Transcript
ECW100 / ECW120 / ECW150 ENCORE SERIES SUBWOOFERS
CONTENT Include a copy of the original receipt or invoice with the purchase date, dealer’s name, customer’s name and invoice number clearly visible. Manufacturing date may be used if no proof of purchase is provided. The customer will pay to ship the defective product; COD will not be accepted.
INTRODUCTION
2
FEATURES
2
PHYSICAL DIMENSIONS
3
THIELE / SMALL PARAMETERS
4
ENCLOSURES DETAILS
5
SINGLE SPEAKER WIRING
8
DUAL SPEAKER WIRING
10
TROUBLESHOOTING
12
WARRANTY
13
Please follow the above instructions carefully when returning product(s) for warranty service. Your warranty service does not cover the following: -Products not purchased from an Authorized VM Audio Dealer. -Damages from poor installation by not following the included instruction manual. -Damages due to excessive moisture, heat and other elements from improper care. -Evidence of tampering or repair by non-authorized personnel. -Products not issued an RMA number. -Damage during freight from poor packaging or handling. -Return shipping on non-defective items. Warranty Turn Around Time It is VM Audio’s goal to turnaround the merchandise in the timely fashion of 1 week. Unexpected delays may occur due to repair parts or replacement shortage. International Warranty Please check with your Authorized International VM Audio Dealer or distributor for specific warranty policies and process for your country. Customer Care Contact Info: Email:
[email protected] Phone: (855) 283-4699 Web Site: www.vmaudio.com
14
CONSUMER LIMITED WARRANTY AGREEMENT Your product is covered by a limited warranty by VM Audio as established below: Mobile Electronics Limited Warranty Products purchased from an Authorized VM Audio Dealer are warranted to be free of defects in material and workmanship for one (1) year from the date of original purchase under normal usage. Products that are identified as “refurbished” have a limited warranty of ninety (90) days from the date of original purchase. Dated proof of purchase (original receipt or invoice) will be required for all warranty claims. In the unlikely event that you experience a manufacturing defect or malfunction during the warranty period, VM Audio will repair the defective product or replace with the same or equivalent product if the same item is not available or discontinued. Replacement product may have superficial blemishes or scratches that do not affect the performance of the product. This warranty is only intended and valid for the original purchaser and cannot be extended to subsequent owners. Any applicable implied warranties are limited to the period of the expressed warranty starting from the original purchase date. No warranties, expressed or implied, will be accepted after the previously listed periods. Exclusions may apply; please check your local state laws. Instructions for Claiming Warranty Service If you should require warranty service, please return the product to the Authorized VM Audio Dealer you originally purchased the item for an experienced and speedy claim of your warranty service. Contact VM Audio directly to find the Authorized Dealers nearest you. In the case the defective merchandise needs to be returned to VM Audio, please contact us and a Return Merchandise Authorization (RMA) number will be assigned. It is important to pack all defective items in the original packaging to prevent damages from shipping, and write the RMA number clearly on the shipping label for faster processing.
13
INTRODUCTION You have just purchased a product from VM Audio’s Encore Series. As one who demands only the best from what life offers, you expect luxury and comfort from your purchasing choice. The Encore Series is designed to satisfy that need and continue to impress. From years of experience and unending passion, the experts at VM Audio have meticulously designed and tested each product to ensure sounds so true and so clear, it feels like a live performance. Please read through the installation instructions and follow carefully; ask for the help of a certified installer if necessary. When properly installed, the Encore Series product will perform at its optimum presentation flawlessly for years to come. The professionals hear what was intended by the artists; now, so can you.
FEATURES • • • • • • • • • • • •
Dual Voice Coil Low Frequency Transducers Lateral High Thrust Mechanical Suspension System Relentless High Excursion Wide Surround Multi-Roll, Linear-Flex Damping Control Large Spider Low Molecular, Deep Piston Cone Diaphragm Ultra Deep, Proprietary Rust-Treated Stamp Steel Basket High Impact-Resistant One Piece Magnet Boot Protection Aerodynamic, Direct Voice Coil Surface-Cooling System Extended, Thermal Cooling Vented Pole Piece Motor Structure Heavy-Duty Nickel Plated Wire Connection Push Terminals Spider Woven High-Conducting Silver Tinsel Leads Sealed or Ported Enclosure Performance
2
PHYSICAL DIMENSIONS
TROUBLESHOOTING
ECW100
ECW120
ECW150
(A) Overall Diameter
10.24 inches 260 mm
12.28 inches 312 mm
15.55 inches 395 mm
(B) Overall Height
7.56 inches 192 mm
8.58 inches 218 mm
10.20 inches 259 mm
(C) Cutout Diameter
8.94 inches 227 mm
11.14 inches 283 mm
13.70 inches 348 mm
(D) Mounting Height
7.20 inches 183 mm
8.19 inches 208 mm
9.02 inches 229 mm
(E) Magnet Diameter
6.14 inches 156 mm
6.69 inches 170 mm
9.25 inches 235 mm
D
If the subwoofer(s) does not appear to be working, check for blown fuses, poor or incorrect wiring connections and incorrect settings. NO SOUND? 1) Source unit volume is turned down or muted: Turn volume up slowly or turn mute off. 2) Speaker leads shorted: Check speaker continuity using a Digital Multimeter (DMM) to ground (it should show no common ground). 3) Speakers not connected or blown: Check speaker connections at amplifier and at speakers. Disconnect speakers at amplifier and measure coil impedance with a Digital Multimeter DISTORTED AUDIO? 1) Gain may not be properly set: Review your amplifier’s user guide to correctly adjust gain setting. 2) Speaker may be damaged: Inspect each speaker cone for signs of damage (frozen cone, burned smell, separated or ripped surround or spider). REDUCED BASS? 1) Speakers may be wired in reverse polarity: Reverse a speaker connection from positive to negative on the stereo or speaker.
E
A
3
C
AMPLIFIER SHUTS DOWN AFTER PLAYING FOR A PERIOD OF TIME? 1) Thermal protection circuits are shutting the amplifier off: Check the location for adequate ventilation (Relocate amplifier if necessary). Impedance may be too low and overheating the amplifier. Check amplifier’s user guide for impedance compatibility.
B
12
DUAL SPEAKER WIRING
THIELE/SMALL PARAMETERS MODELS
Series Connection
ECW150
33 Hz
35 Hz
25 Hz
Driver Compliance (Cms)
177.3 um/N
93 um/N
124 um/N
Moving Mass (Mms)
136.41 g
233.34 g
330 g
Driver Total Q (Qts)
0.25
0.4
0.28
Electrical Q (Qes)
0.27
0.45
0.31
Mechanical Q (Qms)
3.33
3.76
3.40
13.5 Ltr
13.95 Ltr
104 Ltr
Effective Cone Area (Sd)
35 sq.in.
50.27 sq.in.
119 sq.in.
Inductance 1kHz (Le)
1.23 mH
1.22 mH
2.36 mH
11.54 T-M
12.1 T-M
15.63 T-M
Motor Force (BL) Xmax
13.5 mm
13.5 mm
15.88 mm
Efficiency (no)
0.3 %
0.28 %
0.26 %
Sensitivity (SPL@1W/1m)
91 dB
93 dB
94 dB
D.C. Coil Resistance (Re)
3.4 Ω ea.
3.4 Ω ea.
3.6 Ω ea.
25 - 360Hz
23 - 340Hz
23 - 300Hz
POWER (RMS)
1300 W
1500 W
2000 W
POWER (Peak)
2600 W
3000 W
4000 W
Frequency Response
11
ECW120
Free Air Resonance (Fs)
Equivalent Stiffness (Vas)
WARNING! Make sure the amplifier is turned off before connecting the subwoofer to the amplifier
ECW100
4
ENCLOSURE DETAILS
DUAL SPEAKER WIRING
Sealed Box
Parallel Connection
B
C A ENCLOSURE DIMENSIONS
Net Volume
ECW100
16 in. (A)
13 in. (B)
7.5 in. (C)
0.58 cu. ft
ECW120
18 in. (A)
15 in. (B)
10 in. (C)
1.1 cu. ft.
ECW150
24 in. (A)
18 in. (B)
11.75 in. (C)
2 cu. ft.
Wood Thickness = 0.75”
5
WARNING! Verify the amplifier is designed to drive 2 ohm speaker loads on each channel.
10
SINGLE SPEAKER WIRING
Series Connection
Ported Box
B
C A ENCLOSURE DIMENSIONS
WARNING! Make sure the amplifier is turned off before connecting the subwoofer to the amplifier
9
Net Volume
ECW100
22 in. (A)
13 in. (B)
10 in. (C)
1.16 cu. ft
ECW120
26 in. (A)
15 in. (B)
12 in. (C)
2.0 cu. ft.
ECW150
24 in. (A)
18 in. (B)
16.5 in (C)
3.0 cu. ft.
Wood Thickness = 0.75”
6
ENCLOSURE DETAILS
SINGLE SPEAKER WIRING
Port Parallel Connection C
B
A DIMENSIONS ECW100
1 in. (A)
11.5 in. (B)
9 in. (C)
ECW120
1.75 in. (A)
13.50 in. (B)
11 in. (C)
ECW150
2 in. (A)
16.5 in. (B)
26.5 in. (C)
Port Wall Thickness = 0.75”
7
WARNING! Verify the amplifier is designed to drive 2 ohm speaker loads.
8
