Service Manual

Transcript

SERVICE MANUAL MICRO COMPONENT SYSTEM 1 2004 MB066 UX-H10 TIMER SET TIMER ON/OFF INTRO RANDOM SLEEP REMAIN PROGRAM REPEAT ST/MONO TAPE TUNER /BAND CD STANDBY/ON STANDBY/ON VOLUME CD BEAT CUT STANDBY MICRO COMPONENT SYSTEM UX-H10 DISPLAY /CLOCK SET MUTING SOUND /BASS VOLUME RM-SUXH10U REMOTE CONTROL CD SYNCHRO RECORDING OPEN Area Suffix US ---------------- Singapore UT ---------------------Taiwan UW ---- Brazil,Mexico,Peru TABLE OF CONTENTS 1 2 3 4 5 PRECAUTION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 SPECIFIC SERVICE INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-5 DISASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6 ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12 TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-16 COPYRIGHT © 2004 VICTOR COMPANY OF JAPAN, LIMITED No.MB066 2004/1 SPECIFICATION 10 W (5 W + 5 W) at 4 Ω (10% THD) Amplifier Section Output Power (IEC 268-3) CA-UXH10 Speakers/Impedance 4 Ω - 16 Ω Tuner FM tuning range 87.50 MHz-108.00 MHz AM tuning range AM 10 kHz intervals 530 kHz- 1 710 kHz AM 9 kHz intervals CD player Cassette deck General Dynamic range 60 dB Signal-to-noise ratio 60 dB 531 kHz-1 710 kHz Wow and flutter Immeasurable Frequency response Normal (type I) Wow and flutter 0.35 % (WRMS) Power requirement AC 110 V-127 V/ 220 V-240 V , adjustable with the voltage selector, 50 Hz/ 60 Hz Power consumption 22 W (at operation) 100 Hz-10 000 Hz 4.5 W (on standby) Dimensions (W/H/D) (approx.) 145 mm × 209 mm × 226 mm Mass (approx.) Speaker Section Type SP-UXH10 Speakers 2.6 kg Full range bass-reflex type 10 cm cone x1 Power handling capacity 5W Impedance 4Ω Frequency range 100 Hz to 15 kHz Dimensions (W/H/D) (approx.) 135 mm × 209 mm × 152 mm Mass (approx.) 1.3 kg each Design and specifications are subject to change without notice. 1-2 (No.MB066) SECTION 1 PRECAUTION 1.1 Safety Precautions (1) This design of this product contains special hardware and many circuits and components specially for safety purposes. For continued protection, no changes should be made to the original design unless authorized in writing by the manufacturer. Replacement parts must be identical to those used in the original circuits. Services should be performed by qualified personnel only. voltmeter. Move the resistor connection to each exposed metal part, particularly any exposed metal part having a return path to the chassis, and measure the AC voltage across the resistor. Now, reverse the plug in the AC outlet and repeat each measurement. Voltage measured any must not exceed 0.75 V AC (r.m.s.). This corresponds to 0.5 mA AC (r.m.s.). (2) Alterations of the design or circuitry of the product should not be made. Any design alterations of the product should not be made. Any design alterations or additions will void the manufacturers warranty and will further relieve the manufacture of responsibility for personal injury or property damage resulting therefrom. (3) Many electrical and mechanical parts in the products have special safety-related characteristics. These characteristics are often not evident from visual inspection nor can the protection afforded by them necessarily be obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified in the Parts List of Service Manual. Electrical components having such features are identified by shading on the schematics and by ( ) on the Parts List in the Service Manual. The use of a substitute replacement which does not have the same safety characteristics as the recommended replacement parts shown in the Parts List of Service Manual may create shock, fire, or other hazards. (4) The leads in the products are routed and dressed with ties, clamps, tubings, barriers and the like to be separated from live parts, high temperature parts, moving parts and/or sharp edges for the prevention of electric shock and fire hazard. When service is required, the original lead routing and dress should be observed, and it should be confirmed that they have been returned to normal, after reassembling. (5) Leakage shock hazard testing After reassembling the product, always perform an isolation check on the exposed metal parts of the product (antenna terminals, knobs, metal cabinet, screw heads, headphone jack, control shafts, etc.) to be sure the product is safe to operate without danger of electrical shock.Do not use a line isolation transformer during this check. • Plug the AC line cord directly into the AC outlet. Using a "Leakage Current Tester", measure the leakage current from each exposed metal parts of the cabinet, particularly any exposed metal part having a return path to the chassis, to a known good earth ground. Any leakage current must not exceed 0.5mA AC (r.m.s.). • Alternate check method Plug the AC line cord directly into the AC outlet. Use an AC voltmeter having, 1,000Ω per volt or more sensitivity in the following manner. Connect a 1,500Ω 10W resistor paralleled by a 0.15µF AC-type capacitor between an exposed metal part and a known good earth ground. Measure the AC voltage across the resistor with the AC AC VOLTMETER (Having 1000 ohms/volts, or more sensitivity) 0.15 F AC TYPE 1500 10W Place this probe on each exposed metal part. Good earth ground 1.2 Warning (1) This equipment has been designed and manufactured to meet international safety standards. (2) It is the legal responsibility of the repairer to ensure that these safety standards are maintained. (3) Repairs must be made in accordance with the relevant safety standards. (4) It is essential that safety critical components are replaced by approved parts. (5) If mains voltage selector is provided, check setting for local voltage. 1.3 Caution Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. 1.4 Critical parts for safety In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the " " mark nearby are critical for safety. When replacing them, be sure to use the parts of the same type and rating as specified by the manufacturer. (This regulation dose not Except the J and C version) (No.MB066)1-3 1.5 Preventing static electricity Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser diode in the traverse unit (optical pickup). Take care to prevent this when performing repairs. 1.5.1 Grounding to prevent damage by static electricity Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as CD players. Be careful to use proper grounding in the area where repairs are being performed. (1) Ground the workbench Ground the workbench by laying conductive material (such as a conductive sheet) or an iron plate over it before placing the traverse unit (optical pickup) on it. (2) Ground yourself Use an anti-static wrist strap to release any static electricity built up in your body. (caption) Anti-static wrist strap 1M Conductive material (conductive sheet) or iron palate (3) Handling the optical pickup • In order to maintain quality during transport and before installation, both sides of the laser diode on the replacement optical pickup are shorted. After replacement, return the shorted parts to their original condition. (Refer to the text.) • Do not use a tester to check the condition of the laser diode in the optical pickup. The tester's internal power source can easily destroy the laser diode. 1.6 Handling the traverse unit (optical pickup) (1) Do not subject the traverse unit (optical pickup) to strong shocks, as it is a sensitive, complex unit. (2) Cut off the shorted part of the flexible cable using nippers, etc. after replacing the optical pickup. For specific details, refer to the replacement procedure in the text. Remove the anti-static pin when replacing the traverse unit. Be careful not to take too long a time when attaching it to the connector. (3) Handle the flexible cable carefully as it may break when subjected to strong force. (4) I t is not possible to adjust the semi-fixed resistor that adjusts the laser power. Do not turn it. 1.7 Attention when traverse unit is decomposed *Please refer to "Disassembly method" in the text for the CD pickup unit. • Apply solder to the short land sections before the flexible wire is disconnected from the connector on the CD servo board. (If the flexible wire is disconnected without applying solder, the CD pickup may be destroyed by static electricity.) • In the assembly, be sure to remove solder from the short land sections after connecting the flexible wire. 1-4 (No.MB066) SECTION 2 SPECIFIC SERVICE INSTRUCTIONS This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS. (No.MB066)1-5 SECTION 3 DISASSEMBLY 3.1 Main body 3.1.1 Removing the Front panel assembly (See Fig.1 ~ 5) (1) Remove the two screws A and the two screws B on the back of the body. (2) Remove the four screws C on each side of the body. (3) Remove the two screws D on the bottom of the body. (4) Move the front panel assembly in the direction of the arrow and detach. Disconnect the wire from connector CN860 and FM-ANT. Front panel assembly D Caution: When reassembling, set the tab “a” on the right and left side to the groove, and move. CD mechanism assembly A Fig.3 CD mechanism assembly Joint a B Fig.1 Front panel assembly Front panel assembly Joint a Fig.4 C FM-ANT Fig.2 CN860 Fig.5 1-6 (No.MB066) 3.1.2 Removing the Main board (See Fig.6 , 7) • Prior to performing the following procedure, remove the front panel assembly. (1) Disconnect the wire from all connectors on the main board. (2) Remove the two screws E and release the joint b. Front panel assembly CN260 CD mechanism assembly CN602 CN601 CN301 CN370 CN801 CN850 CN851 Main board Fig.6 Front panel assembly Joint b E CD mechanism assembly Main board Fig.7 (No.MB066)1-7 3.1.3 Removing the CD mechanism assembly and the Switch board (See Fig.8 ~ 10) • Prior to performing the following procedure, remove the front panel assembly and the main board. (1) Cut off the four bands setting the wires. Front panel assembly (2) Disconnect the wire from connector on the CD open switch and CN705 on the CD mechanism board. Band (3) Remove the two screws F on the front panel assembly. (4) Release the joint d of the CD mechanism assembly. (5) Remove the five screws G attaching the switch board to the CD mechanism assembly. F Band Open switch connecter CD mechanism assembly CN705 F Fig.8 CD mechanism assembly Joint d Front panel assembly Fig.9 Front panel assembly G Switch board G CD mechanism assembly Fig.10 1-8 (No.MB066) 3.1.4 Removing the CD mechanism board (See Fig.11 ~ 13) • Prior to performing the following procedure, remove the front panel assembly, the main board and the CD mechanism assembly. (1) Disconnect connector on the CD mechanism. (2) Remove the four screws H on the CD mechanism assembly. (3) Cut off the band setting each wire and disconnect the card wire from connector on the CD mechanism. (4) Remove the screw J attaching the wire on the CD mechanism board. Front panel CD mechanism board Switch board Caution: The metal washer and nut come off. (5) Remove the four screws K attaching the CD mechanism. H H Connecter Band CD mechanism assembly Fig.11 CD mechanism board Connecter Band J Nut CD mechanism assembly Fig.12 CD mechanism CD mechanism assembly K K Fig.13 (No.MB066)1-9 3.1.5 Removing the Headphone board (See Fig.14) • Prior to performing the following procedure, remove the front panel assembly, the main board and the CD mechanism assembly. (1) Remove the screw L on the bracket and pull out the headphone board. Head phones board Head phones bracket L CD mechanism assembly Fig.14 3.1.6 Removing the LCD board (See Fig.15) • Prior to performing the following procedure, remove the front panel assembly, the main board and the CD mechanism assembly. (1) Remove the ten screws M and the two screws N on the Front panel assembly. Switch board M M N M LCD board Front panel assembly Fig.15 3.1.7 Removing the Cassette mechanism (See Fig.16) • Prior to performing the following procedure, remove the front panel assembly and the main board. (1) Remove the four screws P on the front panel assembly and press the eject button on the front side to remove the cassette mechanism assembly. P P Cassette mechanism assembly. Fig.16 1-10 (No.MB066) 3.1.8 Removing the Transformer board (See Fig.17) • Prior to performing the following procedure, remove the front panel assembly. (1) Remove the screw Q on the rear cover assembly. (2) Pull out the transformer board in the direction of the arrow. (3) Unsolder the wire extending from the transformer. Trans borad Solder point Q Fig.17 3.1.9 Removing the Transformer (See Fig.18 , 19) • Prior to performing the following procedure, remove the front panel assembly and the transformer board. (1) Remove the two screws R attaching the voltage selector on the bottom of the rear cover assembly. (2) Remove the four screws S on the rear cover assembly. (3) Remove the two screws T setting the power cord on the rear cover assembly. (4) Cut off the band connecting the power cord to the transformer if necessary, remove the transformer. 3.1.10 Removing the FM-antenna board (See Fig.19) • Prior to performing the following procedure, remove the front panel assembly. (1) Remove the screw U on the rear cover assembly. (2) Unsolder the FM-antenna wire on the FM-antenna board. R Fig.18 Solder point FM ANT board e Section U S T S Fig.19 (No.MB066)1-11 SECTION 4 ADJUSTMENT 4.1 (1) (2) (3) (4) (5) (6) (7) (8) (9) (10) (11) Measuring instructions required for adjustment AM signal generator FM signal generator Intter mediate frequency sweep generater FM stereo signal generator Low-frequency oscillator (oscillation frequency 50 Hz-20 kHz, 0dB output with 600 Ω impeadance) Attenuator (600 Ω impeadance) Electric voltmeter Distotion meter Torque guage (cassette for CTG-N) Wow & flutter meter Frequency counter meter 4.1.1 Amplifier section Reference output Speaker output 0 dB(1V)/ 4 Ω H. Phone output -10 dB(0.1V) 32Ω 4.1.2 CD section Test disc: JVC standard disc 4.1.3 Test tape JVC standard test tape 4.1.4 Measuring instruments Radio section FM 1 kHz, 22.5 kHz deviation FM STEREO : 1kHz, 67.5 kHz deviation Pilot signal: 7.5 kHz AM : 1 kHz, 30% modulation Reference output: Speaker output : 0 dB (1V) 4 Ω Headphone output : -10 dB (0.1V) 32 Ω 1-12 (No.MB066) 4.1.5 Cassette Amplifier Section Item Measuring Condition Check and adjustment procedure Head azimuth adjustment Test tape: 8 kHz Signal output terminal: PHONES (with 32 ohm load) 1. Play back the test tape (8 kHz). 2. Adjust the head azimuth adjusting screw so that the phase difference between the R and L channels is minimized at an output level that is within 2 dB of the maximum output level. After thie adjustment, lock the head azimuth adjusting screw with screw, sealant to cover more than a half of the screw head. 3. When the head azimuth is maladjusted, correct it with the head azimuth adjusting screw. Tape speed and wow/ flutter check and adjustment Test tape: 3 kHz Signal output terminal: PHONES (with 32 ohm load) 1. Play back the test tape (3 kHz) by the end portion. 2. Connect a frequency counter and check that it reads between 2940 and 3090 Hz. If not, adjust the frequency with the motor semifixed resistor. 3. Check that the wow/flutter is within 0.38% (unweighted.) PB frequency response check Test tape: Signal output termnal: PHONES (with 32 ohm load) Bias frequency check REC and PB frequency response adjustment Tape: Normal Signal output terminal: Cassette REC./PLAY HEAD Test tape: Signal input FM22.5 DEV 60dB with Emphasis signal output terminal: PHONES (with 32 ohm load) Standard value Adjusting part Output level: Within 2 dB of maximum output level Phase difference L and R channels: Minimum Head azimuth adjusting screw (To be used only after head replacement) See Fig 3-1 2940 to 3090 Hz Tape speed: Motor semifixed resister Within 0.38% (unweighted) check only Play back the test tape while con-firming that deviation between the 1 kHz signal and 8 kHz signal should be 0 (+3~-6) dB. Deviation between 1 kHz and 8 kHz: 0 (+3~-6) dB Set the TUNER or CD function and with TAPE to record. Check to see if the frequency at the measuring point T360 is 60 kHz 1 kHz if not adjst T360 until the frequency counter indicates 60 kHz 1 kHz. T360 At TUNER, set the BAND to the FM position, and record the reference 1 kHz signal and 8kHz signal alternately repeatedly. While playing back the recorded signal differ from that of the 1 kHz signal by within 0 (+3~-6) dB. Level difference between REC and PB: Within 0 (+3~-6) dB. (No.MB066)1-13 4.1.6 Tuner Section Item Measuring Condition Check and adjustment procedure AM IF adjustment Signal input: Loop ANTENNA Signal output: U201 PIN 16 1.Set the intermediate frequency sweep generator to AM 450 kHz. 2.Adjust the T201 for maximum and center output. AM tracking adjustment Signal input: Loop antenna PHONES (with 32 ohm Load) 1.Set the TUNER at 531 kHz adjust T202 until the test pin of R229 Voltage at 1.5V 0.1V. 2.Set the TUNER at 1710 kHz, Check the pin of R229 Voltage at 8.4V 6V. 3.Set theTUNER and S/G at 603 kHz, adjust T204 for maximum output. 4.Set the TUNER and S/G at 1404 kHz, adjust VC201 for maximum output. 5.Repeat the above steps 3 and 4. FM Tracking Adjustment 1-14 (No.MB066) Signal input point: FM-ANT Phones With 32 ohm load 1.Set the Tuner at 87.5MHz adjust L203 until the test pin of R230 voltage at 2.4V 0.1V 2.Set the Tuner at 108MHz. Check the pin of R230 voltage at 8 0.8V 3.Set the Tuner and S/G at 90.1MHz. Adjust L204 for maximum output. 4.Set the Tuner and S/G at 106.1MHz. Adjust VC 202 for maximum output. 5.Repeat the above step 3 and 4 Standard value Adjusting part T201 See Fig 3-3 T202 T204 R229 VC201 R230 L204 VC202 Location of adjusting parts Cassette mechanism section + - CASSETTE MOTOR Tape Speed Adj. Figure 3-1 Head Output Signal Figure 3-2 Main board assembly (FM OSC) L203 R230 (FM VT) VC202 (FM RF) L204 (FM RF) FM-ANT R229 T202 (AM OSC) T201 T204 (AM VT) (AM RF) T202 (AM RF) (AM lF) T360 (BIAS FREQUENCY) (No.MB066)1-15 SECTION 5 TROUBLESHOOTING Circuit General AM FM Symptom No sound No sound, weak sound (Low sensitivity) No sound, weak sound (Low sensitivity) Tape No sound / Recording Unsteady tape sound, weak sound CD Cannot read the TOC. no sound 1-16 (No.MB066) Cause and Remedy Speakers are not connected: Check the speaker connection. Wrong function is selected: Set switch to the proper position. Defective volume control: Set the volume control to a proper sound level. Defective the Headphone jack: Replace the headphone jack. Defect in U801 Check voltages. Replace if necessary. Defect in U601 Check voltages. Replace if necessary. Improper location of unit: Rotate or reposition the unit. Defect in IF T201: Check registance, voltage, and current. Replace as needed. Defect AM antenna coil L202 or oscilloscope coil T202: Replace if necessary. Intermediate frequency tuning faulty: Readjust (see "Adustment"). RF tracking faulty: Readjust (see "Adjustment"). Defective U201: Check voltages. Replace if necessary. Defective U260: Check voltages. Replace if necessary. Poor contact in antenna circuit: Check resistance and resolder. FM antenna not connected: Connect the built-in or external antenna. Defective band selector switch: Replace or repair the switch. Defective U201: Check voltages. Replace if necessary. Defective U260: Check voltages. Replace if necessary. Intermediate frquencytuning faulty: Readjust (see !Adjustment"). Poor contact in FM antenna circuit: Resolder or repair as required. Dirty capstan or head: Clean the capstan or head with alcohol. Irreguler cassette tape winding: Replace tape. Defective U301: Check voltage. Replace if necessary. Cassette erasure prevention tabs broken out: Replace tape or cover tab openings with adhesive tape. Disc is inserted upside down: Insert disc correctry. Disc is dirty: Wipe clean with a soft cloth. Disc is scratched: Use a new disc. Disc is seriously warped: Use a new disc. A non-standard disc has been inserted: Use only a barand neme disc. Moisuture has formed inside the CD deck: Wait about 20 to 30 minutes. Defective IC701: Check voltages. Replace if necessary. Defective IC702: Check voltages. Replace if necessary. Defective IC703: Check voltages. Replace if necessary. Defect in the CD pickup mechanism: Replace as required. (No.MB066)1-17 VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.MB066) Printed in Japan WPC SCHEMATIC DIAGRAMS MICRO COMPONENT SYSTEM UX-H10 CD-ROM No.SML200401 TIMER SET TIMER ON/OFF INTRO RANDOM SLEEP REMAIN PROGRAM REPEAT ST/MONO TAPE TUNER /BAND CD STANDBY/ON STANDBY/ON VOLUME CD BEAT CUT STANDBY MICRO COMPONENT SYSTEM UX-H10 DISPLAY /CLOCK SET MUTING SOUND /BASS VOLUME RM-SUXH10U REMOTE CONTROL CD SYNCHRO RECORDING OPEN Area Suffix US ---------------- Singapore UT ---------------------Taiwan UW ---- Brazil,Mexico,Peru Contents Block diagram ------------------------------------------------------- 2-1 Standard schematic diagrams ---------------------------------- 2-2 Printed circuit boards --------------------------------------------- 2-9 to 12 COPYRIGHT 2004 VICTOR COMPANY OF JAPAN, LTD. No.MB066SCH 2004/1 In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the " " mark nearby are critical for safety. (This regulation does not correspond to J and C version.) Block diagram 2-1 Standard schematic diagrams Power supply section Parts are safety assurance parts. When replacing those parts make sure to use the specified one. 2-2 Amp section Parts are safety assurance parts. When replacing those parts make sure to use the specified one. 2-3 Display section 2-4 Remote section 2-5 CD section Parts are safety assurance parts. When replacing those parts make sure to use the specified one. 2-6 Cassette section Parts are safety assurance parts. When replacing those parts make sure to use the specified one. 2-7 Tuner section 2-8 Printed circuit boards Main board 2-9 CD board 2-10 Power board (forward side) Display board (forward side) Power board (reverse side) Display board (reverse side) 2-11 FM antenna board Headphone board LED board Remocon board (forward side) Key board (forward side) Remocon board (reverse side) Key board (reverse side) 2-12 < MEMO > VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.MB066SCH) Printed in Japan WPC PARTS LIST [ UX-H10 ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix US ---------------------- Singapore UT --------------------------- Taiwan UW ---------- Brazil,Mexico,Peru - Contents Exploded view of general assembly and parts list (Block No.M1) Electrical parts list (Block No.01~05) Packing materials and accessories parts list (Block No.M3) MB066 3- 2 3- 5 3-12 3-1 Exploded view of general assmbly and parts list Block No. M 1 M M 15 PHONE BOARD 1 7 a' a 8 g 2 3 68 KEY BOARD 4 11 21 r 5 LED BOARD 63 64 72 6 71 68 62 73 67 72 22 A 69 39 68 69 r m 69 B 38 54 h 68 56 CN704 58 55 F 65 53 55 52 59 51 DISPLAY BOARD n 69 d c p 69 17 q 48 68 50 55 49 47 46 45 40 44 CD BOARD 70 E 55 3-2 72 k e 37 c 22 12 60 20 43 42 41 75 M M 15 16 MAIN BOARD H a' 7 D 33 35 a FM ANT BOARD f 70 73 g 17 A 70 g 68 13 11 20 14 21 r 80 72 71 68 n k q p B 71 18 e 34 h j m 81 c 75 21 22 28 78 72 22 69 19 82 b 72 79 k 9 H f d h 68 69 72 76 CN704 74 F E b DISPLAY BOARD 9 p 27 CD BOARD 70 D 70 26 74 30 69 q 74 70 G 77 24 29 F902 69 68 31 70 F901 69 POWER BOARD 40 j G 32 D 76 3-3 General assembly  Symbol No. Block No. [M][1][M][M]  Symbol No. Part No. Part Name Description 1 2 3 4 5 6 7 8 11 12 13 14 15 16 17 18 19 20 OW43-00010-00 OW66-00010-03 OW39-04200-00 OW97-09019-00 OW49-04200-00 OW55-09019-01B OW48-00010-05 OW53-00010-00 OW39-00010-00 OW48-04200-01 OW55-00141-02 OW36-00003-04 OW16-10101-92L OW36-03232-02 OW63-00303-01 OW48-07930-08 OW98-04200-00 OW35-00003-00 CD DOOR LENS CD DOOR METAL COVER P.C.MAGNET STABILIZER RING PLASTIC COVER CD TRAY FUNCTION KNOB PHONE PCB BKT CD BKT. PUSH ROD CD EJECT SPRING CD DOOR SWITCH CD DOOR SPRING DAMPER CD MECHA COVER CD MECHA E RING PMMA ABS 21 OW81-02750-00 CD DAMPER 22 OW81-02750-01 CD DAMPER 24 26 27 OW48-00010-01 OW35-10019-00 OW61-00010-03 POWER PCB BKT FIBRE WASHER REAR CABINET OW30-00020-01S AC POWER CORD  28  28 OW30-00010-06 AC POWER CORD 29 OW81-04200-00 RUBBER FOOT 30  31  32 33 34 35 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 58 59 60 62 63 64 65 67 68 69 70 71 72 73 74 75 76 77 78 OW81-00010-00 OW49-00010-00 OW15-00010-05 TA8229K KTD2058 OW39-04200-02 OW48-00010-03 OW36-00010-00 OW48-00010-02 OW39-04200-04 OW53-00010-06 OW53-00010-08 OW53-00010-04 OW53-00010-05 OW53-00010-03 OW53-00010-07 OW66-00010-02 OW36-00010-01 OW43-00010-01 OW66-00010-01 OW48-04200-04 OW43-00010-03 OW55-30000-00 OW60-00010-01 OW39-04200-05 OW53-00010-01 OW53-00010-02 OW94-04200-00 OW91-80010-00 OW43-00010-04 OW43-00010-02 OW68-00010-00 OW48-00010-00 OW40-02045-90 OW40-12608-01 OW40-13010-01 OW40-13008-01 OW40-02005-90 OW40-52610-03 OW40-12606-01 OW40-03006-22 OW40-13008-41 OW40-13012-01 OW40-03010-02 OW16-10212-00 RUBBER FOOT AC CORD HOLDER TRANS FORMER IC TRANSISTOR HEAT SINK MAIN PCB BKT2 CASS KNOB MAIN PCB BKT1 CASS KNOB BKT CASS KNOB CASS KNOB CASS KNOB CASS KNOB CASS KNOB CASS KNOB CASS KNOB CASS DOOR SPRIN CASS DOOR LENS CASS DOOR CASS DOOR BKT DISPLAY LENS JVC BADGE FRONT CABINET PANEL FIXING POWER KNOB VOLUME KNOB CASS DECK LCD LCD FILTER LIGHT GUIDE LIGHT GUIDE LCD BKT SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW SCREW VOLTAGE SW. 3-4 Local 20495830 W/O Felt HIPS ABS BKT. ABS NSX01-050 DLS-02-1 Gear B40GG(x2) Thomson CD Thomson TCP11TK M3 3140-114-13892(x2) 3140-114-13902(x2) BKT. F14 X F3 X 1.5mm US UW UT F11X3mm W/ Tape(x2) 13X6mm ABS OW03-08229-00 OW01-02058-00 Door Plate Pause Stop/Eject F.FWD REW. Play REC. Door Spring Lens ABS BKT. PMMA ABS HB Plate(x6) ABS ABS CS-2SC-3222 PMMA Paper 0.15TH BKT. F 2.0 X 4.5 F 2.6 X 8(x18) F 3.0 X 10(x14) F 3.0 X 8(x8) F2.0 X 5(x3) F2.6 X 10(x4) F2.6 X 12(x3) M3 X 6(x6) F3.0 X 8(x2) F3.0 X12(x6) M3 X 10(x2) 79 80 81 82 Part No. Part Name Description OW40-03005-01 OW35-40007-00 OW35-20001-04 OW35-30005-00 SCREW STEEL NUT TOOTH WASHER SOLDERING LUG M3 X 5 M3 M3 F3.5mm L=9mm Local Electrical parts list Main board  Symbol No. Block No. [0][1][0][0]  Symbol No. Part No. Part Name Description Q204 Q205 Q206 Q207 Q209 Q210 Q260 Q261 Q262 Q263 Q280 Q281 Q300 Q301 Q302 Q303 Q304 Q305 Q306 Q307 Q308 Q309 Q310 Q311 Q312 Q313 Q314 Q315 Q316 Q317 Q318 Q319 Q360 Q361 Q370 Q803 Q804  Q830 Q831 Q832 Q850 Q851  Q860  Q861 9014 9014 9014 9014 9014 9014 9014 9014 9014 9014 9014 8550 8050 2SC2412 2SC2412 2SC2412 2SC2412 2SC2412 2SC2412 8050 8050 9014 9014 9014 9014 9014 9014 9014 9014 8550 8550 9014 8050 2SC2412 8550 9014 9014 KTD2058Y 8550 9014 2SB926T-AA 9014 2SC945P 2SC1383R TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-08550-06 S OW01-08050-06 S OW01-02412-00R OW01-02412-00R OW01-02412-00R OW01-02412-00R OW01-02412-00R OW01-02412-00R OW01-08050-06 S OW01-08050-06 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-09014-05 S OW01-08550-06 S OW01-08550-06 S OW01-09014-05 S OW01-08050-06 S OW01-02412-00R OW01-08550-06 S OW01-09014-05 S OW01-09014-05 S OW01-02058-00 K OW01-08550-06 S OW01-09014-05 S OW01-00926-01 OW01-09014-05 S OW01-00945-16 N OW01-01383-19 D201 D202 D203 D204 D205 D221 D301 D302 D303 D304 D306 D307 D370 D801 D850 D851 D862 D863 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1N4001 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE FR DIODE OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-04001-00 OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R C200 C201 C203 C204 C205 C206 C207 C209 OW05-00220-06 OW05-00220-06 OW06-50474-20 OW05-03102-06T OW05-00102-82 OW05-00030-06 OW06-50475-02 OW05-02103-10 C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR M CAPACITOR 22PF NPO 22PF NPO 0.47MF 50V PITC 1000PF 0.001MF +80-20% 3PF NPO 4.7MF 50V PITCH 0.01MF Local C210 C211 C212 C214 C215 C216 C217 C219 C220 C221 C222 C223 C224 C225 C226 C227 C229 C230 C231 C232 C233 C234 C235 C236 C237 C238 C239 C240 C244 C245 C247 C248 C260 C261 C262 C263 C264 C265 C266 C267 C269 C270 C272 C273 C274 C284 C285 C286 C287 C292 C293 C294 C301 C302 C303 C304 C307 C308 C309 C310 C311 C312 C315 C316 C317 C318 C319 C320 C321 C322 C323 C324 C325 C326 C327 C328 Part No. Part Name Description OW05-02103-10 OW06-50475-02 OW06-50475-02 OW05-03223-06T OW05-02202-10 OW05-02202-10 OW05-03223-06T OW06-50104-03 OW06-50105-02 OW06-50104-03 OW06-50475-02 OW05-03331-03T OW05-07223-82A OW05-03103-06T OW05-03200-03T OW05-03473-06T OW05-00473-82 OW05-00180-06 OW05-00102-82 OW05-03080-03T OW05-03102-06T OW05-03103-06T OW05-03102-06T OW06-16227-02 OW05-03330-03T OW05-09391-05 OW05-03473-06T OW06-16226-02 OW05-00120-06 OW05-00102-82 OW05-03222-06T OW05-03222-06T OW05-03330-03T OW05-03330-03T OW05-03223-06T OW06-16107-02 OW05-03103-06T OW05-03102-06T OW06-50335-02 OW05-03223-06T OW06-50105-02 OW05-03223-06T OW06-25477-02 OW05-07104-82B OW05-03101-06T OW05-03104-06T OW05-03221-03T OW05-03221-03T OW05-03221-03T OW05-03104-06T OW05-07102-10A OW05-03223-06T OW05-03102-06T OW05-03102-06T OW06-16227-02 OW06-16227-02 OW05-03331-03T OW05-03331-03T OW06-50475-02 OW06-50475-02 OW05-03272-06T OW05-03272-06T OW05-02333-10 OW05-02333-10 OW05-02333-10 OW05-02333-10 OW06-50104-03 OW06-50104-03 OW05-03152-06T OW05-03152-06T OW06-50105-02 OW06-25106-02 OW06-16227-02 OW05-03223-06T OW05-03182-06T OW05-03182-06T M CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR M CAPACITOR M CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR CHIP CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR CHIP CAPACITOR P CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR CHIP CAPACITOR CHIP CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR CHIP CAPACITOR CHIP CAPACITOR CHIP CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR CHIP CAPACITOR CHIP CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR M CAPACITOR M CAPACITOR M CAPACITOR M CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR 0.01MF 4.7MF 50V PITCH 4.7MF 50V PITCH 0.022MF 0.002MF 0.002MF 0.022MF 0.1MF 50V 1MF 50V PITCH=5 0.1MF 50V 4.7MF 50V PITCH 330PF 0.022MF 0.01MF B500 K10 20PF N500 J200 0.047MF B500 K4 0.047MF 18PF NPO 0.001MF +80/-20 8PF 1000PF B500 K10 0.01MF B500 K10 1000PF B500 K10 220MF 16V PITCH 33PF N500 J330 390PF 0.047MF B500 K4 22MF 16V PITCH= 12PF NPO 0.001MF +80/-20 2200PF B500 K22 2200PF B500 K22 33PF N500 J330 33PF N500 J330 0.022MF B500 K2 100MF 16V 0.01MF B500 K10 1000PF B500 K10 3.3MF 50V PITCH 0.022MF B500 K2 1MF 50V PITCH=5 0.022MF B500 K2 470MF 25V PITCH 0.1MF 50V 100PF N101J 500 0.1MF 220PF N500 J221 220PF N500 J221 220PF N500 J221 0.1MF 1000PF 0.022MF B500 K2 1000PF B500 K10 1000PF B500 K10 220MF 16V PITCH 220MF 16V PITCH 330PF N500 J331 330PF N500 J331 4.7MF 50V PITCH 4.7MF 50V PITCH 0.002MF B500 K2 0.0027MF 0.033MF 0.033MF 0.033MF 0.033MF 0.1MF 50V 0.1MF 50V 1500PF B500 K15 1500PF B500 K15 1MF 50V PITCH=5 10MF 25V PITCH= 220MF 16V PITCH 0.022MF B500 K2 0.0018MF B500 K 0.0018MF B500 K Local 3-5  Symbol No. Part No. Part Name Description C329 C330 C331 C332 C333 C334 C335 C336 C337 C338 C339 C340 C341 C342 C343 C344 C345 C360 C361 C362 C363 C364 C365 C366 C367 C370 C371 C372 C373 C374 C601 C602 C603 C604 C605 C606 C607 C608 C611 C612 C615 C616 C617 C618 C619 C620 C621 C622 C623 C624 C625 C626 C628 C629 C630 C631 C801 C802 C803 C807 C808 C809 C810  C811  C812 C813 C814 C815 C816 C817 C818  C819 C820 C823 C825 C826 C830 C831 OW06-50105-02 OW06-50105-02 OW06-50105-02 OW06-50105-02 OW05-02102-10 OW05-02102-10 OW05-03151-03T OW05-03151-03T OW05-03151-03T OW05-03151-03T OW06-16227-02 OW06-25106-02 OW06-16476-02 OW06-25106-02 OW06-16107-02 OW05-03223-06T OW06-16475-02 OW05-02392-10 OW05-03331-03T OW05-02103-10 OW05-02102-10 OW05-02102-10 OW06-16336-02 OW05-03223-06T OW05-03223-06T OW05-03223-06T OW05-03223-06T OW05-03223-06T OW06-16227-02 OW05-07223-82A OW06-50475-02 OW06-50475-02 OW06-50475-02 OW06-50475-02 OW06-50475-02 OW06-50475-02 OW06-50475-02 OW06-50475-02 OW06-50475-02 OW06-50475-02 OW05-02104-10 OW05-02104-10 OW06-50105-02 OW06-50105-02 OW06-50475-02 OW06-50475-02 OW05-02103-10 OW05-02103-10 OW06-16227-02 OW05-03104-06T OW06-16107-02 OW05-07223-82A OW05-03221-03T OW05-03221-03T OW05-03103-06T OW05-03103-06T OW06-16226-02 OW05-03102-06T OW05-03102-06T OW06-50225-02 OW06-50225-02 OW06-16476-02 OW06-16476-02 OW06-16108-00 OW06-16108-00 OW06-16107-02 OW06-16107-02 OW05-02154-10 OW05-02154-10 OW05-03104-06T OW06-16227-02 OW06-25338-00 OW06-25477-02 OW05-07104-82B OW05-03104-06T OW05-03104-06T OW05-03104-06T OW06-16107-02 E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR M CAPACITOR M CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR M CAPACITOR CHIP CAPACITOR M CAPACITOR M CAPACITOR M CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR M CAPACITOR M CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR M CAPACITOR M CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR CHIP CAPACITOR CHIP CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR M CAPACITOR M CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR 1MF 50V PITCH=5 1MF 50V PITCH=5 1MF 50V PITCH=5 1MF 50V PITCH=5 0.001MF 0.001MF 150PF N151J 500 150PF N151J 500 150PF N151J 500 150PF N151J 500 220MF 16V PITCH 10MF 25V PITCH= 47MF 16V 10MF 25V PITCH= 100MF 16V 0.022MF B500 K2 4.7MF 16V 0.0039MF 330PF N500 J331 0.01MF 0.001MF 0.001MF 33MF 16V PITCH= 0.022MF B500 K2 0.022MF B500 K2 0.022MF B500 K2 0.022MF B500 K2 0.022MF B500 K2 220MF 16V PITCH 0.022MF 4.7MF 50V PITCH 4.7MF 50V PITCH 4.7MF 50V PITCH 4.7MF 50V PITCH 4.7MF 50V PITCH 4.7MF 50V PITCH 4.7MF 50V PITCH 4.7MF 50V PITCH 4.7MF 50V PITCH 4.7MF 50V PITCH 0.1MF 0.1MF 1MF 50V PITCH=5 1MF 50V PITCH=5 4.7MF 50V PITCH 4.7MF 50V PITCH 0.01MF 0.01MF 220MF 16V PITCH 0.1MF 100MF 16V 0.022MF 220PF N500 J221 220PF N500 J221 0.01MF B500 K10 0.01MF B500 K10 22MF 16V PITCH= 1000PF B500 K10 1000PF B500 K10 2.2MF 50V 2.2MF 50V 47MF 16V 47MF 16V 1000MF 16V 1000MF 16V 100MF 16V 100MF 16V 0.15MF 0.15MF 0.1MF 220MF 16V PITCH 3300MF 25V 470MF 25V 0.1MF 50V 0.1MF 0.1MF 0.1MF 100MF 16V 3-6 Local  Symbol No. Part No. Part Name Description C832 C833 C851 C852 C853 C860 C861 C862 C863 VC201 VC202 OW05-03104-06T OW05-03104-06T OW05-00104-82 OW06-25108-00 OW05-03104-06T OW06-25106-02 OW06-25106-02 OW06-16107-02 OW06-16227-02 OW05-08200-03 OW05-08100-03 C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR TR CAPACITOR TR CAPACITOR 0.1MF 0.1MF 0.1MF +80%-20% 1000MF 25V 0.1MF 10MF 25V PITCH= 10MF 25V PITCH= 100MF 16V 220MF 16V PITCH 20PF 3PIN 10PF 3PIN R146 R147 R200 R201 R202 R203 R207 R209 R211 R212 R213 R214 R215 R216 R218 R222 R223 R225 R226 R227 R228 R229 R230 R232 R233 R235 R236 R238 R239 R242 R247 R248 R260 R261 R262 R263 R265 R266 R267 R268 R269 R270 R271 R272 R273 R274 R275 R276 R277 R278 R279 R280 R281 R282 R284 R285 R286 R290 R293 R294 R301 R302 R303 R304 R305 R306 OW07-15121-50T OW07-15121-50T OW07-25274-60K OW07-25331-60K OW07-25103-60K OW07-15473-50T OW07-25103-60K OW07-15100-50T OW07-25123-60K OW07-25123-60K OW07-25392-60K OW07-25392-60K OW07-25473-60K OW07-25102-60K OW07-25473-60K OW07-25332-60K OW07-25332-60K OW07-15102-50T OW07-25104-60K OW07-25222-60K OW07-15220-50T OW07-15103-50T OW07-15473-50T OW07-15221-50T OW07-15101-50T OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25223-60K OW07-25822-60K OW07-25822-60K OW07-25000-60K OW07-25102-60K OW07-25102-60K OW07-25102-60K OW07-25102-60K OW07-25102-60K OW07-25561-60K OW07-25152-60K OW07-25152-60K OW07-25102-60K OW07-25472-60K OW07-25472-60K OW07-15221-50T OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25102-60K OW07-25102-60K OW07-15103-50T OW07-25103-60K OW07-15103-50T OW07-25182-60K OW07-15102-50T OW07-15102-50T OW07-25104-60K OW07-25103-60K OW07-25274-60K OW07-25224-60K OW07-25102-60K OW07-25102-60K OW07-25332-60K OW07-25332-60K OW07-25150-60K OW07-25150-60K C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR 120 1/8W 52MM T 120 1/8W 52MM T 270K RMC 1/16 330 1/8W 10K RMC 1/16 10 47K 1/8W 52MM T 10K RMC 1/16 10 10 1/8W 52MM T. 12K RMC 1/16 12 12K RMC 1/16 12 3.9K RMC 1/16 3.9K RMC 1/16 47K RMC 1/16 47 1K RMC 1/16 102 47K RMC 1/16 47 3.3K RMC 1/16 3.3K RMC 1/16 1K 1/8W 52MM T. 100K RMC 1/16 2.2K RMC 1/16 22 1/8W 52MM T. 10K 1/8W 52MM T 47K 1/8W 52MM T 220 1/8W 52MM T 100 1/8W 52MM T 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 22K RMC 1/16 22 8.2K RMC 1/16 8.2K RMC 1/16 0 RMC 1/16 000J 1K RMC 1/16 102 1K RMC 1/16 102 1K RMC 1/16 102 1K RMC 1/16 102 1K RMC 1/16 102 560 1/16 561JTP 1.5K RMC 1/16 1.5K RMC 1/16 1K RMC 1/16 102 4.7K RMC 1/16 4.7K RMC 1/16 220 1/8W 52MM T 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 1K RMC 1/16 102 1K RMC 1/16 102 10K 1/8W 52MM T 10K RMC 1/16 10 10K 1/8W 52MM T 1.8K RMC 1/16 1K 1/8W 52MM T. 1K 1/8W 52MM T. 100K RMC 1/16 10K RMC 1/16 10 270K RMC 1/16 220K RMC 1/16 1K RMC 1/16 102 1K RMC 1/16 102 3.3K RMC 1/16 3.3K RMC 1/16 15 1/16 150JTP 15 1/16 150JTP Local  Symbol No. Part No. Part Name Description R307 R308 R309 R310 R311 R312 R313 R314 R315 R316 R317 R318 R319 R320 R321 R322 R323 R324 R325 R326 R327 R328 R329 R330 R331 R332 R333 R334 R335 R336 R337 R338 R339 R340 R341 R342 R343 R344 R345 R346 R347 R348 R349 R350 R351 R352 R353 R354 R355 R356 R357 R358 R360 R361 R362 R364 R365 R366 R369 R371  R372 R373 R600 R601 R602 R603 R604 R605 R606 R607 R617 R618 R619 R620 R801 R802 R803 R804 OW07-25472-60K OW07-25472-60K OW07-25332-60K OW07-25332-60K OW07-25472-60K OW07-25472-60K OW07-25562-60K OW07-25562-60K OW07-15153-50T OW07-15153-50T OW07-25222-60K OW07-25222-60K OW07-25473-60K OW07-25473-60K OW07-25473-60K OW07-25102-60K OW07-25683-60K OW07-25683-60K OW07-25101-60K OW07-25101-60K OW07-25473-60K OW07-25473-60K OW07-25823-60K OW07-25823-60K OW07-25223-60K OW07-25223-60K OW07-25103-60K OW07-25103-60K OW07-25333-60K OW07-25333-60K OW07-15181-50T OW07-25151-50K OW07-25684-60K OW07-25102-60K OW07-15680-50T OW07-25681-60K OW07-25102-60K OW07-25104-60K OW07-25472-60K OW07-25222-60K OW07-25103-60K OW07-25102-60K OW07-25103-60K OW07-25103-60K OW07-15223-50T OW07-25103-60K OW07-25562-60K OW07-25562-60K OW07-25683-60K OW07-25103-60K OW07-25202-60K OW07-25000-60K OW07-25103-60K OW07-25333-60K OW07-25104-60K OW07-15820-00 OW07-15273-50T OW07-25047-60K OW07-25224-60K OW07-25104-60K OW07-15100-08 OW07-15472-50T OW07-15121-50T OW07-15393-50T OW07-25393-60K OW07-25182-60K OW07-25182-60K OW07-25000-60K OW07-25472-60K OW07-25472-60K OW07-15472-50T OW07-25472-60K OW07-25472-60K OW07-25472-60K OW07-25123-60K OW07-25123-60K OW07-15472-50T OW07-25473-60K C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR FUSE RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR 4.7K RMC 1/16 4.7K RMC 1/16 3.3K RMC 1/16 3.3K RMC 1/16 4.7K RMC 1/16 4.7K RMC 1/16 5.6K RMC 1/16 5.6K RMC 1/16 15K 1/8W 52MM T 15K 1/8W 52MM T 2.2K RMC 1/16 2.2K RMC 1/16 47K RMC 1/16 47 47K RMC 1/16 47 47K RMC 1/16 47 1K RMC 1/16 102 68K RMC 1/16 68 68K RMC 1/16 68 100 RMC 1/16 100 RMC 1/16 47K RMC 1/16 47 47K RMC 1/16 47 82K RMC 1/16 82 82K RMC 1/16 82 22K RMC 1/16 22 22K RMC 1/16 22 10K RMC 1/16 10 10K RMC 1/16 10 33K RMC 1/16 33 33K RMC 1/16 33 180 1/8W 52MM T RMC SMD150 1/10 680K RMC 1/16 1K RMC 1/16 102 68 1/8W 52MM T. 680 RMC 1/16 68 1K RMC 1/16 102 100K RMC 1/16 4.7K RMC 1/16 2.2K RMC 1/16 10K RMC 1/16 10 1K RMC 1/16 102 10K RMC 1/16 10 10K RMC 1/16 10 22K 1/8W 52MM T 10K RMC 1/16 10 5.6K RMC 1/16 5.6K RMC 1/16 68K RMC 1/16 68 10K RMC 1/16 10 2K RMC 1/16 202 0 RMC 1/16 000J 10K RMC 1/16 10 33K RMC 1/16 33 100K RMC 1/16 82 1/4W 52MM T. 27K 1/8W 52MM T 4.7 RMC 1/16 220K RMC 1/16 100K RMC 1/16 10 1/4W 52MM T. 4.7K 1/8W 52MM 120 1/8W 52MM T 39K 1/8W 52MM T 39K RMC 1/16 1.8K RMC 1/16 1.8K RMC 1/16 0 RMC 1/16 000J 4.7K RMC 1/16 4.7K RMC 1/16 4.7K 1/8W 52MM 4.7K RMC 1/16 4.7K RMC 1/16 4.7K RMC 1/16 12K RMC 1/16 12 12K RMC 1/16 12 4.7K 1/8W 52MM 47K RMC 1/16 47 Local  Symbol No. Part No. Part Name Description R805 R806 R807 R808 R809 R810 R811 R812  R813 R819 R820 R830 R831 R832 R833 R834  R835 R836 R837 R850 R851 R852 R853 R860 R861 R862  R863  R864 R881 R882 OW07-25392-60K OW07-25392-60K OW07-25331-60K OW07-25331-60K OW07-15022-00 OW07-15022-00 OW07-25103-60K OW07-25103-60K OW07-15470-08 OW07-25103-60K OW07-25103-60K OW07-25560-60K OW07-25273-60K OW07-25152-60K OW07-25104-60K OW07-15221-00 ICP-N20 OW07-25103-60K OW07-25103-60K OW07-25104-60K OW07-25472-60K OW07-25154-60K OW07-25103-60K OW07-15471-50T OW07-15470-00 OW07-15821-00 OW07-15470-08 OW07-15047-08 OW07-15181-50T OW07-15181-50T C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR FUSE RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR IC PROTECTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR FUSE RESISTOR C RESISTOR C RESISTOR C RESISTOR 3.9K RMC 1/16 3.9K RMC 1/16 330 1/8W 330 1/8W 2.2 1/4W 2.2 1/4W 10K RMC 1/16 10 10K RMC 1/16 10 47 1/4W 52MM T. 10K RMC 1/16 10 10K RMC 1/16 10 56 RMC 1/16 560 27K RMC 1/16 27 1.5K RMC 1/16 100K RMC 1/16 220 1/4W OW03-00020-00R 10K RMC 1/16 10 10K RMC 1/16 10 100K RMC 1/16 4.7K RMC 1/16 150K RMC 1/16 10K RMC 1/16 10 470 1/8W 52MM T 47 1/4W 52MM T. 820 1/4W 52MM T 47 1/4W 52MM T. 4.7 1/4W 52MM T 180 1/8W 52MM T 180 1/8W 52MM T L201 L203 L204 L205 L301 L302 L803 L804 L806 L807 L808 L881 L882 L883 T201 T202 T204 OW09-70101-00 OW09-25055-00W OW09-35055-00W OW09-70101-00 OW09-40474-00W OW09-40474-00W OW09-40080-00W OW09-40080-00W OW09-70101-00 OW09-40080-00W OW09-40080-00W OW08-04344-40 OW08-04344-40 OW08-04344-40 OW08-00332-24C OW08-01014-02 OW08-86436-70 AXIAL LEAD FM COIL FM COIL AXIAL LEAD CHOKE COIL CHOKE COIL CHOKE COIL CHOKE COIL AXIAL LEAD CHOKE COIL CHOKE COIL FERRITE COIL FERRITE COIL FERRITE COIL IFT IFT AM ANT T360 OW08-00825-00L REC BIAC INDUCTOR 10MH F5.5MM X 2.5T F5.5MM X 3.5T 0 INDUCTOR 10MH 47MH F6 X 8MM 47MH F6 X 8MM 8UH 8UH INDUCTOR 10MH 8UH 8UH 4T 4T 4T YELLOW 10MM RED 1A1014N COIL OA10-86436 OSC 1A825N BLAC CF201 CF203 CF205 CM1 CM2 CM5 CM6 CN202 CN260 CN301 CN370 CN601 CN602 CN801 CN802 CN850 CN851 CN860 J209 J244 J259 J263 J265 JK801 OW09-50450-00J OW09-50107-07J OW09-50107-20J OW05-00203-82 OW05-00203-82 OW05-00104-82 OW05-00104-82 OW20-12020-01K OW20-11040-02 OW20-11050-00 OW20-11060-00 OW20-11040-00 OW20-11030-00 OW20-12050-00 OW12-00006-00Q OW20-11070-00 OW20-12020-00 OW20-12030-00 OW05-00104-82 OW07-25001-50K OW07-25000-60K OW07-25001-50K OW07-25001-50K OW12-21235-15Q CER. FILTER CER. DIS. CER. FILTER C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR 2PIN HEADER 6PIN RED HEADER 5PIN HEADER 6PIN HEADER 4PIN HEADER 3PIN HEADER 5PIN HEADER SPK. TERMINAL 7PIN HEADER 2PIN HEADER 3PIN HEADER C CAPACITOR RMC SMD C RESISTOR RMC SMD RMC SMD JK TIE1 OW31-50040-50 UL-1007 TIE2 OW31-50040-50 UL-1007 Local 450HK2 JT10.7MG82 LT10.7MS3 0.02MF +80%-20% 0.02MF +80%-20% 0.1MF +80%-20% 0.1MF +80%-20% P=2.5MM P=2 RED B6B-PH B5B-PH JST 2MM B6B-PH JST 2MM P=2MM B4B-PH JS P=2MM B3B-PH JS P=2.5MM WP-4112AE P=2MM B7B-PH JS P=2.5MM P=2.5MM 0.1MF +80%-20% 1206 0 1/8W JP 0 RMC 1/16 000J 1206 0 1/8W JP 1206 0 1/8W JP F3.5MM W/2P2T WIRE 40MM BLACK WIRE 40MM BLACK 3-7  Symbol No. Part No. Part Name Description TIE3 OW31-50040-50 UL-1007 TIE4 OW31-50040-50 UL-1007 U201 U260 U301 U601  U801  U851 VD201 VD202 VD203 X260 XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX  ZD201  ZD830  ZD860  ZD861 TA2149BFN TC9257F AN7312 TC9422F TA8229K ML7808FA SVC348-S SVC201SPA SVC201SPA OW04-07200-08 OW20-42052-31 OW25-04300-01 OW29-00010-01 OW20-41062-32K OW20-61053-22 OW25-84050-02 OW29-00010-00 OW32-92070-20 OW81-10001-00 OW02-30005-03 OW02-30005-03 OW28-32010-00 OW28-32010-00 OW28-02010-01 OW28-02013-01 OW84-00003-00A OW94-04200-00 OW02-50100-00 OW02-50091-00 OW02-50068-00 OW02-50062-00 IC IC IC IC IC IC TUNING DIODE TUNING DIODE TUNING DIODE CRYSTAL 5PIN HEADER CONNECT.BM FM ANT. 6PIN 5PIN 2PIN FM ANT. WIRE DW SPONGE F3MM SUPER F3MM SUPER FIBRE TUBE FIBRE TUBE PVC TUBE PVC TUBE CABLE TIE CASS DECK Z DIODE Z DIODE Z DIODE Z DIODE Local WIRE 40MM BLACK WIRE 40MM BLACK OW03-02149-01 OW03-09257-01 OW03-07312-00 OW03-09422-00 OW03-08229-00 OW03-07808-04 OW02-00348-00 S OW02-00201-00 S OW02-00201-00 S HC-49/US+-20PPM CN880 TO CN801 FM ANT FM PIG ANT FOR CASS MECH FOR CASS HEAD FOR CN110 TO CN FOR RF2 FM OSC. FOR L203 204 LED 102 LED 103 2 X R372 2 X R863 UL ID F2MM L=10 UL ID F2MM L=13 4 UL CS-21SC-3222 10V0.5W 9.1V0.5W 6.8V0.5W 6.2V0.5W Part Name Description  D905  D906  D907  D908  D909  D910  D911  D912 RL202 RL202 RL202 RL202 1N4001 1N4001 1N4001 1N4001 DIODE RECTIFIER DIODE RECTIFIER DIODE RECTIFIER DIODE RECTIFIER FR DIODE FR DIODE FR DIODE FR DIODE OW02-00202-00 OW02-00202-00 OW02-00202-00 OW02-00202-00 OW02-04001-00 OW02-04001-00 OW02-04001-00 OW02-04001-00 C900 C905 C906 C907 C908 C909 C910 C911 C912  C913 OW05-00104-82 OW05-07223-82A OW05-07223-82A OW05-07223-82A OW05-07223-82A OW05-07223-82A OW05-07223-82A OW05-07223-82A OW05-07223-82A OW06-25228-00 C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR 0.1MF +80%-20% 0.022MF 0.022MF 0.022MF 0.022MF 0.022MF 0.022MF 0.022MF 0.022MF 2200MF 25V R903 OW07-15391-36T C RESISTOR 390 3W T902 OW15-00010-05 TRANS FORMER T57-0313001-11 OW20-42032-20 OW33-57312-03W OW33-57202-03W OW16-10212-00 OW28-31510-00 OW28-06085-01 OW28-06100-01 OW28-08130-01 3PIN FUSE FUSE VOLTAGE SW. FIBRE TUBE PVC TUBE PVC TUBE PVC TUBE OW28-04140-01 PVC TUBE CN901 TO CN860 T3.15L 250V T2L 250V SL14-22AM5A FOR D905-D912 FOR YEL FOR RED FOR ORG.BLK FOR GRE FOR BAK CN901  F901  F902 XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX 3-8 Part Name Description XXXXX OW28-16020-01 TUBE XXXXX OW28-00024-00 TUBE XXXXX OW31-00210-80 UL1672 XXXXX OW31-20050-51 UL1007 XXXXX OW78-00004-05 SOLDERLESS XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX XXXXX OW39-10001-00A OW28-00015-01 OW28-14020-01 OW08-04344-50 OW37-00002-00 OW84-00005-00 OW84-07635-00 FUSE HOLDER SHRINKAGE TUBE TUBE FERRITE CORE EYELET CABLE TIE UL CABLE CLAMP Local FOR VOLTAGE SW. FOR VOLTAGE SW. FOR DUAL POWER FOR DUAL POWER FOR AC POWER WI FOR F901 902 VOLTAGE SW. F4 L=20MM UL T25 X 15 X 10 F2 X 4MM 6.5 UL UC-1 Block No. [0][3][0][0]  Symbol No. Block No. [0][2][0][0] Part No. Part No. CD board Power board  Symbol No.  Symbol No. Local Part No. Part Name Description IC701 IC702 IC703 TC9462F TA2153FN TA2092N IC IC IC OW03-09462-00 OW03-02153-00 OW03-02092-00 Q701 Q702 Q703 Q704 Q705 2SC945P 2SC945P 2SA733P 2SC1383R 2SA733P TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR OW01-00945-16 N OW01-00945-16 N OW01-00733-16 N OW01-01383-18 OW01-00733-16 N D701 1N4148 GE DIODE OW2-04148-00C C701 C702 C703 C704 C705 C706 C707 C708 C709 C710 C711 C712 C713 C714 C715 C716 C719 C720 C721 C722 C723 C724 C725 C726 C727 C728 C729 C730 C731 C732 C733 C734 C735 C736 C737 C738 C739 C740 C741 C742 OW05-07103-00A OW05-07104-82B OW05-07223-82A OW06-16476-00 OW06-16107-00 OW06-16106-00 OW06-16106-01 OW05-07222-10A OW05-07473-82A OW06-16226-01 OW05-07222-10A OW05-07473-82A OW06-16476-01 OW06-50105-01 OW05-07104-82B OW05-07473-82A OW06-16476-01 OW05-07473-82A OW05-00103-00 OW06-16476-01 OW06-16476-01 OW06-16227-02 OW05-07104-82B OW05-07104-82B OW05-00103-00 OW05-07104-82B OW05-07104-82B OW05-07104-82B OW05-07473-82A OW05-07473-82A OW05-07102-10A OW06-16476-00 OW06-16107-00 OW05-07153-20A OW05-07103-00A OW05-07470-00A OW05-07272-10A OW06-16476-00 OW05-07224-00 OW05-07471-10A C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR 0.01MF 0.1MF50V 0.022MF 47MF 16V 100MF 16V 10MF 16V 10MF 16V 2200PF EP050X22 0.047MF 22MF 16V 2200PF EP050X22 0.047MF 47MF 16V 1MF 50V 0.1MF50V 0.047MF 47MF 16V 0.047MF 0.01MF 50V 47MF 16V 47MF 16V 220MF 16V PITCH 0.1MF50V 0.1MF50V 0.01MF 50V 0.1MF 50V 0.1MF 50V 0.1MF 50V 0.047MF 0.047MF 1000PF 47MF 16V 100MF 16V 0.015MF 0.01MF 47PF 2700PF 47MF 16V 0.22MF 470PF Local  Symbol No. Part No. Part Name Description C743 C744 OW05-07471-10A OW05-07473-82A C CAPACITOR C CAPACITOR C745 OW05-07121-10A C CAPACITOR C746 C747 C748 C749 C750 C751 C752 C753 C754 C755 C756 C757 C758 C759 C760 C790 C791 C792 C793 C794 C795 OW05-02472-10 OW05-07224-00 OW05-07104-82B OW05-07473-82A OW06-16107-02 OW06-16476-01 OW06-16476-00 OW05-07473-82A OW05-07102-10A OW05-02473-10 OW05-00020-06 OW05-07473-82A OW05-07473-82A OW05-07473-82A OW05-07104-82B OW06-16477-00 OW05-07103-00A OW05-07103-00A OW05-07103-00A OW05-07103-00A OW05-07103-00A M CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR M CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR 470PF 0.047MF 120PF-B50V 52MM 0.0047MF 0.22MF 0.1MF50V 0.047MF 100MF 16V PITCH 47MF 16V 47MF 16V 0.047MF 1000PF 0.047MF 2PF NPO 0.047MF 0.047MF 0.047MF 0.1MF 50V 470MF 16V 0.01MF 0.01MF 0.01MF 0.01MF 0.01MF R701 R702 R703 R704 R705 R706 R707 R711 R716 R717 R721 R722 R723 R724 R725 R726 R727 R728 R729 R730 R731 R732 R733 R734 R735 R736 R737 R738 R739 R740 R741 R742 R743 R744 R745 R746 R747 R748 R757 R758 R759 R760 OW07-15104-50T OW07-15104-50T OW07-15473-50T OW07-15473-50T OW07-15103-50T OW07-15271-50T OW07-15271-50T OW07-15103-50T OW07-15271-50T OW07-15220-50T OW07-15332-50T OW07-15332-50T OW07-15332-50T OW07-15332-50T OW07-15332-50T OW07-15103-50T OW07-15332-50T OW07-15221-50T OW07-15224-50T OW07-15683-50T OW07-15103-50T OW07-15153-50T OW07-15473-50T OW07-15102-50T OW07-15273-50T OW07-15222-50T OW07-15563-50T OW07-15102-50T OW07-15100-50T OW07-15563-50T OW07-15473-50T OW07-15101-50T OW07-15333-50T OW07-15473-50T OW07-15473-50T OW07-15473-50T OW07-15473-50T OW07-15333-50T OW07-15103-50T OW07-15103-50T OW07-15103-50T OW07-15103-50T C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR 100K 1/8W 100K 1/8W 47K 1/8W 47K 1/8W 10K 1/8W 52MM T 270 1/8W 52MM T 270 1/8W 52MM T 10K 1/8W 52MM T 270 1/8W 52MM T 22 1/8W 52MM T. 3.3K 1/8W 3.3K 1/8W 3.3K 1/8W 3.3K 1/8W 3.3K 1/8W 10K 1/8W 52MM T 3.3K 1/8W 220 1/8W 52MM T 220K 1/8W 68K 1/8W 52MM T 10K 1/8W 52MM T 15K 1/8W 47K 1/8W 1K 1/8W 52MM T. 27K 1/8W 2.2K 1/8W 56K 1/8W 1K 1/8W 52MM T. 10 1/8W 52MM T. 56K 1/8W 47K 1/8W 100 1/8W 52MM T 33K 1/8W 47K 1/8W 47K 1/8W 47K 1/8W 47K 1/8W 33K 1/8W 10K 1/8W 52MM T 10K 1/8W 52MM T 10K 1/8W 52MM T 10K 1/8W 52MM T L701 L703 L704 OW09-01000-01 OW09-70101-02T OW09-70101-02T CHOKE COIL COIL COIL W/MAGN. R295 10UH-823465 10UH-823465 CN704 CN705 OW20-80160-00I OW20-11100-00 SOCKET 10PIN HEADER P3 OW31-50040-50 UL-1007 X701 OW09-51693-02Z CER RES. 16PIN FFC P=2 B10B-PH JST WIRE 40MM BLACK 2TT16.93MX Local  Symbol No. Part No. Part Name Description OW20-42021-48 OW20-41032-21K 2PIN 3PIN XXXXX OW20-41061-37 6PIN XXXXX XXXXX XXXXX XXXXX XXXXX OW25-61135-00 OW08-04344-14 OW31-60050-10 OW39-00013-00A OW16-10101-92L FFC 16PIN FERRITE CORE UL-1007 HEAT SINK CD DOOR SWITCH CN701 TO CN851 CN702 TO CN602 CN703 TO CD MOT CN704 TO CD PIC FOR CD TO MAIN FOR P4 TO CD ME IC703 DLS-02-1 THOMSON TCP11TK 5.1V0.5W XXXXX XXXXX XXXXX OW98-04200-00 CD MECHA Z701 OW02-50051-00 Z DIODE Local Display board Block No. [0][4][0][0]  Symbol No. Part No. Part Name Description Q101 Q102 Q103 9014 9014 9018 TRANSISTOR TRANSISTOR TRANSISTOR OW01-09014-05 OW01-09014-05 OW01-09018-10 D101 D102 D103 D104 D105 1SS-133TP 1SS-133TP 1SS-133TP 1SS-133TP ELT-3142D FR DIODE FR DIODE FR DIODE FR DIODE LED OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-00133-00 R OW02-30022-02E C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 OW06-06108-01 OW05-03103-06T OW06-10106-00 OW05-03104-06T OW05-03240-03T OW05-03560-03T OW05-03240-03T OW05-03240-03T OW05-03104-06T OW06-10227-00 OW06-10476-00 OW05-03103-06T OW05-03103-06T OW05-03102-06T OW05-03104-06T OW05-03223-06T OW05-03223-06T OW05-03240-03T OW05-03104-06T OW06-06108-01 E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR CHIP CAPACITOR C CAPACITOR CHIP CAPACITOR CHIP CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR CHIP CAPACITOR C CAPACITOR E CAPACITOR 1000MF 6.3V 0.01MF B500 K10 10MF 10V 0.1MF 24PF N500 J240 56PF B500 K560 24PF N500 J240 24PF N500 J240 0.1MF 220MF 10V 47MF 10V 0.01MF B500 K10 0.01MF B500 K10 1000PF B500 K10 0.1MF 0.022MF B500 K2 0.022MF B500 K2 24PF N500 J240 0.1MF 1000MF 6.3V R101 R102 R103 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R119 R120 R121 R123 R124 R125 R126 R127 R128 R129 OW07-25102-60K OW07-25153-60K OW07-25103-60K OW07-25103-60K OW07-25102-60K OW07-25222-60K OW07-25472-60K OW07-25472-60K OW07-25472-60K OW07-25103-60K OW07-25103-60K OW07-25100-60K OW07-25472-60K OW07-25103-60K OW07-25103-60K OW07-25332-60K OW07-25220-60K OW07-25103-60K OW07-25001-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25272-60K OW07-25102-60K OW07-25152-60K OW07-25103-60K C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR 1K RMC 1/16 102 15K RMC 1/16 15 10K RMC 1/16 10 10K RMC 1/16 10 1K RMC 1/16 102 2.2K RMC 1/16 4.7K RMC 1/16 4.7K RMC 1/16 4.7K RMC 1/16 10K RMC 1/16 10 10K RMC 1/16 10 10 RMC 1/16 100 4.7K RMC 1/16 10K RMC 1/16 10 10K RMC 1/16 10 3.3K RMC 1/16 22 RMC 1/16 220 10K RMC 1/16 10 0 RMC 1/16 000J 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 2.7K RMC 1/16 1K RMC 1/16 102 1.5K RMC 1/16 10K RMC 1/16 10 Local 3-9  Symbol No. Part No. Part Name Description R130 R131 R132 R133 R134 R135 R136 R137 R138 R139 R140 R141 R149 R150 R151 R167 R168 R170 R171 R172 R173 R174 R175 R176 R178 R179 OW07-25471-60K OW07-25681-60K OW07-15821-50T OW07-15102-50T OW07-25220-60K OW07-15220-50T OW07-15471-50T OW07-15681-50T OW07-15821-50T OW07-15102-50T OW07-15122-50T OW07-15152-50T OW07-25152-60K OW07-25152-60K OW07-25152-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25103-60K OW07-25001-60K C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR 470 RMC 1/16 47 680 RMC 1/16 68 820 1/8W 52MM T 1K 1/8W 52MM T. 22 RMC 1/16 220 22 1/8W 52MM T. 470 1/8W 52MM T 680 1/8W 52MM T 820 1/8W 52MM T 1K 1/8W 52MM T. 1.2K 1/8W 1.5K 1/8W 1.5K RMC 1/16 1.5K RMC 1/16 1.5K RMC 1/16 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 10K RMC 1/16 10 0 RMC 1/16 000J L101 L102 L103 OW09-70102-00C OW08-04344-40 OW08-04344-40 COIL FERRITE COIL FERRITE COIL 100UH 4T 4T J103 J112 J125 J126 J127 J128 J129 J130 OW07-25001-50K OW07-25001-50K OW07-25001-60K OW07-25001-60K OW07-25001-60K OW07-25561-60K OW07-25001-60K OW07-25001-60K RMC SMD RMC SMD C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR SW101 OW16-10101-08S TACT SWITCH SW102 OW16-10101-08S TACT SWITCH SW103 OW16-10101-08S TACT SWITCH SW104 OW16-10101-08S TACT SWITCH SW105 OW16-10101-08S TACT SWITCH SW106 OW16-10101-08S TACT SWITCH SW107 OW16-10101-08S TACT SWITCH SW108 OW16-10101-08S TACT SWITCH SW109 OW16-10101-08S TACT SWITCH SW110 OW16-10101-08S TACT SWITCH SW111 OW16-10101-08S TACT SWITCH 1206 0 1/8 JPTP 1206 0 1/8 JPTP 0 RMC 1/16 000J 0 RMC 1/16 000J 0 RMC 1/16 000J 560 1/16 561JTP 0 RMC 1/16 000J 0 RMC 1/16 000J EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM EVQJAE05R H=5MM OW03-87261-10W OW02-66038-25 ZTA7.2MT 32.768 KHZ CN102 TO CN850 CN103 TO CN260 CN104 TO CN705 CN105 TO CN601 CN106 TO CN108 CN107 TO CD DOO LCD101 SW112 OW16-10101-08S TACT SWITCH U101 U102 X101 X102 XXXXX XXXXX XXXXX XXXXX XXXXX 87EP26F-1J13 FM-6038TM2-5A OW09-50720-00 OW04-32768-03S OW20-41071-22 OW20-41041-37 OW20-41102-34 OW20-41041-33K OW25-84070-03 IC SENSOR CER. RES. CRYSTAL 7PIN 4PIN 10PIN 4PIN 3PIN XXXXX OW20-41021-46 2PIN XXXXX OW91-80010-00 LCD 3-10 Local Remote board Block No. [0][5][0][0]  Symbol No. Part No. Part Name Description D501 1N4148 GE DIODE OW02-04148-00C C501 C502 C504 C505 C506 C507 C508 OW05-00221-00 OW05-00221-00 OW05-00471-00 OW06-10476-00 OW07-05010-30 OW07-05104-30 OW09-50455-00J C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C RESISTOR C RESISTOR CER RESONATOR 220 PF 220 PF 470 PF 47MF 10V 1 1/16W 100K 1/16W ZTB455E Local 3-11 Packing materials and accessories parts list Block No. M 3 M M P2 A2,A7 P3 A3 P4 A4 P7 P5 A5,A6 A1 P6 A10 A8 P4 P1 3-12 A9 Packing and accessories Block No. [M][3][M][M]  Symbol No. Part No. Part Name Description A A A A A A A A A A 1 2 3 3 3 4 5 6 7 8 OW00-00010-04 OW23-04910-02 OW88-00010-10 OW88-00010-11 OW88-00010-04 OWA-RE-JVC OW81-01000-01 OW89-09023-36 -----------OW97-02755-00 SPK BOX ASSY AM LOOP ANT INST SHEET INST SHEET INST SHEET REMOTE CONTROL TRBLE CUSHION PROTECT BATTERY AC PLUG ADAPTOR 5W 4ohm(x2) A 9 OW87-00010-06 RATING LABEL A 9 A 10 P 1 P 2 P 3 P 4 P 5 P 6 P 7 OW87-00010-20 OW81-03222-00 OW89-00010-01 OW85-90710-04 OW85-91014-02 OW85-00025-01A OW85-91619-02 OW86-00010-01 OW86-00010-00 RATING LABEL SHEET PROTECT CARTON POLY BAG POLY BAG POLY BAG POLY BAG POLY FOAM POLY FOAM Local US UT UW F116 X F17 X 2mm CD BOARD (x2) US UW UT 145 X 40mm (x2) Right Left 3-13