Transcript
WASHER
Repair Parts List MODEL NUMBER MAT10PSAAL
When requesting service or ordering parts, always provide the following information:
©2005 Maytag Services
- Product Type
- Part Number
- Model Number
- Part Description
Section: CONTROL PANEL Model: MAT10PSAAL
CW11-17
1
Section: CONTROL PANEL No. 1 2 3 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 18 19 20 21 22 23 24 26 26
Part No.
N 22001145 215506 N 22001633 204807 215527 206808 215517 215516L 22001308 212942 410296 206780L 212276 215003 206421 206824 212949 207766 211294 Y215513 33001249 N 33001115 207767 912077 N 33001392 N 33001129 211294 N 22001634 22001348 N Y312953 314531 214610 33001208 210186 215526 206799 N 22001360 22001361 208045 12001277 12001277
Description
Series Qty
PANEL, CONTROL (CHRM) Note: PANEL, CONTROL SCREW, TORX Note: SCREW, CONTROL PANEL WIRE, GROUND Note: WIRE, GROUND GRND.WIRE,SUPP.PLTE TO TOP CVR Note: WIRE, GROUND SCREW Note: SCREW, SWITCH CONTROL SWITCH ASSY. Note: CONTROL SWITCH ASSEMBLY PUSHBUTTON Note: PUSHBUTTON, CONTROL SWITCH BACK BRACKET Note: (ALM) SWITCH, WATER LEVEL Note: SWITCH, WATER LEVEL AIR DOME AND TUBE Note: TUBE, WATER LEVEL SWITCH CLAMP,WATER LEVEL SWTCH TUBE Note: CLAMP, WATER LEVEL TUBE CONSOLE (ALM) SU Note: (ALM) SCREW Note: SCREW, CONSOLE FASTENER Note: CLIP, SCREW RELAY-MOTOR REVERSING Note: RELAY, REVERSING (DPDT) RELAY, SPST 24VDC Note: RELAY, MOTOR (SPST) SCREW Note: SCREW, RELAY TRANSFORMER Note: TRANSFORMER (STEP DOWN) SCREW Note: SCREW, TRANSFORMER SPACER CIRCUIT BOARD Note: SPACER, CONTROL BOARD BATTERY SUPPORT, BATTERY WATER DEFLECTOR Note: SHIELD, CONTROL LOCKNUT Note: LOCKNUT, CONTROL BOARD KIT, BATTERY & SUPPORT Note: BATTERY & SUPPORT KIT BOARD-NLA-MUST REFURBISH Note: BOARD, CONTROL SCREW Note: SCREW, WATER LEVEL SWITCH WIRE HARNESS, MAIN NLA WIRE HARNESS, MAIN RECEPTACLE Note: TERMINAL, EDGEBOARD EDGEBOARD CONNECTOR Note: CONNECTOR, EDGEBOARD BUMPER, LID Note: BUMPER, LID COVER, DISPLAY SCREW, GROUND WIRE TO BASE--NA Note: SCREW, GROUND WIRE SCREW Note: SCREW, CONTROL BOARD SWITCH, OPTIC ASSY. Note: OPTIC SWITCH ASSEMBLY CONNECTOR, EDGEBOARD----NA CONNECTOR, EDGEBOARD HARNESS, WIRE (SENSOR SW'S.) KIT, SURGE SUPPRESSOR Note: SURGE SUPPRESSOR KIT KIT, SURGE SUPPRESSOR Note: SURGE SUPPRESSOR KIT
*Color Code (-)=Not Shown
#=Series, Serial Prefix or Run No., N=Not Available
2
A0 A0 14 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 14 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 14 19
1 4 1 1 2 1 2 1 1 1 1 1 5 2 1 1 1 1 1 4 1 1 1 4 1 1 2 1 1 26 2 1 1 1 2 1 1 1 1 1 1
Section: TOP Model: MAT10PSAAL
CW13-2
3
Section: TOP No.
Part No.
1 211726 2 22001298 207159 3 210186 4 N 216256 5 213501 6 22001311 7 213720 8 211881 9 N 22001309 10 910182 11 22001136 12 301548 13 204807 14 22001342 15 212716 16 205415 17 216255 18 211500 19 Y215699 20 N 206835 21 204445 22 207159
Description
Series Qty
HINGE, BALL CAP, TOP COVER SCREW Note: SCREW, CAP SCREW, GROUND WIRE TO BASE--NA Note: SCREW, GROUND WIRE BRACKET, UNBALANCE Note: BRACKET, PLUNGER SCREW, #6-20 X 1-1/8 INCH Note: SCREW, LID SWITCH LEVER ASSY. (UNBALANCE) Note: UNBALANCE LEVER ASSEMBLY SPRING GROMMET, CORD TOP, MAIN (ALM)----NA Note: TOP (ALM) SCREW Note: SCREW, PLUNGER BRACKET LEVER, UNBALANCE CLAMP, GROUND (W/SCREW) GRND.WIRE,SUPP.PLTE TO TOP CVR Note: GROUND WIRE, SUPPORT PLATE LID W/LEGEND (ALM)----NA Note: (W/LEGEND-ALM) BUMPER, LID SWITCH, LID (W/O TUB LIGHT) PLUNGER, UNBALANCE Note: PLUNGER, LID SWITCH WASHER,BRACKE TO TOP COVER Note: WASHER, BRACKET BRACKET,SWITCH & FUSE Note: BRACKET, SWITCH & FUSE POWER CORD Note: CORD, POWER SCREW & FASTENER ASY. Note: SCREW & FASTENER ASSEMBLY SCREW Note: SCREW, BRACKET
*Color Code (-)=Not Shown
#=Series, Serial Prefix or Run No., N=Not Available
4
A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0
2 1 1 2 1 2 1 1 1 1 2 1 1 1 1 2 1 1 2 1 1 2 1
Section: CABINET Model: MAT10PSAAL
CW12-1
5
Section: CABINET No.
Part No.
211294 1 N 211878 1 212985 2 213846 3 214812 4 215058 5 N 22001303 6 212982 7 Y013783 205161 8 22001275 8 22001604 214337 9 211111 10 214768 11 216078L 12 215057 13 200461 14 216169 22001900 15 22001608 15 22001190 16 205828 17 216170 18 214376 19 200961 20 22001304 21 204439 22 211294 23 212276 24 213007 25 213122 25 213121 26 N 313561 27 22001187 28 22001186
Description
Series Qty
SCREW Note: SCREW, PLATE PLATE, ACCESS PLATE, ACCESS (W/HOLE) Note: PLATE, ACCESS (W/HOLE) GUARD, BELT BRACKET,WATER VALVE Note: BRACKET, WATER VALVE PAD, CABINET BUMPER CABINET (ALM)----NA Note: (ALM) FASTENER, PANEL GASKET, INLET HOSE Note: WASHER, INLET HOSE CLAMP - 15/16" Note: CLAMP, WATER VALVE VALVE, WATER VALVE, WATER 120V 60HZ SCREEN, VALVE HOSE COUPLING Note: COUPLING, HOSE DRAIN HOSE, 4 FOOT Note: HOSE, DRAIN PANEL, FRONT (ALM) SUB Note: (ALM) DRAIN HOSE Note: HOSE, INTERNAL DRAIN HOSE CLAMP - 1-5/8 INCH Note: CLAMP, HOSE CLAMP,HOSE-INJEC.HOSE TO VALVE Note: CLAMP, HOSE PREVENTER, BACK FLOW Note: PREVENTOR, BACK FLOW INJECTOR HOSE & BACKFLOW ASSY. Note: INJECTOR HOSE & CLAMP KIT HOSE, INJECTOR HOSE, INLET ASSY. Note: INLET HOSE ASSEMBLY CLAMP, HOSE SPACER, FRONT PANEL SCREEN WASHER, INLET HOSE INJECTOR ASSY., WATER Note: WATER INJECTOR ASSEMBLY SCREW & FSTNER ASSY(FRT.PANEL) Note: SCREW & FASTENER ASSEMBLY SCREW Note: SCREW, BELT GUARD SCREW Note: SCREW, VALVE BRACKET SCREW, CABINET Note: SCREW, CABINET SIDES SCREW,CBNT.TO FRNT OF BASE--NA Note: SCREW, CABINT SCREW Note: SCREW, CABINET SCREW----NA Note: SCREW, WATER VALVE INJECTOR (UPR) Note: INJECTOR (UPR) INJECTOR (LWR) Note: INJECTOR (LWR)
*Color Code (-)=Not Shown
#=Series, Serial Prefix or Run No., N=Not Available
6
A0 A0 A0 A0 A0 A0 A0 A0 A0 15 A0 15 A0 A0 A0 A0 A0 A0 A0 15 15 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0
2 1 1 1 1 2 1 2 2 1 1 1 2 1 1 1 1 2 1 1 1 1 2 1 2 2 1 2 3 1 6 2 3 2 1 1
Section: TUB Model: MAT10PSAAL
CW17-1
7
Section: TUB No.
Part No.
Description
1 2 3 4 4 5 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
208543 212942 211130 200744 205254 22001606 22001299 Y22001201 204012 211641 22001142 410296 211047 Y0A4298 215532 211100 215980 Y212989 201011 206478 211618 202574 211210 200824 204013 22001141 22001115 Y015667 Y054867 015666
AGITATOR (W/LOCK SCREW) Note: AGITATOR (W/LOCK SCREW) AIR DOME AND TUBE Note: TUBE, WATER LEVEL SWITCH LINER, TUB BEARING BOLT & GASKET ASSY.(SHORT) Note: BOLT & GASKET ASSEMBLY (SHORT) BOLT & GASKET ASSEMBLY (LONG) Note: (LONG) COVER ASSY., TUB TUB COVER & GASKET ASSEMBLY Note: TUB COVER & GASKET ASSEMBLY GASKET, TUB COVER Note: GASKET, TUB COVER MOUNTING STEM REPAIR KIT CLAMP, 1-1/16" Note: CLAMP (1-1/16") RING, BALANCE (W/CONCRETE) Note: RING, BALANCE (W/CONCRETE) CLAMP,WATER LEVEL SWTCH TUBE Note: CLAMP, WATER LEVEL SWITCH TUBE NUT, CLAMPING (INNER TUB) SEAL, AGITATOR DRIVE SHAFT AGITATOR CAP - BLACK Note: CAP, AGITATOR WASHER, CUSHION PLUG, FILTER HOLE Note: PLUG, TUB HOSE, OUTER TUB TO PUMP Note: HOSE, OUTER TUB CLAMP,HOSE (TUB OUTLET) Note: CLAMP, HOSE SCREW & WASHER FOR AGITATOR Note: SCREW & WASHER ASSEMBLY SET SCREW, MTG. STEM Note: SET SCREW, MOUNTING STEM CLAMP, HOSE Note: CLAMP, TUB HOSE WASHER,CLAMPING NUT(STAINLESS) Note: WASHER, CLAMPING NUT BEARING, TUB TUB BEARING REPAIR KIT TUB, INNER (LARGE-GRY) Note: TUB, INNER TUB, OUTER (LARGE) RETAINING RING WASHER, LOCK WASHER,RETAINING(CENTER SEAL)- Note: WASHER, RETAINING
*Color Code (-)=Not Shown
Series Qty
#=Series, Serial Prefix or Run No., N=Not Available
8
A0 A0 A0 A0 A0 15 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0
1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 3 2 1 1 1 1 1 1 1 1 1 1 1 3 1
Section: BASE Model: MAT10PSAAL
LW10-13
9
Section: BASE No.
Part No.
Description
1 2 3 4 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
302699 22001172 Y015627 205254 200744 213100 22001300 203725 203956 213073 214768 216416 901220 Y212989 200461 202574 311426 22001301 200816 201805 211028 911852 206505
22
205132
22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 44 45
205131 215098 Y052734 Y052785 210385 211949 202203 204998 212979 210684 Y015408 210186 211880 213121 Y053241 205000 214956 Y054867 211100 211124 211125
LEG, ADJUSTABLE (W/NUT) BASE (W/DAMPER PADS) SCREW, HEX HD CAP 5/16 X 5/8 BOLT & GASKET ASSEMBLY (LONG) Note: (LONG) BOLT & GASKET ASSY.(SHORT) Note: BOLT & GASKET ASSEMBLY (SHORT) BRACE, TUB SPRING, CENTERING DAMPER W/BOLT & CLIP Note: DAMPER (W/BOLT & CLIP) DAMPER PAD KIT (W/POLY LUBE) Note: DAMPER PAD KIT (W/POLY LUBE) WASHER, DOUBLE Note: WASHER, DOUBLE DRAIN HOSE, 4 FOOT Note: HOSE, INTERNAL DRAIN BOLT, EYE/CENTERING SPRING WIRE, GROUND HOSE, OUTER TUB TO PUMP Note: HOSE, OUTER TUB HOSE CLAMP - 1-5/8 INCH Note: CLAMP, HOSE CLAMP, HOSE Note: CLAMP, HOSE NUT, WASHERED LOCK Note: NUT, MOTOR BASE MOUNT, MOTOR LOWER-ASSEMBLY PULLEY, MOTOR (W/SET SCREW) Note: PULLEY, MOTOR (W/SET SCREW) MOTOR (ONE SPEED) DEFLECTOR,WATER (DRIVE TUBE) Note: DEFLECTOR, WATER (DRIVE TUBE) WASHER, LOCK (BRACE) Note: WASHER, LOCK (BRACE) SWITCH, MOTOR START Note: SWITCH, MOTOR EXTERNAL START PROD. # 201664-15 & 2054633 SWITCH, MOTOR START Note: SWITCH, MOTOR EXTERNAL START PROD. # 201664-14, 2054634 & 201800-4 SWITCH, MOTOR START Note: SWITCH, MOTOR EXTERNAL START PROD. # 207424-2 SHIELD, MOTOR NUT Note: NUT, BRACE (TUB) NUT,BRACE TO DAMPER Note: NUT, BRACE (DAMPER) NUT, LOCK NUT, EYEBOLT PUMP AS PAK GLIDE KIT (4 W/POLY LUBE) WASHER, TUB BRACE FOOT, RUBBER SCREW, BEARING INSERT SCREW, GROUND WIRE TO BASE--NA Note: SCREW, GROUND WIRE SCREW, HEX HD #10 X 1/2 INC Note: SCREW, PUMP SCREW Note: SCREW, MOTOR SHIELD SET SCREW, PULLEY Note: SET SCREW, MOTOR PULLEY GLIDE & SPRING KIT MOUNT, MOTOR/UPPER Note: PLATE, MOTOR MOUNT (UPR) WASHER, LOCK Note: WASHER, LOCK (BRACE) WASHER, CUSHION Note: WASHER, CUSHION (BRACE) V BELT, PUMP V BELT,DRIVE PULLEY Note: V BELT, DRIVE PULLEY
*Color Code (-)=Not Shown
Series Qty
#=Series, Serial Prefix or Run No., N=Not Available
10
A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0
4 1 6 2 1 3 3 1 1 3 1 3 1 1 1 1 3 1 1 1 1 1 1
A0
1
A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0
1 1 3 6 4 3 1 1 3 4 1 1 3 1 1 1 1 3 3 1 1
Section: TRANSMISSION Model: MAT10PSAAL
LW15-14
11
Section: TRANSMISSION No.
Part No.
1 206628 2 207153 3 206713 4 N 215411 5 215415 6 206625 7 215394 8 211483 9 206602 10 206629 11 215401 12 215395 13 215417 14 210690 15 Y058700 16 215581 17 206685 18 206708
Description
Series Qty
COVER, TRANSMISSION SHAFT, AGITATOR (W/SPRING) Note: SHAFT, AGITATOR (W/SPRING) GEAR, BEVEL SHAFT, CENTER COLLAR, LOWER Note: COLLAR (LWR) HOUSING, TRANSMISSION Note: HOUSING, TRANSMISSION WASHER, BEVEL GEAR WASHER, SPLINED SEAL, LIP (CENTER SHAFT) PIN, COLLAR PINION PLATE, CLUTCH SCREW, TRANSMISSION COVER SEAL, RUBBER SILASTIC,ADH.SEALANT Note: SILASTIC, ADHESIVE SEALANT SPRING, AGITATOR SHAFT BLOCK, TORQUE AND YOKE ASSEMBL TRANSMISSION Note: TRANSMISSION (COMPLETE)
*Color Code (-)=Not Shown
#=Series, Serial Prefix or Run No., N=Not Available
12
A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0
1 1 1 1 1 1 1 1 1 1 1 1 8 1 1 1 1 1
Section: CLUTCH, BRAKE & BELTS Model: MAT10PSAAL
LW15-15
13
Section: CLUTCH, BRAKE & BELTS No.
Part No.
1 200720 2 200835 3 211043 4 211045 5 201190 6 201126 7 211059 8 211042 9 N 211038 10 211039 11 213325 12 211000 13 211375 14 213326 15 211089 16 211041 17 Y038315 18 211090
Description
Series Qty
BALL BEARING, RADIAL BEARING, BRAKE ROTOR DRUM, BRAKE HOUSING, BRAKE BRAKE ASSEMBLY Note: PACKAGE, BRAKE ROTOR, BRAKE (W/FACING) PULLEY, DRIVE GASKET, BRAKE DRUM CAP, OIL RETAINER RETAINER, BRAKE SPRING CLIP, RETAINER SCREW,HEX HEAD (BRAKE DRUM) Note: SCREW, BRAKE DRUM (HEX HD) SCREW,STOP LUG(CENTER SHAFT) Note: SCREW, DRIVE LUG SCREW, RETAINING CLIP Note: BOLT, RETAINING CLIP LUG, STOP SPRING, BRAKE TOOL, BRAKE PKG ASSY Note: TOOL, BRAKE PACKAGE ASSEMBLY WASHER, LOCK Note: WASHER, LOCK (DRIVE LUG)
*Color Code (-)=Not Shown
#=Series, Serial Prefix or Run No., N=Not Available
14
A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0 A0
1 1 1 1 1 1 1 1 1 1 1 8 1 1 1 1 1 1
