Transcript
Small Engine Parts PARTS LIST NO.
530163179 Replaces 163179 -- 3/07/07
DATE
3/04/08
44
41
40
39
46
38
51 52
59
60
32 34
53 54
62
35
36
61
63
26
All repairs, adjustments and maintenance not described in the Operator’s Manual must be performed by qualified service personnel.
37
47
56 57 58
27
WARNING
45
49
1
PAGE NO.
TYPE 1---3
43
50
MAC CAT 436
Note: Illustration may differ from actual model due to design changes
42
48
CHAIN SAW MODEL(s)
r PARTS LIST
31
29
30
25
28 24
23
33 22 21
55
Kit--Oil Check Valve
64 66 68
65
20
67
19
18
15
16
17 8
69
14 13 12 71 72
70 Ref. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21. 22. 23. 24. 25. 26.
Part No. 530047963 530047608 530042082 530015123 530016018 530015843 530036142 530047583 530015940 530015814 530044896 538029933 530014381 530015805 530038238 530015814 530029850 530016132 530010846 530071666 530023817 530016080 530055723 530015892 530055708 530069232
9
10
4
11 73
7
Description Assy.--- Isolator Strap --- Limiter Spring --- Isolator Washer Screw Screw Sleeve--- AV Spring Handle--- Front Screw Screw Bar --- 14” Chain 14” Kit--- Assy Spike(incl.14) Screw Plate--- Bar Mounting Screw Chain Catcher Screw Assy--- Oil Cap Kit--- Oil Check Valve Spring --- Starter Dog Screw Baffle--- Air Screw Housing --- Fan Kit--- Rope
n = NEW PART NUMBER FOR THIS
IPL
Ref. 27. 28. 29. 30. 31. 32. 33. 34. 35. 36. 37. 38. 39. 40. 41. 42. 43. 44. 45. 46. 47. 48. 49. 50. 51. 52.
Part No. 530056402 530027531 530037817 530015920 530016134 530015127 530039209 530016133 530047192 530015922 530023877 530069216 530047631 530047602 530047581 530015906 530015886 530036098 530036097 530042082 530069572 530047582 530015814 530053274 530071385 530015875
Description Handle--- Starter Spring --- Recoil Pulley--- Starter Screw Nut--- Flywheel Washer--- Flywheel Assy--- Flywheel Bolt--- Bar Assy--- Fuel Cap Nut--- ”U” --- Type Fitting --- fuel line Kit--- Fuel line (large) Grommet--- Cable Cable--- Throttle Cover--- Rear Handle Screw Screw Lockout--- Throttle Trigger--- Throttle Spring Kit--- Switch Handle --- Rear Screw Assy. Isolator --- lower Kit--- Isolator (Upper) Screw
K= REFER TO THE SERVICE REFERENCE
Ref.
Part No.
53. 54. 55. 56.
530047605 530049005 530056597 530071259
57. 58. 59. 60. 61.
530037820 530049477 530016064 530019206 530047663
62. 63. 64. 65. 66.
530038373 530037821 530030189 530015907 530047061
67. 68. 69. 70. 71. 72. 73.
530015611 530014949 530054736 530015917 530015826 530038593 530069611
6
3
2
5 1
Description Knob --- Choke Grommet--- Knob Assy--- Chassis Kit--- Oil Pump (Incls. 57,58,60) Gear--- Worm Spring Elbow--- Oil Pickup Screw Seal Block Assy--- Oil Pickup (Incl. 62--- 64) Pick--- up Oiler Filter--- Oil Plug --- Oil Filter Washer--- Thrust Assy.--- Clutch Drum w/bearing Washer--- Clutch Assy. Clutch Assy--- Chain Brake Nut--- Bar Mounting Pin--- Retainer Retainer Kit--- Bar Adjust (incl. 71 & 72)
INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)
PARTS LIST NO.
530163179 Replaces 163179 -- 3/07/07
DATE
3/04/08
CHAIN SAW MODEL(s)
r PARTS LIST
MAC CAT 436
Note: Illustration may differ from actual model due to design changes
2
PAGE NO.
TYPE 4
42
27 26
43
44
WARNING
41
45
40
39
46
38
48
49
56 57 58
50
51 52
59
34
53 54
60
32
36
61
62
35
37
47
63
25
All repairs, adjustments and maintenance not described in the Operator’s Manual must be performed by qualified service personnel.
31
29
30
28 24
23
33 22 21
55
Kit--Oil Check Valve
64 66 68
65
20
67
19
18
15
16
17 8
69
14 13 12 71 72
70 Ref. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21. 22. 23. 24. 25. 26.
Part No. 530047963 530047608 530042082 530015123 530016018 530015843 530036142 530047583 530015940 530015814 530044896 538029933 530014381 530015805 530038238 530015814 530029850 530016132 530010846 530071666 530023817 530016080 530055723 530015892 530056333 530069232
9
10
4
11 73
7
Description Assy.--- Isolator Strap --- Limiter Spring --- Isolator Washer Screw Screw Sleeve--- AV Spring Handle--- Front Screw Screw Bar --- 14” Chain 14” Kit--- Assy Spike(incl.14) Screw Plate--- Bar Mounting Screw Chain Catcher Screw Assy--- Oil Cap Kit--- Oil Check Valve Spring --- Starter Dog Screw Baffle--- Air Screw Housing --- Fan Kit--- Rope
n = NEW PART NUMBER FOR THIS
IPL
Ref. 27. 28. 29. 30. 31. 32. 33. 34. 35. 36. 37. 38. 39. 40. 41. 42. 43. 44. 45. 46. 47. 48. 49. 50. 51. 52.
Part No. 530056402 530027531 530037817 530015920 530016134 530015127 530039209 530016133 530047192 530015922 530023877 530069216 530047631 530047602 530047581 530015906 530015886 530036098 530036097 530042082 530069572 530047582 530015814 530053274 530071385 530015875
Description Handle--- Starter Spring --- Recoil Pulley--- Starter Screw Nut--- Flywheel Washer--- Flywheel Assy--- Flywheel Bolt--- Bar Assy--- Fuel Cap Nut--- ”U” --- Type Fitting --- fuel line Kit--- Fuel line (large) Grommet--- Cable Cable--- Throttle Cover--- Rear Handle Screw Screw Lockout--- Throttle Trigger--- Throttle Spring Kit--- Switch Handle --- Rear Screw Assy. Isolator --- lower Kit--- Isolator (Upper) Screw
K= REFER TO THE SERVICE REFERENCE
Ref.
Part No.
53. 54. 55. 56.
530047605 530049005 530056596 530071259
57. 58. 59. 60. 61.
530037820 530049477 530016064 530019206 530047663
62. 63. 64. 65. 66.
530038373 530037821 530030189 530015907 530047061
67. 68. 69. 70. 71. 72. 73.
530015611 530014949 530054739 530015917 530015826 530038593 530069611
6
3
2
5 1
Description Knob --- Choke Grommet--- Knob Assy--- Chassis Kit--- Oil Pump (Incls. 57,58,60) Gear--- Worm Spring Elbow--- Oil Pickup Screw Seal Block Assy--- Oil Pickup (Incl. 62--- 64) Pick--- up Oiler Filter--- Oil Plug --- Oil Filter Washer--- Thrust Assy.--- Clutch Drum w/bearing Washer--- Clutch Assy. Clutch Assy--- Chain Brake Nut--- Bar Mounting Pin--- Retainer Retainer Kit--- Bar Adjust (incl. 71 & 72)
INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)
PARTS LIST NO.
530163179 Replaces 163179 -- 3/07/07
DATE
3/04/08
MAC CAT 436
Note: Illustration may differ from actual model due to design changes
40
41
42
CHAIN SAW MODEL(s)
r PARTS LIST
3
PAGE NO.
Type 5
28 27 26
WARNING
39 38 37
All repairs, adjustments and maintenance not
36
35
described in the Operator’s Manual must be
34
performed by qualified service personnel.
33 29 30
43
58
45
44
46 47 48 49 50
59 60
32 51 52
55
54
22
23
21 53 Kit--Oil Vent 19
56
20
57 61
25
24
31
62 63 15
16
18
17
7
14 64 65
13 12 11 66
68 69
67
8
9
4 6
10
5
3
2
1
70 Ref. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21. 22. 23. 24. 25. 26. 27.
Part No. 530059667 530047608 530059668 530015158 530016018 530015843 530047583 530015940 530015814 530044896 538029933 530014381 530016439 530016132 530038238 530015814 530029850 530016133 530010846 530071666 530016134 530016080 530037817 530055723 530015892 530056333 530069232
Description
Ref.
Assy.--Isolator Limiter Strap Spring--Isolator Washer Screw Screw Front Handle Screw Screw Bar -- 14” Chain -- 14” Kit--Spike (Incl. 13) Screw Screw Plate--Bar Mount. Screw Chain Catcher Bolt--Bar Assy--Oil Cap Kit--Oil Vent Nut--Flywheel Screw Starter Pulley Baffle--Air Screw Housing--Fan Kit -- Rope
n = NEW PART NUMBER FOR THIS
IPL
Part No.
28. 29. 30. 31. 32. 33. 34. 35. 36. 37. 38. 39. 40. 41. 42. 43. 44. 45. 46. 47. 48. 49. 50. 51. 52. 53.
530056402 530027531 530015920 530015127 530039187 530047192 530023877 530069216 530016149 530015775 530047581 530015886 530015906 530036098 530036097 530047582 LLLLL LLLLL 530071958 530015875 530059668 530057473 530057474 530049005 530015922 530058733
54.
530015907
Description Handle--Starter Spring--Recoil Screw Washer--Flywheel Assy--Flywheel Assy--Fuel Cap Fitting--fuel line Kit--Fuel line (large) Spring--Switch Screw Cover--Rear Handle Screw Screw Throttle Lockout Trigger--Throttle Handle -- Rear Screw Assy Isolator--lower Kit--Isolator (Upper) Screw Spring--Isolator Lever--Switch Lever--Choke Grommet--Knob Nut--”U”--Type Kit--Chassis Assy. fuel lines and caps ) Washer--Thrust
K= REFER TO THE SERVICE REFERENCE
Ref.
Part No.
55.
530047061
56. 57. 58.
530015611 530014949 530071259
59. 60. 61. 62. 63.
530037820 530049477 530016064 530019206 530047663
64. 65. 66. 67. 68. 69. 70.
530038373 530056533 545139901 530015917 530015826 530038593 530069611
Description Assy.--Clutch Drum w/bearing Washer--Clutch Assy. Clutch Kit -- Oil Pump (incl. 59,60,62) Gear--Worm Spring Elbow--Oil Pickup Screw Seal Block Assy--Oil Pick--up (Incl. 64,65) Pick--up Oiler Filter--Oil Assy.--Chain Brake Nut--Bar Mounting Pin--Bar Adjust Retainer Kit--Bar Adjusting (incl. # 68,69)
INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)
PARTS LIST NO.
530163179 Replaces 163179 -- 3/07/07
DATE
3/04/08
TYPE 1---3
All repairs, adjustments and maintenance not described in the Operator’s Manual must be performed by qualified service personnel.
1
12 8
3
7
9
4 6
5
10 35
4
PAGE NO.
2
38 36
MAC CAT 436
Note: Illustration may differ from actual model due to design changes
WARNING
37
CHAIN SAW MODEL(s)
r PARTS LIST
11 13
34 33
14
32
16
31
15
17
30 29 26 28
21
27
20 25
Engine Gasket Kit 39
Ref.
Part No.
1. 2. 3. 4. 5. 6.
530016153 530056924 530047213 530015780 530095646 530069247
7.
530069216
8. 9. 10. 11. 12.
530035526 530054144 952030150 530016136 530049117
13. 14. 15. 16. 17. 18.
530015814 530039167 530047442 530037652 530049870 530016132
19
22 23
18
24 40
Description
Ref.
Screw Shield--Cylinder Assy--Air Purge Screw Assy--Fuel Pick--up Kit--Line Purge/Carb. (Small Dia) Kit--Line Purge/Tank (large line) Grommet--Carb Adjust. Seal--Carb Adapter Spark Plug (RCJ--7Y) Clip--High Tension Lead Assy--Wire Harness (includes switch) Screw Module--Ignition Strap--Ground Insulator--Heat Back Plate--Muffler Screw
n = NEW PART NUMBER FOR THIS
IPL
Part No.
19. 20. 21. 22.
530036103 530037813 530069608 530047207
23. 24. 25. 26. 27. 28. 29. 30.
530047062 530037935 530056363 530038729 530015697 530071408 530071412 530069608
31. 32. 33. 34. 35.
530016187 530049700 530016386 530069608 -----530069722 530071621
Description Screen--Spark Diffuser--Muffler Gasket--Muffler (kit) Assy--Muffler (Incl. 17--21) Assy--Crankshaft Cap--Crankcase Assy--Seal & Bearing Ring--Piston Retainer -- Piston Pin Kit--Piston -- (incl. 26--27) Kit--Cylinder Gasket--Carb. Adapter (kit) Screw Carb. Adapter Screw Carb. Gasket (kit) Kit--Carburetor (WT--391) (WT--625)
K= REFER TO THE SERVICE REFERENCE
Ref. 36. 37. 38. 39. 40.
Part No. 530047604 530016101 530037793 530031135 530069608
Description Housing--Air Filter Nut Air Filter -- Foam Wrench--Bar Kit--Engine Gasket (incl. 34,30,21)
Not Shown 530163664 530163665 530163666 530054781
Manual-- (Scan) Manual -- (Euro I) Manual -- (Euro II) Decal--Warning
INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)
PARTS LIST NO.
530163179 Replaces 163179 -- 3/07/07
DATE
3/04/08
TYPE 4
WARNING
2 12 3
7
9
38
4 6
5
10 35
5
PAGE NO.
1
8
36
MAC CAT 436
Note: Illustration may differ from actual model due to design changes
All repairs, adjustments and maintenance not described in the Operator’s Manual must be performed by qualified service personnel.
37
CHAIN SAW MODEL(s)
r PARTS LIST
11 13
34 33
14
32
16
31
15
17
30 29 26 28
21
27
20 25
Engine Gasket Kit 39
Ref.
Part No.
1. 2. 3. 4. 5. 6.
530016153 530056914 530047213 530015780 530095646 530069247
7.
530069216
8. 9. 10. 11. 12.
530035526 530054144 952030150 530016136 530049117
13. 14. 15. 16. 17. 18.
530015814 530039167 530047442 530037652 530049870 530016132
19
22 23
18
24 40
Description
Ref.
Screw Shield--Cylinder Assy--Air Purge Screw Assy--Fuel Pick--up Kit--Line Purge/Carb. (Small Dia) Kit--Line Purge/Tank (large line) Grommet--Carb Adjust. Seal--Carb Adapter Spark Plug (RCJ--7Y) Clip--High Tension Lead Assy--Wire Harness (includes switch) Screw Module--Ignition Strap--Ground Insulator--Heat Back Plate--Muffler Screw
n = NEW PART NUMBER FOR THIS
IPL
Part No.
19. 20. 21. 22.
530036103 530037813 530069608 530047207
23. 24. 25. 26. 27. 28. 29. 30.
530047062 530037935 530056363 530038729 530015697 530071408 530071412 530069608
31. 32. 33. 34. 35.
530016187 530049700 530016386 530069608 -----530069722 530071621
Description Screen--Spark Diffuser--Muffler Gasket--Muffler (kit) Assy--Muffler (Incl. 17--21) Assy--Crankshaft Cap--Crankcase Assy--Seal & Bearing Ring--Piston Retainer -- Piston Pin Kit--Piston -- (incl. 26--27) Kit--Cylinder Gasket--Carb. Adapter (kit) Screw Carb. Adapter Screw Carb. Gasket (kit) Kit--Carburetor (WT--391) (WT--625)
K= REFER TO THE SERVICE REFERENCE
Ref. 36. 37. 38. 39. 40.
Part No. 530047604 530016101 530037793 530031135 530069608
Description Housing--Air Filter Nut Air Filter -- Foam Wrench--Bar Kit--Engine Gasket (incl. 34,30,21)
Not Shown 530164543 530164544 530164545 530054781
Manual-- (Scan) Manual -- (Euro I) Manual -- (Euro II) Decal--Warning
INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)
PARTS LIST NO.
530163179 Replaces 163179 -- 3/07/07
DATE
3/04/08
CHAIN SAW MODEL(s)
r PARTS LIST
MAC CAT 436
Note: Illustration may differ from actual model due to design changes
PAGE NO.
6
TYPE 5 1 2 3
11 12
13
4 5
14
6
15 25
26
16 27
7
17 28
8 18
29
9 10
30
19 31
20 21
WARNING
32
All repairs, adjustments and maintenance not
34
described in the Operator’s Manual must be
22 23
33
performed by qualified service personnel.
24 40 Engine Gasket Kit 35
Ref. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18.
Part No.
39 37 38
36
Description
Ref.
530016153 Screw 530056914 Assy--- Cylinder Shield (includes # 16) 530069247 Kit--- Fuel Line (Small) 530071835 Kit--- Purge Bulb(incl.#5) 530015780 Screw 530095646 Assy--- Fuel Pick--- up 530047442 Strap --- Ground 530039198 Ignition Module 530015814 Screw 530057475 Assy--- Wire Harness 530037793 Foam--- Air Filter 530016101 Nut 530057702 Assy--- Air Box 530035526 Grommet--- Carb Adjust 530054144 Seal--- Carb Adapter 530055698 Reflector--- Heat 952030150 Spark Plug (RCJ --- 7Y) 530016136 Clip --- High Tension Lead n = NEW PART NUMBER FOR THIS
IPL
Part No.
19. 20. 21. 22. 23. 24. 25. 26.
530012550 530049870 530069608 530037813 530036103 530016132 530047631 --- --- --n 545081885
27. 28. 29. 30. 31. 32. 33. 34. 35.
530069608 530016386 530049700 530016187 530069608 530038729 530015697 530071408 530069608
Description Cylinder Backplate--- Muffler Gasket--- Muffler(kit) Diffuser--- Muffler Screen--- Spark Bolt--- Muffler Grommet--- Throttle Cable Kit--- Carburetor Walbro (WT--- 891) (Incl. Grommet) Gasket--- Carb. (kit) Screw Carb. Adapter Screw Gasket--- Adaptor(kit) Ring --- Piston Retainer--- Piston Pin Kit--- Piston (Incl. 32 & 33) Kit--- Engine Gasket (Incl. 21, 27 & 31)
K = REFER TO THE SERVICE REFERENCE
Ref.
Part No.
36. 37. 38. 39. 40.
530031135 530056363 530037935 530047062 530047207
Description Bar Wrench Assy--- Seal & Bearing Cap --- Crankcase Assy--- Crankshaft Assy--- Muffler (Incl . 20--- 24)
Not Shown --- --- --545123556 545123557 545123558 545123559 545123560 545123561 545123562 545123563
Manuals (Scan) (Euro I) (Euro II) (Euro III) (Euro IV) (Euro V) (Turkish) (Russian)
INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)
PARTS LIST NO. DATE
3/04/08
530163179
r PARTS LIST
Replaces 163179 -- 3/07/07
Note: Illustration may differ from actual model due to design changes
CHAIN SAW MODEL(s)
MAC CAT 436 PAGE NO.
Carburetor Assembly --- WT ---391 --- #530069722
KIT D
1 KIT D KIT
Gasket/ Dia. Kit
Carb. Repair Kit
4
3
KIT
KIT
KIT KIT
2
KIT KIT KIT D
KIT KIT KIT KIT Ref.
Part No.
1. 2. 3.
530038479 530038478 530069826
4.
530069844
KIT D KIT
Description Limiter Cap --- High Limiter Cap --- Low Carburetor Repair Kit ( KIT= Indicates Contents) & Includes Limiter Caps Gasket/Diaphragm Kit ( D = Indicates Contents)
Kit -- Carburetor Assembly No. 530071621 -- WT--625 Kit -- Carburetor Assembly No. 530071820 -- W--20 Kit -- Carburetor Assembly No. 530071821 -- WT--662
Note: No Repair kits are available for these carburetors
n = NEW PART NUMBER FOR THIS
IPL
K= REFER TO THE SERVICE REFERENCE
INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)
7
PARTS LIST NO. DATE
3/04/08
530163179
r PARTS LIST
Replaces 163179 -- 3/07/07
Note: Illustration may differ from actual model due to design changes
LLLLL
Service Reference
CHAIN SAW MODEL(s)
MAC CAT 436 PAGE NO.
LLLLL
Note: Due to product improvements, your unit may have been built with or without the spring and screw shown below. If your unit does not have this spring and screw, no action is required. If your unit does have the spring and screw, please order the part numbers listed below.
530015814 Screw
n = NEW PART NUMBER FOR THIS
IPL
530053274 Assy--Isolator Spring
K= REFER TO THE SERVICE REFERENCE
McCulloch Parts
INDICATED FOR MORE INFORMATION. (LOCATED AT END OF IPL)
8
