Transcript
14
MODEL SHOWN: PRD48JDSGU PRO GRAND® STEAM RANGE
PRO GRAND® STEAM & PRO GRAND RANGES
PRO GRAND STEAM & PRO GRAND RANGES 27-INCH DEPTH Pretty only goes so far in the kitchen. When performance matters, when food and cooking matter, the Pro Grand Steam Range delivers. With its award-winning steam & convection oven, exclusive Star® Burners, and a convenient warming drawer, the Pro Grand Steam Range is the most versatile range on the market. Expect better taste, texture and quality. Expect faster, easier defrosting, steaming, baking and reheating. Proudly built in America, this range is yet another shining example of how Thermador is providing Real Innovations for Real Cooks™.
1.800.735.4328 | THERMADOR.COM
15
PRO GRAND® STEAM RANGE FEATURES & BENEFITS SEVEN COOKING OPTIONS The only range in the market with a steam and convection combination oven, plus a full-size convection oven and a warming drawer. This Ultimate Culinary Center™ features seven distinct cooking options that will forever change the way real cooks cook. EXTRALOW® This exclusive feature provides the widest variety of temperature control of any simmer system available, cycling the burner on and off to as low as 100 degrees.
22K BURNER Our powerful sealed Star® Burner delivers an industry-leading 22,000 BTU of pure cooking power for better searing and faster boiling.
GRILL ACCESSORY Our grill accessory (sold separately) features a titanium surface that is easy to clean and dishwasher-safe.
CONVECTION OVEN Thermador‘s True Convection system directs heat to cook food faster and more evenly with gourmet results.
STEAM AND CONVECTION OVEN The award-winning oven offers three distinct cooking variations: Steam only, Convection only or Steam & Convection Cooking which makes food crisp on the outside and moist on the inside, just like it was being served at a 5-star restaurant.
WARMING DRAWER The spacious 1.1 cubic-foot drawer can hold and warm up to 10 dinner plates on an all glass smooth surface. The heated glass technology provides uniform heat and is easy to clean.
12-INCH REMOVABLE GRIDDLE Our 12-inch titanium griddle is thermostatically controlled to deliver consistent, even heating across the entire surface. It is also removable for easy cleaning or interchange it with our grill accessory.
MODEL SHOWN: PRD48JDSGU PRO GRAND® STEAM RANGE
THERMADOR EXCLUSIVE 16
OUR EXCLUSIVE, PATENTED STAR® BURNER
HYDRAULIC SOFTCLOSE® HINGES
The Star Burner‘s unique shape isn‘t just for show. The Star delivers 56% more coverage with superior flame spread and a reduced cold spot for faster and more even heating across any size pan.
New Hydraulic SoftClose hinges prevent slamming and ensure ultra smooth closing of both ovens and the warming drawer.
QUICKCLEAN BASE™ The raised pedestal burner and porcelain maintop have been crafted for perfect integration and easy cleanup. A hand and sponge fit easily under each burner to wipe the surface clean and a teardrop emboss reduces food buildup near the base.
PRO GRAND STEAM RANGE
PRO GRAND® STEAM RANGE FEATURES & BENEFITS
TELESCOPIC RACKS Full Access® telescopic racks glide smoothly on ball bearings, allowing them to expand completely for safe, easy access to your meal. Plus, their robust construction safely supports the heaviest dishes while integrated easy-grip handles make them easy to use.
EXTRA-LARGE CAPACITY OVEN The extra-large capacity 5.1 cubic foot steam and convection oven offers maximum space for best-inclass cooking while the compact 1.4 cubic foot capacity convection oven lets you prepare smaller meals or multiple dishes when entertaining.
VERSATILE DESIGN OPTIONS Pro Grand Ranges feature striking stainless steel feet or you can add a stainless steel toekick accessory for a sleek, finished look. FASTEST SELF-CLEAN In just 2 hours, the interior walls and rack supports become perfectly clean, thanks to the fastest self-cleaning cycle on the market. STAR-K CERTIFIED Thermador Pro Grand Ranges are Star-K certified making it possible to use them on Holy Days and the Sabbath.
THERMADOR EXCLUSIVE 1.800.735.4328 | THERMADOR.COM
17
PRO GRAND® RANGES FEATURES & BENEFITS FASTEST SELF-CLEAN In just 2 hours, the interior walls and rack supports become perfectly clean, thanks to the fastest self-cleaning cycle on the market. EXTRALOW® Our ExtraLow feature provides the widest variety of temperature control of any simmer system. It cycles the Star Burner on and off to maintain temperatures as low as 100°. Each and every Thermador Pro Grand Range features four ExtraLow burners.
22K BURNER
OUR EXCLUSIVE, PATENTED STAR® BURNER
Our powerful sealed Star Burner delivers an industryleading 22,000 BTU of pure cooking power for better searing and faster boiling.
The Star Burner’s unique shape isn’t just for show. The Star delivers 56% more coverage with superior flame spread and a reduced cold spot for faster and more even heating across any size pan. The Star Burner’s coverage area allows for more ports and more flame distribution than a round burner.
35 ports / 16 3/4" perimeter
QUICKCLEAN BASE™ The raised pedestal burner and porcelain maintop have been crafted for perfect integration and easy cleanup. A hand and sponge fit easily under each burner to wipe the surface clean and a teardrop emboss reduces food buildup near the base.
28 ports / 10 3/4" perimeter The design of the Star Burner offers greater heat coverage, and a smaller cold spot, making it ideal for any pan size.
HYDRAULIC SOFTCLOSE® HINGES New Hydraulic SoftClose hinges prevent slamming and ensure ultra smooth closing of the oven door.
THERMADOR EXCLUSIVE 18
EXTRA-LARGE CAPACITY OVEN Our 36-inch and 48-inch dualfuel ovens offer a maximum capacity of 5.7 cubic feet and can accommodate full-sized commercial sheet pans.
PRO GRAND RANGES
PRO GRAND® RANGES FEATURES & BENEFITS
12-INCH REMOVABLE GRIDDLE Our 12-inch titanium griddle is thermostatically controlled to deliver consistent, even heating across the entire surface. It is also removable for easy cleaning or interchange it with our grill accessory.
GRILL ACCESSORY Our grill accessory (sold separately) features a titanium surface that is easy-to-clean and dishwasher-safe.
VERSATILE DESIGN OPTIONS Pro Grand Ranges feature striking stainless steel feet or you can add a stainless steel toekick accessory for a sleek, finished look. THIRD ELEMENT CONVECTION SYSTEM Thermador’s True Convection system directs heat to cook foods more evenly with gourmet results and 25% time savings. STAR-K CERTIFIED
TELESCOPIC OVEN RACKS Full Access® telescopic racks glide smoothly on ball bearings, allowing them to extend completely for safe, easy access to your meal. Plus, their robust construction safely supports the heaviest dishes while integrated easy-grip handles make them easy to use.
Thermador Pro Grand Ranges are Star-K certified making it possible to use them on Holy Days and the Sabbath.
1.800.735.4328 | THERMADOR.COM
19
PRO GRAND® RANGES PLANNING INFORMATION MODEL OPTIONS
DUAL-FUEL: ®
There are two sizes of Thermador Pro Grand Ranges to choose from — 36-inch and 48-inch — in your choice of all-gas or dual-fuel configurations. All models are 27-Inch deep and available in stainless steel or exclusive models available with porcelain cooktop. Dual-fuel models can be converted to Liquid Propane (LP) using the included kit. All-gas models are available in Natural Gas or Liquid Propane (LP) and should be ordered separately from the factory. Be sure to reference the correct model information in this design guide.
Thermador Pro Grand Dual-Fuel Ranges are dual rated, designed to be connected to either 240/208V AC, 60 Hz, 4-wire, single-phase power supply. The connection may be made with a range supply cord kit (purchased separately) or by hard-wiring to the power supply. A dedicated circuit breaker is required.
MODEL
240/208V AC, 60Hz PRD366JGU
35 Amp
PRD364JDGU
35 Amp
INSTALLATION CONSIDERATIONS
PRD486JDGU
50 Amp
The information in this design guide provides key features, product dimensions, cutouts and installation specifications. Before installing a Thermador Pro Grand Range, be sure to verify the cutout dimensions and electrical/gas connections. Also, always consult with the installation manual packed with the product for complete details before installing.
PRD48JDSGU
50 Amp
ALL-GAS: Thermador Pro Grand All-Gas Ranges are equipped with a 3-wire plug and are designed to be connected to a 120V AC, 60 Hz, single-phase power supply. A dedicated circuit breaker is required.
MODEL ELECTRICAL AND GAS SPECIFICATIONS Be sure your appliance is properly installed and grounded by a qualified technician. Installation, electrical and gas connections, and grounding must comply with all applicable local codes. GAS REQUIREMENTS AND HOOKUP Verify that the type of gas being used at the installation site matches the type of gas used by the appliance. If an LP kit is utilized, conversion from natural gas to propane must be done by qualified service personnel only. Please refer to the LP Conversion Instructions for further information. A manual gas shut-off valve must be installed external to the appliance, in a location accessible from the front, for the purpose of shutting off the gas supply. The supply line must not interfere with the back of the unit. NATURAL GAS REQUIREMENTS: Inlet Connection: 3/4" NPT external, 1/2" NPT internal (Minimum 3/4" diam. flex line) Supply Pressure: 6" min. to 14" max. water column (14.9 to 34.9 mb) Manifold Pressure: 5" water column (12.5 mb) PROPANE GAS REQUIREMENTS: Inlet Connection: 3/4" NPT external, 1/2" NPT internal (Minimum 3/4" diam. flex line) Supply Pressure: 11" min. to 14" max. water column (27.4 mb to 34.9 mb) Manifold Pressure: 10" water column (24.9 mb)
20
REQUIRED CIRCUIT BREAKER
REQUIRED CIRCUIT BREAKER 120V AC, 60Hz
PRG366JG - NG
15 Amp
PRL366JG - LP
15 Amp
PRG364JDG - NG
20 Amp
PRL364JDG - LP
20 Amp
PRG486JDG - NG
20 Amp
PRL486JDG - LP
20 Amp
IMPORTANT: The cord supplied with gas ranges having an electric griddle requires a NEMA 5-20 receptacle as shown here. Local codes my require a different wiring method. A dedicated 20 Amp service is required for proper operation. PLUG NEMA 5-20 RECEPTACLE
ELECTRICAL AND GAS LOCATIONS
VENTILATION REQUIREMENTS
Typical placement of the electrical and gas supply can be found within the ”Cutout and Range Dimensions“ located on the product pages. Alternate placement within the supply zone is acceptable. Dual-Fuel ranges may be connected to the power supply with a range supply cord kit (sold separately) or by hard-wiring to the power supply. All-gas ranges may be connected to the power supply with the supplied range cord or by hardwiring. It is the responsibility of the installer to provide the proper wiring components (cord or conduit and wires) and complete the electrical connection as dictated by local codes and ordinances and/or the National Electric Code. The units must be properly grounded.
We strongly recommend that a Thermador Professional Wall or Island Hood or Custom Insert be installed with all Thermador Pro Grand Ranges. Downdraft ventilation should not be used. Do not install a microwave-hood combination above the cooktop, as these types of units do not provide the proper ventilation and are not suitable for use with Thermador Pro Grand Ranges.
Installation of the range must be planned so that the rough-in of the junction box for the receptacle or conduit connection will allow maximum clearance to the rear of the unit.
For high output gas cooktops (60,000 BTU or greater), the minimum of one (1) CFM of ventilation per 100 BTU is recommended. If the cooktop has a grill or griddle, add 150 CFM to the estimated blower capacity. Additional blower capacity may be required for longer duct runs. The following table indicates the ventilation hood options that are recommended for use with Thermador Pro Grand Ranges. Refer to the Ventilation section or www.Thermador.com for a complete selection of Professional ventilation options, blowers, and accessories.
WIDTH CONFIGURATION VENTILATION OPTIONS 36"
WARRANTY
WARNING: All ranges can tip, causing injury. Install anti-tip device packed with range.
4 Burners w/Grill or Griddle 6 Burners
Limited warranty parts and labor (2 year) See page 302 for additional warranty details.
PRO GRAND RANGES
PRO GRAND® RANGES PLANNING INFORMATION
48"
6 Burners w/Grill or Griddle
36" or 42" Pro Wall Hood 36" Custom Insert with optional blower 42" or 48" Island Hood with optional blower 48" or 54" Pro Wall Hood 48" Custom Insert with optional blower 54" Island Hood with optional blower
Thermador Pro Grand® Ranges are CSA approved. DE SIGN
CERTIFIED
CE
R T IF I E D
1.800.735.4328 | THERMADOR.COM
21
PRO GRAND® RANGES 36-INCH DUAL-FUEL PRD366JGU
PRD366JGU INNOVATION - Patented Pedestal Star® Burner with QuickClean Base™ designed for easy surface cleaning and superior heat spread for any size pan - Powerful 22,000 BTU (NG) burner (front right) - Precision simmering capabilities as low as 100°F (375 BTU) with 4 ExtraLow® Simmer burners - SoftClose® hinges for ultra smooth closing of the oven door - Superfast 2-hour self-clean mode – fastest in the industry
PROFESSIONAL PRD366JGU
PERFORMANCE
Dual-Fuel Commercial-Depth Range, Porcelain Cooktop Surface
- 18,000 BTU (NG) Star® Burners - Electronic oven display interfaces to cook timer, meat probe and preheat status with audible alert - Powerful, 8-pass bake and broil elements - Third Element Convection offers precise airflow for cooking on multiple levels without flavor transfer - Large oven 5.7 cu. ft. – accommodates commercial sheet pan - Full Access® telescopic racks, integrated easy-grip handle - Six rack levels for multiple item cooking - Star-K certified
SPECIFICATIONS Total Number of Cooktop Burners
6
Product Width
35 15/16"
Product Height
35 7/8"– 36 3/4"
Product Depth
28 1/2"
DESIGN
Overall Oven Capacity* (cu. ft.) 5.7 Overall Oven Interior Dimensions (W x H x D)
28" x 16" x 22"
Usable Oven Interior Dimensions (W x H x D)
25 1/2" x 11 3/4" x 19 5/8"
Cutout Width
36"
Cutout Height
35 7/8"– 36 3/4"
Cutout Depth
24"– 25 1/8"
Cooktop Surface
Porcelain
Gas Cooktop Burners
1 @ 22,000 BTU / 5 @ 18,000 BTU (NG)
Oven Bake (Watts) Oven Broil (Watts) Convection (Watts)
2,400 4,000 2,750
Total Gas Connection Rating
112,000 BTU (NG)
- Bold Professional design - Pinhole and panel lighting concepts provide functional and stylish aesthetics - Restaurant style metal knobs - Professional style, continuous cast iron grates - Continuous porcelain, easy-to-clean cooking surface - Large oven door window for maximum viewing - Powerful halogen lighting illuminates the oven cavity - Hidden bake element makes cleanup one smooth surface - Signature blue indicator lighting THERMADOR EXCLUSIVE
LP Convertible
Included
Electrical Supply
240/208V AC, 60 Hz
Required Circuit Breaker
35 Amp
Power Cord
Purchase Separately
Shipping Weight (lbs.)
420
*According to AHAM Standards
ACCESSORIES PA36JLBG Low Backguard
PAGRIDDLE Griddle
PAKNOBLKJG Black Knob Kit
PA36JHSG High Shelf
PWOKRINGHC Wok Ring
PAKNOBLUJG Blue Knob Kit
PA36JTKG Toekick IMPORTANT NOTE: A Low Backguard, High Shelf or Island Trim is required for installation.
22
PA12CHPBLK 12" Cutting Board
PRD366JGU
INSTALLATION OPTIONS
36-INCH CUTOUT AND RANGE DIMENSIONS
®
Thermador Pro Grand Ranges feature a bold, professional design and a commercial-depth of 27-inches. These ranges can be installed in a wall or island installation. BACKGUARDS
PRO GRAND RANGES
PRO GRAND® RANGES 36-INCH DUAL-FUEL
When using the Flush Island Trim, Thermador recommends a minimum 12” (305 mm) rear clearance to a combustible surface (see Figure 1, Cabinet Clearances). Clearances from noncombustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction. NATURAL GAS OR LP Thermador Dual-Fuel Pro Grand Ranges are shipped by the factory to operate on natural gas. They must be converted for use with propane. Verify that the type of gas being used at the installation site matches the type of gas used by the appliance. If the location/job site requires conversion from natural gas to propane (LP), utilize the included LP kit. Field conversion must be done by qualified service personnel only. Please refer to the LP Conversion Instructions for further information. IMPORTANT We strongly recommend that a Thermador Professional Wall or Island Hood or Custom Insert be installed with all Thermador Pro Grand Ranges. Downdraft ventilation should not be used. Do not install a microwave-hood combination above the cooktop, as these types of units do not provide the proper ventilation and are not suitable for use with Thermador Pro Grand Ranges. Refer to the Ventilation section or www.Thermador.com for a complete selection of Professional ventilation options, blowers, and accessories. Due to the 27-inch commercial-depth of Pro Grand Ranges, the PH Professional Series Wall Hoods or Professional Series Custom Inserts would provide the appropriate depth from the wall to correspond to these ranges.
as defined in the “National Fuel Gas Code” (ANSI Z223.1, Current Edition). Clearances from non-combustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction.
NOTE: A 36-inch minimum clearance is required between the top of the cooking surface and the bottom of an unprotected cabinet. A 30-inch clearance can be used when the bottom of the wood or metal cabinet is protected by not less than 1/4 inch of a flame retardant material covered with not less than No. 28 MSG sheet steel, 0.015 inch (0.4 mm) thick stainless steel, 0.024 inch (0.6 mm) aluminum, or 0.020 inch (0.5 mm) thick copper.
HIGH ALTITUDE A high altitude kit is available through Customer Services as service part number 746376.
1.800.735.4328 | THERMADOR.COM
23
PRO GRAND® RANGES 36-INCH DUAL-FUEL PRD364JDGU
PRD364JDGU INNOVATION - Patented Pedestal Star® Burner with QuickClean Base™ designed for easy surface cleaning and superior heat spread for any size pan - Powerful 22,000 BTU (NG) burner (front right) - Precision simmering capabilities as low as 100°F (375 BTU) with 4 ExtraLow® Simmer burners - SoftClose® hinges for ultra smooth closing of the oven door - Superfast 2-hour self-clean mode – fastest in the industry
PROFESSIONAL PRD364JDGU
PERFORMANCE
Dual-Fuel Commercial-Depth Range, Porcelain Cooktop Surface
Overall Oven Capacity* (cu. ft.) 5.7
- 18,000 BTU (NG) Star® Burners - Titanium surface non-stick, rust-proof cast-aluminum griddle and grill, removable for easy cleanup - Electronic oven display interfaces to cook timer, meat probe and preheat status with audible alert - Powerful, 8-pass bake and broil elements - Third Element Convection offers precise airflow for cooking on multiple levels without flavor transfer - Large oven 5.7 cu. ft. – accommodates commercial sheet pan - Full Access® telescopic racks, integrated easy-grip handle - Six rack levels for multiple item cooking - Star-K certified
Overall Oven Interior Dimensions (W x H x D)
28" x 16" x 22"
DESIGN
Usable Oven Interior Dimensions (W x H x D)
25 1/2" x 11 3/4" x 19 5/8"
Cutout Width
36"
Cutout Height
35 7/8"– 36 3/4"
Cutout Depth
24"– 25 1/8"
Cooktop Surface
Porcelain
Gas Cooktop Burners
1 @ 22,000 BTU / 3 @ 18,000 BTU (NG)
Oven Bake (Watts) Oven Broil (Watts) Convection (Watts)
2,400 4,000 2,750
Total Gas Connection Rating
76,000 BTU (NG)
LP Convertible
Included
Electrical Supply
240/208V AC, 60 Hz
SPECIFICATIONS Total Number of Cooktop Burners
4
Product Width
35 15/16"
Product Height
35 7/8"– 36 3/4"
Product Depth
28 1/2"
Required Circuit Breaker
35 Amp
Power Cord
Purchase Separately
Shipping Weight (lbs.)
420
- Bold Professional design - Pinhole and panel lighting concepts provide functional and stylish aesthetics - Restaurant style metal knobs - Professional style, continuous cast iron grates - Continuous porcelain, easy-to-clean cooking surface - Large oven door window for maximum viewing - Powerful halogen lighting illuminates the oven cavity - Hidden bake element makes cleanup one smooth surface - Signature blue indicator lighting THERMADOR EXCLUSIVE
*According to AHAM Standards
ACCESSORIES PA36JLBG Low Backguard
PA12GRILHC Grill
PWOKRINGHC Wok Ring
PA36JHSG High Shelf
PAGRIDDLE Griddle
PAKNOBLKJG Black Knob Kit
PA36JTKG Toekick
PA12CVRJ 12" Griddle / Grill Cover
PAKNOBLUJG Blue Knob Kit
IMPORTANT NOTE: A Low Backguard, High Shelf or Island Trim is required for installation.
24
PA12CHPBLK 12" Cutting Board
PRD364JDGU
INSTALLATION OPTIONS
36-INCH CUTOUT AND RANGE DIMENSIONS
®
Thermador Pro Grand Ranges feature a bold, professional design and a commercial-depth of 27-inches. These ranges can be installed in a wall or island installation. BACKGUARDS
PRO GRAND RANGES
PRO GRAND® RANGES 36-INCH DUAL-FUEL
When using the Flush Island Trim, Thermador recommends a minimum 12” (305 mm) rear clearance to a combustible surface (see Figure 1, Cabinet Clearances). Clearances from noncombustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction. NATURAL GAS OR LP Thermador Dual-Fuel Pro Grand Ranges are shipped by the factory to operate on natural gas. They must be converted for use with propane. Verify that the type of gas being used at the installation site matches the type of gas used by the appliance. If the location/job site requires conversion from natural gas to propane (LP), utilize the included LP kit. Field conversion must be done by qualified service personnel only. Please refer to the LP Conversion Instructions for further information. IMPORTANT We strongly recommend that a Thermador Professional Wall or Island Hood or Custom Insert be installed with all Thermador Pro Grand Ranges. Downdraft ventilation should not be used. Do not install a microwave-hood combination above the cooktop, as these types of units do not provide the proper ventilation and are not suitable for use with Thermador Pro Grand Ranges. Refer to the Ventilation section or www.Thermador.com for a complete selection of Professional ventilation options, blowers, and accessories. Due to the 27-inch commercial-depth of Pro Grand Ranges, the PH Professional Series Wall Hoods or Professional Series Custom Inserts would provide the appropriate depth from the wall to correspond to these ranges.
as defined in the “National Fuel Gas Code” (ANSI Z223.1, Current Edition). Clearances from non-combustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction.
NOTE: A 36-inch minimum clearance is required between the top of the cooking surface and the bottom of an unprotected cabinet. A 30-inch clearance can be used when the bottom of the wood or metal cabinet is protected by not less than 1/4 inch of a flame retardant material covered with not less than No. 28 MSG sheet steel, 0.015 inch (0.4 mm) thick stainless steel, 0.024 inch (0.6 mm) aluminum, or 0.020 inch (0.5 mm) thick copper.
HIGH ALTITUDE A high altitude kit is available through Customer Services as service part number 746376.
1.800.735.4328 | THERMADOR.COM
25
PRO GRAND® RANGES 48-INCH DUAL-FUEL PRD486JDGU
PRD486JDGU INNOVATION - Patented Pedestal Star® Burner with QuickClean Base™ designed for easy surface cleaning and superior heat spread for any size pan - Powerful 22,000 BTU (NG) burner (front right) - Precision simmering capabilities as low as 100°F (375 BTU) with 4 ExtraLow® Simmer burners - SoftClose® hinges for ultra smooth closing of the oven door - Cleans both ovens simultaneously in just 2 hours
PROFESSIONAL PRD486JDGU
PERFORMANCE
Dual-Fuel Commercial-Depth Range, Porcelain Cooktop Surface
- 18,000 BTU (NG) Star® Burners - Titanium surface non-stick, rust-proof cast-aluminum griddle and grill, removable for easy cleanup - Electronic oven display interfaces to cook timer, meat probe and preheat status with audible alert - Full featured small oven with convection, broil, self clean and meat probe - Powerful, 8-pass bake and broil elements in large oven and 6-pass elements in small oven - Third Element Convection offers precise airflow for cooking on multiple levels without flavor transfer - Large oven 5.7 cu. ft. – accommodates commercial sheet pan plus 2.5 cu. ft. in small oven - Full Access® telescopic racks, integrated easy-grip handle - Six rack levels in each oven for multiple item cooking - Star-K certified
SPECIFICATIONS Total Number of Cooktop Burners
6
Product Width
47 15/16"
Product Height
36 3/4"
Product Depth
28 1/2"
Overall Oven Capacity* (cu. ft.) 5.7 / 2.5 28" x 16" x 22" (Lg) 12 3/8" x 16" x 22" (Sm)
Overall Oven Interior Dimensions (W x H x D) Usable Oven Interior Dimensions (W x H x D)
25 1/2" x 11 3/4" x 19 5/8" (Lg) 9 7/8" x 11 3/4" x 19 5/8" (Sm)
Cutout Width
48"
Cutout Height
35 7/8"– 36 3/4"
Cutout Depth
24"– 25 1/8"
DESIGN
Cooktop Surface
Porcelain
Gas Cooktop Burners
1 @ 22,000 BTU / 5 @ 18,000 BTU (NG)
12" Center Electric Griddle
6-pass, 1,630 Watts
Oven Bake (Watts) Oven Broil (Watts) Convection (Watts)
2,400 (Lg) / 2,250 (Sm) 4,000 (Lg) / 3,600 (Sm) 2,750 (Lg) / 1,800 (Sm)
Total Gas Connection Rating
112,000 BTU (NG)
LP Convertible
Included
- Bold Professional design - Pinhole and panel lighting concepts provide functional and stylish aesthetics - Restaurant style metal knobs - Professional style, continuous cast iron grates - Continuous porcelain, easy-to-clean cooking surface - Hidden bake element makes cleanup one smooth surface - Large oven door window for maximum viewing - Powerful halogen lighting illuminates the oven cavity - Signature blue indicator lighting
Electrical Supply
240/208V AC, 60 Hz
Required Circuit Breaker
50 Amp
Power Cord
Purchase Separately
Shipping Weight (lbs.)
590
THERMADOR EXCLUSIVE
*According to AHAM Standards
ACCESSORIES PA48JLBG Low Backguard
PA12GRILHC Grill
PWOKRINGHC Wok Ring
PA48JHSG High Shelf
PAGRIDDLE Griddle
PAKNOBLKJG Black Knob Kit
PA48JTKG Toekick
PA12CVRJ 12" Griddle / Grill Cover
PAKNOBLUJG Blue Knob Kit
IMPORTANT NOTE: A Low Backguard, High Shelf or Island Trim is required for installation.
26
PA12CHPBLK 12" Cutting Board
PRD486JDGU
INSTALLATION OPTIONS
48-INCH CUTOUT AND RANGE DIMENSIONS
®
Thermador Pro Grand Ranges feature a bold, professional design and a commercial-depth of 27-inches. These ranges can be installed in a wall or island installation. BACKGUARDS
PRO GRAND RANGES
PRO GRAND® RANGES 48-INCH DUAL-FUEL
When using the Flush Island Trim, Thermador recommends a minimum 12” (305 mm) rear clearance to a combustible surface (see Figure 1, Cabinet Clearances). Clearances from noncombustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction. NATURAL GAS OR LP Thermador Dual-Fuel Pro Grand Ranges are shipped by the factory to operate on natural gas. They must be converted for use with propane. Verify that the type of gas being used at the installation site matches the type of gas used by the appliance. If the location/job site requires conversion from natural gas to propane (LP), utilize the included LP kit. Field conversion must be done by qualified service personnel only. Please refer to the LP Conversion Instructions for further information. IMPORTANT We strongly recommend that a Thermador Professional Wall or Island Hood or Custom Insert be installed with all Thermador Pro Grand Ranges. Downdraft ventilation should not be used. Do not install a microwave-hood combination above the cooktop, as these types of units do not provide the proper ventilation and are not suitable for use with Thermador Pro Grand Ranges. Refer to the Ventilation section or www.Thermador.com for a complete selection of Professional ventilation options, blowers, and accessories. Due to the 27-inch commercial-depth of Pro Grand Ranges, the PH Professional Series Wall Hoods or Professional Series Custom Inserts would provide the appropriate depth from the wall to correspond to these ranges.
as defined in the “National Fuel Gas Code” (ANSI Z223.1, Current Edition). Clearances from non-combustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction.
NOTE: A 36-inch minimum clearance is required between the top of the cooking surface and the bottom of an unprotected cabinet. A 30-inch clearance can be used when the bottom of the wood or metal cabinet is protected by not less than 1/4 inch of a flame retardant material covered with not less than No. 28 MSG sheet steel, 0.015 inch (0.4 mm) thick stainless steel, 0.024 inch (0.6 mm) aluminum, or 0.020 inch (0.5 mm) thick copper.
HIGH ALTITUDE A high altitude kit is available through Customer Services as service part number 746376.
1.800.735.4328 | THERMADOR.COM
27
PRO GRAND® STEAM RANGES 48-INCH DUAL-FUEL STEAM PRD48JDSGU
PRD48JDSGU INNOVATION - The only professional range on the market with a built-in steam oven and warming drawer - 27 easy cook food programs. Pre-programmed modes automatically set the oven temperature and humidity to ensure perfect cooking results - Patented Pedestal Star® Burner with QuickClean Base™ designed for easy surface cleaning and superior heat spread for any size pan - Powerful 22,000 BTU (NG) burner (front right) - Precision simmering capabilities as low as 100°F (375 BTU) with 4 ExtraLow® Simmer burners - SoftClose® hinges for ultra smooth closing of both ovens and the warming drawer - Glass surface warming drawer
PROFESSIONAL PRD48JDSGU Dual-Fuel Commercial-Depth Steam Range, Porcelain Cooktop Surface
SPECIFICATIONS Total Number of Cooktop Burners
6
PERFORMANCE
Product Width
47 15/16"
Product Height
35 7/8"– 36 3/4"
Product Depth
28 1/2"
Overall Oven Capacity* (cu. ft.)
5.1 / 1.4
Overall Oven Interior Dimensions (W x H x D)
25" X 16" X 22" (Lg) 14 3/8" X 10 1/2" X 15 7/8" (Sm)
Usable Oven Interior Dimensions (W x H x D)
25 1/2" x 11 3/4" x 19 5/8" (Lg) 12" x 7 3/4" x 15 5/8" (Sm)
Warming Drawer Interior Capacity (cu. ft.)
1.1
Overall Warming Drawer Interior Dimensions (W x H x D)
14 1/8" X 6 3/8" X 20 5/8"
Usable Warming Drawer Capacity Dimensions (W x H x D)
13 3/8" X 4 5/8" X 18 1/2"
Cutout Width
48"
Cutout Height
35 7/8"– 36 3/4"
Cutout Depth
24"– 25 1/8"
Cooktop Surface
Porcelain
Gas Cooktop Burners
1 @ 22,000 BTU / 5 @ 18,000 BTU (NG)
12" Center Electric Griddle
6-pass, 1,630 Watts
Oven Bake (Watts)
2,400
Oven Broil (Watts)
4,000
Convection (Watts) Total Gas Connection Rating
2,750 (Lg) / 1,800 (Sm) 112,000 BTU (NG)
LP Convertible
Included
Electrical Supply
240/208V AC, 60 Hz
Required Circuit Breaker
50 Amp
Power Cord
Purchase Separately
Shipping Weight (lbs.)
590
- 18,000 BTU (NG) Star® Burners - Titanium surface non-stick, rust-proof cast-aluminum griddle and grill, removable for easy cleanup - 1.4 cu. ft. steam cavity easily accommodates a 14 lb. turkey - Steam oven features 9 advanced conventional cooking modes - Steam cavity is non-plumbed, for easy installation into any home - Steam Clean function helps keep the steam oven spotless - Electronic oven display interfaces to cook timer, meat probe and preheat status with audible alert - Third Element Convection offers precise airflow for cooking on multiple levels without flavor transfer - Powerful, 4,000 Watt 8-pass broil elements in large oven - Full Access® telescopic racks, integrated easy-grip handle - Spacious 1.1 cu. ft. warming drawer holds up to ten 11" dinner plates - Drawer has open sides for easy and convenient access - Star-K certified DESIGN - Distinctive three door design showcases Thermador‘s self-assured bold and elegant design - Pinhole and panel lighting concepts provide functional and stylish aesthetics - Professional style, continuous cast iron grates - Continuous porcelain, easy-to-clean cooking surface - Hidden bake element makes cleanup one smooth surface - Large oven door window for maximum viewing THERMADOR EXCLUSIVE
*According to AHAM Standards
ACCESSORIES
28
PA48JLBSG Low Backguard
PA12GRILHC Grill
CS1XLPH Perforated Cooking Pan–Half Size
CS2LH Baking Tray
PA48JHSSG High Shelf
PAGRIDDLE Griddle
CS2XLPH Perforated Cooking Pan–Full Size
PAKNOBLKJG Black Knob Kit
PA48JTKG Toekick
PA12CVRJ 12" Griddle / Grill Cover
CS2XLH Cooking Pan– Full Size
PAKNOBLUJG Blue Knob Kit
CSRACKH Wire Rack
PWOKRINGHC Wok Ring
CS1XLH Cooking Pan– Half Size
PA12CHPBLK 12" Cutting Board
IMPORTANT NOTE: A Low Backguard, High Shelf or Island Trim is required for installation.
PRD48JDSGU
INSTALLATION OPTIONS
48-INCH CUTOUT AND RANGE DIMENSIONS
®
Thermador Pro Grand Ranges feature a bold, professional design and a commercial-depth of 27-inches. These ranges can be installed in a wall or island installation. BACKGUARDS
PRO GRAND RANGES
PRO GRAND® STEAM RANGES 48-INCH DUAL-FUEL STEAM
When using the Flush Island Trim, Thermador recommends a minimum 12” (305 mm) rear clearance to a combustible surface (see Figure 1, Cabinet Clearances). Clearances from noncombustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction. NATURAL GAS OR LP Thermador Dual-Fuel Pro Grand Ranges are shipped by the factory to operate on natural gas. They must be converted for use with propane. Verify that the type of gas being used at the installation site matches the type of gas used by the appliance. If the location/job site requires conversion from natural gas to propane (LP), utilize the included LP kit. Field conversion must be done by qualified service personnel only. Please refer to the LP Conversion Instructions for further information. IMPORTANT We strongly recommend that a Thermador Professional Wall or Island Hood or Custom Insert be installed with all Thermador Pro Grand Ranges. Downdraft ventilation should not be used. Do not install a microwave-hood combination above the cooktop, as these types of units do not provide the proper ventilation and are not suitable for use with Thermador Pro Grand Ranges. Refer to the Ventilation section or www.Thermador.com for a complete selection of Professional ventilation options, blowers, and accessories. Due to the 27-inch commercial-depth of Pro Grand Ranges, the PH Professional Series Wall Hoods or Professional Series Custom Inserts would provide the appropriate depth from the wall to correspond to these ranges.
as defined in the “National Fuel Gas Code” (ANSI Z223.1, Current Edition). Clearances from non-combustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction.
NOTE: A 36-inch minimum clearance is required between the top of the cooking surface and the bottom of an unprotected cabinet. A 30-inch clearance can be used when the bottom of the wood or metal cabinet is protected by not less than 1/4 inch of a flame retardant material covered with not less than No. 28 MSG sheet steel, 0.015 inch (0.4 mm) thick stainless steel, 0.024 inch (0.6 mm) aluminum, or 0.020 inch (0.5 mm) thick copper.
HIGH ALTITUDE A high altitude kit is available through Customer Services as service part number 746376.
1.800.735.4328 | THERMADOR.COM
29
PRO GRAND® RANGES 36-INCH GAS PRG366JG / PRL366JG
PRG366JG / PRL366JG INNOVATION - Patented Pedestal Star® Burner with QuickClean Base™ designed for easy surface cleaning and superior heat spread for any size pan - Powerful 22,000/18,000 BTU (NG/LP) burner (front right) - Precision simmering capabilities as low as 100°F (375 BTU) with 4 ExtraLow® Simmer burners - SoftClose® hinges for ultra smooth closing of the oven door - Superfast 2-hour self-clean mode – fastest in the industry
PROFESSIONAL PRG366JG / PRL366JG
PERFORMANCE
Natural Gas / Liquid Propane (LP) Gas Commercial-Depth Range, Porcelain Cooktop Surface
- 18,000 BTU (NG) Star® Burners - Electronic oven display interfaces to cook timer, meat probe and preheat status with audible alert - Powerful, 30,000/25,000 BTU bake and 17,000 BTU broil burners (NG/LP) - Convection Bake offers precise multi-level baking results - Large oven 5.5 cu. ft. – accommodates commercial sheet pan - Full Access® telescopic racks, integrated easy-grip handle - Six rack levels for multiple item cooking - Star-K certified
SPECIFICATIONS PRG366JG
PRL366JG
Total Number of Cooktop Burners
6
Product Width
35 15/16"
Product Height
35 7/8"– 36 3/4"
Product Depth
28 1/2"
Overall Oven Capacity* (cu. ft.)
DESIGN
5.5
Overall Oven Interior Dimensions (W x H x D)
28" x 15" x 22"
Usable Oven Interior Dimensions (W x H x D)
25 1/2" x 11 3/4" x 19 5/8"
Cutout Width
36"
Cutout Height
35 7/8"– 36 3/4"
Cutout Depth
24"– 25 1/8"
Cooktop Surface Gas Cooktop Burners
Porcelain 1@ 1@ 22,000 BTU / 18,000 BTU / 5@ 5@ 18,000 BTU 15,000 BTU
Oven Bake Oven Broil
17,000 BTU 30,000 BTU
Total Gas Connection Rating
142,000 BTU 118,000 BTU Order LP or NG
Electrical Supply
120V AC, 60 Hz
Power Cord Shipping Weight (lbs.)
THERMADOR EXCLUSIVE
17,000 BTU 25,000 BTU
LP Convertible Required Circuit Breaker
- Bold Professional design - Pinhole and panel lighting concepts provide functional and stylish aesthetics - Restaurant style metal knobs - Professional style, continuous cast iron grates - Continuous porcelain, easy-to-clean cooking surface - Large oven door window for maximum viewing - Powerful halogen lighting illuminates the oven cavity - Signature blue indicator lighting
15 Amp 96", 3-Wire 420
*According to AHAM Standards
ACCESSORIES PA36JLBG Low Backguard
PAGRIDDLE Griddle
PAKNOBLKJG Black Knob Kit
PA36JHSG High Shelf
PWOKRINGHC Wok Ring
PAKNOBLUJG Blue Knob Kit
PA36JTKG Toekick IMPORTANT NOTE: A Low Backguard, High Shelf or Island Trim is required for installation.
30
PA12CHPBLK 12" Cutting Board
PRG366JG / PRL366JG
INSTALLATION OPTIONS
36-INCH CUTOUT AND RANGE DIMENSIONS
®
Thermador Pro Grand Ranges feature a bold, professional design and a commercial-depth of 27-inches. These ranges can be installed in a wall or island installation. BACKGUARDS
PRO GRAND RANGES
PRO GRAND® RANGES 36-INCH GAS
When using the Flush Island Trim, Thermador recommends a minimum 12” (305 mm) rear clearance to a combustible surface (see Figure 1, Cabinet Clearances). Clearances from noncombustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction. NATURAL GAS OR LP Thermador All-Gas Pro Grand Ranges are shipped by the factory to operate on natural gas. They must be converted for use with propane. Verify that the type of gas being used at the installation site matches the type of gas used by the appliance. If the location/job site requires conversion from natural gas to propane (LP), utilize the included LP kit. Field conversion must be done by qualified service personnel only. Please refer to the LP Conversion Instructions for further information. IMPORTANT We strongly recommend that a Thermador Professional Wall or Island Hood or Custom Insert be installed with all Thermador Pro Grand Ranges. Downdraft ventilation should not be used. Do not install a microwave-hood combination above the cooktop, as these types of units do not provide the proper ventilation and are not suitable for use with Thermador Pro Grand Ranges. Refer to the Ventilation section or www.Thermador.com for a complete selection of Professional ventilation options, blowers, and accessories. Due to the 27-inch commercial-depth of Pro Grand Ranges, the PH Professional Series Wall Hoods or Professional Series Custom Inserts would provide the appropriate depth from the wall to correspond
1.800.735.4328 | THERMADOR.COM
as defined in the “National Fuel Gas Code” (ANSI Z223.1, Current Edition). Clearances from non-combustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction.
NOTE: A 36-inch minimum clearance is required between the top of the cooking surface and the bottom of an unprotected cabinet. A 30-inch clearance can be used when the bottom of the wood or metal cabinet is protected by not less than 1/4 inch of a flame retardant material covered with not less than No. 28 MSG sheet steel, 0.015 inch (0.4 mm) thick stainless steel, 0.024 inch (0.6 mm) aluminum, or 0.020 inch (0.5 mm) thick copper.
31
PRO GRAND® RANGES 36-INCH GAS PRG364JDG / PRL364JDG
PRG364JDG / PRL364JDG INNOVATION - Patented Pedestal Star® Burner with QuickClean Base™ designed for easy surface cleaning and superior heat spread for any size pan - Powerful 22,000/18,000 BTU (NG/LP) burner (front right) - Precision simmering capabilities as low as 100°F (375 BTU) with 4 ExtraLow® Simmer burners - SoftClose® hinges for ultra smooth closing of the oven door - Superfast 2-hour self-clean mode – fastest in the industry
PROFESSIONAL PRG364JDG / PRL364JDG
PERFORMANCE
Natural Gas / Liquid Propane (LP) Gas Commercial-Depth Range, Porcelain Cooktop Surface
- 18,000/15,000 BTU (NG/LP) Star® Burners - Titanium surface non-stick, rust-proof cast-aluminum griddle and grill, removable for easy cleanup - Electronic oven display interfaces to cook timer, meat probe and preheat status with audible alert - Powerful, 30,000/25,000 BTU bake and 17,000 BTU broil burners (NG/LP) - Convection Bake offers precise multi-level baking results - Large oven 5.5 cu. ft. – accommodates commercial sheet pan - Full Access® telescopic racks, integrated easy-grip handle - Six rack levels for multiple item cooking - Star-K certified
SPECIFICATIONS PRG364JDG Total Number of Cooktop Burners
PRL364JDG 4
Product Width
35 15/16"
Product Height
35 7/8"– 36 3/4"
Product Depth
28 1/2"
Overall Oven Capacity* (cu. ft.)
5.5
Overall Oven Interior Dimensions (W x H x D)
28" x 15" x 22"
Usable Oven Interior Dimensions (W x H x D)
28 1/2" x 11 3/4" x 19 5/8"
Cutout Width
36"
Cutout Height
35 7/8"– 36 3/4"
Cutout Depth
24"– 25 1/8"
Cooktop Surface Gas Cooktop Burners
Porcelain 1@ 1@ 22,000 BTU / 18,000 BTU / 3@ 3@ 18,000 BTU 15,000 BTU
12" Center Electric Griddle Oven Bake Oven Broil
6-pass, 1,630 Watts 17,000 BTU 30,000 BTU
17,000 BTU 25,000 BTU
Total Gas Connection Rating
106,000 BTU
88,000 BTU
LP Convertible
Order LP or NG
Electrical Supply
120V AC, 60 Hz
Required Circuit Breaker Power Cord Shipping Weight (lbs.)
DESIGN - Bold Professional design - Pinhole and panel lighting concepts provide functional and stylish aesthetics - Restaurant style metal knobs - Professional style, continuous cast iron grates - Continuous porcelain, easy-to-clean cooking surface - Large oven door window for maximum viewing - Powerful halogen lighting illuminates the oven cavity - Signature blue indicator lighting THERMADOR EXCLUSIVE
20 Amp 96", 3-Wire 420
*According to AHAM Standards
ACCESSORIES PA36JLBG Low Backguard
PA12GRILHC Grill
PWOKRINGHC Wok Ring
PA36JHSG High Shelf
PAGRIDDLE Griddle
PAKNOBLKJG Black Knob Kit
PA36JTKG Toekick
PA12CVRJ 12" Griddle / Grill Cover
PAKNOBLUJG Blue Knob Kit
IMPORTANT NOTE: A Low Backguard, High Shelf or Island Trim is required for installation.
32
PA12CHPBLK 12" Cutting Board
PRG364JDG / PRL364JDG
INSTALLATION OPTIONS
36-INCH CUTOUT AND RANGE DIMENSIONS
®
Thermador Pro Grand Ranges feature a bold, professional design and a commercial-depth of 27-inches. These ranges can be installed in a wall or island installation. BACKGUARDS
PRO GRAND RANGES
PRO GRAND® RANGES 36-INCH GAS
When using the Flush Island Trim, Thermador recommends a minimum 12” (305 mm) rear clearance to a combustible surface (see Figure 1, Cabinet Clearances). Clearances from noncombustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction. NATURAL GAS OR LP Thermador All-Gas Pro Grand Ranges are shipped by the factory to operate on natural gas. They must be converted for use with propane. Verify that the type of gas being used at the installation site matches the type of gas used by the appliance. If the location/job site requires conversion from natural gas to propane (LP), utilize the included LP kit. Field conversion must be done by qualified service personnel only. Please refer to the LP Conversion Instructions for further information. IMPORTANT We strongly recommend that a Thermador Professional Wall or Island Hood or Custom Insert be installed with all Thermador Pro Grand Ranges. Downdraft ventilation should not be used. Do not install a microwave-hood combination above the cooktop, as these types of units do not provide the proper ventilation and are not suitable for use with Thermador Pro Grand Ranges. Refer to the Ventilation section or www.Thermador.com for a complete selection of Professional ventilation options, blowers, and accessories. Due to the 27-inch commercial-depth of Pro Grand Ranges, the PH Professional Series Wall Hoods or Professional Series Custom Inserts would provide the appropriate depth from the wall to correspond to these ranges.
1.800.735.4328 | THERMADOR.COM
as defined in the “National Fuel Gas Code” (ANSI Z223.1, Current Edition). Clearances from non-combustible materials are not part of the ANSI Z21.1 scope and are not certified by CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction.
NOTE: A 36-inch minimum clearance is required between the top of the cooking surface and the bottom of an unprotected cabinet. A 30-inch clearance can be used when the bottom of the wood or metal cabinet is protected by not less than 1/4 inch of a flame retardant material covered with not less than No. 28 MSG sheet steel, 0.015 inch (0.4 mm) thick stainless steel, 0.024 inch (0.6 mm) aluminum, or 0.020 inch (0.5 mm) thick copper.
33
PRO GRAND® RANGES 48-INCH GAS PRG486JDG / PRL486JDG
PRG486JDG / PRL486JDG INNOVATION - Patented Pedestal Star® Burner with QuickClean Base™ designed for easy surface cleaning and superior heat spread for any size pan - Powerful 22,000/18,000 BTU (NG/LP) burner (front right) - Precision simmering capabilities as low as 100°F (375 BTU) with 4 ExtraLow® Simmer burners - SoftClose® hinges for ultra smooth closing of the oven door - Superfast 2-hour self clean in both ovens
PROFESSIONAL PRG486JDG / PRL486JDG
PERFORMANCE
Natural Gas / Liquid Propane (LP) Gas Commercial-Depth Range, Porcelain Cooktop Surface
- 18,000/15,000 BTU (NG/LP) Star® Burners - Titanium surface non-stick, rust-proof cast-aluminum griddle and grill, removable for easy cleanup - Electronic oven display interfaces to cook timer, meat probe and preheat status with audible alert - Full featured small oven with convection, broil, self clean and meat probe - Powerful, 30,000/25,000 BTU bake and 17,000 BTU broil burners in the large oven, 15,000/14,000 BTU bake and 9,000 broil in the small (NG/LP) - Convection Bake offers precise multi-level baking results - Large oven 5.5 cu. ft. – accommodates commercial sheet pan plus 2.4 cu. ft. in small oven - Full Access® telescopic racks, integrated easy-grip handle - Six rack levels in each oven for multiple item cooking - Star-K certified
SPECIFICATIONS PRG486JDG Total Number of Cooktop Burners
PRL486JDG 6
Product Width
47 15/16"
Product Height
7/8"– 36 3/4"
Product Depth Overall Oven Capacity* (cu. ft.)
35
28 1/2" 5.5 / 2.4
Overall Oven Interior Dimensions (W x H x D)
28" x 15" x 22" (Lg) 12 3/8" x 15" x 22" (Sm)
Usable Oven Interior Dimensions (W x H x D)
25 1/2" x 11 3/4" x 19 5/8" (Lg) 9 7/8" x 11 3/4" x 19 5/8" (Sm)
Cutout Width
48"
Cutout Height
35 7/8"– 36 3/4"
Cutout Depth
24"– 25 1/8"
Cooktop Surface Gas Cooktop Burners
12" Center Electric Griddle
Porcelain 1@ 22,000 BTU / 5@ 18,000 BTU
1@ 18,000 BTU / 5@ 15,000 BTU
6-pass, 1,630 Watts 17,000 BTU (Lg) 17,000 BTU (Lg) 30,000 BTU (Sm) 25,000 BTU (Sm) 9,000 BTU (Lg) 9,000 BTU (Lg) 15,000 BTU (Sm) 14,000 BTU (Sm)
Oven Bake Oven Broil Total Gas Connection Rating
157,000 BTU
132,000 BTU
LP Convertible
Order LP or NG
Electrical Supply
120V AC, 60 Hz
Required Circuit Breaker Power Cord Shipping Weight (lbs.)
DESIGN - Bold Professional design - Pinhole and panel lighting concepts provide functional and stylish aesthetics - Restaurant style metal knobs - Professional style, continuous cast iron grates - Continuous porcelain, easy-to-clean cooking surface - Large oven door window for maximum viewing - Powerful halogen lighting illuminates the oven cavity - Signature blue indicator lighting THERMADOR EXCLUSIVE
20 Amp 96", 3-Wire 590
*According to AHAM Standards
ACCESSORIES PA48JLBG Low Backguard
PA12GRILHC Grill
PWOKRINGHC Wok Ring
PA48JHSG High Shelf
PAGRIDDLE Griddle
PAKNOBLKJG Black Knob Kit
PA48JTKG Toekick
PA12CVRJ 12" Griddle / Grill Cover
PAKNOBLUJG Blue Knob Kit
IMPORTANT NOTE: A Low Backguard, High Shelf or Island Trim is required for installation. 34
PA12CHPBLK 12" Cutting Board
PRG486JDG / PRL486JDG
INSTALLATION OPTIONS
48-INCH CUTOUT AND RANGE DIMENSIONS
®
Thermador Pro Grand Ranges feature a bold, professional design and a commercial-depth of 27-inches. These ranges can be installed in a wall or island installation. BACKGUARDS
PRO GRAND RANGES
PRO GRAND® RANGES 48-INCH GAS
Thermador Pro Ranges ship with a flush Island Trim. When installing against a combustible surface, a Thermador High Shelf or Low Backguard must be purchased separately. If the range is installed with the Island Trim, a minimum 12" of clearance is required to a combustible surface. The backguard must be attached to the range before sliding it into the final installed position. NATURAL GAS OR LP Thermador All-Gas Pro Grand Ranges are shipped by the factory to operate on natural gas. They must be converted for use with propane. Verify that the type of gas being used at the installation site matches the type of gas used by the appliance. If the location/job site requires conversion from natural gas to propane (LP), utilize the included LP kit. Field conversion must be done by qualified service personnel only. Please refer to the LP Conversion Instructions for further information. IMPORTANT We strongly recommend that a Thermador Professional Wall or Island Hood or Custom Insert be installed with all Thermador Pro Grand Ranges. Downdraft ventilation should not be used. Do not install a microwave-hood combination above the cooktop, as these types of units do not provide the proper ventilation and are not suitable for use with Thermador Pro Grand Ranges. Refer to the Ventilation section or www.Thermador.com for a complete selection of Professional ventilation options, blowers, and accessories. Due to the 27-inch commercial-depth of Pro Grand Ranges, the PH Professional Series Wall Hoods or Professional Series Custom Inserts would provide the appropriate depth from the wall to correspond to these ranges.
1.800.735.4328 | THERMADOR.COM
as defined in the “National Fuel Gas Code” (ANSI Z223.1, Current Edition). Clearances from non-combustible materials are not part of the ANSI Z21.1 scope and are not certified by definedofinless thethan “National (ANSI Z223.1, CSA.as Clearances 12” (305Fuel mm)Gas mustCode” be approved Current Edition). Clearances non-combustible materials by the local codes and/or by the localfrom authority having are not part of the ANSI Z21.1 scope and are not certified by jurisdiction.
CSA. Clearances of less than 12” (305 mm) must be approved by the local codes and/or by the local authority having jurisdiction.
NOTE: A 36-inch minimum clearance is required between the top of the cooking surface and the bottom of an unprotected cabinet. A 30-inch clearance can be used when the bottom of the wood or metal cabinet is protected by not less than 1/4 inch of a flame retardant material covered with not less than No. 28 MSG sheet steel, 0.015 inch (0.4 mm) thick stainless steel, 0.024 inch (0.6 mm) aluminum, or 0.020 inch (0.5 mm) thick copper.
35
