Transcript
http://www.xiaoyu163.com
SA-WVS200/WVS300 QQ 376315150 892498299 SERVICE MANUAL
US Model Canadian Model
Ver. 1.1 2006. 05
SA-WVS300
AEP Model SA-WVS200/WVS300
UK Model E Model Australian Model SA-WVS300 SA-WVS200
13942296513
13942296513
Photo: SA-WVS300
• SA-WVS200 is active subwoofer in SA-VS200H • SA-WVS300 is active subwoofer in SA-VS300H
SPECIFICATIONS SA-WVS300
POWER OUTPUT AND TOTAL HARMONIC DISTORTION: with 6 ohm loads both channels driven, at 100 Hz; rated 150 watts per channel minimum RMS power, with no more than 10% total harmonic distortion from 250 milliwatts to rated output.
General Power requirements
SA-WVS200/WVS300 Speaker system Active subwoofer, magnetically shielded Speaker units Woofer: 15 cm (6 in.) (x 2), cone type Enclosure type Acoustically Loaded Bass reflex Reproduction frequency range 28 Hz - 200 Hz Continuous RMS power output 150 W (6 ohms 100 Hz, 10% THD)
Power consumptions Dimensions (w/h/d)
Mass
120 V AC, 60 Hz (US, Canadian) 220 - 230 V AC, 50/60 Hz (AEP, UK, CH, KR) 230 - 240 V AC, 50/60 Hz (SP, AUS) 90 W 1 W (standby mode) Approx. 197 x 407 x 502 mm (7 7/8 x 16 1/8 x 19 7/8 in.), including front grille Approx. 12.2 kg (26 lb 15 oz)
Design and specifications are subject to change without notice. • Abbreviation AUS SP CH KR
www 9-879-064-02 2006E02-1 © 2006.05
: Australian model : Singapore model : Chinese model : Korea model
x aoy u163. com
ACTIVE SUBWOOFER
.Sony Corporation i
Home Audio Division Published by Sony Techno Create Corporation
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
Input LINE IN (input pin jack)
AUDIO POWER SPECIFICATIONS (For the U.S. model)
QQ
QQ
QQ 376315150 892498299
TEL 13942296513
TEL
TEL
Chinese Model
http://www.xiaoyu163.com
SA-WVS200/WVS300
QQ 376315150 892498299 TABLE OF CONTENTS
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.
1.
DIAGRAMS
1-1. 1-2. 1-3. 1-4.
Printed Wiring Boards– Pri Amp Section – ..................... 3 Schematic Diagram – Pri Amp Section – ........................ 4 Printed Wiring Boards – Power Amp Section– ............... 5 Schematic Diagram – Power Amp Section – .................. 6
LEAKAGE
2.
EXPLODED VIEWS
2-1. Main Section .................................................................... 7 The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods.
3.
ELECTRICAL PARTS LIST .................................. 8
TEL
TEL
1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments.
13942296513
13942296513
2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A)
0.15 µF
1.5 kΩ
QQ 376315150 892498299
AC Voltmeter (0.75 V)
Earth Ground Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
www
.
xiaoy u163. com
2 http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
To Exposed Metal Parts on Set
http://www.xiaoyu163.com
SA-WVS200/WVS300
SECTION 1 DIAGRAMS
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
1-1. PRINTED WIRING BOARD – PRI AMP SECTION –
3
2
4
1
C502 C501 R501
VR501 BASS BOOST
J501 LINE IN
E
VR502 LEVEL
C511
R409
R408
Q403
Q405
R407
R406 1
R514
D
4
D401
D-7 D-7 B-6 B-6 B-6 C-4 C-7 C-7
8 9 2 4 9 8 2 9 9
R401
JW517
Q402
Q401 Q402 Q403 Q404 Q405 Q501 Q803 Q804
R402
C402
Q401
1
D403
IC502
B
4
3 7 68 3D4021 5 1 5 0
C-2 D-6 C-3 C-5 B-5 B-4
E
C519
5
IC501 IC502 IC503 IC504 IC505 IC506
B
R502
JW516 JW518
D404
R505
C820
C821
R519
JW508 JW509 JW510 JW511
JW515
C-7 C-6 D-6 D-6 B-4 B-4 B-7 B-7
(CHASSIS)
S501
S401
PHASE NORMALtREVERSE
POWER SAVE AUTOtOFF
JW519
11 1-863-035- (11)
For printed wiring boards. Note: • X : parts extracted from the component side. • : Pattern from the side which enables seeing.
www
.
x
i
a o y u 1 6 3
SA-WVS200/WVS300
3 3 http://www.xiaoyu163.com
.
c o
m
376315150 892498299
QQ
B Q803 E
B Q804 E
E
376315150 892498299
R511 1R512 3 9 4 2 2 9 6 5 1R5093
1
C510
Q501
C819
R513
C505
C504
R517 4
R508 E
R403
IC504
1 B
8
R405 JW513
R518
JW505
JW502
C509
5
C818
Location
D401 D402 D403 D404 D501 D502 D814 D815
QQ
QQ
R503
R507
IC503 4
1
R516
D815
B
8
R806 D814
B
C508 5
B
IC501
R531
R504
JW504
T E L
R520
C816
C817
R807
R410
R404
R527
JW504 8
1
1
E
R525
4 D502
R523
1
Q404
4
7 C520
R522
IC505
Ref. No.
R524
8
C512
IC506
BC504
13942296513
C506
5
E
C516
8
E
13942296513
C517
R506
B
R515
C514
5
R521
R526
C515
C
AUTO POWER BOARD (Page 5)
TEL
TEL
JW507
R530 JW501
C513
JW512
JW504 R529
1
4
8
7
B
D501
5
5
6
• Semiconductor Location
BC506
C503
5
POWER AMP BOARD (Page 5)
A
PRI AMP BOARD
A
4
R528
1
http://www.xiaoyu163.com
SA-WVS200/WVS300
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
1-2. SCHEMATIC DIAGRAM – PRI AMP SECTION –
IC504(1/2) BA4558 HPF
C514 0.1
LPF
C516 10 50V
C515 0.1
C517 10 50V
BC506
LPF
IC501(2/2) BA4558 BUFFER J501 1P
R501 1k
C503 220p
LINE IN
IC503(1/2) BA4558
6
8
R531 6.8k
C502 10 50V
4
2
R515 10k
1
6
R505 1k
VR501 5KB
2
4
7 C508 0.22
5
R506 0
3
R517 4.7k
8
3
C509 0.22
1
C511 10 50V
C501 220p
R516 68k
C506 0.047
R524 8.2k
R520 10k
R521 1k
6
REVERSE
D501 1SS133
8
1
1
3
4
7
R407 10k
R410 2.2k
R409 2.2k
C821 47 25V
8 9 2 4 9 8 2 9 9
Q803 2SC1815 +12V REG
C816 10 50V
R806 3.3k C818 10 50V
D814 MTZJ-13B
C819 10 50V
D815 MTZJ-13B
R807 3.3k
R405 10k
C817 10 50V
BC504 7P
C520 0.1
AUTO POWER BOARD (Page6)
Q804 2SA1015 -12V REG
R402 10k
Q401 DTC124ES
R526 2.7k
S401
C402 330 16V
4
R513 2.2k
C820 47 25V
R408 1k
8
C512 0.056
IC506(1/2) BA4558
LIMITTER
Q405 DTA124ES LED DRIVER
R525 15k
3
2
3 7 6 3 1 5 1 5 0
Q404 DTA124ES LED DRIVER
Q403 DTC124ES RELAY DRIVE
1 3
5
6
D404 1SS133
IC505(2/2) BA4558
Q401,402 AUDIO LEVEL DETECT
www
For schematic diagrams. • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • 2 : nonflammable resistor. • 5 : fusible resistor. • C : panel designation.
.
x
i
Note: Note: The components identi- Les composants identifiés par fied by mark 0 or dotted une marque 0 sont critiques line with mark 0 are criti- pour la sécurité. cal for safety. Ne les remplacer que par une Replace only with part piéce portant le numéro number specified. spécifié.
a o y u 1 6 3
SA-WVS200/WVS300
4
4 http://www.xiaoyu163.com
.
• A : B+ Line. • B : B– Line. • Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Signal path. F : AUDIO
c o
m
• Abbreviation CND : Canadian model SP : Singapore model CH : Chinese model KR : Korea model
376315150 892498299
376315150 892498299
2
2 R511 2.2k
R404 100k
D403 1SS133
R514 15k
R512 470k
5
QQ
QQ
R401 100k
QQ
R406 1M
IC502(1/2) BA4558 AMP
AMP C519 10 50V
R403 10k D402 1SS133
Q402 2SA1175 IC501(1/2) BA4558
7
R527 10k
R528 10k
IC502(2/2) BA4558 AUTO POWER CONTROL
4
7
5
R530 2.7k
1 3 9 4 2 2 9 6 5 1 3 D401 1SS133
8
D502 1SS133
R522 15k
IC506(2/2) BA4558
T E L
6
2
R507 1k
R509 39k
R523 8.2k
1
R529 15k
C505 0.22 R508 3.3k
6
R519 10k
4
3
(Page6)
NORMAL
Q501 2SC2785
C504 0.22
R503 100k
8 7
BOARD
C513 0.22
13942296513
13942296513
S501 PHASE
BOOST
R502 100k
R518 10k
LEVEL
POWER AMP
IC505(1/2) BA4558
5
VR502 20KB
IC503(2/2) BA4558
BASS
C510 10 50V
TEL
TEL
5
R504 10k
7
IC504(2/2) BA4558 PHASE SWITCH
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0
SA-WVS200/WVS300
8 9 2 4 9 8 2 9 9
1-3. PRINTED WIRING BOARD – POWER AMP SECTION – 3
4
Q610
E
B
E
3 BC907
Q701 B 1
2
JW602 R624
POWER
BC902
JW603
S801
R622
C801 BC609
C704 R707 R706
JW606 E
1
E
B
B Q802 E
Q704
POWER SW BOARD
Q703 D603
B
Q611
(FOR CHECk)
11 1-863-039- (11)
1
B
JW604 B Q705 E
B
E Q609
GRN
2
Q707 B
11 1-863-038- (11)
1
R621
R603 D601 R614 R609
D602
E
SP801 SPEAKER
R702 E JW607
R620
R615 R616 R617 R710 B
Q603
R708
E
JW612
E
JW609 Q706 JW605
B
R709
Q606
JW613
C705
JW611
R612 JW614
C607
JW610
JW608
Q605 R618
Ref. No.
ON/STANDBY
2
E
• Semiconductor Location
LD401
RED
R703
6
C611
1
C703
R623
B
SP802 SPEAKER
R701
CN605
Q604
B Q702 E
RLY601
C609
JW615
C813
10
LED BOARD
JW623
C812 JW617
9
E
Q608
1 3 9 4 2 2 9 6 5 1 3
POWER SUPPLY BOARD
QQ
3 7 6 3 1 5B 1 5 0
D807
D806
C807
D809
D808
R802
1
C808
2
1
3
1 7
BC805
E
R801
BC807
1
CN804
BC803
JW805 JW804
RY801
C809
C806
C805
C804
D801 T801 POWER TRANSFORMER
JW806
6
C822
C824 D804
D802
D805
D803
C811
F
T802 POWER TRANSFORMER
D811 1 JW801
C823
JW802
2 CN803
JW803
C802
BC802
+
C810
F801
2
R803
1
D810
G
x
C803
a o y u 1 6 3 2
.
BC801
1
www
–
H
AC IN
i
11 1-863-036- (11)
SA-WVS200/WVS300
5 5 http://www.xiaoyu163.com
.
c o
B-7
Q601 Q602 Q603 Q604 Q605 Q606 Q607 Q608 Q609 Q610 Q611 Q701 Q702 Q703 Q704 Q705 Q706 Q707 Q801 Q802
B-2 B-2 C-2 B-2 B-2 C-2 B-2 D-3 C-3 D-2 D-4 B-5 B-5 B-5 A-5 C-4 C-3 C-3 A-3 A-4
8 9 2 4 9 8 2 9 9
PRI AMP BOARD (Page 3)
AUTO POWER BOARD
LD401
m
11 1-863-037- (11)
376315150 892498299
376315150 892498299
T E L
C-2 C-2 B-5 E-8 E-9 F-9 E-9 F-9 E-5 E-5 E-4 E-4 G-3 F-2 B-3 B-4
QQ
QQ
11 1-863-034- (11)
D
Location
D601 D602 D603 D801 D802 D803 D804 D805 D806 D807 D808 D809 D810 D811 D812 D813
13942296513
13942296513
B R610 E
E
8
7
TEL
TEL R605
E
R604
C606
C
B
Q602
R611
R608
C702
R704
R606 B
E Q607
R619
C605
B
B
C604
B
R804
R602
R607 C603
D812
CN606 R613
C608
D813
5
R805
1
B Q601 E
C815
C814 B Q801 E
C602
JW616
C601
R601
POWER AMP BOARD
6
PRI AMP BOARD (Page 3)
A
A
5
R705
2
1
http://www.xiaoyu163.com
SA-WVS200/WVS300
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
1-4. SCHEMATIC DIAGRAM – POWER AMP SECTION –
Q801 2SC1815 +14V REG
R804 2.2k
C814 47 25V
Q601-605
R603 330
D601 1SS133
R609 10k
INPUT AMP D602 1SS133
Q603 2SA1174
CN606 SCN-5P
Q602 2SA1174
PRI AMP BOARD
C602 10 50V
R617 560
R606 180
R619 180
R616 47k
R620 180
Q605 2SC2785 R607 180
R701 22k
D603 1SS133
R624 1.8k 2W
C702 1 50V
C703 220 10V Q701 DTC124ES DC LEVEL DETECT
RLY601
Q704 2SC2785 AC OFF DETECT
C611 0.047 100V
SP801
R623 10
SPEAKER BC608
R612 56k
QQ
BC609 EH2PL
3 7 6 3 1 5 1 5 0 D806 1SR139
(FOR CHECK)
8 9 2 4 9 8 2 9 9 SP802
SPEAKER
R801 0 D807 1SR139
C807 220 35V
R802 0
C808 220 35V
C804 0.01 BC803 2P
CN803 SDN-2P
D808 1SR139
*F801 T1AL/250V T0.8AL/245V T2.5AL/125V
BC902
BC802
RY801
AEP,UK,CH,KR SP
D809 1SR139
US,CND
D801 1SS133
F801 *
S801
C801 4700p
D803 1SR139
C805 220 35V
D804 1SR139
C806 220 35V
BC801 C803 0.01
AC IN
T802 POWER
C809 10000 80V
C822 0.1 100V
D802 1SR139
C802 0.0047
POWER
BC805 6P
D805 1SR139
T801 POWER TRANSFORMER
C810 10000 80V
C811 10 50V
D810 RBV-602 C823 0.1 100V
R803 12k 1/4W
D811 1SS133
CN804 SCN-7P
TRANSFORMER
LD401 SML1216WTP ON/STANDBY C824 0.1
BC807 BC907
www
.
x
i
PRI AMP BOARD (Page4)
a o y u 1 6 3
SA-WVS200/WVS300
6
6 http://www.xiaoyu163.com
.
c o
m
376315150 892498299
376315150 892498299
R611 2.7k
C701 100 50V
R618 10
1 3 9 4 2 2 9 6 5 1 3 C605 220 10V
R805 2.2k Q802 2SA1015 -14V REG
R702 22k
R622 0.22 2W
Q611 MP1620
C609 22 100V
R613 47
D813 MTZJ-15B
QQ
QQ
T E L
R608 180
R705 47k
C704 0.1
R710 10k
POWER AMP
Q607 2SC2705
C815 47 25V
R703 100k
Q707 2SC2785
Q606-611 Q604 2SC2785
C813 10 50V
CN605 SDN-6P
R621 0.22 2W Q608 2SC3623
Q703 2SC2784 RELAY DRIVER
Q702 2SC2785 DC LEVEL DETECT
R709 10k
R707 1.8k
Q609 2SA1175
C608 100p 500V
R602 47k
C601 0.01
R615 2.2k
C603 0.0022 C604 100p
R708 10k
R706 6.8k
C606 10p 500V
R704 100k
Q706 DTA124ES OVER CURRENT DETECT
13942296513
13942296513
(Page4)
R601 33k
Q705 2SC2785 OVER CURRENT DETECT
D812 MTZJ-15B
TEL
TEL
R604 15k
C705 0.1
Q610 MN2488
Q606 2SA1145
R605 33k Q601 2SA1174
R614 10
C607 22 100V
R610 150
C812 10 50V
http://www.xiaoyu163.com
SA-WVS200/WVS300 Ver. 1.1
SECTION 2 EXPLODED VIEWS
QQ 376315150 892498299 NOTE: • -XX, -X mean standardized parts, so they may have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied.
• •
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
Hardware (# mark) list and accessories are given in the last of this parts list. Abbreviation CND : Canadian model SP : Singapore model CH : Chinese model #1 KR : Korea model AUS : Australian model
2-1. MAIN SECTION not supplied
not supplied
a #1
#1
b
3
not supplied
5 4
#1
not supplied #1
#1 T802
F801
not supplied
d
a
T801 #1
8
6
b
#1
not supplied
9
#1
not supplied
SP801 not supplied
#2
QQ
QQ
c d
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
not supplied
2 3 SP802
3 not supplied
1 not supplied Ref. No. 1 2 2 3 4
Part No. A-1068-566-A A-1068-565-A A-1068-571-A
10 10
Description Remarks FRAME ASSY, GRILLE PANEL ASSY, FRONT (US, CND) PANEL ASSY, FRONT (AEP, UK, CH, SP, KR, AUS) 4-874-614-62 SCREW (1) (3.5X16), TAPPING 3-905-609-01 SCREW (TRANSISTOR)
www
Ref. No. 10 #1 #2 0 F801 0 F801
A-1068-610-A A-1068-611-A 4-999-482-81 1-696-847-21 1-751-528-11
08 08 08 08 * 9
1-769-744-52 1-782-464-22 1-783-531-12 1-824-778-11 3-703-244-00
.
Description Remarks SCREW (1) (3.5X20), TAPPING SCREW +BVTP 3X8 TYPE2 IT-3 SCREW +BVTP 4X10 TYPE2 IT-3 FUSE (T1AL/250V) (AEP, UK, CH, KR) FUSE (T0.8AL/245V) (SP, AUS)
xiaoy u163. com 0 F801
5 6 7 08 08
Part No. 4-874-614-52 7-685-646-79 7-685-660-79 1-532-463-33 1-532-501-33
POWER AMP BOARD, COMPLETE PRI AMP BOARD, COMPLETE KNOB (VOL) CORD, POWER (AUS) CORD, POWER (UK) CORD, POWER (AEP, SP) CORD, POWER (CH) CORD, POWER (US, CND) CORD, POWER (KR) BUSHING (2104), CORD
SP801 SP802 0 T801 0 T801
1-533-418-11 FUSE, GLASS CYLINDRICAL (DIA.5) (T2.5AL/125V) (US, CND) 1-825-844-11 SPEAKER (15cm) 1-825-844-11 SPEAKER (15cm) 1-443-405-11 TRANSFORMER, POWER (US, CND) 1-443-406-11 TRANSFORMER, POWER (AEP, UK, CH, KR)
0 T801 0 T802 0 T802 0 T802
1-443-432-11 1-435-993-11 1-435-994-11 1-435-995-11
http://www.xiaoyu163.com
13942296513
13942296513
c #2
TEL
TEL
7 not supplied
TRANSFORMER, POWER (SP, AUS) TRANSFORMER, POWER (US, CND) TRANSFORMER, POWER (AEP, UK, CH, KR) TRANSFORMER, POWER (SP, AUS)
7
http://www.xiaoyu163.com
SA-WVS200/WVS300 Ver. 1.1
SECTION 3
QQ 376315150 892498299 AUTO POWER
LED
ELECTRICAL PARTS LIST
POWER AMP
NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • CAPACITORS: uF: µF
Part No.
•
Description
************************
****************
< CONNECTOR >
1-533-313-11 FUSE HOLDER
* BC608 * BC609
< CONNECTOR > BC801
* BC802 BC807
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P 1-564-506-11 PLUG, CONNECTOR 3P
< CAPACITOR >
C824
1-113-924-11 1-113-925-11 1-113-925-11 1-126-949-11 1-126-949-11
CERAMIC CERAMIC CERAMIC ELECT ELECT
0.0047uF 0.01uF 0.01uF 220uF 220uF
1-164-159-21 CERAMIC
20% 20% 20% 20% 20%
0.1uF
250V 250V 250V 35V 35V 50V
< DIODE > D801 D802 D803 D804 D805
8-719-991-33 8-719-970-02 8-719-970-02 8-719-970-02 8-719-970-02
DIODE DIODE DIODE DIODE DIODE
1SS133T-77 1SR139-400 1SR139-400 1SR139-400 1SR139-400
< RELAY > 0 RY801
1-755-458-11 RELAY
1-131-679-31 1-126-964-11 1-162-302-11 1-162-282-31 1-126-923-91
FILM ELECT CERAMIC CERAMIC ELECT
0.01uF 10uF 0.0022uF 100PF 220uF
5% 20% 20% 10% 20%
50V 50V 16V 50V 10V
C606 C607 C608 C609 C611
1-101-804-00 1-128-560-11 1-101-810-00 1-128-560-11 1-137-353-11
CERAMIC ELECT CERAMIC ELECT FILM
10PF 22uF 100PF 22uF 0.047uF
5% 20% 5% 20% 5%
500V 100V 500V 100V 100V
C701 C702 C703 C704 C705
1-126-968-11 1-126-960-11 1-126-923-91 1-164-159-21 1-164-159-21
ELECT ELECT ELECT CERAMIC CERAMIC
100uF 1uF 220uF 0.1uF 0.1uF
20% 20% 20%
50V 50V 10V 50V 50V
C812 C813 C814 C815
1-126-964-11 1-126-964-11 1-126-947-11 1-126-947-11
ELECT ELECT ELECT ELECT
10uF 10uF 47uF 47uF
20% 20% 20% 20%
50V 50V 35V 35V
QQ 376315150 892498299
< DIODE >
< TRANSFORMER > 0 T802
1-435-993-11 TRANSFORMER, POWER
************************************************************ LED BOARD
*********
D601 D602 D603 D812 D813
8-719-991-33 8-719-991-33 8-719-991-33 8-719-921-92 8-719-921-92
www
LD401
xiaoy u163. com
1-564-518-11 PLUG, CONNECTOR 3P < DIODE >
.
1SS133T-77 1SS133T-77 1SS133T-77 MTZJ-15B MTZJ-15B
< TRANSISTOR >
< CONNECTOR >
* BC907
DIODE DIODE DIODE DIODE DIODE
8-719-025-62 DIODE SML1216W (ON/STANDBY)
************************************************************
Q601 Q602 Q603 Q604 Q605
8-729-035-30 8-729-035-30 8-729-035-30 8-729-119-78 8-729-119-78
Q606
8-729-214-51 TRANSISTOR 2SA1145-O
8 http://www.xiaoyu163.com
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SA1174 2SA1174 2SA1174 2SC2785-HFE 2SC2785-HFE
376315150 892498299
376315150 892498299
TEL 13942296513
C601 C602 C603 C604 C605
QQ
QQ
< CAPACITOR > 0 C802 0 C803 0 C804 C805 C806
1-566-693-11 PIN, CONNECTOR (3.96mm PITCH) 2P 1-564-517-11 PLUG, CONNECTOR 2P
13942296513
13942296513
AUTO POWER BOARD
RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable • COILS uH: µH • SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... • Abbreviation When indicating parts by CND : Canadian model AUS : Australian model reference number, please SP : Singapore model include the board. CH : Chinese model KR : Korea model Remarks Ref. No. Part No. Description Remarks A-1068-610-A POWER AMP BOARD, COMPLETE
TEL
TEL
Ref. No.
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
http://www.xiaoyu163.com
SA-WVS200/WVS300
QQ 376315150 892498299 POWER AMP
Ref. No.
Part No.
Description
Q607 Q608 Q609 Q610
8-729-270-51 8-729-141-30 8-729-119-76 8-749-010-25
TRANSISTOR 2SC2705-O TRANSISTOR 2SC3623A-LK TRANSISTOR 2SA1175-HFE IC MN2488-OPY-M
Q611 Q701 Q702 Q703 Q704
8-749-010-26 8-729-029-86 8-729-119-78 8-729-178-42 8-729-119-78
IC MP1620-OPY-M TRANSISTOR DTC124ESA TRANSISTOR 2SC2785-HFE TRANSISTOR 2SC2784-F TRANSISTOR 2SC2785-HFE
Q705 Q706 Q707 Q801 Q802
8-729-119-78 8-729-029-40 8-729-119-78 8-729-281-51 8-729-231-12
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
POWER SUPPLY
Remarks
Ref. No.
Part No.
POWER SW
PRI AMP
Description
Remarks
POWER SUPPLY BOARD
****************** < CONNECTOR >
BC803
* BC805
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P 1-564-243-11 PIN, CONNECTOR (3.96mm PITCH) 6P < CAPACITOR >
2SC2785-HFE DTA124ESA 2SC2785-HFE 2SC1815-O 2SA1015TP-O
1-126-949-11 1-126-949-11 1-100-946-11 1-100-946-11 1-126-964-11
ELECT ELECT CAP, ELECT CAP, ELECT ELECT
C822 C823
1-106-220-00 MYLAR 1-106-220-00 MYLAR
5% 5%
100V 100V
5% 5% 5%
1/4W 1/4W 1/4W
R601 R602 R603 R604 R605
1-249-435-11 1-249-437-11 1-249-411-11 1-249-431-11 1-249-435-11
CARBON CARBON CARBON CARBON CARBON
33K 47K 330 15K 33K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R606 R607 R608 R609 R610
1-249-408-11 1-249-408-11 1-249-408-11 1-249-429-11 1-249-407-11
CARBON CARBON CARBON CARBON CARBON
180 180 180 10K 150
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R611 R612 R613 R614 R615
1-249-422-11 1-249-438-11 1-249-401-11 1-249-393-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
2.7K 56K 47 10 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
QQ 376315150 892498299
R616 R617 R618 R619 R620
1-249-437-11 1-249-414-11 1-249-393-11 1-249-408-11 1-249-408-11
CARBON CARBON CARBON CARBON CARBON
47K 560 10 180 180
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
0 R621 0 R622 R623 R624 R701
1-208-602-11 1-208-602-11 1-249-393-11 1-216-458-71 1-249-433-11
METAL METAL CARBON METAL OXIDE CARBON
0.22 0.22 10 1.8K 22K
5% 5% 5%
2W 2W 1/4W 2W 1/4W
R702 R703 R704 R705 R706
1-249-433-11 1-249-441-11 1-249-441-11 1-249-437-11 1-249-427-11
CARBON CARBON CARBON CARBON CARBON
22K 100K 100K 47K 6.8K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R707 R708 R709 R710 R804
1-249-421-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
2.2K 10K 10K 10K 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R805
1-249-421-11 CARBON
2.2K
5%
1/4W
TEL 13942296513
< DIODE > D806 D807 D808 D809 D810
8-719-970-02 8-719-970-02 8-719-970-02 8-719-970-02 8-719-302-37
DIODE DIODE DIODE DIODE DIODE
1SR139-400 1SR139-400 1SR139-400 1SR139-400 RBV-602
D811
8-719-991-33 DIODE 1SS133T-77 < RESISTOR >
R801 R802 R803
1-249-393-11 CARBON 1-249-393-11 CARBON 1-249-430-11 CARBON
10 10 12K
************************************************************ POWER SW BOARD
************** < CONNECTOR > BC902
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P < CAPACITOR >
0 C801
1-113-924-11 CERAMIC
0.0047uF 20%
250V
< SWITCH > 0 S801
1-554-920-61 SWITCH, PUSH (AC POWER) (1 KEY) (POWER)
************************************************************ A-1068-611-A PRI AMP BOARD, COMPLETE
********************** < CONNECTOR >
* BC504 * BC506
1-564-522-11 PLUG, CONNECTOR 7P 1-564-520-11 PLUG, CONNECTOR 5P < CAPACITOR >
www
RLY601 1-515-920-11 RELAY (24V)
************************************************************
.
C402 C501 C502 C503 C504
1-104-661-91 1-162-286-21 1-126-964-11 1-162-286-21 1-131-696-11
ELECT CERAMIC ELECT CERAMIC FILM
xiaoy u163. com < RELAY >
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
http://www.xiaoyu163.com
330uF 220PF 10uF 220PF 0.22uF
20% 10% 20% 10% 5%
16V 50V 50V 50V 50V
9
376315150 892498299
376315150 892498299
0.1uF 0.1uF
50V
QQ
QQ
35V 35V
13942296513
13942296513
220uF 20% 220uF 20% 10000MF 10000MF 10uF 20%
TEL
TEL
< RESISTOR >
C807 C808 C809 C810 C811
http://www.xiaoyu163.com
SA-WVS200/WVS300 Ver. 1.1
QQ 376315150 892498299 PRI AMP
Ref. No.
5% 5% 5% 5% 20%
50V 50V 50V 50V 50V
Remarks
R406 R407 R408 R409 R410
1-247-903-00 1-249-429-11 1-249-417-11 1-249-421-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
1M 10K 1K 2.2K 2.2K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
C511 C512 C513 C514 C515
1-126-964-11 1-131-689-31 1-131-696-11 1-164-159-21 1-164-159-21
ELECT FILM FILM CERAMIC CERAMIC
10uF 0.056uF 0.22uF 0.1uF 0.1uF
20% 5% 5%
50V 50V 50V 50V 50V
R501 R502 R503 R504 R505
1-249-417-11 1-249-441-11 1-249-441-11 1-249-429-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
1K 100K 100K 10K 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
C516 C517 C519 C520 C816
1-126-964-11 1-126-964-11 1-126-964-11 1-164-159-21 1-126-964-11
ELECT ELECT ELECT CERAMIC ELECT
10uF 10uF 10uF 0.1uF 10uF
20% 20% 20% 20%
50V 50V 50V 50V 50V
R507 R508 R509 R511 R512
1-249-417-11 1-247-843-11 1-249-436-11 1-249-421-11 1-247-895-91
CARBON CARBON CARBON CARBON CARBON
1K 3.3K 39K 2.2K 470K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
C817 C818 C819 C820 C821
1-126-964-11 1-126-964-11 1-126-964-11 1-126-947-11 1-126-947-11
ELECT ELECT ELECT ELECT ELECT
10uF 10uF 10uF 47uF 47uF
20% 20% 20% 20% 20%
50V 50V 50V 35V 35V
R513 R514 R515 R516 R517
1-249-421-11 1-249-431-11 1-249-429-11 1-249-439-11 1-249-425-11
CARBON CARBON CARBON CARBON CARBON
2.2K 15K 10K 68K 4.7K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R518 R519 R520 R521 R522
1-249-429-11 1-249-429-11 1-249-429-11 1-249-417-11 1-249-431-11
CARBON CARBON CARBON CARBON CARBON
10K 10K 10K 1K 15K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R523 R524 R525 R526 R527
1-249-428-11 1-249-428-11 1-249-431-11 1-249-422-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
8.2K 8.2K 15K 2.7K 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R528 R529 R530 R531 R806
1-249-429-11 1-249-431-11 1-249-422-11 1-249-427-11 1-247-843-11
CARBON CARBON CARBON CARBON CARBON
10K 15K 2.7K 6.8K 3.3K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R807
1-247-843-11 CARBON
3.3K
5%
1/4W
< DIODE > D401 D402 D403 D404 D501
8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33
DIODE DIODE DIODE DIODE DIODE
1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77
8-719-991-33 DIODE 1SS133T-77 8-719-921-88 DIODE MTZJ-13B 8-719-921-88 DIODE MTZJ-13B < IC >
IC501 IC502 IC503 IC504 IC505
8-759-145-58 8-759-145-58 8-759-145-58 8-759-145-58 8-759-145-58
IC IC IC IC IC
IC506
8-759-145-58 IC uPC4558C
uPC4558C uPC4558C uPC4558C uPC4558C uPC4558C
< SWITCH > S401 S501
< JACK > J501
Remarks
QQ 376315150 892498299
TEL 13942296513
D502 D814 D815
Ref. No.
1-771-188-11 SWITCH, SLIDE (POWER SAVE) 1-771-188-11 SWITCH, SLIDE (PHASE)
1-774-785-11 JACK, PIN 1P (LINE IN) < VARIABLE RESISTOR > < TRANSISTOR >
Q401 Q402 Q403 Q404 Q405
8-729-029-86 8-729-119-76 8-729-029-86 8-729-029-40 8-729-029-40
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
Q501 Q803 Q804
8-729-119-78 TRANSISTOR 2SC2785-HFE 8-729-281-51 TRANSISTOR 2SC1815-O 8-729-231-12 TRANSISTOR 2SA1015TP-O
VR501 VR502
DTC124ESA 2SA1175-HFE DTC124ESA DTA124ESA DTA124ESA
************************************************************ MISCELLANEOUS
*************
< RESISTOR >
www
R401 R402 R403 R404 R405
10
1-249-441-11 1-249-429-11 1-249-429-11 1-249-441-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
.
1-227-667-11 RES, VAR (BASS BOOST) 1-225-826-11 RES, VAR, CARBON 20K (LEVEL)
0 08 08 08 08
1-569-008-32 1-696-847-21 1-751-528-11 1-769-744-52 1-782-464-22
ADAPTOR, CONVERSION (SP) CORD, POWER (AUS) CORD, POWER (UK) CORD, POWER (AEP, SP) CORD, POWER (CH)
08 08 0 F801 0 F801
1-783-531-12 1-824-778-11 1-532-463-33 1-532-501-33
CORD, POWER (US, CND) CORD, POWER (KR) FUSE (T1AL/250V) (AEP, UK, CH, KR) FUSE (T0.8AL/245V) (SP, AUS)
xiaoy u163. com 100K 10K 10K 100K 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
Description
0.22uF 0.047uF 0.22uF 0.22uF 10uF
QQ
QQ
Part No.
FILM FILM FILM FILM ELECT
13942296513
13942296513
Description
1-131-696-11 1-131-688-31 1-131-696-11 1-131-696-11 1-126-964-11
TEL
TEL
Part No.
C505 C506 C508 C509 C510
http://www.xiaoyu163.com
SA-WVS200/WVS300 Ver. 1.1
QQ 376315150 892498299 Ref. No.
Part No.
0 F801
1-533-418-11 FUSE, GLASS CYLINDRICAL (DIA.5) (T2.5AL/125V) (US, CND)
Description
Remarks
SP801 SP802 0 T801 0 T801 0 T801
1-825-844-11 1-825-844-11 1-443-405-11 1-443-406-11 1-443-432-11
SPEAKER (15cm) SPEAKER (15cm) TRANSFORMER, POWER (US, CND) TRANSFORMER, POWER (AEP, UK, CH, KR) TRANSFORMER, POWER (SP, AUS)
0 T802 0 T802 0 T802
1-435-993-11 TRANSFORMER, POWER (US, CND) 1-435-994-11 TRANSFORMER, POWER (AEP, UK, CH, KR) 1-435-995-11 TRANSFORMER, POWER (SP, AUS)
************************************************************
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.
ACCESSORIES
*********** TEL
TEL
1-769-329-21 CORD, CONNECTION (PIN-PIN)
13942296513
13942296513
.
QQ 376315150 892498299
376315150 892498299
376315150 892498299
www
QQ
QQ
TEL 13942296513
xiaoy u163. com 11 http://www.xiaoyu163.com
http://www.xiaoyu163.com
SA-WVS200/WVS300
QQ 376315150 892498299
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver.
Date
Description of Revision
1.0
2004.07
New
1.1
2006.05
Addition of Australian model for SA-WVS300.
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
