Transcript
Generated by Foxit PDF Creator © Foxit Software http://www.foxitsoftware.com For evaluation only.
SOLEX FITTING INSTRUCTIONS
*****The friction drive wheel drives on the front tyre, mount the larger clamps on the bottom of forks on the bicycle, smaller clamp/brackets on the top, you can assemble loose to tap with a small hammer, the engine up or down to get the correct pressure of the roller on the tyre, then tighten all bracket nuts.
For front brakes reverse them as the above pictures! *****Below is a accelerator wire, the lever on top needs to be to the left side. When start engine, the lever is to the left side of accelerator wire, the 1with the hole in it.
01
Generated by Foxit PDF Creator © Foxit Software http://www.foxitsoftware.com For evaluation only.
In picture to left side is the cable to operate the decompression lever,you will notice it has been cut close to the cable. The Reason for this is to give the engine more lifting leaver to get the roller off the front tyre, this small modification make it work well , its just an idea if you find you have the same problem as I had .
***** I also find that a front basket bracket works great to use to hold the solex engine lift up handle onto. All I did was bend the bracket backwards for the lever to clip into it .Same as picture 1 on the top of this manuel . Fuel 65ml 2 stroke oil to 1 litre of fuel first 6 tanks then 50ml x 1 litre . can fit a piece of heater hose and clamps over exhaust join 4 leaks Economical fuel consumption: 1.4 L/100km Rated power: 0.8kw/3600r/min Capacity of gasoline tank (L): 1.4 New control lever and front new Led lamp ******Pull both leavers in then pedal let them out at the same time To stop engine pull leavers both accelerator leaver and decompression leavers in like brakes.When the accelerator leaver is out its full throttle , When in its normal running of engine idol . ********Solex take time to understand how to use, as its back to front from centre fit 2 stroke engines with chain drive. There is no carburettor it’s a direct injection system operated by exhaust pressure in fuel tank . *******Please run engine inn , Solex engine will gain more power。After the run in period. Make sure there is correct pressure on tyre if too much you will not be able to lift engine off tyre.If too little roller will spin and slip on tyre causing premature tyre wear .
02
