Transcript
MODEL: RXV FREEDOM™ TYPE: ELECTRIC PERSONAL GOLF CAR MODEL YEAR: 2009 Part No:. 606602
PRODUCT SPECIFICATION CONFIGURATION HIGHLIGHTS Programmable AC Drive System: Factory programmable to application z Solid State variable frequency AC speed controller z Drive-by-wire electronic throttle control z Dash mounted direction selector switch (Forward-Neutral-Reverse) z Descent speed control and automatic hill hold z Full-time regenerative braking Motor: Battery Charger: Electrical System: Drive Train: Transaxle: Brakes: Body Protection:
z z z z z
230 Amp AC Controller Full torque, reduced speed reverse Sealed Hall effect throttle sensor Full diagnostic capability (Hand held diagnostic unit) Six field selectable speeds with hand held diagnostic unit
48 Volt AC induction motor, solid copper windings. 4.4 hp (3.3 kW) Continuous. AC system reads motor speed for accurate speed control in all conditions. Regenerative braking for maximum economy 48 VDC PowerWise™ High Frequency, 120/230 VAC 50/60 Hz. Underwriters Laboratories (U.L.) Listed, (C.S.A. Certified) 48 Volt DC, four, 12 volt deep cycle storage batteries batteries (60 minute minimum, 140 amp-hour @ 20 hr. discharge rate) Direct motor shaft connected to transaxle pinion shaft Differential with reverse helical gears Induction motor. Electro-magnetic parking brake is applied automatically 360° energy transfer bumpers maximize vehicle protection from minor impact
PRODUCT OVERVIEW Dimensions Overall Length Overall Width Overall Height (No Canopy) Overall Height (With Canopy) Wheel Base Front Wheel Track Rear Wheel Track Gnd Clearance @ Differential Vehicle Power Power Source Motor Type Horsepower (kW) Electrical System Batteries (Qty, Type) Key or Pedal Start Speed Controller Drive Train Transaxle Gear Selection Rear Axle Ratio Battery Charger
94.5 In (240 cm) 47.0 in (119 cm) 45.7 in (116 cm) 68.5 in (174 cm) 65.7 in (167 cm) 35.5 in (90 cm) 38.0 in (97 cm) 4.5 in (11 cm) 48 Volts DC 48 Volt AC 4.4 hp (3.3 kW) Continuous 48 Volt Four, 12 Volt Deep Cycle Pedal 235 Amp AC Controller Motor Shaft Direct Drive Limited Slip Differential Dash Mounted Forward-Neutral-Reverse 16.99:1
Performance Seating Capacity Dry Weight Curb Weight Vehicle load capacity Outside Clearance Circle Intersecting Aisle Clearance Speed (Level Ground) Towing Capacity Steering & Suspension Steering Front Suspension Rear Suspension Service Brake Parking Brake Front Tires Rear Tires Body & Chassis Frame Body & Finish Standard Color
2 Person 635 lb (290 kg) (Without Batteries) 935 lb (425 kg) 800 lb (360 kg) 19.2 ft (5.8 m) N/A 17.5 - 19.5 mph (28 - 31 kph) 3 E-Z-GO Golf Cars with approved tow bars Double Ended Rack & Pinion Independent A-Arm Coil Over Shock Mono-Leaf Springs With Hydraulic Shocks Induction Motor Automatic Electro-Magnetic Links 18 x 8.50 - 8 (4 Ply Rated) Links 18 x 8.50 - 8 (4 Ply Rated) Welded Steel. DuraShield™ powder coat Injection molded TPO (Thermoplastic Olefin) Forest Green
48 VDC PowerWise™ QE High Frequency UL/CSA Some items shown may be optional equipment
2009 Electric RXV Freedom GC Released: 7/21/2008 Revised:
Specifications are subject to change without notice * Field installed accessories may require installation charges
1 of 2
OPTIONS & FIELD INSTALLED ACCESSORIES (Installation not included)* Item TIRES & WHEELS: Front & Rear: Links 18 x 8.50 - 8 (4 Ply Rated) T Shot, 18 x 8.50 - 8 (4 Ply Rated) Tour Max 18 x 8.50 - 10 on Alloy Wheels USA Trail 18 x 8.50 - 8 (6 Ply Rated) Wheel Covers: Spoke, Platinum COLORS: Body Color (Forest Green) - Freedom Body Color (Black) - Freedom Body Color (Flame Red) - Freedom Body Color (Ivory) - Freedom Body Color (Molten Red) - Freedom Body Color (Patriot Blue) - Freedom Body Color (Steel Blue) - Freedom Body Color (White) - Freedom Body Color (Custom) - Freedom Cowl Color (Forest Green) - Electric Freedom Cowl Color (Black) - Electric Freedom Cowl Color (Flame Red) - Electric Freedom Cowl Color (Ivory) - Electric Freedom Cowl Color (Molten Red) - Electric Freedom Cowl Color (Patriot Blue) - Electric Freedom Cowl Color (Steel Blue) - Electric Freedom Cowl Color (White) - Electric Freedom Cowl Color (Custom) - Electric Freedom Pin Stripes: Gold Non Standard Color Seating Seat Color (Stone Beige) Seat Color (Oyster) Seat Color (Custom) OTHER PERFORMANCE: Ash Tray Battery Fill System Nozzle (Gun) Battery Fill System Club & Ball Washer, Driver Side Club & Ball Washer, Passenger Side Cooler & Bracket, Driver Side Cooler & Bracket, Passenger Side Cooler Jug (Cube) & Bracket
2009 Electric RXV Freedom GC Released: 7/21/2008 Revised:
Std Opt Fld
z z z z z z z z z z z z z z z z z z z z z z z z
z z z z z
Item Divot Repair Sand Bottle Sand Bucket, Driver Side Sand Bucket, Passenger Side Glove Box Doors, Driver & Passenger Insert, No Sun Canopy Message Holder Fender Scuff Guard Sand Rake SoftSwipe Cleaner Side Basket, Driver Side Side Basket, Passenger Side Tow Bar (Temporary) WEATHER PROTECTION: Bag Cover (Tan) Bag Cover (Oyster) Sun Canopy (Top) Oyster Sun Canopy (Top) Tan Windshield Flat (Requires Sun Canopy) ELECTRICAL: CE Kit Hand Held Diagnostic Unit Headlights Heavy Duty Batteries Batteries (T-1275) Horn Taillights Turn Signals Battery Chargers: Battery Charger 48 V 10 ft (3.0 m) DC Cord Battery Charger 48 V 18 ft (5.5 m) DC Cord World Charger 48 V 3.0m (10.0 ft) Cord World Charger 48 V 5.5m (18.0 ft) Cord Headlights Heavy Duty Batteries Batteries (T-1275) World Charger 48 V 5.5m (18.0 ft) Cord Headlights Heavy Duty Batteries Batteries (T-1275)
Std Opt Fld z z z z z z z z z z z z z z z z z z z z z z z z z z z z z z z z z
z z z z z z
Specifications are subject to change without notice * Field installed accessories may require installation charges
2 of 2
MODEL: RXV FREEDOM™ TYPE: GASOLINE POWERED PERSONAL GOLF CAR MODEL YEAR: 2009 Part No:. 606603
PRODUCT SPECIFICATION CONFIGURATION HIGHLIGHTS Engine: z Valve Train: z Lubrication: z Balancer:
13 hp (9.7 kW) Exceeds SAE J1940 Standard, 4 cycle, 24.5 ci (401 cc) single cylinder, air-cooled by Kawasaki Overhead valve z Fuel System: Fixed float bowl with remote pulse fuel pump Pressurized oil system, spin-on oil filter z Ignition: Electronic spark/magneto Internal counter rotating balance shaft z Air Cleaner: Replaceable dry cartridge
Electrical: Drive Train: Brakes: Transaxle: Body Protection:
Starter/Generator, solid-state regulator, 12 Volt maintenance free battery (425 CCA, 60 minute reserve) Automatic, continuously variable transmission (CVT) Dual rear wheel mechanical self-adjusting drum brakes.Single point park brake release with self-compensating system Differential with helical gears, ground speed governor, forward/reverse 360° energy transfer bumpers maximize vehicle protection from minor impact
PRODUCT OVERVIEW Dimensions Overall Length Overall Width Overall Height (No Canopy) Overall Height (With Canopy) Wheel Base Front Wheel Track Rear Wheel Track Gnd Clearance @ Differential Vehicle Power Power Source Valve Train Horsepower (kW) Electrical System Batteries (Qty, Type) Key or Pedal Start Air Cleaner Lubrication Oil Filter Cooling System Fuel Capacity Drive Train Transaxle Gear Selection Rear Axle Ratio
94.5 In (240 cm) 47.0 in (119 cm) 45.7 in (116 cm) 68.5 in (174 cm) 65.7 in (167 cm) 35.5 in (90 cm) 38.0 in (97 cm) 3.3 in (8 cm) 4 Cycle 24.5 cu in (401 cc) Single Cylinder OHV 13 hp (9.7 kW) Exceeds SAE J1940 Std. Starter/Generator. Solid State Regulator One, 12 Volt Maintenance Free Pedal Industrial Rated Dry Filter with Remote Intake Pressurized Oil System Spin On Air Cooled 6.2 Gallon (23.5 L) tank Continuously variable transmission (CVT) Differential with helical gears Forward - Reverse 11.42:1 (Forward) 15.78:1 (Reverse)
Performance Seating Capacity Dry Weight Curb Weight Vehicle load capacity Outside Clearance Circle Intersecting Aisle Clearance Speed (Level Ground) Towing Capacity Steering & Suspension Steering Front Suspension Rear Suspension Service Brake Parking Brake Front Tires Rear Tires Body & Chassis Frame Body & Finish Standard Color
2 Person 697 lb (316 kg) 747 lb (339 kg) 800 lb (360 kg) 19.0 ft (5.8 m) N/A 19 mph ± 0.5 mph (31 kph ± 0.8 kph) 3 E-Z-GO Golf Cars with approved tow bars Double Ended Rack & Pinion Independent A-Arm Coil Over Shock Mono-Leaf Springs With Hydraulic Shocks Rear Wheel Mechanical Self-Adjusting Drums Self-compensating, single point engagement Links 18 x 8.50 - 8 (4 Ply Rated) Links 18 x 8.50 - 8 (4 Ply Rated) Welded Steel. DuraShield™ powder coat Injection molded TPO (Thermoplastic Olefin) Forest Green
Some items shown may be optional equipment 2009 Gas RXV Freedom GC Released: 7/21/2008 Revised:
Specifications are subject to change without notice * Field installed accessories may require installation charges
1 of 2
OPTIONS & FIELD INSTALLED ACCESSORIES (Installation not included)* Item TIRES & WHEELS: Front & Rear: Links 18 x 8.50 - 8 (4 Ply Rated) T Shot, 18 x 8.50 - 8 (4 Ply Rated) Tour Max 18 x 8.50 - 10 on Alloy Wheels USA Trail 18 x 8.50 - 8 (6 Ply Rated) Wheel Covers: Spoke, Metallic Gold COLORS: Body Color (Forest Green) - Freedom Body Color (Black) - Freedom Body Color (Flame Red) - Freedom Body Color (Ivory) - Freedom Body Color (Burgundy) - Freedom Body Color (Patriot Blue) - Freedom Body Color (Steel Blue) - Freedom Body Color (Inferno Red) - Freedom Body Color (Platinum) - Freedom Body Color (Electric Blue) - Freedom Body Color (Bright White) - Freedom Body Color (Almond) - Freedom Body Color (Custom) -Freedom Pin Stripes: Gold Seating: Seat Color (Stone Beige) Seat Color (Oyster) OTHER PERFORMANCE: Ash Tray Club & Ball Washer, Driver Side Club & Ball Washer, Passenger Side Cooler & Bracket, Driver Side Cooler & Bracket, Passenger Side Sand Bottle Sand Bucket, Driver Side Sand Bucket, Passenger Side Glove Box Doors, Driver & Passenger Insert, No Sun Canopy
Std Opt Fld
z z z
z z z z z z z z z z z z z z
2009 Gas RXV Freedom GC Released: 7/21/2008 Revised:
Std Opt Fld
z z z z z z z z z z z
z z z z z z z z z z z z z
Message Holder Sand Rake SoftSwipe Cleaner Side Basket, Driver Side Side Basket, Passenger Side Mirror, 5 Panel Rear View Tow Bar (Temporary) Fender Scuff Guard
Item ELECTRICAL: Miscellaneous: Brake Lights Headlights Horn Hourmeter Taillights Turn Signals WEATHER PROTECTION: Bag Cover (Stone Beige) Bag Cover (Oyster) Sun Canopy (Top) Oyster Sun Canopy (Top) Stone Beige Windshield Fold Down (Requires Sun Canopy)
z z z z z z z z
Specifications are subject to change without notice * Field installed accessories may require installation charges
2 of 2
