Transcript
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 SCHEMATIC SCH11
BATTERY RED
SOLENOID
A
M
FUSE
AMMETER (OPTIONAL)
BLACK
WHITE
S B G
STARTER
RED
WHITE
M A1
L
A2
ATTACHMENT CLUTCH (CLUTCH OFF) BLACK
CLUTCH/BRAKE (PEDAL UP)
GRAY
REVERSE SWITCH (NOT IN REVERSE)
BLACK BLACK
BLACK
2
BLACK
3
BLACK BLACK
SEAT SWITCH (NOT OCCUPIED)
BLACK BLACK
1 6
GRAY
SHORTING CONNECTOR
CHASSIS HARNESS
IGNITION UNIT
(OPTIONAL)
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES)
HOUR METER
BLUE
BLACK
NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST.
BLACK /WHITE
JUNCTION CONNECTOR
BLACK
FUEL LINE
12V POWER OUTLET (OPTIONAL)
BLUE
FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED)
CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM
28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
RED
LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 RPM DIODE
ALTERNATOR
ORANGE
LIGHT SWITCH
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF) BROWN
BLACK
HEADLIGHTS
IGNITION SWITCH POSITION
CIRCUIT
OFF RUN/OVERRIDE
M+G+A1 B+A1
RUN START
B+A1 B + S + A1
“MAKE”
L+A2
3
6
6
3
2
5
5
2
1
4
4
1
CHASSIS HARNESS CONNECTOR (MATING SIDE)
DASH HARNESS CONNECTOR (MATING SIDE)
3
WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.
NON-REMOVABLE CONNECTIONS
REMOVABLE CONNECTIONS
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 ELECTRICAL T02S 22
With 12V Outlet Option
33 30
79
103
21 87
59
34
With Service Minder Option
27 43 42
46
41
40
26
25
16
71
90
2
94 29
28
55
92 93
4
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 ELECTRICAL
KEY NO.
PART NO.
DESCRIPTION
1 2 8 16 21 22 25 26 27 28 29 30 33 34 40 41 42 43 55 71 79 87 90 92 93 94
163465 74760412 193228 176138 183759 4152J 412894 175158 73510400 198885 401545 193350 411935 110712X 401098 17720408 131563 192507 17060512 400449 175242 197802 400725 196615 192540 191834
Battery Bolt Hex Hd 1/4-20 unc x 3/4 Box Battery Switch Interlock Harness Socket Light Bulb, Light #1156 Cable Battery 6 Ga. BL/Red 14.5 Fuse Nut Keps Hex 1/4-20 unc Cable Ground 18" Rear Battery Blk 6 Ga. Switch Seat Switch Ign Key/Chain Switch Light/Reset Harness Ign Screw 1/4-20 unc x 1/2 Cover Terminal Red Solenoid Screw 5/16-18 x 3/4 Harness Ign. Chass. Socket Asm. Bulb Switch Interlock Clutch Cover Terminal Harness Pigtail Reverse Switch Screw Plastic 10-14 x 2.0 Modual Reverse ROS
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
5
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 CHASSIS 153 302 18 14
137
151
5 176
150
130
176
176
177 175
182 36
130 196
176
194
37
181
235
194
68
236
68 235 34
138
213 68 183
287
218
236 68
183
181
68
162
68
228 58 217 189
194
189
52 159
189 228 152
Chassis-tex_elite basic_5_r1
6
159
189
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 CHASSIS
KEY NO.
PART NO.
DESCRIPTION
5 14 18 34 36 37 52 58 68 130 137 138 150 151 152 153 159 162 175 176 177 180 181 182 183 189 194 196 213 217 218 228 235 236 287 302
197783X428 183393X421 183399X428 196125 17060512 414872X421 73680500 412280 17490508 416358 184921 193224X428 184461 407807 199535 183824X599 17000612 142432 193243 400776 195228 415063 193102X428 193057 74780520 17000512 73900500 414579 74760512 409167 196395 195161 406129 73930500 17600406 183823
Dash Hood Grille Plate Engine Screw 5/16-18 x 3/4 Fender Nut Lock 5/16-18 Drawbar Upper Screw Thdrol 5/16-18 x 1/2 Screw #10 x 0.750 Bumper Hood Cupholder Duct Heat Hood Bracket Pivot Shield Browning Lens Grille Screw Hexwsh Thdrol 3/8-16 x 3/4 Screw Hex Wsh Hi-Lo 1/4 x 1/2 Crossmember Screw 10-24 x 5/8 Wshd Qdrx Bushing Steering Chassis Bushing Mtg. Fender Crgo. Dash Lower Bolt Fin Hex 5/16-18 x 1-1/4 Screw 5/16-18 x 3/4 Nut Lock Hex Flange 5/16-18 Console Asm. Deck Lift Bolt 5/16-18 x 3/4 Rod Pivot Hood X-Piece Hood Step Stud Fastener Spacer Fender Nut Center Lock 5/16-18 Screw 1/4-20 x 3/8 Insert Lens Reflective
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
7
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 DRIVE
70
185
56
143 74 216
184 221
125 80
121
35
42
114
159
122
160
167 159
125
185 188
29
170
64
15
231
161
186 51
17
174
176
189
49
166
187
165 233
178
50 190
232
51
175 153 22 2
52
23 166
116
51 153 279 116
2
73
183 99
1
205 33
73
205
37
8
drive-tex_T2_fender_20
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 DRIVE
KEY NO.
PART NO.
1
------
2 15 17 22 23 29 33 35 37 42 49 50 51 52 56 64 70 73 74 80 99 114 116 121 122 125 143
DESCRIPTION
Transaxle, Hydro Gear T2-AABC-1X1A-1GX1 (See Transaxle Breakdown) 123583X Key Square 19131316 Washer 13/32 x 13/16 x 16 Ga. 197296 Spring, Brake 197660 Rod Shift 140845 Knob 423239 Rod, Brake 12000001 Ring E 197722 Rod, Brake, Park 121749X Washer 25/32 x 1-1/4 x 16 Ga. 8883R Cover, Foot Pedal 72110614 Bolt 194327 Pulley Idler Flat 73900600 Lock Nut 3/8-16 194326 Idler V-Groove 910" Offset 125907X V-Belt, Drive 196200 Shaft Asm. Pedal Brake Control 193220X428 Console 74490544 Bolt Hex 5/16-18 Gr. 5 142432 Screw 1/4 x 1/2 408393 Strap Torque 408418 Rod Spring Bypass 73800500 Nut Lock 5/16-18 unc 73900500 Nut Lock Hex Flange 5/16-18 175611 Bracket Strap Torque 72010520 Bolt 5/16-18 x 2.50 17000512 Screw 5/16-18 x 3/4 17490508 Screw 5/16-18 x 1/2
KEY NO.
PART NO.
DESCRIPTION
153 159 160 161 165 166 167 170 174 175 176 178 183 184 185 186 187 188 189 190 205 216 221 231 232 233 279
4497H 76020412 169484 105709X 196212 428305 405257 413430 197289 408539 196214 197456 156972 198403X505 72110622 194321 19133210 194323 194317 194318 121748X 196131 403187 407287 74780716 405296 424155
Retainer Spring 1" Pin Cotter 1/8 x 3/4 Retainer Clip Spring, Return, Clutch Bushing Nut Push .625 Latch Brake Parking Keeper V-Idler Nut Push Shaft Asm Shift Arm Clevis Rod Shift Spring Shift Spacer Axle Handle Parking Brake Bolt Spacer Retainer Washer Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Washer 25/32 x 1-5/8 x 16 Ga. Bracket Pulley Idler Retainer Spring Clip Handle Idler V-Groove 1.688" Offset Bolt 7/16-14 x 1 Gr 5 Washer Serrated Link Shift
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
9
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 ENGINE 1
21 45
20
79 84 82
18
81
15
69
2
12
37 42
28 29
85 90 9
OPTIONAL EQUIPMENT Spark Arrester
ENGINE TEX?"3?
10
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 ENGINE
KEY NO.
PART NO.
DESCRIPTION
1 2 9 12 15 18 20 21 28 29 37 42 45 69 79 81 82 84 85 90 96 97
-----137352 194319 401985 407545 425162 170545 416358 401137 137180 123487X 10040700 73510400 165291 192334 148456 428287 17060620 173937 17000616 19091416 17670412
Engine B&S Model No. 31P677-0804-B1 Muffler Keeper Belt Engine Pulley Engine Tank Fuel 1.50 Cap Fuel Control Throttle/Choke Screw #10 x 0.750 Fuel Line Spark Arrester Kit Clamp Hose Washer Lock 7/16 Nut Keps Hex 1/4-20 unc Gasket Screw Socket Hd 5/16-18 x .75 Tube Drain Oil Easy Valve Drain Oil Screw 3/8-16 x 1-1/4 Bolt Hex 7/16-20 x 4 x Gr. 5-1.5 Screw 3/8-16 x 1.0 Washer 9/32 x 7/8 x 16 Ga. Screw 1/4-20 x 3/4
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
Engine Power Rating Information The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J11940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J1995 (Revision 2002-5). Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual “on-site” or net horsepower). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine.
11
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 STEERING 26
72 33 45
1
20
71
21
13
16
63
28 22
64
60
28 57
9 8
66
7
67
2 59
9 8
63
19
7
57 6
35 58
67 6 4
61
5 14
15
8
14
69 68
13
62 70
15
13 53
steering-tex_STDHRR_5
12
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 STEERING
KEY NO.
PART NO.
DESCRIPTION
1 2 4 5 6 7 8 9 13 14 15 16 19 20 21 22 26 28 33 35 45 53 57 58 59 60 61 62 63 64 66 67 68 69 70 71 72
414851X421 195968 403087 403088 6266H 121748X 12000029 121232X 121749X 10040600 73540600 408220 194729 198375X428 186737 420537 414854X428 17000612 10040500 194732 19113812 188967 407465 194747 194748 73971000 194740 194741 17000512 199849 71020748 194737 73900700 199162 196197 196075 74780580
Wheel, Steering Axle Asm., Front Spindle Asm., LH Spindle Asm., RH Washer Thrust 0.75 x 1.23 Washer 25/32 x 1-5/8 x 16 Ga. Ring, Clip #T5304-75 Cap, Spindle Washer 25/32 x 1-1/4 x 16 Ga. Washer Lock 3/8 Nut, Crown Lock 3/8-24 unf Shaft Steering Plate Steering Boot, Steering Adapter, Wheel Steering Strg. Supt. Lower Insert, Wheel Steering Screw 3/8-16 x 3/4 Washer Lock 5/16 Gear, Sector Plate Washer 11/32 x 2-3/8 x 12 Ga. Washer Hardened .793 x 1.637 x .060 Bracket Upstop Bolt Shoulder Sector Pivot CFM Washer Thrust Sector Steering Nut Flange Lock 5/8-11 Draglink, LH Draglink, RH Screw 5/16-18 x 3/4 Retainer Clip Spring Steering Bolt Hex Fghd 7/16-14 x 3 Serr Bushing PM Front Axle Nut Lock Flange 7/16-14 Gr. 5 Washer 1.5 x .505 x .118 Bracket Deck Susp. Front Shaft Ext. Steering Bolt 5/16-18 x 5 Gr. 5
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
13
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 MOWER DECK 70
67 7
152
7
37
?$?MAN TEX?,4??R
14
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 MOWER DECK
KEY NO.
PART NO.
1 6 7 8 11
196495 195186 416358 193003 138971
--
139775
--
134149
--13 14 15 19 20 21 23 24 25 26 27 29 30 31 32 33 34 36 37 38 40 42 43 46 47 55
424752 422719 192872 187281 110485X 196539 159770 73680500 192557 105304X 197026 110452X 193108X428 131491 173984 187690 197473 400234 72110612 197379 19131316 199189 73900600 198410 197256 137729 197250 197249
DESCRIPTION Mower Housing Arm Suspension Screw #10 x 0.750 BOS Thread Bolt/Washer Asm 7/16-20 unf Blade, 42" Hi-Lift (For bagging or discharge) Blade, 42" Mulching Premium (For better wear when mulching) Blade, 42" Mulching Std (For mulching mowers only) Blade 42SP" 3N1 Blade 42SP" Premium Shaft Assembly, Mandrel Housing, Mandrel Bearing, Ball, Mandrel Bolt, Shoulder Baffle, Vortex Nut, Crownlock 5/16-18 unc Bracket, Deflector Cap, Sleeve Spring, Torsion, Deflector Nut, Push Shield, Deflector Rod, Hinge Screw Thdrol Rolling Wsh Hd Washer, Spacer Pulley, Mandrel Nut, Toplock, Flanged Bolt Carr Sh. 3/8-16 x 1-1/2 Gr. 5 Pulley, Idler 4.50 RAW Washer 13/32 x 13/16 x 16 Ga. Keeper Belt LH Mandrel Nut, Lock Flg. 3/8-16 unc Spring Torsion Brake Spring Torsion Retainer Screw Thd Roll 1/4-20 x 5/8 Bracket Clutch Cable Arm, Idler
KEY NO.
PART NO.
56 57 59 60 62 63 64 67 68 69 70 113 116 117 118 119 122 123 144 145 147 152 188 189 192 195 208 --
199092 17000616 141043 197261 72110616 199477 199790 198398X421 429636 72140505 198332 17000510 4898H 188606 73930600 19121414 197258 197259 199204 193197 401971 408714 195161 73900500 197260 17000612 17670608 192870
--
199608
DESCRIPTION Spacer, Retainer Screw Hexwsh Thd 3/8-16 x 1 Guard, Tuv Idler (94) Arm Brake Mower Bolt Rdhd Sqnk 3/8-16 unc x 2 Arm Brake Mower Linkage Brake Handle, Clutch Cable V-Belt Bolt Rdhd Sqnk 5/16-18 x 5/8 Clutch Asm. Manual Screw 5/16-18 Bolt Shoulder "A" 2.41 "B" 1.66 Wheel Gage Nut Centerlock 3/8-16 unc Washer 3/8 x 7/8 x 14 Ga. Keeper Belt Eng. LH Keeper Belt Eng. RH Keeper Belt Pulley Idler Primary Spring Return Cable Clutch Manual w/Spr. Stud Fastener Nut Lock Hex Flange Bracket Brake Stand LH Screw Hexwsh Thdr 3/8-16 x 3/4 Screw THDROL 3/8-16 x 1/2 Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/washer and blade bolt/washers not included) Replacement Mower, Complete
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
15
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 MOWER LIFT 87
7
87
90
98
89
10 3 97
100 2
88
97
91
101*
89
lift-tex_22
87
*Key 91 may be substituted for Key 101
KEY NO.
PART NO.
DESCRIPTION
2 3 7 10 87 88 89 90
422027 195231 196492X428 196314 194209 410710 19191912 194208
Shaft Asm., Cross Lift Lever Asm., Lift RH Grip, Lever Spring Torsion Pin Cotter 7/16 Bow Tie Lock Spring Lift Assist Washer Clear Zinc Pin Cotter 5/16 Bow Tie Lock
KEY NO.
PART NO.
DESCRIPTION
91 97 98 100 101
195181 17000612 195270 73930600 407003
Link Lift Susp Mower Rear Screw 3/8-16 x .75 Smgml Tap/R.Z Link Lift Susp. Front Mower Nut Centerlock 3/8 -16 unc Link Asm. Lift Fixed
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
16
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 SEAT
1
8 8 7 7
8 41
8
40
10
6
21
37 37
44 2
43
21
3 seat-tex_6.5SL_2
KEY NO.
PART NO.
DESCRIPTION
1 2 3 6 7 8 10 21
197514 180166 140675 73800600 124181X 171877 196977 171852
Seat Bracket Pivot Fender Strap, Asm Fender Nut, Lock w/Ins. 3/8-16 unc Spring, Seat Cprsn Bolt 5/16-18 unc x 3/4 w/Sems Pan, Seat Bolt, Shoulder 5/16-18
KEY NO.
PART NO.
DESCRIPTION
37 40 41 43 44
73800500 197661 198200 74760612 19133812
Nut, Lock 5/16-18 unc Handle Slide Spring Latch Bolt 3/8-16 unc x 3/4 Washer 13/32 x 2 3/8 x 12 Ga.
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
17
REPAIR PARTS
TRACTOR - - MODEL NUMBER PB195H42LT (96042010700), PRODUCT NO. 960 42 01-07 7
11
9
3
4
4
3
20
8
6
12
12
2
14
KEY NO. 2 3 4 6 7 8 9 11 12
PART NO. 408834 430113 430335 170563 411629 411658 430112 430111 430255
DESCRIPTION Decal Eng. H.P. Decal Hood Decal Side Panel Logo Decal Warning, Keep Hand Away Decal Replacement Parts Decal Fender Warn S/F Decal Fender Logo Decal Ins Strg Whl Decal Fend SD
WHEELS AND TIRES 1 2
11 3 4 7
10 5
6
9 8
KEY NO. 14 20 -------
PART NO. 160396 145005 166960 193226X428 193227X428 430094 430479 430095
KEY NO. 1 2 3 4 5 6 7 8 9 10 11 --
PART NO. DESCRIPTION 59192 Cap Valve Tire 65139 Stem Valve 106732 Rim Asm 6" Front 59904 Tube Front (Service Item Only) 106222X Tire F T 15 x 6 0 - 6 278H Fitting Grease (Front Wheel Only) 9040H Bearing Flange (Front Wheel nly) 104757X428 Cap Axle Blk 1 50 x 1 00 420531 Tire R T 18 x 9.5-8C Turf Saver LT 7152J Tube Rear (Service Item Only) 106108X Rim Asm 8" Rear Service 144334 Sealant, Tire (10 oz. Tube)
DESCRIPTION Decal V-Belt Schematic Decal Bat Dan/Psn Decal Bypass Pad Footrest LH Pad Footrest RH Manual Operator's (English/French) Manual Operator's (Spanish) Manual Parts (English/French)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
wheel_art_1-tex
18
