Transcript
PX300.4 4 CHANNEL POWER AMPLIFIER
SERVICE MANUAL
JBL Consumer Products 250 Crossways Park Dr. Woodbury, New York 11797
Rev1
2/2004
PX300.4
Power Amplifier
CONTENTS Specifications………………………….…………………..……1 Features…………………………………………………………2 Test Conditions And Notes……………………………………2 Controls/connections…………………………………..………3 Mounting…………………………………………….…..………3 Applications………………………………………..……………4 Typical System Configuration…………………………………5 Troubleshooting……………………………………….……..…6 PCB drawings……………………………………..……………7 Parts List………………………………………………..………9 Block Diagrams……………………………………….………12 Semiconductor Pinouts………………………………………13 Exploded view…………………………………………………16 Schematics……………………………………………….……17 Packing…………………………………………………………26 SPECIFICATIONS Power Output, 4 Ohms
75W x 4
Power Output, 2 Ohms
150W x 4
Power Output, .Bridged, 4 Ohms
300W x 2
MIN. Speaker Impedance
2 ohm
Frequency Response .....
11Hz~45KHz, ±1dB
Input Sensitivity (RCA type)
250mV~6V
THD + Noise (4 Ohms) .....
0.04%
Signal-to-Noise
95 dB
Maximum Current Draw
78A
Fuse Replacement
30Ax2
External Dimensions Length
12 ¼” (312mm)
Width
17” (432mm)
Depth
2 9/16” (66mm)
JBL continually strives to improve its products. New materials, production methods and design refinements are introduced into existing models without notice as a routine expression of our design philosophy. For this reason, Power Series Multichannel Automotive Amplifiers may differ in some respects from their published specifications and descriptions, but will always equal or exceed the original specifications unless otherwise stated.
1
PX300.4
Power Amplifier
APPLICATIONS – Px300.4 The JBL Px300.4 amplifier can be set up for stereo or tri-mode operation, as shown in Figures 6 and 7. NOTE: For simplicity, Figures 6 and 7 do not show power, remote and input connections.
Figure 6. The JBL Px300.4 amplifier is set to stereo mode to drive front and rear pairs of full-range speakers.
FRONT GND
(on input panel)
REAR
BATT
BRIDGED R
Px300.4
NOTE: To limit bass sent to full-range speakers, set X-OVER MODE to HP. See page 6 to set FREQ and SLOPE. Set REAR and FRONT INPUT MODE to ST
REM
NEON
POWER
FUSES
Px300.4
L
STEREO
SPEAKER OUTPUTS
R
L
SPEAKER OUTPUTS
RF Speaker
(rear panel)
Set REAR and FRONT X-OVER MODE to FLAT
LR Speaker
+
+
-
-
(on input panel)
LF Speaker ST MO INPUT MODE
NEON
FLAT HP LP MODE
Figure 7. The JBL Px300.4 amplifier is set to drive a stereo component system and a subwoofer with a nominal impedance of 4 ohms or greater.
RR Speaker
+
+
-
-
FRONT GND
REM
Px300.4
NOTE: To drive a pair of rear midbass speakers (instead of subwoofer), set INPUT MODE to ST, X-OVER MODE to LP, and use DBO to set HP filter.
Px300.4 (rear panel)
BRIDGED R
POWER
FUSES
Set REAR INPUT MODE to MO
(on input panel)
(on input panel)
Set FRONT X-OVER MODE to HP
Set REAR X-OVER MODE to LP
(on input panel)
(on input panel)
FLAT HP LP MODE
FLAT HP LP MODE
4
SPEAKER OUTPUTS
STEREO
R
L
NEON
SPEAKER OUTPUTS
Subwoofer
-
+ LF System
ST MO INPUT MODE
L
RF System +
Set FRONT INPUT MODE to ST
REAR
BATT
NEON
+ -
-
5
PX300.4
Power Amplifier TROUBLESHOOTING SYMPTOM No audio (POWER LED is off) No audio (PROTECT LED flashes every 4 sec.) No audio (PROTECT LED is on)
No audio (PROTECT and POWER LEDs flash) I-E/OPT LED is on all times (not flashing) No audio (PROTECT LED is on) Distorted audio
Distorted audio and PROTECT LED flashes Music lacks “punch”
LIKELY CAUSE No voltage at BATT+ or REM terminals, or bad or no ground connection DC voltage on amplifier output
Amplifier is overheated
Voltage less than 9V on BATT+ connection
Amplifier is being overdriven Voltage more than 16V or less than 8.5V on BATT+ connection regulator Input sensitivity is not set properly, or amplifier or source unit is defective Short circuit in speaker or wire
Speakers are not connected properly
6
SOLUTION Check voltages at amplifier terminals with VOM Amplifier may need service; see enclosed warranty card for service information Make sure amplifier cooling is not blocked at mounting location; verify speaker-system impedance is within specified limits (see “Specifications” on the next page) Check vehicle charging system for defective voltage regulator Check INPUT LEVEL setting; see previous page Check vehicle charging system for defective voltage Check INPUT LEVEL setting; or check speaker wires for shorts or grounds Remove speaker leads one at a time to locate shorted speaker or wire, then repair Check speaker connections for proper polarity
7
8
TRS-00-00087 TRS-00-00088 TRS-00-00090 TRS-00-00091 TRS-00-00110 TRS-00-00109 TRS-00-00111
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
SMALL SIGNAL PNP SMALL SIGNAL NPN SMALL SIGNAL PNP SMALL SIGNAL PNP SMALL SIGNAL NPN SMALL SIGNAL NPN SMALL SIGNAL NPN
KTA1023Y KTC1027Y KTA1266GR KTA1268GR KTC3198GR KTC3198BL KTC3200GR
Q16,133,233,333,433 Q143,243,343,443 Q1,2,5,6,12.13 Q4,141,142,241,242,341,342,441,442 Q11,14,15,152,252 Q3 Q131,132,151,231,232,251,331,332,351,431 Q432,451
TRS-00-00073
F.E.T
N-CH JFET
KTK30AGR
Q61,101,201,301,401
DIO-00-00006
DIODE
SWITCHING SIGNAL DIODE
1SS133
15
DIO-00-00003 DIO-00-00020 DIO-00-00108
DIODE DIODE DIODE
RECTIFIER ZENNER DIODE 1W 15V FAST RECOVERY
1N4004 1N4744 FR154
D2,3,4,9,10,61,62,151,251,351 D451,801,802,803,804 D1 D191,291,391,491 D51,52,53,54,55,56,57,58
RES-00-00523 RES-00-00545 RES-00-00589 RES-00-00399 RES-00-00425 RES-00-00421 RES-00-00467 RES-00-00537 RES-00-00556 RES-00-00591
RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR
METAL METAL METAL METAL METAL METAL METAL METAL METAL METAL
4.7KOHM 5.6K OHM 9.4K OHM 10.5K OHM 15K OHM 15.2K OHM 22K OHM 47K OHM 56K OHM 91K OHM
R27 R127,227,327,427 R112,312 R26 R212,412 R111.211.311.411 R131,231,331,431 R102,103,113,202,203,302,303,313,402,403 R107,108,207,208,307,308,407,408 R101,201,301,401,213,413
1 4 2 1 2 4 4 10 8 6
RES-00-00610 RES-00-00660
RESISTOR RESISTOR
CARBON FILM 1/5WJ CARBON FILM 1/5WJ
10 OHM 22 OHM
1 16
RES-00-00716
RESISTOR
CARBON FILM 1/5WJ
47 OHM
RES-00-00622 RES-00-00662 RES-00-00741 RES-00-00756 RES-00-00633
RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR
CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ
150 OHM 240 OHM 680 OHM 820 OHM 1K OHM
RES-00-00595 RES-00-00598 RES-00-00602 RES-00-00644 RES-00-00676 RES-00-00702 RES-00-00720
RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR
CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ
1.2K OHM 1.5K OHM 1.8K OHM 2.7K OHM 3.9K OHM 4.7K OHM 5.6K OHM
RES-00-00734
RESISTOR
CARBON FILM 1/5WJ
6.8K OHM
RES-00-00751 RES-00-00608
RESISTOR RESISTOR
CARBON FILM 1/5WJ CARBON FILM 1/5WJ
8.2K OHM 10K OHM
RES-00-00623 RES-00-00630 RES-00-00658 RES-00-00733 RES-00-00663 RES-00-00666 RES-00-00687 RES-00-00697 RES-00-00724 RES-00-00730
RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR
CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ
15K OHM 18K OHM 22K OHM 6.2K OHM 24K OHM 27K OHM 33K OHM 39K OHM 51K OHM 56K OHM
R5 R135,136,145,146,235,236,245,246.335,336 R345,346,435,436,445,446 R22,23,24,25,36,37,38,39,137,147 R237,247,337,347,437,447 R151,251,351,451 R381,481 R6 R110,210,310,410 R7,20,21,34,35,42,109,134,144,209 R234,244,309,334,344,409,434,444,809,812 R28,43,172,272,372,472 R154,254,354,454 R383,483 R148,248,348,448 R2,138,238,338,438 R1,13,14 R116,119,122,125,216,219,222,225,316,319 R322,325,416,419,422,425 R118,124,133,143,218,224,233,243,318,324 R333,343,418,424,433,443 R12 R3,4,29,62,104,114,115,120,121.126 R128,130,204,214,215,220,221,226.228.230 R304,314,315,320,321,326,328,330.404.414 R415,420,421,426,428,430,805,810 R10,33,155,255,355,455 R171,271,371,471 R8,16,117.123,217,223,317,323,417,423 R807 R105.205 R17,806,811 R9,808 R382,482 R31 R44.45,156,256,356,456
RES-00-00748 RES-00-00604 RES-00-00647 RES-00-00654 RES-00-00706
RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR
CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ CARBON FILM 1/5WJ
75K OHM 100K OHM 200K OHM 220K OHM 430K OHM
R801,802,803,804 R63,106,206 R380,480 R61 R11
4 3 2 1 1
RES-00-00278 RES-00-00312 RES-00-00053
RESISTOR RESISTOR RESISTOR
CARBON FILM 1/4WJ CARBON FILM 1/4WJ CARBON FILM 1/2WJ
10 OHM 220 OHM 4.7 OHM
R15 R18,19
1 2 4
FILM 1/5WF FILM 1/5WF FILM 1/5WF FILM 1/5WF FILM 1/5WF FILM 1/5WF FILM 1/5WF FILM 1/5WF FILM 1/5WF FILM 1/5WF
9
R161,261,361,461
5 4 6 9 5 1 12 5
1 4 8
16 4 2 1 4 20 6 4 2 4 5 3 16 16 1 38
6 4 10 1 2 3 2 2 1 6
ELC-00-00116 ELC-00-00626 ELC-00-00160 ELC-00-00125 ELC-00-00137 ELC-00-00127 ELC-00-00130 ELC-00-00159 ELC-00-00523 ELC-00-00254 ELC-00-00133
CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR
ELECTROLYTIC "SE" ELECTROLYTIC "SE" ELECTROLYTIC "SG" "SMS" ELECTROLYTIC "SG" "SMS" ELECTROLYTIC "SG" "SMS" ELECTROLYTIC "SG" "SMS" ELECTROLYTIC "SG" "SMS" ELECTROLYTIC "SG" "SMS" ELECTROLYTIC "SG" "SMS" ELECTROLYTIC "SXE" ELECTROLYTIC "SG" "SMS"
2.2uF/50V 10uF/50V 4.7uF/50V 10uF/16V 10uF/25V 22uF/16V 47uF/16V 47uF/50V 100uF/16V 100uF/25V 330uF/16V
C801,802 C62 C103,107,131,203,207,231,307,331,431,407 C12 C7 C101,102,201,202,301,302,401,402 C3,8.15 C55,65,75,85 C1,2 ,5,142,171,271,371,471 C9 C191,291,391,491
CEC-00-00077 CEC-00-00090 CEC-00-00093 CEC-00-00103 CEC-00-00105 CEC-00-00108 CEC-00-00073
CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR
CERAMIC DISK 50V "NPO" CERAMIC DISK 50V "NPO" CERAMIC DISK 50V "NPO" CERAMIC DISK 50V "NPO" CERAMIC DISK 50V "NPO" CERAMIC DISK 50V "NPO" CERAMIC DISK 50V "NPO"
10pF 22pF 27pF 47pF 56pF 68pF 100pF
CEO-00-00075 CAPACITOR CEC-00-00102 CAPACITOR CEC-00-00076 CAPACITOR
CERAMIC DISK 50V "NPO" CERAMIC DISK 50V CERAMIC DISK 50V
103pF 473pF 104pF
CEO-00-00074 MYC-00-00184 MYC-00-00186 MYC-00-00183 MYC-00-00090 MYC-00-00157
CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR CAPACITOR
CERAMIC DISK 50V "NPO" MYLAR 5% 100V MYLAR 5% 100V MYLAR 5% 100V MYLAR 63V "TL" MYLAR 63V "TL"
102pF 102J 222J 104J 473J 823J
MYC-00-00083 MYC-00-00156 MYC-00-00066 MYC-00-00085
CAPACITOR CAPACITOR CAPACITOR CAPACITOR
MYLAR 63V MYLAR 63V MYLAR 63V MYLAR 63V
104J 184J 474J 105J
C105,205,305,405 C61,170,270,370,470 C208,408 C109,112,209,212,309,312,409,412 C108,308 C132,232,332,432 C134,141,144,234,241,244,334,341,344,434 C441,444 C21 C23,24 C4,6,14,25,39,701,702,703,704,705 C706,707,708,709,710,711,712,713,714 C100,200,300,400 C17 C16,18 C161,261,361,461 C135,235,335,435 C110,111,113,114,210,211,213,214 ,310,311 C313,314,410,411,413,414 C26 C316,416 C315,415 C13.29
"TL" "TL" "TL" "TL"
MAIN PCB
2 1 10 1 1 8 3 4 8 1 4 4 5 2 8 2 4 12 1 2 19 4 1 2 4 4 16 -1 2 -2 2
ICO-00-00022 ICO-00-00109 ICO-00-00003 ICO-00-00095
I.C I.C I.C I.C
PWM IC "DIP 14" QUAD OP AMP "DIP 14" DUAL OP AMP "DIP 08" DUAL COMPARATOR "DIP08"
TL494CN NJM2058D TL072 KIA393P
U1 U101,102,103,104,105,108,109,110 U111,112,113,114 U801
TRS-00-00089 TRS-00-00106 TRS-00-00030 TRS-00-00024 TRS-00-00111
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
VIDEO TR PNP VIDEO TR NPN AUDIO POWER NPN AUDIO POWER PNP SMALL SIGNAL NPN
KSA1220 KSC2690 2SC4468 2SA1695 KTC3200GR
Q144,244,344,444 Q134,234,334,434 Q135,235,335,435 Q145,245,345,445 Q130.230.330,430
N-CH MOSFET
FQP50N06 "TO-220"
Q7,8,9,10,17,18,19,20
8
FET-00-00034 F.E.T
1 8 4 1
4 4 4 4 4
DIO-00-00048 DIODE DIO-00-00152 DIODE
FAST RECOVERY FAST RECOVERY
1N5404 YG225D2
D7 D5,6,11,12
1 4
DIO-00-00277 LED DIO-00-00243 LED DIO-00-00279 LED
3 PHI RED LED 3 PHI BLUE LED 3 PHI TWO COLOR LED
HNRD-3401L HL-304H1BC2 LT6G62-D7-D63
LED1 LED2 LED801
1 1 1
RES-00-00853 RES-00-01077 RES-00-01044 RES-00-01043 RES-00-01029
MOR-S 2WJ MOR-S 2WJ "FORMING TYPE 20m m MOR-S 2WJ "FORMING TYPE 15m m MOR-S 2WJ "FORMING TYPE 15m m WIRE WOUND 7WJ (25m/m)
2.2K OHM 100 OHM 680 OHM 470 OHM 0.1 OHM
R40,41 R30,32 R162,262,362,462 R191,291,391,491 R152,153,252,253,352,353,452,453
2 2 4 4 8
THS-00-00013 THERMISTOR
50K
FTD5-350
TH
1
VOL-00-00190 VOL-00-00281 VOL-00-00282 VOL-00-00283
V12L5(9X5)G(PH2D)N17KC V12L5(9X5)G(8R)(PH2D)N15KC V12L5(9x5)G(4R)(PH2D)N15KC V12L5(9X5)G(PH2D)N17KC
3B20K X 2 50K x 8 15A2K x 2, 15A200K x2 B500 x 2
VR101,201 VR102,202 VR301 VR302
2 2 1 1
RESISTOR RESISTOR RESISTOR RESISTOR RESISTOR
VOLUME VOLUME VOLUME VOLUME
10
4 2
SWI-00-00022 SWITCH SWI-00-00035 SWITCH
SLIDE SW,2C2P SLIDE SW,4C3P
JSS-2208A (6m/m) JSS-4319A (6m/m)
SW3,4,5,6 SW1,2
ELC-00-00477 CAPACITOR
ELECTROLYTIC "SD,SHL"(10x21m/m
470 F/50V
C19,20
2
ELC-00-00092 CAPACITOR ELC-00-00290 CAPACITOR
ELECTROLYTIC "RX"(16x25m/m) 2200 F/25V ELECTROLYTIC "HC"(35x26m/m) 6800 F/50V
C10,11,32,33 C27,28
4 2
COR-TF-00353 CORE
37PHI ISU
6T(0.7X12):16T(0.7X4)
T1,2
2
COI-00-00096 INDUCTOR COI-00-00093 INDUCTOR
BAR CORE CHOCK COIL
CL-320 CL-510
L1 L3,4
1 2
TER-00-00220 TERMINAL TER-00-00219 TERMINAL
POWER TERMINAL OUTPUT TERMINAL
KTD-9218A . 3P KTD-9216A 4P
TER1 TER2,3
1 2
JAC-00-00041 RCA JACK JAC-00-00043 RCA JACK HOD-00-00006 FUSE HOULDER
GOLD PLATE GOLD PLATE PCB TYPE
DJB-552A (t DJB-554A (t JSF-08031
JACK2 JACK1 FUSE01,02
1 1 2
FUS-AT-00006 AUTO FUSE
ATC 30A
SET(2)+ACCESSORY(2)
4
WIR-00-00016 GND WIRE
#1007 AWG #22 BLACK , 3.2PHI
80m/m
W1
1
TUB-00-00007 TEFLON TUBE TUB-00-00005 TEFLON TUBE
0.7PHI 0.7PHI
5m/m 12m/m
Q130.230.330,430,TH LED801
6 1
HEA-01-574AA PAN-06-561AA PAN-06-564AA COV-22-623B0 BAD-01-515AA FOO-01-504B0
HEAT SINK MAIN PANEL FRONT PANEL REAR WINDOW BADGE FOOT MOUNTING
COV-22-549AA COV-22-549A0
LENS (WITH SILKSCREEN) ACRYLIC LENS (WITHOUT SILKSCREEN) ACRYLIC
ILL-22-503A0 BKT-14-522A0 BKT-05-520A0 BKT-05-521A0 SUB-28-573A0 SUB-28-574A0 SUB-33-513A0 SUB-33-006A0 SIL-34-001A0 SUP-29-502A0 SUB-27-524A0 SUB-28-519A0 SUB-28-503A0 SUB-12-576A0 SC5-NB-30120 SC5-BB-30080 SC1-NL-30060 SC1-NL-40100 SC4-BP-40250 SC4-BL-40250 POL-31-084A0 POL-31-007A0 POL-31-004A0 POL-31-002A0 INN-42-533A0 BOX-36-573AA BOX-39-575BA MAN-01-0052A SUB-00-001A0 LAB-SR-0064A SUB-00-002A0 SUB-00-003A0 LAB-00-0227A LAB-QC-0001A LAB-00-0165A CAR-WA-0032A SUP-21-006A0 CAR-00-0233A LAB-CE-0004A CAR-00-0100A
INDICATOR BRACKET LAMP BRACKET TR(A) BRACKET TR(B) CUSHION BKT-TR(A) CUSHION BKT-TR(B) CUSHION RUBBER(A) CUSHION RUBBER(B) SILICON PAD SUPPORT PCB SWITCH DECAL PAPER SPACER(A) PAPER SPACER(B) TUBE SCREW SCREW SCREW SCREW SCREW SCREW POLY BAG(A) POLY BAG(B) POLY BAG(C) POLY BAG(D) SNOW PAD(L),(R) GIFT BOX CARTON BOX MANUAL SILICAGEL SERIAL NO SCOTCH TAPE OPP TAPE STICKER STICKER STICKER WARRANTYCARD LED GUIDE E-1 STICKER CE STICKER CERTIFICATE SHEET
AL/EXTRUSION(L=430.0mm)
EGI,1.2t EGI,1.2t ACRYLIC,3.0t AL ADC-7(DIE CASTING)
) )
(BLACK SPRAY,SANDTON) BLACK SPRAY(SANDTON) BLACK SPRAY(SANDTON) LOGO:JBL,MODEL NAME: SILK 1
1 1 1 1 1 2 1 1
ACRYLIC(CLEAR) SK5(BK-P) CR,91.0x15.0x1.5t(NI-P) CR,103.0x15.0x1.5t(NI-P) FIBER,87.0x15.0x0.5t FIBER,99.0x15.0x0.5t RUBBER,5.0x7.0x1.6t RUBBER,0 12.0x 0 5.0x2.0t (SP1000)22.0x0.3t NYLON,L=4.5mm FELT,12.0x7.0x0.3t FIBER,200.0x8.0x0.5t FIBER,200.0x10.0x0.5t 0 5.0x40mm STT2 BH 3x12 NI-P STT2 BH 3x8 BK SML 3x6 NI(NO SERRATION)
SML 4x10 NI-P STT1 PH 4x25 BK STT1 LH 4x25 BK VINYL,380.0x580.0x0.1t VINYL,160.0x280.0x0.03t VINYL,80.0x100.0x0.03t VINYL,230.0x350.0x0.03t EPS,378.0x150.0x131.0
ACCESSORY
TR(4),THERMISTOR(1) ACCESSORY(4)
TR FET INDICATOR PCB SUPPORT S/PANEL+H/S(10),RCA(3),TERMINAL(4)
H/S+WINDOW(8) H/S+FOOT MOUNTING(10) BRACKET TR (12) ACCESSORY(4) SET MANUAL ACCESSORY MANUAL
SW#1(B )577.0x383.0x136.0
DW#2,592.0x292.0x408.0 3g
3 20mm
SET
"MADE IN KOREA" QC LABEL WINDOW STICKER ABS,L=12mm ART PAPER ART PAPER
9 SET LED
11
3 4 2 2 2 2 5 4 780mm 7 6 1 1 3 7 17 8 10 12 4 1 1 1 1 2 1 1/2 1 1 1 5cm 2.3m 1 1 1 1 3 2 2 1
Power Amplifier
PX300.4
12
13
14
15
Ref#
Description
Part Number
Qty
01 02 03 04 05 06 07
HEAT SINK MAIN AL/EXTRUSION (L=430mm) FRONT PANEL EGI 1.2T REAR PANEL EGI 1.2T WINDOW ACRYLIC 4.0T BADGE AL MOUNTING FOOT ADC-7 DIE CASTING LENS, ACRYLIC (WITH SILKSCREEN) LENS, ACRYLIC (WITHOUT SILKSCREEN) INDICATOR ACRYLIC (CLEAR) BRACKET TR(A) CR,91 X 15 X 1.5T (NI-P) BRACKET TR(B) CR,103 X 15 X 1.5T (NI-P) CUSHION BKT-TR(A) FIBER 87 X 15 X 0.5T CUSHION BKT-TR(B) FIBER 99 X 15 X 0.5T CUSHION RUBBER (A) 12 X 7 X 1.6T SILICON PAD (SP1000) 22 X 0.3T SUPPORT PCB NYLON L=4.5mm SWITCH DECAL FELT 12 X 7 X 0.3T TUBE 5 X 40mm SCREW STT2 BH 3 X 12 NI-P SCREW STT2 BH 3 X 8 BK SCREW SML 3 X 6 NI (NO SERRATION) SCREW SML 4 X 10 NI-P SCREW STT1 PH 4 X 25 BK
HEA-01-574A0 PAN-06-561A0 PAN-06-564A0 COV-22-623B0 BAD-01-515A0 FOO-01-504B0 COV-22-549AA COV-22-549A0 ILL-22-503A0 BKT-05-521A0 BKT-05-521A0 SUB-28-573A0 SUB-28-574A0 SUB-33-513A0 SIL-34-001A0 SUP-29-502A0 SUB-27-524A0 SUB-12-576A0 SC5-NB-30120 SC5-BB-30080 SC1-NL-30060 SC1-NL-40100 SC4-BP-40250
1 1 1 1 1 2 1 1 3 2 2 2 2 5
08 09 10 11 12 13 14 15 16 17 18 19 20 21 22
6 6 3 6 17 8 10 12
16
A
B
C
D
E 17
1
2
3
4
5
6
7
8
PX300.4
A
B
C
D
E 18
1
2
3
4
5
6
7
8
A
B
C
D
E 19
1
2
3
4
5
6
7
8
A
B
C
D
E 20
1
2
3
4
5
6
7
8
PX300.4
A
B
C
D
E 21
1
2
3
4
5
6
7
8
A
B
C
D
E 22
1
2
3
4
5
6
7
8
A
B
C
D
E 23
1
2
3
4
5
6
7
8
PX300.4
A
B
C
D
E 24
1
2
3
4
5
6
7
8
A
B
C
D
E 25
1
2
3
4
5
6
7
8
26
