Transcript
SERVICE
3 I0100014
IPL, LT 15, 2001-01, 106 26 85-61 J8F1542J
LT15 Spare parts Ersatzteile Pièces détachées Reserve onderdelen Repuestos Reservdelar
106 26 85-61
TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 SCHEMATIC
RED
BLACK
BATTERY
RED
A
RED
FUSE
AMMETER (OPTIONAL)
M STARTER BLACK
WHITE
SOLENOID RED
B
S
G
BLACK
L
M
CLUTCH / BRAKE (PEDAL UP)
A1 A2
WHITE
SEAT SWITCH (NOT OCCUPIED)
IGNITION SWITCH
WHITE
BLACK
BLACK
BLACK BLACK
HOUR METER
ATT'MENT CLUTCH (CLUTCH OFF)
GROUNDING CONNECTOR
(OPTIONAL)
BLUE
SPARK PLUG GAP (2 PLUGS ON TWIN CYL. ENGINES)
IGNITION UNIT
BLACK
FUEL LINE
CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM
FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) ORANGE
BLACK
28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
RED LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 RPM
DIODE
ALTERNATOR
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)
NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST.
BLACK
BROWN
HEADLIGHTS
NON-REMOVABLE CONNECTIONS
IGNITION SWITCH POSITION
CIRCUIT
OFF M+G+A1 RUN/LIGHT B+A1 RUN START
B+A1 B + S + A1
“MAKE” NONE A2+L NONE NONE
REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 ELECTRICAL
22 21
42 24
41
43 27
27 40
26
27
27
25 16
16 33
30
48
52 8
29 27
2 1
28
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 ELECTRICAL
KEY NO.
PART NO.
DESCRIPTION
1 2 8 16 21 22 24 25 26 27 28 29 30 33 40 41 42 43 48 52
532144925 874760412 532156417 532153664 532166182 532004152 532124780 532146147 532175158 873510400 532124773 532121305 532175566 532140401 532170217 871110408 532131563 532175141 532140844 532141940
Battery 12 Volt 25 AMP Bolt Hex Hd 1/4-20unc X 3/4 Case Battery Mech Hinge Switch Interlock Push-In Harness Asm Light W/4152j Bulb Light #1156 Cable Battery 6 Ga 11" red Cable Battery 6 Ga 44" red w/16 wire Fuse Nut Keps Hex 1/4-20 Unc Cable Ground 6 Ga 12" black Switch Plunger Nc Gray Switch Ign Key Ign Molded Generic Harness Ign. Bolt Blk Fin Hex 1/4 - 20 x 1/2 Cover Terminal Red Solenoid Adapter Ammeter Rectangular Protection Wire Loop
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm.
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 CHASSIS AND ENCLOSURES
29 212
17
60
18
28 60
30 12
53
51 52
5
31
55 5
3
57
208 9 208
11 208
207 20
23
54
207 64
207
1
144 3
60
3
13
26 25 26 143
142 115
144 26 25 26
10 142 3
114
145
37 3
37
211 3
2
208
14
74 14
206
3
38
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 CHASSIS AND ENCLOSURES
KEY NO.
PART NO.
DESCRIPTION
1 2 3 5 9 10 11 12 13 14 17 18 20 23 25 26 28 29 30 31 37 38 51 52 53 54 55 57 60 64 74 114 115 142 143 144 145 206 207 208 211 212 --
532174619 532176554 817060612 532155272 532172151 872140608 532155927 532145660 532172108 817490608 532150760 532126938 532156437 532124028 819131312 873800600 532169509 532166603 532172157 532139976 817490508 532169834 873800400 819091416 532145201 532161464 532145202 874780412 872140606 532154798 873680600 532158112 817060620 532165867 532154966 532154207 532156524 532170165 817670508 817670608 532145212 532165919 532005479
Chassis Stamping Drawbar Screw 3/8-16x3/4 Bumper Hood/Dash Dash P/L Bolt Carriage 3/8-16 x 1 Panel Dash Lh Clip Tinnerman Grille P/L Panel Dash Rh Screw Thdrol 3/8-16 x 1/2 Hood LT/PL with Louvers Bumper Hood Plate Mtg Battery Fuel Tank Fr Bushing Washer 13/32 X 13/16 X 12 Ga Nut Lock Hex W/Ins 3/8-16 Unc Grille/Lens asm Lens LT/PL Grille Shark Plain Fender Footrest Bracket Support Fender Screw Thdrol 6/16-18 x 1/2 TYT Bracket Asm Pivot Mower Rear Nut Lock Hex W/Ins 1/4-20 Washer 9/32 x 7/8 x 16 Ga. Bracket Pnt. Pickoff LH Screw Hex Wshd 8-18 x 7/8 Bracket Grille Pickoff RH Bolt Hex 1/4-20 x 3/4 Bolt Rdhd Sqnk 3/8-16unc x 3/4 Dash Lower STLT Nut Crownlock 3/8-16 UNC Keeper Belt Rear LH Stl P930 Screw 3/8-16 x 1-1/4 Plate Reinforcement STLT Bracket Swaybar Chassis Bracket Pnt Footrest STLT Rod Pivot Chassis/Hood Bolt Shoulder 5/16-18 TT Screw Thdrol 5/16-18 x 1/2 Screw Thdrol 3/18-16 x 1/2 Nut Hexflange Lock Insert Lens Reflective Plug Button
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 DRIVE
57 51
89
90 63 197
212
81 59
84 198 161
70 66
159 158
61 65
162 56
21
85
164
169
10
13 14
168
163
112 80
18 113
4
8
42 40
82
3
85
165
51
166 156
5
11 79 52 30 32 170
202
50
150
38
48
42 18
16
55
64
41
83
14
151 51
27
39
6
49 32
30
47
6 52
6
62 35 36
77
120
37 34
25 19
28
24
36
77 96 26
74 78
1 75
35 53
2
145
116
76
29
22
26
27
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 DRIVE
KEY NO.
PART NO.
1
--------
2 3 4 5 6 8 10 11 13 14 16 18 19 21 22 24 25 26 27 28 29 30 32 34 35 36 37 38 39 40 41 42 47 48 49 50 51 52 53 55 56 57 59 61
532146682 532123666 812000028 532121520 817060512 532165866 876020416 532105701 874550412 810040400 873800500 874780616 873800600 532130564 532130804 873350600 532106888 819131316 876020412 532175765 532071673 532169592 874760512 532175578 532120183 819211616 532124963 532165936 874760648 532175461 532175556 819131312 532127783 532154407 532123205 874760624 873680600 873680500 532105710 532105709 817060616 532130801 532169691 817060612
DESCRIPTION Transaxle Peerless 206-545C (Order parts from transaxle manufacturer) Spring Return Brake T/a Zinc Pulley Transaxle 18"tires Ring Retainer # 5100-62 Strap Torque 30 Degrees Screw 5/16-18 X 3/4 Rod Shifter Pin Cotter 1/8 X 1 Cad Washer Plate Shf 388 Sq Hole Bolt 1/4-28 Unf Gr 8 W/Patch Washer Lock Hvy Helical 1/4 Nut Lock Hx W/Ins 5/16-18 Unc Bolt Fin Hex 3/8-16 UNC x `1 Gr. 5 Nut Lock 3/8-16 Unc Knob Deluxe 1/2-13 Unc Blk/Red Rod Brake Blk Zinc 26 840 Nut Hex Jam 3/8-16 Unc Spring Rod Brake 2 00 Zinc Washer 13/32 X 13/16 X 16 Ga Pin Cotter 1/8 X 3/4 Cad Rod Brake Parking LT/YT Cap Brake Parking Black Bracket Mtg Transaxle Bolt Hex Hd 5/16-18unc X 3/4 Shaft Asm Pedal Foot Bearing Nylon Blk 629 Id Washer 21/32 X 1 X 16 Ga Pin Roll 3/16 X 1" Pulley Composite Flat Bolt Fin Hex 3/8-16 Unc x 3 Spacer Split Keeper Belt Idler Washer 13/32 X 13/16 X 12 Ga Pulley Idler V Groove Plastic Bellcrank Clutch Grnd Drw STL Retainer Belt Style Spring Bolt Hex Hd 3/8-16unc X 1-1/2 Nut Crownlock 3/8-16 Unc Nut Crownlock 5/16-18 Unc Link Clutch 7 66 Spring Return Clutch 6 75 Screw 3/8-16 X 1.0 V-Belt Ground Drive 95 25 42" Keeper Belt Span Ctr Screw 3/8-16x3/4
KEY NO.
PART NO.
DESCRIPTION
62 63 64 65 66 70 74 75 76 77 78 79 80 81 82 83 84 85 89 90 96 112 113 116 120 145 150 151 156 158 159 161 162 163 164 165 166 168 169 170 197 198 202 212
532124872 532175410 871170764 810040700 532154778 532134683 532137057 532121749 812000001 532123583 532121748 532125096 532145090 532165592 532165711 819171216 532166231 532150360 532166556 532124346 532124788 819091210 532127285 872140608 873900600 874490540 532175456 819133210 532166002 532165589 532165494 872140406 873680400 874780416 819091010 532165623 532166880 532165492 532165580 532173898 532169613 532169593 872110612 532145212
Cover Pedal Engine Pulley Bolt Hex 7/16-20 x 4 Washer Lock Hvy Hlcl Spr 7/16 Keeper Belt Engine F-Proof Guide Belt Mower Drive RH Spacer Axle Washer 25/32 X 1 1/4 X 16 Ga E-ring #5133-75 Key Square 2 0 X 1845/ 1865 Washer 25/32 X 1-5/8 X 16 Ga Key Woodruff Arm Shift Transaxle Shaft Asm Cross Spring Torsion T/a Washer 17/32 X 3/4 X 16 Ga Link Transaxle Nut Nylock 1/4 - 28 Console Shift 6sp Nut Self-thd Wsh-hd 1/4 Zinc Retainer Spring 1" Zinc/Cad Washer 9/32 x 3/4 x 10 Ga. Strap Torque Lt Bolt Rd Sq Neck 3/8-16 x 1 Nut Lock Flg 3/8-16 Bolt Hex 5/16-18FLGHD Spacer Retainer Washer 13/32 x 2 x 10 Ga. Washer Srrted 5/16 ID x 1 .125 Bracket Shift Mount Hub Tapered Flange Shift LT Bolt Rdhd Sqnk 1/4-20 x 3/4 Gr 5 Nut Crownlock 1/4-20 Unc Bolt Hex Fin 1/4-20 Unc x 1 Gr. 5 Washer 5/8 x .281 x 10 Ga. Bracket Pivot Lever Screw 5/16-18 x 5/8 Bolt Shoulder 5/16-18 x .561 Plate Fastening LT Keeper Belt Transaxle Nyliner Snap-In 5/8" ID Washer Nyl 7/8 ID x .105" Bolt Carr Sh 3/8-16 x 1-1/2 Gr 5 Nut Hex Flg Lock
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 STEERING ASSEMBLY
38 63 11 39
1
41
42 37 37 36
44 51
54
88
91 43
71
68
67
67
29 46
29
8
47
6 9
17
67 13 65
46
85
2
8 7
85
6 9
9 5
47 7
3
32
9 5
68
11
82
29
26
4 43
15
40 15
43
29
28 15
10 30
6 8
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 STEERING ASSEMBLY
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 13 15 17 26 28 29 30 32 36 37 38 39 40 41 42 43 44 46 47 51 54 63 65 67 68 71 82 85 88 91
532172092 532154427 532169840 532169839 532124931 532121748 819272016 812000029 532124937 532175121 810040600 532136518 532145212 532177876 532126847 819131416 817060612 876020412 532130465 532155099 532152927 532172093 819132411 532124701 532159945 532169633 532121749 532153720 532121232 532124836 873800500 874780520 874780616 532160367 872140618 532169827 532175146 532169835 532133835 532175118 532175553
Wheel Steering Axle Asm STMP Dropped STL Spindle Asm LH Spindle Asm RH Bearing Race Thrust Harden Washer 25/32 X 1-5/8 X 16 Ga Washer 27/32 X 1-1/4 X 16 Ga Ring Klip #t5304-75 Bearing Col Strg Blk Link Drag Washer Lock Hvy Hlcl Spr 3/8 Spacer Brg Axle Front Nut Hex Flange Lock Shaft Asm Strg Bushing Link Drag Washer 13/32 X 7/8 X 16ga. Screw 3/8-16x3/4 Pin Cotter 1/8 X 3/4 Cad. Rod Tie Bushing Strg Screw Insert Cap Strg Wh Washer 13/32 X 1-1/20 x 11 Ga Lock nut Adaptor Wheel Strg Boot Steering Shaft Washer 25/32 X 1 1/4 X 16 Ga Extension Steering Shaft LR/LT Cap Spindle Fr Top Blk Fitting Grease Nut Lock Hex w/Ins 5/16-18 Bolt Fin Hex 5/16-18 Unc x 1-1/4 Bolt Fin Hex 3/8-16unc x 1 Gr. 5 Spacer Brace Axle Bolt Rdhd Sq 3/8-16 x 2-1/4 Axle, Brace Steering Asm Bracket Susp Chassis Front Fastner Christmas Tree Bolt Shoulder 7/16-20 Clip Steering
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm.
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 ENGINE
3
2
72 62
1
81
13
66
78 38 32
14 44
16 78
46
33 37 33
31 40
45 29 23
OPTIONAL EQUIPMENT Spark Arrester
4
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 ENGINE
KEY NO.
PART NO.
1 2 3
532170865 817720410 --------
4 13 14 16 23 29 31 32 33 37 38 40 44 45 46 62 66 72 78 81
532137352 532165291 532148456 811050600 532169837 532137180 532174642 532140527 532123487 532137040 532148315 532124028 817670412 817000612 819091416 810040500 532127951 871070512 817060620 873510400
DESCRIPTION Control Th/ch B&S EEC Flag Screw Hex Thd Cut 1/4-20x5/8 T Engine B&S Model No. 287707 Order parts from engine manufacturer Muffler LT B&S Gasket Tube Drain Oil Easy Washer Lock Ext Tooth 3/8 Shield Brn/Dbr Guard Kit Spark Arrestor (Flat Scrn) Tank Fuel Front 2 00 Cap Asm Fuel W/sym Vented Clamp Hose Black Line Fuel 20" Plug Drain Oil Easy Bushing Snap Nyl Blk Fuel Line Screw Hexwsh Thdrol 1/4-20x3/4 Screw Hexwsh Thdr 3/8-16 x 3/4 Washer 9/32 X 7/8 X 16 Ga Washer Lock Hvy Hlcl Spr 5/16 Stop Throttle 3000 RPM Screw Hexhd Cap 5/16-18x 3/4 Screw 3/8-16x1-1/4 Nut Keps Hex 1/4-20 Unc
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 SEAT ASSEMBLY 1 18
8 8
9 14
9
7
7
10
5 6 22 21
2 24 5
16 25 15 11 4 13 17
3
12
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 12
532140117 532140551 871110616 819131610 532145006 873800600 532124181 817000616 819131614 532174894 532166369 532121246
Seat Bracket Pivot Seat 8 720 Bolt Fin Hex 3/8-16unc X 1 Washer 13/32 X 1 X 10 Ga Clip Push-In Nut Hex w/Ins. 3/8-16 Unc Spring Seat Cprsn 2 250 Blk Zi Screw 3/8-16 X 1-1/2 Washer 13/32 X 1 X 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch
KEY NO.
PART NO.
DESCRIPTION
13 14 15 16 17 18 21 22 24 25
532121248 872050412 532134300 532121250 532123976 532124238 532171852 873800500 819171912 532127018
Bushing Snap Blk Nyl 50 Id Bolt Rdhd Sqnk 1/4-20x1-1/2 Spacer Split 28x96 Yel Zinc Spring Cprsn 1 327 Blk Pnt Nut Lock 1/4 Lge Flg Gr 5 Zinc Cap Spring Seat Bolt Shoulder 5/16-18 Unc Nut Hex Lock W/Ins 5/16-18 Washer 17/32 X 1-3/16 X 12 Ga. Bolt Shoulder 5/16-18 X 62
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 DECALS 3
9
11
11
7
4 10
20
2 16 8
1 13
13 6
5
14
15
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 13
532126187 532152262 532170691 532170692 532170846 532145437 532170565 532145494 532141761 532145498 532162927 532159736
Decal 100 DBA Decal Grille Jonsered Sweden Decal Hood RH Decal Hood LH Decal HP Engine Decal Europe Stand CE Decal, Ins. Strg Whl. Jons. Decal Mower Cutfinger Decal Fender Jonsered Decal Read Owner's Manual Syms. Decal Hood Insert Decal Chassis Hot Muffler
WHEELS & TIRES 1 2
5,8 4,10
7 3,9 6
11
KEY NO.
PART NO.
DESCRIPTION
14 15 16 20 -------
532160396 532159737 532140837 532145005 532171284 532171285 532138311 532162598 532176815 532176816
Decal V-Belt Schematic Decal Brake/Clutch Symbol Lt Decal Saddle Brake Parking Decal Bat Dan/Psn Pad Footrest LH STLT Pad Footrest RH STLT Decal Handle Lift Height Adjust Decal Drawbar Load Limit Manual Operator's (Euro.) Manual Operator's (Scan.)
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 --
532059192 532065139 532106222 532059904 532138336 532124957 532124959 532138337 532122082 532124926 532175039 532144334
Cap Valve Tire Stem Valve Tire F Ts 15 X 6 0 - 6 Service Tube Front (Service Item Only) Rim Asm 6"front Silver Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) Rim Asm 8"rear Silver Service Tire R Ts 20x10-8 C Service Tube Rear (Service Item Only) Cap Axle Blk 1 50 X 1 00 Sealant, Tire ( 10 oz. Tube)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 MOWER DECK 67
157 158
68 156 153
151
40 37 36 40
155
152
143
153 154
144
45 150
40
37
159 46
145 44 53
59
56 52 55 51
48
54
142 49 147 50
148
146 33 32 31
90 91
92
94
93
93 92 95
30 35 34
21 21
1 147
116
90
2 21
142 113 111 114
21
22 23
24
115
25 26
2
117
121
119 118
130
16 28
15 14
131
20 18
129 92
92
121
3 4
27
29
18
149
114
13 5
112
115
6
11118 19
21
10 9
119
8
113
117 116
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 MOWER DECK
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 8 9 10 11 13 14 15 16 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 40 44 45 46 48 49 50 51 52 53 54 55 56 59
532165892 872140506 532138017 532165460 532124670 532130832 532850857 810030600 532140296 532138498 532137645 532128774 532110485 532140329 872140505 532132827 532159770 873680500 532134753 532131267 532105304 532123713 532110452 532171859 819111016 532131491 532157722 532129963 532153535 532137266 872110614 532133835 532131494 819131316 873680600 532140088 532124788 532137729 532133944 532174284 532131340 532069180 532139888 532131845 532133943 532155046 532165723 532141043
Housing Asm Mower Bolt Rdhd Sqnk 5/16-18unc X3/4 Bracket Asm Fr Sway Bar 38/42 Bracket Asm Deck 42"sway Bar Retainer Spring Arm Suspension Rear Bolt 3/8-24x1 25 Gr8 Patched Washer Lock Hvy 3/8 Unplated Washer Hard Blade Mower Vented Blade Mower High Lift” Shaft Asm W/lower Bearing Housing Mandrel Vented(machd) Bearing Ball Mandrel Stripper Round Mower Bolt Carr 5/16-18 X 5/8 Bolt Shoulder Baffle Vortex Nut Crown Lock 5/16-18 Stiffener Bracket 42"deck Bracket Deflector Mower 42" Cap Sleeve 80x 112 Blk Mower Spring Torsion Deflector 2 52 Nut Push Phos & Oil Shield Deflector Washer 11/32 X 5/8 X 16 Ga Rod Hinge 42"6 75 Wlg Screw Thdrol Washer Head Washer Spacer Mower Vented Pulley Mandrel Nut 9/16top Lock Flng Cntr Bolt RDHD 3/8-16 UNC x 2-3/4 Gr.5 Fastner Christmas Tree Pulley Idler Flat 3 060 Washer 13/32 X 13/16 X 16 Ga Nut Lock 3/8-16 Unc Guard Mandrel LH Black Spring Retainer 1" Zinc/cad Screw Thdrol 1/4-20x5/8 Washer Hardened Samller Roller Asm Cam Follower 42" dec Bolt Shldr 10-24 Zinc Gr 5 42" Nut Lock #10-24 Unc Bolt Shoulder 5/16-18 Unc Blkz Arm Asm Pad Brake Washer Hardened Arm Idler 42"mower LT/YT Spacer Retainer Mower Guard, Bel
KEY NO.
PART NO.
67 68 90 91 92 93 94 95 111 112 113 114 115 116 117 118 119 121 129 130 131 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 --
532106932 532144959 874760616 532132274 873800600 819171416 532132264 532132273 532155197 532155198 817060514 873510500 872110504 532124842 532165746 873930600 819121414 532143723 819131312 874780616 872140608 532165890 532157109 532158634 532165888 532171977 532131335 532169022 532165898 819091216 532169670 532169676 532169674 532169675 532169671 532169672 532169669 817720410 872140614 532171491
--
532130794
DESCRIPTION Knob Rd 3/8-16 Plstc Thds Blk V-Belt Mower Bolt Fin Hex 3/8-16unc X 1 Bracket Asm Noseroller LH Nut Lock Hex w/ins. 3/8-16 UNC Washer 17/32 X 7/8 X 16 Ga Roller Nose 38 & 42 Bracket Asm Noseroller RH Bracket Gauge Wheel Lh Bracket Gauge Wheel Rh Screw Tapping 5/16-18 Unc Nut Keps 5/16-18 UNC Bolt Carriage 5/16-18unc x 1/2 Bolt Shoulder Wheel Gauge Nut Centerlock 3/8-16 UNC Washer 3/8 x 7/8 x 14 Ga. Bracket Extruded Gauge Wheel Washer 13/32 x 13/16 x 12 Ga. Bolt Fin Hex 3/8-16 UNC x 1 Gr. 5 Bolt Rdhd Sqnk 3/8-16 x 1 Arm Spring Brake Mower Bracket Arm Idler 42" Keeper Belt 42" Clutch Cable Pulley Idler Flat Bolt Carriage Idler Spring Extension Spring Return Idler Retainer Spring Yellow Washer 9/32 x 3/4 x 16 Ga. Bracket Clutch Cable Clutch Cable 42" Washer Flat 3/8" Type B Spring Retainer Spring Retention Lvr Cltch Cab Spacer Clutch Cable Rod Clutch Cable 3/8" Screw Hex Thd Cut 1/4-20 x 5/8 Bolt Rdhd Sqn 3/8-16 Unc x 1-3/4 Deck Serv 42" Vent (Standard Deck - Order Nose Roller and Gauge Wheel components separately Key Nos. 90-95 and 111-121) Mandrel Assembly (Includes Key Numbers 8-10, 12-15, 31 and 33)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 MOWER LIFT
29
28
27 25 24 23
7 41
8
49
37
5
38
30 3
40 36
1
50
13
26
4 6
6
11
5 2
4
12 13 19 13
20 15 31 32
13
19
20
17 18 20 16
20 15
31 32
REPAIR PARTS TRACTOR - MODEL NO. LT15 (J8F1542J), PRODUCT NO. 954 13 00-36 MOWER LIFT
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 11 12 13 15 16 17 18 19 20 23 24 25 26 27 28 29 30 31 32 36 37 38 40 41 49 50
532159460 532159471 532105767 812000002 819211621 532120183 532125631 532122365 532139865 532139866 532124670 532173288 873350800 532130171 873800800 532139868 532163552 532110807 819131016 532124874 532169484 532126971 873350600 532138057 532150233 532169865 873540600 532155097 532123935 817060516 819112410 532155098 532145212 532110452
Wire Asm Inner W/plunger Shaft Asm Lift RH Pin Groove 1 500 Zinc E Ring #5133-62 Washer 21/32 X 1 X 21 Ga Bearing Nylon Blk 629 Id Grip Handle Flute Blk. Button Plunger Link Lift LH Fixed Length Link Lift RH Fixed Length Retainer Spring Link Front Nut Jam Hex 1/2-13 Unc Trunnion Blk Zinc Nut Lock w/wsh 1/2-13 Unc Arm Suspension Rear Retainer Spring Nut Special Washer 13/32 X 5/8 X 16 Ga Spring 2-1/8" Retainer Clip Rod Adj Lift Zinc 7.49 Wrk Lg Nut Hex Jam 3/8-16 Unc Knob Inf 3/8-16 Unc Blk W/sym Trunnion Dp Stop Dbl Thds PLT Bearing Pvt Lift Nut Crownlock 3/8-24 Pointer Pnt Height ind .505 Plug Hole Blk 1.485/1.515 Dia. Screw 5/16-18 x 1 Washer 11/32 x 1-1/2 10 Ga. Scale Ind. Height Blk. Nut Hex Flange Lock Nut Push Phos & Oil
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
