Transcript
SERVICE MANUAL COMPACT COMPONENT SYSTEM 3 2004 MB161
HX-GX7 Area suffix J ----------------------------- U.S.A. C -------------------------- Canada
SP-HXGX7
CA-HXGX7
SP-HXGX7
TABLE OF CONTENTS 1 2 3 4 5
PRECAUTION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 SPECIFIC SERVICE INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6 DISASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7 ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-37 TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-41
COPYRIGHT © 2004 VICTOR COMPANY OF JAPAN, LIMITED
No.MB161 2004/3
SPECIFICATION Amplifier section-CA-HXGX7 Output Power SUBWOOFERS
180 W per channel, min. RMS, driven into 6 Ω at 63 Hz with no more than 10 %total harmonic distortion.
MAIN SPEAKERS
80 W per channel, min. RMS, driven into 6 Ω at 1 kHz with no more than 10 %total harmonic distortion.
Audio input sensitivity/impedance (Measured at 1 kHz, with tape recording signal 300 mV) AUX Speakers/impedance
300 mV/47 kΩ SUBWOOFERS
6 Ω - 16 Ω
MAIN SPEAKERS 6 Ω - 16 Ω Tuner FM tuning range
87.5 MHz - 108.0 MHz
AM tuning range
530 kHz - 1 710 kHz
CD player CD capacity
5 discs
Dynamic range
87 dB
Signal-to-noise ratio
90 dB
Wow and flutter
Immeasurable
MP3 recording format
MPEG 1/2 Audio Layer 3
Max. Bit rate
320 kbps
Cassette deck Frequency response
Normal (type I)
50 Hz - 14 000 Hz
Wow and flutter
0.15 % (WRMS)
General Power requirement
AC 120 V , 60 Hz
Power consumption
245 W/310 VA (at operation) 26 W (on standby)
Dimensions (approx.)
205 mm × 370 mm × 432 mm (W/H/D) (8 1/8 in. × 14 5/8 in. × 17 1/0 16 in.)
Mass (approx.)
10.5 kg (23.2 lbs) Speaker section-SP-HXGX7
Type Speaker Systems
3-Way 4-Speaker Bass-Reflex Type Subwoofer Woofer
12 cm (4 3/4 in.) cone × 2
Tweeter
5 cm (2 in.) cone × 1
Power handling capacity Subwoofer Impedance Frequency range Sound pressure level
16 cm (6 5/16 in.) cone × 1
360 (180 + 180) W
Main speaker
160 (80 + 80) W
Subwoofer
6Ω
Main speaker
6Ω
Subwoofer
27 Hz - 1000 Hz
Main speaker
70 Hz - 25 000 Hz
Subwoofer
78 dB/W·m
Main speaker
88 dB/W·m
Dimensions (approx.)
227 mm × 432 mm × 376 mm (W/H/D) (8 15/16 in. × 17 1/16 in. × 14 13/16 in.)
Mass (approx.)
8 kg (17.7 lbs) each
Design and specifications are subject to change without notice.
1-2 (No.MB161)
SECTION 1 PRECAUTION 1.1
Safety Precautions
(1) This design of this product contains special hardware and many circuits and components specially for safety purposes. For continued protection, no changes should be made to the original design unless authorized in writing by the manufacturer. Replacement parts must be identical to those used in the original circuits. Services should be performed by qualified personnel only.
voltmeter. Move the resistor connection to each exposed metal part, particularly any exposed metal part having a return path to the chassis, and measure the AC voltage across the resistor. Now, reverse the plug in the AC outlet and repeat each measurement. Voltage measured any must not exceed 0.75 V AC (r.m.s.). This corresponds to 0.5 mA AC (r.m.s.).
(2) Alterations of the design or circuitry of the product should not be made. Any design alterations of the product should not be made. Any design alterations or additions will void the manufacturers warranty and will further relieve the manufacture of responsibility for personal injury or property damage resulting therefrom. (3) Many electrical and mechanical parts in the products have special safety-related characteristics. These characteristics are often not evident from visual inspection nor can the protection afforded by them necessarily be obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified in the Parts List of Service Manual. Electrical components having such features are identified by shading on the schematics and by ( ) on the Parts List in the Service Manual. The use of a substitute replacement which does not have the same safety characteristics as the recommended replacement parts shown in the Parts List of Service Manual may create shock, fire, or other hazards. (4) The leads in the products are routed and dressed with ties, clamps, tubings, barriers and the like to be separated from live parts, high temperature parts, moving parts and/or sharp edges for the prevention of electric shock and fire hazard. When service is required, the original lead routing and dress should be observed, and it should be confirmed that they have been returned to normal, after reassembling. (5) Leakage shock hazard testing After reassembling the product, always perform an isolation check on the exposed metal parts of the product (antenna terminals, knobs, metal cabinet, screw heads, headphone jack, control shafts, etc.) to be sure the product is safe to operate without danger of electrical shock.Do not use a line isolation transformer during this check. • Plug the AC line cord directly into the AC outlet. Using a "Leakage Current Tester", measure the leakage current from each exposed metal parts of the cabinet, particularly any exposed metal part having a return path to the chassis, to a known good earth ground. Any leakage current must not exceed 0.5mA AC (r.m.s.). • Alternate check method Plug the AC line cord directly into the AC outlet. Use an AC voltmeter having, 1,000Ω per volt or more sensitivity in the following manner. Connect a 1,500Ω 10W resistor paralleled by a 0.15µF AC-type capacitor between an exposed metal part and a known good earth ground. Measure the AC voltage across the resistor with the AC
AC VOLTMETER (Having 1000 ohms/volts, or more sensitivity)
0.15 F AC TYPE
1500
10W
Place this probe on each exposed metal part.
Good earth ground
1.2
Warning
(1) This equipment has been designed and manufactured to meet international safety standards. (2) It is the legal responsibility of the repairer to ensure that these safety standards are maintained. (3) Repairs must be made in accordance with the relevant safety standards. (4) It is essential that safety critical components are replaced by approved parts. (5) If mains voltage selector is provided, check setting for local voltage.
1.3
Caution
Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system.
1.4
Critical parts for safety
In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the " " mark nearby are critical for safety. When replacing them, be sure to use the parts of the same type and rating as specified by the manufacturer. (This regulation dose not Except the J and C version)
(No.MB161)1-3
1.5
Preventing static electricity
Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser diode in the traverse unit (optical pickup). Take care to prevent this when performing repairs. 1.5.1 Grounding to prevent damage by static electricity Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as laser products. Be careful to use proper grounding in the area where repairs are being performed. (1) Ground the workbench Ground the workbench by laying conductive material (such as a conductive sheet) or an iron plate over it before placing the traverse unit (optical pickup) on it. (2) Ground yourself Use an anti-static wrist strap to release any static electricity built up in your body.
(caption) Anti-static wrist strap 1M
Conductive material (conductive sheet) or iron palate
(3) Handling the optical pickup • In order to maintain quality during transport and before installation, both sides of the laser diode on the replacement optical pickup are shorted. After replacement, return the shorted parts to their original condition. (Refer to the text.) • Do not use a tester to check the condition of the laser diode in the optical pickup. The tester's internal power source can easily destroy the laser diode.
1.6
Handling the traverse unit (optical pickup)
(1) Do not subject the traverse unit (optical pickup) to strong shocks, as it is a sensitive, complex unit. (2) Cut off the shorted part of the flexible cable using nippers, etc. after replacing the optical pickup. For specific details, refer to the replacement procedure in the text. Remove the anti-static pin when replacing the traverse unit. Be careful not to take too long a time when attaching it to the connector. (3) Handle the flexible cable carefully as it may break when subjected to strong force. (4) I t is not possible to adjust the semi-fixed resistor that adjusts the laser power. Do not turn it.
1.7
Attention when traverse unit is decomposed
*Please refer to "Disassembly method" in the text for the pickup unit. • Apply solder to the short land sections before the flexible wire is disconnected from the connecto on the servo board. (If the flexible wire is disconnected without applying solder, the pickup may be destroyed by static electricity.) • In the assembly, be sure to remove solder from the short land sections after connecting the flexible wire.
Short round
Card wire
Pickup
Flexible board
1-4 (No.MB161)
Importance administering point on the safety
F001
F101
F102
8A-125V
8A-125V
6.3A-125V
3.15A-125V
1.8
F104
Caution: For continued protection against risk of fire, replace only with same type 6.3 A/125 V for F001, 8 A/125 V for F101 and F102, 3.15 A/125 V for F104. This symbol specifies type of fast operating fuse. Precaution: Pour eviter risques de feux, remplacez le fusible de surete de F001 comme le meme type que 6,3 A/125 V, 8 A/125 V pour F101 et F102, et 3.15 A/125 V pour F104. ^ Ce sont des fusibles suretes qui functionnes rapide.
(No.MB161)1-5
SECTION 2 SPECIFIC SERVICE INSTRUCTIONS This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS.
1-6 (No.MB161)
SECTION 3 DISASSEMBLY 3.1
Main body section
3.1.1 Removing the metal cover (See Figs.1 to 3) (1) From the back side of the main body, remove the six screws A attaching the metal cover. (See Fig.1.) (2) From the both sides of the main body, remove the two screws B attaching the metal cover. (See Figs.2 and 3.) (3) Remove the metal cover from the main body while lifting the rear section of the metal cover in the direction of the arrow. (See Figs.2 and 3.)
A
Metal cover
A
A Fig.1
Metal cover
B Fig.2
Metal cover
B Fig.3 (No.MB161)1-7
3.1.2 Removing the front panel assembly (See Figs.4 to 7) • Prior to performing the following procedures, remove the metal cover. (1) From the right side of the main body, disconnect the card wires from the connectors (CN43, CN44, CN802, CN803) on the main board. (See Fig.4.) (2) Disconnect the earth wire from the chassis base. (See Fig.4.) (3) From the top side of the main body, disconnect the parallel wires from the connectors (CN201, CN205) on the bridge board. (See Fig.5.)
(4) (5)
(6) (7)
CN201
Reference: When reassembling, pass the parallel wire through the hole a on the plastic chassis before connecting the parallel wire to the connector CN201 on the bridge board. (See Fig.5.) Disconnect the earth wire from the chassis base. (See Fig.6.) From the both sides of the main body, remove the two screws C attaching the front panel assembly. (See Figs.4 and 6.) From the bottom side of the main body, remove the three screws D attaching the front panel assembly. (See Fig.7.) Release the joints b of the front panel assembly from the chassis base and remove the front panel assembly in the direction of the arrow. (See Figs.4,6 and 7.)
Front panel assembly
Card wires CN802
CN205 Parallel wire
Bridge board
Parallel wire a Parallel wire Plastic chassis Fig.5
Front panel assembly
Main board
C C Earth wire
b Chassis base Earth wire
b
CN43 CN803 Card wires CN44 Chassis base Fig.4
Fig.6
Front panel assembly
b
D
b Fig.7
1-8 (No.MB161)
Chassis base
3.1.3 Removing the tuner (See Figs.8 and 9.) • Prior to performing the following procedures, remove the metal cover. (1) From the right side of the main body, disconnect the card wire from the connector CN560 on the main board. (See Fig.8.) (2) From the back side of the main body, remove the two screws E attaching the tuner to the rear panel. (See Fig.9.)
CN560
Tuner Fig.8
E
Card wires
Main board
Rear panel
Fig.9
(No.MB161)1-9
3.1.4 Removing the rear panel (See Figs.10 to 12) • Prior to performing the following procedures, remove the metal cover. (1) From the top side of the main body, disconnect the wire from the connector CN202 on the bridge board. (See Fig.10.) (2) From the back side of the main body, remove the screw F and two screws G attaching the rear cover. (See Fig.11.) (3) Release the sections d and remove the rear cover. (See Fig.11.) (4) Remove the screw H and eleven screws J attaching the rear panel. (See Fig.12.) (5) From the both sides of the main body, release the joints e attaching the rear panel to the chassis base and remove the rear panel with the fan. (See Fig.12.)
Bridge board CN202
3.1.5 Removing the fan (See Figs.10 to 12) • Prior to performing the following procedures, remove the metal cover. (1) From the top side of the main body, disconnect the wire from the connector CN202 on the bridge board. (See Fig.10.) (2) From the back side of the main body, remove the screw F and two screws G attaching the rear cover. (See Fig.11.) (3) Remove the two screws K attaching the fan. (See Fig.12.) (4) Take out the fan from the main body.
Fig.10
G
F d d
d
Rear cover Fig.11
J
Rear panel
J Fan
K
K H
J
J
e
J Fig.12
1-10 (No.MB161)
e
3.1.6 Removing the main board (See Figs.13 and 14) • Prior to performing the following procedures, remove the metal cover and rear panel.
Card wires
Main board CN803 CN802
Reference: Remove the tuner as required. (1) From the right side of the main body, disconnect the card wires from the connectors (CN43, CN44, CN661, CN802, CN803) on the main board. (See Fig.13.) (2) Remove the two screws L attaching the main board. (See Fig.14.) (3) Disconnect the connector CN217 on the main board toward this side and disconnect the connector CN501 on the main board in the direction of the arrow. (See Fig.14.) Reference: • When attaching the main board, insert the sections f of the bridge board in the hole of the main board. (See Fig.14.) • Insert the section g of the main board in the hole of the chassis base before attaching the screws L.
CN661
CN44 Fig.13
Card wires Bridge board
CN43 Main board
L
f
CN217
f
CN501
Main board
L
g Chassis base Fig.14
(No.MB161)1-11
3.1.7 Removing the main amplifier board/subwoofer amplifier boards (See Figs.15 to 17) • Prior to performing the following procedures, remove the metal cover, rear panel and main board. (1) From the top side of the main body, disconnect the wires from the connector (CN206, CN208) on the bridge board. (See Fig.15.) (2) From the back side of the main body, disconnect the connectors (CN600, CN700) on the main amplifier/subwoofer amplifier boards from the connection board in the direction of the arrow. (See Fig.16.) (3) From the side of the main amplifier/subwoofer amplifier boards, remove the tie band bundling the wires. (See Fig.17.) Reference: After reassembling, bundle the wires with the tie band. (See Fig.17.) (4) Remove the two screws M and screw N attaching the main amplifier board. (See Fig.17.) (5) Removing the two screws P and screw Q attaching the subwoofer amplifier board. (See Fig.17.)
Bridge board Wires
CN208
CN206 Fig.15
Main amplifier board Subwoofer amplifier board
Heat sink
CN606
CN700
Connection board Fig.16
Tie band
Wires
M P Q Subwoofer amplifier board Fig.17
1-12 (No.MB161)
N Main amplifier board
3.1.8 Removing the connection board (See Fig.18.) • Prior to performing the following procedure, remove the metal cover, rear panel, main board and main amplifier/subwoofer amplifier boards. (1) From the top side of the main body, remove the two screws R attaching the connection board on the chassis base. Reference: When reassembling, attach the connection board to the section h and align the projection i of the chassis base to the hole of the connection board.
Connection board
R
i
h
R
Chassis base
Fig.18 3.1.9 Removing the bridge board (See Figs.19 and 20) • Prior to performing the following procedures, remove the metal cover, rear panel and main board. (1) From the top side of the main body, disconnect the wires from the connectors (CN206, CN208, CN214) on the bridge board. (See Fig.19.)
Bridge board Parallel wire
Wires CN205
CN208
Reference: After connecting the wire to the connector CN214, fix the wire with the wire holder. (See Fig.19.) (2) Disconnect the parallel wires from the connectors (CN201, CN205, CN213) on the bridge board. (See Fig.19.) (3) Remove the two screws S attaching the bridge board on the 5CD changer mechanism assembly. (See Fig.20.) (4) Bend the claw j in the direction of the arrow and remove the bridge board in an upward direction. (See Fig.20.) Reference: • When attaching the bridge board, align the projections (k,m) in the hole of the bridge board. (See Fig.20.) • When reassembling, pass the wires through the sections (n, p) of the plastic chassis. (See Fig.19.)
CN214
CN206
CN201 CN213
n
p Wire holder
Fig.19
Bridge board k
m
S
S
j
5CD changer mechanism assembly
Fig.20
(No.MB161)1-13
3.1.10 Removing the 5CD changer mechanism assembly (See Figs.21 and 23) • Prior to performing the following procedures, remove the metal cover, rear panel, main board and bridge board. (1) From the both sides of the main body, remove the two screws T attaching the 5CD changer mechanism assembly to the front panel assembly. (See Figs.21 and 22.) (2) Take out the 5CD changer mechanism assembly from the main body.
Front panel assembly 5CD changer mechanism assembly
Reference: When attaching the 5CD changer mechanism assembly, pass the wires through the sections (n, p) of the plastic chassis. (See Fig.22.) (3) From the both and top sides of the 5CD changer mechanism assembly, remove the two screws U and screw V attaching the main chassis. (See Fig.23.) (4) From the top side of the 5CD changer mechanism assembly, remove the three screws W and screw X attaching the 5CD changer mechanism assembly on the plastic chassis. Reference: • When reassembling, align the projections (q,r,s) of the plastic chassis to the holes of the 5CD changer mechanism assembly before attaching the screws W and X. (See Fig.23.) • Align the projections t of the plastic chassis to the holes of the main chassis before attaching the screw V. (See Fig.23.)
T Fig.21
Front panel assembly 5CD changer mechanism assembly Wires
n
p
T
Fig.22
5CD changer mechanism assembly
W
q
U
W
Main chassis
t
Plastic chassis
V t
Earth wire
W r s
W
U Fig.23
1-14 (No.MB161)
X
3.1.11 Removing the primary board (See Figs.19,21,22,24 and 25) • Prior to performing the following procedures, remove the metal cover, rear panel and main board. (1) From the top side of the main body, disconnect the wires from the connectors (CN206, CN208, CN214) on the bridge board. (See Fig.19.) Reference: After connecting the wire to the connector CN214, fix the wire with the wire holder. (See Fig.19.) (2) Disconnect the parallel wires from the connectors (CN201, CN205, CN213) on the bridge board. (See Fig.19.) (3) From the both sides of the main body, remove the two screws T attaching the 5CD changer mechanism assembly to the front panel assembly. (See Figs.21 and 22.)
Primary board
Y
Y
Chassis base Fig.24
Reference: It is not necessary to remove the bridge board from the 5CD changer mechanism assembly. (4) Take out the 5CD changer mechanism assembly with the bridge board from the main body.
Primary board
Reference: When attaching the 5CD changer mechanism assembly, pass the wires through the sections (m, n) of the 5CD changer mechanism assembly. (See Fig.22.) (5) From the top and left sides of the main body, remove the four screws Y and screw Z attaching the primary board on the chassis base. (See Figs.24 and 25.) (6) From the forward side of the primary board, disconnect the power cord from the connector CN200. (See Fig.25.)
CN200
Power cord
Chassis base
Z
Fig.25 3.1.12 Removing the FL board (See Fig.26) • Prior to performing the following procedures, remove the metal cover and front panel assembly. (1) From the inside of the front panel assembly, remove the soldered sections (u, v) on the FL board to remove the parallel wires. (2) Disconnect the card wire from the connector CN902 on the FL board. (3) Remove the four screws AA attaching the FL board. Reference: When attaching the FL board, align the projections w of the front panel assembly in the holes of the FL board before attaching the screws AA.
Front panel assembly w
FL board
AA
AA
AA
w
AA
u
v
Card wire
CN902
Parallel wire
Parallel wire
Fig.26
(No.MB161)1-15
3.1.13 Removing the switch board (See Fig.27) • Prior to performing the following procedures, remove the metal cover and front panel assembly. (1) From the inside of the front panel assembly, remove the three screws AB attaching the switch board. (2) Take out the switch board and remove the soldered section x on the switch board to remove the parallel wire. Reference: When attaching the switch board, align the projections y in the holes of the switch board before attaching the screws AB. 3.1.14 Removing the standby LED board (See Fig.27) • Prior to performing the following procedures, remove the metal cover and front panel assembly. (1) From the inside of the front panel assembly, remove the two screws AC attaching the standby LED board. (2) Take out the standby LED board and remove the soldered section z on the standby LED board to remove the parallel wire.
Front panel assembly
AB
y
aa
AC
y
aa
AB AB
y
AC
y
z
Parallel wires Standby LED board
Switch board
Fig.27
Front panel assembly
Knobs
Reference: When attaching the standby LED board, align the projections aa in the holes of the standby LED board before attaching the screws AC. 3.1.15 Removing the encoder board (See Figs.26 to 29) • Prior to performing the following procedures, remove the metal cover and front panel assembly. (1) From the outside of the front panel assembly, pull out the knobs toward this side. (See Fig.28.) (2) Remove the nut attaching the encoder board. (See Fig.28.) (3) From the inside of the front panel assembly, disconnect the card wire from the connector CN902 on the FL board. (See Fig.26.) (4) Remove the four screws AA, three screws AB and two screws AC attaching the each board. (See Figs.26 and 27.) (5) Take out the FL board with the switch and standby LED boards. Reference: It is not necessary to remove the parallel wires. (6) Remove the ten screws AD attaching the encoder board. (See Fig.29.) Reference: When attaching the encoder board, align the projections ab of the front panel assembly in the holes of the encoder board before attaching the screws AD. (See Fig.29.)
Nut
Fig.28
Front panel assembly
Encoder board
AD ab
AD
AD
ab
AD Fig.29
1-16 (No.MB161)
3.1.16 Removing the microphone board (See Fig.30) • Prior to performing the following procedure, remove the metal cover and front panel assembly. (1) From the inside of the front panel assembly, remove the six screws AE and screw AE’ attaching the microphone board.
Microphone board
AE
AE ac
Reference: • When attaching the microphone board, align the projections ac of the front panel assembly in the holes of the microphone board before attaching the screws AE and AE’. • When attaching the screw AE', attach it with the wire holder.
AE
ac ac
Wire holder
AE
AE'
Wire
Front panel assembly Fig.30 3.1.17 Removing the headphone board (See Fig.31) • Prior to performing the following procedures, remove the metal cover and front panel assembly. (1) From the inside of the front panel assembly, remove the screw AF attaching the headphone board. (2) Remove the wire holder fixing the wire and take out the headphone board. Reference: After attaching the headphone board, fix the wire with the wire holder. 3.1.18 Removing the cassette mechanism assembly (See Fig.31) • Prior to performing the following procedure, remove the metal cover and front panel assembly. (1) From the inside of the front panel assembly, remove the two screws AG and two screws AH attaching the cassette mechanism assembly. Reference: When attaching the cassette mechanism assembly, align the projections (ad,ae) in the holes of the cassette mechanism assembly.
Front panel assembly Cassette mechanism assembly
Wire holder ad
AG
AH Wire
AF ae
AG
AH
Headphone board
Fig.31
(No.MB161)1-17
3.2
CD changer mechanism
3.2.1 Removing the tray assembly (See Fig.1 ~ 5) (1) Remove the two screws A from the top cover and release the two joints a on both sides of the body. (2) Remove the top cover with the two rods attached to the top cover and lifter assembly respectively. (3) Remove the open det lever on the left side of the body. (4) Push part b of the slide (R) assembly on the right side of the body to unlock the tray assembly. Draw out the trays toward the front.
Open det lever
Attention: The tray can be locked if all tray assemblies are attached. (5) From top of the body, move the stopper tab c in the direction of the arrow and release. Pull out the tray assemblies from the body. Caution: Remove the tray assembly from top tray 5 in order.
Fig.3
Attention: When reattaching the sub tray of the tray assembly, or when removing the CD remaining inside, refer to another section.
c
Top cover
A
A
a
a
Tray assembly (Tray 5)
b Lifter assembly
Fig.4
Rod
Fig.1
Rod
Top cover
a
a
Lifter assembly Fig.2 Fig.5 1-18 (No.MB161)
3.2.2 Removing the servo control board (See Fig.6 ~ 9)
Card wire
Caution: Solder the short-circuit point on the pickup before disconnecting the card wire extending from the pickup. If you do not follow this instruction, the pickup may be damaged. (1) Disconnect the card wire from connector CN251 and each wire from connector CN252, CN253 and CN602 on the servo control board on the bottom of the body. Disconnect the wire from joint d. (2) Solder the short round point on the flexible board of the pick up. (3) Remove the four screws B and turn the servo control board as shown in the figure. (4) Disconnect the card wire from connector CN601 on the servo control board.Caution: Unsolder the short-circuit point after reassembling.
Short round
Caution: When reassembling, twist the wires to be connected to connector CN252 and CN253 twice. 3.2.3 Removing the switch board (See Fig.9) (1) Disconnect the wires from connector CN252 and CN253 on the servo control board. (2) Remove the screw C attaching the switch board. (3) Release the wires from the slot e of the switch board.
Flexible board Pickup Fig.7
Card wire
Caution: When reassembling, let the wires through the slot e of the switch board and twist them twice.
CN601
Servo control board
B CN602 CN253
Servo control board Fig.8
d
Servo control board CN253
CN252
B B
e CN252
CN251
Switch board
Fig.6
Switch board
C Fig.9
(No.MB161)1-19
3.2.4 Removing the motor board (See Fig.10 , 11) • Prior to performing the following procedure, remove the servo control board. (1) Turn over the body and remove the two screws D. Move the CD module bkt. in the direction of the arrow to release two joints f. (2) Unsolder the four soldered parts on the motor of the motor board. Caution: If removing the motor board with the motor, you should remove the screws attaching the motor from top of the body(Refer to another section). (3) Remove the two screws E attaching the motor board. (4) Remove the spacer fixing the motor board and tray switch board, and disconnect connector CN2 on the motor board. (5) Disconnect the card wire from connector CN1 on the motor board.
f
f
CD Module braket
D
D
Caution: When reconnecting the card wire, let the card wire through the slot g of the motor board and attach it to the bottom of the body using a double tape.
Fig.10
Spacer Soldering point CN2
E
E Motor Double face tape
CN1
g Card wire
Fig.11
1-20 (No.MB161)
3.2.5 Removing the CD tramecha assembly (See Fig.12) • Prior to performing the following procedure, remove the servo control board. (1) Turn over the body and remove the three screws F attaching the tramecha.
F
F F
CD Tramecha assembly Fig.12
(No.MB161)1-21
3.2.6 Removing the pickup (See Fig.13 , 14) • Prior to performing the following procedure, remove the servo control board and CD tramecha assembly. (1) From top of the CD tramecha assembly, turn the cam gear in the direction of the arrow to move the pickup assembly outward. (2) Push down the stopper h in the direction of the arrow and pull out the shaft. (3) Release the joint i of the pickup assembly and mecha base. (4) Remove the screw G attaching the CD rack. Release the four tabs j at the bottom of the CD rack.
i
Mecha base
Pickup assembly
h
Shaft Cam gear Shaft
Shaft
Stopper
Stopper Fig.13
CD lack
G Pickup
j
j
j Fig.14
1-22 (No.MB161)
3.2.7 Removing the side (L)/ tray switch board (See Fig.15 ~ 17) • Prior to performing the following procedure, remove the tray assembly. (1) Remove the two screws H attaching the side (L) on top of the body. (2) From the side of the body, remove the spacer fixing the tray switch board and motor board. Disconnect connector CN3 on the tray switch board and detach the side (L) upward. (3) Remove the screw J attaching the tray switch board. (4) Push the joint tab k of the side (L) in the direction of the arrow and remove the tray switch board outward, then release joint l.
H
Side (L)
H
Fig.15
H H
CN3
Spacer
Side (L) Fig.16
k Side (L)
l
Tray switch board Fig.17
J
(No.MB161)1-23
3.2.8 Removing the side (R) assembly (See Fig.18 ~ 22) • Prior to performing the following procedure, remove the tray assembly. (1) Push and release the two tabs m of the gear cover through the two notches inside the side (R) assembly. Remove the gear cover outward. (2) Remove the spring attached to part n of the hook on the right side of the body. (3) From top of the body, turn the 1 gear clockwise to move the elevator cam rearward.Move the two slots o and joint p of the elevator cam as shown in Fig.21 and remove the elevator cam outward. (4) Remove the three screws K and detach the side (R) upward.
Side (R) assembly
m
Caution: When reattaching the side (R) assembly, make sure to fit the shaft (part q) into the slot of the select lever.
K
Fig.20
q
n
Spring
Elevator cam
K o
o
Side (R) assembly
p Fig.21
K K
Side (R) assembly
Fig.18
1 gear
Side (R) assembly Sprihg
K n Fig.22
Gear cover Elevator com Fig.19 1-24 (No.MB161)
3.2.9 Removing the lifter assembly (See Fig.23 ~ 27) • Prior to performing the following procedure, remove the tray assembly and side (L)/ side (R) assembly. (1) From top of the body, turn the 1 gear clockwise to move the lifter assembly upward as shown in Fig.24. (2) From top of the body, turn the 2 gear clockwise to move the hook toward the front until it stops. (3) Move the hook stopper in the direction of the arrow while pushing the tab r of the hook stopper to unlock it. Release four joints s to detach from the rack holder. Release the rod from part t. (4) Turn the 1 gear clockwise again to move the lifter assembly upward. (5) Remove the lifter assembly from the body upward at position u where the four pins on the right and left sides of the lifter assembly fit to the notches of the v. Move the lifter assembly toward the front and release from the hook.
Hook
t s Rod
s
s r s
1 gear
2 gear
Hook stopper Fig.25
Lifter assembly
u
u
1 gear
Hook stopper
Hook
Lifter assembly
u
u
v Fig.26
Lifter assembly
Fig.23
Lifter assembly 1 gear
2 gear
Hook stopper
Hook Fig.24
v Fig.27
(No.MB161)1-25
3.2.10 Removing the rack holder assembly/ sensor assembly (See Fig.28 ~ 33) • Prior to performing the following procedure, remove the tray assembly, side (L)/ side (R) assembly, lifter assembly.
L
1 gear
Attention: If the slide gear of the body places at joint w of the rack holder assembly, turn the 1 gear counterclockwise to move the slide gear toward the front. Remove the rack holder assembly. (1) Remove the three screws J attaching the rack holder assembly. Release joint w from the notch.
(2) (3) (4) (5)
Caution: When reattaching the rack holder assembly, do not nip the wire x extending from the sensor assembly. Remove the two screws M attaching the sensor assembly. Move the sensor assembly in the direction of the arrow to release from the slot at joint y. Remove the spring attached to the bottom of the sensor assembly from the boss z on the sensor slider. Remove the screw N and O attaching the sensor board and SV resister respectively.If necessary, unsolder the sensor board.
Rack holder assembly
x
L
Caution: When reattaching the SV resister, attach the sensor slider to the sensor bracket and fit the lever on the bottom of the SV resister into slot a’ of the sensor slider. Caution: When reattaching the rack holder assembly, turn the 1 gear clockwise to move the slide gear and slide lever inside the body rearward. • Let the wire extending from the sensor assembly through notch x to the bottom of the body. • Fit pin c’of the slide lever into hole b’ of the sensor slider on the bottom of the sensor assembly while attaching the spring to the boss z of the sensor slider. • Engage joint y of the sensor assembly to the notch of the body.
w
Rack holder assembly
Rack holder assembly
w
w
Fig.29
1-26 (No.MB161)
L Fig.28
x
N
O
Soldering point
SV resister
M
Sensor board
Sensor assembly
z Sensor braket
M
a'
Sensor slider Fig.32
y
M
Spring
Sensor assembly
Fig.30
a'
M
b'
Sensor slider Spring
y
b'
Slide gear
z
z Fig.31
c' Spring Fig.33
Slide lever
(No.MB161)1-27
3.2.11 Removing the motor (See Fig.34 ,35) • Prior to performing the following procedure, remove the servo control board and top cover. Attention: You need not to remove the tray assembly, and in such case, move it. (1) Remove the two belts on top of the body. (2) Remove the four screws N attaching the motor. (3) Remove the motor board from the bottom of the body. (Refer to the section “Removing the motor board”.) Attention: When removing the motor board with the motor, you need not to unsolder four soldered parts. Caution: When reattaching the motor, turn the side where the label should be put to the front side.
Motor
Motor
N
N Belt
Belt
Fig.34
Label
Fig.35
1-28 (No.MB161)
3.2.12 Taking out the CD in play mode (See Fig.36 ~ 39)
Tray assembly
Attention: Refer to “Removing the tray assembly”. (1) Remove the top cover upward. (2) Unlock the tray assembly and draw out the tray assembly toward the front. (3) From top of the body, turn the 1 gear clockwise to move the lifter assembly upward. (4) From top of the body, turn the 2 gear clockwise to move the sub tray remaining inside the lifter assembly toward the front, then pull out. (5) Take out the CD on the sub tray. (6) After clearing away the CD, insert the sub tray into the main tray. Caution: When reattaching the sub tray, move the tray stopper on the bottom of the main tray in the direction of the arrow to lock the sub tray certainly. (7) Push the tray assembly toward the body and reattach.
Sub tray Fig.37
Tray stopper
Main tray
Tray assembly
1 gear
2 gear
Sub tray
Sub tray Fig.38
Fig.36
Tray stopper
Fig.39 (No.MB161)1-29
3.3
Cassette mechanism assembly
3.3.1 Removing the Play/Record & Clear head (See Fig.1~3) (1) While moving the trigger arm on the right side of the head mount in the direction of the arrow, turn the flywheel R counterclockwise until the head mount comes ahead and clicks. (2) The head turns counterclockwise as you turn the flywheel R counterclockwise (See Fig.2 and 3). (3) Disconnect the flexible wire from connector CN31 on the head amplifier & mechanism control board. (4) Remove the spring from the back of the head. (5) Loosen the azimuth screw for reversing attaching the head. (6) Remove the head on the front side of the head mount.
Cassette mechanism assembly
Head mount
Fly wheelR
Trigger arm Fig.1
Head
Fly wheel R Fig.2
Head
Azimuth screw for reversing
Flexible wire Spring
CN31 Head amplifer & mecha control board Fig.3
1-30 (No.MB161)
3.3.2 Removing the head amplifier & mechanism control board (See Fig.4) (1) Turn over the cassette mechanism assembly and remove the three screws A attaching the head amplifier & mechanism control board. (2) Disconnect the flexible wire from connector CN31 on the head amplifier & mechanism control board. (3) Disconnect connector CN32 of the head amplifier & mechanism control board from connector CN1 on the reel pulse board.REFERENCE: If necessary, unsolder the 4-pin wire soldered to the main motor.
Main motor assembly Capstan belt
3.3.3 Removing the main motor (See Fig.4~7) (1) Remove the two screws B . (2) Half raise the motor and remove the capstan belt from the motor pulley. ATTENTION: Be careful to keep the capstan belt from grease. When reassembling, refer to Fig.6 and 7 for attaching the capstan belt.
Fig.5
Main motor assembly
Head amplifier & mecha control board
A
CN32 4pin wire
Motor pulley
CN31
B
A
Capstan belt Fig.6
Flexible wire
Main motor assembly Main motor assembly Fig.4
Fly wheel
Capstan belt
Motor pulley Fig.7
(No.MB161)1-31
3.3.4 Removing the flywheel (See Fig.8, 9) • Prior to performing the following procedure, remove the head amplifier & mechanism control board and the main motor assembly. (1) From the front side of the cassette mechanism, remove the slit washers attaching the capstan shaft L and R. Pull out the flywheels backward.
Fly wheel R
Fly wheel L Fig.8
Fly wheel L
Fly wheel R
Capstan shaft R
Capstan shaft L
Slit washer Fig.9 3.3.5 Removing the reel pulse board and solenoid (See Fig.10) • Prior to performing the following procedure, remove the head amplifier & mechanism control board. (1) Remove the screw C. (2) Release the tab a, b, c, d and e retaining the reel pulse board. (3) Release the tab f and g attaching the solenoid on the reel pulse board. (4) The reel pulse board and the solenoid come off.
a
b
c
d
Reel pulse board
Solenoid
f
g C
e
Fig.10
1-32 (No.MB161)
3.3.6 Reattaching the Play/ Record & Clear head (See Fig.11~13) (1) Reattaching the head mount assembly. a) Change front of the direction cover of the head mount assembly to the left (Turn the head forward). b) Fit the bosses O', P', Q', U' and V' on the head mount assembly to the holes P and V, the slots O, U and Q of the mechanism sub assembly (See Fig.11 to 13). CAUTION: To remove the head mount assembly, turn the direction cover to the left to disengage the gear. If the gear can not be disengaged easily, push up the boss Q' slightly and raise the rear side of the head mounts slightly to return the direction lever to the reversing side. (2) Tighten the azimuth screw for reversing. (3) Reattach the spring from the back of the Play/ Record & Clear head. (4) Connect the flexible wire to connector CN31 on the head amplifier & mechanism control board.
O' P' V'
U'
Q'
Direction cover
Head mount assembly Fig.11 Head mount assembly
Direction cover
O PQ V U
Fig.12
Azimuth screw for reversing
Head
Head mount
Spring Flexible wire
CN31
Head amplifier & mechanism control board
Fig.13
(No.MB161)1-33
3.4
Speaker section
3.4.1 Removing the side panel assembly (See Fig.1) (1) From the side of the speaker main body, remove the seven screws A and screw B attaching the side panel assembly .
A A
B
A
Side panel assembly Fig.1
3.4.2 Removing the subwoofer (See Fig.2) • Prior to performing the following procedures, remove the side panel assembly. (1) Remove the four screws C attaching the subwoofer. (2) From the back side of the subwoofer, disconnect the red and black wires from the terminal.
Subwoofer
C
C
Terminal
Red wire
Black wire Fig.2
1-34 (No.MB161)
3.4.3 Removing the front panel assembly (See Figs.3 and 4) • Prior to performing the following procedures, remove the side panel assembly. (1) Remove the four screws D attaching the front panel assembly. (See Fig.3.) (2) Release the two joints a. (See Fig.3.) Caution: When removing the front panel assembly from the speaker main body, do not break or damage them that are glued at the joints a. (See Fig.3.) (3) From the inside of the front panel assembly, disconnect the yellow and black wires from the two terminals on the tweeter. (See Fig.3.)
D
Front panel assembly
a
a
3.4.4 Removing the tweeter (See Fig.4) • Prior to performing the following procedure, remove the side panel and front panel assemblies. (1) From the inside of the front panel assembly, remove the two screws E attaching the tweeter.
D Fig.3
Front panel assembly
E
Tweeter
E Yellow wire
Black wire
Terminals Fig.4
(No.MB161)1-35
3.4.5 Removing the top woofer (See Fig.5) • Prior to performing the following procedures, remove the side panel and front panel assemblies. (1) Remove the four screws F attaching the top woofer. (2) From the back side of the top woofer, disconnect the red and black wires from the terminal.
Top woofer
F
F
Terminal
Red wire
Black wire Fig.5 3.4.6 Removing the bottom woofer (See Fig.6) • Prior to performing the following procedures, remove the side panel and front panel assemblies. (1) Remove the four screws G attaching the bottom woofer. (2) From the back side of the bottom woofer, disconnect the black, red and blue wires from the terminal respectively.
Bottom woofer
G
G
Terminal Black wire
Black wire
Blue wire
Red wire Fig.6
1-36 (No.MB161)
SECTION 4 ADJUSTMENT 4.1
Measurement Instruments Required for Adjustment
(1) Low frequency oscillator This oscillator should have a capacity to output 0dBs to 600Ω at an oscillation frequency of 50Hz-20kHz. (2) Attenuator impedance : 600Ω (3) Electronic voltmeter (4) Distortion meter (5) Frequency counter (6) Wow & flutter meter (7) Test tape VT703L : Head azimuth VT712 : Tape speed and running unevenness (3kHz) VT724 : Reference level (1kHz) (8) Blank tape TYPE l : AC-225 TYPE ll : AC-514 (9) Torque gauge : For play and back tension FWD(TW2111A), REV(TW2121a) and FF/REW(TW2231A) (10) Test disc: CTS-1000 4.2
Measurement conditons
Power supply voltage
AC 120V ~, 60Hz
Reference output
Speaker : 0.775V/4Ω Headphone : 0.077V/32Ω
Reference frequency and input level 1kHz, AUX : -8dBs Measurement output terminal
at Speaker J3002
Load resistance
4Ω
4.2.1 Radio Input signal AM frequency
400Hz
AM modulation
30%
FM frequency
400Hz
FM frequency deviation
22.5kHz
4.2.2 Tuner section Voltage applied to tuner
+B : DC5.7V VT : DC 12V
Reference measurement output 26.1mV(0.28V)/3Ω Input positions
AM : Standard loop antenna FM : TP1 (hot) and TP2 (GND)
4.2.3 Standard measurement position of volume Function switch
to Tape
Beat cut switch
to Cut
Super Bass/Active hyper Bass
to OFF
Bass Treble
to Center
Adjustment of main volume to reference output VOL : 0.775V Precautions for measurement (1) Apply 30pF and 33kΩ to the IF sweeper output side and 0.082µ F and 100kΩ in series to the sweeper input side. (2) The IF sweeper output level should be made as low as possible within the adjustable range. (3) Since the IF sweeper is a fixed device, there is no need to adjust this sweeper. (4) Since a ceramic oscillator is used, there is no need to perform any MIX adjustment. (5) Since a fixed coil is used, there is no need to adjust the FM tracking. (6) The input and output earth systems are separated. In case of simultaneously measuring the voltage in both of the input and output systems with an electronic voltmeter for two channels, therefore, the earth should be connected particularly carefully. (7) In the case of BTL connection amp., the minus terminal of speaker is not for earthing. Therefore, be sure not to connect any other earth terminal to this terminal. This system is of an BTL system. (8) For connecting a dummy resistor when measuring the output, use the wire with a greater code size. (9) Whenever any mixed tape is used, use the band pass filter (DV-12).
(No.MB161)1-37
4.3
Cassette mechanism adjustment
Head azinuth adjustment screw (Forward side)
Head azinuth adjustment screw (Forward side)
Head azinuth adjustment screw (Reverse side)
CN31 R/P head, Erase head
Head azinuth adjustment screw (Reverse side)
Mecha control board Motor speed VR37
P1 SW2 VR37
SW1
SW5
CN1
R371 D1
FW100
SW6
IC1
CN33 C374 PP300
R340
Q376
R210
R206
R338 C371
R106
R301
R110
R376
R375 R337
C206
C307
R314
C308
R335 L301
R342
Q375
Q372
R205 C314
R305
C331
C106
R353
R341
D375
Q371
C310
C313
R343
R208
C207
R108
CN32
C105 C205 R372
R315
BIAS adjust VR31
CN34 R105
C107
Q302
C376
R310
Q305
R313
R339
L303
C300 R216
C304
R327
R336
C213 R201
R101
C102
C202
C110
R116
IC33
C210
D340
C342 C220
C120
R107
R346
R344
R345
R306
Q342
R302
R121
C204 C201
R109
R303
C221
R202
C341
C340
C113
R102
VR31
R104
C103
C101
C104 C121
C203
C301
C319
W1
C209 R347
C109 R207
W1 R221 Q346
Q344
Q345
Q343
1-38 (No.MB161)
R204
IC32
C306
R304 C316
CN31
Q347
4.3.1 Mechanism section Item
Condition
Measurement method
Adjustment position
Ref. value
(1) Playback the test tape VT703L (8kHz). Maximum output Only adjust (2) Adjust to maximum output level by aziat changed muth adjustment screw for forward side head and reverse side. (3) This adjustment is adjust by adjustment screw of forward side and adjustment screw of reverse side.
Head azimuth
Test tape :VT703L (8kHz) Output terminal :Speaker out
Tape speed
Test tap Playback the test tape VT712 (3kHz) at end of 2,940 ~ 3,090Hz VR37 :VT712 (3kHz) forward side,adjust to 2,940~3,90Hz indication Output terminal of frequency counter by VR37. :Speaker out or Headphone out
Item
Condition
Measurement method
Adjustment position
Ref. value
Tape speed diviation at FWD/ REV
Test tape Playback the test tape VT712 (3kHz) at end of Leass than : VT712 (3kHz) forward and reverse, tape speed deviation 6.0Hz Output terminal should be less than 6.0Hz. :Speaker out or Headphone out
VR31
Wow & Flutter
Test tape Playback the test tape VT712 (3kHz) at start of Less than 0.25% : VT712 (3kHz) forward and reverse, Wow & Flutter are should (WRMS) Output terminal be less than 0.25%(WRMS). :Speaker out or Headphone out
(No.MB161)1-39
4.3.2 Electrical adjustment Item
Condition
Measurement method
Ref. value AC-225 : 4.20µA AC-514 : 4.0µA
Adjustment position VR31
Recording BIAS adjustment
• Forward or Reverse • Test tape : AC-514 TYPE ll : AC-225 TYPE l • Output termina Recording head
(1) Set the test tape(AC-514 TYPE ll and AC-225 TYPE l), then make REC/ PAUSE condition. (2) Connect 100Ω to recording head by series, then connect to VTVM for measurement the current. (3) After setting, start the recording by release the PAUSE, in this time bias current adjust to next fig. by VR31 for Lch and VR32 for Rch. 4.0 µA (TYPE ll) and 4.20 µA (TYPE l).
R/P playback frequency response
• Reference frequency : 1kHz / 10kHz (Reference: -20dB) • Test tape : AC-514 TYPE ll • Input terminal : OSC IN
(1) Set the test tape (AC-514 TYPE ), then Output deviation VR31 1kHz/10kHz make REC/PAUSE condition. (2) Release the PAUSE, then start recording : -1dB ± 2dB the 1kHz and 10kHz of reference frequency from oscillator. (3) Playback the recorded position, 1kHz and 10kHz output deviation should -1dB 2dB to readjust by VR31 for Lch and VR32 for Rch.
4.3.3 Electrical response confirmation Item Recording bias current
Condition • Forward or Reverse • Test tape : TYPE ll (AC-514) • Measurement terminal : BIAS test point on printed circuit board
Erase current (ref- • Forward or Reverse erence value) • Rec condition Test tape : AC-514 TYPE ll : AC-225 TYPE l • Measurement terminal Both side of Erase head
1-40 (No.MB161)
Measurement method
Ref. value
(1) Change BIAS1 and 2, confirm the fre100 kHz ± 6 kHz quency should be change. (2) Set the test tape (AC-514 TYPE ll), then make REC/PAUSE condition. (3) Confirm the frequency should 100Hz ± 6kHz at BIAS test point on printed circuit board. (1) Set the test tape (AC-514 TYPE ll and AC-225 TYPE l), then make REC/ PAUSE condition. (2) Release the PAUSE to REC condition, connect 1W to ERASE head by series, then confirm the erase current at both side of erase head.
TYPE ll : 120 mA TYPE l : 75 mA
Adjustment position
SECTION 5 TROUBLESHOOTING 5.1
Flow of functional operation untill TOC read
Check Point
Power ON
Play Key
Slider turns REST SW ON.
Confirm that the voltage at the pin5 of CN801 is "H"\"L"\"H".
Automatic tuning of TE offset
Laser ON
Check that the voltage at the pin40 of IC651 is + 5V?
Detection of disc
Automatic tuning of Focus offset
Automatic measurement of Focus S-curve amplitude
Confirm that the Focus error S-cuve signal at the pin28 of IC651 is approx.2Vp-p
Disc is rotated
Confirm that the signal from pin24 IC651 is 0V as a accelerated pulse during approx.400ms.
Tracking error waveform at TOC reading pin 25 of IC601(TE)
VREF
Focus servo ON (Tracking servo ON)
Approx.3sec
Approx 1.8V
Automatic measurement of Tracking error amplitude
Disc states to rotate
Tracking servo off states
Tracking servo on states
Automatic measurement of TE amplitude and automatic tuning of TE balance
Disc to be braked to stop TOC reading finishes
Confirm the waveform of the Tracking error signal. at the pin 25 of IC601 (R604) (See fig-1)
Automatic tuning of Tracking error balance
500mv/div 2ms/div Fig.1
Automatic tuning of Focus error balance Automatic tuning of Focus error gain
Automatic tuning of Tracking error gain
TOC reading
Confirm the eye-pattern at the lead of TP1
Play a disc (No.MB161)1-41
5.2
Maintenance of laser pickup (CD)
5.3
(1) Cleaning the pick up lens Before you replace the pick up, please try to clean the lens with a alcohol soaked cotton swab. (2) Life of the laser diode When the life of the laser diode has expired, the following symptoms will appear. • The level of RF output (EFM output : ampli tude of eye pattern) will below.
Is RF output 1.25 0.22Vp-p?
Replacement of laser pickup (CD)
Turn off the power switch and, disconnect the power cord from the AC outlet.
Replace the pickup with a normal one. (Refer to "Removing the CD pickup" on the previous page)
NO Replace it.
YES
Plug the power cord in, and turn the power on. At this time, check that the laser emits for about 3 seconds and the objective lens moves up and down. Note: Do not observe the laser beam directly.
O.K (3) Semi-fixed resistor on the APC PC board The semi-fixed resistor on the APC printed circuit board which is attached to the pickup is used to adjust the laser power. Since this adjustment should be performed to match the characteristics of the whole optical block, do not touch the semi-fixed resistor. If the laser power is lower than the specified value, the laser diode is almost worn out, and the laser pickup should be replaced. If the semi-fixed resistor is adjusted while the pickup is functioning normally, the laser pickup may be damaged due to excessive current.
1-42 (No.MB161)
Play a disc.
Check the eye-pattern at TP1.
Finish.
5.4
Service mode
5.4.1 Confirming contents (1) System micon reset (2) System micon cold start (3) FL display check (4) Micon version check 5.4.2 Confirming methods
1. System micon reset When CD mechanism stuck, this may solve the problem without removing/inserting power cord. Press the STANDBY/ON, CANCEL and buttons on the main unit simultaneously.
System micon is initialized. 2. System micon cold start This function clears all user setting, and return to initial setting. Daily timer, REC timer Tuner preset SEA preset Last condition (Source, Volume) While pressing both the CANCEL and buttons on the main unit, insert the power cord in an outlet
Operating method using a remote controller Press the VOLUME UP, STOP and STANDBY/ON buttons twice on the remote controller at standby.
This unit returns to initial setting. 3. FL display check This enables all FL segment light up. Press the VOLUME DOWN, STOP and STANDBY/ON buttons on the remote controller at standby.
All of the FL displays light up.
(No.MB161)1-43
4. Micon version check You can confirm Micon version and destination. Insert the power cord in an outlet, and press the STANDBY/ON button on the main unit or remote controller.
Press the FADE MUTING, STOP and STANDBY/ON buttons on the remote controller. System micon version is indicated on the FL display. Press the FADE MUTING, STOP and STANDBY/ON buttons on the remote controller. CD mechanism micon version is indicated on the FL display. Press the FADE MUTING, STOP and STANDBY/ON buttons on the remote controller. Model number is indicated on the FL display. Press the FADE MUTING, STOP and STANDBY/ON buttons on the remote controller. Destination is indicated on the FL display.
1-44 (No.MB161)
5.4.3 Indicating check for FL display
No. 1
2
Function SOURCE CD MP3 TAPE AUX AM FM TUNER PRESET MEMOERY PRESET MEMOERY PRESET MEMOERY
3
4
FL display C D 1 2. 1 2: 1 2. 1 2 2. 1 2: T A P E A U X I N A M 1 6 0 F M 1 0 8. T U N T U N S P S T T T R E T T T C D
TAPE PLAY REVERSE FF/REW MUSIC SCAN REC CD REC CD REC STOP VOLME UP/DOWN MAX MIN RHYTHM AX ON OFF SUBWOOFER LEVEL CHANGE LEVEL CHANGE LEVEL CHANGE LEVEL CHANGE AT LEVEL 0 AT LEVEL 2 SOUND MODE DANCE HALL STADIUM ROCK POP CLASSIC USER1 USER2 USER3 OFF
Note 3 4 3 4
2 0 0
E R F M E R A M E T 1 2 O R E D A A V A A A
P P E P P P R
E E R S E E E E E C
: PRESET NUMBER : PRESET NUMBER TEMPORARY TEMPORARY BLINKING BLINKING TEMPORARY
TEMPORARY
"CD REC FINISHED" SCROLL
V O L U M E V O L U M E V O L U M E
3 0 M A X M I N
TEMPORARY TEMPORARY TEMPORARY
R H Y T H M O N O F F
A X
TEMPORARY
S U S. S. S. M M
B W W W I A
TEMPORARY
W O O O N X
O O O O
O F F F L L
F E E E E E
D A H S T A R P C L A U S U S U S O
N A D O O S E E E F
C L I C P S R R R F
E L U M K
E R R 0 R 1 R 2 V E L V E L
I C 1 2 3
TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY TEMPORARY
(No.MB161)1-45
No. 4
5
Function TONE SETTING TONE MEMORY TONE MEMORY TONE MEMORY TONE MEMORY TONE MEMORY KARAOKE KARAOKE ON KARAOKE OFF MIC MIX MIC MIX MIC OFF ECHO ECHO ECHO OFF KEY CONTROL KEYCON SLEEP SLEEP 10 120 CLOCK ADJUST SET SET DAILY TIMER SELECT SET SET SET SET
FL display S E A B A S T R U S M E
RANGE: -3 0 +3 RANGE: -3 0 +3 NUMBER BLINKING TEMPORARY TEMPORARY TEMPORARY
M I C M I C
TEMPORARY
M I X O F F
E C H O E C H O O F F
RANGE: 1
K E Y C O N
RANGE: -6
3
0
+6
S L E E P
RANGE: 10/20/30/60/120
A M 1 2: 0 0 A M 1 2. 0 0 C L O C K O K
HOUR BLINKING MINUTE BLINKING
D A I O N O N O F F O F F
A T U T U SET 1 SET 1 SET V O L
1-46 (No.MB161)
N T 0 0 1 Y
K A R A O K E O F F
1
SET
C O S E E R M O R
Note
L Y A A S E A A S E C D T A U X N E N E S E C D S E C D S E U M S E
T M M T M M T
I M E R 1 2: 0 0 1 2: 0 0
HOUR BLINKING MINUTE BLINKING
1 2: 0 0 1 2: 0 0
HOUR BLINKING MINUTE BLINKING
1 P E I N R F M R A M T 1 T 1 T E T O K
BLINKING (ALL) BLINKING BLINKING BLINKING BLINKING BLINKING DISC BLINKING TRACK --/5/10/15
No. 5
Function REC TIMER SELECT SET SET SET SET
SET SET 6
7
8
9
TEST (ROM) by Remocon "B332"
CD STATUS OPEN CLOSE NO DISC DISC CHANGE TOC READING ROM CORRECTION (SYSCON) ROM CR. OK ROM CR. NG CD STOP PLAY PAUSE SEARCH +10KEY INPUT MP3 STOP STOP STOP STOP PLAY PLAY PLAY PLAY PLAY PAUSE SEARCH
FL display R E C T O N A M O N A M S E T O F F A M O F F A M S E T T U N E R T U N E R S E T F M 3 0 1 S E T
Note
I M E R 1 2: 0 0 1 2: 0 0
HOUR BLINKING MINUTE BLINKING
1 2: 0 0 1 2: 0 0
HOUR BLINKING MINUTE BLINKING
F M A M
BLINKING BLINKING
0 8. 0 0 O K
BLINKING
S Y S C O N M O D U L E V E R
ROM correction +3 CHARACTORS 4 CHARACTORS (including ROM CORR) J / E / A / US / UW / UX
O P E C L O N O D I D I S C R E A D U P G R
N S E S C 1 2 I N G A D E
SOURCE CD and CURRENT ONLY SOURCE CD and CURRENT ONLY SOURCE CD and CURRENT ONLY SOURCE CD and CURRENT ONLY SOURCE CD and CURRENT ONLY SOURCE CD and CURRENT ONLY
S Y S C O N S Y S C O N
O K E R R
SOURCE CD and CURRENT ONLY SOURCE CD and CURRENT ONLY
C C C C C
D D D D D
1 2. 1. 1. 1. 1 .
8 3: 3: 3: : 3:
G 0 1
T 0 0 1
G 0 1
T 0 0 1
1. 1.
2 3. 2 3.
4 5 4 5 4 5
DISPLAY TOTAL TIME TIME BLINKING
4 5
3: 4 5 3: 4 5
GROUP FILE NAME SCROLL G BLINKING TRACK FILE NAME SCROLL T BLINKING TRACK FILE NAME SCROLL TRACK "SONG TITLE" SCROLL TRACK "PERFORMER" SCROLL TRACK "ALBUM TITLE" SCROLL TIME BLINKING TRACK FILE NAME SCROLL
(No.MB161)1-47
No.
Function
10
PROGRAM PROGRAM MODE DISC INPUT (Disc# key) TRACK INPUT STOP PLAY FULL MEMORY
11
12
13
14
FL display C D D D
D 1 1 1
P R O 1 1 2 3 1 2 3
Note
G R A M P P 1 P 1
DISC#, TRACK# Blink 10key or SEARCH Jog input DEPEND ON DISC TYPE TEMPORARY
C D
F U L L
C D C D
R A N D O M R A N D O M
REPEAT REPEAT 1 track REPEAT 1 disc REPEAT ALL
C D C D C D
1. 1. 1.
3: 4 5 3: 4 5 3: 4 5
CD/MP3 case ANY case ANY case
PROGRESSIVE INTERLACE PROGRESSIVE
I N T E R L A C E P R O G R E S S I V
TEMPORARY TEMPORARY
RANDOM RANDOM MODE SEARCH PLAY
DEMO DEMO START
1-48 (No.MB161)
D E M O W E L C T J C D D I S C 1 D I S C M P 3 D I S C 2 D I S C C D D I S C 3 D I S C C D D I S C 4 D I S C C D D I S C 5 D I S C T U N E T U N E T A A U X A U X D A N H A S T A D
S O O V P
T A R T M E C L A Y P L A Y
P L A Y P L A Y P L A Y P L A Y P L A Y P L A Y P L A Y P L A Y R F M R A M P E I N C E L L I U M
: MOVING DEPEND ON DISC TYPE
No.
Function
FL display
14 C L U U U S. W S. W M A S. W S. W M I P H Y
DEMO OFF
R P A S S S O O X O O N T
O O S E E E O O O O H O
C P S R R R F F L F F L M N
K I C 1 2 3 E R 1 E R 2 E V E L E R 1 E R 0 E V E L A X
D E M O
O F F
BEEP BEEP ON BEEP OFF
B E E P B E E P
O N O F F
TRAY LOCK LOCK UNLOCK
L O C K E D U N L O C K E D
AM STEP CHANGE 9 kHz 10 kHz
A M A M
Note
9 K 1 0 K
(No.MB161)1-49
VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan
(No.MB161)
Printed in Japan WPC
SCHEMATIC DIAGRAMS COMPACT COMPONENT SYSTEM
HX-GX7 CD-ROM No.SML200403 Area suffix J ----------------------------- U.S.A. C -------------------------- Canada
SP-HXGX7
CA-HXGX7
SP-HXGX7
Contents 2-1 2-2 2-9 to 13
Block diagram Standard schematic diagrams Printed circuit boards
COPYRIGHT
2004 VICTOR COMPANY OF JAPAN, LTD.
No.MB161SCH 2004/3
In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the " " mark nearby are critical for safety. (This regulation does not correspond to J and C version.)
Block diagram
REST SW CN602
FEED MOTOR
IC601 RF & SERVO AMP.
T+/F+/-
SM+/FM+/-
SPINDLE MOTOR
/REST_SW
IC671 DRAM IC682 /DCAS
/CAS
IC681 /DWE
CN661
CN651
IC1 POSITION SENSOR
TR1_CL to TR5_CL M.TR_OP
CDL,CDR
DISPD2S DISPD2D RESET
FW216
CN207
CN206
ML MR
FW218
LED1 to LED5 REMIN
IC951 REMOCON RECEIVER
KEY3
IC954 FL DRV. G1 G12
FL1 FL2
P1 to P36 G2 to G11
Q950 Q951
FL900 DISP.
FW901
HPL HPR
HPSW
VL -VL
D208 D209 D210 D211 +/- VL BRIDGE S2
S4H
D212 D213 D214 D215 S4 BRIDGE
-VH,DC PRT
S4H
IC201 FAN REG.
FW904
S929 S930 SWITCH
S926 S927 S928 SWITCH
Headphone jack section
FAN+
FAN-
S4
FAN M
CN214
Primary with main transformer section S4 F104 S2 F101 T001 F001 F102 S1 Trans.
CN200
FW901
CN213
Q212 FAN DRV. CCT
STATUS
KEY2X
FW902
SUB WOOFER
Q220 to Q222 PROTECTOR
FANCTRL
FW202
D913 STANDBY LED
D204 D205 D206 D207 +/- VH BRIDGE S1
KEY4
KEY1,KEY2,KEY2X
D1LED to D5LED
VH -VH
SWL SWR
SPEAKER TERMINAL MAIN
Q230 to Q234 H/P MUTE
HPMUTE
VH
BZ900
ML MR
J1001
S900 to S907 SWITCH
VH,-VH VL,-VL S4H
Q206 37V REG.
37V
CN208 VL,-VL,DC S4H,S4L SURROUND
FW204
D908 to D912 D1LED to D5LED
IC600 MAIN POWER AMP.
FW711
D900 to D907 MIC
ECHO,ECHO
SOUNDMODE+/PRESET+/-,VOL+/-
FL1 FL2 +37V BUZZER
IC955 INV.
CN903
S908 to S925 SWITCH
MAINL MAINR
SWL SWR
CN217
HPMUTE STATUS HPSW,PRT FANCTRL
CN901
CLKB
User control keys section JS958,JS960,JS962 ROTARY ENCODER
VL,-VL,DC SURROUND
CN202
J900
IC952 CONPANDER,LPF & ECHO MIX
IC956 AMP.
SURR HPMUTE STATUS HPSW PRT FCTRL
DC regulator Speaker terminal section SURROUND
CN802
FL display System control section DI,BK
PLAY PHOTO KEY1
CN902
J910
MIC 1
CN803
CN900
MIC 2/AUX IN
SWIN
IC700 SW POWER AMP.
VH,-VH VL,-VL
DC POUT IMP
CN201
MB
S/TDATA,S/TCLK,SLCCE SLCPLAY,PHOTO,SLCKEY
CN205
SOL
User control keys section IC953 MIC AMP. & ALC
SDATA SCK STTA
MOTOR
Q375,Q376 Q371,Q372 SOLENOID MOTOR DRIVE DRIVE
SOLENOID SOL
S4L
J200
SOLCTRL
PHOTO PHOTO+B
IC801 MICON
S4H S4L
IC660 5V REG. POUT IMP DC
FW900
MB
IC33 SERIAL TO PARALLEL PORT EXTENSION
RECB
CN32
RREC,FREC PLAY,TAPE
S5V B5V
S4H
RECL RECR
CN43
IC1 REEL PULSE
Q302,Q305 BIAS OSC/CONT.
CN42
FW100
SW1,SW2 SW5,SW6 SWITCH
CN44
MOTOR SPEED Adj.
S4H 9V
PBMUTE,RECH
CN33
L301 BIAS OSC
RECL,RECR
5.6V
IC670 5.6V MICOM
IC760 9V REG.
REMIN,MIC,ECHO1,ECHO2 KEY1 to KEY4,S/WLED,SMLED SURRLED,SB1LED,SB2LED FLDATA,FLCLK,BK,SM+,SMRSEARCH,FSEARCH,BUZZER D1LED to D5LED,VOL+,VOL-
CN34
CN31
REC/PLAY FREQUENCY RESPONSE Adj.
CN600
Audio main amplifier output section
M9V
VOLDA VOLCLK VOLCE1
L.SENSOR
CN700
IC750 MOTOR 8V
IC401 VOLUME
PBL,PBR
CN610
Audio sub woofer amplifier output section
IC485 BOOST AMP.
IC442 PHYTHM AX
PBL,PBR
POUT
IC466 IC467 LPF & MIX AMP.
Tape deck mechanism control / Pre-amplifier and bias section IC32 AUDIO SIGNAL PROCESSOR
CN710
SMUTE
IC534 SWITCH
S.TR_END
CN253
CN2
CN3
SW1 to SW6 SWITCH
M
SW8 SWITCH
S.TR_ST
SW7 SWITCH
CD tray switch section
REC/PB ERASE HEAD
TXD0 RXD0 RESET
POS_UP POS_DOWN
BASS1 BASS2
Q540
IC526 HPF
TUL,TUR
CN252
IC2 POSITION MOTOR DRV.
WECNT
Q515 to Q517 SW VOLUME & MUTE
IC251 UNIT MICON
CN251
IC1 TRAY MOTOR DRV.
CN1
TR_OP TR_CL
TDATA SDATA TUCLK TUCE
/DRAS
/WE
CD tray control section
TXTD,TXTCK IC201 /RST_DSP MON,FLAG EEPROM DQSY,BLKCK MLD,MDATA E2PSDA STAT,MCLK E2PSCL
RASCNT
9V,M9V S5V,5.6V SWIN
Q541,Q542 MUTE
CASCNT
/RAS
/DR_MUTE PC1,PC2
MAINL MAINR
CN1 CN560
AD0 to AD10 D0 to D3
TRV TRD FOD SPINDLE
IC801 FOCUS TRACKING FEED SPINDLE BTL AMP.
IC651 DIGITAL SERVO & PROCESSOR
External input / Source select switch section TUNER
OUTL,OUTR TX
CN511
CN601
CD PICK UP
TBAL,FBAL,TE,FE,GCTL,/RFDET OFT,BDO,ARF,RFENV
A,B C,D E,F LD MD
CN501
CD changer mechanism control / CD servo and CD system control section
AC IN
FL1,FL2
2-1
Standard schematic diagrams Primary with main transformer section
FW204 QJK015-082614 CT
T001 QQT0423-001
(SHEET 2)
S1 S1 S2 S2
F101 8A-125V F102 8A-125V F001 6.3A-125V
S4CT S4 F104 3.15A-125V
CN200 QGA7901C1-02
S4
FW202 QUM154-21DGZ4 R275 4R7
SGND R277 FL2 4R7
0.1
S3CT C205
(SHEET 2)
FL1
R200 3.3M
Parts are safety assurance parts. When replacing those parts make sure to use the specified one.
SHEET 1 2-2
DC regulator / Audio output section J200 QNB0193-002
(SHEET 3)
(SHEET 4)
PRT
KRC102M-T Q600
10K
R612
AGND MAINR DVDPON
5.6V
5.6V
POUT
POUT
IMP
IMP DVD.GND
10
R611
100
CN610 QGB2510J1-11
CN600 QGB2510K1-11
R606 0.22
0.22
R607
!
DGND
!
2SC3576-JVC-T
4.7K
MAINL
AGND MAINR DVDPON
10K
C608
L250 4.7uH
C606
Q233
R253
MAINL R613
100/50
C605
10/35
100/50
1K C261
R608 33K
0.1uF
C260
Q601 KTA1267/YG/-T
10/50
47K
C604
R603
R609 100
C607
4.7K
!
10/50
4R7
0.1uF
Q232 2SC3576-JVC-T
R602
C263
R267
220P
!
C262
R266
4R7
!
D600 MTZJ9.1B-T2
0.1uF C265 R252
!
220P
C267
R269 4R7
C264
R610
!
C266 0.1uF
C609 220P
!
4.7K
! R268 4R7
C601 220P R601
C602
Q231 2SC3576-JVC-T
C603
C271 1000P
0.22
10/35
R605
1K
! R604 0.22
C600
R600
!
HPSW
S12V
LEVEL
Q230 2SC3576-JVC-T
R251
47K
R250 4.7K
IC600 STK432-070 CN207 QGB2510K1-13
Q234 KRA111M-T
1000P C270 1000P
HPMUTE
FANSPD
HPL
HPSW
C269
HPR
C268 1000P
FANCTRL
! CN201 QGD2504C1-04Z
S5V/B5V
S5V/B5V
0.39
CN511 QGB2510J1-16
(SHEET 3)
10
R629
L602
KTC3199/GL/-T
47/63
Q603
D602
C615
R619
2.2K
R632
47K
C618 1.2K
! R627
47K
R625
2.2K
R624
R631
3.9K
4.7M
!
0.047
C613
1.2K
220
! 1M
R628 10
C617
0.082
!
0.047
R618
0.047
C620
Q602 D601
L601
0.39
KTC3199/GL/-T
10
R616 C612
10
Q604 2SK301/PQ/-T
R620
KTC3199/GL/-T
0.022
56K
C622
D240
47/16
C241
100K
R243
KTA1267/YG/-T
D235
MTZJ15C-T2
C236
10/16
C619
10P
R630
220
R614 100K
R241
10K
R617
0.047
C611
!
47/63
10/50
10K
C240
R240
KTC3199/GL/-T
56K
R242
Q222
0.0047
C235
C616
R626
Q221
MTZJ12C-T2
D234
C234
100/25
KTC3199/GL/-T
!
0.022
R621
R255
470
R233
! 1K
C614
10P
470
1K
RY1
! !
R265
QSK0109-001
!
R264
Q215 KTC3200/GL/-T
Q216
R234
C610
R615
Q220
R263
R260
RY2
R262
! ! !
R261
QSK0109-001
! R254
D260
D261
DC
1/50 R635
C621
10K
0.22/50
R633 82K R622 R634
47K R623
R636
100K
15K
20K D603
FW218 QJK015-111814
CN208 QGA3901C1-11
15K
22K
15K
R230
22K
R229
R231
R232
MTZJ2.4B-T2
R236 DGND 4.7K PAGND B6110 ML
ML
SURROUND
SURROUND DC
!
DC
S4L
! IC650 PQ05RD21
IC670 IC660 ! KIA7805API
CN700 QGB2510K1-12 SWIN SWGND
SWIN SWGND
DC SWFB
IC200
!
KIA317PI
POUT
FW705
(SHEET 3)
CN710 QGB2510J1-12
D671
220/10
MTZJ6.8B-T2
1K
R671 10/50
C670
D660
1K
R661 D661
10/50
C660 C651
470/25
D650
0.33
D228
D227
D229
D230
C650
IC201 KIA7812API
MTZJ5.6C-T2
!
4.7K
B2502
R239
KIA7805API
MTZJ8.2B-T2
-VL VL
10/50
MR
4.7K
C661
MR
R238
C671
4.7K
D670
R237
IMP MTR.GND R220
M9V
D231
R221
M9V AGND
10
D220 1N4003S-T5
R714
R708
56K
R709
56K
0.022 R720
4.7P
100K
2.2K
R716
R715
!
R718
1K
1K
C709
47
47
R733
R734 !
C713
47/63
!
820
1/50
! R732
D706
10
10/50 KTA1267/YG/-T
0.047
C717
47K
C719 R722
D705
MTR.GND
C718
56K
!
10
R726
L702
0.39
KTC3199/GL/-T
Q704
L701
0.39
10
C715 0.047
AGND
R730
1K Q705
R728 KTC3199/GL/-T
0.047
R724
5.6K
5.6K
R723
C714 0.047
R735 C716
! R731 820
R727 10
! D207
1K
10/35
C711
! !
47K
SWR
R721
SWL
R725
C712
SWL SWR
0.1/250
R717
QJK015-101814 -VL
47/63
C218
R209 ! D206
-VL
S4H C220
10K Q706
R736
47
R738
82K R737
! R205
100K
0.01/250
100K
R208
C219
C217
C213
100K
0.01/100 R207
C215 C216
0.1/250 ! D211
1K 56K
PAGND
D205 !
D204 !
0.022 R719
R729
VL
0.01/250
! R204
D209
C221
ECO
0.01/100
! D210 C214
SUB5V
FL1
C212
8200/16
CN212 QGD2504C1-03Z
FL2
! ! D208
C210
B2612
S3CT
100K
! D215 1N5402M-20
C710
4.7P
-VH
VL
R206
! D214 1N5402M-20
C708
VH
VH -VH
D213 1N5402M-20
C209 8200/25
C208
0.01/100
! D212 1N5402M-20
FW216
CN206 QGA3901C1-10
C207
Q703 KTA1268/GL/-T
R710
S2
0.01/100
10K
R713 C705
C704
C703
470P
33K
R707
D701
MTZJ36B-T2
R703
R702
R701
R700
D700 MTZJ36B-T2
B2108
S1
!
100K
47
CN213 QGD2504C1-04Z CN205 QGD2504C1-03Z 37V
R760
!
B7005
Q750 KTA1046/Y/
EP201 QNZ0136-001Z !
!
! R752
R751
R750
!
! IC750
IC760
KIA7809API !
R761
10K
D760 C761
10/50
C760
D750
C751
220/16
MTZJ10B-T2
10/50
1K
C750
R756 Q752
R754
Parts are safety assurance parts. When replacing those parts make sure to use the specified one.
10K
R753
10K
10/50
Q751 KRA110M-T
MTZJ10B-T2
R755
D751 MTZJ5.1B-T2
(SHEET 4) (SHEET 1)
10/35
S2
100K
(SHEET 1)
S1
S4
0.1
Q700 KTC1027/OY/-T
0.1
!
C702
B2952
CT
S4
KTC3200/GL/-T Q702 D704
C707
10K
100/10
R712
10K
C701 220P
R711
0.22
R706
R705
0.22
C700 220P
!
10
C227
!
D702
R704
D703
10/25
S4CT
10K
STK412-400 MTZJ15B-T2
R214
100K
C231
D225 MTZJ20B-T2
Q701 KTA1023/OY/-T
MTZJ15B-T2
C229
KTC3199/GL/-T
22/50
IC700 !
D224 MTZJ18B-T2
C706
R213 47/100
C228
! R222
Q205
C230 0.01
1N4003S-T5
D223
D221
7.5K
R225 !
C237
10/50
R223
3.3K 2.4K
R224
10/50
D222
100/50
MTZJ6.8B-T2
CN214 QGA3901C1-08
9V
Q206 KTC2026/OY/
1N4003S-T5
C226
R212
47
Q210 KRC102M-T
C238
D237 10K
MTZJ13B-T2
C232
47/25
1K R227
R228
47K
MTZJ5.1B-T2
D226
CN202 QGA2510C1-03
Q212 KTC3203/OY/-T
!
R226
9V !
22/50
STATUS
47/50
C225
FAN-
R211 100K
270
FAN+
KRC102M-T
SHEET 2 2-3
Q568 PBR
2SD1328/ST/-X
4.7/50 C467
UN2115-X
UN2211-X C466
Q426
2-4 R476
220k
4.7/50 2200p
4.7/50 100/16 C477
C526
10/35
30K
220k C528
100K R526
100K
R479 0.22
0.015
MIC_MUTE 0.027
0.015
C529
IC467
C475 C532
10/35
C533
HA17558AF-X R528
R428 UN2113-X
220K
10/35
10k
10K
Q540 R542 10K
2.2M C103
IC802
INH R1152 1K RSEARCH
1K FSEARCH
1K R1153
R853
220
1K R1154 R1155 R819 R820
R849 220 R821
R504 IC125
10K BA33BC0T
R516
C493
5.1K
R515 22K R517 22K
R124
1.0K 470 2.2uH
SURRLED
R896 1K
R897 R898 1K ECHO2
R899
1K 1K
S/WLED ECHO1
1K D1LED
1K
1k
D2LED D3LED
1K D4LED
1K D5LED
4.7K
1k
220/16
1k C497 0.01
C111
C495
11k 47/16
100K R836
R835
L124
R522
DISPD2S
47/50
1.2k
C124 220p
R103
0.01 AVC
DISPCS
C115 0.1
R120 R122 100k R119
1k 10/50
C110 0.1
CDL R121 100k 1k 10/50
UN2213-X
D805
C113
DISPCK
1.2k
R834
R110
1K
DISPD2D
10/25
C473 C474
10k
R530
(SHEET 5)
1K
C108
D595
100/6.3
C580
SUB_5V ECO1
LEVEL
RELAY FCTRL
HPSW
R518 HPMUTE
STATUS
SWFB
R531 POUT
S5V
DVDPON
5.6V
(SHEET 2)
SM+
R854
1K
IC580
2.2K
220
R850
R888
Q101 2SD601A/RS/-X
COMP_OUT
R115
R851
MSI
1K
R889
0.022
CbOUT
2.2K
RDSCLK
EECLK
EEDA
MSIN
C102
22
R101
DISPCK
DISPS2D
EECLK
DISPD2S
EEDA
M.P.ON
M.SAFETY
NTSC/PAL
R116
SB2LED
R895
D108
HPFOFF
VOLCE1
VOLDA
SMUTE VOLCLK
BASS1
BASS2
C101 680P
RESET
VPP
TW01
TW02
S1100
1N4003S-T5
1K
10k
1K
2SD1328/ST/-X
DISPRST
220
R112
S.BOOST
220
R818
10k
1K
R894
Q517
IC801 1k
R817
R893
R520
SM-
1K
UPD78F4216AGF
R111
SAFETY
D100
R100 100K
R890
10K
C491 Q110
DVDPON
POUT
RDSDATA
R813
UN2211-X
1K
SURR
AVCI BUZZER
C100
1/50
10K
10k
1K
R1151
30P
R519
1K
R857
R812
1K
R856
STATUS HPMUTE
MIC_MUTE
1K 1K 220
VPP FCTRL SLCPLAY
R583
2SD1328/ST/-X
1K 220
R810
R809
R892
ECO MRELAY
CN801
0.1
R808
R807
1K 1K
VS1 VS3 B_CTRL
TUR
QGF1210G1-07
Q516
QAX0724-001Z
C127
X801
0.1
R816
C126
1K
1K
220
C125
R822
1K
1K
1K
EEDA
470/6.3
VOL-
R827
R828
R823
R825
1K
R805 R806
1K
1K
1K
1K
D801
Q515 2SD1328/ST/-X
D125
BK VOL+
LATB
R829
1k 1K 1K
1K R831
R824 R832 R830
1k R833
R802 R885 R804
R886
MSI
MTZJ5.1B-T2
BASS2
Q535
M.P.ON
FLCLK
FLDATA
NTSC/PAL
SLCCE
S/TCLK
S/TDATA
TDATA
EECLK
D516
100p
DISPCK
220 220
R838
1K
R837
1K
R840 R839
C802
DISPD2S
1k
1k 1k
1K R842
1K
CDR
R844
R521
R841
C588
DISPD2D
SBYLED
FSPEED
D807 R843
VSW
33P
MTZJ3.9B-T2
PHOTO SPI
R557
R826
VRGB VMUTE2
Q100
MTZJ3.9B-T2
47k
KEY1
1K
2SD601A/RS/-X
BASS1
R500
1K
C596
10k
TUL
To TUNER
(SHEET 2)
UN2213-X D515
2SD601A/RS/-X
IC534
QQL231K-2R2Y
1/50
2SD601A/RS/-X
MTZJ3.9B-T2
47k
R861
SPI
33p
Q541
47/16
C104 0.0018
CD4066BM-X
Q487
100k
C597
2SD1328/ST/-X
C428
R596
47K
47/16
C496
KEY4
220/6.3 KEY2
C807
R803
AVC
R597
TDATA
S/TCLK
S/TDATA
TUCE
SM-
1
1
RSEARCH SM+
1
1
1
FSEARCH
D1LED
D2LED
D3LED
D4LED
D5LED
VOL-
VOL+
FLDATA
FLCLK
LATB
BK
BUZZER
KEY1
KEY2
KEY4
SBYLED
C543
C425
C544
C545
C546
SB2LED
SB1LED
SURRLED
SMLED
QGF1205F1-11
2SD1328/ST/-X
Q486
UN2215-X
BA33BC0T
51K
2SD601A/RS/-X
Q595
D594
47k
R598
KEY3
REMIN S/WLED
CN560
C534
47/16 R534
470/6.3
LEVEL
R847
SLCKEY
R852
1K
REMIN
R848
VPP
KEY3
220
Q542
R499
100k
R595
6.8k
R594
MIC
ECHO2
ECHO1
CN802
51K
R535
0.082
220
R858
10K
D802
22K
LRMUTE
15K
C492
220
R859
M.SAFETY
R536
HPSW
100K
Q584
R537
D804 R845
DISPBUSY
1
IC582
1K
1K PRT
Q801
1/50
C594
R599
R540
6.8K
R860
YC_MIX
Q534
R495
INT/PRG
0.01
MRELAY
C804
D809 0.022
C803
SA
1.0K
5.6K
RELAY
100k
C811
R855
R503
TUCE
UN2211-X
INH
47/25
ECO
270
ECO1
R1150
RESET 27P
1K
2.2/50
Q804 C801
0.01
C805
C464
R501
22k R502
D806
C498
UN2111-X
D803
100/6.3
1K
R863
Q802
330
R846
MTZJ4.3B-T2
D814
4.7/50
IC486
R458
Q805
QGF1036F1-06
UN2111-X
C808
1.2K
HA17558AF-X
Q485
0.22
C595
UN2213-X
R498
10K R866
1/50
C494
PBL SLCKEY
1K
100K
R867
R563
100k
220k
PHOTO
1K
1K 1K
R870
R868
R871
R869
UN2211-X
100k
L543 D486
2SD601A/RS/-X
D485
R494
1/50
120K
KEY2
FAOUTR
C540
R475
KEY1
R1163
R533
C476
KEY3
10K
R872
D811
C809
150K
R496
47/16
KEY4
10K R873
1K
R891
Q594
15K
22K
AVCI
10K
R874
R864 2.2K
QRZ9006-4R7X
R532
R478
NTSC/PAL
R876
2.2M
IC526 HA17558AF-X
100K
VOL-
10K 10K 10K
R877
R875
SPDIF
0.015
R473
C531
C486 R497
1K 100
SM+ SM-
10K
R878
D586
AUXR AUXL
QGF1205F1-23
10/25
C471
R490
R493
C489
C490
C488
VOL+
10K
R879
MTZJ3.9B-T2
C530
10/25 RSEARCH
10K
R882
0.1
MTZJ3.9B-T2
0.015
10K R489
100
R487
R492
MSI
220
82k
0.015
8.2K
5.6K
22k
0.1
FSEARCH
D813
0.22
C810
0.1
C586
(SHEET 4)
220K
R529
SLCCE
R482
IC485
C487
8.2K
4.7/50
10K
D808
R481
C472
10K
CN503
56K
R477
C572 R883
UN2115-X
R491
R485
R884
Q803
HA17558AF-X
R488
0.1
TUCE
10K R1157
10/25
C463
100K
R450
R865
D467
10k TDATA
10K
R880
QGB2510J1-05
22k
10K
R881
RDSCLK
D466
PBR R486
STATUS
HPSW
PRT
10K R1158
S.BOOST
1K
100K
R474
0.039
C485
BCTRL
10K 10K
R1160 R1159
10K
C806
R1161
Q442
100K
R471
100K
0.0027
VS3
VS1
VSW
5.6K
R449
4.7K
6.2K R444 6.2K
6.8K
R459
C584
C585
470/6.3
(SHEET 4)
R480
R440 0.0082
C470
30K
270K
IC425
43K
MSIN C499
1K
R470
HA17558AF-X R472
HPFOFF
IC442
10/25
4.7/50
10/25
10/25
R448
KTC3199/GL/-T
C469
10K
JVC8011-X
C460
C459
C458
C456
4.7/50
4.7/50
10/25
10K R445
C462
0.047
KTA1267/YG-T R469
R426
IC466
10K
HA17558AF-X
R429
43K
2SD1328/ST/-X
3.3k
3.3k
R425
R467
100p
SMUTE
Q425 15K
R456
10k
R468
R436
C468 0.22
10K C457
100
C446 C453 C454
10/25
R446
10K
R447
KTC3200/GL/-T
R466
30K IC426
100p 10/25
C455
R454
470K
R452
10/25
Q543
HA17558AF-X
R435
C431
10K 2.2/50
2.2M
R453 470K
AUXL
10/25
C452
C447
4.7K
Q545
1K
R430 R455
0.027
4.7K
R441
PHOTO 100k
0.22/50
10K
C432 100k
47K R439
S/TDATA
R438
C567 R414 C442
J576
10K
2SD1328/ST/-X R415
10K
Q544
R433
R556
10K
AUXR
MIC
C430
0
10/25
10/25 10/25
1K
C451
FMDET R442
0.47/50
C443
R544 47/25
R443
C461
0.0068
R427
QGF1205F1-10 R558 4.7K
FAOUTL
R434
CN44 1/50
C553
RDSDATA
C450
R545 5.6K
R565
MTZJ6.8B-T2
D585
0.01
IC581
10K
R432
4.7K 47p
C549
C583
10/25
C581
SA
FR
47p
C550
UN2113-X
RECR
100k
R412
C589
MTZJ5.6B-T2
DVDPON
C582
10/25
D582
RECL
C433 B5174
4.7K
R555
UN2115-X
100/25
B5109
100k
4.7K
R554
C556
R413
FAOUTR
VOLDA
VOLCE1
D583
R564
C423
R403
C555
1K
R577
1K
Q585
R401
10/35
470p
UN2213-X
1K
FAOUTL
R402
3.6K
DVDPON
VOLCLK
C403
R405
R582
C401
0.1
C405
220
0.1
10/25 2700p 0.1
C409 C407
R1164
3.6K
C408
10/35
C404
C406
10/25
C413 C411
D581
100/25
POUT 0.1
2700p
C410
C412
FL PBL TUL
1N4003S-T5
C402
SLCPLAY AUXL
R1165
R404
SLCKEY
10/25
S/TCLK
10/25
D567 20K
R407
D580
470p
15K
QGF1205F1-09 2.2/50
10/25
R569
10/25
R570
10/25
470/6.3
C422
R408
C419
RECR
C415
RECL
1K R568
C417
QNN0420-001
C414
18k
C416
R567
C418
220p
C568
C420
R576
10/25
1.0K
10/25
R586
R584
DISPCS
10/25
0.022 FR
18k 2.2K
2.2K
R587
DISPBUSY
CDR
2.2K 2.2K R585
R588 4.7K
DISPRST
CDL
UN2211-X
R581
15K
100K
R590
R589 10K
1.0K
DISPCK
R409
470p
100K
R591 4.7K
Q581
UN2211-X
Q580
DISPD2S
2.2/50
C421
0.001
C570
82k
R593
Q583 UN2211-X
10K
R592
DISPS2D R580
20K
R406
Q567 100k
82k
220p
R579
Q582
L580
TUR
CN43 R572
220P
R578
UN2211-X
CN111
0.001
C576
2200p
C577
QQL231K-221Y
IC401 LC75342M-X
R571
C578
C593
AUXR
R573 C569
470/10
100k
C571
1K
220p
0.01
D576
D577
2200/10
C574
R575
(SHEET 7) LRMUTE
22K
R574
(SHEET 7)
External input / Source select switch section CN803 QGF1205F1-15
(SHEET 2)
QSW0454-001
QGD2504C1-03Z
CN715
QGF1036F1-26 CN110 QGF1205F1-21
CN502
Cout Yout
CrOUT Cout
Yout
CrOUT
PQ033EF02SZ
CbOUT
470/10 COMPOUT
VMUTE2
INT/PRG
YCMIX
R102 VS1
VRGB
VS3
VMUTE2
BCTRL
VSW
BR24L01AF-W-X
QNS0089-001
J123
C812
R123 220
2.2uH
L123
D816 C123
1K
220p
RESET
100K
R887
SB1LED
SMLED
GP1FA553TZ
J108
SPDIF
5V
C116 0.1
220/10
C114
C112
SWFB R117
R118
0
0
QGF1036F1-17
CN661
Q111 PRT
2.7K
CN217
FSPEED
SURR
QGB2510J1-13
10K C427 MGND
9V
22K MAINL
R541 CN501 MAINR
QGB2510K1-16
R527
C527 100/16 C536
1000P C575 10/35
SHEET 3
FL display / System control / User control keys section
IC953 HA17558AF-X L1002
C915
R911
R924 10K
R925
8.2K
C907
R926
4700P
C925 1000P R939
B9006
HPR
AGND
1000p
1000p
C1002
C1001
C1006
1000P
1000P
1000P
C1004
C1005
J910
0R0
C960 C962 4.7/50
R940
4.7/50
18K
C911 22/50
C909 0.01
C910 3300P
R1907
10K
R934
NJM4565M-WE
B9003 0R0
R935 4.7K
10K
B9002 0R0
R936
R1905 51K
R1906 51K
C963
R941
C902 100/6.3
R937
4.7/50
0R0
C928
1K
B9001
R933
0R0
R931 1K
R932
R1903 C964 220/10
20K
5.6K
Q911
UN2113-X
IC951
220
R928
UN2113-X Q912
R942
1K
GP1UM271XK
18K
B9000
4.7K
2.2/50
C961 4.7/50
R1904
82K
C930 0.01
C913
220P
15K
C929 220P
C912 0.47/50
Q910 UN2113-X
82K R943
R930
2.7K 20K
DGND
R929
IC956 KEY3
B9005 0R0
B9004 0R0
IC952
S907
(SHEET 3)
9V
HPL
QNS236-001
QNS236-001
B9007 0R0
LED5
C901 1000P
HP
C922 220/10
C923 2200P
R919 1.5K
100 R918
C921 100/10
R917 4.7M
C920 4.7/50
R945
R922 10K
(SHEET 2)
C924 1000P
4.7K
REMIN
MIC
QUB220-21DMHP
560
R910
150
S903
GND2
D1003 MTZJ2.4B-T2 FW711 QUM154-33DGZ4
R938
0.01 C908
BU9253FS-X
LED2
2200P
D918
J900
VR900 QVQ0299-B54
R927
LED3 LED4
QNSO204-001
C1003
2.2uH
D915
S906 R906
LED1
20K
0.1 100P
C905 R909
120
R905
C906 0.01
33K
C900 S902
J1001 L1003
R921 12K
4.7K
R923
100/6.3
VCC
R920 390
20K
390
S905
S901
MTZJ5.1B-T2
R908
100
270
S904 R904
Q903
UN2211-X
Q902
UN2211-X
Q901
UN2211-X
C904 100/10 D917
C903
R944 560
GND1 QUB220-21DMHP
1SS119-041-T2 D916
150P
Q909 2SD1328/ST/-X
R916 4.7K
SLA-362LT-T
D907
SLA-362LT-T
D906
SLA-362LT-T
D905
SLA-362LT-T
D904
SLA-362LT-T
D903
SLA-362LT-T
D902
D901 Q930
2.2/50
220
C918 330P
51
R907
S900
UN2211-X
R912 R913 1K
C916
C919 150P
R1902 220
220
R903
R1901 220
220
R902
R1900 220
220
R901
R990 220
R900 220 SLR-342VC-T
SLR-342VC-T
D900 UN2211-X
Q900
C917
20K
100
QGF1205F1-15
0.22/50
R914 10K
R915 1.5K R997
CN900
L1001 47uH
47uH 4.7K
C914 4.7/50
JS958
JS960
QSW1057-001
P12
P10
P9
CN902
P13
P11
P7 P8
P4
P5
P6
P3
P2
P1
P14
P15
P20
P16
P17
P18
P19
P24
P21
P22
P25
P23
P26
P27
P29
P28
P30
P32
P31
P33
P34
P35
P36
G1
G2
G4
G3
G5
G6
G11
G7
G8
G9
G12
CN903
SOUNDMODE-
SOUNDMODE-
SOUNDMODE+
SOUNDMODE+
PRESET-
PRESET-
PRESET+
PRESET+ DGND
P24
P25
P26
P27
P29
P28
P30
P31
P32
D5LED VOLVOL+ VCC
VOL+ +5V
C940
D4LED
VOL-
0.01
D3LED
D4LED D5LED
0.01
D2LED
D3LED
C939
D2LED
0.01
D1LED
C938 0.01
KEY1 KEY2
C937
R983 100K
P33
P34
G2
G3
R996 100K
R995 100K
D3LED
G4
G5
D2LED
G1
D1LED
P35
KTC3199/GL/-T
PRESET+
P36
PRESET-
KEY2 D1LED
C936 0.01
KEY1
FL2 Q951 Q950 KTC3199/GL/-T
0.01
FL1
SOUNDMODESOUNDMODE+
QSW0857-001
QGF1205F1-18
C935
QGF1210G1-23
G10
QGF1205F1-18
CN901
JS962
QSW1056-001
DGND
D4LED
KEY2X
R956
KEY2X
D5LED 100
VOL-
D908
KRC102M-T
R953
P14
D3LED
Q906
220
SLA-362LT-T
P3 10/50
R954
D5LED
Q908
FL1
R971 R972
S924
S914 FW904 QUM022-10Z3Z3
S925
1K
KEY2X
1K
1K
C941
FW901
1.8K
S916 R965
R948
100/6.3 R950
R946
TC74HCU04AP
1K 1K
FW901
R947
KEY4
S915 IC955
QUM153-10Z4Z4
S926
DGND
QUM153-10Z4Z4
270
S923
FL2 +37V
220
S913
220
SLA-362LT-T
R973
QUM022-10Z3Z3
P13
390
P12
Q952 KRA102M-T
S912
560
FW900
220 D912
FW902
R974
P11
R955
SLA-362LT-T
KRC102M-T
P10
270
Q907
P9
390
D4LED
P8
560
P7
R961
P6
22/50
5.6V
QUM023-10DGZ3
S922
R962
22/50
KRC102M-T
P5
C932
R963
C931
SBYLED
D911
P4
KEY4
100
S921 S911
R970
KEY2
KEY4
C942 S917
1K
S929
D913
R975
S927
1.8K
220
R976
LATB
VCC
10/50 R978
R980 100
SLR-342VC-T
(SHEET 2)
R968
P1 P2
120
S920 S910
D910
P15
100
SLA-362LT-T
R969
Q905
P16
C943
QAN0055-001
S909
220 D2LED
100
R952
P18 P17
G12
BZ900 KEY1
KRC102M-T
P19
G11
S919
150
P20
G10
R982 100K
D909
120
PT6305
G9
L901
QQL244K-100Z
BUZZER
Q904
150
LATB BK
D1LED
P21
220
IC954
G8
R957
QQL244K-100Z
S908
R958
CLKB
220
SLA-362LT-T
R959
P23 P22
R960
G6 G7
R967
R951
L900
DI
R964
(SHEET 3)
S918
KRC102M-T
VOL+
S930
R997
R998
S928
R999
SHEET 4 2-5
CD changer mechanism control / CD servo and CD system control section CN251 QGF1036F1-15 TR3_CL TR2_CL TR4_CL TR1_CL INDEX
TXD0 1k
CN653
NI
1k
100p
R278
0.1/16
C259
C201
M.TR_OP
(SHEET 6)
R284
S.TR_ST
RXD0
TR5_CL
IC201
POS_UP TR_OP POS_DOWN
5.6k
R601
BR24C08FV-X
TBAL
TR_CL C603 FBAL
33k
C604
R625
D
C626
QGA2001F1-03
R281
R624
B
C607
R622
C
C625
0
M.TR_OP
R286
1k
R626
NI 0
GCTL
0
TP601
TR5_CL
R287
1k
R264
TR4_CL
R288
1k
R263
1k
TR3_CL
R289
1k
R262
1k
TR_OP
TR2_CL
R290
1k
R261
1k
TR_CL
TR1_CL
R291
S.TR_ST
R292
R623 NI
NI
POS_DOWN POS_UP OUTL
0
0.1/16
0.1/16
OUTR
NI 0 C254
R265
C622
NI
10k
10k
10k
R257
TP273
100/10
0.1/16 C621
IC601
C257
WECNT
1k
R255
47k
10k
47k
1.2k
10k 2SB1424/QR/-W
R298
100p
RASCNT
EQX5 NI
3.9k
R611
3.9k
R613
1
R617
1.2k
CASCNT
Q653 NI C644
NI
MCLK
C608
STAT
C641
Q631
C001
QAX0684-001Z
X251
WECNT
0.1
MDATA
2SA1037AK/RS/-X
Q291
R297
47/6.3
C252
C251 0.1/16
0.01/16
C258
NI C261
C256
0.1/16
C610
C624
R634 3.9
0.056/16
C004
C611
C631 10/16
C632 0.1/16
0.1/16
R632 3.9
F-
C623
100/10
ARF RFENV
NI
TP1
0
T+ T-
R295
BDO
R631 F+
R294
R293
NI
NI
R618
R619
C616
C615
NI
C614
C612
1K
OFT
C617
R608 D601
R254
0
R606 NI
0.0018
0.0027
0.039/16
0.1/16
F
47k
/RFDET
C
R256
1k
10
B
1
C255
(SHEET 3)
MLD
R635
R607 D
C002
1k
CASCNT
AN22002A-W
C633
R258
1k
A
22k
C253
1k
L.SENSOR E 22k
C291
R253
47/6.3
10k
C642 Q651 NI EQX2
AD4
AD5
AD6
AD7
AD8
D2
D3
/DWE
/DCAS
AD9
TP2
NI
C643 Q652 NI
EQX4
0.1/16
0.1/16
C653
TC7SH32FU-X IC681
IC671 A42L2604V-45L
C655
TC74VHC08FT-X IC682
NI
CN652 NI D652
INDEX
NI
TNO
AD3
AD2
AD1
AD0
AD10
D1
D0
/DRAS
COPY R678
LRCK
0 EMP
SRDATA
QGA2001F1-06 CN602
C812
10k
C651 100/10
NI
D0
D1
D2
D3
/DWE
/DRAS
/DCAS
AD8
AD10
AD7
AD6
AD5
AD4
AD9
AD0
AD1
NI
C679
4.7k R676
R801
4.7k
R809
22k
R814
18k
NAX0476-001X
4.7k
X651 R655
TRD FOD
R682
TXTCK C656
0.1/16
R651 IC651
47k
R675
1k
TXTD
R674
1k
DQSY
MN6627911AC1
TBAL
R673
FE R652
C681 1/16
C675 10p
C676 10p
C674 0.1/16
FBAL
TE
100
XC6206P182M-X
1/16
MON
IC691
100/10
C677
0.1/16
C678
0
TP653
SPINDLE
0
0 R679
NI
5.6k R816
5.6k
5.6k
5.6k R803
R807
R812
0.01/16
NI R808
NI R804
C804
0.47 C803
R677
R805
TRV
D653
0.1/16
NI C814
C813
1000p
NI
NI C805
R817
C806
R813
1500p
FM-
AD2
0.1/16
SM+
AD3
C652 C654
SM-
BCLK
R681
NI
FM+
D654
0
R672
1k
/RST_DSP STAT
1k
RFENV OFT R671
/RFDET
R653
GCTL ARF
33k
R669
BDO
BLKCK 1k
22k
470p
MLD MDATA
C663
NQR0007-002X
0.1/16
27k
C673
NI K653 LRCK
TX
K654
NI
0 NI
R664
100
K652
NI
R665
100/10
R662
K651
0.1/16
D656
SRDATA
0.1/16
C665 C666
IC801
C662
0.12
C661
R657
0.022
1000p
C659
NI
Q654
AN4801SB
BCLK
R663
NI
82k
C667
SPINDLE
100k
TRV
3.3k
560
2.2k
R806
R654
C658
R802
R656
R818
NI
NI
C807
SM-
C808
SM+
/DR_MUTE
22k
FM-
PC2
PC1
FM+
0.1/16
MCLK C657
R683
FLAG
680
R666
560
C669
C668
OUTR 2700p
NI
15k
0.1/16
TRD
C671
FOD 0 D655
C811
C809
NI
NI
T+
C664
15k
R815
100/10
R811
NI
T-
R667
680
NI
C672 R668
560
2700p OUTL
R658
HDU-110
1k
RASCNT
CN601
0.1
1k
TX BLKCK
0
0.022
QGF1006F2-16W
R274
FLAG
1k
A R621
1k
DQSY R285
S.TR_END
R296
(SHEET 6)
R271
MON
TP623
NI
R259
L.SENSOR
VR001
QGF1036F1-17
EMP /RST_DSP
NI
CN253
C003
CN651
1k
TP272
C606
(SHEET 6)
COPY
MN101C61GMB1
EQX2 EQX4
R605
S.TR_END
NI
TNO
TXTCK
TXD0
150p
CN252
C602
1k
TXTD
EQX5 TE
R604
NI
1k 1k
R267
RXD0
E
C601
R283 R282
IC251
/DR_MUTE
100k
R603
0.1/16
F QGA2001F1-02
PC2
TP622 C605
3.9k
330p
R602
PC1
FE
0.1/16
FR659
F+
15k R661 C802 0.1/16
C801 220/10
2-6
15k
SHEET 5
CD tray control section
WJM0331-001A
(SHEET 5)
QVY0002-B14
IC1
QSW0886-002
LB1641
IC1
C3 0.01/50
M.TR_OP
POS_UP TR_OP POS_DOWN TR_CL
100/10
C1
C2
0.1/50
C5 0.01/50
C7
C6
0.1/50 M2
0.1/50 M1
QRA0164-001
TR3_CL TR2_CL TR4_CL TR1_CL TR5_CL
TR_CL TR_OP
TR4_CL TR3_CL TR2_CL TR1_CL
M.TR_OP TR5_CL TR4_CL TR3_CL TR2_CL TR1_CL
D1 MTZJ6.2A-T2
QSW0844-001
SW1 TR1_CL
QSW0844-001
SW2 TR2_CL
QSW0844-001
SW3 TR3_CL
QSW0844-001
QSW0844-001
SW4 TR4_CL
TR5_CL
SW5
TR5_CL
POS_UP POS_DOWN
CN3 QGB1214J1-08S
QSW0931-001
CN2 QGB1214K1-08S
SW6
(SHEET 5)
LB1641
IC2
CN1 QGF1036F1-16
WJM0330-001A
(SHEET 5)
SW8
QRA0164-001
SW7 QSW0886-002
SHEET 6 2-7
MSI-5U2LWA
IC1
SG-105F3
VKZ3174-00B
1SR139-400-T2
QSW0832-001 SW6 QSW0859-001
QSW0832-001 SW1 QSW0832-001 SW2
SW5 270P
C107
R105
C105 100K
390P
2.2K
R104
R102
5.1K
D340
MTZJ5.1B-T
Tape deck mechanism control / Tape circuit such as pre-amp. and bias section
D1
FW100
2.2K
27K
1K
R116 Q342
C104
Q343 2SC3576-JVC-T
220p
C102 0.01
10k
C340 47/50V
Q345 2SC3576-JVC-T Q346 2SC3576-JVC-T
R304 100 R305
R341
10K
C210
1/50V
47/50V R207
C300
C342
220
C306
100/10
C301
C304 10/16V
IC32 HA12238F
R301
4.7P
QGF1205F1-06 C220
CN31
100K
1/50V
9.1K
C213 0.1
R201 C203 C206 2.2/50V 5.1K 0.1
10k R206
R208
RECR
27K
PBR
R340
11K
R205
C205
680
C207
C374 Q371
100/10
R372
D375 MTZJ5.1B-T Q376 KTC3199/GL/-T
3.3K
L303 VQP0033-100Z
C371
R353 10
L301 QQR1118-001
IC33
Q302 2SK2001
470K
100
CD4094BC
R314 15K C308
0.022
2.2
C310
R347 10K Q347 KRC107M-T
C331
22/16
C314
R313
1.5
0.0015
0.022 C316
0.0047
C313
100/10
R327
R315
C319
TP100
4.7/25
330P
R337 3.3K
4.7K
15K
150
330P C221
R376
R221
R375
C121
15K
R338
Q372 KRC107M-T
QVP0008-203Z VR31 R121
KTA1271/OY/-T
0.01
C376
2SB562/C/
1K
Q375
270P
390P
100K
2.2K
R204
5.1K
1K
R216
R202
C201
820P
C101
820P
4.7/25
C209
4.7P
C307 0.001
R210
18K
0.01
R343
C202
220p 0.0068
24K
C204 C110
9.1K
R342
0.0068 R107
C120
QAH0101-001
4.7K
CN32 QGF1205F1-09
22K R339
C341 R345
CN42 QGF1205F1-09
VR37 QVP0077-103Z
R336
Q344 2SC3576-JVC-T
4.7K
4.7K R346
12K
PRL
R110
220/10V
4.7K R344
4.7/25
R306
C109
KRA111M-T
11K
0.1
R302 2.2K
R101 5.1K C103 0.1 C106 2.2/50V C113
R106
RECL
12K
R303
R371 R108
R310 4.7
R335 Q305
2.2K
2SK2001
CN34 QGF1201F3-10
CN33 QGF1205F1-09
(SHEET 3)
(SHEET 3)
Parts are safety assurance parts. When replacing those parts make sure to use the specified one.
SHEET 7 2-8
Printed circuit boards Power board
EP202
S200
Q222
Q221
R241
R242
J200 C271 C260
C270
C267
R269
R266
R243
CN208
C264 C261
CN206
R229
R268
C241
C240
C269 C268
D240
FT201
R240
C263
C262
CN200
Q220
C265
R267
D227
C266 R237
D228 R230
R236 R238
D229 R231
FT200
C200
R239
CN207
D230 R232
RY3 D261
FT210 C236 RY2
R261 R265
R262
T002
R264
D235
R260
C235
Q215
R233
FT211
C234
CN202
RY1
D201
D200
D260
R263
D234
Q216
R200
C201
R234
D207 C202 R202 D205
Q200
D202
EP200 C221
C220
C212
R208
D203
C203
D204 Q234
R206
D210
C217 R254
D206
R255
C204
R251
Q201
R209
R203
R253
D208
C216
R250
R252
T001
C219 C215
C214
Q230
Q231
Q232
Q233
R207
C213
D211
CN201
L250
R201
D209
C218 CN212
FW202
D216
D212
CN213
EP201
D214
C209 C210
D213 PP201
C222 FT220
D215
Q211
FT221
C208
C206
C230
C232 R275
Q212
D237
R270
R272
C231
C211
Q206
R271
C228
R273
D224
D222
D220
D223
R224
R221
R223
R220
(Primary board)
IC200
C226
FT250
R212
C237
FT251
R225
FW204
R274
R211 C225
D225
D231
C205
R276
IC201 Q210
R205
FT231
D226
FT230
C229
R227
R204
R277
C238
R228
FT240
R222
FT241
PP200
C207
R226
R213 CN214 R214
D221
C227
CN205
Q205
(Bridge board)
2-9
Input board
(Main board) Q542 C534
C526
C536 C527 B5146
C528
R531
R533
B5145
FW401
C460
B5185
R529
B5182
Q541 R540
R530
R532
R528
B5186 R455
C457
C455
C447
CN501
B5169
C467
B5152
R466 R476
C540
R535 R537 R536 C530
R519 R469 R468 D467
C459 C458
B5183
IC442
C453
D466
R448 R449
R450
R446 C446
R459
R415
D595
B5109
, R904 Q901
S905
S900
S907
L1003
R908 S904 R900
D901 S906
Q900
D900
R990
(Microphone board)
2-10
R910
CN813
(Headphone board)
R909 Q930
R997
C423
C407
C403
C405
R409
C415
C420
B5133
R111
R401 C433 R402 C408 C406 C404
C412
R406
R122
D100
Q544
Q100 D567
C575
R103
R102 C103 R570
L543 C571
Q568 R574
R575
C572
CN44 CN43
D581
C569 R567
R573
B5140
R571
B5131 IC582 R564
C589
B5141
C567
C574
R556 R557
Q543 R1903
C1006
FW211
C568
Q567
C902
R1900
C964
R1904 D903
L1001 C1004
C588 D585
R901
C911
D902
J1001
Q101 R569
B5120
R563
B5139
Q902
C1005
C570 R568
Q584
R905
C901
Q545
C962
L1002
C104
C102
C555 C553
D905
C963 D1003
C101 R101
R545
R1907
C1001
R404
C100
R572
R902
S901
R120
R555
CN802
GND2
C414
R408 C422
C116
C115 C114
IC951
C900
C410 R412
R940
D904
C1003
C111
Q585
R907
R906
B9008
C549
R942
R1901
R112
Q110 R119 R121
R554
C556 C928
J910
B5143 C402
R100
D583
CN110
S903
R558
C904
CN111
B5112
C929
R903
C550
B5111
D907 R1902
C432
R110
C112
R544
C1002
B5132
C127
CN661
R1905
D906
IC401 C418
C113
C960
Q903
R116
R118
R1155 R1154
R941
C419
C416
R117 R115
C923
CN803
R848
R403
Q111
C125
C110
B5174
B5124
D807
S902
IC125
D125 C126
C545
R899 R898
R877
R878
R1150
R821 R820
Q426
R1906 C921 C961 IC956 B5194
C409
R407 C597 R599
R440
R427
B5175 R1151
R819
R875 R874
R413
Q595 C595
B5128
R434
FW402
R866
R871 R894
Q425 R441
GND1
C546
R897
R879
C580
R429
R943
R828
R1152 R823
B5187
R822
C429 B5126
R405 C401
C421
D915
C544
R882 R876
R827
B5188
B5106
R1153
R830
IC426
R896
R833 R834 R873 R825
R829
R842
R867
R836
R895
B5163
R826
R844 R869 R870 C593
D582
C543
R839
C413
C430
C427
C411
C594
C431
R435 R433
C425
R835
R428
R832
R824
R841
FW402
R843
R840
B5105
B5107 R837
R425
R426
D918
B5104
C417
R598
R438 Q594
IC425
R838
R584
D594 R594
R595
D808
R868
B5113
C443
Q803
R1165 Q580 R588
R1163
R586
B5114
R456
D809
B5116 R593
B5147
R432
R581
R582
C596 R597
R436
R587
C581
R454
R453
R817
R818
R884 Q582
C428
R596
R589
C584
B5181 B5180
R430
R592
Q583
R865
R591 R1164
C586
IC581
R527
C442
Q802 C808
L580 R585
R580
C585
C451
C452
C450
R439
Q581
C582
D580
HS580
IC580
B5102 R583
IC526
C531
C529
R414
R831
R590
D586
C533
R516
R471 B5153
R470
B5156 C471 C477
B5155
C463
B5164
B5167
B5165
C454
B5177
R458
R893
CN801
B5101 C583
R526
C462
R445
R816
R891
C810 B5121
C532
R452
B5195
R864
C476 C466
IC801
D811 C811
R541
B5149
B5179
R443
B5166 C461
Q540
Q534
B5151
IC466
Q442
C464
R444
B5103
D813
D806
R863 C809
R480
R521 Q486
C490
B5171 Q485
B5168
D486 R495 B5170
D485
C801
C495
R850
CN503
R504
C496
R522
B5191 C494
R503
B5157 B5158 IC467 C473 R479
R473 B5172 R478 B5173 R442 R447
Q517
R467
B5154 C472
C474
Q487
R500
R496
R485 R502 C487
D801
R857
R808
R474
FW401
R851
R497
C468 R472
C470
B5100
R492
R494
B5162
R813
B5148 B5150
R482
R499 C493
C475 R481 R477
D816
R812
X801 R854 B5117 R853 R849
R845
B5190
C804
C802
R852
CN217
C805
R802 R886 R805
R846
R810
R888 R807
D803
IC486 C803 B5122 D802 R887
C806
R881
B5110
Q804
Q805 CN560
R889 R858
R498
B5189
C491
B5160 B5161 R872
R809
Q801 R892
R487 B5159
R489 R488 C488
C576
R577
R576
B5119
R861 R803 R885 R804 R806
C812
D814 D805
R1157
R855
B5115
R1161
CN715
R859
C807
R880
CN502
R847 R856
R883
R890 IC802
C577 R579
C497
R542
R534
R520
C469 C498
IC534
D516 R517 Q516
R475
D108
D804
C578 R578
R501
R493
D577
C108 B5130
R860
R490
B5118
IC485
L123
R123
C485
C499
J108
B5108
D515 R515 Q515
C489 D576
L124
B5125
R486
C456
C486
J576
C124 C123
R1158
R1160
R1159
S1100
J123
Q535
EP401 B5144
R491
R124
R518
B5123
C492
EP402
Front board (Subwoofer amplifier board) R759
R750
R758
R752
R757
R751
C719
R735
Q706
R734 R733 C716
C718
R715
R710 CN700
C718
R720
R728 C717
R726
R707
L702
Q705
C703
Q752
C702
C711
L701
D705
Q751 R754
R709
R708
R753
R760
R756
C712
Q750
C708
Q700
C750
R725
C710 R717
R729
Q701
R711
R706
R705
R704
R719
R703
C701
C700
D751
Q704
R723
R761
R713
R712
R722
C714
R721
R714
Q702
Q703
R755
R701
R732
R731
R700
C752
R738
R737
R736
C707
C705
C706
R724 D706
C704
R718
R727
C715
FW216
R716 D704
D700
C751
C760
C761
D703
C937
C935
JS958
C713
IC760
C938
(Standby LED board)
JS960
R603
C603
R602
R619
Q904
R634
(Switch board)
Q905
R999 R998
CN610
Q906
C604
C615
R627
R997
FW902 FW901 CN511
R626
S911
D908
S918
S919
R967
S912
R976
R975
Q600
R632
R978
R959
S928
FW705
R612
R613
C609
S930
Q601
C616
R611
D602
R630
Q603
C619
R631
R629
R628
L602
R980
S921 D909
R960
S910
S920
C608
S927
R968
R606
R958
C617
S929
D604
C618
C607
R607
CN710
D680
Q680
C709
JS958
IC750
R702 D701 D702
C936
R633
R730
IC700
FW218
D760
D750
R969 R970
S924
Q952 FW901
R971
D911
S917
R962
C611
R620
S923
D910
R957
S909
R625
R683
R680
C613
R635
(Connection board) CN812 FW215
C944
C620
R624
D601
R623
S926
D913
S914
IC600
C601
R615
C610
R616
C612
R617
R682
C681
Q681
Q602
R636
S922
R961
R614
BZ900
C614
C605
R609
D600
C680
D681
R681
R608
L601
D603
R604
FW902
C606
R610
S913
R605
R972 S915
C931
S925
D912
S916
R965
R954
R953
R951
R952
R963
R955
R948
R661
Q950
R964
C661
R950
D660
Q907
R973
4
D670 C940
C670
C671
CN600
Q951
R974
D671
R670
JS962
95
C939
L900
IC
IC670
R983
C660 R671
IC955
L901
Q908
R956
C941
R996
D661
R982
R660
R995
S908
IC660
R946
IC650
C651
C650 D650
R947
R684
R651
CN902
C943
CN912 FL900
Q683
R600
R650
C932
C622
Q604
R618
R621
C621
R622
R601 R686 R685
C942
C600 C602
(Main amplifier board) (Encoder board)
(FL board)
2-11
CD servo board
Loading switch board
(Forward side) CN252 CN253
IC201
CN601
C3 C6
C255 C257
IC2 C2
CN652
Q291
R678
C679 R681
R298 R297
IC691
C678
D654 R679
IC651
CN1
CN651
C291
R294 R295
C653 C651
R293
C5
R253
D652
C655
X251
R676 C681 R677
D653 C676
C675 X651
C677 R655 R682
C656
R671 R669
IC801
R653
TP684 TP683 R672 C674
K654
C669
R659 C663 R663 R664 K651 C667 K652 C665 R665
R673
R674
R675
SW8
C673 K653
C811
R662
CN3
R651
TP681 TP682
TP653
R259
R265 R296
IC682
R807 R803
C654
C652
R652
R667 R658
R666 R668
C672
C661 C662
D655
R657
C657 R683 R654 C658 R661 C659 R656
C664
C671 C668
D656 C801
C802
Q654
CN602
C7
R271 R274
C252 C258 C256
IC671
R816 R812
R802
C803 R804 R808 C804 C806 R817 R813 C805
C606
BDO C614 C615 C616 R619 C610 R618 C617 R632
Q653
C812
C808 C807
C809
C1
C251
TP271
C261 IC681
C621
C622
R805 R801
C813 C814 R809 R814 R811 R815
R818
C644 Q651
C607
R603 R601 C603 R602 C604
C623
C624 R634 Q631 R611 R613
D601 C611 C632 C608 C612 C641 C642 R617 C643 Q652
R604 R605
R806
R606
C631 R631
R255
R254
C605
C625 R621 R622 R624 C626 R625
R608
R623 R626
IC601
R281
R256
C253
C601 C602
R607
SW6
C666
SW1
(Reverse side)
CN653
CN251
CN253
CN651
CN252
TP601
X251 TP2
C624
C622
C651
C291
C252
CN652
C631
C678
C812
CN602
TP1
C664
SW7 IC1
R257 R278 R284 R283 R282 R264 R263 R262 R261 R258
D1
R635
M1
M2
R267
R285 R286 R287 R288 R289 R290 R291 R292
C633
CN2
C201
C254 CN251 C259 IC251
C801
C666
2-12
SW2
SW3
SW4
SW5
R1
Cassette switch board
P1 SW2 VR37
SW1
SW5
CN1
R371 D1
FW100
SW6
IC1
Head amplifier board
CN33 C374 PP300
D375
R210
R206
R338 C371
R106
R301
R110
L301
R376
R375 R337
C206
C307
R314
C308
R335
Q376
Q372
R205 C314
R340
Q371
R315
C310
R342
Q375
R372
R305
C331
C106
R353
R341
R208
R108
C207
CN32
C105 C205
C313
R343
CN34 R105
C107
Q302
C376
R310
Q305
R313
R339
L303
C300 R216
C304
R327 R204
IC32 R336
C306
R304 C316
C213 R201
R101
C102
C202
C110
R116
IC33
C210
D340
C342 C220
C120
R107
R346
R344
R306
R345
Q342
R302
R121
C204 C201
R109
R303
C221
R202
C341
C340
C113
R102
VR31
R104
C103
C101
C104 C121
C203
C301
C319
W1
C209 R347
C109 R207
W1 R221 Q344
Q345
Q343
Q346
Q347
CN31
2-13
VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan
(No.MB161SCH)
Printed in Japan WPC
PARTS LIST [ HX-GX7 ]
* All printed circuit boards and its assemblies are not available as service parts.
Area suffix J ----------------------------- U.S.A. C -------------------------- Canada
- Contents Exploded view of general assembly and parts list (Block No.M1) Speaker assembly and parts list (Block No.M2) CD changer mechanism assembly and parts list (Block No.MA) CD mechanism assembly and parts list (Block No.MB) Cassette mechanism assembly and parts list (Block No.MP) Electrical parts list (Block No.01~07) Packing materials and accessories parts list (Block No.M3)
No. MB161
3- 2 3- 5 3- 6 3- 8 3- 9 3-11 3-20
3-1
Exploded view of general assembly and parts list Block No. M 1 M M 81 B
79
42
e f
43 b
a
46
c
Bridge board
44
44
44
g d
86 85 80
84
Standby LED board
25
28
83
81
82 FL board
9 28 39
A
80
27
FL900 d
h
13 88
i
14
K Switch board
22
24 10
1
9
87
i
15 23
26
8 18 K
40
19
21
20 17
36
20
11 16 90
H
12
3
30
103
G
5
20
40
4 3
29 c
7 6
j
89 J
33
3-2
m
Microphone board
32
Headphone board
64
2
k
35
34
42 44 42 46
69
97
92 65 41
44
4
72
77
B
g
67
44
70
78
42
76
68
91
68 49
75
48
n
74 73
98
Subwoofer amplifier board
f
r
39
73
101
C
71 93
E
66
e
D
56 59
D
53
H Primary board
22
47
57
109
r
58
i
b
Main amplifier board
a
104 22
Main board
57
105 58
61
102 60
51
h
F Connection board
Encoder board
21
36
60
108
20
99
p
q
100
107
63
38
m
96
j
35
n
95
106 103
45
m
94
36
C
F
q
37 34
p
E
31 J
62
k
A
55 52 G
54
50
3-3
General assembly Block No. [M][1][M][M] Symbol No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74
3-4
Part No. GV10177-001A GV40313-001A GV40464-001A GV40492-001A GV40483-001A GV40484-001A GV40482-001A GV20260-001A GV30532-001A QYSDSF2608Z GV30534-001A QYSDSF2608Z QYSDSF2608Z GV30571-001A GV30542-001A GV30541-001A GV40461-001A GV40462-001A LV30225-011A QYSDSF2608Z GV30570-001A QYSDSF2608Z GV30528-003A GV40459-001A QYSDSF2608Z GV30529-002A QYSDSF2608Z QYSDSF2608Z E65923-003 GV30588-001A GV30572-001A GV40034-001A GV40398-001A VKL7850-002 VKW5258-003 QYSBSF3012Z QYSBSF3008Z QYSBSG3010Z GV10179-001A QYSSSF3010Z GV10182-001A QYSSSF3010Z QYSBSGG3008E QYSBSF3008Z QYSBSGG3008E LV30225-079A E310243-002 LV30225-011A QAU0346-001 GV10181-001A QYSBSG3006Z GV40313-002A GV30547-002A QYSBSGG3008Z GV30545-001A QYSBSG3020E GV40297-003A QYSBSG3014E QYSBSG3020E QYSDSTL4008Z QYSBSGG3008Z QYSBSGG3008E QZW0033-001 QYSBSGY3008E GV10183-001A GV10199-002A GV30544-001A LV30225-011A QYSBSG3030Z QYSBSGY3008E QYSBSGY3008E QYSBSGY3008E QYSBSGY3008E QYSBSGY3008E
Part Name
Symbol No.
Part No.
Part Name
75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95
QYSBSGY3008E QYSBSF3012E QYSBSGY3008E QYSBSGY3008E GV10110-003A/S/ QYSDSG3006M QYSBSGY3008E GV20261-001A GV20261-002A GV20261-003A GV20261-004A GV20261-005A GV30531-001A GV30604-001A GV30540-001A GV30533-001A GV30589-001A LV42035-002A VYSH101-009 LV30225-011A QQT0423-001
96
QMPD380-200-JN
Description Local
Description Local
FRONT PANEL FELT SPACER (x2) ARM SPRING (x2) COMP.SPRING (x2) BUTTON ASSY.(L) BUTTON ASSY.(R) SOUND BUTT.ASSY WINDOW SCREEN PRESET ORNAMENT SCREW 2.6mm x 8mm VOLUME ORNAMENT SCREW 2.6mm x 8mm SCREW 2.6mm x 8mm SOUND MODE ORNA FUNCTION BUTTON BUTTON FUNCTION INDICA DISPLAY LENS (x2) SPACER (x2) SCREW 2.6mm x 8mm(x8) CONTROL BUTT.A SCREW 2.6mm x 8mm(x8) POWER BUTTON STANDBY INDICAT SCREW 2.6mm x 8mm(x2) DISPLAY BUTTON SCREW 2.6mm x 8mm(x3) SCREW 2.6mm x 8mm(x4) TAPPING SCREW CASS.HOLD.ASSY. CASS.EJECT SYS. DAMPER ASSY. SPRING EJECT SAFTY(R) TORSION SPRING TAP SCREW 3.0mm x 12mm(x2) SCREW 3mm x 8mm(x2) TAPPING SCREW 3mm x 10mm(x2) PLASTICS CHASS TAP SCREW M3 x 10mm(x2) MAIN CHASSIS TAP SCREW M3 x 10mm(x3) TAPPING SCREW 3mm x 8mm(x2) SCREW 3mm x 8mm(x4) TAPPING SCREW 3mm x 8mm SPACER PLASTIC RIVET SPACER TUNER CHASSIS BASE TAPPING SCREW 3mm x 6mm(x2) FELT SPACER (x2) HEAT SINK TAP SCREW 3mm x 8mm SUPPORT BRAC. TAP SCREW 3mm x 20mm(x2) LEAF SPRING (x2) TAP SCREW 3mm x 14mm(x2) TAP SCREW 3mm x 20mm(x2) ASSY SCREW 4mm x 8mm(x4) TAP SCREW 3mm x 8mm TAPPING SCREW 3mm x 8mm STRAIN RELIEF SPECIAL SCREW 3mm x 8mm(x3) REAR PANEL REAR COVER FAN BRACKET SPACER (x2) TAP SCREW M3 x 30mm(x2) SPECIAL SCREW 3mm x 8mm(x2) SPECIAL SCREW 3mm x 8mm SPECIAL SCREW 3mm x 8mm(x2) SPECIAL SCREW 3mm x 8mm(x4) SPECIAL SCREW 3mm x 8mm(x2)
97 98 99 100 101 102 103 104
QAR0317-001 QUQH10-1718BJ QUQH12-0922BJ QUQH12-1016BJ QUQH12-1109AJ QUQH12-2315BJ QUQH12-1520BJ QUQH12-1811BJ
SPECIAL SCREW SPECIAL SCREW SPECIAL SCREW SPECIAL SCREW METAL COVER TAP SCREW SPECIAL SCREW CD FITTING (1) CD FITTING (2) CD FITTING (3) CD FITTING (4) CD FITTING (5) PRESET KNOB SND.MODE KNOB FRONT LENS VOLUME KNOB RATING LABEL LASER CAUTION SPACER SPACER POWER TRANSF POWER CORD (US/CA) FAN CARD WIRE CARD WIRE CARD WIRE CARD WIRE CARD WIRE CARD WIRE CARD WIRE
105
QMF51U1-6R3-J8
FUSE
106
QMF51U1-8R0-J8
FUSE
107
QMF51U1-8R0-J8
FUSE
108
QMF51U1-3R15-J8
FUSE
GV40522-001A
LUMIRROR SHEET
109
3mm x 8mm 3mm x 12mm 3mm x 8mm(x2) 3mm x 8mm(x2) 3mm x 6mm(x2) 3mm x 8mm(x6)
T 001 2m BLACK
FC 1
F 001 6.3A AC125V F 101 8A AC125V F 102 8A AC125V F 103 3.15A AC125V
Speaker assembly and parts list Block No. M 2 M M
14
3 8 4 8
11
12 6
7
2
11
10 10
13
11
10
13
5
10 9
8
10
1 10 12
12
Speaker Block No. [M][2][M][M] Symbol No. 1 1 2 2 3 4 5 6 7 8 9 10 11 12
Part No.
Part Name
J200-XGD7L0S-40 J200-XGD7R0S-40 J221-XGD7L0S-10 J221-XGD7R0S-10 300-J0XGX71200 300-J0XGX71600 300-J1XGX71200 302-J0XGX70500 411-B140100P1 411-P140120P1 411-B74516AB1 411-B74530AB1 411-B84020AB1 411-N54020AB1
FRONT PANEL ASY FRONT PANEL ASY SIDE PANEL ASSY SIDE PANEL ASSY TOP WOOFER SUBWOOFER BOTTOM WOOFER TWEETER SCREW SCREW SCREW SCREW SCREW SCREW
Description Local
Symbol No. 13 14 14
Part No.
Part Name
441-802103-00 600-LXGX7J-00 600-RXGX7J-00
LEG CUSHION SPEC LABEL SPEC LABEL
Description Local (x8)
(x2) (x2) (x2) (x2) (x4) (x16) (x2) (x14) (x8) (x8)
3-5
CD changer mechanism assembly and parts list Block No. M A M M
48
FMU-SC6-2M
47 46 Grease
18
20
=JVG-31N =JVS-1003
34
35
34
45
C
19
E B
33
15
35
21
A
16 32 31
30
12
17
29
B
F
17
31
17
37
7
F
39
5
41
10 10
6 3
c
d
E
1
D
11
C
14
13
2
D
4
27 28
28 43
23
G
28 A
9 d
8
b
G
40
38
42
8
50
36
50
53 49 f
44 a
54
57
e
3-6
50
e
51 55
55
55 55
49
49
c b
56
52
52
24 25
49
f
36
22
50
a
52
26
CD changer mechanism Block No. [M][A][M][M] Symbol No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57
Part No.
Part Name
Description Local
LV10743-004A LV43278-001A LV33961-002A LV33962-001A QYSDST2605Z QVY0027-B14 QYSDST2004Z QAR0164-001 LV42340-001A LV41431-002A QYSPSPU1725N LV10744-002A LV21406-003A LV43279-001A LV33963-001A LV33964-002A QYSDST2605Z LV33965-004A LV21408-002A LV21409-002A LV43285-001A LV21520-003A LV33974-001A LV33975-001A LV33976-001A LV43287-001A LV33977-002A QYSDST2605Z LV10749-002A LV33980-001A QYSDST2605Z LV10746-003A LV10750-002A LV43289-002A QYSDSF2608Z QYSDST2605Z QYSDSF2608Z QYSDST2605Z QYSDST2004Z WJM0330-002A WJM0331-001A QUQ110-1521BF VYSA1R4-056 ---------------------VKS3697-001 VYH7313-005 LV33981-001A QYSDSF2606Z LV41659-002A LV43245-001A LV21410-001A QYSDST2605Z LV21411-001A QYSDST2605Z QYSDSF2608Z QUQ710-16Y0AJ QJJ010-061802
CHASSIS ASSY SENSOR SPRING SENSOR SLIDER SENSOR BRACKET SCREW 2.6mm x 5mm(x2) S V RESISTOR SCREW 2mm x 4mm MOTOR (x2) MOTOR PULLEY (x2) BELT (x2) SCREW 1.7mm x 2.5mm(x4) RACK HOLDER LOADING RACK LIFT ARM ASSY HOOK HOOK STOPPER SCREW 2.6mm x 5mm(x3) LIFTER ASSY RAIL(R) RAIL(L) ROD (L) SIDE(R) ASSY SELECT LEVER GEAR COVER ELEVATOR CAM ELEVATOR SPRING CLICK SPRING SCREW 2.6mm x 5mm(x3) SIDE(L) OPEN DET.LEVER SCREW 2.6mm x 5mm(x2) TRAY ASSY (x5) TOP COVER ROD (x2) SCREW 2.6mm x 8mm(x2) SCREW 2.6mm x 5mm(x2) SCREW 2.6mm x 8mm SCREW 2.6mm x 5mm SCREW 2mm x 4mm E-SI C WIRE C-F E-SI C WIRE C-F FFC WIRE SPACER CD TRAMECHA ASSY CLAMPER OT 1 MAGNET OT 2 CD YOKE OT 3 SCREW OT 4 INSULATOR (x4) SPECIAL SCREW (x4) CD TM BASE SCREW 2.6mm x 5mm(x3) CD MODULE BKT SCREW 2.6mm x 5mm(x2) SCREW 2.6mm x 8mm(x4) FFC WIRE SIN CR C-C WIRE
3-7
CD mechanism assembly and parts list Block No. M B M M Grease & Bond
FXL-M75T-2M
= JVG-31N
15
4 2 3
5 7 6 1 6 8
9 13 10
12 11
14
CD mechanism Block No. [M][B][M][M] Symbol No. 1 2 3 4 5 6 7 8
3-8
Part No.
Part Name
Description Local
LV10723-002A OPTIMA-73B1C E406777-002SM LV31002-001A E307745-441SM QYSDSP2003N E406750-442SM LV42350-001A
CD MECHA BASE A C.D PICK C.D SHAFT CD RACK C.D GEAR 3 SCREW 2mm x 3mm(x4) PINION T.T.ASSY
Symbol No. 9 10 11 12 13 14 15
Part No.
Part Name
QAR0253-001 QAR0276-001 EMW10190-441 QGA2001F1-06 QSW0506-001 E75832-221SS QYSDSF2006Z
FEED MOTOR SP MOTOR CIR BOARD CONNECTOR LEAF SW SPECIAL SCREW SCREW
Description Local
W-B (1-6) 2mm x 6mm
Cassette mechanism assembly and parts list Block No. M P M M
SLC-S302M
Grease =EM-30L =UD-24 =LEN-320M =MOBIL-1
8
15 2 2
14
10
9 3 34 13
16 3
12
6
23
4
5 11
27
7
1 29
C
1
The lower side
A
24
B
Switch board
5 19
6 30 25
11
22
18 20
21
17
C
31 28
26 36
A 33
_ 8.7 +
32
0.1 0.15 mm
33
B Head amplifier board
32
35
35 3-9
Cassette mechanism Block No. [M][P][M][M] Symbol No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
3-10
Part No.
Part Name
VKS1165-00N VKS2274-002 VKW5286-002 VKS5559-001 VKS5595-002 VKS5560-003 LV42013-001A SLC-RP4SVM VKY3149-002 LV31786-002A VKS1166-003 VKW5279-002 VKW5280-001 LV41584-001A LV41585-003A QYSBSF2005Z VKS5603-00G VKS3785-001MM VKW5284-002 VKS2278-003 VKW5301-001 VKW5266-001 WDL214025 QYSBSF2005Z VKS3786-00G VKF3205-00B WDL183425 VKF3207-00C WDL173525-6 VKZ3174-00B LV42836-001A MSI-5U2LWA VKR4761-003 QYSPSP2604Z QYSBSF2608Z QUQH12-0906BF
CHASSIS B. ASSY REEL GEAR B.T. SPRING PLAY IDLE GEAR BLIND FR IDLE GEAR EARTH SPRING HEAD MOUNT ASSY CASSETTE SP. PLAY LEVER CONTROL CAM HEAD BASE SP(R) HEAD BASE SP(L) BRAKE(R) BRAKE(L) SCREW MAIN PULLEY ASS FR ARM SWING SPRING TRIGGER ARM FR SPRING ELEVATOR SPRING WASHER SCREW CLUTCH ASSY F.WHEEL ASSY(R) SLIT WASHER F.WHEEL ASSY(L) SLIT WASHER DC SOLENOID CAPSTAN BELT D.C.MOTOR MOTOR PULLEY SCREW TAPPING SCREW WIRE
Description Local
(x2) (x2)
2mm x 5mm
2mm x 5mm
2.6mm x 4mm(x2) 2.6mm x 8mm(x3)
Electrical parts list Power board Block No. [0][1][0][0] Symbol No.
Part No.
Part Name
KIA7812API
IC
Q205 Q206 Q212 Q216 Q220 Q221 Q222 Q230 Q231 Q232 Q233 Q234
KTC3199/GL/-T KTC2026/OY/ KTC3203/OY/-T KTC3199/GL/-T KTC3199/GL/-T KTC3199/GL/-T KTA1267/YG/-T 2SC3576-JVC-T 2SC3576-JVC-T 2SC3576-JVC-T 2SC3576-JVC-T KRA111M-T
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DIGI TRANSISTOR
D204 D205 D206 D207 D208 D209 D210 D211 D212 D213 D214 D215 D221 D224 D225 D226 D227 D228 D229 D230 D231 D237 D240 D260 D261
1N5402M-20 1N5402M-20 1N5402M-20 1N5402M-20 1N5402M-20 1N5402M-20 1N5402M-20 1N5402M-20 2A02-M 2A02-M 2A02-M 2A02-M MTZJ6.8B-T2 MTZJ18B-T2 MTZJ20B-T2 MTZJ5.1B-T2 1SS133-T2 1SS133-T2 1SS133-T2 1SS133-T2 1SS133-T2 MTZJ13B-T2 1SS133-T2 1SS133-T2 1SS133-T2
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE Z DIODE Z DIODE Z DIODE Z DIODE DIODE DIODE DIODE DIODE DIODE Z DIODE DIODE DIODE DIODE
QFLC2AJ-103Z QFLC2AJ-103Z QETM1EM-688 EETB1HM-228JC EETB1HM-228JC QFLC2AJ-103Z QFLC2AJ-103Z QFKC2EK-104Z QEZ0613-478 QEZ0613-478 QFKC2EK-103Z QCE22HP-103 QFKC2EK-103Z QETN1HM-476Z QETN1HM-106Z QETN2AM-476Z QETN1HM-226Z QDYB1CM-103Y QETN1HM-226Z QETN1EM-476Z QETN1HM-106Z QETN1HM-106Z QETN1HM-106Z QETN1EM-476Z
M CAPACITOR M CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR M CAPACITOR M CAPACITOR MM CAPACITOR E CAPACITOR E CAPACITOR MM CAPACITOR C CAPACITOR MM CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR
0.01uF 100V J 0.01uF 100V J 6800uF 25V M
QRZ9037-335 QRK126J-470X QRK126J-470X QRE141J-104Y QRE141J-104Y QRE141J-104Y
COMP RESISTOR UNF C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR C RESISTOR
3.3MΩ 1/2W K 47Ω 1/2W J 47Ω 1/2W J 100kΩ 1/4W J 100kΩ 1/4W J 100kΩ 1/4W J
R200 R204 R205 R206 R207 R208
Part No.
Part Name
Description Local
R209 R211 R212 R213 R214 R225 R226 R227 R228 R229 R230 R231 R232 R234 R236 R237 R238 R239 R240 R241 R242 R243 R250 R251 R252 R253 R254 R255 R260 R261 R262 R263 R264 R265 R275 R277
QRE141J-104Y QRE141J-104Y QRJ146J-470X QRE141J-752Y QRE141J-104Y QRJ146J-6R8X QRE141J-102Y QRE141J-103Y QRE141J-473Y QRE141J-153Y QRE141J-153Y QRE141J-223Y QRE141J-223Y QRE141J-102Y QRE141J-472Y QRE141J-472Y QRE141J-472Y QRE141J-472Y QRE141J-103Y QRE141J-104Y QRE141J-103Y QRE141J-104Y QRE141J-472Y QRE141J-472Y QRE141J-472Y QRE141J-472Y QRL01DJ-471X QRL01DJ-471X QRK126J-331X QRK126J-331X QRK126J-331X QRK126J-331X QRK126J-331X QRK126J-331X QRZ9006-4R7X QRZ9006-4R7X
C RESISTOR C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR OMF RESISTOR OMF RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR F.RESISTOR F.RESISTOR
100kΩ 1/4W J 100kΩ 1/4W J 47Ω 1/4W J 7.5kΩ 1/4W J 100kΩ 1/4W J 6.8Ω 1/4W J 1kΩ 1/4W J 10kΩ 1/4W J 47kΩ 1/4W J 15kΩ 1/4W J 15kΩ 1/4W J 22kΩ 1/4W J 22kΩ 1/4W J 1kΩ 1/4W J 4.7kΩ 1/4W J 4.7kΩ 1/4W J 4.7kΩ 1/4W J 4.7kΩ 1/4W J 10kΩ 1/4W J 100kΩ 1/4W J 10kΩ 1/4W J 100kΩ 1/4W J 4.7kΩ 1/4W J 4.7kΩ 1/4W J 4.7kΩ 1/4W J 4.7kΩ 1/4W J 470Ω 1W J 470Ω 1W J 330Ω 1/2W J 330Ω 1/2W J 330Ω 1/2W J 330Ω 1/2W J 330Ω 1/2W J 330Ω 1/2W J 4.7Ω 1/4W J 4.7Ω 1/4W J
L250
QQL231K-470Y
COIL
47uH K
CN200 CN201 CN202 CN205 CN206 CN207 CN208 CN213 CN214 EP200 EP201 FT200 FT201 FT220 FT221 FT230 FT231 FT250 FT251 FW202 FW204 J200 PP200 RY1 RY2
QGA7901C1-02 QGD2504C1-04Z QGA2501C1-03 QGD2504C1-03Z QGA2501C1-10 QGB2510K1-13 QGA2501C1-11 QGD2504C1-04Z QGA3901C1-08 QNZ0136-001Z QNZ0136-001Z QNG0003-001Z QNG0003-001Z QNG0003-001Z QNG0003-001Z QNG0003-001Z QNG0003-001Z QNG0003-001Z QNG0003-001Z QUM154-20DGZ4 QJK015-082614 QNB0193-002 QZW0038-001 QSK0109-001 QSK0109-001
CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR EARTH PLATE EARTH PLATE FUSE CLIP FUSE CLIP FUSE CLIP FUSE CLIP FUSE CLIP FUSE CLIP FUSE CLIP FUSE CLIP FLAT WIRE FLAT WIRE SPK.TERMINAL WIRE CLAMP RELAY RELAY
W-B (1-2) (1-4) W-B (1-3) (1-3) W-B (1-10) B-B (1-13) W-B (1-11) (1-4) W-B (1-8)
Description Local
IC201
C207 C208 C209 C212 C213 C214 C215 C216 C217 C218 C219 C220 C221 C225 C227 C228 C229 C230 C231 C232 C237 C238 C240 C241
Symbol No.
0.01uF 100V J 0.01uF 100V J 0.1uF 250V K 4700uF 4700uF 0.01uF 250V K 0.01uF 500V P 0.01uF 250V K 47uF 50V M 10uF 50V M 47uF 100V M 22uF 50V M 0.01uF 16V M 22uF 50V M 47uF 25V M 10uF 50V M 10uF 50V M 10uF 50V M 47uF 25V M
3-11
Input board
Symbol No.
Block No. [0][2][0][0] Symbol No.
Part No.
Part Name
IC125 IC401 IC442 IC466 IC467 IC485 IC486 IC526 IC534 IC801 IC802 IC951 IC956
BA33BC0T LC75342M-X JCV8011-X NJM4565M-WE NJM4565M-WE NJM4565M-WE NJM4565M-WE NJM4565M-WE CD4066BM-X UPD784215AGF540 BR24L01AF-W-X GP1UM271XK NJM4565M-WE
REGULATOR IC IC IC IC IC IC IC IC IC IC IC IR DETECT UNIT IC
Q100 Q101 Q110 Q111 Q442 Q485 Q486 Q487 Q515 Q516 Q517 Q534 Q535 Q540 Q541 Q542 Q567 Q568 Q594 Q595 Q802 Q803 Q804 Q900 Q901 Q902 Q903 Q930
2SD601A/RS/-X 2SD601A/RS/-X UN2211-X UN2213-X KTC3199/GL/-T 2SD601A/RS/-X 2SD601A/RS/-X 2SD601A/RS/-X 2SD1328/ST/-X 2SD1328/ST/-X 2SD1328/ST/-X UN2213-X UN2213-X UN2113-X 2SD1328/ST/-X 2SD1328/ST/-X KTA1267/YG/-T UN2211-X 2SD601A/RS/-X UN2215-X UN2211-X UN2115-X UN2111-X UN2211-X UN2211-X UN2211-X UN2211-X UN2211-X
TRANSISTOR TRANSISTOR TRANSISTOR DIGI TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DIGI TRANSISTOR DIGI TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR D.TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
D100 D466 D467 D485 D486 D515 D516 D567 D594 D595 D801 D803 D804 D805 D806 D807 D808 D809 D811 D813 D814 D900 D901 D902 D903 D904 D905 D906 D907 D915 D918
1SS133-T2 1SS133-T2 1SS133-T2 1SS133-T2 1SS133-T2 MTZJ3.9B-T2 MTZJ3.9B-T2 1SS133-T2 1SS133-T2 1SS133-T2 MTZJ5.1B-T2 1SS133-T2 1SS133-T2 1SS133-T2 1SS133-T2 1SS133-T2 1SS133-T2 MTZJ4.3B-T2 1SS133-T2 1SS133-T2 1SS133-T2 SLR-342VC-T SLR-342VC-T SLA-362LT-T SLA-362LT-T SLA-362LT-T SLA-362LT-T SLA-362LT-T SLA-362LT-T 1SS133-T2 1SS133-T2
DIODE DIODE DIODE DIODE DIODE Z DIODE Z DIODE DIODE DIODE DIODE Z DIODE DIODE DIODE DIODE DIODE DIODE DIODE Z DIODE DIODE DIODE DIODE LED LED LED LED LED LED LED LED DIODE DIODE
3-12
Part No.
Part Name
D1003
MTZJ2.4B-T2
Z DIODE
C100 C101 C102 C103 C104 C111 C112 C113 C114 C116 C125 C126 C127 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C418 C419 C420 C421 C422 C423 C425 C432 C433 C446 C447 C450 C451 C452 C453 C454 C455 C456 C457 C458 C459 C460 C461 C462 C463 C464 C466 C467 C468 C469 C470 C471 C472 C473 C474 C475 C476 C477 C485 C486 C487 C488 C489 C490 C491 C492
QEKC1HM-105Z NCB31HK-681X NCB31CK-223X NCS31HJ-330X NCB31HK-182X NCB31CK-103X QETN1HM-106Z QETN1HM-106Z QETN1AM-227Z NCB31CK-104X QETN1AM-477Z NCF31CZ-104X NCF31CZ-104X NCB31HK-471X QETN1EM-107Z NCB31CK-104X NCB31CK-104X NCB31CK-104X NCB31CK-104X NCB31HK-272X NCB31HK-272X QTE1H28-106Z QTE1H28-106Z QTE1H28-106Z QTE1H28-106Z QETN1HM-106Z QETN1HM-106Z QETN1HM-106Z QETN1HM-106Z QETN1HM-225Z QETN1HM-225Z QTE1H28-106Z QTE1H28-106Z NCB31HK-471X NCB31HK-471X QETN1EM-107Z NCF21CZ-105X NCS31HJ-101X NCS31HJ-101X QTE1H28-106Z QTE1H28-106Z QETN1EM-476Z QETN1HM-106Z NCB31CK-273X QETN1HM-475Z QETN1HM-475Z QETN1HM-225Z QETN1HM-106Z QETN1HM-106Z QETN1HM-106Z QETN1HM-475Z QETN1HM-106Z QETN1HM-474Z QETN1HM-224Z QETN1EM-106Z QETN1HM-106Z QETN1HM-475Z QETN1HM-475Z NCB31CK-224X NCB31CK-473X NCB31HK-822X QETN1HM-475Z QETN1HM-475Z NCB31CK-224X NCB31CK-273X NCB31HK-222X NCB31CK-153X QETN1CM-107Z NCB31CK-393X NCB31CK-823X NCB31CK-104X NCB31CK-104X QETN1EM-476Z QETN1HM-105Z QETN1EM-476Z QETN1EM-476Z
E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR
Description Local
Description Local
38kHz
1uF 50V M 680pF 50V K 0.022uF 16V K 33pF 50V J 1800pF 50V K 0.01uF 16V K 10uF 50V M 10uF 50V M 220uF 10V M 0.1uF 16V K 470uF 10V M 0.1uF 16V Z 0.1uF 16V Z 470pF 50V K 100uF 25V M 0.1uF 16V K 0.1uF 16V K 0.1uF 16V K 0.1uF 16V K 2700pF 50V K 2700pF 50V K 10uF 50V 10uF 50V 10uF 50V 10uF 50V 10uF 50V M 10uF 50V M 10uF 50V M 10uF 50V M 2.2uF 50V M 2.2uF 50V M 10uF 50V 10uF 50V 470pF 50V K 470pF 50V K 100uF 25V M 1uF 16V Z 100pF 50V J 100pF 50V J 10uF 50V 10uF 50V 47uF 25V M 10uF 50V M 0.027uF 16V K 4.7uF 50V M 4.7uF 50V M 2.2uF 50V M 10uF 50V M 10uF 50V M 10uF 50V M 4.7uF 50V M 10uF 50V M 0.47uF 50V M 0.22uF 50V M 10uF 25V M 10uF 50V M 4.7uF 50V M 4.7uF 50V M 0.22uF 16V K 0.047uF 16V K 8200pF 50V K 4.7uF 50V M 4.7uF 50V M 0.22uF 16V K 0.027uF 16V K 2200pF 50V K 0.015uF 16V K 100uF 16V M 0.039uF 16V K 0.082uF 16V K 0.1uF 16V K 0.1uF 16V K 47uF 25V M 1uF 50V M 47uF 25V M 47uF 25V M
Symbol No.
Part No.
Part Name
Description Local
C493 C494 C495 C496 C497 C498 C499 C526 C527 C528 C529 C530 C531 C532 C533 C534 C536 C540 C543 C544 C545 C546 C571 C594 C595 C596 C597 C801 C802 C804 C805 C806 C807 C808 C809 C810 C811 C812 C900 C901 C902 C921 C923 C928 C929 C960 C961 C962 C963 C964 C1001 C1002 C1003 C1004 C1005 C1006
NDC31HJ-101X QETN1HM-225Z QETN1HM-476Z QETN1EM-476Z QETN1CM-227Z QETN1EM-476Z NCB31HK-272X QTE1V06-106Z QTE1V06-106Z QFLC1HJ-153Z QFLC1HJ-153Z QFLC1HJ-153Z QFLC1HJ-153Z QTE1V06-106Z QTE1V06-106Z QETN1EM-476Z QETN1CM-107Z QETN1HM-106Z NCF21CZ-105X NCF21CZ-105X NCF21CZ-105X NCF21CZ-105X QETN1AM-477Z QETN1HM-105Z QETN1HM-105Z QETN1HM-105Z NCS31HJ-330X NCS31HJ-270X NCS31HJ-300X NCB31CK-103X NCF21CZ-105X QETN1AM-227Z QETN1AM-477Z NCB31CK-224X QETN1HM-475Z NCB31CK-224X QETN1CM-107Z NCB31CK-103X QEKC0JM-107Z NCB31CK-102X QEKC0JM-107Z QEKC1AM-107Z NCB31CK-102X NCB31HK-221X NCB31HK-221X QEKC1HM-475Z QEKC1HM-475Z QEKC1HM-475Z QEKC1HM-475Z QER61AM-227Z QDGB1HK-102Y QDGB1HK-102Y QDXB1CM-222Y QDGB1HK-102Y QDGB1HK-102Y QDGB1HK-102Y
C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR M CAPACITOR M CAPACITOR M CAPACITOR M CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR
100pF 50V J 2.2uF 50V M 47uF 50V M 47uF 25V M 220uF 16V M 47uF 25V M 2700pF 50V K 10uF 35V 10uF 35V 0.015uF 50V J 0.015uF 50V J 0.015uF 50V J 0.015uF 50V J 10uF 35V 10uF 35V 47uF 25V M 100uF 16V M 10uF 50V M 1uF 16V Z 1uF 16V Z 1uF 16V Z 1uF 16V Z 470uF 10V M 1uF 50V M 1uF 50V M 1uF 50V M 33pF 50V J 27pF 50V J 30pF 50V J 0.01uF 16V K 1uF 16V Z 220uF 10V M 470uF 10V M 0.22uF 16V K 4.7uF 50V M 0.22uF 16V K 100uF 16V M 0.01uF 16V K 100uF 6.3V M 1000pF 16V K 100uF 6.3V M 100uF 10V M 1000pF 16V K 220pF 50V K 220pF 50V K 4.7uF 50V M 4.7uF 50V M 4.7uF 50V M 4.7uF 50V M 220uF 10V M 1000pF 50V K 1000pF 50V K 2200pF 16V M 1000pF 50V K 1000pF 50V K 1000pF 50V K
R100 R101 R102 R103 R110 R111 R112 R115 R116 R117 R118 R119 R120 R121 R122 R401 R402 R403 R404 R405 R406
NRSA63J-104X NRSA63J-220X NRSA63J-225X NRSA63J-473X NRSA63J-104X NRSA63J-103X NRSA63J-103X NRSA63J-222X NRSA63J-222X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-102X NRSA63J-102X NRSA63J-104X NRSA63J-104X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-362X NRSA63J-362X NRSA63J-203X
MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR
100kΩ 1/16W J 22Ω 1/16W J 2.2MΩ 1/16W J 47kΩ 1/16W J 100kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 2.2kΩ 1/16W J 2.2kΩ 1/16W J 0Ω 1/16W J 0Ω 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 3.6kΩ 1/16W J 3.6kΩ 1/16W J 20kΩ 1/16W J
Symbol No. R407 R408 R409 R412 R413 R414 R415 R425 R426 R442 R443 R444 R445 R446 R447 R448 R449 R450 R452 R453 R454 R455 R456 R458 R459 R466 R467 R468 R469 R470 R471 R472 R473 R474 R475 R476 R477 R478 R479 R480 R481 R482 R485 R486 R487 R488 R489 R490 R491 R492 R493 R494 R495 R496 R497 R498 R499 R500 R501 R502 R503 R504 R515 R516 R517 R518 R519 R520 R521 R522 R526 R527 R528 R529 R530 R531 R532 R533
Part No.
Part Name
NRSA63J-203X NRSA63J-153X NRSA63J-153X NRSA63J-104X NRSA63J-104X NRSA63J-104X NRSA63J-104X NRSA63J-303X NRSA63J-303X NRSA63J-472X NRSA63J-472X NRSA63J-622X NRSA63J-622X NRSA63J-103X NRSA63J-103X NRSA63J-472X NRSA63J-562X NRSA63J-104X NRSA63J-474X NRSA63J-474X NRSA63J-101X NRSA63J-225X NRSA63J-153X NRSA63J-0R0X NRSA63J-682X NRSA63J-332X NRSA63J-332X QRE141J-433Y QRE141J-433Y NRSA63J-274X NRSA63J-104X NRSA63J-104X NRSA63J-104X NRSA63J-104X NRSA63J-224X NRSA63J-224X NRSA63J-563X NRSA63J-223X NRSA63J-223X QRE141J-102Y NRSA63J-822X NRSA63J-823X NRSA63J-124X NRSA63J-223X QRE141J-562Y NRSA63J-822X NRSA63J-113X NRSA63J-223X NRSA63J-223X NRSA63J-101X NRSA63J-101X NRSA63J-224X QRE141J-682Y QRE141J-154Y NRSA63J-104X NRSA63J-104X NRSA63J-473X NRSA63J-473X NRSA63J-271X NRSA63J-104X QRE141J-562Y QRE141J-103Y NRSA63J-223X QRE141J-512Y NRSA63J-223X QRE141J-272Y QRE141J-103Y NRSA63J-103X NRSA63J-102X NRSA63J-102X NRSA63J-104X NRSA63J-104X QRE141J-224Y QRE141J-224Y QRE141J-103Y QRE141J-103Y QRE141J-153Y QRE141J-153Y
MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR C RESISTOR C RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR C RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR C RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR C RESISTOR C RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR C RESISTOR C RESISTOR MG RESISTOR C RESISTOR MG RESISTOR C RESISTOR C RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR
Description Local 20kΩ 1/16W J 15kΩ 1/16W J 15kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 30kΩ 1/16W J 30kΩ 1/16W J 4.7kΩ 1/16W J 4.7kΩ 1/16W J 6.2kΩ 1/16W J 6.2kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 4.7kΩ 1/16W J 5.6kΩ 1/16W J 100kΩ 1/16W J 470kΩ 1/16W J 470kΩ 1/16W J 100Ω 1/16W J 2.2MΩ 1/16W J 15kΩ 1/16W J 0Ω 1/16W J 6.8kΩ 1/16W J 3.3kΩ 1/16W J 3.3kΩ 1/16W J 43kΩ 1/4W J 43kΩ 1/4W J 270kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 220kΩ 1/16W J 220kΩ 1/16W J 56kΩ 1/16W J 22kΩ 1/16W J 22kΩ 1/16W J 1kΩ 1/4W J 8.2kΩ 1/16W J 82kΩ 1/16W J 120kΩ 1/16W J 22kΩ 1/16W J 5.6kΩ 1/4W J 8.2kΩ 1/16W J 11kΩ 1/16W J 22kΩ 1/16W J 22kΩ 1/16W J 100Ω 1/16W J 100Ω 1/16W J 220kΩ 1/16W J 6.8kΩ 1/4W J 150kΩ 1/4W J 100kΩ 1/16W J 100kΩ 1/16W J 47kΩ 1/16W J 47kΩ 1/16W J 270Ω 1/16W J 100kΩ 1/16W J 5.6kΩ 1/4W J 10kΩ 1/4W J 22kΩ 1/16W J 5.1kΩ 1/4W J 22kΩ 1/16W J 2.7kΩ 1/4W J 10kΩ 1/4W J 10kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 220kΩ 1/4W J 220kΩ 1/4W J 10kΩ 1/4W J 10kΩ 1/4W J 15kΩ 1/4W J 15kΩ 1/4W J
3-13
Symbol No. R534 R535 R536 R537 R540 R541 R542 R567 R568 R569 R570 R571 R572 R573 R574 R575 R578 R579 R594 R595 R596 R597 R598 R599 R804 R805 R806 R807 R808 R809 R810 R812 R813 R816 R817 R818 R819 R820 R821 R822 R823 R824 R825 R826 R827 R828 R829 R831 R832 R833 R834 R835 R836 R837 R838 R839 R840 R841 R842 R843 R844 R845 R846 R847 R848 R849 R850 R851 R852 R853 R854 R855 R856 R857 R863 R864 R865 R866
3-14
Part No.
Part Name
NRSA63J-513X NRSA63J-513X NRSA63J-103X NRSA63J-223X NRSA63J-102X NRSA63J-103X NRSA63J-103X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-104X NRSA63J-104X NRSA63J-103X NRSA63J-223X NRSA63J-102X NRSA63J-104X NRSA63J-104X NRSA63J-682X NRSA63J-104X NRSA63J-104X NRSA63J-103X NRSA63J-473X NRSA63J-225X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-221X NRSA63J-102X NRSA63J-221X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-122X NRSA63J-122X NRSA63J-102X NRSA63J-221X NRSA63J-221X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-104X NRSA63J-331X NRSA63J-472X NRSA63J-102X NRSA63J-221X NRSA63J-221X NRSA63J-221X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-221X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-222X NRSA63J-102X NRSA63J-103X
MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR
Description Local 51kΩ 1/16W J 51kΩ 1/16W J 10kΩ 1/16W J 22kΩ 1/16W J 1kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 10kΩ 1/16W J 22kΩ 1/16W J 1kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 6.8kΩ 1/16W J 100kΩ 1/16W J 100kΩ 1/16W J 10kΩ 1/16W J 47kΩ 1/16W J 2.2MΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 220Ω 1/16W J 1kΩ 1/16W J 220Ω 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1.2kΩ 1/16W J 1.2kΩ 1/16W J 1kΩ 1/16W J 220Ω 1/16W J 220Ω 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 100kΩ 1/16W J 330Ω 1/16W J 4.7kΩ 1/16W J 1kΩ 1/16W J 220Ω 1/16W J 220Ω 1/16W J 220Ω 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 220Ω 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 2.2kΩ 1/16W J 1kΩ 1/16W J 10kΩ 1/16W J
Symbol No.
Part No.
Part Name
Description Local
R867 R868 R869 R870 R871 R872 R874 R875 R876 R877 R878 R879 R880 R881 R882 R883 R884 R887 R888 R889 R890 R891 R892 R893 R894 R895 R896 R897 R898 R899 R900 R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R940 R941 R942 R943 R990 R997 R1150 R1151 R1152 R1153 R1154 R1155 R1157 R1900 R1901 R1902 R1903 R1904 R1905 R1906 R1907
NRSA63J-104X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-103X NRSA63J-104X NRSA63J-102X NRSA63J-102X NRSA63J-103X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA02J-221X NRSA02J-221X NRSA02J-221X NRSA02J-221X NRSA63J-101X NRSA63J-121X NRSA63J-151X NRSA63J-221X NRSA63J-271X NRSA63J-391X NRSA63J-561X NRSA63J-183X NRSA63J-183X NRSA63J-823X NRSA63J-823X NRSA02J-221X NRSA63J-101X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-103X NRSA02J-221X NRSA02J-221X NRSA02J-221X NRSA63J-102X NRSA63J-102X NRSA63J-513X NRSA63J-513X NRSA63J-103X
MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR
100kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 10kΩ 1/16W J 100kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 10kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 220Ω 1/10W J 220Ω 1/10W J 220Ω 1/10W J 220Ω 1/10W J 100Ω 1/16W J 120Ω 1/16W J 150Ω 1/16W J 220Ω 1/16W J 270Ω 1/16W J 390Ω 1/16W J 560Ω 1/16W J 18kΩ 1/16W J 18kΩ 1/16W J 82kΩ 1/16W J 82kΩ 1/16W J 220Ω 1/10W J 100Ω 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 10kΩ 1/16W J 220Ω 1/10W J 220Ω 1/10W J 220Ω 1/10W J 1kΩ 1/16W J 1kΩ 1/16W J 51kΩ 1/16W J 51kΩ 1/16W J 10kΩ 1/16W J
L1001 L1002 L1003
QQL231K-470Y QQL231K-470Y QQL231K-2R2Y
COIL COIL COIL
47uH K 47uH K 2.2uH K
CN43 CN44 CN217 CN501 CN560 CN661 CN801 CN802 CN803 CN813 EP401
QGF1205F1-09 QGF1205F1-10 QGB2510J1-13 QGB2510K1-16 QGF1205F1-11 QGF1036F1-17 QGF1210G1-07 QGF1205F1-23 QGF1205F1-15 QGF1205F1-15 E409182-001SM
CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR GRAND TERMINAL
FFC/FPC (1-9) FFC/FPC (1-10) B-B (1-13) B-B (1-16) FFC/FPC (1-11) FFC/FPC (1-17) FFC/FPC (1-7) FFC/FPC (1-23) FFC/FPC (1-15) FFC/FPC (1-15)
Symbol No. EP402 FW211 FW401 FW402 GND1 GND2 J910 J1001 S900 S901 S902 S903 S904 S905 S906 S907 SP01 TW01 TW02 X801
Part No.
Part Name
Description Local
E409182-001SM QUM154-40DGZ4 QUM15A-12Z4Z4 QUM153-12Z4Z4 QUB220-13HPDT QUB220-09HPDT QNS0235-001 QNS0204-001 QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z LV30225-011A QUB230-10Z4Z4 QUB230-10Z4Z4 QAX0724-001Z
GRAND TERMINAL FLAT WIRE FLAT WIRE FLAT WIRE FLAT WIRE SINGLE WIRE PHONE JACK PHONE JACK TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW SPACER FLAT WIRE FLAT WIRE CRYSTAL
12.000000MHz
Front board Block No. [0][3][0][0] Symbol No.
Part No.
Part Name
IC600 IC660 IC670 IC700 IC750 IC760 IC954 IC955
STK432-070 KIA7805API KIA7805API STK412-430 KIA7808API KIA7809API PT6305 SN74HCU04N
IC IC IC POWER I.C IC IC FL DRIVER FL DRIVER
Q600 Q601 Q602 Q603 Q604 Q700 Q701 Q702 Q703 Q704 Q705 Q706 Q904 Q905 Q906 Q907 Q908 Q950 Q951 Q952
KRC102M-T KTA1267/YG/-T KTC3199/GL/-T KTC3199/GL/-T 2SK301/PQ/-T KTC1027/OY/-T KTA1023/OY/-T KTC3200/GL/-T KTA1268/GL/-T KTC3199/GL/-T KTC3199/GL/-T KTA1267/YG/-T KRC102M-T KRC102M-T KRC102M-T KRC102M-T KRC102M-T KTC3199/GL/-T KTC3199/GL/-T KRA102M-T
DIGI TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DIGI TRANSISTOR DIGI TRANSISTOR DIGI TRANSISTOR DIGI TRANSISTOR DIGI TRANSISTOR TRANSISTOR TRANSISTOR DIGI TRANSISTOR
D600 D601 D602 D603 D660 D661 D670 D671 D700 D701 D702 D703 D704 D705 D706 D750 D760 D908
MTZJ9.1B-T2 1SS133-T2 1SS133-T2 MTZJ2.4B-T2 MTZJ8.2C-T2 1SS133-T2 1SS133-T2 MTZJ6.8C-T2 MTZJ36B-T2 MTZJ36B-T2 MTZJ15B-T2 MTZJ15B-T2 1SS133-T2 1SS133-T2 1SS133-T2 MTZJ10B-T2 MTZJ10B-T2 SLA-362LT-T
Z DIODE DIODE DIODE Z DIODE Z DIODE DIODE DIODE Z DIODE Z DIODE Z DIODE Z DIODE Z DIODE DIODE DIODE DIODE Z DIODE Z DIODE LED
Description Local
Symbol No.
Part No.
Part Name
D909 D910 D911 D912 D913
SLA-362LT-T SLA-362LT-T SLA-362LT-T SLA-362LT-T SLR-342VC-T
LED LED LED LED LED
C600 C601 C602 C603 C604 C605 C606 C607 C608 C609 C610 C611 C612 C613 C614 C615 C616 C617 C618 C619 C620 C621 C622 C660 C661 C670 C671 C700 C701 C702 C703 C704 C705 C706 C707 C708 C709 C710 C711 C712 C713 C714 C715 C716 C717 C718 C719 C750 C751 C760 C761 C931 C932 C935 C936 C937 C938 C939 C940 C941 C942 C943
QTE1V06-106Z QCBB1HK-221Y QCBB1HK-221Y QCBB1HK-221Y QTE1V06-106Z QETN1HM-107Z QETN1HM-106Z QETN1HM-106Z QETN1HM-107Z QCBB1HK-221Y QCSB1HJ-100Y QETN1JM-476Z QFLC1HJ-473Z QFLC1HJ-473Z FQCF31HZ-223Z QETN1JM-476Z QCSB1HJ-100Y QFLC1HJ-473Z QFLC1HJ-473Z FQCF31HZ-223Z QFLC1HJ-823Z QETN1HM-224Z QETN1HM-105Z QETN1HM-106Z QETN1HM-106Z QETN1HM-106Z QETN1AM-227Z QCBB1HK-221Y QCBB1HK-221Y QTE1V06-106Z QTE1V06-106Z QCBB1HK-471Y QFZ0212-104Z QFZ0212-104Z QETN1CM-107Z QCSB1HK-4R7Y QCSB1HK-4R7Y FQCF31HZ-223Z FQCF31HZ-223Z QETN1JM-476Z QETN1JM-476Z QFLC1HJ-473Z QFLC1HJ-473Z QFLC1HJ-473Z QFLC1HJ-473Z QETN1HM-105Z QETN1HM-106Z QETN1HM-106Z QETN1CM-227Z QETN1HM-106Z QETN1HM-106Z QEKC1HM-226Z QEKC1HM-226Z QDYB1CM-103Y QDYB1CM-103Y QDYB1CM-103Y QDYB1CM-103Y QDYB1CM-103Y QDYB1CM-103Y QEKC0JM-107Z QEKC1HM-106Z QEKC1HM-106Z
E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR M CAPACITOR M CAPACITOR D.CAPACITOR E CAPACITOR C CAPACITOR M CAPACITOR M CAPACITOR D.CAPACITOR M CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR M CAPACITOR M CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR D.CAPACITOR D.CAPACITOR E CAPACITOR E CAPACITOR M CAPACITOR M CAPACITOR M CAPACITOR M CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR
10uF 35V 220pF 50V K 220pF 50V K 220pF 50V K 10uF 35V 100uF 50V M 10uF 50V M 10uF 50V M 100uF 50V M 220pF 50V K 10pF 50V J 47uF 63V M 0.047uF 50V J 0.047uF 50V J
QRE141J-102Y QRE141J-473Y QRE141J-473Y QRE141J-102Y QRT01DJ-R22X QRT01DJ-R22X QRT01DJ-R22X QRT01DJ-R22X QRE141J-333Y
C RESISTOR C RESISTOR C RESISTOR C RESISTOR MF RESISTOR MF RESISTOR MF RESISTOR MF RESISTOR C RESISTOR
1kΩ 1/4W J 47kΩ 1/4W J 47kΩ 1/4W J 1kΩ 1/4W J 0.22Ω 1W J 0.22Ω 1W J 0.22Ω 1W J 0.22Ω 1W J 33kΩ 1/4W J
R600 R601 R602 R603 R604 R605 R606 R607 R608
Description Local
47uF 63V M 10pF 50V J 0.047uF 50V J 0.047uF 50V J 0.082uF 50V J 0.22uF 50V M 1uF 50V M 10uF 50V M 10uF 50V M 10uF 50V M 220uF 10V M 220pF 50V K 220pF 50V K 10uF 35V 10uF 35V 470pF 50V K 0.1uF 0.1uF 100uF 16V M 4.7pF 50V K 4.7pF 50V K 47uF 63V M 47uF 63V M 0.047uF 50V J 0.047uF 50V J 0.047uF 50V J 0.047uF 50V J 1uF 50V M 10uF 50V M 10uF 50V M 220uF 16V M 10uF 50V M 10uF 50V M 22uF 50V M 22uF 50V M 0.01uF 16V M 0.01uF 16V M 0.01uF 16V M 0.01uF 16V M 0.01uF 16V M 0.01uF 16V M 100uF 6.3V M 10uF 50V M 10uF 50V M
3-15
Symbol No.
Part No.
Part Name
R609 R610 R611 R612 R613 R614 R615 R616 R617 R618 R619 R620 R621 R622 R623 R624 R625 R626 R627 R628 R629 R630 R631 R632 R633 R634 R635 R636 R661 R671 R700 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 R712 R713 R714 R715 R716 R717 R718 R719 R720 R721 R722 R723 R724 R725 R726 R727 R728 R729 R730 R731 R732 R733 R734 R735 R736 R737 R738 R750 R751 R760 R761 R946 R947 R948 R950 R951
QRJ146J-101X QRJ146J-101X QRJ146J-100X QRE141J-103Y QRE141J-103Y QRE141J-221Y QRE141J-563Y QRJ146J-100X QRJ146J-100X QRE141J-105Y QRE141J-392Y QRJ146J-122X QRE141J-475Y QRE141J-473Y QRE141J-153Y QRE141J-473Y QRE141J-222Y QRE141J-563Y QRJ146J-122X QRJ146J-100X QRJ146J-100X QRE141J-221Y QRE141J-473Y QRE141J-222Y QRE141J-823Y QRE141J-104Y QRE141J-103Y QRE141J-203Y QRE141J-102Y QRE141J-102Y QRE141J-103Y QRE141J-103Y QRE141J-103Y QRE141J-103Y QRJ146J-100X QRZ0224-R22 QRZ0224-R22 QRE141J-333Y QRE141J-563Y QRE141J-563Y QRE141J-102Y QRE141J-103Y QRE141J-103Y QRE141J-103Y QRE141J-103Y QRE141J-104Y QRE141J-222Y QRE141J-102Y QRE141J-102Y QRE141J-102Y QRE141J-102Y QRE141J-473Y QRE141J-473Y QRE141J-562Y QRE141J-562Y QRJ146J-100X QRJ146J-100X QRJ146J-100X QRJ146J-100X QRE141J-563Y QRE141J-563Y QRJ146J-821X QRJ146J-821X QRJ146J-470X QRJ146J-470X QRE141J-103Y QRE141J-823Y QRE141J-104Y QRE141J-104Y QRK126J-2R2X QRJ146J-1R0X ERX12SJR33E QRJ146J-2R2X QRE141J-102Y QRE141J-102Y QRE141J-102Y QRE141J-102Y QRE141J-221Y
UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR EMIT RESISTOR EMIT RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR
3-16
Description Local 100Ω 1/4W J 100Ω 1/4W J 10Ω 1/4W J 10kΩ 1/4W J 10kΩ 1/4W J 220Ω 1/4W J 56kΩ 1/4W J 10Ω 1/4W J 10Ω 1/4W J 1MΩ 1/4W J 3.9kΩ 1/4W J 1.2kΩ 1/4W J 4.7MΩ 1/4W J 47kΩ 1/4W J 15kΩ 1/4W J 47kΩ 1/4W J 2.2kΩ 1/4W J 56kΩ 1/4W J 1.2kΩ 1/4W J 10Ω 1/4W J 10Ω 1/4W J 220Ω 1/4W J 47kΩ 1/4W J 2.2kΩ 1/4W J 82kΩ 1/4W J 100kΩ 1/4W J 10kΩ 1/4W J 20kΩ 1/4W J 1kΩ 1/4W J 1kΩ 1/4W J 10kΩ 1/4W J 10kΩ 1/4W J 10kΩ 1/4W J 10kΩ 1/4W J 10Ω 1/4W J 0.22Ω 0.22Ω 33kΩ 1/4W J 56kΩ 1/4W J 56kΩ 1/4W J 1kΩ 1/4W J 10kΩ 1/4W J 10kΩ 1/4W J 10kΩ 1/4W J 10kΩ 1/4W J 100kΩ 1/4W J 2.2kΩ 1/4W J 1kΩ 1/4W J 1kΩ 1/4W J 1kΩ 1/4W J 1kΩ 1/4W J 47kΩ 1/4W J 47kΩ 1/4W J 5.6kΩ 1/4W J 5.6kΩ 1/4W J 10Ω 1/4W J 10Ω 1/4W J 10Ω 1/4W J 10Ω 1/4W J 56kΩ 1/4W J 56kΩ 1/4W J 820Ω 1/4W J 820Ω 1/4W J 47Ω 1/4W J 47Ω 1/4W J 10kΩ 1/4W J 82kΩ 1/4W J 100kΩ 1/4W J 100kΩ 1/4W J 2.2Ω 1/2W J 1Ω 1/4W J 2.2Ω 1/4W J 1kΩ 1/4W J 1kΩ 1/4W J 1kΩ 1/4W J 1kΩ 1/4W J 220Ω 1/4W J
Symbol No.
Part No.
Part Name
Description Local
R952 R953 R954 R955 R956 R957 R958 R959 R960 R961 R962 R963 R964 R965 R967 R968 R969 R970 R971 R972 R973 R974 R975 R976 R978 R980 R982 R983 R995 R996 R997
QRE141J-221Y QRE141J-221Y QRE141J-221Y QRE141J-221Y QRE141J-101Y QRE141J-101Y QRE141J-121Y QRE141J-151Y QRE141J-221Y QRE141J-271Y QRE141J-391Y QRE141J-561Y QRE141J-102Y QRE141J-182Y QRE141J-101Y QRE141J-101Y QRE141J-121Y QRE141J-151Y QRE141J-221Y QRE141J-271Y QRE141J-391Y QRE141J-561Y QRE141J-102Y QRE141J-182Y QRE141J-221Y QRE141J-101Y QRE141J-104Y QRE141J-104Y QRE141J-104Y QRE141J-104Y QRE141J-101Y
C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR
220Ω 1/4W J 220Ω 1/4W J 220Ω 1/4W J 220Ω 1/4W J 100Ω 1/4W J 100Ω 1/4W J 120Ω 1/4W J 150Ω 1/4W J 220Ω 1/4W J 270Ω 1/4W J 390Ω 1/4W J 560Ω 1/4W J 1kΩ 1/4W J 1.8kΩ 1/4W J 100Ω 1/4W J 100Ω 1/4W J 120Ω 1/4W J 150Ω 1/4W J 220Ω 1/4W J 270Ω 1/4W J 390Ω 1/4W J 560Ω 1/4W J 1kΩ 1/4W J 1.8kΩ 1/4W J 220Ω 1/4W J 100Ω 1/4W J 100kΩ 1/4W J 100kΩ 1/4W J 100kΩ 1/4W J 100kΩ 1/4W J 100Ω 1/4W J
L601 L602 L701 L702
QQLZ035-R39 QQLZ035-R39 QQLZ035-R39 QQLZ035-R39
COIL COIL COIL COIL
0.39uH 0.39uH 0.39uH 0.39uH
BZ900 CN511 CN600 CN610 CN700 CN710 CN812 CN902 CN912 FL900 FL901 FW215 FW216 FW218 FW901 FW902 JS958 JS960 JS962 S908 S909 S910 S911 S912 S913 S914 S915 S916 S917 S918 S919 S920 S921 S922 S923 S924 S925 S926 S927 S928 S929
QAN0055-001 QGB2510J1-16 QGB2510K1-11 QGB2510J1-11 QGB2510K1-10 QGB2510J1-10 QGF1210G1-23 QGF1210G1-18 QGF1205F1-18 QLF0133-001 GV30530-001A QUM153-09DGZ4 QJK008-101814 QJK008-111814 QUM153-10Z4Z4 QUM152-10Z4Z4 QSW1057-001 QSW1056-001 QSW0857-001 QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z QSW0825-001Z
BUZZER CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR FL TUBE FL HOLDER FLAT WIRE FLAT WIRE FLAT WIRE FLAT WIRE FLAT WIRE ROTARY SW ROTARY SW ROTARY SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT SW
B-B (1-16) B-B (1-11) B-B (1-11) B-B (1-10) B-B (1-10) FFC/FPC (1-23) FFC/FPC (1-18) FFC/FPC (1-18)
Symbol No. SP900 SP902 SP903
Part No.
Part Name
VYH7653-001 E3400-439 E3400-439
IC HOLDER SPECER SPECER
Description Local
CD servo board Block No. [0][4][0][0] Symbol No.
Part No.
Part Name
IC201 IC251 IC601 IC651 IC671 IC681 IC682 IC691 IC801
BR24L08FV-W-X MN101C61GMB3 AN22002A-W MN6627911AC1 A42L2604V-45L SN74AHC1G32DC-X SN74LV08APW-X XC6206P182M-X AN4801SB-W
IC IC IC IC IC IC IC IC IC
Q291 Q631
2SB1424/QR/-W 2SA1037AK/RS/-X
TRANSISTOR TRANSISTOR
C201 C251 C252 C253 C255 C258 C259 C291 C603 C604 C605 C606 C610 C611 C612 C614 C615 C616 C621 C622 C623 C624 C631 C632 C633 C641 C651 C652 C653 C654 C655 C656 C657 C658 C659 C661 C662 C663 C664 C665 C666 C667 C669 C672 C673 C674 C675 C676 C677 C678 C679 C681
NCB31CK-104X NCB31CK-104X QEKJ0JM-476Z NCB31CK-104X NCB31CK-104X NCB31CK-103X NDC31HJ-101X QEKJ0JM-476Z NCB31CK-104X NCB31CK-104X NDC31HJ-331X NDC31HJ-151X NCB31CK-563X NCB31CK-104X NCB31CK-104X NCB31CK-393X NCB31HK-272X NCB31HK-182X NCB31CK-104X QEKJ1AM-107Z NCB31CK-104X QEKJ1AM-107Z QEKJ1CM-106Z NCB31CK-104X NCB31EK-223X NDC31HJ-101X QEKJ1AM-107Z NCB31CK-104X NCB31CK-104X NCB31CK-104X NCB31CK-104X NCB31CK-104X NDC31HJ-471X NCB31CK-104X NCB31EK-223X NCB31HK-102X NCB21CK-124X NCB31CK-104X QEKJ1AM-107Z NCB31CK-104X QEKJ1AM-107Z NCB31CK-104X NCB31HK-272X NCB31HK-272X NCB31CK-104X NCB31CK-104X NDC31HJ-100X NDC31HJ-100X NCB31CK-104X QEKJ1AM-107Z NCB21CK-105X NCB21CK-105X
C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR
Description Local
0.1uF 16V K 0.1uF 16V K 47uF 6.3V M 0.1uF 16V K 0.1uF 16V K 0.01uF 16V K 100pF 50V J 47uF 6.3V M 0.1uF 16V K 0.1uF 16V K 330pF 50V J 150pF 50V J 0.056uF 16V K 0.1uF 16V K 0.1uF 16V K 0.039uF 16V K 2700pF 50V K 1800pF 50V K 0.1uF 16V K 100uF 10V M 0.1uF 16V K 100uF 10V M 10uF 16V M 0.1uF 16V K 0.022uF 25V K 100pF 50V J 100uF 10V M 0.1uF 16V K 0.1uF 16V K 0.1uF 16V K 0.1uF 16V K 0.1uF 16V K 470pF 50V J 0.1uF 16V K 0.022uF 25V K 1000pF 50V K 0.12uF 16V K 0.1uF 16V K 100uF 10V M 0.1uF 16V K 100uF 10V M 0.1uF 16V K 2700pF 50V K 2700pF 50V K 0.1uF 16V K 0.1uF 16V K 10pF 50V J 10pF 50V J 0.1uF 16V K 100uF 10V M 1uF 16V K 1uF 16V K
Symbol No.
Part No.
Part Name
Description Local
C801 C802 C803 C804 C805 C806
QERF1AM-227Z NCB31CK-104X NCB31AK-474X NCB31CK-103X NCB31HK-102X NCB31HK-152X
E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR
220uF 10V M 0.1uF 16V K 0.47uF 10V K 0.01uF 16V K 1000pF 50V K 1500pF 50V K
R253 R255 R256 R257 R258 R259 R261 R262 R263 R264 R265 R267 R271 R274 R278 R281 R282 R283 R284 R285 R286 R287 R288 R289 R290 R291 R292 R293 R294 R295 R296 R297 R298 R601 R602 R603 R604 R605 R606 R607 R608 R611 R613 R617 R621 R622 R624 R625 R631 R632 R634 R635 R651 R652 R653 R654 R655 R656 R657 R658 R659 R661 R662 R663 R664 R665 R666 R667 R668 R669 R671
NRSA63J-103X NRSA63J-102X NRSA63J-102X NRSA63J-0R0X NRSA63J-102X NRSA63J-103X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-103X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-473X NRSA63J-473X NRSA63J-473X NRSA63J-103X NRSA63J-122X NRSA63J-103X NRSA63J-562X NRSA63J-392X NRSA63J-333X NRSA63J-104X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-223X NRSA63J-223X NRSA63J-392X NRSA63J-392X NRSA63J-122X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-3R9X NRSA63J-3R9X NRSA63J-100X NRSA63J-473X NRSA63J-0R0X NRSA63J-223X NRSA63J-823X NRSA63J-472X NRSA63J-104X NRSA63J-561X NRSA63J-0R0X NRSA63J-153X NRSA63J-153X NRSA02J-101X NRSA63J-273X NRSA63J-0R0X NRSA63J-681X NRSA63J-561X NRSA63J-681X NRSA63J-561X NRSA63J-102X NRSA63J-333X
MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR
10kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 0Ω 1/16W J 1kΩ 1/16W J 10kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 10kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 47kΩ 1/16W J 47kΩ 1/16W J 47kΩ 1/16W J 10kΩ 1/16W J 1.2kΩ 1/16W J 10kΩ 1/16W J 5.6kΩ 1/16W J 3.9kΩ 1/16W J 33kΩ 1/16W J 100kΩ 1/16W J 0Ω 1/16W J 0Ω 1/16W J 22kΩ 1/16W J 22kΩ 1/16W J 3.9kΩ 1/16W J 3.9kΩ 1/16W J 1.2kΩ 1/16W J 0Ω 1/16W J 0Ω 1/16W J 0Ω 1/16W J 0Ω 1/16W J 0Ω 1/16W J 3.9Ω 1/16W J 3.9Ω 1/16W J 10Ω 1/16W J 47kΩ 1/16W J 0Ω 1/16W J 22kΩ 1/16W J 82kΩ 1/16W J 4.7kΩ 1/16W J 100kΩ 1/16W J 560Ω 1/16W J 0Ω 1/16W J 15kΩ 1/16W J 15kΩ 1/16W J 100Ω 1/10W J 27kΩ 1/16W J 0Ω 1/16W J 680Ω 1/16W J 560Ω 1/16W J 680Ω 1/16W J 560Ω 1/16W J 1kΩ 1/16W J 33kΩ 1/16W J
3-17
Symbol No. R672 R673 R674 R675 R676 R677 R678 R679 R681 R682 R801 R802 R803 R805 R806 R807 R809 R811 R812 R814 R815 R816 R818 CN251 CN252 CN253 CN601 CN602 CN651 K654 X251 X651
Part No.
Part Name
NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-102X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-0R0X NRSA63J-103X NRSA63J-101X NRSA63J-472X NRSA63J-222X NRSA63J-562X NRSA63J-472X NRSA63J-332X NRSA63J-562X NRSA63J-223X NRSA63J-153X NRSA63J-562X NRSA63J-183X NRSA63J-153X NRSA63J-562X NRSA63J-223X
MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR MG RESISTOR
QGF1036F1-15 QGA2001F1-02 QGA2001F1-03 QGF1006F2-16W QGA2001F1-06 QGF1036F1-17 NQR0007-002X QAX0684-001Z NAX0476-001X
Description Local
CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR FERRITE BEADS C RESONATOR CRYSTAL
1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 1kΩ 1/16W J 0Ω 1/16W J 0Ω 1/16W J 0Ω 1/16W J 0Ω 1/16W J 10kΩ 1/16W J 100Ω 1/16W J 4.7kΩ 1/16W J 2.2kΩ 1/16W J 5.6kΩ 1/16W J 4.7kΩ 1/16W J 3.3kΩ 1/16W J 5.6kΩ 1/16W J 22kΩ 1/16W J 15kΩ 1/16W J 5.6kΩ 1/16W J 18kΩ 1/16W J 15kΩ 1/16W J 5.6kΩ 1/16W J 22kΩ 1/16W J FFC/FPC (1-15) W-B (1-2) W-B (1-3) FFC/FPC (1-16) W-B (1-6) FFC/FPC (1-17) 8.38MHz 33.8688MHz
Loading switch board Block No. [0][5][0][0] Symbol No.
Part No.
Part Name
Description Local
IC1 IC2
LB1641 LB1641
IC IC
D1
MTZJ6.2A-T2
Z DIODE
C1 C2 C3 C5 C6 C7
QEKC1AM-107Z QCFB1HZ-104Y QFLC1HJ-103Z QFLC1HJ-103Z QCFB1HZ-104Y QCFB1HZ-104Y
E CAPACITOR C CAPACITOR M CAPACITOR M CAPACITOR C CAPACITOR C CAPACITOR
100uF 10V M 0.1uF 50V Z 0.01uF 50V J 0.01uF 50V J 0.1uF 50V Z 0.1uF 50V Z
CN1 CN2 CN3 SW1 SW2 SW3 SW4 SW5 SW6 SW7 SW8
QGF1036F1-15 QGB1214J1-08S QGB1214K1-08S QSW0844-001 QSW0844-001 QSW0844-001 QSW0844-001 QSW0844-001 QSW0854-002 QSW0886-002 QSW0886-002
CONNECTOR CONNECTOR CONNECTOR PUSH SWITCH PUSH SWITCH PUSH SWITCH PUSH SWITCH PUSH SWITCH PUSH SW DETECT SWITCH DETECT SWITCH
FFC/FPC (1-15) B-B (1-8) B-B (1-8)
Cassette switch board Block No. [0][6][0][0] Symbol No. IC1
3-18
Part No.
Part Name
SG-105F3-BB,C
PHOTO SENSER
Description Local
Symbol No.
Part No.
Part Name
Description Local
D1
1SR139-400-T2
SI DIODE
R371 VR37
QRE141J-123Y QVP0077-103Z
C RESISTOR TRIM RESISTOR
12kΩ 1/4W J 10kΩ
CN1 FW100 P1 SW1 SW2 SW5 SW6
QGF1205F1-09 QUM024-07A2Z3 QNZ0104-001 QSW0832-001 QSW0832-001 QSW0832-001 QSW0859-001
CONNECTOR PARA RIBON WIRE POST PIN CASS.SWITCH CASS.SWITCH CASS.SWITCH DETECT SWITCH
FFC/FPC (1-9)
Head amplifier board Block No. [0][7][0][0] Symbol No.
Part No.
Part Name
IC32
HA12238F
IC
IC33
CD4094BC
IC
Q302 Q305 Q342 Q343 Q344 Q345 Q346 Q347 Q371 Q372 Q375 Q376
2SC2001/K/-T 2SC2001/K/-T KRA111M-T 2SC3576-JVC-T 2SC3576-JVC-T 2SC3576-JVC-T 2SC3576-JVC-T KRC107M-T KTA1271/OY/-T KRC107M-T 2SB562/C/-T KTC3199/GL/-T
TRANSISTOR TRANSISTOR DIGI TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DIGI TRANSISTOR TRANSISTOR DIGI TRANSISTOR TRANSISTOR TRANSISTOR
D340 D375
MTZJ5.1B-T2 MTZJ5.1B-T2
Z DIODE Z DIODE
C101 C102 C103 C104 C105 C106 C107 C109 C110 C113 C120 C121 C201 C202 C203 C204 C205 C206 C207 C209 C210 C213 C220 C221 C300 C301 C304 C306 C307 C308 C310 C313 C314 C316 C319 C331
QDGB1HK-821Y QDYB1CM-103Y QFLA1HJ-104Z QCBB1HK-221Y QCBB1HK-391Y QERF1HM-225Z QCBB1HK-271Y QEKJ1EM-475Z QDYB1CM-682Y QFLA1HJ-104Z QCSB1HK-4R7Y QCBB1HK-331Y QDGB1HK-821Y QDYB1CM-103Y QFLA1HJ-104Z QCBB1HK-221Y QCBB1HK-391Y QERF1HM-225Z QCBB1HK-271Y QEKJ1EM-475Z QDYB1CM-682Y QFLA1HJ-104Z QCSB1HK-4R7Y QCBB1HK-331Y QEKJ1HM-105Z QEKJ1AM-107Z QEKJ1CM-106Z FQETJ1AM-227Z QDGB1HK-102Y QDXB1CM-152Y QCBB1HK-223Y QEKJ1AM-107Z QCFB1HZ-105Y QFG32AJ-223Z QFLC1HJ-472Z QEKJ1CM-476Z
C CAPACITOR C CAPACITOR M CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR M CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR M CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR M CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR C CAPACITOR C CAPACITOR E CAPACITOR C CAPACITOR PP CAPACITOR M CAPACITOR E CAPACITOR
Description Local R/P Equalizer Serial to parallel port extension
820pF 50V K 0.01uF 16V M 0.1uF 50V J 220pF 50V K 390pF 50V K 2.2uF 50V M 270pF 50V K 4.7uF 25V M 6800pF 16V M 0.1uF 50V J 4.7pF 50V K 330pF 50V K 820pF 50V K 0.01uF 16V M 0.1uF 50V J 220pF 50V K 390pF 50V K 2.2uF 50V M 270pF 50V K 4.7uF 25V M 6800pF 16V M 0.1uF 50V J 4.7pF 50V K 330pF 50V K 1uF 50V M 100uF 10V M 10uF 16V M 1000pF 50V K 1500pF 16V M 0.022uF 50V K 100uF 10V M 1uF 50V Z 0.022uF 100V J 4700pF 50V J 47uF 16V M
Symbol No.
Part No.
Part Name
QEKJ1CM-476Z QEKJ1HM-105Z QEKJ1CM-476Z QEKJ1EM-475Z QEKJ1AM-107Z QDYB1CM-103Y
E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR E CAPACITOR C CAPACITOR
47uF 16V M 1uF 50V M 47uF 16V M 4.7uF 25V M 100uF 10V M 0.01uF 16V M
R101 R102 R104 R105 R106 R107 R108 R110 R116 R121 R201 R202 R204 R205 R206 R207 R208 R210 R216 R221 R301 R302 R303 R304 R305 R306 R310 R313 R314 R315 R327 R335 R336 R337 R338 R339 R340 R341 R342 R343 R344 R345 R346 R347 R353 R372 R375 R376 VR31
QRE141J-512Y QRE141J-512Y QRE141J-222Y QRE141J-104Y QRE141J-113Y QRE141J-912Y QRE141J-273Y QRE141J-103Y QRE141J-102Y QRE141J-153Y QRE141J-512Y QRE141J-512Y QRE141J-222Y QRE141J-104Y QRE141J-113Y QRE141J-912Y QRE141J-273Y QRE141J-103Y QRE141J-102Y QRE141J-153Y QRE141J-221Y QRE141J-222Y QRE141J-222Y QRJ146J-101X QRE141J-103Y QRE141J-472Y QRJ146J-4R7X QRE141J-2R2Y QRE141J-153Y QRE141J-101Y QRE141J-474Y QRE141J-222Y QRE141J-223Y QRE141J-332Y QRE141J-392Y QRE141J-104Y QRE141J-681Y QRE141J-123Y QRE141J-243Y QRE141J-183Y QRE141J-472Y QRE141J-472Y QRE141J-472Y QRE141J-103Y QRZ9005-100X QRE141J-102Y QRE141J-151Y QRE141J-472Y QVP0008-203Z
C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR UNF C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR C RESISTOR FUSI RESISTOR C RESISTOR C RESISTOR C RESISTOR TRIM RESISTOR
5.1kΩ 1/4W J 5.1kΩ 1/4W J 2.2kΩ 1/4W J 100kΩ 1/4W J 11kΩ 1/4W J 9.1kΩ 1/4W J 27kΩ 1/4W J 10kΩ 1/4W J 1kΩ 1/4W J 15kΩ 1/4W J 5.1kΩ 1/4W J 5.1kΩ 1/4W J 2.2kΩ 1/4W J 100kΩ 1/4W J 11kΩ 1/4W J 9.1kΩ 1/4W J 27kΩ 1/4W J 10kΩ 1/4W J 1kΩ 1/4W J 15kΩ 1/4W J 220Ω 1/4W J 2.2kΩ 1/4W J 2.2kΩ 1/4W J 100Ω 1/4W J 10kΩ 1/4W J 4.7kΩ 1/4W J 4.7Ω 1/4W J 2.2Ω 1/4W J 15kΩ 1/4W J 100Ω 1/4W J 470kΩ 1/4W J 2.2kΩ 1/4W J 22kΩ 1/4W J 3.3kΩ 1/4W J 3.9kΩ 1/4W J 100kΩ 1/4W J 680Ω 1/4W J 12kΩ 1/4W J 24kΩ 1/4W J 18kΩ 1/4W J 4.7kΩ 1/4W J 4.7kΩ 1/4W J 4.7kΩ 1/4W J 10kΩ 1/4W J 10Ω 1kΩ 1/4W J 150Ω 1/4W J 4.7kΩ 1/4W J 20kΩ
L301 L303
QQR1118-002 QQL244K-100Z
OSC COIL(BIAS) COIL
10uH K
CN31 CN32 CN33 CN34 H32
QGF1205F1-06 QGF1205F1-09 QGF1205F1-09 QGF1201F3-10 GV40397-002A
CONNECTOR CONNECTOR CONNECTOR CONNECTOR IC HOLDER
C340 C341 C342 C371 C374 C376
Description Local
FFC/FPC (1-6) FFC/FPC (1-9) FFC/FPC (1-9) FFC/FPC (1-10)
3-19
Packing materials and accessories parts list Block No. M 3 M M
A3
P7 A1, A2, A4, A5, A6, A7, A8, A9, A10
P2 1/2
P2 2/2 P5 P5 P9
P4 P3 P11 1/2 A12 P6
P10
P3 2/2
A11 P10 P8
P1
3-20
P11
Packing and accessories Block No. [M][3][M][M] Symbol No. A 1 A 1 A 2 A 3 A 4 A 5 A 6 A 7 A 8 A 9 A 10 A 11 A 12 P 1 P 1 P 2 P 3 P 4 P 5 P 6 P 7 P 8 P 9 P 10 P 11
Part No.
Part Name
GVT0124-002A GVT0124-001A GV40511-001A GV40510-001B BT-51028-2 YU20333 QAL0014-001 QAL0457-001 RM-SHXGX7J -------------------BT-52006-2 HXGX7J-SPBOX-R HXGX7J-SPBOX-L GV20280-002A GV20280-001A GV10212-001A GV10213-001A QPC07007030P GV40168-010A GV30209-004A QPC02503515P 720-XGD7B0-00 720-XGD7T0-00 700-120076-10 715-250054-00
INST BOOK INST BOOK NOTICE SHEET CAUTION SHEET REGISTER CARD SAFETY INST. AM LOOP ANT ANT.WIRE REMOCON BATTERY WARRANTY CARD SPEAKER BOX SPEAKER BOX CARTON ASSY. CARTON ASSY. CUSHION TOP CUSHION BOTTOM POLY BAG SHEET CUSHION SPACER POLY BAG POLYFOAM BTTM POLYFOAM TOP POLY BAG MIRAMAT SHEET
Description Local ENG,FRE ENG
GX7C GX7J GX7J
(x2) GX7C GX7C GX7J 70cm x 70cm (x2) 25cm x 35cm (x2) (x2)
3-21
