Transcript
Service Manual Model: L-8
(8-CHANNEL MIXING CONSOLE WITH DIGITEL EFFECTS)
www.altoproaudio.com
Version: 1.1
CONTENTS 1. Specification 2. Block Diagram 3. Schematic Diagram 4. Printed Circuit Board 5. Wiring Diagram 6. Test Procedure 7. Electrical Parts List 8. Exploded Views & Mechanical Parts List 9. Notes
8.1.TECHNICAL SPECIFICATION SPECIFICATION (L-8) Mono input channels Microphone input Frequency response Distortion (THD & N)
electronically balanced, discrete input configuration 10Hz to 55kHz, + 3dB 0.005% at + 4dBu, 1kHz
Gain range SNR (Signal to Noise Ratio)
0dB to 60dB (MIC) 115dB
Line input Frequency response Distortion (THD & N) Sensitivity range
electronically balanced 10Hz to 55kHz, + 3dB 0.005% at + 4dBu, 1kHz +15dBu to 45dBu
Stereo input channels Line input Frequency response Distortion (THD & N) Impedances Microphone input Channel Insert return All other inputs Tape out All other output
unbalanced 10Hz to 55kHz, + 3dB 0.005% at +4dBu, 1kHz
1.4kOhm 2.5kOhm 10kOhm or greater 1kOhm 120Ohm
Equalization Hi shelving Mid bell Low shelving Low Cut filter
+ 15dB @12kHz + 12dB @2.5kHz + 15dB @80Hz 75Hz, 18dB/oct.
DSP SECTION A/D and D/A converters DSP resolution Type of effects
Presets Controls
Main Mix Section Noise (Bus noise)
Max output AUX Return gain range AUX Sends max out
24 bit 24 bit Hall, Room, Vocal & Plate REVERBS Mono & Stereo DELAY (max DELAY TIME 500ms) Chorus, Flanger & Vibrato MODULATIONS REV+DELAY, REV+CHORUS, REV+FLANGER, REV+VIBRATO combinations 256 16-position PRESET BANK Selector 16-position VARIATION selector CLIP LED MUTE SWITCH with LED indicator
Fader 0 dB, channels muted: 100dBr (ref.:+4dBu) Fader 0dB, all input channels assigned and set to UNITY gain: 90dBr (ref.:+4dBu) +22dBu balanced XLR, +22dBu unbalanced, 1/4" jacks OFF to +20dB +22dBu
Power supply Main voltage
USA/Canada Europe U.K./Australia
Power Consumption Fuse Main connection Physical Dimension (W D Net weight Shipping weight
H)
100 120V~, 60Hz 210 230V~, 50Hz 240V~, 50Hz
25watts 100 120V~ : T500mAL 210 240V~ : T250mAL Standard IEC receptacle
245mm 268mm 2.4Kg (5.29lb) 3.5Kg (7.72lb)
24/73mm (9.64" 10.54"
0.94"/2.87")
A
B
C
1
MIC5 IN
2 3 1
R RN TN
T
R RN TN
T
R RN TN
PRESETS
5e S
3c 4d 2b 1a
DSP FOOTSWITCH
MUTE
VARIATIONS
RIGHT
LEFT
T
5e S
3c 4d 2b 1a
2
STEREO AUX RETURN 2
R RN TN
5e S
LEFT(MONO) 3c 4d 2b 1a
RIGHT
T
5e S
3c 4d 2b 1a
STEREO AUX RETURN 1
PHANTOM POWER +48V
T
R RN TN
5e S
LEFT(MONO) 3c 4d 2b 1a
RIGHT
T
R RN TN
5e S
3c 4d 2b 1a
-
+
-
+
T
R RN TN
LO
LO
MID
HI
DSP BOARD
+
-
+
-
+
-
+
-
CHANNEL 5,6 ONLY
GAIN
5e S
3
AUX RETURN1
80 2.5K 12K EQ
+/-15db
HI
80 2.5K 12K 3-BAND EQ
MID
SG/OL
75Hz HI PASS
+/-15db
3c 4d 2b 1a
GAIN
80 2.5K 12K 3-BAND EQ
INSERT
STEREO INPUT CHANNELS (5-8)
MIC GAIN:0~60dB LINE IN TRIM:+15dB~-45dB
LINE IN
2 3 1
-
+
D
MIC IN
PHANTOM POWER +48V
MONO INPUT CHANNELS ( 1-4 )
3
-
2
AUX1
AUX RETURN2
SG/OL
2
LO CUT
LEVEL
1
3
LEVEL
4
1
1
4
PRE
POST
2
2
AUX1
AUX2
BALANCE
AUX2
AUX1
PAN
AUX-1
RIGHT-BUS
LEFT-BUS
RIGHT-BUS
LEFT-BUS
AUX-1
AUX-2
RIGHT-BUS
LEFT-BUS
AUX-2
AUX-1
RIGHT-BUS
LEFT-BUS
LEFT-BUS RIGHT-BUS AUX-1 AUX-2 EFX SEND LEFT-BUS RIGHT-BUS AUX-1 AUX-2 EFX SEND
+
1
5
5
RIGHT-BUS
LEFT-BUS
RIGHT-BUS
LEFT-BUS
EFX SEND
AUX-2
AUX-1
2
2
2TK TO MIX
CONTROL ROOM & PHONES
2
2
6
RIGHT METER
LEFT METER
3
1
3
1
2TK TO CTRL ROOM
3
1
3
1
MAIN MIX LEVEL
6
Date: File: 7
Size A2(C)
Titel
7
2 3 1
2 3 1
MAIN MIX RIGHT
MAIN MIX LEFT
MAIN OUT
AUX SEND2
AUX SEND1
AUX SEND
RIGHT
LEFT
TAPE OUT
PHONES
5-Oct-2003 L8MAP.Sch
Model No: L-8 BLOCK DIAGRAM Sheet Drawn By:
RIGHT
LEFT
ALTO MIXING CONSOLE
R T S
R T S
CONTROL ROOM OUTPUT
R T S
PHONES OUTPUT
TAPE IN
2-TRACK
R T S
R T S
R T S
R T S
8
8
Revision VER030118 1 of 1 KEVIN LIN.
A
B
C
D
2.Block Diagram
3. Schematic Diagram 2
C87 47u/25V
LEVEL
VR8 W50K
C88 47u/25V
6
R236 30K
U3B 4580M
MID 2.5K VR4 B50K
C195 2.2u/50V
C155 12n(M)
C132 18n(M)
EQ HI 12KHZ
VR10 B50K
R213 1K1
R198 910R
C96 47u/25V
C181 22P R221 1M
C94 47u/25V
C95 47u/25V
LEVEL
R257 3K9
VR16 W50K
R199 910R
2
C196 2.2u/50V
C156 12n(M) VR12 R155 B50K 6K8
R156 6K8
VR18 B50K
TR4 BR
EQ HI 12KHZ
R214 1K1
C173 12n(M)
U6A 4580M
R200 910R
VR19 B50K
LEVEL
R258 3K9
EQ HI 12KHZ
VR26 B50K
R215 1K1
R160 6K8
2
C106 47u/25V
1
TR6 BR
U9A 4580M
VR27 B50K
C105 47u/25V
C185 22P LEVEL
R203 910R
U12B 4580M
LEFT-BUS
VR23B JQ10K
R294 5K1
R292 5K1
R208 910R
PRE-CH7
VR22 W50K
R313 5K1 C199 2.2u/50V
R170 6K8
R268 1K5
R312 5K1
R232 47K
LO 80HZ
AUX-PRE
C121 47u/25V
C191 22P C124 47u/25V
LEVEL
R226 1M
R259 3K9
VR31A JQ10K
C186 22P R273 36K
2
C107 47u/25V
1
EQ HI 12KHZ
PAN
R209 910R
U19A 4580M
POST
R298 5K1
PEAK LD4 RED
1
U20A 4580M
C127 47u/25V C128 47u/25V LEVEL
VR47B W50K
R263 3K9
PRE-CH8
R299 5K1
R123 R282 10K 36K
6
7 5
C129 47u/25V
U20B 4580M
VR46B JQ10K
RIGHT-BUS
AUX-2
R174 6K8
LO 80HZ
AUX-1
POST
VR42B R211 B50K 910R
AUX-PRE
AUX-2
(PRE)
R227 1M
C125 47u/25V
AUX-POST R314 5K1
5
U19B 4580M
C200 2.2u/50V
C126 47u/25V
R234 47K
C162 12n(M) VR43B R175 B50K 6K8
R173 6K8
R317 5K1 LD6 RED
TR12 BR
R235 47K
VR45 W50K
R269 +VCC 1K5
R255 4K7
AUX-1
AUX-PRE VR44 W50K
PEAK
TR11 BR
C154 33n(M)
C153 33n(M)
PGND
VR29 W50K
R125 10K
TR7 BR 8
PGND
C205 100n
C289 100n
C295 100n
C297 100n
C217 100n
C219 100n
C207 100n
A
C201 100n
+VCC
C206 100n
C290 100n
C296 100n
U17C 4580M
C298 100n
U19C 4580M
U20C 4580M
C218 100n
C220 100n
Titel
4
U16C 4580M
4
U12C 4580M
4
U9C 4580M
4
-VCC
U6C 4580M
4
U3C 4580M
UDASP IN-OUT SECTION L8MN1.S03
4
LED DISPLAY L8MN1.S02
4
MAIN IN-OUTPUT L8MN1.S01
C208 100n
C202 100n
2
3
4
5
6
INPUT STAGE PCB# L8MN1.PCB
Size Date: File:
1
B
R315 5K1
J6 C193 22P
MID 2.5K
VR30 W50K
LEFT-BUS
VR46A JQ10K
7
R210 910R
R316 5K1
BAL
R124 10K
C194 22P
R122 10K
R120 10K C170 18n(M)
C130 47u/25V
6
AUX-POST R297 5K1
2 3
R247 22K
C178 12n(M)
R148 1K3
C
C192 22P R283 36K
VR47A W50K
R246 22K
R121 10K
LEFT-BUS
RIGHT-BUS
J4
R219 1K1
R296 5K1
VR31B JQ10K
R262 3K9
C152 33n(M)
VR41B B50K
VR37 W50K
PEAK
PGND
C161 12n(M) VR43A R172 B50K 6K8
C151 33n(M)
AUX-1
AUX-PRE
TR9 BR
3
VR42A B50K
LD5 RED
TR10 BR
VR38 W50K
+VCC
R254 4K7
R233 47K
C177 12n(M)
R147 1K3
R171 6K8
AUX-1
R293 5K1
R267 +VCC 1K5
TR8 BR
R231 68K
AUX-POST
C120 47u/25V
U16B 4580M
AUX-2
(PRE)
MID 2.5K
AUX-2
AUX-POST
R239 30K
R251 4K7
C146 33n(M) R71 10K
A
R207 910R
C169 18n(M)
VR41A B50K
R218 1K1
RIGHT-BUS
J3
U12A 4580M
R164 6K8
RIGHT-BUS
R310 5K1
POST
2
(PRE) C198 2.2u/50V
C158 12n(M) VR28 R163 B50K 6K8
C145 33n(M)
EQ HI 12KHZ
R295 5K1
3
C104 47u/25V
VR39B JQ10K
J5
C150 33n(M)
C149 33n(M)
C137 18n(M)
PAN
VR21 W50K
VR32 W50K
C115 47u/25V
R225 1M
PGND
MID 2.5K R162 6K8
LO 80HZ
AUX-PRE
LD3 RED
7
R202 910R
7 5
U17B 4580M
C160 12n(M) VR36B R169 B50K 6K8
R168 6K8
AUX-1
POST
5
R143 1K3
VR35B B50K
D
R99 R280 10K 36K
6
C190 22P C119 47u/25V
LEFT-BUS
VR39A JQ10K
C189 22P
R98 10K C168 18n(M)
R311 5K1
BAL
R100 10K
5
R146 1K3
C138 18n(M)
R223 1M
R261 3K9
VR40B W50K
R245 22K
C176 12n(M)
TR5 BR
C102 47u/25V
LEVEL
1
R266 +VCC 1K5
6
LO 80HZ
R272 36K
PEAK
R230 68K
C166 18n(M)
C174 12n(M)
R97 10K
3
R250 4K7
C144 33n(M)
C134 18n(M)
C321 47u/25V
VR23A JQ10K
C184 22P
R238 30K
R63 10K
RTN-CH4
VR14 W50K
VR13 W50K
VR24 W50K
C103 47u/25V
C197 2.2u/50V
C114 47u/25V
MID 2.5K
AUX-2
LD2 RED
C97 47u/25V
U9B 4580M
C157 12n(M) VR20 R159 6K8 B50K
C143 33n(M)
R206 910R
PRE-CH6
(PRE)
R158 6K8
B
R290 5K1
AUX-POST R288 5K1 R289 5K1
5
MID 2.5K
LO 80HZ
RIGHT-BUS
J2
POST
7
R201 910R
U17A 4580M
6
PGND
R222 1M
U16A 4580M
C116 47u/25V
3
R111 10K
C182 22P
6
R141 1K3
R96 10K
VR34B B50K
TR3 BR
C101 47u/25V
1
C148 33n(M)
R217 1K1
LEFT-BUS
2
7
PEAK
R229 68K
C165 18n(M)
R205 910R
EQ HI
R291 5K1
VR15B JQ10K
R265 +VCC 1K5
R249 4K7
C142 33n(M)
C141 33n(M)
C133 18n(M)
RTN-CH3
C98 47u/25V
1
R237 30K
R55 10K
C320 47u/25V
R271 36K
PAN
VR35A B50K
C147 33n(M)
C136 18n(M)
(PRE)
R154 6K8
LO 80HZ
R281 36K
VR40A W50K
R244 22K
C188 22P
C112 47u/25V
C159 12n(M) VR36A R167 6K8 B50K
R166 6K8
L8MN1 (1/3) R260 3K9
3
R145 1K3
3
U6B 4580M
MID 2.5K
LO 80HZ
C183 22P
5
VR11 B50K
AUX-PRE VR5 W50K
VR15A JQ10K
LEVEL
R224 1M
MID 2.5K
AUX-1
R285 5K1
R204 910R
PRE-CH5
VR6 W50K
LD1 RED
C111 47u/25V
1 AUX-2
PGND
6
R139 1K3
R284 5K1
C175 12n(M)
2
AUX-POST
PEAK TR2 BR
7
C
R286 5K1
TR1 BR
C164 18n(M)
C172 12n(M)
(SOLTON用1K2)
RTN-CH2
J1
R264 +VCC 1K5
R248 4K7 R228 68K
R216 1K1
RIGHT-BUS
POST
R151 6K8 C140 33n(M)
C139 33n(M)
R152 6K8
R47 10K
C319 47u/25V
EQ HI
(PRE)
R150 6K8
LO 80HZ
U3A 4580M
C113 47u/25V
C187 22P
8
RTN-CH1
R197 910R
VR7B JQ10K
1
C167 18n(M)
VR34A B50K
C135 18n(M)
LEFT-BUS
3
5
VR3 B50K
R287 5K1
4
D
R196 910R
C90 47u/25V
PAN
8
7
8
C318 47u/25V
R270 36K
2
7
R137 1K3
VR7A JQ10K
C180 22P
8
C171 12n(M)
R220 1M
R256 3K9
6
8
R212 1K1
C89 47u/25V
C179 22P
5
8
EQ HI 12KHZ
C163 18n(M)
4
8
VR2 B50K
C131 18n(M)
3
8
1
7
A2
Model No: 5-Oct-2003 L8MN1.Sch
Revision
ALTO L-8
VER030113 Sheet Drawn By: 8
1 of 4 KEVIN LIN.
1
2
3
C241 47u/25V AUX-RTN1-L
D
6
R302 5K1
2
C249 47u/25V
LEFT-BUS
U21A 4580M
2TK TO CTRL ROOM
LEFT-BUS
3
R241 22K
C243 47u/25V
C239 47u/25V
R78 8K2
MAIN-L-2
R320 56K
VR48B W50K
RIGHT-BUS
C11 22P
R7 10K
AUX-RTN2-L
R9 10K
2
VR49A W50K
C6
3
U2A 4580M C12 22P
C
C5 47u/25V
R8 10K
AUX-RTN2-R
R11 10K
R10 10K
6
C7
VR9 W50K
5K1
R27 10K
5
U2B 4580M
47u/25V
CTRL-R-R
U27B 4580M
R86 10K
LEFT-BUS
EFX TO AUX1 R321 36K
R306 5K1
2TK-IN-L
2TK-IN-L
C247 47u/25V
U1B 4580M
R186 20K
2TK TO MIX
C
SW9A PS-22E85L
C248 47u/25V
6
C271 100P
RIGHT-BUS
5
C281 22P
R187 20K
C246 47u/25V
(AUX RETURN2)
7
27K
C256 47u/25V
2TK TO CR-L
VR49B W50K
R14
CTRL-R-R
7 5
R-METER
C270 22P
R26 3K9
6
7
C20 100P
C10 47u/25V
6
C244 47u/25V
U1A 4580M
AUX-1
R12
VR50A W50K
R279 36K
R349 27K
R305 5K1
3
27K
47u/25V
2TK TO CR-R
R319 36K
CTRL-R-L
R82 10K
R345 3K9
SW10B PS-22E85L
1
R13
1
C14 100P
U27A 4580M
MAIN-R-2
2
CTRL-R-L
1
C226 22P
C224 22P
R25 3K9
D
C250 47u/25V
2 3
C255 47u/25V
AUX RETURN 2
C19 47u/25V
VR50B W50K
R348 27K
C245 47u/25V
C9 47u/25V
C225 22P
RIGHT-BUS
5
U21B 4580M
R344 3K9
L-METER
R304 5K1
7
R240 22K
L8MN1 (2/4)
2TK TO CR-L
6
C266 100P
8
R278 36K SW10A PS-22E85L
C269 22P
AUX-RTN1-R
7
PHONES/ CONTROL ROOM
R318 56K
VR48A W50K
1
C265 100P
5
C223 22P
AUX RETURN 1 R77 8K2
4
7 5
R308 5K1
R81 10K
U23B 4580M
LEFT-BUS
2TK TO CR-R
C8 47u/25V
C13 22P
R16 3K9
MAIN MIX
C264 22P
6
LEFT-BUS
R15 5K1
2
C234 47u/25V
2TK-IN-R
MAIN-L-3
7
C45 47u/25V
U26B 4580M
1
C307 100n
8
C305 100n
8
8
8
8
C211 100n
C233 47u/25V
C309 100n
U23C 4580M
U24C 4580M
U25C 4580M
U26C 4580M
MAIN-R-3
7
C212 100n
U31B 4580M
C311 100n
U27C 4580M
C306 100n
C286 47u/25V
C308 100n
AUX-SEND1
AUX-SEND1
AUX-2
AUX-2
C232 47u/25V
6
AUX-SEND2
7 5
R184 20K
CN3 2.5-12P-B24 (TO L8MN1)
R41 51K
RTN-CH1 RTN-CH2 RTN-CH3 RTN-CH4 C15 100n
U1C 4580M
C17 100n
U2C 4580M
C340 100n
U31C 4580M
C310 100n
C312 100n
U24B 4580M
+VCC -VCC PH PWR
C16 100n
1 2 3 4 5 6 7 8 9 10 11 12
PRE-CH5 PRE-CH6 PRE-CH7 PRE-CH8 +VCC -VCC
CN4 2.5-12P-B24 (TO L8MN1) MAIN-R-2 MAIN-R-3 MAIN-L-2 MAIN-L-3
1 2 3 4 5 6 7 8 9 10 11 12
AUX-RTN1-L AUX-RTN1-R AUX-RTN2-L EFXRTN-L AUX-RTN2-R EFXRTN-R
CN5 2.5-8P-B24A (TO L8MN1) CTRL-R-L CTRL-R-R 2TK-IN-L 2TK-IN-R AUX-SEND1 AUX-SEND2
1 2 3 4 5 6 7 8
FOOTSW
1 2 3 4 5 6 7 8 PGND
C18 100n
C341 100n
Titel
Model No:
A
4
5
6
7
Revision ALTO L-8
5-Oct-2003 L8MN1.S01
Date: File: 3
DGND
STEREO AUX & SENDS & MAIN OUT & 2TK & CTRL R & PHONES A2(C)
2
CN0 2.5-8P
PH PWR -VCC +VCC +5VD
Size
1
AUX-SEND2
R185 20K
4
4
4
4
4
4
4
4
4
C204 100n
1
MAIN-R-3
5
A -VCC
C231 47u/25V
2
U24A 4580M
+VCC
U21C 4580M
AUX-1
B
R274 36K
6
U31A 4580M
R74 39K
AUX-1
R375 5K1
1 3
3
U25A 4580M
2
RIGHT-BUS
R309 5K1
R85 10K
C221 22P
3
8
2
RIGHT-BUS
C203 100n
VR51A W50K
MAIN-R-2
R75 10K
8
R301 5K1
C24 22P
R276 36K R93 5K1
RIGHT
C238 47u/25V
8
MAIN MIX
8
C260 22P
MAIN-R-2
C263 22P
U23A 4580M
C222 22P R275 36K
R339 3K9
1 3
MAIN-L-3
R72 10K
B
C236 47u/25V
R188 20K
SW9B PS-22E85L
C252 47u/25V
2
C272 100P
5
U26A 4580M
R189 20K
2TK-IN-R
6
3
R73 39K
C251 47u/25V
MAIN-L-2
R76 10K
R39 5K1
1 7
5
U25B 4580M
C22 22P
R277 36K R38 5K1
LEFT
VR51B W50K
MAIN-L-2
C237 47u/25V
C282 22P
VER030120 Sheet Drawn By:
2 of 3 KEVIN LIN. 8
R427 10K
PGND PGND
2
1
1 5
R-METER
R368 100K
C283 47u/25V
R371 0R0
D2B
2
5
6
R370 100K
U30B 4580M
7
R372 0R0
D3B
R358 470R
U36B LM339
R361 510R
LD32 YEL
U37A LM339
LD33 RED
U37D LM339
R366 27K
Date: File:
Size
Titel
A4
5-Oct-2003 L8MN1.S02
Model No:
ALTO L-8
DISPLAY STAGE
U40E LM339
LD31 GR
U40D LM339
R365 5K6
U37C LM339
LD21 RED
U39E LM339
LD30 GR
U40A LM339
R364 2K
U37B LM339
LD20 YEL
U38E LM339
LD29 GR
U36D LM339
R363 1K3
U40C LM339
LD19 GR
(+18)
U37E LM339
3
R362 620R
U40B LM339
LD18 GR
(+10)
U36E LM339
LD28 GR
U36A LM339
U36C LM339
LD17 GR
(+7)
U35E LM339
2
U30C 4580M
LD27 GR
U39D LM339
R428 10K
LD26 GR
U39A LM339
PGND PGND
C284 47u/25V
13
R369 100K
U30A 4580M
1
3
D3A DA204K
2
3
2
1
C343 47P
LD25 GR
2
A
L-METER
3
6 4
LD24 GR
R360 330R
13
D2A DA204K
14 11
1
10
C342 47P
5
LD23 GR
4
LD22 GR
11
U35D LM339
10
U35A LM339
R357 470R
1 5
U38D LM339
14
R359 330R
4
U38A LM339
1
R356 470R
14 11
TR14 HR
9
R355 120R
8
U39C LM339
10
R367 100K
R353 120R
R352 470R
7
R354 56R
7
U39B LM339
1 5
PGND
R87 10K
PGND
6
LD16 GR
4
B
C
D1B
DA204K
D1A
R351 470R 9
U35C LM339
8
U35B LM339
7
U38C LM339
6
U38B LM339
8
D
9
LD15 GR
13
8
LD14 GR
14 11
4
LD13 GR
7
LD12 GR
10
3
LD11 GR
2
12
LD10 GR
1 5
3
TR13 HR
6
(+4)
4
12
R350 120R
9
(+2)
14 13
3
+VCC
8
(0)
7
LEFT METER
6
(-2)
9 11 12
(-4)
8 10 3
(-7)
1 2
12
(-10)
7 5
3
(-20)
4 12
(-30)
6
3
14 13
3
2
9 11
12
1
8 10
13
LD7 GR
R252 2K
R253 4K7
4
Sheet Drawn By:
C214 100n
PGND
C258 47u/25V
3 of 4 KEVIN LIN.
VER030120
-VCC
Revision
R374 47R
PGND
C257 47u/25V
R373 47R +VCC
PHANTOM
LD8 RED
PGND
+VCC
PH PWR
PWR ON
C213 100n
-VCC
+VCC
-VCC
L8MN1 (3/4)
4
A
B
C
D
1
2
3
4
5
6
7
8
L8MN1 (4/4) 2 4 6 8
2 4 6 8
+5VD
10K CHANGE TO 3K3
D
5
3
1
5
3
C2 33P
U44B 4580M
U44A 4580M
RL1B RY-5W-K (MUTE)
2 4 6 8 10 12 14 16
C62 R46 1.5nF 2.5% 10K
C40 22P
1 3 5 7 9 11 13 15
1 2 4 8
1 2 3 4
COM
VARIATION DGND
1 2 4 8
10
Q
J
COM
CLK 9
PRESET
DGND
Q
R
6 7
1 2 3 4
S
R19 10K
2
EFXRTN-L
7
EFXRTN-L
R68 68R
CN6 HEADER 8X2
R1 10K
U49D 74HC14
U48B 74HC109
EN2 SDB161PVB15FS
K
15
C50 4.7uF
R22 10K
EN1 SDB161PVB15FS
11
+5VD
R17 3K3
AR2 680R*4
1 3 5 7
AR1 680R*4
C61 R24 1.5nF 2.5% 10K
C39 22P
1 3 5 7
D
8
14 12
9
U49F 74HC14
13 12
13
DGND
DGND
DGND
2
EFXRTN-R
AUX-SEND2
EFX-SEED
+5VD
U49C 4
5
74HC14
6
74HC14
R4 47K
U43A NE555
C117 33P
U45B 4580M
3
OUT
4
RS
C 2
C49 22P
R54 2K2 R53 10K
DS
CTR
TG
C60 R21 C38 1.5nF 2.5% 10K 22P C59 4.7uF
3
R56 10K
C118 10uF
C1 100N
6 7
6
TH
7
6
6 5
U45A 4580M
RL1C RY-5W-K (MUTE)
U49B R48 10K
7
3
C
8
R23 10K
1 4
EFXRTN-R
R6 68R
R20 10K
5
C52 4.7uF
R18 3K3
2
5
1
R2 10K
DGND
DGND
3
U46A 4580M
+5VD
DGND
DGND
1
U46B 4580M
R90 4K7
2M2 R114
3 1
R67 10K
TR16 BR
5
6
Q
J
U47B LM393
U47A LM393
CLK
R66 10K
6
R65 R5 220R 820K
D16 DA202K
DGND
7
DGND
R50 10K
U48A 74HC109
7
1K
2
D9 RLS4148
+5VD
10K
TR17 BR
Q
S
B
C51 100N
R
R112 1M R113
R118 10K R3
5
MUTE(GLOW) PEAK(FLICKER)
C37 100N
RL1A RY-5W-K 2
LD54 RED
D10A RB400D
K
+5VD
2 4
2
3
D15 BAS316
R52 10K
D7 BAS316
R80 220R
1
FOOTSW
B
U49A 74HC14
1
R49 7K5
+VCC
C3 1uF
R79 220R
C4 1uF
SW1 PS-22E85NL (MUTE)
DGND
C35 100N
14
16
8
U48C 74HC109 8
C31 100N
8
C29 100N
8
8
DGND
DGND
DGND
C36 +5VD 100N
+VCC
C30 100N
U49G 74HC14
C32 100N
8
1
U43B NE555
C86 10uF JP1
7
U47C LM393 4
4
U46C 4580M
4
-VCC
U45C 4580M
4
U44C 4580M
DGND
UDASP IN/OUT SECTION PGND
A
A
Titel
UDASP IN/OUT SECTION
Size A2(C)
5-Oct-2003 L8MN1.S03
Date: File: 1
2
3
4
5
6
Model No:
7
Revision
ALTO L-8
VER030217 Sheet Drawn By:
4 of 4 KEVIN LIN. 8
2
TR25 HR
R15 1K50
D5 C52 BAS316 1000u/10V
TR36 HR
R391 470R
R94 2K49
TR23 HR
R396 470R
R381 2K49
LINE IN 5/6 LEFT(MONO)
TR39 HR
TR33 HR
5e S
C273 100P
3c 4d 2b 1a
RIGHT
2
5e S
C274 100P
R387 2K49 -VCC
C117 47u/25V
R37 10K
-VCC
C202 100n
R95 5K11
C109 47u/25V
C118 47u/25V
C297 100n
U13C 4580M R190 20K
C316 22P R414 5K11
R165 2K49
U11A 4580M
C83 22P
TR38 HR
TR31 HR
U10A 4580M
1
R411 5K11
2
3
R395 470R
C84 22P
R380 2K49
R23 1K50 C12 1n
C81 0.22u/50V
U10B 4580M
C80 0.22u/50V
6
C11 1n
R379 2K49
-VCC
-VCC
C205 100n
U4C 4580M
C287 100n
U5C 4580M
C204 100n
C299 100n
U14C 4580M
C298 100n
C289 100n
U7C 4580M
C206 100n
C301 100n
U15C 4580M
C288 100n
C43 100n
U16C 4580M
C300 100n
C291 100n
U8C 4580M
C290 100n
R142 1K3
R424 10K0
SW4B PS-22E85L
C108 47u/25V
6
C79 0.22u/50V
C110 22P R412 5K11
INS-CH4
R161 6K8
7 5
R134 62K
C
R183 20K
U11B 4580M
-VCC
C293 100n
C295 100n
U10C 4580M
C292 100n
R347 47R
U11C 4580M
+VCC
C294 100n
R346 47R
C296 100n
U28C
U29C
BA15218N
BA15218N
-VCC
C253 C313 47u/25V 100n
C303 100n
STEREO AUX RETURN1
U18C 4580M
C302 100n
C45 100n
C304 100n
3c 4d 2b 1a
LEFT 1 (MONO / MASTER)
R324 120R AUX-SEND1
AUX-RTN1-L
R323 120R
FOOTSWITCH R 3c RN 4d TN 2b T
1a
S
5e
LEFT(MONO)
PRE-CH5
1
C279 100P
5e S
3
R113 10K
X16 JY-6351G-02-250
R192 20K
C277 100P
RIGHT
C24 TP8 47u/25V
6
3c 4d 2b 1a
PRE-CH6
7
U16B 4580M
R116 10K
C278 100P
U18A 4580M
R194 20K
AUX-SEND2 R325 120R
STEREO AUX RETURN2
3c 4d 2b 1a
TAPE IN
T
1a
S
5e
B
X23 JY-6351G-02-250
TAPE OUT
X31 SCP6873NS3232
EFXRTN-L AUX-RTN2-L
1
L(WHITE)
5e
C230 22P
R119 10K
3c 4d 2b 1a
5
R117 10K
U18B 4580M
2
R(RED)
PRE-CH8
R195 20K
RIGHT 2
MAIN-L-2
4
R342 1K
C123 47u/25V
7
X25 JY-6351G-02-250
AUX SEND2
X20 JY-6351G-02-250 6
3c 4d 2b 1a 5e
R 3c RN 4d TN 2b
AUX-RTN1-R
X19 JY-6351G-02-250
LEFT 2
C69 22P
R322 120R
5e
PRE-CH7
1
C229 22P
R115 10K
X17 JY-6351G-02-250
RIGHT 1
C122 47u/25V
3
C280 100P
T
5e S
R193 20K
2
R114 10K
R RN TN
R118 10K
3c 4d 2b 1a
AUX SEND1
FOOTSW
X22 JY-6351G-02-250
C68 22P
R112 10K
3c 4d RN 2b TN 1a T
LINE IN 7/8
C22 TP7 47u/25V
R38 10K
U15B 4580M
SW4A PS-22E85L
R67 5K11
R413 5K11
7
R400 4R7
LO CUT
R181 20K
C59 22P R423 10K0
5
TR32 A1316
C99 47u/25V
3
5e
5
5
R106 10K
D7 C55 BAS316 1000u/10V
+VCC
R426 10K0
2
U15A 4580M
R109 10K
R182 20K
U8B 4580M
C254 C314 47u/25V 100n
U13B 4580M
U16A 4580M
7
C228 22P
C203 100n
U2C 4580M
C67 22P
6
R130 2K49
X18 JY-6351G-02-250
1
R105 10K
C44 10n
VR25 2C10K TR22 A1316
8
C201 100n
U1C 4580M
C65 22P
R415 5K11
R110 10K R104 10K
X15 JY-6351G-02-250
R394 470R
R36 6K34
C28 22u/35V
R179 20K
2
7
3
C227 22P
R133 62K
2
R191 2K49
1
R416 5K11
6
R383 2K49
5
+VCC
+VCC
R425 10K0
C315 22P
R401 4R7
R108 10K
C276 100P
T
U13A 4580M
5
TR34 A1316
+VCC R135
SW3B PS-22E85L
C100 47u/25V 7
C76 0.22u/50V
C82 22P R408 5K11
-VCC
-VCC
R35 6K34
R22 1K50
C66 22P
R103 10K
R RN TN
5e S
X12 JY-6351G-02-250
U14A 4580M
C317 22P
R107 10K
R102 10K
C27 22u/35V
7
U5B 4580M
R128 2K49
-VCC
C275 100P
X14 JY-6351G-02-250
+VCC
C39 47u/63V
5
3
R397 470R
C14 1n
R101 10K
T
LINE IN4
SW2B PS-22E85L
3
R27 1K50
-VCC
INS-CH2
C93 47u/25V
R132 62K
R386 2K49
C13 1n
R26 1K50
3c 4d RN 2b TN 1a T
8
D8 C56 BAS316 1000u/10V
-VCC
R140 1K3
R422 10K0
D
INS-CH3
R157 6K8
+VCC
VR33 2C10K TR24 A1316
R25 4R7
R
R153 6K8
6
C73 0.22u/50V
C61 22P R405 5K11
1
C42 47u/63V
R RN TN
C74 0.22u/50V
R138 1K3
R420 10K0
2
R44 20K
R89 4R7
3c 4d 2b 1a
R385 2K49
R129 2K49
+VCC
-VCC
C18 330P
X13 JY-5042-030G
C10 1n
4
C41 47u/63V
-VCC
+VCC
R384 2K49
R144 2K49
TR21 HR
4
R88 4R7
R382 2K49
C46 10n
R64 2K49
+VCC
C47 10n
6
R21 1K50
-VCC
C40 10n
-VCC
+VCC
R10 6K81
C77 0.22u/50V
7
R399 4R7
-VCC
R43 20K
4
PH PWR
TR30 A1316
C78 0.22u/50V
U7B 4580M
5
SW3A PS-22E85L
R62 5K11
R409 5K11
1
8
-VCC
1 3 2 4
6
R17 1K50 C8 1n
C64 22P
C4 330P
X11 JY-5042-030G C75 0.22u/50V
U4B 4580M
1 3 2 4
MIC 4
SW2A PS-22E85L
R54 5K11
7
R398 4R7
C7 1n R59 2K49
R421 10K0
EFXRTN-R AUX-RTN2-R
MAIN-R-2
5
R343 1K
6
TR18 A1316
LO CUT
R178 20K
C54 22P
R406 5K11
5
TR28 A1316
LO CUT R180 20K
C58 22P
6
C37 47u/63V
4
R32 6K34 R16 1K50
MIC 5
2
R419 10K0 C60 22P
VR9 2C10K
-VCC
R31 6K34
C
R9 6K81
R407 5K11
8
C23 22u/35V
1
3
R8 6K81
R24 4R7
4
5e S
U4A 4580M
R7 6K81
C91 47u/25V
3
8
T
U5A 4580M
C62 22P
4
C21 22u/35V
R393 470R
C9 1n
R177 20K
8
R RN TN
X8 JY-6351G-02-250
B
R91 2K49
TR27 HR
R390 470R
2
2K49
2
C33 47u/63V
TR20 A1316
R127 2K49
4
R49 4R7
1
R410 5K11
3
VR17 2C10K
PH PWR
1
R40 20K
U7A 4580M
8
TR17 HR
TR29 HR
-VCC
R33 6K34
C92 47u/25V
3
TR37 HR
4
R65 2K49
U8A 4580M
C63 22P
8
C35 10n
R392 470R
R34 6K34
C26 22u/35V
+VCC
R56 2K49
R126 2K49
3
R60 2K49
C17 10n
C32 47u/63V
+VCC
D6 C53 BAS316 1000u/10V
2
C36 47u/63V
R18 1K50
U2B 4580M
R131 62K
L8PU2
+VCC
4
+VCC
T
X10 JY-6351G-02-250
8
LINE IN2
+VCC
-VCC
C2 330P
X7 JY-5042-030G 3c 4d 2b 1a
-VCC
TR19 HR
R42 20K
C25 22u/35V
5e S
4
PH PWR
R51 2K49
C6 1n
-VCC
R66 2K49
R90 2K49
8
1
7
C70 5 0.22u/50V
C50 22P R402 5K11
SW1B PS-22E85L
C86 47u/25V
6
R58 2K49
LINE IN GAIN=+15~-45dB
R4 6K81
R136 1K3
R418 10K0
8
MIC GAIN=0~-60dB
R3 6K81
6
C5 1n R45 2K49
R48 4R7
7
R11 4R7
LINE IN3
C38 10n
+VCC
8
TR26 A1316
TR16 A1316
R149 6K8
4
R30 6K34
C71 0.22u/50V
C34 47u/63V
R20 4R7 R RN TN
3c 4d 2b 1a
INS-CH1
R61 2K49
C31 10n
+VCC
C3 330P
X9 JY-5042-030G C72 0.22u/50V
U1B 4580M
1 3 2 4
MIC 3
SW1A PS-22E85L
R46 5K11
R403 5K11
5
LO CUT
R176 20K
C49 22P R417 10K0
C48 22P
VR1 2C10K
-VCC
R29 6K34
R12 1K50
1 3 2 4
2
3
R389 470R
R19 4R7
1
R404 5K11
R6 6K81
7
4
R388 470R
C30 47u/63V
C20 22u/35V
X6 JY-6351G-02-250
U1A 4580M
R5 6K81
C85 47u/25V
3
TR35 HR 2
R28 20K
C19 22u/35V
T
U2A 4580M
C57 22P
1
R14 4R7 R RN TN
5e S
MIC 2
R57 2K49
+VCC
8
TR15 HR
D4 C51 BAS316 1000u/10V
8
LINE IN1
R52 2K49
PH PWR
4
3c 4d 2b 1a
C29 47u/63V
C16 10n
6
+VCC
R53 2K49
C1 330P
X5 JY-5042-030G D
R50 2K49
C15 10n
+VCC
8
R13 4R7
1 3 2 4
MIC 1
R2 6K81
+VCC
5
4
R1 6K81
+VCC
4
8
PH PWR
3
4
1
2TK-IN-L 2TK-IN-R
5e
X21 JY-6351G-02-250
CN1 9P-2.0 (TO L8PU1) RTN-CH1 INS-CH1 RTN-CH2 INS-CH2 RTN-CH3 INS-CH3 RTN-CH4 INS-CH4
A
1 2 3 4 5 6 7 8 9
CN2 7P-2.0 (TO L8PU1) CTRL-R-R CTRL-R-L MAIN-R-2 MAIN-R-3 MAIN-L-2 MAIN-L-3
CN3 2.5-12P-B24 (TO L8MN1) RTN-CH1 RTN-CH2 RTN-CH3 RTN-CH4
1 2 3 4 5 6 7 +VCC -VCC PH PWR
PRE-CH5 PRE-CH6 PRE-CH7 PRE-CH8 +VCC -VCC
CN4 2.5-12P-B24 (TO L8MN1) MAIN-R-2 MAIN-R-3 MAIN-L-2 MAIN-L-3
1 2 3 4 5 6 7 8 9 10 11 12
AUX-RTN1-L AUX-RTN1-R AUX-RTN2-L EFXRTN-L AUX-RTN2-R EFXRTN-R
1 2 3 4 5 6 7 8 9 10 11 12
C261 22P R84 10K
CN5 2.5-8P-B24A (TO L8MN1) CTRL-R-L CTRL-R-R 2TK-IN-L 2TK-IN-R AUX-SEND1 AUX-SEND2
2
1 2 3 4 5 6 7 8
FOOTSW
R330 120R
CTRL-R-R
6 1
3
5
C262 22P R83 10K
U28B BA15218N
R331 120R
A
X28 JY-6351G-02-250
R332 120R
2
CTRL-R-L
PHONES
5e 7
U28A BA15218N
3c 4d 2b 1a
6 1
3
7 5
U29A BA15218N
R334 U29B 120R BA15218N
Titel
Date: File: 1
2
3
4
5
6
INPUT/OUTPUT STAGE
PCB# L8PU2.PCB Size A2(C)
7
Model No:
Revision VER030120
ALTO L-8 5-Oct-2003 L8PU2.Sch
Sheet 1 of 1 KEVIN LIN. Drawn By: 8
A
B
C
D
1 2 3 4 5 6 7 8 9
GND-INS
CN1 9P-2.0
1
1
GND-INS
GND-INS
GND-INS
R12 120R
RTN4 INS4
R9 120R
RTN3 INS3
R8 120R
RTN2 INS2
GND-INS
R1 120R
RTN1 INS1
5e
1a
5e
1a
5e
1a
S
T
5e
1a
3c R RN 4d TN 2b
S
T
3c R RN 4d TN 2b
S
T
3c R RN 4d 2b TN
S
T
3c R RN 4d TN 2b
X4 JY-6351G-02-250
INSERT4
X3 JY-6351G-02-250
INSERT3
X2 JY-6351G-02-250
INSERT2
X1 JY-6351G-02-250
INSERT1
2
CN2 7P-2.0
1 2 3 4 5 6 7
2
MAIN-L-2 MAIN-L-3
MAIN-R-2 MAIN-R-3
R10 120R
R2 120R
R4 120R
R3 120R
S
T 5e
1a
3
R23 5K1
R21 5K1
X6 JY-6351G-02-250
CTRL ROOM L
5e
1a
3c R RN 4d TN 2b
S
T
X5 JY-6351G-02-250
CTRL ROOM R 3c R RN 4d TN 2b
3
R24 5K1
R22 5K1
Date: File:
Size A4
Titel
R16 120R
R15 120R
R14 120R
R13 120R
5e
1a
S
T
2 3 1
2 3 1
5e
1a
3c R RN 4d TN 2b
S
T
3c R RN 4d TN 2b
X9 JY-5030-030G
X10 JY-5030-030G
LEFT
RIGHT
MAIN OUT (BALANCED)
X7 JY-6351G-02-250
MAIN L (UNBAL)
X8 JY-6351G-02-250
MAIN R (UNBAL)
ALTO L-8 5-Oct-2003 L8PU1.Sch
Model No:
PCB# L8PU1.PCB
4
Sheet 1 of 1 Drawn By: KEVIN LIN.
Revision VER021103
OUTPUT STAGE (INSERT & MAIN OUTPUT)
R11 120R
R5 120R
R7 120R
R6 120R
L8PU1
4
A
B
C
D
4. PRINTED CIRCUIT DIAGRAM
PCB : L8MN1 Top Overlay
PCB : L8MN1 Top Layer
PCB : L8MN1 Bottom Layer
PCB : L8PU1 Top Overlay
PCB : L8PU1 Bottom Layer
PCB : L8PU2 Top Overlay
PCB : L8PU2 Top Layer
PCB : L8PU2 Bottom Layer
PCB : RD82PWR Top Overlay
PCB : RD82PWR Bottom Layer
PCB : 313123/2 Top Layer
PCB : 313123/2 Bottom Layer
PCB : 313123/2 Top Overlay
A
B
C
D
1
1
CN4
CN3
2
CN1 9P-2.0 (TO L8PU1)
(TO L8MN1) 2.5-12P-B24
3
3
CN4
L8PU2
7P-2.0
CN2
7 6 5 4 3 2 1
(TO L8PU2)
2.5-12P-B24 (TO L8PU2)
9 8 7 6 5 4 3 2 1
L8PU1 MAIN-L-3 MAIN-L-2 MAIN-R-3 MAIN-R-2 GND CTRL-R-L CTRL-R-R
2
2.5-12P-B24 (TO L8PU2)
(TO L8MN1) 2.5-12P-B24
CN3
GND INS-CH4 RTN-CH4 INS-CH3 RTN-CH3 INS-CH2 RTN-CH2 INS-CH1 RTN-CH1
GND INS-CH4 RTN-CH4 INS-CH3 RTN-CH3 INS-CH2 RTN-CH2 INS-CH1 RTN-CH1
(TO L8PU2)
12 11 10 9 8 7 6 5 4 3 2 1
9 8 7 6 5 4 3 2 1
12 11 10 9 8 7 6 5 4 3 2 1
MAIN-L-3 MAIN-L-2 MAIN-R-3 MAIN-R-2 GND CTRL-R-L CTRL-R-R
CN5
(TO L8MN1) 2.5-8P-B24A
CN5
2.5-8P-B24A (TO L8PU2)
L8MN1
CN2 7P-2.0 (TO L8PU1)
7 6 5 4 3 2 1 8 7 6 5 4 3 2 1
9P-2.0
PH PWR -VCC +VCC PRE-CH8 PRE-CH7 PRE-CH6 PRE-CH5 GND RTN-CH4 RTN-CH3 RTN-CH2 RTN-CH1
GND EFXRTN-R AUX-RTN2-R EFXRTN-L AUX-RTN2-L AUX-RTN1-R AUX-RTN1-L GND MAIN-L-3 MAIN-L-2 MAIN-R-3 MAIN-R-2
4
4
FOOTSW GND AUX-SEND2 AUX-SEND1 2TK-IN-R 2TK-IN-L CTRL-R-R CTRL-R-L
8 7 6 5 4 3 2 1
CN1
12 11 10 9 8 7 6 5 4 3 2 1
12 11 10 9 8 7 6 5 4 3 2 1
GND +5V +15V GND -15V GND GND +48V
1 2 3 4 5 6 7 8
CN0
(TO RD82PWR)
2.5-8P
5
GND +5V +15V GND -15V GND GND +48V
5
CN3
2.5-8P
(TO L8MN1)
1 2 3 4 5 6 7 8
6
3P-3.9
CN1
RD82PWR
2 1
2P-2.5
CN2 6
1 2 3
Date: File: 7
Size A3
Titel
PT-S12_230V (PT-S12_115V)
7
5-Oct-2003 L8PIN.Sch
Model No: L-8 WIRE CONFIGATION
ALTO MIXING CONSOLE
PHANTOM
Sheet Drawn By:
8
POWER
8
Revision VER030403
1 of 1 SAMBOW
A
B
C
D
5. Wiring Diagram
7. Electrical Parts List
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
├0001--------------------------------││ ││ │└0001------------------------------│ │ │ │ │ └0001-----------------------------│ │ │ │ │ ├0001----------------------------│ │ │ │ │ └0002----------------------------│ │ ├0002--------------------------------││ ││ │└0001------------------------------│ │ │ │ │ ├0001-----------------------------│ │ │ │ │ ├0002-----------------------------│ │ │ │ │ └0003-----------------------------│ │ ├0003--------------------------------││ ││ │├0001------------------------------││ ││ │└0002------------------------------│ │ ├0004--------------------------------│ │ ├0005--------------------------------│ │ ├0006--------------------------------│ │ ├0007--------------------------------│ │ ├0008--------------------------------│ │ ├0009--------------------------------│ │ ├0010--------------------------------│ │ ├0011--------------------------------│ │ ├0012--------------------------------│ │
2003/10/05 1 / 19
MA04065 panel L-8 ALTO MA04066 panel L-8 MA04067 panel L-8 MJ01186 hot gradual zinc 1.0t*2135*1220mm 20.45kg ME00097 screw M3*10*0.5PH MB02799 rear board L8 MB02800 rear board L-8 MJ00058 iron board 1*2135*1220 20.45kg ME00032 iron pillar hexagon6.35*M3*5.2 ME00004 screw M3*10*0.5PH MJ01189 partitions L-8 MJ00061 Zn-plated board 1*2135*1220 20.45kg ME00066 iron pillar M3*7 HI00026 power switch RA12KKATOF 2P HI00171 power switch R612KKAT0F1 HC00008 AC outlet 3515 A TYPE(RF-2004-C-4.8) HD00054 fuse 250mA 250V φ5.2*20mm CSA/S/UL/VDE MG00304 copper pole M3*14*0.5PH MG00363 bare M3*14*0.5PH MG00305 copper pole M3*24*0.5PH NI01862 key 5.5*5.5*14.5 NI01863 key φ5.5*W10*7.5
PCS PCS PCS PCS KG PCS PCS PCS PCS KG PCS PCS PCS PCS KG PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 15 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 20 0.00 2.0000 1 0.00 2.0000 1 0.00 1.0000 1 0.00 1.0000 221 0.00 3.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 8.0000 1 0.00 3.0000 1 0.00 1.0000 1 0.00 4.0000 1 0.00 7.0000 1 0.00
2003/04/29 N %
2003/04/24 N %
2003/04/24 N %
2003/04/24 N %
2003/07/11 N %
2003/04/29 N %
2003/04/24 N %
2003/04/24 N %
2003/08/24 N %
2003/08/24 N %
2003/04/29 N %
2003/04/24 N %
2003/04/24 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Version
Date Page No.: Version
UNIT: Date:
Item No Item Descri
2003/10/05 2 / 19
PCS 2003/04/29
Loss %
Ver.
Unit
Component Remark
├0013--------------------------------NI02083 │ knob φ10.5*18 │ ├0014--------------------------------NI02081 │ knob │ φ10.5*18 ├0015--------------------------------NI02082 │ knob │ φ10.5*18 ├0016--------------------------------NI02084 │ knob │ φ10.5*18 ├0017--------------------------------NI02386 │ konb │ φ14*13mm ├0018--------------------------------MG00041 │ screw M3*6 │ ├0019--------------------------------MG00042 │ screw │ M3*10 ├0020--------------------------------MG00061 │ screw │ M3*10 ├0021--------------------------------MG00102 │ screw │ M4*8 ├0022--------------------------------MF00038 │ washer │ φ4*φ7*1t ├0023--------------------------------MF00048 │ washer │ φ4*φ8*0.5t ├0024--------------------------------ME00060 │ socket nut JY-6351G-02-250 │ ├0025--------------------------------MF00061 │ washer │ JY-6351G-02-250 ├0026--------------------------------HA01174 │ signle terminal wiring CF:W146 │ 80 green/yellow ├0027--------------------------------HA01835 │ P.V.C single wave wired UL1617 │ 80 brown ├0028--------------------------------HA01392 │ row-wire connector wiring │ 2P 150 ├0029--------------------------------HA02355 │ wire │ 8P-8P 200mm UL1007 22AWG ├0030--------------------------------HA00861 │ power cord Europe 3P │ LT-312+LT-501 ├0031--------------------------------NI00218 │ cable tie-black ALT-102SB │ ├0032--------------------------------- @ NI00252 ││ sleeve ││ φ4*20mm │└0001------------------------------NI00248 │ sleeve │ φ4*1000mm ├0033--------------------------------NI00501 │ foot cushion │ 12.7*9*3t(SF-004)
PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS M PCS
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
18.0000 1 0.00 12.0000 1 0.00 6.0000 1 0.00 5.0000 1 0.00 2.0000 1 0.00 37.0000 1 0.00 2.0000 1 0.00 15.0000 1 0.00 2.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 24.0000 1 0.00 24.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 2.0000 1 0.00 7.0000 1 0.00 20.0000 1000 0.00 4.0000 1 0.00
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/06/24 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2002/06/04 N %
2003/04/29 N %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
├0034--------------------------------│ │ ├0035--------------------------------│ │ ├0036--------------------------------│ │ ├0037--------------------------------││ ││ │└0001------------------------------│ │ ├0038--------------------------------││ ││ │└0001------------------------------│ │ │ │ │ └0001-----------------------------│ │ ├0039--------------------------------│ │ ├0040--------------------------------│ │ ├0041--------------------------------│ │ ├0042--------------------------------│ │ ├0043--------------------------------│ │ ├0044--------------------------------│ │ ├0045--------------------------------│ │ ├0046--------------------------------│ │ ├0047--------------------------------│ │ ├0048--------------------------------│ │ ├0049--------------------------------│ │ ├0050--------------------------------│ │ ├0051--------------------------------││ ││ │└0001------------------------------│ │
NA00123 PE bag 0.04t*580*300mm HJ00006 desiccant 30g TC00160 transformer PT-DJM3_230V MI01629 separating shade S-12 MJ00090 iron board 0.3*200*3000 1.431kg MJ01145 heat sink RD82 MJ01142 radiator RD82 MJ00070 AL board 4*2440*1220 32.40kg NI02249 caushion TW-1(TO-220) NC00022 insulation 0.3t*18*45mm S-8 NC00005 silicone insulator TO-220 square type MG00162 screw M3*8 ME00015 colour nut 3m/m MF00037 washer φ3*φ5*1t MF00030 washer φ3*φ8*0.8t NF00061 assurance card ALTO NE05004 label ALTO NI02620 insulation board 1*86.5*53 L-8 NI02633 knob φ10.5*18 NI00826 knob φ12*18 double color NF01355 instruction L-8 ALTO NH00149 paper 889*640mm
2003/10/05 3 / 19
PCS KG PCS PCS PCS PCS KG PCS PCS PCS KG PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS PCS 張 令
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 119 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 880 0.00 4.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 4.0000 1 0.00 3.0000 1 0.00 6.0000 1 0.00 2.0000 1 0.00 1.0000 1 0.00 4.0000 1 0.00 1.0000 1 0.00 3.0000 1 0.00 8.0000 1 0.00 1.0000 1 0.00 2.0000 1 0.00
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/02/08 N %
2003/04/29 N %
2002/11/25 N %
2003/02/22 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/07/28 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/09/09 N %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
├0052--------------------------------│ │ ├0053--------------------------------││ ││ │├0001------------------------------││ ││ │└0002------------------------------│ │ ├0054--------------------------------│ │ ├0055--------------------------------│ │ ├0056--------------------------------│ │ ├0057--------------------------------│ │ ├0058--------------------------------││ ││ │├0001------------------------------││ ││ ││ ││ │├0002------------------------------││ ││ ││ ││ │├0003------------------------------││ ││ ││ ││ │├0004------------------------------││ ││ ││ ││ │├0005------------------------------││ ││ ││ ││ │├0006------------------------------││ ││ ││ ││ ││ ││ ││ ││ ││ ││ │├0007------------------------------││ ││ ││
NB02249 colour box L-8 ALTO NE11348 label L-8 ALTO NH00012 bond paper 0.04*1M NI00014 membrane 0.035*1M NI01272 handle for wireless coloful box NB01568 barrier S8 NB01625 barrier S8 NB02354 box L-8 HK03835 K-PC board P-L8MN1-DIP RA00185 fixed resistor 1/4W 120Ω M type R350,R353 CB00009 electrolytic capacitor 1uF/50V φ4*7mm C3,C4
2003/10/05 4 / 19
PCS PCS M M PCS PCS PCS PCS PCS PCS
PCS
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
1.0000 1 0.00 4.0000 1 0.00 1.0000 80 0.00 1.0000 80 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 1 0.00 1.0000 4 0.00 1.0000 1 0.00 2.0000 1 0.00
2003/04/29 N %
2003/04/29 N %
2003/05/31 N %
2003/05/31 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/05/30 N %
2003/04/29 N %
2003/04/29 N %
2.0000 2003/04/29 N 1 0.00 %
CB00011 electrolytic capacitor PCS 2.2uF/50V φ5*11mm C195,C196,C197,C198,C199,C200
6.0000 2003/04/29 1 N 0.00 %
CB00018 electrolytic capacitor 4.7uF/25V φ4*7mm C50,C52,C59
PCS
3.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
CB00024 electrolytic capacitor 10uF/16V φ4*7mm C86,C118
CB00175 70.0000 2003/06/13 PCS N electrolytic capacitor 1 47uF/25V SLL φ5*11mm 0.00 % C5,C6,C7,C8,C9,C10,C19,C45,C87,C88,C89,C90,C94,C95, C96,C97,C98,C101,C102,C103,C104,C105,C106,C107,C111, C112,C113,C114,C115,C116,C119,C120,C121,C124,C125, C126,C127,C128,C129,C130,C231,C232,C233,C234,C236, C237,C238,C239,C241,C243,C244,C245,C246,C247,C248, C249,C250,C251,C252,C255,C256,C257,C258,C283,C284, C286,C318,C319,C320,C321 CF00054 16.0000 2003/04/29 PCS N metal-film capacitor MSC 1 0.012uF/63V ±5% CASE01 0.00 % C155,C156,C157,C158,C159,C160,C161,C162,C171,C172,
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
PCS 2003/04/29
Loss %
Ver.
Unit
Component Remark
││ ││ │├0008------------------------------││ ││ ││ ││ ││ │├0009------------------------------││ ││ ││ ││ ││ │├0010------------------------------││ ││ ││ ││ │├0011------------------------------││ ││ ││ ││ │├0012------------------------------││ ││ ││ ││ │├0013------------------------------││ ││ ││ ││ │├0014------------------------------││ ││ ││ ││ │├0015------------------------------││ ││ ││ ││ │├0016------------------------------││ ││ ││ ││ │├0017------------------------------││ ││ ││ ││ ││ │├0018------------------------------││ ││ ││ ││ │├0019------------------------------││ ││ ││ ││
2003/10/05 5 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
C173,C174,C175,C176,C177,C178 CF00021 16.0000 2003/04/29 metal-film capacitor MSC 1 PCS N 0.018uF/63V 5% CASE01 0.00 % C131,C132,C133,C134,C135,C136,C137,C138,C163,C164, C165,C166,C167,C168,C169,C170 CF00023 16.0000 2003/04/29 PCS N metal-film capacitor MSC 1 0.033uF/63V 5% CASE01 0.00 % C139,C140,C141,C142,C143,C144,C145,C146,C147,C148, C149,C150,C151,C152,C153,C154 CF00070 metal-film capacitor FKP 0.0015uF/63V 2.5% (PFR5 152H63J11L4) C60,C61,C62 HC00261 row-wire header 12P 2.0mm 180° CN3,CN4 HC00259 row-wire header 8P 2.0mm 180° CN5 HC00072 row-wire header 8P 2.5mm 90° CN0 HC00511 row-pin header(single)#2804 2.54 180° 2*8P(gold-plated) 5.7mm CN6 HI00162 push-button switch 2 paragraphs 6p PS-22E8552L SW9,SW10 HI00177 push-button switch 2段 6P PS-22E8552N(3.3*3.3)NO LOCK SW1
PCS
3.0000 2003/04/29 1 N 0.00 %
PCS
2.0000 2003/06/24 N 1 0.00 %
PCS
1.0000 2003/06/24 N 1 0.00 %
PCS
1.0000 2003/04/29 1 N 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
SA00052 21.0000 2003/04/29 PCS N L.E.D high intensity 1 3m/m round(green)long foot 26 0.00 % LD7,LD10,LD11,LD12,LD13,LD14,LD15,LD16,LD17,LD18,LD19, LD22,LD23,LD24,LD25,LD26,LD27,LD28,LD29,LD30,LD31 SA00053 10.0000 2003/04/29 PCS N L.E.D high intensity 1 3m/m round(red)long foot 26mm 0.00 % LD1,LD2,LD3,LD4,LD5,LD6,LD8,LD21,LD33,LD54 SA00054 L.E.D high intensity 3m/m round(yellow)long foot 26 LD20,LD32
PCS
2.0000 2003/04/29 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
│├0020------------------------------││ ││ │├0021------------------------------││ ││ ││ ││ │├0022------------------------------││ ││ ││ ││ ││ │├0023------------------------------││ ││ ││ ││ │├0024------------------------------││ ││ ││ ││ ││ │├0025------------------------------││ ││ ││ ││ │├0026------------------------------││ ││ ││ ││ │├0027------------------------------││ ││ ││ ││ │└0028------------------------------│ │ │ │ │ ├0001-----------------------------│ │ │ │ │ ├0002-----------------------------│ │ │ │ │ │ │ │ │ ├0003-----------------------------│ │ │ │ │ │ │ │ │ ├0004-----------------------------│ │ │ │ │ │ │ │ │ ├0005-----------------------------│ │ │ │ │ │ │ │
2003/10/05 6 / 19
NI01782 LED spacer support LEDS-11 11mm RC00259 potentiometer J/Q10K RV112BC-40-30A-J/Q10K-0C VR7,VR15,VR23,VR31,VR39,VR46
PCS PCS
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
33.0000 2003/04/29 1 N 0.00 % 6.0000 2003/04/29 N 1 0.00 %
RC00235 17.0000 2003/04/29 potentiometer 1 PCS N 0.00 % W50K RV09BC-40-30F-W50K-0C VR5,VR6,VR8,VR9,VR13,VR14,VR16,VR21,VR22,VR24,VR29, VR30,VR32,VR37,VR38,VR44,VR45 RC00237 PCS potentiometer W50K RV112BC-40-30A-W50K-0C VR40,VR47,VR48,VR49,VR50,VR51
6.0000 2003/04/29 N 1 0.00 %
RC00233 12.0000 2003/04/29 PCS N potentiometer 1 B50K RV09BC-40-30F-B50K-0C 0.00 % VR2,VR3,VR4,VR10,VR11,VR12,VR18,VR19,VR20,VR26,VR27, VR28 RC00236 PCS potentiometer B50K RV112BC-40-30A-B50K-0C VR34,VR35,VR36,VR41,VR42,VR43
6.0000 2003/04/29 N 1 0.00 %
HI00161 relay RY-5W-K,5V RL1
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 1 N 0.00 %
HI00195 switch SDB161PVB15.5F-1-4-16-16PC EN1,EN2 HK03834 K-PC board P-L8MN1-SMD HB00917 pc board L8MN1_VER030714 RD00059 SMD fixed resistor 1/10W 0.0Ω ±5% 0603 R371,R372 RD00065 SMD fixed resistor 1/10W 47Ω ±5% 0603 R373,R374 RD00346 SMD fixed resistor 1/10W 56Ω ±5% 0603 R354 RD00066 SMD fixed resistor 1/10W 68Ω ±5% 0603 R6,R68
PCS PCS PCS
1.0000 2003/04/29 N 1 0.00 % 1.0000 2003/04/29 N 1 0.00 % 2.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
│ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │
├0006-----------------------------│ │ │ │ ├0007-----------------------------│ │ │ │ ├0008-----------------------------│ │ │ │ ├0009-----------------------------│ │ │ │ ├0010-----------------------------│ │ │ │ ├0011-----------------------------│ │ │ │ ├0012-----------------------------│ │ │ │ │ ├0013-----------------------------│ │ │ │ ├0014-----------------------------│ │ │ │ ├0015-----------------------------│ │ │ │ ├0016-----------------------------│ │ │ │ ├0017-----------------------------│ │ │ │ ├0018-----------------------------│ │ │ │
RD00069 SMD fixed resistor 1/10W 120Ω ±5% 0603 R355 RD00073 SMD fixed resistor 1/10W 220Ω ±5% 0603 R65,R79,R80 RD00076 SMD fixed resistor 1/10W 330Ω ±5% 0603 R359,R360 RD00078 SMD fixed resistor 1/10W 470Ω ±5% 0603 R351,R352,R356,R357,R358 RD00347 SMD fixed resistor 1/10W 510Ω ±5% 0603 R361 RD00348 SMD fixed resistor 1/10W 620Ω ±5% 0603 R362
2003/10/05 7 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
PCS
1.0000 2003/04/29 1 N 0.00 %
PCS
3.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 1 N 0.00 %
PCS
5.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
RD00349 16.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 0.00 % 910Ω ±5% 0603 R196,R197,R198,R199,R200,R201,R202,R203,R204,R205, R206,R207,R208,R209,R210,R211 RD00083 SMD fixed resistor 1/10W 1.0KΩ ±5% 0603 R114
PCS
RD00350 PCS SMD fixed resistor 1/10W 1.1KΩ ±5% 0603 R212,R213,R214,R215,R216,R217,R218,R219
1.0000 2003/04/29 1 N 0.00 % 8.0000 2003/04/29 N 1 0.00 %
RD00351 9.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 1.3KΩ ±5% 0603 0.00 % R137,R139,R141,R143,R145,R363,R146,R147,R148 RD00085 PCS SMD fixed resistor 1/10W 1.5KΩ ±5% 0603 R264,R265,R266,R267,R268,R269
6.0000 2003/04/29 N 1 0.00 %
RD00087 SMD fixed resistor 1/10W 2.0KΩ ±5% 0603 R252,R364
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
RD00088 SMD fixed resistor 1/10W 2.2KΩ ±5% 0603 R54
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
│ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │
├0019-----------------------------│ │ │ │ │ ├0020-----------------------------│ │ │ │ ├0021-----------------------------│ │ │ │ │ │ │ ├0022-----------------------------│ │ │ │ ├0023-----------------------------│ │ │ │ │ │ ├0024-----------------------------│ │ │ │ ├0025-----------------------------│ │ │ │ ├0026-----------------------------│ │ │ │ │ │ │ ├0027-----------------------------│ │ │ │ ├0028-----------------------------│ │ │ │ ├0029-----------------------------│ │ │ │ ├0030-----------------------------│ │
2003/10/05 8 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
RD00092 12.0000 2003/08/26 SMD fixed resistor 1/10W 1 PCS N 0.00 % 3.9KΩ ±5% 0603 R16,R339,R344,R345,R256,R257,R258,R259,R260,R261,R262, R263 RD00093 PCS SMD fixed resistor 1/10W 4.7KΩ ±5% 0603 R90,R248,R249,R250,R251,R253,R254,R255
8.0000 2003/04/29 N 1 0.00 %
RD00094 37.0000 2003/06/07 PCS N SMD fixed resistor 1/10W 1 5.1KΩ ±5% 0603 0.00 % R375,R287,R288,R289,R290,R291,R292,R293,R294,R295, R296,R297,R298,R299,R301,R302,R304,R305,R306,R308, R309,R310,R311,R312,R313,R314,R315,R316,R317,R12,R15, R38,R39,R284,R285,R286,R93 RD00095 SMD fixed resistor 1/10W 5.6KΩ ±5% 0603 R365
PCS
1.0000 2003/04/29 N 1 0.00 %
RD00097 22.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 6.8KΩ ±5% 0603 0.00 % R150,R151,R152,R154,R155,R156,R158,R159,R160,R162, R163,R164,R166,R167,R168,R169,R170,R171,R172,R173, R174,R175 RD00098 SMD fixed resistor 1/10W 7.5KΩ ±5% 0603 R49
PCS
1.0000 2003/04/29 1 N 0.00 %
RD00099 SMD fixed resistor 1/10W 8.2KΩ ±5% 0603 R77,R78
PCS
2.0000 2003/04/29 1 N 0.00 %
RD00101 50.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 10KΩ ±5% 0603 0.00 % R1,R2,R3,R7,R8,R9,R10,R11,R19,R20,R21,R22,R23,R24,R27, R46,R47,R48,R50,R52,R53,R55,R56,R63,R66,R67,R71,R72, R75,R76,R81,R82,R85,R86,R87,R96,R97,R98,R99,R100,R111, R118,R120,R121,R122,R123,R124,R125,R427,R428 RD00306 PCS SMD fixed resistor 1/10W 20KΩ ±5% 0603 R184,R185,R186,R187,R188,R189
6.0000 2003/04/29 N 1 0.00 %
RD00105 PCS SMD fixed resistor 1/10W 22KΩ ±5% 0603 R240,R241,R244,R245,R246,R247,R319,R321
8.0000 2003/08/26 N 1 0.00 %
RD00106 SMD fixed resistor 1/10W 27KΩ ±5% 0603 R348,R349,R366
PCS
3.0000 2003/08/26 N 1 0.00 %
PCS
4.0000 2003/04/29 N 1 0.00 %
RD00107 SMD fixed resistor 1/10W 30KΩ ±5% 0603
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
PCS 2003/04/29
Loss %
Ver.
Unit
Component Remark
│ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │
│ │ ├0031-----------------------------│ │ │ │ │ ├0032-----------------------------│ │ │ │ ├0033-----------------------------│ │ │ │ ├0034-----------------------------│ │ │ │ ├0035-----------------------------│ │ │ │ ├0036-----------------------------│ │ │ │ ├0037-----------------------------│ │ │ │ ├0038-----------------------------│ │ │ │ ├0039-----------------------------│ │ │ │ ├0040-----------------------------│ │ │ │ ├0041-----------------------------│ │ │ │ │ │ │ ├0042-----------------------------│ │ │ │
2003/10/05 9 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
R236,R237,R238,R239 RD00353 14.0000 2003/08/26 SMD fixed resistor 1/10W 1 PCS N 36KΩ ±5% 0603 0.00 % R270,R271,R272,R273,R274,R275,R276,R277,R278,R279, R280,R281,R282,R283 RD00109 SMD fixed resistor 1/10W 39KΩ ±5% 0603 R73,R74 RD00111 SMD fixed resistor 1/10W 47KΩ ±5% 0603 R4,R232,R233,R234,R235 RD00354 SMD fixed resistor 1/10W 51KΩ ±5% 0603 R41 RD00112 SMD fixed resistor 1/10W 56KΩ ±5% 0603 R318,R320 RD00114 SMD fixed resistor 1/10W 68KΩ ±5% 0603 R228,R229,R230,R231 RD00116 SMD fixed resistor 1/10W 100KΩ ±5% 0603 R367,R368,R369,R370 RD00124 SMD fixed resistor 1/10W 820KΩ ±5% 0603 R5
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
5.0000 2003/04/29 1 N 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
4.0000 2003/04/29 1 N 0.00 %
PCS
4.0000 2003/04/29 1 N 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
RD00125 9.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 1.0MΩ ±5% 0603 0.00 % R112,R220,R221,R222,R223,R224,R225,R226,R227 RD00126 SMD fixed resistor 1/10W 2.2MΩ ±5% 0603 R113
PCS
1.0000 2003/04/29 N 1 0.00 %
CI00051 38.0000 2003/04/29 PCS N SMD ceramic capacitor 0603 1 22PF/50V NPO ±5% 0.00 % C11,C12,C13,C22,C24,C38,C39,C40,C49,C179,C180,C181, C182,C183,C184,C185,C186,C187,C188,C189,C190,C191, C192,C193,C194,C221,C222,C223,C224,C225,C226,C260, C263,C264,C269,C270,C281,C282 CI00053 SMD ceramic capacitor 0603 33PF/50V NPO ±5% C2,C117
PCS
2.0000 2003/04/29 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
│ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │
├0043-----------------------------│ │ │ │ ├0044-----------------------------│ │ │ │ ├0045-----------------------------│ │ │ │ │ │ │ │ ├0046-----------------------------│ │ │ │ ├0047-----------------------------│ │ │ │ ├0048-----------------------------│ │ │ │ ├0049-----------------------------│ │ │ │ ├0050-----------------------------│ │ │ │ ├0051-----------------------------│ │ │ │ ├0052-----------------------------│ │ │ │ ├0053-----------------------------│ │ │ │ │ ├0054-----------------------------│ │ │ │
2003/10/05 10 / 19
CI00055 SMD ceramic capacitor 0603 47PF/50V NPO ±5% C342,C343 CI00059 SMD ceramic capacitor 0603 100PF/50V NPO ±5% C14,C20,C265,C266,C271,C272
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
PCS
2.0000 2003/04/29 1 N 0.00 %
PCS
6.0000 2003/04/29 N 1 0.00 %
CI00075 45.0000 2003/04/29 SMD ceramic capacitor 0603 1 PCS N 0.1uF/50V Y5V +80,-20% 0.00 % C1,C29,C30,C31,C32,C35,C36,C51,C15,C16,C17,C18,C37, C201,C202,C203,C204,C205,C206,C207,C208,C211,C212, C213,C214,C217,C218,C219,C220,C289,C290,C295,C296, C297,C298,C305,C306,C307,C308,C309,C310,C311,C312, C340,C341 RE00011 resistor 680Ω*4 ±5% 8P 0603 AR1,AR2 SE00028 diode BAS316,115 D7,D15 SE00008 SMD rectifier diode DA204K/T-146 D1,D2,D3 SE00009 SMD rectifier diode DAN202K/T-146 D16 SE00007 SMD rectifier diode RB400D(D3A) D10 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34) D9 SF00004 SMD transistor 2SA1036K(R)(MMBT3906LT1) TR13,TR14
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
3.0000 2003/04/29 1 N 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
SF00010 14.0000 2003/04/29 PCS N SMD transistor 1 2SC2412K(R)(MMBT3904LT1) 0.00 % TR1,TR2,TR3,TR4,TR5,TR6,TR7,TR8,TR9,TR10,TR11,TR12, TR16,TR17 SG00032 SMD integraded circuit LM339DR/(TI) U35,U36,U37,U38,U39,U40
PCS
6.0000 2003/04/29 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
PCS 2003/04/29
Loss %
Ver.
Unit
Component Remark
│ ├0055-----------------------------│ │ │ │ │ │ │ │ │ │ │ ├0056-----------------------------│ │ │ │ │ │ │ │ │ ├0057-----------------------------│ │ │ │ │ │ │ │ │ ├0058-----------------------------│ │ │ │ │ │ │ │ │ ├0059-----------------------------│ │ │ │ │ │ │ │ │ ├0060-----------------------------│ │ │ │ │ │ │ │ │ ├0061-----------------------------│ │ │ │ │ │ │ │ │ └0062-----------------------------│ │ │ │ ├0059--------------------------------││ ││ │├0001------------------------------││ ││ ││ ││ │├0002------------------------------││ ││ ││ ││ │├0003------------------------------││ ││ ││ ││ │├0004------------------------------││ ││ ││ ││ │├0005------------------------------││ ││
2003/10/05 11 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
SG00122 21.0000 2003/04/29 SMD integrated circuit 1 PCS N 0.00 % NJM4580M-TE3 U1,U2,U3,U6,U9,U12,U16,U17,U19,U20,U21,U23,U24,U25, U26,U27,U30,U31,U44,U45,U46 SG00068 SMD integraded circuit 74HC14DT U49 SG00164 integrated circut 74HC109D U48 SG00005 SMD integrated circuit BA10393F U47 SG00094 SMD integrated circuit NE555DT U43 RD00091 SMD fixed resistor 1/10W 3.3KΩ ±5% 0603 R17,R18 RD00096 SMD fixed resistor 1/10W 6.2KΩ ±5% 0603 R25,R26 RD00102 SMD fixed resistor 1/10W 12KΩ ±5% 0603 R13,R14
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/08/27 1 0.00 %
PCS
2.0000 2003/08/27 1 0.00 %
HK03838 PCS K-PC board P-L8PU2-DIP RA00505 PCS precise resistor 1/4W 6.81KΩ M type R1,R2,R3,R4,R5,R6,R7,R8,R9,R10 CB00074 electrolytic capacitor 1000uF/10V φ8*11mm C51,C52,C53,C55,C56
PCS
1.0000 2003/04/29 N 1 0.00 % 10.0000 2003/04/29 N 1 0.00 % 5.0000 2003/04/29 N 1 0.00 %
CB00003 12.0000 2003/04/29 PCS N electrolytic capacitor 1 0.22uF/50V φ5*11mm 0.00 % C70,C71,C72,C73,C74,C75,C76,C77,C78,C79,C80,C81 CB00029 PCS electrolytic capacitor 22uF/35V φ5*11mm C19,C20,C21,C23,C25,C26,C27,C28 CB00175 electrolytic capacitor 47uF/25V SLL φ5*11mm
PCS
8.0000 2003/04/29 N 1 0.00 % 17.0000 2003/06/13 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
PCS 2003/04/29
Loss %
Ver.
Unit
Component Remark
││ ││ ││ │├0006------------------------------││ ││ ││ ││ │├0007------------------------------││ ││ ││ ││ │├0008------------------------------││ ││ ││ ││ │├0009------------------------------││ ││ ││ ││ ││ │├0010------------------------------││ ││ ││ ││ │├0011------------------------------││ ││ ││ ││ │├0012------------------------------││ ││ ││ ││ │├0013------------------------------││ ││ ││ ││ │├0014------------------------------││ ││ ││ ││ │├0015------------------------------││ ││ ││ ││ │├0016------------------------------││ ││ ││ ││ │├0017------------------------------││ ││ ││ ││ │└0018------------------------------│ │ │ │
2003/10/05 12 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
C22,C24,C85,C86,C91,C92,C93,C99,C100,C108,C109,C117, C118,C122,C123,C253,C254 CB00042 electrolytic capacitor PCS 47uF/63V 105℃ LZ φ8*11mm C29,C30,C32,C33,C34,C36,C37,C39,C41,C42
10.0000 2003/04/29 1 N 0.00 %
SB00050 10.0000 2003/04/29 PCS N transistor 1 2SA1316-GR 0.00 % TR16,TR18,TR20,TR22,TR24,TR26,TR28,TR30,TR32,TR34 SD00007 integrated circuit BA15218N (M5218L substitute) U28,U29
PCS
2.0000 2003/04/29 1 N 0.00 %
HC00125 16.0000 2003/04/29 PCS N MIC jack 1 JY-6351G-02-250 0.00 % X6,X8,X10,X12,X14,X15,X16,X17,X18,X19,X20,X21,X22,X23, X25,X28 HI00162 push-button switch 2 paragraphs 6p PS-22E8552L SW1,SW2,SW3,SW4 RC00296 potentiometer O10KΩ RV09BC-40-30F-02C10K VR1,VR9,VR17,VR25,VR33 HC00126 MIC jack for balance JY-5042-030G female plug 180° X5,X7,X9,X11,X13 HC00403 rca SCP6873NS3232T2 4P X31 HA01583 header wiring 12P-12P 40 CN3,CN4 HA01580 row-wire connector wiring 8P(male)-8P(female) 40mm UL1007 28AWG CN5 HA01507 row-wire connector wiring 7P(male)-7P(parent) 140 CN2 HA01506 header wiring AF:W267 9P(male)-9P(parent) 140 CN1 HK03837 K-PC board P-L8PU2-SMD
PCS
4.0000 2003/04/29 N 1 0.00 %
PCS
5.0000 2003/04/29 1 N 0.00 %
PCS
5.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/06/24 N 1 0.00 %
PCS
1.0000 2003/06/24 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
PCS 2003/04/29
Loss %
Ver.
Unit
Component Remark
│ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │
├0001-----------------------------│ │ ├0002-----------------------------│ │ │ │ │ ├0003-----------------------------│ │ │ │ ├0004-----------------------------│ │ │ │ ├0005-----------------------------│ │ │ │ ├0006-----------------------------│ │ │ │ ├0007-----------------------------│ │ │ │ ├0008-----------------------------│ │ │ │ │ ├0009-----------------------------│ │ │ │ │ ├0010-----------------------------│ │ │ │ ├0011-----------------------------│ │ │ │ ├0012-----------------------------│ │ │ │ │ │ ├0013-----------------------------│ │ │
2003/10/05 13 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
HB00916 1.0000 2003/04/29 pc board 1 PCS N 0.00 % L8PU2_VER030714 RD00355 15.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 4.7Ω ±5% 0603 0.00 % R11,R13,R14,R19,R20,R24,R25,R48,R49,R88,R89,R398,R399, R400,R401 RD00069 SMD fixed resistor 1/10W 120Ω ±5% 0603 R322,R323,R324,R325
PCS
4.0000 2003/04/29 1 N 0.00 %
RD00078 10.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 470Ω ±5% 0603 0.00 % R388,R389,R390,R391,R392,R393,R394,R395,R396,R397 RD00083 SMD fixed resistor 1/10W 1.0KΩ ±5% 0603 R342,R343 RD00351 SMD fixed resistor 1/10W 1.3KΩ ±5% 0603 R136,R138,R140,R142 RD00097 SMD fixed resistor 1/10W 6.8KΩ ±5% 0603 R149,R153,R157,R161
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
4.0000 2003/04/29 N 1 0.00 %
PCS
4.0000 2003/04/29 N 1 0.00 %
RD00101 21.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 0.00 % 10KΩ ±5% 0603 R37,R38,R83,R84,R101,R102,R103,R104,R105,R106,R107, R95,R110,R112,R113,R114,R115,R116,R117,R118,R119 RD00306 18.0000 2003/04/29 PCS N SMD fixed resistor 1/10W 1 20KΩ ±5% 0603 0.00 % R28,R40,R42,R43,R44,R176,R177,R178,R179,R180,R181, R182,R183,R190,R192,R193,R194,R195 RD00113 SMD fixed resistor 1/10W 62KΩ ±5% 0603 R131,R132,R133,R134
PCS
RD00201 PCS SMD precise resistor 1/10W 1.50KΩ ±1% 0603 R12,R15,R16,R17,R18,R21,R22,R23,R26,R27
4.0000 2003/04/29 N 1 0.00 % 10.0000 2003/04/29 N 1 0.00 %
RD00204 35.0000 2003/04/29 PCS N SMD precise resistor 1/10W 1 2.49KΩ ±1% 0603 0.00 % R45,R50,R51,R52,R53,R56,R57,R58,R59,R60,R61,R64,R65, R66,R90,R91,R94,R126,R127,R128,R129,R130,R135,R144, R165,R191,R379,R380,R381,R382,R383,R384,R385,R386,R387 19.0000 2003/04/29 RD00210 PCS N SMD precise resistor 1/10W 1 5.11KΩ ±1% 0603 0.00 % R46,R54,R62,R67,R402,R403,R404,R405,R406,R407,R408,
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
PCS 2003/04/29
Loss %
Ver.
Unit
Component Remark
│ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │
│ │ ├0014-----------------------------│ │ │ │ ├0015-----------------------------│ │ │ │ ├0016-----------------------------│ │ │ │ │ │ ├0017-----------------------------│ │ │ │ ├0018-----------------------------│ │ │ │ ├0019-----------------------------│ │ │ │ ├0020-----------------------------│ │ │ │ ├0021-----------------------------│ │ │ │ │ │ ├0022-----------------------------│ │ │ │ ├0023-----------------------------│ │ │ │ ├0024-----------------------------│ │ │ │ ├0025-----------------------------│ │ │ │ │
2003/10/05 14 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
R409,R410,R411,R412,R413,R414,R415,R416 RD00287 SMD precise resistor 1/10W PCS 6.34KΩ ±1% 0603 R29,R30,R31,R32,R33,R34,R35,R36
8.0000 2003/04/29 1 N 0.00 %
RD00214 10.0000 2003/04/29 PCS N SMD precise resistor 1/10W 1 10.0KΩ ±1% 0603 0.00 % R417,R418,R419,R420,R421,R422,R423,R424,R425,R426 CI00051 30.0000 2003/04/29 PCS N SMD ceramic capacitor 0603 1 22PF/50V NPO ±5% 0.00 % C48,C49,C50,C54,C57,C58,C59,C60,C61,C62,C63,C64,C65, C66,C67,C68,C69,C82,C83,C84,C110,C227,C228,C229,C230, C261,C262,C315,C316,C317 CI00059 PCS SMD ceramic capacitor 0603 100PF/50V NPO ±5% C273,C274,C275,C276,C277,C278,C279,C280
8.0000 2003/04/29 N 1 0.00 %
CI00062 SMD ceramic capacitor 0603 330PF/50V NPO ±5﹪ C1,C2,C3,C4,C18
5.0000 2003/04/29 N 1 0.00 %
PCS
CI00065 SMD ceramic capacitor 0603 PCS 0.001uF/50V X7R ±10% C5,C6,C7,C8,C9,C10,C11,C12,C13,C14
10.0000 2003/04/29 1 N 0.00 %
CI00071 PCS SMD ceramic capacitor 0603 0.01uF/50V X7R ±10% C15,C16,C17,C31,C35,C38,C40,C44,C46,C47
10.0000 2003/04/29 N 1 0.00 %
CI00075 28.0000 2003/04/29 PCS N SMD ceramic capacitor 0603 1 0.1uF/50V Y5V +80,-20% 0.00 % C43,C45,C201,C202,C203,C204,C205,C206,C287,C288,C289, C290,C291,C292,C293,C294,C295,C296,C297,C298,C299, C300,C301,C302,C303,C304,C313,C314 RD00004 SMD fixed resistor 1/10W 47Ω ±5% 0805 R346,R347 RD00007 SMD fixed resistor 1/10W 120Ω ±5% 0805 R330,R331,R332,R334
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
4.0000 2003/04/29 N 1 0.00 %
SG00122 13.0000 2003/05/26 PCS N SMD integrated circuit 1 NJM4580M-TE3 0.00 % U1,U2,U4,U5,U7,U8,U10,U11,U13,U14,U15,U16,U18 SF00004 15.0000 2003/04/29 PCS N SMD transistor 1 2SA1036K(R)(MMBT3906LT1) 0.00 % TR15,TR17,TR19,TR21,TR23,TR25,TR27,TR29,TR31,TR33, TR35,TR37,TR38,TR39,TR36
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
│ ├0026-----------------------------│ │ │ │ │ │ │ │ │ └0027-----------------------------│ │ │ │ ├0060--------------------------------││ ││ │├0001------------------------------││ ││ │├0002------------------------------││ ││ │├0003------------------------------││ ││ ││ ││ │├0004------------------------------││ ││ ││ ││ │├0005------------------------------│││ │││ │││ │││ ││└0001----------------------------││ ││ │├0006------------------------------││ ││ ││ ││ │├0007------------------------------││ ││ ││ ││ │└0008------------------------------│ │ │ │ ├0061--------------------------------││ ││ │├0001------------------------------││ ││ │├0002------------------------------││ ││ ││ ││ │├0003------------------------------││ ││ ││
SE00028 diode BAS316,115 D4,D5,D6,D7,D8 RD00107 SMD fixed resistor 1/10W 30KΩ ±5% 0603 R108,R109 HK03836 K-PC board P-L8PU1 HB00915 pc board L8PU1(1*4)_VER030214 RA00185 fixed resistor 1/4W 120Ω M type RA00232 fixed resistor 1/4W 5.1KΩ M type R21,R22,R23,R24 HC00392 shape male JY-5030-030G 180° X9,X10 HA01925 jumper wire 10mm JP1,JP2,JP3 HA02249 wire φ0.6 HC00125 MIC jack JY-6351G-02-250 X1,X2,X3,X4,X5,X6,X7,X8 HC00258 row-wire header 7P 2.0mm 180° CN2 HC00260 row wire header 9P 2.0mm 180° CN1 HK03648 K-PCb P-RD82PWR(RD82FX) HB00879 pc board RD82PWR_VER030110 RA00242 fixed resistor 1/4W 10KΩ M type R2 RA00159 fixed resistor 1/4W 10Ω Mr type R3
2003/10/05 15 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
PCS
5.0000 2003/04/29 1 N 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS PCS PCS PCS
1.0000 1 0.00 1.0000 1 0.00 16.0000 1 0.00 4.0000 1 0.00
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
2003/04/29 N %
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
3.0000 2003/04/29 N 1 0.00 %
M KG PCS
0.0200 2002/09/19 N 1 0.00 % 8.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS PCS PCS
PCS
1.0000 2003/04/29 N 1 0.00 % 1.0000 2003/03/12 N 1 0.00 % 1.0000 2003/03/12 N 1 0.00 % 1.0000 2003/03/12 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
││ │├0004------------------------------││ ││ ││ ││ │├0005------------------------------││ ││ ││ ││ │├0006------------------------------││ ││ ││ ││ │├0007------------------------------││ ││ ││ ││ │├0008------------------------------││ ││ ││ ││ │├0009------------------------------││ ││ ││ ││ │├0010------------------------------││ ││ ││ ││ │├0011------------------------------││ ││ ││ ││ │├0012------------------------------││ ││ ││ ││ │├0013------------------------------││ ││ ││ ││ │├0014------------------------------││ ││ ││ ││ │├0015------------------------------││ ││ ││ ││ │├0016------------------------------││ ││ ││ ││
2003/10/05 16 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
SA00094 14.0000 2003/03/12 rectifier diode 1 PCS N 1N4002/100V 0.00 % D1,D2,D3,D4,D5,D6,D7,D9,D10,D11,D12,D13,D14,D8 SA00127 zener diode 1/2W 47V 1N5261 ZD1 RA00250 fixed resistor 1/4W 20KΩ M type R4 RA00301 fixed resistor 1/4W 390KΩ M type R1 CB00039 electrolytic capacitor 47uF/25V φ5*11mm C3,C4 CB00043 electrolytic capacitor 47uF/100V φ10*12mm C8,C9 CB00052 electrolytic capacitor 100uF/100V φ13*20mm C5,C6 CB00061 electrolytic capacitor 220uF/100V φ12*25mm C7 CB00082 electrolytic capacitor 2200uF/25V φ16*20mm C1,C2 SD00077 integrated circuit 7815(TO-220) TR1 SD00079 integrated circuit 7915(TO-220) TR2 SB00043 transistor TIP122(ST) TR3 HC00076 row-wire header 2P 2.5mm 180° CN2
PCS
1.0000 2003/03/12 N 1 0.00 %
PCS
1.0000 2003/03/12 N 1 0.00 %
PCS
1.0000 2003/03/12 N 1 0.00 %
PCS
2.0000 2003/03/12 N 1 0.00 %
PCS
2.0000 2003/03/12 N 1 0.00 %
PCS
2.0000 2003/03/12 1 N 0.00 %
PCS
1.0000 2003/03/12 N 1 0.00 %
PCS
2.0000 2003/03/12 N 1 0.00 %
PCS
1.0000 2003/03/12 N 1 0.00 %
PCS
1.0000 2003/03/12 N 1 0.00 %
PCS
1.0000 2003/03/12 N 1 0.00 %
PCS
1.0000 2003/03/12 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
PCS 2003/04/29
Loss %
Ver.
Unit
Component Remark
│├0017------------------------------││ ││ ││ ││ │├0018------------------------------││ ││ ││ ││ │├0019------------------------------│││ │││ │││ │││ ││└0001----------------------------││ ││ │├0020------------------------------│││ │││ │││ │││ ││└0001----------------------------││ ││ │├0021------------------------------││ ││ ││ ││ │└0022------------------------------│ │ │ │ ├0062--------------------------------││ ││ │├0001------------------------------││ ││ ││ ││ │├0002------------------------------││ ││ ││ ││ │├0003------------------------------│││ │││ │││ │││ ││└0001----------------------------││ ││ │├0004------------------------------│││ │││ ││├0001----------------------------│││ │││ │││ │││
HC00082 row-wire header 8P 2.5mm 180° CN3 HC00089 row-wire header 3P 3.9mm 180° CN1 HA01922 jumper wire 8mm JP1,JP6,JP7,JP10 HA02249 wire φ0.6 HA01925 jumper wire 10mm JP2,JP3,JP4,JP8,JP9 HA02249 wire φ0.6 SD00074 integrated circuit 7805(TO-220) TR4 CB00070 electrolytic capacitor 1000uF/16V φ10*16mm C10 HK03893 PC board P-313123-DIP(L-8) SC00004 quartz crystalloid 16.00MHZ LP-3.5S(HC-49US) XT1 HC00499 row pin 2.54mm 180°2*8P CN2 SG00193 integrated ciucire AT27LV010A-90JC/L-8 IC4 SG00139 integrated ciucire AT27LV010A-90JC HK04041 PC board P-313123-AI(L-8) CB00165 electrolytic capacitor 10uF/16V φ4*5mm C7
2003/10/05 17 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
PCS
1.0000 2003/03/12 1 N 0.00 %
PCS
1.0000 2003/03/12 N 1 0.00 %
PCS
4.0000 2003/03/12 1 N 0.00 %
M KG PCS
M KG PCS
PCS
PCS PCS
0.0180 2002/09/19 N 1 0.00 % 5.0000 2003/03/12 N 1 0.00 % 0.0200 2002/09/19 N 1 0.00 % 1.0000 2003/03/12 1 N 0.00 % 1.0000 2003/03/12 N 1 0.00 % 1.0000 2003/04/29 N 1 0.00 % 1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/06/24 N 1 0.00 %
PCS
1.0000 2003/05/31 1 0.00 %
PCS PCS PCS
1.0000 2003/05/30 N 1 0.00 % 1.0000 2003/06/19 1 0.00 % 1.0000 2003/06/18 N 1 0.00 %
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
││├0002----------------------------│││ │││ │││ │││ ││└0003----------------------------││ │ ││ │ ││ ├0001---------------------------││ │ ││ │ ││ ├0002---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0003---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0004---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0005---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0006---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0007---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0008---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0009---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0010---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0011---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0012---------------------------││ │ ││ │ ││ │ ││ │
CB00166 electrolytic capacitor PCS 100uF/16V φ6*5mm C19,C12,C5,C24,C21,C25,C26,C28,C2,C16 HK03894 PC board P-313123-SMD(L-8) HB00895 pc board 313123/2(1*6) CI00049 SMD ceramic capacitor 0603 15PF/50V NPO ±5% C8,C9
2003/10/05 18 / 19
PCS PCS PCS
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
10.0000 2003/06/18 1 N 0.00 % 1.0000 2003/06/18 N 1 0.00 % 1.0000 2003/04/29 1 N 0.00 % 2.0000 2003/04/29 N 1 0.00 %
CI00075 13.0000 2003/04/29 PCS N SMD ceramic capacitor 0603 1 0.1uF/50V Y5V +80,-20% 0.00 % C17,C15,C18,C6,C10,C22,C20,C13,C14,C1,C3,C4,C11 RD00061 SMD fixed resistor 1/10W 10Ω ±5% 0603 R22
PCS
1.0000 2003/04/29 1 N 0.00 %
RD00068 PCS SMD fixed resistor 1/10W 100Ω ±5% 0603 R12,R14,R7,R8,R34,R17,R13,R33
8.0000 2003/04/29 N 1 0.00 %
RD00073 SMD fixed resistor 1/10W 220Ω ±5% 0603 R3
1.0000 2003/04/29 N 1 0.00 %
PCS
RD00085 PCS SMD fixed resistor 1/10W 1.5KΩ ±5% 0603 R16,R15,R21,R20,R4,R19,R10,R18,R9,R5
10.0000 2003/04/29 N 1 0.00 %
RD00088 PCS SMD fixed resistor 1/10W 2.2KΩ ±5% 0603 R28,R27,R23,R24,R29,R30,R25,R26
8.0000 2003/04/29 N 1 0.00 %
RD00101 SMD fixed resistor 1/10W 10KΩ ±5% 0603 R32,R31,R1
PCS
3.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
2.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
RD00125 SMD fixed resistor 1/10W 1.0MΩ ±5% 0603 R2 RE00006 SMDrow resistor1/16W 100Ω*4 ±5% 8P 0603 AR1,AR2 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34) D1
SEKAKU ELECTRON INDUSTRY CO.,LTD
Multi-Level BOM Structure Listing Report No.: IEBO_P02 Prepared by JG970003[蔡忠憲] Item No. DESCRIPTION:
PF01225 L-8 L-8_ALTO_230V
Date Page No.: Version
Version
UNIT: Date:
Item No Item Descri
Loss %
PCS 2003/04/29 Ver.
Unit
Component Remark
││ ├0013---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0014---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0015---------------------------││ ││ ││ ││ ││ ││ ││ ││ ││ │└0001-------------------------││ │ ││ │ ││ ├0016---------------------------││ │ ││ │ ││ │ ││ │ ││ ├0017---------------------------││ │ ││ │ ││ │ ││ │ ││ └0018---------------------------││ ││ ││ ││ │└0005------------------------------│ │ │ │ │ ├0001-----------------------------│ │ │ │ │ └0002-----------------------------│ │ ├0063--------------------------------││ ││ │└0001------------------------------│ │ │ │ │ └0001-----------------------------│ │ ├0064--------------------------------│ │ └0065---------------------------------
SG00068 SMD integraded circuit 74HC14DT IC1 SG00138 integrated ciucrt AS4LC256K16EO-60JC IC6 SG00166 integrated circuit TY-2 ALTO(GMCODE:105022) IC3 SG00147 integrated circut CHEF DSP(GMCODE:105022) SG00037 SMD integrated circuit LD1117DT33C IC2 HC00233 IC jack (SMD) PLCC32 (D03-32T.A.4) IC4 SG00016 SMD integrated circuit UDA1345TS (Philips) IC5 NE11475 label L-8 NH00035 bond paper 0.06*1M NI00017 membrane 0.055*1M NC00080 wood washer φ3.17*φ8.2*1 NC00079 insulation φ8.2*1 NC00014 insulator 0.65M*60M*1t NI00863 insulate bean TO220B MG00020 screw M3*8
2003/10/05 19 / 19
Cardinal Effective Date Usage Rate @:Phantom Layer Attrition Rate
PCS
1.0000 2003/04/29 1 N 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 1 N 0.00 %
PCS PCS
1.0000 2003/05/10 N 1 0.00 % 1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS
1.0000 2003/04/29 N 1 0.00 %
PCS M M PCS KG KG PCS PCS
1.0000 1 0.00 1.0000 410 0.00 1.0000 410 0.00 4.0000 1 0.00 1.0000 1 0.00 68.0000 39000000 0.00 4.0000 1 0.00 4.0000 1 0.00
2003/06/23 %
2003/06/26 N %
2003/06/26 N %
2003/05/16 %
2003/02/25 N %
2002/04/04 N %
2003/06/24 %
2003/06/24 %
8. Exploded Views
Mechanical Parts List Model No. NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45
Item No MA04065 HK03838 MG00305 MG00061 MG00041 MF00061 ME00060 NI02084 NI01862 NI01863 HK03835 MG00304 MG00363 NI02083 NI02081 NI02082 NI00826 NI02386 NI02633 MI01629 TC00160 MG00102 MJ01189 NI02620 HK03893 HK03836 HC00008 MG00042 HI00171 HI00026 ME00016 MF00038 HA01174 MF00048 MB02799 HK03648 MJ01145 MF00037 MF00030 ME00015 MG00162 NI02249 NI00501 NC00022 NC00005
ALTO L-8 Item Description panel K-PC board copper pole screw screw washer socket nut knob key key K-PC board copper pole bare knob knob knob knob konb knob separating shade transformer screw partitions insulation board PC board K-PC board AC outlet screw power switch power switch colour nut washer signle terminal wiring CF:W146 washer rear board K-PCb heat sink washer washer colour nut screw caushion foot cushion insulation silicone insulator
L-8 ALTO P-L8PU2-DIP M3*24*0.5PH M3*10 M3*6 JY-6351G-02-250 JY-6351G-02-250 φ10.5*18 5.5*5.5*14.5 φ5.5*W10*7.5 P-L8MN1-DIP M3*14*0.5PH M3*14*0.5PH φ10.5*18 φ10.5*18 φ10.5*18 φ12*18 double color φ14*13mm φ10.5*18 S-12 PT-S12_230V M4*8 L-8 1*86.5*53 L-8 P-313123-DIP(L-8) P-L8PU1 3515 A TYPE(RF-2004-C-4.8) M3*10 R612KKAT0F1 RA12KKATOF 2P 4m/m φ4*φ7*1t 80 green/yellow φ4*φ8*0.5t L8 P-RD82PWR(RD82FX) RD82 φ3*φ5*1t φ3*φ8*0.8t 3m/m M3*8 TW-1(TO-220) 12.7*9*3t(SF-004) 0.3t*18*45mm S-8 TO-220 square type
pcs 1 1 1 15 37 24 24 5 4 7 1 8 3 18 12 6 8 2 3 1 1 2 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 2 2 2 4 4 4 1 1
