Manual 18434864

Transcript

Service AG. Volkswagen AG d agen oes ksw not l o gu yV b ara d e nte is r o eo h ut ra a c s s Workshop Manual rrectness of i t to the co nf o r m spec atio h re n in wit es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ility ab y li an pt ce Golf Variant 2007 ➤ Golf Variant 2010 ➤ Jetta 2005 ➤ Jetta 2011 ➤ Communication Edition 04.2010 thi sd o cu m en ht rig py Co t. agen lksw Vo by AG. Prote cted by c o py rig ht . C op yi Service Department. Technical Information Service List of Workshop Manual Repair GroupsList of Workshop Manual Repair GroupsList of Workshop Manual Repair Groups ility ab y li an pt ce rrectness of i t to the co nf o r m spec atio h re n in wit es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng 91 - Radio, telephone, navigation AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s thi sd o cu m en ht rig py Co t. Repair Group agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Technical information should always be available to the foremen and mechanics, because their careful and constant adherence to the instructions is essential to ensure vehicle road-worthiness and safety. In addition, the normal basic safety precautions for working on motor vehicles must, as a matter of course, be observed. All rights reserved. No reproduction without prior agreement from publisher. Copyright © 2010 Volkswagen AG, Wolfsburg D3E801B0E3A Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ AG. VolkswagenCommunication - Edition 04.2010 AG do agen es n ot g ua ran tee or ac w olks yV b ed ris ho t au Contents es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ility ab y li an pt ce ss 91 - Radio, telephone, navigation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . rrectness of i t to the co nf o r m spec atio h re n in wit Communication systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fault finding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio “Lowentry” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing radio “Lowentry” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “Lowentry” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio R components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio “Premium 7” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing radio “Premium 7” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “Premium 7” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio R components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio “Premium 8” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing radio “Premium 8” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “Premium 8” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Activating and deactivating transport protection device . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio R components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio system “RCD 210” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing radio “RCD 210” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “RCD 210” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio R components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio system “RCD 300” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing radio “RCD 300” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “RCD 300” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio R components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio system “RCD 310” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing radio “RCD 310” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “RCD 310” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio components “RCD 310” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio system “RCD 500” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing radio “RCD 500” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “RCD 500” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Activating and deactivating transport protection device . . . . . . . . . . . . . . . . . . . . . . . . . . . . thi sd o cu m en ht rig py Co t. agen lksw Vo by AG. Prote cted by c o py rig ht . C op yi 1 1.1 2 2.1 2.2 2.3 2.4 2.5 2.6 3 3.1 3.2 3.3 3.4 3.5 3.6 4 4.1 4.2 4.3 4.4 4.5 4.6 4.7 5 5.1 5.2 5.3 5.4 5.5 5.6 6 6.1 6.2 6.3 6.4 6.5 6.6 7 7.1 7.2 7.3 7.4 7.5 7.6 8 8.1 8.2 8.3 8.4 8.5 Contents 1 1 1 2 2 3 4 7 8 10 11 11 12 13 16 18 19 21 21 22 23 26 28 29 30 31 31 32 33 36 37 39 40 40 41 42 45 46 48 49 49 50 51 54 56 57 59 59 60 61 64 65 i Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 un le r fo ng agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Contents ht rig py Co t. ii rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio components “RCD 500” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio system “RCD 510” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing radio “RCD 510” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . “RCD 510” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Activating and deactivating transport protection device . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio components “RCD 510” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . CD changer R41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . CD changer R41 connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing CD changer R41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iPod holder R192 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . ..V.o.lk.sw . .ag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . en AG ag. e.n. . . . . . . . . . .A.G. d.o.es. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . w Fault finding . s k not l o V by of iPod holder R192 . . . . . . . g.ua. r. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview d an e tee ris Removing and installing adapter for iPod holder ............................ tho oR192 u ra a c s Removing and installing iPod holder R192 . . . . . . . . . ........................... s iPod holder R192 connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fault finding procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . USB connection retainer R193 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing USB connection retainer R193 . . . . . . . . . . . . . . . . . . . . . . . . . . USB connection retainer R193 connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fault finding procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Connection for external audio sources R199 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Connector for connection for external audio sources R199 . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing connection for external audio sources R199 . . . . . . . . . . . . . . . . Multimedia control unit J650 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of multimedia control unit J650 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing multimedia system control unit J650 . . . . . . . . . . . . . . . . . . . . . . Coding multimedia control unit J650 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Multimedia control unit J650 final control diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Amplifier R12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing amplifier R12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Amplifier R12 connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Reading amplifier R12 measured values . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Loudspeaker systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of loudspeaker systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing front bass loudspeakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing rear bass loudspeakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing front mid-range loudspeakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing front treble loudspeakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing rear treble loudspeakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing frequency switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Satellite radio R146 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing satellite radio R146 (saloon) . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing satellite radio R146 (Variant) . . . . . . . . . . . . . . . . . . . . . . . . . . . . Satellite radio R146 connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ility ab y li an pt ce 8.6 8.7 9 9.1 9.2 9.3 9.4 9.5 9.6 9.7 10 10.1 10.2 10.3 11 11.1 11.2 11.3 11.4 11.5 11.6 11.7 12 12.1 12.2 12.3 12.4 13 13.1 13.2 14 14.1 14.2 14.3 14.4 14.5 15 15.1 15.2 15.3 15.4 16 16.1 16.2 16.3 16.4 16.5 16.6 16.7 17 17.1 17.2 17.3 17.4 66 67 69 69 70 71 74 76 77 78 79 79 79 79 82 82 82 83 83 84 85 85 86 86 88 89 89 91 92 92 95 95 96 96 98 98 100 100 100 101 105 106 106 110 111 112 113 114 115 117 117 117 118 119 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ rrectness of i t to the co nform spec at i h re o n wit in t his do c um en ht rig py Co t. agen lksw Vo by AG. Prote cted by 18.1 18.2 18.3 18.4 18.5 18.6 19 19.1 19.2 19.3 19.4 19.5 19.6 20 20.1 20.2 20.3 20.4 20.5 20.6 21 21.1 21.2 21.3 21.4 21.5 21.6 22 22.1 22.2 22.3 22.4 22.5 22.6 23 23.1 23.2 23.3 23.4 23.5 23.6 24 24.1 24.2 24.3 24.4 24.5 24.6 25 25.1 25.2 25.3 ... ... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio navigation system “RNS 300” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing control unit with display for radio and navigation J503 . . . . . . . . “RNS 300” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio components “RNS 300” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio navigation system “RNS 310” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing control unit with display for radio and navigation J503 . . . . . . . . “RNS 310” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio components “RNS 310” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio navigation system “RNS 315” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing control unit with display for radio and navigation J503 . . . . . . . . “RNS 315” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio components “RNS 315” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio-navigation system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing control unit with display for radio and navigation J503 . . . . . . . . Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting components “RNS MFD 2 DVD” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...................................................................... General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of radio navigation system “RNS 510” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing control unit with display for radio and navigation J503 . . . . . . . . “RNS 510” connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic anti-theft coding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adapting radio components “RNS 510” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Aerial systems (saloon) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of aerial system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing aerial modules on rear window . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing satellite tuner aerial R172 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing frequency modulation (FM) frequency filter . . . . . . . . . . . . . . . . . . Renewing aerial wires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Aerial systems (Variant) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of aerial system up to MY2009 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of aerial system as of MY2010 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing aerial amplifier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing roof aerial . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Renewal of aerial wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Aerial systems (saloon) model year 2011 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Assembly overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing aerial amplifier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ility ab y li an pt ce es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n n AG. Volkswagen AG do Communication - Edition 04.2010 es n wage s k l ot g o yV u b ara ed ris 17.5 Activating satellite radio R146 . . . .nt.ee. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ho t or au . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .a.c . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ss 18 Contents 119 121 121 122 123 126 127 129 130 130 131 132 135 137 138 140 140 141 142 145 147 148 150 150 151 152 155 158 159 161 161 162 163 166 169 170 171 171 172 173 176 177 178 179 179 180 181 181 182 183 184 184 185 185 iii c o p yri gh t . C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi Contents rrectness of i t to the co nf o r m spec atio h re n in wit iv thi sd o cu m en 26.11 26.12 26.13 27 27.1 27.2 27.3 27.4 27.5 28 28.1 28.2 28.3 28.4 29 29.1 30 30.1 30.2 30.3 30.4 ht rig py Co t. 26.10 Removing and installing roof aerial . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Renewal of aerial wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Telephone systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of telephone system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of “UHV Low”/“UHV Premium Light” telephone system . . . . . . . . . . . . . . . . . . . . Mobile telephone operating electronics control unit J412 connectors . . . . . . . . . . . . . . . . AG. Volkswagen AG d gen(UHV) a Telephone transmitter and receiver unit R36 connectorsoes .no. . . . . . . . . . . . . . . . . . . w ks t Vol y b Telephone fitting locations . . . e.d. . . . . . . . . . . . . . . . . . . . . . . . . . . g. u.a.ra. . . . . . . . . . . . . . . . n ir s Removing and installing telephone bracket R126 up to 06/2006 . . . . . .te.e .o . . . . . . . . . . . . tho u r a Removing and installing telephone bracket R126 as of 06/2006 . . . . . . . . .ac. . . . . . . . . . . ss Removing and installing mobile telephone operating electronics control unit J412 up to 06/2006 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing mobile telephone operating electronics control unit J412 as of 06/2006 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing telephone microphone R38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing operating unit for preparation for mobile telephone E508 . . . . . . Adapting telephone transmitter and receiver unit R36 components . . . . . . . . . . . . . . . . . . Multifunction steering wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing steering wheel operating unit up to model year 2009 . . . . . . . . . . Removing and installing steering wheel operating unit up to model year 2010 . . . . . . . . . . Removing and installing multifunction steering wheel control unit J453 up to MY2009 . . . . Adapting multifunction steering wheel components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Compass system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Removing and installing magnetic field sender for compass G197 (saloon) . . . . . . . . . . . . Removing and installing magnetic field sender for compass G197 (Variant) . . . . . . . . . . . . Removing and installing magnetic field sender for compass G197 (Jetta 2011) . . . . . . . . Suppression measures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Implementation of suppression measures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Notes on operating mobile telephones and two-way radios . . . . . . . . . . . . . . . . . . . . . . . . General notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Notes on performing repair work . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Overview of battery A /radio transmitter unit/fuse/wiring harness . . . . . . . . . . . . . . . . . . . . Transmitting power and aerial fitting locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ility ab y li an pt ce 25.4 25.5 26 26.1 26.2 26.3 26.4 26.5 26.6 26.7 26.8 26.9 186 187 188 188 188 190 191 191 193 194 194 195 196 197 197 198 199 199 199 200 201 202 203 203 203 204 205 207 207 208 208 208 210 210 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 91 – Radio, telephone, navigation 1 Communication systems The communication systems include the radio systems, the nav‐ igation system, the aerial system, the loudspeaker systems, the digital sound package, the telephone system, the CD changer, the compass system and the multifunction steering wheel. Some equipment is optional so not all systems are installed in every vehicle. When dealing with complaints, it is absolutely necessary to un‐ derstand the functions and the operation of the communication systems ⇒ Instruction manual . In the event of repair work or fault finding ⇒ Vehicle diagnosis, testing and information system VAS 5051 use “Guided fault find‐ ing” mode. 1.1 Fault finding The communication systems are self-diagnosing. For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. rrectness of i t to the co nf o r m spec atio h re n in wit es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ility ab y li an pt ce AG. Volkswagen AG d agen oes ksw not l o V gu y b ara d nte ise r o eo h t u ra a c s s thi sd o cu m en ht rig py Co t. agen lksw Vo by 1. Communication systems 1 AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 2 Radio “Lowentry” Radio Lowentry Note ♦ When dealing with complaints, it is absolutely necessary to understand the functions and the operation of the communi‐ cation systems ⇒ Instruction manual . ♦ The anti-theft coding system uses a fixed code. Deactivating ⇒ page 9 . ♦ In the event of repair work or fault finding ⇒ Vehicle diagnosis, testing and information system VAS 5051. ♦ When the battery -A- is reconnected, please remember to check vehicle equipment (radio, clock, convenience electron‐ ics, etc.) in accordance with the ⇒ Electrical system; Rep. Gr. 27 workshop manual and/or the ⇒ owner's manual . 2.1 General description The “Lowentry” radio system consists of the radio -R- and the loudspeakers in the doors. AG. Volkswagen AG d agen oes w The radio -R- has a final output stage with an output olks power of 4 yV b x 20 W. ed is or es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ility ab y li an pt ce th The loudspeakers are designed as a 3-way system in the front au s s and as a 2-way system in the rear. not gu ara nte eo ra c The following is installed in the “Lowentry” radio system: rrectness of i t to the co nf o r m spec atio h re n in wit ♦ A bass loudspeaker, a mid-range loudspeaker and a treble loudspeaker in each of the front doors. ♦ A bass loudspeaker and a treble loudspeaker in each of the rear doors. The CD drive integrated in the radio -R- can play the following formats: ♦ Audio CD ♦ CD-R ♦ CD-RW ♦ MP3 The following formats cannot be played: ♦ “Mixed CD” (CD with data and audio files) Prote cted by For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. 2 Rep. Gr.91 - Radio, telephone, navigation AG. The radio -R- is equipped with self-diagnosis. agen lksw Vo by Fault finding c o p yri gh t . C op yi 2.1.1 ht rig py Co t. The aerial is a window aerial and is located in the rear window (saloon). In the Variant, the aerial is located in the roof aerial. thi sd o cu m en ♦ CD with diameter of 8 cm Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 2.2 Overview of radio “Lowentry” 1 - Radio -R❑ Connectors ⇒ page 7 ❑ Removing and installing ⇒ page 4 2 - Aerial -R11❑ Aerial systems (saloon) ⇒ page 171 ❑ Aerial systems (Variant) ⇒ page 179 3 - Rear left treble loudspeaker -R14- / rear right treble loud‐ speaker -R16❑ Installed in the rear left and right door trims ❑ Loudspeaker systems ⇒ page 106 AG. Volkswagen AG d agen oes ksw not l o V gu y b ara d nte ise r o eo h t u ra a c s s 6 - Front left mid-range loud‐ speaker -R103- / front right mid-range loudspeaker -R104❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 ht rig py Co t. r fo ng 7 - Front left treble loudspeaker -R20- / front right treble loudspeaker -R22❑ Installed in mirror triangle of the right and left front doors ❑ Loudspeaker systems ⇒ page 106 rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce 5 - Front left bass loudspeaker -R21- / front right bass loud‐ speaker -R23❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 un le 4 - Rear left bass loudspeaker -R15- / rear right bass loud‐ speaker -R17❑ Installed in the rear left and right door trims ❑ Loudspeaker systems ⇒ page 106 2. 3 agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition e04.2010 n AG. Volkswagen AG does not gu ara nte eo ra c Removing and installing radio “Lowen‐ try”s Note ♦ The part number for the radio -R- can be found on a sticker on the radio -R- housing. ♦ If the radio -R- has to be renewed, deactivate the anti-theft coding system ⇒ page 9 . The new code number should be given to the customer. ♦ If the anti-theft code is not known it can be requested via the established systems. For this, you need the identification num‐ ber of the radio -R- . It is located on a sticker on the side of the radio -R- . The identification number is also embossed in the material of the side panel of the radio -R- . Special tools and workshop equipment required ht rig py Co t. r fo ng ♦ Removal wedge -3409- agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Removing – Remove CD from radio -R- ⇒ Owner's manual . – Switch off ignition and all electrical consumers and remove ignition key. – Remove upper cover together with air vents out of the dash panel until the underneath bolts of the centre console cover can be reached, ⇒ General body repairs, exterior; Rep. Gr. 68 . – Remove bolts -arrows- (1.5 Nm). 4 Rep. Gr.91 - Radio, telephone, navigation rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p s ility ab y li an pt ce un le 2.3 ag ksw Vol y b ed ris o h t au Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Carefully lever out cover of centre console using removal wedge -3409- -arrows- and take it off. – Remove bolts -arrows- (1.5 Nm) on radio -R- . AG. Volkswagen AG d agen oes ksw not l o V gu y b ara d nte ise r o eo h t u ra a c s s – Press together connector locking mechanism in direction of -arrows-. ht rig py Co t. r fo ng – Then swing locking bar up in direction of -arrow- and discon‐ nect connector. rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce un le – Pull the radio -R- out of the installation shaft until you can gain access to the connectors on the back of the radio -R- . 2. 5 agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi AG. Volkswagen AG d agen o es n lksw Variant 2010 ➤ , Jetta Golf Variant 2007 ➤V,oGolf 2005 ot g ➤ , Jetta 2011 ➤ ua by d ran Communicationris-e Edition 04.2010 t un le Installing – Fit connectors on the radio -R- and lock them. – Push the radio -R- straight into the dash panel. Note Never press on the display or the operating buttons when fitting the radio -R- , as the radio -R- may be damaged. – Fit the radio -R- with 4 bolts -arrows- (1.5 Nm). – Install centre console cover. – Deactivate anti-theft coding ⇒ page 9 . AG. Prote cted by Rep. Gr.91 - Radio, telephone, navigation agen lksw Vo by c o p yri gh t. C op yi 6 ht rig py Co t. r fo ng – Check the radio -R- coding and recode the radio -R⇒ page 10 . rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p on aerial connection and discon‐ ee or ac ility ab y li an pt ce – Release nect it. tho au s connector -arrows Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 2.4 “Lowentry” connectors 1 - Multi-pin connector 1, 8-pin, loudspeaker outputs ❑ Pin assignment ⇒ page 7 2 - Multi-pin connector 2, 8-pin, CAN bus, telephone ❑ Pin assignment ⇒ page 8 3 - Multi-pin connector 3, 12pin, telephone ❑ Pin assignment ⇒ page 8 4 - Multi-pin connector 4 ❑ Not assigned 5 - Aerial connection ❑ Connector colour, white ❑ AM/FM ❑ Aerial systems (saloon) ⇒ page 171 ❑ Aerial systems (Variant) ⇒ page 179 es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n 8- Front right loudspeaker (-) Front left loudspeaker (-) Rear left loudspeaker (-) do c um en 7- Rear right loudspeaker (-) Prote cted by 6- Rear left loudspeaker (+) AG. 5- Front left loudspeaker (+) agen lksw Vo by 4- Front right loudspeaker (+) c o p yri gh t . C op yi 3- Rear right loudspeaker (+) ht rig py Co t. 2- Multi-pin connector 1, 8-pin, loudspeak‐ er outputs rrectness of i t to the co nform spec at i h re o n wit in t his 2.4.1 1- ility ab y li an pt ce n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss 2. 7 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 2.4.2 Multi-pin connector 2, 8-pin, CAN bus, telephone 9 - CAN bus (high) 10 - CAN bus (low) 11 - Telephone mute 12 - Terminal 31 13 - Radio -R- on 14 - ATA terminal 30 15 - Terminal 30 16 - ATA (SAFE) terminal 30 2.4.3 Multi-pin connector 3, 12-pin, telephone 1-5 - Not assigned 6 - Telephone LF input signal (-) 7-11 - Not assigned AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s pe rm itte d ility ab y li an pt ce un le 12 - Telephone LF input signal (+) Anti-theft coding rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com 2.5 The “Lowentry” radio -R- is equipped with an anti-theft coding system which works in conjunction with the dash panel insert. If the voltage supply for the radio -R- is disconnected and then reconnected, the radio will be still operational without the need to enter the anti-theft code again. A prerequisite is that the initial activation of the anti-theft coding takes place and that the radio R- is reconnected in the same vehicle. 2.5.1 Functional notes r te o iva r rp fo g n agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi If the radio -R- is replaced, the radio code must be entered again. Deactivating anti-theft coding ⇒ page 9 Then after switching on the “S contact” via the ignition lock the code is automatically compared between the dash panel insert and the radio -R- . 8 Rep. Gr.91 - Radio, telephone, navigation ht rig py Co t. When this is done, the internal code of the radio -R- is compared with the code in the dash panel insert. If the codes are identical with each other, the dash panel insert will recognise that the con‐ nected radio -R- belongs to the vehicle. The radio -R- is therefore immediately operational without the need to enter the anti-theft code again. do c um en After initial activation of the anti-theft coding, an internal radio code is stored in the radio -R- and in the dash panel insert. If the radio -R- is now disconnected from the voltage supply due to re‐ pairs (e.g. radio -R- or battery -A- ) removed and the voltage supply is then reconnected, data is transferred between the radio -R- and the dash panel insert. Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Comparison takes approx. 5 seconds. It must be ensured that a diagnostic unit has not been connected or is not connected during this period of time. After this time, the radio -R- of the vehicle will be ready for oper‐ ation without the need to enter the radio code again even if the voltage supply has been cut off and then reconnected. The anti-theft coding becomes effective and blocks the radio -Rwhen: ♦ The radio -R- is installed in another vehicle or . Volkswagen AG does not l o gu yV b ara is A radio -R- whichishas ed been locked by the anti-theft coding nte r o eo shown when “SAFE” and “1000” is shown in the display when h ut ra a switching the radio -Ron. c s s ility ab y li an pt ce Deactivate the anti-theft coding to release the unit lock ⇒ page 9 . Deactivating anti-theft coding A locked radio -R- will only work again if the correct radio code for the anti-theft coding system is entered. Note ♦ The anti-theft radio code is stuck on the radio card together with the unit number ⇒ Instruction manual . ♦ The radio card should not be kept in the vehicle for security reasons. Ask the customer for the radio code. ♦ If a radio -R- is renewed, the numerical code of the replace‐ ment radio must be used. ♦ The customer must be informed that the radio code has changed. agen lksw Vo by Prote cted by c o py rig ht . C op yi – Switch on the radio -R- . ht rig py Co t. – Obtain the code of the radio -R- . rrectness of i t to the co nf o r m spec atio h re n in wit 2.5.2 thi sd o cu m en es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng gen AG ♦ The dash panel insertksiswachanged. The radio -R- automatically displays “SAFE” and then “1000”. AG. – Enter the radio code using station buttons 1 to 4. Use station button 1 to enter the first digit of the radio code and station 2 for the second digit etc. – Then press the function button arrow and hold it down until the electronic anti-theft coding system is activated. This is in‐ dicated by a brief signal sound. If the radio code has been entered correctly into the radio -R- , a radio frequency appears in the display. Note If an incorrect anti-theft code is entered, it can be immediately corrected with a further attempt. If an incorrect radio code is en‐ tered twice, the radio -R- will be blocked for one hour. During the locking period, the radio -R- must remain switched on and the ignition key must remain in the ignition lock. The process can then be repeated after one hour. Do not forget that only two attempts are allowed, after which the radio -R- will be blocked for one hour. 2. 9 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 2.6 Adapting radio -R- components Special tools and workshop equipment required ♦ Vehicle diagnostic, testing and information system -VAS 5051B- Procedure – In vehicle diagnostic, testing and information system -VAS 5051B- , select “Guided fault finding”. – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: ♦ Body ♦ Electrical system ♦ 01 - On board diagnosis-capable systems ♦ Corresponding radio system ♦ Radio system functions ht rig py Co t. agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi Rep. Gr.91 - Radio, telephone, navigation do c um en 10 rrectness of i t to the co nform spec at i h re o n wit in t his es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n ility ab y li an pt ce n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 3 Radio “Premium 7” Radio Premium 7 Note ♦ When dealing with complaints, it is absolutely necessary to understand the functions andAthe of the communi‐ olkswagen AG G. Voperation does agen manual . cation systems. ⇒ Instruction no lksw Vo by t gu ara ed ♦ The anti-theft coding uses a fixed code, deactivating anti-theft nt ris ho coding ⇒ page ut 19 . ee or ac testing and information system VAS 5051. ♦ When the battery -A- is reconnected, please remember to 3.1 General description The radio system “Premium 7” comprises a radio -R- , an inte‐ grated 6-disc CD changer and loudspeakers in the doors. The radio -R- has a final output stage with an output power of 4 x 20 W. The loudspeakers are designed as a 3-way system in the front and as a 2-way system in the rear. The following is installed in the “Premium 7” radio system: ♦ A bass loudspeaker, a mid-range loudspeaker and a treble loudspeaker in each of the front doors. ♦ A bass loudspeaker and a treble loudspeaker in each of the rear doors. rrectness of i t to the co nf o r m spec atio h re n in wit check vehicle equipment (radio, clock, convenience electron‐ ics, etc.) in accordance with the ⇒ Electrical system; Rep. Gr. 27 workshop manual and/or the ⇒ instruction manual . thi sd o cu m en es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ♦ In the event of repair work or fault finding ⇒ Vehicle diagnosis, ility ab y li an pt ce a ss ht rig py Co t. Prote cted by c o py rig ht . C op yi To extend the functions, connection options are available for am‐ plifier -R12- , telephone and satellite radio -R146- . agen lksw Vo by The 6-disc CD changer integrated in the radio -R- can play the following formats: AG. ♦ Audio CD ♦ CD-R ♦ CD-RW ♦ MP3 The following formats cannot be played: ♦ CD with diameter of 8 cm ♦ “Mixed CD” (CD with data and audio files) The aerial is a window aerial and is located in the rear window (saloon). In the Variant, the aerials are located in the rear right side window and in the roof aerial. The aerial system includes a “diversity function” integrated in the radio -R- . 3.1.1 Fault finding The radio -R- is equipped with self-diagnosis. For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. 3. 11 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 3.2 Overview of radio “Premium 7” 1 - Radio -R❑ Connectors ⇒ page 16 ❑ Removing and installing ⇒ page 13 2 - Amplifier -R12❑ Optional ❑ Under left front seat ❑ Amplifier -R12⇒ page 100 . 3 - Satellite tuner aerial -R172❑ Optional ❑ On roof rear side ❑ Aerial systems (saloon) ⇒ page 171 ❑ Aerial systems (Variant) ⇒ page 179 4 - Aerial -R11- / Radio aerial 2 -R93❑ Aerial systems (saloon) ⇒ page 171 ❑ Aerial systems (Variant) ⇒ page 179 pe rm itte d un le ility ab y li an pt ce 5 - Satellite radio -R146❑ Optional ❑ Under rear shelf in lug‐ gage compartment (sa‐ gen AG. Volkswagen AG d oes wa not loon). olks gu yV b ara d e ❑ Under right front nte ris seat o eo (Variant). uth ra c sa s ❑ Satellite radio -R146⇒ page 117 . es, in part or in w l purpos hole ercia , is n m ot com 7 - Rear left bass loudspeaker -R15- / rear right bass loudspeaker -R17❑ Installed in the rear left and right door trims. ❑ Loudspeaker systems ⇒ page 106 . 8 - Front left bass loudspeaker -R21- / front right bass loudspeaker -R23❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 . rrectness of i t to the co nform spec a t i h re o n in wit thi s 6 - Rear left treble loudspeaker -R14- / rear right treble loudspeaker -R16❑ Installed in the rear left and right door trims ❑ Loudspeaker systems ⇒ page 106 r te o iva r rp fo g n 9 - Front left mid-range loudspeaker -R103- / front right mid-range loudspeaker -R104❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 . agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi Rep. Gr.91 - Radio, telephone, navigation ht rig py Co t. 12 do c um en 10 - Front left treble loudspeaker -R20- / front right treble loudspeaker -R22❑ Installed in mirror triangle of the right and left front doors ❑ Loudspeaker systems ⇒ page 106 . Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 3.3 Removing and installing radio “Premium 7” Note ♦ The part number for the radio -R- can be found on a sticker on the radio -R- housing. ♦ If the radio -R- has to be renewed, deactivate the electronic anti-theft coding system ⇒ page 19 . Please inform the cus‐ tomer of the new radio code. gen AG. Volkswagen AG d a lksw oes n ot g Vo ♦ If the radio code is notdknown, it can be requested via the ues‐ by a Special tools and workshop equipment required ♦ Removal wedge -3409- Removing – Switch off ignition and all electrical consumers and remove ignition key. ht rig py Co t. r fo ng – Remove CD from radio -R- ⇒ Owner's manual . rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p un le ility ab y li an pt ce ra e tablished systems. oFor ris this, you need the identification numberntee h t or of the radio -R- .auIt is located on a sticker on the side of the ac s radio -R- . Thesidentification number is also embossed in the material of the side panel of the radio -R- . c o p yri gh t . C op yi – Remove upper cover together with air vents out of the middle of the dash panel until the underneath bolts of the centre con‐ sole cover can be reached, ⇒ General body repairs, exterior; Rep. Gr. 68 . agen lksw Vo by AG. Prote cted by – Remove bolts -arrows- (1.5 Nm). 3. 13 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Carefully lever out cover of centre console using removal wedge -3409- -arrows- and take it off. – Remove bolts -arrows- (1.5 Nm) on radio -R- . AG. Volkswagen AG d agen oes ksw not l o V gu y b ara d nte ise r o eo h t u ra a c s s – Press together connector locking mechanism in direction of -arrows-. AG. Prote cted by Rep. Gr.91 - Radio, telephone, navigation agen lksw Vo by c o p yri gh t. C op yi 14 ht rig py Co t. r fo ng – Then swing locking bar up in direction of -arrow- and discon‐ nect connector. rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce un le – Pull the radio -R- out of the installation shaft until you can gain access to the connectors on the back of the radio -R- . Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Release connectors -arrows- from aerial connections and dis‐ connect them. Installing – Fit connectors on the radio -R- and lock them. – Push the radio -R- straight into the dash panel. Note Never press on the display or the operating buttons when fitting the radio -R- , as the radio -R- may be damaged. – Fit the radio -R- with 4 bolts -arrows- (1.5 Nm). – Install centre console cover. – Deactivate the anti-theft coding ⇒ page 19 . AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s ht rig py Co t. r fo ng rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce un le – Check the radio -R- coding and recode the radio -R⇒ page 19 . 3. 15 agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 3.4 “Premium 7” connectors 1 - Multi-pin connector 1, 8-pin, loudspeaker outputs ❑ Pin assignment ⇒ page 16 rrectness of i t to the co nf o r m spec atio h re n in wit 4 - Multi-pin connector 4, 12pin, satellite radio -R146❑ Pin assignment ⇒ page 17 ility ab y li an pt ce 3 - Multi-pin connector 3, 12pin, telephone ❑ Pin assignment ⇒ page 17 n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng 2 - Multi-pin connector 2, 8-pin, CAN bus, telephone ❑ Pin assignment ⇒ page 17 5 - Aerial connection ❑ Connector colour beige ❑ Pin assignment ⇒ page 18 Prote cted by 1- Rear right loudspeaker (+) 2- Front right loudspeaker (+) 3- Front left loudspeaker (+) 4- Rear left loudspeaker (+) 5- Rear right loudspeaker (-) 6- Front right loudspeaker (-) 7- Front left loudspeaker (-) 8- Rear left loudspeaker (-) 16 Rep. Gr.91 - Radio, telephone, navigation AG. In combination with amplifier -R12- , audio signals from radio -Rare used as input signals for amplifier -R12- . agen lksw Vo by c o p yri gh t . C op yi Multi-pin connector 1, 8-pin, loudspeak‐ er outputs ht rig py Co t. 3.4.1 thi sd o cu m en 6 - Aerial connection ❑ Connector colour trans‐ parent ❑ Pin assignment ⇒ page 18 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 3.4.2 Multi-pin connector 2, 8-pin, CAN bus, telephone 9 - CAN bus (high) 10 - CAN bus (low) 11 - Telephone mute 12 - Terminal 31 13 - Radio -R- on 14 - ATA terminal 30 15 16 - AG. Volkswagen AG d agen oes ksw not l o Terminal 30 by V gu ara d e nte is r o ATA (SAFE) terminal 30 eo h ut ra a c s s 1–5 - Not assigned 6 - Telephone LF input signal (-) 7–11 - Not assigned 12 - Telephone LF input signal (+) 3.4.4 Multi-pin connector 4, 12-pin, satellite radio -R146- 2 - Not assigned Prote cted by c o py rig ht . C op yi 4 - Not assigned AG. 6 - Not assigned agen lksw Vo by 5 - Terminal 30 to satellite radio -R146- ht rig py Co t. 3 - Audio earth from satellite radio -R146- thi sd o cu m en 1 - Audio left from satellite radio -R146- rrectness of i t to the co nf o r m spec atio h re n in wit es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng Multi-pin connector 3, 12-pin, telephone ility ab y li an pt ce 3.4.3 7 - Audio right from satellite radio -R1468 - 12 - Not assigned 3. 17 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 3.4.5 Aerial connections 1 - Connector colour white, saloon aerial systems ⇒ page 171 - Connector colour white, Variant aerial systems ⇒ page 179 2 - Connector colour beige, saloon aerial systems ⇒ page 171 - Connector colour beige, Variant aerial systems ⇒ page 179 Note The radio -R- has an aerial diversity function for terrestrial radio reception. Both aerial connections are signal inputs. The radio R- analyses continuously which of the two connected aerials transmits the better reception signal. The aerial with the better reception signal is then selected. This switching process is not audible. 3.5 Electronic anti-theft coding The “Premium 7” radio -R- is equipped with an electronic anti-theft coding system which works in conjunction with the dash panel insert. If the voltage supply for the radio -R- is cut off and then recon‐ nected, the radio will still be operational without the need to enter the radio code again. A prerequisite is that the electronic anti-theft coding system has already been activated for the first time and that the radio -R- is reconnected in the same vehicle. 3.5.1 Functional notes . Volkswagen AG gen AG does swa k not l o After initial activation of the anti-theft coding, an internal gu y Vradio b ara d e code is stored in the radio -R- and in the dash panel insert. If the nte is r o eo h radio -R- is now disconnected from the voltage supply due to re‐ ut ra a c pairs (e.g. radio -R- or battery -A- ) removed and the voltage s s When this is done, the internal code of the radio -R- is compared with the code in the dash panel insert. If the codes are identical with each other, the dash panel insert will recognise that the con‐ nected radio -R- belongs to the vehicle. The radio -R- is therefore immediately operational without the need to enter the anti-theft code again. If the radio -R- is replaced, the radio code must be entered. Deactivating anti-theft coding ⇒ page 19 Then after switching on the “S contact” via the ignition lock the code is automatically compared between the dash panel insert and the radio -R- . The comparison takes approx. 5 seconds. During this period no diagnostic unit may be connected. The anti-theft coding becomes effective and blocks the radio -Rwhen: 18 Rep. Gr.91 - Radio, telephone, navigation AG. ♦ The dash panel insert is changed. agen lksw Vo by Prote cted by c o py rig ht . C op yi ♦ The radio -R- is installed in another vehicle or ht rig py Co t. r fo ng After this time, the radio -R- of the vehicle will be ready for oper‐ ation without the need to enter the radio code again even if the voltage supply has been cut off and then reconnected. rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p un le ility ab y li an pt ce supply is then reconnected, data is transferred between the radio -R- and the dash panel insert. Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 A radio -R- which has been locked by the anti-theft coding is ageshown . Volkswis n AG d in the display when shown when “SAFE” “1000” en AG agand oes ksw-R- on. not l o switching the yradio V gu b ed ara nte ris Deactivate eo ho the anti-theft coding to release the unit lock ut 19 . ra ⇒ page a c s un le urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce s 3.5.2 Deactivating electronic anti-theft coding Note rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en A locked radio -R- will only work again if the correct radio code for the anti-theft coding system is entered. ♦ The anti-theft radio code is stuck on the radio card together with the unit number ⇒ Instruction manual . ♦ The radio card should not be kept in the vehicle for security reasons. Ask the customer for the radio code. ♦ If a radio -R- is renewed, the radio code of the replacement device must be used. ♦ The customer must be informed that the radio code has changed. – Obtain the code of the radio -R- . ht rig py Co t. r fo ng – Switch on the radio -R- . Prote cted by c o p yri gh t. C op yi The radio -R- automatically displays “SAFE” and then “1000”. – Enter the radio code stuck on the radio card using station but‐ tons 1 to 4. Use station button 1 to enter the first digit of the radio code and station 2 for the second digit etc. agen lksw Vo by AG. – Then press the station button, which is located under “OK” on the display (normally it is the last station button) and hold the button down until the electronic anti-theft coding system is ac‐ tivated. This is indicated by a brief signal sound. If the radio code has been entered correctly into the radio -R- , a radio frequency appears in the display. Note If the incorrect radio code is entered, it can be immediately cor‐ rected with a further attempt. If an incorrect radio code is entered twice, the radio -R- will be blocked for one hour. During the locking period, the radio -R- must remain switched on and the ignition key must remain in the ignition lock. The process of deactivating the anti-theft coding can then be repeated after one hour. Do not for‐ get that only two attempts are allowed, after which the radio -Rwill be blocked for one hour. 3.6 Adapting radio -R- components Special tools and workshop equipment required 3. 19 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 ♦ Vehicle diagnosis, testing and information system -VAS 5051B- rrectness of i t to the co nf o r m spec atio h re n in wit es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng Procedure ility ab y li an pt ce AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s – Select “guided fault finding” in the vehicle diagnosis, testing and information system -VAS 5051B- . – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: ♦ Body ♦ Electrical system ♦ 01 - On board diagnosis-capable systems ♦ Corresponding radio system agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Rep. Gr.91 - Radio, telephone, navigation thi sd o cu m en 20 ht rig py Co t. ♦ Radio system functions Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 4 Radio “Premium 8” Radio Premium 8 Note ♦ When dealing with complaints, it is absolutely necessary to understand the functions and the operation of the communi‐ cation systems ⇒ Instruction manual . ♦ The anti-theft coding uses a fixed code ⇒ page 77 . ♦ In the event of repair work or fault finding ⇒ Vehicle diagnosis, testing and information system VAS 5051. ♦ When the battery -A- is reconnected, please remember to check vehicle equipment (radio, clock, convenience electron‐ ics, etc.) in accordance with the ⇒ Electrical system; Rep. Gr. 27 workshop manual and/or the ⇒ owner's manual . 4.1 General description The radio system “Premium 8” comprises a radio -R- , an inte‐ grated 6-disc CD changer and loudspeakers in the doors. AG. Volkswagen AG d agen oes ksw not l o V The radio -R- has a plug position for the use of SD storage cards gu by ara d e W for reproducing audio content and an output stage with 4 xris20 nte o eo h output. ut ra a c s s pe rm itte d un le ility ab y li an pt ce The loudspeakers are designed as a 3-way system in the front and as a 2-way system in the rear. rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com The radio system “Premium 8” is available in a version with loud‐ speakers operated via the 4 internal loudspeaker outputs or in a version with the amplifier -R12- . In this case, the loudspeakers are connected directly to the amplifier -R12- and the loudspeaker outputs of the radio -R- are used for amplifier -R12- input signals. The following loudspeakers are installed with the radio system “Premium 8”: ♦ A bass loudspeaker, a mid-range loudspeaker and a treble loudspeaker in each of the front doors. ♦ A bass loudspeaker and a treble loudspeaker in each of the rear doors. To extend the functions, connection options are available for am‐ plifier -R12- , CD changer -R41- and telephone. r te o iva r rp fo g n The integrated 6-disc CD changer can play the following formats: AG. ♦ MP3 agen lksw Vo by ♦ CD-RW Prote cted by c o p yri gh t. C op yi ♦ CD-R ht rig py Co t. ♦ Audio CD do c um en An optional satellite radio -R146- is integrated into radio -R- “Pre‐ mium 8”. The following formats cannot be played: ♦ CD with diameter of 8 cm ♦ “Mixed CD” (CD with data and audio files) 4. 21 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Note The internal CD changer has a transport protection device which must be deactivated before installing a new radio -R- . The trans‐ port protection device must also be switched on before shipping a removed radio -R- . For this, the Radio -R- must still be con‐ AG. Volkswagen AG d agen nected to the voltage supply. oes w s n lk ot g ua ran tee or ac es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n ility ab y li an pt ce o yV db e ris The aerial is a window aerial and is located in the rear window tho (saloon). In the Variant, the aerialssare au located in the rear side windows and in the roof aerial. Thes aerial system includes a “di‐ versity function” integrated in the radio -R- . 4.1.1 Fault finding rrectness of i t to the co nform spec at i h re o n wit in t his The radio -R- is equipped with self-diagnosis. For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. 4.2 Overview of radio “Premium 8” 22 Rep. Gr.91 - Radio, telephone, navigation AG. 4 - Satellite tuner aerial -R172❑ Roof aerial. ❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . ❑ Aerial systems in sa‐ loons from model year 2011 ⇒ page 179 agen lksw Vo by Prote cted by c o p yri gh t. C op yi 3 - Multimedia system control unit -J650❑ Optional ❑ In centre console ❑ Multimedia system con‐ trol unit -J650⇒ page 95 ❑ CD changer -R41⇒ page 79 ❑ Connection for external audio sources -R199⇒ page 91 ht rig py Co t. 2 - Amplifier -R12❑ Optional ❑ Under left front seat ❑ Amplifier -R12⇒ page 100 . do c um en 1 - Radio -R❑ Connectors ⇒ page 26 ❑ Activating and deacti‐ vating transport protec‐ tion device ⇒ page 28 ❑ Removing and installing ⇒ page 23 . Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 5 - Aerial -R11- / Radio aerial 2 -R93❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . ❑ Aerial systems in saloons from model year 2011 ⇒ page 179 6 - Rear left treble loudspeaker -R14- / rear right treble loudspeaker -R16❑ Installed in the rear left and right door trims. ❑ Loudspeaker systems ⇒ page 106 . 7 - Rear left bass loudspeaker -R15- / rear right bass loudspeaker -R17❑ Installed in the rear left and right door trims ❑ Loudspeaker systems ⇒ page 106 8 - Front left bass loudspeaker -R21- / front right bass loudspeaker -R23❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 9 - Front left mid-range loudspeaker -R103- / front right mid-range loudspeaker -R104❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 10 - Front left treble loudspeaker -R20- / front right treble loudspeaker -R22swagleft en Afront G. Volkand ❑ Installed in mirror triangle ofagthe G do doors en Aright es n ksw l ot g o V⇒ page 106 ❑ Loudspeaker systems y ua b ss ran tee or ac ♦ The part number for the radio -R- can be found on a sticker on the radio -R- housing. ♦ If the radio -R- has to be renewed, deactivate the electronic anti-theft coding system ⇒ page 29 . ♦ The integrated CD changer has a transport protection device which must be deactivated before installing a new radio -R- . The transport protection device must also be activated before shipping a removed radio -R- . For this, the radio -R- must still be connected to the voltage supply. Activating and deactivat‐ ing transport protection device ⇒ page 28 . Special tools and workshop equipment required ♦ Removal wedge -3409- rrectness of i t to the co nf o r m spec atio h re n in wit Note thi sd o cu m en es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng Removing and installing radio “Premium 8” ility ab y li an pt ce 4.3 ed ris o h t au 4. 23 ht rig py Co t. agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Removing – Remove CD from radio -R- ⇒ Operating manual . – Activate the transport protection device ⇒ page 28 . – Switch off ignition and all electrical consumers and remove ignition key. – Remove upper cover together with air vents out of the middle of the dash panel until the underneath bolts of the centre con‐ sole cover can be reached, ⇒ General body repairs, exterior; Rep. Gr. 68 . – Remove bolts -arrows- (1.5 Nm). – Carefully lever out cover of centre console using removal wedge -3409- -arrows- and take it off. un le r fo ng AG. Rep. Gr.91 - Radio, telephone, navigation agen lksw Vo by Prote cted by c o p yri gh t. C op yi 24 ht rig py Co t. – Pull the radio -R- out of the installation shaft until you can gain access to the connectors on the back of the radio -R- . rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce – Remove bolts -arrows- (1.5 Nm) on radio -R- . AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 olkswagen AG en AG. V does not gu ara nte eo ra c rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com pe rm itte d ris ho ut a ss ility ab y li an pt ce un le ag – Press together connector locking mechanism in direction ksw of Vol y -arrows-. b ed agen lksw Vo by Prote cted by c o p yri gh t. C op yi AG. Installing ht rig py Co t. – Release connectors -arrows- of aerial connections and dis‐ connect connectors. do c um en r te o iva r rp fo g n – Then swing locking bar up in direction of -arrow- and pull out connectors. – Fit connectors on the radio -R- and lock them. – Push the radio -R- straight into the dash panel. Note Never press on the display or the operating buttons when fitting the radio -R- , as the radio -R- may be damaged. – Fit the radio -R- with 4 bolts -arrows- (1.5 Nm). – Install centre console cover. – Deactivate the anti-theft coding ⇒ page 29 . – Deactivate the transport protection device ⇒ page 28 . – Check the radio -R- coding and recode the radio -R⇒ page 30 . 4. 25 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 4.4 “Premium 8” connectors 1 - Aerial connection ❑ Connector colour, black ❑ SAT connection to roof aerial (saloon) ⇒ page 171 . ❑ SAT connection to roof aerial (Variant) ⇒ page 179 . ❑ Aerial systems in sa‐ loons from model year 2011 ⇒ page 179 2 - Multi-pin connector 1, 8-pin, loudspeaker outputs ❑ Pin assignment ⇒ page 27 3 - Multi-pin connector 2, 8-pin, CAN bus, telephone ❑ Pin assignment ⇒ page 27 4 - Multi-pin connector 3, 12pin, telephone ❑ Pin assignment ⇒ page 27 5 - Multi-pin connector 4, 12pin, CD changer -R41❑ Pin assignment ⇒ page 28 6 - Not fitted n AG. Volkswagen AG do es n wage ot g ua ran tee or ac rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com pe rm itte d un le ility ab y li an pt ce ks 7 - Aerial connection Vol by d e ❑ Connector colour, white ris ho t au ❑ FM2 ss ❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . ❑ Aerial systems in saloons from model year 2011 ⇒ page 179 agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Rep. Gr.91 - Radio, telephone, navigation ht rig py Co t. 26 do c um en r te o iva r rp fo g n 8 - Aerial connection ❑ Connector colour, white ❑ AM/FM ❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . ❑ Aerial systems in saloons from model year 2011 ⇒ page 179 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 olkswagen AG en AG. V Multi-pin connector 1, 8-pin, does agloudspeak‐ ksw not l o V gu y er outputs ara db e n s i or tee or ac es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng Rear right loudspeaker (+) 2- Front right loudspeaker (+) 3- Front left loudspeaker (+) 4- Rear left loudspeaker (+) 5- Rear right loudspeaker (-) 6- Front right loudspeaker (-) 7- Front left loudspeaker (-) 8- Rear left loudspeaker (-) rrectness of i t to the co nf o r m spec atio h re n in wit 1- Multi-pin connector 2, 8-pin, CAN bus, telephone 12 - Terminal 31 13 - Not assigned 14 - Not assigned AG. 11 - Telephone mute agen lksw Vo by 10 - CAN bus (low) thi sd o cu m en 9 - CAN bus (high) Prote cted by c o p yri gh t. C op yi 4.4.2 ility ab y li an pt ce In combination with amplifier -R12-au,thaudio signals from radio -Rss are used as input signals for amplifier -R12- . ht rig py Co t. 4.4.1 15 - Terminal 30 16 - ATA (SAFE) terminal 30 4.4.3 Multi-pin connector 3, 12-pin, telephone 1–5 - Not assigned 6 - Telephone LF input signal (-) 7–11 - Not assigned 12 - Telephone LF input signal (+) 4. 27 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 4.4.4 Multi-pin connector 4, 12-pin, CD changer -R41- 1- Audio input left (+) 2- Audio input earth 3- Audio earth from CD changer -R41- 4- Terminal 30 to CD changer -R41- 5- Not assigned 6- CD data out to CD changer -R41- 7- Audio input right (+) 8- Audio left from CD changer -R41- 9- Audio right from CD changer -R41- 10 - Control signal to CD changer -R4111 - CD data in from CD changer -R4112 - CD clock from CD changer -R41- 4.5 Activating and deactivating transport protection device The transportation device must be activated before shipping a “Premium 8” and deactivated when installing a new radio -R- . This takes place electronically via the key pad of the radio -R- . When the transport protection device has been activated, the drive of the internal CD changer is brought to a “transport posi‐ tion”. Activating transport protection device: Unit status: “ON” or “OFF”. The radio -R- must be connected to the voltage supply. n AG. – Press and hold keys marked with -arrows- simultaneously agefor ksw l o V at least 5 seconds. by d se un le ility ab y li an pt ce ri the transport Once the drive of the internal CD changer reaches ho ut a position, “CDC transport protection device activated” appears in ss the display. Volkswagen AG does not gu ara nte eo ra c – Connect and install the radio -R- . – Press and hold keys marked with -arrows- simultaneously for at least 5 seconds. The following appears on the radio display: “CDC transport pro‐ tection device activated”. A button with the word “Deactivate” is located under it. – Press “Deactivate” button. agen lksw Vo by AG. Rep. Gr.91 - Radio, telephone, navigation Prote cted by c o p yri gh t. C op yi 28 ht rig py Co t. r fo ng Transport protection device has now been deactivated. rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p Deactivating transport protection device: Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 4.6 Electronic anti-theft coding The radio -R- is equipped with an electronic anti-theft coding sys‐ tem which works in conjunction with the dash panel insert. If the voltage supply for the radio -R- is cut off and then recon‐ nected, the radio will still be operational without the need to enter the radio code again. A prerequisite is that the electronic anti-theft coding system has already been activated for the first time and that the radio -R- is reconnected in the same vehicle. The radio code is determined by means of the vehicle diagnosis, testing and information system -VAS 5051B- . The radio card used in the past and the sticker on the radio -R- have been dis‐ continued. Volkswa Note rrectness of i t to the co nf o r m spec atio h re n in wit 4.6.1 Deactivating electronic anti-theft coding A locked radio -R- will only work again if the correct numerical code for the electronic anti-theft coding system is entered. Using the VAS tester to find out the radio code: – Select “guided fault finding” in the vehicle diagnosis, testing and information system -VAS 5051B- . – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: ♦ Body ♦ Electrical system ♦ 01 - On board diagnosis-capable systems ♦ Corresponding radio system c o p yri gh t . C op yi agen lksw Vo by ♦ Radio code request ht rig py Co t. ♦ Radio system functions thi sd o cu m en es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng In order to find out testing and information system -VAS 5051B- must be connected “online” (network connection), and the user must possess valid rights to use the programme for requesting radio codes. ility ab y li an pt ce gen AG n AG. does wage not olks V gu y b ara d e nte ris o eo h t u ra c sa s the numerical code, the vehicle diagnosis, Prote cted by Your system rights are then determined. The operating data, the VIN and the unit number of the radio -R- are then read out auto‐ matically. AG. Note When a new radio -R- is being installed, it is possible that the vehicle diagnosis, testing and information system -VAS 5051Bcannot read out the unit number of the radio -R- . In this case, please enter the unit number manually. It can be read on a sticker on the radio -R- unit and is also embossed on the side of the unit. The radio code determined is then shown on the display of the vehicle diagnosis, testing and information system -VAS 5051B- . The radio code must be entered in the radio -R- manually. Deactivating anti-theft coding: – Switch on the radio -R- . An entry mask appears. 4. 29 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Using the keypad, enter the right radio code in the entry mask. – Confirm the entry by pressing the entry button. The radio -R- will be released and is ready for use. Note If an incorrect radio code has been entered on deactivating the electronic lock, “SAFE” first flashes in the display, followed by “1000” again. The entire process can now be repeated again. The number of attempts is shown in the display. If an incorrect radio code is entered again, the radio -R- will be blocked for approx. one hour, i.e. it cannot be operated. This lock is indicated by the fact that “SAFE” is permanently shown in the display. The process of deactivating the anti-theft coding can then be repeated after one hour. Do not forget that only two attempts are allowed, after which the radio -R- will be blocked for one hour. 4.7 Adapting radio -R- components Special tools and workshop equipment required ♦ Vehicle diagnosis, testing and information system -VAS 5051B- es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ility ab y li an pt ce AG. Volkswagen AG d agen oes ksw not l o V gu y Procedure b ara d nte ise r o eo h t vehicle diagnosis, testing – Select “guided fault finding” in the u ra a c s and information system -VAS 5051B. s – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: ♦ Electrical system rrectness of i t to the co nf o r m spec atio h re n in wit ♦ Body ♦ 01 - On board diagnosis-capable systems ♦ Corresponding radio system ♦ Radio system functions ht rig py Co t. agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Rep. Gr.91 - Radio, telephone, navigation thi sd o cu m en 30 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 5 Radio system “RCD 210” Radio RCD 210 Note ♦ When dealing with complaints, it is absolutely necessary to understand the functions and the operation of the communi‐ cation systems ⇒ Instruction manual . ♦ The anti-theft coding uses a fixed code ⇒ page 37 . ♦ In the event of repair work or fault finding ⇒ Vehicle diagnosis, testing and information system VAS 5051. ♦ When the battery -A- is reconnected, please remember to n AG. Volkswagen AG do electron‐ check vehicle equipment (radio, e n wage clock, convenience ksthe l ot g Gr. o ics, etc.) in accordancebywith ⇒ Electrical system; sRep. V u d e 27 workshop manual and/or the ⇒ instruction manual . arant s ri The “RCD 210” radio system consists of the radio -R- and the loudspeakers in the doors. The loudspeakers are designed as a 2-way system. Depending on equipment, loudspeaker systems are installed in the front only (2 x 20 W) or front and rear (4 x 20 W). The following is installed in the version with 2 x 20 W in the front doors: ♦ A bass loudspeaker, a mid-range loudspeaker and a treble loudspeaker on each side In the version with 4 x 20 W, a bass loudspeaker and a treble loudspeaker are additionally installed in each rear door. To extend the functionality, there is a connection for a CD changer -R41- and a telephone. The CD drive integrated in the radio -R- can play the following formats: agen lksw Vo by AG. Prote cted by ♦ CD-RW c o p yri gh t. C op yi ♦ CD-R ht rig py Co t. ♦ Audio CD rrectness of i t to the co nform spec at i h re o n wit in t his The radio -R- has an output stage with 2 x 20 W output power; 4 x 20 W output power is also available as an option. do c um en es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n General description ility ab y li an pt ce 5.1 ee or ac tho au s s ♦ MP3 The following formats cannot be played: ♦ CD with diameter of 8 cm ♦ “Mixed CD” (CD with data and audio files) The aerial is a window aerial and is located in the rear window (saloon). In the Variant, the aerial is located in the roof aerial. The aerial version comes without “diversity function”. 5.1.1 Fault finding The radio -R- is equipped with self-diagnosis. For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. 5. 31 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 5.2 Overview of radio system “RCD 210” 1 - Radio -R❑ Connectors ⇒ page 36 ❑ Removing and installing ⇒ page 33 2 - Connection for external au‐ dio sources -R199❑ In centre console ❑ Connection for external audio sources -R199⇒ page 91 3 - Aerial -R11❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . 4 - Rear left treble loudspeaker -R14- / rear right treble loud‐ speaker -R16❑ Installed in the rear left and right door trims. ❑ Loudspeaker systems ⇒ page 106 . 5 - Rear left bass loudspeaker -R15- / rear right bass loud‐ speaker -R17❑ Installed in the rear left and right door trims. ❑ Loudspeaker systems n AG. Volkswagen AG do ⇒ page 106 . es wage ks Vol urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p un le not gu ara nte eo ra c ility ab y li an pt ce by 6 - Front left bass loudspeaker ed ris loud‐ -R21- / front right bass o th speaker -R23- s au s ❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 . rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en 7 - Front left mid-range loudspeaker -R103- / front right mid-range loudspeaker -R104❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 . AG. Rep. Gr.91 - Radio, telephone, navigation agen lksw Vo by Prote cted by c o py rig ht . C op yi 32 ht rig py Co t. r fo ng 8 - Front left treble loudspeaker -R20- / front right treble loudspeaker -R22❑ Installed in mirror triangle of the right and left front doors ❑ Loudspeaker systems ⇒ page 106 . Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 5.3 Removing and installing radio “RCD 210” Note ♦ The part number for the radio -R- can be found on a sticker on the radio -R- housing. ♦ If the radio -R- has to be renewed, deactivate the electronic anti-theft coding system ⇒ page 38 . Special tools and workshop equipment required ♦ Removal wedge -3409- Removing – Remove CD from radio -R- ⇒ Owner's manual . – Switch off ignition and all electrical consumers and remove ignition key. – Remove upper cover together with air vents out of the middle of the dash panel until the underneath bolts of the centre con‐ sole cover can be reached, ⇒ General body repairs, exterior; n AG. Volkswagen AG do Rep. Gr. 68 . e wage ris tho u a ss r fo ng rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce un le s no t gu ara nte eo ra c ks Vol ht rig py Co t. – Remove bolts -arrows- (1.5 Nm). ed by 5. 33 agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss – Remove bolts -arrows- (1.5 Nm) on radio -R- . r fo ng – Pull the radio -R- out of the installation shaft until you can gain access to the connectors on the back of the radio -R- . – Press together connector locking mechanism in direction of -arrows-. ht rig py Co t. agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi – Then swing locking bar up in direction of -arrow- and discon‐ nect connector. 34 Rep. Gr.91 - Radio, telephone, navigation rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce un le – Carefully lever out cover of centre console using removal wedge -3409- -arrows- and take it off. Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 AG. Volkswagen AG d oes not gu ara nte eo ra c agenpull it off. – Release connector -arrow- on aerial connection and lksw Installing ility ab y li an pt ce un le – Fit connectors on the radio -R- o yV db ir se tho ulock a and them. ss Never press on the display or the operating buttons when fitting the radio -R- , as the radio -R- may be damaged. – Fit the radio -R- with 4 bolts -arrows- (1.5 Nm). – Install centre console cover again. – Deactivate the anti-theft coding ⇒ page 38 . ht rig py Co t. r fo ng – Check the radio -R- coding and recode the radio -R⇒ page 39 . rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en Note urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p – Push the radio -R- straight into the dash panel. 5. 35 agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi olkswagen AG en AG. V do ag Golf Variant 2007 ➤ , Golf Variant 2010 ➤ ,oJetta ksw 2005 ➤ , Jetta 2011es➤ not V l gu y b ara Communication - Edition 04.2010 d e rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com 1 - Aerial connection ❑ Connector colour, white ❑ AM/FM ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . pe rm itte d un le “RCD 210” connectors ility ab y li an pt ce 5.4 nte eo ra c ris tho u a ss Rear right loudspeaker (+) 2- Front right loudspeaker (+) 3- Front left loudspeaker (+) 4- Rear left loudspeaker (+) 5- Rear right loudspeaker (-) 6- Front right loudspeaker (-) 7- Front left loudspeaker (-) 8- Rear left loudspeaker (-) 36 Prote cted by 1- Rep. Gr.91 - Radio, telephone, navigation AG. Multi-pin connector 1, 8-pin, loudspeak‐ er outputs agen lksw Vo by 5.4.1 c o p yri gh t . C op yi 5 - Multi-pin connector 4, 12pin, CD changer -R41❑ Pin assignment ⇒ page 37 ht rig py Co t. 4 - Multi-pin connector 3, 12pin, telephone ❑ Pin assignment ⇒ page 37 do c um en 3 - Multi-pin connector 2, 8-pin, CAN bus, telephone ❑ Pin assignment ⇒ page 37 r te o iva r rp fo g n 2 - Multi-pin connector 1, 8-pin, loudspeaker outputs ❑ Pin assignment ⇒ page 36 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 5.4.2 Multi-pin connector 2, 8-pin, CAN bus, telephone 9 - CAN bus (high) 10 - CAN bus (low) 11 - Telephone mute 12 - Terminal 31 13 - Not assigned 14 - Not assigned 15 - Terminal 30 16 - ATA (SAFE) terminal 30 Multi-pin connector 3, 12-pin, telephone 1–5 - Not assigned es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ility ab y li an pt ce 6 - Telephone LF input signal (-) 7–11 - Not assigned Multi-pin connector 4, 12-pin, CD changer -R41- 2- Audio input earth 3- Audio earth from CD changer -R41- 4- Terminal 30 to CD changer -R41- 5- Not assigned 6- CD data out to CD changer -R41- 7- Audio input right (+) 8- Audio left from CD changer -R41- 9- Audio right from CD changer -R41- AG. Audio input left (+) thi sd o cu m en 1- agen lksw Vo by 5.4.4 rrectness of i t to the co nf o r m spec atio h re n in wit 12 - Telephone LF input signal (+) ht rig py Co t. 5.4.3 n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss Prote cted by c o p yri gh t . C op yi 10 - Control signal to CD changer -R4111 - CD data in from CD changer -R4112 - CD clock from CD changer -R41- 5.5 Electronic anti-theft coding The radio -R- is equipped with an electronic anti-theft coding sys‐ tem which works in conjunction with the dash panel insert. If the voltage supply for the radio -R- is cut off and then recon‐ nected, the radio will still be operational without the need to enter the radio code again. A prerequisite is that the electronic anti-theft coding system has already been activated for the first time and that the radio -R- is reconnected in the same vehicle. The radio code is determined by means of the vehicle diagnosis, testing and information system -VAS 5051B- . The radio card 5. 37 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 G. Volkswage n AG d nA oes wage not used in the past and the sticker on the Vradio olks -R- have been dis‐ gu y b ara continued. d e n un le pe rm itte d tee or ac es, in part or in w l purpos hole ercia , is n m ot com 5.5.1 rrectness of i t to the co nform spec a t i h re o n in wit thi s In order to find out the radio code, the vehicle diagnosis, testing and information system -VAS 5051B- must be connected “online” (network connection), and the user must possess valid rights to use the programme for requesting radio codes. ility ab y li an pt ce Note ris tho u a ss Deactivating electronic anti-theft coding A locked radio -R- will only work again if the correct radio code for the anti-theft coding system is entered. Using the VAS tester to find out the radio code: – Select “guided fault finding” in the vehicle diagnosis, testing and information system -VAS 5051B- . ♦ 01 - On board diagnosis-capable systems Prote cted by ♦ Radio code request AG. ♦ Radio system functions agen lksw Vo by c o p yri gh t . C op yi ♦ Corresponding radio system Your system rights are then determined. The operating data, the VIN and the unit number of the radio -R- are then read out auto‐ matically. Note When a new radio -R- is being installed, it is possible that the vehicle diagnosis, testing and information system -VAS 5051Bcannot read out the unit number of the radio -R- . In this case, please enter the unit number manually. It can be read off from the sticker affixed to the unit and is additionally stamped into the side of the unit. The radio code determined is then shown on the display of the vehicle diagnosis, testing and information system -VAS 5051B- . The radio code must be entered in the radio -R- manually. Deactivating anti-theft coding: – Switch on the radio -R- . The word “SAFE” appears for approx. 10 seconds on the display and then number sequence “1000”. – Enter the radio code by pressing the corresponding function buttons until the right number sequence appears. After the four-digit radio code has been entered, “OK” appears on the display. – Once you have entered the correct radio code, confirm it with the “OK” function button on the display. The radio -R- will be released and is ready for use. 38 Rep. Gr.91 - Radio, telephone, navigation do c um en ♦ Electrical system ht rig py Co t. ♦ Body r te o iva r rp fo g n – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Note If the incorrect radio code is entered, it can be immediately cor‐ rected with a further attempt. If an incorrect radio code is entered twice, the radio -R- will be blocked for one hour. Then leave the radio -R- and the ignition on. The process of deactivating the antitheft coding can then be repeated after one hour. Do not forget that only two attempts are allowed, after which the radio -R- will be blocked for one hour. 5.6 Adapting radio -R- components Special tools and workshop equipment required ♦ Vehicle diagnosis, testing and information system -VAS 5051B- Procedure – Select “guided fault finding” in the vehicle diagnosis, testing AG..Volkswagen AG d and information system -VASsw5051Bagen oes k Vol not g y ua d b “Functions/component” and the fol‐ – Using GoTo button, select ran ise tee r o lowing menu options in succession: h o ut un le ra c a ss ility ab y li an pt ce ♦ Body pe rm itte d ♦ Electrical system rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com ♦ 01 - On board diagnosis-capable systems ♦ Corresponding radio system do c um en ht rig py Co t. r te o iva r rp fo g n ♦ Radio system functions 5. 39 agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 n AG. Volkswagen AG do e wage 6 Radio system “RCD 300” un le ♦ When dealing with complaints, it is absolutely necessary to understand the functions and the operation of the communi‐ cation systems ⇒ Instruction manual . ♦ The anti-theft coding uses a fixed code, deactivating anti-theft coding ⇒ page 47 . ♦ In the event of repair work or fault finding ⇒ Vehicle diagnosis, testing and information system VAS 5051. ♦ When the battery -A- is reconnected, please remember to General description The “RCD 300” radio system consists of the radio -R- and the loudspeakers in the doors. The following is installed in the version with 2 x 20 W in the front doors: ♦ A bass loudspeaker, a mid-range loudspeaker and a treble loudspeaker on each side In the version with 4 x 20 W, a bass loudspeaker and a treble loudspeaker are additionally installed in each rear door. To extend the functionality, there is a connection for a CD changer -R41- and a telephone. The CD drive integrated in the radio -R- can play the following formats: ♦ Audio CD ♦ CD-R ♦ CD-RW ♦ MP3 The following formats cannot be played: ♦ CD with diameter of 8 cm ♦ “Mixed CD” (CD with data and audio files) The aerial is a window aerial and is located in the rear window (saloon). In the Variant, the aerials are located in the rear right side window and in the roof aerial. The aerial system includes a “diversity function” integrated in the radio -R- . 6.1.1 Fault finding The radio -R- is equipped with self-diagnosis. For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. 40 Rep. Gr.91 - Radio, telephone, navigation AG. The loudspeakers are designed as a 3-way system in the front and as a 2-way system in the rear. agen lksw Vo by Prote cted by c o p yri gh t. C op yi The radio -R- has an output stage with 2 x 20 W output power; 4 x 20 W output power is also available as an option. ht rig py Co t. 6.1 r fo ng check vehicle equipment (radio, clock, convenience electron‐ ics, etc.) in accordance with the ⇒ Electrical system; Rep. Gr. 27 workshop manual and/or the ⇒ instruction manual . rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p Note ss ility ab y li an pt ce Radio RCD 300 s no t gu ara nte eo ra c ks Vol by d e ris ho t au Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 6.2 Overview of radio system “RCD 300” 1 - Radio -R❑ Connectors ⇒ page 45 ❑ Removing and installing ⇒ page 42 2 - CD changer -R41❑ 6-pin ❑ Below the hinged centre armrest ❑ CD changer -R41⇒ page 79 3 - Aerial -R11- / Radio aerial 2 -R93❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . un le ility ab y li an pt ce 4 - Rear left treble loudspeaker -R14- / rear right treble loud‐ n AG. Volkswagen AG do speaker -R16es n wage s k l ot g o y Vthe rear left ua ❑ Installedd bin ran e s i and oright door trims. tee r h t or u ac a ❑ Loudspeaker systems ss ⇒ page 106 . pe rm itte d 6 - Front left bass loudspeaker -R21- / front right bass loud‐ speaker -R23❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 . r te o iva r rp fo g n 7 - Front left mid-range loudspeaker -R103- / front right mid-range loudspeaker -R104❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 . do c um en 8 - Front left treble loudspeaker -R20- / front right treble loudspeaker -R22❑ Installed in mirror triangle of the right and left front doors ❑ Loudspeaker systems ⇒ page 106 . ht rig py Co t. es, in part or in w l purpos hole ercia , is n m ot com rrectness of i t to the co nform spec a t i h re o n in wit thi s 5 - Rear left bass loudspeaker -R15- / rear right bass loud‐ speaker -R17❑ Installed in the rear left and right door trims. ❑ Loudspeaker systems ⇒ page 106 . 6. 41 agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 6.3 Removing and installing radio “RCD 300” Note ♦ The part number for the radio -R- can be found on a sticker on the radio -R- housing. ♦ If the radio -R- has to be renewed, deactivate the electronic olkswagen AG anti-theft coding system ⇒ page 47 . Please inform the cus‐ AG. V does agen ksw not l tomer of the new radio code. o V g y db ua ran tee e ♦ If the radio code is not known, it canobe ris requested via the es‐ or ac Special tools and workshop equipment required ♦ Removal wedge -3409- r fo ng – Remove CD from radio -R- ⇒ Owner's manual . Prote cted by – Remove bolts -arrows- (1.5 Nm). 42 Rep. Gr.91 - Radio, telephone, navigation AG. – Remove upper cover together with air vents out of the middle of the dash panel until the underneath bolts of the centre con‐ sole cover can be reached, ⇒ General body repairs, exterior; Rep. Gr. 68 . agen lksw Vo by c o p yri gh t. C op yi – Switch off ignition and all electrical consumers and remove ignition key. ht rig py Co t. Removing rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p un le ility ab y li an pt ce th tablished systems. For this, you need au the identification number s of the radio -R- . It is located on sa sticker on the side of the radio -R- . The identification number is also embossed in the material of the side panel of the radio -R- . Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Carefully lever out cover of centre console using removal wedge -3409- -arrows- and take it off. – Remove bolts -arrows- (1.5 Nm) on radio -R- . – Pull the radio -R- out of the installation shaft until you can gain access to the connectors on the back of the radio -R- . AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s do c um en ht rig py Co t. r te o iva r rp fo g n – Then swing locking bar up in direction of -arrow- and discon‐ nect connector. rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com pe rm itte d ility ab y li an pt ce un le – Press together connector locking mechanism in direction of -arrows-. 6. 43 agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Release connectors -arrows- from aerial connections and dis‐ connect them. Installing – Fit connectors on the radio -R- and lock them. – Push the radio -R- straight into the dash panel. Note Never press on the display or the operating buttons when fitting the radio -R- , as the radio -R- may be damaged. – Fit the radio -R- with 4 bolts -arrows- (1.5 Nm). – Install centre console cover again. – Deactivate the anti-theft coding ⇒ page 47 . – Check the radio -R- coding and recode the radio -R⇒ page 48 . ht rig py Co t. agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi Rep. Gr.91 - Radio, telephone, navigation thi sd o cu m en 44 rrectness of i t to the co nf o r m spec atio h re n in wit es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ility ab y li an pt ce n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 6.4 “RCD 300” connectors 1 - Multi-pin connector 1, 8-pin, loudspeaker outputs ❑ Pin assignment ⇒ page 45 2 - Multi-pin connector 2, 8-pin, CAN bus, telephone ❑ Pin assignment ⇒ page 46 3 - Multi-pin connector 3, 12pin, telephone ❑ Pin assignment ⇒ page 46 4 - Multi-pin connector 4, 12pin, CD changer -R41❑ Pin assignment ⇒ page 46 5 - Aerial connection ❑ Connector colour beige ❑ FM2 ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . Multi-pin connector 1, 8-pin, loudspeak‐ er outputs Rear right loudspeaker (+) 2- Front right loudspeaker (+) 3- Front left loudspeaker (+) 4- Rear left loudspeaker (+) 5- Rear right loudspeaker (-) 6- Front right loudspeaker (-) 8- Rear left loudspeaker (-) AG. Front left loudspeaker (-) agen lksw Vo by 7- do c um en r te o iva r rp fo g n 1- ht rig py Co t. 6.4.1 rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com pe rm itte d un le ility ab y li an pt ce 6 - Aerial connection ❑ Connector colour trans‐ . Volkswage n AG d n AG parent oes wage not olks V gu y b ara ❑ AM/FM ed nte ris o eo ❑ Aerial usystem, saloon th ra a 171 . c ⇒ page ss ❑ Aerial system, Variant ⇒ page 179 . 6. 45 Prote cted by c o p yri gh t . C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 6.4.2 Multi-pin connector 2, 8-pin, CAN bus, telephone 9 - CAN bus (high) 10 - CAN bus (low) 11 - Telephone mute 12 - Terminal 31 13 - Not assigned 14 - Not assigned 15 - Terminal 30 16 - ATA (SAFE) terminal 30 6.4.3 Multi-pin connector 3, 12-pin, telephone 1–5 - Not assigned 6 - Telephone LF input signal (-) 7–11 - Not assigned 12 - Telephone LF input signal (+) es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n Multi-pin connector 4, 12-pin, CD changer -R41- Not assigned 2- Audio earth from CD changer -R41- 3- Not assigned 4- Terminal 30 to CD changer -R41- 5- Not assigned 6- CD data out to CD changer -R41- 7- Not assigned 8- Audio left from CD changer -R41- 9- Audio right from CD changer -R41- rrectness of i t to the co nform spec at i h re o n wit in t his 1- ility ab y li an pt ce 6.4.4 n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss 10 - Control signal to CD changer -R41- Electronic anti-theft coding agen lksw Vo by c o p yri gh t . C op yi Prote cted by 6.5 The radio -R- is equipped with an electronic anti-theft coding sys‐ tem which works in conjunction with the dash panel insert. AG. If the voltage supply for the radio -R- is cut off and then recon‐ nected, the radio will still be operational without the need to enter the radio code again. A prerequisite is that the electronic anti-theft coding system has already been activated for the first time and that the radio -R- is reconnected in the same vehicle. 46 Rep. Gr.91 - Radio, telephone, navigation ht rig py Co t. 12 - CD clock from CD changer -R41- do c um en 11 - CD data in from CD changer -R41- Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 6.5.1 Functional notes After initial activation of the anti-theft coding, an internal radio code is stored in the radio -R- and in the dash panel insert. If the radio -R- is now disconnected from the voltage supply due to re‐ pairs (e.g. radio -R- or battery -A- ) removed and the voltage supply is then reconnected, data is transferred between the radio -R- and the dash panel insert. When this is done, the internal code of the radio -R- is compared with the code in the dash panel insert. If the codes are identical with each other, the dash panel insert will recognise that the con‐ nected radio -R- belongs to the vehicle. The radio -R- is therefore immediately operational without the need to enter the anti-theft code again. If the radio -R- is replaced, the radio code must be entered. Deactivating anti-theft coding ⇒ page 47 Then after switching on the “S contact” via the ignition lock the code is automatically compared between the dash panel insert and the radio -R- . Comparison takes approx. 5 seconds. It must be ensured that a diagnostic unit has not been connected or is not connected during this period of time. After this time, the radio -R- of the vehicle will be ready for oper‐ ation without the need to enter the radio code again even if the voltage supply has been cut off and then reconnected. The anti-theft coding becomes effective and blocks the radio -Rwhen: ♦ The radio -R- is installed in another vehicle or ♦ The dash panel insert is changed. olkswagen AG G. Vanti-theft en A A radio -R- which has been locked the coding does is agby ksw not l o shown when “SAFE” and “1000” is shown in the display when V gu y b ara d e switching the radio -R- on. nt ris ee or ac tho un le Deactivating electronic anti-theft coding pe rm itte d 6.5.2 es, in part or in w l purpos hole ercia , is n m ot com Note ♦ The radio code is stuck on the radio card together with the unit number ⇒ Instruction manual . ♦ The radio card should not be kept in the vehicle for security reasons. Ask the customer for the radio code. ♦ If a radio -R- is renewed, the radio code of the replacement device must be used. ♦ The customer must be informed that the radio code has – Obtain the code of the radio -R- . c o p yri gh t. C op yi The radio -R- automatically displays “SAFE” and then “1000”. ht rig py Co t. – Switch on the radio -R- . do c um en r te o iva r rp fo g n changed. rrectness of i t to the co nform spec a t i h re o n in wit thi s A locked radio -R- will only work again if the correct radio code for the anti-theft coding system is entered. ility ab y li an pt ce au Deactivate the anti-theft coding to release the unit lock ss ⇒ page 47 . agen lksw Vo by Next to the four function buttons, the display shows the position of the radio code to be entered with an “X”. 6. 47 AG. Prote cted by AG. Volkswagen A G do agen Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta ksw2005 ➤ , Jetta 2011 ➤es not Vol gu y b Communication - Edition 04.2010 ara ed ility ab y li an pt ce the four function buttons indicated. Press the relevant function button as many times as necessary until the correct number is shown in the centre of the display. es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n – nte eo ra c ris tho u a sequence, using Enter the code on the radio card in the correct ss Note rrectness of i t to the co nform spec at i h re o n wit in t his – Then press the function button next to the word “ENTER”. The unit is then ready to operate again and switches to its last op‐ erating state. Adapting radio -R- components c o p yri gh t. C op yi Special tools and workshop equipment required Prote cted by – Select “guided fault finding” in the vehicle diagnosis, testing and information system -VAS 5051B- . – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: ♦ Body ♦ Electrical system ♦ 01 - On board diagnosis-capable systems ♦ Corresponding radio system ♦ Radio system functions 48 Rep. Gr.91 - Radio, telephone, navigation AG. Procedure agen lksw Vo by ♦ Vehicle diagnosis, testing and information system -VAS 5051B- ht rig py Co t. 6.6 do c um en If you enter an incorrect radio code to deactivate the electronic lock, “SAFE” first flashes in the display, followed by “1000” again. The entire process can now be repeated again. The number of attempts is shown in the display. If an incorrect radio code is en‐ tered again, the radio -R- will be blocked for approx. one hour, i.e. it cannot be operated. This lock is indicated by the fact that “SAFE” is permanently shown in the display. The process of de‐ activating the anti-theft coding can then be repeated after one hour. Do not forget that only two attempts are allowed, after which the radio -R- will be blocked for one hour. Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 7 Radio system “RCD 310” Radio RCD 310 Note ♦ When dealing with complaints, it is absolutely necessary to Volkswa n AG d AG. and thegeoperation understand the functions agen oes of the communi‐ ksw not l o V cation systems ⇒ Instruction manual . gu by a d ise ran un le pe rm itte d testing and information system VAS 5051. ility ab y li an pt ce r ♦ The anti-theft coding uses a fixed code ⇒ page 56te.e o ho ut ra a c s ♦ In sthe event of repair work or fault finding ⇒ Vehicle diagnosis, check vehicle equipment (radio, clock, convenience electron‐ ics, etc.) in accordance with the ⇒ Electrical system; Rep. Gr. 27 workshop manual and/or the ⇒ instruction manual . 7.1 rrectness of i t to the co nform spec a t i h re o n in wit thi s General description The main features of the RCD 310 radio -R- are, among others, as follows: ♦ 4 x 20 watt loudspeaker channels ♦ Monochrome display ♦ Control for external CD changer -R41♦ Connection for external sound amplifier ♦ DAB operation possible do c um en r te o iva r rp fo g n ♦ Telephone controls (hands-free system) The “RCD 310” radio system consists of the radio -R- and the front and rear loudspeakers. ht rig py Co t. es, in part or in w l purpos hole ercia , is n m ot com ♦ When the battery -A- is reconnected, please remember to agen lksw Vo by Prote cted by c o py rig ht . C op yi The CD drive integrated in the radio -R- can play the following CD formats: AG. ♦ Audio CD ♦ CD-R ♦ CD-RW ♦ MP3 The following formats cannot be played: ♦ CD with diameter of 8 cm ♦ “Mixed CD” (CD with data and audio files) The aerial is installed in the rear side windows. The aerial system includes a “diversity function” integrated in the radio -R- . 7.1.1 Fault finding The radio -R- is equipped with self-diagnosis. For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. 7. 49 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 7.2 Overview of radio system “RCD 310” 1 - Radio -R❑ Connectors ⇒ page 54 ❑ Removing and installing ⇒ page 51 2 - CD changer -R41❑ Optional ❑ In centre console ❑ CD changer -R41n AG. Volkswagen AG do es n wage s ⇒ page 79 k l ot Vo y db gu ara nte eo ra c rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com pe rm itte d un le ility ab y li an pt ce e control 3 - Multimedia system ris tho unit -J650u a ss ❑ Optional ❑ In centre console ❑ Multimedia system con‐ trol unit -J650⇒ page 95 4 - Connection for external au‐ dio sources -R199❑ In centre console ❑ Connection for external audio sources -R199⇒ page 91 r te o iva r rp fo g n ht rig py Co t. c o p yri gh t . C op yi 6 - Rear left treble loudspeaker -R14- / rear right treble loudspeaker -R16❑ Installed in the rear left and right door trims ❑ Loudspeaker systems ⇒ page 106 do c um en 5 - Aerial -R11- / Radio aerial 2 -R93❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . ❑ Aerial systems in sa‐ loons from model year 2011 ⇒ page 179 agen lksw Vo by AG. Prote cted by 7 - Rear left bass loudspeaker -R15- / rear right bass loudspeaker -R17❑ Installed in the rear left and right door trims ❑ Loudspeaker systems ⇒ page 106 8 - Front left bass loudspeaker -R21- / front right bass loudspeaker -R23❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 9 - Front left mid-range loudspeaker -R103- / front right mid-range loudspeaker -R104❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 10 - Front left treble loudspeaker -R20- / front right treble loudspeaker -R22❑ Installed in mirror triangle of the right and left front doors ❑ Loudspeaker systems ⇒ page 106 50 Rep. Gr.91 - Radio, telephone, navigation Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 7.3 Removing and installing radio “RCD 310” Note ♦ The part number for the radio -R- can be found on a sticker on the radio -R- housing. ♦ If the radio -R- has to be renewed, deactivate the electronic anti-theft coding system ⇒ page 56 . rrectness of i t to the co nf o r m spec atio h re n in wit Removing ility ab y li an pt ce ♦ Removal wedge -3409- es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng Special tools and workshop equipment required AG. Volkswagen AG d agen oes ksw not l o V gu y b ara d nte ise r o eo h t u ra a c s s – Remove CD from radio -R- ⇒ Owner's manual . agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi – Remove bolts -arrows- (1.5 Nm). ht rig py Co t. – Remove upper cover together with air vents out of the middle of the dash panel until the underneath bolts of the centre con‐ sole cover can be reached, ⇒ General body repairs, exterior; Rep. Gr. 68 . thi sd o cu m en – Switch off ignition and all electrical consumers and remove ignition key. 7. 51 rrectness of i t to the co nform spec a t i h re o n in wit thi s un le es, in part or in w l purpos hole ercia , is n m ot com pe rm itte d – Carefully lever out cover of centre console using removal wedge -3409- -arrows- and take it off. – Remove bolts -arrows- (1.5 Nm). agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi – Then swing locking bar up in direction of -arrow- and discon‐ nect connector. Rep. Gr.91 - Radio, telephone, navigation ht rig py Co t. – Press together connector locking mechanism in direction of -arrows-. do c um en r te o iva r rp fo g n – Pull the radio -R- out of the installation shaft until you can gain access to the connectors on the back of the radio. 52 ➤ ility ab y li an pt ce AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e s i r Golf Variant 2007 ➤ th, oGolf Variant 2010 ➤ , Jetta 2005 ➤ , Jettante2011 eo u ra Communication - sEdition 04.2010 c sa Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Release connectors -arrows- of aerial connections and dis‐ connect connectors. Installing – Fit connectors on radio -R- . – Push radio -R- straight into the dash panel. Note Never press on the display or the operating buttons when fitting the radio -R- as the radio -R- may be damaged. – Fit the radio -R- with 4 bolts -arrows- (1.5 Nm). – Install centre console cover. – Deactivate the anti-theft coding ⇒ page 56 . AG. Volkswagen AG d agen oes ksw not l o V gu y b ara d nte ise r o eo h t u ra a c s s ht rig py Co t. r fo ng rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce un le – Check the radio -R- code and recode it ⇒ page 57 . 7. 53 agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 “RCD 310” connectors 5 - Multi-pin connector 4, 12pin, CD changer -R41❑ Pin assignment ⇒ page 56 urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p 4 - Multi-pin connector 3, 12pin, telephone ❑ Pin assignment ⇒ page 55 r fo ng 6 - Aerial connection ❑ Connector colour, white ❑ FM2 ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . ❑ Aerial systems in saloons from model year 2011 ⇒ page 179 Rep. Gr.91 - Radio, telephone, navigation AG. 54 agen lksw Vo by Prote cted by c o py rig ht . C op yi 7 - Aerial connection ❑ Connector colour, white ❑ AM/FM ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . ❑ Aerial systems in saloons from model year 2011 ⇒ page 179 rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en 3 - Multi-pin connector 2, 8-pin, CAN bus, telephone ❑ Pin assignment ⇒ page 55 AG. Volkswagen AG d agen oes ksw not l o gu yV b ara d e nte is r o eo h ut ra a c s s ility ab y li an pt ce 2 - Multi-pin connector 1, 8-pin, loudspeaker outputs ❑ Pin assignment ⇒ page 55 un le 1 - Aerial connection ❑ Connector colour, black ❑ DAB ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . ❑ Aerial systems in sa‐ loons from model year 2011 ⇒ page 179 ht rig py Co t. 7.4 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 7.4.1 Multi-pin connector 1, 8-pin, loudspeak‐ er outputs Rear right loudspeaker (+) 2- Front right loudspeaker (+) 3- Front left loudspeaker (+) 4- Rear left loudspeaker (+) 5- Rear right loudspeaker (-) 6- Front right loudspeaker (-) 7- Front left loudspeaker (-) 8- Rear left loudspeaker (-) ility ab y li an pt ce 7.4.2 n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n 1- Multi-pin connector 2, 8-pin, CAN bus, telephone 10 - CAN bus (low) 11 - Telephone mute 12 - Terminal 31 13 - Not assigned 14 - Not assigned 15 - Terminal 30 rrectness of i t to the co nform spec at i h re o n wit in t his 9 - CAN bus (high) 16 - ATA (SAFE) terminal 30 Multi-pin connector 3, 12-pin, telephone AG. Prote cted by 12 - Telephone LF input signal (+) agen lksw Vo by 7–11 - Not assigned c o p yri gh t . C op yi 6 - Telephone LF input signal (-) do c um en 1–5 - Not assigned ht rig py Co t. 7.4.3 7. 55 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 7.4.4 Multi-pin connector 4, 12-pin, CD changer -R41- 1- Audio input left (+) 2- Audio input earth 3- Audio earth from CD changer -R41- 4- Terminal 30 to CD changer -R41- 5- Not assigned 6- CD data out to CD changer -R41- 7- Audio input right (+) 8- Audio left from CD changer -R41- 9- Audio right from CD changer -R41- 10 - Control signal to CD changer -R4111 - CD data in from CD changer -R4112 - CD clock from CD changer -R41- 7.5 Electronic anti-theft coding The radio -R- is equipped with an electronic anti-theft coding sys‐ tem which works in conjunction with the dash panel insert. If the voltage supply for the radio -R- is cut off and then recon‐ nected, the radio will still be operational without the need to enter the radio code again. A prerequisite is that the electronic anti-theft coding system has already been activated for the first time and that the radio -R- is reconnected in the same vehicle. The radio code is determined by means of the vehicle diagnosis, testing and information system -VAS 5051B- . The radio card used in the past and the sticker on the radio -R- have been dis‐ continued. AG. Volkswagen AG d agen oes ksw not l o V gu y b ara d nte ise r o eo h t u ra a diagnosis, testing c vehicle s s Note es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n Deactivating electronic anti-theft coding rrectness of i t to the co nform spec at i h re o n wit in t his 7.5.1 ility ab y li an pt ce In order to find out the radio code, the and information system -VAS 5051B- must be connected “online” (network connection), and the user must possess valid rights to use the programme for requesting radio codes. A locked radio -R- will only work again if the correct radio code for the anti-theft coding system is entered. Using the VAS tester to find out the radio code: – Select “guided fault finding” in the vehicle diagnosis, testing and information system -VAS 5051B- . – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: ♦ Body ♦ Electrical system ♦ Corresponding radio system agen lksw Vo by AG. Prote cted by Rep. Gr.91 - Radio, telephone, navigation c o p yri gh t. C op yi 56 ht rig py Co t. ♦ Radio system functions do c um en ♦ 01 - On board diagnosis-capable systems Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 ♦ Radio code request Your system rights are then determined. The operating data, the VIN and the unit number of the radio -R- are then read out auto‐ matically. Note When a new radio -R- is being installed, it is possible that the vehicle diagnosis, testing and information system -VAS 5051Bcannot read out the unit number of the radio -R- . In this case, please enter the unit number manually. It can be read on a sticker on the radio -R- and is also embossed on the radio -R- . The radio code determined is then shown on the display of the vehicle diagnosis, testing and information system -VAS 5051B- . . Volkswagen AG gen AG does not gu ara nte eo ra c a The radio code must be entered in the radio -R- manually. ksw Vol Deactivating anti-theft coding: un le ss ility ab y li an pt ce – Switch on the radio -R- . by ed ris o th au pe rm itte d The word “SAFE” appears for approx. 10 seconds on the display and then number sequence “1000”. rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com – Enter the radio code by pressing the corresponding function buttons until the right number sequence appears. After the four-digit radio code has been entered, “OK” appears on the display. – Once you have entered the correct radio code, confirm it with the “OK” function button on the display. The radio -R- will be released and is ready for use. r te o iva r rp fo g n Adapting radio components “RCD 310” AG. Special tools and workshop equipment required agen lksw Vo by Prote cted by c o py rig ht . C op yi 7.6 do c um en If the incorrect radio code is entered, it can be immediately cor‐ rected with a further attempt. If an incorrect radio code is entered twice, the radio -R- will be blocked for one hour. Then leave the radio -R- and the ignition on. The process of deactivating the antitheft coding can then be repeated after one hour. Do not forget that only two attempts to enter the code are allowed, after which the radio -R- will be blocked for one hour. ht rig py Co t. Note ♦ Vehicle diagnostic, testing and information system -VAS 5051B- 7. 57 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Procedure – In vehicle diagnostic, testing and information system -VAS 5051B- , select “Guided fault finding”. – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: ♦ Body ility ab y li an pt ce ♦ es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ♦ ♦ Radio system functions rrectness of i t to the co nf o r m spec atio h re n in wit agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi Rep. Gr.91 - Radio, telephone, navigation thi sd o cu m en 58 ht rig py Co t. ♦ n AG. Volkswagen AG do es n wage s k l Electrical system ot g o yV ua b ran ed s i tee r 01 - On board diagnosis-capable systems o h t or u ac a Corresponding radio system ss Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 8 Radio system “RCD 500” Radio RCD 500 Note ♦ When dealing with complaints, it is absolutely necessary to understand the functions and the operation of the communi‐ cation systems ⇒ Instruction manual . ♦ The anti-theft coding uses a fixed code, deactivating anti-theft coding ⇒ page 67 . ♦ In the event of repair work or fault finding ⇒ Vehicle diagnosis, testing and information system VAS 5051. ♦ When the battery -A- is reconnected, please remember to check vehicle equipment (radio, clock, convenience electron‐ ics, etc.) in accordance with the ⇒ Electrical system; Rep. Gr. 27 workshop manual and/or the ⇒ instruction manual . 8.1 General description The radio “RCD 500” consists of the radio -R- , the integrated 6disc CD changer and the loudspeakers in the doors. The radio -R- has a final output stage with an output power of 4 x 20 W. The loudspeakers are designed as a 3-way system in the front and as a 2-way system in the rear. The radio system “RCD 500” is available in a version with loud‐ speakers operated via the 4 internal loudspeaker outputs or in a version with the amplifier -R12- . In this case, the loudspeakers are connected directly to the amplifier -R12- and the loudspeaker outputs of the radio -R- are used for amplifier -R12- input signals. The following loudspeakers are installed with the radio system AG. Volkswagen AG d agen “RCD 500”: oes w s k n l o yV b ♦ A bass loudspeaker, a mid-range loudspeaker and a treble ed ris o loudspeaker in each of the front doors. h ut sa un le The integrated 6-disc CD changer can play the following formats: ♦ Audio CD ♦ CD-R ♦ CD-RW ♦ MP3 The following formats cannot be played: ♦ CD with diameter of 8 cm ht rig py Co t. r fo ng ♦ “Mixed CD” (CD with data and audio files) rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p To extend the functions, connection options are available for am‐ plifier -R12- , CD changer -R41- and telephone. ility ab y li an pt ce s a treble loudspeaker in each of the ♦ A bass loudspeaker and rear doors. ot g ua ran tee or ac 8. 59 agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Note The integrated CD changer has a transport protection device which must be deactivated before installing a new radio -R- . The transport protection device must also be activated before shipping a removed radio -R- . For this, the radio -R- must still be connected to the voltage supply. The aerial is a window aerial and is located in the rear window (saloon). In the Variant, the aerials are located in the rear right side window and in the roof aerial. The aerial system includes a “diversity function” integrated in the radio -R- . 8.1.1 Fault finding The radio -R- is equipped with self-diagnosis. For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. 8.2 Overview of radio system “RCD 500” AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n ility ab y li an pt ce 1 - Radio -R❑ Connectors ⇒ page 64 ❑ Activating and deacti‐ vating transport protec‐ tion device ⇒ page 65 ❑ Removing and installing ⇒ page 61 rrectness of i t to the co nform spec at i h re o n wit in t his 2 - CD changer -R41❑ In centre console ❑ CD changer -R41⇒ page 79 3 - Amplifier -R12❑ Optional ❑ Under left front seat ❑ Amplifier -R12⇒ page 100 . Rep. Gr.91 - Radio, telephone, navigation AG. 60 agen lksw Vo by Prote cted by c o p yri gh t. C op yi 6 - Rear left bass loudspeaker -R15- / rear right bass loud‐ speaker -R17❑ Installed in the rear left and right door trims. ❑ Loudspeaker systems ⇒ page 106 . ht rig py Co t. 5 - Rear left treble loudspeaker -R14- / rear right treble loud‐ speaker -R16❑ Installed in the rear left and right door trims. ❑ Loudspeaker systems ⇒ page 106 . do c um en 4 - Aerial -R11- / Radio aerial 2 -R93❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . AG. Volkswagen AG d agen oes ksw n t l o Golf Variantb2007 ➤ , Golf Variant 2010 ➤ , oJetta gu 2005 ➤ , Jetta 2011 ➤ yV ara d nte ise Communication - Edition 04.2010 r o eo h t u ra a c s loudspeaker s-R21- / front right bass loudspeaker -R23- 8 - Front left mid-range loudspeaker -R103- / front right mid-range loudspeaker -R104❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 . 9 - Front left treble loudspeaker -R20- / front right treble loudspeaker -R22❑ Installed in mirror triangle of the right and left front doors ❑ Loudspeaker systems ⇒ page 106 . Removing and installing radio “RCD 500” ♦ The part number for the radio -R- can be found on a sticker on ♦ If the radio -R- has to be renewed, deactivate the electronic anti-theft coding system ⇒ page 67 . Please inform the cus‐ tomer of the new radio code. agen lksw Vo by c o p yri gh t. C op yi the radio -R- housing. thi sd o cu m en Note ht rig py Co t. 8.3 rrectness of i t to the co nf o r m spec atio h re n in wit es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng ility ab y li an pt ce 7 - Front left bass ❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 . AG. Prote cted by ♦ If the radio code is not known, it can be requested via the es‐ tablished systems. For this, you need the identification number of the radio -R- . It is located on a sticker on the side of the radio -R- . The identification number is also embossed in the material of the side panel of the radio -R- . ♦ The CD changer in the radio -R- has a transport protection device which must be deactivated before installing a new radio -R- . The transport protection device must also be activated before shipping a removed radio -R- . For this, the Radio -Rmust still be connected to the voltage supply. Activating and deactivating transport protection device ⇒ page 65 . Special tools and workshop equipment required ♦ Removal wedge -3409- Removing – Remove CD from radio -R- ⇒ Operating manual . – Switch off ignition and all electrical consumers and remove ignition key. – Remove upper cover together with air vents out of the middle of the dash panel until the underneath bolts of the centre con‐ sole cover can be reached, ⇒ General body repairs, exterior; Rep. Gr. 68 . 8. 61 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Remove bolts -arrows- (1.5 Nm). AG. Volkswagen AG d agen oes ksw not l o gu yV b ara d e nte is r o eo h ut ra a c s s – Remove bolts -arrows- (1.5 Nm) on radio -R- . – Press together connector locking mechanism in direction of -arrows-. AG. Rep. Gr.91 - Radio, telephone, navigation agen lksw Vo by Prote cted by c o py rig ht . C op yi 62 ht rig py Co t. r fo ng – Pull the radio -R- out of the installation shaft until you can gain access to the connectors on the back of the radio -R- . rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce un le – Carefully lever out cover of centre console using removal wedge -3409- -arrows- and take it off. Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Then swing locking bar up in direction of -arrow- and pull out connectors. n AG. Volkswagen AG do es n wage s k l ot g o yV ua b d ran ir se tee o h t or u ac a ss Installing – Fit connectors on the radio -R- and lock them. – Push the radio -R- straight into the dash panel. Note rrectness of i t to the co nform spec at i h re o n wit in t his es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n ility ab y li an pt ce – Release connectors -arrows- of aerial connections and dis‐ connect connectors. Never press on the display or the operating buttons when fitting the radio -R- , as the radio -R- may be damaged. – Fit the radio -R- with 4 bolts -arrows- (1.5 Nm). – Install centre console cover. – Deactivate the anti-theft coding ⇒ page 66 . – Check the radio -R- coding and recode the radio -R⇒ page 67 . do c um en – Deactivate the transport protection device ⇒ page 65 . 8. 63 ht rig py Co t. agen lksw Vo by AG. Prote cted by c o p yri gh t . C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 8.4 “RCD 500” connectors 1 - Multi-pin connector 1, 8-pin, loudspeaker outputs ❑ Pin assignment ⇒ page 64 pe rm itte d rrectness of i t to the co nform spec a t i h re o n in wit thi s es, in part or in w l purpos hole ercia , is n m ot com 4 - Multi-pin connector 4, 12pin, CD changer -R41❑ Pin assignment ⇒ page 65 AG. Volkswagen AG d agen oes ksw not l o gu yV b ara d e nte is r o eo h ut ra a c s s ility ab y li an pt ce 3 - Multi-pin connector 3, 12pin, telephone ❑ Pin assignment ⇒ page 65 un le 2 - Multi-pin connector 2, 8-pin, CAN bus, telephone ❑ Pin assignment ⇒ page 65 1- Rear right loudspeaker (+) 2- Front right loudspeaker (+) 3- Front left loudspeaker (+) 4- Rear left loudspeaker (+) 5- Rear right loudspeaker (-) 6- Front right loudspeaker (-) 7- Front left loudspeaker (-) 8- Rear left loudspeaker (-) 64 Rep. Gr.91 - Radio, telephone, navigation AG. In combination with amplifier -R12- , audio signals from radio -Rare used as input signals for amplifier -R12- . agen lksw Vo by Prote cted by c o py rig ht . C op yi Multi-pin connector 1, 8-pin, loudspeak‐ er outputs ht rig py Co t. 8.4.1 do c um en 6 - Aerial connection ❑ Connector colour trans‐ parent ❑ AM/FM ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . r te o iva r rp fo g n 5 - Aerial connection ❑ Connector colour beige ❑ FM2 ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . AG. Volkswagen AG d agen oes ksw not l o gu yV b ara d e nte is r o e h Golf Variant 2007 ➤ , Golf Variant 2010 ➤or,aJetta ut a c s s 9 - CAN bus (high) 10 - CAN bus (low) 11 - Telephone mute 12 - Terminal 31 13 - Not assigned 14 - Not assigned 15 - Terminal 30 16 - ATA (SAFE) terminal 30 8.4.3 Multi-pin connector 3, 12-pin, telephone 1–5 - Not assigned Prote cted by c o py rig ht . C op yi 8.4.4 AG. 12 - Telephone LF input signal (+) agen lksw Vo by 7–11 - Not assigned ht rig py Co t. 6 - Telephone LF input signal (-) do c um en es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n rrectness of i t to the co nform spec at i h re o n wit in t his Multi-pin connector 2, 8-pin, CAN bus, telephone ility ab y li an pt ce 8.4.2 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Multi-pin connector 4, 12-pin, CD changer -R41- 1- Not assigned 2- Audio earth from CD changer -R41- 3- Not assigned 4- Terminal 30 to CD changer -R41- 5- Not assigned 6- CD data out to CD changer -R41- 7- Not assigned 8- Audio left from CD changer -R41- 9- Audio right from CD changer -R41- 10 - Control signal to CD changer -R4111 - CD data in from CD changer -R4112 - CD clock from CD changer -R41- 8.5 Activating and deactivating transport protection device The transport protection device must be activated before shipping a “RCD 500” and deactivated before installing a new radio -R- . This takes place electronically via the key pad of the radio -R- . When the transport lock has been activated, the player of the CD changer is brought to a “transport position”. 8. 65 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Activating transport protection device: Unit status: “ON” or “OFF”, wiring must be connected to the radio -R- . – Press and hold keys marked with -arrows- simultaneously for at least 5 seconds. The radio -R- unit display shows “TRANSPRT” when the player of the CD changer has moved into transport position. Deactivating transport protection device: – Connect and install the radio -R- . – Press CANCEL key to deactivate transport protection device. 8.6 Electronic anti-theft coding The radio -R- is equipped with an electronic anti-theft coding sys‐ tem which works in conjunction with the dash panel insert. If the voltage supply for the radio -R- is cut off and then recon‐ nected, the radio will still be operational without the need to enter the radio code again. A prerequisite is that the electronic anti-theft coding system has already been activated for the first time and that the radio -R- is reconnected in the same vehicle. 8.6.1 Functional notes After initial activation of the anti-theft coding, an internal radio code is stored in the radio -R- and in the dash panel insert. If the radio -R- is now disconnected from the voltage supply due to re‐ pairs (e.g. radio -R- or battery -A- ) removed and the voltage supply is then reconnected, data is transferred between the radio -R- and the dash panel insert. un le ility ab y li an pt ce When this is done, the internal code of the radio -R-AisG.compared Volkswage genare identicaln AG doe with the code in the dash panel insert. If theolkcodes s no swa t gu V with each other, the dash panel insert will byrecognise that the con‐ ara d nte ise The radio -R- is therefore nected radio -R- belongs to the vehicle. r o eo h immediately operational without the ut need to enter the anti-theft ra a c s s code again. Deactivating anti-theft coding ⇒ page 67 Then after switching on the “S contact” via the ignition lock the code is automatically compared between the dash panel insert and the radio -R- . Comparison takes approx. 5 seconds. It must be ensured that a diagnostic unit has not been connected or is not connected during this period of time. After this time, the radio -R- of the vehicle will be ready for oper‐ ation without the need to enter the radio code again even if the voltage supply has been cut off and then reconnected. The anti-theft coding becomes effective and blocks the radio -Rwhen: ♦ The radio -R- is installed in another vehicle or ♦ The dash panel insert is changed. r fo ng AG. Rep. Gr.91 - Radio, telephone, navigation agen lksw Vo by Prote cted by c o p yri gh t. C op yi 66 ht rig py Co t. A radio -R- which has been locked by the anti-theft coding is shown when “SAFE” and “1000” is shown in the display when switching the radio -R- on. rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p If the radio -R- is replaced, the radio code must be entered. Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Deactivate the anti-theft coding to release the unit lock ⇒ page 67 . 8.6.2 Deactivating electronic anti-theft coding A locked radio -R- will only work again if the correct radio code for the anti-theft coding system is entered. Note ♦ The radio code is stuck on the radio card together with the unit number ⇒ Instruction manual . ♦ The radio card should not be kept in the vehicle for security reasons. Ask the customer for the radio code. ♦ If a radio -R- is renewed, the radio code of the replacement device must be used. ♦ The customer must be informed that the radio code has changed. – Obtain the code of the radio -R- . – Switch on the radio -R- . The radio -R- automatically displays “SAFE” and then “1000”. Next to the four function buttons, the display shows the position of the radio code to be entered with an “X”. – Enter the radio code in the correct sequence, using the four function buttons indicated. Press the relevant function button as many times as necessary until the correct number is shown in the centre of the display. G. Volkswage nA wage If you enter an incorrect radio code to deactivate the electronic lock, “SAFE” first flashes in the display, followed by “1000” again. The entire process can now be repeated again. The number of attempts is shown in the display. If an incorrect radio code is en‐ tered again, the radio -R- will be blocked for approx. one hour, i.e. it cannot be operated. This lock is indicated by the fact that “SAFE” is permanently shown in the display. The process of de‐ activating the anti-theft coding can then be repeated after one hour. Do not forget that only two attempts are allowed, after which the radio -R- will be blocked for one hour. 8.7 Adapting radio components “RCD 500” ht rig py Co t. r fo ng Special tools and workshop equipment required rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p a ss n AG d oes not gu ara nte eo ra c ility ab y li an pt ce Note un le olks – Then press the function button next to the word “ENTER”. The yV db radio -R- is ready for operation again and switches to the last e is r operating mode. ho ut 8. 67 agen lksw Vo by AG. Prote cted by c o py rig ht . C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 ♦ Vehicle diagnostic, testing and information system -VAS 5051B- Procedure – In vehicle diagnostic, testing and information system -VAS 5051B- , select “Guided fault finding”. – Using GoTo button, select “Functions/component” and the fol‐ lowing menu options in succession: ♦ Body ♦ Electrical system ♦ 01 - On board diagnosis-capable systems ility ab y li an pt ce agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Rep. Gr.91 - Radio, telephone, navigation do c um en 68 rrectness of i t to the co nform spec at i h re o n wit in t his es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n ♦ Radio system functions ht rig py Co t. ♦ Corresponding radio system AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 9 Radio system “RCD 510” Radio RCD 510 Note ♦ When dealing with complaints, it is absolutely necessary to understand the functions and the operation of the communi‐ cation systems ⇒ Instruction manual . AG. Volkswagen AG d agen oes ksw not l o gu yV b ara d In the event of repair work or fault finding ⇒ Vehicle diagnosis, e nte is r testing and information system VAS 5051. tho eo u ra a c s s When the battery -A- is reconnected, please remember to ♦ The anti-theft coding uses a fixed code ⇒ page 77 . un le ility ab y li an pt ce ♦ check vehicle equipment (radio, clock, convenience electron‐ ics, etc.) in accordance with the ⇒ Electrical system; Rep. Gr. 27 workshop manual and/or the ⇒ owner's manual . General description The radio “RCD 510” consists of the radio -R- , the integrated 6disc CD changer and the loudspeakers in the doors. The radio -R- has a plug position for the use of SD storage cards for reproducing audio content and an output stage with 4 x 20 W output. The loudspeakers are designed as a 3-way system in the front and as a 2-way system in the rear. The following loudspeakers are installed with the radio system “RCD 510”: AG. ♦ A bass loudspeaker and a treble loudspeaker in each of the rear doors. agen lksw Vo by Prote cted by c o p yri gh t. C op yi ♦ A bass loudspeaker, a mid-range loudspeaker and a treble loudspeaker in each of the front doors. ht rig py Co t. r fo ng The radio system “RCD 510” is available in a version with loud‐ speakers operated via the 4 internal loudspeaker outputs or in a version with the amplifier -R12- . In this case, the loudspeakers are connected directly to the amplifier -R12- and the loudspeaker outputs of the radio -R- are used for amplifier -R12- input signals. rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en 9.1 urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ♦ To extend the functions, connection options are available for am‐ plifier -R12- , CD changer -R41- and telephone. The integrated 6-disc CD changer can play the following formats: ♦ Audio CD ♦ CD-R ♦ CD-RW ♦ MP3 The following formats cannot be played: ♦ CD with diameter of 8 cm ♦ “Mixed CD” (CD with data and audio files) 9. 69 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 Note The internal CD changer has a transport protection device which must be deactivated before installing a new radio -R- . The trans‐ port protection device must also be switched on before shipping a removed radio -R- . For this, the radio -R- must still be connected to the voltage supply. The aerial is a window aerial and is located in the rear window G. Volkswagen AG d n Athe (saloon). In the Variant, the aerials are located rear right oes agein w s k not Vol side window and in the roof aerial. The gu by aerial system includes a ara d e “diversity function” integrated in the nte ris radio -R- . ho ut eo ra c un le Fault findingss a For fault finding, use the vehicle diagnosis, testing and informa‐ tion system -VAS 5051B- in “Guided fault finding” mode. 9.2 Overview of radio system “RCD 510” Prote cted by 5 - Amplifier -R12❑ Optional ❑ Under left front seat ❑ Amplifier -R12⇒ page 100 . 6 - Aerial -R11- / Radio aerial 2 -R93❑ Aerial systems (saloon) ⇒ page 171 . ❑ Aerial systems (Variant) ⇒ page 179 . 70 Rep. Gr.91 - Radio, telephone, navigation AG. 4 - Connection for external au‐ dio sources -R199❑ In centre console ❑ Connection for external audio sources -R199⇒ page 91 agen lksw Vo by c o p yri gh t. C op yi 3 - Multimedia system control unit -J650❑ Optional ❑ In centre console ❑ Multimedia system con‐ trol unit -J650⇒ page 95 ht rig py Co t. 2 - CD changer -R41❑ Optional ❑ In centre console ❑ CD changer -R41⇒ page 79 r fo ng 1 - Radio -R❑ Connectors ⇒ page 74 ❑ Activating and deacti‐ vating transport protec‐ tion device ⇒ page 76 ❑ Removing and installing ⇒ page 71 rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p The radio -R- is equipped with self-diagnosis. ility ab y li an pt ce 9.1.1 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 ❑ Aerial systems in saloons from model year 2011 ⇒ page 179 7 - Rear left treble loudspeaker -R14- / rear right treble loudspeaker -R16❑ Installed in the rear left and right door trims ❑ Loudspeaker systems ⇒ page 106 8 - Rear left bass loudspeaker -R15- / rear right bass loudspeaker -R17❑ Installed in the rear left and right door trims ❑ Loudspeaker systems ⇒ page 106 9 - Front left bass loudspeaker -R21- / front right bass loudspeaker -R23❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 10 - Front left mid-range loudspeaker -R103- / front right mid-range loudspeaker -R104❑ Installed in the front left and right door trims ❑ Loudspeaker systems ⇒ page 106 11 - Front left treble loudspeaker -R20- / front right treble loudspeaker -R22❑ Installed in mirror triangle of the right and left front doors ❑ Loudspeaker systems ⇒ page 106 pe rm itte d ility ab y li an pt ce Removing and installing radio “RCD 510” un le 9.3 AG. Volkswagen AG d agen oes ksw not l o gu yV b ara d e nte is r o eo h ut ra a c s s es, in part or in w l purpos hole ercia , is n m ot com Note rrectness of i t to the co nform spec a t i h re o n in wit thi s ♦ The part number for the radio -R- can be found on a sticker on the radio -R- housing. ♦ If the radio -R- has to be renewed, deactivate the electronic anti-theft coding system ⇒ page 29 . ♦ The integrated CD changer has a transport protection device which must be deactivated before installing a new radio -R- . The transport protection device must also be activated before shipping a removed radio -R- . For this, the radio -R- must still be connected to the voltage supply. Activating and deactivat‐ ing transport protection device ⇒ page 76 . do c um en ht rig py Co t. agen lksw Vo by AG. ♦ Removal wedge -3409- r te o iva r rp fo g n Special tools and workshop equipment required Prote cted by c o py rig ht . C op yi Removing – Remove CD from radio -R- ⇒ Operating manual . – Activate the transport protection device ⇒ page 76 . 9. 71 Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Switch off ignition and all electrical consumers and remove ignition key. – Remove upper cover together with air vents out of the middle of the dash panel until the underneath bolts of the centre con‐ sole cover can be reached, ⇒ General body repairs, exterior; Rep. Gr. 68 . AG. Volkswagen AG d agen oes ksw not l o V gu y b ara d nte ise r o eo h t u ra a c s s – Carefully lever out cover of centre console using removal wedge -3409- -arrows- and take it off. – Pull the radio -R- out of the installation shaft until you can gain access to the connectors on the back of the radio -R- . agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi – Press together connector locking mechanism in direction of -arrows-. 72 Rep. Gr.91 - Radio, telephone, navigation ht rig py Co t. r fo ng – Remove bolts -arrows- (1.5 Nm) on radio -R- . rrectne s s o f i t to the co n form spec atio h re n wit i n thi sd o c um en urposes, in part or in wh ole, cial p is n mer m ot p o c erm or e t a itte v i r d p ility ab y li an pt ce un le – Remove bolts -arrows- (1.5 Nm). Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 – Then swing locking bar up in direction of -arrow- and pull out connectors. ility ab y li an pt ce Installing – Fit connectors on the radio -R- and lock them. Note rrectness of i t to the co nform spec at i h re o n wit in t his – Push the radio -R- straight into the dash panel. Never press on the display or the operating buttons when fitting the radio -R- , as the radio -R- may be damaged. – Fit the radio -R- with 4 bolts -arrows- (1.5 Nm). – Install centre console cover. – Deactivate the anti-theft coding ⇒ page 29 . – Deactivate the transport protection device ⇒ page 76 . – Check the radio -R- coding and recode the radio -R⇒ page 78 . do c um en es, in part or in w l purpos hole ercia , is n m ot p om c r erm o e t a itte riv du p or nl f e g n – AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut of aerial connections and dis‐ ra Release connectors -arrowsa c s s connect connectors. 9. 73 ht rig py Co t. agen lksw Vo by AG. Prote cted by c o p yri gh t. C op yi Golf Variant 2007 ➤ , Golf Variant 2010 ➤ , Jetta 2005 ➤ , Jetta 2011 ➤ Communication - Edition 04.2010 “RCD 510” connectors es, in part or in w l purpos hole ercia , is n m m ot p o c erm or e t a itte iv r du rp o nl f e ng 7 - Aerial connection ❑ Connector colour, white ❑ FM2 ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . ❑ Aerial systems in saloons from model year 2011 ⇒ page 179 8 - Aerial connection ❑ Connector colour, white ❑ AM/FM ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . ❑ Aerial systems in saloons from model year 2011 ⇒ page 179 74 Rep. Gr.91 - Radio, telephone, navigation AG. 6 - Not fitted agen lksw Vo by 5 - Multi-pin connector 4, 12pin, CD changer -R41❑ Pin assignment ⇒ page 28 thi sd o cu m en 4 - Multi-pin connector 3, 12pin, telephone ❑ Pin assignment ⇒ page 27 Prote cted by c o p yri gh t. C op yi 3 - Multi-pin connector 2, 8-pin, CAN bus, telephone ❑ Pin assignment ⇒ page 27 rrectness of i t to the co nf o r m spec atio h re n in wit 2 - Multi-pin connector 1, 8-pin, loudspeaker outputs ❑ Pin assignment ⇒ page 27 AG. Volkswagen AG d agen oes ksw not l o V gu by ara d e nte is r o eo h ut ra a c s s ility ab y li an pt ce 1 - Aerial connection ❑ Connector colour, black ❑ DAB ❑ Aerial system, saloon ⇒ page 171 . ❑ Aerial system, Variant ⇒ page 179 . ❑ Aerial systems in sa‐ loons from model year 2011 ⇒ page 179 ht rig py Co t. 9.4