Transcript
DIESEL LIGHT TOWER MLT4060KV • MLT4060MV • MLT4080KV
00121
PARTS MANUAL 33777 A 08/15
WARNING CALIFORNIA PROPOSITION 65 WARNING: Diesel engine exhaust and some of its constituents are known to the state of California to cause cancer, birth defects, and other reproductive harm.
WARNING CALIFORNIA PROPOSITION 65 WARNING: This product contains or emits chemicals known to the state of California to cause cancer, birth defects, and other reproductive harm.
ii
Introduction This parts manual was prepared based on the information available at the time of publication and is subject to change without notice. Generac Mobile Products reserves the right to change parts at any time. To check whether a revised parts manual is available, contact Generac Mobile Products. DO NOT MODIFY or use this equipment for any application other than which it was designed for. To keep your equipment fully operational, it is suggested you maintain a stock of commonly used maintenance or service parts. A recommended spare parts list can be found in the back of this manual. To order service parts, please go to www.generacmobile.com or call Generac Mobile Products.
WARNING Before operating or servicing this equipment, read and understand the Generac Operating Manual which was included with the unit when shipped from the factory. Failure to do so increases the risk of injury to yourself or others.
GENERAC MOBILE PRODUCTS LLC 215 Power Drive • Berlin, WI 54923 U.S.A. Phone: 920-361-4442 FAX: 920-361-4416 Toll Free: 1-800-926-9768 www.generacmobile.com For technical or parts QUESTIONS, please contact the Generac Mobile Products Customer Support or Technical Support team at 1-800-926-9768.
Engine Make:__________________________________________ Engine Serial Number:___________________________________ Engine Model Number: __________________________________ Generator Make: _______________________________________ Generator Model Number: ________________________________ Generator Serial Number: ________________________________ Unit Model Number:_____________________________________ Unit Serial Number: _____________________________________
iii
This Page Intentionally Left Blank
iv
Table of Contents Introduction .............................................................................................................................................. iii Parts Manual Instructions............................................................................................................ 1 Unit Decals - Mast, Chassis, and Doors ............................................................................... 2 Unit Decals - Left Side Interior.............................................................................................. 3 Unit Decals - Right Side Interior ........................................................................................... 4 Mast, Junction Box and Lights to Unit .................................................................................. 6 Light Assembly ..................................................................................................................... 8 Mast Junction Box Assembly - Hard Wired Lights.............................................................. 10 Mast Junction Box Assembly - Quick Disconnect Lights Option ........................................ 12 Mast Assembly ................................................................................................................... 14 Mast Assembly - Bottom Post ............................................................................................ 16 Roof and Doors to Unit ....................................................................................................... 18 Front, Rear, and Side Panels to Unit .................................................................................. 20 Mast Switch Box Assembly ................................................................................................ 22 Control Box to Unit ............................................................................................................. 24 Control Box Assembly ........................................................................................................ 26 Control Panel Assembly - MLT4060KV, MLT4060MV ....................................................... 28 Control Panel Assembly - MLT4080KV .............................................................................. 30 Cooling System Assembly .................................................................................................. 32 Engine and Generator to Unit............................................................................................. 34 Engine Assembly - Mitsubishi Left Side ............................................................................. 36 Engine Assembly - Mitsubishi Right Side ........................................................................... 38 Engine Assembly - Kubota Left Side .................................................................................. 40 Engine Assembly - Kubota Right Side................................................................................ 42 Generator Assembly ........................................................................................................... 44 Fuel Tank and Ballast Boxes to Unit .................................................................................. 46 Trailer Assembly ................................................................................................................. 48 Trailer - Jack and Hitch Options ......................................................................................... 50 Axle Assembly .................................................................................................................... 52 Recommended Spare Parts List (1 of 2) ............................................................................ 54 Recommended Spare Parts List (2 of 2) ............................................................................ 55
v
This Page Intentionally Left Blank
vi
Parts Manual Instructions Product illustrations are only representations. Products supplied may vary from the illustrations in this parts manual. Parts not shown in the illustration are indicated by a double dash (--) in the item column. Please be prepared to provide the following information when ordering replacement parts: model number, serial number (on unit serial tag), part number, purchase order number (if applicable), shipping address, shipping method. Refer to the illustration below to locate the unit ID tag and Vehicle Identification Number (VIN) tag on the unit. Important information, such as the unit serial number, model number, VIN and tire loading information are found on these tags. Record the information from these tags so it is available if the tags are lost or damaged. When ordering parts or requesting assistance, you may be asked to provide this information.
Unit ID Tag Located on inside of front panel Manufactured by Generac Mobile Products LLC (920) 361-4442
VIN Tag MANUFACTURED BY/FABRIQUE PAR: Generac Mobile Products LLC GVWR/PNBV: 000KG (0000LBS) GAWR / PNBE
TIRE / PNEU
RIM / JANTE
DATE:
00/0000
COLD INF. PRESS./ PRESS. DE
RENSEIGNEMENTS SUR LES PNEUS ET LE CHARGEMENT
The weight of cargo should never exceed 0000KG (0000LBS) Le poids du chargement ne doit jamais depasser 0000KG (0000LBS) SEE OWNER’S MANUAL FOR ADDITIONAL INFORMATION
THIS VEHICLE CONFORMS TO ALL APPLICABLE STANDARDS PRESCRIBED UNDER THE U.S. FEDERAL MOTOR VEHICLE SAFETY STANDARDS(FMVSS) AND CANADIAN MOTOR VEHICLE SAFETY REGULATIONS IN EFFECT ON THE DATE OF MANUFACTURE. CE VEHICULE EST CONFORME A TOUTES LES NORMES QUI LUI SONT APPLICABLES EN VERTU DU REGLEMENT SUR LA SECURITE DES VEHICULES AUTOMOBILES DU CANADA EN VIGUEUR A LA DATE SA FABRICATION.
XXX000 TRAILER
MODEL: V.I.N./N.I.V.:
00000000000000000
TYPE:
Model
Serial Number
Manufacturing Code
Weight (lbs/kg)
RPM/Frequency
TIRE AND LOADING INFORMATION
GONF A FROID - KPA(PSI/LPC) SGL / DUAL
EACH AXLE
(800) 926-9768
Country of Origin
Rating 1 ph. 1.0PF
3 ph. .8PF
3 ph. 1.0PF
KW Ins. Class
KVA V
FOR ELECTRICAL EQUIPMENT ONLY. POUR MATERIAL ELECTRIQUE SEULEMENT. 209649
A
Form: SFC626B
VOIR LE MANUEL DE L’USAGER POUR PLUS DE RENSEIGNEMENTS
00224
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
1
Align arrows before towing unit.
UNIT DECALS - MAST, CHASSIS, AND DOORS
TOWING INSTRUCTIONS
ABSCHLEPPANWEISUNGEN
INSTRUCCIONES PARA REMOLQUE
INSTRUCTIONS DE REMORQUAGE
1. Read operator's manual. 2. Use hitch rated for trailer's "gross vehicle weight rating". 3. Securely attach trailer to tow vehicle. 4. Attach safety chains using a cross pattern. 5. Attach breakdown chain to vehicle. 6. Check trailer lights.
1. Benutzerhandbuch lesen. 2. Anhängevorrichtung verwenden, die der „Gesamtbetriebsgewichtsklasse” des Fahrzeugs entspricht. 3. Anhänger sicher am Abschleppfahrzeug befestigen. 4. Sicherheitsketten über Kreuz anbringen. 5. Abreißkette am Fahrzeug anbringen. 6. Anhängerleuchten prüfen.
1. Lea el manual del operador. 2. Use un enganche adecuado para la “capacidad de peso bruto del vehículo” del remolque. 3. Enganche firmemente el remolque al vehículo de remolque. 4. Enganche las cadenas de seguridad en forma cruzada. 5. Enganche al vehículo la cadena de emergencia para averías. 6. Revise las luces del remolque.
1. Lire le manuel de l’utilisateur. 2. Utiliser un attelage convenant au poids nominal brut de la remorque. 3. Arrimer solidement la remorque au véhicule tracteur. 4. Poser les chaînes de sécurité en les croisant. 5. Fixer la chaîne de remorquage au véhicule. 6. Vérifier les feux de la remorque.
PN: 12142 Decal, Ground
DANGER
GEFAHR PELIGRO DANGER
ALWAYS KEEP TENSION ON CABLES! SLACK MAY CAUSE CABLE DAMAGE AND EXCESSIVE WEAR! KABEL STETS GESPANNT HALTEN! EIN DURCHHÄNGEN DES KABELS KANN ZU BESCHÄDIGUNGEN UND FRÜHZEITIGER ABNUTZUNG FÜHREN! ¡MANTENGA SIEMPRE EL CABLE TENSIONADO! ¡LA FALTA DE TENSIÓN EN EL CABLE PUEDE CAUSARLE DAÑOS Y DESGASTE EXCESIVO! LES CÂBLES DOIVENT ÊTRE TOUJOURS TENDUS! UN CÂBLE AVEC DU MOU PEUT SE DÉTÉRIORER ET S’USER RAPIDEMENT!
PN: 13614 Decal, Mast Junction Located inside box
01150
Note: All safety and operating decals are located on decal sheet 33953 unless otherwise noted. 2
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
UNIT DECALS - LEFT SIDE INTERIOR
WARNING DANGER
GEFAHR PELIGRO DANGER
WARNUNG ADVERTENCIA AVERTISSEMENT
WARNING
WARNUNG ADVERTENCIA AVERTISSEMENT
WARNING Do not set up unit in high wind or during electrical storms! Check for overhead obstructions before using!
WARNUNG Die Einheit nicht bei hohem Wind oder bei Gewittern einrichten! Vor Gebrauch auf über Kopf befindliche Hindernisse achten!
DANGER
ADVERTENCIA ¡No monte la unidad si hay viento fuerte ni durante tormentas eléctricas! ¡Revise las obstrucciones elevadas antes de usar!
AVERTISSEMENT Ne pas installer l’appareil par vents violents ou lorsqu’il y a un orage! Vérifier l’absence d’obstacles en hauteur avant l’utilisation!
Contact with overhead electrical power lines will cause serious injury or death. Do not position light tower under electrical power lines.
GEFAHR Der kontakt mit elektrischen Hochspannungsleitungen kann zu schweren oder lebensgefährlichen Verletzungen führen. Den Beleuchtungswagen nie direkt unter Hochspannungsleitungen aufstellen.
PELIGRO El contacto con las líneas electricas elevadas podría causar lesiones serias o la muerte. No posicione la torre de iluminación debajo de líneas electricas.
DANGER Le contact avec des câbles électriques suspendus causera des blessures graves ou la mort. Ne pas positionner la tour lumineuse sous des câbles électriques.
ENGINE OPERATION / MOTORBETRIEB / FUNCIONAMIENTO DEL MOTOR / FONCTIONNEMENT DU MOTEUR:
1
BEFORE STARTING THE ENGINE / VOR DEM STARTEN DES MOTORS / ANTES DE ENCENDER EL MOTOR / AVANT DE FAIRE DÉMARRER LE MOTEUR:
1. CHECK FUEL LEVEL. TREIBSTOFFSTAND PRÜFEN. REVISE EL NIVEL DE COMBUSTIBLE. VÉRIFIER LE NIVEAU D’ESSENCE.
WARNING
3. CHECK COOLANT LEVEL. KÜHLMITTELSTAND PRÜFEN. REVISE EL NIVEL DEL REFRIGERANTE. VÉRIFIER LE NIVEAU DE LIQUIDE DE REFROIDISSEMENT.
2. CHECK ENGINE OIL LEVEL. 4. MAKE SURE MAIN CIRCUIT BREAKER IS OFF. VERGEWISSERN SIE SICH, DASS DER HAUPTTRENNSCHALTER MOTORÖLSTAND PRÜFEN. AUSGESCHALTET IST. REVISE EL NIVEL DE ACEITE DEL MOTOR. ASEGÚRESE DE QUE EL CORTACIRCUITOS PRINCIPAL VÉRIFIER LE NIVEAU D’HUILE DU MOTEUR. ESTÉ APAGADO. S’ASSURER QUE LE DISJONCTEUR DU CIRCUIT PRINCIPAL EST DÉSACTIVÉ.
2 3
ALL CIRCUIT BREAKERS OFF! / ALLE TRENNSCHALTER SIND AUSGESCHALTET! / ¡TODOS LOS CORTACIRCUITOS ESTÁN APAGADOS! / TOUS LES DISJONCTEURS DU CIRCUIT SONT DÉSACTIVÉS!
I O
I O
I O
CRANK ENGINE TO START
OFF GLOW PLUG
GLÜHKERZEN AKTIVIEREN ACTIVE LAS BUJÍAS DE CALEFACCIÓN ACTIVER LES BOUGIES DE PRÉCHAUFFAGE
GLOW PLUG
OFF GLOW PLUG
RUN
RUN
START
START
MOTOR ZUM STARTEN AUF VOLLEN TOUREN LAUFEN LASSEN PONGA EN FUNCIONAMIENTO EL MOTOR PARA QUE ARRANQUE ACTIONNER LE MOTEUR POUR LE FAIRE DÉMARRER
TURN CIRCUIT BREAKERS ON / TRENNSCHALTER EINSCHALTEN / ENCIENDA LOS CORTACIRCUITOS / ACTIVER LES DISJONCTEURS DU CIRCUIT
SCHLÜSSEL FREIGEBEN SUELTE LA LLAVE RELÂCHER LA CLÉ
I O
I O
I O
I O
I O
I O
I O
WARNING
SHUT DOWN / AUSSCHALTEN / APAGUE / ÉTEINDRE
6
AVERTISSEMENT
RELEASE KEY
OFF RUN
START
5
WARNUNG ADVERTENCIA
I O
START ENGINE / MOTOR STARTEN / ENCIENDA EL MOTOR / FAIRE DÉMARRER LE MOTEUR ACTIVATE GLOW PLUGS
4
I O
ALL CIRCUIT BREAKERS OFF! / ALLE TRENNSCHALTER SIND AUSGESCHALTET! / ¡TODOS LOS CORTACIRCUITOS ESTÁN APAGADOS! / TOUS LES DISJONCTEURS DU CIRCUIT SONT DÉSACTIVÉS!
STOP ENGINE / MOTOR STOPPEN / DETENGA EL MOTOR / ÉTEINDRE LE MOTEUR
I O
I O
Read and understand the supplied operator’s manual before operating this machine. Failure to do so increases the risk of injury to yourself or others.
WARNUNG
OFF GLOW PLUG
I O
RUN
START
Vor dem Betrieb dieser Maschine muss das Bedienerhandbuch gelesen und verstanden worden sein. Ein Unterlassen erhöht das eigene Verletzungsrisiko und das anderer.
ADVERTENCIA Lea y asegúrese de comprender el manual del operador proporcionado antes de operar esta máquina. De lo contrario, aumenta el riesgo de lesiones a usted y a otras personas.
AVERTISSEMENT Lire et comprendre le manuel de l’utilisateur fourni avec l’appareil avant de l’utiliser. L’omission de le faire augmente le risque de blessure pour vous et pour les autres.
01151
Note: All safety and operating decals are located on decal sheet 33953 unless otherwise noted. 33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
3
UNIT DECALS - RIGHT SIDE INTERIOR
DANGER
GEFAHR PELIGRO DANGER WARNING
WARNUNG ADVERTENCIA AVERTISSEMENT
DANGER GEFAHR PELIGRO DANGER
DIESEL ULTRA LOW SULFUR FUEL ONLY S≤15 mg/kg
PN: 27433 Decal, Ultra Low Sulfur PN: 70164 Decal, Do Not Remove Bolt
NOTICE WARNING
Lamp glass can be damaged by road debris from towing vehicle and other vehicles. To prevent lamp damage, face lamp glass backwards during transport.
WARNUNG ADVERTENCIA AVERTISSEMENT
HINWEIS AVISO AVIS
WARNING Do not move unit with tower up!
WARNUNG
WARNING
Die Einheit nicht mit ausgefahrenem Turm transportieren!
ADVERTENCIA ¡No mueva la unidad con la torre elevada!
AVERTISSEMENT Ne pas déplacer l’appareil si la tour est à pleine hauteur!
WARNUNG ADVERTENCIA AVERTISSEMENT A A
B
C
D
STOP
TO RAISE MAST: 1. Position unit on level surface, free of overhead obstacles. 2. Extend outriggers, level unit and adjust lights (A). 3. Press winch control switch upward (B). 4. STOP at colored mark on lowest moving section on mast (C). 5. Rotate mast to aim lights, tighten knob to set position (D). ANHEBEN DES MASTES: 1. Gerät auf einer horizontalen Fläche frei von Hindernissen nach oben aufstellen. 2. Ausleger ausfahren, Gerät horizontal ausrichten und Lampen einstellen (A). 3. Windenschalter nach oben drücken (B). 4. An der farbigen Markierung am untersten verfahrbaren Abschnitt des Mastes ANHALTEN (C). 5. Mast zur Ausrichtung der Lampen drehen, Knopf an der richtigen Position festziehen (D). PARA ELEVAR EL MÁSTIL: 1. Coloque la unidad en una superficie nivelada, sin obstáculos elevados. 2. Extienda los soportes, nivele la unidad y ajuste las luces (A). 3. Presione el interruptor de control del torno hacia arriba (B). 4. PARE en la marca coloreada en la sección móvil más baja del mástil (C). 5. Gire el mástil para dirigir las luces, apriete la perilla para ajustar la posición (D).
WARNING
POUR SOULEVER LE MÂT : 1. Positionner l’unité sur une surface à niveau, exempte d’obstructions aériennes. 2. Étendre les stabilisateurs, mettre l’unité à niveau et ajuster les lampadaires (A). 3. Appuyer l’interrupteur du contrôle du treuil vers le haut (B). 4. ARRÊTER à la marque de couleur sur la section de mouvement la plus basse sur le mât (C). 5. Tourner le mât pour cibler les lampadaires, serrer le bouton pour régler la position (D).
E
F
A G
C
D
A B
UV
A A
TO LOWER THE MAST:
Ultraviolet radiation from lamp can cause serious skin and eye irritation. Use only with provided undamaged lens cover and fixture.
WARNUNG Die ultraviolette Strahlung der Lampe kann zu schwerer Haut- und Augenreizung führen. Nur zusammen mit der mitgelieferten, unbeschädigten Objektivkappe und -vorrichtung verwenden.
ADVERTENCIA La radiación ultravioleta de la lámpara puede irritar gravemente los ojos y la piel. Utilice solo con la cubierta y el accesorio para lente no dañados que se proporcionan.
6. Turn off lights, main breaker and engine. 7. Rotate mast so winch is facing rear. Tighten knob to set position (E). 8. Press winch control switch downward (F). 9. Raise jacks and secure outriggers if unit is to be moved (G). 10. Aim light heads backwards if unit is to be moved. ABSENKEN DES MASTES: 6. Lampen, Hauptschalter und Motor ausschalten. 7. Mast soweit drehen bis die Winde zur Rückseite gerichtet ist. Knopf an der richtigen Position festziehen (E). 8. Windenschalter nach unten drücken (F). 9. Stützen anheben und Ausleger sichern, wenn das Gerät bewegt werden soll (G). 10. Lampenköpfe nach hinten ausrichten, wenn das Gerät bewegt werden soll.
E
PARA BAJAR EL MÁSTIL: 6. Apague las luces, el disyuntor principal y el motor. 7. Gire el mástil para del torno se enfrenta a la parte trasera. Apriete la perilla para ajustar la posición (E). 8. Presione el interruptor de control del torno hacia abajo (F). 9. Si se va a mover la unidad, eleve los gatos y fije los soportes (G). 10. Si se va a mover la unidad, dirija los cabezales de las luces hacia atrás. POUR ABAISSER LE MÂT : 6. Fermer les lampadaires, le disjoncteur principal et le moteur. 7. Pivoter le mât afin que le treuil soit tourné vers l'arrière. Serrer l'ecrou papillon pour régler la position (E). 8. Appuyer l’interrupteur du contrôle du treuil vers le bas (F). 9. Soulever les crics et fixer les stabilisateurs si l’unité doit être déplacée (G). 10. Cibler les têtes de lampadaire en arrière si l’unité doit être déplacée.
F
G
AVERTISSEMENT Les rayons UV de la lampe peuvent causer de fortes irritations de la peau et des yeux. N’utiliser qu’avec les protections et fixations pour lentilles intactes fournies.
PN: 33301 Decal, Mast setup
01152
Note: All safety and operating decals are located on decal sheet 33953 unless otherwise noted. 4
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
This Page Intentionally Left Blank
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
5
MAST, JUNCTION BOX AND LIGHTS TO UNIT
1
2
15
7
3
3 3
4
6
8 5
8 3 7
3 9 10
G
3 8
B H A B C
G
B
E F 14 10
13 11 12 10 10 10
11 11 D B
6
A
MLT4060KV/MV-MLT4080KV Parts Manual
01153
33777 A
MAST, JUNCTION BOX AND LIGHTS TO UNIT Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Part No. 13527B 60753 60698 Page 10 Page 14 33041B 61036 60358 60683 60309 62221 50215 33234B 60388 Page 8
OPTIONAL FEATURES Spare Tire: A 60388 B 60309 C 35030B D 35031B E 60096 F 15976 G 62221 H 10734B
33777 A
Qty 1 2 12 1 1 1 4 6 6 12 9 1 1 2 4
Description Weldment, mast crossbar Screw, .375-16 x 3.5 std hex, G5 Washer, .375 flat .875/.040, SS Assembly, mast junction box Assembly, mast Weldment, lift support Screw, .375-16 x 1.25 std hex, SS Nut, .375-16 nylock, G5 Screw, .500-13 x 1.50 std hex, SS Washer, .500 flat 1.060/.090 Nut, .500-13 nylock, G5 Screw, .500-13 x 4.0 std hex, G5 Weldment, step platform Screw, .500-13 x 1.50 std hex, G5 Assembly, light
5 10 1 1 5 1 5 1
Screw, .500-13 x 1.50 std hex, G5 Washer, .500 flat 1.060/.090 Bracket, spare tire holder Plate, spare tire holder Nut, .500-20 lug, G5 Wheel, ST175/80D13, 1360 lb Nut, .500-13 nylock, G5 Weldment, spare tire holder
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
7
LIGHT ASSEMBLY 35 1 34
2 3 4 2 33
5
32
31 A 6
7 8
30
9 10 27 29 12 28
27 26
15
2 2
11
5
14
13
17 16
18 19
20
15 10
25
24 B
9 8
21 D
7
23
C
22 01154
8
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
LIGHT ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 --
Part No. 13399 13371 13372 13370 13395 13438 62221 60247 13392 13390 13374 13393 13381 13396 13378 13366 15861 13386 13387 15864 13403 61174 13368 13380 13375 13377 13388 13394 13376 11391 13373 13369 13367 13398 13397 13331
OPTIONAL FEATURES Quick Disconnect Light: A 13383 B 60398 C 19041 D 60061 -13601
33777 A
Qty 1 4 2 1 2 1 2 2 2 4 1 1 1 2 2 1 1 1 1 1 1 1 1 1 1 1 10 1 1 1 1 1 1 1 1 1
1 1 1 1 1
Description Screw, M4 x 18 pan phil Washer, #4 Washer, #4 nylon Assembly, tether Nut, M4 nylock Cord, power - hard wired Nut, .500-13 nylock, G5 Washer, .750 flat 2.020/.090 Stud, trunnion mounting Washer, .500 nylon Support, housing/trunnion w/out cord Screw, M5 x 12 phillips green Socket, bulb w/out threaded insert Screw, pan phillips Gasket, silicone Assembly, housing Nut, special, .500NPT lock Fitting, nipple - .500 Connector, weathertight - .500 Strain relief, .500NPT watertight, .270/.464 ID Handle, T - wing nut Washer, .750 external star Trunnion Bracket, bulb support Support, housing/trunnion w/cord Bracket, non socket end plate Screw, M5 x 12 flg hex, slotted Screw, M4 x 10 pan phil Bracket, socket end plate Bulb, 1000W MH short length Gasket, lens Lens, glass Assembly, aluminum ring Screw, ground Nut, nylock Assembly, light - hard wired
Cord, power quick disconnect Screw, 10-32 x .500 pan phil, SS Clip, spring holder Nut, 10-32 nylock Assembly, light - quick disconnect, cord clip
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
Items 1 - 35
Replaces item 6
9
MAST JUNCTION BOX ASSEMBLY - HARD WIRED LIGHTS 1 2
3
4 5 6
10
8
8 9
7
14
8 9 8 10
13
11
12
12 01155
10
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
MAST JUNCTION BOX ASSEMBLY - HARD WIRED LIGHTS Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 --
33777 A
Part No. 12109 60424 13749 66100 66101 66102 15864 14656 60755 60062 16143 60415 12095B 12094 11789
Qty 1 4 1 4 2 1 4 1 2 5 1 5 1 1 1
Description Cover, box, 2 gang plastic Screw, 6-32 x .750 pan phil, G2, self thread Gasket, junction box Connector, 2 position Connector, 3 position Connector, 5 position Strain relief - .500NPT watertight, .270/464 ID Strain relief - .750NPT watertight, .545/709 ID Fitting, strt - .750MNPT x .500FNPT, nylon Screw, 10-32 x .750 pan phil, G2 Clamp, tubing - .500 Nut, 10-32 nylock, SS Bracket, junction box - black Box, junction Assembly, mast junction box - hard wired
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
Items 1 - 14
11
MAST JUNCTION BOX ASSEMBLY - QUICK DISCONNECT LIGHTS OPTION
1
16 2 3 4
10 5
9
6 11
7 12 8
9
11
10
12 13 15
14
14 01540
12
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
MAST JUNCTION BOX ASSEMBLY - QUICK DISCONNECT LIGHTS OPTION Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 --
33777 A
Part No. 60424 66100 66101 66102 13749 12094 12713 14656 15403 12410 60755 60062 16143 60415 12095B 12109 11957
Qty 4 4 2 1 1 1 1 1 4 4 2 5 1 5 1 1 1
Description Screw, 6-32 x .750 pan phil, G2, self thread Connector, 2 position Connector, 3 position Connector, 5 position Gasket, junction box Box, junction Fitting, strt - .500MNPT x .500FNPT, steel Strain relief, .750NPT, watertight Connector, quick disconnect - female Assembly, quick disconnect receptacle cap w/chain Fitting, strt - .750MNPT x .500FNPT, nylon Screw, 10-32 x .750 pan phil, G2 Clamp, tubing - .500 Nut, 10-32 nylock, SS Bracket, junction box - black Cover, box, 2 gang plastic Assembly, mast junction box - quick disconnect
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
Items 1 - 16
13
MAST ASSEMBLY
3 4
1 2
5 6 7
14 11 12
15
13
8 10 5
7
9
20 2 5
19 29
7 19
18 16
17
28 15
21 27 26
22
7
25
23
24
30
01157
14
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
MAST ASSEMBLY Item 1 2 3 4‘ 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 --------
33777 A
Part No. 32015B 63279 32409 32524 15380 60067 32569 32010B 14262 15627 60140 60206 60386 13789 63325 32007B 33736 60309 63281 13790 63280 32004B 60285 60271 60119 33395B 15861 14871 32408 Page 16 34132 34128 34129 34130 33397 33228 10770
Qty 1 2 1 1 4 2 14 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1
Description Weldment, mast section, 1.25 in Pin, clevis - .500 dia x .780 Shim, 2 x 2 tube Sheave, 2.50 in Pin, cotter - .125 x 1.25 Washer, #10 flat .435/.060, SS Screw, 8-16 x .375 pan phil, SS Weldment, mast section, 2 in Sheave, 3 in Clamp, tubing - .625 heavy duty Nut, .375-16 hex, G5 Washer, .375 split lock Washer, .375 flat .993/.064 Shim, 3 x 3 tube Pin, clevis - .500 dia x 1.063 Weldment, mast section - 3 in Assembly, pulley Washer, .500 flat 1.060/.090 Clip, E-ring Shim, 4 x 4 tube Pin, grooved clevis - .500 dia x .780 Weldment, mast section, 4 in Nut, .312-18 hex, G2 Washer, .312 split lock Washer, .312 flat .875/.070 Guard, pulley Nut, .500NPT lock Strain relief, .500NPT, .500 cord Shim, 5 x 5 tube Assembly, mast bottom Cable, .188 in. x 116 in., SS Cable, .188 in. x 69.25 in., SS Cable, .188 in. x 69.75 in., SS Cable, .188 in. x 67.875 in., SS Coil cord Assembly, vertical mast Wire group - coil cord ground extension
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
Attaches to item 30 Attaches to item 22 Attaches to item 16 Attaches to item 8 Items 1 - 30
15
MAST ASSEMBLY - BOTTOM POST
1 3
2
4 5 7
6 10
8 7
13
9
14
11 12
15
1
28 16
28
27 17 24 26 12 25 23
21
18
22 9 19
20 01158
16
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
MAST ASSEMBLY - BOTTOM POST Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 -----
33777 A
Part No. 31757 63325 15380 60309 33736 60144 60696 16143 60393 63272 60358 60386 13796B 60271 60168 33247B 60247 50197 33224B 60584 11649Z 60286 60243 33822B 60352 33858B 61143 34293 17936 31759 31758 31757
Qty 2 1 1 1 1 1 2 1 3 1 2 4 1 3 3 1 1 0.75 ft 1 1 1 2 2 1 2 1 2 1 1 1 1 1
Description Sensor, proximity Pin, clevis - .500 dia x 1.063 Pin, cotter - .125 x 1.25 Washer, .500 flat 1.060/.090 Assembly, pulley Nut, .250-20 nylock, G5 Washer, .250 flat .625/.050, SS Clamp, tubing - .500 Screw, .250-20 x 1.0 std hex, G5 Pin, clevis - .500 dia x 1.25 Nut, .375-16 nylock, G5 Washer, .375 flat .993/.064 Weldment, proximity sensor bracket Washer, .312 split lock Screw, .312-18 x .750 std hex, G5 Weldment, mast bottom - 5 in Washer, .750 flat 2.020/.130 Weatherstripping - .06 x 1.0 Weldment, mast tube Nut, .750-10 nylock, G5 Weldment, T-bolt Washer, .250 split lock Washer, .250 flat .735/.060 Bracket, winch cover Screw, .375-16 x 1.25 std hex, G5 Bracket, winch mounting Nut, .250-20 U-clip - short type Winch, electric - 1200 lb hoist Wire group - electric winch Wire group - winch battery power cables Wire group - winch power cables Wire group - proximity sensor
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
17
ROOF AND DOORS TO UNIT
4 5 2 3
6
A 1
7 8
9
10
13 11 14 12 15 2
16
2 16 17
17
18 2 3 2 10 19
01159
18
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
ROOF AND DOORS TO UNIT Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
Part No. 16538W 60268 12605 60690 60703 60698 19714 20287 60061 60067 60696 60144 60414 19726 22419B 16598 16591W 15123 61180
OPTIONAL FEATURES Level Indicator: A 14433 Silent Pack: -16739W
33777 A
Qty 1 48 2 4 4 4 1 1 1 2 1 1 1 1 1 2 2 2 1
Description Panel, top Rivet, .188 dia x .126 to .250 grip, SS Latch, T-handle, SS Screw, .375-16 x 1.0 std hex, SS Washer, .375 split lock, SS Washer, .375 flat .875/.040, SS Cap, overflow jug Jug, overflow Nut, 10-32 nylock Washer, #10 flat .435/.060, SS Washer, .250 flat .625/.050, SS Nut, .250-20 nylock, G5 Screw, .250-12 x 1.50 std hex, G5 Clamp, overflow jug Bracket, overflow jug Hinge, door - .188 pin, 48.5 in. long Panel, door Latch, paddle - 7 lb spring Screw, 10-32 x .750 pan phil, SS
1
Level, eye
2
Panel, door
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
19
FRONT, REAR, AND SIDE PANELS TO UNIT
4
3
1 2
A
6
5
8
10 12
9
11
13
15 16
14 36
28
30
7
22
35 37
15 16
27
30
15
2
32
30 16
18 17 34 19 16
2
21
16 17
31 17
33
20
24
25
22 23
26 16
27
30 29
28
B
E
F
G
C D
20
01160
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
FRONT, REAR, AND SIDE PANELS TO UNIT Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37
Part No. 35500W 60657 10223 60423 60457 60067 10219 10221 60268 11222 60089 60540 11121 15628 60140 60698 60689 Page 22 60696 60704 60684 66372 60694 60730 15215 60267 66373 16560 60690 60703 35502W 60649 33746W 66425 60729 60295 33240W
OPTIONAL FEATURES Silent Pack: A 12189W B 15425 C 34744W D 34783W E 60507 F 60701 G 60340
33777 A
Qty 1 26 1 2 2 2 2 2 2 1 2 2 1 2 10 38 10 1 2 2 2 2 8 8 6 6 2 2 22 36 1 1 1 1 8 8 1
Description Panel, rear Nut, .375-16 cage, G5, for 12 GA Assembly, license plate holder Rivet, .188 dia x .250 to .375 grip Nut, 10-24 nylock, G2 Washer, #10 flat .435/.060, SS Assy, rear tail/turn light, 3-wire with plug Grommet, rear light, rubber Rivet, .188 dia x .126 to .250 grip, SS Bracket, manual holder Washer, .265 fender 1.25/.060 Screw, 10-24 x .750 pan phil, SS Manual holder tube Clamp, wire - .38 plastic Nut, .375-16 hex, G5 Washer, .375 flat .875/.040, SS Screw, .375-16 x 4.0 std hex SS Assembly, mast toggle switch box Washer, .250 flat .625/.050, SS Washer, .250 split lock, SS Screw, .250-20 x .875 std hex, SS Light, clearance marker - red Screw, 8-32 x .750 pan phil, SS Nut, 8-32 U-clip Rubber bumper Rivet, .125 dia x .191 to .270 grip, alum Light, clearance marker - amber Fender, plastic - 13 in. tire Screw, .375-16 x 1.0 std hex, SS Washer, .375 split lock, SS Panel, left side Clamp, tubing - .750 heavy duty Panel, front Strain relief, 1.25 Romex, w/nut Washer, .375 fender 1.50/.090 Screw, .375-16 x .750 std hex, SS Panel, right side
1 16 1 2 16 16 16
Duct, radiator guard Nut, .312-18 cage Panel, front Duct, front Screw, .312-18 x 1.0 std hex, SS Washer, .312 split lock, SS Washer, .312 flat .875/.040, SS
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
21
MAST SWITCH BOX ASSEMBLY
1
9 17 4 2 16 4
3
15
8
1
13
5
7 14 12 6
11
8
10
9
22
MLT4060KV/MV-MLT4080KV Parts Manual
01161
33777 A
MAST SWITCH BOX ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 --
33777 A
Part No. 60277 65049 33750B 60061 50197 50187 61143 63105 60526 33751B 60758 61229 62187 65707 33255B 11293 60036 33471
Qty 4 2 1 4 .125 ft .33 ft 2 4 4 1 4 1 4 1 1 1 4 1
Description Screw, 10-32 x .500 pan phil, G2 Relay, 12V 30/40A NO w/diode Panel, box - mast switch Nut, 10-32 nylock Weatherstripping, .06 x 1.0 Seal, door - D-shaped - .750 Nut, .250-20 U-clip - short type Nut, 8-32 U-clip, G5 Screw, 8-32 x .500 pan phil, G2 Panel, cover - mast switch Nut, 4-40 nylock, G2 Connector, amp - 7 position receptacle, flange Screw, 4-40 x .500 pan phil, SS Switch, toggle - SPDT, spring, weatherproof Bracket, electric winch Contactor, 12V electric winch Nut, M6-1.0 sflg, G8.8 Assembly, mast switch box
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
Items 1 - 17
23
CONTROL BOX TO UNIT 3 2 1
4
3 2 5
6 7
8
9 A B
C D
2
E
F
10
G
H
2
K
10
J L
F P
M N 01162
24
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
CONTROL BOX TO UNIT Item 1 2 3 4 5 6 7 8 9 10
Part No. 60649 60340 60303 Page 26 11543B 60090 60089 12924B 14146 62043
OPTIONAL FEATURES Battery Charger: A 60419 B 65326 -21259 Battery Disconnect: C 60028 D 60271 E 60277 F 60119 G 65499 H 13654B J 60067 K 65498 L 60061 M 15073 N 15074 P 60303
33777 A
Qty 1 12 6 1 2 2 2 1 2 6
Description Clamp, tubing - .750 heavy duty Washer, .312 flat .875/.040, SS Nut, .312-18 nylock, G2 Control box Spacer, control box Nut, .250-20 wing, G5 Washer, .265 fender 1.250/.060 Angle, battery hold down Bolt, J .250-20 x 10.0 Screw, .312-18 x 2.25 std hex, SS
2 1 1
Screw, 6-32 x .500 flg hex, G2, self-tapping Charger, battery 2A Decal, battery charger
2 2 2 2 1 1 2 1 2 1 1 2
Screw, .312-18 x 1.0 std hex, G5 Washer, .312 split lock Screw, 10-32 x .500 pan phil, G2 Washer, .312 flat .875/.070 Assembly, switch lockout lever Bracket, battery disconnect Washer, #10 flat .435/.060, SS Switch, disconnect Nut, 10-32 nylock Cable, battery - 24 in. 4GA black, .438 lug Cable, battery - 38 in. 4GA red, .438 lug Nut, .312-18 nylock, G2
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
Included with item 9 Included with item 9
25
CONTROL BOX ASSEMBLY
2 3
1
20 19 18
7
17 15 14
16
8
5
14
4
6
13
A
7
12 9
8 7 7
9
B C
10
11 01467
26
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
CONTROL BOX ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11
Part No. 13690B 60148 60398 65959 60397 60396 14219 60252 60061 14201 Page 28
Qty 2 2 4 2 1 1 5 3 2 1 1
12 13 14 15 16 17 18 19 20
Page 30 60526 15125 14231 14203 14139 61045 63105 13666B 60062
1 6 9 2 1 1 4 6 1 3
Description Notes Bracket, capacitor Nut, M12-1.75 flange, G8.8 Screw, 10-32 x .500 pan phil, SS Capacitor, 24μF, stud mounted Screw, 10-32 x 1.0 pan phil, G2 Screw, 10-32 x 1.25 pan phil, G2 Strain relief, .75 Romex Washer, #10 split lock Nut, 10-32 nylock Relay, 10A SPDT 12VDC time delay, 15 second fixed Assembly, control panel MLT4060KV/MV only Assembly, control panel MLT4080KV only Screw, 8-32 x .500 pan phil, G2 Jumper Nut, 10-32 hex, G2 Block, terminal - 10 pos., 30A, 600V, #8 screw Block, terminal - 12 pos., 30A, 600V, #8 screw Nut, 10-32 flange Nut, 8-32 U-clip, G5 Control box Screw, 10-32 x .750 pan phil, G2
1 1 4
Fitting, bushing - .500 x .375 Light, interior with switch Screw, 10-16 x .500 std hex, G2, self-drilling
OPTIONAL FEATURES Interior Light: A 19163 B 11947 C 60364
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
27
CONTROL PANEL ASSEMBLY - MLT4060KV, MLT4060MV
1
2 3
23
24
22
21
6 4 5
7 19
8
18 9 20
10 17
19 18
12
11
14 16 14 15
28
13
MLT4060KV/MV-MLT4080KV Parts Manual
01164
33777 A
CONTROL PANEL ASSEMBLY - MLT4060KV, MLT4060MV Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 ---------
33777 A
Part No. 66423 60061 66257 14249 14137 14130 60318 14204 15195 16694 65850 14231 15085 60252 60277 60406 13677 60405 60058 60062 10444 10441 65388 65963 65849 10443 10440 35267 35268 35269 35266 35270 35271
Qty 1 3 3 4 1 1 2 1 1 1 1 2 1 4 2 2 1 16 16 3 1 1 1 1 1 1 1 1 1 1 1 1 1
Description PCB, LED lights w/connector Nut, 10-32 nylock Spacer, .2 ID x .375 OD x .25 long, plastic Breaker, 15A, 120V, 1-pole Receptacle, 240V/30A twist-lock Receptacle, 120V/20A GFI Nut, 8-32 hex, G5 Kit, ground bar Switch, key Glow plug indicator Breaker, 10A, 240V, 1-pole, push button Nut, 10-32 hex, G2 Gauge, hour meter Washer, #10 split lock Screw, 10-32 x .500 pan phil, G2 Screw, 8-32 x 1.0 pan phil, SS Hinge, continuous - 11 in Screw, 6-32 x .250 pan phil, G2 Washer, #6 split lock Screw, 10-32 x .750 pan phil, G2 Panel, control - Mitsubishi, 6kW Panel, control - Kubota, 6kW Light, indicator red, 12VDC Breaker, 30A, 250V, 2-pole, stud terminal w/aux Breaker, 10A, 120V, 1-pole, push button Assembly, control panel - Mitsubishi Assembly, control panel - Kubota Wire group - 20A GFCI Wire group - 30A twist-lock Wire group - light switches Wire group - LED light board Wire group - 6kW control box Wire group - 6kW control box
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
MLT4060MV only
MLT4060MV only MLT4060KV only
Items 1 - 34 Items 1 - 34
MLT4060KV only MLT4060MV only
29
CONTROL PANEL ASSEMBLY - MLT4080KV
24
23
1
2
22
3
21
20 4 5
7 18
8
17 6
9 19 18 16
18
17
17 11
10
13 15 13 14
30
12
MLT4060KV/MV-MLT4080KV Parts Manual
01165
33777 A
CONTROL PANEL ASSEMBLY - MLT4080KV Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 ---------
33777 A
Part No. 66423 60061 66257 14249 14137 65963 60318 14204 15195 65850 14231 15085 60252 60277 60406 13677 60405 60058 60062 13675 65388 65864 65849 14130 13884 10458 35309 35267 35269 35266 68271 35310
Qty 1 3 3 4 1 1 2 1 1 1 2 1 4 2 2 1 22 22 3 1 1 1 1 2 1 1 1 1 1 1 1 1
Description PCB, LED lights w/connector Nut, 10-32 nylock Spacer, .2 ID x .375 OD x .25 long, plastic Breaker, 15A, 120V, 1-pole Receptacle, 240V/30A twist-lock Breaker, 30A, 250V, 2-pole, stud terminal w/aux Nut, 8-32 hex, G5 Kit, ground bar Switch, key Breaker, 10A, 240V, 1-pole, push button Nut, 10-32 hex, G2 Gauge, hour meter Washer, #10 split lock Screw, 10-32 x .500 pan phil, G2 Screw, 8-32 x 1.0 pan phil, SS Hinge, continuous - 11 in Screw, 6-32 x .250 pan phil, G2 Washer, #6 split lock Screw, 10-32 x .750 pan phil, G2 Panel, control - Kubota, 8kW Light, indicator red, 12VDC Breaker, 40A, 250V, 2-pole, screw terminal w/aux Breaker, 10A, 120V, 1-pole, push button Receptacle, 120V/20A GFI Assembly, control panel - Kubota Wire group - control panel wiring 8kW Wire group - 20A GFCI, red Wire group - 20A GFCI, black Wire group - light switches Wire group - LED light board Wire group - 30A L6-30R Wire group - 8kW LT control box
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
31
COOLING SYSTEM ASSEMBLY
1 5 8
7
2
6 17
2 3 5 11 12
4 14 15
10
16
6
7 8
13
9 B A 01166
32
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
COOLING SYSTEM ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
Part No. 60690 60698 60703 60140 11683B 15627 60119 60271 60032 11413B 60364 16687 32383 60316 15422 12350 16688 60716 15422 13924
OPTIONAL FEATURES Engine Heater: A 15422 B 65649
33777 A
Qty 6 12 6 6 2 2 4 4 4 1 9 1 1 2 2 1 1 1 2 1
2 1
Description Screw, .375-16 x 1.0 std hex, SS Washer, .375 flat .875/.040, SS Washer, .375 split lock, SS Nut, .375-16 hex, G5 Bracket, radiator Clamp, tubing - .625 heavy duty Washer, .312 flat .875/.070 Washer, .312 split lock Nut, M8-1.25 hex, G8.8 Guard, fan Screw, 10-16 x .500 std hex, G2, self-drilling Hose, radiator - upper Hose, radiator - upper Clamp, hose - SAE 032 (1.56-2.50) Clamp, hose - SAE 020 (.75-1.75) Hose, radiator - lower Hose, radiator - lower Clamp, tubing - 1.50 light duty Clamp, hose - SAE 020 (.75-1.75) Radiator, w/fan guard - welded
Notes
MLT4060/80KV only MLT4060MV only MLT4060/80KV only MLT4060MV only MLT4060/80KV only MLT4060MV only MLT4060/80KV only
Clamp, hose - SAE 020 (.75-1.75) Heater, engine - lower radiator hose
MLT4060KV/MV-MLT4080KV Parts Manual
33
ENGINE AND GENERATOR TO UNIT
1 2
To control box
7 8 4
6
5
B
7 4
7
A
C E D G
F
F 2 H
3 4 01167
34
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
ENGINE AND GENERATOR TO UNIT Item 1 2 3 4 5 6 7 8
Part No. 60205 60698 60206 60140 60495 60026 60747 16155
OPTIONAL FEATURES Drain Valve: A 60774 60766 B 60365 C 50201 12227 D 60205 E 60206 F 60698 G 60716 H 60144 Silent Pack: -18496 -50709 -60498 -60774 -60365 -28213 -62076
33777 A
Qty 8 16 8 10 1 1 3 1
Description Screw, .375-16 x 1.0 std hex, G5 Washer, .375 flat .875/.040, SS Washer, .375 split lock Nut, .375-16 hex, G5 Screw, M10-1.25 x 16 - std hex, G8.8 Washer, M10 - split lock Washer, .375 internal star Assembly, wire - engine/chassis ground
Notes
1 1 1 3 ft 1 1 1 2 1 1
Valve, drain 22mm - 1.5 with nipple Valve, drain 18mm - 1.5 with nipple Clamp, hose - SAE 010 (.56-1.06) Hose, .625 in., 200 psi, class A Hose, oil drain, .375 x 20, SAE 30R7 Screw, .375-16 x 1.0 std hex, G5 Washer, .375 flat .875/.040, SS Washer, .375 flat .875/.040, SS Clamp, tubing - 1.50 light duty Nut, .25-20 nylock, G5
MLT4060/80KV only MLT4060MV only
1 3 ft 1 1 2 1 1
Fitting, bushing - 2.50 OD x 2.0 ID Hose, .625 in., 300 psi Fitting, plug - .750NPT square drive Valve, drain with nipple Clamp, hose - SAE 010 (.56-1.06) Fitting, .750NPT street elbow Fitting, strt - .750MNPT x .625 barb
MLT4060KV/MV-MLT4080KV Parts Manual
MLT4060/80KV only MLT4060MV only MLT4060/80KV only MLT4060/80KV only MLT4060/80KV only MLT4060/80KV only MLT4060/80KV only
35
ENGINE ASSEMBLY - MITSUBISHI LEFT SIDE
1 2
31
4
3 4
35 5 36 34
6
6
8
7
9 10
11 12 33
13
14 32 29
15 3
31
30
19
4
18
16
16
16
21
22 1 2
20
16
17
20 A 23
4 24
29 28
20
36
25 20
27
26
MLT4060KV/MV-MLT4080KV Parts Manual
01170
33777 A
ENGINE ASSEMBLY - MITSUBISHI LEFT SIDE Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 --
Part No. 60422 60026 60285 60119 16551B 60316 16589 16742 63288 60286 16692 13513 11691 11148 16691 60778 14211 14211 17145 60777 50018 60649 12838B 60256 17641 17647 50018 60144 60243 13278 60271 60393 32885 34066 61061 16444 16677
OPTIONAL FEATURES Heated Fuel Filter: A 13876 Cold Weather Belt: -10386
Qty 4 4 6 8 1 2 1 1 4 4 1 2 1 1 1 4 1.04 ft .16 ft 1 4 1 ft 1 1 2 1 1 1.04 ft 2 4 1 4 2 1 1 2 1 1
Description Screw, M10-1.25 x 25 std hex, G8.8 Washer, M10 split lock Nut, .312-18 hex, G2 Washer, .312 flat .875/.070 Bracket, air cleaner - black Clamp, hose - SAE 032 (1.56-2.50) Hose, air cleaner Fan, Mitsubishi Screw, M6-1.0 x 12 pan head, G8.8 Washer, .250 split lock V-belt, Mitsubishi Bolt w/washer Bracket, lower radiator hose guard Dipstick, oil Filter, oil - Mitsubishi Clamp, hose - .188, crimp style Hose, fuel - .188 ID, 50 psi, SAE 30R7 Hose, fuel - .188 ID, 50 psi, SAE 30R7 Fitting, T - .188 x .188 x .188 barb, nylon Clamp, hose - .312, crimp style Hose, fuel - .312 ID, 50 psi, SAE 30R7 Clamp, tubing - .750 heavy duty Bracket, fuel filter/pump, black Screw, .312-18 x 1.50 std hex, G5, fully threaded Filter, fuel Filter, fuel, element Hose, fuel - .312 ID, 50 psi, SAE 30R7 Nut, .250-20 nylock, G5 Washer, .250 flat .735/.060 Fuel pump, electric Washer, .312 split lock Screw, .250-20 x 1.0 std hex, G5 Engine - Mitsubishi LE3 Filter, air, w/bracket Screw, .312-18 x .875 std hex, G5 Element, air filter Switch, oil pressure
1
Kit, heater - fuel filter, Mitsubishi
1
Belt, cold weather - Mitsubishi, 6kW & 8kW
Notes
Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated. OEM warranty parts must be purchased through an OEM dealer. Please contact Generac Mobile Products with questions.
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
37
ENGINE ASSEMBLY - MITSUBISHI RIGHT SIDE
19
18 17
1
6
2 7 4
16 15
3
5 14 8 1 2 11 12
4 3 13
10
9
8
01171
38
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
ENGINE ASSEMBLY - MITSUBISHI RIGHT SIDE Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 --
Part No. 60275 60702 60422 60026 70130B 11147 16833 15241 15074 15073 60747 60495 16554B 16743 60032 60029 16678 11042 13710 10457
OPTIONAL FEATURES Silent Pack: -34776
Qty 2 2 8 8 1 1 1 2 1 1 1 1 1 1 4 4 1 1 1 1
1
Description Screw, .500-13 x 1.0 std hex, G5 Washer, .500 split lock, SS Screw, M10-1.25 x 25 std hex, G8.8 Washer, M10 split lock Weldment, engine mount - right, black Cap, oil filler Starter Isolator, rubber - 80-200 lbs, 2 in. wide Cable, battery - 38 in., 4GA red, .438 lug Cable, battery - 24 in., 4GA black, .438 lug Washer, .375 internal star Screw, M10-1.25 x 16 std hex, G8.8 Weldment, engine mount - LH, black Alternator Nut, M8-1.25 hex, G8.8 Washer, M8 split lock Switch, temperature sensor Gasket, muffler Muffler, 30 degree flare Harness, engine - Mitsubishi
Notes
Muffler, Mitsubishi modified
Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated. OEM warranty parts must be purchased through an OEM dealer. Please contact Generac Mobile Products with questions.
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
39
ENGINE ASSEMBLY - KUBOTA LEFT SIDE
29
2
23
1
28
19 27 30 25
3
27 26
4
24
5
15 22 6 23 19
21 20
8 7
6 9 19 18
10
17
19
A
18 17
11
11
12 11 13
16
B C
D
15 14
40
01168
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
ENGINE ASSEMBLY - KUBOTA LEFT SIDE Item 1 2 3 4 5 6 7 8 9 10 --
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
Part No. 15495 60087 11628 14099 10775 60778 14211 14211 17145 13481 13515 60777 50018 13278 60393 60243 50018 62001 60271 60119 61082 60029 13483B 60285 60144 41235ZY 16589 60316 34066 16444 13310 13281
OPTIONAL FEATURES Heated Fuel Filter: A 13834 B 13682 C 10407 D 13515 -10662 -13684
Qty 1 4 1 1 1 4 1.3 ft .167 ft 1 1 1 4 1.67 ft 1 2 4 1 ft 4 4 8 2 2 1 4 2 2 1 2 1 1 1 1
1 1 1 1 1 1
Description Fan, engine Screw, M6-1.0 x 16 sflg hex, G8.8 Belt, V Switch, coolant temperature Filter, oil Clamp, hose - .188, crimp style Hose, fuel - .188 ID, 50 psi, SAE 30R7 Hose, fuel - .188 ID, 50 psi, SAE 30R7 Fitting, T - .188 x .188 x .188 barb, nylon Filter, fuel Element, fuel filter Clamp, hose - .312, crimp style Hose, fuel - .312 ID, 50 psi, SAE 30R7 Pump, fuel Screw, .250-20 x 1.0 std hex, G5 Washer, .250 flat .735/.060 Hose, fuel - .312 ID, 50 psi, SAE 30R7 Screw, .312-18 x 1.25 std hex, G5 Washer, .312 split lock Washer, .312 flat .875/.070 Screw, M8-1.25 x 20 std hex, G8 Washer, M8 split lock Weldment, filter bracket Nut, .312-18 hex, G2 Nut, .250-20 nylock, G5 Spacer, .75 OD x .44 ID x 1.0 long Hose, air cleaner Clamp, hose - SAE 032 (1.56-2.50) Filter, air, with bracket Element, air filter Engine, Kubota - D1005-E3BG1-MGM-1 Engine, Kubota - D1105BG
Notes
MLT4060KV only MLT4080KV only
Gasket, heated fuel filter Heater, fuel filter Adapter, heated fuel filter Element, fuel filter Harness, fuel filter heater - outside Harness, fuel filter heater - inside
Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated. OEM warranty parts must be purchased through an OEM dealer. Some Kubota engine parts are serial number specific. Please contact Kubota Engine America Corp. or the Generac Mobile Products Technical Service Department for information regarding engine parts.
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
41
ENGINE ASSEMBLY - KUBOTA RIGHT SIDE
1 17 18 16 2 14 3
15
4
13
12 10 9
11 5
2
7
1
6
8 3
4
42
MLT4060KV/MV-MLT4080KV Parts Manual
01169
33777 A
ENGINE ASSEMBLY - KUBOTA RIGHT SIDE Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 --
Part No. 60422 60026 12338B 15241 15074 15073 60747 60495 63168 60029 60702 60275 13709 11042 14099 12486 12484 30582 13298 10461
OPTIONAL FEATURES Silent Pack: -36391
Qty 8 8 2 2 1 1 1 1 4 4 2 2 1 1 1 1 1 1 1 1
1
Description Screw, M10-1.25 x 25 std hex, G8.8 Washer, M10 split lock Weldment, engine mount Isolator, rubber - 80-200 lbs, 2 in. wide Cable, battery - 38 in., 4GA red, .438 in. lug Cable, battery - 24 in., 4GA black, .438 in. lug Washer, .375 internal star Screw, M10-1.25 x 16 std hex, G8.8 Screw, M8-1.25 x 30 std hex Washer, M8 split lock Washer, .500 split lock, SS Screw, .500-13 x 1.0 std hex, G5 Muffler, 30 degree flare Gasket, muffler Switch, coolant temperature Alternator Cap, oil filler Starter Starter Harness, engine - Kubota
Notes
MLT4060KV only MLT4080KV only
Muffler, Kubota modified
Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated. OEM warranty parts must be purchased through an OEM dealer. Some Kubota engine parts are serial number specific. Please contact Kubota Engine America Corp. or the Generac Mobile Products Technical Service Department for information regarding engine parts.
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
43
GENERATOR ASSEMBLY
2 1
22
5
4 3
20 21
20
2 6 7
19
8
18
To Engine
9 17 16
15 10
14
11 12 13
44
01172
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
GENERATOR ASSEMBLY Item 1
Part No. 12736
Qty 1
Description Cover, generator - 6kW
11338
1
Cover, generator - 8kW
60398 60168 60165 60166
6 6 6 18
Screw, 10-32 x 5.0 pan phil, SS Screw, .312-18 x .750 std hex, G5 Screw, M8-1.25 x 16 std hex, G10 Washer, M8 flat
11336 16123 11339 12527 12329
6 1 1 1 1
Screw, .375-24 x 1.75 Plate, drive - SAE 6.5 Spacer, generator drive plate Fan, generator Seal, pancake bearing - 6kW
11337
1
O-ring, pancake bearing - 8kW
12328
1
Bearing, pancake - 6kW
16134
1
Bearing, pancake - 8kW
16556
1
Generator, Marathon - 6kW
18 19 20 21 22
10486 15045 60206 60205 15241 60702 60275 60352 60494 60206 60026 12327 14219 16395 61045 35132
1 1 2 2 2 2 2 8 8 8 8 1 1 2 2 1
Generator, Marathon - 8kW Bracket, generator Washer, .375 split lock Screw, .375-16 x 1.0 std hex, G5 Isolator, rubber - 80-200 lbs, 2 in. wide Washer, .500 split lock, SS Screw, .50-13 x 1.0 std hex, G5 Screw, .375-16 x 1.25 std hex, G5 Screw, M10-1.25 x 30 std hex, G8.8 Washer, .375 split lock Washer, M10 split lock Cover, pancake case Strain relief - .75 Romex w/nut Clamp, capacitor Nut, 10-32 sflg Capacitor, 25μF 440V - 6kW
--
35406 16153
1 1
Capacitor, 25μF 550V - 8kW Harness, generator - 6kW
2 3 --
4 5 6 7 8 --
--
9
10 11 12 13 14 15 16 17
Notes MLT4060MV/KV only MLT4080MV/KV only MLT4060/80KV only MLT4060MV only MLT4060MV only (qty 12 only)
Included w/item 9, MLT4060MV/KV only Included w/item 9, MLT4080KV only Included w/item 9, MLT4060MV/KV only Included w/item 9, MLT4080KV only MLT4060MV/KV only MLT4080KV only
MLT4060/80KV only MLT4060MV only MLT4060/80KV only MLT4060MV only
MLT4060MV/KV only MLT4080KV only
Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated. OEM warranty parts must be purchased through an OEM dealer. Please contact Generac Mobile Products with questions.
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
45
FUEL TANK AND BALLAST BOXES TO UNIT
1 18 17
13
2 A
16 4 15
3
13
14 12
11
5 6 7
9
8
10 1 01173
46
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
FUEL TANK AND BALLAST BOXES TO UNIT Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 --
Part No. 60358 12359B 50187 12080 60028 60271 60119 10656 62086 60698 39998 12259 60777 50018 15142 14211 16271 12361B 69632
OPTIONAL FEATURES Lanyard Fuel Cap: A 12137
33777 A
Qty 2 1 2 1 12 12 12 4 12 1 1 1 4 2.42 ft 1 1.3 ft 1 1 1
1
Description Nut, .375-16 nylock, G5 Weldment, fuel tank strap, large Seal, D-shaped Cap, fuel tank Screw, .312-18 x 1.0 std hex, G5 Washer, .312 split lock Washer, .312 flat .875/.070 Assembly, transformer Nut, .312-18 U-clip - short type Washer, .375 flat .875/.040, SS Tank, fuel, 56 gallon Tube, fuel pickup, 24 in Clamp, hose - .312, crimp style Hose, fuel - .312 ID, 50 psi, SAE 30R7 Fitting, strt - .250NPT x .312 barb Hose, fuel - .188 ID, 50 psi, SAE 30R7 Fitting, 90° - .250NPT x .188 barb Weldment, fuel tank strap Tank assembly, fuel - 30 gallon poly
Notes
Cap, fuel tank, with lanyard
MLT4060KV/MV-MLT4080KV Parts Manual
47
TRAILER ASSEMBLY 1 2 3
2
4 5
7 7
10
9
26
6
27
8
29
18
30 27
21 28 21
20
19
17 9
21 26
27
7 27
26
10
22 23 11
25
12
24
13 16
11 13
15
14 01174
48
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
TRAILER ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 --
Part No. 60690 60698 12358B 60703 60140 11681 14326 33237B 12408Z 11682 60503 19637 60504 60096 15976 Page 52 35275 35274 35273 35272 62221 23254 23256 12647 23367 50215 60309 60416 16830 33724B 14129
OPTIONAL FEATURES Silent Pack: -33243B Trailer Plug Adapters: -65463 -65464 -65465
33777 A
Qty 3 6 1 3 3 1 3 1 2 2 4 8 4 10 2 1 2 2 2 2 4 1 1 1 2 4 3 8 1 1 1
Description Screw, .375-16 x 1.0 std hex, SS Washer, .375 flat .875/.040, SS Pan, fuel tank Washer, .375 split lock, SS Nut, .375-16 hex, G5 Jack, side wind - 2000 lb Ring, retaining Weldment, chassis Weldment, outrigger Jack, top wind - 2000 lb Screw, shackle, .562-18 x 3.0 std hex, G5 Plate, shackle bracket Nut, .562-18 lock, G5 Nut, .500-20 lug, G5 Wheel, ST175/80D13, 1360 lb Assembly, axle Washer, .375 flat .416 x .820 x .057 Cotter pin, 5/64 x 1.0 Spring, compression, .562 x 1.50 Pin, plunger, .375 Nut, .500-13 nylock, G5 Jack, top wind - 2000 lb, tube-mounted Pin, jack - 2000 lb, tube mount Cable, tether - jack pin and ground rod cover Chain, safety Screw, .500-13 x 4.0 std hex, G5 Washer, .500 flat 1.060/.090 Washer, .500 flat 1.375/.090 Coupler, 2.0 ball/2.50 channel Weldment, removable tongue Harness, main trailer
1
Weldment, chassis, containment
1 1 1
Adapter, trailer wiring - flat 4 to round 6 pin Adapter, trailer wiring - flat 4 to round 7 pin Adapter, trailer wiring - flat 4 to round 7 blade
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
49
TRAILER - JACK AND HITCH OPTIONS
1
6
2
5 2 4 5
3
3
4
19
5
18
4 3 2
18
9
17
16
7 8
6
15 14 13
9 12 11
10 01883
50
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
TRAILER - JACK AND HITCH OPTIONS Item Part No. Qty Tube Mount Jack Options: 1 11978 1 2 61036 12 3 11965Z 3 4 60698 36 5 60358 12 6 23254 2 7 23256 3 8 12647 3 Hitch Options: 9 12155B 2 10 60376 2 11 13003B 1 12 11672B 1 13 16835B 1 14 16999B 1 15 16741ZC 1 16 12229 1 17 50215 2
Description Jack, side wind - 2000 lb, tube mount Screw, .375-16 x 1.25 std hex, SS Weldment, jack adapter Washer, .375 flat .875/.040, SS Nut, .375-16 nylock, G5 Jack, top wind - 2000 lb, tube mount Pin, jack - 2000 lb, tube mount Cable, tether - jack pin and ground rod cover Spacer, coupler Screw, .500-13 x 4.50 std hex, G5 Coupler, 2.0 ball/3.0 channel Weldment, hitch - 3.0 x 1.625 ring/2.50 tube Weldment, lunette ring - 3.0 x 1.0 ring/2.50 tongue Weldment, lunette ring - 2.5 x 1.0 ring/2.50 tongue Weldment, combo hitch - 2.50 tongue Coupler, 2.31 ball/3.0 channel Screw, .500-13 x 4.0 std hex, G5
18
60309
4
Washer, .500 flat 1.060/.090
19
62221
2
Nut, .500-13 nylock, G5
33777 A
Notes
MLT4060KV/MV-MLT4080KV Parts Manual
Attaches item 10
Attaches items 11 - 15 Attaches items 11 - 15 Attaches items 10 - 15
51
AXLE ASSEMBLY
1
3
2 9 8
4
7
6 5
01746
52
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
AXLE ASSEMBLY Item 1 2 3 4 5 6 7 8 9
33777 A
Part No. 11206 60674 11201 16593 12460 11203 11202 13000 11511
Qty 2 10 4 1 2 8 2 2 4
Description Axle hub w/studs and outer races Stud, wheel, .500-20 wheel, G8 Bolt, U - 2200 lb Axle, 2200 lb 56TC 45SC Cap, wheel bearing Nut, U-bolt, 2200 lb Tie-plate, 2200 lb Seal - 2200 lb Bearing, roller
MLT4060KV/MV-MLT4080KV Parts Manual
Notes
53
RECOMMENDED SPARE PARTS LIST (1 OF 2) ENGINE - COMMON Cap, radiator..................................................................................................... 19219 Element, air filter............................................................................................... 16444 Fuel pump......................................................................................................... 13278 ENGINE - KUBOTA Alternator .......................................................................................................... 12486 Belt, fan ............................................................................................................ 11628 Dipstick ............................................................................................................. 12483 Element, fuel filter ............................................................................................. 13515 Element, oil filter ............................................................................................... 10775 Fan, engine....................................................................................................... 15495 Fuel shutdown solenoid.................................................................................... 13018 Hose, radiator - lower ....................................................................................... 12350 Hose, radiator - upper....................................................................................... 16687 Oil fill cap .......................................................................................................... 12484 Starter - MLT4060KV ........................................................................................ 30582 Starter - MLT4080KV ........................................................................................ 13298 Switch, coolant temperature ............................................................................ 14099 Switch, oil pressure .......................................................................................... 15375 ENGINE - MITSUBISHI Alternator .......................................................................................................... 16743 Belt, fan ............................................................................................................ 16692 Dipstick ............................................................................................................. 11148 Element, fuel filter ............................................................................................. 17647 Element, oil filter ............................................................................................... 16691 Fan, engine....................................................................................................... 16742 Fuel shutdown solenoid.................................................................................... 16683 Hose, radiator - lower ....................................................................................... 16688 Hose, radiator - upper....................................................................................... 32383 Oil fill cap .......................................................................................................... 11147 Starter............................................................................................................... 16833 Switch, coolant temperature ............................................................................ 16678 Switch, oil pressure .......................................................................................... 16677 Thermostat........................................................................................................ 16745 ELECTRICAL Assembly, light fixture - hard wired ................................................................... 13311 Assembly, light fixture - quick disconnect, cord clip .......................................... 13601 Breaker, main (4060 only) ................................................................................ 65963 Breaker, main (4080 only) ................................................................................ 65864 Breaker, lights ................................................................................................... 14249 Bulb, 1000W MH short length........................................................................... 11391 Capacitor, lights ................................................................................................ 65959 Capacitor, generator (4060 only) ...................................................................... 35132 Capacitor, generator (4080 only) ...................................................................... 35406 Coil cord ........................................................................................................... 33397 Contactor - electric winch ................................................................................. 11293 54
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
RECOMMENDED SPARE PARTS LIST (2 OF 2) GFI.................................................................................................................... 14130 Hour meter........................................................................................................ 15085 Key ................................................................................................................... 15309 Key switch ........................................................................................................ 15195 LED board w/wires ........................................................................................... 17647 Receptacle, 30A - twist lock ............................................................................. 14137 Relay, electric winch ......................................................................................... 65049 Sensor, proximity .............................................................................................. 65511 Transformer (ballast) ........................................................................................ 10930 MAINTENANCE KITS Kubota 250 hour service kit .............................................................................. SK151 Kubota 2000 hour service kit ............................................................................ SK152 Mitsubishi 250 hour service kit ......................................................................... SK170 Mitsubishi 2000 hour service kit ....................................................................... SK171 MAST Cable, 116 in..................................................................................................... 34132 Cable, 67.88 in ................................................................................................. 34130 Cable, 69.25 in ................................................................................................. 34128 Cable, 69.75 in ................................................................................................. 34129 TRAILER Jack, side wind (rear) ....................................................................................... 11681 Jack, top wind (outrigger) ................................................................................. 11682 Ring, retaining .................................................................................................. 14326
33777 A
MLT4060KV/MV-MLT4080KV Parts Manual
55
This Page Intentionally Left Blank
56
MLT4060KV/MV-MLT4080KV Parts Manual
33777 A
NOTES ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ 57
NOTES ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ 58
