Service Manual

Transcript

WM-FX193/FX195 SERVICE MANUAL US Model WM-FX193 Ver 1.0 2000.01 Canadian Model AEP Model E Model Chinese Model WM-FX193/FX195 Photo : WM-FX195 Model Name Using Similar Mechanism NEW Tape Transport Mechanism Type MF-WMFX195-114 SPECIFICATIONS • Frequency range FM: 87.5 - 108 MHz (Italy, Saudi Arabia) 87.6 - 107.9 MHz (Other countries) AM: 526.5 - 1606.5 kHz (Italy, Saudi Arabia)) 531 - 1602 kHz (Other countries) • Power requirement 3 V DC batteries R6 (AA) x 2 • Dimensions 89.1 x 117.7 x 35.5 mm (w/h/d) incl. projecting parts and controls • Mass Approx. 140 g/Approx. 220 g incl. batteries and a cassette • Supplied accessories Stereo headphones or Stereo earphones (1)/Belt clip (1) Design and specifications are subject to change without notice. Battery life (approximate hours) Sony alkaline LR6 (SG) playback 25 radio 55 (EIAJ*) Sony R6P (SR) 7.5 18 * Measured value by the standard of EIAJ (Electronic Industries Association of Japan). (Using a Sony HF series cassette tape) Note • The battery life may shorten depending on the operation of the unit. RADIO CASSETTE PLAYER MICROFILM TABLE OF CONTENTS Specifications ........................................................................... 1 1. GENERAL Location and Function of Controls .................................... 2 2. DISASSEMBLY 2-1. Cabinet (Rear) Sub ASSY .......................................... 2-2. Main Board ................................................................. 2-3. Mechanism Deck ........................................................ 2-4. Belt, Capstan/Reel Motor (M901) .............................. 2-5. Holder Sub ASSY, Cassette ........................................ 3 3 4 4 5 Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270°C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. 3. ADJUSTMENTS 3-1. Mechanical Adjustments ............................................. 6 3-2. Electrical Adjustments ................................................ 6 4. DIAGRAMS 4-1. Block Diagram ............................................................ 9 4-2. Printed Wiring Boards ............................................... 11 4-3. Schematic Diagram ................................................... 13 5. EXPLODED VIEWS 5-1. Cabinet Section ......................................................... 17 5-2. Mechanism Section -1 .............................................. 19 5-3. Mechanism Section -2 .............................................. 20 6. ELECTRICAL PARTS LIST ................................... 21 SECTION 1 GENERAL This section is extracted from instruction manual. LOCATION AND FUNCTION OF CONTROLS FM MODE i FM/AM/TAPE (RADIO OFF) AVLS NORM/ LIMIT BATT TUNING x VOLUME m nPLAY M MEGA BASS/ OFF (FX195 only) –2– SECTION 2 DISASSEMBLY z The equipment can be removed using the following procedure. Set Cabinet (rear) sub ASSY Main board Mechanism deck Belt, Capstan/reel moter (M901) Holder sub ASSY, Cassette Note : Follow the disassembly procedure in the numerical order given. 2-1. CABINET (REAR) SUB ASSY Holder sub ASSY, Cassette Claws 4 Cabinet (front) 2 5 Claw 3 Claws 5 Claw Cabinet (rear) sub ASSY 6 4 Claw 5 Claw 4 Claws 1 Screws B1.7x9 3 Claws 3 Claws 2-2. MAIN BOARD Orange Black White 2 Remove solder 1 Screw WH1.4 Red Main board 3 Claws 4 Head flexible board Cabinet (front) –3– 2-3. MECHANISM DECK Mechanism deck 1 Insert the precision screwdriver (1.4 mm flat-blabe) in to the slit and release two claws. 2 Cabinet (front) 2-4. BELT, CAPSTAN/REEL MOTOR (M901) 2 Screws (M1.4) Mechanism deck 3 Capstan/reel motor (M901) 1 Belt –4– 2-5. HOLDER SUB ASSY, CASSETTE Cabinet (front) 3 Move it away from projection Holder sub ASSY, Cassette 4 Spring (torsion) Cabinet (front) 1 5 Holder sub ASSY, Cassette Cabinet (front) 2 Move it away from projection Holder sub ASSY, Cassette z CAUTIONS DURING ASSEMBLY 1 Insert the dial indicator to the square hole of the cabinet (front) and align to the pointer. 2 Insert the spring (torsion) in to the L shape slot as shown in the figure. 3, 4 Insert the hinge of the “Holder sub ASSY, Cassette”. 5 Close the “Holder sub ASSY, Cassette” then press in. Hinge Holder sub ASSY, Cassette Spring (torsion) 5 2 3 Dial indicator 1 Hinge 4 Cabinet (front) –5– SECTION 3 ADJUSTMENTS 3-1. MECHANICAL ADJUSTMENTS 3-2. ELECTRICAL ADJUSTMENTS PRECAUTION PRECAUTION 1. Clean the following parts with a denatured-alcohol-moistened swab : playback head pinch roller capstan rubber belt 2. Demagnetize the playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. These measurement and adjustment should be performed with the rated power supply voltage (2.5 V) unless otherwise noted. • Supplied voltage : 2.5V. • Switch and control position MEGA BASS switch : OFF (FX195) VOLUME control : maximum AVLS switch : NORM Test Tape Torque Measurement Mode Torque Meter FWD FWD back tension FF, REW CQ-102C CQ-201B Type Signal Used for WS-48A 3kHz, 0dB Tape Speed Adjustment Meter Reading 20 – 30 g • cm (0.28 – 0.41 oz• inch) 0.4 – 2 g • cm (0.006 – 0.027 oz• inch) more than 40 g • cm (more than 0.56 oz• inch) Tape Speed Adjustment Procedure : test tape WS-48A (3kHz, 0dB) frequency counter *1 set phones jack (J302) 1. Playback WS-48A (tape center part) and adjust RV601 so that the frequency counter reading becomes 3,000Hz. Standard value : 2,985–3,015Hz 2. Playback WS-48A (tape top and end). Check that frequency counter reading is within 1.5% of the reading of step 1. *1 FX193 E, Chines, Saudi Arabia, 16Ω E, Chines, Saudi Arabia, AEP, French, Italian, FX195 CEV FX193 US, Canadian, AEP, French, Italian, CEV 32Ω FX195 Canadian • Abbreviation CEV : Ukraine, Hungary, Czech Adjustment Location : [MAIN BOARD] (Conductor side) RV601 : Tape Speed Adjustment –6– TUNER SECTION • Repeat the procedures in each adjustment several times, and the frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. 0 dB = 1µV AM Section BAND : AM AM RF signal generator < [ Put the lead-wire antenna close to the set. > : US, Canadian, E5, E6 model ] : Italian, Saudi Arabia model AM IF ADJUSTMENT Adjust for a maximum reading on level meter. T1 30% amplitude modulation by 400Hz signal. Output level : as low as possible AM FREQUENCY COVERAGE ADJUSTMENT Adjust for a maximum reading on level meter. L4 FM Section BAND : FM CT4 FM RF signal generator [MAIN BOARD] (Conductor side) 1,690kHz [516.5kHz] < 1,770kHz> [1,631.5kHz] AM TRACKING ADJUSTMENT 0.01µF L1 620kHz CT1 -1 -2 22.5kHz frequency deviation by 400Hz signal. Output level : as low as possible Adjust for a maximum reading on level meter. L3 EXCEPT US, CND, E5, E6 MODEL 86MHz [87.35MHz] 109.5MHz [108.25MHz] FM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. TP1 JR5 L2 JR3 JR1 FB301 C12 JR2 FB201 1,400kHz FM FREQUENCY COVERAGE ADJUSTMENT CT3 TP338 505kHz Adjust for a maximum reading on level meter. TP1 TP339 FB101 455kHz BATT CT2 86MHz [87.35MHz] 109.5MHz [108.25MHz] CP1 L4 US, CND, E5, E6 MODEL S1 TP9 TP8 Adjustment Location : Main board (See page 8) JR4 US, CN T1 level meter *1 set phones jack (J302) *1 FX193 E, Chines, Saudi Arabia, E, Chines, Saudi Arabia, AEP, French, Italian, FX195 CEV FX193 US, Canadian, AEP, French, Italian, CEV 32Ω FX195 Canadian • Abbreviation CND : Canadian E5, E6 : South America CEV : Ukraine, Hungary, Czech 16Ω –7– Adjustment Location : [MAIN BOARD] (Conductor side) CT1 : AM Tracking Adjustment CT4 : AM Frequency Coverage Adjustment CT2 : FM Tracking Adjustment CT3 : FM Frequency Coverage Adjustment L4 : AM Frequency Coverage Adjustment [MAIN BOARD] (Component side) T1 : AM IF Adjustment L2 : FM Tracking Adjustment L1 : AM Tracking Adjustment L3: FM Frequency Coverage Adjustment –8– WM-FX193/FX195 SECTION 4 DIAGRAMS 4-1. BLOCK DIAGRAM • Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukrine, Hungary, Czech E5, E6 : South America FR : French –9– – 10 – • Signal path. F : FM f : AM E : PB WM-FX193/FX195 4-2. PRINTED WIRING BOARDS Semiconductor Location 6 8 7 9 10 11 -1 -2 DRY BATTERY SIZE "AA" (IEC DESIGNATION R6) 2PCS, 3V LIMIT EXCEPT US, CND, E5, E6 MODEL B TP1 -2 JR321 TP341 JR304 JR302 TP335 COM 40 37 36 R610 35 JR305 COM TP634TP636 C313 TH601 C208 C206 30 C306 JR311 R210 R302 G L R TP212 R110 C308 R307 C309 10 TP231 R204 12 25 L302 TP209 TP211 JR347 20 24 C307 C101 1315 R201 TP213 JR307 C108 R308 C201 R101 JR306 C310 JR309 TP232 TP230 TP229 TP315 TP319 C303 C301 TP217 JR312 JR310 C311 JR308 TP214 TP210 C302 4 TP321 3 2 1 C304 TP233 WM-FX193 JR402 TP331 11 (11) S302 S301 02 FM AM S304 HP901 PLAYBACK HEAD TAPE (RADIO OFF) L-CH MEGA BASS H 4 Note: • X : parts extracted from the component side. f • : internal component. • b : Pattern of the rear side. • Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukraine, Hungary, Czech E5, E6 : South America 2 R-CH OFF WM-FX195 3 – 11 – 1-675-134- TP332 (POWER) G M901 CAPSTAN/REEL MOTOR R609 IC301 5 U V W R607 48 45 1 E, E9, CH, EA MODEL J301 DC IN 3V C305 C106 R601 C606 TP640 C314 TP334 BT2 TP635 TP639 C609 RV601 C608 C607 C602 C203 R203 R103 TP205 Vref JR350 C605 C604 JR351 R207 JR349 C207 C107 C331 R106 R206 JR346 JR345 C329 Q301 R320 JR340 C330 R5 C105 JR341 C205 TP207 R107 JR348 TP647 TP648 R602 C603 R104 C103 R109 R209 JR329 L5 JR339 R603 Q1 C B E TP333 C333 R120 TP336 C325 JR336 R208 R108 L301 JR328 JR322 JR323 JR364 TP320 R6 JR215 D120 TP330 BATT JR366 TP13 TP6 JR217 C B E C23 JR365 R2 JR218 C21 C20 R21 C6 TP337 -1 C5 C7 JR361 TP317 Q2 TP10 24 JR363 JR362 TP316 TP225 JR367 JR369 TP222 JR216 20 C9 C B E JR368 TP224 TP223 TP11 13 15 C18 C10 C19 FX193:US,CND F JR344 C40 JR371 JR372 R10 TP221 TP12 JR343 C334 IC1 R7 JR342 1 5 R8 CT2 CV2 CT3 C13 L3 C26 12 10 TP2 R1 C3 VOLUME R321 C15 C22 JR370 RV301 TP5 X2 JR338 JR303 TP643 TP641 TP642 W V U R3 Q302 C104 C204 C17 TP226 JR337 R4 JR335 C24 C16 E JR333 C14 TP4 C28 JR214 CV1-4 TUNING JR325 R9 JR331 C2 C11 JR213 JR334 R121 US, CND, E5, E6 MODEL CF1 EXCEPT E, E9, JR401 CH, EA MODEL TP228 TP227 JR332 JR327 JR330 R22 L2 CF2 JR326 US, CND, E5, E6 MODEL TP3 T1 JR212 JR211 JR4 C8 DX JR324 L4 L1 TP7 AM FERRITE ROD ANTENNA CV3 D CP1 C B E EXCEPT US, CND, E5, E6 MODEL LOCAL C1 ST BATT(–) US, CND, E5, E6 MODEL S1 TP9 TP8 S1 FM MODE MONO JR5 TP338 CV1 C FB301 C12 JR2 FB201 J302 i BATT(+) JR201 JR3 JR1 TP339 FB101 CT1 E-6 F-4 E-6 D-6 NORM C315 E-4 E-8 [MAIN BOARD] JR301 S305 AVLS CT4 Q1 Q2 Q301 Q302 5 G-4 A IC1 IC301 4 Location CV4 Ref. No. D120 3 2 1 C4 z 1 – 12 – WM-FX193/FX195 4-3. SCHEMATIC DIAGRAM Note: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. f • : internal component. • U : B+ Line. • Power voltage is dc 3V and fed with regulated dc power supply from external power voltage jack (J301). no mark : FM ( ) : AM < > : TAPE PLAY • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Signal path. F : FM E : PB • Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukraine, Hungary, Czech E5, E6 : South America FR : French – 13 – – 14 – – 15 – SECTION 5 EXPLODED VIEWS z NOTE : • -XX, -X mean standardized parts, so they may have some difference from the original one. • Color indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ••• (RED) ↑ ↑ Parts color Cabinet's color • Items marked “ * ”are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. IC Block Diagrams. AM RF IN FM RF OUT RF VCC FM OSC AM OSC AFC DET OUT MPX IN LPF2 LPF1 L-OUT R-OUT IC1 TA2111F-(EL) 24 23 22 21 20 19 18 17 16 15 14 13 AF AMP FM OSC AM OSC DECODE AF BUFFER VCO DIVIDE FM MUTE AM MIX AM DET FM MIX • Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukraine, Hungary, Czech E5, E6 : South America FR : French 5-1. CABINET SECTION ST/MONO FM/AM LEVEL DET FM DET 23 ST LED Part No. Description Remark 1 2 3 4 X-3378-185-1 CABINET (REAR) SUB ASSY (EXCEPT E, E9, EA,CH) X-3378-186-1 CABINET (REAR) SUB ASSY (E, E9, EA,CH) 3-019-503-11 SHEET(CABINET REAR) 3-318-203-92 SCREW(B1.7), TAPPING 3-022-581-01 PLATE, LIGHT GUIDE 5 6 6 6 6 3-039-265-01 A-3021-289-A A-3021-290-A A-3021-291-A A-3021-292-A 6 6 A-3021-293-A MAINBOARD, COMPLETE (FX193:US,CND) A-3021-294-A MAINBOARD, COMPLETE (FX193:AEP,CEV) A-3021-295-A MAINBOARD, COMPLETE (FX193:FR) A-3021-296-A MAINBOARD, COMPLETE (FX193:Italian) A-3021-297-A MAINBOARD, COMPLETE (FX195:EA) Ref. No. 19 19 19 19 LID,BATTERY CASE MAINBOARD, COMPLETE (FX195:E,E9,CH) MAINBOARD, COMPLETE (FX193:E,E9,CH) MAINBOARD, COMPLETE (FX193:EA) MAINBOARD, COMPLETE (FX193:E5,E6) 19 19 19 19 19 19 19 FM RF 1 2 3 4 5 6 7 8 9 10 11 12 FM RF IN RF GND AM LOW CUT MIX OUT AGC VCC AM IF IN FM IF IN GND TUN LED ST LED QUAD FX195 6 6 21 20 6 6 6 A-3021-298-A MAINBOARD, COMPLETE (FX195:CND) A-3021-299-A MAINBOARD, COMPLETE (FX195:AEP,CEV) A-3021-300-A MAINBOARD, COMPLETE (FX195:FR) A-3021-301-A MAINBOARD, COMPLETE (FX195:Italian) A-3021-302-A MAINBOARD, COMPLETE (FX195:E5,E6) 7 8 9 10 11 3-029-332-01 9-910-999-31 3-039-262-01 3-039-266-01 3-921-955-01 TERMINAL (-), BATTERY SCREW(M1.7X1.5) KNOB(TUNING) TERMINAL (+), BATTERY SCREW (M1.4), TOOTH (WH) 12 13 14 15 16 3-019-859-01 3-019-860-01 3-019-858-01 3-019-861-01 3-375-114-31 BUTTON (STOP) BUTTON (FF) BUTTON (PLAY) BUTTON (REW) SCREW 17 18 19 3-039-259-01 COVER, LID 3-039-260-01 DIAL INDICATOR 3-039-267-01 HOLDER, CASSETTE (FX195:CND,E5,E6) (GOLD) 19 19 DR MP-GND WOUT VOUT UOUT FC OUT 39 38 37 WB 40 VB 41 OSC UB 42 MVCC 48 47 46 45 44 43 MF-WMFX195-114 19 24 18 15 14 FREQ CARC. PRE DRIVER 17 8 13 12 9 L1 10 FWD/ REV COM 1 OPERATION LOGIC OSC REF VOLTAGE 7 OPERATION DET 16 PLUSE DET REF VOLTAGE FOR SPEED CONTROL BIAS LOW BOOST VSP IN+ MVREF M-GND 32 LOW BOOST SW 30 29 28 27 PRE REV IN (L) 10 PRE FWD IN (R) 11 MIX IN (L) MIX IN (R) H.P IN (L) H.P IN (R) 23 23 24 L1 3-039-255-41 3-039-255-51 3-039-261-01 1-754-084-11 CABINET (FRONT) (FX195:AEP,Italian,CEV,FR) CABINET (FRONT) (FX195:CND,E5,E6) POINTER ANTENNA, FERRITE-ROD (AM TRACKING) 5 2 4 PRE REV IN (R) 12 26 LP.2 REF SYS CONT – + 25 MIX OUT (R) 3 VREF 20 21 22 R.REF SYSTEM POWER OUT (L) POWER GND POWER OUT (COM) VCC POWER OUT (R) 23 24 MIX OUT (L) 18 19 POWER IN (R) 15 16 17 POWER IN (L) 14 POWER MUTE 13 VREF R.F – 16 – – 17 – 3-039-267-81 HOLDER, CASSETTE (FX195:Italian,EA) (BLACK) X-3378-178-1 HOLDER SUB ASSY, CASSETTE (FX193:AEP,FR,CEV,E,E9,CH) (GRAY) X-3378-179-1 HOLDER SUB ASSY, CASSETTE (FX193:AEP,CEV,E,E9,CH) (BLUE) X-3378-180-1 HOLDER SUB ASSY, CASSETTE (FX193:EA) (GRAY) X-3378-181-1 HOLDER SUB ASSY, CASSETTE (FX193:Italian,EA) (BLUE) SPRING (CASSETTE) CABINET (FRONT) (FX193:E,E9,CH,EA) CABINET (FRONT) (FX193:AEP,Italian,FR,CEV) CABINET (FRONT) (FX193:US,CND,E5,E6) CABINET (FRONT) (FX195:E,E9,CH,EA) 6 3 3-039-267-31 HOLDER, CASSETTE (FX195:AEP,CEV,FR,E,E9,CH) (GOLD) 3-039-267-41 HOLDER, CASSETTE (FX195:AEP,CEV,FR,E,E9,CH) (BLUE) 3-039-267-51 HOLDER, CASSETTE (FX195:AEP,CEV,FR,E,E9,CH) (BLACK) 3-039-267-61 HOLDER, CASSETTE (FX195:Italian,EA)(GOLD) 3-039-267-71 HOLDER, CASSETTE (FX195:Italian,EA) (BLUE) 3-932-037-01 3-039-255-01 3-039-255-11 3-039-255-21 3-039-255-31 1 PRE FWD IN (L) 9 Remark 22 23 23 23 23 31 DET OUT DET Description 3-039-267-11 HOLDER, CASSETTE (FX195:CND,E5,E6) (BLUE) 3-039-267-21 HOLDER, CASSETTE (FX195:CND,E5) (BLACK) 20 21 19 11 36 35 34 33 SPEED CURRENT DET RI 2 Part No. X-3378-182-1 HOLDER SUB ASSY, CASSETTE (FX193:E5,E6) (GRAY) X-3378-183-1 HOLDER SUB ASSY, CASSETTE (FX193:US,CND,E5,E6) (BLUE) X-3378-184-1 HOLDER SUB ASSY, CASSETTE (FX193:E5,E6) (ORANGE) 3-007-012-01 SPRING (TORSION) 3-039-268-01 KNOB(MEGABASS) (FX195) 19 IC301 LB8115W-NA-TLM S/S 3 PRE GND 4 PRE OUT (L) 5 PRE NF (L) 6 PRE OUT (R) 7 PRE NF (R) 8 1 6 6 6 22 TUN LED FM IF AM IF AGC Ref. No. • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. – 18 – 5-2. MECHANISM SECTION-1 (MF-WMFX195-114) 54 HP901 52 55 53 M901 56 51 Ref. No. 51 52 53 54 55 Part No. Description 3-013-560-11 3-703-816-31 3-921-042-01 3-703-816-73 X-3369-749-1 BELT SCREW (M1.4), SPECIAL HEAD GEAR(REEL) SCREW (M1.4), SPECIAL HEAD PINCH LEVER (N) ASSY Remark Ref. No. 56 HP901 M901 – 19 – Part No. Description Remark 3-920-996-01 SPRING (PINCH N) 1-500-641-11 HEAD, MAGNETIC (PLAYBACK) 1-763-073-11 MOTOR (CAPSTAN/REEL) (INCLUDING PULLEY) 5-3. MECHANISM SECTION-2 (MF-WMFX195-114) 109 110 108 111 112 113 114 105 107 106 115 104 118 116 103 117 102 101 Ref. No. Part No. Description Part No. Description 101 102 103 104 105 3-921-797-01 3-921-003-01 3-938-628-02 3-920-999-01 X-3376-169-1 WASHER BEARING SPRING (PLAY-CP) GEAR (A) CLUTCH ASSY Remark Ref. No. 111 112 113 114 115 3-921-335-01 3-920-990-01 3-921-050-01 X-3372-619-1 3-921-043-11 WASHER, LEVER SPRING (UD), COMPRESSION GEAR (B) WHEEL ASSY (P), CAPSTAN GEAR (D) 106 107 108 109 110 3-013-142-01 3-015-436-01 3-938-613-01 3-728-091-01 3-923-530-01 SPRING (FR-CP) SPRING (STOP) LEVER (OW), DETECTION WASHER, STOPPER SLEEVE (M) 116 117 118 3-036-664-11 SPRING (FR LEVER OWN) X-3377-890-1 CHASSIS ASSY (GL-02C) 3-016-989-01 SPRING (SW-CP) – 20 – Remark SECTION 6 ELECTRICAL PARTS LIST NOTE : • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms METAL : Metal-film resistor METAL OXIDE :Metal oxide-film resistor F : nonflammable • Items marked “ * ”are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. Ref. No. • SEMICONDUCTORS In each case, u : µ , for example : uA.... : µ A.... , uPA.... : µ PA.... uPB.... : µ PB.... , uPC.... : µ PC.... uPD.... : µ PD.... • CAPACITORS uF : µ F • COILS uH : µ H Remark When indicating parts by reference number, please include the board. • Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukraine, Hungary, Czech E5, E6 : South America FR : French Part No. Description A-3021-289-A A-3021-290-A A-3021-291-A A-3021-292-A A-3021-293-A MAIN BOARD, COMPLETE (FX195:E,E9,CH) MAIN BOARD, COMPLETE (FX193:E,E9,CH) MAIN BOARD, COMPLETE (FX193:EA) MAIN BOARD, COMPLETE (FX193:E5,E6) MAIN BOARD, COMPLETE (FX193:US,CND) C13 1-163-091-00 CERAMIC CHIP 8PF C13 1-163-217-11 CERAMIC CHIP 1PF C14 1-135-151-21 TANTALUM CHIP 4.7uF A-3021-294-A A-3021-295-A A-3021-296-A A-3021-297-A A-3021-298-A MAIN BOARD, COMPLETE (FX193:AEP,CEV) MAIN BOARD, COMPLETE (FX193:FR) MAIN BOARD, COMPLETE (FX193:Italian) MAIN BOARD, COMPLETE (FX195:EA) MAIN BOARD, COMPLETE (FX195:CND) C15 C16 C17 C18 1-163-077-00 1-164-227-11 1-124-584-00 1-163-023-00 C18 1-163-021-91 CERAMIC CHIP A-3021-299-A A-3021-300-A A-3021-301-A A-3021-302-A MAIN BOARD, COMPLETE (FX195:AEP,CEV) MAIN BOARD, COMPLETE (FX195:FR) MAIN BOARD, COMPLETE (FX195:Italian) MAIN BOARD, COMPLETE (FX195:E5,E6) ********************************* C19 1-163-023-00 CERAMIC CHIP C19 1-163-021-91 CERAMIC CHIP C20 C21 C22 1-164-360-11 CERAMIC CHIP 1-164-360-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 5% 50V (US,CND,E5,E6) 0.01uF 10% 50V (EXCEPT US,CND,E5,E6) 0.1uF 16V 0.1uF 16V 0.001uF 10% 50V C23 C24 C26 C28 1-115-156-11 1-164-360-11 1-162-964-11 1-163-090-00 1uF 0.1uF 0.001uF 7PF C28 1-163-217-11 CERAMIC CHIP 1PF C40 C101 C103 C104 C105 1-164-360-11 1-162-962-11 1-162-968-11 1-126-153-11 1-115-156-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 0.1uF 470PF 0.0047uF 22uF 1uF 10% 10% 20% 0% 16V 50V 50V 6.3V 10V C106 C107 C108 C201 C203 1-162-964-11 1-115-156-11 1-162-964-11 1-162-962-11 1-162-968-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001uF 1uF 0.001uF 470PF 0.0047uF 10% 0% 10% 10% 10% 50V 10V 50V 50V 50V 50V 16V 16V 10V 16V C204 C205 C206 C207 C208 1-126-153-11 1-115-156-11 1-162-964-11 1-115-156-11 1-162-964-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 22uF 1uF 0.001uF 1uF 0.001uF 20% 0% 10% 0% 10% 6.3V 10V 50V 10V 50V 16V 50V C301 C302 C303 1-115-156-11 CERAMIC CHIP 1-104-847-11 TANTAL. CHIP 1-164-360-11 CERAMIC CHIP 1uF 22uF 0.1uF 0% 20% 10V 4V 16V 3-029-332-02 TERMINAL (-), BATTERY < CAPACITOR > C1 1-163-083-00 CERAMIC CHIP 1PF C1 1-163-085-00 CERAMIC CHIP 2PF C2 1-163-093-00 CERAMIC CHIP 10PF C2 1-163-101-00 CERAMIC CHIP 22PF C3 1-163-093-00 CERAMIC CHIP 10PF 50V (EXCEPT Italian,EA) 50V (Italian,EA) 5% 50V (EXCEPT Italian,EA) 5% 50V (Italian,EA) 5% 50V (EXCEPT Italian,EA) C3 1-163-101-00 CERAMIC CHIP 22PF 5% 50V (Italian,EA) 50V (EXCEPT Italian,EA) 50V (Italian,EA) 50V 0.5PF 50V C4 1-163-575-11 CERAMIC CHIP 3PF C4 1-163-088-00 CERAMIC CHIP 5PF C4 C5 1-163-089-00 CERAMIC CHIP 1-162-937-11 CERAMIC CHIP 6PF 6PF C6 C7 C8 C9 C10 1-162-964-11 1-165-128-11 1-164-360-11 1-115-156-11 1-164-360-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001uF 0.22uF 0.1uF 1uF 0.1uF 10% 0% C11 C12 1-107-823-11 CERAMIC CHIP 1-162-964-11 CERAMIC CHIP 0.47uF 0.001uF 10% 10% 0% Ref. No. MAIN – 21 – Part No. Description CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP Remark 0.25PF 50V (EXCEPT Italian,EA) 0.25PF 50V (Italian,EA) 20% 4V 0.1uF 0.022uF 100uF 0.015uF 10% 25V 10% 25V 20% 10V 5% 50V (US,CND,E5,E6) 0.01uF 10% 50V (EXCEPT US,CND,E5,E6) 0.015uF 0% 10V 16V 10% 50V 50V (EXCEPT Italian,EA) 50V (Italian,EA) MAIN Ref. No. Part No. Description Remark C304 C305 1-164-360-11 CERAMIC CHIP 1-124-584-00 ELECT 0.1uF 100uF C306 C307 C308 C309 C310 1-107-823-11 1-164-360-11 1-115-156-11 1-164-505-11 1-162-964-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.47uF 0.1uF 1uF 2.2uF 0.001uF C311 C313 C314 C315 C325 1-162-974-11 1-135-149-21 1-164-360-11 1-115-156-11 1-115-156-11 CERAMIC CHIP TANTALUM CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 2.2uF 0.1uF 1uF 1uF 0% 0% 50V 10V 16V 10V 10V C329 C330 C331 C333 C334 1-115-156-11 1-115-156-11 1-135-151-21 1-124-434-00 1-164-004-11 CERAMIC CHIP CERAMIC CHIP TANTALUM CHIP ELECT CERAMIC CHIP 1uF 1uF 4.7uF 220uF 0.1uF 0% 0% 20% 20% 10% 10V 10V 4V 4V 25V C602 C603 C604 C605 C606 1-162-970-11 1-115-467-11 1-163-809-11 1-163-809-11 1-163-809-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 0.22uF 0.047uF 0.047uF 0.047uF 10% 10% 10% 10% 10% 25V 10V 25V 25V 25V C607 C608 C609 1-107-823-11 CERAMIC CHIP 0.47uF 1-135-149-21 TANTALUM CHIP 2.2uF 1-164-360-11 CERAMIC CHIP 0.1uF 10% 20% 16V 10V 16V 20% Ref. No. 0% 0% 10% 20% 16V 16V 10V 16V 50V J302 Remark 1-750-061-11 JACK,DC(POLARITY UNIFIED TYPE) (DC IN 3V)(E,E9,CH,EA) 1-565-287-11 JACK (i) < JUMPER RESISTOR > < FILTER > CF1 CF2 Description < JACK > J301 10% Part No. 16V 10V 1-527-870-00 FILTER 1-767-733-71 FILTER ASSY, CERAMIC JR1 1-216-864-11 METAL CHIP 0 5% 1/16W (EXCEPT US,CND,E5,E6) 0 5% 1/16W (EXCEPT US,CND,E5,E6) 1K 5% 1/16W (EXCEPT US,CND,E5,E6) 0 5% 1/16W (US,CND,E5,E6) 0 5% 1/16W (US,CND,E5,E6) JR2 1-216-864-11 METAL CHIP JR3 1-216-821-11 METAL CHIP JR4 1-216-864-11 METAL CHIP JR5 1-216-864-11 METAL CHIP JR201 JR211 JR212 JR213 JR214 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W JR215 JR216 JR217 JR218 JR301 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/8W JR302 JR303 JR304 JR305 JR306 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W JR307 JR308 JR309 JR310 JR311 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W JR312 JR321 JR322 JR323 JR324 1-216-296-00 1-216-296-00 1-216-864-11 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/16 1/8W 1/8W JR325 JR326 JR327 JR328 JR329 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W JR330 JR331 JR332 JR333 JR334 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W JR335 JR336 JR337 JR338 JR339 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W JR340 JR341 1-216-296-00 METAL CHIP 1-216-296-00 METAL CHIP 0 0 5% 5% 1/8W 1/8W < COMPOSITION CIRCUIT BLOCK > CP1 CP1 1-234-395-11 FILTER, BAND PASS (US,CND,E5,E6) 1-236-711-21 FILTER, BAND PASS (EXCEPT US,CND,E5,E6) < TRIMMER > CT1 CT2 CT3 CT4 1-141-613-11 1-141-613-11 1-141-613-11 1-141-613-11 CAP, VAR (AM TRACKING) CAP, VAR (FM TRACKING) CAP, VAR (FM FREQUENCY COVERAGE) CAP, VAR (AM FREQUENCY COVERAGE) < VARIABLE CAPACITOR > CV1 CV2 CV3 CV4 1-141-613-11 1-141-613-11 1-141-613-11 1-141-613-11 CAP, VAR (TUNING) CAP, VAR (TUNING) CAP, VAR (TUNING) CAP, VAR (TUNING) < DIODE > D120 8-719-074-20 LED LNV210C6AOSO (BATT) < FERRITE BEAD > FB101 FB201 FB301 1-414-760-21 INDUCTOR CHIP 1-414-760-21 INDUCTOR CHIP 1-414-760-21 INDUCTOR CHIP < IC > IC1 IC301 8-759-493-20 IC TA2111F-(EL) 8-759-574-69 IC LB8115W-TLM – 22 – MAIN Ref. No. Part No. Description Remark JR342 JR343 JR344 1-216-296-00 METAL CHIP 1-216-296-00 METAL CHIP 1-216-296-00 METAL CHIP 0 0 0 5% 5% 5% 1/8W 1/8W 1/8W JR345 JR346 JR347 JR348 JR349 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W JR350 JR351 JR361 JR362 JR363 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W JR364 JR365 JR366 JR367 JR368 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W JR369 JR370 JR371 JR372 JR401 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-295-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 Ref. No. Part No. Description R7 R8 R9 R10 1-216-815-11 1-216-797-11 1-216-815-11 1-216-827-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP 330 10 330 3.3K 5% 1/16W 5% 1/16W 5% 1/16W 5% 1/16W (FX193:US,CND) R21 R22 R101 R103 R104 1-216-829-11 1-216-829-11 1-216-821-11 1-216-855-11 1-216-839-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 4.7K 1K 680K 33K 5% 5% 5% 5% 5% R106 R107 R108 1-216-819-11 METAL CHIP 1-216-214-00 RES-CHIP 1-216-138-00 METAL CHIP 680 4.7K 3.3 5% 5% 5% R108 R108 R108 JR402 1-216-864-11 METAL CHIP 5% 1/8W 5% 1/8W 5% 1/8W 5% 1/8W 5% 1/10W (EXCEPT E,E9,CH,EA) 0 5% 1/16W (FX193) < COIL > L1 L2 L2 L3 1-754-084-11 ANTENNA, FERRITE-ROD (AM TRACKING) 1-416-623-11 COIL (WITH CORE) (EXCEPT Italian,EA) (FM TRACKING) 1-416-624-11 COIL (WITH CORE) (Italian,EA) (FM TRACKING) 1-416-626-11 COIL (WITH CORE) (EXCEPT Italian,EA) (FM FREQUENCY COVERAGE) L3 1-416-627-11 COIL (WITH CORE) (Italian,EA) (FM FREQUENCY COVERAGE) L4 1-406-408-11 COIL (OSC) (EXCEPT Italian,EA) (AM FREQUENCY COVERAGE) 1-406-409-11 COIL (OSC) (Italian,EA) (AM FREQUENCY COVERAGE) 1-216-295-00 METAL CHIP 0 5% 1/10W 1-412-002-31 INDUCTOR CHIP 4.7uH 1-216-864-11 METAL CHIP 0 5% 1/16W L4 L5 L301 L302 Q1 Q2 Q301 Q302 8-729-216-22 8-729-216-22 8-729-230-49 8-729-230-49 R108 R109 R109 R109 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/8W 1/8W (US) 1-216-150-91 RES-CHIP 10 5% 1/8W (FX193:CND,AEP,Italian,CEV/FX195:CND) 1-216-166-00 RES-CHIP 47 5% 1/8W (FX193:FR) 1-216-154-00 RES-CHIP 15 5% 1/8W (FX193:E,E5,E6,E9,CH,EA/FX195:EXCEPT CND,FR) 1-216-174-00 RES-CHIP 100 5% 1/8W (FX195:FR) 1-216-190-00 RES-CHIP 470 5% 1/8W (FX193:US,CND,AEP,Italian,CEV/FX195:CND) 1-216-198-91 RES-CHIP 1K 5% 1/8W (FR) 1-216-182-00 RES-CHIP 220 5% 1/8W (FX193:E,E5,E6,E9,CH,EA/FX195:EXCEPT CND,FR) R110 1-216-864-11 METAL CHIP 0 R110 1-216-807-11 METAL CHIP 68 R120 R121 R201 1-216-819-11 METAL CHIP 1-216-825-11 METAL CHIP 1-216-821-11 METAL CHIP 680 2.2K 1K R203 R204 R206 R207 R208 1-216-855-11 1-216-839-11 1-216-819-11 1-216-214-00 1-216-138-00 680K 33K 680 4.7K 3.3 R208 1-216-150-91 RES-CHIP 10 5% 1/8W (FX193:CND,AEP,Italian,CEV/FX195:CND) 1-216-166-00 RES-CHIP 47 5% 1/8W (FX193:FR) 1-216-154-00 RES-CHIP 15 5% 1/8W (FX193:E,E5,E6,E9,CH,EA/FX195:EXCEPT CND,FR) 1-216-174-00 RES-CHIP 100 5% 1/8W (FX195:FR) 1-216-190-00 RES-CHIP 470 5% 1/8W (FX193:US,CND,AEP,Italian,CEV/FX195:CND) R208 R208 < TRANSISTOR > R208 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR R209 2SA1162-G 2SA1162-G 2SC2712-YG 2SC2712-YG Remark R209 METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP 5% 1/16W (EXCEPT FX195: FR) 5% 1/16W (FX195:FR) 5% 1/16W 5% 1/16W 5% 1/16W 5% 5% 5% 5% 5% R1 R2 R3 R4 R5 1-216-295-00 1-216-839-11 1-216-234-00 1-216-234-00 1-216-831-11 METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP 0 33K 33K 33K 6.8K 5% 5% 5% 5% 5% 1/10W 1/16W 1/8W 1/8W 1/16W R210 R302 1/8W (FR) 1-216-182-00 RES-CHIP 220 5% 1/8W (FX193:E,E5,E6,E9,CH,EA/FX195:EXCEPT CND,FR) 1-216-864-11 METAL CHIP 0 5% 1/16W (EXCEPT FR) 1-216-807-11 METAL CHIP 68 5% 1/16W (FX195:FR) 1-216-789-11 METAL CHIP 2.2 5% 1/16W R6 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R307 1-216-833-91 RES-CHIP < RESISTOR > R209 R210 – 23 – 1-216-198-91 RES-CHIP 1K 5% 10K 5% 1/16W 1/16W 1/16W 1/8W 1/8W (US) 1/16W WM-FX193/FX195 MAIN Ref. No. Part No. Description R308 R320 R321 R601 1-216-845-11 1-216-845-11 1-216-841-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100K 100K 47K 1K 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W Remark R602 R603 R607 R609 R610 1-216-835-11 1-216-841-11 1-216-845-11 1-216-833-91 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP 15K 47K 100K 10K 1K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W Ref. No. < VARIABLE RESISTOR > RV301 RV601 1-225-362-11 RES, VAR, CARBON (VOLUME w) 1-223-994-21 RES, CARBON ADJ VAR 4.7K (TAPE SPEED) < SWITCH > S1 S301 S302 S304 S305 1-692-298-11 1-692-299-11 1-762-302-11 1-692-462-31 1-692-298-11 SWITCH, SLIDE (FM MODE) SWITCH, SLIDE (FM/AM/TAPE, RADIO OFF) SWITCH, DETECTION (SMALL TYPE) (POWER) SWITCH, SLIDE (MEGA BASS) (FX195) SWITCH, SLIDE (AVLS) Part No. Description Remark ACCESSORIES & PACKING MATERIALS ******************************* 1-505-521-11 HEADPHONE (MDR-023) (FX193:US,CND,AEP, Italian,FR,CEV/FX195:CND) 3-020-998-01 CLIP, BELT 3-867-998-11 MANUAL, INSTRUCTION (AEP,Italian,FR) (ENGLISH,FRENCH,SPANISH,PORTUGUESE, GERMAN,ITALIAN,DUTCH,SWEDISH,FINNISH) 3-867-998-21 MANUAL, INSTRUCTION (US,E5,E6) (ENGLISH, SPANISH, PORTUGUESE) 3-867-998-31 MANUAL, INSTRUCTION (CND,CH) (ENGLISH,FRENCH,SIMPLIFIED,CHINESE) 3-867-998-41 MANUAL, INSTRUCTION (E,EA) (ENGLISH,TRADITIONAL CHINESE,ARABIC) 3-867-998-51 MANUAL, INSTRUCTION (E9) (ENGLISH,TRADITIONAL CHINESE,ARABIC) 3-867-998-61 MANUAL, INSTRUCTION (CEV) (ENGLISH, RUSSIAN,HUNGARIAN,SLOVAK,POLISH, CZECH,TURKISH,GREEK) 8-953-130-90 HEADPHONE MDR-E805LP (FX193:E,E5,E6, E9,CH,EA/FX195:EXCEPT CND) < TRANSFORMER > T1 1-404-949-11 TRANSFORMER, IF (AM IF) < THERMISTOR > TH601 1-803-751-21 THERMISTOR, POSITIVE < VIBRATOR > X2 1-767-733-71 FILTER ASSY, CERAMIC ************************************************************** MISCELLANEOUS ************** HP901 L1 M901 1-500-641-11 HEAD, MAGNETIC (PLAYBACK) 1-754-084-11 ANTENNA, FERRITE-ROD (AM TRACKING) 1-763-073-11 MOTOR (CAPSTAN/REEL) ************************************************************** Sony Corporation 9-927-646-11 Personal Audio Division Company – 24 – 2000A0278-1 Printed in Japan © 2000.1 Published by General Engineering Dept.