Transcript
Material Safety Data Sheet
U.S. Department of Labor
May be used to comply with OSHA's Hazard Communication Standard, 29 CFR 1910.1200. Standard must be consulted for specific requirements.
Occupational Safety and Health Administration (Non-Mandatory Form) Form Approved OMB No. 1218-0072
IDENTITY (As Used on Label and List) OPC Drum in DK-18 for DP80F and DP85F Section I Manufacture's Name
Emergency Telephone Number
TOSHIBA TEC CORPORATION Address (Number, Street, City, State, and ZIP Code)
Telephone Number for Information
Shuwa-Shiba Park Bldg. A, 4th floor 2-4-1, Shibakoen Minato-ku, Tokyo 105, JAPAN
+81-3-3438-6948 Date Prepared 1-Nov-99 Signature of Preparer (optional)
Section II - Hazardous Ingredients/Identity Information Hazardous Components (Specific Chemical Identity; Common Name(s))
Coating Layer
Other Limits
OSHA PEL ACGIH TLV
Recommended
CAS No.
Binder resin Photosensitive material
+++ +++
N.A. N.A.
N.A. N.A.
N.A. N.A.
Pigment
+++
N.A.
N.A.
N.A.
N.A.
N.A.
N.A.
Substrate
% (optional) <1
> 99
Aluminum +++ +++: Suplier' s confidential information Section III - Physical/Chemical Characteristics Boiling Point
Flash Point
N. A. Vapor Pressure (mm Hg.)
N. A. No data available
Melting Point N. A.
Density (g/cm3)
pH 2.7
Explosion Properties
N. A. Flammability
N. A. Oxidizing Properties
N. A. Ignition Temperature
N. A. Solubility in Water
(Degrees Centigrade) Partition Coefficient, n-octagonal/Water
Insoluble
N. A. N. A.
Appearance and Odor Green, solid cylinder and odorless Section IV - Fire and Explosion Hazard Data Flash Point (Method used)
Flammable Limits
N. A.
LEL
UEL
N.A.
N.A.
Extinguishing Media Water, foam, CO2 and dry chemicals Extinguishing Media to Avoid None Special Firefighting Procedures None Unusual Fire and Explosion Hazards This materials has no unusual fire or explosion hazards. Protection of Firefighters No special equipment is required. (Reproduce locally)
OSHA 174, Sept. 1985 * N. A.
Not Available
Material Safety Data Sheet
U.S. Department of Labor
May be used to comply with OSHA's Hazard Communication Standard, 29 CFR 1910.1200. Standard must be consulted for specific requirements.
Occupational Safety and Health Administration (Non-Mandatory Form) Form Approved OMB No. 1218-0072
IDENTITY (As Used on Label and List) Toner in TK-18 for DP80F and DP85F Section I Manufacture's Name
Emergency Telephone Number
TOSHIBA TEC CORPORATION Address (Number, Street, City, State, and ZIP Code)
Telephone Number for Information
Shuwa-Shiba Park Bldg. A, 4th floor
+81-3-3438-6948
2-4-1, Shibakoen
Date Prepared
Minato-ku, Tokyo 105, JAPAN
1-Nov-99 Signature of Preparer (optional)
Section II - Hazardous Ingredients/Identity Information Hazardous Ingredients: Chemical Name : Carbon black
WT%: 1 -5 %
CAS No. : 1333-86-4
OSHA Z-Tables : 3.5mg/m3
NTP : Not listed
ACGIH-TLV : 3.5mg/m3
IARC Monographs : Group 2B Major Ingredients: [Generic Name]
[CAS No.]
[WT%]
Polyester resin
+++
>90 %
Carbon black
1333-86-4
1- 5 %
Polyolefin wax
+++
1- 5 %
Organic pigment
+++
1- 5 %
Amorphous silica
+++
<1%
+++: Suplier' s confidential information Section III - Physical/Chemical Characteristics Boiling Point
Flash Point N. A.
Vapor Pressure (mm Hg.)
N. A. Melting Point
No data
N. A. Density (g/cm3)
available pH
1.2 Explosion Properties
N. A. Flammability
No data
No data available Oxidizing Properties
available Ignition Temperature
No data available Solubility in Water
(Degrees Centigrade)
450
Partition Coefficient, n-octagonal/Water Negligible
Appearance
N. A.
Physical State:
Solid
Form:
Powder
Color:
Black
Softening Point
Faint odor
(Degrees Centigrade)
Odor Section IV - Fire and Explosion Hazard Data Flash Point (Method used) N. A. Extinguishing Media
Particle Size (um)
Flammable Limits
5 - 15
120 - 130 LEL
UEL
N.A.
N.A.
Water spray, foam, CO2 and dry chemicals Extinguishing Media to Avoid Full water jet Special Firefighting Procedures None Unusual Fire and Explosion Hazards If dispersed in air, like most finely divided organic powders, may form an explosive mixture. Protection of Firefighters Use self-contained breathing apparatus (SCBA). (Reproduce locally) OSHA 174, Sept. 1985 * N. A. Not Aplicable
