Propane Conversion Instructions

Transcript

PROPANE CONVERSION INSTRUCTIONS WARNING 7KLVFRQYHUVLRQPXVWEHSHUIRUPHGE\DTXDOL¿HGLQVWDOOHU or gas supplier in accordance with the manufacturer’s instructions and all codes and requirements of the authority having jurisdiction. Failure to follow ALL instructions could result in serious injury or property GDPDJH7KHTXDOL¿HGDJHQF\SHUIRUPLQJWKLVZRUN assumes responsibility for the conversion. 7KHSUHVVXUHUHJXODWRUDQGWKHEXUQHURUL¿FHVDUHVHWIRUQDWXUDO JDV7RXVHSURSDQHJDVWKHUHJXODWRUDQGEXUQHURUL¿FHVPXVW be converted. CONVERTING THE PRESSURE REGULATOR Remove the warming drawer and panel behind drawer. The pressure regulator is located in the lower, left hand rear corner of the range as viewed from the front. Pressure Regulator A. WARNING 'RQRWRSHUDWHWKHFRRNWRSRURYHQEXUQHUVRIWKLVUDQJH when using propane (bottled) gas before converting the SUHVVXUHUHJXODWRUDQGEXUQHURUL¿FHVIRUSURSDQHJDVXVH )DLOXUHWRGRVRFRXOGFDXVHKLJKÀDPHVDQGWR[LFIXPHV which can result in serious injury. Propane Red/Orange Propane Blue/Brown LR RR LF RF Propane Red/Orange Regulator style A 3. Turn the metal cap so the type of gas being converted to is displayed and replace the protective plastic cover.  6FUHZWKHKH[QXWFDSEDFNLQWRWKHUHJXODWRU (Do not over tighten) If this is your regulator:  8VHDQDGMXVWDEOHZUHQFKWRXQVFUHZWKHKH[QXWFDS from the pressure regulator. 2. Turn the plastic cap 1/4 turn to disassemble. B. Using a 7 mm or 9/32” nut driver, remove the top burner RUL¿FHV7KHVHPD\EHDFFHVVHGWKURXJKWKHEXUQHURSHQLQJLQ the base. NAT ( 3ODFHWKHROGRUL¿FHVLQWRWKHPHWDOER[DORQJZLWKWKHVH LQVWUXFWLRQVDQGUHSODFHRQWRWKHEDFNRIWKHUDQJHIRU SRVVLEOHIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV NOTICE: 6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV & 5HPRYHWKHSURSDQHRUL¿FHVIURPWKHER[SURYLGHG7KH SURSDQHRUL¿FHVKDYHWKHOHWWHU´/µRQWKHWRS  7RDLGLQLGHQWLI\LQJWKHSURSHUORFDWLRQIRUWKHSURSDQHRUL¿FHV during conversion from Natural Gas to Propane Gas, color FRGHVKDYHEHHQDGGHGWRWKHVLGHRUWRSRIWKHRUL¿FH6HHWKH FKDUWEHORZ(DFKRUL¿FHPD\DOVRVKRZDVHULHVRIHQJUDYHG PDUNV,,,,,, ORFDWHGRQWKHWRS 95 5RWDWHFDSFRXQWHU FORFNZLVHWRORRVHQ 7RSUHYHQWOHDNDJHPDNHVXUHWKHRUL¿FHVDUHVHFXUHO\VFUHZHG into the gas supply tubes. Round burner PROPANE Propane Conversion Kit To adjust your range for use with propane gas, follow these instructions: 'LVFRQQHFWDOOHOHFWULFDOSRZHUDWWKHPDLQFLUFXLWEUHDNHURUIXVHER[ 6KXWRȺWKHJDVVXSSO\WRWKHUDQJHE\FORVLQJWKHPDQXDOVKXW RȺYDOYH 2UL¿FHORFDWHG through this opening Propane Orange/Green NAT Cap assembly • Flat bladed screwdriver EODGHDSSUR[LPDWHO\µ across) • Nut drivers: 1/4”, 9/32” or 7mm Propane Red/Yellow A. Remove the top grates, burner caps and burner heads. If this is your regulator:  8VHDQDGMXVWDEOHZUHQFKWRXQVFUHZWKHKH[QXWFDS from the pressure regulator.  &RPSOHWHO\UHPRYHWKHSURWHFWLYHSODVWLFFDSRȺWKH threaded metal cap. 5RWDWHFDSFRXQWHU FORFNZLVHWRORRVHQ B. ' ,QVWDOOWKHSURSDQHRUL¿FHVLQWKHLUSUHFLVHORFDWLRQV Gas Valve 5HPRYHWKHVWRUDJHGUDZHU7KHSURSDQHRUL¿FHVIRUWKHFRRNWRS EXUQHUVDUHVKLSSHGRQWKHEDFNRIWKHUDQJHLQWKHORFDWLRQVKRZQ TOOLS REQUIRED: • Adjustable wrench • 6RFNHWZUHQFKZLWK µVRFNHWDQGH[WHQVLRQ • Phillips head screwdriver CONVERTING THE COOKTOP BURNERS PROPANE Denotes 0.95mm Orifice size opening Denotes LP (Propane) Gas III BURNER OUTPUT RATINGS: BTU/HR Propane Gas 10” W.C.P. BTU SIZE BURNER RATE ORIFICE COLOR MARKINGS (mm) Regulator style B  7XUQWKHSODVWLFFDSRYHUDQGKRRNLWLQWRWKHVORWV5RWDWH cap 1/4 turn to reassemble. The type of gas to be used should now be visible on the top of the cap.  6FUHZWKHKH[QXWFDSEDFNRQWRWKHSUHVVXUHUHJXODWRU RF LF RR LR C BAKE BROIL 18,000 18,000 9,500 5,000 8,000 16,000 12,000 0.047” (1.19) 0.047” (1.19) 0.035” (0.89) 0.026” (0.66) 0.034” (0.86) 0.047” (1.19) 0.041” (1.04) Red/Orange Red/Orange Blue/Brown Red/Yellow Orange/Green Orange Red 119L 119L 89L 66L 86L .047 041L PROPANE CONVERSION INSTRUCTIONS 31-11011-1 09-15 GE PGB911 CONVERTING THE OVEN BURNERS NOTICE: This product cannot be converted to propane by adjusting the oven orifices. The orifices must be replaced for propane BAKE BURNER ORIFICE Lift burner %DNHEXUQHURUL¿FH 5HPRYHRYHQUDFNVGRRUDQGRYHQERWWRP5HPRYHWKHµ KH[VFUHZVVHFXULQJWKHEDNHEXUQHU 7KHEDNHEXUQHURUL¿FHLVRQWKHJDVYDOYHORFDWHGEHKLQGWKH ZDUPLQJGUDZHU/LIWWKHEXUQHURȺWKHRUL¿FHDQGDSSO\D µVRFNHWRQDQH[WHQVLRQWRWKHKH[EDVHRIWKHRUL¿FHRQ WKHJDVYDOYH/RRVHQWKHRUL¿FHE\WXUQLQJFRXQWHUFORFNZLVH and remove. NOTICE: 6DYHWKHVHRULILFHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV 6HOHFWWKHSURSDQHEDNHRUL¿FHIURPWKHNLWDQGLQVWDOOLWRQWKH gas valve. Tighten until snug. 5HSODFHWKHEDNHEXUQHURYHUWKHRUL¿FHDQGUHSODFHDOOVFUHZV securing the burner. BROIL BURNER ORIFICE Broil RUL¿FH Oven light 5HPRYHWKHµKH[VFUHZVHFXULQJWKHEURLOEXUQHUDQGDOORZ LWWRKDQJGRZQIUHHRIWKHEURLORUL¿FH $SSO\DµZUHQFKWRWKHKH[EDVHRIWKHRUL¿FH/RRVHQWKH RUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH 6HOHFWWKHSURSDQHEURLORUL¿FHIURPWKHNLWDQGLQVWDOOLWRQWKH broil elbow. Tighten until snug. 5HSODFHWKHEURLOEXUQHURYHUWKHRUL¿FHDQGUHSODFHWKHVFUHZ securing the burner. ADJUSTING AIR SHUTTER SETTINGS FOR OVEN BURNERS 1. With a Phillips head screwdriver, loosen the screws securing the DLUVKXWWHURQWKHEDNHEXUQHU$GMXVWWKHDLUVKXWWHUWRIXOO\RSHQ 2. Turn on the gas. 3. Turn on the electricity. 4. Reinstall the oven door. Screw  7XUQRQWKHEDNHEXUQHU Air shutter 2YHQEXUQHUÀDPHPXVWEHREVHUYHG ZLWKWKHGRRUFORVHGWRSURSHUO\FKHFN ÀDPHFKDUDFWHULVWLFV  $V\RXZDWFKWKHÀDPHZLWKWKHRYHQGRRUFORVHGFKHFNWKH following through the oven door window. D ,IWKHÀDPHVDUH\HOORZRSHQWKHDLUVKXWWHUPRUH E ,IWKHÀDPHVEORZDZD\RUÀXWWHUIURPWKHEXUQHUFORVHWKH air shutter slightly.  7XUQEDNHEXUQHURȺDQGUHSHDWZLWKEURLOEXUQHU WARNING ,I\RXDWWHPSWWRPHDVXUHWKHLQQHUFRQHRIWKHÀDPHSOHDVHXVH caution: burns could result. ADJUSTING LOW FLAME SETTING ON COOKTOP BURNERS Low setting adjustments must be made with other burners in operation on a medium setting. This procedure prevents the ORZÀDPHIURPEHLQJVHWWRRORZUHVXOWLQJLQWKHÀDPHEHLQJ H[WLQJXLVKHGZKHQRWKHUEXUQHUVDUHWXUQHGRQ A. Turn on all surface burners to medium setting. %7XUQWKHNQRERQWKHEXUQHUEHLQJDGMXVWHGWR´/2µ &5HPRYHWKHNQREDQGLQVHUWDVPDOOÀDWEODGHVFUHZGULYHULQWR the valve shaft and/or side adjustment screw(s) as shown and WXUQFORFNZLVHWRIXOO\WLJKWHQGRZQWKHE\SDVVVFUHZV 5HSHDW for all valves. ',IÀDPHDSSHDUVWRRORZRUXQVWDEOHVORZO\WXUQE\SDVVVFUHZ FRXQWHUFORFNZLVHXQWLODVWDEOHÀDPHH[LVWVIRUHDFKEXUQHU Remember, other burners must be turned on to medium. ($GGLWLRQDOO\IRUHDFKEXUQHUEHLQJDGMXVWHGTXLFNO\RSHQ DQGFORVHWKHRYHQGRRUZKLOHREVHUYLQJÀDPH,IÀDPHLV H[WLQJXLVKHGFRQWLQXHDGMXVWLQJE\SDVVVFUHZIRUDODUJHU ÀDPH5HSHDWGRRURSHQLQJVXQWLOÀDPHLVVWDEOH )5HSODFHWKHNQRE ADDITIONAL INFORMATION BURNER OUTPUT RATINGS: BTU/HR NG (Natural) Gas 5” W.C.P. BTU ORIFICE SIZE BURNER COLOR MARKING RATE (mm) RF LF LR RR C BAKE BROIL 18,000 18,000 5,000 9,500 10,000 16,000 13,500 0.078” (1.98) 0.078” (1.98) 0.040” (1.01) 0.053” (1.36) 0.055” (1.40) 0.070” (1.78) 0.066” (1.67) 198 N Purple Purple White/Purple Green Yellow None Red 198N 198N 101N 136N 140N 50 066N Denotes 1.98 mm Orifice size opening Denotes Natural Gas III  &KHFNLQJWKHÀDPHVL]H  ,WVKRXOGEHDSSUR[LPDWHO\µWRµORQJIRUWKHEDNHDQG broil burners. The combustion quality of the EXUQHUÀDPHVQHHGVWREH determined visually. 127(,IEXUQHUÀDPHVORRN OLNH$ IXUWKHUDLUVKXWWHU DGMXVWPHQWWRWKHEDNHEXQHU LVUHTXLUHG1RUPDOEXUQHUÀDPHVVKRXOGORRNOLNH% RU&  GHSHQGLQJRQWKHW\SHRIJDV\RXXVH:LWKSURSDQHJDV some yellow tipping on the outer cones is normal. (A) Yellow flames: Further Adjustment Required (B) Yellow tips on outer cones: Normal for Propane Gas (C) Soft blue flames: Normal for Natural Gas )RUHLJQSDUWLFOHVLQWKHJDVOLQHPD\FDXVHDQRUDQJHÀDPHDW ¿UVWEXWWKLVZLOOVRRQGLVDSSHDU Center adjustment screw only for all other burners. SPECIAL NOTE: 7RFRQYHUWWKHRYHQEDFNWRQDWXUDOJDVUHYHUVHWKH LQVWUXFWLRQVJLYHQLQPDNLQJSURSDQHDGMXVWPHQWV NOTICE: 2QFHWKHFRQYHUVLRQLVFRPSOHWHDQGFRQ¿UPHG ¿OORXWWKHSURSDQHVWLFNHUDQGLQFOXGH\RXUQDPH RUJDQL]DWLRQDQGGDWHFRQYHUVLRQZDVPDGH$SSO\WKH VWLFNHUWRWKHUDQJHQHDUWKHUHJXODWRUWRDOHUWRWKHUV in the future that this appliance has been converted WRSURSDQH,IFRQYHUWLQJEDFNWRQDWXUDOJDVIURP SURSDQHSOHDVHUHPRYHWKHVWLFNHUVRRWKHUVNQRZWKH appliance is set to use natural gas. 9. When all adjustments are made and the results are satisfactory: a. Retighten the air shutter screws. b. Replace the oven bottom. c. Replace the storage drawer. PROPANE CONVERSION INSTRUCTIONS 31-11011-1 09-15 GE PGB911