Transcript
HARNESS- ENGINE, CUM ISX PB387 DETAIL "
DETAIL " J "
M" DATA WIRES
FINAL ASSEMBLY
P20-1063-04 6
10
P3 LABEL: ENGINE ECU
WIRE TERMINATION FOR P20-1072
P20-1063- 04
1
SEAL SHRINK TUBE WITH 3M JET MELT ADHESIVE #3789
25mm PIN A
661-1
PIN B
662-1
90° BACKSHELL
PIN C
660-1 660-4 SPLICE
CABLE SHIELDED
50mm 75mm
CONNECTOR
DRAIN WIRE
41
50
DETAIL " K" WIRE TERMINATION FOR P20-1063- 04 CONVOLUTED TUBING
DATA WIRES
FINAL ASSEMBLY
SEAL SHRINK TUBE WITH 3M JET MELT ADHESIVE #3789
25mm TERM 46
661-0
TERM 47
662-0 660-0
TERM 37 660-3 SPLICE
CONNECTOR DRAIN WIRE
CABLE SHIELDED
50mm 75mm
DETAIL " L " NOTES:
J1939 DATA LINK CABLE SPLICE
1) ASSEMBLE PER PETERBILT MPS 1600.002.
TO BACKBONE 662-1 HARNESS 660-1
661-1
2) FOR USE WITH MODEL 387 TRUCK WITH CUMMINS ISX AND SIGNATURE SERIES ENGINES, WITH CM870 CONTROLLER.
SEAL SHRINK TUBE WITH 3M JET MELT ADHESIVE #3789
CABLE
3) SELECT TERMINALS PER SK28129. USE TERMINAL CODE 11 OR 12 WITH THE FOLLOWING EXCEPTIONS: ITEM #/CONNECTOR/TERMINAL J43, P3, AND J6 T1 T2 AND T3
TO 661-0 ENGINE ECU 662-0
661-2
660-0
660-2
662-2
AND TRIPLETS TO TERMINAL T15
660-6
TWISTED PAIRS
SHRINK TUBE DATA LINK, J1587/J1708 VEHICLE SPEED
TWISTED TRIPLETS EE12-1, EE22-1, EE02-4, EE39-1,
AND EE23-1 THROTTLE AND EE58-1 REMOTE THROTTLE
6) HARNESS MANUFACTURER TO ASSEMBLE THE FOLLOWING: CONNECTORS J7 AND P33 CONNECTORS J28 AND P18 CONNECTORS J60 AND P51 CONNECTORS J69 AND P31 CONNECTOR J43 AND TERMINATING RESISTOR R1 S 7) PLUG ALL UNUSED CAVITIES AND SEAL ALL WEATHER PROOF CONNECTORS AS FOLLOWS: USE 16-07833 FOR METRI-PACK, WEATHER-PACK, AND DEUTSCH CONNECTORS.
TABLE A FUTURE USE
8) CONVOLUTED TUBING SHALL BE MAXIMIZED TO THE REAR OF EACH CONNECTOR WITHOUT PLACING STRAIN ON TERMINALS AS MANUFACTURING PROCESS DICTATES. 9) PART NUMBER IS GENERATED BY THE FOLLOWING: SEE TABLE A
VAR
OMIT CIRCUITS
OMIT ITEM NUMBERS
USAGE
0
-
-
-
VAR
OMIT CIRCUITS
OMIT ITEM NUMBERS
USAGE
1
660-0, 661-0, 662-0, 660-1, 661-1, 662-1, 660-2, 661-2, 662-2, 660-3, 660-4, 660-5, 660-6
J43, P5, R1, S20, S21, S22, S25, S26, S27
WITHOUT J1939 DATA LINK
2
NONE
NONE
WITH J1939 DATA LINK
VAR
OMIT CIRCUITS
1
EE02-4, EE03-2, EE18-1, EE39-1, EE58-1, EE63-1, EE64-1, 239-2
2
NONE
SEE TABLE B SEE TABLE C
TABLE B J1939 DATA LINK
P92-6083-ABC EXAMPLE: PN P92-6083- 021 IS FOR WITH J1939 DATA LINK , . AND WITHOUT DUAL STATION CONTROLS 10) YELLOW TAPE INDICATES HARNESS ROUTING INDEX POINT. C 11) THE USE OF CAVITY PLUGS ON P1, P2, AND P3 IS CRITICAL. 12) SPLICE LOCATIONS ARE SHOWN FOR REFERENCE ONLY WITH THE EXECPTION OF THE FOLLOWING: SPLICE S4 SHALL BE PLACED AS CLOSE TO CONNECTOR P2 AS IS PRACTICAL. 13) FOR HARNESS MANUFACTURER USE ONLY: SIMILAR TO P92-6047-000.
TABLE C DUAL STATION CONTROLS
14) SUPERSEDES P92-6047-000 PROD SVCE
TERM
EE13-1 EE15-1 EE63-1 EE18-1 EE20-1 EE43-1 EE06-1 EE05-1 EE22-1 417-1 EE14-1 EE64-1 EE28-1 EE08-1 EE19-1 EE04-1 418-1 EE58-1 EE12-1 EE23-1 EE07-1 EE17-1 EE39-1 EE25 EE31-1 EE03-3 EE02-2 EE03-4 EE01-1 EE26 660-3 EE41-1 EE21-1 83-1 EE10-1 EE24-1 661-0 662-0
1 2 3 4 5 6 7 8 9 10 11 13 15 16 17 18 20 21 22 23 24 25 26 27 28 29 32 33 34 36 37 38 39 40 43 44 46 47
10
6
1 11
50
MATING VIEW
41
TO TERMINATING RESISTOR
CABLE
CABLE S 5) THE FOLLOWING CIRCUITS TO BE TWISTED PAIRS (ONE TWIST PER 25MM):
AND 418-1 AND EE26
CKT NO.
TERMINAL CODE/PN 21 12-1/4 12-7/16
4) CIRCUITS 660-0, 661-0, 662-0, AND FOR CIRCUITS 660-1, 661-1, 662-1, AND FOR CIRCUITS 660-2, 661-2, AND 662-2, USE P92-1549 OR EQUIVALENT.
417-1 EE25
1
-
P92-6083
X X
OMIT ITEM NUMBERS J60, P51, AND S28
NONE
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 QTY
USAGE WITHOUT DUAL STATION CONTROLS WITH DUAL STATION CONTROLS
T15 T3 T2 T1 S29 S28 S27 S26 S25 S22 S21 S20 S5 S4 S3 S2 R1 P52 P51 P34 P33 P32 P31 P18 P10 P9 P8 P7 P6 P4 P3 P2 P1 J69 J60 J43 J28 J7 J6
RING_TERMINAL RING_TERMINAL RING_TERMINAL RING_TERMINAL SPLICE SPLICE SPLICE SPLICE SPLICE SPLICE SPLICE SPLICE SPLICE SPLICE SPLICE SPLICE P20-1075 P20-1158-202 16-06777 16-06461 16-04464 16-06461 P20-1040 16-06461 16-06461 16-06461 16-06414 16-06414 P20-1082 P20-1158-204 P20-1063-04 P20-1133-19-3-2 P20-1133-47-5-2 P67-1005-102-2 16-06778 P20-1072 16-06568 16-04465 P20-1072
ITEM PART NUMBER
BLACK_PVC_SHRINK_TUBE_TERM_INSULATION BLACK_PVC_SHRINK_TUBE_TERM_INSULATION BLACK_PVC_SHRINK_TUBE_TERM_INSULATION RED_PVC_SHRINK_TUBE_TERMINAL_INSULATION CIRCUIT_EE01 CIRCUIT_EE02 CIRCUIT_660 CIRCUIT_660 CIRCUIT_660 CIRCUIT_660 CIRCUIT_662 CIRCUIT_661 CIRCUIT_EE04 CIRCUIT_29 CIRCUIT_239 CIRCUIT_239 DEUTSCH,_TERMINATING_RESISTOR_120-ohm GRAY_DEUTSCH_DTP_PLUG_SEALED BLACK_DEUTSCH_DT_SEALED BLACK_PACKARD_METRI-PACK_280_SEALED BLACK_PACKARD_WP_TOWER_SEALED BLACK_PACKARD_METRI-PACK_280_SEALED BLACK_PACKARD_METRI-PACK_150_SEALED BLACK_PACKARD_MP_280_SEALED BLACK_PACKARD_MP_280_SEALED BLACK_PACKARD_MP_280_SEALED LT-GRY_PACKARD_MP_150_SEALED LT-GRY_PACKARD_MP_150_SEALED BLACK_PACKARD_MP_150_SEALED GRAY_DEUTSCH_DTP_PLUG_SEALED BLACK_DEUTSCH_DRC_PLUG_SEALED BLACK_DEUTSCH_HDP20_PLUG_SEALED BLACK_DEUTSCH_HDP20_PLUG_SEALED BLACK_PACKARD_METRI-PACK_150_SEALED BLACK_DEUTSCH_DT_SEALED BLK_DEUTSCH_DT_RECPT_SEALED_(J1939-THRU) BLACK_PACKARD_METRI-PACK_280_SEALED BLACK_PACKARD_WP_SHROUD_SEALED BLK_DEUTSCH_DT_RECPT_SEALED_(J1939-THRU) PRODUCT DESCRIPTION
MATERIAL
HARNESS- ENGINE, CUM ISX PB387 P9 LABEL:A/C CLUTCH CKT NO. TERM 239-8 93-1
SECTIONA-A
CKT NO. EE19-1 417-1 418-1 EE07-1 EE08-1 EE10-1 EE12-1 EE13-1 EE14-1 EE15-1 EE17-1 EE22-1 EE23-1 EE24-1 EE01-2 EE02-1 EE03-1 EE28-1 EE04-2 EE05-1
A B
ECM PORT "J2" AND "J3" BREAKOUT
B
A
250 MAIN HARNESS BUNDLE
P7 LABEL:A/C PRESS SWITCH CKT NO. TERM EE43-1 B EE01-3 A
P2 LABEL: CHASSIS LOAD CENTER TERM 2 3 6 9 19 8 7 8 10 2 7 18 9
P1 LABEL: DASH ENGINE HARNESS
J1939 DATA LINK BREAKOUT
400
TERM 1 2 3 7 8 10 12 13 14 15 17 22 23 24 25 26 27 35 44 45
35 35 36 22 37 38
23 24
10 11 12
39
34
9
25
46 32
8
18 7
1
13 26
5
30
31
19
2
3 4
25 40
47 33
20 21
10
CKT NO. 93-1 EE20-1 B239-1 EE21-1 29-2 EE01-4 30-2 A269-1 30-3 29-3 59-1
47
20 1
17
6 16 28 15
30 29
45 45
44
2
-
P92-6083
12 15 16 18 19
11
3 12
1 4
6 5
14
13
17 16
15
43
14
41
27
40
42 MATING VIEW
15 5
MATING VIEW 1000 P2
MULTI-FUNCTION CONNECTOR BREAKOUT
SEE DETAIL "J" FOR WIRE TERMINATION, ON SHEET 1.
R1
800
CKT NO.
J43 A
P3
661-2 662-2 660-5
B
SEE CHART "A" FOR CIRCUIT CONFIGURATION ON SHEET 1.
A
SEE DETAIL "K" FOR WIRE TERMINATION ON SHEET 1.
A
P32 LABEL: COOLANT LEVEL SENSOR
J43 LABEL: J1939 DATA LINK TERM A A B C
CKT NO. EE02-3 EE31-1
MARK WITH YELLOW TAPE (SEE NOTE 10)
C B MATING VIEW
TERM A B
300
150
150
SEE DETAIL "M" FOR CONVOLUTE TERMINATION ON SHEET 1.
175
TAPE BACK LOCATION FOR J1939 CABLE SPLICE. SEE DETAIL "L", SHEET 1.
TAPE BACK
300
K344-813 800
150
500
300
P1
200 250 150
B
200
P31
A
P51
150
A
1
30-2
350
DUAL STATION CONTROLS - REMOTE PTO ENABLE - REMOTE THROTTLE ENABLE - REMOTE THROTTLE CONTROL - TORQUE LIMIT SWITCH
250 2
4
3 MATING VIEW
P51 LABEL: DUAL STATION CONTROLS CKT NO. TERM EE03-2 3 1 12 EE39-1 4 EE18-1 239-2 EE64-1 EE58-1 EE02-4 EE63-1
5 8 9 10 11 12
300 1400
SEE DETAIL "J" FOR WIRE TERMINATION, ON SHEET 1. 6
7
B
577-1
4
J60
A
P4 LABEL: ENGINE ECU TERM 1
P31 LABEL: ETHER SOLENOID VLV CKT NO. TERM EE03-4 A 83-1 B
MARK WITH YELLOW TAPE (SEE NOTE 10)
B
CKT NO.
J69
MATING VIEW
600 300
250
300
400
CKT NO.
T1
1 500
P33
275
TERM A B
10
0
A
LABEL: STARTER INTERRUPT JUMPER
T2 LABEL: ENGINE GROUND CKT NO. TERM 239-1
1
A269-1 239-7
CKT NO. EE25 EE26
T15 LABEL: ENGINE GROUND CKT NO. TERM 660-6 1
B
P33
A B
P6 LABEL: VEHICLE SPEED SENSOR
250
A J7
B
J7 LABEL:STARTER INTERRUPT CKT NO. TERM A239-1 B B239-1 A
CKT NO. 239-9 239-9
239-3 59-1
MATING VIEW
T3 LABEL: ENGINE GROUND CKT NO. TERM 239-5 1 577-1 1
A B C
C B MATING VIEW
P8 LABEL: REVERSE CKT NO. TERM
TERM A B
A B
P18
P18 LABEL: NEUTRAL START INTERRUPT CKT NO.
TERM
239-6 A239-1
A B
J28
J28 LABEL: NEUTRAL START INTERRUPT JUMPER CKT NO. 239-10 239-10
P34 LABEL: ENGINE FAN SOLENOID VALVE
TERM A B
0 10
29-1 1
300
1 2
661-1 662-1 660-4
P10 LABEL: XMSN TEMP SENSOR CKT NO. TERM B
239-5 30-3
300
TAPE BACK
TERM
A
CKT NO.
CKT NO.
B A
LABEL: STARTER TERMINAL SOLENOID
200
P52 LABEL: PRIMING PUMP TERM 2
J6 LABEL: J1939 DATA LINK TERM A
CKT NO. EE03-3 EE41-1
TERM A B
HARNESS- ENGINE, CUM ISX PB387
EE23-1 , GRN/BLU
13
EE13-1 , RED/ORN
IDLE VALIDATION, ON-IDLE
14
EE14-1 , BLU
ECM COMMON 1
25
EE01-2 , BLK/WHT
NO CIRCUIT, NO WIRE
6
IDLE/DIGN INCREMENT (N14+ ONLY)
5
ENG AUTO/MANUAL FAN SW (CUMMINS)1
NO CIRCUIT, NO WIRE
36
NO CIRCUIT, NO WIRE
37
ECM COMMON 3
27
EE03-1 , BLK/WHT
DIAGNOSTIC SWITCH
15
EE15-1 , LT_GRN
59-1 , VIO
239-8 , BLK
239-7 , BLK
239-3 , BLK
239-10 , BLK
239-9 , BLK
239-1 , BLK
660-6 , WHT
29-1 , PRP
660-5 , WHT
662-2 , GRN
_ 660-2 , BARE 661-2 , YEL
662-1 , GRN
30-2 , ORN
577-1 , BLK
EE18-1 , GRN/WHT
662-0 , GRN
661-0 , YEL
417-1 , PRP
418-1 , WHT
EE28-1 , GRN
EE12-1 , BLK/RED
47
EE05-1 , LT_GRN/BLK
NO CIRCUIT, NO WIRE
EE19-1 , WHT/LT_GRN
41
EE06-1 , YEL/BLK
NO CIRCUIT, NO WIRE
EE15-1 , LT_GRN
40
EE24-1 , LT_GRN
39
NO CIRCUIT, NO WIRE
EE10-1 , BRN/WHT
38
S27
EE13-1 , RED/ORN
S5
EE39-1 , GRN/YEL
EE08-1 , BLU
EE02-2 , BLK/WHT
8
EE31-1 , LT_GRN/PINK
CRUISE ON/OFF
EE21-1 , RED
EE02-1 , BLK/WHT
EE20-1 , WHT
26
NO CIRCUIT, NO WIRE
1
GROUND (STR RELAY COIL)
29-2 , PRP
8
STARTER RELAY
29-3 , PRP
18
STARTER RELAY
EE20-1 , WHT
3
SERVICE BRAKE SWITCH
EE21-1 , RED
7
IGN PWR, ENG SHTDWN
EE01-4 , BLK/WHT
9
ECM COMMON 1
1
PLUG - NO CIRCUIT, NO WIRE
4
PLUG - NO CIRCUIT, NO WIRE
5
30-3 , ORN
2
PLUG - NO CIRCUIT, NO WIRE
11
PLUG - NO CIRCUIT, NO WIRE
13
PLUG - NO CIRCUIT, NO WIRE
17
PLUG - NO CIRCUIT, NO WIRE
14
PLUG - BAT (-), ECM
10
PLUG - BAT (-), ECM
30-3 , ORN
16
12/24 VDC BAT (+), ECM
30-2 , ORN
12
12/24 VDC BAT (+), ECM
PRIMING PUMP
7
SWITCHED POWER (ACC)
8
8
GROUND
EE02-4 , BLK/WHT
11
11
ACCEL POSITION RETURN
EE39-1 , GRN/YEL
4
4
REMOTE ACCEL POSITION
EE58-1 , GRN
10
10
ACCEL POSITION SUPPLY
EE63-1 , WHT/BLK
12
12
REMOTE THROTTLE ENABLE
EE64-1 , LT_BLU
9
9
TORQUE LIMIT SWITCH
EE18-1 , GRN/WHT
5
5
REMOTE PTO ENABLE
EE03-2 , BLK/WHT
3
3
ECM COMMON 3
6
6
PLUG - REMOTE PTO-INTERLOCK
2
2
1
1
45
44
43
16
41
24
25
2
49
17
8
7
18
34
11
1
23
9
22
15
20
10
46
47
37
31
12
35
30
48
19
14
33
40
5
39
50
28
32
42
26
21
6
3
29
38
13
4
27
36
1
2
3
4
OBD LAMP
CHECK ENGINE LAMP (AMBER)
STOP ENGINE LAMP (RED)
CRUISE ON/OFF
TACHOMETER
CRUISE CONTROL RES/ACCEL
CRUISE CONTROL SET/COAST
DIAGNOSTIC SWITCH
STARTER LOCKOUT
MANUAL FAN SWITCH
ENG BRAKE SEL SW 2 (33%)
ENG BRAKE SEL SW 3 (50%)
ENG BRAKE SEL SW 1 (17%)
ECM SWITCH RETURN
IDLE VALIDATION, ON-IDLE
IDLE VALIDATION, OFF-IDLE
THROTTLE RETURN
THROTTLE POSITION SENSE
THROTTLE SPLY, +5 VDC
CLUTCH SWITCH
DATA_LINK_J1587/J1708_(-)
DATA_LINK_J1587/J1708_(+)
DATA_LINK_J1939_(H)
DATA_LINK_J1939_(L)
DATA_LINK_J1939_SHLD
OEM TEMPERATURE
CENTINEL - MAKEUP TANK SW
OEM PRESSURE
TACHOGRAPH
IDLE SHTDN - RELAY
AMB AIR TEMP
MAXIMUM ENGINE SPEED
ECM RETURN
ETHER START
SERVICE BRAKE SWITCH
IGN POWER, ENG SHTDWN
HI COOLANT TEMP WRN LP
COOLANT LEVEL SENSE
OEM/ENGINE SENSOR RETURN
ECM RETURN
REMOTE THROTTLE POSITION
OEM / SENSOR SUPPLY (+)
A/C INPUT SIGNAL
REMOTE THROTTLE ENABLE
ECM RETURN
ENG FAN CLUTCH DRIVER
TORQUE LIMIT SWITCH
REMOTE PTO ON/OFF SW
VSS (+) INPUT SIGNAL
VSS (-) INPUT SIGNAL
BAT (-), ECM
PLUG - NO CIRCUIT, NO WIRE
PLUG - NO CIRCUIT, NO WIRE
12/24 VDC BAT (+), ECM
PLUG - NO CIRCUIT, NO WIRE PLUG - NO CIRCUIT, NO WIRE J60 P6
P4
P3 ENGINE ECU
REMOTE PTO AND THROTTLE OPTIONS
7 239-2 , BLK
83-1 , ORN/WHT
ECM COMMON 2
16
EE03-2 , BLK/WHT
EE03-4 , BLK/WHT
EE07-1 , PINK
WARNING LAMP
BACKUP LIGHTS
B239-1 , BLK
6
P51
660-0 , BARE _
EE17-1 , YEL
7
24
239-5 , BLK
EE01-3 , BLK/WHT
660-3 , WHT
17
10
S29
S28
CRUISE RESUME
CHECK ENGINE LIGHT (AMBER)
A/C COMPRESSOR CLUTCH COIL
A269-1 , PINK/WHT
15
B
EE01-4 , BLK/WHT
CRUISE SET
STOP ENGINE LIGHT (RED)
XMSN TEMP GAUGE SENSOR
2
S4
DUAL STATION CONTROLS
EE23-1 , GRN/BLU
34
EE22-1 , PINK
NO CIRCUIT, NO WIRE
EE01-2 , BLK/WHT
33
19
93-1 , LT_GRN/WHT
P7
EE04-2 , LT_GRN/YEL
32
NO CIRCUIT, NO WIRE
EE19-1 , WHT/LT_GRN
EE04-1 , LT_GRN/YEL
NO CIRCUIT, NO WIRE
NO CIRCUIT, NO WIRE
661-1 , YEL
A
EE14-1 , BLU
19
EE01-1 , BLK/WHT
31
ENG AUTO/MANUAL FAN SW (CAT)
P2 59-1 , VIO
P52
30
NO CIRCUIT, NO WIRE
S2
239-4 , BLK
A/C PRESS SWITCH (OPEN CIRCUIT = FAN ON)
EE17-1 , YEL
NO CIRCUIT, NO WIRE
29
EE07-1 , PINK
NO CIRCUIT, NO WIRE
P18
660-6 , WHT
EE64-1 , LT_BLU
28
B
S22
EE41-1 , WHT/LT_GRN
21
NO CIRCUIT, NO WIRE
S21
EE03-3 , BLK/WHT
20
NO CIRCUIT, NO WIRE
EE05-1 , LT_GRN/BLK
EE43-1 , WHT
NO CIRCUIT, NO WIRE
J7
A P10
SEE NOTE 12 FOR SPLICE LOCATION
EE58-1 , GRN
18
B
29-1 , PRP
EE63-1 , WHT/BLK
NO CIRCUIT, NO WIRE
S20
662-2 , GRN
11
B
A
660-2 , BARE
45
NO CIRCUIT, NO WIRE
660-1 , BARE
9
ENGINE BRAKE 2 (LOW-HIGH)
EE04-2 , LT_GRN/YEL
661-0 , YEL
NO CIRCUIT, NO WIRE
A
B
B
239-3 , BLK
662-0 , GRN
46
A P9
J28
P33 B
A
660-0 , BARE
44
ENGINE BRAKE 3
B
XMSN TEMP SENSOR (GAUGE)
ENGINE HARNESS
4
ENGINE BRAKE 1 (MED-HIGH)
A P8
A
S3
EE08-1 , BLU
IDLE/DIGN DECREMENT (N14+ ONLY)
1 T3
A/C CLUTCH
93-1 , LT_GRN/WHT
EE22-1 , PINK
23
IDLE VALIDATION, OFF-IDLE
1 T2
A269-1 , PINK/WHT
22
THROTTLE, RETURN
1 T15
239-6 , BLK
EE12-1 , BLK/RED
B
P34
NEUTRAL REVERSE START (BU LP SW) INTERRUPT JUMPER
A239-1 , BLK
EE28-1 , GRN
12
THROTTLE, POSITION
T1
A239-1 , BLK
35
THROTTLE, SUPPLY
S25
A
1
A
577-1 , BLK
42
CLUTCH OUT (PEDAL RELEASED)
B P32 P31
STARTER INTERRUPT (OVERCRANK) JUMPER
B239-1 , BLK
418-1 , WHT
43
DATA LINK J1922 (-)
661-1 , YEL
B
ENGINE GROUND
239-5 , BLK
3
DATA LINK J1922 (+)
662-1 , GRN
A
B
A
ENG FAN SOLENOID VALVE (12V=FAN OFF)
EE03-3 , BLK/WHT
DATA_LINK_J1587/J1708_(-)
B
A
STARTER TERMINAL SOLENOID
EE41-1 , WHT/LT_GRN
417-1 , PRP
C
EE03-4 , BLK/WHT
2
661-2 , YEL
SAE J1939 DATA LINK P1
DATA_LINK_J1587/J1708_(+)
_
TO ENGINE DASH HARNESS
B
EE31-1 , LT_GRN/PINK
A
660-1 , BARE
COOALNT LEVEL SENSOR
J69
J43 S26
660-4 , WHT
C
ETHER SOLENOID
83-1 , ORN/WHT
ENGINE HARNESS J6 ENGINE HARNESS
R1
EE02-3 , BLK/WHT
120 ohm SAE J1939 DATA LINK TERMINATING RESISTOR
3
-
P92-6083
ENGINE ECU
EE25 , BLU/RED
A
EE26 , BLU/ORN
B
VEHICLE SPEED SENSOR THE VEHICLE SPEED SENSOR IS OMITTED WHEN USED WITH ELECTRONIC CONTROLLED TRANSMISSIONS THAT BROADCAST VEHICLE SPEED INFORMATION OVER THE SAE J1939 DATA LINK BUSS.
HARNESS- ENGINE, CUM ISX PB387
WIRE INFORMATION FOR HARNESS: P92-6083-000 CKT NO. 239-1 239-2 239-3 239-4 239-5 239-6 239-7 239-8 239-9 239-10 29-1 29-2 29-3 30-2 30-3 417-1 418-1 577-1 59-1 660-0 660-1 660-2 660-3 660-4 660-5 660-6 661-0 661-1 661-2 662-0 662-1 662-2 83-1 93-1 A239-1 A269-1 B239-1 EE25 EE26 EE01-1 EE01-2 EE01-3 EE01-4 EE02-1 EE02-2 EE02-3 EE02-4 EE03-1 EE03-2 EE03-3 EE03-4 EE04-1 EE04-2 EE05-1 EE06-1 EE07-1 EE08-1 EE10-1 EE12-1 EE13-1 EE14-1 EE15-1 EE17-1 EE18-1 EE19-1 EE20-1 EE21-1 EE22-1 EE23-1 EE24-1 EE28-1 EE31-1 EE39-1 EE41-1 EE43-1 EE58-1 EE63-1 EE64-1
WIRE GAUGE 2 14 18 14 10 18 18 16 18 18 8 12 12 12 12 18 18 10 18 20 20 20 18 18 18 16 20 20 20 20 20 20 18 16 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18 18
INSUL SGX GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL NONE NONE NONE GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL GXL
WIRE NUMBER 16-08316 16-06017 16-04762 16-06017 16-07064 16-04762 16-04762 16-04783 16-04762 16-04762 16-07227 16-05749 16-05749 16-05749 16-05749 16-04762 16-04762 16-07064 16-04762 P92-1549 P92-1549 P92-1549 16-04762 16-04762 16-04762 16-04783 P92-1549 P92-1549 P92-1549 P92-1549 P92-1549 P92-1549 16-04762 16-04783 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762 16-04762
TO FROM TERM TERM DESCRIPTION COMPONENT COMPONENT BLK S3 SPLICE 1 T2 RING_TERMINAL 1 GROUND BLK P51 16-06777 8 S3 SPLICE 1 GROUND BLK S3 SPLICE 1 P10 16-06461 A GROUND BLK S3 SPLICE 1 S2 SPLICE 1 GROUND BLK T3 RING_TERMINAL 1 P52 P20-1158-202 1 GROUND BLK S2 SPLICE 1 P18 16-06461 A GROUND BLK S2 SPLICE 1 P8 16-06414 B GROUND BLK S2 SPLICE 1 P9 16-06461 A GROUND BLK P33 16-04464 A P33 16-04464 B GROUND BLK J28 16-06568 A J28 16-06568 B GROUND PRP S4 SPLICE 1 T1 RING_TERMINAL 1 STARTER_BUTTON PRP P2 P20-1133-19-3-2 8 S4 SPLICE 1 STARTER_BUTTON PRP P2 P20-1133-19-3-2 18 S4 SPLICE 1 STARTER_BUTTON ORN P2 P20-1133-19-3-2 12 P4 P20-1158-204 4 BATTERY_(+) ORN P2 P20-1133-19-3-2 16 P52 P20-1158-202 2 BATTERY_(+) PRP P1 P20-1133-47-5-2 2 P3 P20-1063-04 10 DATA_LINK_J1587/J1708_(+) WHT P1 P20-1133-47-5-2 3 P3 P20-1063-04 20 DATA_LINK_J1587/J1708_(-) BLK T3 RING_TERMINAL 1 P4 P20-1158-204 1 GROUND VIO P2 P20-1133-19-3-2 19 P10 16-06461 B XMSN_TEMP_GAUGE_SENSOR BARE S22 SPLICE 1 S27 SPLICE 1 DRAIN/SHIELD BARE S22 SPLICE 1 S26 SPLICE 1 DRAIN/SHIELD BARE S22 SPLICE 1 S25 SPLICE 1 DRAIN/SHIELD WHT S27 SPLICE 1 P3 P20-1063-04 37 DATA_LINK_J1939_(SHLD) WHT S26 SPLICE 1 J6 P20-1072 C DATA_LINK_J1939_(SHLD) WHT S25 SPLICE 1 J43 P20-1072 C DATA_LINK_J1939_(SHLD) WHT T15 RING_TERMINAL 1 S22 SPLICE 1 DATA_LINK_J1939_(SHLD) YEL S20 SPLICE 1 P3 P20-1063-04 46 CAN_H YEL S20 SPLICE 1 J6 P20-1072 A CAN_H YEL S20 SPLICE 1 J43 P20-1072 A CAN_H GRN S21 SPLICE 1 P3 P20-1063-04 47 CAN_L GRN S21 SPLICE 1 J6 P20-1072 B CAN_L GRN S21 SPLICE 1 J43 P20-1072 B CAN_L ORN/WHT P31 P20-1040 B P3 P20-1063-04 40 ETHER _STARTING_AID LT_GRN/WHT P2 P20-1133-19-3-2 2 P9 16-06461 B AIR CONDITIONER BLK J7 16-04465 B P18 16-06461 B GROUND PINK/WHT P2 P20-1133-19-3-2 15 P8 16-06414 A BACKUP_LIGHTS BLK P2 P20-1133-19-3-2 6 J7 16-04465 A GROUND BLU/RED P6 P20-1082 A P3 P20-1063-04 27 ROAD_SPEED_SENSOR_(+) BLU/ORN P6 P20-1082 B P3 P20-1063-04 36 ROAD_SPEED_SENSOR_(-) BLK/WHT S29 SPLICE 1 P3 P20-1063-04 34 ECM_COMMON_1 BLK/WHT P1 P20-1133-47-5-2 25 S29 SPLICE 1 ECM_COMMON_1 BLK/WHT S29 SPLICE 1 P7 16-06414 A ECM_COMMON_1 BLK/WHT P2 P20-1133-19-3-2 9 S29 SPLICE 1 ECM_COMMON_1 BLK/WHT P1 P20-1133-47-5-2 26 S29 SPLICE 1 ECM_COMMON_2 BLK/WHT S28 SPLICE 1 P3 P20-1063-04 32 OEM/ENGINE_SENSOR_RETURN BLK/WHT P32 16-06461 A S28 SPLICE 1 COOLANT_LEVEL_SENSOR_RETURN BLK/WHT P51 16-06777 11 S28 SPLICE 1 REMOTE_ACCEL_POSITION_RETURN BLK/WHT P1 P20-1133-47-5-2 27 S29 SPLICE 1 ECM_COMMON_3 BLK/WHT P51 16-06777 3 S29 SPLICE 1 ECM_COMMON_3 BLK/WHT P34 16-06461 A P3 P20-1063-04 29 ECM_COMMON_3 BLK/WHT P31 P20-1040 A P3 P20-1063-04 33 ECM_COMMON_3 LT_GRN/YEL S5 SPLICE 1 P3 P20-1063-04 18 ENGINE BRAKE_1 LT_GRN/YEL P1 P20-1133-47-5-2 44 S5 SPLICE 1 ENGINE BRAKE_1 LT_GRN/BLK P1 P20-1133-47-5-2 45 P3 P20-1063-04 8 ENGINE BRAKE_2 YEL/BLK S5 SPLICE 1 P3 P20-1063-04 7 ENGINE BRAKE_3 PINK P1 P20-1133-47-5-2 7 P3 P20-1063-04 24 CRUISE_RESUME/ACCEL BLU P1 P20-1133-47-5-2 8 P3 P20-1063-04 16 CRUISE_ON/OFF BRN/WHT P1 P20-1133-47-5-2 10 P3 P20-1063-04 43 STOP_ENGINE_LIGHT BLK/RED P1 P20-1133-47-5-2 12 P3 P20-1063-04 22 ACCEL_POSITION_SUPPLY RED/ORN P1 P20-1133-47-5-2 13 P3 P20-1063-04 1 IDLE_VALIDATION_OFF-IDLE BLU P1 P20-1133-47-5-2 14 P3 P20-1063-04 11 IDLE_VALIDATION_ON-IDLE LT_GRN P1 P20-1133-47-5-2 15 P3 P20-1063-04 2 DIAGNOSTIC_SIGNAL YEL P1 P20-1133-47-5-2 17 P3 P20-1063-04 25 CRUISE_SET/COAST GRN/WHT P51 16-06777 5 P3 P20-1063-04 4 REMOTE_PTO_ENABLE WHT/LT_GRN P1 P20-1133-47-5-2 1 P3 P20-1063-04 17 ENG_FAN_MANUAL_OVERRIDE WHT P2 P20-1133-19-3-2 3 P3 P20-1063-04 5 SERVICE_BRAKE_SWITCH RED P2 P20-1133-19-3-2 7 P3 P20-1063-04 39 ECM_SWITCHED_POWER PINK P1 P20-1133-47-5-2 22 P3 P20-1063-04 9 CAB _ACCEL_POSITION GRN/BLU P1 P20-1133-47-5-2 23 P3 P20-1063-04 23 ACCEL_POSITION_RETURN LT_GRN P1 P20-1133-47-5-2 24 P3 P20-1063-04 44 CHECK_ENGINE_LIGHT GRN P1 P20-1133-47-5-2 35 P3 P20-1063-04 15 CLUTCH_SWITCH LT_GRN/PINK P32 16-06461 B P3 P20-1063-04 28 COOLANT_LEVEL_SENSE GRN/YEL P51 16-06777 4 P3 P20-1063-04 26 REMOTE_ACCEL_POSITION WHT/LT_GRN P34 16-06461 B P3 P20-1063-04 38 ENGINE_FAN_CLUTCH_DRIVER WHT P7 16-06414 B P3 P20-1063-04 6 A/C_PRESS GRN P51 16-06777 10 P3 P20-1063-04 21 REMOTE_ACCEL_POSITION_SUPPLY WHT/BLK P51 16-06777 12 P3 P20-1063-04 3 REMOTE_ACCEL_ENABLE LT_BLU P51 16-06777 9 P3 P20-1063-04 13 TORQUE_LIMIT_SWITCH COLOR
P92-6083
-
4
