Service Manual Cd-g10000 Cp-g10000s

Transcript

CD-G10000/CP-G10000S SERVICE MANUAL No. S1506CDG10000 MINI COMPONENTSYSTEM MODEL CD-G10000 CD-G10000 Mini Component System consisting of CD-G10000 (main unit) and GBOXSA090AWM1 (rear speaker system). SPEAKER SYSTEM MODEL CP-G10000S CP-G10000S Speaker System consisting of CP-G10000S (front speaker system) and CP-SW10000S (active subwoofer). In the interests of user-safety the set should be restored to its original condition and only parts identical to those specified be used. CONTENTS CHAPTER 1. GENERAL DESCRIPTION [1] Specifications ................................................. 1-1 [2] Names of parts............................................... 1-2 CHAPTER 2. ADJUSTMENTS [1] Mechanism section ........................................ 2-1 [2] Tuner section ................................................. 2-1 [3] TEST MODE .................................................. 2-2 [4] CD SECTION ................................................. 2-4 [5] CD section...................................................... 2-4 [6] Standard Specification of Stereo System Error Message Display Contents ................... 2-4 [7] CD Changer mechanism section ................... 2-5 CHAPTER 5. CIRCUIT DESCRIPTION [1] Notes on schematic diagram .........................5-1 [2] Types of transistor and LED ..........................5-1 [3] Waveforms of CD circuit ................................5-2 [4] Voltage...........................................................5-3 CHAPTER 6. CIRCUIT SCHEMATICS AND PARTS LAYOUT [1] Schematic diagram........................................6-1 [2] Wiring side of PWB......................................6-13 CHAPTER 7. FLOWCHART [1] Troubleshooting .............................................7-1 CHAPTER 3. MECHANISM BLOCKS [1] Caution on disassembly ................................. 3-1 [2] Removing and reinstalling the main parts ........ 3-5 CHAPTER 8. OTHERS [1] Function table of IC .......................................8-1 [2] FL Display....................................................8-10 CHAPTER 4. DIAGRAMS [1] Block diagrams............................................... 4-1 Parts Guide (CD-G10000) Parts Guide (CP-G10000S) Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the safety and performance of the set. SHARP CORPORATION This document has been published to be used for after sales service only. The contents are subject to change without notice. CD-G10000/CP-G10000S IMPORTANT SERVICE NOTES BEFORE RETURNING THE AUDIO PRODUCT BEFORE RETURNING THE AUDIO PRODUCT (Fire & Shock Hazard) Before returning the audio product to the user, perform the following safety checks. 1. Inspect all lead dress to make certain that leads are not pinched or that hardware is not lodged between the chassis and other metal parts in the audio product. 2. Inspect all protective devices such as insulating materials, cabinet, terminal board, adjustment and compartment covers or shields, mechanical insulators etc. 3. To be sure that no shock hazard exists, check for leakage current in the following manner. * Plug the AC line cord directly into a 120 volt AC outlet. * Using two clip leads, connect a 1.5 kohm, 10 watt resistor paralleled by a 0.15 µF capacitor in series with all exposed metal cabinet parts and a known earth ground, such as conduit or electrical ground connected to earth ground. * Use a VTVM or VOM with 1000 ohm per volt, or higher, sensitivity to measure the AC voltage drop across the resistor (See diagram). * Connect the resistor connection to all exposed metal parts having a return path to the chassis (antenna, metal cabinet, screw heads, knobs and control shafts, escutcheon, etc.) and measure the AC voltage drop across the resistor. VTVM AC SCALE 1.5 kohms 10 W 0.15 mF TEST PROBE TO EXPOSED METAL PARTS All check must be repeated with the AC line cord plug connection reversed. Any reading of 0.3 volt RMS (this corresponds to 0.2 milliamp. AC.) or more is excessive and indicates a potential shock hazard which must be corrected before returning the audio product to the owner. –i– CONNECT TO KNOWN EARTH GROUND CD-G10000/CP-G10000S Service Audio E Market CD-G10000/CP-G10000S Manual 1. GENERAL DESCRIPTION CHAPTER [1] Specifications FOR A COMPLETE DESCRIPTION OF THE OPERATION OF THIS UNIT, PLEASE REFER TO THE OPERATION MANUAL. CD-G10000 CP-G10000S General Power source Power consumption Dimensions Weight Type AC 120 V, 60 Hz 175 W Maximum input power Rated input power Impedance Dimensions Width: 10-1/4" (260 mm) Height: 13" (330 mm) Depth: 12-7/8" (326 mm) 23.0 lbs. (10.4 kg) CD player Type Signal readout D/A converter Frequency response Dynamic range Weight 5-disc multi-play compact disc player Non-contact, 3-beam semiconductor laser pickup 1-bit D/A converter 20 - 20,000 Hz Type Maximum input power Rated input power Impedance Dimensions 90 dB (1 kHz) Amplifier Weight Power source Power consumption Output power Input terminals Speaker type Impedance Dimensions Weight FM: 87.5 - 108.0 MHz AM: 530 - 1,720 kHz 65 W 16 ohms Width: 7-7/8" (200 mm) Height: 16-9/16" (420 mm) Depth: 16-15/16" (430 mm) 8.8 lbs. (4.0 kg)/each AC 120 V, 60 Hz 120 W 400 watts minimum RMS into 6 ohms from 50 Hz to 120 Hz, 10% total harmonic distortion Subwoofer input (audio signal): 200mV / 10 k ohms at 70 Hz 10" (25 cm) woofer 6 ohms Width: 15-3/4" (400 mm) Height: 16-9/16" (420 mm) Depth: 20-1/16" (510 mm) 47.6 lbs. (21.6 kg) Specifications for this model are subject to change without prior notice. Cassette deck Wow and flutter Full-range speaker system 4" (10 cm) speaker 2 130 W CP-SW10000S Tuner Frequency response Signal/noise ratio 135 W 8 ohms Width: 8-11/16" (220 mm) Height: 16-9/16" (420 mm) Depth: 16-15/16" (430 mm) 12.1 lbs. (5.5 kg)/each GBOXSA090AWM1 Output power Front speakers 135 watts minimum RMS per channel into 8 ohms from 100 Hz to 20 kHz, 10% total harmonic distortion Rear speakers 65 watts minimum RMS per channel into 16 ohms from 5 kHz to 20 kHz, 10% total harmonic distortion Output terminals Front speakers: 8 ohms Rear speakers: 16 ohms Headphones: 16 - 50 ohms (recommended: 32 ohms) Subwoofer pre-out (audio signal): 200 mV/10 k ohms at 70 Hz Video out: 1 Vp-p (75 ohms) Input terminals Game/ Auxiliary (audio signal): 500 mV/ 47 k ohms Game/Video: 1 Vp-p (75 ohms) Frequency range 2-way type speaker system 2" (5 cm) tweeter 1 5-1/8" (13 cm) woofer 2 270 W 50 - 14,000 Hz (normal tape) 55 dB (TAPE 1, playback) 50 dB (TAPE 2, recording/playback) 0.3 % (WRMS) 1–1 CD-G10000/CP-G10000S [2] Names of parts CD-G10000 Front panel 1. Disc Trays 2. Timer Indicator 3. Power On/Stand-by Button 4. Disc Track Up or Fast Forward, Tape 2 Fast Forward, Tuner Preset Up, Time Up Button 5. Clock/Timer Button 6. Tuning Up Button 7. Tuning Down Button 8. Disc Track Down or Fast Reverse, Tape 2 Rewind, Tuner Preset Down, Time Down Button 9. Equalizer Mode Select Button 10. Tape 1 Cassette Compartment 11. Headphone Jack 12. Game/Video Input Jacks 13. Disc Number Select Buttons 14. Disc Direct Play Button 15. Disc Tray Open/Close Button 16. Character Button 17. Enter Button 18. Disc Play or Repeat, Tape Play Button 19. Memory/Set Button 20. Tape 2 Record Pause Button 21. MP3 Disc Navigation Mode Select Button 22. Disc or Tape Stop Button 23. Cursor Buttons 24. Extra Bass/Demo Mode Button 25. Volume Control 26. Tape 2 Cassette Compartment 27. Tuner (Band) Button 28. CD Button 29. Tape (1 2) Button 30. Game/Video Button 13 1 2 3 14 15 16 17 18 19 20 21 4 5 6 7 22 23 24 8 9 10 25 26 11 27 28 29 30 12 Display 1 1. Disc Number Indicators 2. MP3 Folder Indicator 3. MP3 Title Indicators 4. MP3 Total Indicator 5. Sleep Indicator 6. Timer Play Indicator 7. Timer Recording Indicator 8. Tape 2 Record Indicator 9. Daily Timer Indicator 10. FM Stereo Mode Indicator 11. FM Stereo Receiving Indicator 12. Memory Indicator 13. Tape Play Indicator 14. MP3 Disc Indicator 15. Extra Bass Indicator 16. Disc Repeat Play Indicator 17. Disc Pause Indicator 18. Disc Play Indicator 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 Rear panel 1. Cooling Fan 2. Subwoofer Pre-output Jack 3. AC Power Cord 4. FM 75 Ohms Antenna Terminal 5. FM Antenna Ground Terminal 6. AM Loop Antenna Jack 7. Video Output Jack 8. Front Speaker Terminals 9. Rear Speaker Terminals 4 5 6 7 1 8 2 3 1–2 9 CD-G10000/CP-G10000S CD-G10000 Remote control 1 1. Remote Control Transmitter 2. Disc Number Select Buttons 3. Clock/Timer Button 4. Character Input/Disc Direct Search Buttons 5. MP3 Disc Navigation Mode Select Button 6. Enter Button 7. Memory/Set Button 8. Tape 2 Record Pause Button 9. Disc Track Down or Fast Reverse, Tape 2 Rewind, Tuner Preset Down, Time Down Button 10. Disc or Tape Stop Button 11. CD Button 12. Tuner (Band) Button 13. Equalizer Mode Select Button 14. Extra Bass Button 15. Power On/Stand-by Button 16. Disc Random Button 17. Character Button 18. Cursor Buttons 19. Disc Clear/Dimmer Button 20. Disc Pause Button 21. Disc Track Up or Fast Forward, Tape 2 Fast Forward, Tuner Preset Up, Time Up Button 22. Disc Play or Repeat, Tape Play Button 23. Tape (1 2) Button 24. Game/Video Button 25. MP3 Disc Display Button 26. Volume Up and Down Buttons 15 2 3 4 16 5 6 17 18 7 8 9 10 11 12 13 14 19 20 21 22 23 24 25 26 CP-G10000S 3 1. Woofers 2. Tweeter 3. Bass Reflex Duct 4. Speaker Terminals 1 2 4 GBOXSA090AWM1 1. Full-range Speakers 2. Speaker Terminals 2 1 CP-SW10000S 1. Power Indicator 2. Subwoofer 3. Bass Reflex Duct 4. Power Switch 5. Volume Control 6. Crossover Frequency Control 7. Cooling Fan 8. Subwoofer Input Jack 9. AC Power Cord 1 4 5 6 2 7 3 8 9 1–3 CD-G10000/CP-G10000S Service Audio E Market CD-G10000/CP-G10000S Manual 2. ADJUSTMENTS CHAPTER • Signal generator: 1 kHz, 40 kHz dev., FM modulated [1] Mechanism section • • FM Band Coverage FM RF Specified Value Tape 1: Over 80 g Tape 2: Over 80 g Frequency Frequency Display — 87.50 MHz 98.00 MHz (10-30 dB) 98.00 MHz Instrument Setting/ Connection Adjusting Point T301 (fL): *1 1.3 V ± 0.1 V L312 *2 Torque Check Torque Meter *1. Input: Antenna Output: TP301 *2. Input: Antenna Output: Speaker terminal Specified Value Tape 1 Tape 2 30 to 80 g.cm 30 to 80 g.cm — 70 to 180 g.cm — 70 to 180 g.cm Play: TW-2111 Fast forward: TW-2231 • Test Stage Driving Force Check Torque Meter Play: TW-2111 FM RF • Signal generator: 10.7 MHz, FM modulated Test Stage IF Tape Speed Test Tape Normal speed Adjusting Point Variable Resistor in motor. MTT-111 Specified Value 3,000 ± 30 Hz Speaker FM IF Instrument Connection Speaker Terminal (Load resistance: 6 ohms) Frequency Frequency Display 98 MHz 10.7 MHz Setting/Adjusting Point T302 (Turn the core of transformer T302 fully counter clockwise) MAIN PWB TAPE MECHANISM FM BAND COVERAGE fL R381 TP301 CNP301 AM LOOP ANTENNA Tape Motor Variable Resistor in motor Figure 1 FM IF 1 FM RF L312 T303 T306 AM TRACKING fL [2] Tuner section T351 AM IF T302 IC301 SO302 FM ANTENNA TERMINAL T301 TP302 AM BAND COVERAGE fL fL: Low-range frequency fH: High-range frequency • Figure 2 Adjustment Points AM IF/RF Signal generator: 400 Hz, 30%, AM modulated Test Stage Frequency Frequency Display AM IF AM Band Coverage AM Tracking 450 kHz — 1,720 kHz 530 kHz 990 kHz 990 kHz *1. Input: Antenna *2. Input: Antenna Setting/ Adjusting Parts T351 (fL): T306 1.1 ± 0.1 V (fL): T303 Instrument Connection *1 *2 *1 Output: TP302 Output: TP301 2–1 R356 Instrument Connection *1 CD-G10000/CP-G10000S [3] TEST MODE • Setting the test mode During stand-by mode, press ON/STAND-BY button while pressing down the button and X-BASS/DEMO button. then, press the CD button to enter the test mode. C D << IL isn’t done T E S T OPEN/CLOSE operation is using manual. IL isn’t done >>,<< IL isn’t done >>buttons make pick's slide possible. A to page 2-3 <> key input. <> key input. Do TOC IL. Do normal play. When these following key is input into PLAY key, track number can be appoint directly. << 1 >> key: Track 4 << 2 >> key: Track 9 << 3 >> key: Track 15 Adjustment result automatically will display as below for each 2 sec: a) “FOF_XXXX” b) “TOF_XXXX” c) “TBAL_XX” d) “TGAN_XX” f) “FGAN_XX” g) “RFLS_XX” –––––––– <> key input. STOP explanation: a) Focus off set b)Tracking off set c)Tracking balance d)Tracking Gain f) Focus Gain g) RF level shift VOL — Last memory P.GEQ — FLAT X-BASS — OFF To cancel: Power OFF = “FOF_XXXX” = “TOF_XXXX” = “TBAL_XX” = “TGAN_XX” = “FGAN_XX” = “RFLS_XX” 2–2 CD-G10000/CP-G10000S A <> key input. Laser ON. <> key input. Tracking OFF play at that specific point. <> key input. Tracking ON play from that specific point. <> key input. Adjustment result automatically will display as below for each 2 sec: a) “FOF_XXXX” b) “TOF_XXXX” c) “TBAL_XX” d) “TGAN_XX” f) “FGAN_XX” g) “RFLS_XX” <> key input. STOP Sliding the PICKUP with<< in STOP mode. explanation: a) Focus off set b)Tracking off set c)Tracking balance d)Tracking Gain f) Focus Gain g) RF level shift VOL — Last memory P.GEQ — FLAT X-BASS — OFF To cancel: Power OFF >>, << >> button must only be = “FOF_XXXX” = “TOF_XXXX” = “TBAL_XX” = “TGAN_XX” = “FGAN_XX” = “RFLS_XX” 2–3 CD-G10000/CP-G10000S [4] CD SECTION [5] CD section • CD Error code description Adjustment Since this CD system incorporates the following automatic adjustment functions, readjustment is not needed when replacing the pickup. Therefore, different PWBs and pickups can be combined freely. Error 01 10* 11* Each time a disc is changed, these adjustments are performed automatically. Therefore, playback of each disc can be performed under optimum conditions. 20* Items adjusted automatically 21* 1) Offset adjustment (The offset voltage between the head amplifier output and the VREF reference voltage is compensated inside the IC.) * Focus offset adjustment * Tracking offset adjustment 31 * 3) Gain adjustment (The gain is compensated inside the IC so that the loop gain at the gain crossover frequency will be 0 dB.) Focus gain adjustment * Tracking gain adjustment 'CHECKING' If Error is detected, 'CHECKING' will be displayed instead of 'ERCD**'. 'ER-CD**' display will only be displayed when error had been detected for the 5th times. 2) Tracking balance adjustment * Explanation When Pickup set inner position, inner switch cannot detect 'ON' level for 10 secs. CAM error. Can't detect CAM switch when CAM is moving. When it detect cam operation error during initialize process. TRAY error. Can't detect TRAY switch when TRAY is moving. When it detect TRAY operation error during initialize process. When it change to CD function, DSP cannot read initial data. [6] Standard Specification of Stereo System Error Message Display Contents CD TUNER Error Contents Pickup Mechanism Error. CD Changer Mechanism Error. Display 'ER-CD01' 'ER-CD**' (*) CD DSP Communication Error. Focus Not Match/IL Time Over. PLL Unlock. 'ER-CD31' 'NO DISC' FM 87.5 MHz Notes PU-IN SW Detection NG. 10: CAM SW Detection NG during normal operation 11: CAM SW Detection NG during initialize process 20:TRAY SW Detection NG during normal operation 21:TRAY SW Detection NG during initialize process DSP COMMUNICATION ERROR. PLL Unlock. (*) CHECKING: BEFORE TRANSPORTING THE UNIT If CD changer mechanism error is detected, ‘CHECKING’ will be display instead of ‘ER-CD**’. ‘ER-CD**’ display will only be display when error had been detected for the 5 th times. The following process need to be taken after set tapering/parts replacement. 1. Press the ON/STAND-BY button to enter stand-by mode. Speaker abnormal detection and +B PROTECTION display 2. While pressing down the button and the X-BASS/DEMO button, press the ON/STAND-BY button. The Micro Computer version number will be displayed as “XM******”. In case speaker abnormal detection or +B PROTECTION had occurred, it can be check by pressing ‘POWER’, ‘ ’ and ‘X-BASS’ button. MicroComputer version number will displayed as “XM******”. 3. Press OPEN/CLOSE button until “WAIT”→ “FINISHED” appears. Press ‘GAME/VIDEO’ button during version number display and then press ‘POWER’, ‘MEMORY/SET’ and ‘GAME/VIDEO’ button. Display will show “S** B**”. S is referring to speaker abnormal detection and B is referring to +B PROTECTION. ** is in hex valve. 4. Unplug the AC cord and the unit is ready for transporting. +B PROTECTION is condition when irregular process occur on power supply line. 2–4 CD-G10000/CP-G10000S [7] CD Changer mechanism section • A number in the drawing sheet is the number of the parts guide (CHANGER MECHANISM PARTS). 1 141 140 HALF GEAR MUST ARRANGE AS SHOWN 2–5 CD-G10000/CP-G10000S 2 139 APPLY SANKOL BEFORE FIX FIX ITEM 1 ACCORDING TO THE SHOWN PICTURE ABOVE ROTATE MODE BIG GEAR UNTIL REACH AS SHOWN IN PICTURE 2–6 CD-G10000/CP-G10000S 3 143 APPLY GREASE 112 PULL THE LEVER UNITIL REACH THE ARROW MARK 2–7 CD-G10000/CP-G10000S 4 FIGURE 2 FIGURE 1 152 118 142 APPLY GREASE SLOT CLAMP SW ARM INSIDE BASE SLOT 2–8 CD-G10000/CP-G10000S 5 APPLY GREASE AT BOTTOM SIDE OF GEAR FOLLOW MARKING NO NEED APPLY GREASE AT BOTTOM SIDE APPLY GREASE AT TOP SIDE OF GEAR FOLLOW MARKING 127 OTHER THAN FIGURE 1 DIRECTION ALL N.G O.K 128 N.G FIGURE 1 BLACK MARK 2–9 CD-G10000/CP-G10000S 6 APPLY GREASE AT HALF GEAR AREA ROTATE CLOCKWISE UNTIL REACH HERE (MAXIMUM) 129 2 – 10 CD-G10000/CP-G10000S 7 CHANGE COLOR TO BLACK 148 151 150 2 – 11 CD-G10000/CP-G10000S 8 TRAY BIG GEAR CHANGE COLOR TO BLACK MUST FREE FROM GREASE THE SHOWN AREA O.K GREASE APPLICATION LENGTH GREASE APPLICATION PORTION N.G 124 TRAY BIG GEAR CHANGE COLOR TO BLACK 131 SHOWN HOLE MUST FACING ARROW DIRECTION 2 – 12 CD-G10000/CP-G10000S 9 APPLY GREASE AT BOTTOM SIDE ONLY 138 126 TR-RE JOINT GEAR C 125 APPLY GREASE ONLY AT TOP SIDE GEAR MUST FIX ACCORDING TO THE HOLE'S 2 – 13 CD-G10000/CP-G10000S 10 148 147 146 145 2 – 14 CD-G10000/CP-G10000S 11 121 APPLY GREASE 144 130 WHEN FIXING ITEM 2 MUST FOLLOW AS SHOWN 2 – 15 CD-G10000/CP-G10000S 12 117 FIGURE 1 FIGURE 2 APPLY GREASE FIGURE 3 2 – 16 APPLY GREASE SC141 CD-G10000/CP-G10000S 13 ITEM 2 , 3 MUST APPLY GREASE ON TOP SIDE GEAR ONLY 134 133 GEAR 112 O.K GEAR 112 N.G 132 TOP VIEW AFTER ASSY 2 – 17 FIX REVERSE N.G CD-G10000/CP-G10000S 14 APPLY GREASE BEFORE FIX MOVE 112 UNTIL TOUCH THE WALL B A DURING GEAR A ROTATE MUST PRESS SHOWN AREA AND LEVER B WILL MOVE ARROW DIRECTION THEN FIX PART 108 SCREW TORQUE 2 108 +0.5 -0 kgf-cm 803 x6 APPLY GREASE CONFIRM WHETHER FIXED PROPELY OR NOT 2 – 18 CD-G10000/CP-G10000S 15 APPLY GREASE 115 BEHIND THE LEVER NEED TO APPLY GREASE PULL IT THEN LEVER WILL MOVE IN 2 – 19 CD-G10000/CP-G10000S 16 123 115 APPLY GREASE APPLY GREASE BEFORE FIX APPLY GREASE AT BOSS SPRING MUST ARRANGE UNDER THE HOOK O.K LR JOINT LEV BOARD R BOARD R LR JOINT LEV N.G 2 – 20 CD-G10000/CP-G10000S 17 ASSY REVERSELY N.G 103 137 136 APPLY GREASE BIG SLOT MUST FACING OUT WHEN FIX & AFTER FIX TO BASE CHASSIS AFTER ASSY CONFIRM THE FREE DROP GEAR POSITION DURING FIXING 2 – 21 CD-G10000/CP-G10000S 18 ASSY REVERSELY N.G APPLY GREASE 114 135 136 BIG SLOT MUST FACING OUT WHEN FIX & AFTER FIX TO BASE CHASSIS AFTER ASSY CONFIRM THE FREE DROP GEAR POSITION DURING FIXING CONFIRM BOTH GEAR SIT PROPELY & LOCKED 2 – 22 CD-G10000/CP-G10000S 19 AFTER FIX OUTER UP/DOWN LEVER HOLD SHOWN PORTION AND MOVE UP/DOWN THEN CONFIRM LEVER GO INSIDE THE HOLE OR NOT 120 IF GO INSIDE HOLE IS O.K BIGGER SLOT FACING OUT IF NO GO INSIDE HOLE IS N.G 119 BIGGER SLOT FACING OUT 2 – 23 CD-G10000/CP-G10000S 20 BIG SLOT FACING OUT 110 2 – 24 CD-G10000/CP-G10000S 21 PUSH THE LEVER ACCORDING TO ARROW DIRECTION THEN FIX WHEN FIX MAIN BASE ASSY FOLLOW ACCORDING TO O.K PICTURE O.K MAKE SURE MECHA HOLDER SHAFT FIX PROPELY TO LEVER 2 – 25 N.G N.G CD-G10000/CP-G10000S 22 APPLY SANKOL APPLY SANKOL ON TOP 101 APPLY SANKOL INSIDE THE SLOT & OTHER SHOWN PORTION RIB 102 RIB APPLY SANKOL AT TRAY SLIDING PORTION FIX TRAY NO 1 FIRST THAN FOLLOW OTHER 2 – 26 COSMO GUIDE TRAY HAVE MARKING AS SHOWN CD-G10000/CP-G10000S 23 111 GEAR UP/DOWN BOARD APPLY GREASE AT INNER & OUTER GEAR SLIDING PORTION WHEN FIX GEAR UP/ DOWN BOARD THE TWO LEVER MUST AT PARALLEL LINE & POSITION AT TOP MAX SIDE AFTER ASSY GEAR UP/DOWN BOARD 2 – 27 CD-G10000/CP-G10000S 24 SCREW TORQUE 3 +0.5 -0 804 2 – 28 kgf-cm CD-G10000/CP-G10000S 25 AFTER ASSY TOP PLATE FIX THE FFC FFC4 AFTER PUSH MAKE SURE SNAP PROPELY PRESS IN BACK PORTION 122 AFTER FIX PUSH FOLLOW ARROW DIRECTION 107 BEFORE LOCK SLOT IN AFTER LOCK BEFORE LOCK MUST CONFIRM AFTER LOCK BEFORE LOCK AFTER LOCK MUST CONFIRM 2 – 29 CD-G10000/CP-G10000S 26 CAUTION O.K 1. MAKE SURE NO PWB CHIP INSIDE SET .( BEFORE FIX MAKE SURE PWB NO DUST , GREASE & ETC ) N.G 803 2 – 30 CD-G10000/CP-G10000S 27 THE TWO SLOT MUST FREE FROM GREASE APPLY GREASE BELOW THE MARKING FOR BOTH PORTION ASSEMBLY SEQUENCE 1. APPLY GREASE TO MAIN BASE GREASE APPLICATION AREA ALL BOSS APPLY GREASE 105 APPLY GREASE APPLY GREASE AT 3 HALF MOON APPLY GREASE 1 RIB ONLY CAUTION APPLY GREASE TRAY SLIDING AREA MUST FREE FROM GREASE APPLY GREASE AT BOTH SLOT APPLY GREASE APPLY GREASE INSIDE SLOT APPLY GREASE APPLY GREASE AT WALL 2 – 31 CD-G10000/CP-G10000S 28 MOTOR SCREWING HOLE SCREW TORQUE 1.5 13.8 + 0.2 -0 MUST HAVE GAP M1,2 12.2 +- 0.1 REFERENCE ONLY MOTOR GEAR HEIGHT FROM MAIN BASE 12.2 +- 0.1 + 0.5 -0 AFTER SCREW MOTOR,CONFIRM THE ARRANGEMENT AS IN FIGURE 2 FIGURE 2 801 APPLY GREASE 2 – 32 CD-G10000/CP-G10000S 29 3.1 + 0.1 APPLY SANKOL SHAFT X 3 DIM AFTER INSERTION MUST CONFIRM EVERYDAY SANKOL APPLICATION AREA 109-2 APPLY GREASE AT THE SLIDING PORTION 114 APPLY GREASE 116 UP / DOWN HOLDER CHANGE TO NATURE COLOR 2 – 33 CD-G10000/CP-G10000S 30 BEFORE MELT IT AFTER MELT IT ( MUST FLAT ) WHEN FITTING STABILIZER PLATE TO STABILIZER, ROTATE STABILIZER ANTI CLOCKWISE BY JIG ( BY HAND CANNOT X ) CHANGE COLOR TO NATURE BELOW 2 – 34 AFTER ASSY TO HOLDER STABILIZER NEED CLEAN WITH ALCOHOL DISC TOUCHING SURFACE CD-G10000/CP-G10000S 31 104 APPLY GREASE MUST MAKE SURE SNAP PROPELY BOTH SIDE ALL SURFACE MUST TOUCH GAP N.G O.K 2 – 35 N.G CD-G10000/CP-G10000S 32 NO GAP HAVE GAP O.K N.G 2 – 36 CD-G10000/CP-G10000S Service Audio E Market CD-G10000/CP-G10000S Manual 3. MECHANISM BLOCKS CHAPTER [1] Caution on disassembly Caution on Disassembly Follow the below-mentioned notes when disassembling the unit and reassembling it, to keep it safe and ensure excellent performance: 1. Take cassette tape and compact disc out of the unit. 2. Be sure to remove the power supply plug from the wall outlet before starting to disassemble the unit. 3. Take off nylon bands or wire holders where they need to be removed when disassembling the unit. After servicing the unit, be sure to rearrange the leads where they were before disassembling. CD-G10000 STEP REMOVAL PROCEDURE 1 Top/Side Cabinet 1. Screw .................... (A1) x11 2 Changer Unit/ Rear Panel B 1. Screw ...................... 2. Hook ........................ 3. Flat Cable ................ 4. Socket ..................... (B1) x2 (B2) x2 (B3) x1 (B4) x1 3 Rear Panel A with Fan motor/ Terminal PWB 1. Screw ...................... (C1) x6 2. Socket ..................... (C2) x1 3. Socket ..................... (C3) x1 4 Main PWB 1. Screw ...................... (D1) x2 2. Flat Cable ............... (D2) x1 3. Socket ..................... (D3) x4 4. Flat Wire .................. (D4) x1 5. Screw ...................... (D5) x4 5 6 Front Panel Main PWB Display PWB 8 9 Game Input PWB 1. Screw........................ (H1) x2 CD Servo PWB 1. Screw ...................... (J1) x2 2. Flat Cable ............... (J2) x2 3. Socket ..................... (J3) x1 4. Hook ........................ (J4) x1 Changer Mechanism Unit 1. Screw ...................... (K1) x4 2. Changer Chassis .... (K2) x1 11 CD Mechanism 1. Screw ...................... (L1) x4 Front Panel (B2)x1 Pull (B1)x2 M3x10mm Rear Panel A Fan Motor 1. Knob ........................ (G1) x1 2. Screw .................... (G2) x10 3. Hook ........................ (G3) x5 10 (B4)x1 Rear Panel B 1. Open the cassette cover. 2. Screw ....................... (F1) x6 3. Flat Cable ................ (F2) x1 7 Pull Changer Mechanism Unit 1. Screw ...................... (E1) x2 2. Flat Wire .................. (E2) x1 3. Hook ........................ (E3) x2 Tape Mechanism CD Servo (B3)x1 PWB (B2)x1 (C2)x1 (C1)x6 M3x10mm Lug Wire (C3)x1 Main PWB Terminal PWB (D1)x1 M3x10mm (D3)x2 Note 1: After removing the connector for the optical pickup from the connector, wrap the conductive aluminium foil around the front end of the connector so as to protect the optical pickup from electrostatic damage. (D2)x1 (E2)x1 (D3)x1 Front Panel (E3)x1 Top/Side Cabinet Front Panel (A1)x3 M3x10mm Rear Panel B (D5)x4 M3x6mm (D4)x1 (D3)x1 (E3)x1 Power PWB Main PWB Rear Panel A (A1)x5 M3x10mm (A1)x3 M3x10mm 3–1 (E1)x2 M3x8mm (D1)x1 M3x10mm CD-G10000/CP-G10000S (F2)x1 (K1)x4 M3x10mm Front Panel Tape Mechanism Lug Wire Open (F1)x6 M3x10mm (K2)x1 Cassette Cover Lug Wire Changer Mechanism Unit Front Panel Display PWB (G3)x5 (G2)x10 M2.6x10mm (L1)x4 M2.6x10mm (G1)x1 CD Mechanism Game Input PWB (H1)x2 M3x10mm Changer Mechanism Unit (J1)x2 M3x10mm (J3)x1 (J4)x1 (J2)x1 (J2)x1 CD Servo PWB Changer Mechanism Unit 3–2 CD-G10000/CP-G10000S CP-G10000S GBOXSA090AWM1 REMOVAL STEP PROCEDURE STEP 1 1 Woofer 1. Front Panel .............. (A1) x1 2. Screw ...................... (A2) x8 2 Tweeter 1. Screw ...................... (B1) x2 REMOVAL Woofer PROCEDURE 1. Front Panel .............. (A1) x1 2. Screw ...................... (A2) x8 (A1)x1 (A1)x1 Screwdriver Screwdriver Speaker Box Ass'y Speaker Box Ass'y Driver should be pried away from Speaker Box. Driver should be pried away from Speaker Box. Speaker Box Ass'y Speaker Box Ass'y Woofer Woofer (A2)x4 M3.5x16mm (A2)x4 M4x16mm Tweeter (B1)x2 M3x12mm (A2)x4 M3.5x16mm (A2)x4 M4x16mm Woofer Woofer 3–3 CD-G10000/CP-G10000S Speaker Box Ass'y CP-SW10000S REMOVAL STEP 1 Rear Cabinet 1. Screw ...................... (A1) x1 2. Screw .................... (A2) x13 2 Power PWB/Fan Motor 1. Screw ...................... (B1) x8 2. Screw ...................... (B2) x2 3. Socket ..................... (B3) x5 4. Screw ...................... (B4) x2 3 Transformer PWB 1. Screw ...................... (C1) x2 2. Socket ..................... (C2) x3 4 Jack PWB 5 Transformer PWB (C2)x2 1. Screw ...................... (D1) x4 2. Bracket .................... (D2) x1 3. Screw ...................... (D3) x1 4. Socket ..................... (D4) x1 1. Screw Cover ............ 2. Catching Holder ....... 3. Screw ...................... 4. Socket ..................... Front Panel (C1)x1 M3x10mm (E1) x8 (E2) x8 (E3) x8 (E4) x2 6 Subwoofer 1. Screw ...................... (F1) x8 7 Volume PWB 1. Screw ...................... (G1) x4 2. Socket ..................... (G2) x3 8 Front Panel PROCEDURE (C2)x1 (C1)x1 M3x10mm Washer (D2)x1 (D1)x4 M3x20mm Jack PWB (D4)x1 Power Switch PWB 1. Screw ...................... (H1) x2 (D3)x1 M3x8mm Front Panel Front Panel Speaker Box Ass'y (E3)x8 M4x40mm (E2)x8 (E1)x8 Speaker Box Ass'y (A1)x1 M3x10mm (F1)x8 M4x20mm Rear Cabinet (A2)x13 M4x20mm Subwoofer Front Panel Speaker Box Ass'y (H1)x2 M3x10mm (B3)x3 (E4)x1 Power Switch PWB Front Panel (G1)x4 M3x10mm (B2)x2 M4x16mm Volume PWB (B1)x4 M3x8mm (G2)x3 (E4)x1 Power PWB (B1)x4 M3x8mm (B4)x2 M3x14mm Fan Motor (B3)x2 3–4 CD-G10000/CP-G10000S [2] Removing and reinstalling the main parts 1. TAPE MECHANISM SECTION Perform steps 1 to 5 and 6 of the disassembly method to remove the tape mechanism. 1.1. How to remove the record/playback and erase heads (TAPE 2) (See Fig. 1) 1. When you remove the screws (A1) x 2 pcs., the recording/playback head and three-dimensional head of the erasing head can be removed. TAPE 2 Pinch Roller (C1)x1 Clutch Ass'y Pinch Roller Pawl Pull Figure 3 Record/Playback Head 1.4. How to remove the belt (TAPE 2) (See Fig. 4) 1. Remove the main belt (D1) x 1 pc., from the motor side. 2. Remove the FF/REW belt (D2) x 1 pc. 1.5. How to remove the belt (TAPE 1) (See Fig. 4) 1. Remove the main belt (E1) x 1 pc., from the motor side. Erase Head 2. Remove the FF/REW belt (E2) x 1 pc. (A1)x2 M2x9mm TAPE 2 FF/REW Belt (D2)x1 Tape Motor Tape Motor TAPE 1 TAPE 2 Main Belt Main Belt (E1)x1 (D1)x1 Figure 1 1.2. How to remove the playback head (TAPE 1)(See Fig. 2) 1. When you remove the screws (B1) x 2 pcs., the playback head can be removed. TAPE 1 FF/REW Belt (E2)x1 Main Belt (D1)x1 Main Belt (E1)x1 TAPE 1 Clutch Ass'y Figure 4 Playback Head 1.6. How to remove the motor (See Fig. 5) 1. Remove the screws (F1) x 2 pcs., to remove the motor. Tape Motor Clutch Ass'y (B1)x2 M2x9mm (F1)x2 M2.6x5mm Figure 2 1.3. How to remove the pinch roller (TAPE 1/2) (See Fig. 3) 1. Carefully bend the pinch roller pawl in the direction of the arrow , and remove the pinch roller (C1) x 1 pc., in the direction of the arrow . NOTE: When installing the pinch roller, pay attention to the spring mounting position. 3–5 Figure 5 CD-G10000/CP-G10000S 2. CD MECHANISM SECTION Perform steps 1, 2, 9 10 and 11 of the disassembly method to remove the CD mechanism. Reduction gear C 2.1. Remove the pickup. (See Fig. 1) 1. Remove the stop washer (A1) x 1 pc., to remove the gear (A2) x 1 pc. 2. Remove the screws (A3) x 2 pcs., to remove the shaft (A4) x 1 pc. 3. Remove the pickup. Front NOTE: After removing the connector for the optical pickup from the connector wrap the conductive aluminium foil around the front end of connector so as to protect the optical pickup from electrostatic damage. Rear Figure 3 2. In another case, if CD mechanism is at tray No.1 play position and to remove CD located in tray No.3, the procedure is as follows: (A3)x2 M2.6x6mm If the gear up down board is located at tray No.1 position, then rotate gear clock-wise until it at stock position. Rotate reduction gear D clockwise (Figure 4) to move the CD mechanism to tray No.3 position.This is confirmed by checking the gear up down board position by the marking as indicated on the main chassis as shown in Figure 5. CD Mechanism Reduction gear D Shaft (A4)x1 Gear (A2)x1 Stop Washer (A1)x1 Up Pickup Unit Figure 1 Down Figure 4 3. CHANGER MECHANISM SECTION Perform steps 1, 2, 9 and 10 of the disassembly method to remove the CD changer mechanism. 3.1. How to remove CD Disc (See Fig. 2~5) 1. When CD is at play position (Figure 2), rotate reduction gear C clock-wise as shown in Figure 3 Until disc tray is at stock position, then rotate further to eject the disc tray so that CD can be removed from the tray. Gear up down board CD Disc Disc Tray Guide Tray Mark 1 Mark 3 Mark 5 (DISC 3) (DISC 1) (DISC 5) Mark 2 Mark 4 (DISC 2) (DISC 4) Figure 5 CD At play position. CD Disc CD At stalk position. Figure 2 3–6 CD-G10000/CP-G10000S 3.2. How to Remove the tray motor/main cam motor/5Changer Motor PWB (See Fig. 6) 1. Remove the screws (A1)x 2 pcs., to remove tray motor/main cam motor/5-Changer Motor PWB. Changer Mechanism Unit Main Cam Motor Tray Motor 5-Changer Motor PWB (A1)x2 M2x10mm Figure 6 NOTE: There are 2 more screws tighten the motors at the bottom of main chassis. Before performing procedure 1 above, disc stop spring, top plate gear up down board and trays must be removed, then only the 2 screws can be untighten. 3–7 CD-G10000/CP-G10000S —— MEMO —— 3–8 CD-G10000/CP-G10000S Service Audio E Market CD-G10000/CP-G10000S Manual 4. DIAGRAMS CHAPTER [1] Block diagrams CD-G10000 TRAY_SW2 PHOTO D_GND +5V(+B9) SUB CE NC 8 7 6 5 4 3 2 1 59 69 41 LVDD MO_B-/CONT2 35 45 RVDD MO_B+/CONT3 36 42 LCHO M0_SPEED/CONT6 70 44 RCHO 47 C2F/SBCK CE CL DI DO 51 53 F16MOUT ZD1 *WRG DRF *RES 68 67 66 65 64 63 62 DATA TRAY_SW1 9 F16MIN CLAMP CNP5 16 15 14 13 12 11 10 DISC CE 8 DI +5V 7 DO +8V 6 DRF D_GND 5 WRQ +5V 4 CD_RES DGND 3 +B7 L-CH 2 +B4 AGND 1 +B8 R-CH CNP2 CL TO DISPLAY SECTION TO MAIN SECTION MOT_A+/CONT5 74 IC1 LC78648E CD SERVO XOUT MOT_A-/CONT4 75 XL1 48 16.9344 MHz XIN 20 LDS TDO 22 19 LDD SLDO 23 FDO 21 SPDO 24 32 61 DIN BIN CIN AIN 9 8 7 EIN 15 14 10 40 28 25 +3.3V 49 80 60 27 26 1 FIN AVDD1 AVDD2 DVDD DVDD VVDD PU-IN/CONT1 34 XVDD 79 Q2 +3.3V Q1 5 4 3 2 1 PHOTO DISC CLAMP TRAY_SW1 TRAY_SW2 D_GND 11 10 9 8 7 6 5 4 3 2 1 GND PICKUP UNIT Figure 4-1 BLOCK DIAGRAM (1/6) 4–1 TRACKING COIL FOCUS COIL TRAY SW2 SW3 SW2 TRAY SW1 M M1 TRAY MOTOR SW4 RX1 DISC M2 MAIN CAM MOTOR - PHOTO INTERRUPTER CAMM + + - LASER DRIVER SW1 CLAMP 6 CAM+ 7 +5V CNP6A 8 TR+ 11 10 9 TR- CNP6 NSW1 PICKUPIN 1 1 6 VCC 22 VCC 29 D0EM ADBCK ADDATA LRSY 6 8 10 12 14 DRASB 16 +3.3V +5V 2 33 MDATA8 DWEB 15 1 VCC 2 3 30 MDATA7 MDATA7 10 44 3 4 MDATA4 7 39 IC6 SI3033LUS VOLTAGE REGULATOR 5 ADLRCK 23 23 MDATA0 7 CKOUT MDATA3 5 80 79 9 CKIN(16M) C2FIN MDATA0 2 DATAIN IC4 LV16256-35T D-RAM DATACK CD-G10000/CP-G10000S 40 MDATA15 ADRS0 18 41 RASB ADRS3 21 42 WEB ADRS4 24 IC3 LC78683E MP3 DECODER 50 ADRSB ADRS8 28 20 22 32 52 62 53 ADRS7 69 MDATA8 35 76 DVDD1 DVDD2 DVDD3 DVDD4 DVDD5 DVDD6 CASUB MDATA11 38 43 44 45 68 61 51 31 21 11 77 73 66 +3.3V FSYNC MP3 DO 14 12 30 INTB 29 VDD 15 SYS-CE 24 VDD MO_B+ 43 17 21 AVDD 23 22 MO_B- 20 19 MOT_A- VIN2 28 PVCC2 VIN1 VIN3 VIN4 17 15 11 13 MOT_A+ +5V Q3 Q4 Q5 16 SYS-CL 27 SVCC 9 PVCC1 VO4+ VO4- VO1+ VO1- VO2+ VO2- 1 35 36 5 3 4 2 6 18 SYS-DO 34 19 SYS-DI 32 25 RESET IC2 LA6261 FOCUS/TRACKING/ SPIN/SLED DRIVER M- NM1 SPINDLE MOTOR M- CE 10 X1 X2 27 26 XL2 4.19 MHz + NM2 SLED MOTOR IC5 IXA006AW MICROCOMPUTER 31 + NSW1 PICKUPIN VO3+ VO3- 10 REGOUT 33 Figure 4-2 BLOCK DIAGRAM (2/6) 4–2 CL 11 28 44 37 24 23 9 1 INTB MDATA15 43 OEB MDATA12 40 CASLB 31 DCASLB 60 ADRS0 CMDOUT FSYNC 30 DCASUB 75 CD-G10000/CP-G10000S +B4 IC301 TA7358AP FM FRONT END CF303 AM LOOP ANTENNA Q707 Q708 Q714~ Q717 SOLENOID DRIVER 20 FM+B TAPE MECHANISM ASS'Y 11 FM/AM 7 VCO 16 12 3 4 5 6 9 10 17 21 +B4 SWITCHING +B4 1 2 3 JK690 GAME INPUT L AUX R 23 L 9 R 16 TAPE L 10 R 15 L 11 TUNER R 14 CD L 12 R 13 VIDEO 1 3 4 DI 1 CE 2 CLK 24 IC601 LC75341 AUDIO PROCESSOR 7 18 TAPE 1 L-CH P.B. HEAD R-CH SWITCHING Q101~ Q104 L(T1) 1 R(T1) 24 L(T2) 2 R(T2) 23 POP REDUCE 6 L REC 9 R REC 16 11 12 15 T1/T2 REC +B4 13 P.B NOR/ HIGH T1/T2 10 ALC REC/PLAY IC101 AN7345K PLAYBACK AND RECORD/ PLAYBACK AMP. T1/T2 BIAS JOG701 VOLUME Q113 SWITCHING Q111 L103 BIAS OSC Q603 Q604 7 L REC 18 R 19 Q112 -20dB ATT Q601 Q602 3 Q107 Q108 MUTING 4 L PB 21 R H/N 21 R 4 L SWITCHING Q105 Q114 Q106 SWITCHING +B4 ERASE HEAD 14 15 Q360 FM CNS601 BI601 REC. P.B. TAPE 2 L-CH REC./P.B. R-CH HEAD AC BIAS 22 15 16 OSC +B4 JK691 VIDEO OUT CNP2 FROM CD SECTION 1 18 L R +B4 Q109 SWITCHING LED DRIVER Q110 +B4 BIAS Q710 LED703 Figure 4-3 BLOCK DIAGRAM (3/6) 4–3 30 58 48 IC701 IXA054AW SYSTEM MICROCOMPUTER (2/2) SYSTEM +B7 IC302 LC72131 PLL(TUNER) 17 13 8 IC303 LA1832S FM IF DET./ FM MPX./ AM IF X352 4.5 MHz VT +B7 7 AM BAND T306 COVERAGE T303 MOTOR DRIVER Q706 Q711 Q712 AM OSC IN Q302 AM TRACKING CNP301 21 AM RF IN AM OSC OUT 24 23 OSC BUFF 1 2 4 5 9 FM/AM MO/ST 1 2 T301 FM OSC X351 456 kHz CF351 FM MPXIN DET FM RF L312 450 kHz CF352 T351 AM IF 8 AM IF 7 AM MIX 5 FM/AM GND OUT FM+B 9 3 4 STEREO 1 BF301 B.P.F FM OSC SO302 FM ANTENNA TERMINAL 10.7 MHz FM IF T302 6 CE DI CLK DO FM ANTENNA ZD351 5.1V MO/ST CD-G10000 CD-G10000/CP-G10000S FL701 FL DISPLAY 1 2 50 51 27 ~ 47 8 ~ 26 4 5 TAPE MECHANISM ASS'Y +B5 VDD ~ 39 78 79 VLOAD ~ IC701 IXA054AW SYSTEM MICROCOMPUTER (1/2) +B5 KEY SW701-SW707 SW712-SW723 SW725-SW735 31 53 10 11 12 16 21 24 20 17 18 19 CE CLK DI DO VDD VDD 1 2 3 4 5 6 7 56 15 41 ~ 99 100 RESET ~ 97 +B5 AVDD 34 33 ~ 80 RX701 REMOTE 3 SENSOR 1 2 59 40 25 13 27 28 26 47 46 38 58 +B5 XL701 4.19 MHz +B5 SO904 SURROUND SPEAKER TERMINAL TO CD SECTION +B8 RESET Q709 +B5 FAN MOTOR DRIVER SP DET. M901 FAN M MOTOR Q906 D905~D907 SYSTEM MUTE 603 604 IC901 STK41244 POWER AMP. L 18 R 14 7 6 5 2 SO901 SPEAKER TERMINAL Q901~ Q904 SP RELAY Q905 ON-OFF RL914 11 L-OUT 8 R-OUT 1 Y JK904 SUBWOOFER PRE-OUT +B7 JK701 HEADPHONES PT801 MAIN POWER TRANSFORMER D801 +B1 -B1 F802 5A/125V -B2 D802 +B2 IC851 AN80T53 MULTI REGULATOR VF2 -VF BIAS VF1 /T2 LD+8V +B3 +B7 +B4 M+13V A+10V A_+5V +B9 SW5V +B6 F801 5A/125V 7 2 6 1 +5V F804 2A/125V D803, D804 3 D+5V +B8 F805 6A/125V RL841 F803 2A/125V AC_RLY R T.F. D863 RELAY DRIVER Q841 D842~ D845 UNSW_5.6V +B5 IC854 1 AN78L05 VOLTAGE REGULATOR 3 PT841 SUB POWER TRANSFORMER Figure 4-4 BLOCK DIAGRAM (4/6) 4–4 AC POWER SUPPLY CORD AC 120 V, 60 Hz Q801 VOLTAGE REGULATOR CD-G10000/CP-G10000S CP-SW10000S 11 8 VH+ 14 VL+ 15 VL- 17 VH- + - 18 GND + - 7 6 5 2 1 IC901 STK41244 POWER AMP. L902 D903 Q903 Q904 Q902 D902 D901 Q901 L901 D910 VH- VR502 VOLUME Q908 VH+ Q909 Q501 IC502 KIA4558P OPE AMP. 1 VH- 7 4 8 2 3 D801 VH+ 5 VL- +12V VL+ VR501 CROSSOVER FREQUENCY IC501 KIA4558P OPE AMP. 1 D802 7 8 IC801 KIA7812AP VOLTAGE REGULATOR 4 2 3 5 3 1 2 LED502 LED501 SO501 SUBWOOFER INPUT Figure 4-5 BLOCK DIAGRAM (5/6) 4–5 D912 D911 VL- VL+ Q907 L D803~D806 CD-G10000/CP-G10000S M401 FAN MOTOR + M - D908 L902 RL901 L L1_OUT R D906 R1_OUT Q905 Q906 D912 Q908 Q401 D911 CNS901 D910 Q402 L CNP901 L901 1 1 2 2 3 3 4 4 D907 D909 Q909 SP1 SUBWOOFER D801 SW802 POWER F805 6.3A/125V D802 F801 6.3A/125V F804 6.3A/125V F806 500mA/125V 6 1 2 1 2 AC POWER SUPPLY CORD 120 V, 60 Hz T.F. PT801 POWER TRANSFORMER Figure 4-6 BLOCK DIAGRAM (6/6) 4–6 CD-G10000/CP-G10000S Service Audio E Market CD-G10000/CP-G10000S Manual 5. CIRCUIT DESCRIPTION CHAPTER • The indicated voltage in each section is the one measured by Digital Multimeter between such a section and the chassis with no signal given. [1] Notes on schematic diagram • • • 1. In the tuner section, indicates AM indicates FM stereo Resistor: To differentiate the units of resistors, such symbol as K and M are used: the symbol K means 1000 ohm and the symbol M means 1000 kohm and the resistor without any symbol is ohm-type resistor. Besides, the one with “Fusible” is a fuse type. 2. In the main section, a tape is being played back. 3. In the deck section, a tape is being played back. ( ) indicates the record state. Capacitor: To indicate the unit of capacitor, a symbol P is used: this symbol P means pico-farad and the unit of the capacitor without such a symbol is microfarad. As to electrolytic capacitor, the expression “capacitance/withstand voltage” is used. (CH), (TH), (RH), (UJ): Temperature compensation (ML): Mylar type (P.P.): Polypropylene type 4. In the power section, a tape is being played back. 5. In the CD section, the CD is stopped. • Parts marked with “ “( ) are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the safety and performance of the set. Schematic diagram and Wiring Side of P.W.Board for this model are subject to change for improvement without prior notice. REF. NO JOG701 NSW1 SW1 SW2 SW3 SW4 SW701 SW702 SW703 SW704 SW705 SW706 SW707 SW712 SW713 SW714 SW715 SW716 DESCRIPTION REF. NO SW717 SW718 SW719 SW720 SW721 SW722 SW723 SW725 SW726 SW727 SW728 SW729 SW730 SW731 SW732 SW733 SW734 SW735 POSITION ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF VOLUME PICKUP IN CLAMP TRAY SW1 TRAY SW2 DISC POWER ON/STAND-BY CLOCK/TIMER TUNING UP TUNING DOWN FAST REWIND/PRESET DOWN EQUALIZER FAST FORWARD/PRESET UP TUNER (BAND) CD TAPE GAME/VIDEO X-BASS/DEMO DESCRIPTION LEFT UP CHARACTER RIGHT ENTER DOWN MP3 NAVIGATION PLAY/REPEAT STOP REC/PAUSE MEMORY/SET OPEN/CLOSE DIRECT PLAY DISC2 DISC4 DISC5 DISC3 DISC1 POSITION ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF ON—OFF [2] Types of transistor and LED FRONT VIEW TOP VIEW B (2) TOP VIEW C (3) FRONT VIEW E (1) E C B (S)(G)(D) (1)(2)(3) KRC102 M KRC104 M KTA1266 GR KTA1271 Y KTA1273 Y KTA1274 Y KTC3194 Y KTC3199 GR KTC3200 GR KTC3203 Y KTC3205 Y AC 2SD601 AR KRA107 S KRC102 S KRC104 S KTA1504 Y KTC2875 B KTC3875 GR KDS184 5–1 FRONT VIEW AC D10XB60F 304VT2H3 A50ABC2L SDPB50CD CD-G10000/CP-G10000S [3] Waveforms of CD circuit Stopped CH1=500 mV DC 10:1 CH3=500 mV DC 10:1 T 1 IC1 21 Stopped CH1=200 mV DC 10:1 500 ms/div (500 ms/div) NORM:20 kS/s T 1999/04/07 09:51:15 500 ms/div (500 ms/div) NORM:20 kS/s CH2=500 mV DC 10:1 FDO 1 T FDO 1 IC1 21 2 6 IC1 24 1 TDO 2 IC1 22 3 SPDO CH1 v/DIV 500 mV =Filter= Smoothing : ON BW : FULL =Offset= CH1 : 0.000 V CH2 : 0.0 V CH3 : 0.000 V CH4 : 0.00 V Stopped CH1=500 mV DC 10:1 1 IC1 21 3 IC1 68 CH2=10 V DC 10:1 =Record Length= Main : 100 K Zoom : 2K CH3=1 V DC 10:1 =Filter= Smoothing : ON BW : FULL =Trigger= Mode : AUTO Type : EDGE CH1 Delay : 0.0 ns Hold off : 0.2 µs Stopped CH1=500 mV DC 10:1 500 ms/div (500 ms/div) NORM:20 kS/s T 2 IC1 76 CH3=1 V DC 10:1 =Trigger= Mode : NORMAL Type : EDGE CH2 Delay : 2.924 ms Hold off : 0.2 µs 1999/04/05 17:33:17 CH4=1 V 500 ms/div (500 ms/div) DC 10:1 NORM:20 kS/s 3 4 DRF PD02 IC1 77 T TE IC1 17 =Record Length= Main : 100 K Zoom : 2K PD01 7 FDO 1 8 4 =Offset= CH1 : 0.000 V CH2 : 0.000 V CH3 : 0.00 V CH4 : 0.00 V 3 CH Position To -3 div -1 div 0 div =Filter= =Offset= Smoothing : ON CH1 : 0.000 V BW : FULL CH2 : 0.0 V CH3 : 0.00 V CH4 : 0.00 V 1 CH2 Position 0.20 div +1 div +3 div =Record Length= Main : 100 K Zoom : 2K IC1 21 FDO 1 CH1 v/DIV 500 mV =Trigger= Mode : AUTO Type : EDGE CH1 Delay : 0.0 ns Hold off : 0.2 µs =Filter= Smoothing : ON BW : FULL Stopped CH1=2 V DC 10:1 =Offset= CH1 : 0.000 V CH2 : 0.0 V CH3 : 0.00 V CH4 : 0.00 V =Record Length= Main : 100 K Zoom : 2K T =Trigger= Mode : AUTO Type : EDGE CH2 Delay : 0.0 ns Hold off : 0.2 µs 1999/04/07 09:25:28 500 ns/div (500 ns/div) NORM:200 MS/s T 5 9 IC1 4 IC1 39 DOUT =Filter= Smoothing : ON BW : FULL Vp-p=1.0 V~1.3 V 0.5 mV/div,0.5 µsec/div Stopped CH1=10 V DC 10:1 1 T CH2=1 V DC 10:1 Stopped CH1=2 V DC 10:1 100 ms/div (100 ms/div) NORM:100 kS/s 10 =Offset= CH1 : 0.00 V CH2 : 0.00 V CH3 : 0.00 V CH4 : 0.00 V =Record Length= Main : 1K Zoom : 100 T CH2=2 V DC 10:1 CH3=2 V DC 10:1 =Trigger= Mode : NORMAL Type : EDGE CH1 Delay : 2.887 ms Hold off : 0.2 µs 1999/04/05 20:50:17 5 µs/div (5 µs/div) NORM:100 kS/s IC1 57 TE 4 IC1 17 1 2 LRSY 11 IC1 58 2 DATACK 3 IC1 68 T 1 DRF 12 IC1 59 T 3 DATA =Filter= Smoothing : ON BW : FULL =Offset= CH1 : 0.0 V CH2 : 0.00 V CH3 : 0.00 V CH4 : 0.00 V =Record Length= Main : 100 K Zoom : 2K =Trigger= Mode : NORMAL Type : EDGE CH1 Delay : 2.924 ms Hold off : 0.2 µs =Filter= Smoothing : ON BW : FULL 5–2 CH3 v/DIV 2V =Offset= CH1 : 0.00 V CH2 : 0.00 V CH3 : 0.00 V CH4 : 0.00 V =Record Length= Main : 5K Zoom : 100 =Trigger= Mode : AUTO Type : EDGE CH3 Delay : 0.0 ns Hold off : 0.2 µs CD-G10000/CP-G10000S [4] Voltage CD-G10000 VOLTAGE 3.20 V 1.61V 1.61 V 1.60 V 1.61 V 3.08 V 1.65 V 1.65 V 1.65 V 1.65 V 1.48 V 0V 1.65 V 0V 1.65 V 1.47 V 1.48 V 0V 0V 0V 1.60 V 0V 1.61 V 1.61 V 0V 0V 3.20 V 0V 3.20 V 0V 0V 1.59 V 1.60 V 3.20 V 0V 0V 0V 0V 0V 0V 3.61 V 0V 0V 1.80 V 3.60 V 0V 1.45 V 1.49 V 3.19 V 3.79 V 0V 0V 0V 0V 0V 0V 0V 0V 0V 3.20 V 0V 0V 0.53 V 0V 5.16 V 5.18 V 4.68 V 0V 0V 0V 0V 0V 0V 4.86 V 4.86 V 3.01 V 0V 1.12 V 0V 3.20 V IC301 IC2 IC1 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 VOLTAGE 2.10 V 2.20 V 2.10 V 2.20 V 2.10 V 2.20 V 0V 4.37 V 5.02 V 3.20 V 1.62 V 1.65 V 1.62 V 1.65 V 1.62 V 0V 1.62 V 1.64 V 4.71 V 4.71 V 3.92 V 3.11 V 3.10 V 2.50 V 1.65 V 0V 5.02 V 8.68 V 5.02 V 0.59 V 0.71 V 0V 0V 0V 2.11 V 2.20 V IC101 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 VOLTAGE 0V 0V 0.57 V 2.03 V 0.44 V 0V 0V 0.58 V 3.45 V 3.35 V 0V 0V 6.97 V 4.16 V 0V 3.42 V 0.57 V 0V 0V 0.41 V 2.03 V 0.57 V 0V 0V PIN NO. 1 2 3 4 5 6 7 8 9 VOLTAGE 0V 0V 0.29 V 0.20 V 0V 0.29 V 0.26 V 0.29 V 0.29 V IC302 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 VOLTAGE 2.57 V 0V 0V 0V 0V 5.22 V 10.18 V 4.76 V 0V 0V 5.23 V 0V 5.23 V 0V 0V 2.59 V 5.24 V 0V 0V 10.18 V 0V 2.57 V IC303 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 VOLTAGE 1.97 V 5.15 V 1.97 V 1.96 V 0V 0V 5.21 V 3.59 V 5.15 V 0V 2.01 V 1.25 V 2.27 V 1.13 V 1.10 V 1.96 V 0V 1.29 V 2.08 V 1.29 V 1.95 V 1.95 V 5.15 V 3.65 V IC851 PIN NO. 1 2 3 4 5 6 7 VOLTAGE 5.22 V 13.11 V 20.66 V 0V 19.72 V 10.22 V 8.67 V IC601 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 VOLTAGE 0V 0V 0V 5.10 V 5.10 V 5.10 V 5.10 V 5.11 V 5.10 V 5.10 V 5.10 V 5.10 V 5.10 V 5.10 V 5.10 V 5.10 V 5.10V 5.10 V 5.10 V 5.10 V 5.10 V 5.10 V 10.20 V 0V IC901 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 VOLTAGE 52.80 V 21.60 V 9.60 V -9.70 V -21.60V -48.80 V 0V -19.70 V -22.90 V -22.10 V -18.60 V -51.30 V 51.40V -0.14 V -0.13 V -50.04 V -0.14 V -0.14 V IC701 PIN NO. 51 4.74 V 52 4.65 V 53 0V 54 4.70 V 55 4.72V 56 4.72 V 57 0V 58 0V 59 0V 60 4.83 V 61 2.27 V 62 1.99 V 63 0V 64 4.73 V 65 0V 66 4.74 V 67 0V 68 0V 69 5.22 V 70 0V 71 0V 72 4.68 V 73 0V 74 0V 75 0V 76 5.20 V 77 0V 78 5.01 V 79 5.01 V 80 2.64 V 81 5.01 V 82 5.01 V 83 0V 84 0V 85 5.01 V 86 1.67 V 87 5.20 V 88 5.01 V 89 4.87 V 90 0V 91 2.02 V 92 0V 93 13.10 V 94 0V 95 0V 96 4.74 V 97 0V 98 4.61 V 99 0V 100 0V VOLTAGE VOLTAGE 0V 0V 0V 0V 5.17 V 5.17 V -29.70 V 0V -0.26 V -0.24 V -0.22 V -0.20 V -0.19 V -0.19 V -0.18 V -0.17 V -0.16 V 0V -29.90 V -29.90 V -29.90 V -29.90 V -29.90 V -19.76 V -27.40 V -24.87 V -22.29 V -22.30 V -30.13 V -27.43 V -14.50 V -27.20 V -19.30 V -6.08 V -21.85 V -27.22 V -21.89 V -17.00 V -27.38 V -27.10 V -27.07 V -27.00 V -27.00 V -27.35 V -26.27 V -27.11 V -27.00 V -27.07 V -27.07 V -26.83 V CP-G10000S IC901 PIN NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 VOLTAGE 68.0 V 30.5 V 18.5 V -18.5 V -30.5V -68.0 V 0V 13.6 mV 17.8 mV 18.3 mV 14.6 mV -66.5 V 66.5 V -151.0 mV -153.7 mV -65.5 V -155.5 mV -152.5 mV IC501 PIN NO. 1 2 3 4 5 6 7 8 VOLTAGE 0V 0V 0V 5.0 V 6.5 mV 6.5 mV 162.5 mV 5.0 V 5–3 Q903 IC502 PIN NO. 1 2 3 4 5 6 7 8 VOLTAGE 6.5 mV 6.5 mV 7.5 mV 4.0 V 7.5 mV 7.5 mV 7.5 mV 4.0 V IC801 PIN NO. 1 2 3 19.5 V 0.5 mV 12.0 V Q902 PIN NO. E C B VOLTAGE 17.7 mV 6.3 V 17.7 mV 11.4 mV 6.3 V 1.5 mV Q401 PIN NO. E C B VOLTAGE 1.5 mV 6.3 V 11.4 mV VOLTAGE 2.2 mV 0.8 V 0.7 V Q906 PIN NO. E C B VOLTAGE 0.7 V 0.8 V 1.5 V VOLTAGE 5.5 V 12.0 V 16.2 mV Q402 PIN NO. E C B Q905 PIN NO. E C B VOLTAGE 18.2 mV 6.3 V 18.2 mV VOLTAGE Q904 PIN NO. E C B VOLTAGE Q901 PIN NO. E C B PIN NO. E C B VOLTAGE 0.7 mV 6.0 V 0.7 mV Q403 PIN NO. E C B VOLTAGE 5.5 V 187.5 mV 3.7 V CD-G10000/CP-G10000S —MEMO— 5–4 CD-G10000/CP-G10000S Service Audio E Market CD-G10000/CP-G10000S Manual 6. CIRCUIT SCHEMATICS AND PARTS LAYOUT CHAPTER [1] Schematic diagram CD-G10000 A +B BI601 R601 1K 3 L-CH 4 CD_GND 5 A +10V 6 CD_GND 6 7 +8V 8 7 CD+5V 8 9 3 R602 1K 4 +B +B JP601 0 A_GND 14 R-CH 3 R618 330 CD_D_GND 17 CD_A_GND 18 R615 15K 15K R614 2 1 C615 4.7/50 C617 1/50 C619 1/50 C621 1/50 2.2K Q602 KTC2875 B 3 2 RTRE RIN RSEL0 8 LSEL0 9 L4 DECK C608 0.22 20 R1 CD R606 4.7K C612 0.0027 C606 0.18 19 C614 1/50 C616 4.7/50 C618 1/50 C620 1/50 C622 1/50 18 17 16 15 R2 TUNER L1 12 R603 1K C610 R604 1/50 10K 21 R3 L2 11 R4 AUX L3 10 1 3 RBASS 5 C605 LTRE 0.18 6 C613 1/50 LIN 7 C611 0.0027 R610 R616 2.2K LBASS Q608 KRA107 M 1 JP662 0 R612 390 R619 330 L-CH Q604 KTC3875 GR +B CD_GND 20 R611 2.2K Q607 KRA107 S 11 C607 0.22 C602 0.022 C603 220/10 22 ROUT 4 LOUT + - 6 - 5 1 - D~H TO POWER SECTION VCD_A+10V +B VDD 23 VREF -+ + - CCB INTERFACE 3 VSS R607 4.7K C601 220/16 CLK 24 + - +B A_5V R617 2.2K R613 390 Q601 KTC2875 B 1 DI 2 CE C609 1/50 R605 10K +- LD+8V 8 C Q603 KTC3875 GR Q603, Q604: SYSTEM MUTE 12 IC601 C653 LC75341 220P AUDIO PROCESSOR + - +B C651 220P +B 5 C652 220P B A_GND + - P6-10 11-F TO CD SERVO PWB CNP6 2 1 + - CNS601 R-CH 1 14 13 C623 1/50 R6 8.2 C624 1/50 820K C626 0.0022 R608 R609 820 C625 0.0022 22K R621 C639 1/50 22K D R620 C640 22/50 JP802 0 FM SIGNAL PLAYBACK SIGNAL RECORD SIGNAL R149 150 0V R111 3 Figure 6-1 SCHEMATIC DIAGRAM (1/12) 6–1 5 R142 82(1/2W 0.022 C135 ALC Nor/CrO2 RIPPLE ALC Vcc C131 47/25 R129 5.6K 15K 4 Q109 KTA15 SWITC 0 R144 22K C115 560P • NOTES ON SCHEMATIC DIAGRAM can be found on page 5-1. 2 0V 0V H 1 12 11.6V 220/10 C133 C134 R132 100 0.0033 R134 C132 47/25 10K 22/25 C130 C128 0.022 1.5K R150 68K C120 0.0022 R123 4.7K R115 56 Q101 KTC3200 GR SWITCHING 11 C125 22/50 C138 0.0082 C139 0.039(ML) 3.9K 10 +B R158 220 R143 47K R119 9 13 C137 0.047(ML) 0V IC101 PLAYBACK R117 100K AND RECORD/ C113 0.039 PLAYBACK C111 AMP. 47/25 8 7 R135 10K R103 2.2K 6 0.0033 100 R107 47K 0.7V 0V 5 C109 330P R113 1K 0V 0V IC101 AN7345K 4 0.022 R133 R105 3.3K 3 15 14 16 + 56K Hich=CHROME 56K + - C129 0.7V 2 17 C127 0V 0V 1 0.7V 10K Q107 KTC3875 GR 0V MUTING C126 22/50 18 C123 270P C103 180P R128 5.6K 19 20 21 3.3/50 47K R108 SWITCHING Q103 KTC3200 GR 22 4.7K G T2_L2 C110 330P 23 +- 112K Hich=T1 112K + L C107 330P T2_L1 CNP102 RECORD/ PLAYBACK HEAD 0V 24 C117 47/25 7 TAPE2 T2_R1 R106 3.3K Q104 KTC3200 GR SWITCHING R C108 330P R121 18K 6 0V 0V C105 0.0015 5 0.7V R114 1K 0V 0.0015 ERASE T2_R2 A_GND 3 4 0V SWITCHING Q106 KTC3875 GR R124 4.7K R139 0.7V 0V R120 3.9K C106 2 C104 180P(CH) R104 2.2K 0.7V 4.7K 1 M_GND 1K Q102 KTC3200 GR Q105 KTC3875 GR SWITCHING L-CH R-CH 1 2 3 4 5 6 7 R101 SWITCHING C101 560P C116 C118 560P 47/25 R127 T1_L 0V ERASE HEAD C112 47/25 C114 0.039 R118 100K A_GND CNP101 R110 2 3 R122 18K R116 56 1K R109 4.7K R-CH L-CH F 1 3 2 1 R126 C150 4.7K 47/50 C124 270P R R138 10K R130 3.4V Q114 KRC104 S SWITCHING R112 15K R102 C102 560P T1_R R137 220K 3 0V L TAPE 1 PLAYBACK HEAD REC_L REC_R 2 Q112 KTA1504 Y SWITCHING R136 220K 3 1 1 0V C121 0.022 9.3V 3.4V 2 R131 1.5K 8.6V MUTING Q108 R147 10K R148 4.7K KTC3875 GR R146 10K 9.3V C143 E SWITCHING Q113 KRC104 S C119 0.0022 VIDEO SIGNAL AUX SIGNAL + C141 100/16 +B CD SIGNAL 6 CD-G10000/CP-G10000S GAME INPUT PWB-B2 JK691 VIDEO OUT D691 DS1SS133 P6-6 11-B TO POWER PWB CNP901 C693 0.01 C602 0.022 +B JK692 HEADPHONES D690 DS1SS133 C601 220/16 WTM901 1 M_+13V SP_RLY R-CH GND L-CH 5 FW901 +B CNS603 R603 1K CNP603 5 4 1 3 2 3 4 3 4 1 5 5 VIDEO IN 1 R693 33K 2 R691 6.8K R690 6.8K AUX/VIDEO 6 C610 R604 1/50 10K C695 0.001 JK690 GAME INPUT C694 0.001 C696 0.01 C608 0.22 R-CH R692 33K BI603 +B C603 220/10 L-CH C691 390P C690 390P CHASSIS R606 4.7K C612 0.0027 C606 0.18 C614 1/50 C616 4.7/50 C618 1/50 C620 1/50 C622 1/50 CE 21 A+10V +B +B 9 DGND DI 22 CLK R642 10K R644 8.2K C624 1/50 23 TUN_R 25 AGND 14 R643 8.2K R641 10K P6-4 10-H TO TUNER SECTION 16 TUN_L 26 DO R608 820K 24 R139 JP608 0 REC_L REC_R R137 220K R136 220K +B 0.7V 10K 14 0.022 DI +B 2 R141 4.7K 1 Q109 KTA1504 Y SWITCHING D_GND S_MUTE 3 10 T_T1/T2 R144 22K 4 SP_DET 3 SP_RLY 2 1 SP_RLY SP_DET SW_5V CNP701B M_+13 +B_PROTECT D_GND A+10V AGND TAPE_A_GND - 20dB M_GND L103 C139 0.039(ML) 6 5 SW_5V +B 47/25 R143 47K C137 0.047(ML) 7 A+10V M_+13V +B 0V C138 0.0082 8 T_BIAS +B 0V 9 REC/PLAY R142 82(1/2W) 0V 11 P6-7 2-F TO DISPLAY PWB R140 47K 12 BIAS Q110 KRC104 S CNP701A 0V 13 +B_PROTECT 11.6V R158 220 R145 Q111 4.7 KTC3203 Y BIAS OSC 12 C135 220/10 ALC Nor/CrO2 RIPPLE ALC Vcc 11 15 CLK C131 47/25 10 R135 10K K K 13 16 DO 330 µH C140 15 14 6 16 CE C134 C133 C132 47/25 22/25 R134 10K Q107 KTC3875 GR 0V MUTING 1 FFC701 MAIN PWB-A1 (1/3) 15 19 14 9 16 10 13 7 4 5 P6-5 1-D~H TO POWER SECTION 6 7 8 9 10 Figure 6-2 SCHEMATIC DIAGRAM (2/12) 6–2 11 12 CD-G10000/CP-G10000S CD-G10000 A C302 0.001 AM TRACKING fL 0.001 D301 DS1SS133 D302 DS1SS133 C332 0.022 VD301 SVC347S AM OSC. T306 R365 10K 2.2/50 B C338 C331 0.047 R358 3.3K C362 C323 0.022 C342 0.022 C330 15P(CH) AM ANTENNA T303 R336 10K AM BAND COVERAGE fL R323 68K C334 22P(CH) C335 560P 24 T301 +B 2 R327 0 AM OSC IN FM IF IN AM OSC OUT 5.6K R351 C389 0.022 C350 0.001 3 1 T302 R325 47K 0.022 TP301 FM IF C312 0.022 10/50 R309 10K C352 FM BAND COVERAGE fL VD303 SVC230C R322 680 C397 0.022 +B R382 150 R316 4.7K C318 100P Q302 KTC3194 Y OSC BUFF C394 47/25 R381 10K JP303 0 C393 1/50 C381 12P(CH) JP307 0 22 21 20 IC LC X352 4.5 MHz C382 15P(CH) 2 3 AM SIGNAL +B G MAIN PWB-A1 (2/3) H • NOTES ON SCHEMATIC DIAGRAM can be found on page 5-1. 1 2 3 4 Figure 6-3 SCHEMATIC DIAGRAM (3/12) 6–3 5 6 100P(CH) FM SIGNAL 100P(CH) R375 470 C377 +B C376 C383 47P F R374 1K 1 1K E C316 0.022 C315 0.01 C307 10/50 C324 4.7P(CH) FM OSC. R314 22 +B R373 L312 C309 0.001 R311 100K D305 DS1SS133 C308 4.7P(CH) FM RF 1 C306 0.022 X IN X OUT VSS AOUT CE GND IC301 TA7358AP FM FRONT END 9 C311 18P(CH) C320 0.001 SO302 FM ANTENNA TERMINAL 8 23 CF303 7 C313 22P (CH) 6 C347 0.022 C304 0.01 FM 75 OHMS D 5 JP312 R302 10 0 JP309 0 4 C310 15P(CH) 2 3 VD302 SVC230C JP308 0 2 2 R313 33K 1 1 C317 0.001 1 C303 10P(CH) CNP301 1 2 3 C305 4.7P(CH) AM LOOP ANTENNA C C351 B.P.F BF301 6 7 7 10 8 14 13 12 9 11 R376 1K IC302 PLL (TUNER) 8 C386 330P R395 47K R388 3.9K C398 100/10 0.022 C356 0.001 C370 1/50 C355 22P(CH) 3 R353 270 IF OUT PHASE C357 R355 2.2/50 3.3K R386 22K C365 C366 C364 C363 R357 470K C373 0.015 0.015 C374 R356 1K 27P(CH) C369 TP302 0.022 0.001 2.2/50 0.022 2.2/50 0.022 C361 C362 C368 1/50 X351 456 kHz IC303 LA1832S FM IF DET./FM MPX./AM IF L-CH OUT PHASE MO/ST (FM/AM) R-CH OUT VCC MPX IN FM DET MPX VCO STEREO C358 12 1/50 +B C396 100/10 C395 0.022 R360 4.7K 21 22 9 6–4 23 24 9 14 10 Figure 6-4 SCHEMATIC DIAGRAM (4/12) TUN_L 6 17 16 15 10 11 JP317 0 R393 1K 9 TUN_R L351 100 µH CF351 8 R387 5.6K 0.001 C399 0.022 AM IF C354 SD VSM AM IF IN AM LOW CUT FM/AM OUT GND 7 DGND 5 19 18 0.022 FM AFC AM RF IN 6 15 14 13 AGND C380 10/50 JP310 0 2 C353 CF352 1 R377 47K C392 0.001 C387 0.022 T351 4 5 R384 5.6K C385 0.01 2.2K R352 1K 16 A+10V 4 3 3 17 R359 1.8K C393 R380 1/50 1.5K 20 19 18 C372 1/50 DO MO/ST SD IF IN ST IND 22 21 20 21 R350 2.7K C367 1/50 CLK FM/AM VDD FM IN IF CONT AM IN FM/AM R381 10K 1K C394 47/25 REG AM OSC IN AM MIX OUT 2 R379 0.022 1 22 R378 DO C350 23 FM IF IN AM OSC OUT 5.6K R351 24 AIN PD CL 1 2 1K IC302 LC72131 DI 10/50 0.022 R358 3.3K R372 1K JP303 0 1K C397 0.022 R373 C352 C351 R365 10K DI CE C378 R375 470 100P(CH) C383 47P R374 C382 5P(CH) 100P(CH) X352 4.5 MHz C377 C381 P(CH) 100P(CH) C389 C376 R382 150 X IN X OUT VSS AOUT CE C342 0.022 CD-G10000/CP-G10000S C371 1/50 L352 ZD351 100 µH DZ5.1BSB R392 SWITCHING R391 270 Q360 KTA1266 GR +B 270 R385 5.6K R383 5.6K C391 47/25 C388 0.001 C384 0.001 +B C379 100P(CH) +B 16 25 26 P6-2 11-C TO MAIN SECTION 11 12 CD-G10000/CP-G10000S CD-G10000 C917 0.01 R958 100(1/4W) Fusible R925 1.5K (1/2W) D906 DS1SS133 C901 0.22/50 R928 39K R927 39K R922 0.1(5W) C922 C921 4700/50 4700/50 -B -B C920 -B L L901 3 µH C923 3900/85 3900/85 R929 R930 47K 47K SP_DET D910 1N4004S D909 1N4004S D885 DS1SS133 C946 0.1/50 C R926 1.5K (1/2W) R934 56K R935 56K R908 1K C902 0.22/50 ZD903 DZ12BSB R939 10(1/2W) 100/100 C915 C918 100/50 D905 DS1SS133 R920 1.5K C919 0.01 R921 2.2K R Q903 KTC3875 GR ZD902 DZ12BSB C916 100/50 R919 1.5K R910 1K L902 3 µH KTC3875 GR R916 C914 100/100 R918 2.2K C911 100/100 +B +B -B Q901 KTC3875 GR C904 0.001 1 R917 0.1(5W) Q902 KTC3875 GR R901 R902 56K 56K 2 -B B C903 0.001 3 +B -B C912 100/100 4 56K 5 R937 6 C925 47/50 7 Q904 8 IC901 STK41244 POWER AMP. D907 DS1SS133 9 VH+ 10 0.22(5W) R913 R904 1K 11 0.22(5W) 12 VL+ + 13 R912 100(1/4W) Fusible 14 R911 56K R907 56K 15 C909 0.1(ML) R909 C910 3P(CH) 33K 560 4.7/50 R906 C906 C905 4.7/50 R905 560 16 C908 C907 3P(CH) 100P(CH) C913 100P(CH) 17 VL- - 18 R903 1K VH- - A GND + VL- VH- VL+ VH+ +B +B 10V 6 SW 5 C855 10/50 R863 3.3 (1/2W) SP_RLY C859 22/50 13 14 G 15 16 17 18 19 20 13V 2 R885 680 5V 1 -B +B C865 +B 22/25 R854 3.3K C864 22/25 +B R853 22K 1 VOLTAGE REGULATOR IC852 KIA7805AP +B +B 1 3 D860 DS1SS133 A+10V +B_PROTECT +B -B -B C817 22/25 +B R857 22K C852 0.1 (ML) C851 0.1(ML) 2 3 4 4 4 5 5 5 6 6 6 7 7 7 8 8 9 9 9 10 10 10 11 CNS801 D+5V D863 DS1SS133 VCD A+10V +B +B SW_5V +B +B AGND(AUDIO PRO) M_GND D_GND CD_D_GND CD_A_GND TAPE_A_GND CD_GND H • NOTES ON SCHEMATIC DIAGRAM can be found on page 5-1. 1 2 3 8 +B +B R859 10K 3 2 2 +B LD+8V CHASSIS CN 1 1 BI801 +B CHASSIS 12 -B +B M_+13V D861 DS1SS133 11 22K 2 3 4 Figure 6-5 SCHEMATIC DIAGRAM (5/12) 6–5 5 6 VF 1 2 -V P_ 3 VF 4 + 5 6 AC RLY 10 R886 +B +B C850 4700/25 D862 DS1SS133 P6-1 1-C P6-2 8-H TO MAIN SECTION 9 VCC +B 3 C856 0.1 (ML) SP_DET R864 22K 8 GND 4 R-CH E 7 22K CNP802 5 47K R887 6 - 8 11 - E FROM DISPLAY PWB FW701 4 47K R888 ZD805 DZ12BSB 8V 7 C854 220/25 A_GND 3 R889 -B 1 2 F Q886 KTC3875 GR C885 0.1 MULTI REGULATOR IC851 AN80T53 L_CH D Q885 KTC3875 GR CD-G10000/CP-G10000S MAIN PWB-A1 (3/3) FM SIGNAL R944 1.5K L 56K RL914 R951 1K Q905 KTC3199 GR R940 10(1/2W) R938 0.2V SP RELAY ON-OFF 10(1/2W) R941 10(1/2W) R939 10(1/2W) L L901 3 µH D911 DS1SS133 + - M M901 FAN MOTOR FW901 P6-2 10-A FROM GAME INPUT PWB CNP903 4.4V L921 0.29 µH L920 0.29 µH R946 R956 1K 1 CNP901 M_+13V 1 SP_RLY 2 R-CH 3 GND 4 L-CH 5 +B C928 0.22 (ML) 2 1 L1_OUT R1_OUT R935 56K C929 0.22 (ML) 2 Q907 KTC3203 Y R959 220 R R937 R950 68K 47K 1 2 3 BI901 1 2 3 3 2 1 C962 22/50 CNS901 C963 22/50 R934 56K R949 1K(1/2W) C931 10/50 R947 15K SO904 JK904 SURROUND SUBWOOFER SPEAKER TERMINAL PRE-OUT 680(2W) R957 4.7K 680(2W) R945 1.5K R942 L R943 R Q906 KTC3203 Y D912 DS1SS133 R CNS971 +B FAN MOTOR DRIVER CNP971 +B L902 3 µH SP_L1-CH +B 8.2K R961 C960 8.2K 3.3/25 R962 680 C952 0.01 6 OHMS MIN R960 SP_R1-CH SP_L1-CH_GND SP_R1-CH_GND +B SPEAKER TERMINAL PWB-H SO901 SPEAKER TERMINAL -B C810 0.22 +B D801 D10XB60F CHASSIS CNP801 1 1 VH+ 2 2 3 3 2 3 4 4 4 5 5 5 VL- 6 6 7 6 VH- GND 10 10 10 11 CNS801 D804 +B 1N4004S D803 1N4004S C807 0.1 F803 2A/125V (ML) 1 2 -VF P_IN 3 C805 22/100 C804 220/63 DZ30BSB 2.2K(1/2W) R808 47/50 ZD803 C802 47/50 R806 47K C803 C801 100/35 R803 12K 47 R804 VF2 D806 1N4004S RL841 T.F. PT801 POWER TRANSFORMER ZD801 R891 DZ6.2BSA Q801 KTA1274 Y 100 R805 47 VOLTAGE REGULATOR VF1 4 6 R890 4.7M (1/2W) +B UNSW_ 5.6V IC854 AN78L05 3 C861 0.022 D853 1N4004S 1 2 D856 DS1SS133 R858 220 AC_RLY R841 220K R842 1K R843 47K D842 D845 1N4004S 1N4004S D844 D843 1N4004S 1N4004S C842 470/35 C843 0.047(ML) 5 CNP802 CHASSIS 6 - 8 11 - E FROM DISPLAY PWB FW701 R801 100K R802 ZD802 47K DZ7.5BSB C844 0.0047 9 F805 6A/125V 8 9 F804 2A/125V +B D846 DS1SS133 8 9 F801 5A/125V -B C806 0.1(ML) -B 7 8 C808 0.1 (ML) D802 D10XB60F R844 82 7 +B VL+ C841 Q841 KTC3199 GR 1000/6.3 1 F802 5A/125V C809 0.1 (ML) D805 1N4004S BI801 AC POWER SUPPLY CORD AC 120 V, 60 Hz C811 0.22 PT841 SUB POWER TRANSFORMER POWER PWB-B1 6 7 8 9 10 Figure 6-6 SCHEMATIC DIAGRAM (6/12) 6–6 11 12 CD-G10000/CP-G10000S CD-G10000 DISPLAY PWB-A2 R751 330 3 G12 P02 P01 P04 P03 P05 P07 P06 P08 P09 P12 P11 P10 P13 P15 P14 P17 P16 P18 P21 P20 P19 P23 P22 P24 P26 P25 P27 P29 P28 P30 NP NP F 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 C707 1/50 1 +10V R745 10K LED703 SDPB50CD B 2 R794 1.5 A F FL701 FL DISPLAY LED DRIVER Q710 KRC102 S G8 G9 G10 G11 S9 79 VLOAD G12 S1 S2 S3 S4 S5 S6 S7 S8 81 82 83 84 85 86 87 88 89 90 91 92 93 80 R750 47K 78 S10 77 S11 76 S12 75 S13 C 74 S14 73 S15 72 (DIST 3),S16 71 (DIST 2),S17 70 (DIST 1),S18 69 (DIST 0),S19 68 S20 67 S21 66 S22 IC701 IXA054AW SYSTEM MICROCOMPU 65 S23 64 S24 63 S25 62 S26 61 S27 D 60 S28 59 MIC SW/S29 58 ILLU LED/S30 7 6 5 4 3 2 1 1 FFC701 SP DET 1K 1K 1K R733 R724 560 1K R729 R725 680 2.2K REC/PLAY T_BIAS A+10V D716 DS1SS133 +B M_+13V +B SW_5V +B +B SP_DET SP_RLY Ð20dB Q714~Q717: SOLENOID DRIVER 3 CNP701A 1 Q717 KRA107 S 3 2 1 G TAPE MOTOR + M - FFC702 1 7 1 2 7 SOL 3 4 5 6 1 7 7 1 3 2 2 Q714 KRC104 S 3 1 Q706 KTA1273 Y LED701 304VT2H3 2 Q712 1 KRC104 S R790 8.2K Q707 KTA1273 Y R787 4.7K R786 4.7K H 3 Q711 KRA107 S R777 10K CNP702A T2 RUN +MTR 6 5 SOL2 SOL1 4 F_REC 3 T1 RUN 2 2 SOL 1 Q715 KRA107 S 1 Q716 2 KRC104 S TAPE MECHANISM PWB-D GND D710 DS1SS133 Q708 KTA1273 Y JOG701 VOLUME R778 10K R779 10K D709 DS1SS133 Q706, Q711, Q712: MOTOR DRIVER Q707, Q708: SOLENOID DRIVER • NOTES ON SCHEMATIC DIAGRAM can be found on page 5-1. 2 R726 R727 T_T1/T2 3 1 680 +B S_MUTE R771 4.7K 8 D_GND R785 2.7K 9 CNP701B P6-2 11-G TO MAIN PWB F +B_PROTECT C710 0.047 11 10 DI R780 10K 12 CLK R775 4.7K 13 DO R776 4.7K 14 CE C709 0.047 15 M_+13V 16 R770 5.6K 16 R728 R731 10K 50 49 48 47 46 45 44 43 42 41 40 39 38 R762 R784 1K 10K E REMOCON 51 VSS 52 R732 1K S MUTE 54 TRAY SW1 53 TRAY SW2 TIMER LED 1K T_SOL_B 1K R730 R788 4.7K T_MOTOR R746 57 DIST 56 CLAMP SW 55 DISC_SW T_SOL_A 100 VDD 1K R740 SP_RLY R741 AC_RLY R789 4.7K 3 4 Figure 6-7 SCHEMATIC DIAGRAM (7/12) 6–7 5 6 CD-G10000/CP-G10000S F F1 NX NX G01 G03 G02 G03 G05 G04 G06 G07 G08 G09 G10 G12 G11 P02 P01 P04 P03 P05 P07 P06 P08 P09 P11 P10 FL701 FL DISPLAY 8 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 R795 1.5 C702 220/10 C701 1/50 6 7 8 IC701 IXA054AW SYSTEM MICROCOMPUTER 1K AVREF AVDD PHOTO P_IN 1K R706 R707 1K 1K R708 1K C704 15P(CH) C705 18P(CH) T_FP SW 28 PROTECT 29 VOL_JOG 30 C730 0.047 3 +B 1 1K 1K 2 1K KEY 1 KEY 2 R718 1K 16 FFC704 1K 1K 1K R573 10K C723 0.047 R759 5.6K C720 0.022 +B WTM705 +B FW701 1 VF2 C727 0.047 1 -VF P_IN R722 1K R723 1K R719 1K R720 1K KEY 0 1K 1K 1K 1K R724 R733 R736 R721 560 1K R729 R725 2.2K R726 R727 680 680 R728 CNP704 1K 9 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 R731 10K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 1K R717 1K R739 1K T_RUN PULS 26 TUN_SM(SPAN) 27 SP DET REMOCON VSS S MUTE TIMER LED T_SOL_B T_SOL_A T_MOTOR 1K R704 R705 R709 CLK 17 R710 DI 18 R711 DO 19 R712 CE 20 R713 CD_CE 21 R714 CD_CLK 22 R715 CD_DI 23 R716 CD_DO 24 AVSS 25 LED/S30 VDD R703 VDD 16 SW/S29 MP SW _SW 1K R702 1 CD_RESOUT CD_WRQ CD_DRF CD DO CD DI CD CLK CD CE DISC SW CLAMP SW TRAY SW1 TRAY SW2 PHOTO GND +5V +B SUB_CE CNP5 P6-10 12-C TO CD SERVO PWB 5 1K CNP802 P6-5 6-G TO POWER PWB 4 1K R701 Q713 KRC104 S 3 R763 XL701 XIN 12 VPP/IC 13 4.19 MHz 14 R769 1K CD_DRF 15 0),S19 SP_RLY 2 C721 0.022 1),S18 +B 1 ILLU LED 9 RESET 10 XOUT 11 2),S17 AC_RLY G1 VDD Ð20dBATT T_BIAS T_REC/PLAY T_T1/T2 CD_RESOUT CD_WRQ SUB CE 3),S16 Y SW1 Y SW2 G2 G3 G4 G5 G6 G7 G8 G9 G10 G11 G12 S1 S2 S3 S4 S5 S6 S7 2 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 AD VF1 +B UNSW5.6 AC RELAY CTR 6 6 L701 5V BACK UP +B D713 DS1SS133 100 µH C715 0.01 4.7K +B 1 R761 10K RD23 680 KEY 2 JOG701 VOLUME C710 0.047 KEY 1 R767 10K RD24 820 SW725 SW726 R785 2.7K LED701 304VT2H3 R768 10K C732 0.047 PLAY/ REPEAT STOP RD11 RD12 680 820 SW712 SW713 TUNER (BAND) RD01 680 KEY 0 R766 10K SW701 C722 0.047 CD RD02 820 RD25 1K SW727 RD26 1.5K SW728 MEMORY/ REC/ SET PAUSE RD13 1K RD27 2.2K RD28 2.7K SW729 RD29 3.9K RD14 1.5K 2.2K 2.7K SW716 SW717 SW714 SW715 RD30 5.6K SW730 SW731 DIRECT OPEN/ CLOSE PLAY RD15 RD16 DISC 2 RD17 3.9K +B RX701 PIC3704 D715 DS1SS133 R593 4.7K R771 4.7K R780 10K RESET Q709 R781 47K KRC102 S 2 3 D714 DS1SS133 C714 3.3/50 +B R783 100 R782 100K R773 10K +B D711 DS1SS133 D712 DS1SS133 R791 4.7K RD31 10K 1 2 3 C717 47/25 RD32 15K SW732 SW733 SW734 SW735 DISC 4 DISC 1 RD18 5.6K SW718 SW719 DISC 5 DISC 3 RD19 10K RD20 15K RD21 33K SW720 SW721 SW722 SW723 GAME/ X-BASS/ RIGHT ENTER DOWN UP LEFT VIDEO DEMO MP3 NAVIGATION RD03 RD04 RD05 RD06 CHARACTER 2.2K 2.7K 1K 1.5K TAPE SW702 SW703 SW704 CLOCK/ TUNING TUNING POWER DOWN ON/STAND-BY TIMER UP SW705 FAST REWIND/ PRESET DOWN SW706 SW707 EQUALIZER FAST FORWARD/ PRESET UP R 6 7 8 9 10 Figure 6-8 SCHEMATIC DIAGRAM (8/12) 6–8 11 12 CD-G10000/CP-G10000S CD-G10000 A CD SERVO PWB-C C32 C31 C30 C73 C28 C72 C27 CD SIGNAL 100P(CH) 0.022 100P(CH) 100P(CH) 100P(CH) 100P(CH) 100P(CH) 1K 1K 1K 1K 1K 1K 1K R47 R46 R45 R44 R43 R42 R41 +B +B 5V +B R7 47 C1 47/25 +B 0.022 5V 11 10 9 8 PD 7 6 5 C 4 3 2 1 C5 0.047 R12 330 R2 0 0.01 100P(CH) C6 C12 RM2 4.7K R10 4.7K 10K 4.7K R96 R29 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 DVDD 150 +B 60 DATA 59 DATACK 58 LRSY 57 ASDFIN 56 5 LPF ASDACK 55 6 JITTC ASLRCK 54 7 AIN F16MOUT 53 IC1 R56 8 CIN OUT1 52 4.7K 9 BIN LC78648E F16MIN 51 10 DIN IOMODE 50 CD 11 FEC XVDD 49 SERVO PHLPF/RFMON 12 XIN 48 R28 XL1 13 VREF XOUT 47 16.9344MHz 220 14 EIN XVSS 46 15 FIN RVDD 45 16 TEC RCHO 44 17 TE LRVSS 43 ZD1 18 TEIN LCHO 42 MA8033 19 LDD 41 20 LDS LVDD +B 1 2 3 4 RF 12 3 8 R37 R36 R35 R34 R33 R32 R31 11 10 5 7 R1 0 0.056 C33 C9 TP2 3.3/16 SLDO SPDO AVSS AVDD2 DVDD DVSS VPB DEFECT FSEQ EFLG FSX PU-IN/CONT1 M0_B-/CONT2 MO_B+/CONT3 MONI1 MONI2 DOUT TEST C18 +B +B C21 10/25 C23 0.0015 (ML) R25 10K 100/10 1K 2.2K 2.2K +B R18 R49 R8 C17 0.022 R14 R13 R16 R15 D C25 0.01 R23 2.2K 9 6.8K 8.2K 6.8K 6.8K 1 C20 330/6.3 FDO 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 GND C34 0.01 VR LD C82 TR- +B +B 6 C46 0.01 0.0033 TR- 390 470P R27 100 2 C11 0.056 390 390 390 390 390 390 390 R30 C16 4 FO+ FO- AVDD1 SLCO EFMIN C8 0.0027 TDO FO+ C3 47/25 CNP1 TR+ TR+ R17 4.7K C22 10/25 C24 0.0015 (ML) 0.82µH C +B C4 0.001 C83 0.001 5V 12 C35 0.047 R39 680 R50 680 R38 56K R24 2.2K 13 F R9 10 L1 14 B TP R19 1K 15 A Q1 KTA1504 Y R40 4.7K VVDD VVSS PCKIST PD02 PD01 MOT_A-/CONT4 MOT_A+/CONT5 MONI3/EMPH MONI4 MONI5 MO_SPEED/CONT6 C2F/SBCK DRF *RES *WRG DO DI CL CE DVSS VCC 16 VREF E C37 0.1 C38 0.01 GND 16 LD 15 14 VREF PD 13 VCC 12 VR 11 E 33K R6 10 A R5 0 9 B R4 0 8 F 33K R3 7 C 6 GND 5 TR+ 4 FO3 FO+ 2 TR1 FFC1 C36 0.22 R99 2.2M C2 0.01 PICKUP UNIT(306) R88 +B +B B C74 0.001 C26 +B R26 10K 3.3V +B C52 0.01 R55 6.8K +B R58 10K +B G M M NSW1 PICKUP-IN CNS3A/B 6 6 6 - 5 5 5 +- 4 4 4 3 3 2 2 2 1 1 1 - 3 6 5 4 3 2 1 CNP3 SP+ SPSL+ SLPUIN GND 2.2K R85 C29 0.001 100/10 +B +B CNP3A IC2 LA6261 FOCUS/TRACKING/ SPIN/SLED DRIVER Q2 KTA1271Y C41 100/10 NM1 SPINDLE MOTOR NM2 SLED MOTOR 5V +B +B R93 4.7K R95 +B +B 1 (1/4W) +B +B +8V +B R94 1(1/4W) +B +B H • NOTES ON SCHEMATIC DIAGRAM can be found on page 5-1. 1 2 0.1 47/10 SVCC SGND VREFIN VCONT6 REV6 FWD6 VCONT5 REV5 FWD5 10 11 12 13 14 15 16 17 18 CD MOTOR PWB-F +- C58 1 2 3 4 5 6 7 8 9 C59 PGND1 REGIN PVCC1 C86 0.022 VO3+ VO3VO2+ VO2VO1+ VO1- F 27 26 25 24 23 22 21 20 19 VIN1G VIN2 VIN2G VIN3 VIN3G VIN4 VIN4G VO5VO5+ VO6VO6+ PGND2 MUTE PVCC2 VO4VO4+ 36 35 34 33 32 31 30 29 28 REGOUT VIN1 C61 100/10 C56 R91 10K 2.2K R48 1K D1 KDS184 R59 C62 0.01 C57 100/10 +B C60 0.001 R57 10K R92 10K +B E R54 5.6K 3 4 Figure 6-9 SCHEMATIC DIAGRAM (9/12) 6–9 5 6 CD-G10000/CP-G10000S +B +B +B +B 0 150 C47 0.01 +B 470P VDD VSS X1 X2 R74 1K R72 1K R69 1K R67 R66 R77 R64 R78 1K 1K 1K 1K 1K 1 2 3 4 5 6 7 8 9 10 11 CL R62 AVSS CE R73 2.2K +B R65 2.2K R63 2.2K 1K 5V C85 0.022 Q5 2SD601 AR R21 ML) R22 4.7K 4.7K R89 R87 4.7K R52 R84 4.7K 1 R86 4.7K GND TRAY SW2 TRAY SW1 CLAMP DISC PHOTO +5V TR+ TRCAM+ CAM- +B C70 0.01 R98 270 C69 47/25 1 2 3 4 5 C2FIN 6 TEST1 7 CKIN(16M) 8 VSS 9 CKOUT 10 TEST2 11 DVDD1 12 PW 13 SBSY 14 SFSY 15 SBCK 16 AVDD1 17 VPRFR 2122 18 VCOC 19 VPDO 20 AVSS IC3 LC78684E MP3-DEODER DVDD3 VSS DVDD2 VSS R82 2.2K 60 59 58 57 56 55 54 53 VSS 52 DVDD4 51 50 49 48 47 46 45 44 43 42 41 +B ADRS0 ADRS1 ADRS2 ADRS3 ADRS4 ADRS5 ADRS6 ADRS7 SW1 CLAMP 4 SW4 DISC 5 6 RX1 7 8 + 9 10 11 CNP6 11 11 M M1 TRAY MOTOR M M2 MAIN CAM MOTOR + - ADRS8 OEB CASUB CASLB WEB RASB MDATA8 MDATA9 MDATA10 MDATA11 MDATA12 MDATA13 MDATA14 MDATA15 2V Q6 KTC3875 GR C10 ADRS0 ADRS1 ADRS2 ADRS3 VCC 0.1 DCASLB DCASUB DOEB ADRS8 ADRS7 ADRS6 ADRS5 ADRS4 VSS VSS VCC VCC IC4 LV1625635T D-RAM DWEB DRASB 47/10 C58 0.1 VSS 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 C59 CNP2 C87 +B 0.1 IC6 SI3033LUS VOLTAGE +B REGULATOR FJ1 RM6 680 RM5 270 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 +B 3 C14 47/10 ADRS0 ADRS1 ADRS2 ADRS3 WEB RASB MDATA4 MDATA5 MDATA6 MDATA7 3.3V MDATA0 MDATA1 MDATA2 MDATA3 0.01 +B C53 2.0V CASLB CASUB OEB ADRS8 ADRS7 ADRS6 ADRS5 ADRS4 MDATA11 MDATA10 MDATA9 MDATA8 MDATA15 MDATA14 MDATA13 MDATA12 C64 33P (CH) C66 0.01 MDATA0 MDATA1 MDATA2 MDATA3 MDATA4 MDATA5 MDATA6 MDATA7 C65 47/10 C75 0.001 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 C63 1/50 2.2K R85 R81 3.3K C44 100/10 R83 150 C29 0.001 2.2K R59 C42 33P(CH) R80 82 DATACK DATAIN RESB INTB MP3 CE MP3 CL CMDIN CMDOUT OVF CNTOK WOK VSS DVDD6 CRCF FSYNC STDAT STCK STREQ VSS DVDD6 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 LRSY ADDATA ADBCK ADLRCK +B C68 0.01 SW2 TRAY SW1 3 L3 2.2µH TP TPTPTP SW3 TRAY SW2 2 1 2 3 4 5 6 7 8 9 10 11 3.3V R26 10K CNP6A 1 5V +B 5-CHANGER MOTOR PWB-E FFC4 11 11 +B Q3 2SD601 AR R20 4.7K 4.7K 0.82µH R24 2.2K L1 C24 R79 4.7K CNP5 C84 0.022 Q4 2SD601 AR 4.7K C22 10/25 C71 0.1 R61 2.2K R60 1K +B 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 CNP704 390 390 390 390 390 390 390 CD RES WRQ DRF DO DI CL CE DISC CLAMP TRAY SW1 TRAY SW2 PHOTO GND +5V SUB_CE 33K 7 6 5 4 3 2 1 RESET R76 FSYNC 1K 33 32 31 30 29 28 27 26 25 24 23 R70 ICO 22 1K 34 35 MP3-RES CDEMPH 21 36 20 37 VSS IC5 SYS-DI 19 38 SYS-DO 18 39 IXA006AW VDD 17 MICRO- SYS-CL 16 40 41 COMPUTER SYS-CE 15 INTB 14 +B 42 43 AVDD MP3 DI 13 44 AVREF MP3 DO 12 FDO FCLK R71 2.2K FFC704 16 R68 100K P6-8 12-C TO DISPLAY PWB XL2 4.19MHz R75 220 C51 0.01 R97 C50 47/10 CNP4 RM1 10K R10 4.7K 7 6 5 4 3 2 1 5V R17 4.7K RES VPP +5V FCLK FDO FDI GND L2 2.2µH ONLY FOR FLASH 1 2 C13 0.022 +B C76 +B 3.3 +B +B +B R-CH 2 AGND 5 L-CH DGND +5V(DIG.) 6 DGND_DRIVER P6-1 1-B FROM MAIN PWB CNS601 7 +8V 8 +5V(ANL) +B +B +B +B C48 1 3 4 C39 0.1 +B +B +B 5V 0.01 0.022 +B • The number 1 to 12 are waveform number shown in page 5-3. 6 7 8 9 10 Figure 6-10 SCHEMATIC DIAGRAM (10/12) 6 – 10 11 12 CD-G10000/CP-G10000S CP-SW10000S 2 1 +B +B +B R538 5.6K R928 56K R933 10(1/2W) D912 1N414 C931 10/50 Q909 KRC104 M VR501 10K(A) 3 5 2 1 2 1 2 1 R527 560 LED B PWB-B4 3 2 2 1 1 1 CNP902 3 2 1 VL- -B -B VL+B -B C932 220/16 ZD904 DZ13BSB D802 D10XB60 VOLTAGE REGULATOR IC801 KIA7812AP C808 0.1 (ML) 3 R510 2.7K 2 1 CNS505 VOLUME PWB-B1 D804 D805 D803 D806 C807 1000/25 1 2 CNP505 2 1 CNS503 2 1 2 1 R502 1.5K R501 10K R507 100K CNP502 JACK PWB-A3 SO501 SUBWOOFER INPUT BI501 R536 10K R526 560 LED501 A50ABC2L LG902 CHASS LED A PWB-B3 • NOTES ON SCHEMATIC DIAGRAM can be found on page 5-1. 2 C803 0.1 (ML) C804 0.1 (ML) D803~D806: GD1N4004 -B CNS501 VL+ +B C501 0.001 -B 2 1 3 2 CNP503 G 2 1 3 VH+ +B R528 120K C506 10/50 2 1 4 R533 470K 6 C507 100P CNP501 4 R801 22K 2 4 C511 100P C510 10/50 R511 1K 4 + - R512 1K IC501 KIA4558P OPE AMP. 4 +12V ZD504 DZ5.1BSB C508 0.033(ML) + 8 5 100K C526 1 10/50 7 C512 10/50 5 CROSSOVER FREQUENCY R513 R514 2.7K +B 5 D801 D10XB60 R934 560(3W) ZD503 DZ5.1BSB C513 100P -B C515 0.12 5 -B C810 0.1 (ML) C519 100P R517 1K C514 1 F C516 0.1(ML) CNS902 C520 100P R519 1K R518 10K 6 5 -B VH- C518 10/50 4 + - 3 LG901 CHASSIS CNS504 2 ZD501 DZ3.9BSB C517 100P C521 0.22 7 + 8 R935 560 (3W) C933 220/16 CNP504 1 IC502 KIA4558P OPE AMP. E 1K R520 1K R521 1K ZD903 DZ13BSB R524 R525 Q501 5.6K KTC3199 GR R522 1K C523 100P 1 R927 56K D911 1N4148H R957 1K R523 2.2K C529 10/50 C522 10/50 VH- VOLUME R535 4.7K ZD502 DZ3.9BSB H D910 1N4148H +B D R537 10K LED502 A50ABC2L R955 10K L D913 1N4148H C937 0.1/50 VR502 10K(A) BI502 VH+ VL+ R_CH INPUT L_CH INPUT R926 47K +B CNS502 C921 3900/85 R925 47K R909 1K C902 1/50 L901 3 µH C923 4700/50 R960 10K -B C922 4700/50 C920 3900/85 C92 0.2 R924 39K R923 39K D904 GD1N4004 -B C R929 56K D905 GD1N4004 Q908 KRC102 M C919 0.01 (ML) R915 0.1 (5W) R911 100(1/4W) Fusible C901 1/50 ZD902 DZ12BSB D901 1N4148H C92 0.22 R959 47K R917 1.8K R919 2.2K R922 1.5K (1/2W) R921 1.5K (1/2W) C925 47/50 C915 100/100 C913 100/100 D902 1N4148H D903 1N4148H 0.01 (ML) Q902 KTC3199 GR Q901 KTC3199 GR C911 0.1 (ML) ZD901 DZ12BSB C918 100/50 R916 0.1 (5W) C917 C916 100/50 C914 100/100 R910 1K -B L902 3 µH Q903 KTC3199 GR R958 47K 3 -B C912 100/100 R942 C910 3P 33K R908 56K 560 47/50 4 Q904 KTC3199 GR 5 IC901 STK41244 POWER AMP. Q907 KRC102 M 6 VH+ 7 8 VL+ 9 10 VL- 11 R918 R920 1.8K 2.2K C909 3P C908 100P R904 1K R907 56K 12 R914 0.22 (5W) 13 R913 0.22 (5W) 14 -B C904 0.1(ML) R906 C906 C905 47/50 R905 560 C903 0.1(ML) R901 56K 15 R902 56K B 16 R912 100(1/4W) Fusible 17 C907 100P VH- + - 18 R903 1K GND + - A 3 4 Figure 6-11 SCHEMATIC DIAGRAM (11/12) 6 – 11 5 6 CD-G10000/CP-G10000S POWER PWB-A1 SUBWOOFER SIGNAL M401 FAN MOTOR D908 1N4148H 1 1 2 2 R936 1.5K L R941 15K RL901 R937 1.5K L902 3 µH R928 56K L1_OUT R C404 47/25 R931 10(1/2W) R933 10(1/2W) R960 10K D911 1N4148H Q906 KTC3199 GR Q402 KTC3203 Y R938 22K R405 120K R939 47K D912 1N4148H R404 4.7K R940 47K Q908 KRC102 M R959 47K L C931 10/50 Q909 KRC104 M C402 100/16 Q401 KTC3205 Y C930 47/25 C401 10/50 R402 1.5K D907 1N4148H D913 1N4148H C925 47/50 L901 3 µH R409 4.7 Q905 KTC3199 GR CNP901 SP_L-CH SP_L-CH_GND R401 4.7 Posistor CNS901 C928 0.22 D906 1N4148H C929 0.22 R930 10(1/2W) C926 0.22 R932 10(1/2W) C927 0.22 R927 56K R929 56K R1_OUT D910 1N4148H M CNS402 CNP402 9 GR + - SP_R-CH SP_R-CH_GND 1 1 2 2 3 3 4 4 SP1 SUBWOOFER POWER SWITCH PWB-B2 F806 T500mA/125V D805 2 1 1 2 3 4 3 4 5 5 1 2 1 2 CNP804 1 2 1 F801 6.3A/125V D806 CNS802 1 2 CNP805 6: GD1N4004 2 C935 0.047 CNP802 F804 T6.3A/125V D802 D10XB60 CNP803 2 2 1 1 1 2 CNP801 1 2 2 CNS804 -B 1 CNS806 F805 T6.3A/125V C803 0.1 (ML) C804 0.1 (ML) SW802 POWER CNS805 C806 0.22 CNP806 C805 0.22 0 CNS803 -B AC POWER SUPPLY CORD 120 V, 60 Hz TRANSFORMER PWB-A2 T.F. PT801 POWER TRANSFORMER LG902 CHASSIS 6 7 8 9 10 Figure 6-12 SCHEMATIC DIAGRAM (12/12) 6 – 12 11 12 CD-G10000/CP-G10000S [2] Wiring side of PWB CD-G10000 A MAIN PWB-A1 C391 C383 C396 R392 R391 R385 R393 C398 R355 C355 R906 C904 C913 C902 R912 IC901 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 R921 R920 R942 C919 C923 C920 R941 R939 LG2 BI901 1 3 R960 CNP903 3 2 1 1 2 3 CNS901 SO904 SURROUND SPEAKER TERMINAL H 1 2 3 4 Figure 6-13 WIRING SIDE OF PWB (1/11) 6 – 13 5 C917 R919 Q902 RL914 G R916 R917 R913 R911 R922 D911 D906 D905 R943 R918 C910 Q901 SO901 SPEAKER TERMINAL L-CH 1 R910 R961 C929 R617 R958 R904 L901 R-CH C962 R620 C640 R902 R935 R-CH C961 R616 C946 Q607 C906 R909 Q604 Q603 C909 C905 R618 R621 JP805 R905 R901 IC601 C371 C372 C364 C368 JP662 R608 Q608 R614 Q602 LG4 C358 C386 R387 R384 R359 R360 R386 JP317 R351 C361 R358 C342 C363 R619 C622 15 14 13 C6 R641 C624 C626 R903 C903 C907 C908 R908 R907 D907 R934 C928 L920 R962 C960 18 17 C620 16 C911 D912 R944 R945 R947 Q903 Q904 Q905 B C E T351 R383 C318 T301 C324 C639 C912 R940 R938 R937 L921 F L-CH L902 B C E Q906 R956 R946 R950 R949 C931 P6-20 4-G FROM GAME INPUT PWB JK904 SUBWOOFER PRE-OUT VD302 C316 R610 22 21 20 C374 R642 TP302 R615 R611 C602 24 C616 23 C618 19 R357 R613 C601 C606 R606 C614 C373 R356 R612 C603 C608 C399 C369 C925 E C B SPEAKER TERMINAL PWB-H C367 T306 R951 R959 C366 R350 1 2 3 4 5 R957 Q907 CNS603 IC303 X351 C362 L312 2 1 CNP971 JK691 VIDEO OUT E R327 C309 C312 R309 T302 D691 C357 R353 C353 C354 C610 C370 C356 24 23 22 21 20 19 18 17 16 15 14 13 C332 C335 R604 C350 R352 R365 VD301 C330 CNP603 C388 1 2 3 4 5 6 7 8 9 10 11 12 C901 C693 C389 C320 R322 R325 C307 JP307 C331 D690 BR 2 RD 1 CNS971 CF303 R395 ZD351 L352 C351 CF351 JP310 C313 VD303 C352 R336 R323 C338 B C E C395 R313 C334 T303 D JP312 C311 R311 C323 D301 D302 C385 R375 R382 CF352 3 2 1 1 2 3 C317 R316 CNP301 M901 FAN MOTOR Q302 C303 BF301 1 2 3 1 2 1 2 B C E C308 D305 AM LOOP ANTENNA L351 C393 JP308 R302 C310 R314 C347 C305 C304 IC301 JP309 GND R380 C315 C306 S0302 FM ANTENNA TERMINAL R377 R388 R376 C365 C384 C392 C380 C394 C397 R381 C C387 22 21 20 19 18 17 16 15 14 13 12 Q360 R379 JP303 9 8 7 6 5 4 3 2 1 C377 IC302 TP301 FM 75 OHMS R378 R372 C378 1 2 3 4 5 6 7 8 9 10 11 C382 C381 B C376 C379 R374 X352R373 Q601 C302 6 CD-G10000/CP-G10000S WH BK WH BK WH BK WH R605 C617 Q113 Q114 R149 R617 R144 Q111 R143 C140 R111 R141 R140 R142 Q109 2 1 R888 R930 R928 R863 R929 C922 C952 D910 1 LG1 7 8 CNS801 D909 Q902 C921 11 D863 C850 R887 C885 R885 Q886 R886 C851 C855 C854 R854 ZD805 R889 Q885 3 BI801 C916 ZD903 R926 R925 R927 D885 ZD902 7 5 3 1 C918 C914 1 C864 C915 6 4 2 9 1 2 3 4 5 CNP901 BL WH BL WH BL WH BL WH BL RD 10 9 8 7 6 5 4 3 2 1 FW901 P6-20 4-H FROM GAME INPUT PWB 10 Figure 6-14 WIRING SIDE OF PWB (2/12) 6 – 14 CNP2 P6-18 11-G TO CD SERVO PWB IC852 IC851 1 2 3 4 5 6 7 8 CNS601 CNP801 P6-20 4-A TO POWER PWB C817 C859 R864 RD WH BK WH BK WH BK WH LG3 C865 R857 R853 C852 C946 C139 L103 C137 E C B C138 D861 R620 R916 R145 C141 Q110 D860 D862 C917 R919 Q106 7 6 5 4 3 2 1 R105 Q103 R103 E C B Q101 R104 E C B Q102 R112 E C B Q104 R106 Q112 R616 R918 C106 Q105 R134 C112 R116 R118 E C B R146 R147 9 Q604 4 3 2 R117 C111 R139 1 C619 C612 C631 R641 24 C621 R643 C626 C625 R609 R608 C623 R958 IC101 Q107 RD R148 C615 C611 C613 C130 FROM TAPE 2 RECORD/PLAYBACK HEAD C605 C132 R120 C116 R859 22 IC601 20 1 2 3 4 5 6 7 8 9 10 11 12 R113 C113 C856 24 22 21 20 19 18 17 16 15 14 13 C110 CNP101 3 2 1 C105 C101 C102 C109 R119 C115 BI601 C602 16 23 18 C609 R607 C607 C114 C118 C103 C601 606 06 14 P6-19 4-E C104 C653 C651 C652 608 1 FFC701 FROM TAPE 1 PLAYBACK HEAD C108 C107 JP608 R126 C124 R128 R114 C603 C143 C123 R127 R137 C119 R121 R123 16 14 12 10 8 6 4 2 R150 13 14 15 16 17 18 19 20 21 22 23 24 R109 R110 R107 R108 R601 R603 R602 R131 C117 15 13 11 9 7 5 3 1 11 10 9 8 7 6 5 4 3 2 1 R101 R102 CNP701B R130 C125 12 CNP102 C129 R133 C121 R129 C133 R135 C127 C150 C131 C135 R132 C126 R115 R158 C128 CNP701A C134 Q108 R136 P6-19 5-E R122 R138 C120 R124 P6-15 3-G TO DISPLAY PEB 16 11 12 CD-G10000/CP-G10000S CD-G10000 A DISPLA PWB-A2 R776 RD03 Q716 SW703 TUNING UP JP707 R725 C732 R778 R726 Q717 R727 E C B JP717 B C E Q7 Q715 R779 R728 JP718 R777 RD01 B C E Q706 R759 R723 D716 R739 RD02 JP701 SW712 TUNER (BAND) C722 SW702 CLOCK/ TIMER RD12 R767 R761 JP708 R789 SW713 CD/ VIDEO CD 3 2 1 R724 C717 C702 R788 R762 R729 RX701 R741 R730 R746 R754 R740 C727 SW707 FAST FORWARD/ PRESET UP D R731 R784 50 R732 51 RD11 R719 C R785 Q707 C710 R775 SW705 FAST REWIND/ PRESET DOWN C709 RD05 RD06 R771 RD04 JOG701 VOLUME R780 SW706 EQUALIZER Q714 SW704 TUNING DOWN R766 B R768 C72 R718 R720 R773 R72 R721 R736 R733 31 30 35 25 20 40 45 55 60 15 IC701 10 65 70 E 75 8590 80 81 R750 SW701 ON/ STAND-BY 5 95 LED701 FL701 51 50 CNP701A 16 14 12 10 8 6 4 2 15 13 11 9 7 5 3 1 F 16 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 2 1 FFC701 CNP701B P6-14 10-B TO MAIN PWB G H 1 2 3 4 Figure 6-15 WIRING SIDE OF PWB (3/11) 6 – 15 5 6 CD-G10000/CP-G10000S P6-20 5-A TO POWER PWB CNP802 P6-19 3-B TO TAPE MECHANISM PWB 6 FFC702 7 1 FW701 D710 D709 OG701 OLUME C710 CNP702A R712 R711 R709 R710 D713 D714 R781 C730 C705 XL701 R763 R701 JP702 80 81 16 FFC704 Q710 RD26 R751 75 8590 R706 R703 LED703 R702 R745 1 100 SW729 OPEN/ CLOSE C701 2 1 RD27 C707 R795 5 4 R794 1 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 1 1 3 5 7 9 11 13 16 R707 C704 5 L701 R713 C721 10 2 4 6 8 10 12 14 15 CNP5 P6-18 10-G TO CD SERVO PWB R716 CNP704 R705 R704 SW719 CHARACTER R715 R714 C723 R573 R719 R718 R708 R720 R791 R769 RD16 JP705 SW720 RIGHT Q709 C714 SW725 PLAY/ REPEAT R721 R717 SW717 LEFT RD15 SW721 SW722 ENTER DOWN RD14 SW718 UP 15 Q713 R783 SW723 MP3 NAVIGATION JP706 20 D712 R782 D715 D711 RD23 Q711 SW715 GAME/VIDEO SW714 TAPE SW728 MEMORY/ SET C715 RD13 95 SW727 REC/ PAUSE 1 WTM705 R790 R786 R770 R717 R759 R723 D716 R739 B C E 701 6 RD24 RD25 B C E Q708 Q712 R779 8 77 R768 C720 R718 R722 R773 SW726 STOP R787 JP701 SW716 X-BASS/ DEMO 1 3 5 7 2 4 6 1 SW730 DIRECT PLAY SW735 DISC 1 RD28 SW731 DISC 2 SW734 DISC 3 RD32 RD29 SW732 DISC 4 RD31 RD30 SW733 DISC 5 7 8 9 10 Figure 6-16 WIRING SIDE OF PWB (4/11) 6 – 16 11 12 CD-G10000/CP-G10000S CD-G10000 A B 1110 9 6 2 1 C25 C L3 75 IC3 35 40 41 70 50 55 61 60 R99 C36 C35 R39 4 5 8 7 R49 R8 3 12 C68 35 18 19 20 15 R54 IC6 25 22 C70 R12 65 45 30 20 C37 5 3 2 1 23 C10 25 IC2 15 1 R50 R55 C62 IC4 10 40 10 25 44 5 70 75 80 1 15 C59 1 5 65 80 21 30 E 10 C83 20 C46 R28 R78 60 61 R29 C53 R56 R63 C47 IC1 R85 C75 R65 R3 R6 R2 R4 R1 R5 C8 15 55 R59 R60 1 12 R61 50 L1 R91 R92 15 10 5 44 R67 R66 R77 R64 R62 40 25 20 IC5 C71 21 20 25 RM2 35 30 C82 41 40 35 30 45 C52 R30 R31 R32 R33 R34 R35 R36 R37 23 C66 33 R74 R72 R69 RM1 C51 R38 C5 C17 R73 R76 D ZD1 L2 R15 R16 R13 R14 R93 R18 C34 R7 10 9 30 5 F 35 1 C84 R98 36 CD/MP3 PWB-D (TOP VIEW) G H 1 2 3 4 Figure 6-17 WIRING SIDE OF PWB (5/11) 6 – 17 5 6 CD-G10000/CP-G10000S C1 C3 C38 C4 C50 R75 R40 R23 R25 R22 D1 C23 C58 R80 Q5 R84 C29 C85 C69 C31 C30 C32 C28 C73 C72 C27 C41 C14 C39 C13 C48 R46 R45 R47 R43 R44 R42 R41 C57 C60 R48 CNS3B P6-19 5-F FROM CD MOTOR PWB C65 C42 R57 R58 CNP3 6 5 4 3 2 1 C64 R87 R52 R21 C86 11 C63 R82 C44 R81 Q3 R20 C24 B C E C56 Q2 CNP6 CNP6A P6-19 1-D TO CHANGER PWB 1 3 5 7 9 11 R79 Q4 2 4 6 8 10 7 6 5 4 3 2 1 R83 C74 R88 R96 R10 R17 1 R70 R26 1 FFC4 R71 R68 C22 XL1 R24 C33 C12 C6 XL2 Q1 R9 C26 C11 R86 R89 16 14 12 10 8 6 4 2 R27 C20 R19 15 13 11 9 7 5 3 1 C21 FFC1 16 CNP1 P6-19 1-G TO CD PICKUP UNIT C9 CNP4 C18 C2 R94 R97 CNP5 C61 CNP2 16 14 12 10 8 6 4 2 15 13 11 9 7 5 3 1 CD/MP3 PWB-D (BOTTOM VIEW) 16 FJ1 R95 C76 8 7 6 5 4 3 2 1 1 CNS601 P6-14 11-E FROM MAIN PWB FFC704 CNP704 P6-16 11-D TO DISPLAY PWB 7 8 9 10 Figure 6-18 WIRING SIDE OF PWB (6/11) 6 – 18 11 12 CD-G10000/CP-G10000S CD-G10000 A COLOR TABLE B BR BROWN RD(R) RED OR ORANGE YL YELLOW GR GREEN BL BLUE VL VIOLET GY GRAY WH(W) WHITE BK BLACK PK PINK TAPE MECHANISM ASSEMBLY P6-16 7-A TO DISPLAY PWB CNP702 TAPE MECHANISM PWB-D FFC702 7 1 1 3 5 7 2 4 6 SW SW SW 2 1 SOLENOID SOLENOID +- C TAPE MOTOR SW1 CLAMP WH BK SW3 TRAY SW2 + + BK RD E WH 3 2 1 7 6 5 4 3 2 1 CNP102 CNP101 P6-14 9-B TO MAIN PWB P6-14 10-D TO MAIN PWB 5-CHANGER MOTOR PWB-E - BL RX1 SW4 DISC M2 MAIN CAM MOTOR PK GR GR BK YL WH BK RD WH BK - GR SW2 TRAY SW1 1 M1 TRAY MOTOR YL WH WH 10 8 6 4 2 PLAYBACK HEAD PK 11 9 7 5 3 1 1 RECORD/PLAYBACK HEAD ERASE HEAD CNP6A CNP6 P6-18 7-E TO CD SERVO PWB D TAPE 2 TAPE 1 11 BK FFC4 11 P6-18 8-8 TO CD SERVO PWB CNP3 F 6 5 4 3 2 1 WH GR WH GR WH RD CNS3B 16 FFC1 16 6 5 4 3 2 1 CNS3A 16 CNP1 + G P6-18 7-D TO CD SERVO PWB 654 321 1 1 CNP3A NM1 SPINDLE MOTOR 1 NSW1 PICKUP IN PICKUP UNIT(306) + CD MOTOR PWB-F H NM2 SLED MOTOR • The number 1 to 12 are waveform number shown in page 5-2. 1 2 3 4 Figure 6-19 WIRING SIDE OF PWB (7/11) 6 – 19 5 6 CD-G10000/CP-G10000S CD-G10000 A FW701 D853 D856 R803 C801 R891 Q801 B C E R808 C803 ZD803 R806 C802 D806 D801 C811 C810 C804 D802 F803 2A/125V Q841 C808 F802 5A/125V C809 C843 R842 10 9 8 7 6 5 4 3 2 1 CNP801 R804 R801 R805 ZD801 R802 C807 F804 2A/125V D845 D844 D842 D843 D803 C805 C841 B D805 R858 D804 C806 C842 R844 ZD802 1 2 3 C861 IC854 R841 1 2 3 4 5 6 CNP802 P6-16 10-A FROM DISPLAY PWB P6-14 14-G FROM MAIN PWB CNS801 POWER PWB-B1 F801 5A/125V B C E R843 C PT801 MAIN POWER TRANSFORMER AC POWER SUPPLY CORD AC 120 V, 60 Hz F805 6A/125V D T.F. R890 E C844 WH D846 RL841 BK PT841 SUB POWER TRANSFORMER F JK690 GAME INPUT R692 C690 R-CH 6 BK BK BK BK BK L-CH R691 C691 R693 5 4 3 2 1 CNS603 1 5 5 WTM901 VIDEO IN 1 1 FW901 CNP901 P6-14 10-G TO MAIN PWB G BI603 AUX/VIDEO CNP602 P6-13 2-E TO MAIN PWB R690 JK692 HEADPHONES COLOR TABLE BR BROWN RD(R) RED OR ORANGE YL YELLOW GR GREEN BL BLUE VL VIOLET GY GRAY WH(W) WHITE BK BLACK PK PINK GAME INPUT PWB-B2 H 1 2 3 4 Figure 6-20 WIRING SIDE OF PWB (8/11) 6 – 20 5 6 CD-G10000/CP-G10000S CP-SW10000S A C807 POWER PWB-A1 LG902 R409 D805 C808 C803 3 R926 C921 R801 ZD903 CNP805 CNP902 F805 6.3A/125V 5 4 1 2 3 C915 C914 F804 6.3A/125V 2 C806 1 C805 R925 C920 C918 D801 D905 ZD902 R922 D 5 4 3 2 1 CNP806 2 D802 C804 C932 ZD904 R923 C922 CE1 IC801 C R934 C810 1 C933 LG901 C402 R924 R935 CNS902 P6-23 5-C FROM VOLUME PWB F806 500mA/125V D803 D806 Q402 R402 R403 R405 R404 D804 C923 E C B B C E R401 Q401 C404 C401 B C916 R921 ZD901 1 IC901 C902 R902 C904 R942 E R904 C905 C911 R905 C925 C901 R901 C903 Q903 E C B D904 C908 R913 R908 16 17 R907 C909 C910 18 C906 C907 R903 R929 R914 R911 3 4 5 6 7 8 9 10 11 12 13 14 15 C913 R906 R915 2 D902 Q901 R916 B C E Q906 E C B Q905 RL901 Q902 E C B G C928 Q907 CNP402 D913 1 1 2 M401 FAN MOTOR R917 C919 D901 R919 R939 R938 R955 C931 E C B L902 E C B B C E BR 2 1 Q908 3 R957 R918 C917 R933 C929 C937 R920 R931 4 R937 CNP901 D908 C930 C927 R936 D907 L901 D906 F R940 R941 D903 R927 R928 R910 R909 Q904 B C E Q909 C912 R912 2 RD CNS402 B C E D911 R959 R958 SP1 SUBWOOFER C926 R930 D912 D910 R932 R960 4 3 2 1 BK RD BK RD CNS901 H 1 2 3 4 Figure 6-21 WIRING SIDE OF PWB (9/11) 6 – 21 5 6 CD-G10000/CP-G10000S TRANSFORMER PWB-A2 6 - 28 5 - C FROM VOLUME PWB CNP802 2 F801 6.3A/125V CNS802 P6-23 4-E FROM POWER SWITCH PWB 1 COLOR TABLE BROWN RED OR ORANGE YL YELLOW GR GREEN BL BLUE VL VIOLET GY GRAY WH(W) WHITE BK BLACK PK PINK AC POWER SUPPLY CORD AC 120 V, 60 Hz CNP801 BR RD(R) CNP804 1 1 1 2 2 2 BR BL CNS801 CNS804 BL BR BL 2 BR 1 2 3 8 5 2 1 CNS806 7 YL YL BL 4 RD BL 1 BK RD PT801 POWER TRANSFORMER 9 CNS805 10 Figure 6-22 WIRING SIDE OF PWB (10/11) 6 – 22 11 12 CD-G10000/CP-G10000S CP-SW1000S GY WH(W) BK PK GRAY WHITE BLACK PINK R523 R538 Q501 C534 R512 5 4 3 2 1 CNS902 WH GR WH GR RD 5 4 3 2 1 5 4 3 2 1 6 - 31 6 - B CNP902 TO POWER PWB CNS501 CNP502 2 1 C506 C512 C513 ZD503 1 CNS504 CNP504 CROSSOVER FREQUENCY 1 CNS502 2 1 C514 R527 BI502 2 LED502 CNP501 2 C515 R513 R514 R537 R525 R521 C529 R535 R522 C520 R524 B C E 2 1 CNS503 4 3 2 1 C501 ZD504 VL VIOLET LED B PWB-B4 C526 C518 R528 C508 C507 R533 R507 R510 IC501 C511 BL BLUE GR C523 ZD502 C519 C522 R517 4 3 2 1 5 6 7 8 C510 YL OR ORANGE YELLOW GREEN VOLUME VR502 IC502 R520 R518 C521 R519 RED VR501 C R511 RD(R) 5 6 7 8 ZD501 C517 B BR BROWN C516 COLOR TABLE A 1 2 D 1 2 WH BK CNP503 LED501 R536 2 1 BI501 VOLUME PWB-B1 R526 LED A PWB-B3 GY E 6 - 32 12 - B TO TRANSFORMER PWB CNP802 2 1 CNS505 F BL WH BK BR CNS802 2 1 CNS803 2 1 SW802 POWER 2 1 CNP505 1 2 R502 SO501 SUBWOOFER INPUT R501 CNP803 C935 G JACK PWB-A3 POWER SWITCH PWB-B2 H 1 2 3 4 Figure 6-23 WIRING SIDE OF PWB (11/11) 6 – 23 5 6 CD-G10000/CP-G10000S Service Audio E Market CD-G10000/CP-G10000S Manual 7. FLOWCHART CHAPTER [1] Troubleshooting 1. When the CD does not function The CD section may not operate when the objective lens of the optical pickup is dirty. Clean the objective lens, and check the playback operation. When this section does not operate even after the above step is taken, check the following items. Remove the cabinet and follow the trouble shooting instructions. “Track skipping and/or no TOC (Table Of Contents) may be caused by build up of dust other foreign matter on the laser pickup lens. Before attempting any adjustment make certain that the lens is clean. If not, clean it as mentioned below.” Turn the power off. Gently clean the lens with a lens cleaning tissue and a small amount of isopropyl alcohol. Do not touch the lens with the bare hand. 1. Parts code UDSKA0004AFZZ CD optical pickup Lens cleaner disc HOW TO USE 1. Using the brush in the cleaner cap, apply 1 or 2 drops of the cleaning fluid to the brush on the CD cleaner disc which has the mark next to it. 2. Place the CD cleaner disc onto the CD disc tray with the brush side down,then press the play button. 3. You will hear music for about 20 seconds and the CD player will automatically stop. If it still play continuously, press the stop button. Cleaning fluid CAUTION The CD lens cleaner should be effective for 30-50 operations, however if the brushes become worn out earlier then please replace the cleaner disc. If the CD cleaner brushes become very wet then wipe off any excess fluid with a soft cloth. Do not drink the cleaner fluid or allow it contact with the eyes. In the event of this happening then drink and / or rinse with clean water and seek medical advice. The CD cleaner disc must not be used on car CD players or on computer CD-ROM drives. All rights reserved. Unauthorized duplicating, broadcasting and renting this product is prohibited by law. Cleaner disc 2. When a CD cannot be played 2.1. “E-CD01” is displayed. 1) Check the power to IC1 (LC78648E), the presence of the clock signal (16.9344 MHz) and the status of the RESET terminal (pin 67 on IC1). 2) Does the pickup move to the PICKUP-IN Switch (NSW1) position? If (1) and (2) are OK, check the system microcomputer (especially the communication line with the DSP). 2.2. Pressing the CD operation key is accepted, but playback does not occur. 1) Focus-HF system check 2) Tracking system check 3) Spin system check 4) PLL system check 5) Others 7–1 CD-G10000/CP-G10000S (1) Focus-HF system check. Stopped CH1=500 mV DC 10:1 Although a CD is inserted and the cover is closed, “NO DISC” is displayed. CH3=500 mV DC 10:1 T 500 ms/div (500 ms/div) NORM:20 kS/s FDO 1 Press the Tray1 CD Eject Button without inserting a disc, and try starting the playback operation. TDO 3 CH1 v/DIV 500 mV =Filter= Smoothing : ON BW : FULL =Offset= CH1 : 0.000 V CH2 : 0.0 V CH3 : 0.000 V CH4 : 0.00 V =Record Length= Main : 100 K Zoom : 2K =Trigger= Mode : AUTO Type : EDGE CH1 Delay : 0.0 ns Hold off : 0.2 µs Figure 1 1. Does the pickup move to the PICKUP-IN Switch (NSW1) position? Yes 2. Does the focus (lens) move up and down? (Waveform drawing Figure 1) No Sled motor (NM2). No Check the focus peripheral circuit. No Check the laser diode driver Q1 peripheral circuit. No Spindle motor (NM1). No Pins 7~11, 13, 19 and 20 on IC1 Check the laser diode driver Q1 peripheral circuit. Yes 3. Is the laser lit? Yes 4. Is the turntable rotating? When a disc is loaded, start playback operation. 1. Is focus servo activated? (Waveform drawing Figure 2) Yes 2. Does DRF change from “L” to “H”? No Is the disc rotating? No If the disc is spinning and a HF waveform is generated, DRF will go H. Yes 3. Is the HF waveform normal? (Waveform drawing Figure 3) Stopped CH1=500 mV DC 10:1 CH2=10 V DC 10:1 No CH3=1 V DC 10:1 Check the spin system. If the level is not normal. 500 ms/div (500 ms/div) NORM:20 kS/s FDO 1 T 2 DRF TE 3 CH Position To -3 div -1 div 0 div +1 div +3 div =Filter= =Offset= =Record Length= Smoothing : ON CH1 : 0.000 V Main : 100 K BW : FULL CH2 : 0.0 V Zoom : 2K CH3 : 0.00 V CH4 : 0.00 V CH2 Position 0.20 div =Trigger= Mode : AUTO Type : EDGE CH1 Delay : 0.0 ns Hold off : 0.2 µs Vp-p=1.0 V~1.3 V 0.5 mV/div,0.5 µsec/div Figure 3 Figure 2 7–2 CD-G10000/CP-G10000S (2) Focus-HF system check. Check the TE waveform at pin 15 on IC1. If the waveform shown in Figure 4 appears and soon after NO DISC appears? No “Initialization” is possible, but play is not possible? Yes Yes The tracking servo is not activated. Check the peripheral circuits at pins 16, 17 and 22 on IC1, and FFC1. A normal jump operation cannot be completed or the beginning of the track cannot be found. Check the around pin 22 on IC1. No “Initialization” is not possible. Data cannot be read. Check the VCO-PLL (Pin76~80 on IC1) system. T Stopped CH1=10 V DC 10:1 CH2=1 V DC 10:1 100 ms/div (100 ms/div) NORM:100 kS/s TE 2 T 1 DRF =Filter= Smoothing : ON BW : FULL =Offset= CH1 : 0.0 V CH2 : 0.00 V CH3 : 0.00 V CH4 : 0.00 V =Record Length= Main : 100 K Zoom : 2K =Trigger= Mode : NORMAL Type : EDGE CH1 Delay : 2.924 ms Hold off : 0.2 µs Figure 4 (3) Spin system check. Press the OPEN/CLOSE switch without inserting a disc, and then try starting the play operation. 1. The turntable rotates a little? (Waveform drawing Figure 5) Yes The spin driver circuit is OK. No 2. The turntable doesn't rotate. Check around pin 24 on IC1, pins 3 and 4 on IC2, and CNS3A/ CNS3B. Stopped CH1=200 mV DC 10:1 T 1999/04/07 09:51:15 500 ms/div (500 ms/div) NORM:20 kS/s CH2=500 mV DC 10:1 T FDO 2 1 SPDO =Filter= Smoothing : ON BW : FULL =Offset= CH1 : 0.000 V CH2 : 0.000 V CH3 : 0.00 V CH4 : 0.00 V =Record Length= Main : 100 K Zoom : 2K Figure 5 7–3 =Trigger= Mode : NORMAL Type : EDGE CH2 Delay : 2.924 ms Hold off : 0.2 µs CD-G10000/CP-G10000S (4) PLL system check. CH1=500 mV DC 10:1 When a disc is loaded, start play operation. CH3=1 V DC 10:1 1999/04/05 17:33:17 CH4=1 V 500 ms/div (500 ms/div) DC 10:1 NORM:20 kS/s PDO1 3 The HF waveform is normal, but the TOC data cannot be read. 4 PDO2 Check the PDO waveform. (Figure 6) T FDO 1 CH1 v/DIV 500 mV Check around pins 76~80 on IC1. =Filter= Smoothing : ON BW : FULL =Offset= CH1 : 0.000 V CH2 : 0.0 V CH3 : 0.00 V CH4 : 0.00 V =Record Length= Main : 100 K Zoom : 2K =Trigger= Mode : AUTO Type : EDGE CH2 Delay : 0.0 ns Hold off : 0.2 µs Figure 6 (5) Others. The HF waveform is normal and the time is displayed normally, but no sound is produced. Or the sound has dropouts. Is pin 69 (C2F) on IC1 “L” ? No Yes 1. When playing at normal speed. Check the peripheral circuit at pin 39 (DOUT) on IC1 and the waveform (Figure 7). There are too many error flags on a damaged disc which makes error correction impossible. Check again using a known good disc. If OK, Check the unit. Stopped CH1=2 V DC 10:1 T 1999/04/07 09:25:28 500 ns/div (500 ns/div) NORM:200 MS/s T 1 DOUT =Filter= Smoothing : ON BW : FULL =Offset= CH1 : 0.00 V CH2 : 0.00 V CH3 : 0.00 V CH4 : 0.00 V =Record Length= Main : 1K Zoom : 100 Figure 7 7–4 =Trigger= Mode : NORMAL Type : EDGE CH1 Delay : 2.887 ms Hold off : 0.2 µs CD-G10000/CP-G10000S Service Audio E Market CD-G10000/CP-G10000S Manual 8. OTHERS CHAPTER [1] Function table of IC IC1 VHiLC78648E-1: CD Servo (LC78648E) (1/2) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12* 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29* Terminal Name AVDD1 SLCO EFMIN RF LPF JITTC AIN CIN BIN DIN FEC PHLPF/RFMON VREF EIN FIN TEC TE TEIN LDD LDS FDO TDO SLDO SPDO AVSS2 AVDD2 DVDD DVSS VPB Input/Output Output Output Input Output Output Input Input Input Input Input Output Output Output Input Input Output Output Input Output Input Output Output Output Output — — — — Output Setting in Reset — — — — — — — — — — 30* 31* DEFECT FSEQ Output Output L L 32 33* EFLG FSX Output Output L L 34 CONT1 Input/Output Input 35 CONT2 Input/Output Input 36 CONT3 Input/Output Input 37* MONI1 Input/Output Input 38* 39* 40 41 42 43 MONI2 DOUT TEST LVDD LCHO LRVSS Output Output Input — Output — L L L — LVDD/2 — ZHI AVDD1/2 — — — — — ADAVDD/2 ADAVDD/2 ADAVDD/2 ADAVDD/2 — — — — H Function Analog power supply pin 1. slice level con- Slice level Control output pin. trol. RF signal input pin. RF signal Output pin. RF signal DC level detection LPF capacitor connection pin. Jitter detection capacitor connection pin. A signal input pin. C signal input pin. B signal input pin. D signal input pin. FE signal LPF capacitor connection pin. Reference supply setting terminal. VREF voltage output pin. E signal input pin. F signal input pin. TE signal LPF capacitor connection pin. TE signal output pin. TES signal generation TE signal input pin Laser power control signal output pin. Laser power control signal input pin. Focus control output pin. D/A output. Tracking control output pin. D/A output. Thread control output pin. D/A output. Spindle control output pin. D/A output. Analog GND pin 2. Must always be connected to 0 V. Analog power supply pin 2. Digital power supply pin. Digital GND pin 2. Must always be connected to 0 V. Rough servo/phase control automatic switching monitor output pin.“H” for rough servo and “L” for phase servo. Defect signal output pin. Synchronization signal detection output pin. Outputs a high level when the Synchronization signal detection from the EFM signal and the internally generated Synchronization signal agree. C1, C2 error correction monitor pin 7.35 kHz Synchronization signal output pin. CLV playback mode. General purControlled by command from the microprocessor. Any of these pose I/O pin 1. that are unused must be either set up as input pin ports and connected to 0 V, or set up as output pin ports and left open. General purpose I/O pin 2. General purpose I/O pin 3. External deiemphasis setting pin, INternal signal monitor pin 1. Controlled by microprocessor. Internal signal monitor pin 2. Digital OUT output Pin. (EIAJ format) Test input pin. Must always be connected to 0 V. L channel Power supply pin. Left channel D/A converter L channel output supply pin. LR channel GND pin. Must always be connected to 0 V. In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. 8–1 CD-G10000/CP-G10000S IC1 VHiLC78648E-1: CD Servo (LC78648E) (2/2) Pin No. 44 45 46 47 48 Terminal Name RCHO RVDD XVSS XOUT XIN Input/Output Output — — Output Input Setting in Reset RVDD /2 — — Oscillator Oscillator 49 50 XVDD IOMODE — Input — — 51 52* 53 F16MIN OUT1 16MOUT Input Output Output 54 ASLRCK Input — L CLK Output — 55 ASDACK Input — 56 ASDFIN Input — 57 58 59 60 61 62 63 64 65 66 67 LRSK DATACK DATA DVDD DVSS CE CL DI DO WRQB RESB Output Output Output — — Input Input Input Output Output Input L L L — — — — — (H) L — 68 69 DRF C2F/SBCK Output Input/Output L Input 70 CONT6/SBCK Input/Output Input 71* 72* 73 74 MONI5 MONI4 MONI3 CONT5 Output Output Output Input/Output L L L Input 75 CONT4 Input/Output Input 76 77 78 PDO1 PDO2 PCKIST Output Output Input — — — 79 80 VVSS VVDD — — — — Function Right channel R channel Power supply pin. D/A converter R channel output supply pin. Digital GND pin. Must always be connected to 0 V Power supply for crystal oscillator. Crystal Connected for a 16.9344 MHz crystal oscillator pin. oscillator Digital power supply pin. Must always be connected to 0 V CONT4 to 6. MONI3~5, DRF, WRQB pin output mode switching input pin. ”L” setting: Normal output “H” setting: Nch open drain output DF. DAC external clock input pin. General-purpose output pin 1. 16.9344 MHz output port. Left/Right clock input pin. (Must be connect to 0 V when unused.) Bit clock input pin. Anti-shock (Must be connect to 0 V when unused.) Left/Right channel data input pin. (Must be connect to 0 V when unused.) Left/Right channel data output pin. Digital data Bit clock output pin. output Left/Right clock output pin. Digital power supply pin. Digital GND pin 2. Must always be connected to 0V. Chip enable signal input pin. Data transfer clock input pin. Microcomputer Interface Data output pin. Data output pin. (Try state output.) Interruption signal output pin. Reset input pin for LSI. This pin must be set LOW briefly after power is first applied. Focus ON detection pin. Error flag monitor pin, or sub Controlled by commands from the microprocode read clock input pin. cessor. General-purpose I/O pin 6, or Controlled by commands from the microprosub code read clock input pin. cessor. Any of these that are unused must be either set up as input pin ports and connected to 0 V, or set up as output pin ports and left open. Internal signal monitor pin 5. Internal signal monitor pin 4. Internal signal monitor pin 3. General purControlled by command from the microprocessor. Any of pose I/O pin 5. these that are unused must be either set up as input pin ports and connected to 0 V, or set up as output pin ports and left General purpose I/O pin 4. open when unused. PLL Phase comparison output pin 1 to control built-in VCO. Phase comparison output pin 2 to control built-in VCO. Resistor connection pin to set current for PDO1 and 02 outputs. Built-in VCO GND pin. Must always be connected to 0 V. Built-in VCO power supply pin. In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. The same potential must be supplied to all power supply pins, i, e., AVDD1, AVDD2, XVDD, DVDD, LVDD and RVDD) 8–2 CD-G10000/CP-G10000S VVDD VVSS PCKIST PD02 PD01 CONT4 CONT5 MONI3 MONI4 MONI5 CONT6/SBCK C2F/SBCK DRF *RES *WRQ DO DI CL CE DVSS IC1 VHiLC78648E-1: CD Servo (LC78648E) 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 AVDD1 1 60 DVDD SLCO 2 59 DATA EFMIN 3 58 DATACK RF 4 57 LRSY LPF 5 56 ASDFIN JITTC 6 55 ASDACK AIN 7 54 ASLRCK CIN 8 53 F16MOUT BIN 9 52 OUT1 DIN 10 51 F16MIN LC78648E FEC 11 50 IOMODE PHLPF/RFMON 12 49 XVDD VREF 13 48 XIN EIN 14 47 XOUT FIN 15 46 XVSS TEC 16 45 RVDD TE 17 44 RCHO PHLPF/RFMON VREF 29 30 31 32 33 34 35 36 37 38 39 40 DVSS VPB FSEQ EFLG CONT1 CONT2 MONI1 MONI2 TEST MONITOR VREF A/D LDD LDS LPF RF AIN CIN BIN DIN DOUT 28 CONT3 26 27 FSX 25 DEFECT 24 DVDD 23 AVDD2 22 AVSS 21 SPDO 41 LVDD SLDO 42 LCHO LDS 20 TDO 43 LRVSS LDD 19 FDO TEIN 18 A/D SERVO PROCESSOR APC RF SIGNAL PROCESSOR AUTO ADJUST RAM TRACK JUMP RUPTURE DEFECT CLV CAV CONTROL DRF FDO TDO SPDO SLDO AVDD1 AVSS AVDD2 DEFECT FEC EIN FIN TEC TE TEIN FOCUS ERROR PROCESSOR TRACKING ERROR PROCESSOR VPB CPU I/F JITTC SLCO EFMIN PDO1 PDO2 PCKIST VVDD VVSS XVDD XVSS XIN XOUT F16MIN F16MOUT ASLRCK ASDACK ASDFIN RVDD RCHO LRVSS LCHO LVDD JITTER/DETECT PORT SLICE LEVEL CONTROL FRAME SYNC DETECT,PROTECT, INSERT, EFM DECODE PLL RAM CLOCK GENERATOR EXTERNAL AUDIO IN DRF CONT1~6 OUT1 FSEQ FSX EFLG C2F ERROR CORRECTION INTERPOLATION MUTE CL CE DI DO WRQB MONITOR SIGNAL SELECTOR ATTENUATION SUBCODE DECODE CRC & TEXT 8FS DIGITAL FILTER DEEMPHASIS AUDIO OUT LPF 1bit DAC SERIAL OUT MONI1~5 DOUT LRSY DATACK DATA DVDD DVDD DVSS RESB TEST IOMODE DVSS Figure 8-3 BLOCK DIAGRAM OF IC 8–3 CD-G10000/CP-G10000S IC2 VHILA6261//-1: Focus/Tracking/Spin/Sled Driver (LA6261) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12* 13 14* 15 16* 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 Terminal Name VO3+ VO3VO2+ VO2VO1+ VO1PGND1 REGIN PVCC1 REGOUT VIN1 VIN1G VIN2 VIN2G VIN3 VIN3G VIN4 VIN4G FWD5 REV5 VCONT5 FWD6 REV6 VCONT6 VREFIN SGND SVCC PVCC2 MUTE PGND2 VO6+ VO6VO5+ VO5VO4+ VO4- Function BTL Output pin (+) for channel 3. BTL Output pin (-) for channel 3. BTL Output pin (+) for channel 2. BTL Output pin (-) for channel 2. BTL Output pin (+) for channel 1. BTL Output pin (-) for channel 1. Power GND for channels 1,2,3 and 4 (BTL). Regulator pin (External PNP base). Power for channels 1,2,3 and 4 (BTL). (SVCC short-crircuited) Regulator pin (External PNP collector). Input pin for channel 1 Input pin for channel 1 (for gain control) Input pin for channel 2 Input pin for channel 2 (for gain control) Input pin for channel 3 Input pin for channel 3 (for gain control) Input pin for channel 4 Input pin for channel 4 (for gain control) CH5 Output change pin (FWD). Logic input for bridge. CH5 Output change pin (REV). Logic input for bridge. Input pin for CH5 output voltage control CH6 Output change pin (FWD). Logic input for bridge. CH6 Output change pin (REV). Logic input for bridge. Input pin for CH5 output voltage control. Reference voltage input pin. Signal system GND Signal system power (PVCC1 short - circuited) Power for channel 5 and 6 (H bridge). Input pin for BTL mute. Power GND for channels 5 and 6 (H bridge). H bridge Output pin (+) for channel 6. H bridge Output pin (-) for channel 6. H bridge Output pin (+) for channel 5. H bridge Output pin (-) for channel 5. BTL Output pin (+) for channel 4. BTL Output pin (-) for channel 4. In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. * Set power system GND to the minimum potential together with SGND * Short-circuit three pins of power system SVSS and PVCC1 externally before use. 8–4 CD-G10000/CP-G10000S IC2 VHILA6261//-1: Focus/Tracking/Spin/Sled Driver (LA6261) 1 + - + - CH3 36 CH4 35 2 + - + - 3 34 4 33 + - 32 Pre Drive 5 CH2 6 + - 7 8 31 CH5 30 29 Pre Drive + - 9 CH1 28 CH6 + VOLTAGE CONTROL AMP + - BTL 10 22k 11 22k 1k 16 17 18 + DUFFER AMP For 1/2 VCC DUFFER AMP For VREF 11k Reference voltage + 22k + Band gad 1k Figure 8-5 BLOCK DIAGRAM OF IC 8–5 25 24 23 22 21 TSD 1k 11k Mode select 22k 1k 15 + - 11k 13 14 26 Mode select 12 27 + + - 11k 20 19 CD-G10000/CP-G10000S IC601 VHiLC75341/-1: Audio Processor (LC75341) VSS LOUT 5 LBASS 6 LTRE 7 8 9-12 LIN LSEL0 L4-1 20 RBASS 21 ROUT 22 VREF 23 24 VDD CLK LOUT 3 4 Terminal Name R1-4 RSEL0 RIN RTRE LBASS CE Pin No. 13-16 17 18 19 LTRE 2 Function Serial data and clock input pin for control. Chip enable pin. Data written into an internal latch in a timing of "H" to "L". Each analog switch is activated. Data transfer enabled at "H" level. Ground pin. Bass band filter comprising capacitor and resistor connection pin and bass/treble output pin. Bass band filter comprising capacitor and resistor connection pin. Treble band filter comprising capacitor and resistor connection pin. Volume + equalizer output pin. Input selector output pin. Input signal pin. LIN Terminal Name DI LSEL0 Pin No. 1 8 7 6 5 4 Function Input signal pin. Input selector output pin. Volume + equalizer output pin Treble band filter comprising capacitor and resistor connection pin. Bass band filter comprising capacitor and resistor connection pin. Bass band filter comprising capacitor and resistor connection pin and bass/ treble output pin. 0.5x VDD voltage generation block for analog ground. Capacitor of several 10µF to be connected between VREF and AWSS (VSS) as a countermeasure against power ripple. Supply pin Serial data and clock input pin for control. L4 9 CD L3 10 L2 11 L1 12 Tuner Tape CONTROL CIRCUIT Video CONTROL CIRCUIT R1 13 LVref 2 CE CCB INTERFACE 1 DI 24 CLK CONTROL CIRCUIT R2 14 3 VSS RVref RSEL0 17 18 19 20 21 ROUT 22 VREF RBASS R4 16 RTRE 23 VDD RIN R3 15 Figure 8-6 BLOCK DIAGRAM OF IC 8–6 CD-G10000/CP-G10000S IC701 RH-iXA054AWZZ: System Microcomputer (IXA054AW) (1/2) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14* 15 16 17 18 19 20 21 22 23 24 25 26 27* 28 29 30 31-33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49* 50* 51* 52* 53 54 55 56 57 58-68 69 70 71 72 Port Name VDD P37 P36 P35 P34 P33 P32 P31 P30 RESET X2 X1 IC(VPP) XT2 P04 VDD P27 P26 P25 P24 P23 P22 P21 P20 AVSS ANI7 ANI6 ANI5 ANI4 ANI3 ANI2-ANI0 AVDD AVREF INTP3 P02 INTP1 INTP0 VSS P74 P73 P72 P71 P70 VDD P127 P126 P125 P124 P123 P122 P121 P120 P117 P116 P115 FIP41-FIP31 P101/FIP30 P100/FIP29 P97/FIP28 P96/FIP27 Terminal Name VDD -20dBATT T BIAS T_REC/PLAY T_T1/T2 CD RESOUT CD_WRQ SUB CE ILLU LED RESET XOUT XIN VPP NO USE CD_DRF VDD CLK DI DO CE CD CE CD CLK CD DI CD DO AVSS T RUN PULS TUN SM T_FP SW PROTECT VOL JOG KEY 2-KEY 0 AVDD AVREF P_IN PHOTO SP DET REMOCON VSS S MUTE TIMER LED T_SOL B T_MOTOR T_SOL A VDD SP RLY AC RLY NS SW3 NO USE NS SW1 NO USE TRAY SW2 TRAY SW1 DISC SW CLAMP SW DIST S30-S20 S19/DEST0 S18/DEST1 S17/DEST2 S16/DEST3 Input/Output Input Output Output Output Output Output Input Output Output Input Output Input — — Input Input Output Output Input Output Output Output Output Input — Input Input Input Input Input Input Input Input Input Input Input Input — Output Output Output Output Output Input Output Output Output Output Output Output Input Input Input Input Input Output Input Output Output Output Function (+) Power supply 5 V. -20dB Attenuator. Tape record bias control. Tape REC/PLAY control. Tape T1/T2 Control. CD Reset. CD WRQ input. MP3 Sub-micom CE. FL Edge light control. Reset Input. Main clock output 4.19 MHz. Main clock input 4.19 MHz. GND Open CD DRF detect. (+) Power supply 5 V. Clock output. Data output. Data input. CE Output. CD Chip enable. CD Clock. CD Data output. CD Data input. Analog ground. Tape T1/T2 Run Pulse detect. Connect to GND. Tape Fool Proof A & B SW. Power abnormal detect. Volume jog input. Key input. Analog power supply 5 V. Analog reference voltage 5 V. Power failure detect. 5-Changer Photo SW. Speaker abnormal detect. Remocon input. Ground voltage. System mute control. Timer LED control. Tape 2 solenoid control. Tape motor control. Tape 1 solenoid control. (+) Power supply 5 V. Speaker relay control. AC relay control. New sound mode SW3. Open. New sound mode SW1. Open. 5-Changer Tray SW2. 5-Changer Tray SW1. 5-Changer Disc SW. 5-Changer Clamp SW. Destination input. FL Segment driver. FL segment driver/Destination input. FL segment driver/Destination input. FL segment driver/Destination input. FL segment driver/Destination input. In this unit, the terminal with asterisk mark (*) is (open) terminal which is not connected to the outside. 8–7 CD-G10000/CP-G10000S IC701 RH-iXA054AWZZ: System Microcomputer (IXA054AW) (2/2) S5 S6 S7 S8 P84/FIP17 83 P85/FIP18 82 P86/FIP19 81 S3 S4 S2 S1 P81/FIP14 86 P82/FIP15 85 P83/FIP16 84 G12 FIP12 88 P80/FIP13 87 G11 FIP11 89 G10 G9 FIP9 91 FIP10 90 G7 G8 FIP7 93 FIP8 92 G4 G5 G6 G3 FIP3 97 FIP4 96 FIP5 95 FIP6 94 G2 VLOAD P36/BUZ P90/FIP21 78 S10 4 P35/PCL P91/FIP22 77 T_T1/T2 5 P34/T12 P92/FIP23 76 S11 S12 CD_RESOUT 6 P33/T11 P93/FIP24 75 S13 CD_WRQ 7 S14 8 P94/FIP25 P95/FIP26 74 SW_CE P32/TO2 P31/TO1 73 S15 ILL4_LED 9 P30/TO0 P96/FIP27 72 RESET 10 RESET P97/FIP28 71 XOUT 11 X2 P100/FIP29 70 XIN 12 X1 P101/FIP30 69 VPP 13 IC(VPP) P102/FIP31 68 S16 (DIST3) S17 (DIST2) S18 (DIST1) S19 (DIST0) S20 14 XT2 P103/FIP32 67 S21 CD_DRF 15 P04/XT1 P104/FIP33 66 S22 VDD 16 VDD P105/FIP34 65 S23 CLK 17 P27/SCK0 P106/FIP35 64 S24 DI 18 P26/SO0/SB1 P107/FIP36 63 S25 DO 19 P25/SI0/SB0 P110/FIP37 62 S26 CE 20 P24/BUSY P111/FIP38 61 CD_CE 21 P23/STB P112/FIP39 60 S27 S28 CD_CLK 22 P22/SCK1 P113/FIP40 59 29 CD_DI 23 P21/SO1 P114/FIP41 58 30 CD_DO 24 P20/SI1 P115/FIP42 57 DIST AVSS 25 AVSS P116/FIP43 56 CLAMP SW T_RUN PULS 26 P17/ANI7 P117/FIP44 55 DISC SW TUN_SM 27 P16/ANI6 P120/FIP45 54 TRAY SW1 T_FP SW 28 29 P121/FIP46 P122/FIP47 53 PROTECT P15/ANI5 P14/ANI4 52 TRAY SW2 NO USE VOL_JOG 30 P13/ANI3 P123/FIP48 51 NS_SW1 AVREF P03/INTP3 P02/INTP2 P01/INTP1 P00/INTPOT0 VSS P74 P73 P72 P70 VDD P127/FIPS2 P126/FIPS1 P125/FIPS0 P124/FIP49 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 AVREF P-IN PHOTO SP_DET REMOCON VSS S MUTE TIMER LED T_SOL B T MOTOR T_SOL A VDD SP_RLY AC_RLY NS_SW3 NO USE P71 AVDD 34 AVDD P10/ANI0 IXA054AW 33 T_REC/PLAY FIP2 98 S9 79 KEY0 3 G1 80 VLOAD P11/ANI1 T_BIAS Function FL segment driver. VLOAD -35 V FL segment driver. FL grid driver. P87/FIP20 P12/ANI2 P37 32 VDD 2 31 1 KEY1 VDD -20dBATT Input/Output Output Input Output Output FIP1 99 Terminal Name S15-S10 VLOAD S9-S1 G12-G1 FIP0 100 Port Name FIP26-FIP21 VLOAD FIP20-FIP11 FIP10-FIP0 KEY2 Pin No. 73-78 79 80-88 89-100 Figure 8-8 BLOCK DIAGRAM OF IC 8–8 CD-G10000/CP-G10000S IC851 VHIAN80T53/-1: Multi Regulator (AN80T53) Pin No. 1 2 3 4 5 6 7 Terminal Name Function REG4 Output REG3 Output VCC GND MODE 1 REG2 Output REG1 Output 5.1 V power supply with a minimum peak out current of 1200 mA. 13 V power supply with a minimum peak out current of 1350 mA. Connected to Power supplies. Connected to the IC substrate. REG1, REG2,REG3 and REG4 outputs are turned ON when this pin is 5 V. 10 V power supply with a minimum peak out current of 800 mA. 8.5 V power supply with a minimum peak out current of 700 mA. Peak Current Protection, Thermal Protection, Load Short Protection. Out puts + - + - Prc Drive + - Prc Drive + - Prc Drive Prc Drive Reference Voltage 5 MODE1 2 REG3 13V 3 4 1 7 6 VCC GND REG4 5.1V REG1 8.5V REG2 10.0V Figure 8-9 BLOCK DIAGRAM OF IC 8–9 CD-G10000/CP-G10000S [2] FL Display FL701 VVKNA12MM44-1 GRID ASSIGNMENT 1a 1a 2a 1a 2a 1a 2a 1a 1a 2a 2a 1a 2a 1a 1a col2 Dot2 2a 2a 1a 2a 2a col1 1G 2G 3G 4G 5G 6G 7G 8G 9G 10G 11G 12G D5a D5a D5b D5c a D4a D4a D4b h j k f D4c D1b D3c m e (2G~11G) D1a D1a n d D2c D2b c p r D2a D2a b g D3a D3a (1G) Dot1 D1c D1b ANODE CONNECTION 2G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c 1G P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 P16 P17 P18 P19 P20 P21 P22 P23 P24 P25 P26 P27 P28 P29 FOLDER TITLE-1 TITLE-2 TITLE-3 5 D5-a D5-b D5-c 4 D4-a D4-b D4-c 3 D3-a D3-b D3-c 2 D2-a D2-b D2-c 1 D1-a D1-b D1-c 3G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c 4G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c 5G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c 6G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c 7G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c 8G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c P30 51 OUTER DIMENSIONS 10G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c Col1 Col2 9G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c Dot1 Dot2 11G 1a 1b 1k 1j 1h 1f 1m 1d 1g 1p 1e 1n 1r 1c 2a 2b 2k 2j 2h 2f 2m 2d 2g 2p 2e 2n 2r 2c 12G TOTAL RDS TA PTY PTYI TP SLEEP DAILY (L) (R) REC ST ( ) MEMORY ( ) kHz MHz MP3 X-BASS 1 PATTERN AREA PIN CONNECTION PIN NO. 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 CONNECTION F2 F2 NP NP P30 P29 P28 P27 P26 P25 P24 P23 P22 P21 P20 P19 P18 P17 P16 P15 P14 P13 P12 P11 P10 P9 PIN NO. 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 CONNECTION P8 P7 P6 P5 P4 P3 P2 P1 12G 11G 10G 9G 8G 7G 6G 5G 4G 3G NX NX 2G 1G NP F1 8 – 10 1 F1 CD-G10000/CP-G10000S PARTS GUIDE No. S1506CDG10000 MINI COMPONENT SYSTEM MODEL CD-G10000 CD-G10000 Mini Component System consisting of CD-G10000 (main unit) and GBOXSA090AWM1 (rear speaker system). CONTENTS [1] INTEGRATED CIRCUITS [12] CD MECHANISM PARTS [2] TRANSISTORS [13] CHANGER MECHANISM PARTS [3] DIODES [14] CABINET PARTS [4] FILTERS [5] TRANSFORMERS [15] SURROUND SPEAKER BOX PARTS [6] COILS [16] PACKING PARTS [7] VARIABLE CAPACITORS [17] ACCESSORIES [8] VIBRATORS [18] P.W.B. ASSEMBLY (Not Replacement Item) [9] CAPACITORS [10] RESISTORS [11] OTHER CIRCUITRY PARTS [19] OTHER SERVICE PART „ INDEX Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the safety and performance of the set. SHARP CORPORATION This document has been published to be used for after sales service only. The contents are subject to change without notice. CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [1] INTEGRATED CIRCUITS IC1 IC2 IC3 IC4 IC5 IC6 IC101 IC301 IC302 IC303 IC601 IC701 IC851 IC852 IC854 IC901 VHILC78648E-1 VHILA6261//-1 VHILC78684E-1 VHILV1625635T RH-IXA006AWZZ VHISI3033LUS1 VHIAN7345K/-1 VHITA7358AP-1 VHILC72131/-1 VHILA1832S/-1 VHILC75341/-1 RH-IXA054AWZZ VHIAN80T53/-1 VHIKIA7805AP1 VHIAN78L05/-1 VHISTK41244-1 AW AN AZ AT AT AG AM AG AP AN AM AV AL AF AE BF CD Servo,LC78648E Focus/Tracking/Spin/Sled Driver,LA6261 MP3 Decoder,LC78684E D-RAM,LV6125635T Microcomputer,IXA006AW Voltage Regulator,SI3033LUS1 Playback and Record/Playback Amp.,AN7345K FM Front End,TA7358AP PLL (Tuner),LC72131 FM IF Det./FM Mpx./AM IF,LA1832S Audio Processor,LC75341 System Microcomputer,IXA054AW Multi Regulator,AN80T53 Voltage Regulator,KIA7805AP Voltage Regulator,AN78L05 Power Amp.,STK41244 AB AC AC AC AC AB AC AC AC AC AB AB AB AB AB AC AC AB AC AC AD AB AC AC AB AB AB AB AE AE AE AB AB AB AC AC AC AB AC AB AE AB AB AB AB AB AB AB AB AC AC Silicon,PNP,KTA1504 Y Silicon,PNP,KTA1271 Y Silicon,NPN,2SD601 AR Silicon,NPN,2SD601 AR Silicon,NPN,2SD601 AR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3200 GR Silicon,NPN,KTC3200 GR Silicon,NPN,KTC3200 GR Silicon,NPN,KTC3200 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,PNP,KTA1504 Y Digital,NPN,KRC104 S Silicon,NPN,KTC3203 Y Silicon,PNP,KTA1504 Y Digital,NPN,KRC104 S Digital,NPN,KRC104 S Silicon,NPN,KTC3194 Y Silicon,PNP,KTA1266 GR Silicon,NPN,KTC2875 B Silicon,NPN,KTC2875 B Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Digital,NPN,KRA107 S Digital,NPN,KRA107 S Silicon,PNP,KTA1273 Y Silicon,PNP,KTA1273 Y Silicon,PNP,KTA1273 Y Digital,NPN,KRC102 S Digital,NPN,KRC102 S Digital,NPN,KRA107 S Digital,NPN,KRC104 S Digital,NPN,KRC104 S Digital,NPN,KRC104 S Digital,NPN,KRA107 S Digital,NPN,KRC104 S Digital,NPN,KRA107 S Silicon,PNP,KTA1274 Y Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3875 GR Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3203 Y Silicon,NPN,KTC3203 Y AB AB AB AB AB AB AB AB AB AB AB AB AB AB Silicon,KDS184 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 [2] TRANSISTORS Q1 Q2 Q3 Q4 Q5 Q6 Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q113 Q114 Q302 Q360 Q601 Q602 Q603 Q604 Q607 Q608 Q706 Q707 Q708 Q709 Q710 Q711 Q712 Q713 Q714 Q715 Q716 Q717 Q801 Q841 Q885 Q886 Q901 Q902 Q903 Q904 Q905 Q906 Q907 VSKTA1504Y/-1 VSKTA1271Y/-1 VS2SD601AR/-1 VS2SD601AR/-1 VS2SD601AR/-1 VSKTC3875GR-1 VSKTC3200GR-1 VSKTC3200GR-1 VSKTC3200GR-1 VSKTC3200GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTA1504Y/-1 VSKRC104S//-1 VSKTC3203Y/-1 VSKTA1504Y/-1 VSKRC104S//-1 VSKRC104S//-1 VSKTC3194Y/-1 VSKTA1266GR-1 VSKTC2875B/-1 VSKTC2875B/-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKRA107S//-1 VSKRA107S//-1 VSKTA1273Y/-1 VSKTA1273Y/-1 VSKTA1273Y/-1 VSKRC102S//-1 VSKRC102S//-1 VSKRA107S//-1 VSKRC104S//-1 VSKRC104S//-1 VSKRC104S//-1 VSKRA107S//-1 VSKRC104S//-1 VSKRA107S//-1 VSKTA1274Y/-1 VSKTC3199GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3875GR-1 VSKTC3199GR-1 VSKTC3203Y/-1 VSKTC3203Y/-1 [3] DIODES D1 D301 D302 D305 D690 D691 D709 D710 D711 D712 D713 D714 D715 D716 VHDKDS184//-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 2 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [3] DIODES ! D801 D802 D803 D804 D805 D806 D842 D843 D844 D845 D846 D853 D856 D860 D861 D862 D863 D885 D905 D906 D907 D909 D910 D911 D912 LED701 LED703 ZD1 ZD351 ZD801 ZD802 ZD803 ZD805 ZD902 ZD903 VHDD10XB60F-1 VHDD10XB60F-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHD1N4004S/-1 VHDDS1SS133-1 VHD1N4004S/-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHDDS1SS133-1 VHD1N4004S/-1 VHD1N4004S/-1 VHDDS1SS133-1 VHDDS1SS133-1 VHP304VT2H3-1 VHPSDPB50CD-1 VHEMA8033//-1 VHEDZ5R1BSB-1 VHEDZ6R2BSA-1 VHEDZ7R5BSB-1 VHEDZ300BSB-1 VHEDZ120BSB-1 VHEDZ120BSB-1 VHEDZ120BSB-1 AL AL AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AC AK AC AC AB AB AB AB AB AB Silicon,D10XB60F Silicon,D10XB60F Silicon,1N4004S Silicon,1N4004S Silicon,1N4004S Silicon,1N4004S Silicon,1N4004S Silicon,1N4004S Silicon,1N4004S Silicon,1N4004S Silicon,DS1SS133 Silicon,1N4004S Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,DS1SS133 Silicon,1N4004S Silicon,1N4004S Silicon,DS1SS133 Silicon,DS1SS133 LED,Red,304VT2H3 LED,Blue,SDPB50CD Zener,3.3V,MA8033 Zener,5.1V,DZ5.1BSB Zener,6.2V,DZ6.2BSA Zener,7.5V,DZ7.5BSB Zener,30V,DZ30BSB Zener,12V,DZ12BSB Zener,12V,DZ12BSB Zener,12V,DZ12BSB AE AD AK AE Band Pass Filter FM IF,10.7 MHz FM IF AM IF BL AL AB AE AD AD Power,Main Power,Sub FM OSC. FM IF AM Antenna AM OSC. AM IF AD AD AD AB AB AB AB AB AC AC AA AA 0.82 µ H 2.2 µ H 2.2 µ H 330 µ H,Choke FM RF 100 µ H,Choke 100 µ H,Choke 100 µ H,Choke 3 µ H,Choke 3 µ H,Choke 0.29 µ H 0.29 µ H AG AD AD Variable Capacitance,SVC347S Variable Capacitance,SVC230C Variable Capacitance,SVC230C AF AF AE AB AH Crystal,456 kHz Crystal,4.5 MHz Ceramic,16.9344 MHz Ceramic,4.19 MHz Crystal,4.19 MHz [4] FILTERS BF301 CF303 CF351 CF352 RFILR0008AWZZ RFILF0124AFZZ RFILF0003AWZZ RFILA0009AWZZ [5] TRANSFORMERS ! ! PT801 PT841 T301 T302 T303 T306 T351 RTRNP0518AWZZ RTRNP0483AWZZ RCILBA001AWZZ RCILI0017AWZZ RCILA0052AWZZ RCILB0067AWZZ RCILI0019AWZZ [6] COILS L1 L2 L3 L103 L312 L351 L352 L701 L901 L902 L920 L921 RCILC0011AWZZ RCILC0012AWZZ RCILC0012AWZZ VP-MK331K0000 RCILR0056AWZZ VP-DH101K0000 VP-DH101K0000 VP-DH101K0000 RCILZ0024AWZZ RCILZ0024AWZZ RCILZ0137AFZZ RCILZ0137AFZZ [7] VARIABLE CAPACITORS VD301 VD302 VD303 VHCSVC347S/-1 VHCSVC230C/-1 VHCSVC230C/-1 [8] VIBRATORS X351 X352 XL1 XL2 XL701 92LCRSTL1425A RCRSP0019AWZZ RCRM-0047AWZZ RCRM-0043AWZZ RCRSP0003AWZZ 3 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [9] CAPACITORS C1 C2 C3 C4 C5 C6 C8 C9 C10 C11 C12 C13 C14 C16 C17 C18 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C35 C36 C37 C38 C39 C41 C42 C44 C46 C47 C48 C50 C51 C52 C53 C56 C57 C58 C59 C60 C61 C62 C63 C64 C65 C66 C68 C69 C70 C71 C72 C73 C74 C75 C76 C82 C83 C84 C85 C86 C87 C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 VCEAZA1EW476M VCKYCY1CB103K VCEAZA1EW476M VCKYCY1HB102K VCKYCY1CB473K VCKYCY1CB103K VCKYCY1HB272K RC-EZ0004AWZZ VCKYCY1CB104K VCKYCY1CB563K VCCCCY1HH101J VCKYCY1EF223Z VCEAZA1AW476M VCKYCY1HB471K VCKYCY1EF223Z VCEAZA1AW107M VCEAZA0JW337M VCEAZA1EW106M VCEAZA1EW106M VCQYKA1HM152K VCQYKA1HM152K VCKYCY1CB103K VCKYCY1EF223Z VCCCCY1HH101J VCCCCY1HH101J VCKYCY1HB102K VCCCCY1HH101J VCKYCY1EF223Z VCCCCY1HH101J VCKYCY1CB563K VCKYCY1CB103K VCKYCY1CB473K VCKYCY1CF224Z VCKYCY1CB104K VCKYCY1CB103K VCKYCY1CB104K VCEAZA1AW107M VCCCCY1HH330J VCEAZA1AW107M VCKYCY1CB103K VCKYCY1CB103K VCKYCY1EF223Z VCEAZA1AW476M VCKYCY1CB103K VCKYCY1CB103K VCKYCY1CB103K VCEAZA1AW107M VCEAZA1AW107M VCEAZA1AW476M VCKYCY1CB104K VCKYCY1HB102K VCEAZA1AW107M VCKYCY1CB103K VCEAZA1HW105M VCCCCY1HH330J VCEAZA1AW476M VCKYCY1CB103K VCKYCY1CB103K VCEAZA1EW476M VCKYCY1CB103K VCKYCY1CB104K VCCCCY1HH101J VCCCCY1HH101J VCKYCY1HB102K VCKYCY1HB102K VCKYCY1CB103K VCKYCY1HB332K VCKYCY1HB102K VCKYCY1EF223Z VCTYBT1EF223Z VCTYBT1EF223Z VCKYCY1CB104K VCKYCY1HB561K VCKYCY1HB561K VCKYBT1HB181K VCCCCY1HH181J VCKYCY1HB152K VCKYCY1HB152K VCKYCY1HB331K VCKYCY1HB331K VCKYCY1HB331K VCKYCY1HB331K VCEAZA1EW476M VCEAZA1EW476M VCTYPA1EX393K 47 µ F,25V,Electrolytic 0.01 µ F,16V 47 µ F,25V,Electrolytic 0.001 µ F,50V 0.047 µ F,16V 0.01 µ F,16V 0.0027 µ F,50V 3.3 µ F,16V,Electrolytic 0.1 µ F,16V 0.056 µ F,16V 100 pF (CH),50V 0.022 µ F,25V 47 µ F,10V,Electrolytic 470 pF,50V 0.022 µ F,25V 100 µ F,10V,Electrolytic 330 µ F,6.3V,Electrolytic 10 µ F,25V,Electrolytic 10 µ F,25V,Electrolytic 0.0015 µ F,50V,Mylar 0.0015 µ F,50V,Mylar 0.01 µ F,16V 0.022 µ F,25V 100 pF (CH),50V 100 pF (CH),50V 0.001 µ F,50V 100 pF (CH),50V 0.022 µ F,25V 100 pF (CH),50V 0.056 µ F,16V 0.01 µ F,16V 0.047 µ F,16V 0.22 µ F,16V 0.1 µ F,16V 0.01 µ F,16V 0.1 µ F,16V 100 µ F,10V,Electrolytic 33 pF (CH),50V 100 µ F,10V,Electrolytic 0.01 µ F,16V 0.01 µ F,16V 0.022 µ F,25V 47 µ F,10V,Electrolytic 0.01 µ F,16V 0.01 µ F,16V 0.01 µ F,16V 100 µ F,10V,Electrolytic 100 µ F,10V,Electrolytic 47 µ F,10V,Electrolytic 0.1 µ F,16V 0.001 µ F,50V 100 µ F,10V,Electrolytic 0.01 µ F,16V 1 µ F,50V,Electrolytic 33 pF (CH),50V 47 µ F,10V,Electrolytic 0.01 µ F,16V 0.01 µ F,16V 47 µ F,25V,Electrolytic 0.01 µ F,16V 0.1 µ F,16V 100 pF (CH),50V 100 pF (CH),50V 0.001 µ F,50V 0.001 µ F,50V 0.01 µ F,16V 0.0033 µ F,50V 0.001 µ F,50V 0.022 µ F,25V 0.022 µ F,25V 0.022 µ F,25V 0.1 µ F,16V 560 pF,50V 560 pF,50V 180 pF,50V 180 pF (CH),50V 0.0015 µ F,50V 0.0015 µ F,50V 330 pF,50V 330 pF,50V 330 pF,50V 330 pF,50V 47 µ F,25V,Electrolytic 47 µ F,25V,Electrolytic 0.039 µ F,25V AB AA AB AA AA AA AA AD AB AB AA AB AB AA AB AB AC AB AB AB AB AA AB AA AA AA AA AB AA AB AA AA AB AB AA AB AB AA AB AA AA AB AB AA AA AA AB AB AB AB AA AB AA AB AA AB AA AA AB AA AB AA AA AA AA AA AA AA AB AA AA AB AA AA AA AA AA AA AA AA AA AA AB AB AA 4 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [9] CAPACITORS C114 C115 C116 C117 C118 C119 C120 C121 C123 C124 C125 C126 C127 C128 C129 C130 C131 C132 C133 C134 C135 C137 C138 C139 C140 C141 C143 C150 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C313 C315 C316 C317 C318 C320 C323 C324 C330 C331 C332 C334 C335 C338 C342 C347 C350 C351 C352 C353 C354 C355 C356 C357 C358 C361 C362 C363 C364 C365 C366 C367 C368 C369 C370 C371 C372 C373 C374 C376 C377 C378 C379 C380 C381 C382 VCTYPA1EX393K VCKYCY1HB561K VCKYCY1HB561K VCEAZA1EW476M VCEAZA1EW476M VCKYCY1HB222K VCKYCY1HB222K VCKYCY1EF223Z VCKYCY1HB271K VCKYCY1HB271K VCEAZA1HW226M VCEAZA1HW226M VCTYPA1CX223K VCTYPA1CX223K VCKYCY1HB332K VCKYCY1HB332K VCEAZA1EW476M VCEAZA1EW476M VCEAZA1EW226M VCEAZA1AW227M VCKYCY1EF223Z VCQYKA1HM473K VCQPKA2AA822J VCQYKA1HM393K VCEAZA1EW476M VCEAZA1CW107M VCEAZA1HW335M VCEAZA1HW476M VCKYCY1HB102K VCCCCY1HH100D VCKYCY1HB103K VCCCCY1HH4R7C VCKYCY1EF223Z VCEAZA1HW106M VCCCCY1HH4R7C VCKYCY1HB102K VCCCCY1HH150J VCCCCY1HH180J VCKYCY1EF223Z VCCCCY1HH220J VCKYCY1HB103K VCKYCY1EF223Z VCKYCY1HB102K VCKYBT1HB101K VCKYBT1HB102K VCKYCY1EF223Z VCCCCY1HH4R7C VCCCCY1HH150J VCKZPA1HF473Z VCKYCY1EF223Z VCCCCY1HH220J VCKYCY1HB561K VCKYCY1HB102K VCKYCY1EF223Z VCKYCY1EF223Z VCKYCY1EF223Z VCKYCY1EF223Z VCEAZA1HW106M VCKYCY1EF223Z VCKYCY1EF223Z VCCCCY1HH220J VCKYCY1HB102K VCEAZA1HW225M VCEAZA1HW105M VCKYCY1EF223Z VCEAZA1HW225M VCKYCY1EF223Z VCEAZA1HW225M VCTYPA1CX223K VCKYCY1HB102K VCEAZA1HW105M VCEAZA1HW105M VCCCCY1HH270J VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCTYPA1CX153K VCTYPA1CX153K VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCEAZA1HW106M VCCCCY1HH120J VCCCCY1HH150J 0.039 µ F,25V 560 pF,50V 560 pF,50V 47 µ F,25V,Electrolytic 47 µ F,25V,Electrolytic 0.0022 µ F,50V 0.0022 µ F,50V 0.022 µ F,25V 270 pF,50V 270 pF,50V 22 µ F,50V,Electrolytic 22 µ F,50V,Electrolytic 0.022 µ F,16V 0.022 µ F,16V 0.0033 µ F,50V 0.0033 µ F,50V 47 µ F,25V,Electrolytic 47 µ F,25V,Electrolytic 22 µ F,25V,Electrolytic 220 µ F,10V,Electrolytic 0.022 µ F,25V 0.047 µ F,50V,Mylar 0.0082 µ F,100V,Polypropylene 0.039 µ F,50V,Mylar 47 µ F,25V,Electrolytic 100 µ F,16V,Electrolytic 3.3 µ F,50V,Electrolytic 47 µ F,50V,Electrolytic 0.001 µ F,50V 10 pF (CH),50V 0.01 µ F,50V 4.7 pF (CH),50V 0.022 µ F,25V 10 µ F,50V,Electrolytic 4.7 pF (CH),50V 0.001 µ F,50V 15 pF (CH),50V 18 pF (CH),50V 0.022 µ F,25V 22 pF (CH),50V 0.01 µ F,50V 0.022 µ F,25V 0.001 µ F,50V 100 pF,50V 0.001 µ F,50V 0.022 µ F,25V 4.7 pF (CH),50V 15 pF (CH),50V 0.047 µ F,50V 0.022 µ F,25V 22 pF (CH),50V 560 pF,50V 0.001 µ F,50V 0.022 µ F,25V 0.022 µ F,25V 0.022 µ F,25V 0.022 µ F,25V 10 µ F,50V,Electrolytic 0.022 µ F,25V 0.022 µ F,25V 22 pF (CH),50V 0.001 µ F,50V 2.2 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 0.022 µ F,25V 2.2 µ F,50V,Electrolytic 0.022 µ F,25V 2.2 µ F,50V,Electrolytic 0.022 µ F,16V 0.001 µ F,50V 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 27 pF (CH),50V 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 0.015 µ F,16V 0.015 µ F,16V 100 pF (CH),50V 100 pF (CH),50V 100 pF (CH),50V 100 pF (CH),50V 10 µ F,50V,Electrolytic 12 pF (CH),50V 15 pF (CH),50V AA AA AA AB AB AA AA AB AA AA AB AB AA AA AA AA AB AB AB AC AB AB AA AB AB AC AB AB AA AA AA AA AB AB AA AA AA AA AB AA AA AB AA AA AA AB AA AA AA AB AA AA AA AB AB AB AB AB AB AB AA AA AB AB AB AB AB AB AA AA AB AB AA AB AB AB AA AA AA AA AA AA AB AA AA 5 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [9] CAPACITORS ! C383 C384 C385 C386 C387 C388 C389 C391 C392 C393 C394 C395 C396 C397 C398 C399 C601 C602 C603 C605 C606 C607 C608 C609 C610 C611 C612 C613 C614 C615 C616 C617 C618 C619 C620 C621 C622 C623 C624 C625 C626 C639 C640 C651 C652 C653 C690 C691 C693 C694 C695 C696 C701 C702 C704 C705 C707 C709 C710 C714 C715 C717 C720 C721 C722 C723 C727 C730 C732 C801 C802 C803 C804 C805 C806 C807 C808 C809 C810 C811 C817 C841 C842 C843 C844 VCCSBT1HL470J VCKYCY1HB102K VCKYCY1HB103K VCKYCY1HB331K VCKYCY1EF223Z VCKYCY1HB102K VCKYBT1HB102K VCEAZA1EW476M VCKYCY1HB102K VCEAZA1HW105M VCEAZA1EW476M VCKYCY1EF223Z VCEAZA1AW107M VCKYCY1EF223Z VCEAZA1AW107M VCKYCY1EF223Z VCEAZA1CW227M VCKYPA1HF223Z VCEAZA1AW227M VCFYFA1HA184J VCFYFA1HA184J VCFYFA1HA224J VCFYFA1HA224J VCEAZA1HW105M VCEAZA1HW105M VCKYCY1HB272K VCKYCY1HB272K VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW475M VCEAZA1HW475M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCEAZA1HW105M VCKYCY1HB222K VCKYCY1HB222K VCEAZA1HW105M VCEAZA1HW226M VCKYCY1HB221K VCKYCY1HB221K VCKYCY1HB221K VCKYPA1HB391K VCKYPA1HB391K VCKYCY1HB103K VCKYPA1HB102K VCKYPA1HB102K VCKYPA1HB103K VCEAZA1HW105M VCEAZA1AW227M VCCCCY1HH150J VCCCCY1HH180J VCEAZA1HW105M VCKYCY1HB473K VCKYCY1HB473K VCEAZA1HW335M VCKYCY1HB103K VCEAZA1EW476M VCKYCY1EF223Z VCKYCY1EF223Z VCKYCY1HF103Z VCKYCY1EF473Z VCKYCY1EF473Z VCKYCY1EF473Z VCKYCY1EF473Z VCEAZA1VW107M VCEAZA1HW476M VCEAZA1HW476M VCEAZA1JW227M VCEAZA2AW226M VCQYKA1HM104K VCQYKA1HM104K VCQYKA1HM104K VCQYKA1HM104K VCFYDA2AA224J VCFYDA2AA224J VCEAZA1EW226M VCEAZA0JW108M VCEAZA1VW477M VCQYKA1HM473K RC-KZ002LAWZZ 47 pF,50V 0.001 µ F,50V 0.01 µ F,50V 330 pF,50V 0.022 µ F,25V 0.001 µ F,50V 0.001 µ F,50V 47 µ F,25V,Electrolytic 0.001 µ F,50V 1 µ F,50V,Electrolytic 47 µ F,25V,Electrolytic 0.022 µ F,25V 100 µ F,10V,Electrolytic 0.022 µ F,25V 100 µ F,10V,Electrolytic 0.022 µ F,25V 220 µ F,16V,Electrolytic 0.022 µ F,50V 220 µ F,10V,Electrolytic 0.18 µ F,50V,Thin Film 0.18 µ F,50V,Thin Film 0.22 µ F,50V,Thin Film 0.22 µ F,50V,Thin Film 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 0.0027 µ F,50V 0.0027 µ F,50V 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 4.7 µ F,50V,Electrolytic 4.7 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 0.0022 µ F,50V 0.0022 µ F,50V 1 µ F,50V,Electrolytic 22 µ F,50V,Electrolytic 220 pF,50V 220 pF,50V 220 pF,50V 390 pF,50V 390 pF,50V 0.01 µ F,50V 0.001 µ F,50V 0.001 µ F,50V 0.01 µ F,50V 1 µ F,50V,Electrolytic 220 µ F,10V,Electrolytic 15 pF (CH),50V 18 pF (CH),50V 1 µ F,50V,Electrolytic 0.047 µ F,50V 0.047 µ F,50V 3.3 µ F,50V,Electrolytic 0.01 µ F,50V 47 µ F,25V,Electrolytic 0.022 µ F,25V 0.022 µ F,25V 0.01 µ F,50V 0.047 µ F,25V 0.047 µ F,25V 0.047 µ F,25V 0.047 µ F,25V 100 µ F,35V,Electrolytic 47 µ F,50V,Electrolytic 47 µ F,50V,Electrolytic 220 µ F,63V,Electrolytic 22 µ F,100V,Electrolytic 0.1 µ F,50V,Mylar 0.1 µ F,50V,Mylar 0.1 µ F,50V,Mylar 0.1 µ F,50V,Mylar 0.22 µ F,100V,Thin Film 0.22 µ F,100V,Thin Film 22 µ F,25V,Electrolytic 1000 µ F,6.3V,Electrolytic 470 µ F,35V,Electrolytic 0.047 µ F,50V,Mylar 0.0047 µ F,250V,Ceramic AA AA AA AA AB AA AA AB AA AB AB AB AB AB AB AB AC AB AC AC AC AC AC AB AB AA AA AB AB AB AB AB AB AB AB AB AB AB AB AA AA AB AB AA AA AA AA AA AA AA AA AA AB AC AA AA AB AB AB AB AA AB AB AB AB AB AB AB AB AC AB AB AD AC AB AB AB AB AD AD AB AC AD AB AC 6 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [9] CAPACITORS C850 C851 C852 C854 C855 C856 C859 C861 C864 C865 C885 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C912 C913 C914 C915 C916 C917 C918 C919 C920 C921 C922 C923 C925 C928 C929 C931 C946 C952 C960 C961 C962 J631 VCEAZW1EW478M VCQYKA1HM104K VCQYKA1HM104K VCEAZA1EW227M VCEAZA1HW106M VCQYKA1HM104K VCEAZA1HW226M VCKYPA1HF223Z VCEAZA1EW226M VCEAZA1EW226M VCKYCY1HB104K VCEAZA1HW224M VCEAZA1HW224M VCKYCY1HB102K VCKYCY1HB102K VCEAZA1HW475M VCEAZA1HW475M VCCCCY1HH101J VCCCCY1HH3R0C VCQYKA1HM104K VCCCCY1HH3R0C VCEAZA2AW107M VCEAZA2AW107M VCCCCY1HH101J VCEAZA2AW107M VCEAZA2AW107M VCEAZA1HW107M VCKYCY1HB103K VCEAZA1HW107M VCKYCY1HB103K RC-EZ0124AWZZ RC-EZ0065AWZZ RC-EZ0065AWZZ RC-EZ0124AWZZ VCEAZA1HW476M VCQYKA1HM104K VCQYKA1HM104K VCEAZA1HW106M VCEAZA1HW104M VCKYCY1HB103K VCEAZA1HW335M VCEAZA1HW226M VCEAZA1HW226M VCKYBT1HB103K AK AB AB AC AB AB AB AB AB AB AD AB AB AA AA AB AB AA AA AB AA AD AD AA AD AD AC AA AC AA AR AN AN AR AB AB AB AB AB AA AB AB AB AB 4700 µ F,25V,Electrolytic 0.1 µ F,50V,Mylar 0.1 µ F,50V,Mylar 220 µ F,25V,Electrolytic 10 µ F,50V,Electrolytic 0.1 µ F,50V,Mylar 22 µ F,50V,Electrolytic 0.022 µ F,50V 22 µ F,25V,Electrolytic 22 µ F,25V,Electrolytic 0.1 µ F,50V 0.22 µ F,50V,Electrolytic 0.22 µ F,50V,Electrolytic 0.001 µ F,50V 0.001 µ F,50V 4.7 µ F,50V,Electrolytic 4.7 µ F,50V,Electrolytic 100 pF (CH),50V 3 pF (CH),50V 0.1 µ F,50V,Mylar 3 pF (CH),50V 100 µ F,100V,Electrolytic 100 µ F,100V,Electrolytic 100 pF (CH),50V 100 µ F,100V,Electrolytic 100 µ F,100V,Electrolytic 100 µ F,50V,Electrolytic 0.01 µ F,50V 100 µ F,50V,Electrolytic 0.01 µ F,50V 3900 µ F,85V,Electrolytic 4700 µ F,50V,Electrolytic 4700 µ F,50V,Electrolytic 3900 µ F,85V,Electrolytic 47 µ F,50V,Electrolytic 0.1 µ F,50V,Mylar 0.1 µ F,50V,Mylar 10 µ F,50V,Electrolytic 0.1 µ F,50V,Electrolytic 0.01 µ F,50V 3.3 µ F,50V,Electrolytic 22 µ F,50V,Electrolytic 22 µ F,50V,Electrolytic 0.01 µ F,50V AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 33 kohms,1/16W 0 ohm,Jumper,0.8x1.55mm,Green 0 ohm,Jumper,0.8x1.55mm,Green 33 kohms,1/16W 47 ohms,1/16W [10] RESISTORS JP1 JP303 JP307 JP308 JP309 JP310 JP312 JP317 JP601 JP602 JP603 JP604 JP608 JP634 JP661 JP662 JP701 JP702 JP705 JP706 JP707 JP708 JP715 JP717 JP718 JP805 JP808 JP809 JP810 JP811 JP812 R1 R2 R3 R4 R5 R6 R7 VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB333J VRS-CY1JB000J VRS-CY1JB000J VRS-CY1JB333J VRS-CY1JB470J 7 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [10] RESISTORS R8 R9 R10 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R46 R47 R48 R49 R50 R52 R54 R55 R56 R57 R58 R59 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 R72 R73 R74 R75 R76 R77 R78 R79 R80 R81 R82 R83 R84 R85 R86 R87 R88 R89 R91 R92 R93 R94 R95 R96 VRS-CY1JB222J VRS-CY1JB100J VRS-CY1JB472J VRS-CY1JB331J VRS-CY1JB822J VRS-CY1JB682J VRS-CY1JB682J VRS-CY1JB682J VRS-CY1JB472J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB222J VRS-CY1JB222J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB101J VRS-CY1JB221J VRS-CY1JB151J VRS-CY1JB391J VRS-CY1JB391J VRS-CY1JB391J VRS-CY1JB391J VRS-CY1JB391J VRS-CY1JB391J VRS-CY1JB391J VRS-CY1JB391J VRS-CY1JB563J VRS-CY1JB681J VRS-CY1JB472J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB222J VRS-CY1JB681J VRS-CY1JB472J VRS-CY1JB562J VRS-CY1JB682J VRS-CY1JB472J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB222J VRS-CY1JB102J VRS-CY1JB222J VRS-CY1JB102J VRS-CY1JB222J VRS-CY1JB102J VRS-CY1JB222J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB104J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB222J VRS-CY1JB102J VRS-CY1JB222J VRS-CY1JB102J VRS-CY1JB221J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB472J VRS-CY1JB820J VRS-CY1JB332J VRS-CY1JB222J VRS-CY1JB151J VRS-CY1JB472J VRS-CY1JB222J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB472J VRD-ST2EE1R0J VRD-ST2EE1R0J VRS-CY1JB472J 2.2 kohms,1/16W 10 ohm,1/16W 4.7 kohms,1/16W 330 ohms,1/16W 8.2 kohms,1/16W 6.8 kohms,1/16W 6.8 kohms,1/16W 6.8 kohms,1/16W 4.7 kohms,1/16W 1 kohm,1/16W 1 kohm,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 2.2 kohms,1/16W 2.2 kohms,1/16W 10 kohm,1/16W 10 kohm,1/16W 100 ohm,1/16W 220 ohms,1/16W 150 ohms,1/16W 390 ohms,1/16W 390 ohms,1/16W 390 ohms,1/16W 390 ohms,1/16W 390 ohms,1/16W 390 ohms,1/16W 390 ohms,1/16W 390 ohms,1/16W 56 kohms,1/16W 680 ohms,1/16W 4.7 kohms,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 2.2 kohms,1/16W 680 ohms,1/16W 4.7 kohms,1/16W 5.6 kohms,1/16W 6.8 kohms,1/16W 4.7 kohms,1/16W 10 kohm,1/16W 10 kohm,1/16W 2.2 kohms,1/16W 1 kohm,1/16W 2.2 kohms,1/16W 1 kohm,1/16W 2.2 kohms,1/16W 1 kohm,1/16W 2.2 kohms,1/16W 1 kohm,1/16W 1 kohm,1/16W 100 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 2.2 kohms,1/16W 1 kohm,1/16W 2.2 kohms,1/16W 1 kohm,1/16W 220 ohms,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 4.7 kohms,1/16W 82 ohms,1/16W 3.3 kohms,1/16W 2.2 kohms,1/16W 150 ohms,1/16W 4.7 kohms,1/16W 2.2 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 10 kohm,1/16W 10 kohm,1/16W 4.7 kohms,1/16W 1 ohm,1/4W 1 ohm,1/4W 4.7 kohms,1/16W AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 8 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [10] RESISTORS R97 R98 R99 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R126 R127 R128 R129 R130 R131 R132 R133 R134 R135 R136 R137 R138 R139 R140 R141 R142 R143 R144 R145 R146 R147 R148 R149 R150 R158 R302 R309 R311 R313 R314 R316 R322 R323 R325 R327 R336 R350 R351 R352 R353 R355 R356 R357 R358 R359 R360 R365 R372 R373 R374 R375 R376 R377 R378 R379 R380 R381 VRS-CY1JB333J VRS-CY1JB271J VRS-CY1JB225J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB222J VRS-CY1JB222J VRS-CY1JB332J VRS-CY1JB332J VRS-CY1JB473J VRS-CY1JB473J VRS-CY1JB472J VRS-CY1JB472J VRD-ST2CD153J VRS-CY1JB153J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD560J VRD-ST2CD560J VRS-CY1JB104J VRS-CY1JB104J VRS-CY1JB392J VRS-CY1JB392J VRS-CY1JB183J VRS-CY1JB183J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB562J VRS-CY1JB562J VRS-CY1JB152J VRS-CY1JB152J VRS-CY1JB101J VRS-CY1JB101J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB224J VRS-CY1JB224J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB473J VRS-CY1JB472J VRD-RT2HD820J VRS-CY1JB473J VRS-CY1JB223J VRD-ST2CD4R7J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB472J VRD-ST2EE151J VRS-CY1JB683J VRD-ST2EE221J VRS-CY1JB100J VRD-ST2CD103J VRS-CY1JB104J VRS-CY1JB333J VRD-ST2CD220J VRS-CY1JB472J VRS-CY1JB681J VRS-CY1JB683J VRS-CY1JB473J VRS-CY1JB000J VRS-CY1JB103J VRS-CY1JB272J VRS-CY1JB562J VRS-CY1JB102J VRS-CY1JB271J VRS-CY1JB332J VRS-CY1JB102J VRS-CY1JB474J VRD-ST2CD332J VRS-CY1JB182J VRS-CY1JB472J VRS-CY1JB103J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRD-ST2CD471J VRS-CY1JB102J VRS-CY1JB473J VRS-CY1JB102J VRS-CY1JB222J VRS-CY1JB152J VRS-CY1JB103J 33 kohms,1/16W 270 ohms,1/16W 2.2 Mohms,1/16W 1 kohm,1/16W 1 kohm,1/16W 2.2 kohms,1/16W 2.2 kohms,1/16W 3.3 kohms,1/16W 3.3 kohms,1/16W 47 kohms,1/16W 47 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 15 kohms,1/6W 15 kohms,1/16W 1 kohm,1/6W 1 kohm,1/6W 56 ohms,1/6W 56 ohms,1/6W 100 kohm,1/16W 100 kohm,1/16W 3.9 kohms,1/16W 3.9 kohms,1/16W 18 kohms,1/16W 18 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 5.6 kohms,1/16W 5.6 kohms,1/16W 1.5 kohms,1/16W 1.5 kohms,1/16W 100 ohm,1/16W 100 ohm,1/16W 10 kohm,1/16W 10 kohm,1/16W 220 kohms,1/16W 220 kohms,1/16W 10 kohm,1/16W 10 kohm,1/16W 47 kohms,1/16W 4.7 kohms,1/16W 82 ohms,1/2W 47 kohms,1/16W 22 kohms,1/16W 4.7 ohms,1/6W 10 kohm,1/16W 10 kohm,1/16W 4.7 kohms,1/16W 150 ohms,1/4W 68 kohms,1/16W 220 ohms,1/4W 10 ohm,1/16W 10 kohm,1/6W 100 kohm,1/16W 33 kohms,1/16W 22 ohms,1/6W 4.7 kohms,1/16W 680 ohms,1/16W 68 kohms,1/16W 47 kohms,1/16W 0 ohm,Jumper,0.8x1.55mm,Green 10 kohm,1/16W 2.7 kohms,1/16W 5.6 kohms,1/16W 1 kohm,1/16W 270 ohms,1/16W 3.3 kohms,1/16W 1 kohm,1/16W 470 kohms,1/16W 3.3 kohms,1/6W 1.8 kohms,1/16W 4.7 kohms,1/16W 10 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 470 ohms,1/6W 1 kohm,1/16W 47 kohms,1/16W 1 kohm,1/16W 2.2 kohms,1/16W 1.5 kohms,1/16W 10 kohm,1/16W AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 9 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [10] RESISTORS R382 R383 R384 R385 R386 R387 R388 R391 R392 R393 R395 R573 R593 R601 R602 R603 R604 R605 R606 R607 R608 R609 R610 R611 R612 R613 R614 R615 R616 R617 R618 R619 R620 R621 R641 R642 R643 R644 R690 R691 R692 R693 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 R712 R713 R714 R715 R716 R717 R718 R719 R720 R721 R722 R723 R724 R725 R726 R727 R728 R729 R730 R731 R732 R733 R736 R739 R740 R741 R745 R746 R750 R751 R759 R761 VRD-ST2EE151J VRS-CY1JB562J VRD-ST2CD562J VRS-CY1JB562J VRD-ST2CD223J VRD-ST2CD562J VRS-CY1JB392J VRD-ST2EE271J VRD-ST2EE271J VRD-ST2CD102J VRS-CY1JB473J VRD-ST2CD103J VRS-CY1JB472J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB821J VRS-CY1JB821J VRS-CY1JB222J VRS-CY1JB222J VRS-CY1JB391J VRS-CY1JB391J VRS-CY1JB153J VRS-CY1JB153J VRS-CY1JB222J VRS-CY1JB222J VRD-ST2CD331J VRS-CY1JB331J VRS-CY1JB223J VRS-CY1JB223J VRS-CY1JB103J VRD-ST2CD103J VRS-CY1JB822J VRS-CY1JB822J VRD-ST2CD682J VRD-ST2CD682J VRD-ST2CD333J VRD-ST2CD333J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRD-ST2CD102J VRD-ST2CD102J VRS-CY1JB102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRD-ST2CD102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRD-ST2CD102J VRS-CY1JB102J VRD-ST2CD102J VRS-CY1JB222J VRS-CY1JB681J VRS-CY1JB681J VRD-ST2CD561J VRD-ST2CD102J VRS-CY1JB103J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB102J VRD-ST2CD102J VRD-ST2CD101J VRD-ST2CD102J VRD-ST2CD103J VRD-ST2CD102J VRD-ST2CD473J VRD-ST2CD331J VRD-ST2CD562J VRS-CY1JB103J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 150 ohms,1/4W 5.6 kohms,1/16W 5.6 kohms,1/6W 5.6 kohms,1/16W 22 kohms,1/6W 5.6 kohms,1/6W 3.9 kohms,1/16W 270 ohms,1/4W 270 ohms,1/4W 1 kohm,1/6W 47 kohms,1/16W 10 kohm,1/6W 4.7 kohms,1/16W 1 kohm,1/6W 1 kohm,1/6W 1 kohm,1/6W 10 kohm,1/16W 10 kohm,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 820 ohms,1/16W 820 ohms,1/16W 2.2 kohms,1/16W 2.2 kohms,1/16W 390 ohms,1/16W 390 ohms,1/16W 15 kohms,1/16W 15 kohms,1/16W 2.2 kohms,1/16W 2.2 kohms,1/16W 330 ohms,1/6W 330 ohms,1/16W 22 kohms,1/16W 22 kohms,1/16W 10 kohm,1/16W 10 kohm,1/6W 8.2 kohms,1/16W 8.2 kohms,1/16W 6.8 kohms,1/6W 6.8 kohms,1/6W 33 kohms,1/6W 33 kohms,1/6W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/6W 1 kohm,1/6W 1 kohm,1/16W 1 kohm,1/6W 1 kohm,1/6W 1 kohm,1/6W 1 kohm,1/6W 1 kohm,1/6W 1 kohm,1/6W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/6W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/6W 1 kohm,1/16W 1 kohm,1/6W 2.2 kohms,1/16W 680 ohms,1/16W 680 ohms,1/16W 560 ohms,1/6W 1 kohm,1/6W 10 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/16W 1 kohm,1/6W 100 ohm,1/6W 1 kohm,1/6W 10 kohm,1/6W 1 kohm,1/6W 47 kohms,1/6W 330 ohms,1/6W 5.6 kohms,1/6W 10 kohm,1/16W 10 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [10] RESISTORS ! ! R762 R763 R766 R767 R768 R769 R770 R771 R773 R775 R776 R777 R778 R779 R780 R781 R782 R783 R784 R785 R786 R787 R788 R789 R790 R791 R794 R795 R801 R802 R803 R804 R805 R806 R808 R841 R842 R843 R844 R853 R854 R857 R858 R859 R863 R864 R870 R885 R886 R887 R888 R889 R890 R891 R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 R912 R913 R916 R917 R918 R919 R920 R921 R922 R925 R926 R927 R928 R929 R930 R934 R935 R937 R938 R939 VRS-CY1JB103J VRS-CY1JB102J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB103J VRD-ST2CD102J VRS-CY1JB562J VRD-ST2CD472J VRS-CY1JB103J VRS-CY1JB472J VRS-CY1JB472J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB103J VRD-ST2CD103J VRS-CY1JB473J VRD-ST2CD104J VRS-CY1JB101J VRS-CY1JB102J VRS-CY1JB272J VRS-CY1JB472J VRD-ST2CD472J VRD-ST2CD472J VRD-ST2CD472J VRS-CY1JB822J VRS-CY1JB472J VRD-ST2EE1R5J VRD-ST2EE1R5J VRD-ST2CD104J VRD-ST2CD473J VRD-ST2CD123J VRD-ST2EE470J VRD-ST2EE470J VRD-ST2CD473J VRD-RT2HD222J VRD-ST2CD224J VRD-ST2CD102J VRD-ST2CD473J VRD-ST2EE820J VRD-ST2CD223J VRD-ST2CD332J VRD-ST2CD223J VRD-ST2CD221J VRD-ST2CD103J VRD-RH2HD3R3J VRD-ST2CD223J VRS-CY1JB000J VRS-CY1JB681J VRS-CY1JB223J VRS-CY1JB223J VRD-ST2CD473J VRD-ST2CD473J RR-HZ0001AWZZ VRD-ST2EE101J VRS-CY1JB563J VRS-CY1JB563J VRS-CY1JB102J VRS-CY1JB102J VRS-CY1JB561J VRS-CY1JB561J VRS-CY1JB563J VRS-CY1JB102J VRS-CY1JB333J VRD-ST2CD102J VRS-CY1JB563J VRG-ST2EC101J VRN-CM05NR22J VRN-CM05NR22J VRN-CM05N0R1J VRD-ST2CD222J VRS-CY1JB152J VRS-CY1JB152J VRD-ST2CD222J VRN-CM05N0R1J VRD-RT2HD152J VRD-RT2HD152J VRD-ST2EE393J VRD-ST2EE393J VRD-ST2EE473J VRD-ST2EE473J VRD-ST2CD563J VRD-ST2CD563J VRS-CY1JB563J VRD-RT2HD100J VRD-RT2HD100J AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AE AA AA AA AA AA AA AA AA AA AA AA AA AB AD AD AD AA AA AA AA AD AA AA AA AA AA AA AA AA AA AA AA 10 kohm,1/16W 1 kohm,1/16W 10 kohm,1/16W 10 kohm,1/16W 10 kohm,1/16W 1 kohm,1/6W 5.6 kohms,1/16W 4.7 kohms,1/6W 10 kohm,1/16W 4.7 kohms,1/16W 4.7 kohms,1/16W 10 kohm,1/16W 10 kohm,1/16W 10 kohm,1/16W 10 kohm,1/6W 47 kohms,1/16W 100 kohm,1/6W 100 ohm,1/16W 1 kohm,1/16W 2.7 kohms,1/16W 4.7 kohms,1/16W 4.7 kohms,1/6W 4.7 kohms,1/6W 4.7 kohms,1/6W 8.2 kohms,1/16W 4.7 kohms,1/16W 1.5 ohms,1/4W 1.5 ohms,1/4W 100 kohm,1/6W 47 kohms,1/6W 12 kohms,1/6W 47 ohms,1/4W 47 ohms,1/4W 47 kohms,1/6W 2.2 kohms,1/2W 220 kohms,1/6W 1 kohm,1/6W 47 kohms,1/6W 82 ohms,1/4W 22 kohms,1/6W 3.3 kohms,1/6W 22 kohms,1/6W 220 ohms,1/6W 10 kohm,1/6W 3.3 ohms,1/2W 22 kohms,1/6W 0 ohm,Jumper,0.8x1.55mm,Green 680 ohms,1/16W 22 kohms,1/16W 22 kohms,1/16W 47 kohms,1/6W 47 kohms,1/6W 4.7 Mohms,1/2W 100 ohm,1/4W 56 kohms,1/16W 56 kohms,1/16W 1 kohm,1/16W 1 kohm,1/16W 560 ohms,1/16W 560 ohms,1/16W 56 kohms,1/16W 1 kohm,1/16W 33 kohms,1/16W 1 kohm,1/6W 56 kohms,1/16W 100 ohm,1/4W,Fusible 0.22 ohms,5W 0.22 ohms,5W 0.1 ohm,5W 2.2 kohms,1/6W 1.5 kohms,1/16W 1.5 kohms,1/16W 2.2 kohms,1/6W 0.1 ohm,5W 1.5 kohms,1/2W 1.5 kohms,1/2W 39 kohms,1/4W 39 kohms,1/4W 47 kohms,1/4W 47 kohms,1/4W 56 kohms,1/6W 56 kohms,1/6W 56 kohms,1/16W 10 ohm,1/2W 10 ohm,1/2W 11 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [10] RESISTORS ! R940 R941 R942 R943 R944 R945 R946 R947 R949 R950 R951 R956 R957 R958 R959 R960 R961 R962 RD01 RD02 RD03 RD04 RD05 RD06 RD11 RD12 RD13 RD14 RD15 RD16 RD17 RD18 RD19 RD20 RD21 RD23 RD24 RD25 RD26 RD27 RD28 RD29 RD30 RD31 RD32 RM1 RM2 RM5 RM6 AA AA AC AC AA AA AA AA AA AA AA AA AA AB AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 10 ohm,1/2W 10 ohm,1/2W 680 ohms,2W 680 ohms,2W 1.5 kohms,1/6W 1.5 kohms,1/6W 47 kohms,1/16W 15 kohms,1/16W 1 kohm,1/2W 68 kohms,1/6W 1 kohm,1/2W 1 kohm,1/16W 4.7 kohms,1/16W 100 ohm,1/4W,Fusible 220 ohms,1/16W 8.2 kohms,1/2W 8.2 kohms,1/2W 470 ohms,1/2W 680 ohms,1/6W 820 ohms,1/16W 1 kohm,1/16W 1.5 kohms,1/6W 2.2 kohms,1/16W 2.7 kohms,1/16W 680 ohms,1/16W 820 ohms,1/16W 1 kohm,1/6W 1.5 kohms,1/16W 2.2 kohms,1/16W 2.7 kohms,1/16W 3.9 kohms,1/16W 5.6 kohms,1/16W 10 kohm,1/16W 15 kohms,1/16W 33 kohms,1/16W 680 ohms,1/6W 820 ohms,1/6W 1 kohm,1/6W 1.5 kohms,1/16W 2.2 kohms,1/16W 2.7 kohms,1/16W 3.9 kohms,1/16W 5.6 kohms,1/16W 10 kohm,1/16W 15 kohms,1/16W 10 kohm,1/16W 10 kohm,1/16W 270 ohms,1/16W 680 ohms,1/16W QCNWN2715AWPZ QCNWN2714AWPZ QCNWN2713AWPZ QCNWN2561AWZZ QCNCWYP16AWZZ 92LCONE8P53254 92LCONE6P53253 92LCONE6P53254 92LCONE7P53253 QCNCWZY16AWZZ QCNCWZX11AWZZ QCNCWZO11AWZZ QCNCM705CAFZZ QCNCM705GAFZZ 92LCONE2P5268 92LCONE5P53253 AG AK AH AE AD AC AC AC AC AD AC AC AA AB AB AB Connector Ass'y,9/8Pin Within CNS601 Connector Ass'y,6/5Pin Within CNS603 Connector Ass'y,11/10Pin Within CNS801 Connector Ass'y,3/3Pin with CNS901 Socket,16Pin Plug,8Pin Plug,6Pin Plug,6Pin Plug,7Pin Socket,16Pin Socket,11Pin Socket,11Pin Plug,3Pin Plug,7Pin Plug,2Pin Plug,5Pin QCNCWZY16AWZZ AD Socket,16Pin QCNCWZX16AWZZ AD Socket,16Pin QCNCWZY07AWZZ AC Socket,7Pin QCNCWZY16AWZZ 92LCONEAP5267X QCNCW012FAWZZ QCNCW012EAWZZ QCNCM705CAFZZ 92LCONE2P53253 QCNWNA087AWPZ QCNWNA080AWPZ QFS-D502DAWNI QFS-D502DAWNI QFS-D202BSJNI AD AC AC AC AA AB AF AC AC AC AB Socket,16Pin Plug,10Pin Plug,6Pin Socket,5Pin Plug,3Pin Plug,2Pin Connector Ass'y,6/6Pin with CNS3B Connector Ass'y,2Pin Fuse,5A/125V Fuse,5A/125V Fuse,2A/125V VRD-RT2HD100J VRD-RT2HD100J VRS-VV3DA681J VRS-VV3DA681J VRD-ST2CD152J VRD-ST2CD152J VRS-CY1JB473J VRS-CY1JB153J VRD-RT2HD102J VRD-ST2CD683J VRD-RT2HD102J VRS-CY1JB102J VRS-CY1JB472J VRG-ST2EC101J VRS-CY1JB221J VRD-RT2HD822J VRD-RT2HD822J VRD-RT2HD471J VRD-ST2CD681J VRS-CY1JB821J VRS-CY1JB102J VRD-ST2CD152J VRS-CY1JB222J VRS-CY1JB272J VRS-CY1JB681J VRS-CY1JB821J VRD-ST2CD102J VRS-CY1JB152J VRS-CY1JB222J VRS-CY1JB272J VRS-CY1JB392J VRS-CY1JB562J VRS-CY1JB103J VRS-CY1JB153J VRS-CY1JB333J VRD-ST2CD681J VRD-ST2CD821J VRD-ST2CD102J VRS-CY1JB152J VRS-CY1JB222J VRS-CY1JB272J VRS-CY1JB392J VRS-CY1JB562J VRS-CY1JB103J VRS-CY1JB153J VRS-CY1JB103J VRS-CY1JB103J VRS-CY1JB271J VRS-CY1JB681J [11] OTHER CIRCUITRY PARTS ! ! ! BI601 BI603 BI801 BI901 CNP1 CNP2 CNP3 CNP3A CNP4 CNP5 CNP6 CNP6A CNP101 CNP102 CNP301 CNP603 CNP701 A CNP701 B CNP702 A CNP704 CNP801 CNP802 CNP901 CNP903 CNP971 CNS3A CNS971 F801 F802 F803 12 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [11] OTHER CIRCUITRY PARTS ! ! ! F804 F805 FFC1 FFC4 FFC701 FFC702 FFC704 FJ1 FL701 FW701 FW901 JK690 JK691 JK692 JK904 JOG701 LG1 LG2 LG3 LG4 M1 M2 M901 NM1 NM2 NSW1 RL841 RL914 RX1 RX701 SO302 SO902 SO904 SW1 SW2 SW3 SW4 SW701 SW702 SW703 SW704 SW705 SW706 SW707 SW712 SW713 SW714 SW715 SW716 SW717 SW718 SW719 SW720 SW721 SW722 SW723 SW725 SW726 SW727 SW728 SW729 SW730 SW731 SW732 SW733 SW734 SW735 WTM705 WTM901 QFS-D202BSJNI QFS-D602DAWNI QCNWNA088AWPZ QCNWN2701AWPZ QCNWN2716AWPZ QCNWN2495AWZZ QCNWN2718AWPZ RCORFA001AWZZ VVKNA12MM44-1 QCNWN2712AWPZ QCNWN2711AWPZ QSOCJ0313AWZZ QSOCJ0120AWZZ QJAKM0004AWZZ QSOCJA010AWZZ QSW-ZA001AWZZ QLUGPA001AWZZ QLUGPA001AWZZ QLUGPA001AWZZ QLUGPA001AWZZ 92LMTR5529BASY 92LMTR5529BASY RMOTV0059AWZZ 92LMTR5515CASY 92LMTR1854BASY QSW-F9001AW01 RRLYD0018AWZZ RRLYD0016AWZZ VHPGP1S094HCZ VHLPIC3704/-1 QTANC0206AWZZ QTANA0424AWZZ QTANA0428AWZZ QSW-P9003AWZZ QSW-P9003AWZZ QSW-P9003AWZZ QSW-P9006AWZZ 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT 92LSWICH1401AT QCNCW019FAWZZ QCNCW019EAWZZ AB AC AF AD AF AD AF AB AX AD AD AF AD AK AC AE AC AC AC AC AD AD AL AS AP AD AH AH AF AG AD AE AE AD AD AD AF AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AB AB Fuse,2A/125V Fuse,6A/125V Flat Cable,16Pin Flat Cable,11Pin Flat Cable,16Pin Flat Cable,7Pin Flat Cable,16Pin Ferrit Bead FL Display Flat Wire,6Pin Flat Wire,5Pin Jack,Game Input Jack,Video Out Jack,Headphones Jack,Subwoofer Pre-Out Switch,Jog Type [Volume] Lug Terminal Lug Terminal Lug Terminal Lug Terminal Motor with Gear [Tray] Motor with Gear [Main Cam] Motor Air Cooling,Fan Motor with Chassis [Spindle] Motor with Gear [Sled] Switch,Push Type [Pickup In] Relay Relay Photo Interrupter,GP1S094HCZ Remote Sensor,PIC3704 Terminal,FM Antenna Terminal,Speaker Terminal,Surround Speaker Switch,Push Type [Clamp] Switch,Push Type [Tray SW1] Switch,Push Type [Tray SW2] Switch,Push Type [Disc] Switch,Key Type [On/Stand-by] Switch,Key Type [Clock/Timer] Switch,Key Type [Tuning Up] Switch,Key Type [Tuning Down] Switch,Key Type [Fast Rewind/Preset Down] Switch,Key Type [Equalizer] Switch,Key Type [Fast Forward/Preset Up] Switch,Key Type [Tuner (Band)] Switch,Key Type [CD] Switch,Key Type [Tape] Switch,Key Type [Game/Video] Switch,Key Type [X-Bass/Demo] Switch,Key Type [Left] Switch,Key Type [Up] Switch,Key Type [Character] Switch,Key Type [Right] Switch,Key Type [Enter] Switch,Key Type [Down] Switch,Key Type [MP3 Navigation] Switch,Key Type [Play/Repeat] Switch,Key Type [Stop] Switch,Key Type [Rec/Pause] Switch,Key Type [Memory/Set] Switch,Key Type [Open/Close] Switch,Key Type [Direct Play] Switch,Key Type [Disc2] Switch,Key Type [Disc4] Switch,Key Type [Disc5] Switch,Key Type [Disc3] Switch,Key Type [Disc1] Socket,6Pin Socket,5Pin 13 CD-G10000/CP-G10000S [12] CD MECHANISM PARTS 306-2 306 306-1 701 306-3 704 304 701 302 301 703x2 NM1 307 NM2 308 305x2 NSW1 PWB-F 14 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [12] CD MECHANISM PARTS ! 301 302 304 305 306 306- 1 306- 2 306- 3 307 308 701 703 704 NM1 NM2 NSW1 NGERH0011AWZZ NGERH0012AWZZ NSFTM0020AWFW 92LMCUSN1524A 92LHPC1LFASY -------NGERR0043AFZZ MSPRC0961AFZZ PCUSG0001AWSA PCUSG0004AWSA XBSSD26P06000 XBBSD20P03000 LX-WZ1070AFZZ 92LMTR5515CASY 92LMTR1854BASY QSW-F9001AW01 AC AC AD AD BB — AC AA AD AD AA AA AA AS AP AD Gear,Middle Gear,Drive Shaft,Guide Cushion Pickup Unit Ass'y Pickup Unit (Not Replacement Item) Gear,Rack Spring,Rack Cushion Cushion Screw,M2.6x6mm Screw,M2x3mm Washer,M1.5xM3.8x0.25mm Motor with Chassis [Spindle] Motor with Gear [Sled] Switch,Push Type [Pickup In] 15 CD-G10000/CP-G10000S [13] CHANGER MECHANISM PARTS 115 107 803x6 123 119 135 104 112 136 122 113 108 141 130 133 143 801x2 139 134 111 124 132 110 120 144 118 103 131 142 117 127 140 137 121 145 128 125 152 126 152 138 136 804 149 101 150 105 148 148 101 129 147 147 146 146 101 151 145 M1 M2 101 SW1 SW2 SW3 RX1 PWB-E 101 102 SW4 109-3 102 803x2 109-5 106 109-1 102 102 109 116 109-4 102 109-2 16 114 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [13] CHANGER MECHANISM PARTS 101 102 103 104 105 106 107 108 109 109- 1 109- 2 109- 3 109- 4 109- 5 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 801 803 804 M1 M2 SW1 SW2 SW3 SW4 GCOVA1513AWZZ GCOVA1514AWZZ LANGG0008AWZZ LANGG0009AWZZ LCHSM0194AWZZ LHLDZ9017AWZZ LPLTP0014AWZZ LPLTP0015AWZZ MHOLD5529ASY LHLDM9001AWZZ LHLDZ9019AWM1 LPLTM0017AWZZ LPLTMA001AWFW PMAGF0003AWZZ MLEVP0129AWZZ MLEVP0130AWZZ MLEVP0131AWZZ MLEVP0132AWZZ MLEVP0133AWZZ MLEVP0134AWZZ MLEVP0135AWZZ MLEVP0136AWZZ MLEVP0137AWZZ MLEVP0138AWZZ MLEVP0139AWZZ MSPRC0044AWFJ MSPRD0191AWFJ MSPRD0192AWFJ NGERH0176AWZZ NGERH0177AWZZ NGERH0178AWZZ NGERH0179AWZZ NGERH0180AWZZ NGERH0181AWZZ NGERH0182AWZZ NGERH0183AWZZ NGERH0184AWZZ NGERH0185AWZZ NGERH0186AWZZ NGERH0187AWZZ NGERH0188AWZZ NGERH0189AWZZ NGERH0190AWZZ NGERH0191AWZZ NGERH0192AWZZ NGERH0193AWZZ NGERH0194AWZZ NGERH0195AWZZ NGERH0196AWZZ NGERH0198AWZZ NGERH0199AWZZ NGERH0200AWZZ NGERH0201AWZZ NGERH0202AWZZ NGERH0203AWZZ NGERH0204AWZZ NSFTT0084AWFD LX-BZA006AWFD XEBSD20P10000 XEBSD30P10000 92LMTR5529BASY 92LMTR5529BASY QSW-P9003AWZZ QSW-P9003AWZZ QSW-P9003AWZZ QSW-P9006AWZZ AF AF AD AC AP AF AK AG AP AD AK AB AC AF AC AG AD AD AC AD AC AC AC AB AC AB AC AB AF AC AC AC AB AC AC AC AC AC AC AB AC AB AC AE AC AC AB AC AC AB AB AB AB AB AB AB AD AB AA AA AD AD AD AD AD AF Disc Tray Guide Tray Outer Tray Guide Inner Tray Guide Main Base CD Mechanism Holder Top Plate Gear Plate Up/Down Holder Ass'y Stabilizer Up/Down Holder Ass'y Stabilizer Plate Plate Magnet Tray Lock Lever Gear Up/Down Board Mechanism Up/Down Board (L) Mechanism Up/Down Board (R) Mechanism Clamp Board L/R Joint Lver Tray Set Lever Mechanism Clamp Switch Lever Mechanism Clamp Switch Arm Inner GR Up/Down Lever Outer GR Up/Down Lever Shift Spring Disc Stop Spring Balance Spring Tray Big Gear Tray Front Gear A Tray Front Gear B Tray Rear Gear A Tray Rear Gear B Mechanism Clamp Gear A Mechanism Clamp Joint Gear Mechanism Clamp Board Gear Tray Rear Joint Gear A Tray Rear Joint Gear B Tray Rear Joint Gear C Tray Rear Drive Gear Tray Drive Gear Tray Front Drive Gear Tray Front Joint Gear Mode Big Gear G-Up/Down Gear A G-Up/Down Gear B Mechanism Up/Down Gear A Mechanism Up/Down Gear B Mechanism Clamp Switch Gear Reduction Gear A Reduction Gear B Reduction Gear C Reduction Gear D Up/Down Reduction Gear E Up/Down Reduction Gear F Tray Reduction Gear E Shaft,Main Base Screw,Special Screw,M2x10mm Screw,M3x10mm Motor with Gear [Tray] Motor with Gear [Main Cam] Switch,Push Type [CLAMP] Switch,Push Type [TRAY SW1] Switch,Push Type [TRAY SW2] Switch,Push Type [DISC] 17 CD-G10000/CP-G10000S [14] CABINET PARTS BELT CONNECTION FF/REW Tape FF/REW ROLLER Motor ROLLER ASS'Y ASS'Y CHANGER MECHANISM UNIT 601x5 202 FLYWHEEL FLYWHEEL ASS'Y MAIN BELT ASS'Y TAPE2 TAPE1 234 PWB-D CD MECHANISM 601x3 605x6 234 603x4 234 206 234 601x3 601x2 204 209 M901 602x4 207 223 604x10 216 PWB-C 205 602x2 605x2 205 601x11 609x2 612 222 205 228 205 210 227 201 201-22 218 610 PWB-H 226 PWB-A2 FL701 205 614x2 604 201-21 610 615 201-20 201-10 616x2 601x2 PWB-A1 212 610 201-12 225 212 201-16 201-17 201-15 213 201-14 230 201-27 216 232 616x2 201-8 607x2 PWB-B2 613x2 201-28 601x2 214 201-25 201-23 201-13 230 617 608x4 201-9 229 201-24 201-26 604 201-1 201-9 201-11 220 221 PWB-B1 615 201-4 201-2 Silicon Grease 617 PT801 212 611 224x10 201-18 201-5 203x2 201-6 201-19 201-7 208 219 606x2 201-3 217 18 203x2 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [14] CABINET PARTS ! ! 201 201- 1 201- 2 201- 3 201- 4 201- 5 201- 6 201- 7 201- 8 201- 9 201-10 201-11 201-12 201-13 201-14 201-15 201-16 201-17 201-18 201-19 201-20 201-21 201-22 201-23 201-24 201-25 201-26 201-27 201-28 202 203 204 205 206 207 208 209 210 212 213 214 216 217 218 219 220 221 222 223 224 225 226 227 228 229 230 234 601 602 603 604 605 606 607 608 609 610 611 612 613 614 615 616 617 CCABA6232AW01 -------GCOVA1521AWSA GCOVA1522AWSA GDORF0127AWSA GDORF0128AWSA HDECQ1108AWSA HDECQ1109AWSA JKNBZ0982AWSA MLIF-A001AWZZ JKNBZA023AWSD JKNBZA024AWSD JKNBZA057AWSA JKNBZ0986AWSA JKNBZ0987AWSA JKNBZ0991AWSA GCOVA1533AWSA HBDGB1007AWSA MSPRDA002AWFJ MSPRDA003AWFJ HDECQA039AWSA HDECQA086AWSA HDECQA148AWSA MLOKC0014AWZZ MLOKC0015AWZZ MSPRD0196AWFJ MSPRD0197AWFJ JKNBZA058AWSA JKNBZ0989AWSA GCAB-3101AWSA PCUSG0022AWZZ GITARA253AWSA GCOVA1520AWSA LCHSZ0025AWZZ PSLDMA009AWFW 92LNBAND1318A KMECBA001AWZZ HDECQ1110AWSA QCNWN1860AWZZ JKNBK0103AWSA HDECQ1104AWSA 92LCSPR1431C LCHSM0201AWFW GITARA252AWSA LBND-1011AWZZ QACCD0022AWZZ LBSHC0005AWZZ NFANP0001AWZZ LANGK0437AWFW QFSHD0001AWZZ PRDAR0320AWFW LHLDZ9024AWZZ LANGT0042AWFW PSHEPA019AWZZ LHLDZA004AWZZ LANGK0435AWFW PFLT-A006AWZZ XJBSD30P10000 XEBSD30P10000 LX-EZ0005AWFD XEBSD26P10000 XESSD30P10000 XJSSD30P08000 LX-EZ0010AWFD XHBSD40P08000 XBBSD20P04000 LX-JZ0010AFFD LX-LZA002AWZZ LX-LZ0002AW00 LX-JZ0037AWFD LX-JZ0044AWFF XWHSD32-10080 XHBSD30P06000 LX-JZ0036AWFD — AK AK AE AE AE AE AE AD AM AM AG AE AE AF AC AD AB AB AH AG AK AC AC AB AC AH AE AY AB AK AG AM AG AA BC AF AC AD AL AA AR AP AA AM AD AD AE AB AV AD AC AF AC AF AB AA AA AA AA AA AA AA AA AA AA AD AC AB AB AA AA AB Front Panel Ass'y Front Panel (Not Replacement Item) Cover,Cassette [Tape 1] Cover,Cassette [Tape 2] Holder,Cassette [Tape 1] Holder,Cassette [Tape 2] Panel,Cassette [Tape 1] Panel,Cassette [Tape 2] Button,Disc Number Damper Button,Operation A Button,Operation B Button,Function Button,Memory Button,Tuning Button,Power Cover,Timer Badge,SHARP Spring,Cassette [Tape 1] Spring,Cassette [Tape 2] Volume Knob Ring,A Volume Knob Ring,B Decoration Plate,Amp. Lock,Cassette [Tape 1] Lock,Cassette [Tape 2] Spring,Cassette Lock [Tape 1] Spring,Cassette Lock [Tape 2] Button,MP3 Navigation,A Button,MP3 Navigation,B Cabinet,Top/Side Cushion,Leg Rear Panel B Cover,CD Tray Chassis,Changer Shield,Dust Cover Nylon Band,80mm Tape Mechanism Ass'y Panel,Edge Light Lug Wire Knob,Volume Cover,Volume Knob Spring,Ring Chassis,Main Rear Panel,A Nylon Band AC Power Supply Cord with CNS805 Bushing,AC Power Supply Cord Rotary Fan Bracket,Fan Support A Holder,Fuse Heat Sink Holder,Edge Light Bracket,PWB Support Insulator,Main PWB Holder,Rib Support Bracket,Heat Sink Support Felt Screw,M3x10mm Screw,M3x10mm Screw,M2.6x10mm Screw,M2.6x10mm Screw,M3x10mm Screw,M3x8mm Screw,Special Screw,M4x8mm Screw,M2x4mm Screw,M3x10mm Push Rivet Snap Rivet Screw,M3x18mm Screw,M3x10mm Washer,M3.2xM8x1mm Screw,M3x6mm Screw,M3x12mm 19 CD-G10000/CP-G10000S [15] SURROUND SPEAKER BOX PARTS 901 904 SP1, 2 908 910x4 904 905 SP3, 4 910x4 904 907 903x4 902 SP3,4 SPEAKER SP1,2 SPEAKER 909 906 SP3,4 SPEAKER 907 BK RD RD SP1,2 SPEAKER 20 BK CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [15] SURROUND SPEAKER BOX PARTS 901 902 903 904 905 906 907 908 909 910 911 SP1 SP2 SP3 SP4 GBOXSA043AW01 HPNLSA016AWSA PCUSGA020AWZZ PCUSSA015AWZZ QCNWNA148AWZZ HDECQA062AWSA CDECQA063AW01 TSPC-A362AWZZ XJBSD30P12000 XMBSF35P16000 XEBSD26P10000 RSP-ZA041AWZZ RSP-ZA041AWZZ RSP-ZA041AWZZ RSP-ZA041AWZZ CC BA AB AH AR AP AZ AD AA AC AA BD BD BD BD Speaker Box Ass'y Front Panel Leg Cushion Cushion,Front Panel Support Lead Wire Ass'y Decoration Panel Speaker Ring Ass'y Label,Specifications Screw,M3x12mm Screw,M3.5x16mm Screw,M2.6x10mm Speaker Speaker Speaker Speaker AG AM AS AE AD AB AB AB AD AU AG AM Loop Antenna RCA Cable Speaker Cord,Surround Speaker Operation Manual Quick Guide Label,Energy Star Label,Model No. Polyethylene Bag,Accessories FM Antenna Remote Control Battery Lid,Remote Control [17] ACCESSORIES 1 1- 1 QANTL0005AWZZ QCNWGA003AWPZ QCNWHA004AWZZ TINSEA075AWZZ TINSZA128AWZZ TLABZA113AWSA TLABZA227AWZZ 92LBAG1460C1 92LFANT1746A RRMCG0395AWSA GFTAT1017AWSA [18] P.W.B. ASSEMBLY (Not Replacement Item) ! PWB-A PWB-B PWB-C PWB-D PWB-E PWB-F PWB-G 92LPWB6232MANS 92LPWB5534PWRS 92LPWB5612CDUS -------QPWBF1055AWZZ QPWBF0027AWZZ 92LPWB5813SPKS — — — — AE AD — Main/Display (PWB-A1,2) (Combined Ass'y) Power/Game Input (PWB-B1,2) (Combined Ass'y) CD Servo Tape Mechanism 5-Changer Motor (PWB Only) CD Motor (PWB Only) Speaker Terminal AZ CD Pickup Lens Cleaner [19] OTHER SERVICE PART UDSKA0004AFZZ 21 CD-G10000/CP-G10000S „INDEX INDEX PARTS CODE [ C CCABA6232AW01 CDECQA063AW01 [ G GBOXSA043AW01 GCAB-3101AWSA GCOVA1513AWZZ GCOVA1514AWZZ GCOVA1520AWSA GCOVA1521AWSA GCOVA1522AWSA GCOVA1533AWSA GDORF0127AWSA GDORF0128AWSA GFTAT1017AWSA GITARA252AWSA GITARA253AWSA [ H HBDGB1007AWSA HDECQ1104AWSA HDECQ1108AWSA HDECQ1109AWSA HDECQ1110AWSA HDECQA039AWSA HDECQA062AWSA HDECQA086AWSA HDECQA148AWSA HPNLSA016AWSA [ J JKNBK0103AWSA JKNBZ0982AWSA JKNBZ0986AWSA JKNBZ0987AWSA JKNBZ0989AWSA JKNBZ0991AWSA JKNBZA023AWSD JKNBZA024AWSD JKNBZA057AWSA JKNBZA058AWSA [ K KMECBA001AWZZ [ L LANGG0008AWZZ LANGG0009AWZZ LANGK0435AWFW LANGK0437AWFW LANGT0042AWFW LBND-1011AWZZ LBSHC0005AWZZ LCHSM0194AWZZ LCHSM0201AWFW LCHSZ0025AWZZ LHLDM9001AWZZ LHLDZ9017AWZZ LHLDZ9019AWM1 LHLDZ9024AWZZ LHLDZA004AWZZ LPLTM0017AWZZ LPLTMA001AWFW LPLTP0014AWZZ LPLTP0015AWZZ LX-BZA006AWFD LX-EZ0005AWFD LX-EZ0010AWFD LX-JZ0010AFFD LX-JZ0036AWFD LX-JZ0037AWFD LX-JZ0044AWFF LX-LZ0002AW00 LX-LZA002AWZZ LX-WZ1070AFZZ [ M MHOLD5529ASY MLEVP0129AWZZ MLEVP0130AWZZ MLEVP0131AWZZ MLEVP0132AWZZ MLEVP0133AWZZ MLEVP0134AWZZ PRICE NEW PART RANK MARK RANK No. PARTS CODE MLEVP0135AWZZ MLEVP0136AWZZ MLEVP0137AWZZ MLEVP0138AWZZ MLEVP0139AWZZ MLIF-A001AWZZ MLOKC0014AWZZ MLOKC0015AWZZ MSPRC0044AWFJ MSPRC0961AFZZ MSPRD0191AWFJ MSPRD0192AWFJ MSPRD0196AWFJ MSPRD0197AWFJ MSPRDA002AWFJ MSPRDA003AWFJ [ N ] NFANP0001AWZZ NGERH0011AWZZ NGERH0012AWZZ NGERH0176AWZZ NGERH0177AWZZ NGERH0178AWZZ NGERH0179AWZZ NGERH0180AWZZ NGERH0181AWZZ NGERH0182AWZZ NGERH0183AWZZ NGERH0184AWZZ NGERH0185AWZZ NGERH0186AWZZ NGERH0187AWZZ NGERH0188AWZZ NGERH0189AWZZ NGERH0190AWZZ NGERH0191AWZZ NGERH0192AWZZ NGERH0193AWZZ NGERH0194AWZZ NGERH0195AWZZ NGERH0196AWZZ NGERH0198AWZZ NGERH0199AWZZ NGERH0200AWZZ NGERH0201AWZZ NGERH0202AWZZ NGERH0203AWZZ NGERH0204AWZZ NGERR0043AFZZ NSFTM0020AWFW NSFTT0084AWFD [ P ] PCUSG0001AWSA PCUSG0004AWSA PCUSG0022AWZZ PCUSGA020AWZZ PCUSSA015AWZZ PFLT-A006AWZZ PMAGF0003AWZZ PRDAR0320AWFW PSHEPA019AWZZ PSLDMA009AWFW ] 14-201 15-907 AZ 15-901 14-202 13-101 13-102 14-205 14-201- 2 14-201- 3 14-201-16 14-201- 4 14-201- 5 17-1- 1 14-218 14-204 CC AY AF AF AG AK AK AC AE AE AG AP AK 14-201-17 14-214 14-201- 6 14-201- 7 14-210 14-201-20 15-906 14-201-21 14-201-22 15-902 AD AL AE AE AF AH AP AG AK BA 14-213 14-201- 8 14-201-13 14-201-14 14-201-28 14-201-15 14-201-10 14-201-11 14-201-12 14-201-27 AD AE AE AE AE AF AM AM AG AH 14-209 BC 13-103 13-104 14-230 14-223 14-227 14-219 14-221 13-105 14-217 14-206 13-10913-106 13-10914-226 14-229 13-10913-10913-107 13-108 13-801 14-603 14-607 14-610 14-617 14-613 14-614 14-612 14-611 12-704 AD AC AF AE AC AA AD AP AR AM AD AF AK AD AC AB AC AK AG AB AA AA AA AB AB AB AC AD AA ] ] ] ] ] 1 2 3 4 [ Q ] QACCD0022AWZZ QANTL0005AWZZ QCNCM705CAFZZ " QCNCM705GAFZZ QCNCW012EAWZZ QCNCW012FAWZZ QCNCW019EAWZZ QCNCW019FAWZZ QCNCWYP16AWZZ QCNCWZO11AWZZ QCNCWZX11AWZZ QCNCWZX16AWZZ QCNCWZY07AWZZ QCNCWZY16AWZZ " ] 13-109 13-110 13-111 13-112 13-113 13-114 13-115 AP AC AG AD AD AC AD 22 No. PRICE NEW PART RANK MARK RANK 13-116 13-117 13-118 13-119 13-120 14-201- 9 14-201-23 14-201-24 13-121 12-306- 3 13-122 13-123 14-201-25 14-201-26 14-201-18 14-201-19 AC AC AC AB AC AD AC AC AB AA AC AB AB AC AB AB 14-222 12-301 12-302 13-124 13-125 13-126 13-127 13-128 13-129 13-130 13-131 13-132 13-133 13-134 13-135 13-136 13-137 13-138 13-139 13-140 13-141 13-142 13-143 13-144 13-145 13-146 13-147 13-148 13-149 13-150 13-151 12-306- 2 12-304 13-152 AD AC AC AF AC AC AC AB AC AC AC AC AC AC AB AC AB AC AE AC AC AB AC AC AB AB AB AB AB AB AB AC AD AD 12-307 12-308 14-203 15-903 15-904 14-234 13-109- 5 14-225 14-228 14-207 AD AD AB AB AH AB AF AV AF AG 14-220 1711-CNP101 11-CNP903 11-CNP102 11-CNP901 11-CNP802 11-WTM901 11-WTM705 11-CNP1 11-CNP6A 11-CNP6 11-CNP701B 11-CNP702A 11-CNP5 11-CNP704 AM AG AA AA AB AC AC AB AB AD AC AC AD AC AD AD CD-G10000/CP-G10000S PARTS CODE " QCNWGA003AWPZ QCNWHA004AWZZ QCNWNA088AWPZ QCNWN1860AWZZ QCNWN2495AWZZ QCNWN2561AWZZ QCNWN2701AWPZ QCNWN2711AWPZ QCNWN2712AWPZ QCNWN2713AWPZ QCNWN2714AWPZ QCNWN2715AWPZ QCNWN2716AWPZ QCNWN2718AWPZ QCNWNA080AWPZ QCNWNA087AWPZ QCNWNA148AWZZ QFS-D202BSJNI " QFS-D502DAWNI " QFS-D602DAWNI QFSHD0001AWZZ QJAKM0004AWZZ QLUGPA001AWZZ " " " QPWBF0027AWZZ QPWBF1055AWZZ QSOCJ0120AWZZ QSOCJ0313AWZZ QSOCJA010AWZZ QSW-F9001AW01 " QSW-P9003AWZZ " " " " " QSW-P9006AWZZ " QSW-ZA001AWZZ QTANA0424AWZZ QTANA0428AWZZ QTANC0206AWZZ [ R ] RC-EZ0004AWZZ RC-EZ0065AWZZ " RC-EZ0124AWZZ " RCILA0052AWZZ RCILB0067AWZZ RCILBA001AWZZ RCILC0011AWZZ RCILC0012AWZZ " RCILI0017AWZZ RCILI0019AWZZ RCILR0056AWZZ RCILZ0024AWZZ " RCILZ0137AFZZ " RC-KZ002LAWZZ RCORFA001AWZZ RCRM-0043AWZZ RCRM-0047AWZZ RCRSP0003AWZZ RCRSP0019AWZZ RFILA0009AWZZ RFILF0003AWZZ RFILF0124AFZZ RFILR0008AWZZ RH-IXA006AWZZ RH-IXA054AWZZ RMOTV0059AWZZ RR-HZ0001AWZZ RRLYD0016AWZZ No. PRICE NEW PART RANK MARK RANK 11-CNP701A 171711-FFC1 14-212 11-FFC702 11-BI901 11-FFC4 11-FW901 11-FW701 11-BI801 11-BI603 11-BI601 11-FFC701 11-FFC704 11-CNS971 11-CNS3A 15-905 11-F803 11-F804 11-F801 11-F802 11-F805 14-224 11-JK692 11-LG1 11-LG2 11-LG3 11-LG4 18-PWB-F 18-PWB-E 11-JK691 11-JK690 11-JK904 11-NSW1 12-NSW1 11-SW1 11-SW2 11-SW3 13-SW1 13-SW2 13-SW3 11-SW4 13-SW4 11-JOG701 11-SO902 11-SO904 11-SO302 AD AM AS AF AC AD AE AD AD AD AH AK AG AF AF AC AF AR AB AB AC AC AC AB AK AC AC AC AC AD AE AD AF AC AD AD AD AD AD AD AD AD AF AF AE AE AE AD 9-C9 9-C921 9-C922 9-C920 9-C923 5-T303 5-T306 5-T301 6-L1 6-L2 6-L3 5-T302 5-T351 6-L312 6-L901 6-L902 6-L920 6-L921 9-C844 11-FJ1 8-XL2 8-XL1 8-XL701 8-X352 4-CF352 4-CF351 4-CF303 4-BF301 1-IC5 1-IC701 11-M901 10-R890 11-RL914 AD AN AN AR AR AE AD AD AD AD AB AD AB AC AC AA AA AC AB AB AE AH AF AE AK AD AE AT AV AL AE AH PARTS CODE RRLYD0018AWZZ RRMCG0395AWSA RSP-ZA041AWZZ " " " RTRNP0483AWZZ RTRNP0518AWZZ [ S SPAKAA029AWZZ SPAKAA030AWZZ SPAKAA031AWZZ SPAKAA032AWZZ SPAKCA218AWZZ SPAKP0032AWZZ SSAKHA016AWZZ SSAKHA017AWZZ [ T TINSEA075AWZZ TINSZA128AWZZ TLABZA113AWSA TLABZA227AWZZ TSPC-A362AWZZ [ U UDSKA0004AFZZ [ V VCCCCY1HH100D VCCCCY1HH101J " " " " " " " " " " " " VCCCCY1HH120J VCCCCY1HH150J " " " VCCCCY1HH180J " VCCCCY1HH181J VCCCCY1HH220J " " VCCCCY1HH270J VCCCCY1HH330J " VCCCCY1HH3R0C " VCCCCY1HH4R7C " " VCCSBT1HL470J VCEAZA0JW108M VCEAZA0JW337M VCEAZA1AW107M " " " " " " " VCEAZA1AW227M " " VCEAZA1AW476M " " " VCEAZA1CW107M VCEAZA1CW227M VCEAZA1EW106M " VCEAZA1EW226M 23 No. 11-RL841 17-1 15-SP1 15-SP2 15-SP3 15-SP4 5-PT841 5-PT801 PRICE NEW PART RANK MARK RANK AH AU BD BD BD BD AL BL ] 1616161616161616] 1717171715-908 AE AD AB AB AD 19- AZ ] ] 9-C303 9-C12 9-C27 9-C28 9-C30 9-C32 9-C72 9-C73 9-C376 9-C377 9-C378 9-C379 9-C907 9-C913 9-C381 9-C310 9-C330 9-C382 9-C704 9-C311 9-C705 9-C104 9-C313 9-C334 9-C355 9-C369 9-C42 9-C64 9-C908 9-C910 9-C305 9-C308 9-C324 9-C383 9-C841 9-C20 9-C18 9-C41 9-C44 9-C56 9-C57 9-C61 9-C396 9-C398 9-C134 9-C603 9-C702 9-C14 9-C50 9-C58 9-C65 9-C141 9-C601 9-C21 9-C22 9-C133 AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AC AC AB AB AB AB AB AB AB AB AC AC AC AB AB AB AB AC AC AB AB AB CD-G10000/CP-G10000S PARTS CODE " " " VCEAZA1EW227M VCEAZA1EW476M " " " " " " " " " " " " VCEAZA1HW104M VCEAZA1HW105M " " " " " " " " " " " " " " " " " " " " " " VCEAZA1HW106M " " " " VCEAZA1HW107M " VCEAZA1HW224M " VCEAZA1HW225M " " VCEAZA1HW226M " " " " " VCEAZA1HW335M " " VCEAZA1HW475M " " " VCEAZA1HW476M " " " VCEAZA1JW227M VCEAZA1VW107M VCEAZA1VW477M VCEAZA2AW107M " " " VCEAZA2AW226M VCEAZW1EW478M VCFYDA2AA224J " VCFYFA1HA184J No. 9-C817 9-C864 9-C865 9-C854 9-C1 9-C3 9-C69 9-C111 9-C112 9-C117 9-C118 9-C131 9-C132 9-C140 9-C391 9-C394 9-C717 9-C946 9-C63 9-C358 9-C367 9-C368 9-C370 9-C371 9-C372 9-C393 9-C609 9-C610 9-C613 9-C614 9-C617 9-C618 9-C619 9-C620 9-C621 9-C622 9-C623 9-C624 9-C639 9-C701 9-C707 9-C307 9-C352 9-C380 9-C855 9-C931 9-C916 9-C918 9-C901 9-C902 9-C357 9-C362 9-C364 9-C125 9-C126 9-C640 9-C859 9-C961 9-C962 9-C143 9-C714 9-C960 9-C615 9-C616 9-C905 9-C906 9-C150 9-C802 9-C803 9-C925 9-C804 9-C801 9-C842 9-C911 9-C912 9-C914 9-C915 9-C805 9-C850 9-C810 9-C811 9-C605 PRICE NEW PART RANK MARK RANK AB AB AB AC AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AC AC AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AD AC AD AD AD AD AD AC AK AD AD AC PARTS CODE " VCFYFA1HA224J " VCKYBT1HB101K VCKYBT1HB102K " VCKYBT1HB103K VCKYBT1HB181K VCKYCY1CB103K " " " " " " " " " " " " " " VCKYCY1CB104K " " " " " VCKYCY1CB473K " VCKYCY1CB563K " VCKYCY1CF224Z VCKYCY1EF223Z " " " " " " " " " " " " " " " " " " " " " " " " " " VCKYCY1EF473Z " " " VCKYCY1HB102K " " " " " " " " " " " " " " " " 24 No. 9-C606 9-C607 9-C608 9-C318 9-C320 9-C389 9-J631 9-C103 9-C2 9-C6 9-C25 9-C34 9-C38 9-C46 9-C47 9-C51 9-C52 9-C53 9-C62 9-C66 9-C68 9-C70 9-C76 9-C10 9-C37 9-C39 9-C59 9-C71 9-C87 9-C5 9-C35 9-C11 9-C33 9-C36 9-C13 9-C17 9-C26 9-C31 9-C48 9-C84 9-C121 9-C135 9-C306 9-C312 9-C316 9-C323 9-C332 9-C342 9-C347 9-C350 9-C351 9-C353 9-C354 9-C361 9-C363 9-C387 9-C395 9-C397 9-C399 9-C720 9-C721 9-C723 9-C727 9-C730 9-C732 9-C4 9-C29 9-C60 9-C74 9-C75 9-C83 9-C302 9-C309 9-C317 9-C338 9-C356 9-C366 9-C384 9-C388 9-C392 9-C903 9-C904 PRICE NEW PART RANK MARK RANK AC AC AC AA AA AA AB AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AB AB AB AB AB AB AA AA AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA CD-G10000/CP-G10000S PARTS CODE VCKYCY1HB103K " " " " " " " VCKYCY1HB104K VCKYCY1HB152K " VCKYCY1HB221K " " VCKYCY1HB222K " " " VCKYCY1HB271K " VCKYCY1HB272K " " VCKYCY1HB331K " " " " VCKYCY1HB332K " " VCKYCY1HB471K VCKYCY1HB473K " VCKYCY1HB561K " " " " VCKYCY1HF103Z VCKYPA1HB102K " VCKYPA1HB103K VCKYPA1HB391K " VCKYPA1HF223Z " VCKZPA1HF473Z VCQPKA2AA822J VCQYKA1HM104K " " " " " " " " " VCQYKA1HM152K " VCQYKA1HM393K VCQYKA1HM473K " VCTYBT1EF223Z " VCTYPA1CX153K " VCTYPA1CX223K " " VCTYPA1EX393K " VHCSVC230C/-1 " VHCSVC347S/-1 VHD1N4004S/-1 " " " " " No. 9-C304 9-C315 9-C385 9-C693 9-C715 9-C917 9-C919 9-C952 9-C885 9-C105 9-C106 9-C651 9-C652 9-C653 9-C119 9-C120 9-C625 9-C626 9-C123 9-C124 9-C8 9-C611 9-C612 9-C107 9-C108 9-C109 9-C110 9-C386 9-C82 9-C129 9-C130 9-C16 9-C709 9-C710 9-C101 9-C102 9-C115 9-C116 9-C335 9-C722 9-C694 9-C695 9-C696 9-C690 9-C691 9-C602 9-C861 9-C331 9-C138 9-C806 9-C807 9-C808 9-C809 9-C851 9-C852 9-C856 9-C909 9-C928 9-C929 9-C23 9-C24 9-C139 9-C137 9-C843 9-C85 9-C86 9-C373 9-C374 9-C127 9-C128 9-C365 9-C113 9-C114 7-VD302 7-VD303 7-VD301 3-D803 3-D804 3-D805 3-D806 3-D842 3-D843 PRICE NEW PART RANK MARK RANK AA AA AA AA AA AA AA AA AD AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AB AB AA AA AA AA AA AB AA AA AA AA AA AB AB AA AA AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AA AA AA AA AA AA AA AA AA AD AD AG AB AB AB AB AB AB PARTS CODE " " " " " VHDD10XB60F-1 " VHDDS1SS133-1 " " " " " " " " " " " " " " " " " " " " " " " " VHDKDS184//-1 VHEDZ120BSB-1 " " VHEDZ300BSB-1 VHEDZ5R1BSB-1 VHEDZ6R2BSA-1 VHEDZ7R5BSB-1 VHEMA8033//-1 VHIAN7345K/-1 VHIAN78L05/-1 VHIAN80T53/-1 VHIKIA7805AP1 VHILA1832S/-1 VHILA6261//-1 VHILC72131/-1 VHILC75341/-1 VHILC78648E-1 VHILC78684E-1 VHILV1625635T VHISI3033LUS1 VHISTK41244-1 VHITA7358AP-1 VHLPIC3704/-1 VHP304VT2H3-1 VHPGP1S094HCZ VHPSDPB50CD-1 VP-DH101K0000 " " VP-MK331K0000 VRD-RH2HD3R3J VRD-RT2HD100J " " " VRD-RT2HD102J " VRD-RT2HD152J " VRD-RT2HD222J VRD-RT2HD471J VRD-RT2HD820J VRD-RT2HD822J " VRD-ST2CD101J VRD-ST2CD102J " " " 25 No. 3-D844 3-D845 3-D853 3-D909 3-D910 3-D801 3-D802 3-D301 3-D302 3-D305 3-D690 3-D691 3-D709 3-D710 3-D711 3-D712 3-D713 3-D714 3-D715 3-D716 3-D846 3-D856 3-D860 3-D861 3-D862 3-D863 3-D885 3-D905 3-D906 3-D907 3-D911 3-D912 3-D1 3-ZD805 3-ZD902 3-ZD903 3-ZD803 3-ZD351 3-ZD801 3-ZD802 3-ZD1 1-IC101 1-IC854 1-IC851 1-IC852 1-IC303 1-IC2 1-IC302 1-IC601 1-IC1 1-IC3 1-IC4 1-IC6 1-IC901 1-IC301 11-RX701 3-LED701 11-RX1 3-LED703 6-L351 6-L352 6-L701 6-L103 10-R863 10-R938 10-R939 10-R940 10-R941 10-R949 10-R951 10-R925 10-R926 10-R808 10-R962 10-R142 10-R960 10-R961 10-R740 10-R113 10-R114 10-R393 10-R601 PRICE NEW PART RANK MARK RANK AB AB AB AB AB AL AL AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AB AC AB AB AC AM AE AL AF AN AN AP AM AW AZ AT AG BF AG AG AC AF AK AB AB AB AB AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA CD-G10000/CP-G10000S PARTS CODE " " " " " " " " " " " " " " " " " " " " " " VRD-ST2CD103J " " " " " VRD-ST2CD104J " VRD-ST2CD123J VRD-ST2CD152J " " VRD-ST2CD153J VRD-ST2CD220J VRD-ST2CD221J VRD-ST2CD222J " VRD-ST2CD223J " " " VRD-ST2CD224J VRD-ST2CD331J " VRD-ST2CD332J " VRD-ST2CD333J " VRD-ST2CD471J VRD-ST2CD472J " " " VRD-ST2CD473J " " " " " VRD-ST2CD4R7J VRD-ST2CD560J " VRD-ST2CD561J VRD-ST2CD562J " " VRD-ST2CD563J " VRD-ST2CD681J " VRD-ST2CD682J " VRD-ST2CD683J VRD-ST2CD821J VRD-ST2EE101J VRD-ST2EE151J " VRD-ST2EE1R0J " VRD-ST2EE1R5J No. 10-R602 10-R603 10-R704 10-R705 10-R707 10-R708 10-R709 10-R710 10-R711 10-R712 10-R717 10-R723 10-R725 10-R730 10-R739 10-R741 10-R746 10-R769 10-R842 10-R910 10-RD13 10-RD25 10-R309 10-R573 10-R642 10-R745 10-R780 10-R859 10-R782 10-R801 10-R803 10-R944 10-R945 10-RD04 10-R111 10-R314 10-R858 10-R918 10-R921 10-R386 10-R853 10-R857 10-R864 10-R841 10-R618 10-R751 10-R358 10-R854 10-R692 10-R693 10-R375 10-R771 10-R787 10-R788 10-R789 10-R750 10-R802 10-R806 10-R843 10-R888 10-R889 10-R145 10-R115 10-R116 10-R729 10-R384 10-R387 10-R759 10-R934 10-R935 10-RD01 10-RD23 10-R690 10-R691 10-R950 10-RD24 10-R891 10-R149 10-R382 10-R94 10-R95 10-R794 PRICE NEW PART RANK MARK RANK AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA PARTS CODE " VRD-ST2EE221J VRD-ST2EE271J " VRD-ST2EE393J " VRD-ST2EE470J " VRD-ST2EE473J " VRD-ST2EE820J VRG-ST2EC101J " VRN-CM05N0R1J " VRN-CM05NR22J " VRS-CY1JB000J " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " VRS-CY1JB100J " VRS-CY1JB101J " " " VRS-CY1JB102J " " " " " " " " " " " " " " " " " " " " 26 No. 10-R795 10-R158 10-R391 10-R392 10-R927 10-R928 10-R804 10-R805 10-R929 10-R930 10-R844 10-R912 10-R958 10-R917 10-R922 10-R913 10-R916 1010-R1 10-R2 10-R4 10-R5 10-JP1 10-R327 10-R870 10-JP303 10-JP307 10-JP308 10-JP309 10-JP310 10-JP312 10-JP317 10-JP601 10-JP602 10-JP603 10-JP604 10-JP608 10-JP634 10-JP661 10-JP662 10-JP701 10-JP702 10-JP705 10-JP706 10-JP707 10-JP708 10-JP715 10-JP717 10-JP718 10-JP805 10-JP808 10-JP809 10-JP810 10-JP811 10-JP812 10-R9 10-R302 10-R27 10-R132 10-R133 10-R783 10-R18 10-R19 10-R41 10-R42 10-R43 10-R44 10-R45 10-R46 10-R47 10-R48 10-R60 10-R62 10-R64 10-R66 10-R67 10-R69 10-R70 10-R72 10-R74 10-R76 10-R77 PRICE NEW PART RANK MARK RANK AA AA AA AA AA AA AA AA AA AA AA AB AB AD AD AD AD AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA CD-G10000/CP-G10000S PARTS CODE " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " VRS-CY1JB103J " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " " VRS-CY1JB104J " " " VRS-CY1JB151J " VRS-CY1JB152J " " " " " " VRS-CY1JB153J " " No. 10-R78 10-R101 10-R102 10-R352 10-R356 10-R372 10-R373 10-R374 10-R376 10-R378 10-R701 10-R702 10-R703 10-R706 10-R713 10-R714 10-R715 10-R716 10-R718 10-R719 10-R720 10-R721 10-R722 10-R724 10-R732 10-R733 10-R736 10-R763 10-R784 10-R903 10-R904 10-R908 10-R956 10-RD03 10-R25 10-R26 10-R57 10-R58 10-R91 10-R92 10-RM1 10-RM2 10-R134 10-R135 10-R138 10-R139 10-R146 10-R147 10-R336 10-R365 10-R381 10-R604 10-R605 10-R641 10-R731 10-R761 10-R762 10-R766 10-R767 10-R768 10-R773 10-R777 10-R778 10-R779 10-RD19 10-RD31 10-R68 10-R117 10-R118 10-R311 10-R29 10-R83 10-R130 10-R131 10-R380 10-R919 10-R920 10-RD14 10-RD26 10-R112 10-R614 10-R615 PRICE NEW PART RANK MARK RANK AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA PARTS CODE " " " VRS-CY1JB182J VRS-CY1JB183J " VRS-CY1JB221J " " VRS-CY1JB222J " " " " " " " " " " " " " " " " " " " " " " VRS-CY1JB223J " " " " VRS-CY1JB224J " VRS-CY1JB225J VRS-CY1JB271J " " VRS-CY1JB272J " " " " VRS-CY1JB331J " VRS-CY1JB332J " " " VRS-CY1JB333J " " " " " VRS-CY1JB391J " " " " " " " " " VRS-CY1JB392J " " " " VRS-CY1JB470J VRS-CY1JB472J " " " " " 27 No. 10-R947 10-RD20 10-RD32 10-R359 10-R121 10-R122 10-R28 10-R75 10-R959 10-R8 10-R23 10-R24 10-R49 10-R59 10-R61 10-R63 10-R65 10-R71 10-R73 10-R82 10-R85 10-R103 10-R104 10-R379 10-R610 10-R611 10-R616 10-R617 10-R726 10-RD05 10-RD15 10-RD27 10-R144 10-R620 10-R621 10-R886 10-R887 10-R136 10-R137 10-R99 10-R98 10-RM5 10-R353 10-R350 10-R785 10-RD06 10-RD16 10-RD28 10-R12 10-R619 10-R81 10-R105 10-R106 10-R355 10-R3 10-R6 10-R97 10-R313 10-R909 10-RD21 10-R30 10-R31 10-R32 10-R33 10-R34 10-R35 10-R36 10-R37 10-R612 10-R613 10-R119 10-R120 10-R388 10-RD17 10-RD29 10-R7 10-R10 10-R17 10-R20 10-R21 10-R22 10-R40 PRICE NEW PART RANK MARK RANK AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA CD-G10000/CP-G10000S PARTS CODE " " " " " " " " " " " " " " " " " " " " " " " " " " " " VRS-CY1JB473J " " " " " " " " VRS-CY1JB474J VRS-CY1JB561J " VRS-CY1JB562J " " " " " " " " VRS-CY1JB563J " " " " " VRS-CY1JB681J " " " " " " " VRS-CY1JB682J " " " VRS-CY1JB683J " VRS-CY1JB820J VRS-CY1JB821J " " " VRS-CY1JB822J " " " VRS-VV3DA681J " VS2SD601AR/-1 " No. 10-R52 10-R56 10-R79 10-R84 10-R86 10-R87 10-R88 10-R89 10-R93 10-R96 10-R109 10-R110 10-R123 10-R124 10-R126 10-R127 10-R141 10-R148 10-R316 10-R360 10-R593 10-R606 10-R607 10-R775 10-R776 10-R786 10-R791 10-R957 10-R107 10-R108 10-R140 10-R143 10-R325 10-R377 10-R395 10-R781 10-R946 10-R357 10-R905 10-R906 10-R54 10-R128 10-R129 10-R351 10-R383 10-R385 10-R770 10-RD18 10-RD30 10-R38 10-R901 10-R902 10-R907 10-R911 10-R937 10-R39 10-R50 10-RM6 10-R322 10-R727 10-R728 10-R885 10-RD11 10-R14 10-R15 10-R16 10-R55 10-R150 10-R323 10-R80 10-R608 10-R609 10-RD02 10-RD12 10-R13 10-R643 10-R644 10-R790 10-R942 10-R943 2-Q3 2-Q4 PRICE NEW PART RANK MARK RANK AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AC AC AC AC PARTS CODE No. PRICE NEW PART RANK MARK RANK " VSKRA107S//-1 " " " " VSKRC102S//-1 " VSKRC104S//-1 " " " " " " VSKTA1266GR-1 VSKTA1271Y/-1 VSKTA1273Y/-1 " " VSKTA1274Y/-1 VSKTA1504Y/-1 " " VSKTC2875B/-1 " VSKTC3194Y/-1 VSKTC3199GR-1 " VSKTC3200GR-1 " " " VSKTC3203Y/-1 " " VSKTC3875GR-1 " " " " " " " " " " " " VVKNA12MM44-1 [ X ] XBBSD20P03000 XBBSD20P04000 XBSSD26P06000 XEBSD20P10000 XEBSD26P10000 " XEBSD30P10000 " XESSD30P10000 XHBSD30P06000 XHBSD40P08000 XJBSD30P10000 XJBSD30P12000 XJSSD30P08000 XMBSF35P16000 XWHSD32-10080 2-Q5 2-Q607 2-Q608 2-Q711 2-Q715 2-Q717 2-Q709 2-Q710 2-Q110 2-Q113 2-Q114 2-Q712 2-Q713 2-Q714 2-Q716 2-Q360 2-Q2 2-Q706 2-Q707 2-Q708 2-Q801 2-Q1 2-Q109 2-Q112 2-Q601 2-Q602 2-Q302 2-Q841 2-Q905 2-Q101 2-Q102 2-Q103 2-Q104 2-Q111 2-Q906 2-Q907 2-Q6 2-Q105 2-Q106 2-Q107 2-Q108 2-Q603 2-Q604 2-Q885 2-Q886 2-Q901 2-Q902 2-Q903 2-Q904 11-FL701 AC AB AB AB AB AB AB AB AC AC AC AC AC AC AC AB AC AE AE AE AE AB AB AB AC AC AD AB AB AC AC AC AC AC AC AC AB AB AB AB AB AB AB AB AB AB AB AB AB AX 12-703 14-609 12-701 13-803 14-604 15-911 13-804 14-602 14-605 14-616 14-608 14-601 15-909 14-606 15-910 14-615 AA AA AA AA AA AA AA AA AA AA AA AA AA AA AC AA [ 9 ] 92LBAG1460C1 92LCONE2P5268 92LCONE2P53253 92LCONE5P53253 92LCONE6P53253 92LCONE6P53254 92LCONE7P53253 92LCONE8P53254 92LCONEAP5267X 92LCRSTL1425A 92LCSPR1431C 92LFANT1746A 92LHPC1LFASY 92LMCUSN1524A 1711-CNP301 11-CNP971 11-CNP603 11-CNP3 11-CNP3A 11-CNP4 11-CNP2 11-CNP801 8-X351 14-216 1712-306 12-305 AB AB AB AB AC AC AC AC AC AF AA AD BB AD 28 CD-G10000/CP-G10000S PARTS CODE 92LMTR1854BASY " 92LMTR5515CASY " 92LMTR5529BASY " " " 92LNBAND1318A 92LPWB5534PWRS 92LPWB5612CDUS 92LPWB5813SPKS 92LPWB6232MANS 92LSWICH1401AT " " " " " " " " " " " " " " " " " " " " " " " " " " " " " No. 11-NM2 12-NM2 11-NM1 12-NM1 11-M1 11-M2 13-M1 13-M2 14-208 18-PWB-B 18-PWB-C 18-PWB-G 18-PWB-A 11-SW701 11-SW702 11-SW703 11-SW704 11-SW705 11-SW706 11-SW707 11-SW712 11-SW713 11-SW714 11-SW715 11-SW716 11-SW717 11-SW718 11-SW719 11-SW720 11-SW721 11-SW722 11-SW723 11-SW725 11-SW726 11-SW727 11-SW728 11-SW729 11-SW730 11-SW731 11-SW732 11-SW733 11-SW734 11-SW735 PRICE NEW PART RANK MARK RANK AP AP AS AS AD AD AD AD AA BQ BP AL BY AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC AC 29 CD-G10000/CP-G10000S 30 CD-G10000/CP-G10000S PARTS GUIDE No. S1506CDG10000 SPEAKER SYSTEM MODEL CP-G10000S CP-G10000S Speaker System consisting of CP-G10000S (front speaker system) and CP-SW10000S (active subwoofer). CONTENTS [1] INTEGRATED CIRCUITS [10] OTHER CIRCUITRY PARTS [2] TRANSISTORS [11] FRONT SPEAKER BOX PARTS [3] DIODES [4] TRANSFORMER [12] SUBWOOFER BOX PARTS [5] COILS [6] VARIABLE RESISTORS [7] THERMISTOR [13] ACCESSORIES/PACKING PARTS [14] P.W.B. ASSEMBLY (Not Replacement Item) [8] CAPACITORS „ INDEX [9] RESISTORS Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the safety and performance of the set. SHARP CORPORATION This document has been published to be used for after sales service only. The contents are subject to change without notice. CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [1] INTEGRATED CIRCUITS IC501 IC502 IC801 IC901 VHIKIA4558P-1 VHIKIA4558P-1 VHIKIA7812AP1 VHISTK41244-1 AC AC AF BF Ope Amp.,KIA4558P Ope Amp.,KIA4558P Voltage Regulator,KIA7812AP Power Amp.,STK41244 AD AC AB AB AB AB AB AB AB AC AC AC Silicon,NPN,KTC3205 Y Silicon,NPN,KTC3203 Y Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3199 GR Silicon,NPN,KTC3199 GR Digital,NPN,KRC102 M Digital,NPN,KRC102 M Digital,NPN,KRC104 M AH AH AB AB AB AB AA AA AA AB AB AA AA AA AA AA AA AA AK AK AC AC AC AC AB AB AB AB Silicon,D10XB60 Silicon,D10XB60 Silicon,GD1N4004 Silicon,GD1N4004 Silicon,GD1N4004 Silicon,GD1N4004 Silicon,1N4148H Silicon,1N4148H Silicon,1N4148H Silicon,GD1N4004 Silicon,GD1N4004 Silicon,1N4148H Silicon,1N4148H Silicon,1N4148H Silicon,1N4148H Silicon,1N4148H Silicon,1N4148H Silicon,1N4148H LED,Blue,A50ABC2L LED,Blue,A50ABC2L Zener,3.9V,DZ3.9BSB Zener,3.9V,DZ3.9BSB Zener,5.1V,DZ5.1BSB Zener,5.1V,DZ5.1BSB Zener,12V,DZ12BSB Zener,12V,DZ12BSB Zener,13V,DZ13BSB Zener,13V,DZ13BSB BL Power with CNS804/CNS805/CNS806 AC AC 3 µ H,Choke 3 µ H,Choke AK AE 10 kohm (A) [Crossover Frequency] 10 kohm (A) [Volume] AE Posistor,4.7 ohms AB AC AB AA AB AA AB AB AA AB AA AE AL AB AA AB AA AA AC AB 10 µ F,50V,Electrolytic 100 µ F,16V,Electrolytic 47 µ F,25V,Electrolytic 0.001 µ F,50V 10 µ F,50V,Electrolytic 100 pF,50V 0.033 µ F,50V,Mylar 10 µ F,50V,Electrolytic 100 pF,50V 10 µ F,50V,Electrolytic 100 pF,50V 1 µ F,50V,Thin Film 0.12 µ F,50V,Thin Film 0.1 µ F,50V,Mylar 100 pF,50V 10 µ F,50V,Electrolytic 100 pF,50V 100 pF,50V 0.22 µ F,50V,Thin Film 10 µ F,50V,Electrolytic [2] TRANSISTORS Q401 Q402 Q501 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 VSKTC3205Y/-1 VSKTC3203Y/-1 VSKTC3199GR-1 VSKTC3199GR-1 VSKTC3199GR-1 VSKTC3199GR-1 VSKTC3199GR-1 VSKTC3199GR-1 VSKTC3199GR-1 VSKRC102M//-1 VSKRC102M//-1 VSKRC104M//-1 [3] DIODES D801 D802 D803 D804 D805 D806 D901 D902 D903 D904 D905 D906 D907 D908 D910 D911 D912 D913 LED501 LED502 ZD501 ZD502 ZD503 ZD504 ZD901 ZD902 ZD903 ZD904 VHDD10XB60/-1 VHDD10XB60/-1 VHDGD1N4004-1 VHDGD1N4004-1 VHDGD1N4004-1 VHDGD1N4004-1 VHD1N4148H/-1 VHD1N4148H/-1 VHD1N4148H/-1 VHDGD1N4004-1 VHDGD1N4004-1 VHD1N4148H/-1 VHD1N4148H/-1 VHD1N4148H/-1 VHD1N4148H/-1 VHD1N4148H/-1 VHD1N4148H/-1 VHD1N4148H/-1 VHPA50ABC2L-1 VHPA50ABC2L-1 VHEDZ3R9BSB-1 VHEDZ3R9BSB-1 VHEDZ5R1BSB-1 VHEDZ5R1BSB-1 VHEDZ120BSB-1 VHEDZ120BSB-1 VHEDZ130BSB-1 VHEDZ130BSB-1 [4] TRANSFORMER ! PT801 RTRNPA006AWZZ [5] COILS L901 L902 RCILZ0024AWZZ RCILZ0024AWZZ [6] VARIABLE RESISTORS VR501 VR502 RVR-GA003AWZZ RVR-GA004AWZZ [7] THERMISTOR ! R401 RH-QX0006AWZZ [8] CAPACITORS C401 C402 C404 C501 C506 C507 C508 C510 C511 C512 C513 C514 C515 C516 C517 C518 C519 C520 C521 C522 VCEAZA1HW106M VCEAZA1CW107M VCEAZA1EW476M VCKYPA1HB102K VCEAZA1HW106M VCCSPA1HL101J VCQYKA1HM333K VCEAZA1HW106M VCCSPA1HL101J VCEAZA1HW106M VCCSPA1HL101J VCFYFA1HA105J VCFYFA1HA124J VCQYKA1HM104K VCCSPA1HL101J VCEAZA1HW106M VCCSPA1HL101J VCCSPA1HL101J VCFYFA1HA224J VCEAZA1HW106M 2 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [8] CAPACITORS ! C523 C526 C529 C803 C804 C805 C806 C807 C808 C810 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C912 C913 C914 C915 C916 C917 C918 C919 C920 C921 C922 C923 C925 C926 C927 C928 C929 C930 C931 C932 C933 C935 C937 VCCSPA1HL101J VCEAZA1HW106M VCEAZA1HW106M VCQYKA1HM104K VCQYKA1HM104K VCFYDA2AA224J VCFYDA2AA224J VCEAZA1EW108M VCQYKA1HM104K VCQYKA1HM104K VCEAZA1HW105M VCEAZA1HW105M VCQYKA1HM104K VCQYKA1HM104K VCEAZA1HW476M VCEAZA1HW476M VCCSPA1HL101J VCCSPA1HL101J VCCSPA1HL3R0C VCCSPA1HL3R0C VCQYKA1HM104K VCEAZA2AW107M VCEAZA2AW107M VCEAZA2AW107M VCEAZA2AW107M VCEAZA1HW107M VCQYKA1HM103K VCEAZA1HW107M VCQYKA1HM103K RC-EZ0124AWZZ RC-EZ0124AWZZ RC-EZ0085AWZZ RC-EZ0085AWZZ VCEAZA1HW476M VCFYFA1HA224J VCFYFA1HA224J VCFYFA1HA224J VCFYFA1HA224J VCEAZA1EW476M VCEAZA1HW106M VCEAZA1CW227M VCEAZA1CW227M RC-KZ002LAWZZ VCEAZA1HW104M AA AB AB AB AB AD AD AE AB AB AB AB AB AB AB AB AA AA AA AA AB AD AD AD AD AC AA AC AA AR AR AM AM AB AC AC AC AC AB AB AC AC AC AB 100 pF,50V 10 µ F,50V,Electrolytic 10 µ F,50V,Electrolytic 0.1 µ F,50V,Mylar 0.1 µ F,50V,Mylar 0.22 µ F,100V,Thin Film 0.22 µ F,100V,Thin Film 1000 µ F,25V,Electrolytic 0.1 µ F,50V,Mylar 0.1 µ F,50V,Mylar 1 µ F,50V,Electrolytic 1 µ F,50V,Electrolytic 0.1 µ F,50V,Mylar 0.1 µ F,50V,Mylar 47 µ F,50V,Electrolytic 47 µ F,50V,Electrolytic 100 pF,50V 100 pF,50V 3 pF,50V 3 pF,50V 0.1 µ F,50V,Mylar 100 µ F,100V,Electrolytic 100 µ F,100V,Electrolytic 100 µ F,100V,Electrolytic 100 µ F,100V,Electrolytic 100 µ F,50V,Electrolytic 0.01 µ F,50V,Mylar 100 µ F,50V,Electrolytic 0.01 µ F,50V,Mylar 3900 µ F,85V,Electrolytic 3900 µ F,85V,Electrolytic 4700 µ F,50V,Electrolytic 4700 µ F,50V,Electrolytic 47 µ F,50V,Electrolytic 0.22 µ F,50V,Thin Film 0.22 µ F,50V,Thin Film 0.22 µ F,50V,Thin Film 0.22 µ F,50V,Thin Film 47 µ F,25V,Electrolytic 10 µ F,50V,Electrolytic 220 µ F,16V,Electrolytic 220 µ F,16V,Electrolytic 0.0047 µ F,250V,Ceramic 0.1 µ F,50V,Electrolytic AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA 1.5 kohms,1/6W 1.8 kohms,1/6W 4.7 kohms,1/6W 120 kohms,1/6W 4.7 ohms,1/2W 10 kohm,1/6W 1.5 kohms,1/6W 100 kohm,1/6W 2.7 kohms,1/6W 1 kohm,1/4W 1 kohm,1/4W 100 kohm,1/6W 2.7 kohms,1/6W 1 kohm,1/6W 10 kohm,1/6W 1 kohm,1/4W 1 kohm,1/6W 1 kohm,1/4W 1 kohm,1/6W 2.2 kohms,1/6W 1 kohm,1/6W 5.6 kohms,1/6W 560 ohms,1/4W 560 ohms,1/4W 120 kohms,1/6W 470 kohms,1/6W 4.7 kohms,1/6W 10 kohm,1/6W 10 kohm,1/6W 5.6 kohms,1/6W 22 kohms,1/6W 56 kohms,1/6W 56 kohms,1/6W 1 kohm,1/6W 1 kohm,1/6W 560 ohms,1/6W 560 ohms,1/6W 56 kohms,1/6W 56 kohms,1/6W [9] RESISTORS R402 R403 R404 R405 R409 R501 R502 R507 R510 R511 R512 R513 R514 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R533 R535 R536 R537 R538 R801 R901 R902 R903 R904 R905 R906 R907 R908 VRD-ST2CD152J VRD-ST2CD182J VRD-ST2CD472J VRD-ST2CD124J VRD-RT2HD4R7J VRD-ST2CD103J VRD-ST2CD152J VRD-ST2CD104J VRD-ST2CD272J VRD-ST2EE102J VRD-ST2EE102J VRD-ST2CD104J VRD-ST2CD272J VRD-ST2CD102J VRD-ST2CD103J VRD-ST2EE102J VRD-ST2CD102J VRD-ST2EE102J VRD-ST2CD102J VRD-ST2CD222J VRD-ST2CD102J VRD-ST2CD562J VRD-ST2EE561J VRD-ST2EE561J VRD-ST2CD124J VRD-ST2CD474J VRD-ST2CD472J VRD-ST2CD103J VRD-ST2CD103J VRD-ST2CD562J VRD-ST2CD223J VRD-ST2CD563J VRD-ST2CD563J VRD-ST2CD102J VRD-ST2CD102J VRD-ST2CD561J VRD-ST2CD561J VRD-ST2CD563J VRD-ST2CD563J 3 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [9] RESISTORS ! ! R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R923 R924 R925 R926 R927 R928 R929 R930 R931 R932 R933 R934 R935 R936 R937 R938 R939 R940 R941 R942 R955 R957 R958 R959 R960 VRD-ST2CD102J VRD-ST2CD102J VRG-ST2EC101J VRG-ST2EC101J VRN-CM05NR22J VRN-CM05NR22J VRN-CM05N0R1J VRN-CM05N0R1J VRD-ST2CD152J VRD-ST2CD152J VRD-ST2CD222J VRD-ST2CD222J VRD-RT2HD152J VRD-RT2HD152J VRD-ST2EE393J VRD-ST2EE393J VRD-ST2EE473J VRD-ST2EE473J VRD-ST2CD563J VRD-ST2CD563J VRD-ST2CD563J VRD-RT2HD100J VRD-RT2HD100J VRD-RT2HD100J VRD-RT2HD100J VRS-VV3LA561J VRS-VV3LA561J VRD-ST2CD152J VRD-ST2CD152J VRD-ST2CD223J VRD-ST2CD473J VRD-ST2CD473J VRD-ST2CD153J VRD-ST2CD333J VRD-ST2CD103J VRD-ST2CD102J VRD-ST2CD473J VRD-ST2CD473J VRD-ST2CD103J AA AA AB AB AD AD AD AD AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AC AC AA AA AA AA AA AA AA AA AA AA AA AA 1 kohm,1/6W 1 kohm,1/6W 100 ohm,1/4W,Fusible 100 ohm,1/4W,Fusible 0.22 ohms,5W 0.22 ohms,5W 0.1 ohm,5W 0.1 ohm,5W 1.5 kohms,1/6W 1.5 kohms,1/6W 2.2 kohms,1/6W 2.2 kohms,1/6W 1.5 kohms,1/2W 1.5 kohms,1/2W 39 kohms,1/4W 39 kohms,1/4W 47 kohms,1/4W 47 kohms,1/4W 56 kohms,1/6W 56 kohms,1/6W 56 kohms,1/6W 10 ohm,1/2W 10 ohm,1/2W 10 ohm,1/2W 10 ohm,1/2W 560 ohm,3W 560 ohm,3W 1.5 kohms,1/6W 1.5 kohms,1/6W 22 kohms,1/6W 47 kohms,1/6W 47 kohms,1/6W 15 kohms,1/6W 33 kohms,1/6W 10 kohm,1/6W 1 kohm,1/6W 47 kohms,1/6W 47 kohms,1/6W 10 kohm,1/6W AE AD AB AB AB AB AB AA AC AC AC AC AB AD AC AB AC AF AF AH Connector Ass'y,2/2Pin with CNS501 Connector Ass'y,2/2Pin with CNS502 Plug,2Pin Plug,2Pin Plug,2Pin Plug,2Pin Plug,5Pin Plug,2Pin Plug,2Pin Plug,2Pin Plug,2Pin Plug,2Pin Plug,2Pin Plug,5Pin Plug,4Pin Plug,5Pin Connector Ass'y,2Pin Connector Ass'y,2/2Pin with CNS505 Connector Ass'y,5/5Pin with CNS902 Connector Ass'y,2/2Pin with CNS802 Connector Ass'y,4Pin Fuse,6.3A/125V Fuse,6.3A/125V Fuse,6.3A/125V Fuse,500mA/125V Lug Terminal Lug Terminal Motor,Air Cooling Fan Relay Jack,Subwoofer Input Switch,Push Type [Power] [10] OTHER CIRCUITRY PARTS ! ! ! ! ! ! ! ! ! ! BI501 BI502 CNP402 CNP501 CNP502 CNP503 CNP504 CNP505 CNP801 CNP802 CNP803 CNP804 CNP805 CNP806 CNP901 CNP902 CNS402 CNS503 CNS504 CNS803 CNS901 F801 F804 F805 F806 LG901 LG902 M401 RL901 SO501 SW802 QCNWNA106AWPZ QCNWNA105AWPZ 92LCONE2P53253 92LCONE2P53254 92LCONE2P53254 92LCONE2P5268 92LCONE5P53254 QCNCM705BAFZZ QCNCM049BAWZZ QCNCM049BAWZZ QCNCM049BAWZZ QCNCM049BAWZZ QCNCM035BAWZZ QCNCM050EAWZZ QCNCM050DAWZZ 92LCONE5P53253 QCNWN1542AWZZ QCNWNA075AWPZ QCNWNA077AWPZ QCNWNA076AWPZ QCNWNA141AWPZ QFS-D632CAWNI QFS-D632CAWNI QFS-D632CAWNI QFS-D501CAWNI QLUGP0001AWZZ QLUGP0001AWZZ RMOTV0059AWZZ RRLYD0016AWZZ QSOCJA010AWZZ QSW-P0014AWZZ AC AC AC AC AC AC AL AH AC AK 4 CD-G10000/CP-G10000S [11] FRONT SPEAKER BOX PARTS 906 903 SP1, 2 908 910x4 SP5, 6 909x2 907 SP3, 4 910x4 SP5, 6 TWEETER 902 904 905x4 SP3,4 WOOFER SP1,2 WOOFER 911x2 SP5, 6 TWEETER 901 BK C1, C2 Capacitor 2.7 µF, GY 250 V Electrolytic SP3,4 WOOFER 902 BK GY GY SP1,2 WOOFER 5 BK C1, C2 Capacitor 2.7 µF, 250 V Electrolytic C D - G 1 0 0 0 0 NO. / C P - G 1 0 0 0 0 S PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [11] FRONT SPEAKER BOX PARTS 901 902 903 904 905 907 908 909 910 911 SP1 SP2 SP3 SP4 SP5 SP6 CDECQA061AW01 CDECQA063AW01 GBOXSA042AW01 HPNLSA015AWSA PCUSGA020AWZZ QCNWNA147AWZZ TSPC-A313AWZZ XMBSF30P12000 XMBSF40P16000 XEBSD26P10000 RSP-ZA039AWZZ RSP-ZA039AWZZ RSP-ZA039AWZZ RSP-ZA039AWZZ RSP-ZA040AWZZ RSP-ZA040AWZZ Tweeter Ring Ass'y Woofer Ring Ass'y Speaker Box Ass'y Front Panel Cushion,Leg Lead Wire Ass'y (with Capacitor C1,2) Label,Specifications Screw,M3x12mm Screw,M4x16mm Screw,M2.6x10mm Woofer Woofer Woofer Woofer Tweeter Tweeter BB AZ ** BA AB AS AD AA AC AA BF BF BF BF AS AS 6 CD-G10000/CP-G10000S [12] SUBWOOFER BOX PARTS 946x2 946x2 952x4 955x4 911 954x13 926x2 947x2 PWB-A1 923x4 946x8 957 945 908 Silicon Grease 933 928 929x2 930x4 938 927x3 949x4 932x6 913 939x2 IC901 946x2 905 922 948x2 946x2 953 908 953 M401 913 952x4 955x4 923x4 940x4 930x4 911 927x3 PWB-A3 909 930 923 923 930 941x2 934 953 955x2 944 914 932x2 935 PWB-A2 937x4 914 944 946 953 953x5 918 904 921x2 956x6 921x4 PT801 912 931 910 SP1 SP1 SUBWOOFER 950x8 BK RD SP1 SUBWOOFER 950x4 PWB-B3 942x2 901 LED501 RD 902 924x4 903 916 BK 925 942x8 936x2 942x2 PWB-B2 944x4 920x2 951x8 917x8 906 907x2 PWB-B1 919x8 942x2 942x2 901-4 901-2 901-3 901-1 PWB-B4 916 LED502 7 CD-G10000/CP-G10000S NO. PARTS CODE PRICE NEW PART RANK MARK RANK DESCRIPTION [12] SUBWOOFER BOX PARTS ! ! 901 901- 1 901- 2 901- 3 901- 4 902 903 904 905 906 907 908 909 910 911 912 913 914 916 917 918 919 920 921 922 923 924 925 926 927 928 929 930 931 932 933 934 935 936 937 938 939 940 941 942 943 944 945 946 947 948 949 950 951 952 953 954 955 956 957 SP1 CDECQA064AW01 HDECQA064AWSA LHLDZA013AWZZ HDECQA066AWSA HDECQA065AWSA CDUC-A016AW01A CPNLSA017AW01 GBOXSA039AWSA GCOVHA011AWSA JKNBZA047AWSA JKNBZA048AWSA LANGKA017AWFW LANGKA021AWFW LBSHC0005AWZZ LCHSMA009AWFW LCHSSA005AWFW LHLDFA004AWZZ LHLDFA005AWZZ LHLDZA014AWZZ LHLDZ8002AWSA NFANP0001AWZZ PCOVQA002AWSA PCUSGA025AWZZ PCUSGA028AWZZ PCUSGA036AWZZ PCUSG0008AWZZ PCUSG0139AWZZ PCUSSA003AWZZ PFLT-A008AWZZ PFLT-A011AWZZ PRDARA054AWFW PRDARA044AWFW PSPAS0003AWZZ QACCD0032AW00 QFSHD0001AWZZ TSPC-A316AWZZ 92LCSPR1431C 92LNBAND1318A LX-EZ0010AWFD LX-HZ0169AFFD LX-JZ0036AWFD LX-JZ0037AWFD LX-WZ7004AWZZ XBBSD20P04000 XEBSD26P06000 XEBSD26P10000 XEBSD30P10000 XEBSF30P10000 XJBSD30P08000 XJBSD30P10000 XJBSD30P14000 XJBSF30P08000 XMBSF40P16000 XMPSF40P40000 XTBSF30P20000 XTBSF40P16000 XTBSF40P20000 XWHSD32-10130 PSHEZA073AWZZ TLABSA031AWZZ RSP-ZA107AWZZ Decoration Bar Ass'y Decoration Cover,Front White Reflector Edge Light Panel Decoration Cover,Rear Duct Port Ass'y Front Panel Ass'y Speaker Box Ass'y Rear Cover Knob,Power Knob,Volume/Crossover Frequency Bracket,Heat Sink Support Bracket,Fan Bushing,AC Power Supply Cord Chassis,Amp. Chassis,Power Transformer Holder,PWB,A Holder,PWB,B Holder,LED Catching Holder Rotary Fan Cover Cushion,Fan,A Cushion,Power Transformer Cushion,Fan,B Cushion,Gum Cushion,Leg Cushion,Duct Port Felt Felt,Amp. Chassis Heat Sink Heat Sink,Sub Spacer AC Power Supply Cord with CNS801 Holder,Fuse Label,Specifications Spring,Ring Nylon Band,80mm Screw,Special Screw,M4x8mm Screw,M3x12mm Screw,M3x18mm Washer,M3.2xM6x0.3mm Screw,M2x4mm Screw,M2.6x6mm Screw,M2.6x10mm Screw,M3x10mm Screw,M3x10mm Screw,M3x8mm Screw,M3x10mm Screw,M3x14mm Screw,M3x8mm Screw,M4x16mm Screw,M4x40mm Screw,M3x20mm Screw,M4x16mm Screw,M4x20mm Washer,M3.2xM13x1.0mm Speacer UL Label Subwoofer AU AL AE AH AE BF BY AV AF AE AE AE AD AK AM AC AC AC AG AD AE AB AC AB AB AG AE AA AA AY AE AC AB AD AA AA AA AA AB AB AB AA AA AA AA AA AA AA AA AA AC AC AB AA AA AA AB AD BV [13] ACCESSORIES/PACKING PARTS QCNWHA003AWZZ SPAKAA030AWZZ SPAKAA031AWZZ SPAKCA248AWZZ SSAKHA016AWZZ SSAKHA017AWZZ Speaker Cord,Front Speaker Packing Add.,Front Speaker Packing Add.,Subwoofer Packing Case Protection Bag,Front Speaker Polyethylene Bag,Subwoofer AN AN AV AH AG [14] P.W.B. ASSEMBLY (Not Replacement Item) ! ! PWB-A PWB-B 92LPWB6242AMPS 92LPWB6242CTRS — — Power/Transformer/Jack (PWB-A1~3)(Combined Ass'y) Volume/Power Switch/LED A/LED B (PWB-B1~4) (Combined Ass'y) 8 CD-G10000/CP-G10000S „INDEX INDEX PARTS CODE [ C ] CDECQA061AW01 CDECQA063AW01 CDECQA064AW01 CDUC-A016AW01A CPNLSA017AW01 [ G ] GBOXSA039AWSA GBOXSA042AW01 GCOVHA011AWSA [ H ] HDECQA064AWSA HDECQA065AWSA HDECQA066AWSA HPNLSA015AWSA [ J ] JKNBZA047AWSA JKNBZA048AWSA [ L ] LANGKA017AWFW LANGKA021AWFW LBSHC0005AWZZ LCHSMA009AWFW LCHSSA005AWFW LHLDFA004AWZZ LHLDFA005AWZZ LHLDZ8002AWSA LHLDZA013AWZZ LHLDZA014AWZZ LX-EZ0010AWFD LX-HZ0169AFFD LX-JZ0036AWFD LX-JZ0037AWFD LX-WZ7004AWZZ [ N ] NFANP0001AWZZ [ P ] PCOVQA002AWSA PCUSG0008AWZZ PCUSG0139AWZZ PCUSGA020AWZZ PCUSGA025AWZZ PCUSGA028AWZZ PCUSGA036AWZZ PCUSSA003AWZZ PFLT-A008AWZZ PFLT-A011AWZZ PRDARA044AWFW PRDARA054AWFW PSHEZA073AWZZ PSPAS0003AWZZ [ Q ] QACCD0032AW00 QCNCM035BAWZZ QCNCM049BAWZZ " " " QCNCM050DAWZZ QCNCM050EAWZZ QCNCM705BAFZZ QCNWHA003AWZZ QCNWN1542AWZZ QCNWNA075AWPZ QCNWNA076AWPZ QCNWNA077AWPZ QCNWNA105AWPZ QCNWNA106AWPZ QCNWNA141AWPZ QCNWNA147AWZZ QFS-D632CAWNI QFS-D632CAWNI QFS-D632CAWNI QFS-D501CAWNI QFSHD0001AWZZ QLUGP0001AWZZ " QSOCJA010AWZZ QSW-P0014AWZZ No. PRICE NEW PART RANK MARK RANK 11-901 11-902 12-901 12-902 12-903 BB AZ AU 12-904 11-903 12-905 BY ** AV 12-901- 1 12-901- 4 12-901- 3 11-904 AL AE AH BA 12-906 12-907 AF AE 12-908 12-909 12-910 12-911 12-912 12-913 12-914 12-917 12-901- 2 12-916 12-936 12-937 12-938 12-939 12-940 AE AE AD AK AM AC AC AG AE AC AA AA AB AB AB 12-918 AD 12-919 12-923 12-924 11-905 12-920 12-921 12-922 12-925 12-926 12-927 12-929 12-928 12-956 12-930 AE AB AG AB AB AC AB AE AA AA AE AY 12-931 10-CNP805 10-CNP801 10-CNP802 10-CNP803 10-CNP804 10-CNP901 10-CNP806 10-CNP505 1310-CNS402 10-CNS503 10-CNS803 10-CNS504 10-BI502 10-BI501 10-CNS901 11-907 10-F801 10-F804 10-F805 10-F806 12-932 10-LG901 10-LG902 10-SO501 10-SW802 PARTS CODE [ R RC-EZ0085AWZZ " RC-EZ0124AWZZ " RCILZ0024AWZZ " RC-KZ002LAWZZ RH-QX0006AWZZ RMOTV0059AWZZ RRLYD0016AWZZ RSP-ZA039AWZZ " " " RSP-ZA040AWZZ " RSP-ZA107AWZZ RTRNPA006AWZZ RVR-GA003AWZZ RVR-GA004AWZZ [ S SPAKAA030AWZZ SPAKAA031AWZZ SPAKCA248AWZZ SSAKHA016AWZZ SSAKHA017AWZZ [ T TLABSA031AWZZ TSPC-A313AWZZ TSPC-A316AWZZ [ V VCCSPA1HL101J " " " " " " " " VCCSPA1HL3R0C " VCEAZA1CW107M VCEAZA1CW227M " VCEAZA1EW108M VCEAZA1EW476M " VCEAZA1HW104M VCEAZA1HW105M " VCEAZA1HW106M " " " " " " " " VCEAZA1HW107M " VCEAZA1HW476M " " VCEAZA2AW107M " " " VCFYDA2AA224J " VCFYFA1HA105J VCFYFA1HA124J VCFYFA1HA224J " " " " BF AC AB AC AC AC AC AC AD AA AN AC AF AH AF AD AE AS AB AC AC AC AK 9 No. PRICE NEW PART RANK MARK RANK ] 8-C922 8-C923 8-C920 8-C921 5-L901 5-L902 8-C935 7-R401 10-M401 10-RL901 11-SP1 11-SP2 11-SP3 11-SP4 11-SP5 11-SP6 12-SP1 4-PT801 6-VR501 6-VR502 AM AM AR AR AC AC AC AE AL AH 1313131313- AN AV BV BL AK AE ] AH AG ] 12-957 11-908 12-933 AD AD ] 8-C507 8-C511 8-C513 8-C517 8-C519 8-C520 8-C523 8-C907 8-C908 8-C909 8-C910 8-C402 8-C932 8-C933 8-C807 8-C404 8-C930 8-C937 8-C901 8-C902 8-C401 8-C506 8-C510 8-C512 8-C518 8-C522 8-C526 8-C529 8-C931 8-C916 8-C918 8-C905 8-C906 8-C925 8-C912 8-C913 8-C914 8-C915 8-C805 8-C806 8-C514 8-C515 8-C521 8-C926 8-C927 8-C928 8-C929 AA AA AA AA AA AA AA AA AA AA AA AC AC AC AE AB AB AB AB AB AB AB AB AB AB AB AB AB AB AC AC AB AB AB AD AD AD AD AD AD AE AL AC AC AC AC AC CD-G10000/CP-G10000S PARTS CODE VCKYPA1HB102K VCQYKA1HM103K " VCQYKA1HM104K " " " " " " " VCQYKA1HM333K VHD1N4148H/-1 " " " " " " " " " VHDD10XB60/-1 " VHDGD1N4004-1 " " " " " VHEDZ120BSB-1 " VHEDZ130BSB-1 " VHEDZ3R9BSB-1 " VHEDZ5R1BSB-1 " VHIKIA4558P-1 " VHIKIA7812AP1 VHISTK41244-1 VHPA50ABC2L-1 " VRD-RT2HD100J " " " VRD-RT2HD152J " VRD-RT2HD4R7J VRD-ST2CD102J " " " " " " " " VRD-ST2CD103J " " " " " VRD-ST2CD104J " VRD-ST2CD124J " VRD-ST2CD152J " " " " " VRD-ST2CD153J VRD-ST2CD182J VRD-ST2CD222J " " VRD-ST2CD223J No. 8-C501 8-C917 8-C919 8-C516 8-C803 8-C804 8-C808 8-C810 8-C903 8-C904 8-C911 8-C508 3-D901 3-D902 3-D903 3-D906 3-D907 3-D908 3-D910 3-D911 3-D912 3-D913 3-D801 3-D802 3-D803 3-D804 3-D805 3-D806 3-D904 3-D905 3-ZD901 3-ZD902 3-ZD903 3-ZD904 3-ZD501 3-ZD502 3-ZD503 3-ZD504 1-IC501 1-IC502 1-IC801 1-IC901 3-LED501 3-LED502 9-R930 9-R931 9-R932 9-R933 9-R921 9-R922 9-R409 9-R517 9-R520 9-R522 9-R524 9-R903 9-R904 9-R909 9-R910 9-R957 9-R501 9-R518 9-R536 9-R537 9-R955 9-R960 9-R507 9-R513 9-R405 9-R528 9-R402 9-R502 9-R917 9-R918 9-R936 9-R937 9-R941 9-R403 9-R523 9-R919 9-R920 9-R801 PRICE NEW PART RANK MARK RANK AA AA AA AB AB AB AB AB AB AB AB AB AA AA AA AA AA AA AA AA AA AA AH AH AB AB AB AB AB AB AB AB AB AB AC AC AC AC AC AC AF BF AK AK AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA PARTS CODE No. " VRD-ST2CD272J " VRD-ST2CD333J VRD-ST2CD472J " VRD-ST2CD473J " " " VRD-ST2CD474J VRD-ST2CD561J " VRD-ST2CD562J " VRD-ST2CD563J " " " " " " VRD-ST2EE102J " " " VRD-ST2EE393J " VRD-ST2EE473J " VRD-ST2EE561J " VRG-ST2EC101J " VRN-CM05N0R1J " VRN-CM05NR22J " VRS-VV3LA561J " VSKRC102M//-1 " VSKRC104M//-1 VSKTC3199GR-1 " " " " " " VSKTC3203Y/-1 VSKTC3205Y/-1 [ X ] XBBSD20P04000 XEBSD26P06000 XEBSD26P10000 " XEBSD30P10000 XEBSF30P10000 XJBSD30P08000 XJBSD30P10000 XJBSD30P14000 XJBSF30P08000 XMBSF30P12000 XMBSF40P16000 " XMPSF40P40000 XTBSF30P20000 XTBSF40P16000 XTBSF40P20000 XWHSD32-10130 12-941 12-942 11-911 12-943 12-944 12-945 12-946 12-947 12-948 12-949 11-909 11-910 12-950 12-951 12-952 12-953 12-954 12-955 AA AA AA AA AA AA AA AA AA AA AA AC AC AC AB AA AA AA [ 9 ] 92LCONE2P5268 92LCONE2P53253 92LCONE2P53254 " 92LCONE5P53253 92LCONE5P53254 92LCSPR1431C 92LNBAND1318A 92LPWB6242AMPS 92LPWB6242CTRS 10-CNP503 10-CNP402 10-CNP501 10-CNP502 10-CNP902 10-CNP504 12-934 12-935 14-PWB-A 14-PWB-B AB AB AB AB AB AB AA AA BX AZ 10 9-R938 9-R510 9-R514 9-R942 9-R404 9-R535 9-R939 9-R940 9-R958 9-R959 9-R533 9-R905 9-R906 9-R525 9-R538 9-R901 9-R902 9-R907 9-R908 9-R927 9-R928 9-R929 9-R511 9-R512 9-R519 9-R521 9-R923 9-R924 9-R925 9-R926 9-R526 9-R527 9-R911 9-R912 9-R915 9-R916 9-R913 9-R914 9-R934 9-R935 2-Q907 2-Q908 2-Q909 2-Q501 2-Q901 2-Q902 2-Q903 2-Q904 2-Q905 2-Q906 2-Q402 2-Q401 PRICE NEW PART RANK MARK RANK AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AA AB AB AD AD AD AD AC AC AC AC AC AB AB AB AB AB AB AB AC AD CD-G10000/CP-G10000S −− MEMO −− 11 CD-G10000/CP-G10000S −− MEMO −− 12 CD-G10000/CP-G10000S ̌HOW TO ORDER REPLACEMENT PARTS̍ To have your order filled promptly and correctly, please furnish the following information. 1. MODEL NUMBER 2. REF. No. 3. PART NO. 4. DESCRIPTION For U.S.A. only Contact your nearest SHARP Parts Distributor to order. For location of SHARP Parts Distributor, Please call Toll-Free; 1-800-BE-SHARP MARK: SPARE PARTS-DELIVERY SECTION Explanation of capacitors/resistors parts codes Capacitors Resistors VCC ....................... Ceramic type VCK ........................ Ceramic type VCT ........................ Semiconductor type VC MF ............... Cylindrical type (without lead wire) VC MN............... Cylindrical type (without lead wire) VC TV................ Square type (without lead wire) VC TQ ............... Square type (without lead wire) VC CY ............... Square type (without lead wire) VC CZ ............... Square type (without lead wire) VC J.. The 13th character represents capacity difference. ("J" ±5%, "K" ±10%, "M" ±20%, "N" ±30%, "C" ±0.25 pF, "D" ±0.5 pF, "Z" +80-20%.) VRD ....................... Carbon-film type VRS ........................ Carbon-film type VRN ....................... Metal-film type VR MF ............... Cylindrical type (without lead wire) VR MN............... Cylindrical type (without lead wire) VR TV................ Square type (without lead wire) VR TQ ............... Square type (without lead wire) VR CY ............... Square type (without lead wire) VR CZ ............... Square type (without lead wire) VR J.. The 13th character represents error. ("J" ±5%, "F" ±1%, "D" ±0.5%.) If there are no indications for the electrolytic capacitors, error is ±20%. CAUTION:FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH SAME TYPE F801,F804,F805 6.3A, 125V / F806 500mA, 125V FUSES If there are no indications for other parts, the resistors are ±5% carbon-film type. ATTENTION:POUR ASSURER UNE LONGUE PROTECTION CONTRE UN INCENDIE, REMPLACER SEULEMENT PAR UN FUSIBLE DE TYPE F801,F804,F805 6.3A, 125V F806 500mA, 125V NOTE: Parts marked witȟ ̍are important for maintaining the safety of the set. Be sure to replace parts with specified ones for maintaining the safety and performance of the set. CD-G10000/CP-G10000S COPYRIGHT © 2005 BY SHARP CORPORATION ALL RIGHTS RESERVED. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any from or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher. SHARP CORPORATION AV Systems Group Quality & Reliability Control Center Higashihiroshima, Hiroshima 739-0192, Japan Printed in Japan A0501-210DS HA M SC