Maf18mn1

Transcript

WASHER Repair Parts List MODEL NUMBER MAF18MN1 When requesting service or ordering parts, always provide the following information: ©2005 Maytag Services - Product Type - Part Number - Model Number - Part Description Section: MAIN EXPLODED VIEW - FINAL ASSEMBLY Model: MAF18MN1 721132 1 Section: MAIN EXPLODED VIEW - FINAL ASSEMBLY No. 1 2 Part No. Description 24001169 24001676 24001300 PANEL KIT, VALVE HINGE, TOP COVER Note: (NOTE: 18003069 AFTER SERIAL NUMBER) HINGE (TAKE APART) Note: (PREV. PART #602784 NOTE: USE 18003070 BEFORE SERIAL NUMBER) SCREW (8-18 X 3/8") SCREW (1/4-20 X 1/2") KIT, PANEL (REAR) PANEL KIT, SIDE (RT.)18 Note: (AS VIEWED FROM FRONT) PANEL, FRONT (INR) TRIM, PANEL (INNER FRONT) DECAL, CYCLE INDICATOR GLASS, TIMER LIGHT, INDICATOR (RED 110V) LIGHT, INDOCATOR (AMBER 110V) DECAL, MAYTAG RIVET, POP S.S. (1/8" X 1/4") PANEL, CONTROL (ALUM) PANEL KIT, SIDE (LT.)18 Note: (AS VIEWED FROM THE FRONT) BRACKET, SOAP DISPENSER RIVET, BLIND S.S. (1/8 X 5/16) NOT REQUIRED PART OR SEE NOTE Note: PART NUMBER NOT AVAILABLE NAMEPLATE NUT, S.S. (1/4"-20) LOCKWASHER COVER, SOAP DSPNSR CLAMP, SOAP DISPENSER COVER ASSY KIT, TOP Note: KIT ASSY., TOP COVER LOCK, TOP COVER LATCH, TOP COVER BRACE, TOP CAPACITOR (100MF) SCREW (1/4-20 X 1-1/4") BRACKET, CAPACITOR NUT, FIBERLOCK (1/4) NUT, FIBERLOCK, PLTD (6-32) NOT REQUIRED PART OR SEE NOTE Note: PART NUMBER NOT AVAILABLE 3 24001301 4 24001323 5 24001400 6 24001162 7 24001677 8 24001550 9 24001679 10 24001680 11 24001681 12 24001682 13 24001683 14 24001533 15 N 24001686 16 N 24001155 17 24001539 18 24001540 19 -----20 24001671 21 24001510 22 24001295 23 24001219 24 24001542 25 24001168 26 24001220 27 24001221 28 24001695 29 24001236 30 24001303 31 24001692 32 24001305 33 24001425 34 ------ *Color Code (-)=Not Shown Series Qty #=Series, Serial Prefix or Run No., N=Not Available 2 1 2 2 24 8 1 1 1 2 1 1 1 1 1 6 1 1 2 4 1 1 3 3 1 1 1 1 1 1 1 8 1 17 1 1 Section: DOOR AND RELATED PARTS Model: MAF18MN1 721137 3 Section: DOOR AND RELATED PARTS No. Part No. - N 24001639 1 24001718 2 24001075 3 24001098 4 24001333 5 24001334 6 -----7 24001341 8 24001305 9 24001467 10 24001103 11 24001336 12 24001721 13 24001338 14 24001310 15 24001340 16 24001343 17 24001342 18 24001728 18 N 24001145 18 24001133 18 N 24001727 19 24001474 20 24001722 21 24001827 23 24001462 24 24001407 Description Series Qty DOOR ASSY. (OPL) DOOR GASKET, DOOR GLASS, DOOR HINGE, DOOR MOUNT, DOOR NOT REQUIRED PART OR SEE NOTE Note: PART NUMBER NOT AVAILABLE SCREW (8-32X 5/8") NUT, FIBERLOCK (1/4) SCREW, S.S. (1/4 - 20 X 7/8) ROD, PUSH BUTTON HANDLE, DOOR PIN, SPRING SPRING, DOOR LOCK SCREW (5/16-18 X 5/8") SPACER, DOOR HANDLE ARM, LATCH NUT, LOCK (8-32) OUTER PANEL KIT (COIN ALM) Note: KIT, OTR. PNL COIN (ALM) PANEL KIT, FRONT OPL Note: KIT, PNL, FRT OPL (STLS.) PANEL KIT, FRONT COIN Note: KIT, PNL, FRT COIN (STLS.) OUTER PANEL KIT (COIN SS COR) Note: KIT, OTR. PNL COIN (SS COR) SCREW, S.S. (#8-32 X 3/8 PL) TRIM, OUTER FRONT PANEL PIN, SPRING (STLS) DECAL, PUSH BUTTON RED DECAL *Color Code (-)=Not Shown #=Series, Serial Prefix or Run No., N=Not Available 4 1 1 1 1 1 2 1 3 8 4 1 1 1 1 1 1 1 3 1 1 1 1 4 1 1 1 1 Section: DOOR SAFETY INTERLOCK-OPL MODELS Model: MAF18MN1 721296 5 Section: DOOR SAFETY INTERLOCK-OPL MODELS No. Part No. 1 24001476 2 24001229 3 24001477 4 N 24001478 5 24001479 6 24001305 7 24001230 8 24001480 9 24001293 10 24001342 11 24001481 12 24001295 13 24001323 14 24001642 15 24001483 16 24001484 17 24001485 18 24001101 19 24001358 20 24001486 22 24001487 23 24001301 24 24001488 Description Series Qty NUT, FIBERLOCK (#4-40) SWITCH, DOOR LOCK SPACER, NYLON (#6) PLATE, DOOR LOCK SCREW, S.S. (#8-32 X 3/16) NUT, FIBERLOCK (1/4) LEVER, DOOR LOCK WASHER, TEFLON (#8) SPRING, TORSION NUT, LOCK (8-32) NUT, FIBERLOCK PLTD (#10-32) LOCKWASHER SCREW (1/4-20 X 1/2") SCREW, S.S. (1/4-20 X 1 1/2") CATCH, DOOR LOCK COVER, DOOR LOCK PLATE WASHER, SHOULDER (TEFLON) SOLENOID, DOOR REL (110/220V) WASHER, FLAT (#10) STOP, PUSH BUTTON COVER, DOOR LOCK ASSY. SCREW (8-18 X 3/8") SHIELD, SPLASH (DOOR LOCK) *Color Code (-)=Not Shown 1 1 4 1 2 2 1 3 1 2 1 4 2 2 1 1 1 1 1 1 1 2 1 #=Series, Serial Prefix or Run No., N=Not Available 6 Section: CONTROL MODULE Model: MAF18MN1 721155 7 Section: CONTROL MODULE No. Part No. Description 3 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 27 28 29 30 31 32 34 35 24001105 24001738 24001737 24001222 24001412 24001414 24001030 ----------24001357 24001358 24001740 24001741 24001417 24001415 24001026 24001027 24001028 24001029 24001411 24001178 24001577 -----24001578 24001247 24001742 24001248 24001580 24001579 24001176 24001295 24001419 24001744 24001254 CONTACTOR (120V) RELAY RELAY SWITCH, TRI LEVEL----N TERMINAL STRIP SCREW, S.S. (#6-32 X 1/2 PLTD) DECAL,INSUL.TERM STIRP (33-40) NOT REQUIRED PART OR SEE NOTE Note: PART NUMBER NOT AVAILABLE NOT REQUIRED PART OR SEE NOTE Note: PART NUMBER NOT AVAILABLE SCREW WASHER, FLAT (#10) SWITCH, CYCLE SELECTOR NUT, FIBERLOCK NUT, BRASS (#6-32) WASHER, S.S. (#6 EXT. TOOTH) DECAL,INSUL. TERM STRIP (1-8) DECAL,INSUL.TERM STRIP (9-16) DECAL,INSUL.TERM STRIP (17-24) DECAL,INSUL.TERM STRIP (25-32) SCREW, S.S. (6-32 X 3/8 PLTD) CYCLE KIT, TIMER (120V) MOTOR, TIMER (110V 60HZ) NOT REQUIRED PART OR SEE NOTE Note: PART NUMBER NOT AVAILABLE SCREW, S.S. (6-32 X 1/4") CAPACITOR, DOOR LOCK P.C. BOARD (110V) PC BOARD, DOOR LOCK SCREW, S.S. (#10-32 X 3/8") WASHER, S.S. (#10 LOCK EXT.) RELAY, TIME OFF DELAY LOCKWASHER NUT, PLTD (1/4-#20 HEX) BOOT, PUSH BUTTON SWITCH, MOMENTARY N N N N N N *Color Code (-)=Not Shown Series Qty #=Series, Serial Prefix or Run No., N=Not Available 8 1 1 1 1 5 10 1 0 0 3 5 1 1 10 10 1 1 1 1 1 1 2 0 2 1 1 1 2 2 1 1 1 1 1 Section: WATER VALVE Model: MAF18MN1 721357 9 Section: WATER VALVE No. Part No. Description 1 3 4 5 5 24001118 24001232 24001776 24001226 24001634 24001122 24001231 6 24001232 VALVE (3WAY 110-127V/50-60HZ) COIL, WATER VALVE VALVE, WATER (2 WAY) VALVE, MIXING (3 WAY) SCREEN, VALVE KIT, VALVE REPAIR (13MM) Note: KIT, REPAIR (13MM) KIT, DIAPHRAM (SHORT) Note: KIT, REPAIR (10MM) MODELS ONLY) COIL, WATER VALVE *Color Code (-)=Not Shown Series Qty (FOR USE IN MIXING VALVE #=Series, Serial Prefix or Run No., N=Not Available 10 1 1 1 1 2 2 2 1 Section: MAIN EXPLODED VIEW-SUB ASSEMBLY Model: MAF18MN1 721129 11 Section: MAIN EXPLODED VIEW-SUB ASSEMBLY No. Part No. Description 1 2 3 4 5 6 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 24001369 24001511 24001512 24001647 24001021 24001082 24001078 24001648 24001651 24001650 24001086 24001502 24001826 24001093 24001501 24001500 24001499 24001085 24001015 24001515 24001283 24001662 24001258 24001014 24001019 24001661 24001438 24001803 24001375 24001184 24001388 24001215 24001215 24001215 24001266 24001384 24001657 24001516 24001353 24001660 24001116 24001565 24001805 24001659 24001808 24001258 24001515 24001130 KIT ASSY., FRAME (2 SPEED) WASHER, HARDENED (PLTD. 5/8) PIN, COTTER PLTD. (1/8X1 1/2) ROD, MOTOR SUPPORT BUSHING, MOTOR (UC/UW) MOTOR,2SP (208/240/60/3) MOTOR,2SP (120/60/1/) KEY (MOTOR 3/16" X 1 1/2") CLIP, MOTOR SPRING SPRING (BELT TENSION) PULLEY, MOTOR SCREW (1/4"-20 X 3/4") CONNECTION, TEE-DRAIN BELT, V (3V-710) WASHER, S.S. SCREW, S.S. (3/8"-16X1) KEY (3/8" X 1 1/4") PULLEY, BASKET Note: (NOTE..18000456 BEFORE SERIAL NUMBER) BEARING (6207 2RS C3) NUT, FIBERLOCK PLTD. (3/8-16) CLAMP, HOSE (#28) HOSE, OVERFLOW KIT, TRUNNION (2SP.) BEARING (6208 2RS C3) SEAL, SHAFT (SS SPR60X80X10MM) AIR TRAP Note: HOSE, AIR DOME CLAMP, HOSE (#10) SHIM, SHELL KIT, SHIELD RETRO Note: KIT, SHIELD RETRO GASKET KIT (FRONT SHELL) KIT, BAND SHELL KIT, BAND FASTENER KIT, BAND FASTENER KIT, BAND FASTENER BASKET (18-2 SPEED) KIT, FRONT SHELL BOLT (S.S. 3/8-16 X 1 1/2") WASHER, FLAT PLTD. (3/8") CLAMP, HOSE (#40) HOSE, DRAIN (REAR) VALVE, DRAIN (2" 110V,60HZ) HOSE, DRAIN (FRONT) TRIM, FRONT PANEL BOLT (S.S. 1/2"-13 X2) WASHER, S.S. KIT, TRUNNION (2SP.) NUT, FIBERLOCK PLTD. (3/8-16) SLEEVE, SFT (2SP) *Color Code (-)=Not Shown Series Qty #=Series, Serial Prefix or Run No., N=Not Available 12 1 2 2 1 2 1 1 1 1 1 1 4 1 1 2 1 1 1 1 6 2 1 1 1 2 1 1 3 1 1 1 1 3 7 1 1 2 4 4 1 1 1 1 6 3 1 2 1 Section: MOTOR Model: MAF18MN1 721140 13 Section: MOTOR No. 1 1 2 3 Part No. Description 24001082 24001078 24001018 ------ MOTOR,2SP (208/240/60/3) MOTOR,2SP (120/60/1/) BEARING, 6204-2RS NOT REQUIRED PART OR SEE NOTE Note: PART NOT USED *Color Code (-)=Not Shown Series Qty #=Series, Serial Prefix or Run No., N=Not Available 14 1 1 1 0 Section: SOAP DISPENSER Model: MAF18MN1 721143 15 Section: SOAP DISPENSER No. Part No. 1 24001627 2 24001031 3 24001032 4 24001117 5 24001118 6 24001765 7 24001766 8 24001433 9 24001225 10 24001432 11 24001301 12 24001629 13 24001430 14 24001429 15 24001436 16 24001434 17 24001342 18 24001767 19 24001768 20 24001769 21 24001770 22 24001771 23 24001772 24 24001773 25 N 24001774 26 24001432 27 24001426 28 24001552 29 24001442 30 24001353 31 24001282 32 24001423 33 24001357 34 24001414 35 24001425 36 24001424 37 24001775 Description Series Qty DISPENSER, SUPPLY (COIN) BREAKER, VAC. (TOP) BREAKER, VAC. (BTM) VALVE (2WAY 110-127V/50-60HZ) VALVE (3WAY 110-127V/50-60HZ) MANIFOLD, SUPPLY MANIFOLD, FILL HOLDER, FUSE FUSE, CONTROL (2AMP) SCREW, S.S. (#8-32 X 3/8) SCREW (8-18 X 3/8") BLOCK, INPUT POWER (3 WIRE) SCREW, S.S (6-32 X 1) COVER, JUNCTION BOX GROMMET, BUSHING CONNECTOR, GROUND NUT, LOCK (8-32) HOSE HOSE HOSE HOSE HOSE HOSE HOSE HOSE SCREW, S.S. (#8-32 X 3/8) COVER, VACUUM BREAKER HOSE, VACUUM BREAKER HOSE, SOAP DISPENSER CLAMP, HOSE (#40) CLAMP, HOSE (#48) CLAMP, HOSE (#8) SCREW SCREW, S.S. (#6-32 X 1/2 PLTD) NUT, FIBERLOCK, PLTD (6-32) CAP, PLUG (YELLOW) FLOW RESTRICTOR ASSY. *Color Code (-)=Not Shown 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 2 1 1 1 3 1 5 1 1 1 3 1 23 4 4 6 1 1 #=Series, Serial Prefix or Run No., N=Not Available 16 Section: DRAIN VALVE Model: MAF18MN1 CW21-131 17 Section: DRAIN VALVE No. 1 1 2 3 4 5 6 Part No. Description 24001116 24001217 24001530 24001528 24001826 24001565 24001502 24001353 VALVE, DRAIN (2" 110V,60HZ) Note: (B)VALVE, DRAIN VALVE, DRAIN (3") Note: (A)VALVE, DRAIN VALVE, MOTOR DRAIN (110V 60HZ) Note: (A)MOTOR, DRAIN VALVE MAIN DRIVE SHAFT AND SEAL KIT CONNECTION, TEE-DRAIN Note: CONNECTION, TEE HOSE, DRAIN (FRONT) Note: HOSE, DRAIN (FRT) SCREW (1/4"-20 X 3/4") CLAMP, HOSE (#40) *Color Code (-)=Not Shown Series Qty #=Series, Serial Prefix or Run No., N=Not Available 18 1 1 1 1 1 1 4 4