8023 (3/3) KDC-7024 (3/3) KDC-7024Y (3/3) MA142WA UN5212 6 CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. • DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. 7 26 X16-2190-10 KDC-7024/Y,722,8023 EXPLODED VIEW (MECHANISM) A B 43 37 F 43 51 F 1 43 56 37 55 43 2 36 33 37 37 Jx2 53 H Bx2 850 834 5 32 849 41 807 809 35 33 DPU1 22 8 G 40 806 E Ax2 15 44 39 2 801 42 45 DM2 23 11 10 26 13 17 27 30 12 38 18 31 29 28 19 25 14 DFPC1 16 24 DM1 3 F A B C D E F G H J φ2x8 : N09-4460-05 : N09-4472-05 M1.7x8.5 : N09-6004-05 M1.7x2.5 : N09-6006-05 φ2x3.5 : N09-6007-05 M2x2 : N09-6051-05 φ2x6(BLK) 1.6 WASHER : N19-2163-04 : N39-2020-46 M2x2 : N09-6108-05 M2x3.5 (X32-) 52 858 F Parts with the exploded numbers larger than 700 are not supplied. F 27 KDC-7024/Y,722,8023 EXPLODED VIEW (UNIT) C 210 D 278 : A M2x1.9 : B : C M2x2 : D : E M2x3(BLK) : F φ2x5 : G φ2x5(BLK) : H φ2x4 : J M2x3(BLK) : K M2x2 : M φ2x5(BLK) N FLAT WASHER : DC1 RM2 302 DC2 RM1 220x2 306 1 SIZE AA BATTERY (Not Supplied) 303 201 769 814 292 N19-2176-04 N24-3015-60 N38-2025-46 N38-2650-45 N67-3005-46 N83-3005-46 N83-3008-46 N86-2004-45 N80-3008-46 N83-3010-46 N84-2004-46 U 216 297 758 Tx2 214 DME1 ED1 311 717 270 206 769 293 300 296 298 215 718 FLAT WASHER : RETAINIING RING : M2x2.5 : M2.6x5(BLK) : M3x5 : φ3x5 : φ3x8 : φ2x4(BLK) : φ3x8 : φ3x10 : φ2x4 : PA1 213 790 P Q R S T U V W X Y Z 219 PA2 294 N09-4448-05 N09-6073-05 N09-6087-05 N09-6088-05 N09-6089-05 N09-6093-05 N09-6094-05 N09-6095-05 N09-6096-05 N09-6097-05 N09-6105-05 N19-2175-04 707 705 299 262x2 243 313 310 (X16-219) 810 PME1 U FPC1 G 264 281 (X16-214) 222 225 809 Q Z U 816 Q M 812 228 256 808 315 (X16-221) 265 774 208 251 K D 237 245 223 C 709 239 Kx2 Cx2 229 P 286 277 230 236 Cx2 Q P 235 233 C C 224 285 Cx2 272 283 PM2 N 817 234 FPC2 266 253 768 819 280 227 226 238 232 703 K 267 PM1 287 K K Q B 204 Yx2 Cx2 Rx2 763 Yx2 760 279 775 U (X25-) K 252 FPC3 W2 759 (X25-966) G 249 F1 820 U 748 284 G X 740 C G Jx2 3 747 V G U U Vx2 Vx2 243 242 FC1 F 776 2 262x2 773 G 295 264 225 (X16-208) 262x2 312 F H Ex2 S A Cx2 K Q 250 768 U 702 212 W A Depends on the model. Refer to the parts list. 28 S Parts with the exploded numbers larger than 700 are not supplied. KDC-7024/Y,722,8023 PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. A N DestiRef. No. d e Parts No. Description nation d w KDC-7024/Y,722,8023 ✽ ✽ ✽ ✽ ✽ 201 204 206 PA1 PA1 1C 3C 1D 1D 1D A02-2731-03 A22-2988-03 A52-0831-02 A64-2981-01 A64-2983-01 PA1 PA2 PA2 PME1 RM1 1D ✽ A64-2987-01 1C A64-2995-02 1C A64-3003-02 2C ✽ A10-5029-11 1C A70-2026-05 PANEL ASSY PANEL ASSY PANEL ASSY CHASSIS ASSY REMOTE CONTROLLER ASSY (RC-420) RM2 1C REMOTE CONTROLLER ASSY (RC-505) K6 A70-2040-05 PLASTIC CABINET ASSY SUB PANEL ASSY TOP PLATE PANEL ASSY PANEL ASSY K6 M2 E4E5 K6M2 E4E5 M2 - B46-0100-50 B46-0606-04 B46-0612-14 ✽ B46-0653-03 B64-2460-00 WARRANTY CARD ID CARD ID CARD USER CARD INSTRUCTION MANUAL (ENGLISH) K6M2E4 K6 M2E4E5 K6 K6 - ✽ B64-2461-10 ✽ B64-2463-00 B64-2468-00 B64-2469-00 B64-2470-00 INSTRUCTION MANUAL (FRE.SPA.) INSTRUCTION MANUAL (ENG.T-CHI.) INSTRUCTION MANUAL (ENGLISH) INSTRUCTI.MANUAL (FRE.GER.DUT.) INSTRUCTI.MANUAL (ITA.SPA.POR.) K6 M2 E4E5 E4 E4 208 210 ✽ B64-2471-00 ✽ B64-2472-00 ✽ B64-2473-00 3C B03-5015-03 1C ✽ B07-3078-01 212 213 213 213 214 3C 1D 1D 1D 1C 215 216 219 1C ✽ B12-1222-03 1C ✽ B19-2201-04 1C ✽ B43-1505-04 INDICATOR ASSY LIGHTING BOARD KENWOOD BADGE 220 222 223 224 225 1C 2C 3C 3D 2C ✽ ✽ ✽ ✽ D10-4674-04 D10-4716-04 D10-4718-04 D10-4721-11 D10-4749-03 LEVER ARM ASSY ARM ASSY SLIDER ASSY LEVER 226 227 228 229 230 3D 3D 2D 3D 3C ✽ ✽ ✽ ✽ ✽ D10-4750-04 D12-0637-03 D13-2270-04 D13-2272-04 D13-2273-14 LEVER CAM GEAR GEAR GEAR 232 233 234 235 236 3C 3D 3D 3D 3D ✽ ✽ ✽ ✽ ✽ D13-2274-14 D13-2276-04 D13-2277-04 D13-2278-04 D13-2289-03 GEAR GEAR GEAR GEAR RACK (GEAR) 237 238 239 3C ✽ D13-2290-04 3C ✽ D16-0617-05 3C ✽ D23-0958-04 ✽ ✽ ✽ ✽ ✽ B07-3080-02 B10-4388-01 B10-4390-01 B10-4394-01 B12-1221-04 E : Europe K : North America M : Other Areas W : Without Europe INSTRUCTION MANUAL (RUS.POL.) E5 INSTRUCTI.MANUAL (CZE.HUN.CRO.) E5 INSTRUCTION MANUAL (SWE.FIN.) E5 DRESSING PLATE ASSY ESCUTCHEON ESCUTCHEON FRONT GLASS FRONT GLASS FRONT GLASS INDICATOR K6 M2 E4E5 GEAR ASSY BELT RETAINER K6 : KDC-722 M2 : KDC-8023 E4 : KDC-7024 E5 : KDC-7024Y 242 242 243 243 245 A d d 2D 2D 2D 2D 3D DC1 DC2 DC2 FC1 1C 1C 1C 2D ✽ E30-4942-05 E30-6062-05 E30-6106-05 E39-0565-05 DC CORD (ISO) DC CORD DC CORD FLAT CABLE 249 250 251 252 253 2C 3C 3C 2C 3C ✽ ✽ ✽ ✽ ✽ F07-1121-03 F07-1122-03 F07-1123-03 F09-1794-04 F09-1798-04 COVER COVER COVER SHEET SHEET 256 262 F1 2D ✽ F09-1842-04 2D F29-0049-05 2D F52-0006-05 264 265 266 267 270 2C 3C 3C 3D 2C 272 3D ✽ G11-3559-04 Ref. No. N e w Parts No. E30-6212-05 ✽ E30-6213-05 ✽ E30-6216-05 E30-6217-05 ✽ E41-0351-05 ✽ ✽ ✽ ✽ ✽ G01-3162-04 G01-3188-04 G01-3189-04 G01-3199-04 G11-3539-04 Destination CORD WITH PINPLUG (2PR+1AUX) M2 CORD WITH PINPLUG (2PR) K6E4E5 CORD WITH DIN CONNECTOR (CH) K6M2 CORD WITH DIN CONNECTOR (CH+DIS) E4E5 FLAT CABLE CONNECTOR Description E4E5 M2 K6 SHEET INSULATING COVER FUSE (MINI BLADE TYPE) EXTENSION SPRING EXTENSION SPRING TORSION COIL SPRING TORSION COIL SPRING CUSHION (VOL) CUSHION - ✽ H10-4854-12 ✽ H21-1151-04 H25-0329-04 H25-0337-04 H25-1111-04 POLYSTYRENE FOAMED FIXTURE PROTECTION SHEET PROTECTION BAG (280X450X0.03) K6M2 PROTECTION BAG (180X300X0.03) PROTECTION BAG (280X450X0.03) E4E5 - ✽ ✽ ✽ ✽ ITEM CARTON CASE ITEM CARTON CASE ITEM CARTON CASE ITEM CARTON CASE H54-2721-03 H54-2723-03 H54-2727-03 H54-2728-03 277 278 279 280 281 3C 1C 3D 3D 2C ✽ J19-5220-03 J21-9823-03 ✽ J21-9951-03 ✽ J21-9954-02 ✽ J21-9956-12 HOLDER MOUNTING HARDWARE ASSY MOUNTING HARDWARE ASSY MOUNTING HARDWARE ASSY MOUNTING HARDWARE ASSY 283 284 285 286 287 3D 2C 3C 3C 3D ✽ ✽ ✽ ✽ ✽ J21-9997-03 J21-9999-02 J31-1055-04 J31-1056-04 J74-1444-04 MOUNTING HARDWARE ASSY MOUNTING HARDWARE ASSY COLLAR COLLAR RIGID PRINTED WIRING BOARD FPC1 FPC2 2D ✽ J84-0153-05 3D ✽ J84-0156-04 FLEXIBLE PRINTED WIRING BOARD FLEXIBLE PRINTED WIRING BOARD 292 293 294 295 296 1C 1C 1C 2C 1C ✽ ✽ ✽ ✽ ✽ K24-4004-04 K24-4005-04 K24-4006-04 K24-4007-04 K25-1527-03 KNOB (PLAY) KNOB (EJECT) KNOB (ATT) KNOB (OPEN) KNOB (SRC,Q) 297 298 299 300 1C 1C 2C 1C ✽ ✽ ✽ ✽ K25-1529-03 K25-1530-04 K25-1528-03 K29-7031-03 KNOB (AM/FM) KNOB (SCRL) KNOB (1-6) KNOB ASSY (VOL) K6 M2 E4 E5 Indicates safety critical components. 29 KDC-7024/Y,722,8023 PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. A N DestiRef. No. d e Parts No. Description nation d w 302 1C N99-1723-05 SCREW SET K6M2 303 1C ✽ N99-1734-05 SCREW SET A 3D N09-4448-05 MACHINE SCREW B 3C ✽ N09-6073-05 STEPPED SCREW C 3D ✽ N09-6087-05 MACHINE SCREW KDC-7024/Y,722,8023 Ref. No. A d d N e w Parts No. Destination Description C12-14 C15 C16 C16 C21 CK73GB1H104K CK73GB1H103K CK73GB1C104K CK73GB1H104K CK73GB1H103K CHIP C CHIP C CHIP C CHIP C CHIP C 0.10UF 0.010UF 0.10UF 0.10UF 0.010UF K K K K K CK73GB1H103K CHIP C 0.010UF K D E F G H 3C 3D 2C 2C 2C ✽ ✽ ✽ ✽ ✽ N09-6088-05 N09-6089-05 N09-6093-05 N09-6094-05 N09-6095-05 STEPPED SCREW MACHINE SCREW TAPTITE SCREW MACHINE SCREW MACHINE SCREW C26-29 J K M N P 2C 3C 2C 2C 3D ✽ ✽ ✽ ✽ ✽ N09-6096-05 N09-6097-05 N09-6105-05 N19-2175-04 N19-2176-04 MACHINE SCREW MACHINE SCREW STEPPED SCREW FLAT WASHER FLAT WASHER CP1 CP4,5 R1 R2-5 R6 R90-1016-05 R90-0724-05 RK73GB2A433J RK73GB2A222J RK73GB2A392J MULTI-COMP MULTI-COMP CHIP R 43K CHIP R 2.2K CHIP R 3.9K 470 X4 1K X4 J 1/10W J 1/10W J 1/10W Q R S T U 2C N24-3015-60 3C N38-2025-46 3D ✽ N38-2650-45 2D N67-3005-46 2D N83-3005-46 E TYPE RETAINING RING PAN HEAD MACHIN SCREW PAN HEAD MACHIN SCREW PAN HEAD SEMS SCREW PAN HEAD TAPTITE SCREW R7,8 R9 R10 R11 R12 RK73GB2A331J RK73GB2A101J RK73GB2A102J RK73GB2A4R7J RK73GB2A751J CHIP R CHIP R CHIP R CHIP R CHIP R 330 100 1.0K 4.7 750 J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W V W 2D 3C N83-3008-46 N86-2004-45 PAN HEAD TAPTITE SCREW BINDING HEAD TAPTITE SCREW RLED RPH RK73GB2A102J RK73GB2A104J CHIP R CHIP R R13 R14 R15 R23 R24 RK73GB2A102J RK73GB2A4R7J RK73GB2A104J RK73GB2A102J RK73GB2A473J CHIP R CHIP R CHIP R CHIP R CHIP R 1.0K 4.7 100K 1.0K 47K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W SW1 SW2-3 SW4 S68-0871-05 S68-0863-05 S68-0864-05 PUSH SWITCH (PANEL MECHA) PUSH SWITCH (PANEL MECHA) PUSH SWITCH (PANEL MECHA) R26 R31 R32-35 R36 R41,42 RK73GB2A102J RK73GB2A433J RK73GB2A222J RK73GB2A4R7J RK73GB2A122J CHIP R CHIP R CHIP R CHIP R CHIP R 1.0K 43K 2.2K 4.7 1.2K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R51,52 R53,54 R67,68 RK73FB2B271J RK73GB2A472J RK73GB2A331J CHIP R CHIP R CHIP R 270 4.7K 330 J 1/8W J 1/10W J 1/10W D1 D2-5 D21,22 D26 IC1 MA3062-M DA204U FTZ6.8E MA3091-M LC75808W ZENER DIODE DIODE ZENER DIODE ZENER DIODE MOS-IC IC2 IC3 Q1 Q1 Q5 LC75878W RS-171 DTA114EUA UN5111 2SC4081 MOS-IC ANALOGUE IC DIGITAL TRANSISTOR DIGITAL TRANSISTOR TRANSISTOR Q6 Q6 Q11 DTA114EUA UN5111 2SC4081 DIGITAL TRANSISTOR DIGITAL TRANSISTOR TRANSISTOR 1C 1.0K 100K 313 CN1 CN2 J 1/10W J 1/10W 306 PH PM1 PM2 T90-0552-05 T95-0212-05 3D ✽ T42-1076-14 3D ✽ T42-1077-04 ANTENNA ADAPTOR E4E5 OPTO ISOLATOR (PANEL MECHA) MOTOR ASSY MOTOR ASSY DME1 2D CD MECHANISM ASSY X92-4450-01 SUB-CIRCUIT UNIT (X16-2080-10) J1 E59-0833-15 RECTANGULAR PLUG CP1 R90-1019-05 MULTI-COMP IC1 ✽ BR24C01AFV-W 100 X2 MEMORY IC SUB-CIRCUIT UNIT (X16-2140-10) 310 311 312 D11 D16-19 ED1 2C ✽ B11-1405-04 2C ✽ B11-1406-04 2C ✽ B19-2204-02 B30-1564-05 B30-1571-05 ✽ B38-1119-05 REFLECTION SHEET OPTICAL DIFFUSER LIGHTING BOARD LED (1608, BLUE) LED (WHITE) LIQUID CRYSTAL C1 C2-5 C2-5 C6 C7 CC73GCH1H681J CK73GB1C104K CK73GB1H104K CK73GB1H103K CK73FB1A225K C11 C12-14 CC73GCH1H681J CHIP C CK73GB1C104K CHIP C E : Europe K : North America M : Other Areas W : Without Europe 30 CHIP C CHIP C CHIP C CHIP C CHIP C 2C ✽ E29-1930-04 E40-9364-05 E41-0166-05 CONDUCTIVE RUBBER FLAT CABLE CONNECTOR FLAT CABLE CONNECTOR SWITCH UNIT (X16-2190-10) 680PF 0.10UF 0.10UF 0.010UF 2.2UF J K K K K D1-11 D12 D13 D14 D15 B30-1605-05 B30-1566-05 B30-1605-05 B30-1566-05 B30-1605-05 LED (2COLOR PG/RED) LED (1608, RED) LED (2COLOR PG/RED) LED (1608, RED) LED (2COLOR PG/RED) 680PF 0.10UF J K D16 D17 B30-1566-05 B30-1605-05 LED (1608, RED) LED (2COLOR PG/RED) K6 : KDC-722 M2 : KDC-8023 E4 : KDC-7024 E5 : KDC-7024Y Indicates safety critical components. KDC-7024/Y,722,8023 PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. A N DestiRef. No. d e Parts No. Description nation d w D18,19 B30-1566-05 LED (1608, RED) D21 B30-1566-05 LED (1608, RED) CN1 ✽ E41-0419-05 FLAT CABLE CONNECTOR R1,2 R3-5 R6-9 R10 R15 RK73FB2B511J RK73FB2B331J RK73FB2B511J RK73FB2B471J RK73GB2A241J CHIP R CHIP R CHIP R CHIP R CHIP R 510 330 510 470 240 J J J J J R16-19 RK73GB2A102J CHIP R 1.0K J 1/10W S1 S2,3 S4 S5-8 S9 S10-13 S14 S15-18 S19 S20 S21 D20 D20 Q1 Q1 Q2,3 ✽ S70-0901-05 S70-0864-05 S70-0856-05 S70-0864-05 S70-0856-05 S70-0864-05 S70-0856-05 S70-0864-05 S70-0856-05 S70-0864-05 ✽ T99-0445-05 DAP202U MA142WA DTA114YUA UN5114 2SC4081 1/8W 1/8W 1/8W 1/8W 1/10W TACT SWITCH TACT SWITCH TACT SWITCH TACT SWITCH TACT SWITCH TACT TACT TACT TACT TACT SWITCH SWITCH SWITCH SWITCH SWITCH ROTARY ENCODER DIODE DIODE DIGITAL TRANSISTOR DIGITAL TRANSISTOR TRANSISTOR SUB-CIRCUIT UNIT (X16-2210-10) 315 2C ✽ E58-0968-05 RECTANGULAR RECEPTACLE FPC3 2C ✽ J84-0154-05 FLEXIBLE PRINTED WIRING BOARD ELECTRIC UNIT (X25-966x-xx) C1,2 C3,4 C5 C5,6 C7,8 CE04NW1HR47M CK73FB1C474K CE04NW0J470M CE04NW0J470M CK73FB1C474K ELECTRO CHIP C ELECTRO ELECTRO CHIP C 0.47UF 0.47UF 47UF 47UF 0.47UF 50WV K 6.3WV K6E4E5 6.3WV M2 K M2 C9 C10 C11 C11 C12 CK73GB1A474K CC73GCH1H151J CK73GB1E223K CK73GB1H223K CK73GB1H103K CHIP C CHIP C CHIP C CHIP C CHIP C 0.47UF 150PF 0.022UF 0.022UF 0.010UF K J K K K C13-16 C21-24 C21,22 C31-34 C41,42 CK73FB1H104K CK73FB1C105K CK73FB1C105K C90-5296-05 CE04NW1V3R3M CHIP C CHIP C CHIP C NP-ELECT ELECTRO 0.10UF 1.0UF 1.0UF 0.22UF 3.3UF K K K 50WV 35WV C49,50 C67 C69 C70,71 C71 CE04NW1V3R3M CK73FB1H104K CK73FB1H104K CK73GB1H103K CK73GB1H103K ELECTRO CHIP C CHIP C CHIP C CHIP C 3.3UF 0.10UF 0.10UF 0.010UF 0.010UF 35WV K K K K M2 K6E4E5 C100 C100 C90-5235-05 C90-5484-05 ELECTRO ELECTRO 2200UF 3900UF 16WV 16WV K6M2 E4E5 E : Europe K : North America M : Other Areas W : Without Europe K6 : KDC-722 M2 : KDC-8023 M2E4E5 K6 E4 : KDC-7024 E5 : KDC-7024Y SWITCH UNIT (X16-2190-10) Ref. No. A d d N e w Parts No. Destination Description C101 C102 C103 C104 C105 CK73GB1H103K C90-2866-05 CK73GB1H103K CE04NW1C100M CE04NW0J101M CHIP C ELECTRO CHIP C ELECTRO ELECTRO 0.010UF 220UF 0.010UF 10UF 100UF K 16WV K 16WV 6.3WV C106 C107 C108 C109 C126 CK73GB1A474K CK73FB1C105K CE04CW1A221M CE04CW1A101M CE04NW1V3R3M CHIP C CHIP C ELECTRO ELECTRO ELECTRO 0.47UF 1.0UF 220UF 100UF 3.3UF K K 10WV 10WV 35WV C127 C127 C128 C129 C130 CK73GB1C683K CK73GB1H683K CE04NW1H0R1M CK73GB1H103K CK73GB1E223K CHIP C CHIP C ELECTRO CHIP C CHIP C 0.068UF 0.068UF 0.1UF 0.010UF 0.022UF K K 50WV K K C130 C131 C132 C134,135 C200 CK73GB1H223K CE04NW1H010M CK73GB1H102K CK73GB1H103K CE04NW0J470M CHIP C ELECTRO CHIP C CHIP C ELECTRO 0.022UF 1.0UF 1000PF 0.010UF 47UF K 50WV K K 6.3WV C201 C202 C203 C204 C206 CK73GB1H103K CC73GCH1H220J CC73GCH1H270J CK73GB0J105K CK73GB0J105K CHIP C CHIP C CHIP C CHIP C CHIP C 0.010UF 22PF 27PF 1.0UF 1.0UF K J J K K C207,208 C211 C213 C250 C251 CK73GB1H103K CK73GB1H102K CK73GB1H103K CE04NW1C470M CK73GB1H103K CHIP C CHIP C CHIP C ELECTRO CHIP C 0.010UF 1000PF 0.010UF 47UF 0.010UF K K K 16WV K C252 C252 C253,254 C253,254 C255 CE04MW1H2R2M CE04NW1H2R2M CK73GB1C104K CK73GB1H104K CE04NW1H010M ELECTRO ELECTRO CHIP C CHIP C ELECTRO 2.2UF 2.2UF 0.10UF 0.10UF 1.0UF 50WV 50WV K K 50WV C256 C257 C258 C259-262 C401 CE04NW1C330M C90-2935-05 CE04NW1H010M CK73GB1A224K CK73GB1H103K ELECTRO ELECTRO ELECTRO CHIP C CHIP C 33UF 1.0UF 1.0UF 0.22UF 0.010UF 16WV 50WV 50WV K K C403 C405 C407 C408 C409 CK73GB1H103K CK73GB1H103K CK73GB1H103K CK73FB1A225K CK73GB1H103K CHIP C CHIP C CHIP C CHIP C CHIP C 0.010UF 0.010UF 0.010UF 2.2UF 0.010UF K K K K K E4E5 E4E5 C410 C411 C412,413 CE04NW1C100M ELECTRO CC73GCH1H331J CHIP C CC73GCH1H100D CHIP C 10UF 330PF 10PF 16WV J D E4E5 E4E5 E4E5 CN1 CN2 CN3 CN4 CN4 E41-0224-05 E40-3237-05 ✽ E41-0384-05 E40-9527-05 E41-0213-05 PIN ASSY PIN ASSY PIN ASSY FLAT CABLE CONNECTOR FLAT CABLE CONNECTOR CN5 E40-9368-05 FLAT CABLE CONNECTOR E4E5 E4E5 K6M2 Indicates safety critical components. 31 KDC-7024/Y,722,8023 PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. A N DestiRef. No. d e Parts No. Description nation d w CN6 ✽ E41-0399-05 FLAT CABLE CONNECTOR CN7 E41-0009-05 PIN ASSY J1 E58-0863-15 RECTANGULAR RECEPTACLE W2 ✽ E30-6218-05 CORD WITH PLUG L1 L4 L5 L6 L7 L33-1170-05 L40-4795-91 L92-0075-05 L40-4795-91 L33-1039-05 CHOKE COIL ASSY SMALL FIXED INDUCTOR (4.7UH,J) CHIP FERRITE SMALL FIXED INDUCTOR (4.7UH,J) LINE FILTER COIL L11-13 L11-13 L11,12 L11,12 X1 L40-4795-34 L40-4795-68 L40-4795-34 L40-4795-68 L78-0821-05 SMALL FIXED INDUCTOR SMALL FIXED INDUCTOR (4.7UH) SMALL FIXED INDUCTOR SMALL FIXED INDUCTOR (4.7UH) RESONATOR X2 X3 L77-2738-05 L77-2002-05 CRYSTAL RESONATOR CRYSTAL RESONATOR N83-3005-46 N80-3008-46 N83-3010-46 N84-2004-46 PAN HEAD TAPTITE SCREW PAN HEAD TAPTITE SCREW PAN HEAD TAPTITE SCREW PAN HEAD TAPTITE SCREW R1,2 R3 R3,4 R5,6 R7 RK73EB2E100J RK73EB2E4R7J RK73EB2E4R7J RK73EB2E100J RK73GB2A472J CHIP R CHIP R CHIP R CHIP R CHIP R 10 4.7 4.7 10 4.7K J J J J J 1/4W 1/4W 1/4W 1/4W 1/10W R8 R9,10 R21,22 R23,24 R31,32 RK73GB2A103J RK73FB2B333J RK73GB2A361J RK73GB2A223J RK73EB2E181J CHIP R CHIP R CHIP R CHIP R CHIP R 10K 33K 360 22K 180 J J J J J 1/10W 1/8W 1/10W 1/10W 1/4W R45,46 R47,48 R55,56 R60,61 R61 RK73GB2A361J RK73GB2A223J RK73EB2E181J RK73GB2A102J RK73GB2A102J CHIP R CHIP R CHIP R CHIP R CHIP R 360 22K 180 1.0K 1.0K J J J J J 1/10W 1/10W 1/4W 1/10W 1/10W R100 R101 R102 R103 R104 RK73FB2B223J RK73GB2A101J RK73GB2A222J RK73GB2A223J RK73FB2B221J CHIP R CHIP R CHIP R CHIP R CHIP R 22K 100 2.2K 22K 220 J J J J J 1/8W 1/10W 1/10W 1/10W 1/8W R105 R106 R107 R108 R112 RK73GB2A153J R92-3047-05 R92-3032-05 RK73FB2B152J RK73FB2B152J CHIP R CHIP R CHIP R CHIP R CHIP R 15K 24K 4.3K 1.5K 1.5K J D D J J 1/10W 1/10W 1/10W 1/8W 1/8W R124 R125,126 R127 R128,129 R130 RK73FB2B472J RD14DB2H102J RK73GB2A223J RD14DB2H102J RK73GB2A223J CHIP R SMALL-RD CHIP R SMALL-RD CHIP R 4.7K 1.0K 22K 1.0K 22K J J J J J 1/8W 1/2W 1/10W 1/2W 1/10W R131 R132 R133 R134 RK73FB2B472J RK73FB2B561J RK73GB2A104J RK73GB2A473J CHIP R CHIP R CHIP R CHIP R 4.7K 560 100K 47K J J J J 1/8W 1/8W 1/10W 1/10W U X Y Z 2D 2D 2D 2D E : Europe K : North America M : Other Areas W : Without Europe 32 K6 : KDC-722 M2 : KDC-8023 E4E5 E4E5 K6M2 K6M2 E4E5 K6E4E5 M2 M2 M2 K6E4E5 K6M2 K6M2 M2E4E5 E4E5 E4 : KDC-7024 E5 : KDC-7024Y ELECTRIC UNIT (X25-966x-xx) A d d N e w R135 R135 R138 R139 R140 RK73GB2A104J RK73GB2A223J RK73GB2A223J RK73FB2B103J RK73GB2A103J CHIP R CHIP R CHIP R CHIP R CHIP R 100K 22K 22K 10K 10K Destination J 1/10W K6M2 J 1/10W E4E5 J 1/10W J 1/8W J 1/10W R141 R142 R143 R144 R145 RK73GB2A822J RK73GB2A183J RD14DB2H332J RK73EB2E473J RK73GB2A104J CHIP R CHIP R SMALL-RD CHIP R CHIP R 8.2K 18K 3.3K 47K 100K J J J J J 1/10W 1/10W 1/2W 1/4W 1/10W R146 R147,148 R148 R200 R201 RK73EB2E102J RK73EB2E103J RK73EB2E103J RK73GB2A153J RK73GB2A103J CHIP R CHIP R CHIP R CHIP R CHIP R 1.0K 10K 10K 15K 10K J J J J J 1/4W M2E4E5 1/4W E4E5 1/4W K6M2 1/10W 1/10W R202 R203,204 R204,205 R205,206 R207 RK73GB2A104J RK73GB2A103J RK73GB2A103J RK73GB2A103J RK73GB2A104J CHIP R CHIP R CHIP R CHIP R CHIP R 100K 10K 10K 10K 100K J J J J J 1/10W 1/10W E4E5 1/10W K6 1/10W M2 1/10W R208,209 R212,213 R214,215 R216,217 R218 RK73GB2A103J RK73GB2A102J RK73GB2A472J RK73GB2A102J RK73GB2A222J CHIP R CHIP R CHIP R CHIP R CHIP R 10K 1.0K 4.7K 1.0K 2.2K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R219,220 R221-224 R225-227 R228 R229 RK73GB2A101J RK73GB2A102J RK73GB2A101J RK73GB2A102J RK73GB2A104J CHIP R CHIP R CHIP R CHIP R CHIP R 100 1.0K 100 1.0K 100K J J J J J 1/10W 1/10W 1/10W E4E5 1/10W 1/10W R230 R231 R232 R233 R234-240 RK73GB2A102J RK73GB2A104J RK73GB2A102J RK73GB2A104J RK73GB2A222J CHIP R CHIP R CHIP R CHIP R CHIP R 1.0K 100K 1.0K 100K 2.2K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R241 R245,246 R247 R248 R250-253 RK73GB2A102J RK73GB2A102J RK73GB2A104J RK73GB2A102J RK73GB2A104J CHIP R CHIP R CHIP R CHIP R CHIP R 1.0K 1.0K 100K 1.0K 100K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W K6M2 R250,251 R254,255 R256 R256,257 R259 RK73GB2A104J RK73GB2A222J RK73GB2A104J RK73GB2A104J RK73GB2A102J CHIP R CHIP R CHIP R CHIP R CHIP R 100K 2.2K 100K 100K 1.0K J J J J J 1/10W E4E5 1/10W 1/10W E4E5 1/10W K6M2 1/10W R260,261 R262 R264 R265 R266 RK73GB2A222J RK73GB2A102J RK73GB2A222J RK73GB2A104J RK73GB2A102J CHIP R CHIP R CHIP R CHIP R CHIP R 2.2K J 1.0K J 2.2K J 100K J 1.0K J 1/10W 1/10W 1/10W 1/10W 1/10W R267 R268 R269 R270,271 R272 RK73GB2A473J RK73GB2A333J RK73GB2A472J RK73GB2A471J RK73GB2A472J CHIP R CHIP R CHIP R CHIP R CHIP R 47K 33K 4.7K 470 4.7K 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. Parts No. Description J J J J J Indicates safety critical components. KDC-7024/Y,722,8023 PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. A N DestiRef. No. d e Parts No. Description nation d w R273 RK73GB2A222J CHIP R 2.2K J 1/10W R274 RK73GB2A102J CHIP R 1.0K J 1/10W R275 RK73GB2A104J CHIP R 100K J 1/10W R277,278 RK73GB2A471J CHIP R 470 J 1/10W R279,280 RK73GB2A472J CHIP R 4.7K J 1/10W ELECTRIC UNIT (X25-966x-xx) Ref. No. D52-55 D52,53 D60 D62 D63-65 A d d N e w Parts No. MA3062WA MA3062WA MA3062WA MA3062WA DA204U ZENER DIODE ZENER DIODE ZENER DIODE ZENER DIODE DIODE R282 R283 R285 R300,301 R302 RK73GB2A103J RK73GB2A103J RK73GB2A102J RK73GB2A472J RK73GB2A221J CHIP R CHIP R CHIP R CHIP R CHIP R 10K 10K 1.0K 4.7K 220 J J J J J 1/10W M2 1/10W K6E4E5 1/10W 1/10W 1/10W D66 IC1 IC2 IC3 IC4 R303 R305 R306 R307 R308 RK73GB2A223J RK73GB2A432J RK73GB2A100J RK73GB2A622J RK73EB2E102J CHIP R CHIP R CHIP R CHIP R CHIP R 22K 4.3K 10 6.2K 1.0K J J J J J 1/10W 1/10W 1/10W 1/10W 1/4W E4E5 IC7 IC8 IC12 IC13,14 IC15 S-80837CNNB TC74HC02AF TDA7479D LB1930M BR24C01AF-W MOS-IC MOS-IC ANALOGUE IC ANALOGUE IC ROM IC R309-311 R312 R313-317 R318,319 R321-323 RK73EB2E471J RK73EB2E101J RK73EB2E472J RK73EB2E101J RK73GB2A222J CHIP R CHIP R CHIP R CHIP R CHIP R 470 100 4.7K 100 2.2K J J J J J 1/4W E4E5 1/4W 1/4W 1/4W 1/10W Q1 Q2 Q3 Q4 Q4 2SA2057 2SC4081 2SA1576A DTA124EUA UN5112 TRANSISTOR TRANSISTOR TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR R324,325 R326 R327,328 R329 R330,331 RK73GB2A472J RK73GB2A104J RK73GB2A472J RK73EB2E472J RK73EB2E101J CHIP R CHIP R CHIP R CHIP R CHIP R 4.7K 100K 4.7K 4.7K 100 J J J J J 1/10W 1/10W 1/10W 1/4W 1/4W Q5 Q5 Q6 Q6 Q7 DTC124EUA UN5212 DTC144EUA UN5213 DTA124EUA DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR R332 R402 R403 R404 R405-407 RK73EB2E471J RK73FB2B102J RK73GB2A223J RK73GB2A472J RK73GB2A222J CHIP R CHIP R CHIP R CHIP R CHIP R 470 1.0K 22K 4.7K 2.2K J J J J J 1/4W 1/8W 1/10W 1/10W E4E5 1/10W E4E5 Q7 Q8,9 Q11 Q11 Q12 UN5112 2SA2057 DTC124EUA UN5212 DTA124EUA DIGITAL TRANSISTOR TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR W1 R92-1252-05 CHIP R 0 OHM J 1/16W E4E5 D1 D2 D3 D4 D6 1N5393G-M5 RB160L-40 MA4056(N)-M MA4082(N)-L MA4110-L DIODE DIODE ZENER DIODE ZENER DIODE ZENER DIODE Q12 Q13 Q14 Q23 Q23 UN5112 2SA2057 2SC4081 DTC114YUA UN5214 DIGITAL TRANSISTOR TRANSISTOR TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR D9-12 D9-12 D13 D14 D15 S1J 1SR154-400 1SS133 MA4056-M MA4047-M DIODE DIODE DIODE ZENER DIODE ZENER DIODE Q24,25 Q25 Q26 Q26 Q27 2SB1240 2SB1240 DTC114YUA UN5214 2SA1576A TRANSISTOR TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR TRANSISTOR D16 D17 D20 D23,24 D23,24 MA4068(N)-M MA4062(N)-M 1SS133 DAP202U MA142WA ZENER DIODE ZENER DIODE DIODE DIODE DIODE Q28 Q28 Q29 Q29 Q30 DTA124EUA UN5112 DTA123JK KRA105S DTC144EUA DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR D25-27 D25,26 D28 D29-31 D33-40 RD6.8M(B2) RD6.8M(B2) RD6.8MW 1SS133 S1J ZENER DIODE ZENER DIODE ZENER DIODE DIODE DIODE Q30 Q32-34 Q51,52 Q51,52 Q53 UN5213 2SC4081 DTA124EUA UN5112 DTC143TUA DIGITAL TRANSISTOR TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR D33-40 D50 D51 1SR154-400 RD6.8M(B2) RD6.8MW DIODE ZENER DIODE ZENER DIODE Q53 Q54 Q54 Q55,56 Q55,56 UN5216 DTC124EUA UN5212 DTC143TUA UN5216 DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR E : Europe K : North America M : Other Areas W : Without Europe K6 : KDC-722 M2 : KDC-8023 M2E4E5 E4E5 M2 K6E4E5 M2 E4 : KDC-7024 E5 : KDC-7024Y IMSA-6801 ✽ UPD703030GC015 TDA7411 M5237ML TDA7560 Description Destination E4E5 K6M2 SURGE ABSORBER MI-COM IC ANALOGUE IC ANALOGUE IC ANALOGUE IC E4E5 K6M2 K6M2 K6M2 E4E5 M2E4E5 M2E4E5 Indicates safety critical components. 33 KDC-7024/Y,722,8023 PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. A N DestiRef. No. d e Parts No. Description nation d w Q59,60 DTC143TUA DIGITAL TRANSISTOR Q59,60 UN5216 DIGITAL TRANSISTOR Q63 DTA124EUA DIGITAL TRANSISTOR Q63 UN5112 DIGITAL TRANSISTOR Q102 DTC124EUA DIGITAL TRANSISTOR Q102 Q103 Q104 Q104 TH1 A1 A1 UN5212 2SB1188(Q,R) DTC143TUA UN5216 PTH9C42BD471Q ✽ X86-3730-11 X86-3732-70 DIGITAL TRANSISTOR TRANSISTOR DIGITAL TRANSISTOR DIGITAL TRANSISTOR POSITIVE RESISTOR E4E5 E4E5 FRONT-END UNIT FRONT-END UNIT K6M2 E4E5 CD PLAYER UNIT (X32-5200-00) C1,2 C3 C4 C5 C6 CK73GB0J105K CK73FB1A225K C92-0566-05 CC73GCH1H220J CC73GCH1H030C CHIP C CHIP C CHIP-TAN CHIP C CHIP C 1.0UF 2.2UF 10UF 22PF 3.0PF K K 6.3WV J C C7 C8 C10 C11 C12 CK73GB1C104K CK73GB0J105K CK73GB1H472K CK73GB1H682K CK73GB1H332K CHIP C CHIP C CHIP C CHIP C CHIP C 0.10UF 1.0UF 4700PF 6800PF 3300PF K K K K K C13 C14 C15 C16 C17 CK73GB1C333K CK73GB1H472K CK73GB1E473K CC73GCH1H221J CK73GB1H472K CHIP C CHIP C CHIP C CHIP C CHIP C 0.033UF 4700PF 0.047UF 220PF 4700PF K K K J K C18 C19,20 C21 C23 C24 CC73GCH1H331J CK73GB1C104K CK73FB1A225K CK73GB1H102K CK73GB1E223K CHIP C CHIP C CHIP C CHIP C CHIP C 330PF 0.10UF 2.2UF 1000PF 0.022UF J K K K K C25 C26 C28 C29 C33 CK73GB1H153K CK73GB0J105K CK73GB0J105K CK73GB1C104K CK73GB1C104K CHIP C CHIP C CHIP C CHIP C CHIP C 0.015UF 1.0UF 1.0UF 0.10UF 0.10UF K K K K K C35 C39 C40 C41 C42 CK73GB1C104K CK73GB1H152K CK73GB1H103K CK73EB1C225K CK73GB1H152K CHIP C CHIP C CHIP C CHIP C CHIP C 0.10UF 1500PF 0.010UF 2.2UF 1500PF K K K K K C44 C46 C51 C55 C67,68 CK73GB1H103K CK73GB1E473K CK73GB1C104K CK73GB1C104K CK73GB1C104K CHIP C CHIP C CHIP C CHIP C CHIP C 0.010UF 0.047UF 0.10UF 0.10UF 0.10UF K K K K K C71,72 C77,78 C79,80 C85 C89 CK73GB1H471K CC73GCH1H680J CK73GB1H222K CK73GB1C104K CK73GB1H222K CHIP C CHIP C CHIP C CHIP C CHIP C 470PF 68PF 2200PF 0.10UF 2200PF K J K K K CN1 E40-9536-05 FLAT CABLE CONNECTOR E : Europe K : North America M : Other Areas W : Without Europe 34 K6 : KDC-722 M2 : KDC-8023 E4 : KDC-7024 E5 : KDC-7024Y ELECTRIC UNIT (X25-966x-xx) Ref. No. A d d N e w Parts No. Destination Description CN1 CN2 CN2 E41-0193-05 E40-9527-05 E41-0213-05 FLAT CABLE CONNECTOR FLAT CABLE CONNECTOR FLAT CABLE CONNECTOR X1 L78-0851-05 RESONATOR (16.93MHZ) CP1 CP2 R3 R5 R6 R90-1019-05 R90-1014-05 RK73GB2A272J RK73GB2A361J RK73GB2A272J MULTI-COMP MULTI-COMP CHIP R 2.7K CHIP R 360 CHIP R 2.7K 100 X2 100 X4 J 1/10W J 1/10W J 1/10W R7 R8 R9 R10,11 R12 RK73GB2A104J RK73GB2A472J RK73FB2B100J RK73GB2A562J RK73GB2A682J CHIP R CHIP R CHIP R CHIP R CHIP R 100K 4.7K 10 5.6K 6.8K J J J J J 1/10W 1/10W 1/8W 1/10W 1/10W R13 R15 R16 R17 R18 RK73GB2A392J RK73GB2A824J RK73GB2A223J RK73GB2A393J RK73GB2A392J CHIP R CHIP R CHIP R CHIP R CHIP R 3.9K 820K 22K 39K 3.9K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R19 R20 R21 R22 R32 RK73GB2A473J RK73GB2A104J RK73GB2A244J RK73GB2A623J RK73GB2A683J CHIP R CHIP R CHIP R CHIP R CHIP R 47K 100K 240K 62K 68K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R34 R35 R36 R37 R38 RK73GB2A363J RK73GB2A104J RK73GB2A151J RK73GB2A471J RK73GB2A224J CHIP R CHIP R CHIP R CHIP R CHIP R 36K 100K 150 470 220K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R40 R46 R47 R49 R52 RK73GB2A133J RK73GB2A102J RK73GB2A103J RK73GB2A472J RK73GB2A104J CHIP R CHIP R CHIP R CHIP R CHIP R 13K 1.0K 10K 4.7K 100K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R53 R54 R70 R71 R73 RK73GB2A103J RK73GB2A104J RK73GB2A103J RK73GB2A183J RK73GB2A683J CHIP R CHIP R CHIP R CHIP R CHIP R 10K 100K 10K 18K 68K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R74 R75 R76 R79,80 R81 RK73GB2A123J RK73GB2A333J RK73GB2A103J RK73GB2A103J RK73GB2A333J CHIP R CHIP R CHIP R CHIP R CHIP R 12K 33K 10K 10K 33K J J J J J 1/10W 1/10W 1/10W 1/10W 1/10W R82 R84 R101,102 R103,104 R107,108 RK73GB2A223J RK73GB2A103J RK73GB2A332J RK73GB2A562J RK73FB2B331J CHIP R CHIP R CHIP R CHIP R CHIP R 22K 10K 3.3K 5.6K 330 J J J J J 1/10W 1/10W 1/10W 1/10W 1/8W R110 R117,118 R121,122 R125,126 R202 RK73FB2B201J RK73FB2B203J RK73FB2B203J RK73FB2B203J RK73GB2A104J CHIP R CHIP R CHIP R CHIP R CHIP R 200 20K 20K 20K 100K J J J J J 1/8W 1/8W 1/8W 1/8W 1/10W Indicates safety critical components. KDC-7024/Y,722,8023 PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. A N DestiRef. No. d e Parts No. Description nation d w R213 RK73GB2A104J CHIP R 100K J 1/10W R218 RK73GB2A473J CHIP R 47K J 1/10W R233 RK73GB2A622J CHIP R 6.2K J 1/10W R234 RK73GB2A103J CHIP R 10K J 1/10W S1,2 S3 S68-0863-05 S68-0862-05 PUSH SWITCH PUSH SWITCH D1 D2 D3 D4 IC1 DAN202U MA8051-L DA204U DAN202U AN22002AA DIODE ZENER DIODE DIODE DIODE ANALOGUE IC IC2 IC4 IC6 Q1 Q2 MN662773KH2 BA5824FP NJM4580M1 MCH6101 DTC124EUA MOS-IC ANALOGUE IC ANALOGUE IC TRANSISTOR DIGITAL TRANSISTOR Q3 Q4 Q5 DTA143XUA 2SA1362(Y) DTC124EUA DIGITAL TRANSISTOR TRANSISTOR DIGITAL TRANSISTOR CD MECHANISM ASSY (X92-4450-01) 2 1B A10-4827-12 CHASSIS 5 8 10 11 12 1B 2A 3A 2A 3A D10-4576-43 D10-4579-03 D10-4581-13 D10-4582-13 D10-4583-03 ARM ASSY LEVER ASSY ARM ARM ARM 13 14 15 16 17 3A 3B 2A 3B 3B D10-4584-03 D10-4585-03 D10-4586-13 D10-4587-22 D10-4588-13 ARM ARM SLIDER SLIDER SLIDER 18 19 22 23 24 3B 3B 2A 2B 3B D10-4595-04 D10-4596-14 D13-2151-04 D13-2152-04 D13-2153-04 ARM ARM GEAR GEAR GEAR 25 26 27 28 29 3B 3B 3B 3B 3B D13-2154-04 D13-2155-04 D13-2156-14 D13-2157-04 D13-2158-04 GEAR WORM GEAR GEAR GEAR 30 31 32 33 35 3B 3B 2B 2A 2B D13-2168-04 D13-2171-04 D13-2172-03 D14-0759-04 D21-2382-04 GEAR GEAR RACK (GEAR) ROLLER SHAFT 36 37 1A 1B D23-0954-04 D39-0246-05 RETAINER DAMPER 38 39 40 41 42 2B 2A 2A 1B 2A G01-3072-04 G01-3073-04 G01-3074-04 G01-3075-04 G01-3076-04 EXTENSION SPRING TORSION COIL SPRING EXTENSION SPRING EXTENSION SPRING EXTENSION SPRING E : Europe K : North America M : Other Areas W : Without Europe K6 : KDC-722 M2 : KDC-8023 E4 : KDC-7024 E5 : KDC-7024Y CD PLAYER UNIT (X32-5200-00) 43 44 45 A d d 1B 2B 2B 51 52 53 55 56 Ref. No. N e w Parts No. Description G01-3077-04 G02-1399-04 G02-1408-04 EXTENSION SPRING FLAT SPRING FLAT SPRING 1A 3B 1B 1A 1B J21-9676-22 J21-9677-02 J21-9678-03 J90-1001-11 J90-1023-03 MOUNTING HARDWARE MOUNTING HARDWARE MOUNTING HARDWARE GUIDE GUIDE A B C E F 2B 1B 2B 2B 1A N09-4460-05 N09-4472-05 N09-6004-05 N09-6007-05 N09-6051-05 TAPTITE SCREW (OVAL P TAPTIT) MACHINE SCREW (M1.7X8.5) MACHINE SCREW (M1.7X2.5 IB-L) MACHINE SCREW (PAN M2X2) TAPTITE SCREW (BIND P 2X5) G H J 2A 1B 1B N19-2163-04 N39-2020-46 N09-6108-05 FLAT WASHER PAN HEAD MACHIN SCREW MACHINE SCREW (M2✽3.5TYPE3) DM1 DM2 3B 2B T42-1066-04 T42-1067-04 DC MOTOR ASSY (SP) DC MOTOR ASSY (LO) DPU1 2D X93-2000-00 OPTICAL PICKUP ASSY Destination Indicates safety critical components. 35 KDC-7024/Y,722,8023 SPECIFICATIONS FM Frequency Range (Frequency step) KDC-7024/Y 87.5MHz~108.0MHz (50kHz) KDC-722 87.9MHz~107.9MHz (200kHz) AM (MW) Channel Space Selection Usable Sensitivity (S/N 26dB) Usable Sensitivity (S/N 30dB) Quieting Sensitivity (S/N 46dB) Quieting Sensitivity (S/N 50dB) Frequency Response (±3.0dB) S/N Selectivity (DIN) Selectivity Stereo Separation Frequency Range (Frequency step) 0.7µV/75Ω 1.6µV/75Ω 30Hz~15kHz 65dB (MONO) ≥ 80dB (±400kHz) 35dB (1kHz) 531kHz~1611kHz (9kHz) 50kHz/200kHz 9.3dBf (0.8µV/75Ω) 15.2dBf (1.6µV/75Ω) 30Hz~15kHz 70dB (MONO) ≥ 80dB (±400kHz) 40dB (1kHz) 530kHz~1700kHz (10kHz) 25µV 153kHz~281kHz 45µV GaAlAs (λ=780nm) 8 Times Over Sampling 1 Bit 500~200rpm (CLV) Below Measurable Limit 10Hz~20kHz (±1dB) 0.01% (1kHz) 105dB (1kHz) 93dB 95dB 2000mV/10kΩ (CD/CD-CH) ≤ 600Ω 50Wx4 30Wx4 100Hz±10dB 1kHz±10dB 10kHz±10dB 14.4V 10A 178x50x165 (mm) 9kHz/10kHz 28dBµ (25µV) GaAlAs (λ=780nm) 8 Times Over Sampling 1 Bit 500~200rpm (CLV) Below Measurable Limit 10Hz~20kHz (±1dB) 0.01% (1kHz) 105dB (1kHz) 93dB 95dB 2000mV/10kΩ (CD/CD-CH) ≤ 600Ω 50Wx4 22Wx4 100Hz±10dB 1kHz±10dB 10kHz±10dB 14.4V 10A 178x50x165 (mm) 7x1-15/16x6-1/2 (in) 3.75lbs (1.70kg) Channel Space Selection Usable Sensitivity (S/N 20dB) LW Frequency Range Usable Sensitivity (S/N 20dB) CD Laser Diode Digital Filter (D/A) D/A Converter Spindle Speed (CD-DA) Wow & Flutter Frequency Response Total Harmonic Distortion S/N Ratio Dynamic Range Channel Separation Preout Level/Load (Unbalanced) Preout Impedance AUX Frequency Response Input Input Maximum Voltage Input impedance Amplifier Maximum Power Full Bandwidth Power (at less than 1% THD) PWR DIN45324, +B=14.4V Tone Bass Middle Treble General Operating Voltage (11V~16V allowable) Current Consumption Installation Size (WxHxD) Weight 1.70kg KDC-8023 87.5MHz~108.0MHz (50kHz) 87.9MHz~107.9MHz (200kHz) 50kHz/200kHz 9.3dBf (0.8µV/75Ω) 15.2dBf (1.6µV/75Ω) 30Hz~15kHz 70dB (MONO) ≥ 80dB (±400kHz) 40dB (1kHz) 531kHz~1611kHz (9kHz) 530kHz~1700kHz (10kHz) 9kHz/10kHz 28dBµ (25µV) GaAlAs (λ=780nm) 8 Times Over Sampling 1 Bit 500~200rpm (CLV) Below Measurable Limit 10Hz~20kHz (±1dB) 0.01% (1kHz) 105dB (1kHz) 93dB 95dB 2000mV/10kΩ (CD/CD-CH) ≤ 600Ω 20Hz~20kHz±1dB 1200mV 100kΩ 50Wx4 22Wx4 100Hz±10dB 1kHz±10dB 10kHz±10dB 14.4V 10A 178x50x165 (mm) 1.70kg follows a policy of continuous advancements in development. For this reason specifications may be changed without notice. KENWOOD CORPORATION 2967-3, Ishikawa-machi, Hachioji-shi, Tokyo 192-8525, Japan KENWOOD USA CORPORATION KENWOOD ELECTRONICS ITALIA S.p.A. P.O. BOX 22745, 2201 East Dominguez Street, Long Beach, CA90801-5745, U.S.A. Via G. Sirtori 7/9, 20129 Milano, Italy KENWOOD ELECTRONICS CANADA INC. KENWOOD IBÉRICA S.A. 6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8 Bolivia, 239-08020 Barcelona, Spain KENWOOD ELECTRONICS LATIN AMERICA S.A. KENWOOD ELECTRONICS AUSTRALIA PTY. LTD. (A.C.N. 001 499 074) P.O. Box 55-2791 Paitilla, Plaza Credicorp Bank Panama, Piso 9, Oficina 901, Calle 50, Panama, Rep. de Panama 16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113, Australia KENWOOD ELECTRONICS BRASIL LTDA. KENWOOD ELECTRONICS (HONG KONG) LTD. Alameda Ministro Rocha Azevedo No. 456, Edificio Jaú, 10o Andar, Cerqueira César, Cep 0140-001, São Paulo-SP-Brasil Unit 3712-3724, Level 37, Tower 1, Metroplaza, 223 Hing Fong Road, Kwai Fong, N.T., Hong Kong KENWOOD ELECTRONICS UK LIMITED P.O. Box 61318, Jebel Ali, Dubai, U.A.E. Kenwood House, Dwight Road, Watford, Herts, WD18 9EB, United Kingdom KENWOOD ELECTRONICS DEUTSCHLAND GMBH Rembrücker-Str. 15, 63150 Heusenstamm, Germany KENWOOD ELECTRONICS FRANCE S.A. 13, Boulevard Ney, 75018 Paris, France KENWOOD ELECTRONICS BELGIUM N.V. Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium KENWOOD ELECTRONICS GULF FZE KENWOOD ELECTRONICS (THAILAND) CO., LTD. 2019 New Pechburi Road, Bangkapi, Huaykwang, Bangkok, 10320 Thailand KENWOOD ELECTRONICS SINGAPORE PTE. LTD. 1 Genting Lane, #07-00, Kenwood Building, Singapore, 349544 KENWOOD ELECTRONICS (MALAYSIA) SDN BHD #4.01 Level 4, Wisma Academy Lot 4A, Jalan 19/1, 46300 Petaling Jaya, Selangor Darul Ehsan, Malaysia