Rcd-w1 - Diagramasde.com

Transcript

RCD-W1 SERVICE MANUAL US Model Canadian Model E Model Ver 1.3 2002.11 Model Name Using Similar Machanism NEW CD-R CD Mechanism Type CDM-700(CD-RW) Optical Pick-up Type CDP KRS-220C Model Name Using Similar Mechanism NEW CD Mechanism Type CDM-700(CDP) SPECIFICATIONS DECK A (the CD player section) System Compact disc and digital audio system Laser Semiconductor laser ( λ = 780 nm) Emission duration: continuous Frequency response 20Hz–20,000kHz (0.5 dB) Signal-to-noise ratio More than 100 dB Dynamic range More than 93 dB DECK B (the CD-R and CD-RW recording section) System Compact disc digital audio system Laser Semiconductor laser ( λ = 780 nm) Emission duration: continuous Playable discs CD, CD-R, CD-RW Recordable discs CD-R, CD-RW (for music use) Frequency response 20 to 20,000 Hz ±0.5 dB Signal-to-noise ratio Over 96 dB during playback Dynamic range More than 93 dB during playback Inputs ANALOG IN (Phono jacks) impedance 47 kilohms Rated input 330 mVrms Minimum input 125 mVrms DIGITAL OPTICAL IN (Square optical connector jack) Optical wavelength 660 nm Outputs ANALOG OUT (Phono jacks) impedance 47 kilohms Rated output 2 Vrms Load impedance over 10 kilohms OPTICAL DIGITAL OUT (Square optical connector jack) Wavelength 660 nm Output level -18 dBm General Power requirements U.S.A. and Canada 120 V AC, 60 Hz Power consumption 28 W Dimensions (approx.) (w/h/d) incl. projecting parts and control 430 x 108 x 368 mm Mass (approx.) 4.6 kg Supplied accessories • Audio connecting cord (2) • Remote commander (remote) (1) • Size AA (R6) batteries (2). Design and specifications are subject to change without notice. COMPACT DISC RECORDER 9-929-582-14 Sony Corporation 2002K0200-1 © 2002.11 Home Audio Company Published by Sony Engineering Corporation RCD-W1 SAFETY CHECK-OUT (US model only) NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. The Laser component in this product is capable of emitting radiation exceeding the limit for Class 1. This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior. After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE The AC leakage from any exposed metal part to earth Ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A) To Exposed Metal Parts on Set This caution label is located inside the unit. 0.15µF 1.5kΩ AC voltmeter (0.75V) Earth Ground Fig. A. Using an AC voltmeter to check AC leakage. CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of soldering iron around 270˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. SAFETY-RELATED COMPONENT WARNING !! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. 2 ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY. RCD-W1 TABLE OF CONTENTS Error Messages 1. SERVICING NOTE .......................................................... 4 The following table explains the error messages that appear in the display. 2. GENERAL .......................................................................... 8 Message Explanation 3. DISASSEMBLY CHECK DISC • A record-related button has been pressed when a finalized disc is in the DECK B. 3-1. Top Case ............................................................................... 9 3-2. Tray Door, Front Panel Assy .............................................. 10 3-3. HP board, FL board, VOL board ........................................ 10 3-4. Back Panel ......................................................................... 11 3-5. Audio Board ....................................................................... 11 3-6. Power Board ...................................................................... 12 3-7. CDP Deck assy (Deck A), CD-R Deck Assy (Deck B) ..... 12 3-8. BD Board (Deck A) ........................................................... 13 3-9. CDP Mechanism Assy (Deck A) ........................................ 13 3-10.Spindle Motor Assy, Pick-Up Block (Deck A) .................. 14 3-11.BD-R Board ........................................................................ 14 3-12.CD-R Mechanism Assy (Deck B) ...................................... 15 3-13.Sled Mechanism Assy ........................................................ 15 • A record-related button has been pressed when a standard CD is in the DECK B. DATA DISC A non-audio CD-ROM or a CDVideo disc has been placed in the machine. DISC ERROR • An unfinalized disc has been placed in the DECK A. • A DVD disc has been placed in the unit. DISC FULL ERROR There is not enough time left on the disc to complete a planned recording. • The disc is not seated properly. • There is a problem with the disc. FAILED A dubbing has not been completed properly. FULL More than 20 tracks have been programmed. NO AUDIO A record-related button has been pressed when a non-audio disc is in the DECK B. 4. ELECTRICAL ADJUSTMENT ................................... 16 5. DIAGRAMS 5-1. Circuit Boards Location .................................................... 23 5-2. Block diagrams – CD-R Section (1/2) – ........................... 25 Block diagrams – CD-R Section (2/2) – ........................... 26 Block diagrams – CDP Section – ...................................... 27 Block diagrams – Audio Section – ................................... 28 Block diagrams – Power Section – ................................... 29 5-3. Printed Wiring Board – CD-R Section (Side A) – ............ 30 Printed Wiring Board – CD-R Section (Side B) – ............ 31 5-4. Schematic Diagram – CD-R Section (1/6) – ..................... 32 5-5. Schematic Diagram – CD-R Section (2/6) – ..................... 33 5-6. Schematic Diagram – CD-R Section (3/6) – ..................... 34 5-7. Schematic Diagram – CD-R Section (4/6) – ..................... 35 5-8. Schematic Diagram – CD-R Section (5/6) – ..................... 36 5-9. Schematic Diagram – CD-R Section (6/6) – ..................... 37 5-10. Printed Wiring Board – CDP Section (Side A) – .............. 38 Printed Wiring Board – CDP Section (Side B) – ............... 39 5-11. Schematic Diagram – CDP Section (1/3)– ....................... 40 5-12. Schematic Diagram – CDP Section (2/3)– ....................... 41 5-13. Schematic Diagram – CDP Section (3/3)– ....................... 42 5-14. Schematic Diagram – Audio Section (1/2)– ..................... 43 5-15. Schematic Diagram – Audio Section (2/2)– ..................... 44 5-16. Printed Wiring Board – Audio Section – ........................... 45 5-17. Printed Wiring Board – Panel Section – ........................... 46 5-18. Schematic Diagram – Panel Section – ............................. 47 5-19. Printed Wiring Board – Power Section – ......................... 48 5-20. Schematic Diagram – Power Section – ............................ 49 5-21. IC Pin Functions ............................................................... 50 5-22. IC Block Diagrams ........................................................... 55 6. EXPLODED VIEWS 6-1. 6-2. 6-3. 6-4. Front Panel Section ............................................................. 61 Chassis Section ................................................................... 62 CD Play Section (Deck A) .................................................. 63 CD Record Section ............................................................. 64 7. ELECTRICAL PARTS LIST ................................. 65 3 RCD-W1 SECTION 1 SERVICING NOTE NOTES REGARDING HANDLING OF THE PICK-UP 1. Notes for transport and storage 1) The pick-up should always be left in its conductive bag until immediately prior to use. 2) The pick-up should never be subjected to external pressure or impact. Storage in conductive bag Drop impact 2. Repair notes 1) The pick-up incorporates a strong magnet, and so should never be brought close to magnetic materials. 2) The pick-up should always be handled correctly and carefully , taking care to avoid external pressure and impact. If it is subjected to pressure or impact, the result may be an operational malfunction and/or damage to the printed-circuit board. 3) Each and every pick-up is already individually adjusted to a high degree of precision, and for that reason the adjustment point and installation screws should absolutely never be touched. 4) Laser beams may damage the eyes! Absolutely never permit laser beams to enter the eyes! Also NEVER switch ON the power to the laser output part (lens, etc.) of the pick-up if it is damaged. NEVER look directly at the laser beam, and don’t let contact fingers or other exposed skin. 5) Cleaning the lens surface If there is dust on the lens surface, the dust should be cleaned away by using an air bush (such as used for camera lens). The lens is held by a delicate spring. When cleaning the lens surface, therefore, a cotton swab should be used, taking care not to distort this. Pressure Magnet Pressure How to hold the pick-up Cotton swab Conductive Sheet 6) Never attempt to disassemble the pick-up. Spring by excess pressure. If the lens is extremely dirty, apply isopropyl alcohol to the cotton swab. (Do not use any other liquid cleaners, because they will damage the lens.) Take care not to use too much of this alcohol on the swab, and do not allow the alcohol to get inside the pick-up. 4 RCD-W1 NOTES REGARDING COMPACT DISC PLAYER REPAIRS 1. Preparations 1) Compact disc players incorporate a great many ICs as well as the pick-up (laser diode). These components are sensitive to, and easily affected by, static electricity. If such static is high voltage, components can be damaged, and for that reason components should be handled with care. 2) The pick-up is composed of many optical components and other high-precision components. Care must be taken, therefore, to avoid repair or storage where the temperature of humidity is high, where strong magnetism is present, or where there is excessive dust. 2. Notes for repair 1) Before replacing a component part, first disconnect the power supply lead wire from the unit 2) All equipment, measuring instruments and tools must be grounded. 3) The workbench should be covered with a conductive sheet and grounded. When removing the laser pick-up from its conductive bag, do not place the pick-up on the bag. (This is because there is the possibility of damage by static electricity.) 4) To prevent AC leakage, the metal part of the soldering iron should be grounded. 5) Workers should be grounded by an armband (1MW) 6) Care should be taken not to permit the laser pick-up to come in contact with clothing, in order to prevent static electricity changes in the clothing to escape from the armband. 7) The laser beam from the pick-up should NEVER be directly facing the eyes or bare skin. Armband Resistor (1MW ) Resistor (1MW) Conductive Sheet 5 RCD-W1 Electrostatically Sensitive Devices (ESD) Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive Devices (ESD). Examples of typical ESD devices are integrated circuits and some field-effect transistors and semiconductor chip components. The following techniques should be used to help reduce the incidence of component damage caused by static electricity. 1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off any electrostatic charge on your body by touching a known earth ground. Alternatively, obtain and wear a commercially available discharging wrist strap device, which should be removed for potential shock reasons prior to applying power to the unit under test. 2. After removing an electrical assembly equipped with ESD devices, place the assembly on a conductive surface such as aluminum foil, to prevent electrostatic charge buildup or exposure of the assembly. 3. Use only a grounded-tip soldering iron to solder or unsolder ESD devices. 4. Use only an anti-static solder removal device. Some solder removal devices not classified as "anti-static" can generate electrical charges sufficient to damage ESD devices. 5. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ESD devices. 6. Do not remove a replacement ESD device from its protective package until immediately before you are ready to install it. (Most replacement ESD devices are packaged with leads electrically shorted together by conductive foam, aluminum foil or comparable conductive materials). 7. Immediately before removing the protective material from the leads of a replacement ESD device, touch the protective material to the chassis or circuit assembly into which the device will by installed. CAUTION : BE SURE NO POWER IS APPLIED TO THE CHASSIS OR CIRCUIT, AND OBSERVE ALL OTHER SAFETY PRECAUTIONS. 8. Minimize bodily motions when handing unpackaged replacement ESD devices. (Otherwise harmless motion such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can gen erate static electricity sufficient to damage an ESD device). 6 RCD-W1 NOTE ON CHECKING POWER SUPPLY CIRCUIT 1. When check the primary part, you must remove the GND pin of the scope and soldering machine. Primary GND : C903 – terminal at power board. 2. When check the primary part, you must open the another GND(not used GND) of scope. (If another scope GND is connected to secondary GND or other system, input power line or system have some damage.) 3. When touch the primary part by hand in defected system, if you use the power line switch, remove the power cord and then check or touch. Because in general power switch is switching only one line. 4. When check the primary part, after remove power cord and dis charge the primary capacitor, and then check the system. In the normal state, the voltage of the capacitor is small (about 10V), but in the abnormal state is very high ( about 140V at 100V A.C or 300V at 220V). When discharge the capacitor, use the wattage resistor(about 100 ohm). 5. In the narrow system, Until set repaired completely, insert the power cord at the moment repeatedly and then check the waveform. 6. In the wide system, when insert the power cord, check the wave form after about 3 second. Because the wide system is the soft start method. BD-R BOARD CHECK AND ADJUSTING JIGS In case of checking or adjusting the LD power of BD-R board, the PC connection jig (J-2501-210-A) and the test program are required. This test program is distributed with the service manual. RCD-W1 BD-R board CD-R test connector (PN201) PC connection jig (J-2501-210-A) PS-232C cable (D-sub 9pin) (straight type) SW501 PC connection jig Set SW501 to “D” side W D CN505 CNP501 PC 7 RCD-W1 SECTION 2 GENERAL FRONT PANEL 1 2 34 56 7 8 9 wk wj 0 wh wg wf wd ws wa w; qlqk qj qh qg qf qd qs qa LOCATION OF PARTS AND CONTROLS 8 1 Power button qg ERASE button (DECK B) 2 OPEN/CLOSE A button (DECK A) qh FINALIZE button (DECK B) 3 . AMS button (DECK A) qj DISC tray (DECK B) 4 > AMS button (DECK A) qk CD SYNCHRO HIGH button 5 . AMS button (DECK B) ql CD SYNCHRO NORMAL button 6 > AMS button (DECK B) w; DISC tray (DECK A) 7 OPEN/CLOSE A button (DECK B) wa 8 H button (DECK B) ws TIME button (DECK A) 9 z REC button wd RELAY button (DECK A) remote sensor q; REC LEVEL knob (DECK B) wf x button (DECK A) qa X button (DECK B) wg X button (DECK A) qs x button (DECK B) wh PHONE jack qd INPUT button (DECK B) wj PHONE LEVEL knob qf TIME button (DECK B) wk H button (DECK A) RCD-W1 SECTION 3 DISASSEMBLY Note: Disassemble the unit in the order as shown below. Set Top case Tray door, Front panel assy Back panel HP board, FL board, VOL board Audio board Power board CDP deck assy (deck A) CDP mechanism assy (deck A) BD board (deck A) Spindle motor assy, Pick-up block (deck A) CD-R deck assy (deck B) BD-R board (deck B) CD-R mechanism assy (deck B) Sled mechanism assy Note: Follow the disassembly procedure in the numerical order given. 3-1. TOP CASE 2Three screws (case) 1Two screws (case) 4Top case 3 1Two screws (case) 9 RCD-W1 3-2. TRAY DOOR, FRONT PANEL ASSY Note:After No.2 removal, remove in the state power turns off. 1 Turn power on by pressing POWER button in the drrow A direction and press OPEN/CLOSE button in the drrow B to open the tray. Then remove the tray door in the drow C direction. (In the case of DECK B, remove it in the same manner.) Tray door 6Connector (PN901) C A 5Connector (PN603) B 4Connector (PN904) 3Connector (PN401) 2Connector (PN501) 8 Tray door (Play) (deck A) 9Front panel assy Tray door (Rec) (deck B) 3-3. HP BOARD, FL BOARD, VOL BOARD 7Claws 7Screw (Special) 8HP board 3Two screws (Special) 6POWER knob 4 5PWB holder 0Two screws (Special) 9Four screws (Special) 2P/VOLUME knob qsFL board and VOL board qaClaws 10 Front panel 1REC VOL knob RCD-W1 3-4. BACK PANEL 3Cord power 5Back panel 1Four screws (3X10) 2Two screws (3X8 BK) 4 3-5. AUDIO BOARD 5Connector (PN201) 3Connector (PN602) 6Two screws (special) 2Connector (PN105) 4Connector (PN606) 7Three screws (special) 9AUDIO board 8 1Wire (flat type) (CN102) 11 RCD-W1 3-6. POWER BOARD 2Two screws (special) 3Two screws (special) 1Connector (PN601) 5POWER board 4 3-7. CDP DECK ASSY (DECK A), CD-R DECK ASSY (DECK B) 2Two screws (special) 3Two screws (special) 1Wire (flat type)(PN605) 5CDP deck assy (deck A) 6Two screws (special) 7Two screws (special) 9CD-R deck assy (deck B) 4 8 12 RCD-W1 3-8. BD BOARD (DECK A) 1Three claws 4Wire (flat type) (PN201) 2Wire (flat type) (PN301) 3Connector (PN609) 6 BD board 5Wire (flat type) (PN401) 3-9. CDP MECHANISM ASSY (DECK A) 3Clamp holder assy 1Screw (1.7X6) 7Two screws 2 4Push out the disc tray by pushing the Up/Down guide un the drrow A direction. 9CDP mechanism assy Up/Down guide 8 Main base A Bottom view 5 6Disc tray 13 RCD-W1 3-10. SPINDLE MOTOR ASSY, PICK-UP BLOCK (DECK A) 5Screw (1.7X5) 3Screw (1.7X5) 8Pick-up block 7 4Shaft L 6Shaft R 2Spindle motor assy 1Three screws (2X6) 3-11. BD-R BOARD (DECK B) 1Three claws 3Wire (fiat type) (CN401) 4Wire (fiat type) (CN501) 6 2Connector (CN701) 7BD-R board 5Wire (flat type) (CN502) 14 RCD-W1 3-12. CD-R MECHANISM ASSY (DECK B) 3Clamp holder assy 1Screw (1.7X6) 7Two screws 2 4Push out the disc tray by pushing the Up/Down suide un the drrow A direction. 9CD-R mechanism assy Up/Down guide Main base 8 A Bottom view 5 6Disc tray 3-13. SLED MECHANISM ASSY CD-R mechanism assy 5Sled mechanism assy 4Two screws (2.0x11.5) 3Screw (2.0x4.5) 2Pinion gear assy 1Washer 15 RCD-W1 SECTION 4 ELECTRICAL ADJUSTMENT LD Power Adjustment Jigs used on this adjustment • LD Power Meter A laser power meter 10mW or more measurable is required. Don’t use the laser power meter for Mini disc because of 10mW max. Optical power meter (TQ8210): Product of ADVANTEST (on the market). A thin type optical sensor (Q82017A): Product of ADVANTEST (on the market). • PC Connection Jig (J-2501-210-A) • Test Program FD Dragon program Ver. 5.41 (This test program is distributed with the service manual.) • PC (Windows 95/98) • RS-232C Cable (on the market) D-SUB 9 pin, straight type • Test Disc for Operation Check A low reflecting rate disc for checking playback performance. OK: It can be played back. • Low reflecting CD-R disc: TCD-R082LMT (J-2502-063-1) • Low reflecting CD-RW disc: TCD-W082L (J-2502-063-2) Laser Power Adjustment (CD-R Only) In case of the following parts are replaced, this adjustment is required. 1. CD-R optical pick-up block (KRS-220C) 2. IC702 (EP- ROM) Specification of Dragon Program Usage Environment The Dragon Program programmed by API function of Windows 95 can be surely operated on the Windows 95/98 platform. It isn’t guaranteed on the other platform. Start up Procedure: 1. Connect the PC connection jig with the RS-231C cable between the test connector (PN201) on CD-R of RCD-W1 and COM port on PC. (Check SW501 on the PC connection jig to “D” side.) 2. Turn power on RCD-W1. 3. Execute Dragon.exe on Windows. (Two files Dragon.exe and dragon.cfg are displayed on the setup menu window.) 4. Select “Setup I/F” on “Setup” pull-down menu, then “Select I/F Method” window is open. 5. Select Com Port matching to the Com Port connected the PC connection jig. 6. Select “38400” of “Select Transfer Rate”. 7. Click OK. Fig 1 : Dragon menu and setup menu windows Fig 2 : Select I/F method window 16 RCD-W1 CD-R LD Setting Check (VRDC/VWDC/FPD Level Value Check) This routine is for checking performances of the record/playback D-A converter (IC409), RFIC (IC413), the encoder/decoder IC (IC401), CPLD (IC601), the optical pick-up block (KRS-220C), the microcomputer(IC701) and so on. It diagnoses malfunctions of interface, the pick-up or so on. It diagnoses the circuit in the recording mode without disc. Description of each item OFF LEVEL: In case of the laser turns off, FPDO output is 3V. Sampling value at this time. VRDC LEVEL: APC circuit VRDC signal sampling value after READ power setting. VRDC FPD: Optical pick-up FPDO signal sampling value after READ power setting. VWDC1 LEVEL:APC circuit VWDC signal sampling value after setting WRITE power to regular value. VWDC1 FPD: Optical pick-up FPDO signal sampling value after setting WRITE power to regular value. VWDC2-1 FPD: There are two types of characteristics because of a non-linearity period of laser diode in the over drive portion. This is FPDO sampling value in case of setting one of them to VWDC2 value. VWDC2-2 FPD: FPDO sampling value in case of setting the other to VWDC2 value. Specification of each item 38400-3300 : REC (CD-R only) Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. • Signal path. J : CD play c : digital out I : CD REC • Abbreviation CND : Canadian model. MX : Mexican model. For printed wiring boards. Note: • : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: (Side B) Parts face side: (Side A) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated. • Indication of transistor C Q These are omitted BC E B E These are omitted • Abbreviation CND : Canadian model. MX : Mexican model. 5-1. CIRCUIT BOARDS LOCATION POWER board BD board HP board AUDIO board BD-R board FL board VOL board 23 RCD-W1 WAVEFORMS – CDR SECTION – 1 – CD SECTION – IC401 ig (RRFIN) PLAY MODE 6 1 IC301 uf (CDP33M) IC201 id (XTLO) 5.0Vp-p 4.8Vp-p 0.8Vp-p 0.2V/dic 500nsec/div 2 7 IC401 th (FE) PLAY MODE 2 IC501 yh (EXTAL) IC701 yh (EXTAL) 0.2V/div 500nsec/div 50nsec (20MHz) 29.5nsec (33.86880MHz) 8 IC401 tj (TE) PLAY MODE 1.7Vp-p 1.7Vp-p 0.1Vp-p 3 29.5nsec (33.86880MHz) 2V/div 20nsec/div 29.5nsec (33.86880MHz) 3 IC101 qg (RFAC) IC306 qs (ILRCK) PLAY MODE 0.8Vp-p 5.0Vp-p 0.2V/div 500µsec/div 0.3Vp-p 22.5µsec 0.2V/dic 500nsec/div 4 9 IC310 4 4 IC101 qh (FF) IC306 qd (ISCLK) PLAY MODE 0.2Vp-p 4.0Vp-p 4.8Vp-p 0.1V/div 5msec/div 2.9nsec (33.86880MHz) 5 0.36µsec 0 IC301 yg (CLK_IN) 5 IC101 qk (TE) IC201 149 (XIN) PLAY MODE 1Vp-p 2.2Vp-p 1V/div 5msec/div 29.5nsec (33.86880MHz) 29.5nsec (33.86880MHz) – PANEL SECTION – 1 IC801 4 (X2) 4.8Vp-p 0.2µsec (5MHz) 24 1.0Vp-p RCD-W1 5-2. BLOCK DIAGRAMS – CD-R SECTION (1/2) – IC407 4 RF AMP IC413 (1/2) RF EQUALIZER, FOCUS/TRACKING,ERROR DETECT G H RFO SRFO S/H MATRIX 64 RFRPIN RF AMP IC413 (2/2) EQREP 71 EQRFN 72 RF EQ PH01 PH/BH TEIN IC406 HAVCOFS RFCT RFRP TX AFC AGCON MCLK XLAT SDATA SCLK ERGCNT BUFFER EFM 14 BS 2,3 58 IC403 (4/4) 9 57 TE AMP 1 DIFERENTIAL IC411 (1/2) 8 Y0 1 Y1 5 Y2 2 Y3 4 X0 12 X1 14 X2 15 X3 11 88 26 51 61 62 55 Y RX TX 3 ASYM2/OUT X ASYM1/BETA 13 CTLX 10 CTLY 9 +8V REG +8V (B) +8V REG IC511 6 5 OPOUT1 TRK- +8V(A) +8V(B) M701 LOADING MOTOR M TRAY+ TRAYSLD+ M SLD- 11 12 VO1+ DRV OPOUT2 7 OPIN26 OPIN2+ 5 VO2VO2+ DRV 10 PWR VCC1 19 PWR VCC2 STBY1 9 STBY2 20 16 17 18 VO4- 25 OPIN4- 26 OPIN4+ 27 DRV IC409 IC512 RPOWER VWDC2 TAO WREF HAVCOFS ACT-MUTE TRAY-MUTE TRAYCTL VWDCLMT 22 OPIN323 OPIN3+ 24 DRV HALL SENSOR HA+ HAHBCONTROL SW_IN1 27 SW_CNT 25 SW_OUT 26 VLO 19 ADD AMP 16 OUT2 7 +2.5V SLO HALL SENSOR HVHW+ HWHH+ 9 10 11 12 13 14 15 H1+ H1H2+ H2H3+ H3VH EPCLK EPDATA BUFFER DADATA 17MCPLD ERGCNT +2V WLDON REPDSH WFPDSH WBLSH SPDSH (2.5V) 5 4 +4V REG. MPDSH 2 OSCEN ENBL ODON SLD_OUT ADSEL Z 9 10 11 X SPNBOOST CDR/RW WR/RE Y 3 5 4 1 2 DMO PS 23 EC 22 FR 20 S3 18 FG3 19 5 BUFFER 7 13 12 IC509 (2/2) 2 -A W/XR EEFS EFM3 POPC1 RESAMP1 EFCK 1 SPNON RESAMP2 SPNREV SBRK RDPCON 32 RDPCON 60 RDPCON SYSTEM CONTROL IC701 (1/2) MPDSH IC601 OSCEN ENBL ODON 36 ATIP/EFM 37 WBLOCK 38 ADTRIG Y 14 18 19 20 21 WLDON REPDSH WFPDSH WBLSH SPDSH 33 CDR/RW 34 WR/RE ATIP/EFM WBLOCK ADTRIG 15 IC509 (1/2) DRIVE 17MHz ERGCNT 18 SDATA 19 SCLK 24 /DACS LPCD W/XR IC508 HALL1 1 14 13 5 3 6 7 8 A+5V AMP GAIN SELECT SLDFG 21 /EPCS DACS SLD_MUTE SPN8/12 CONTROL BUFFER 3 23 /CXACS DADATA DACLK DO 17 CLK 16 LD 15 AO10 AO11 AO12 59 AGCON 48 RECD1 49 RECD2 SCLK CS 1 CK 2 DI 3 IC103 HALL/SLDO HU+ HUHV+ AO6 AO7 SLD_MOVE IC510 M502 SPINDUL MOTOR IC702 +4V MOTOR DRIVER M EEPROM WBLOCK 17 22 EDGE 18 B+ 8 A3 2 A2 4 A1 7 /CXACS CXADATA RIPBC IC514 (2/2) HB_IN W V U AO8 AO9 1 IC502 HB+ VH+ VH- 7 8 9 12 13 20 CDR/RW # 7 WR/RE # 2 4 IC514 (1/2) MOTOR CONTROLER 2 3 9 10 23 24 AO4 AO5 1 DACLK /DACS 2V_ACT M501 SLED MOTOR 3 4 5 6 7 BUFFER 78 AMYS2/LVL0 IC414 IC411 (2/2) 5 RIPBC 18 AO1 19 AO2 OPOUT3 VO3+ VO3- D/A CONVERTER FAO OPOUT4 VO4+ 15 7 I 39 40 41 42 43 EEFS EFM3 POPC1 RESAMP1 EFCK 2 RESAMP2 44 34MCLK WRSMP 12 MONTITO 22 LDON 23 WGATE 27 EFM1 29 EFM2 30 HRSW 31 /RST 16 WRSMP MONTITO LDON WGATE EFM1 I I TRK+ TRACKING COIL 14 4 OPIN13 OPIN1+ 2 VO1- AGCON RECOD1 RECOD2 I FCS- 13 2 1 7 I FCS+ FOCUS COIL IC412 IC404 +12V 96 79 AMYS2/LVL1 53 XTOR COMPARATOR +8V (A) CD-R SECTION (2/2) (Page 26) FE SELECT ASYM2 PH02 73 BH02 74 ASYM1 BETAOUT 82 BETA BELEVELO SWRF 4 1 TE IC405 TEBC IC501 RP FE BUFFER BTL MOTOR DRIVE BS RP TE WBLIN ACON RECD2 RECD1 MPDSH ROPCSH_E CEO WBLSH SODSH CE 46 47 48 49 17MCPLD Q402 80 81 2 /CXACS CXADATA SCLK ERGCNT Q405 3 40 41 42 43 RECD2 RECD1 CE 11 38 39 50 REGISTER MPDSH ROPCSH_E 5 WLDON FVREF WFPDSH RF PDSH WREF CE WBLSH SODSH 5 13 12 Q403 WLDON 3 7 Q401 RPOWER 1 Q404 CE 5 75 FE 56 XTOR 53 FE TE WFPDSH I RF PDSH ODON W/XR ENBL OSCEN +4V ERGCNT PDVC APC 10 FPDIN 17 FPDO 16 VRDC 14 MLDON LD DRIVER/CONTROL EPDVC 9 VWDCLMT VWDC2 I PD VRDC ODON W/XR IN3OSCEN TE WREF D401 VWDC1 VWDC2 FPDO EFM(RFAC) 7 IC403 (2/4,3/4) FEO 6 LD 6 5 OPCING G H E F 85 65 WR/RE E F C D AIN BIN CIN DIN EIN FIN GIN HIN 1 BUFFER CDR/RW C D 100 99 98 97 95 94 93 92 86 PRE A B A B IC403 (1/4) 3 1 MSPP IC401 1 PRFIN OPTICAL PICK-UP BLOCK (KRS-220C) 3 2 EFM2 HRSW HOLL/SLDO 22 HALL/SLDOUT ADSEL 6 ADSEL SPNBOOST 100 SPNBOOST SPN8/12 99 SPN8/12 •Signal Path : CD PLAY I : CD REC /RST 63 RESET SPNFG SYS BUS 34MCLK A+5V 25 25 2 CD-R SECTION (2/2) (Page 26) RCD-W1 – CD-R SECTION (2/2) – DATA SELECT IC307 198 TE FE 197 FE RX 191 RX 192 TX TX HRST# PRST# 96-103 130-122 104 105 106 107 110 111 112 113 53 95 UAD0 I UAD7 URD# UWR# UCS0# UCS1# URDY UINT0# UINT1# SDINT# SRC DAC_MCLK SDAC_MCK RCASH# RCASL# RRAS# RWE# ROE# 1-10, 80-75 IC302 A0 I A9 30 31 38 37 36 31 32 15 14 30 /UCAS /LCAS /RAS /WE /DE γ SDR 46 γ LRCK 44 γ SCLK 45 γ CLK_OUT 48 DAC_MCK SDAC_MCK PCLK_OUT 49 I/O0 I I/O7 A0 I A14 /WE 27 OE 22 /CS 20 73 72 70 71 89 88 CSB1 87 CSB3 33-40 IC203 CSB1 CSB3 11-13,15-19 RAM I/O0 I I/O15 AUD.MUTE OUTDATA1 <0> I OUTDATA1 <7> OUTDATA2 <0> I OUTDATA2 <7> OUTDATA2 <0> I OUTDATA2 <7> DIOWB DIORB BUS_DA <1> BUS_DA <0> BUS_DA <2> MDA_DATA MDA_LRCK MDA_CLK 18 17 16 21 OMCK DATA SELECT P_DATA P_LRCK P_CLK IC304 3 5 P_LRCK 1 AD_LRCK 2 P_CLK 13 AD_CLK 12 PLRCK 41 PSCLK 42 I 4 AD_DATA 15 14 14 SDIN SDA/CDOUT 1 AD0/CS 2 12 ILRCK AD1/CDIN 27 SCL/CCLK 28 I NT 19 13 ISCLK RST 9 MCLK SDAC_MCK CDR_MUTE P_PCMDT P_LRCK P_BITCK SRC_DOUT SRC_CS SRC_DIN SRC_CLK SRC_INT SRC_RESET OPT_S M_S 9,10,11 RAM_DATA <0> I RAM_DATA <7> B AUDIO SECTION (Page 28) SDOUT OLRCK OSCLK OMCK P_DATA PDATA 43 MDA_DATA MDA_LRCK MDA_CLK AD_DATA AD_LRCK AD_CLK OPT_SEL M_PBSEL S_PBSELT 13-27 RA0 I RAD9 RAM 1-10,21,23-26 RD0 I RD15 DIOWB DIORB BUS DA1 BUS DA0 BUS DA2 CSB1 CSB3 2-5,7-10, 35-38,40-43 70 69 62 60 59 57 56 DIOWB DIORB BUS_DA1 BUS_DA0 BUS_DA2 18-21, 24-29 EFCK ROPC1 LDON FG CE TEBC WGATE FEFS HWR# HRD# HA1 HA0 HA2 CS1FX CS3FX DA0-DA15 32,33,29-24, 21-14 FAO TAO SLO DMD EFM1 EFM2 EFM3 WRSMP RESAMP1 RESAMP2 72,73,76-82, 85-91 HD0 I HD15 IC201 52-48, 45-81 DSP SERVO UA0 I UA8 I I I 2 CD-R SECTION (1/2) (Page 25) MDA_DATA MDA_LRCK MDA_CLK AD_DATA AD_LRCK AD_CLK IC301 I EFCK ROPC1 LDON FG CE TEBC WGATE FEFS 207 208 3 2 183 184 185 180 181 182 177 186 142 7 204 194 166 179 TXP OUT RECORD CONTROL 8 EFM FAO TAO SLO DMD EFM1 EFM2 EFM3 WRSMP RESAMP1 RESAMP2 TXP 26 IC306 TP C34M 34MCLK 4 RXP M_S TE OPT_S 203 RP 4 10 9,11 DUBBING DUBSEL 51 CLKSEL0 CLKSEL<0> 59 CLKSEL1 CLKSEL<1> 60 P_CLK 62 RAM_ADDRESS <0> I RAM_ADDRESS <14> 30 RAM_WEB 31 RAM_OEB 32 RAM_CSB IC303 4 2 DUBBING CLKSEL0 CLKSEL1 CDP_33M AS_DUBBING DUB_SPD0 DUB_SPD1 MCKO A CLOCK OSC CLK_IN 65 RESET_B RP 5 3 OPT IN I CD-R SECTION (1/2) (Page 25) 201 BS 2 1 I 1 BS CDR DATA DOUT 146 163 EFM EFM 15 IC310 CDP SECTION (Page 27) X301 33.8688MHz 61 AUD_MUTE RESET IC101 /RST 1 OUT FWRST IN 2 D+5V +3.3V REG. IC102 3 66 67 8 /PRST EXTAL XTAL AUD_MUTE UA0 I UA8 /URD /UHWR /UCS0 UCS1 SRDY /UNIT0 /UNIT1 /SDIN 27-34 36-43,45 70 71 5 4 58 88 89 17 UAD0 I UAD7 X701 20MHz SYSTEM CONTROL /LOAD_SW /OPEN_SW TRAY_MUTE ATIP/EFM SLDMOVE ACT_MUTE ACT_MUTE TRAY_MUTE ATIP/EFM SLDMOVE SPNON SPNFG SPNON 47 SPNFG SBRK 46 SBRK 94 95 98 85 2 25 26 SLDFG SLDFG FWE 10 97 FWMD2 75 BTS_RXD 15 BTS_TXD 13 S701 (LOADING) 26 REC_TXD REC_TXD 12 REC_RXD 14 REC_CLK 16 RW_RXD REC_CLK FWE_ON 9 IC701 (2/2) I SYS BUS 4 OUT VCC 2 CTRL 1 +3.3v 26 TRAY ( OPEN ) D701 PN201 OR FWEN FWMD2 TEST RXD CONNECTOR TXD •Signal Path : CD PLAY : CD (DIGITAL) I: CD REC RCD-W1 – CDP SECTION – RF_1XL Q102 4V DIGITAL SERVO DIGITAL SIGNAL PROCESSOR IC101 18 143 20 142 CE FAO 113 TAO 2 Q105 112 SAO 111 LD_OFF DIFF AMP SPNFGG SLD_ERR TAO SAO IC301 VM2+ DRV 6 A M301 SLED MOTOR 9 VM4- B M P_PCMDT 56 CE/FE_SEL ACT_MUTE SPNFG TRAY_MUTE 1 IN3 2 IN3+ 3 8 OUT4 21 IN4- 20 IN4+ 19 DRV 13 12 LD+ SLD+ LD- SLD- 15 14 VM4+ DRV OUT5 VM5VM5+ IN5DRV IN5+ VREFO VREF 83 SLDPHA_A 84 SLDPHA_B 85 TRAY_CTL 23 SLDPHA_A SPNREV SLDPHA_B 16 17 18 22 23 SPIN_ON SAO MOTOR DRIVER IC401 M WOUT 2 VOUT 28 UOUT 27 KICK_LOW VCREF 5 MDP SPN_4X LIMIT SW HALL SENSOR HU+ UIN1 UIN2 VIN1 VIN2 WIN1 20 21 18 19 16 WIN2 17 VH 15 HUHV+ HVHW+ HWHH+ CONTROL FG 13 RS 14 SS 11 24 81 POW_CTL FLD_TXD FLD_CLK D FL/POWER SECTION (Page 29) +4V REG IC601 +5VA FLD_CS RMC_IN KEY_IN0 KEY_IN1 KEY_IN2 4 88 78 79 80 63 27 MCKO SRC_DIN SRC_DIN SRC_CLK SRC_DOUT SRC_CS A CD-R SECTION (2/2) (Page 26) SRC_INT SRC_RESET DPT_SEL M_PBSEL S_PBSEL DUB_SPD0 DUB_SPD1 AS_DUBBING REC_CLK RW_TXD 15 4 9,10 KEY_IN1 KEY_IN2 RESET P_BITCK CDP_33M SRC_CLK L/R_SWL REC_TXD 12 ASIC_CONF 8 REC_RXDE 14 AS_PGM 19 NC AS_DONE 20 NC IC502 1 RESET 2 27 CD/CDR_EMPH CD/CDR_DATAL CD/CDR__LVL AUD_LVL MAIN_MUTE REC_CLK 16 FLD_CS REMO_IN KEY_IN0 P_LRCK /PD PWR_SW 50 49 97 96 81 60 LVL_SW 21 91 POW_CTL 13 DIG_TXD 17 DIG_CLK P_PCMDT SUB_MUTE CDR_EMPH R_RMC MAIN_EMPH SUBOUT_SEL AUDIO_LVL AUD_SW CD/CDR_MUTE SW001 SPN_ON DUB_SW DUB_SW 48 CD_SW 59 SUB_SW 58 APCON 51 SRC_OUT 12 SRC_CS 3 SRC_INT 90 SRC_RESET 98 OPT_SEL 71 MPB_SEL 70 SPB_SEL 69 AES_SEL1 6 AES_SEL0 7 AS_DUBBING 72 TRAY ( OPEN ) (LOADING) +4V P_BITCK IC501 SPNREV SLD_IN P_LRCK SYSTEM CONTROL 43 SPIN_ON SPNFG A+5V SLEDIN_SW 33 TRAY_CTL SPN-CTL AMP VCF 4 41 40 39 38 87 37 36 34 SPNREV IC403 M401 SPINDUL MOTOR 27 29 26 28 30 SLDPHA_A SLDPHA_B Q401 DRIVE 93 94 25 SLD_ERR SPL_4X 45 SPL_8CM KICK_LOW 46 KICK_LOW SLD_IN 47 SLEDIN_SW LD_OFF 99 LD_ON RW_GUP 55 RW_GUP ACT_MUT 31 ACTUATOR TRAY_MUTE 32 TRAY_MUTE RF_1XH 53 MODE1 RF_4XL 52 MODE2 TRAY_CTL 82 95 SPNFG SLD_ERR Q403 W V U SRC_DIN SRC_CLK TAO CH3IN M B M609 LOADING MOTOR VM3- LEVEL METER L/R SEL POWER_DOWN P OUT SEL CD/CDR_LVL CD/CDR_EMPH CD/CDR_MUTE 5 VM3+ 10 AUDIO SECTION (Page 28) CDP_33M 1 7 MUTE1 26 MUTE2 25 A X201 33.8688MHz 84 CDX_XRST 32 C FAO OUT2 30 IN228 IN2+ 27 VM2- 71 SQCK TRK- DRV 119 41 51 63 64 68 69 SCOR SQSO T- 31 VM1+ COUT TRK+ 34 36 IN137 IN1+ 40 VM1- VC/FE T+ 35 TRAY_OUT_SW FCS- 98 97 100 96 95 PWR MUTE DUB SEL IC302 TRAY_IN TRACKING COIL FCS+ 103 103 105 AUD_LVL L/R SEL /PD CD/CDR_DATA CD/CDR_LVL CD/CDR_EMPH CD/CDR_MUTE 83 52 SELECTOR OUT1 F- XTLI MCKO BTL MOTOR DRIVE F+ MUTE SERVO DSP 129 PWM1 117 MDP MDP FOCUS COIL XTLO GEL. CLOCK 114 4V IC402 CPU INTERFACE FAO XRST RW_GUP CDR_EMPH R OUT SEL P_LRCK LRCK 27 21 12 VR TE SCOR SQSO SQCK APC 1 MD PD CEI CDP_BCK CDP_LRCK PR_BTCK DUB SEL GFS XT_SEL CDX_MUTE LD DRIVER Q101 LD ANALOG SWITCH • AMP • A/D CONVERTER SE 2 LD CDP_DATA P_BCK 31 FE 3 +5VA CE P_PCMDTK 29 R_RMC 16 TE DA15 CDP_DOUT 62 17 FE TRACKING ERROR AMP DA16 SERIAL/ PARALEL PROCESSOR LOCK GFS XTSL MUTE FOCUS ERROR AMP VC DOUT CDR_EMPH SUB_MUTE LOCK VCC 27 DIGITAL OUT 29 CLOCK SCLK SENS V.C FEI 141 32K RAM ERROR CORRECTOR RFDC DATA XLAT E F E F RFDCI 28 D/A PROCESSOR REGISTER CXD_CS CXD_CLK SENS_CLK SENS C D RFDCO RF SUM AMP EFM DEMODULATOR 13 15 FOK 6 7 8 9 10 11 C D RFAC EQ CXD_DATA A B A B AC AMP 3 COUT MIRR RF 24 25 26 MIRR FOK OPTICAL PICK-UP BLOCK IC201 RX_4XL Q104 RF AMP +5VA 2 1 NC 5 3 NC SELECTOR REC_CLK RW_TXD •Signal Path IC602 REC_RXD : CD PLAY RCD-W1 – AUDIO SECTION – IC112 JK101-1 LY402 L 3 4 ANALOG CDR IN 2 5 6 I 7 IC102(1/2) 2 3 VR802 7 1 8 5 6 I RELAY DRIVE Q405 MIC LEVEL 7 AINL1 AINR+ IC103(1/2) 2 3 5VD IC103(2/2) 5 SDATA 21 I 2 1 AD DATA LRCK 19 AD LRCK SCLK 18 AD CLK 5 3 (5/6) (3/6) 15 10 11 10 5 6 JK103 DIGITAL OPTICAL CD OUT 4 9 3 4 1 2 JK104 DIGITAL OPTICAL CDR OUT (2/6) (1/6) MCLK 17 B 2 AINR16 /PD CD-R SECTION (2/2) (Page 26) IC106 JK105 (6/6) DIGITAL OPTICAL CDR IN 5 7 6 AINL+ IC106 DIGITAL OUT SELECT TXP OUT R 6 5 IC108 A-D CONVERTER IC102(2/2) 13 I 12 (4/6) 9 8 I OPT IN DUB SEL CDP D OUT R OUT SEL CDR EMPH IC105 IC109 CDP SECTION (Page 27) C PLAYBACK SIGNAL SELECTOR CDP DATA CDP BCK CDP LRCK SDAC_MCK 5 3 12 13 2 1 4 9 14 11 15 10 IC104 D-A CONVERTER 6 SDATA 5 BICK L.P.F. 5 A OUTL+ 23 AOUTL- 22 6 3 A OUT R+ 21 A OUT R - 20 JK101-2 7 L 1 2 7 LRCK PHONES OUT SELECTOR 1 1 3 MCLK 8 S/MUTE/CS DEMO/CCLK 10 4 PD B+ FOR D-A CONV. SWITCH Q202 1 1 5VD 1 1 1 1 CD-R SECTION (2/2) (Page 26) B MDA DATA 7 3 2 1 JK101-3 PHONES MDA CLK MDA DATA MCLK 5 BICK 7 LRCK VR801 PHONE LEVEL IC404 L.P.F. 6 SDATA 5 A OUTL+ 23 AOUTL- 22 JK101-3 7 6 3 A OUT R+ 21 A OUT R - 20 L 1 2 RELAY DRIVE Q405 3 MCLK IC110 DEMO/CCLK 10 CDR MUTE Q207 MUTE IC406 5 6 IC401 D-A CONVERTER R Q208 MUTE IC111 ANALOG CD IN R Q404 MUTE ANALOG CDR OUT Q403 MUTE LEVEL/METER SELECTOR 8 S/MUTE/CS Q401 4 PD CD/CDR EMPH 3 Q411 5 Q402 Q410 1 2 4 9 12 15 10 13 14 11 LEVEL METER L/R SEL PWR MUTE C CD/CDR LVL POWER DOWN CD/CDR MUTE P OUT SEL CDP SECTION (Page 27) •Signal Path : CD PLAY : CD (DIGITAL) I : CD REC 28 28 RCD-W1 – POWER SECTION – KEY_IN1 KEY MATRIX SW801 - 808 SW810 - 822 KEY_IN2 KEY_IN3 RMC801 RMC_IN REMOTE 1 COMMANDER RECIEVER FLD_TXD 8 SI1 FLD_CLK 7 SCK1 FLD_CS F0 80 I I F15 65 15 PO1 FLUORESCENT DISPLAY FLD801 64 I F16 61 I • F35 58 I 43 (F+) (F-)AC2 (F-) (F+)AC1 D920 SWITCH Q904,910,911 D D907 FL DRIVER IC801 -12V X1 3 X2 4 3 -12V REG. IC906 5 6 -34V CDP SECTION (Page 27) T901 POWER TRANSFORMER D908 2 BD901 4 7 3 +12V REG. IC907 SWITCHING REGURATOR 3 IC901 9 1 DRAIN 2 DCP D910 VCC 5 1 3 GND D911 +15V -34V VLOAD 60 2 M12V RESET 6 3 IC802 1 IC905 D906 1 2 1 L903 +5V +5V 13 4 +5V (U-COM) RESET +12V REG. D909 12 A+5V SWITCH Q901,902 D+5V 11 5V(LAMP) 5VD(DCR) +5VA L904 SWITCH Q907,908 PWR_CTL REG. IC904 29 29 IC902 POWER SW901 AC IN 8 X801 5MHz V+12V L901 T901 T1.6A FB 4 LINE FILTER RCD-W1 5-3.PRINTED WIRING BOARD -CD-R SECTION- 3 2 1 A • See page 23 for Circuit Board location. 4 6 7 • Semiconductor Location OPTICAL PICK–UP BLOCK M501 SLED MOTOR M502 SPINDLE MOTOR BD-R BOARD (SIDE A) 5 1 2 11 1 2 10 8 31 32 2 7 1 14 A 1 5 B 7 1 8 9 1 5 8 25 1 26 BD BOARD PN605 (Page 38) 1 8 1 5 8 4 14 8 1 8 4 28 15 4 1 2 16 16 4 5 1 8 4 5 C 9 6 1 8 8 C AUDIO BOARD CN105 (Page 45) 1 1 23 12 11 22 33 9 16 1 34 44 1 2 B D 15 4 1 5 8 16 R745 R747 R748 1 1 2 4 3 5 E 30 30 AUDIO BOARD PN105 (Page 45) Ref. No. Location IC102 IC201 IC304 IC403 IC405 IC406 IC411 IC413 IC502 IC508 IC509 IC514 IC601 IC702 E-5 D-4 C-6 B-4 C-4 B-5 C-4 B-4 B-3 C-2 C-2 C-3 C-3 D-3 RCD-W1 3 2 1 4 5 6 7 BD-R BOARD (SIDE B) A 5 4 1 2 1 3 5 3 1 3 2 2 4 15 1 9 3 4 1 5 8 14 14 8 7 1 21 22 28 76 100 1 75 BCE 1 1 3 16 21 8 22 7 BCE BCE 14 1 BCE 15 15 1 4 5 51 25 26 50 4 1 5 8 28 • Semiconductor Location Ref. No. 28 11 10 AKA C 20 28 15 1 14 40 41 1 5 3 4 SW701 (LOADING/OPEN) 1 21 60 1 61 75 11 22 AKA 12 76 KAK 20 100 1 D M 8 BCE B M701 LOADING MOTOR 1 81 4 5 25 44 23 1 3 33 34 26 50 31 31 D101 D401 D701 D-6 C-3 D-4 IC101 IC103 IC203 IC301 IC302 IC303 IC306 IC307 IC310 IC401 IC404 IC407 IC409 IC412 IC414 IC501 IC510 IC511 IC512 IC701 D-6 A-3 D-3 D-2 C-2 D-2 B-2 B-2 C-2 B-3 B-4 B-3 C-3 B-4 B-4 B-5 B-6 A-4 A-5 D-5 Q401 Q402 Q403 Q404 Q405 B-3 B-3 B-3 B-3 B-3 51 FOR CHECK E Location RCD-W1 5-4.SCHEMATIC DIAGRAM -CD-R SECTION (1/6)- • See page 24 for Waveforms. (3/6) (2/6,3/6,4/6) EFM (2/6,3/6,4/6,5/6) C R455 470 ADTRIG RP C429 0.47 IC411 NJM3404AV R627 0 R428 0 R422 3.3k C607 0.01 C453 0.1 C404 2200p C460 10 16V C462 0.1 C454 10 6.3V R426 33k C434 150p C433 0.1 R429 10k R430 0 R432 47k BUFFER/ DIFFERENTIAL OUT1 R414 10k C476 0.1 R436 1k R424 15k R437 33k C430 0.01 R417 10k D401 KDS121 OUT2 IN1+ IN2IN2+ VEE RIPBC R423 33k C605 220 IC414 NC7SZ66 I/O O/I GND C402 0.033 C606 8p L606 17MCPLD RESAMP2 SWITCH 17MHZ RESMAP2 WFPDSH GND RFPDSH WBLSH SPDSH MPDSH TDI TMS TCK R601 220 VCC R602 220 R603 220 R604 220 R605 220 RFPDSH WBLSH SPDSH MPDSH FLAGC CTL C481 0.1 R418 15k R446 0 C479 3p IN1- OUT2 R487 22k IN1+ IN2- R489 1M L401 SWITCH VCC OPCING CTL C440 0.1 C474 220p R472 22k VWDC2 RPOWER DADATA DACLK /DACS R448 1k PD D PD C PD B PD A VWDCLMT TRAYCT L Q402 DTC144EKA INVERTER R438 22k R411 68k C422 0.1 C469 1000p OUT2 IN2- C414 0.1 VEE TE FE TZC XTOK XTOR XTAND AGCON R406 27k R407 27k C445 3300p Q405 DTC144EKA SWITCH Q404 DTC144EKA SWITCH Q403 DTC144EKA SWITCH R413 1M R404 1k C428 0.1 C443 0.15 C446 0.1 32 C608 0.01 RX IN2+ XTOR C415 10 6.3V C419 0.1 C421 0.1 WBLIN R409 100 C412 0.1 2V ACT (2/6) C420 0.1 C557 0.1 C470 10 6.3V IC514 NJM3414V IC405 BU4052BCFV SELECTOR Q401 DTC144EKA SWITCH Y0 Y2 Y Y3 Y1 INHIB VEE VSS VCC X2 X1 X X0 X3 CTLX CTLY OUT1 BETA ASYM1/BETA ASYM1 BLEVELO WR/RE CDR/R W C558 0.1 C449 0.1 +4V REG VCC IN1- OUT2 IN1+ IN2- VEE IC103 BA3939FP R425 3.3k BUFFER C423 0.1 C426 0.33 ASYM2 OUT R441 330k R610 330 C418 0.1 ASYM2 C427 0.015 C602 0.1 C477 0.1 C413 0.1 C416 10 6.3V C425 0.33 C424 0.33 LDON R266 0 VCC IN1IN1+ R410 68k C468 1 WGATE AND OUT1 C409 0.1 ROPCSH E MPDSH SPDSH WBLSH RFPDSH ERGCNT SLDOFST R476 4.7k PD H PD G PD F PD E R492 0 (2/6) 1 GND AO2 AO1 DO VLK LD ED AO12 AO11 VCC R451 330 C417 0.1 VRDC HAVCOFS TRK SPP VREFAO3 AO4 AO5 AO6 AO7 AO8 AO9 AO10 VREF+ C459 150p RF EQ, FOCUS/TRACKING ERROR DETECT FPDO R474 10k R475 82k R471 10k IC401 CXA2551R FPDVC RPOWER WREF D/A CONVERTER WLDON ERGCNT SCLK SDATA XLAT DVCC DVSS ROPCSH MPDSH SPDSH WBLSH RFPDSH WFPDSH DSPVCC BGIREF VTIREF AVCC VC DVC AVSS VCT1 VCT2 CNT VC CAV CNT WBLIN CDR/RW ROPCON HFSW CDR/RW ROPCON HFSW EFM2 EFM1 HFM ON WGATE VCC GND TDO LDON C609 10 6.3V C603 10 6.3V IC412 TC7W08FU WLDON ERGCNT CXACLK CXADATA /CXACS CEP CEM CEO SWRF WREF APCCSW VWDC1 VWDC2 VWDCN VWDC FVREF RREF VRDCN VRDC AVCC FPDO FPDIN AVSS SMIN SMFB SMOUT AGC3C AGC1C AGC1C ATFM C467 10 6.3V PHO1 BHO2 PHO2 EQRFN EQRFP SRFO EFGH AUX AVCC MPXOUT MSPP RFRPIN AVSS RFRP RFCT RFCTC1 RFCTC2 TEIN 17MCPLD IC409 M62352GP C466 0.1 BHO1 PHC1 BHC1 RZC RECD1 RECD2 BETAOUT PHC2 BHC2 RRFIN RRF AVSS MCLK AVCC WRF MPP HIN GIN FIN EIN HAVC DIN CIN BIN AIN C408 RECD1 220p RECD2 BETA C410 1000p C411 1000p CE BLEVELO WREF I/O O/I GND WR/RE R619 220 R620 220 IN2+ C407 10 6.3V C439 330p WBLOCK ATIP/EFM MONITO R607 330 R608 220 R609 180 C473 100 16V LPLD VCC VEE C401 2200p R268 0 R267 0 C437 0.1 OUT1 R466 1.8k IC407 NC7SZ66 R269 0 R481 R493 R494 R496 R497 R473 C435 1k 0.1 XTOR R401 0 IC601 CST0100C WRSMP WLDON ERGCNT IN2+ VEE R403 0 R467 C432 1k 0.1 R469 1.8k AGCON IN2- IN1+ C478 3p R434 0 FE TX OUT2 IN1- R490 4.7k COMPARATOR R405 100 C480 0.1 C405 0.22 VCC IC404 NJM2903V R488 10k R458 10k ASYM1 ASYM2 OUT1 C475 7p C403 0.1 R449 0 MPXO RF AMP FPDO R445 3.3k C406 0.22 C482 0.01 IC413 EL2245CS 680 680 680 680 680 VWDCLMT R483 1k R611 0 C431 0.1 ODON W/XR ENBL W/XR ENBL C604 10 6.3V VCC IN1- R415 10k OSCEN 32 C601 0.1 EEFS R612 220 R613 220 OUT4 IN4IN4+ VEE IN3+ IN3OUT3 R435 1k W/XR OSCEN ENBL R456 2.2k L402 VRDC VWDC2 VWDC OUT1 IN1IN1+ VCC IN2+ IN2OUT2 R433 47k /RST C463 10 16V C464 0.1 C455 10 6.3V R431 47k 34MCLK EFCK RESMAP1 ROPC1 EFM3 EEFS ADTRIG WBLOCK ATIP/EFM VCC WR/RE C461 0.1 BUFFER /TE AMP R477 0 WRSMP WLDON ERGCNT VCC /RST GND W/XR OSCEN ENBLE ODON MONITO L403 10µH 34MCLK EFCK RESAMP1 ROPC1 R416 10k IC403 NJM3403AV FPDVC FPDO R442 470 R427 47k HAVCOFS PD G PD D PD C PD E R495 1k R420 1k R454 10k IN2+ BS IN2- VEE TEBC IN1+ R453 3.3k PD F PD B PD A PD H (3/6,4/6) (2/6,3/6,4/6,6/6) 4V A5V EFM1 EFM3 EFM2 WLDON TRACKING COIL FCS+ FCSTRK+ TRK- OUT2 47k 27p 680 27p 680 FOCUS COIL VWDC1 VWDC2 FPDO VRDC ODON W/XR IN3OSCEN FPDVC PDVC IN1- R460 C438 R457 C441 R465 PD LD DRIVER/CONTROL LD FCSTRK+ TRKFCS+ C442 47p C458 150p C456 150p A B C D E F G H FCSTRKTRK+ FCS+ FGND PDGND F B A H PDVCC PDVC G D C E NC FPDVC FPDO VCC VCC CFREO CMOD PGND VRDC VWDC2 VWDC1 DGND OSCEN ODON W/XR IN3- C451 0.1 VCC TE BUFFER OUT1 A B C D E F G H (3/6,4/6,5/6) D5V (2/6,3/6) B (3/6) 5V (3/6) 2V A IC406 NJM3414V R452 1.2k CN401 1 • See page 57 for IC Block Diagrams. OUT ADJ C114 100 1.6V IN2+ C471 10 6.3V R419 5.6k C503 0.1 C112 0.1 CNT GND IN C111 1 C447 0.1 GND 32 RCD-W1 5-5.SCHEMATIC DIAGRAM -CD-R SECTION (2/6)- (1/6) 2V ACT • See page 56 for IC Block Diagrams. (1/6,3/6,4/6,5/6) C (3/6) 12V (1/6) (1/6,3/6,4/6,6/6) A5V 1 (1/6,3/6,4/6) A (1/6,3/6) B IC501 BA5983FM IC502 BA5925FA C506 0.01 SLD+ SLD- GND HA+ HAA+ CA+ BIAS IN CB+ B+ HBHB+ IN1+ IN1OUT1 STBY C510 5600p C507 5600p C508 0.01 CN501 C505 0.1 R515 1k C509 0.01 SW IN2 SW IN1 SW OUT SW CNT VHVH+ HB IN VCC VLVLO EDGE OUT2 IN2IN2+ R516 10k R577 22k R519 6.8k R575 22k SLO FAO R517 2.2k R592 R579 470k 22k TAO TRK SPP C542 C539 R578 R518 82k SLDFG SLD OUT TRK+ TRKFCS+ FCS- R520 100k C514 6800p R522 330k SLD MOVE C515 6800p R524 39k R525 470k R581 10 R580 10 R574 10 R576 10 C544 0.1 C543 0.1 C541 0.1 C540 0.1 HALL1 C551 0.047 C552 0.047 R560 0 SLD OUT TRAY MUTE SLDSLD+ TRAYTRAY+ IN GND C534 0.1 R504 C525 0.1 R565 1.8 C538 100 16V C537 0.1 C533 100 16V IC508 BU4053BCFV C504 100 16V C536 1 C531 1 R556 R557 R558 68k 270k 100k C521 0.47 R503 0 AMP GAIN SELECT Y1 Y0 Z1 Z Z0 INHIB VEE VSS C522 2200p IC509 NJM3404AV R569 47k BUFFER VCC Y X X1 X0 CTLX CTLY CTLZ OUT1 R567 R568 180k 100k IN1IN1+ VEE VCC OUT2 IN2IN2+ R570 0 C520 0.47 ADSEL SPNBOOST SPN8/12 0.047 R583 10k +8V REG OUT OUT SLD OUT C550 R564 1.8 R563 1.8 HALL/SLDO HALL1 C549 0.1 R590 10k C524 0.1 FGND FGND RNF VMI GSW VCC FG PS EC ECR FR FG3 SB CNF BR VH 100 100 N502 SPINDLE MOTOR R582 10k C530 0.1 R502 R553 CN502 W V U H+ HU+ HUHV+ HVHW+ HWH- NC A3 NC A2 NC NC A1 GND H1+ H1H2+ H2H3+ H3- R584 6.8k IC512 NJM7808DLA MOTOR DRIVER C548 0.1 TRAYCTL R586 4.7k C523 0.1 SBRK SPNFG REVDET SPNON C501 0.1 C529 10 16V C528 0.1 IC510 BA6664FM R585 10k R508 10k +8V REG IN C546 0.1 FGND FGND PREVCC OPIN4+ OPIN4OPOUT4 OPIN3+ OPIN3OPOUT3 GND STBY2 PWRVCC2 VO3VO3+ VO4VO4+ R587 10k IC511 NJM7808DLA SLDOFST C535 1 C553 0.1 27k ACT MUTE GND R554 100 BIASIN OPIN1+ OPIN1OPOUT1 OPIN2+ OPIN2OPOUT2 GND STBY1 PWRVCC1 VO2VO2+ VO1VO1+ R573 27k WBLOCK R521 39k R523 100k BTL MOTOR DRIVER DMO SLD+ SLDH1+ H1H2+ H2HA+ HA- MOTOR CONTROLLER 0.1 0.1 0.1 M501 SLED MOTOR R572 22k C511 C512 C513 C555 0.01 GND 33 33 RCD-W1 5-6.SCHEMATIC DIAGRAM -CD-R SECTION (3/6)- • See page 24 for Waveforms. • See page 55 for IC Block Diagrams. C235 0.1 C232 0.1 R238 10k C212 0.1 C213 0.1 C214 0.1 C215 0.1 C216 0.1 R221 10k /RST CSB1 CSB3 BUS DA1 BUS DA0 BUS DA2 DIORB DIOWB DA0 DA15 DA13 DA1 DA14 DA3 DA12 DA2 DA11 DA4 DA9 DA5 DA10 DA7 UAD1 UAD0 UAD3 UAD2 UAD6 UAD5 UAD4 /URD UAD7 /PRST 3 DA8 DA6 5 (5/6) (4/6) R227 0 IC203 GM71C18160CT-6 R220 10k R219 10k HDASP HRST CS2FX VDD VSS CS1FX HA0 HA2 VDD HA1 HPDIAG HIRQ IOCS15 DAMCK VSS I/O14 I/O13 I/O12 RDO4 VCC I/O4 VSS I/O11 C110 0.1 RDO11 RDO5 RDO6 RDO7 I/O5 I/O6 I/O10 I/O9 I/O7 NC I/O8 NC RDO10 RDO9 RDO8 NC NC /WE NC /LCAS /UCAS C211 0.1 RWEOB ADDRO9 RRASOB RRASOB RWEOB ADDRO0 ADDRO1 ROEB ADDRO2 ADDRO3 /RAS NC RDO1 VSS VDD XOUT XIN VDD5 C34M AVSS L OUT AVDD FG REVDET TEST1 AVDD R OUT TEST0 SLO AVSS AVSS DMO AVSS A1 A2 A3 A6 A5 A4 ADDRO8 ADDRO7 ADDRO6 ADDRO5 ADDRO4 VSS C242 0.1 5V (1/6) 12V (2/6) RDO15 RDO2 D5V (1/6, 4/6, 5/6) C209 0.1 5VIF (6/6) +3V REG RDO3 RDO4 RDO5 RDO6 RDO7 L103 FB NF RDO14 C208 0.1 C102 0.1 C207 0.1 SPNFG REVDET R259 47k C243 10 6.3V C220 0.1 SLO 5VA AGND M12V C106 220 6.3V C107 0.1 C109 1 16V C101 0.1 C105 100 16V MGND C356 0.1 /FWRST R746 100 FWMD2 FWEN R744 R745 100 100 BTS RXD BTS TXD R747 R748 100 100 PN201 DMO C743 0.1 FWMD2 FWEN RXD TXD DGND 5VD 220 C740 0.01 C3 X7 /OPEN SW R743 10k R742 470 34MCLK RIPBC TAO FAO RP CE BS FE TE TEBC TX RX ROPCSH E EFM3 ROPC1 EFM1 EFM2 WRSMP RESAMP1 RESAMP2 ESFS EEFS EFM EFCK WGATE HFSW C741 0.01 (1/6) SW701 (LOADING/OPEN) R740 470 /LOAD SW R241 220 220 220 R255 R256 R257 220 220 R253 R254 220 220 220 R250 C224 4700p R251 R252 180 15k R234 R240 33k FOR CHECK R741 10k R245 220 R228 1k 5.6k B R236 R235 (1/6,2/6) AUDIO BOARD (1/2) (Page 43) C108 0.1 R229 100 R237 4.7k PN105 5VD DGND L301 FB R104 0 C202 4700p FAO TAO WRSMP RESAMP1 DOUT ADATA ESFS EEFS RD7 SBRK MON ROEB ADDRO9 IC102 RD4 RD5 RD6 C2PO ABCK ALRCK A8 A7 BA033SFP RD2 RD3 CLKOUT LDON NC A0 RDO12 RDO13 RD14 RD15 FLAGC FLAGD RCAS0B RCAS1B /OE A9 A5V (1/6, 2/6, 4/6, 6/6) CTRL VCC MONIT FLAGA FLAGB RDO13 RDO12 RDO8 RDO9 RD13 VSS VDD DSP SERVO C241 0.1 RDO15 RDO14 RDO10 RDO11 RD11 RD12 OT19790 C240 0.1 C210 0.1 GND OUT WBLIN MONITO E1T1P E11TS EFCK C222 0.1 HWR HRD IORDY IC201 VDD VSS C221 10 6.3V RDO2 RDO3 I/O1 I/O2 I/O3 ADDRO7 ADDRO8 RDO0 RCAS0B RCAS1B RD8 EFMNT3 EFMNT4 R231 0UH C113 10 16V VCC RD9 RD10 UA0 ARST# WGATE HFSW R230 100 6 (5/6) ADDRO5 ADDRO6 RCASH# UA3 UA2 UA1 PANICIN EFMNT1 EFMNT2 8 (6/6) ADDRO4 RD1 RD0 RCASL# UA5 UA4 VREF AVSS LRCK BITCK ADDRO2 ADDRO3 VSS I/O15 VDD UA7 UA6 EFMR1 ASY EFM LRCK BITCK HD15 HDRQ RWE# ROE# VSS EFMR3 EFMR2 PCMDATA R239 220 LDON PCMDATA VDD HD0 UA10 UA9 UA8 AVDD AVDD FLAGC HD1 HD14 VSS RAD11 RRAS# VDD VSS FLAGA FLAGB HD2 HD13 HD3 HD12 VDD HD11 HD10 HD4 VSS HD9 HD5 HD8 HD6 VSS VDD HD7 UAD1 UAD0 UA12 UA11 2VREF AVDD WBLIN MONITO RAD9 RAD10 RP CE UA0 UA14 UA13 BS RPBC UA2 UA1 RAD6 RAD7 RAD8 VREF FE C218 0.1 SDINT# UALE UA15 TE AVDD AVSS UA5 UA4 UA3 VDD RAD5 TEBC AVSS UA7 UA6 UNIT0# UNIT1# RX TX TC UA8 RAD4 VSS VDD VSS UINT1 /SDINT VSS URDY ROPC2 ROPC3 URDY UINT0 ADDRO0 ADDRO1 RAD0 RAD1 RAD2 RAD3 RESAMP2 EFM1 C217 0.1 UWR# UCS0# UCS1# VDD EFM2 EFM3 ROPC1 /UCS1 PRST CPUTYPE /UHWR /UCS0 4/6,5/6) UAD4 UAD3 UAD2 C UAD6 UAD5 (1/6,2/6, URD UAD7 RAM VCC I/O0 RDO0 RDO1 A (1/6,2/6,4/6) C225 0.1 (1/6) (1/6,4/6) GND 2V C223 1000p C226 0.1 C227 0.1 C201 0.01 C238 0.1 C204 3300p C206 0.1 CN701 TRAY+ C229 0.1 C239 10 6.3V C228 0.1 4V 34 34 R260 15k L202 10µH TRAY- TRAYLD+ TRAYLD- M701 TRAY LOADING MOTOR RCD-W1 5-7.SCHEMATIC DIAGRAM -CD-R SECTION (4/6)- • See page 24 for Waveforms. • See page 51 for IC Pin Function Description. 4V (1/6, 3/6) (1/6, 2/6, 3/6) A 3 A5V (1/6, 2/6, 3/6, 6/6) R101 27k OUT C103 10 16V 0.047 C710 C709 C713 0.01 0.01 0.047 C714 0.1 AUD MUTE FWE ON FWE VREF(4V) AVCC ASYM2/LVL1 ASYM1/LVL0 BETA/JITTER HALL/SLDOUT MPXO DAC0 ADC5 AVSS /UINT1 /UNIT0 ESFS CSO/P84 ADTRIG OPCING SPNFG SBRK FWE VSS REC CXD HD64F3062 BTS CXD EWC RXD URDY FLAGB FLAGB(RFZC) AS STRT R728 /DACS TRAY MUTE R727 R726 IC702 2.2k 2.2k T HOT RX T HOT YX FS781 C704 0.1 EEP ROM C708 0.1 C707 0.1 RB702 GND 35 35 EPDATA EPCLK RECD2 /LOAD SW RECD1 UA8 /OPEN SW EPCS RB701 UA6 UA7 UA4 UA5 UA2 UA3 UA0 UA1 UAD6 UAD7 UAD4 UAD5 UAD1 UAD2 UAD3 ACT MUTE UAD0 R738 100 R729 10k CS VCC RECD2 TSTMDO /OPEN SW RECD1 HOT RX HOT YX /LOAD SW 10k FLAGA XTOR TSTMD1 XTOR VSS 47 ROPCON AGCON AGCON SRDY VSS VSS /CXACS R711 /RST SDATAI CDR/RW /EPCS 47 47 X701 C705 20MHz 15p C706 15p ROPCON /SDINT SDATO SCLK R709 R710 C716 0.1 /RESET /STBY SYSTEM CONTROL BTS RXD REC CLK C750 10 6.3V EXTAL VSS NMI IC701 UA6 UA7 47 47 /URD VCC UA4 UA5 R706 R708 XTAL UA1 UA2 UA3 TRAY MUTE 47 47 AUD MUTE FWE ON VCC UA0 /CXACS /DACS R704 R707 47 /URD /AS UAD7 EPCS 47 47 R721 ADSEL WR/RE UAD5 UAD6 DACLK EPDATA EPCLK R703 R705 100 100 /UHWR /UHWR UAD3 UAD4 BTS RXD REC CLK /SDINT R719 R720 MD0 1 ULWR ACT UAD0 UAD1 UAD2 REC TXD BTS TXD REC RXD R718 4.7k GND ADSEL WR/RE FWEN R702 470k R715 C702 10k 100p MD2 1 MD1 0 /PRST /UCS1 /UCS0 /UCS1 /UCS0 CDR/RW DADATA SPNON SLDFG VCC ATIP/EFM ATIP/EFM /PRST CXADATA CXACLK SLDMOVE R712 10k (5/6, 6/6) FLAGA(TEZC) VSS 7 SPNBOOST SPN8/12 C751 10 6.3V R701 150 C721 10 6.3V C715 0.1 C701 0.1 FWE DO R102 82k C712 ORG GND (1/6, 2/6, 3/6, 5/6) FWE ON DI IN C D701 KDS121 R716 1k R713 100 FWMD2 ASYM2 OUT MPXO L701 10µH NC RESET HALL/SLDO SLD MOVE UINT0 ESFS ADTRIG UINT1 SPNFG SBRK R714 100 C722 10 6.3V SK R103 10k D101 KDS187 ASYM1/BETA R717 1k XC61AN3002P AS STRT IC101 OPCING (1/6, 3/6, 5/6) /FWRST /RST D5V SPNON SLDFG SPNBOOST SPN8/12 (3/6) RCD-W1 5-8.SCHEMATIC DIAGRAM -CD-R SECTION (5/6)- • See page 24 for Waveforms. D5V (1/6, 3/6, 4/6) C348 1K C347 1K C309 0.1 R325 0.01 R305 82P R336 560 R310 470 R335 470 C311 0.1 C310 0.1 R390 0 R320 10k R322 220 5 C351 220p CLOCK OSC. 3 RA302 220X4 R388 FB 5 2 /RST 4 R386 1M R387 220 X301 33.8688MHz RA303 220X4 C344 18p C345 18p AS STRT CSB3 CSB1 BUS DA2 BUS DA1 BUS DA0 DIORB DIOWB DA15 DA14 DA13 DA12 C (1/6, 2/6, 3/6, 4/6) RA301 220X4 R382 680 R385 0 C325 820 RAM DATA7 RAM DATA6 RAM DATA5 RAM DATA4 RAM DATA3 RAM DATA2 RAM DATA1 RAM DATA0 RAM CSB RAM OEB RAM WEB GND VCC RAM ADDRESS 14 RAM ADDRESS 13 RAM ADDRESS 12 RAM ADDRESS 11 RAM ADDRESS 10 RAM ADDRESS 9 RAM ADDRESS 8 IC301 VC00S01 RECORD CONTROL INVERTER C306 0.1 ADR14 ADR13 ADR12 ADR11 ADR10 ADR9 ADR8 RA304 220X4 RA306 220X4 C320 2.2 16V C321 0.1 IC302 W2457AS-35 RAM ADR14 ADR12 ADR7 ADR6 ADR5 ADR4 ADR3 ADR2 ADR1 ADR0 RD0 RD1 RD2 A14 A12 A7 A6 A5 A4 A3 A2 A1 A0 I/O0 I/O1 I/O2 VSS VCC /WE A13 A8 A9 A11 OE A10 /CS I/O7 I/O6 I/O5 I/O4 I/O3 /WE ADR13 ADR8 ADR9 ADR11 OE ADR10 RAM/CS RD7 RD6 RD5 RD4 RD3 5 (3/6) RA305 220X4 C301 0.1 36 C305 0.1 L302 C350 220p C349 220p (3/6) 6 RESET B P CLK GND VCC CLK IN SRT CSB3 CSB1 BUS DA 2 BUS DA 1 BUS DA 0 DIORB DIOWB CDP33M OUT DATA2 7 OUT DATA2 6 OUT DATA2 5 OUT DATA2 4 OUT DATA2 3 OUT DATA2 2 IC303 TC7S04F RD7 RD6 RD5 RD4 RD3 RD2 RD1 RD0 RAM/CS OE /WE ADR0 ADR1 ADR2 ADR3 ADR4 ADR5 ADR6 ADR7 C303 0.1 C307 0.1 R323 390 CLKSEL 1 CLKSEL 0 VCC GND TESTPP NC TPSING NDOUT ACDELAY DUBSEL GND PCLK OUT RCLK OUT VCC RSDA RSCLK RLRCK PSDA PSCLK PLRCK C304 0.1 OUT DATA2 1 OUT DATA2 0 OUT DATA1 7 OUT DATA1 6 OUT DATA1 5 OUT DATA1 4 OUT DATA1 3 OUT DATA1 2 OUT DATA1 1 OUT DATA1 0 GND VCC RAM ADDRESS 0 RAM ADDRESS 1 RAM ADDRESS 2 RAM ADDRESS 3 RAM ADDRESS 4 RAM ADDRESS 5 RAM ADDRESS 6 RAM ADDRESS 7 C346 0.1 2 4 3 DA11 DA10 DA9 DA8 DA7 DA6 DA5 DA4 DA3 DA2 DA1 DA0 IC310 TC7S04M (4/6, 6/6) CDP 33M MDA DATA MDA CLK MDA LRCK P DATA P CLK P LRCK C308 0.1 DUBBING OMCK SDAC MCK DAC MCK CLKSEL1 CLKSEL0 7 36 C302 0.1 GND RCD-W1 5-9.SCHEMATIC DIAGRAM -CD-R SECTION (6/6)- • See page 24 for Waveforms. • See page 56 for IC Block Diagrams. 7 (4/6, 5/6) PN605 P CLK P BITCK DGND P LRCK AS DUBBING OPT SEL M PBSEL S PBSEL SRC RESET SRC INT SRC DOUT SRC CS SRC DIN SRC CLK DUB SPD0 DUB SBD1 P PCMDT ASIC PGM ASIC DONE ASIC DIN ASIC CLK DGND MCK0 DGND RW TXD REC RXD REC CLK P LRCK DUBBING SRC INT L308 10µH IC306 CS8420 R337 10k C327 0.1 CDP 33M SRC DATA SELECT Y1B Y0B Y1C ZC Y0C E VEE VSS AD DATA C333 0.08 VDD ZB ZA Y1B Y0B SA SB SC C334 8200p R371 4.7k C355 R368 R369 P CLK AD CLK R308 220 C332 0.01 120 100 100 C331 0.01 SRC CLK REC RXD REC TXD REC CLK R375 R376 R377 R378 330 220 220 220 C312 680 SRC INT MDA DATA MDA LRCK MDA CLK C313 47p A BD BOARD (3/3) (Page 42) A5V (1/6, 2/6, 3/6, 4/6) OMCK 100p P LRCK AD LRCK P DATA R307 R306 220 220 C329 0.1 C330 2.2 16V 220 220 220 100p R355 47k IC304 BU4053 R373 R374 R380 SCL/CCLK AD1/CDIN TXP TXN H/S VD+ DGND OMCK U INT SDOUT OLRCK OSCLK TCBL C338 SDA/CDOUT AD0/CS EMPH RXP RXN VA+ AGND FILT RST RMCK RERR ILRCK ISCLK SDIN 100p 220 220 220 C323 0.1 C340 L306 10µH C326 10 16V C339 C322 2.2 16V R366 R365 R364 (3/6) SRC CLK CLKSEL0 CLKSEL1 P DATA 5VIF C314 47p R367 1k R327 10k CN102 GND DAC MCK R370 100 IC307 BU4053 DATA SELECT Y1B Y0B Y1C ZC Y0C E VEE VSS (3/6) 8 37 VDD ZB ZA Y1B Y0B SA SB SC R261 0 R263 0 R264 0 R265 0 R270 0.1U R262 0 AD CLK AD LRCK AD DATA AUD MUTE MDA CLK MDA DATA MDA LRCK SDAC MCK C336 0.1 37 C335 2.2 16V MCLK GND AD CLK AD LRCK AD DATA CDR MUTE MDA CLK MDA DATA MDA LRCK GND SDAC MCK OPT IN NC DIGI IN DGND TXP OUT B AUDIO BOARD (1/2) (Page 43) RCD-W1 5-10.PRINTED WIRING BOARD -CDP SECTION- • See page 23 for Circuit Board location. 1 A 2 3 4 5 13 1 12 7 OPTICAL PICK–UP BLOCK M401 SPINDLE MOTOR BD BOARD (SIDE A) 6 2 17 16 1 10 2 G AUDIO BOARD CN602 (Page 45) 1 B 8 F AUDIO BOARD CN606 (Page 45) 1 9 C E POWER BOARD CN901 (Page 48) 1 10 D D 1 1 2 FL BOARD CN802 (Page 46) A 25 E M301 SLED MOTOR 38 38 26 BD–R BOARD PN605 (Page 30) RCD-W1 3 2 1 4 5 6 BD BOARD (SIDE B) • Semiconductor Location A 5 4 M609 LOADING MOTOR E 8 1 15 1 16 30 22 21 15 1 7 8 14 M 1 4 8 28 5 8 5 4 1 E E B E 3 2 E 1 A 4 K K 1 3 2 42 22 1 21 1 51 75 76 SW001 (LOADING/OPEN) 50 C IC501 100 26 25 1 36 37 1 144 A K K D 6 9 1 8 72 73 109 108 16 E 1 FOR CHECK 39 39 Ref. No. D201 D502 Location D-2 B-2 IC101 IC201 IC301 IC302 IC401 IC402 IC403 IC501 IC502 IC601 IC602 B-3 D-3 C-3 B-2 B-3 A-2 B-3 C-2 B-2 B-4 D-2 Q101 Q102 Q104 Q105 Q401 Q403 A-3 B-2 B-3 B-2 B-3 B-3 RCD-W1 5-11.SCHEMATIC DIAGRAM -CDP SECTION (1/3)- • See page 24 for Waveforms. • See page 59,60 for IC Block Diagrams. 4V R132 6.8k R133 10k C104 10 6.3V R104 15k R105 15k C120 0.1 RFDC R122 33k Q102 DTC144EKA SWITCH R222 3.3k R223 3.3k R227 33k C218 220p RF 1XH R108 180k C117 1 C119 100 6.3V Q105 DTC144EKA SWITCH C220 0.01 C121 1000p R107 120k C107 1 C116 100 6.3V C122 47p R147 0 R113 1k R148 0 C114 0.1 C115 47 16V C219 0.047 R228 10k R229 100k R213 22k P LRCK R230 100 P PCMDT R231 100 P BITCK R232 56 PR BITCK R233 56 C228 68p CE TE FE RW GUP 0.047 10k 150p 3300p C118 3300p C225 68p FAO TAO R201 22k C209 1 FOK R241 100 R242 100 MIRR COUT CXD CLK CXD CS CXD DATA SENS CLK R239 100 SENS C212 1 C224 0.1 C222 22p X201 33.8688MHz C221 22p C229 0.1 GFS C223 0.01 C213 33 R234 470 R235 100 R236 100 NC IN GND CTRL MDP DSP,SERVO R237 0UH +3.8V REG NC FSW TESO FOK DFCT MIRR COUT DVSS4 CLOK XLAT DATA ATSK SCLK SENS DVDD4 AVDD3 NC NC NC NC PWMLN PWMLP AVSS3 AVSS5 XTLI XTLO AVDD5 AVDD4 PWMRP PWMRN AVSS4 DVSS3 LMUTO RMUTO XWO NC IC201 CXD-3011-1R IC601 BA3939FP OUT R422 27k R202 33k R203 10k NC SE FE VC VPCO1 VPCO2 VCTL FILO FILI PCO CLTV AVSS1 RFAC BIAS ASYI ASYO AVDD1 NC NC NC NC DVDD1 DVSS1 ASYE PSSL WDCK LRCK LRCKI DA16 PCMDI DA15 BCKI SOUT SOCK XOLT NC XTSEL R139 2.2k C215 R224 C216 C217 R146 3.9k C226 68p A B C D E F C112 0.1 RF AMP LD DC OFST PD RFDCI RFDCO EQ IN VC AC SUM GND REF A VFC B BST C RFG D VCC E CEI F CE SW TE BAL DVCC TE DVC FEI RFAC FE C227 68p LD MD RF C108 1 C101 0.01 C111 0.1 C205 1 CXD XRST R218 150k R216 33k FE SQSO SQCK C123 470p R131 10k SCOR C210 0.1 R217 68k SUB DOUT CXD MUTE RF 4XL R128 68k IC101 CXA2581N R140 2.2k SPNFG C211 100p NC TE CE RFDC ADIO AVSS2 IGEN AVDD2 V16M VCKI PDO TEST VCOI VCOO DVDD5 PWMI NC NC NC NC TES3 TES2 DTSO DVSS5 SSTP LOCK MDS MDP MON AVDD6 BSSD FAO TAO SAO AVSS6 NC Q101 2SA1037 LD DRIVE C204 1 Q104 DTA144EKA SWITCH R124 10k R106 0 R126 10k C102 100 6.3V R101 15 RF LD OFF TRACKING COIL FCS+ FCSTRK+ TRK- R102 15 F E C B D A LD MD C208 220p L203 0µH NC GTOP XUGF XPLCK GFS RFCK DVDD2 C2PO XRAOF MNT3 MNT2 MNT1 MNT0 DVSS2 XTSL MCKO NC NC NC NC FSTIO C4M C16M DVDD3 MD2 DOUT MUTE WFCK SCOR SBSO EXCK SQSO SQCK SCSY XRST NC PD R208 33k C202 1000p R125 10k MD VR R214 10k C103 1 R127 100k VCC LD FOCUS COIL LOCK TE CE RFDC F+ T+ TFGND VC VCC F E C B D A LD MD VR RF C206 0.1 C214 0.1 C106 0.1 C105 0.1 PN201 VC LD VC C605 100 6.3V C602 0.1 C203 0.1 R601 4.7k CDP 33M 1 2 3 4 RF A B C D E F A B C D E F 5VA R103 22 C201 0.1 GND D 40 40 B RCD-W1 5-12.SCHEMATIC DIAGRAM -CDP SECTION (2/3)- • See page 58 for IC Block Diagrams. (3/3) 5VM C304 220 6.3V IC301 M56788FP MOTOR DRIVER R302 150k R301 56k CH3IN OUT3 IN3VBS2 VM2 NC GND IN3+ VM3VM3+ GND VM4+ VM4VM5+ VM5OUT5 IN5NI5+ IN4+ IN4OUT4 (3/3) 12V C312 100 16V PN301 A M301 SLED MOTOR A B B R305 100k PN609 M609 LOADING MOTOR C301 1 LD+ LDR306 100k R304 3.3k R303 1k C308 C309 1 1 FAO R312 22k R310 22k C302 10 16V 2 1 (1/3) 4 3 TAO R315 27k C310 1200p R313 22k R412 3.3k R411 3.3k ACT MUTE TRAY MUTE C414 0.047 R307 56k SLDPHA B TRAY CTL SLDPHA A R308 150k REG+ REGB IN1+ VBS1 VM1 IN1OUT1 VM1VM1+ GND VM2+ VM2OUT2 GND IN2IN2+ MUTE1 MUTE2 SS.GND VREF VREFO R319 2.2k C311 0.1 R414 3.3k R318 2.2k C303 1 R413 3.3k 4V (1/3, 3/3) L401 IC401 LB11995H C402 0.1 C409 0.1 MOTOR DRIVER PWR GND WOUT NC VC VCREF FC LMC SIG GND NC NC S/S BRAKE FG RS C404 0.1 C405 0.1 R402 47k PN401 U W V SLEDIN SW GND HVHH+ HU+ HUHW+ HWHV+ R538 22k R407 150 C412 0.1 R429 2.2k IC403 NJM2100M Q403 KTD1304 SWITCH VEE R403 100 C406 0.1 C415 0.08 VEE IC402 NJM2100M VCC Q401 KTD1304 SWITCH R418 22k C419 0.068 R405 1k R404 1k C416 0.08 R417 470 DIFF AMP VCC C407 0.1 R415 47k R426 10k R427 2.2k SPN-CTL AMP C408 0.1 R416 47k R424 15k R406 150 R419 39k R423 10k R425 10k C421 0.1 C424 0.1 R430 C423 10 10k 16V R435 68k R431 10k R434 100k R421 10k R536 100 R437 3.3k R436 2.2k R433 2.2k C417 0.1 SLED ERR PWR NMI PWRFAIL KICK LOW MDP SPNREV SPN ON SPNFG GND SLD IN M401 SPINDLE MOTOR C410 100 R408 1 16V R409 1 R410 1 VOUT UOUT VCC2 VCC3 NC RF VCC1 UIN2 UIN1 VIN2 VIN1 WIN2 WIN1 VH R428 1k C411 47 16V SPN 4X C401 0.1 C403 0.1 5VA (1/3, 3/3) VC (1/3) D (1/3, 3/3) 41 41 RCD-W1 5-13.SCHEMATIC DIAGRAM -CDP SECTION (3/3)- • See page 24 for Waveforms. • See page 50 for IC Pin Function Description. 12V 5VA 5VM 9 PWRFAIL C701 0.1 FE PN605 L501 R530 FWEN REC TXD FLD TXD REC RXD FLASH RXD REC CLK FLD CLK R566 470k R563 100k R511 10k R502 R503 R504 R505 R506 R501 100 100 330 330 330 330 R507 100 R508 100 R509 100 R510 100 ASIC PGM ASIC DONE L/R SEL R512 330 TRAY CTL TRAY IN FOK R513 330 GND PN603 AUD LVL AUD LVL KEY IN2 KEY IN1 KEY IN0 SCOR REMO IN PWR CTL SRC INT 0 0 330 330 330 330 DUB SEL C710 0.01 C711 0.01 CDR EMPH SUB MUTE DUB SEL P LRCK P PCMDT P BITCK DUB SEL CDP LRCK CDP DATA CDP BCK DGND CDP DOUT CDR EMPH CDR MUTE REMO IN EXT RMC R556 DUBBING OPT SEL M PBSEL S PBSEL C501 15p X501 20MHz SUB DOUT CDR EMPH SUB MUTE REMO IN R RMC C505 0.1 C502 15p PWR NMI R524 470 R546 330 R545 330 R544 100 R543 R542 R541 R540 R539 IC502 XC61AN3002 TRAY OUT MAIN MUTE SUB MUTE CDR EMPH 330 470 470 10k 10k R525 27k R523 10k RF 1XH RF 4XL R RMC D502 KDS187 RESET IN OUT CE/FE SW RW GUP GND C509 0.1 C512 0.1 C513 0.1 R547 100 R537 100 R535 330 R522 3.3k R533 3.3k R521 1k SQCK SQSO CXD MUTE XTSEL GFS LOCK R534 R532 10k SPN ON SPN 4X KICK LOW SLD IN DUB SEL CDP/CDR EMPH /PD 1k 1k 1k 1k R514 R515 R516 R517 R527 10k R518 330 R519 330 R520 1k CXD XRST SPNREV FOR CHECK REMO IN PN604 100 100 100 100 SYSTEM CONTROL IC501 R555 R554 R552 R550 R549 R548 R316 22k C510 1 R526 82k IC602 BU4053 ASIC CLK RW CLK ASIC DIN REC TXD RW TXD R317 22k R311 100 TRAY OUT TRAY IN Y1B Y0B Y1C ZC Y0C E VEE VSS R314 100 SW001 (LOADING/OPEN) ASIC CONF REC CLK R610 0 R611 0 42 42 B PN602 LEVEL METER L/R SEL POWER DOWN P OUT SEL CD/CDR LVL CD/CDR EMPH GND CD/CDR MUTE PN606 C709 0.01 SELECTOR KEY IN2 KEY IN1 KEY IN0 R602 R603 R604 R605 8 100p 100p 100p 100p R567 100 R568 100 C712 C713 C714 C715 SRC CLK SRC DIN FLD TXD FLD CLK FLD BLK FLD CS /PD CDP/CDR DATA CDP/CDR LVL CDP/CDR EMPH FWMD2 4.7k MD2 MD1 MD0 AS DUBBING OPT SEL MPB SEL SPB SEL VCC XTAL EXTAL VSS NMI /RESET /STBY TRAY OUT SW CD/CDR MUTE CD MUTE SUB EMPH VSS CE/FE SEL RW GUP AGC ON MODE1 MODE2 APCON H8/3062 CXD CLK CXD DATA SENS CLK CXD CS SENS ACT MUTE TRAY MUTE R564 100k SRC DOUT SRC CS FLD CS FLD BLK DUB SPD0 DUB SPD1 ASIC CONF VCC SRC OUT SRC CS FLD CS FLD BLK AES SEL0 AES SEL1 ASIC CONF FWE ON FWE VSS REC TXD DIG TXD REC RXD FLASH RXD REC CLK DIG CLK CDP ONLY AS PGM AS DONE LVL SW VSS TRAY CTL TRAY IN FOK CXD CLK CXD DATA SENS CLK CXD CS SENS ACTUATOR TRAY MUTE CXD XRST SPNREV VCC SQCK SQSO CXD MUTE XT SEL GFS LOCK DUB SPD TEST SPIN ON VSS SPL 8CM KICK LOW SLEDIN SW DUB SEL MAIN EMPH PWR DOWN C511 0.1 C207 100p 0.01 0.01 0.01 0.01 R606 1 AUD LVL 100 R607 100 L/R SEL /PD CDP/CDR DATA CDP/CDR LVL CDP/CDR EMPH C504 100 6.3V C514 0.01 R609 10k ATSK LD ON SRC RESET SUBOUT SEL AUDIO LEVEL SPNFG MIRR COUT VSS PWR CTL SRC INT REMO IN REAR REMO IN SCOR AVSS SLDPHA B SLDPHA A SLD ERR VC/FE AUD LVL KEY IN2 KEY IN1 KEY IN0 VREF AVCC R608 RW TXD REC RXD RW CLK FWMD2 FWEN FLASH RXD FLD TXD C705 C706 C707 C708 C507 100 6.3V PN601 PWR FAIL A+5V AGND 5VM DGND M12V 5VD MGND PWR CTL 1 MAIN MUTE R565 150 FWMD2 FWEN RXD TXD DGND 5VD C508 0.1 C506 0.1 CDP 33M PWR CTL FLD TXD FLD CLK FLD BLK FLD CS R558 100 SLDPHA B R557 100 SLDPHA A SLED ERR CE/FE SELECT R561 330 IC302 TC4W53FU LD OFF SRC RESET CDP/CDR DATA CDP/CDR LVL SPNFG MIRR COUT A VSS CH1/H C729 100p C725 100p C726 100p C306 0.1 VEE SRC CLK DUB SPD0 DUB SPD1 PWR CTL C704 0.01 VCC DUBBING OPT SEL M PBSEL S PBSEL SRC RESET SRC INT SRC DOUT SRC CS CH0/L 0.01 0.01 0.01 0.01 0.01 100p 100p 100p C719 C720 C721 C722 C723 C727 C728 C724 INH P LRCK DUBBING OPT SEL M PBSEL S PBSEL SRC RESET SRC INT SRC DOUT SRC CS SRC DIN SRC CLK DUB SPD0 DUB SPD1 P PCMDT ASIC PGM ASIC DONE ASIC DIN ASIC CLK D201 KDS121 PWR CTL FLD TXD FLD CLK FLD BLK FLD CS REMO IN DGND KEY IN2 KEY IN1 KEY IN0 C703 0.1 C730 0.1 R562 4.7k R531 0 PR BITCK COM P BITCK DGND P LRCK AS DUBBING OPT SEL M PBSEL S PBSEL SRC RESET SRC INT SRC DOUT SRC CS SRC DIN SRC CLK DUB SPD0 DUB SPD1 P PCMDT ASIC PGM ASIC DONE ASIC DIN ASIC CLK DGND MCK0 DGND RW TXD REC RXD REC CLK C702 0.1 CE/FE SW CE 4V D VDD ZB ZA Y1A Y0A SA SB SC C604 0.1 RCD-W1 5-14.SCHEMATIC DIAGRAM -AUDIO SECTION (1/2)- • See page 60 for IC Block Diagrams. 19 CDRMUTE OPT IN CD/CDR LVL PN105 MCLK GND AD CLK AD LRCK AD DATA CDR MUTE MDA CLK MDA DATA MDA LRCK GND SDAC MCK OPT IN NC DIGI IN DGND TXP OUT BD-R BOARD (6/6) (Page 37) POWER MUTE 15V DRV 3.3V -12V +5V +12V MCLK R101 47 R102 47 AD CLK AD LRCK AD DATA R103 47 CDR CLK CDR DATA CDR LRCK Q202 KRC3198 SWITCH R204 1k CDR DOUT C205 47 10V C206 0.1 R205 3.9k D/A CONVERTER C213 3300p DVSS DVDD MCLK CN301 S MCK XRST BCK DATA LRCK V-12 GND V+12 15V DRV 5VD DGND 5VA AGND M12V MGND POWER BOARD (Page 49) BD-R BOARD (3/6) (Page 34) R206 10k 5VD DGND 5VA AGND M12V MGND C204 47 35V R111 330 C209 470 6.3V C223 100 10V XRST CDP/CDR DEMP C210 100 10V R209 1.2k R219 1.5k CDR DEMP CDP DOUT R238 1k R239 1k R211 C225 1k 820p C221 R212 3300p 1k C227 820p C202 100 16V OUTA INAINA+ V- INB- R216 1.2k C145 0.1 R222 1k C134 0.1 C212 100 16V C222 3300p INB+ C207 0.1 C106 47 35V C203 R214 820p 1k C218 820p C120 47 35V C119 0.1 A/D CONVERTER C104 1000p C105 0.1 R213 1.5k OUTB R118 10k V+ INA- OUTB INA+ INB- C124 100p R126 3.3k INB+ V- C103 4.7 50V V+ C118 100p C115 22 50V R106 330 R107 330 C224 100 10V R215 1.2k R210 1.5k R115 47k L C126 0.1 C127 47 35V R128 2.7k R120 4.7k C245 0.1 C211 100 10V R208 1.2k IC102 NJM4565 AMP IC112 AK5351 IC104 NJM5532M Q401 KTC3198 AMP R114 47k R113 47k R112 47k R105 330 R201 10k LEVEL METER L/R SEL POWER DOWN P OUT SEL CD/CDR LVL CD/CDR EMPH GND CD/CDR MUTE POWER MUTE EXT RMC R OUT SEL CDR EMPH CDP DOUT DGND CDP BCK CDP DATA CDP LRCK DUB SEL R124 10k OUTA C102 1000p Q402 KTC3198 AMP C117 22 50V C116 22 50V CKS2 CKS1 CKS0 P/ S VCOM AOUTL+ AOUTLAOUTR+ AOUTRAVSS AVDD VREFH VREFL BVSS PD BICK SDATA LRCK SMUTE/ CS DFS DEM0/CCLK DEM1/CDTI DIF0 DIF1 DIF2 R203 4.7k PN502 NOT USED R202 1k CDP/CDR DEMP CN105 C114 22 50V IC105 AK4393 S MCK R217 1.5k R132 22k AINR+ AINRVREF VA AGND AINL+ AINLTST1 HPFE TST2 TST3 VD IC103 NJM4565 R125 10k VB SMODE1 CMODE SDATA FSYNC LRCK SCLK MCLK /PD SMODE2 TST4 DGND AD DATA AD LRCK AD CLK MCLK R134 22k C108 0.1 C121 100p C109 0.01 R119 10k R104 470 R451 10k C101 47 35V AMP OUTA INA- OUTB INA+ INB- V- C123 47 16V AUDIO BOARD (2/2) V+ C125 100p R127 3.3k INB+ R C128 0.1 C122 0.1 R121 4.7k R129 2.7k C129 47 16V GND C208 0.1 C231 C220 22 22 50V 50V R236 470 R237 470 MCLK CD L CD R AOUTL+ AOUTLDUB SEL P BITCK P PCMDT P LRCK CN606 8 CN602 BD BOARD (3/3) (Page 42) POWER MUTE EXT RMC R OUT SEL CDR EMPH CDP DOUT DGND CDP BCK CDP DATA CDP LRCK DUB SEL CDR DEMP CDP DOUT P BITCK P PCMDT P LRCK C138 0.1 R401 1k PLAYBACK SIGNAL SELECT LEVEL MEMER SELECTOR Y1B Y0B Y1C ZC Y0C E VEE VSS IC109 BU4053BCFV Y1B Y0B Y1C ZC Y0C E VEE VSS VDD ZB ZA Y1A Y0A SA SB SC IC108 BU4053BCFV R417 1k C229 0.1 C110 0.1 C141 0.1 DIGITAL CUT SELECT Y1B Y0B Y1C ZC Y0C E VEE VSS VDD ZB ZA Y1A Y0A SA SB SC VDD ZB ZA Y1A Y0A SA SB SC D OUT C248 100p OPT OUT XRST CDP/CDR DEMP IC110 BU4053BCFV P BITCK CDR CLK BCK LRCK XRST CDP DOUT CDR DOUT 1 CDR LRCK P LRCK CDR DATA DATA P PCMDT BD BOARD (3/3) (Page 42) LEVEL METER L/R SEL POWER DOWN P OUT SEL CD/CDR LVL CD/CDR EMPH GND CD/CDR MUTE C214 100p C249 0.1 43 43 RCD-W1 5-15.SCHEMATIC DIAGRAM -AUDIO SECTION (2/2)- • See page 60 for IC Block Diagrams. PN501 RIN GND ROUT LIN GND LOUT R L C131 22 50V R433 18k Q405 A103 RELAY DRIVE LY402 LK101 L103 R431 18k R117 0 CDR IN R CDR OUT R R116 10k C130 220p L104 C429 C133 220p 22 50V R432 3.3k R434 3.3k VOL BOARD (Page 47) DUB SEL GND OPT IN CD OUT R ANALOG CDR IN L CDR OUT L CD OUT L +12V +5V 3.3V R402 10k R223 1k IC401 AK4393 C405 47 10V R224 1k MCLK D/A CONVERTER C404 0.1 19 DVSS DVDD MCLK PD BICK SDATA LRCK SMUTE/CS DFS DEM0/CCLK DEM1/CDTI DIF0 DIF1 DIF2 XRST CDR CLK CDR DATA CDR LRCK CDRMUTE CDR DEMP R249 4.7k CKS2 CKS1 CKS0 P/ S VCOM AOUTL+ AOUTLAOUTR+ AOUTRAVSS AVDD VREFH VREFL BVSS C402 0.1 Q404 D1302 R425 1k Q403 D1302 C406 470 6.3V AOUTL+ Q411 KTC3198 AMP C407 0.1 IC404 NJM5532M OUTA R413 C416 1k 820p C415 3300p R408 1k -12V C412 100 16V R407 1.5k C408 100 10V C409 100 10V R415 1.2k R416 1.2k R429 470 R414 1.5k R405 1.2k R430 470 C425 22 50V R406 1.2k C413 100 10V AOUTL- R424 1k Q403,404 MUTE C414 100 10V Q410 KTC3198 AMP Q207,208 MUTE Q208 D1302 C401 47 35V C426 22 50V AUDIO BOARD (1/2) C237 0.0039 100V C236 0.0039 100V R403 10k R404 10k C132 220p C430 220p Q207 D1302 V+ INA- OUTB INA+ INB- R427 22k C427 0.0039 C419 820p C417 820p C136 0.1 C228 0.1 C424 R421 820p 1k R422 C418 1k 3300p INB+ V- PN401 HP R OUT GND HP L OUT R420 1.5k R419 1.5k R428 22k IC106 74HCU04 C428 0.0039 C411 100 16V INVERTER R264 22 VCC CD L CD R R138 3.3k C135 0.1 R147 3.3k IC406 NJM4560 R477 22 OUTA INAR478 390 INA+ V- C473 0.1 C472 100 16V R225 15k R482 R481 R479 R480 PHONES AMP V+ OUTB INB- R475 390 INB+ R218 15k C474 0.1 C471 100 16V R231 8.2k PHONES OUT SELECT Y1B Y0B Y1C ZC Y0C E VEE VSS VDD ZB ZA Y1A Y0A SA SB SC C142 0.1 R230 8.2k 330 330 330 330 R476 22 R266 C137 2.2k 0.1 R143 22 R145 3.3k IC111 BU4053BCFV R144 22 Q105 A103 C476 0.1 C217 220 25V R256 3.3k Q204-206 MUTE SWITCH R229 4.7k Q206 KTC3198 R146 3.3k R228 1k VEE Q204 D1302 CD/CDR LVL D OUT OPT OUT 15V DRV POWER MUTE 44 C140 0.1 C139 0.1 R137 1k JK104 OPTICAL CDR OUT R141 3.3k R226 2.7k R133 4.7k JK105 OPTICAL CDR IN 44 C247 100p R142 100 C252 47p R135 22 R136 22 R140 1k C143 0.1 C144 0.1 JK103 OPTICAL CD OUT HP BOARD (Page 47) RCD-W1 5-16.PRINTED WIRING BOARD -AUDIO SECTION- • See page 23 for Circuit Board location. 3 2 1 4 5 AUDIO BOARD (SIDE A) 6 8 7 AUDIO BOARD (SIDE B) A 5 E C B 4 1 5 5 8 Ref. No. 1 8 4 • Semiconductor Location 24 1 13 12 B CDR OUT IN 6 I VOL BOARD CN805 (Page 46) CD OUT R ECB L ECB Location IC102 IC103 IC104 IC105 IC106 IC108 IC109 IC110 IC111 IC112 IC401 IC404 IC406 A-2 A-2 F-2 F-3 E-1 D-2 E-3 E-3 D-2 B-3 C-2 C-2 E-2 JK103 JK104 JK105 E-7 E-7 D-7 Q202 Q204 Q205 Q206 Q207 Q208 Q401 Q402 Q403 Q404 Q405 Q410 Q411 F-5 F-6 F-6 F-7 E-6 E-6 E-6 E-6 C-6 B-6 A-7 B-6 C-6 14 4 1 5 8 15 28 ECB 1 C J ECB HP BOARD CN802 (Page 46) B BD–R BOARD CN102 (Page 30) D 16 9 9 16 1 8 1 4 8 1 IN 16 3 CDR C 8 1 16 9 5 9 E 9 1 8 8 16 BD–R BOARD PN105 (Page 30) 1 6 ECB E C B 1 14 OUT 3 DIGITAL OPTICAL ECB E C B 1 3 8 15 7 F 4 1 5 8 28 14 1 F BD BOARD PN602 (Page 38) G BD BOARD PN606 (Page 38) 8 Q205 E C B E C B E C B ECB H G POWER BOARD PN201 (Page 48) 45 45 CD OUT RCD-W1 5-17.PRINTED WIRING BOARD -PANEL SECTION- • See page 23 for Circuit Board location. 3 2 1 4 K A 5 6 POWER BOARD PN201 (Page 48) D 8 7 9 BD BOARD PN603 (Page 38) FL BOARD 21 1 2 3 87 1 3 B > Z > > AMS > AMS HIGH N X NORMAL CD SYNCHRO C x HP BOARD VOL BOARD I D AUDIO BOARD PN501 (Page 45) PN803 1 2 1 JK802 PHONES 6 8 7 OPEN/CLOSE Z J z 1 3 VR801 PHONE LEVEL AUDIO BOARD PN401 (Page 45) B E X 1 L VR802 REC LEVEL POWER BOARD PN901 (Page 48) x F 46 46 2 RCD-W1 5-18.SCHEMATIC DIAGRAM -PANEL SECTION- • See page 24 for Waveforms. • See page 53 for IC Pin Function Description. FLD801 FLUORESCENT INDICATOR TUBE G1 G2 G3 G4 G5 G6 G7 G8 G9 G10 G11 G12 G13 G14 G15 G16 P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 P16 P17 P18 P19 P20 RMC801 RPM6938 C804 100 16V R833 100 CN801 C802 0.1 G1 G2 G3 G4 G5 G6 G7 G8 G9 G10 G11 G12 G13 G14 G15 G16 P1 P2 P3 P4 C813 100p FLD TXD FLD CLK C812 100p C801 0.1 C826 0.1 F+ FGND34V -34V GND 5VU GND NC C810 0.1 CN802 C811 100p NC FLD TXD FLD CLK RESET FLD CS RMC IN GND KEY IN0 KEY IN1 KEY IN2 FLD CS C818 0.1 VDD1 VSS1 X1 X2 IC RESET SCK1 S11 S01 BUSY P23 P22 P21 P20 P00 P01 P02 X801 5MHz FLD CLK FLD TXD C817 33p R845 1k R844 1k R843 1k R841 4.7k R834 3.3k R842 1k FLD CS IC802 KIA7042P C822 0.1 VLOAD VDD2 F20 F21 F22 F23 F24 F25 F26 F27 F28 F29 F30 F31 F32 F33 F34 F35 F36 F37 IC801 uPD78023GC-LG1 FL DRIVE AVSS AN14 AN13 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 P16 P17 P18 P19 P20 C823 0.1 C805 0.022 C806 0.022 C807 0.022 SW803 AMS R803 3.3k R804 3.9k SW804 AMS AN12 AN11 VSSO ACDD VDDO P64 P63 P62 P61 P60 P57 P56 P55 P54 P53 P52 P51 P50 P47 P46 SW805 R849 47k R851 47k R848 47k 8 5 1 CN803 OPEN/CLOSE VR802 20K/20K CN805 R806 8.2k SW802 SW807 C821 0.1 8 SW806 R847 47k C820 0.1 5 SW801 R805 5.6k R850 47k 1 PN803 RESET R IN GND R OUT L OUT GND L IN R801 1.8k R802 2.7k REC L802 R820 18k R812 8.2k SW815 SW816 SW817 REC LEVEL R822 18k R813 1.8k R814 2.7k R815 3.3k R816 3.9k SW818 R817 5.6k SW819 R811 5.6k R810 3.9k R808 2.7k R809 3.3k R807 1.8k R821 18k R8 H1 BD802 OPEN/CLOSE PHONE LEVEL SW808 TIME SW810 AMS SW811 AMS SW812 RELAY SW813 BD801 SW814 R818 8.2k SW820 SW821 SW822 R819 15k BD BOARD (3/3) (Page 42) F0 F1 F2 F3 F4 F5 F6 F7 F8 F9 F10 F11 F12 F13 F14 F15 F16 F17 F18 F19 L801 100µH C816 33p POWER BOARD (Page 49) VR801 50K/50K JK802 PHONES TIME FINALIZE ERASE CD SYNCHRO NORMAL MIN CD SYNCHRO HIGH INPUT 47 MAX 47 BD803 CN804 HP L GND HP R AUDIO BOARD (2/2) (Page 44) R8 H2 PW801 POWER PN902 POWERPOWER+ POWER BOARD (Page 49) AUDIO BOARD (2/2) (Page 44) RCD-W1 5-19.PRINTED WIRING BOARD -POWER SECTION- • See page 23 for Circuit Board location. 3 2 1 L A POWER BOARD 4 5 HP BOARD PN901 (Page 46) E 6 BD BOARD PN601 (Page 38) K 7 FL BOARD CN801 (Page 46) BCE E C B ECB B ECB + AC IN BCE 3 1 – 1 3 5 1 3 2 4 H AUDIO BOARD CN301 (Page 45) ECB C • Semiconductor Location Ref. No. C E A K K A G D 48 48 1 4 BCE Location BD901 B-2 D901 D902 D906 D907 D908 D909 D910 D920 C-3 C-3 C-4 B-4 C-4 C-4 C-4 B-4 IC901 IC902 IC904 IC905 IC906 IC907 C-3 C-4 C-4 D-5 B-6 C-6 Q901 Q902 Q904 Q907 Q908 Q910 Q911 B-6 B-5 B-5 C-6 C-6 B-4 A-4 ZD901 A-5 RCD-W1 5-20.SCHEMATIC DIAGRAM -POWER SECTION- BD901 S1WB60 T901 POWER TRANSFORMER R901 2.7 2W C903 *1 *1 C903 150 250V :US,CND 100 400V :E,MX D920 EU01W L917 C905 0.01 630V R904 56k R943 3.3k C906 100p 1000V D901 EG01CW R941 10k C915 220 10V Q911 D1302 SWITCH R942 10k Q904 C103 SWITCH Q910 D1302 SWITCH ZD901 5.1V L908 22µH D907 EU01W SWITCHING REGURATOR C921 47 50V BC901 0UH L905 22µH D908 EU01W IC901 STR-G6153 C902 0.1 250V L901 D910 EU01W R911 0.35 2W C909 0.047 C901 0.1 V901 C904 0.022 HP BOARD (Page 47) C926 47 50V C931 47 50V C927 47 50V L909 22µH D902 EU01W 9 IC906 KA7912 C935 10 25V -12V REG IC907 KA7812 5 +12V REG 1 C923 1000 16V C924 1000 16V D909 B10A45V1 C916 1000 16V D906 RU3YXLF C917 47 50V L903 20µH L904 20µH L910 22µH C925 330 10V IC905 KA78R12 F901 T1.6A 250V R924 330 R927 3.6k R926 1k R925 2.2k PW901 3 C929 100 16V C928 0.047 C936 100 16V C932 100 16V Q907 KSB1151 R931 120 C934 100 16V PHOTO ISOLATION 8 Q901 KTC3198 R928 3.3k SCHATTKY 49 49 R919 4.7k R922 120 R923 4.7k Q908 KTC3198 C914 0.0047 C937 2200 6.3V PN904 C933 330 10V 2 IC904 KA431 AUDIO BOARD (1/2) (Page 43) L911 22µH R921 1.2k 1 PN201 -15V(-12V) GND V+12V +15V 5VD(CDR) DGND 5VA AGND M12V MGND R903 2.7 R930 4.7k 12V REG IC902 LTV817 4 Q902 KSB1151 R933 1.2k C918 100 16V C913 0.0047 BD BOARD (3/3) (Page 42) R912 3.9 C907 AC IN PWR FAIL A+5V AGND 5VM DGND M12V 5VD MGND PWR CTL C938 10 25V D911 RL104 R900 1.5M PN901 CN901 C919 47 50V R902 100k 2W C900 47 50V C930 47 50V R905 82k R920 47k R929 47k 1 F+ F-34VGND -34V GND 5VU GND NC FL BOARD (Page 47) RCD-W1 5-21. IC PIN FUNCTION DISCRIPTION • IC501 HD64F3062AFBL-CD (SYSTEM CONTROL) (BD Board) Pin No. 1 Pin Name Pin No. 51 Pin Name APCON I/O O Audio out mute signal output 52 MODE2 O PreAmp control2 output Description VCC I/O I 2 SRC_OUT I/O 3 SRC_CS O CS8420 chip select signal output 53 MODE1 O PreAmp control1 output 4 FLD_CS O FLD chip select signal output 54 AGC_ON O PreAmp AGC on control (Not used) 5 FLD_BLK O FLD blanking select signal output 55 RW_GUP O LD power select (CD-R/CDRW) signal output 6 AES_SEL0 O Mode sel0 to ASIC (VC00S01) 56 CE/FE_SEL O CE/FE select signal output 7 AES_SEL1 O Mode sel1 to ASIC (VC00S01) 57 VSS — Ground 8 ASIC_CONF O ASIC config complete 58 SUB_EMPH O Sub emph signal output Description +5V Serial data to CS8420 9 FW_ON O Fresh memory write enable check 59 CD_MUTE O CD mute signal output 10 FWE I Flash write enable 60 CD/CDR_MUTE O CD/CDR mute signal output 11 VSS — Ground 61 TRAY_OUT_SW I Tray out switch signal input 12 REC_TXD O Serial communication with CDRW data out/ASIC config 62 /STBY I Not used (connected to VCC) 13 DIG_TXD O FLD data out/flash write 63 /RESET I Reset input 14 REC_RXD I Serial commnication with CDRW data in/ASIC config 64 NMI I Non maskable interrupt 15 FLASH_RXD I Receive data from FLD/Flash read 65 VSS — Ground 16 REC_CLK O Serial commnication with CDRW CLK out/ASIC config 66 EXTAL I Connected to the crystal oscillator (20MHz) 17 DIG_CLK O FLD clock output 67 XTAL O Connected to the crystal oscillator (20MHz) 18 CDP_ONLY I Mode select input 68 VCC I Power supply 19 AS_PGM O ASIC program signal (Not used) 69 SPB_SEL O EXT input/CDP data select signal output 20 AS_DONE I ASIC done signal (Not used) 70 MPB_SEL O EXT input/CDR data select signal output 21 LVL_SW O Level meter L/R select signal output 71 OPT_SEL O OPT SELECT signal output 22 VSS — Ground 72 AS_DUBBING O Dubbing select signal output 23 TRAY_CTL O Tray control signal output 73 MD0 I Micom mode select input 24 TRAY_IN I Tray in switch input 74 MD1 I Micom mode select input 25 FOK I FOK singnal input from CXD3011 75 MD2 I Micom mode select input 26 CXD_CLK O Serial clock to CXD3011 76 AVCC I Power supply 27 CXD_DATA I/O Serial data to CXD3011 77 VREF I VREF input (+4V) 28 SENS_CLK O Sequencer clock 78 KEY_IN0 I Key input 0 (A/D pore) 29 CXD_CS O Chip select to CXD3011 79 KEY_IN1 I Key input 1 (A/D pore) 30 SENS O Sequencer data output 80 KEY_IN2 I Key input 2 (A/D pore) 31 ACTUATOR O Actuator mute 81 AUD_LVL I Audio level for level meter 32 TRAY_MUTE O Tray mute 82 VC/FE I VC (CE) /FE input 33 CXD_XRST O Resee signal to CXD3011 83 SLD_ERR I Sled error for sled control 34 SPNREV O Spindle RS signal output 84 SLDPHA_A O DAC output for sled control A 35 VCC I Power supply 85 SLDPHA_B O DAC output for sled control B 36 SQCK O Sub Q signal clock output 86 AVSS — Ground 37 SQSO I Sub Q code signal input 87 SCOR I Sub code signal input 38 CXD_MUTE O Mute signal to CXD3011 88 REMO_IN I Remocon data receive signal input 39 XT_SEL O Crystal selection to CXD3011 89 REMO_IN_REAR I Not used (open) 40 GFS I GFS signal input from CXD3011 90 SRC_INT I Interrupt signal input from CS8420 41 LOCK I Spindle lock signal from CXD3011 91 PWR_CTL O Power control signal output 42 DUB_SPD_TEST I Mode select input 92 VSS — Ground 43 SPIN_ON O Spindle on signal output 93 COUT I COUT signal input from CXD3011 44 VSS — Ground 94 MIRR I MIRR signal input from CXD3011 45 SPL_8CM O Spindle 8cm/12cm select signal output 95 SPNFG I Spindle FG signal input 46 KICK_LOW O Spindle speed control signal output 96 AUDIO_LEVEL O CD/CDR select signal output 47 SLEDIN_SW I Sled In switch signal input 97 SUBOUT_SEL O CD/CDR select signal output 48 DUB_SEL O Dubbing select signal output 98 SRC_RESET O Reset signal output to CS8420 49 MAIN_EMHP O Main emph signal output 99 LD_ON O Laser on signal output 50 PWR_DOWN O Power down control output 100 ATSK I Mode select input 50 50 RCD-W1 • IC701 HD64F3062AFBL-CDR (SYSTEM CONTROL) (BD-R Board) Pin No. 1 VCC Pin Name I/O I Power supply 2 ATIP/EFM# O ATIP/EFM signal output to XC9536 3 /PRST O Preset signal output to OTI-9790 4 /UCS1 O Mode set signal output to OTI-9790 5 /UCS0 O Mode set signal output to OTI-9790 6 ADSEL O Hall or sled out AD signal selector signal output 7 WR/RE# O Read or write (CPLD) select signal output 8 AUD_MUTE O Audio mute 9 FWE_ON O Flash write enable check Flash memory write enable Description 10 FWE I 11 VSS — Ground 12 REC_TXD O Serial data output to CDP 13 BTS_TXD O Flash write data output 14 REC_RXD I Serial data input from CDP 15 BTS_RXD I Receive data from flash read 16 REC_CLK O Clock output to CDP 17 /SDINT I Servo interrupt input 18 SDATAO O Serial data output to CXA2551R 19 SCLK O Serial clock to CXA2551R 20 CDR/PW# O CDR/CDRW select signal output 21 /EPCS O EPROM chip selector signal output 22 VSS — Ground 23 /CXALS O CXA2551R chip select signal output 24 /DACS O DAC chip select signal output 25 TRAY_MUTE O Tray mute signal output 26 ACT_MUTE O Actuator mute signal output 27 UAD0 I/O Data BUS 28 UAD1 I/O Data BUS 29 UAD2 I/O Data BUS 30 UAD3 I/O Data BUS 31 UAD4 I/O Data BUS 32 UAD5 I/O Data BUS 33 UAD6 I/O Data BUS 34 UAD7 I/O Data BUS 35 VCC I Power supply 36 UA0 O Address BUS 37 UA1 O Address BUS 38 UA2 O Address BUS 39 UA3 O Address BUS 40 UA4 O Address BUS 41 UA5 O Address BUS 42 UA6 O Address BUS 43 UA7 O Address BUS 44 VSS — Ground 45 UA8 O Address BUS 46 /LOAD_SW I OPEN switch signal input 47 /OPEN_SW I LOAD switch signal input 48 RECD1 I RECD1 signal input from CXA2551R 49 RECD2 I RECD2 signal input from CXA2551R 50 TSTMDO I Not used 51 RCD-W1 Pin No. 51 I/O O Not used HOT_RX I Not used 53 XTOR I XTOR signal input from CXA2551R 54 TSTMD1 I Servo flag input 55 AS_STRT I Test mode 1 (Not used) 56 FLAGB(RFZC) I Servo flag input 57 VSS 58 SRDY I OAK data ready 59 AGCON O AGC on signal output to CXA2551R 60 ROPCON O ROPC related CPLD signal output 61 SDATAI I Serial data input from EEPROM 62 /STBY I Not used (connected to VCC) 63 /RESET I Reset signal input 64 NMI I Non maskable interrupt (connected to ground ) 65 VSS — 66 EXTAL I Crystal oscillator input (20MHz) 67 XTAL O Crystal oscillator output (20MHz) 68 VCC O Power supply 69 /AS O Not used 70 /URD O µ-COM data read signal output 71 /UHWR O µ-COM data write signal output 72 /ULWR O Not used 73 MD0 (1) I Mode select input 74 MD1 (0) I Mode select input 75 MD2 (1) I Mode select input 52 52 Pin Name HOT_TX — Description Ground Ground 76 AVCC I Power supply 77 VREF (4V) I VREF input (+4V) 78 ASYM1/LVL0 I RF hold data input 79 ASYM2/LVL1 I RF hold data input 80 BETA/JITTER O Not used 81 MPXO I Multiplexed output from CXA2551R 82 HALL/SLDOUT I AD signal for sled control 83 ADC5 I Not used 84 ADC0 O Not used 85 SLDMOVE O Sled kick level output 86 AVSS — Ground 87 ESFS I Encoding subframe FS signal input from OTI-9790 88 /UINT0 I Interrupt signal input from OTI-9790 89 /UINT1 I Interrupt signal input from OTI-9790 90 ADTRIG I AD trig signal input from XC9536 91 CS0/P84 O Not used 92 VSS — Ground 93 FLAGA (TEZC) I Servo flag input 94 SBRK O Short brake for spindle control 95 SPNFG I Spindle FG signal input 96 OPCING O Opcing signal output 97 SLDFG I Sled FG signal input 98 SPNON O Spindle ON signal output 99 SPN8/12 O Spindle 8/12 detect signal output 100 SPNBOOST O Spindle boost signal output RCD-W1 • IC801 DRIVER (uPD780232GC-LG1) (FL Board) Pin No. 1 2 3 4 Pin Name VDD1 I/O I Power supply VSS1 — Ground X1 I Connected to the crystal oscillator (5MHz) X2 O Connected to the crystal oscillator (5MHz) 5 IC I Internally connected. (Connect to ground) 6 RESET I System reset input 7 SCK1 8 SI1 I I/O Description Serial serial clock I/O Serial data input 9 SO1 O Serial data output 10 BUSY O Not used 11 P23 O Not used 12 P22 O Not used 13 P21 O Not used 14 P20 O Not used 15 P00 I Chip select signal input 16 P01 O Not used 17 P02 I Connect to Vdd via a resistor. 18 AVSS — Ground 19 ANI3 I Connect to Vdd via a resistor. 20 ANI2 I Connect to Vdd via a resistor. 21 ANI1 I Connect to Vdd via a resistor. 22 ANI0 I Connect to Vdd via a resistor. 23 VSS0 — Ground 24 AVDD I Power supply 25 VDD0 I Power supply 26 P64 — Not used 27 P63 — Not used 28 P62 — Not used 29 P61 — Not used 30 P60 — Not used 31 P57 — Not used 32 P56 — Not used 33 P55 — Not used 34 P54 — Not used 35 P53 — Not used 36 P52 — Not used 37 P51 — Not used 38 P50 I 39 P47 — Not used 40 P46 — Not used 41 F37 — Not used 42 F36 — Not used 43 F35 O Fluorescent disply tube segment signal output 44 F34 O Fluorescent disply tube segment signal output 45 F33 O Fluorescent disply tube segment signal output 46 F32 O Fluorescent disply tube segment signal output 47 F31 O Fluorescent disply tube segment signal output 48 F30 O Fluorescent disply tube segment signal output 49 F29 O Fluorescent disply tube segment signal output 50 F28 O Fluorescent disply tube segment signal output Connect to Vdd via a resistor. 53 RCD-W1 Pin No. 51 F27 I/O O Description Fluoresent disply tube segment signal output. 52 F26 O Fluoresent disply tube segment signal output. 53 F25 O Fluoresent disply tube segment signal output. 54 F24 O Fluoresent disply tube segment signal output. 55 F23 O Fluoresent disply tube segment signal output. 56 F22 O Fluoresent disply tube segment signal output. 57 F21 O Fluoresent disply tube segment signal output. 58 F20 O Fluoresent disply tube segment signal output. 59 VDD2 I Power supply for FL driver 60 VLOAD I Power supply (-34V) for FL driver 61 F19 O Fluoresent disply tube segment signal output. 62 F18 O Fluoresent disply tube segment signal output. 63 F17 O Fluoresent disply tube segment signal output. 64 F16 O Fluoresent disply tube segment signal output. 65 F15 O Fluoresent disply tube common signal output. 66 F14 O Fluoresent disply tube common signal output. 67 F13 O Fluoresent disply tube common signal output. 68 F12 O Fluoresent disply tube common signal output. 69 F11 O Fluoresent disply tube common signal output. 70 F10 O Fluoresent disply tube common signal output. 71 F9 O Fluoresent disply tube common signal output. 72 F8 O Fluoresent disply tube common signal output. 73 F7 O Fluoresent disply tube common signal output. 74 F6 O Fluoresent disply tube common signal output. 75 F5 O Fluoresent disply tube common signal output. 76 F4 O Fluoresent disply tube common signal output. 77 F3 O Fluoresent disply tube common signal output. 78 F2 O Fluoresent disply tube common signal output. 79 F1 O Fluoresent disply tube common signal output. 80 F0 O Fluoresent disply tube common signal output. 54 Pin Name RCD-W1 5-22. IC BLOCK DIAGRAMS DMCON 0 ENCODER CD DECODER 1 CD-DA MPWM ION DEFS DPLOCK SPINDLE MOTOR CONTROLLER CIRC ENCODER 4k SRAM CIRC ENCODER CIRC ENCODER 4k SRAM ATIP ENCODER SECTOR PROCESSROR DRAM BUFFER MANAGER SUBCODE OPERATOR SUBCODE U COM INTERFACE ATAPI CLOCK AVSS AVSS R OUT AVDD AVDD L OUT AVSS XIN XOUT ADATA DOUT ALRCK ABCK C2PO LDON CLKOUT FLAGD FLAGC FLAGB FLAGA MONIT VSS VDD MONITO WBLIN ARST# UA0 UA1 UA2 UA3 UA4 UA5 UA6 UA7 UA8 UA9 UA10 UA11 UA12 UA13 UA14 UA15 UALE SDINT# UNIT1# UNIT0# URDY VSS VDD UCS1# UCS0# UWR# HRST# HDASP# VDD CS3FX CS1FX VSS HA2 HA0 HPDIAG# HA1 VDD TOCS16# HIRO VSS DAMCK# IORDY HRD# HWR# HDRQ HD15 HD0 VDD VSS HD14 HD1 HD13 HD2 HD12 HD3 HD11 VDD VSS HD4 HD10 HD5 HD9 HD6 HD8 HD7 VDD VSS CPUTYPE PRST# UAD0 UAD1 UAD2 UAD3 UAD4 UAD5 UAD6 UAD7 URD# AVSS DMO SLO TEST0 TEST1 REVDET FG C34M VDD5 VDD VSS MON SBRK RD7 RD6 RD5 RD4 RD3 RD2 RD15 RD14 VDD VSS RD13 RD12 RD11 RD10 RD9 RD8 RCASH# RCASL# RD0 RD1 VDD VSS ROE# RWE# RRAS# RAD11 RAD10 RAD9 RAD8 RAD7 RAD6 RAD5 VDD VSS RAD4 RAD3 RAD2 RAD1 RAD0 VREF VREF TAO FAO AVDD 2VREF CE RP RPBC BS AVSS AVDD TE FE VREF AVSS TEBC TC TX RX VSS VDD ROPC3 ROPC2 ROPC1 EFM3 EFM2 EFM1 RESAMP2 RESAMP1 WRSMP EEFS ESFS EFCK E11TS E1T1P VSS VDD EFMNT4 EFMNT3 EFMNT2 EFMNT1 PANICIN HFSW WGATE AVSS VREF EFM ASY EFMR1 EFMR2 EFMR3 AVDD AVDD IC201 OTI9790 (BD-R board) 55 RCD-W1 IC510 BA6664FM-E2 (BD-R board) IC306 CS8420-CSR (BD-R board) NC 1 A3 2 NC RXP 4 RXN 5 VA + AGND FILT RST C&U BUFFER DATA DECORD/ ENCORD 6 7 DRIVER 3 MISC CONT E MPH AES3 DECORD/ ENCORD 8 25 TXN NC 6 A1 7 23 VD + GND 8 H1+ 9 GAIN SWITCH 22 DGND – 21 OMCK 23 PS 22 FC 30 FGND 21 ECR 20 FR 19 FG 3 18 SB 17 CNF BRAKE MODE 16 BR Hall Bias 15 VH + – – H1- 10 26 GSW FG + 20 U VMI 24 PS TORQUE SENSE AMP + 27 VCC TL AMP RNF 25 VCC CURRENT SENSE AMP FGIN 29 24 H/S 9 VM GAIN CONTROL NC 5 26 TXP 5V TSD 3 A2 4 27 IDO/CDIN OUTPUT CLKGEN 2 RECEVER ADO/CS 28 SCL/CCLK CONTROL PORT & REGISTER + 1 28 – SDA/CDOUT DRIVER 11 ILRCKD 12 ISCLK 13 SDIN 14 19 INT AUDIO I/O 10 RERR SERIAL I/O RMCK CLOCK DATA RECOV VCC – 17 OLRCK + 16 OSCLK SAMPLE RATE CON + H2+ 11 18 SDOUT 15 TCBI VCC H2 - 12 – D H3 + 13 + CK R Q Q SHORT BRAKE – + H3 - 14 – OPOUT3 FGND GND STBY2 PWRVCC2 VO3 - VO3+ 23 22 30 21 20 19 18 17 + – + – VCC STAND BY CH4 VCC – +X2 15 Level Shift – + X2 Level Shift + – X1 Level Shift + X1 – Level Shift – X1 + + X1 – – X1 + + X1 – 2 3 4 5 6 7 29 8 9 10 11 12 13 14 BIASIN OPIN 1+ OPIN 1- OPOUT 1 OPIN 2+ OPIN 2- OPOUT 2 FGND GND STBY1 PWRVCC1 VO2 - VO2+ VO1 - VO1+ STAND BY CH1/2/3 VCC 1 + – + – 56 16 VO4+ OPIN3- 24 VO4 - OPIN3+ 25 + X1 – OPOUT4 26 – X1 + OPIN4- 27 + X1 – OPIN4+ 28 – X1 + PREVCC IC501 BA5983FM (BD-R board) RCD-W1 BHO1 76 PHC1 77 BHC1 78 PHO1 BHO2 PHO2 EQRFN EQRFP SRFO EFGH AUX AV C C MPXOUT MSPP RFRPIN AV S S RFRP RFCT RFCTC1 RFCTC2 TEIN TE FE TZC XT OK XT OR XT AND AGCON IC401 CXA2551AR (BD-R board) 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 PH/BH 50 WLDON 49 ERGCNT 48 SCLK RZC 79 47 S D ATA RECD2 80 46 X L AT RECD1 81 45 DVCC B E TA O U T 82 44 DVSS MPX RFEQ RFRP FE TE PHC2 83 43 ROPCSH BHC2 84 42 MPDSH RRFIN 85 41 SPDSH RRF 86 40 WBLSH GND 87 39 RFPDSH MCLK 88 38 WFPDSH AV C C 89 37 DSPV CC BET A SPPO EFGH SRFO RFO REGISTER FEO WRF 90 36 BGIREF MPP 91 35 VTIREF HIN 92 GIN 93 BIAS VC 34 AV C C 33 VC 32 DVC 31 AV S S 30 VCT1 29 VCT2 28 CNT_VC 27 C AV _ C N T 26 AT F G APC S/H MA TRIX 14 15 16 17 18 19 20 21 22 23 24 25 TFMA 13 A T IP AGC1C 12 FPDO VWDCN 11 FPDIN VWDC2 10 AV C C 9 VRDC 8 VRDCN 7 RREF 6 FVREF 5 AMP VWDC 4 VWDC1 ADO 3 WREF 2 APCCSW 1 CEO 100 APC SWRF AIN CE CEM 99 BCO 98 BIN CEP CIN OP- AGC2C 97 AGC3C 96 DIN SADBC SMFB H AV C SADO SMOUT 95 AV S S 94 SMIN FIN EIN SBCO 57 RCD-W1 IC301 M56788FP (BD board) 3 VBS2 4 VM2 5 NC GND 6 IN3+ 8 + VBS2 VBS2 39 VBS1 38 VM1 7 R R - Vm2 Vm1 - VBS2 9 + - VM3(+) 10 + GND 11 VM4(+) 12 VM4(-) 13 VM3 (-) CH3 OUT5 16 IN5- 17 IN5+ 18 IN4+ 19 IN4OUT4 20 R E1 VBS1 x5 VREFO CH2 + - x5 + BIAS VBS1 CH5 VBS2 + E5 31 VM2(-) 27 IN2+ Low,Open MUTEON 1– 4 CH 5CH 32 VM2(+) 28 IN2- + E2 TSD 34 VM1(+) 33 GND 29 GND SLEEP x8 35 VM1(-) 30 OUT2 VBS1 + + + x8 + - 37 IN136 OUT1 VBS1 CH4 + + - CH1 VBS2 + - 14 15 VBS1 x8 VBS2 VM5(-) R Vrefm1 Vrefm2 Hi:Sleep VM5(+) 41 REGB 40 IN1+ VREG E3 + IN3- 42 REG+ VBS2 + 2 26 MUTE1 25 MUTE2 1.25v VBS2 + - VBS1 E4 21 VREF 24 SS.GND + 1 OUT3 + CH3IN 23 VREF 22 VREFO IC401 LB11995H-TLM (BD board) 8 NC 9 NC Rotation direction detector SIG GND 21 UIN2 20 UIN1 Short brake 19 VIN2 Current limiter Hall power supply 10 BRAKE 12 FG 13 FG RS 14 RS Waveform distributor S/S 11 Matrix 18 VIN1 17 WIN2 16 + 58 WIN1 15 VH – 6 7 Forward/ reverse – – FC LMC + – + 5 – VCREF + 24 NC 23 RF 22 VCC1 + 4 26 VCC2 25 VCC3 – VC Reference voltage 28 VOUT 27 WOUT + Thermal shutdown FG RG – 3 + 2 NC – 1 WOUT + PWR GND RCD-W1 NC TE CE RFDC ADIO AVSS2 IGEN AVDD2 V16M VCKI PDO TEST VCOI VCOO DVDD5 PWMI NC NC NC NC TES3 TES2 DTSO DVSS5 SSTP LOCK MDS MDP MON AVDD6 BSSD FAO TAO SAO AVSS6 NC IC201 CXD3011-1R (BD board) 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 SELECTOR 107 NC FSW 106 TESO 105 99 98 97 96 95 FOK DECT MIRR COUT DVSS4 CLOK XLAT DATA ATSK SCLK SENS 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 DVDD4 AVDD3 NC NC NC NC PWMLN PWMLP AVSS3 AVSS5 XTLI XTLO AVDD5 AVDD4 PWMRP PWMRN AVSS4 DVSS3 LMUTO RMUTO XWD NC 108 ANANLOG SWITCH AMP A V C CAV CLV PROCESSOR PROCESSOR FST SELED DSP SLED SERVO TRACKING SERVO FOCUS OSC DIC AMP SLED TRACKING FOCUS FOK DFCK MIRR ADDRESS GENERATOR FST * 8 D/A DATA PROCESSOR PEAK DETECTOR +1 BIT DAC, 8BIT DIGITAL FILTER PROTECTER SYNC MUX 103 101 100 ERROR CORRECTOR ERROR PATE COUNTER Q SUBCODE DEMODULATOR EFM P-W SUBCODE DPLL 104 102 SERVO I/F RAM 32K REGISTER 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 NOISE SHAPER DIGITAL PUT OSC SERIAL/PARALLEL PROCESSOR GEN. CLOCK FST 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 NC GTOP XUGF PLCK GFS RFCK DVDD2 C2PO XRAOF MNT3 MNT2 MNT1 MNT0 DVSS2 XTSL MCKO NC NC NC NC FSTIO C4M C16M DVDD3 MD2 DOUT MUTE WFCK SCOR SBSO EXCK SQSO SQCK SCSY XRST NC VPCO1 VPCO2 VCTL FILO FILT PCO CLTV AVSS1 RFAC BIAS ASYI ASYO AVDD1 NC NC NC NC DVDD1 DVSS1 ASYE PSSL WDCK LRCK LRCK1 DA16 PCMDI DA15 BCKI SOUT SOCK XOLT NC PRIORITY ENCODER OSC FILTER 8-TIMES SEQUE NCER SERVO AUTO TIMING GENERATOR2 1 2 3 4 GENERATOR TIMING NC SE FE VC 59 RCD-W1 2 AC SUM AC VCA VFC PD REC 1 BST LD RFG IC101 CXA2581N (BD board) EQ APC 30 DC_OFST 29 RFDCI 28 RFDCO EQ_ON/OFF EQ_IN 3 RW/ROM AC_SUM 4 GND 5 DV CC RW/ROM VC DVC A 6 B 7 C 8 D 9 VCC 27 VC 26 RFC 25 VFC 24 BST 23 RFG 22 VCC 21 CEI 20 CE 19 TE_BAL 18 TE 17 FEI 16 FE DV CC DVC VOFST RW/ROM VC RW/ROM VOFST VC F 10 gm E 11 gm VOFST RW/ROM DV CC VC RW/ROM B DVC C DV CC A D SW 12 DVCC 13 DVC DVC VC RW/ROM APC-OFF (Hi-Z) RW/ROM (H/L) DVC VC VOFST V CC VC VC DVC 14 RFAC 15 IC105,401 AK4393VF-E2 (AUDIO board) DVSS 1 DVDD 2 28 CKS2 DVDD 3 27 CKS1 Clock Divider 26 CKS0 PD 4 BICK 5 SDATA 6 Left Channel De-emphasis Soft Mute LRCK 7 SMUTE/CS 8 DFS 9 25 P/S DFS Serial Input Interface 24 VCOM De-emphasis Soft Mute 8X Interpolator Multi-bit ∆∑ Modulator Switched Capacitor Filter 8X Interpolator Multi-bit∆∑ Modulator Switched Capacitor Filter 23 A OUTL+ 22 A OUT- 21 A OUTR+ 20 A OUTR- Right Channel DEM0/CCLK 10 DEM1/CDIT 11 DIF0 12 60 Control Register 19 AVSS De-emphasis Control AVDD 18 AVDD 17 VREFH DIF1 13 16 VREFL DIF2 14 15 BVSS RCD-W1 SECTION 6 EXPLODED VIEWS NOTE: • -XX, -X mean standardized parts, so they may have • Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. some difference from the original one. • Items marked “*” are not stocked since they are • Abbreviation : Canadian model seldom required for routine service. Some delay CND MX : Mexican model should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. When indicating parts by reference number, please include the board name. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. 6-1. FRONT PANEL SECTION 10 9 7 8 10 7 6 not supplied not supplied 7 12 not supplied 11 7 7 not supplied 10 5 4 FLD801 3 2 1 Ref. No. Part No. Description 1 2 3 4 5 4-235-379-01 4-235-360-01 4-235-359-01 4-235-378-01 4-235-449-01 KNOB, REC VOL DOOR, TRAY (REC) DOOR, TRAY (PLAY) KNOB, P/VOLUME PANEL ASSY, FRONT 6 7 4-235-380-01 KNOB, POEWR 4-235-377-01 SCREW, SPECIAL Remark Ref. No. 8 9 10 Part No. Description Remark A-4726-177-A HP BOARD,COMPLETE 4-235-363-01 CASE, TOP 4-235-383-01 SCREW (CASE) 11 A-4726-178-A VOL BOARD,COMPLETE 12 A-4726-179-A FL BOARD,COMPLETE FLD801 1-518-766-11 INDICATOR TUBE, FLUORESCENT 61 RCD-W1 6-2. CHASSIS SECTION 56 61 58 56 54 56 55 56 56 56 51 59 not supplied not supplied not supplied not supplied 56 not supplied 56 53 60 57 52 53 51 52 51 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. Part No. Description 51 52 53 54 54 4-235-403-01 4-235-400-01 4-235-402-01 4-235-401-01 4-235-401-11 SCREW, SPECIAL (3X8 BK) RUBBER, FOOT HOLDER, FOOT PANEL, BACK (E,MX,US) PANEL, BACK (CND) 55 56 57 4-235-362-01 SCREW SPECIAL (3X10) 4-235-364-01 SCREW, SPECIAL 1-823-105-11 WIRE (FLAT TYPE) (16 CORE) 62 Remark Ref. No. 58 59 Part No. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. Description Remark 1-823-104-11 WIRE (FLAT TYPE) (26 CORE) A-4727-517-A POWER BOARD,COMPLETE (E,MX) 59 60 60 60 0 61 A-4735-112-A A-4727-516-A A-4727-519-A A-4735-113-A 1-823-044-11 POWER BOARD,COMPLETE (CND,US) AUDIO BOARD,COMPLETE (E) AUDIO BOARD,COMPLETE (MX) AUDIO BOARD,COMPLETE (CND,US) CORD, POWER (CND,US) 0 61 1-823-333-11 CORD, POWER (E,MX) RCD-W1 6-3. CD PLAY SECTION (DECK A) 127 101 102 123 112 122 not supplied 113 129 114 115 116 111 119 124 not supplied 119 122 120 117 117 122 118 121 130 103 122 106 104 107 128 105 125 109 108 110 126 Ref. No. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Remark Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. Part No. Description Part No. Description 101 102 103 104 105 4-235-453-01 4-235-404-01 4-235-381-01 4-235-382-01 4-235-407-01 CLAMP ASSY, DISC HOLDER, CLAMP BELT GEAR, PULLEY GEAR, LOADING 116 117 118 119 120 4-235-415-01 4-235-389-01 4-236-695-01 4-235-390-01 4-235-418-01 SHAFT, L RUBBER, FRONT MOTOR ASSY, SPINDLE RUBBER, REAR BASE, PU 106 107 108 109 110 4-235-384-01 4-235-386-01 4-235-454-01 4-235-387-01 4-235-388-01 BASE, UP/DOWN BASE, MAIN MOTOR ASSY, LOADING GUIDE, UP/DOWN TRAY, DISC 121 122 123 124 125 4-236-696-01 4-235-419-01 4-235-420-01 4-235-421-01 4-235-391-01 MOTOR ASSY, SLED SCREW, 2X6 SCREW, 1.7X6 SCREW, 1.7X5 SCREW, 1.7X4.5 0111 112 113 114 115 1-476-791-11 1-823-045-11 4-235-412-01 4-235-413-01 4-235-414-01 PICK-UP BLOCK WIRE (FLAT TYPE) (17 CORE) GUIDE, FEED SPRING, FEED SHAFT, R 126 127 128 129 130 A-4726-180-A 4-235-451-01 4-235-450-01 4-235-460-01 A-4735-108-A BD BOARD,COMPLETE HOLDER ASSY, CLAMP MECHANISM ASSY, LOADING MECHANISM ASSY DECK ASSY (CDP) Ref. No. Remark 63 RCD-W1 6-4. CD RECORD SECTION (DECK B) 173 151 152 180 178 175 not supplied 166 179 not supplied 166 not supplied not supplied 167 164 169 not supplied 165 171170 162 153 163 172 168 168 154 157 156 174 155 161 159 158 160 Ref. No. Part No. Description 151 152 153 154 155 4-235-453-01 4-235-404-01 4-235-381-01 4-235-382-01 4-235-407-01 CLAMP ASSY, DISC HOLDER, CLAMP BELT GEAR, PULLEY GEAR, LOADING 156 157 158 159 160 4-235-384-01 4-235-386-01 4-235-454-01 4-235-387-01 4-235-388-01 161 0162 163 164 165 4-235-391-01 1-476-792-11 4-235-455-01 4-235-456-01 4-235-457-01 64 176 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Remark Ref. No. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. Part No. Description 166 167 168 169 170 4-235-390-01 1-823-046-11 4-235-389-01 4-235-392-01 4-235-394-01 RUBBER, REAR WIRE (FLAT TYPE) (32 CORE) RUBBER, FRONT WASHER SCREW, 2.0X11.5 BASE, UP/DOWN BASE, MAIN MOTOR ASSY, LOADING GUIDE, UP/DOWN TRAY, DISC 171 172 173 174 175 4-235-393-01 4-235-395-01 4-235-451-01 4-235-450-01 4-235-452-01 SCREW, 2.0X4.5 SCREW, 1.7X3 HOLDER ASSY, CLAMP MECHANISM ASSY, LOADING MECHANISM ASSY, PU SCREW, 1.7X4.5 OPTICAL PICK-UP (CD-R) GEAR ASSY, RACK GEAR ASSY, PINION MECHANISM ASSY 176 178 179 180 A-4726-182-A A-4735-110-A 1-823-103-11 4-235-420-01 BD-R BOARD,COMPLETE DECK ASSY (CD-R) WIRE (FLAT TYPE) 8P SCREW, 1.7X6 Remark RCD-W1 SECTION 7 ELECTRICAL PARTS LIST AUDIO Note: The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. When indicating parts by reference number, please include the board name. • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • RESISTORS All resistors are in ohms METAL: Metal-film resistor METAL OXIDE: Metal Oxide-film resistor F : nonflammable Ref. No. Part No. Description Remark * * * A-4727-516-A AUDIO BOARD, COMPLETE (E) A-4727-519-A AUDIO BOARD, COMPLETE (MX) A-4735-113-A AUDIO BOARD, COMPLETE (US,CND) Ref. No. Part No. • SEMICONDUCTORS In each case, u: µ , for example: uA...: µ A..., uPA...: µ PA..., uPB...: µ PB..., uPC...: µ PC..., uPD...: µ PD... • CAPACITORS uF : µ F • COILS uH : µ H • Abbreviation CND : Canadian model MX : Mexican model Description Remark C142 C143 C144 1-163-038-00 CERAMIC CHIP 1-163-038-00 CERAMIC CHIP 1-163-038-00 CERAMIC CHIP 0.1uF 0.1uF 0.1uF C145 C202 C203 C204 C205 1-163-038-00 1-126-933-11 1-163-139-00 1-126-947-11 1-126-947-11 CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT 0.1uF 100uF 820PF 47uF 47uF C206 C207 C208 C209 C210 1-163-038-00 1-163-038-00 1-163-038-00 1-126-935-11 1-104-665-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT C211 C212 C213 C214 C217 1-104-665-11 1-126-933-11 1-115-419-11 1-163-251-11 1-104-666-11 C218 C220 C221 C222 C223 25V 25V 25V *************************** < CAPACITOR > C101 C102 C103 C104 C105 1-126-947-11 1-163-275-11 1-126-963-11 1-163-275-11 1-163-038-00 ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 47uF 0.001uF 4.7uF 0.001uF 0.1uF 20% 5% 20% 5% 35V 50V 50V 50V 25V C106 C108 C109 C110 C114 1-126-947-11 1-163-038-00 1-163-021-11 1-163-038-00 1-126-965-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 47uF 0.1uF 0.01uF 0.1uF 22uF 20% 35V 25V 50V 25V 50V C115 C116 C117 C118 C119 1-126-965-11 1-126-965-11 1-126-965-11 1-163-251-11 1-163-038-00 ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP 22uF 22uF 22uF 100PF 0.1uF 20% 20% 20% 5% 50V 50V 50V 50V 25V C120 C121 C122 C123 C124 1-126-947-11 1-163-251-11 1-163-038-00 1-126-947-11 1-163-251-11 ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 47uF 100PF 0.1uF 47uF 100PF 20% 5% 35V 50V 25V 35V 50V C125 C126 C127 C128 C129 1-163-251-11 1-163-038-00 1-126-947-11 1-163-038-00 1-126-947-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT 100PF 0.1uF 47uF 0.1uF 47uF 5% C130 C131 C132 C133 C134 1-163-259-91 1-126-965-11 1-163-259-91 1-126-965-11 1-163-038-00 CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP 220PF 22uF 220PF 22uF 0.1uF C135 C136 C137 C138 C139 1-163-038-00 1-163-038-00 1-163-038-00 1-163-038-00 1-163-038-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 25V 25V 25V 25V 25V C140 C141 1-163-038-00 CERAMIC CHIP 1-163-038-00 CERAMIC CHIP 0.1uF 0.1uF 25V 25V 10% 20% 20% 5% 20% 20% 5% 20% 5% 20% 50V 25V 35V 25V 35V 50V 50V 50V 50V 25V 20% 5% 20% 20% 25V 16V 50V 35V 35V 0.1uF 0.1uF 0.1uF 470uF 100uF 20% 20% 25V 25V 25V 6.3V 10V ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT 100uF 100uF 3300PF 100PF 220uF 20% 20% 5% 5% 20% 10V 16V 25V 50V 25V 1-163-139-00 1-126-965-11 1-115-419-11 1-115-419-11 1-104-665-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT 820PF 22uF 3300PF 3300PF 100uF 5% 20% 5% 5% 20% 50V 50V 25V 25V 10V C224 C225 C227 C228 C229 1-104-665-11 1-163-139-00 1-163-139-00 1-163-038-00 1-163-038-00 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100uF 820PF 820PF 0.1uF 0.1uF 20% 5% 5% 10V 50V 50V 25V 25V C231 C236 C237 C245 C247 1-126-965-11 1-165-590-11 1-165-590-11 1-163-038-00 1-163-251-11 ELECT PETE FILM PETE FILM CERAMIC CHIP CERAMIC CHIP 22uF 20% 0.0039uF 0.0039uF 0.1uF 100PF 5% 50V 100V 100V 25V 50V C248 C249 C252 C401 C402 1-163-251-11 1-163-038-00 1-163-243-11 1-126-947-11 1-163-038-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 100PF 0.1uF 47PF 47uF 0.1uF 50V 25V 50V 35V 25V C404 C405 C406 C407 C408 1-163-038-00 1-126-947-11 1-126-935-11 1-163-038-00 1-104-665-11 CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT 0.1uF 47uF 470uF 0.1uF 100uF 5% 5% 20% 20% 20% 20% 25V 35V 6.3V 25V 10V 65 RCD-W1 AUDIO Ref. No. Part No. Description Remark C409 C411 C412 C413 C414 1-104-665-11 1-126-933-11 1-126-933-11 1-104-665-11 1-104-665-11 ELECT ELECT ELECT ELECT ELECT 100uF 100uF 100uF 100uF 100uF 20% 20% 20% 20% 20% 10V 16V 16V 10V 10V C415 C416 C417 C418 C419 1-115-419-11 1-163-139-00 1-163-139-00 1-115-419-11 1-163-139-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 3300PF 820PF 820PF 3300PF 820PF 5% 5% 5% 5% 5% 25V 50V 50V 25V 50V C424 C425 C426 C427 C428 1-163-139-00 1-126-965-11 1-126-965-11 1-165-590-11 1-165-590-11 CERAMIC CHIP 820PF ELECT 22uF ELECT 22uF PETE FILM 0.0039uF PETE FILM 0.0039uF 5% 20% 20% 50V 50V 50V C429 C430 C471 C472 C473 1-163-259-91 1-163-259-91 1-126-933-11 1-126-933-11 1-163-038-00 CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP 5% 5% 20% 20% 50V 50V 16V 16V 25V C474 C476 1-163-038-00 CERAMIC CHIP 1-163-038-00 CERAMIC CHIP 220PF 220PF 100uF 100uF 0.1uF 0.1uF 0.1uF < IC > IC102 IC103 IC104 IC105 IC106 8-759-710-97 8-759-710-97 8-759-064-92 8-759-650-48 8-759-644-49 IC IC IC IC IC NJM4565M(TE2) NJM4565M(TE2) NJM5532M-D AK4393VF-E2 74HCU04D IC108 IC109 IC110 IC111 IC112 8-759-448-71 8-759-448-71 8-759-448-71 8-759-448-71 6-700-345-01 IC IC IC IC IC BU4053BCFV-E2 BU4053BCFV-E2 BU4053BCFV-E2 BU4053BCFV-E2 AK5351 IC401 IC404 IC406 JK103 JK104 8-759-650-48 8-759-064-92 8-759-194-97 8-749-921-12 8-749-921-12 IC IC IC IC IC AK4393VF-E2 NJM5532M-D NJM4560MD GP1F32T (OPTICAL CD OUT) GP1F32T (OPTICAL CDR OUT) JK105 8-749-019-69 IC TORX178 (OPTICAL CDR IN) 25V 25V Ref. No. Part No. Description Remark < TRANSISTOR > Q202 Q204 Q205 Q206 Q207 8-729-036-89 8-729-016-64 8-729-037-16 8-729-036-89 8-729-016-64 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR KTC3198GR-A KTD1302 KRA103M-AT KTC3198GR-A KTD1302 Q208 Q401 Q402 Q403 Q404 8-729-016-64 8-729-036-89 8-729-036-89 8-729-016-64 8-729-016-64 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR KTD1302 KTC3198GR-A KTC3198GR-A KTD1302 KTD1302 Q405 Q410 Q411 8-729-037-16 TRANSISTOR KRA103M-AT 8-729-036-89 TRANSISTOR KTC3198GR-A 8-729-036-89 TRANSISTOR KTC3198GR-A < RESISTOR > R101 R102 R103 R104 R105 1-216-017-00 1-216-017-00 1-216-017-00 1-216-041-00 1-216-037-00 RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP 47 47 47 470 330 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R106 R107 R111 R112 R113 1-216-037-00 1-216-037-00 1-216-037-00 1-216-089-00 1-216-089-00 METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 330 330 330 47K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R114 R115 R116 R117 R118 1-216-089-00 1-216-089-00 1-216-073-00 1-216-295-00 1-216-073-00 RES-CHIP RES-CHIP RES-CHIP SHORT RES-CHIP 47K 47K 10K 0 10K 5% 5% 5% 1/10W 1/10W 1/10W 5% 1/10W R119 R120 R121 R124 R125 1-216-073-00 1-216-065-00 1-216-065-00 1-216-073-00 1-216-073-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 10K 4.7K 4.7K 10K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R126 R127 R128 R129 R132 1-216-061-00 1-216-061-00 1-216-059-00 1-216-059-00 1-216-081-00 RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP 3.3K 3.3K 2.7K 2.7K 22K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R133 R134 R135 R136 R137 1-216-065-00 1-216-081-00 1-216-009-00 1-216-009-00 1-216-049-11 RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP 4.7K 22K 22 22 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R138 R140 R141 R142 R143 1-216-061-00 1-216-049-11 1-216-061-00 1-216-025-11 1-216-009-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 3.3K 1K 3.3K 100 22 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R144 R145 R146 R147 R201 1-216-009-00 1-216-061-00 1-216-061-00 1-216-061-00 1-216-073-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 22 3.3K 3.3K 3.3K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R202 1-216-049-11 RES-CHIP 1K 5% 1/10W < JACK > JK101 1-815-706-11 JACK, PIN 6P (ANALOG IN/OUT) < COIL > L103 L104 1-400-091-21 INDUCTOR 1-400-091-21 INDUCTOR 0uH 0uH < RELAY > LY402 1-755-443-11 RELAY < CONNECTOR > PN105 * PN401 66 1-784-375-21 CONNECTOR, FFC/FPC 16P 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P RCD-W1 AUDIO Ref. No. Part No. Description R203 R204 R205 R206 1-216-065-00 1-216-049-11 1-216-063-00 1-216-073-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP 4.7K 1K 3.9K 10K 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W R208 R209 R210 R211 R212 1-216-051-00 1-216-051-00 1-216-053-00 1-216-049-11 1-216-049-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 1.2K 1.2K 1.5K 1K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R213 R214 R215 R216 R217 1-216-053-00 1-216-049-11 1-216-051-00 1-216-051-00 1-216-053-00 METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP 1.5K 1K 1.2K 1.2K 1.5K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R218 R219 R222 R223 R224 1-216-077-00 1-216-053-00 1-216-049-11 1-216-049-11 1-216-049-11 METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP 15K 1.5K 1K 1K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R225 R226 R228 R229 R230 1-216-077-00 1-216-059-00 1-216-049-11 1-216-065-00 1-216-071-00 METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP 15K 2.7K 1K 4.7K 8.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R231 R236 R237 R238 R239 1-216-071-00 1-216-041-00 1-216-041-00 1-216-049-11 1-216-049-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 8.2K 470 470 1K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R249 R256 R264 R266 R401 1-216-065-00 1-216-061-00 1-216-009-00 1-216-057-00 1-216-049-11 RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP 4.7K 3.3K 22 2.2K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R402 R403 R404 R405 R406 1-216-073-00 1-216-073-00 1-216-073-00 1-216-051-00 1-216-051-00 RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP 10K 10K 10K 1.2K 1.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. Part No. BD Description Remark R432 R433 1-216-061-00 RES-CHIP 1-216-079-00 METAL CHIP 3.3K 18K 5% 5% 1/10W 1/10W R434 R451 R475 R476 R477 1-216-061-00 1-216-073-00 1-216-039-00 1-216-009-00 1-216-009-00 RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP 3.3K 10K 390 22 22 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R478 R479 R480 R481 R482 1-216-039-00 1-216-037-00 1-216-037-00 1-216-037-00 1-216-037-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 390 330 330 330 330 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W ****************************************************** A-4726-180-A BD BOARD, COMPLETE R407 R408 R413 R414 R415 1-216-053-00 1-216-049-11 1-216-049-11 1-216-053-00 1-216-051-00 METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP 1.5K 1K 1K 1.5K 1.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R416 R417 R419 R420 R421 1-216-051-00 1-216-049-11 1-216-053-00 1-216-053-00 1-216-049-11 METAL CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP 1.2K 1K 1.5K 1.5K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R422 R424 R425 R427 R428 1-216-049-11 1-216-049-11 1-216-049-11 1-216-081-00 1-216-081-00 RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP 1K 1K 1K 22K 22K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R429 R430 R431 1-216-041-00 METAL CHIP 1-216-041-00 METAL CHIP 1-216-079-00 METAL CHIP 470 470 18K 5% 5% 5% 1/10W 1/10W 1/10W ***************** < CAPACITOR > C101 C102 C103 C104 C105 1-162-970-11 1-128-590-11 1-125-837-11 1-135-259-11 1-165-319-11 CERAMIC CHIP ELECT CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP 0.01uF 100uF 1uF 10uF 0.1uF 10% 20% 10% 20% C106 C107 C108 C111 C112 1-164-156-11 1-164-346-11 1-164-346-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 1uF 1uF 0.1uF 0.1uF 25V 16V 16V 25V 25V C114 C115 C116 C117 C118 1-165-319-11 1-104-607-11 1-128-590-11 1-164-346-11 1-162-967-11 CERAMIC CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 47uF 20% 100uF 20% 1uF 0.0033uF 10% 50V 16V 6.3V 16V 50V C119 C120 C121 C122 C123 1-128-590-11 1-165-319-11 1-115-416-11 1-162-923-11 1-164-315-11 ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100uF 0.1uF 0.001uF 47PF 470PF 6.3V 50V 25V 50V 50V C201 C202 C203 C204 C205 1-165-319-11 1-115-416-11 1-165-319-11 1-164-346-11 1-164-346-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.001uF 0.1uF 1uF 1uF C206 C207 C208 C209 C210 1-165-319-11 1-162-927-11 1-164-230-11 1-164-346-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 100PF 220PF 1uF 0.1uF C211 C212 C213 C214 C215 1-162-927-11 1-164-346-11 1-216-803-11 1-165-319-11 1-165-176-11 CERAMIC CHIP CERAMIC CHIP METAL CHIP CERAMIC CHIP CERAMIC CHIP 100PF 1uF 33 0.1uF 0.047uF 5% 10% 50V 16V 1/16W 50V 16V C216 C217 C218 C219 C220 1-164-217-11 1-162-967-11 1-164-230-11 1-165-176-11 1-162-970-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 150PF 0.0033uF 220PF 0.047uF 0.01uF 5% 10% 5% 10% 10% 50V 50V 50V 16V 25V 20% 5% 5% 5% 5% 5% 5% 5% 25V 6.3V 6.3V 6.3V 50V 50V 25V 50V 16V 16V 50V 50V 50V 16V 25V 67 RCD-W1 Ver 1.3 2002.11 BD Ref. No. Part No. Description C221 C222 C223 C224 C225 1-162-919-11 1-162-919-11 1-162-970-11 1-165-319-11 1-162-925-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 22PF 22PF 0.01uF 0.1uF 68PF 5% 5% 10% Remark C226 C227 C228 C229 C301 1-162-925-11 1-162-925-11 1-162-925-11 1-165-319-11 1-164-346-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 68PF 68PF 68PF 0.1uF 1uF 5% 5% 5% C302 C303 C304 C306 C308 1-126-394-11 1-164-346-11 1-165-589-21 1-165-319-11 1-164-346-11 ELECT CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 10uF 1uF 220uF 0.1uF 1uF 20% C309 C310 C311 C312 C401 1-164-346-11 1-164-670-11 1-165-319-11 1-128-416-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP 1uF 1200PF 0.1uF 100uF 0.1uF C402 C403 C404 C405 C406 1-164-156-11 1-164-156-11 1-165-319-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 25V 25V 50V 25V 25V C407 C408 C409 C410 C411 1-164-156-11 1-164-156-11 1-164-156-11 1-128-416-11 1-104-607-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP 0.1uF 0.1uF 0.1uF 100uF 47uF 25V 25V 25V 16V 16V C412 C414 C415 C416 C417 1-164-156-11 1-165-176-11 1-165-591-21 1-165-591-21 1-165-319-11 CERAMIC CHIP CERAMIC CHIP CERAMIC (SMD) CERAMIC (SMD) CERAMIC CHIP 0.1uF 0.047uF 0.08uF 0.08uF 0.1uF C419 C421 C423 C424 C501 1-110-563-11 1-165-319-11 1-126-394-11 1-164-156-11 1-163-231-11 CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP 0.068uF 0.1uF 10uF 0.1uF 15PF C502 C504 C505 C506 C507 1-163-231-11 1-128-590-11 1-164-156-11 1-165-319-11 1-128-590-11 CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP 15PF 100uF 0.1uF 0.1uF 100uF C508 C509 C510 C511 C512 1-165-319-11 1-164-156-11 1-164-346-11 1-165-319-11 1-165-319-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 1uF 0.1uF 0.1uF 50V 25V 16V 50V 50V C513 C514 C602 C604 C605 1-165-319-11 1-162-970-11 1-165-319-11 1-165-319-11 1-128-590-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP 0.1uF 0.01uF 0.1uF 0.1uF 100uF 50V 25V 50V 50V 6.3V C701 C702 C703 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 5% 5% 20% 20% 20% 50V 50V 25V 50V 50V 50V 50V 50V 50V 16V 16V 16V 6V 50V 16V 16V 16V 50V 16V 25V Ref. No. Part No. Description Remark C704 C705 1-162-970-11 CERAMIC CHIP 1-162-970-11 CERAMIC CHIP 0.01uF 0.01uF 10% 10% 25V 25V C706 C707 C708 C709 C710 1-162-970-11 1-162-970-11 1-162-970-11 1-162-970-11 1-162-970-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 0.01uF 0.01uF 0.01uF 0.01uF 10% 10% 10% 10% 10% 25V 25V 25V 25V 25V C711 C712 C713 C714 C715 1-162-970-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 100PF 100PF 100PF 100PF 10% 5% 5% 5% 5% 25V 50V 50V 50V 50V C719 C720 C721 C722 C723 1-162-970-11 1-162-970-11 1-162-970-11 1-162-970-11 1-162-970-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 0.01uF 0.01uF 0.01uF 0.01uF 10% 10% 10% 10% 10% 25V 25V 25V 25V 25V C724 C725 C726 C727 C728 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 100PF 100PF 100PF 100PF 5% 5% 5% 5% 5% 50V 50V 50V 50V 50V C729 C730 1-162-927-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 100PF 0.1uF 5% 50V 25V < DIODE > D201 D502 8-719-084-78 DIODE KDS121 8-719-084-79 DIODE KDS187 < IC > 68 0.1uF 0.1uF 0.1uF 10% 10% 20% 5% 5% 20% 20% 10% 20% 25V 16V 50V 50V 50V 16V 50V 16V 25V 50V 50V 6.3V 25V 50V 6.3V 25V 25V 25V IC101 IC201 IC301 IC302 IC401 8-752-089-73 6-700-349-01 6-700-343-01 8-759-082-61 6-700-344-01 IC IC IC IC IC CXA2581N OTI9790 M56788FP TC4W53FU(TE12R) LB1195H-TLM IC402 IC403 IC501 IC502 IC601 8-759-710-55 8-759-710-55 6-800-236-01 6-700-342-01 8-759-458-10 IC IC IC IC IC NJM2100M-TE1 NJM2100M-TE1 HD64F3062AFBL-CD XC61AN3002 BA3939-E2 IC602 8-759-300-71 IC BU4053BCF < COIL > L203 L401 L501 1-400-090-21 INDUCTOR 0uH 1-412-058-11 INDUCTOR CHIP 10uH 1-412-058-11 INDUCTOR CHIP 10uH < CONNECTOR > PN201 PN301 PN401 PN601 PN602 1-784-376-11 1-784-364-21 1-793-989-21 1-815-767-11 1-815-766-11 CONNECTOR, FFC/FPC 17P CONNECTOR, FFC/FPC 4P CONNECTOR, FFC/FPC 13P SOCKET, CONNECTOR 9P SOCKET, CONNECTOR 8P PN603 PN604 PN605 PN606 1-815-768-11 1-815-765-11 1-784-383-21 1-815-768-11 SOCKET, CONNECTOR 10P SOCKET, CONNECTOR 6P CONNECTOR, FFC/FPC 26P SOCKET, CONNECTOR 10P RCD-W1 BD Ref. No. Part No. * PN609 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P Description Remark < TRANSISTOR > Q101 Q102 Q104 Q105 Q401 8-729-026-48 1-801-806-11 8-729-027-38 1-801-806-11 8-729-056-33 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SA1037AK-T146-Q DTC144EKA DTA144EKA-T146 DTC144EKA KTD1304S Q403 8-729-056-33 TRANSISTOR KTD1304S < RESISTOR > R101 R102 R103 R104 R105 1-216-799-11 1-216-799-11 1-216-801-11 1-216-835-11 1-216-835-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 15 15 22 15K 15K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R106 R107 R108 R113 R122 1-216-864-11 1-216-846-11 1-216-848-11 1-216-821-11 1-216-839-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 120K 180K 1K 33K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R124 R125 R126 R127 R128 1-216-833-11 1-216-833-11 1-216-833-11 1-216-845-11 1-216-843-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 10K 10K 100K 68K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R131 R132 R133 R139 R140 1-216-833-11 1-216-831-11 1-216-833-11 1-216-825-11 1-216-825-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 6.8K 10K 2.2K 2.2K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R146 R147 R148 R201 R202 1-216-828-11 1-216-864-11 1-216-864-11 1-216-837-11 1-216-839-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 3.9K 0 0 22K 33K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R203 R208 R213 R214 R216 1-216-833-11 1-216-839-11 1-216-837-11 1-216-833-11 1-216-839-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 33K 22K 10K 33K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R217 R218 R222 R223 R224 1-216-843-11 1-216-847-11 1-216-827-11 1-216-827-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 68K 150K 3.3K 3.3K 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R227 R228 R229 R230 R231 1-216-839-11 1-216-833-11 1-216-845-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 33K 10K 100K 100 100 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R232 R233 R234 R235 R236 1-216-806-11 1-216-806-11 1-216-817-11 1-216-809-11 1-216-809-11 RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP 56 56 470 100 100 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R237 1-414-229-11 FERRITE 0UH Ref. No. Part No. Description R239 R241 R242 R301 1-216-809-11 1-216-809-11 1-216-809-11 1-216-842-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 100 56K 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W R302 R303 R304 R305 R306 1-216-847-11 1-216-821-11 1-216-827-11 1-216-845-11 1-216-845-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 150K 1K 3.3K 100K 100K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R307 R308 R310 R311 R312 1-216-842-11 1-216-847-11 1-216-837-11 1-216-809-11 1-216-837-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 56K 150K 22K 100 22K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R313 R314 R315 R316 R317 1-216-837-11 1-216-809-11 1-216-838-11 1-216-837-11 1-216-837-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 100 27K 22K 22K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R318 R319 R402 R403 R404 1-216-825-11 1-216-825-11 1-216-841-11 1-216-809-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 2.2K 2.2K 47K 100 1K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R405 R406 R407 R408 R409 1-216-821-11 1-216-811-11 1-216-811-11 1-244-378-21 1-244-378-21 METAL CHIP 1K METAL CHIP 150 METAL CHIP 150 RES, CARBON (SND) RES, CARBON (SND) 5% 5% 5% 1 1 1/16W 1/16W 1/16W (3216) (3216) R410 R411 R412 R413 R414 1-244-378-21 1-216-827-11 1-216-827-11 1-216-827-11 1-216-827-11 RES, CARBON (SND) METAL CHIP 3.3K METAL CHIP 3.3K METAL CHIP 3.3K METAL CHIP 3.3K 1 5% 5% 5% 5% (3216) 1/16W 1/16W 1/16W 1/16W R415 R416 R417 R418 R419 1-216-841-11 1-216-841-11 1-216-817-11 1-216-837-11 1-216-840-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 47K 470 22K 39K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R421 R422 R423 R424 R425 1-216-833-11 1-216-838-11 1-216-833-11 1-216-835-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 27K 10K 15K 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R426 R427 R428 R429 R430 1-216-833-11 1-216-825-11 1-216-821-11 1-216-825-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 2.2K 1K 2.2K 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R431 R433 R434 R435 R436 1-216-833-11 1-216-825-11 1-216-845-11 1-216-843-11 1-216-825-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 2.2K 100K 68K 2.2K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R437 R501 R502 R503 1-216-827-11 1-216-815-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 3.3K 330 100 100 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 69 RCD-W1 BD Ref. No. BD-R Part No. Description Remark R504 1-216-815-11 METAL CHIP 330 5% 1/16W R505 R506 R507 R508 R509 1-216-815-11 1-216-815-11 1-216-809-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 330 330 100 100 100 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R510 R511 R512 R513 R514 1-216-809-11 1-216-833-11 1-216-815-11 1-216-815-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 10K 330 330 1K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R515 R516 R517 R518 R519 1-216-821-11 1-216-821-11 1-216-821-11 1-216-815-11 1-216-815-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 1K 1K 330 330 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R520 R521 R522 R523 R524 1-216-821-11 1-216-821-11 1-216-827-11 1-216-833-11 1-216-817-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 1K 3.3K 10K 470 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R525 R526 R527 R531 R532 1-216-838-11 1-216-844-11 1-216-833-11 1-216-864-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 27K 82K 10K 0 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R533 R535 R536 R537 R538 1-216-827-11 1-216-815-11 1-216-809-11 1-216-809-11 1-216-837-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 3.3K 330 100 100 22K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R539 R540 R541 R542 R543 1-216-833-11 1-216-833-11 1-216-817-11 1-216-817-11 1-216-815-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 10K 470 470 330 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R544 R545 R546 R547 R548 1-216-809-11 1-216-815-11 1-216-815-11 1-216-809-11 1-216-815-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 330 330 100 330 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R549 R550 R552 R554 R555 1-216-815-11 1-216-815-11 1-216-815-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 330 330 330 0 0 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R556 R557 R558 R561 R562 1-216-829-11 1-216-809-11 1-216-809-11 1-216-815-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 100 100 330 4.7K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R563 R564 R565 R566 R567 1-216-845-11 1-216-845-11 1-216-811-11 1-216-853-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100K 100K 150 470K 100 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R568 1-216-809-11 METAL CHIP 100 5% 1/16W Ref. No. Part No. Description R601 R602 R603 R604 1-216-829-11 1-216-809-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 100 100 100 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W R605 R606 R607 R609 R610 1-216-809-11 1-216-809-11 1-216-809-11 1-216-833-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 100 10K 0 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R611 1-216-864-11 METAL CHIP 0 5% 1/16W < SWITCH > 70 SW001 1-786-204-11 SWITCH, DETECTION (OPEN/LOADING) < VIBRATOR > X201 X501 1-795-349-11 VIBRATOR, CRYSTAL (33.8688MHz) 1-781-136-21 VIBRATOR, CERAMIC (20MHz) ****************************************************** A-4726-182-A BD-R BOARD, COMPLETE ******************* < CAPACITOR > C101 C102 C103 C105 C106 1-164-156-11 1-107-826-11 1-131-651-21 1-128-416-11 1-165-589-21 CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP ELECT CHIP ELECT 0.1uF 0.1uF 10uF 100uF 220uF C107 C108 C109 C110 C111 1-164-156-11 1-107-826-11 1-164-346-11 1-164-156-11 1-109-982-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 1uF 0.1uF 1uF C112 C113 C114 C201 C202 1-107-826-11 1-128-416-11 1-128-416-11 1-162-970-11 1-162-968-11 CERAMIC CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 100uF 100uF 0.01uF 0.0047uF C204 C206 C207 C208 C209 1-162-967-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 C210 C211 C212 C213 C214 10% 20% 20% 25V 16V 16V 16V 10% 25V 16V 16V 25V 10V 10% 20% 20% 10% 10% 16V 16V 16V 25V 50V CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.0033uF 10% 0.1uF 0.1uF 0.1uF 0.1uF 50V 25V 25V 25V 25V 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 25V 25V 25V 25V 25V C215 C216 C217 C218 C220 1-164-156-11 1-164-156-11 1-164-156-11 1-107-826-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 25V 25V 25V 16V 25V C221 C222 C223 C224 C225 1-127-688-21 1-107-826-11 1-115-416-11 1-162-968-11 1-107-826-11 TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10uF 0.1uF 0.001uF 0.0047uF 0.1uF 10% 10% 20% 10% 5% 10% 10% 6.3V 16V 25V 50V 16V RCD-W1 BD-R Ref. No. Part No. Description C226 C227 C228 C229 C232 1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 10% 10% 10% 10% 10% 16V 16V 16V 16V 16V Remark C235 C238 C239 C240 C241 1-107-826-11 1-107-826-11 1-127-688-21 1-107-826-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 10uF 0.1uF 0.1uF 10% 10% 20% 10% 10% 16V 16V 6.3V 16V 16V C242 C243 C301 C302 C303 1-107-826-11 1-127-688-21 1-165-319-11 1-165-319-11 1-163-038-00 CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 10uF 0.1uF 0.1uF 0.1uF 10% 20% 16V 6.3V 50V 50V 25V C304 C305 C306 C307 C308 1-163-038-00 1-163-038-00 1-163-038-00 1-165-319-11 1-163-038-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 25V 25V 25V 50V 25V C309 C310 C311 C312 C313 1-163-038-00 1-163-038-00 1-163-038-00 1-216-819-11 1-162-923-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP METAL CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 680 47PF 25V 25V 25V 1/16W 50V C314 C320 C321 C322 C323 1-162-923-11 1-127-861-11 1-165-319-11 1-127-861-11 1-163-038-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 47PF 2.2uF 0.1uF 2.2uF 0.1uF 5% 10% C325 C326 C327 C329 C330 1-216-820-11 1-131-651-21 1-163-038-00 1-163-038-00 1-127-861-11 METAL CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 820 10uF 0.1uF 0.1uF 2.2uF 5% 20% 10% 1/16W 16V 25V 25V 16V C331 C332 C333 C334 C335 1-162-970-11 1-162-970-11 1-165-591-21 1-165-592-21 1-127-861-11 CERAMIC CHIP CERAMIC CHIP CERAMIC (SMD) CERAMIC (SMD) CERAMIC CHIP 0.01uF 0.01uF 0.08uF 8200PF 2.2uF 10% 10% 25V 25V 10% 16V C336 C338 C339 C340 C344 1-165-319-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-918-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 100PF 100PF 100PF 18PF 5% 5% 5% 5% 50V 50V 50V 50V 50V C345 C346 C347 C348 C349 1-162-918-11 1-107-826-11 1-216-821-11 1-216-821-11 1-164-230-11 CERAMIC CHIP CERAMIC CHIP METAL CHIP METAL CHIP CERAMIC CHIP 18PF 0.1uF 1K 1K 220PF 5% 10% 5% 5% 5% 50V 16V 1/16W 1/16W 50V C350 C351 C355 C356 C401 1-164-230-11 1-164-230-11 1-216-810-11 1-164-156-11 1-162-966-11 CERAMIC CHIP CERAMIC CHIP METAL CHIP CERAMIC CHIP CERAMIC CHIP 220PF 220PF 120 0.1uF 0.0022uF 5% 5% 5% 50V 50V 1/16W 25V 50V C402 C403 1-164-677-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 0.033uF 0.1uF 10% 5% 5% 10% 10% 50V 16V 50V 16V 25V 16V 25V Ref. No. Part No. Description Remark C404 C405 C406 1-162-966-11 CERAMIC CHIP 1-164-489-11 CERAMIC CHIP 1-164-489-11 CERAMIC CHIP 0.0022uF 10% 0.22uF 10% 0.22uF 10% 50V 16V 16V C407 C408 C409 C410 C411 1-127-688-21 1-164-230-11 1-164-156-11 1-115-416-11 1-115-416-11 TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10uF 220PF 0.1uF 0.001uF 0.001uF 5% 5% 6.3V 50V 25V 25V 25V C412 C413 C414 C415 C416 1-164-156-11 1-164-156-11 1-164-156-11 1-127-688-21 1-127-688-21 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP TANTAL. CHIP 0.1uF 0.1uF 0.1uF 10uF 10uF 20% 20% 25V 25V 25V 6.3V 6.3V C417 C418 C419 C420 C421 1-164-156-11 1-165-319-11 1-165-319-11 1-164-156-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 10% 25V 50V 50V 25V 16V C422 C423 C424 C425 C426 1-164-156-11 1-164-156-11 1-110-501-11 1-110-501-11 1-110-501-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.33uF 0.33uF 0.33uF 10% 10% 10% 25V 25V 16V 16V 16V C427 C428 C429 C430 C431 1-164-245-11 1-164-156-11 1-107-823-11 1-162-970-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.015uF 0.1uF 0.47uF 0.01uF 0.1uF C432 C433 C434 C435 C437 1-107-826-11 1-164-156-11 1-164-217-11 1-107-826-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 150PF 0.1uF 0.1uF 10% 5% 10% 10% 16V 25V 50V 16V 16V C438 C439 C440 C441 C442 1-162-920-11 1-162-959-11 1-107-826-11 1-162-920-11 1-162-923-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 27PF 330PF 0.1uF 27PF 47PF 5% 5% 10% 5% 5% 50V 50V 16V 50V 50V C443 C445 C446 C447 C449 1-164-492-11 1-162-967-11 1-107-826-11 1-107-826-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.15uF 0.0033uF 0.1uF 0.1uF 0.1uF 10% 10% 10% 10% 16V 50V 16V 16V 25V C451 C453 C454 C455 C456 1-164-156-11 1-164-156-11 1-127-688-21 1-127-688-21 1-164-217-11 CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP TANTAL. CHIP CERAMIC CHIP 0.1uF 0.1uF 10uF 10uF 150PF C458 C459 C460 C461 C462 1-164-217-11 1-164-217-11 1-131-651-21 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP 150PF 150PF 10uF 0.1uF 0.1uF 5% 5% 20% 50V 50V 16V 25V 25V C463 C464 C466 C467 C468 1-131-651-21 1-164-156-11 1-107-826-11 1-127-688-21 1-109-982-11 TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP 10uF 0.1uF 0.1uF 10uF 1uF 20% 16V 25V 16V 6.3V 10V 20% 5% 10% 10% 10% 20% 20% 5% 10% 20% 10% 25V 25V 16V 25V 25V 25V 25V 6.3V 6.3V 50V 71 RCD-W1 BD-R Ref. No. Part No. Description C469 C470 C471 C473 C474 1-162-964-11 1-127-688-21 1-127-688-21 1-128-416-11 1-164-230-11 CERAMIC CHIP TANTAL. CHIP TANTAL. CHIP ELECT CHIP CERAMIC CHIP 0.001uF 10uF 10uF 100uF 220PF 10% 20% 20% 20% 5% 50V 6.3V 6.3V 16V 50V C475 C476 C477 C478 C479 1-162-912-11 1-107-826-11 1-107-826-11 1-162-908-11 1-162-908-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 7PF 0.1uF 0.1uF 3PF 3PF 0.5PF 10% 10% 0.25PF 0.25PF 50V 16V 16V 50V 50V C480 C481 C482 C501 C503 1-164-156-11 1-107-826-11 1-162-970-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.01uF 0.1uF 0.1uF C504 C505 C506 C507 C508 1-128-416-11 1-107-826-11 1-162-970-11 1-163-018-00 1-162-970-11 ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100uF 0.1uF 0.01uF 0.0056uF 0.01uF 20% 10% 10% 5% 10% 16V 16V 25V 50V 25V C509 C510 C511 C512 C513 1-162-970-11 1-163-018-00 1-107-826-11 1-164-156-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 0.0056uF 0.1uF 0.1uF 0.1uF 10% 5% 10% 25V 50V 16V 25V 16V C514 C515 C520 C521 C522 1-162-969-11 1-162-969-11 1-107-823-11 1-164-005-11 1-162-966-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.0068uF 0.0068uF 0.47uF 0.47uF 0.0022uF 10% 10% 10% C523 C524 C525 C528 C529 1-164-156-11 1-164-156-11 1-164-156-11 1-107-826-11 1-131-651-21 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP 0.1uF 0.1uF 0.1uF 0.1uF 10uF C530 C531 C533 C534 C535 1-107-826-11 1-164-346-11 1-128-416-11 1-107-826-11 1-109-982-11 CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 1uF 100uF 0.1uF 1uF 20% 10% 10% 16V 16V 16V 16V 10V C536 C537 C538 C540 C541 1-109-982-11 1-107-826-11 1-128-416-11 1-107-826-11 1-107-826-11 CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP 1uF 0.1uF 100uF 0.1uF 0.1uF 10% 10% 20% 10% 10% 10V 16V 16V 16V 16V C543 C544 C546 C548 C549 1-107-826-11 1-107-826-11 1-107-826-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 10% 10% 10% 16V 16V 16V 25V 25V C550 C551 C552 C553 C555 1-165-176-11 1-165-176-11 1-165-176-11 1-107-826-11 1-162-970-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.047uF 0.047uF 0.047uF 0.1uF 0.01uF 10% 10% 10% 10% 10% C557 C558 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 72 Remark 0.1uF 0.1uF 10% 10% 10% 25V 16V 25V 25V 25V 10% 25V 25V 16V 25V 50V 10% 20% 25V 25V 25V 16V 16V 10% 16V 16V 16V 16V 25V 25V 25V Ref. No. Part No. Description Remark C601 C602 C603 1-164-156-11 CERAMIC CHIP 1-164-156-11 CERAMIC CHIP 1-127-688-21 TANTAL. CHIP 0.1uF 0.1uF 10uF 20% 25V 25V 6.3V C604 C605 C606 C607 C608 1-127-688-21 1-216-813-11 1-162-913-11 1-162-970-11 1-162-970-11 TANTAL. CHIP METAL CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10uF 220 8PF 0.01uF 0.01uF 20% 5% 0.50PF 10% 10% 6.3V 1/16W 50V 25V 25V C609 C701 C702 C704 C705 1-127-688-21 1-164-156-11 1-162-927-11 1-164-156-11 1-162-917-11 TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10uF 0.1uF 100PF 0.1uF 15PF 20% 6.3V 25V 50V 25V 50V C706 C707 C708 C709 C710 1-162-917-11 1-164-156-11 1-164-156-11 1-162-970-11 1-162-970-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 15PF 0.1uF 0.1uF 0.01uF 0.01uF 5% C712 C713 C714 C715 C716 1-165-176-11 1-165-176-11 1-107-826-11 1-164-156-11 1-164-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.047uF 0.047uF 0.1uF 0.1uF 0.1uF 10% 10% 10% 16V 16V 16V 25V 25V C721 C722 C740 C741 C743 1-127-688-21 1-127-688-21 1-162-970-11 1-162-970-11 1-164-156-11 TANTAL. CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10uF 10uF 0.01uF 0.01uF 0.1uF 20% 20% 10% 10% 6.3V 6.3V 25V 25V 25V C750 C751 1-127-688-21 TANTAL. CHIP 1-127-688-21 TANTAL. CHIP 10uF 10uF 20% 20% 6.3V 6.3V 5% 5% 10% 10% 50V 25V 25V 25V 25V < CONNECTOR > CN102 CN401 CN501 CN502 * CN701 1-784-375-21 1-815-764-11 1-784-367-11 1-784-370-21 1-564-704-11 CONNECTOR, FFC/FPC 16P CONNECTOR, FFC 32P CONNECTOR, FFC/FPC 8P CONNECTOR, FFC/FPC 11P PIN, CONNECTOR (SMALL TYPE) 2P < JUMPER RESISTOR > CX32 CX33 CX34 1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP 0 0 0 < DIODE > D101 D401 D701 8-719-084-79 DIODE KDS187 8-719-084-78 DIODE KDS121 8-719-084-78 DIODE KDS121 < IC > IC101 IC102 IC103 IC201 IC203 6-700-342-01 8-759-476-20 8-759-458-10 6-700-349-01 8-759-486-65 IC IC IC IC IC XC61AN3002 BA033SFP-E2 BA3939-E2 OTI9790 GM71VS18163CLT-6 IC301 IC302 IC303 6-700-348-01 IC VC00S01 6-700-347-01 IC W2457AS-35 8-759-031-84 IC TC7S04F(TE85R) 5% 5% 5% 1/16W 1/16W 1/16W RCD-W1 BD-R Ref. No. Part No. Description Remark IC304 IC306 8-759-300-71 IC BU4053BCF 6-700-346-01 IC CS8420-CSR IC307 IC310 IC401 IC403 IC404 8-759-300-71 8-759-031-84 8-752-097-31 8-759-058-45 8-759-338-95 IC IC IC IC IC BU4053BCF TC7S04F CXA2551AR NJM3403AV NJM2903V(TE2) IC405 IC406 IC407 IC409 IC411 8-759-387-26 8-759-545-66 8-759-575-32 8-759-635-27 8-759-058-43 IC IC IC IC IC BU4052BCFV-E2 NJM3414M NC7SZ66P5X M62352GP-75E NJM3404AV IC412 IC413 IC414 IC501 IC502 8-759-082-58 8-759-350-97 8-759-575-32 8-759-679-08 8-759-536-49 IC IC IC IC IC TC7W08FU(TE12R) EL2245CS NC7SZ66P5X BA5983FM BA5925FV-E2 IC508 IC509 IC510 IC511 IC512 8-759-448-71 8-759-058-43 8-759-588-60 8-759-697-62 8-759-697-62 IC IC IC IC IC BU4053BCFV-E2 NJM3404AV BA6664FM-E2 NJM7808DL1A(TE1) NJM7808DL1A(TE1) IC514 IC601 IC701 IC702 8-759-545-66 6-700-341-01 6-800-235-01 8-759-466-52 IC IC IC IC NJM3414M CST0100C HD64F3062AFBL-CDR CAT93C86S-LE10 < COIL > L103 L202 L301 L302 L306 1-400-090-21 1-412-058-11 1-400-090-21 1-412-058-11 1-412-058-11 INDUCTOR INDUCTOR CHIP INDUCTOR INDUCTOR CHIP INDUCTOR CHIP 0uH 10uH 0uH 10uH 10uH L308 L401 L402 L403 L701 1-412-058-11 1-412-058-11 1-412-058-11 1-412-058-11 1-412-058-11 INDUCTOR CHIP INDUCTOR CHIP INDUCTOR CHIP INDUCTOR CHIP INDUCTOR CHIP 10uH 10uH 10uH 10uH 10uH Ref. No. Part No. Description R221 R227 R228 R229 1-216-833-11 1-216-864-11 1-216-812-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 0 180 100 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W Remark R230 R231 R234 R235 R236 1-216-809-11 1-414-229-11 1-216-835-11 1-216-830-11 1-216-821-11 METAL CHIP FERRITE METAL CHIP METAL CHIP METAL CHIP 100 0UH 15K 5.6K 1K 5% 1/16W 5% 5% 5% 1/16W 1/16W 1/16W R237 R238 R239 R240 R241 1-216-829-11 1-216-833-11 1-216-813-11 1-216-839-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 10K 220 33K 220 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R245 R250 R251 R252 R253 1-216-813-11 1-216-813-11 1-216-813-11 1-216-813-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 220 220 220 220 220 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R254 R255 R256 R257 R259 1-216-813-11 1-216-813-11 1-216-813-11 1-216-813-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 220 220 220 220 47K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R260 R261 R262 R263 R264 1-216-835-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 15K 0 0 0 0 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R265 R266 R267 R268 R269 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R270 R305 R306 R307 R308 1-164-156-11 1-162-926-11 1-216-813-11 1-216-813-11 1-216-813-11 CERAMIC CHIP CERAMIC CHIP METAL CHIP METAL CHIP METAL CHIP 0.1uF 82PF 220 220 220 5% 5% 5% 5% 25V 50V 1/16W 1/16W 1/16W R310 R320 R322 R323 R325 1-216-817-11 1-216-833-11 1-216-813-11 1-216-816-11 1-162-970-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP CERAMIC CHIP 470 10K 220 390 0.01uF 5% 5% 5% 5% 10% 1/16W 1/16W 1/16W 1/16W 25V R327 R335 R336 R337 R355 1-216-833-11 1-216-817-11 1-216-818-11 1-216-833-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 470 560 10K 47K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R364 R365 R366 R367 R368 1-216-813-11 1-216-813-11 1-216-815-11 1-216-821-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 220 220 330 1K 100 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R369 R370 R371 R373 1-216-809-11 1-216-809-11 1-216-829-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 4.7K 220 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W < CONNECTOR > PN105 PN201 PN605 1-815-765-11 SOCKET, CONNECTOR 6P 1-815-765-11 SOCKET, CONNECTOR 6P 1-784-383-21 CONNECTOR, FFC/FPC 26P < TRANSISTOR > Q401 Q402 Q403 Q404 Q405 1-801-806-11 1-801-806-11 1-801-806-11 1-801-806-11 1-801-806-11 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTC144EKA DTC144EKA DTC144EKA DTC144EKA DTC144EKA < RESISTOR > R101 R102 R103 R104 R219 1-216-838-11 1-216-844-11 1-216-833-11 1-216-864-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 27K 82K 10K 0 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R220 1-216-833-11 METAL CHIP 10K 5% 1/16W 73 RCD-W1 BD-R Ref. No. Part No. Description Remark R374 1-216-813-11 METAL CHIP 220 5% 1/16W R375 R376 R377 R378 R380 1-216-815-11 1-216-813-11 1-216-813-11 1-216-813-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 330 220 220 220 220 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R382 R385 R386 R387 R388 1-216-819-11 1-216-864-11 1-216-857-11 1-216-813-11 1-414-229-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP FERRITE 680 0 1M 220 0UH 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W R390 R401 R403 R404 R405 1-216-864-11 1-216-864-11 1-216-864-11 1-216-821-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 1K 100 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R406 R407 R409 R410 R411 1-216-838-11 1-216-838-11 1-216-809-11 1-216-843-11 1-216-843-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 27K 27K 100 68K 68K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R413 R414 R415 R416 R417 1-216-857-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1M 10K 10K 10K 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R418 R419 R420 R422 R423 1-216-835-11 1-216-830-11 1-216-821-11 1-216-827-11 1-216-839-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 15K 5.6K 1K 3.3K 33K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R424 R425 R426 R427 R428 1-216-835-11 1-216-827-11 1-216-839-11 1-216-841-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 15K 3.3K 33K 47K 0 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R429 R430 R431 R432 R433 1-216-833-11 1-216-864-11 1-216-841-11 1-216-841-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 0 47K 47K 47K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R434 R435 R436 R437 R438 1-216-864-11 1-216-821-11 1-216-821-11 1-216-839-11 1-216-837-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 1K 1K 33K 22K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R441 R442 R445 R446 R448 1-216-851-11 1-216-817-11 1-216-827-11 1-216-864-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 330K 470 3.3K 0 1K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R449 R451 R452 R453 R454 1-216-864-11 1-216-815-11 1-216-822-11 1-216-827-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 330 1.2K 3.3K 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R455 1-216-817-11 METAL CHIP 470 5% 1/16W 74 Ref. No. Part No. Description R456 R457 R458 R460 1-216-825-11 1-216-819-11 1-216-833-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 2.2K 680 10K 47K 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W R465 R466 R467 R469 R471 1-216-819-11 1-216-824-11 1-216-821-11 1-216-824-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 1.8K 1K 1.8K 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R472 R473 R474 R475 R476 1-216-837-11 1-216-821-11 1-216-833-11 1-216-844-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 1K 10K 82K 4.7K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R477 R481 R483 R487 R488 1-216-864-11 1-216-819-11 1-216-821-11 1-216-837-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 680 1K 22K 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R489 R490 R492 R493 R494 1-216-857-11 1-216-829-11 1-216-864-11 1-216-819-11 1-216-819-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1M 4.7K 0 680 680 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R495 R496 R497 R502 R503 1-216-821-11 1-216-819-11 1-216-819-11 1-216-809-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 680 680 100 0 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R508 R515 R516 R517 R518 1-216-833-11 1-216-821-11 1-216-833-11 1-216-825-11 1-216-844-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 1K 10K 2.2K 82K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R519 R520 R521 R522 R523 1-216-831-11 1-216-845-11 1-216-840-11 1-216-851-11 1-216-845-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 6.8K 100K 39K 330K 100K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R524 R525 R553 R554 R556 1-216-840-11 1-216-853-11 1-216-809-11 1-216-809-11 1-216-843-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 39K 470K 100 100 68K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R557 R558 R560 R563 R564 1-216-850-11 1-216-845-11 1-216-864-11 1-217-907-11 1-217-907-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 270K 100K 0 1.8 1.8 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/10W 1/10W R565 R567 R568 R569 R570 1-217-907-11 1-216-848-11 1-216-845-11 1-216-841-11 1-216-864-11 RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1.8 180K 100K 47K 0 5% 5% 5% 5% 5% 1/10W 1/16W 1/16W 1/16W 1/16W R572 R573 R574 1-216-837-11 METAL CHIP 1-216-838-11 METAL CHIP 1-216-797-11 METAL CHIP 22K 27K 10 5% 5% 5% 1/16W 1/16W 1/16W RCD-W1 FL BD-R Ref. No. Part No. Description Remark R575 R576 1-216-837-11 METAL CHIP 1-216-797-11 METAL CHIP 22K 10 5% 5% 1/16W 1/16W R577 R578 R579 R580 R581 1-216-837-11 1-216-838-11 1-216-837-11 1-216-797-11 1-216-797-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 22K 27K 22K 10 10 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R582 R583 R584 R585 R586 1-216-833-11 1-216-833-11 1-216-831-11 1-216-833-11 1-216-829-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 10K 6.8K 10K 4.7K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R587 R590 R592 R601 R602 1-216-833-11 1-216-833-11 1-216-853-11 1-216-813-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 10K 470K 220 220 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R603 R604 R605 R607 R608 1-216-813-11 1-216-813-11 1-216-813-11 1-216-815-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 220 220 220 330 220 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R609 R610 R611 R612 R613 1-216-812-11 1-216-815-11 1-216-864-11 1-216-813-11 1-216-813-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 180 330 0 220 220 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R619 R620 R627 R701 R702 1-216-813-11 1-216-813-11 1-216-864-11 1-216-811-11 1-216-853-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 220 220 0 150 470K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R703 R704 R705 R706 R707 1-216-805-11 1-216-805-11 1-216-805-11 1-216-805-11 1-216-805-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47 47 47 47 47 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R708 R709 R710 R711 R712 1-216-805-11 1-216-805-11 1-216-805-11 1-216-805-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47 47 47 47 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R713 R714 R715 R716 R717 1-216-809-11 1-216-809-11 1-216-833-11 1-216-821-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 10K 1K 1K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R718 R719 R720 R721 R726 1-216-829-11 1-216-809-11 1-216-809-11 1-216-805-11 1-216-825-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 100 100 47 2.2K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R727 R728 R729 R738 R740 1-216-825-11 1-216-833-11 1-216-833-11 1-216-809-11 1-216-817-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 2.2K 10K 10K 100 470 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W Ref. No. Part No. Description Remark R741 R742 R743 R744 R745 1-216-833-11 1-216-817-11 1-216-833-11 1-216-809-11 1-216-809-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 470 10K 100 100 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R746 R747 R748 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP 100 100 100 5% 5% 5% 1/16W 1/16W 1/16W < NETWORK RESISTOR > RA301 RA302 RA303 RA304 RA305 1-239-416-11 1-239-416-11 1-239-416-11 1-239-416-11 1-239-416-11 NETWORK RESISTOR (CHIP) 220 NETWORK RESISTOR (CHIP) 220 NETWORK RESISTOR (CHIP) 220 NETWORK RESISTOR (CHIP) 220 NETWORK RESISTOR (CHIP) 220 RA306 RA701 RA702 1-239-416-11 NETWORK RESISTOR (CHIP) 220 1-239-416-11 NETWORK RESISTOR (CHIP) 220 1-239-416-11 NETWORK RESISTOR (CHIP) 220 < SWITCH > SW701 1-786-204-11 SWITCH, DETECTION (OPEN/LOADING) < VIBRATOR > X301 X701 1-795-349-11 VIBRATOR, CRYSTAL (33.8688MHz) 1-781-136-21 VIBRATOR, CERAMIC (20MHz) ****************************************************** A-4726-179-A FL BOARD, COMPLETE ***************** < CAPACITOR > C801 C802 C804 C805 C806 1-164-159-11 1-164-159-11 1-126-933-11 1-161-494-00 1-161-494-00 CERAMIC CERAMIC ELECT CERAMIC CERAMIC 0.1uF 0.1uF 100uF 0.022uF 0.022uF C807 C810 C811 C812 C813 1-161-494-00 1-164-159-11 1-162-282-31 1-162-282-31 1-162-282-31 CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC 0.022uF 0.1uF 100PF 100PF 100PF C816 C817 C818 C820 C821 1-162-211-31 1-162-211-31 1-164-159-11 1-164-159-11 1-164-159-11 CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC 33PF 33PF 0.1uF 0.1uF 0.1uF C822 C823 C826 1-164-159-11 CERAMIC 1-164-159-11 CERAMIC 1-164-159-11 CERAMIC 0.1uF 0.1uF 0.1uF 20% 10% 10% 10% 5% 5% 50V 50V 16V 25V 25V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V < CONNECTOR > * CN803 1-695-823-11 CONNECTOR, BOARD TO BOARD 8P < FLUORESCENT DISPLAY > FLD801 1-518-766-11 INDICATOR TUBE, FLUORESCENT 75 RCD-W1 FL HP Ref. No. Part No. POWER Description Remark Ref. No. Part No. < IC > IC801 IC802 Description Remark < VIBRATOR > 6-800-228-01 IC uPD780232GC-LG1 8-759-971-11 IC KIA7042P-TP X801 1-795-348-11 VIBRATOR, CRYSTAL (5MHz) ****************************************************** < RESISTOR > A-4726-177-A HP BOARD, COMPLETE ***************** R803 R804 R807 R808 R809 1-247-843-11 1-249-424-11 1-249-420-11 1-249-422-11 1-247-843-11 CARBON CARBON CARBON CARBON CARBON 3.3K 3.9K 1.8K 2.7K 3.3K 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W F 1/4W F 1/4W R810 R811 R812 R813 R814 1-249-424-11 1-249-426-11 1-249-428-11 1-249-420-11 1-249-422-11 CARBON CARBON CARBON CARBON CARBON 3.9K 5.6K 8.2K 1.8K 2.7K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W F F F 0 PN902 R815 R816 R817 R818 R819 1-247-843-11 1-249-424-11 1-249-426-11 1-249-428-11 1-249-431-11 CARBON CARBON CARBON CARBON CARBON 3.3K 3.9K 5.6K 8.2K 15K 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W 1/4W F 1/4W 0 PW801 < JACK > JK802 1-815-702-11 JACK (LARGE TYPE) (PHONES) < CONNECTOR > F * PN804 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P 1-815-703-11 PIN, CONNECTOR 2P < SWITCH > 1-771-757-12 SWITCH, PUSH (1 KEY) (POWER) < VARIABLE RESISTOR > VR801 1-227-425-11 RES, VAR 50K/50K (PHONE LEVEL) ****************************************************** R820 R821 R822 R833 R834 1-249-432-11 1-249-432-11 1-249-432-11 1-247-807-31 1-247-843-11 CARBON CARBON CARBON CARBON CARBON 18K 18K 18K 100 3.3K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R841 R842 R843 R844 R845 1-249-425-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 4.7K 1K 1K 1K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R846 R847 R848 R849 R850 R851 1-249-425-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 CARBON CARBON CARBON CARBON CARBON CARBON 4.7K 47K 47K 47K 47K 47K 5% 5% 5% 5% 5% 5% 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W * * A-4727-517-A POWER BOARD, COMPLETE (E,MX) A-4735-112-A POWER BOARD, COMPLETE (US,CND) ***************************** Note: The parts not described here are not supplied for service. F F F F F < INFRARED RECEIVER > < CAPACITOR > 0 C903 1-165-878-11 ELECT 150uF 20% 0 C903 1-165-879-11 ELECT 100uF 20% < COIL > 0 BC901 1-400-104-11 INDUCTOR < BRIDGE DIODE > 0 BD901 8-719-510-06 DIODE S1WB60 RMC801 8-749-016-29 IC RPM6938 < DIODE > < SWITCH > SW803 SW804 SW808 SW810 SW811 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 SWITCH, KEYBOARD (AMS .) SWITCH, KEYBOARD (AMS > ) SWITCH, KEYBOARD (CD SYNCHRO HIGH) SWITCH, KEYBOARD (INPUT) SWITCH, KEYBOARD (CD SYNCHRO NORMAL) SW812 SW813 SW814 SW815 SW816 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 SWITCH, KEYBOARD (ERASE) SWITCH, KEYBOARD (FINALIZE) SWITCH, KEYBOARD (TIME) SWITCH, KEYBOARD (OPEN/CLOSE A ) SWITCH, KEYBOARD (TIME) SW817 SW818 SW819 SW820 SW821 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 SWITCH, KEYBOARD (AMS .) SWITCH, KEYBOARD (AMS > ) SWITCH, KEYBOARD (RELAY) SWITCH, KEYBOARD ( X ) SWITCH, KEYBOARD ( G ) SW822 1-762-875-21 SWITCH, KEYBOARD ( x ) 0 D902 D906 D907 D908 D909 D910 D920 8-719-085-16 8-719-085-15 8-719-085-16 8-719-085-16 8-719-085-17 DIODE DIODE DIODE DIODE DIODE EU01W RU3YXLF-C1 EU01W EU01W B10A45V1 8-719-085-16 DIODE EU01W 8-719-085-16 DIODE EU01W < FUSE > 0 F901 1-576-533-11 FUSE T1.6A 250V < IC > 76 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. 0UH Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. 0 IC901 0 IC902 IC904 IC905 IC906 IC907 6-700-520-01 6-700-521-01 6-700-522-01 8-759-189-48 6-700-523-01 IC IC IC IC IC STR-G6153T PS2561-1-V KIA431 KA78R12TU KA7912 8-759-347-19 IC KIA7812PI 250V (US,CND) 400V (E,MX) RCD-W1 POWER Ref. No. Part No. Description VOL Remark < RESISTOR > 0 R901 1-244-389-11 RES, MATEL PLATE 2.7 < TRANSFORMER > 0T901 1-437-598-11 TRANSFORMER,POWER < ZENNER DIODE > ZD901 8-719-109-85 DIODE MTZJ-5.1B ****************************************************** A-4726-178-A VOL BOARD, COMPLETE ****************** < CONNECTOR > * PN803 1-695-822-11 CONNECTOR, BOARD TO BOARD 8P < RESISTOR > R801 R802 R805 R806 1-249-420-11 1-249-422-11 1-249-426-11 1-249-428-11 CARBON CARBON CARBON CARBON 1.8K 2.7K 5.6K 8.2K 5% 5% 5% 5% 1/4W F 1/4W F 1/4W 1/4W F < SWITCH > SW801 SW802 SW805 SW806 SW807 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 SWITCH, KEYBOARD (OPEN/CLOSE A ) SWITCH, KEYBOARD (REC z ) SWITCH, KEYBOARD ( X ) SWITCH, KEYBOARD ( G ) SWITCH, KEYBOARD ( x ) < VARIABLE RESISTOR > VR802 1-223-799-11 RES, VAR, CARBON 20K/20K (REC LEVEL) ****************************************************** MISCELLANEOUS ************* 57 58 0 61 0 61 0 111 1-823-105-11 1-823-104-11 1-823-044-11 1-823-333-11 1-476-791-11 WIRE (FLAT TYPE) (16 CORE) WIRE (FLAT TYPE) (26 CORE) CORD, POWER (CND,US) CORD, POWER (E,MX) PICK-UP BLOCK 112 0 162 167 179 FLD801 1-823-045-11 1-476-792-11 1-823-046-11 1-823-103-11 1-518-766-11 WIRE (FLAT TYPE) (17 CORE) OPTICAL PICK-UP (CD-R) WIRE (FLAT TYPE) (32 CORE) WIRE (FLAT TYPE) 8P INDICATOR TUBE, FLUORESCENT ****************************************************** ACCESSORIES & PACKING MATERIALS **************************** 1-476-514-11 REMOTE COMMANDER (RM-R50) 4-228-696-01 COVER, BATTERY (FOR RM-R50) 4-235-461-41 MANUAL ASSY, OWNERS (ENGLISH,FRENCH)(CND) 4-235-463-01 MANUAL ASSY, OWNERS (ENGLISH) (US) 4-235-463-11 MANUAL ASSY, OWNERS (SPANISH) (MX) 4-235-463-21 MANUAL ASSY, OWNERS (ENGLISH,SPANISH)(E) Supply the owner's manual assy that is for all destination as a set only for service. ****************************************************** The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. 77 RCD-W1 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2000. 12 New 1.1 2001.04 SUPPLEMENT-1: Circuit board Location, Block Diagram, Schematic Diagram, IC Pin Function, Exploded View and Electrical Parts List are added. 1.2 2001.08 Addition of Servicing note, Disassembly, Electrical Adjustment and Printed Wiring Boards. Change of Block Diagram, Schematical Diagram, IC Pin Function, Exploded View and Electrical Parts List. 1.3 2002.11 Change of IC201. (SPM-02102)