Transcript
This information has been compiled by the Vacuum Cleaner Manufacturer's Association working with government and private sources, concerned with product safety. These basic guidelines are for your protection and convenience. THIS CLEANER IS INTENDED FOR HOUSEHOLD USE ONLY
IMPORTANT SAFETY INSTRUCTIONS When you use an appliance, basic precautions should always be followed, including the following: READ ALL INSTRUCTIONS BEFORE YOU USE THE APPLIANCE ALWAYS FOLLOW THESE SAFETY INSTRUCTIONS
WARNING: TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK OR INJURY: Look on your vacuum cleaner and follow all label and marking instructions. Electric shock could occur if used outdoors or on wet surfaces. Do not let children play with the vacuum cleaner. Watch closely when the vacuum cleaner is used by or near children. Do not use the vacuum cleaner to pick up flammable or combustible liquids or fumes, such as gasoline, or use in areas where they may be present. Keep the vacuum cleaner on the floor. Only the hand-held vacuum cleaners may be set on furniture. Unplug the vacuum cleaner if you leave the room. Unplug it when it is not in use and before you service it. Keep end of hose, wands and other openings away from your face and body. Keep your hands, feet, hair and clothing away from moving parts. Only use attachments and hoses recommended by the manufacturer. Use the vacuum cleaner only as stated in this manual. Turn all controls to "OFF", before unplugging the vacuum cleaner. Do not use an extension cord with this vacuum cleaner. Do not touch the plug or the vacuum cleaner with wet hands. Do not use the power cord to pull or carry the vacuum cleaner. Do not use the power cord as a
handle. Do not shut any door on the cord or pull the cord around sharp edges or corners. Keep the cord away from heated surfaces. Do not run the vacuum cleaner over the cord. Do not use vacuum cleaner with a damaged cord or plug. Do not use vacuum cleaner if working improperly, dropped, damaged, left outdoors or dropped in water. First, send to service center for check and repair. Do not use the vacuum cleaner without dustbag or filters in place. Store the vacuum cleaner indoors. Put the vacuum cleaner away after use to prevent tripping accidents. Do not pull on the cord to unplug the vacuum cleaner. Grasp the plug instead. Be most careful when vacuum cleaning on stairs. Do not put any object into the vacuum cleaner vent or other openings. Do not turn the vacuum cleaner on if something is blocking an opening. Keep vents free of things that slow air flow, such as dust, lint and hair. Do not pick up anything that is hot, smoking or burning. Do not pick up cigarettes, hot ashes or matches. Always turn off the vacuum cleaner before connecting or removing either the hose or the motorized nozzle. Using improper voltage may result in damage to motor and possible injury to user. Proper voltage is listed on the cleaner plate.
Approved by the Vacuum Cleaners Manufacturer's Association Executive Committee, April 29, 1987.
GROUNDING INSTRUCTIONS (only for 3-wire models, those that include 2 blades and 1 grounding pin) This appliance must be grounded. If it should malfunction or breakdown, grounding provides a path of least resistance for electric current to reduce the risk of electric shock. This appliance is equipped with a cord having an equipment-grounding conductor and grounding plug. The plug must be plugged into an appropriate outlet that is properly installed and grounded in accordance with all local codes and ordinances.
DANGER
- Improper connection of the equipment-grounding conductor can result in a risk of electric shock. Check with a qualified electrician or service person if you are in doubt as to whether the outlet is properly grounded. Do not modify the plug provided with the appliance - if it will not fit the outlet, have a proper outlet installed by a qualified electrician. This appliance is for use on a nominal 240-volt circuit. Make sure that the appliance is connected to an outlet having the same configurations as the plug. No adapter should be used with this appliance. If the supply cord of this appliance is damaged, it must be replaced by the special cord Part #I -425436-000.
WARNING: Electrical shock could occur if used outdoors or on wet surface.
TABLE OF CONTENTS .......................................................... 4 Using your Tank Vacuum Cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Attachments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7 Using the Power Nozzle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Paper Bag Removal and Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 MICRO FRESH Filtration System (Optional) . . . . . . . . . . . . . . . . . . . . . . . . 10-11 Using the Blower Feature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 Features
Powerful Royal Tanks are versatile tanks for you
Get acquainted with your tank vacuum cleaner Take full advantage of all the special accessory tools for the Royal tank. They'll work hard for you. -
Cord Wrap
completely closed when cleaning floors since maximum suction is required for floor cleaning.
114( Two Cleaning Wands - Made of
12 Extra-long Power Cord
chrome-plated tubular steel.
Exhaust Filtering Vent - Disperses dust-free air.
Crevice Tool - Narrow, smoothly pointed tool concentrates suction in hardto-reach places.
Rear End Bell
1 Tip Toe Switch - Conveniently located ON/OFF switch. 16 Heavy duty, Vinyl Handle - Comfortable to the grip. Outlet for Power Nozzle Plug Front End Bell
1161 Round Dusting Brush - Long, soft flexible bristles. 1171 1 0 Floor and Wall Brush - Soft bristles for vacuuming bare floors, walls and ceilings. 6 Upholstery Nozzle - Ideal for cleaning furniture and drapes.
191 Hose Insert 1101 Bell Clamps on both sides -
1191 Power Nozzle - separate motor and
Secures front end bell.
Crush Proof Hose - Light, pliable, durable vinyl for ease of use.
111] 360"Swivel Front Wheels - For maximum maneuverability. Load-bearing Wheels Bleed valve - Rotate open to reduce suction when cleaning fragile items. It is necessary for the bleed valve to be kept
revolving brush system.
11" Rug Nozzle - cleans all types of rugs and carpets.
1221 Cord Straps - 6 straps used to secure external hose cord to flexible hose. 1231 External Hose Cord
USING YOUR ROYAL TANK VACUUM IS AS EASY AS 1-2-3
...
ATTACH THE FLEXIBLE HOSE Insert the slotted connector end of the hose into the front end bell. Twist clockwise to lock securely.
SELECT THE ATTACHMENT Determine what vacuuming you will be doing, then insert the desired tool into the pistol grip or wand.
PLUG IN THE TANK AND TURN ON Plug the power cord into your most convenient wall outlet. The 40-foot total cleaning radius lets you clean without constantly replugging.
HOW TO USE THE ATTACHMENTS Your tank's assortment of cleaning tools lets you vacuum almost everything around your home.
NOTE: Disconnect cleaner from electrical outlet during assembly
ASSEMBLE THE CLEANING WANDS: The wand with the vinyl seal is the lower section which attaches to the Power nozzle and cleaning tools. The other metal wand attaches to the grip. To join wands together, push in pin of lower wand and lock into hole of upper wand.
VINYL SEAL
d!Y
FLOOR AND WALL BRUSH: Cleans linoleum, tile, bare wood or concrete floors, papered or painted walls and ceilings. This 10-inch brush has long, soft bristles that dust and buff at the same time. Inserted into the lower wand section, the brush will lock into place and then swivel conveniently as you clean.
ROUND DUSTING BRUSH: Cleans bookcases, lampshades, screens, televisions, picture frames, baseboards, and all metal, wood, or molded plastic furniture . . . any place around your home. The long soft bristles won't mar your furniture but will delicately lift the surface dust and whisk it away.
UPHOLSTERY NOZZLE: Cleans furniture, curtains, stairways, bedding, clothing, and car interiors. Nozzle may be used with either both cleaning wands to reach drapery valances, the back of the sofa, and other hard-to-clean places.
NOTE: To clean the brushes, just apply suction from the hose directly to the bristles.
CREVICE TOOL: Cleans all hard-to-reach places including deep furniture crevices, button cushions, bookcases, baseboard corners, and automobile upholstery. It's also easier to clean behind ranges and refrigerators.
To attach, push the end of the selected tool into the opening of the wand. Pull apart to remove. To remove FLOOR TOOL ONLY, depress vinyl collar to release pin. Pull apart.
Transforms the tank into an upright-type vacuum. With its separate motor and revolving brush system, the Power Nozzle actually lifts your carpet. The revolving brush gently sweeps the carpet clean of dust and dirt particles deep in carpeting. To attach, press down on wand until pin snaps into place and locks. The flat area of the tube seal should face towards the front of the power nozzle. Plug the external hose cord into the outlet on the top of the tool caddy (Refer to #7, page 4) and the power nozzle. Use the straps to secure the external hose cord to the flexible hose. To disconnect, unplug the external hose cord from the power nozzle. Position flat area of the tube seal to face toward the front of the pin. Push in on flat area of the tube seal to release locking pin and pull. When ordering a Power Nozzle, refer to the following:
I
Power Nozzle Grid Tank Model
/
Required Power Nozzle
/
PAPER BAG REMOVAL AND REPLACEMENT NOTE: Disconnect cleaner from electrical outlet for maintenance. Replace the paper bag when approximately one-half full. Set the tank on end with the exhaust vent (rear bell) on the floor. Grasp the bell clamps in each hand. Holding your hands toward the rear of the clamp, pull outward. Grasp the. front end bell (the hose may still be connected), gently pull outward. Take care not to spill any dirt. Pull off paper bag and discard.
The cloth bag in the tank does not always have to be removed for cleaning. If cleaning is required, remove the bag and shake dirt into a suitable container. Replace with a new paper bag. Place the hole in the paper bag over the metal fitting inside the front end bell. Place the front end bell back onto the tank by sliding the paper bag into the tank. The chrome end plate must slide over the edges of the tank. Hold in place and fasten the bell clamps to both sides. Clamps will "snap" into place when fully seated. Continue normal operation of your vacuum cleaner.
FlLTRATION SYSTEM (optional) Royal's filtration system for over 99.9% "fresh" exhaust air. This system assures you that fine powdery dust will not be blown back into the air you breathe or onto your furniture and carpets again.
*Examine the Five Layers of Filtration in Your Tank Vacuum Circulating air lifts dust and dirt from your carpets and transports it through the hose to a 175 square inch double layer disposable paper bag (I)*.The second layer of the paper bag contains electrostatically charged fibers (2)*. The air passes through the double layered paper bag, depositing dirt and lint. It then passes into a finely woven cotton twill cloth bag (3) with 160 square inches. The air finally passes through a double-sided filter pad. The MICRO FRESH filter pad consists of an electrostatically charged fiber material (4) attached to a reticulated flexible urethane foam (5). When used as a system, the air expelled at the rear exhaust is over 99.9% "fresh". *Not included on all models.
Replaceable
Fa-]
Filter Pads
NOTE: Unplug tank before changing filter. The filter pad is located between the filter bag and tank motor. Check your filter pad periodically for dirt build-up. The filter pad should be changed at least every six months or when three paper bags have been used. TO INSTALL, remove front end bell and cloth bag. Drop filter into tank with white side facing towards you. Put cloth bag back into place. Attach front end bell and continue normal operation of your tank.
Replaceable
Paper Bags (optional)
MICRO FRESH disposable paper bags are lined with electrostatically charged fibers that trap fine dust and pollen particles down to 0.1 microns in size. To remove and replace, refer to page 9. Enhance the performance of your tank vacuum with MICRO FRESH high filtration paper bags and filter pads. See an Authorized Royal Dealer or a participating retailer to purchase an assortment of MICRO FRESH products.
HOW TO USE YOUR TANK FOR BLOWING NOTE: Unplug tank before changing Hose Connection. (1) Simply connect the hose to the rear end bell of the tank instead of the front end bell. You'll be using the exhaust end instead of the suction end. Be conscious of where you'll be blowing the dust. Our suggestion is to always blow it toward a dampened sheet or towel which will trap the dust and not send it flying into the air. Then, you simply toss the "dusty" sheet or towel into your automatic washer for cleaning. Don't be concerned if the paper filter bag is not empty when you use the blower. The tank's MICRO FRESH Filtration System will entrap the dust and not allow it to recirculate during this use. (MICRO FRESH filter pads optional.) When you finish using your Royal tank as a blower, unplug your tank and reconnect the hose to the front end bell for vacuum cleaning.
OPTIONAL ACCESSORIES When you need replacement parts or are ready to expand your Tank Cleaning System, consult an authorized Royal Dealer. Cloth Bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-041 140-000 Package of 3 Paper Bags . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-040447-001 Package of 10 Paper Bags . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-041147-001 Package of 3 High Filtration Paper Bags and 1 MICRO FRESH Filter Pad . . . . . . . . . . 3-467130-001 MICRO FRESH Filter Pad . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-460030-001 NOTE: Register your cleaner to validate warranty.
WARRANTY Royal Appliance Mfg. Co. warrants this Royal vacuum cleaner to be free from defects in material and workmanship. The period of the warranty is a LIFETIME on the housing and a limited number of years (stated on original carton) on all other components (except two years on the hose assembly, accessory tools, and on the power nozzle), depending on model purchased. The warranty commences upon the date of original purchase and receipt of your warranty card. If the vacuum cleaner should become defective within the warranty period, complete service (parts and labor) will be provided free of charge:
1) at the store where the machine was purchased, if the store is an AUTHORIZED DEALER and WARRANTY STATION. 2) by Royal Appliance Mfg. Co. if the store, where the machine was purchased, is an AUTHORIZED DEALER.
In the event of a change in the purchaser's residence of 50 or more miles from residence at time of purchase from an AUTHORIZED DEALER, such service will be provided by the nearest warranty station. This warranty does not cover the following: 1) Parts that normally require replacement such as belts, bags, brushes. and bulbs. 2) Failure, loss, or deterioration due to ordinary wear and tear or from misuse or unauthorized repair. 3) Machines used for other than normal personal, family, or household purposes.
4) Costs of any transportation to and from any place of repair, all of which costs are to be paid by the owner.
This warranty gives you specific legal rights and you may also have other rights which may vary from state to state.
Model No.
I
I
PLEASE ENTER SERIAL NO. NO.
s
